TAir-ST02-V.01 (03may16)

Tengah Airbase – RC Caisson & Open Trench - Yew Ann
PROPOSED CONSTRUCTION OF NEW WATER LINE AND SEWER

LINE AT TENGAH AIR BASE MUKIM 12 LOT 00280C, 00271T,
00272A, 00310V, 00315N, 00318C, 00319M, 00321C, 00320L,
00322M, 00324V, 00325P, 00327A, 00328K, 00329N, 00333X,
00334L, 00326T, 00331K, 00335C, 00336M, 00337W, 00342P,
00338V, 00341V, 00340W, 00353M, 00352C, 00351L, 00364X,
00365L, 00366C, 00367M, 00368W, 00363N, 00362K, 00323W,
01474C, 01476W, 01451T, 01453K, 01452A, 01454N, 00308P
AT 611 OLD CHOA CHU KANG ROAD, SINGAPORE 698930.
E3361-01571-2016-ST02
ERSS FOR RCCAISSON & OPEN TRENCH
(Depth of excavation d<6.0m)
FOR
YEW ANN CONSTRUCTION PTE LTD

Report By
DPC CONSULTING ENGINEERS

Design + Planning Consultants
18 Boon Lay Way, #04-121 TradeHub21, Singapore 609966
Tel: 6795 2919 Fax: 6795 2917
[email protected]
Date Revision No. Document Ref. Prepared By Checked By
20 April 2016 V.01 YAnn-TAir-ST02-V.01-200416 SWE/Haiming William LAU
Page 1 of 71
CONSULTING
Page 2 of 71
CONSULTING
CONTENT PAGE
PE’S CERTIFICATION
A. INTRODUCTION 4
B. CODES OF PRACTICES 4
C. SOIL PROFILE AND INTERPRETATION OF SOIL PARAMETERS 4-5
D. METHOD OF ANALYSIS 6-7
E. RESULTS OF FE ANALYSIS 7-8
F. DESIGN INFORMATION 9
G. INSTRUMENTATION AND MONITORING PROGRAMME 9
H. CONCLUSIONS 9
ANNEX A – LIST OF FIGURES 11-26
ANNEX B - INPUT SOIL PARAMETERS 27-28
ANNEX C – SOIL REPORT 29-30
ANNEX D – ERSS DRAWINGS 31-35
ANNEX E – STRUCTURAL CALCULATION & BASAL HEAVE CHECK 36-70
PE’S CERTIFICATION 71
Page 3 of 71
CONSULTING
A. INTRODUCTION
This submission outlines the analysis and design of soldier piles system for open
trench and 3.5m diameter temporary “sinking” RC caisson for construction of
manhole (MH4) at Tengah Air base. Adopted ERSS for open trench comprises of
UB200x200x41kG/m with layers of horizontal walers and struts.
The entire excavation is nested in green field environment with sufficient space for
open cut excavation. Entire depth of temporary RC caisson/shaft is made up of
series of cast-in-situ RC rings of 1.0m depth above ground level and sink in
tandem with the excavation work. Simulation was done by Plaxis software,
incorporate relevant soil parameters extracted from nearby soil borelog. The site
lies within the geological demarcation of Bt Timah Formation and subsoil
properties as depicted in BH-402 were used to extract relevant soil parameters.
B. CODES OF PRACTICES
The following SS or EN Standards/Codes of Practice are used and/or referred in

the impact study.
SS EN 1993 Eurocode 3 : Design of Steel Structures

SS EN 1995 Eurocode 5 : Design of Timber Structures
SS EN 1997 Eurocode 7 : Geotechnical Design
SS CP 18: 1992 Code of Practice for Earthworks
SS CP 04: 2003 Code of Practice for Foundation, Singapore Standard
TR 26: 2010: Reference for Deep Excavation
C. SOIL PROFILE AND INTERPRETATION OF SOIL PARAMETERS
Based on the soil exploratory findings from relevant bore logs, the project area lies
within the geological demarcation of Residual soil underlain by Bukit Timah
formation with weathered rock founding stratum.
The subsoil comprised of firm to stiff-sand-Silt mixtures probably formed by the in-
situ weathering of the underlying bedrock (residual soils and completely
weathered rock derived from Bukit Timah Granite) at upper layers. The
proportions of sand, silt and clay are highly variable and exist in a state varying
from firm/stiff condition at the top to very stiff/hard/very dense condition at deeper
depth.
BH-402 was near to the proposed temporary shafts and used to extract real soil
profile/parameters. Soil profile of the borlog is summarized and characterized in
Table 1 and Annex B.
Page 4 of 71
Tengah Airbase – RC Caisson & Open Trench - Yew Ann
Description EC7 DA1/1 EC7 DA 1/2
PERMANENT : Unfavourable Load 1.35 1.0

