Icom Pw-1 F Amplifier Repair Manual-E

HF/50 MHz ALL BAND
LINEAR AMPLIFIER
iC-PW1
INTRODUCTION DANGER
This service manual describes the latest service information for HIGH VOLTAGE! NEVER touch the antenna con-
the IC-PW1 HF/50 MHz ALL BAND LINEAR AMPLIFIER at nector or the power supply section in the linear amplifier
the time of publication. while connecting the IC-PW1 to an AC outlet.
MODEL VERSION SYMBOL
NEVER carry the linear amplifier by yourself. At least two
U.S.A. USA persons must carry the linear amplifier since it weights ap-
prox. 25 kg (55.12 lb).
IC-PW1 Europe EUR
Europe-1 EUR-1 NEVER expose the IC-PW1 to rain or moisture since fire
or shock hazard could occur.
To upgrade quality, all electrical or mechanical parts and inter-
nal circuits are subject to change without notice or obligation. NEVER touch the IC-PW1 with metal strips, wire, etc.
These materials may cause fires and electric shocks.
ORDERING PARTS REPAIR NOTES

Be sure to include the following four points when ordering 1. Make sure a problem is internal before disassembling the
replacement parts: linear amplifier or the remote controller.
1. 10-digit order numbers 2. DO NOT open the linear amplifier or the remote controller
2. Component part number and name until the linear amplifier is disconnected from its power
3. Equipment model name and unit name source.
4. Quantity required 3. DO NOT force any of the variable components.
Turn them slowly and smoothly.
<SAMPLE ORDER> 4. DO NOT short any circuits or electronic parts. An insu-
1140003830 S.IC TC4W66F IC-PW1 MAIN UNIT 1 piece lated tuning tool MUST be used for all adjustments.
8810003160 SET Screw 3 × 6 ZK IC-PW1 CHASSIS 6 pieces
5. DO NOT keep power ON for a long time when the linear
Addresses are provided on the inside back cover for your amplifier is defective.
convenience. 6. READ the instructions of test equipment thoroughly
before connecting equipment to the linear amplifier.
TABLE OF CONTENTS
SECTION 1 SPECIFICATIONS
SECTION 2 INSIDE VIEWS
SECTION 3 CIRCUIT DESCRIPTION

3-1 LINEAR AMPLIFIER CIRCUITS ......................................................................................... 3 - 1
3-2 ANTENNA TUNER CIRCUITS ........................................................................................... 3 - 2
3-3 PROTECTION CIRCUITS .................................................................................................. 3 - 3
3-4 POWER SUPPLY CIRCUITS ............................................................................................ 3 - 4
3-5 PORT ALLOCATIONS ....................................................................................................... 3 - 4
SECTION 4 ADJUSTMENT PROCEDURES

4-1 PREPARATION................................................................................................................... 4 - 1
4-2 PA AND FRONT UNITS ADJSTMENT ............................................................................... 4 - 2
4-3 MAIN UNIT ADJUSTMENT ................................................................................................ 4 - 3
SECTION 5 PARTS LIST
SECTION 6 MECHANICAL PARTS AND DISASSEMBLY
SECTION 7 SEMI-CONDUCTOR INFORMATION
SECTION 8 BOARD LAYOUTS

8-1 ANT-SW UNIT .................................................................................................................... 8 - 1
8-2 C-NET BOARD ................................................................................................................... 8 - 1
8-3 L-NET BOARD.................................................................................................................... 8 - 2
8-4 H-NET BOARD ................................................................................................................... 8 - 2
8-5 CONNECT BOARD ............................................................................................................ 8 - 3
8-6 COMBINR UNIT ................................................................................................................. 8 - 4
8-7 SPLITR UNIT ...................................................................................................................... 8 - 5
8-8 PA UNIT .............................................................................................................................. 8 - 6
8-9 DET BOARD ....................................................................................................................... 8 - 7
8-10 JACK-1 UNIT ...................................................................................................................... 8 - 8
8-11 SW BOARD ........................................................................................................................ 8 - 9
8-12 FILTER UNIT..................................................................................................................... 8 - 11
8-13 MAIN UNIT ....................................................................................................................... 8 - 13
SECTION 9 BLOCK DIAGRAM
SECTION 10 VOLTAGE DIAGRAM

10-1 WIRING DIAGRAM........................................................................................................... 10 - 1
10-2 SPLITR, PA, AND COMBINR UNITS ............................................................................... 10 - 2
10-3 FILTER UNIT .................................................................................................................... 10 - 3
10-4 PA UNIT ............................................................................................................................ 10 - 4
10-5 FRONT UNIT .................................................................................................................... 10 - 5
10-6 MAIN UNIT ....................................................................................................................... 10 - 6
10-7 TUNER UNIT .................................................................................................................... 10 - 7
SECTION 1 SPECIFICATIONS
M GENERAL
• Frequency range : 1.800–1.999 MHz
3.500–3.999 MHz
4.630 MHz
7.000–7.300 MHz
10.100–10.150 MHz
14.000–14.350 MHz
18.068–18.168 MHz
21.000–21.450 MHz
24.890–24.990 MHz*1
28.000–29.700 MHz*1
50.000–54.000 MHz
*1The USA version can only be used the antenna tuner on the 24–28 MHz bands.
• Duty cycle : Full duty
• Input connector : SO-239 × 2 (50 Ω)
• Output connector : SO-239 × 4 (50 Ω)
• Power supply voltage : 90 V–132 V AC or 180 V–264 V AC
(single-phase; 50/60 Hz)
• Usable temperature range : –10 ˚C to +40 ˚C; +14 ˚F to +104 ˚F
• Dimensions : Linear amplifier 350(W)×265(H)×375(D) mm;
(Projections not included) 13.78(W)×10.43(H)×14.76(D) in
Remote controller 205(W)×71(H)×68.3(D) mm;
8.07(W)×2.80(H)×2.69(D) in
• Weight : 25 kg; 55.12 lb (Included in the remote controller)
(Included in the remote controller)
M LINEAR AMPLIFIER
• Output power :
INPUT AC VOLTAGE
MODE
90–132 V AC 180–264 V AC
CW, RTTY 450–600 W* 1
950–1150 W
SSB 450–600 W PEP*2 950–1150 W PEP
*1 EUR-1 version is 450–550 W;

*2 EUR-1 version is 450–550 W PEP
• Driving power : Max. 100 W
• Sprious emissions : Less than –60 dB (for HF bands)
Less than –70 dB (for 50 MHz band)
M ANTENNA TUNER
• Output matching range : 16.7–150.0 Ω*1 (for HF bands)
20.0–125.0 Ω (for 50 MHz band)
*1 Specifications of 1.9 MHz band guaranteed 1.85–1.95 MHz
• Auto tuning accuracy : VSWR 1.5:1 or less
• Min. required input power : 60 W
• Insertion loss : Less than 1 dB (after tuning)
All stated specifications are subject to change without notice or obligation.
1-1
SECTION 2 INSIDE VIEWS
FRONT UNIT
SW BOARD
ANT-SW UNIT
JACK1 UNIT FRONT

SIDE
LOWPASS FILTER
POWER UNIT FILTER UNIT
PA-4 BOARD COMBINR UNIT
PA-2 BOARD
PA-3 BOARD
SPLITR UNIT
PA-1 UNIT
2-1
TUNER UNIT
C-NET BOARD
DET BOARD H-NET BOARD
CONNECT BOARD
FRONT
SIDE
MAIN UNIT
L-NET BOARD
2-2
SECTION 3 CIRCUIT DESCRIPTION
3-1 LINEAR AMPLIFIER CIRCUITS 3-1-3 POWER AMPLIFIER CIRCUITS

3-1-1 EXCITER INPUT SWITCHING CIRCUIT (PA1–4 BOARDS)
(SPLITR UNIT) The power level divided signal from the SPLITR unit is
The applied signal from the exciter (transceiver) is passed amplified at the power amplifier circuit (Q1a/b). The ampli-
through the exciter select circuit (RL1) then applied to the fied signal is applied to the COMBINR unit.
THROUGH/AMP switching relay (RL2). The switched signal
is passed through the attenuator circuit (R3–R6) when the Two power MOS-FETs (MRF150) and a negative feedback
amplifier is activated. The attenuated signal is applied to the circuit are employed for each PA unit to obtain a stable 300
power split circuit (L2–L4, L6, R9–R12). W or higher of RF power and to maintain response gain for
all bands within 3 dB.
When “THROUGH” is selected, the signal from the exciter
select circuit is applied to the FILTER unit via J8.
3-1-4 POWER COMBINER CIRCUIT
The attenuator circuit attenuates the switched signal approx. (CONBINR UNIT)
1 dB to protect the amplifier circuits from excessive input The amplified signals from the PA1 and PA2 boards are
power and stabilizes the amplifying operation. combined at the hybrid circuit (L1, R1) to obtain a 500 W RF
level and the impedance is converted to 25 Ω.
3-1-2 POWER SPLITTER CIRCUIT (SPLITR UNIT) The amplified signals from the PA3 and PA4 boards are
The power splitter circuit converts the antenna impedance to combined at another hybrid circuit (L2, R2).
1⁄4 (12.5 Ω) at L2, then the applied RF power level is divid-
ed at the hybrid circuit (L3, R9, R10). The divided RF signals Both signals are again combined at another hybrid circuit
are separately passed through another hybrid circuit (L4, (L3, R3) to obtain a 1 kW RF level and the impedance is
R11 and L6, R12) to convert the impedance to 50 Ω and converted to 12.5 Ω. The combined signal is applied to the
divide the power level. FILTER unit via the impedance convertor (L5) for conversion
to 50 Ω impedance.
The power level divided signal is applied to the one of four
PA units (PA1–PA4) via J4 to J7.
3-1-5 FILTER CIRCUIT (FILTER UNIT)
The RF power level at J4, J5, J6 and J7 is approx. 1⁄5 of The signal from the CONBINR unit is passed through one of
applied power (from the exciter). 8 low-pass filters.
The filtered signal is applied to the matching circuit.
• SPLITTER CIRCUIT
TRU
J1 J8
IN1
C26
RL1 C2 PA1
J2 RL2 R3 J4
L2 L3 L4
IN2
C18 R4 C11
D1 R11
R5
J9 D2 C17 R9 R10
R1 R7 R6
GND C19 C3 J5 PA2
F C4
5V C7 C8
L7 D4 D5
TEMP
IN L1 L8 R8
L5
DRIV D3
R2
L9 C5 C9 C10
R13 J6 PA3
L6
R17 C14
R14 R15 R12
C21 R16 R18
IC1
C22 L11 J7 PA4
"HV" to PA1 board
via the J11, pin 1
"T8V" to PA1 board

via the J11, pin 5 and 6
3-1
2-step (3-step for the 50 MHz band) Chebyschev low-pass (2) Reactance components detector
filters are adopted, to obtain –60 dB or less higher harmon- Reactance components are picked up by comparing the
ic emissions for all HF bands or –70 dB or less for the 50 phase of the RF current and RF voltage. The RF current is
MHz band. detected by L3 and R4 (DET board), and then amplified at
IC1a and IC2d. The amplified RF current is applied to the
The filtered signal is passed through or bypasses the anten- phase comparator (DET board; IC4, pin 13). The RF volt-
na tuner and is then applied to one of four antenna connec- ages are detected at C1–C3 on the DET board, and ampli-
tors via the antenna select relay (RL1–RL4) on the ANT-SW fied at IC1c and IC2a, then applied to the phase comparator
unit. (IC4, pin 1). The output signal from the phase comparator
(IC4, pin 6 for RF voltage, pin 9 for RF current) is rectified at
D13 and D14 for conversion into DC voltage. The rectified
voltage signals are combined, then applied to the antenna
3-2 ANTENNA TUNER CIRCUITS CPU (MAIN unit; IC12, pin 64) after being amplified at IC9a
3-2-1 MATCHING CIRCUIT (TUNER UNIT) on the MAIN unit.
The matching circuit is a T-network. Using 2 tuning motors,
ECL-IC is used for IC1 and IC2 on the DET board to ensure
the matching circuit obtains rapid overall tuning speed.
quick and stable signal detection even at low RF signal level
input.
Using relays (TUNER unit; RL1–RL10, L-NET board; RL1,
RL2, H-NET board; RL1–RL10), the relay control signals
(3) Resistance components detector
from the antenna tuner CPU (MAIN unit; IC12) via the relay
Resistance components are picked up by L5, R14 and R21,
driver (MAIN unit; IC14) ground one of the taps of L3–L5 (L-
and detected by Q1, D11 and D12 on the DET board. The
NET board) or L11–L15 (H-NET board) and add network
detected resistance components are amplified at IC9a on
capacitors (C-NET board). After selecting the coils and
the MAIN unit, and then applied to the antenna CPU (IC12,
capacitors, 2 motors (TUNER unit; MF1, MF2) adjust C1
pin 1).
and C2 using the antenna tuner CPU and the motor driver
(MAIN unit; IC15) to obtain a low SWR (Standing Wave
Ratio).
3-2-3 MOTOR CONTROL CIRCUIT
(MAIN UNIT AND C-NET, L-NET, H-NET
3-2-2 DETECTOR CIRCUIT BOARDS)
(MAIN AND FILTER UNITS) The control circuit of the internal antenna tuner consists of
(1) SWR detector the CPU, EEPROM, tuning motors and tuning relays.
Forward and reflected power are picked up by a current
transformer (FILTER unit; L22), detected by D15 and D16, (1) CPU and EEPROM (MAIN unit)
and then applied to the MAIN unit. The antenna tuner CPU (IC12) controls the tuning motors
via the motor driver (IC15) and tuning relays via the relay dri-
The applied signals are amplified at the SWR amplifier ver (IC14, Q9–Q14). The CPU memorizes the best preset
(MAIN unit; IC31a/b). The amplified voltages are applied to position and the contents are stored in the EEPROM (IC7)
the antenna tuner CPU (MAIN unit; IC12, pins 2, 3). The without the need for a backup battery.
CPU detects the SWR.
• DETECTOR CIRCUIT
From FILTER unit To C-NET board

COUPLER COUPLER
L3, R4 L5, R14, R21
D3, D4,
Q1, D11, D5, D6,
D12 Impedance Phase
detector detector D13, D14,
IC2, IC4
DET board
MAIN unit
6 2
Amplifier IC9
7 1
1 64
Tuner CPU
IC12
3-2
(2) Tuning controls (MAIN unit) (1) FOR-ALC
A motor driver (IC15) rotates the tuning motors (MF1, MF2) The detected “FOR” voltage signal from the SWR detector
to obtain a low SWR. circuit (FILTER unit; D15, D16, L22) is op-amplified at IC1a
then applied to the ACC2 socket (JACK1 unit; J5, pin 5) via
(3) Tuning relays (C-NET, L-NET and H-NET boards) the ALC adjustment pot (JACK1 unit; R1) and ALC2 jack
According to the operating frequency band and antenna (JACK2 unit; J7).
condition, tuning relays select the capacitors and coils.
(2) ID-ALC
In the IC-PW1, internal power supply voltage (ID) is used for
ID-ALC. The power supply voltage (ID) is amplified at the op-
3-3 PROTECTION CIRCUITS amplifier (IC1c), then applied to the ACC2 socket.
3-3-1 GENERAL
(3) SWR-ALC
The IC-PW1 has two protection systems. One system
SWR-ALC protects the power amplifiers (PA1–PA4 boards;
bypasses the power amplifier, and the other system shuts
Q1a/b) when SWR worsens and when dielectric break-
down the internal power supply activation.
down/discharge from excessive voltage rises.
Protection activates when:
The detected “REF” voltage signal from the SWR detector
• a mismatched frequency band signal is transmitted.
circuit (FILTER unit; D15, D16, L22) is op-amplified at the
• the ALC control level exceeds the control range.
SWR/DRIVE amplifier (IC1b) then applied to the ACC2
• the power level balance between the 4 PA units becomes
socket (JACK1 unit; J5, pin 5).
unbalanced.
• the output voltage of the internal power supply (VD)
(4) DRV-ALC
exceeds 55 V DC.
DRV-ALC activates when the exciter input exceeds 120 W
• the current of the power amplifiers (ID) exceeds 50 A.
to protect the power amplifiers. The op-amplified “REF” sig-
• the heatsink temperature of the power amplifier exceeds
nal at the SWR/DRIVE amplifier (IC1b) is used for operation.
+100˚C (212˚F).
However, the limiter circuit on the SPRITR unit (D4, D5) is
• the applied AC voltage exceeds the specified value.
activated for momentary excessive input such as leading
edge power, etc.
The main CPU controls the THROUGH/AMP switch and
internal power supply operation.
3-3-3 DRIVING POWER DETECTOR CIRCUIT
3-3-2 ALC CIRCUIT (MAIN UNIT) (SPLITR AND MAIN UNITS)
The ALC (Automatic Level Control) circuit automatically lim- A portion of the attenuated input power from the exciter input
its RF output power by controlling the input level of the switching circuit (SPLITR unit; RL1) is divided by R7 and R8,
exciter. and then rectified at D3, R2 and C5 for conversion to DC
voltages. The rectified DC voltages are applied to the drive
amplifier (MAIN unit; IC21a/b). The amplified DC voltages
are applied to the main CPU (MAIN unit; IC26)
• ALC CIRCUITS
9 8
Regurator Id control
IC1
RL5 FILTER UNIT