VARIABLE : Unfavourable Load 1.50 1.3
PERMANENT : Favourable Load 1.0 1.0
c’ 1.0 1.25
tan ’ 1.0 1.25
Cu 1.0 1.4
Resistance 1.0 1.0
Table 1.0 – EC 7 Design Approach Partial Factors
From Description of Soil Depth DA 1/1 DA 1/2 SPT Stiffness E Remarks

(m)
Geological Classifications & (m) (N) (mPa)
GL - 0.0 m
weathering Cu c’ ’ q Cu c’ ’ q Eu ~ 2.5N E’ ~2.0N
< 250 mPa < 200mPa
0.0m -7.5m Loose Silty SAND–OE 7.5 30 3.0 30.0 20.0 22 2.4 24.7 17.5 6 15 12 DA ½ governs
GVI 4<N<10
7.5m-10.0m Stiff Sandy SILT 2.5 55 4.0 31.0 -- 39 3.2 25.6 -- 11 27.5 22 -ditto-
GVI 8<N<15
10.0m-16.5m Hard Sandy SILT 6.5 150 8.0 31.0 -- 108 6.4 25.6 -- 34 85 68 -ditto-
GV 30<N
> 16.50m Bt Timah GRANITE >16.5 300 12 36.0 -- 214 9.6 30 -- >100 100 80 -ditto-
GIV 100<N
Table 2 : Sub-soil Profile (BH-402) – DSTA Tengah Airbase– (RL108.7m) c’ = 0.2N cu = 5N
CLAY/SILT -- V Soft N<2, Soft 2<N<4, Firm 4<N<8, Stiff 8<N<15, V STiff 15<N<30, Hard 30<N
CLAY/SILT -- V Soft Cu<20, Soft 20<Cu<40, Firm 40<Cu<75 Stiff 75< Cu<150, V STiff 150<Cu<300, Hard 300<Cu
SAND -- V Loose N<4, Loose 4<N<10, M Dense 10<N<30, Dense 30<N<50, V Dense 50<N
OA(E) N<10, OA(D) 10<N<30, OA(C) 30<N<50 OA(B) 50<N<100 OA(A) 100<N
Page 5 of 71

TAir-ST02-V.01 (03may16)

Uploaded by

Copyright:

Available Formats

TAir-ST02-V.01 (03may16)

Uploaded by

Document Information

Original Title

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

TAir-ST02-V.01 (03may16)

Uploaded by

Copyright:

Available Formats

Tengah Airbase – RC Caisson & Open Trench - Yew Ann

PROPOSED CONSTRUCTION OF NEW WATER LINE AND SEWER

ERSS FOR RCCAISSON & OPEN TRENCH

(Depth of excavation d<6.0m)

YEW ANN CONSTRUCTION PTE LTD

DPC CONSULTING ENGINEERS

Date Revision No. Document Ref. Prepared By Checked By

20 April 2016 V.01 YAnn-TAir-ST02-V.01-200416 SWE/Haiming William LAU

C. SOIL PROFILE AND INTERPRETATION OF SOIL PARAMETERS 4-5

D. METHOD OF ANALYSIS 6-7

E. RESULTS OF FE ANALYSIS 7-8

G. INSTRUMENTATION AND MONITORING PROGRAMME 9

ANNEX A – LIST OF FIGURES 11-26

ANNEX B - INPUT SOIL PARAMETERS 27-28

ANNEX C – SOIL REPORT 29-30

ANNEX D – ERSS DRAWINGS 31-35

ANNEX E – STRUCTURAL CALCULATION & BASAL HEAVE CHECK 36-70

The following SS or EN Standards/Codes of Practice are used and/or referred in

SS EN 1993 Eurocode 3 : Design of Steel Structures

C. SOIL PROFILE AND INTERPRETATION OF SOIL PARAMETERS

Description EC7 DA1/1 EC7 DA 1/2

PERMANENT : Unfavourable Load 1.35 1.0

From Description of Soil Depth DA 1/1 DA 1/2 SPT Stiffness E Remarks

Table 2 : Sub-soil Profile (BH-402) – DSTA Tengah Airbase– (RL108.7m) c’ = 0.2N cu = 5N

You might also like