From SPLITR unit D15, D16, L22 To DET board
From TUNER unit VSWR detector
RL1
REF
6 ALC selector
"T13" from MAIN unit ALC1
ACC socket1,
SWR/DRIVE 7 ALC2 pin 5
control
IC1 ACC socket2,
FOR pin 5
7 1
2
1 ALC amp.
RF power control
5 3
IC1
Main CPU IC26
Relay driver
IC18
3-3
3-3-4 TEMPERATURE DETECTOR CIRCUIT 3-5 PORT ALLOCATIONS
(SPLITR AND MAIN UNITS) 3-5-1 EXPANDER IC (SWITCH BOARD; IC1)
The temperature detector circuit detects the temperature of
Pin Port
the heatsink for final FETs and controls amplifying operation. Description
number name
A thermistor (SPLITR unit; R16) detects temperature of the Outputs INPUT “1” LED control signal.
4 I1L
heatsink for final FETs, and the detected temperature signal High: While INPUT “1” LED is ON.
(DC voltage) is applied to the main CPU (MAIN unit; IC26, Outputs INPUT “2” LED control signal.
pin 12), to control the cooling fans and amplifying operation. 5 I2L
High: While INPUT “2” LED is ON.
Common 5 V is applied to the thermistor for reference. Outputs ANT “4” LED control signal.
11 A4L
High: While ANT “4” LED is ON.
Outputs ANT “3” LED control signal.
3-3-5 DRIVING FREQUENCY DETECTOR CIRCUIT 12 A3L
(SPLITR AND MAIN UNITS)
Outputs ANT “2” LED control signal.
A portion of the RF signal from RL1 (SPLITR unit) is divided 13 A2L
at C18 and C19, then applied to the driving frequency detec-
tor circuit in the MAIN unit as the “F” signal. Outputs ANT “1” LED control signal
The “F” signal from the SPLITR unit is amplified at the lim- 14 A1L
iter amplifier (MAIN unit; IC30) after being amplified at Q34
and Q35. The amplified signal is divided at the divider (MAIN
unit; IC20) for conversion to pulse-type signals. The signals
are applied to the main CPU (MAIN unit; IC26, pin 76). The
CPU counts the number of pulses as the driving frequency,
then controls the protector for frequency band selection.
3-5-2 EXPANDER IC (SWITCH BOARD; IC2)
The driving frequency detector circuit detects the input
power level at the same time to prevent malfunction at low Pin Port
Description
power level inputs. number name
Outputs “VD” LED control signal.
4 VML
High: While “VD” LED is ON.
Outputs “SWR” LED control signal.
5 SML
3-4 POWER SUPPLY CIRCUITS High: While “SWR” LED is ON.
• VOLTAGE LINE Outputs “ALC” LED control signal.
6 AML
LINE DESCRIPTION High: While “ALC” LED is ON.
+12 V line from the regulator circuit. The output Outputs “TEMP” LED control signal.
12 TML
H12 voltage is applied to the meter lamp (FRONT High: While “TEMP” LED is ON.
unit; DS1, DS2).
Outputs “ID” LED control signal.
13 IML
12 V controlled from a H12 line by the relay con- High: While “ID” LED is ON.
12 V trol circuit (IC8, IC9).
Outputs “PO” LED control signal.
14 PML
5 V DC converted from a 12 V line at IC5 on the High: While “PO” LED is ON.
5V MAIN unit. The voltage is used for the phase
detector on the DET unit.
5 V DC converted from a S12 line (+12 V) at IC6
+5 V on the FRONT unit. The voltage is used for the
output expander IC on the FRONT unit.
–5 V DC converted from a –13 V line at IC5 on
–5 V the DET board.
–13 V DC converted from a H12 (+12 V) line at
–13 V IC8 on the MAIN unit.
Transmit 13 V DC converted from a H12 (+12 V)
T13 line at Q3 on the MAIN unit.
Transmit 8 V DC converted from a T13 line at
T8V IC1 on the SPLITR unit. The output voltage is
used for PA1, PA2, PA3 and PA4 on the PA unit.
45 V line from the regulator circuit. The voltage is
HV used for PA1, PA2, PA3 and PA4 on the PA unit.
3-4
3-5-3 EXPANDER IC (SWITCH BOARD; IC3) 3-5-5 SHIFT REGISTER IC (SWITCH BOARD; IC7)
Pin Port Pin Port
Description Description
number name number name
Outputs “50” LED control signal. Input port for the antenna switching
4 50ML
High: While “50” LED is ON. 1 ANT signal.
Low: When “ANT” switch is pushed.
Outputs “24” LED control signal.
6 24ML
High: While “24” LED is ON. Input port for the tuner power ON/OFF
switching signal.
Outputs “7” LED control signal. 4 TUNER
11 7ML Low: When “TUNER” switch is
High: While “7” LED is ON.
pushed.
Outputs “10” LED control signal.
12 10ML Input port for the PA power ON/OFF
switching signal.
5 PA
Outputs “14” LED control signal. Low: When “AMP/PROTECT” switch
13 14ML is pushed.
14 18ML Outputs “18” LED control signal. Input port for the meter mode select
signal for meter-1.
6 MET1
Low: When “METER-1” switch is
pushed.
Input port for the meter mode select
signal for meter-2.
7 MET2
Low: When “METER-2” switch is
3-5-4 EXPANDER IC (SWITCH BOARD; IC4) pushed.
Pin Port Input port for the band up signal.
Description 13 BUP
number name Low: When “UP” switch is pushed.
Outputs “3.5” LED control signal.
4 3_5M Input port for the band down signal.
High: While “3.5” LED is ON.
14 BDN Low: When “DOWN” switch is
Outputs “1.8” LED control signal. pushed.
5 1_9M
High: While “1.8” LED is ON.
Input port for the port select signal.
Outputs “AMP/PROTECT” LED con- 15 I1/2 Low: When “INPUT” switch is select-
trol signal. ed.
11 PROL
High: While “AMP/PROTECT” LED is
ON.
Outputs “AMP/PROTECT” LED con-
trol signal.
12 PAL
High: While “AMP/PROTECT” LED is
ON.
Outputs “TUNER” LED control signal.
13 TUNL
High: While “TUNER” LED is ON.
Outputs “TRANSMIT” LED control sig-
14 TRANS nal.
High: While “TRANSMIT” LED is ON.
Outputs “AUTO” LED control signal.
15 AUTOL
High: While “AUTO” LED is ON.
3-5
3-5-6 CPU (MAIN UNIT; IC26)
Pin Port Pin Port
Description Description
number name number name
Input port for the forward power volt- Outputs ANT1 select signal to RL4 on
7 FOR age from IC2 (pin 1). 43 ANT1 the ANT-SW unit.
Low : When ANT1 is selected.
Input port for the reflected voltage
8 REF
from IC2 (pin 7). Outputs ANT2 select signal to RL3 on
44 ANT2 the ANT-SW unit.
Input port for the voltage from power
9 Vc supply “VO” signal. The voltage is
controlled by R197. Outputs ANT3 select signal to RL2 on
Input port for the current from power
10 Ic supply “IO” signal. The current is con-
trolled by R22. Outputs ANT4 select signal to RL1 on
Input port for the ALC signal which is
11 ALCM Low : When ANT4 is selected.
used for the METER-2.
Outputs cooling fan control signal for
Input port for the signal about temper-
12 TEMP 47 PAF the PA unit.
ature of the heatsink.
High: The PA fan is working.
16 USA Input port for the version set signal.
Low: USA version is set.
48 TUF the CHASSIS unit.
Input port for the version set signal. High: The tuner fan is working.
17 JPN
Low: JPN version is set.
Input port for the transmit switching 49 REGF the power supply unit.
32 SEND signal. High: The power supply fan is working.
Low: While transmitting
Data output port to the tuner CPU in
56 STA
Outputs a input port select signal. the MAIN unit.
33 I1/2 Low: When INPUT1 is selected.
Input port for the informed signal
High: When INPUT2 is selected.
about the power switch of the exciter
Outputs a bandpass filter select signal. 62 ACC81 on JACK1 unit.
35 1.9MF High: When 1.8–1.999 MHz band is High: When power of the exciter is
selected. ON.
Outputs a bandpass filter select signal. Input port for the protect signal about
36 3.5MF High: When 3.5–3.999 MHz band is 73 REGT tempareture of the power supply.
selected. High: While protecting.
Outputs a bandpass filter select signal. Input port for the signal to obtain sta-
74 BALA
37 7MF High: When 7.0–7.300 MHz band is ble power from the PA unit.
selected.
Data input port from the tuner CPU in
79 KEY
Outputs a bandpass filter select signal. the MAIN unit.
38 10MF High: When 10.10–10.150 MHz band
Input port for the protect signal about
is selected.
80 MAXI the the power supply current.
Outputs a bandpass filter select signal. High: While protecting.
39 14MF High: When 14.10–14.350 MHz band
is selected.
Outputs a bandpass filter select signal.
40 18MF High: When 18.068–18.168 MHz
band is selected.
41 24MF High: When 24.980–24.990 MHz
band is selected.
42 50MF High: When 50.000–54.000 MHz
band is selected.
3-6
SECTION 4 ADJUSTMENT PROCEDURES
4-1 PREPARATION
‘ REQUIRED TEST EQUIPMENT
EQUIPMENT GRADE AND RANGE EQUIPMENT GRADE AND RANGE

Frequency range : 1.8–60 MHz Ammeter Capability : 0.1–100 A
Output power : 50–100 W
Exciter (Transceiver) Mode : RTTY or FM Impedance : 50, 100 and 150 Ω
RF dummy load Capability : 1500 W or more
IC-736 (for tuner basis voltage adjustment)
Digital DC voltmeter Input impedance : 10 MΩ/V DC or better
Measuring range : 10–1500 W
RF power meter Frequency range : 1.8–60 MHz DC voltmeter Input impedance : 50 kΩ/V DC or better
(terminated type) Impedance : 50 Ω Load-resistor Capability : 9.7–10.3 A
SWR : Less than 1.2 : 1
■ CONNECTION
Connect 2-conductor plug to REMOTE

connector when adjusting meter maximum
point.
1/8" (3.5 mm)

2-conductor plug
Shorten inner and outer plugs
RF
dummy load
RF power meter
1500 W/50 Ω
Coaxial cable
to the ANT1 connector
INPUT1
Coaxial cable
EXCITER
RF OUT
GND
GND
IC-PW1
Ground
AC outlet
[USA] : 100–120/220–240 V
[EUR] and [EUR-1] : 230 V
4-1
4-2 PA AND FRONT UNIT ADJUSTMENT
Idling current must be taken out the PA unit from the main body.
ADJUSTMENT
MEASUREMENT
ADJUSTMENT ADJUSTMENT CONDITION VALUE POINT
UNIT LOCATION UNIT ADJUST
IDLING 1 • [POWER] switch : OFF Front Connect the DC 100 mA PA1 R9
CURRENT • Pre-set R9 and R10 on the PA1 panel ammeter to the HV
board to maximum counterclock- line between PA1
wise position. board and the
• [POWER] switch : ON power supply unit.
• [AMP] switch : ON
• Exciter frequency : 14.1 MHz
• Mode : USB
• Apply no audio signal to the
[MICROPHONE] connector.
• Connect the lead of L6 to ground.
• Transmitting.
2 • Disconnect the lead of L6 from Front Connect the DC 200 mA PA1 R10
ground. panel ammeter to the HV
• Connect the lead of L5 to ground. line between PA1
• Transmitting. board and the
power supply unit.
3 • Disconnect the lead of L5 from 200 mA R9
ground.
• Connect the lead of L6 to ground.
4 • Same adjustments as steps 1–4 for PA2–PA4 boards.

METER 1 • [POWER] switch : OFF Controller [METER-1] Set as below : SW R56
MAXIMUM • Connect the terminator to 1.5 k
POINT [REMOTE] jack, then while push-
ing the [ANT] switch, turn power 0
100 250 500 1K
1.5K
20 30 40
ON. PO
ID
0
10
HOT
50
60
A
W
• METER-1 : [PO] scale TEMP
• METER-2 : [VD] scale METER-1
2 [METER-2] Set as below : R57

60
10 20 30 40
50
0 60
1.5 2 3
VD 1 V
SWR ALC adj
ALC
METER-2
4-2
• Idling current adjustment
Front side (after removed front panel)
WS1
ID ALC and ID meter check point
Ammeter
L6
Connect the lead of L6 to ground
PA1–PA4 boards
R10
FRONT R9
SIDE
• Idling current pre-setting
• Idling current adjustment
PA-1 BOARD L5
PA-2 BOARD
PA-3 BOARD Connect the lead of L5
PA-4 BOARD
to ground
• Meter maximum point adjustment

Switch board
SW BOARD
FRONT
SIDE
R57
R56
Meter maximum point adjustment
4-3
4-3 MAIN UNIT ADJUSTMENT
The TUNER BASIS VOLTAGE ADJUSTMENT needs the IC-736 as an exciter.
ADJUSTMENT
MEASUREMENT
SWR 1 • Input AC voltage : 200 V Controller [METER-1] 400 W Exciter RF
DETECTOR • Pre-set R4, R6, R15 to 90˚ coun- power
CIRCUIT terclockwise volume
• Pre-set R5, R22 to center.
• Pre-set S3 to 5, and S4 to 4.
• [METER-1] : [PO] scale
• Pre-set ALC adj1 to max. coun-
terclockwise, and then turn slow-
ly ALC adj1 to max. clockwise.
• Mode : RTTY
• RF power : minimum
• Transmitting
2 • [METER-2] : [SWR] scale [METER-2] Minimum value FILTER C73
• Transmitting
• After adjustment, reset ALC adj1 to max. conterclockwise.
TUNER 1 • Disconnect J5 on the tuner unit of IC-736 DISPLAY Display of IC-736 Verify
BASIS VOLT- IC-736, and then connect to J18 shows “SET”.
AGE on the MAIN unit of IC-PW1.
• Connect [ANT1] connector of IC-
736 to [INPUT1] connector of IC-
PW1.
• Connect a 150 Ω dummy load to
[ANT1] connector of IC-PW1.
• Turn S5 to “SET”.
• Connect CP1 to ground.
• Push and hold [ANT], [ENT] and
[TUNER] switches of IC-736,
then turn IC-736 ON.
2 • Push [TUNER] key of IC-736. Display of IC-736
shows “END”.
After adjustment, remove the jumper wire from CP1 and reset S5 to counter side.
• SWR detector circuit adjustment Rear panel
INPUT1
ANT4 ANT3 ANT2 ANT1
ACC-2 ALC2 SEND2 ACC-1 ALC1 SEND1 INPUT2
EXCITER
1 1&2
CONTROLLER
REMOTE ALC adj2 REMOTE ALC adj1
ALC adj1
SWR detector circuit
L
pre-setting
4-4
• SWR detector circuit adjustment
MAIN unit
R15
R6
R4
FRONT SWR detector R5
SIDE
pre-setting R22
S3
S4
MAIN UNIT
Filter unit
C73
FRONT
SIDE
SWR detector circuit adjustment
FILTER UNIT
• Tuner basis voltage adjustment
FRONT
SIDE
MAIN UNIT
J5
Disconnect J5 from here
J18
Connect J5 on the tuner unit Bottom view of IC-736
of IC-736 to here
MAIN unit of IC-PW1
S5 CP1
Tuner basis voltage pre-setting
4-5
MAIN UNIT ADJUSTMENT (Continued)
ADJUSTMENT
MEASUREMENT
POWER SET 1 • Input AC voltage : 200 V Controller [METER-2] Set [ALC] meter to REAR ALC adj1
(HF BAND, • METER-1 : [PO] scale center as below: panel
AC 200 V,) • METER-2 : [ALC] scale
• Exciter frequency : 21.1 MHz 0
10 20 30 40
50
60
1.5 2 3
• Mode : RTTY VD
SWR
1
ALC adj
V
• Transmitting ALC
METER-2
2 REAR Connect the RF 1050 W MAIN R4

panel power meter to the
[ANT1] connector.
3 • Repeat steps1, 2 several times for precision.
(AC 100 V) 1 • Input AC voltage : 100 V Controller [METER-2] Set [ALC] meter to REAR ALC adj1
[USA], [EUR] • Set ALC adj1 to max. counter- center as below: panel
only clockwise.
• Exciter frequency : 14.1 MHz 0
10 20 30 40
50
60
1.5 2 3
• Mode : RTTY VD
SWR
1
ALC adj
V
• Transmitting ALC
METER-2
2 REAR Connect the RF 520 W MAIN R6

panel power meter to the
[ANT1] connector.
3 • Repeat steps1, 2 several times for precision.
(50 MHz, 1 • Input AC voltage : 200 V REAR Connect the RF 1020 W MAIN R5
AC 200 V) • Exciter frequency : 50.2 MHz panel power meter to the
• Mode : RTTY [ANT1] connector.
• Transmitting
PO 1 • Turn ALC adj1 to max. counter- REAR Connect the RF 1050 W REAR ALC adj1
METER SET clockwise. panel power meter to the panel
(HF bands) • METER-1 : [PO] scale [ANT1] connector.
• Mode : RTTY
• Transmitting
2 Controller [METER-1] 1050 W MAIN R26
(50 MHz band) 1 • Connect the RF power meter to Controller [METER-1] Same power as the MAIN R240
the [ANT1] connector. RF power meter.
• Transmitting
SWR 1 • Connect a 100 Ω dummy load to Controller [METER-2] SWR 2 MAIN R31
METER SET [ANT1] connector.
• METER-2 : [SWR] scale
• Mode : RTTY
• Power : 1 kW
• Transmitting
VD 1 • METER-2 : [VD] scale Controller [METER-2] Same voltage as the MAIN R197
METER SET • Connect the DC voltmeter DC voltmeter.
between the “HV” line and the
“GND” line of the power supply
unit.
4-6
Rear panel
INPUT1
ANT4 ANT3 ANT2 ANT1
ACC-2 ALC2 SEND2 ACC-1 ALC1 SEND1 INPUT2
EXCITER
1 1&2
CONTROLLER
REMOTE ALC adj2 REMOTE ALC adj1
ALC adj1
• Power set adjustment for HF band
• PO meter set adjustment L
FRONT
SIDE
MAIN UNIT
MAIN unit
R5
Power set adjustment
for 50 MHz band
R4
Power set adjustment
for HF band R26
PO meter set adjustment
(AC 200 V) R240
R6 R31
Power set adjustment SWR meter set adjustment
for HF band R197
(AC 100 V) VD meter set adjustment

• VD meter set adjustment
WS1
VD meter set check point
DC voltmeter
4-7
MAIN UNIT ADJUSTMENT (Continued)
ADJUSTMENT
MEASUREMENT
ID ALC 1 • Connect a DC ammeter to the Controller [METER-1] Set [ID] meter to a half MAIN R22
“HV” line between power supply value of connecting
unit and PA unit. ammeter.
2 • METER-1 : [ID] scale. Front Ammeter 38 A Exciter RF
• Exciter frequency : 14.1 MHz panel power
• Mode : RTTY
• Transmitting
3 • Connect a load-resistor between 9.7 – 10.3 A The
“HV” line and “GND” line on load-
power supply unit. resistor
• Transmitting
• Disconnect a DC ammeter, and
then connect a DC ammeter to
the “HV” line between power sup-
ply unit and a load-resistor.
4 • Disconnect a DC ammeter, and 34.7 – 35.3 A MAIN R15
then connect a DC ammeter to
the “HV” line between power sup-
ply unit and PA unit.
ID METER 1 • Connect a DC ammeter to the Controller [METER-1] The same value of the MAIN R22
“HV” line between power supply ammeter.
unit and PA unit.
• METER-1 : [ID] scale.
• Mode : RTTY
• Transmitting
• ID ALC and ID meter adjustment
MAIN unit
FRONT
SIDE
R15
R22
ID ALC adjustment
MAIN UNIT
R22
ID meter adjustment
4-8
• ID ALC and ID meter adjustment
WS1
ID ALC and ID meter check point
Ammeter
• ID ALC adjustment
load-resistor
Ammeter
WS1
ID ALC check point
WS1
ID ALC check point
Ammeter
4-9
SECTION 5 PARTS LIST
[MAIN UNIT] [MAIN UNIT]

REF ORDER REF ORDER
DESCRIPTION DESCRIPTION
NO. NO. NO. NO.
IC1 1110001340 S.IC NJM3403AM-T1 D2 1790000620 S.DIODE MA77 (TX)
IC2 1110000960 S.IC NJM4558M-T1 D3 1790000620 S.DIODE MA77 (TX)
IC3 1110000960 S.IC NJM4558M-T1 D4 1730000680 S.ZENER RD4.7M-T2B2
IC4 1110000960 S.IC NJM4558M-T1 D6 1730000680 S.ZENER RD4.7M-T2B2
IC5 1180001070 S.IC TA7805F (TE16L) D7 1790001640 S.DIODE 1SS373 (TPH3)
IC7 1140003610 S.IC X24C04S8-2.7T6 D8 1790001640 S.DIODE 1SS373 (TPH3)
IC8 1180001260 S.IC BA9700AF-T1 D11 1750000270 S.DIODE 1SS301 (TE85R)
IC9 1110000960 S.IC NJM4558M-T1 D12 1750000270 S.DIODE 1SS301 (TE85R)
IC10 1130003920 S.IC TC4S69F (TE85R) D13 1750000290 S.DIODE 1SS300 (TE85R)
IC11 1130003920 S.IC TC4S69F (TE85R)
D14 1750000290 S.DIODE 1SS300 (TE85R)
IC12 1140004120 S.IC M38022M2-138FP
D15 1790001130 S.DIODE D2FS4-4063
IC13 1110001550 S.IC S-8054ALB-LM-T1
D16 1790000620 S.DIODE MA77 (TX)
IC14 1160000130 S.IC TD62783AF (TP1)
IC15 1110004510 S.IC TD62597AFN (EL) D17 1790000620 S.DIODE MA77 (TX)
IC16 1130001880 S.IC µPD4069UBG-T1 D18 1790000620 S.DIODE MA77 (TX) [USA] only
IC17 1140004450 S.IC X24C01AS-3.0T6 D20 1790000620 S.DIODE MA77 (TX)
IC18 1160000130 S.IC TD62783AF (TP1) D21 1790000620 S.DIODE MA77 (TX)
IC19 1160000130 S.IC TD62783AF (TP1) D23 1730000410 S.ZENER RD5.1M-T2B2
IC20 1130008410 S.IC TC74AC393F (EL) D24 1730000410 S.ZENER RD5.1M-T2B2
IC21 1110000960 S.IC NJM4558M-T1 D26 1750000270 S.DIODE 1SS301 (TE85R)
IC25 1110001550 S.IC S-8054ALB-LM-T1 D27 1790000620 S.DIODE MA77 (TX)
IC26 1140007690 S.IC TMP90PM38F D50 1790000620 S.DIODE MA77 (TX)
IC27 1130003760 S.IC TC4S81F (TE85R) D51 1790000620 S.DIODE MA77 (TX)
IC28 1140003830 S.IC TC4W66F (TE12L) D52 1750000270 S.DIODE 1SS301 (TE85R)
IC30 1130007430 S.IC TC7S14FU (TE85R) D54 1790000620 S.DIODE MA77 (TX)
IC31 1110000960 S.IC NJM4558M-T1 D55 1790000620 S.DIODE MA77 (TX)
IC33 1130005820 S.IC TC4S584F (TE85R) D56 1790001640 S.DIODE 1SS373 (TPH3)
D59 1790001640 S.DIODE 1SS373 (TPH3)
D60 1790001640 S.DIODE 1SS373 (TPH3)
Q1 1510000780 S.TRANSISTOR 2SA1586-Y (TE85R)
D61 1750000270 S.DIODE 1SS301 (TE85R)
Q2 1530002690 S.TRANSISTOR 2SC4116-GR (TE85R)
D62 1750000290 S.DIODE 1SS300 (TE85R)
Q3 1520000530 S.TRANSISTOR 2SB1119S-TD
D63 1750000270 S.DIODE 1SS301 (TE85R)
Q4 1590002310 S.TRANSISTOR DTC114EE TL
D66 1790001130 S.DIODE D2FS4-4063
D67 1790001640 S.DIODE 1SS373 (TPH3)
D68 1790001640 S.DIODE 1SS373 (TPH3)
D69 1790000620 S.DIODE MA77 (TX)
D70 1790001640 S.DIODE 1SS373 (TPH3)
D71 1790000620 S.DIODE MA77 (TX)
D72 1750000270 S.DIODE 1SS301 (TE85R)
D73 1750000270 S.DIODE 1SS301 (TE85R)
D75 1750000270 S.DIODE 1SS301 (TE85R)
D76 1790001640 S.DIODE 1SS373 (TPH3)
X1 6050009890 S.XTAL CR-569 (6.144 MHz)
X2 6050009870 S.XTAL CR-567 (9.8304 MHz)
L1 6200003260 S.COIL NL 322522T-101J
L2 6200003260 S.COIL NL 322522T-101J
L3 6200003260 S.COIL NL 322522T-101J
Q23 1510000780 S.TRANSISTOR 2SA1586-Y (TE85R)
L4 6200003260 S.COIL NL 322522T-101J
L5 6200003260 S.COIL NL 322522T-101J
L6 6200003260 S.COIL NL 322522T-101J
Q26 1510000670 S.TRANSISTOR 2SA1588-GR (TE85R)
L7 6200003260 S.COIL NL 322522T-101J
L8 6200003260 S.COIL NL 322522T-101J
L9 6200001830 S.COIL NL 322522T-100J
L10 6200001830 S.COIL NL 322522T-100J
L11 6200003260 S.COIL NL 322522T-101J
L12 6200003260 S.COIL NL 322522T-101J
L13 6200003260 S.COIL NL 322522T-101J
Q34 1530002370 S.TRANSISTOR 2SC2714-O (TE85R)
L14 6200003260 S.COIL NL 322522T-101J
Q35 1560000270 S.FET 2SK302-Y (TE85R)
L15 6200003260 S.COIL NL 322522T-101J
L16 6200003260 S.COIL NL 322522T-101J
L17 6200001830 S.COIL NL 322522T-100J
L19 6200003260 S.COIL NL 322522T-101J
L21 6200003260 S.COIL NL 322522T-101J
L22 6200003260 S.COIL NL 322522T-101J
L24 6200003260 S.COIL NL 322522T-101J
L25 6200003260 S.COIL NL 322522T-101J
L27 6200001830 S.COIL NL 322522T-100J
L28 6140002220 COIL LR-270
L29 6190000220 COIL S0971136-101K
L30 6200003260 S.COIL NL 322522T-101J
L31 6200003260 S.COIL NL 322522T-101J
L32 6200003260 S.COIL NL 322522T-101J
D1 1790001640 S.DIODE 1SS373 (TPH3)
L35 6140002220 COIL LR-270
S.=Surface mount
5-1
REF ORDER REF ORDER
NO. NO. NO. NO.
L36 6200003260 S.COIL NL 322522T-101J R14 7030003690 S.RESISTOR ERJ3GEYJ 124 V (120 kΩ)
L37 6180000990 COIL LAL 04NA 101K R15 7310002740 S.TRIMMER RV-150 (RH03A3A14X0FC) 103
L38 6200003950 S.COIL HF50ACC 322513-T R22 7310002580 S.TRIMMER RV-108 (RH03A3A15X05A) 104
L39 6200003950 S.COIL HF50ACC 322513-T R23 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)
L42 6200003950 S.COIL HF50ACC 322513-T R26 7310002820 S.TRIMMER RV-158 (RH03A3AS5) 474
L47 6200003950 S.COIL HF50ACC 322513-T R31 7310002820 S.TRIMMER RV-158 (RH03A3AS5) 474
L54 6200003950 S.COIL HF50ACC 322513-T R38 7030003450 S.RESISTOR ERJ3GEYJ 122 V (1.2 kΩ)
L64 6200003950 S.COIL HF50ACC 322513-T R52 7030006060 S.RESISTOR ERJ12YJ100H (10 Ω)
L76 6200003260 S.COIL NL 322522T-101J R64 7030003540 S.RESISTOR ERJ3GEYJ 682 V (6.8 kΩ)
L80 6910003570 COIL 2943-666663 R68 7030003630 S.RESISTOR ERJ3GEYJ 393 V (39 kΩ)
L82 6200003260 S.COIL NL 322522T-101J R70 7030003380 S.RESISTOR ERJ3GEYJ 331 V (330 Ω)
L100 6200003260 S.COIL NL 322522T-101J R71 7030006220 S.RESISTOR ERJ12YJ470H (47 Ω)
L101 6200003260 S.COIL NL 322522T-101J R73 7030008170 S.RESISTOR ERJ12YJ1R0H (1 Ω)
L107 6910003570 COIL 2943-666663 R78 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ)
L108 6910003570 COIL 2943-666663 R79 7030003810 S.RESISTOR ERJ3GEYJ 125 V (1.2 MΩ)
L114 6180000900 COIL LAL 03NA 101K R85 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
L115 6180000880 COIL LAL 03NA 100K R86 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ)
L116 6180000880 COIL LAL 03NA 100K R87 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)
L119 6200003260 S.COIL NL 322522T-101J R90 7030003380 S.RESISTOR ERJ3GEYJ 331 V (330 Ω)
R96 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)
R1 7030003840 S.RESISTOR ERJ3GEYJ 225 V (2.2 MΩ) R98 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)
R2 7030003740 S.RESISTOR ERJ3GEYJ 334 V (330 kΩ) R99 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)
R4 7310002580 S.TRIMMER RV-108 (RH03A3A15X05A) 104 R101 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)
R5 7310002840 S.TRIMMER RV-160 (RH03A3A16) 105 R102 7030003370 S.RESISTOR ERJ3GEYJ 271 V (270 Ω)
R6 7310002580 S.TRIMMER RV-108 (RH03A3A15X05A) 104 R103 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)
S.=Surface mount
5-2
REF ORDER REF ORDER
NO. NO. NO. NO.
R119 7030003540 S.RESISTOR ERJ3GEYJ 682 V (6.8 kΩ) R210 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ)
R122 7030003590 S.RESISTOR ERJ3GEYJ 183 V (18 kΩ) R213 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ)
R123 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) R222 7010006930 RESISTOR PSD1/4 470 Ω
R124 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) R223 7010006930 RESISTOR PSD1/4 470 Ω
R132 7030003620 S.RESISTOR ERJ3GEYJ 333 V (33 kΩ) R229 7030003820 S.RESISTOR ERJ3GEYJ 155 V (1.5 MΩ)
R136 7030003540 S.RESISTOR ERJ3GEYJ 682 V (6.8 kΩ) R232 7010000990 RESISTOR R25XJ 47 Ω
R140 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) R222 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω)
R141 7030000420 S.RESISTOR MCR10EZHJ 2.2 kΩ R223 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω)
R142 7030000420 S.RESISTOR MCR10EZHJ 2.2 kΩ R229 7030003710 S.RESISTOR ERJ3GEYJ 184 V (180 kΩ)
R145 7030000420 S.RESISTOR MCR10EZHJ 2.2 kΩ R238 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ)
R146 7030000420 S.RESISTOR MCR10EZHJ 2.2 kΩ R240 7310002840 S.TRIMMER RV-160 (RH03A3A16) 105
R148 7030000420 S.RESISTOR MCR10EZHJ 2.2 kΩ
R149 7030000420 S.RESISTOR MCR10EZHJ 2.2 kΩ
R150 7030000420 S.RESISTOR MCR10EZHJ 2.2 kΩ C1 4030006880 S.CERAMIC C1608 JB 1H 472K-T-A
R152 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) C3 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
R160 7030003760 S.RESISTOR ERJ3GEYJ 474 V (470 kΩ) C17 4030006880 S.CERAMIC C1608 JB 1H 472K-T-A
R161 7030003380 S.RESISTOR ERJ3GEYJ 331 V (330 Ω) C18 4030006880 S.CERAMIC C1608 JB 1H 472K-T-A
R163 7030003420 S.RESISTOR ERJ3GEYJ 681 V (680 Ω) C20 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
R172 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ) C29 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
R173 7030000420 S.RESISTOR MCR10EZHJ 2.2 kΩ C31 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
R174 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ) C33 4030006880 S.CERAMIC C1608 JB 1H 472K-T-A
R178 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ) C37 4510004640 S.ELECTROLYTIC ECEV1CA470SP
R181 7030000420 S.RESISTOR MCR10EZHJ 2.2 kΩ C40 4510004640 S.ELECTROLYTIC ECEV1CA470SP
R182 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ) C41 4030006880 S.CERAMIC C1608 JB 1H 472K-T-A
R186 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ) C46 4510006240 S.ELECTROLYTIC ECEV1CA221P
R187 7030000420 S.RESISTOR MCR10EZHJ 2.2 kΩ C47 4030010210 S.CERAMIC C3216 JB 1C 105M-T-A
R188 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ) C48 4510006670 S.ELECTROLYTIC ECEV 1CA 471P
R189 7030000420 S.RESISTOR MCR10EZHJ 2.2 kΩ C49 4510006670 S.ELECTROLYTIC ECEV 1CA 471P
R190 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ) C50 4030010210 S.CERAMIC C3216 JB 1C 105M-T-A
R191 7030000420 S.RESISTOR MCR10EZHJ 2.2 kΩ C51 4030010210 S.CERAMIC C3216 JB 1C 105M-T-A
R192 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ) C52 4510004640 S.ELECTROLYTIC ECEV1CA470SP
R193 7030000420 S.RESISTOR MCR10EZHJ 2.2 kΩ C53 4510004640 S.ELECTROLYTIC ECEV1CA470SP
R197 7310002760 S.TRIMMER RV-152 (RH03A3AJ4X0HA) 223 C56 4510005600 S.ELECTROLYTIC ECEV1CS100SR
S.=Surface mount
5-3
REF ORDER REF ORDER
NO. NO. NO. NO.
C61 4030011600 S.CERAMIC C1608 JB 1C 104KT-N C227 4030008920 S.CERAMIC C1608 JB 1C 473K-T-A
C64 4030011600 S.CERAMIC C1608 JB 1C 104KT-N C228 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C66 4510005600 S.ELECTROLYTIC ECEV1CS100SR C230 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
C67 4030006880 S.CERAMIC C1608 JB 1H 472K-T-A C231 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
C68 4030011600 S.CERAMIC C1608 JB 1C 104KT-N C232 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
C69 4030007030 S.CERAMIC C1608 CH 1H 150J-T-A C223 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
C70 4030007030 S.CERAMIC C1608 CH 1H 150J-T-A C233 4510005600 S.ELECTROLYTIC ECEV1CS100SR
C71 4030011600 S.CERAMIC C1608 JB 1C 104KT-N C234 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
C73 4030011600 S.CERAMIC C1608 JB 1C 104KT-N C236 4510003840 ELECTROLYTIC 50 MV 1 SWB
C75 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
C77 4030011600 S.CERAMIC C1608 JB 1C 104KT-N RL2 6330001320 RELAY AHY103
C78 4030011600 S.CERAMIC C1608 JB 1C 104KT-N RL3 6330001320 RELAY AHY103
C81 4030011600 S.CERAMIC C1608 JB 1C 104KT-N J2 6510019140 S.CONNECTOR 52610-1090
C82 4030011600 S.CERAMIC C1608 JB 1C 104KT-N J3 6510003450 CONNECTOR B09B-EH-S
C88 4030009660 S.CERAMIC C1608 JF 1C 224Z-T-A J14 6510017650 CONNECTOR 52045-1045
C94 4030006880 S.CERAMIC C1608 JB 1H 472K-T-A J21 6510003440 CONNECTOR B08B-EH-S
C98 4030011600 S.CERAMIC C1608 JB 1C 104KT-N S3 2260002220 SWITCH S-1010A
C99 4030011600 S.CERAMIC C1608 JB 1C 104KT-N S4 2260002220 SWITCH S-1010A
C100 4030011600 S.CERAMIC C1608 JB 1C 104KT-N S5 2220000530 S.SWITCH SW-161
C103 4030011600 S.CERAMIC C1608 JB 1C 104KT-N EP1 0910051090 PCB B 4891J
C110 4030011600 S.CERAMIC C1608 JB 1C 104KT-N [FILTER UNIT]
C111 4030011600 S.CERAMIC C1608 JB 1C 104KT-N REF ORDER
C112 4030011600 S.CERAMIC C1608 JB 1C 104KT-N DESCRIPTION
NO. NO.
C114 4030011340 S.CERAMIC C1608 CH 1H 471J-T-A D2 1710000470 DIODE 1S955
C115 4030011600 S.CERAMIC C1608 JB 1C 104KT-N D4 1710000470 DIODE 1S955
C121 4030008920 S.CERAMIC C1608 JB 1C 473K-T-A D6 1710000470 DIODE 1S955
C122 4030010110 S.CERAMIC C1608 SL 1H 471J-T-A D8 1710000470 DIODE 1S955
C123 4030008920 S.CERAMIC C1608 JB 1C 473K-T-A D10 1710000470 DIODE 1S955
C124 4030006880 S.CERAMIC C1608 JB 1H 472K-T-A D12 1710000470 DIODE 1S955
C125 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A D14 1710000470 DIODE 1S955
C126 4030011600 S.CERAMIC C1608 JB 1C 104KT-N D15 1710000980 DIODE MBD701
C201 4030007020 S.CERAMIC C1608 CH 1H 120J-T-A D16 1710000980 DIODE MBD701
C202 4030007020 S.CERAMIC C1608 CH 1H 120J-T-A D17 1710000470 DIODE 1S955
C203 4030011600 S.CERAMIC C1608 JB 1C 104KT-N D18 1710000470 DIODE 1S955
C206 4030011600 S.CERAMIC C1608 JB 1C 104KT-N L1 6110003450 COIL LA-539
C210 4030006880 S.CERAMIC C1608 JB 1H 472K-T-A L6 6110003420 COIL LA-541
C211 4030011600 S.CERAMIC C1608 JB 1C 104KT-N L7 6140001900 COIL LR-200
C213 4510005600 S.ELECTROLYTIC ECEV1CS100SR L9 6140001890 COIL LR-198
C221 4030011600 S.CERAMIC C1608 JB 1C 104KT-N L15 6180001220 COIL LAL 04NA 100K
C222 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A L16 6180001220 COIL LAL 04NA 100K
C226 4030008920 S.CERAMIC C1608 JB 1C 473K-T-A L20 6180000990 COIL LAL 04NA 101K
S.=Surface mount
5-4
[FILTER UNIT] [FILTER UNIT]
REF ORDER REF ORDER
NO. NO. NO. NO.
L21 6180000990 COIL LAL 04NA 101K C66 4040000150 BARRIER UAT 05X 472K
L22 6140001000 COIL LR-123 C68 4040000150 BARRIER UAT 05X 472K
L27 6110003440 COIL LA-538 C71 4030004740 S.CERAMIC C2012 JB 1H 472K-T-A
L28 6110003460 COIL LA-537 C72 4030004740 S.CERAMIC C2012 JB 1H 472K-T-A
L29 6110003460 COIL LA-537 C73 4610001220 TRIMMER CVE101-56 (100P)
L30 6180001220 COIL LAL 04NA 100K C74 4030005040 S.CERAMIC C2012 CH 1H 271J-T-A
L31 6110002260 COIL LA-403 C75 4040000150 BARRIER UAT 05X 472K
L32 6180000990 COIL LAL 04NA 101K C76 4010005080 CERAMIC DE0707 SL 470J 3KV
L33 6910000670 COIL BL01RN1-A62-001 C77 4010005070 CERAMIC DE0707 SL 390J 3KV
C78 4010005110 CERAMIC DE0910 SL 220J 6KV
R2 7010004320 RESISTOR R20J 10 kΩ C80 4010004310 CERAMIC DE0705 SL 100D 1KV
R3 7010004320 RESISTOR R20J 10 kΩ C81 4010004310 CERAMIC DE0705 SL 100D 1KV
R4 7010004320 RESISTOR R20J 10 kΩ C83 4010005030 CERAMIC DE0707 SL 120J 3KV
R7 7030007360 S.RESISTOR ERJ1WYJ470H (47 Ω) C87 4010005030 CERAMIC DE0707 SL 120J 3KV
R15 7540000050 ABSORBER DSA-701MA C100 4010000500 CERAMIC DD104 B 102K 50V
C101 4040000150 BARRIER UAT 05X 472K
C102 4040000150 BARRIER UAT 05X 472K
C1 4010004770 CERAMIC DE0910 SL 390J 6KV C103 4040000150 BARRIER UAT 05X 472K
C4 4010005130 CERAMIC DE0910 SL 470J 6KV C104 4040000150 BARRIER UAT 05X 472K
C5 4010005130 CERAMIC DE0910 SL 470J 6KV C107 4030004740 S.CERAMIC C2012 JB 1H 472K-T-A
C7 4010004760 CERAMIC DE0910 SL 330J 6KV C110 4010004820 CERAMIC DE1410 SL 121J 6KV
C9 4010004800 CERAMIC DE1210 SL 820J 6KV C115 4010006900 CERAMIC HE80SJ YB 472K 50V
C26 4010004830 CERAMIC DE1510 SL 151J 6KV C133 4030008960 S.CERAMIC C2012 JB 1C 104K-T-A
C27 4010004830 CERAMIC DE1510 SL 151J 6KV C134 4030008960 S.CERAMIC C2012 JB 1C 104K-T-A
C39 4010004290 CERAMIC DE1310 SL 181J 3KV RL1 6330000201 RELAY VS-12TBU-E-UC
C49 4320000640 DIP MICA DM20C681J5-N RL11 6330000201 RELAY VS-12TBU-E-UC
C50 4320000640 DIP MICA DM20C681J5-N RL12 6330000201 RELAY VS-12TBU-E-UC
C53 4010004300 CERAMIC DE1410 SL 221J 3KV RL15 6330001500 RELAY AW3033
C54 4010004300 CERAMIC DE1410 SL 221J 3KV RL16 6330001210 RELAY VB-12TBU-UC (UL3)
C55 4320000640 DIP MICA DM20C681J5-N RL17 6330001210 RELAY VB-12TBU-UC (UL3)
C56 4320000640 DIP MICA DM20C681J5-N
C58 4040000150 BARRIER UAT 05X 472K
C60 4040000150 BARRIER UAT 05X 472K
C62 4040000150 BARRIER UAT 05X 472K
C64 4040000150 BARRIER UAT 05X 472K
S.=Surface mount
5-5
[FILTER UNIT] [SPLITR UNIT]
REF ORDER REF ORDER
NO. NO. NO. NO.
WS1 8600035753 M.OTHER EX1900 P01*J01FI-3 IC1 1180001250 S.IC TA7808F (TE16L)
WS2 8970022640 M.OTHER EX1900 1.5D COAXIAL (1)/FI
WS3 8970022650 M.OTHER EX1900 TEFLON COAXIAL (1)/FI
WS5 8970023250 M.OTHER EX1900 J LEAD SET (1)/FI D1 1750000270 S.DIODE 1SS301 (TE85R)
D2 1750000270 S.DIODE 1SS301 (TE85R)
D3 1790000490 S.DIODE HSM88AS-TR
EP1 6910011330 TERMINAL OT-009 M3 D4 1710000950 DIODE RG3D
EP2 6910011330 TERMINAL OT-009 M3 D5 1710000950 DIODE RG3D
EP3 6910011330 TERMINAL OT-009 M3
EP4 6910011330 TERMINAL OT-009 M3
EP5 0910048749 PCB B 4888I L1 6200003260 S.COIL NL 322522T-101J
L2 6140000970 COIL LR-119
L3 6140000970 COIL LR-119
L4 6140001000 COIL LR-123
L5 6180000900 COIL LAL 03NA 101K
L6 6140001000 COIL LR-123
L7 6200003260 S.COIL NL 322522T-101J
[COMBINR UNIT] L8 6200003260 S.COIL NL 322522T-101J
REF ORDER L9 6200003260 S.COIL NL 322522T-101J
DESCRIPTION L10 6200003260 S.COIL NL 322522T-101J
NO. NO.
L11 6200003260 S.COIL NL 322522T-101J
D1 1710000040 DIODE 1S953
D2 1710000040 DIODE 1S953
D3 1710000040 DIODE 1S953 R1 7070000591 RESISTOR ERG1SJ 333 (33 kΩ)
R2 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ)
R3 7100000580 RESISTOR SRW7P-M 50 Ω (500)
L1 6140000970 COIL LR-119 R4 7100000580 RESISTOR SRW7P-M 50 Ω (500)
L5 6140003290 COIL LR-365 R7 7030008020 S.RESISTOR ERJ12YJ472H (4.7 kΩ)
R8 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω)
R9 7030006180 S.RESISTOR ERJ1WYJ101H (100 Ω)
R1 7070000830 RESISTOR ERG3SJ 101 (100 Ω) R10 7030006180 S.RESISTOR ERJ1WYJ101H (100 Ω)
R2 7070000830 RESISTOR ERG3SJ 101 (100 Ω) R11 7030006070 S.RESISTOR ERJ12YJ101H (100 Ω)
R3 7010004070 RESISTOR R20J 100 Ω R12 7030006070 S.RESISTOR ERJ12YJ101H (100 Ω)
R4 7010003950 RESISTOR R20J 10 Ω R13 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)
R5 7010003950 RESISTOR R20J 10 Ω R14 7030003590 S.RESISTOR ERJ3GEYJ 183 V (18 kΩ)
R6 7100000580 RESISTOR SRW7P-M 50 Ω (500) R15 7030003690 S.RESISTOR ERJ3GEYJ 124 V (120 kΩ)
R7 7010003910 RESISTOR R20J 4.7 Ω R16 7510000140 THERMISTOR ERT-D2FHL 802S
R8 7010003970 RESISTOR R20J 15 Ω R17 7030003460 S.RESISTOR ERJ3GEYJ 152 V (1.5 kΩ)
R9 7010003950 RESISTOR R20J 10 Ω R18 7030006210 S.RESISTOR ERJ12YJ4R7H (4.7 Ω)
R10 7010003950 RESISTOR R20J 10 Ω
R11 7010004070 RESISTOR R20J 100 Ω
C1 4030006880 S.CERAMIC C1608 JB 1H 472K-T-A
C2 4030011790 S.CERAMIC GRM44-1 Y5V 684Z 100PT
C1 4040000690 BARRIER UAT 08X 473K C3 4030006880 S.CERAMIC C1608 JB 1H 472K-T-A
C2 4040000690 BARRIER UAT 08X 473K C4 4510005840 S.ELECTROLYTIC ECEV1HANR47R
C4 4010004790 CERAMIC DE1210 SL 680J 6KV C7 4030006960 S.CERAMIC C1608 CH 1H 050C-T-A
C5 4010005110 CERAMIC DE0910 SL 220J 6KV C8 4010006900 CERAMIC HE80SJ YB 472K 50V
C6 4010005110 CERAMIC DE0910 SL 220J 6KV C9 4510006880 ELECTROLYTIC 100 MV 33 CZ
C7 4030005050 S.CERAMIC C2012 CH 1H 331J-T-A C10 4010006900 CERAMIC HE80SJ YB 472K 50V
C8 4030005050 S.CERAMIC C2012 CH 1H 331J-T-A C11 4010005740 CERAMIC HM60SJ SL 560J 500V
C14 4010005740 CERAMIC HM60SJ SL 560J 500V
J1 6510017920 CONNECTOR 1811P342 C18 4010005610 CERAMIC HM60SJ SL 100D 500V
J2 6510017920 CONNECTOR 1811P342 C19 4010005690 CERAMIC HM60SJ SL 300J 500V
J3 6510017920 CONNECTOR 1811P342 C20 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
J4 6510017920 CONNECTOR 1811P342 C21 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
J5 6510003080 CONNECTOR RT01T-1.0B C22 4510005600 S.ELECTROLYTIC ECEV1CS100SR
J6 6510003080 CONNECTOR RT01T-1.0B C23 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
J7 6510003080 CONNECTOR RT01T-1.0B C24 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
C25 4510005600 S.ELECTROLYTIC ECEV1CS100SR
WS1 8970022610 M.OTHER EX1900 0.8D COAXIAL (3)/CO
WS2 8600035730 M.OTHER EX1900 P01*J08CO
RL1 6330001330 RELAY AG 201344
RL2 6330000470 RELAY NR-HD (12V) AE5343
EP1 6910011330 TERMINAL OT-009 M3
EP2 6910011330 TERMINAL OT-009 M3
EP3 0910048756 PCB B 4889F J1 6510007020 CONNECTOR TMP-J01X-V6
EP5 0910049250 PCB B 5039 J2 6510007020 CONNECTOR TMP-J01X-V6
J4 6510007020 CONNECTOR TMP-J01X-V6
J11 6510019970 S.CONNECTOR 52808-1090
WS1 8600035721 M.OTHER EX1900 P01*J03*09SP-1
S.=Surface mount
5-6
[SPLITR UNIT] [PA-1 BOARD]
REF ORDER REF ORDER
NO. NO. NO. NO.
EP1 0910048784 PCB B 4890D C1 4010005740 CERAMIC HM60SJ SL 560J 500V
EP2 9034901004 TUBE D=1.0, L=10 mm C3 4030011790 S.CERAMIC GRM44-1 Y5V 684Z 100PT
EP3 9050409902 TUBE D=1.0, L=15 mm C4 4030011790 S.CERAMIC GRM44-1 Y5V 684Z 100PT
EP4 9019000830 TUBE PLASTIC TUBE D=6.0, L=750 mm C11 4030006480 S.CERAMIC GRM42-6 B 104K 50PT
EP5 9001602001 TUBE IRRAX 0.7 (d) L=10 mm C13 4030006480 S.CERAMIC GRM42-6 B 104K 50PT
C23 4510006830 ELECTROLYTIC 63 MV 470CZ
C24 4510006830 ELECTROLYTIC 63 MV 470CZ
[PA UNIT] C25 4030006480 S.CERAMIC GRM42-6 B 104K 50PT
REF ORDER C26 4030003410 S.CERAMIC GRM42-6 B 473K 50PT
DESCRIPTION C27 4030001170 S.CERAMIC GRM42-6 B 102K 50PT
NO. NO.
Q1 1560001000 FET MRF150MP (SRFJ150MP) PAIR C35 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
C42 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A
MF1 2710000620 FAN PUDC12Z4-992 C44 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
MF2 2710000620 FAN PUDC12Z4-992 C45 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A
MF3 2710000620 FAN PUDC12Z4-992 C46 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
W1 8900006990 CABLE OPC-683 C55 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
W2 8900007360 CABLE OPC-711 C56 4030006880 S.CERAMIC C1608 JB 1H 472K-T-A
W3 8900006990 CABLE OPC-683 C57 4030006880 S.CERAMIC C1608 JB 1H 472K-T-A
W4 8900007360 CABLE OPC-711
J2 6510017920 CONNECTOR 1811P342

WS1 8970022930 M.OTHER EX1900 J BOARD SET (4)/PA J3 6510019970 S.CONNECTOR 52808-1090
J4 6510019970 S.CONNECTOR 52808-1090
J5 6510003390 CONNECTOR B03B-EH-S
W6 7030003860 S.JUMPER ERJ3GE JPW V

[PA-1 BOARD]
REF ORDER WS1 8970022531 M.OTHER EX1900 J BOARD SET-1 (1)/PA-1
DESCRIPTION WS2 8970022540 M.OTHER EX1900 1.5D COAXIAL (1)/PA-1
NO. NO.
D1 1750000270 S.DIODE 1SS301 (TE85R)
D2 1750000270 S.DIODE 1SS301 (TE85R) EP1 6910011330 TERMINAL OT-009 M3
D4 1750000270 S.DIODE 1SS301 (TE85R) EP3 6910000640 BEAD FSOH090RN
EP4 0910048706 PCB B 4884F
L1 6110001730 COIL LA-262

L2 6140003040 COIL LR-322B
L3 6140002590 COIL LR-296
L4 6140000720 COIL LR-95
L5 6180000900 COIL LAL 03NA 101K
L6 6180000900 COIL LAL 03NA 101K [PA-2 BOARD]
L7 6140002030 COIL LR-230 REF ORDER
L9 6200003260 S.COIL NL 322522T-101J DESCRIPTION
NO. NO.
L11 6200003950 S.COIL HF50ACC 322513-T
D1 1750000270 S.DIODE 1SS301 (TE85R)
D2 1750000270 S.DIODE 1SS301 (TE85R)
R2 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ) D3 1750000270 S.DIODE 1SS301 (TE85R)
R4 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ) D4 1750000270 S.DIODE 1SS301 (TE85R)
R5 7070000890 RESISTOR ERG3SJ 150 (15 Ω)
R7 7030006140 S.RESISTOR ERJ1WYJ560H (56 Ω) L1 6110001730 COIL LA-262
R8 7030006140 S.RESISTOR ERJ1WYJ560H (56 Ω) L2 6140003040 COIL LR-322B
R9 7310003180 TRIMMER EVN-2ACA00 B24 (203) L3 6140002590 COIL LR-296
R10 7310003180 TRIMMER EVN-2ACA00 B24 (203) L4 6140000720 COIL LR-95
R11 7070000900 RESISTOR ERX3SJ 1R8 (1.8 Ω) L5 6180000900 COIL LAL 03NA 101K
R12 7070000900 RESISTOR ERX3SJ 1R8 (1.8 Ω) L6 6180000900 COIL LAL 03NA 101K
R15 7070000960 RESISTOR ERG3SJ 561 (560 Ω) L7 6140002030 COIL LR-230
R16 7080001300 RESISTOR ERG3SJ 270 (27 Ω) L9 6200003260 S.COIL NL 322522T-101J
R17 7070000940 RESISTOR ERG3SJ 331 (330 Ω) L11 6200003950 S.COIL HF50ACC 322513-T
R20 7070000930 RESISTOR ERG3SJ 330 (33 Ω) R2 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ)
R21 7070001000 RESISTOR ERG3SJ 821 (820 Ω) R4 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ)
R23 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R5 7070000890 RESISTOR ERG3SJ 150 (15 Ω)
R24 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R6 7070000890 RESISTOR ERG3SJ 150 (15 Ω)
R9 7310003180 TRIMMER EVN-2ACA00 B24 (203)
S.=Surface mount
5-7
[PA-2 BOARD] [PA-3 BOARD]
REF ORDER REF ORDER
NO. NO. NO. NO.
R10 7310003180 TRIMMER EVN-2ACA00 B24 (203) L1 6110001730 COIL LA-262
R11 7070000900 RESISTOR ERX3SJ 1R8 (1.8 Ω) L2 6140003040 COIL LR-322B
R12 7070000900 RESISTOR ERX3SJ 1R8 (1.8 Ω) L3 6140002590 COIL LR-296
R16 7080001300 RESISTOR ERG3SJ 270 (27 Ω) L5 6180000900 COIL LAL 03NA 101K
R17 7070000940 RESISTOR ERG3SJ 331 (330 Ω) L6 6180000900 COIL LAL 03NA 101K
R19 7070000890 RESISTOR ERG3SJ 150 (15 Ω) L9 6200003260 S.COIL NL 322522T-101J
R20 7070000930 RESISTOR ERG3SJ 330 (33 Ω) L11 6200003950 S.COIL HF50ACC 322513-T
R24 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) R2 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ)
C1 4010005740 CERAMIC HM60SJ SL 560J 500V R6 7070000890 RESISTOR ERG3SJ 150 (15 Ω)
C3 4030011790 S.CERAMIC GRM44-1 Y5V 684Z 100PT R7 7030006140 S.RESISTOR ERJ1WYJ560H (56 Ω)
C4 4030011790 S.CERAMIC GRM44-1 Y5V 684Z 100PT R8 7030006140 S.RESISTOR ERJ1WYJ560H (56 Ω)
C11 4030006480 S.CERAMIC GRM42-6 B 104K 50PT R9 7310003180 TRIMMER EVN-2ACA00 B24 (203)
C13 4030006480 S.CERAMIC GRM42-6 B 104K 50PT R10 7310003180 TRIMMER EVN-2ACA00 B24 (203)
C16 4030011790 S.CERAMIC GRM44-1 Y5V 684Z 100PT R11 7070000900 RESISTOR ERX3SJ 1R8 (1.8 Ω)
C17 4030011790 S.CERAMIC GRM44-1 Y5V 684Z 100PT R12 7070000900 RESISTOR ERX3SJ 1R8 (1.8 Ω)
C18 4030011790 S.CERAMIC GRM44-1 Y5V 684Z 100PT R15 7070000960 RESISTOR ERG3SJ 561 (560 Ω)
C19 4030011790 S.CERAMIC GRM44-1 Y5V 684Z 100PT R16 7080001300 RESISTOR ERG3SJ 270 (27 Ω)
C23 4510006830 ELECTROLYTIC 63 MV 470CZ R17 7070000940 RESISTOR ERG3SJ 331 (330 Ω)
C24 4510006830 ELECTROLYTIC 63 MV 470CZ R18 7070000890 RESISTOR ERG3SJ 150 (15 Ω)
C25 4030006480 S.CERAMIC GRM42-6 B 104K 50PT R19 7070000890 RESISTOR ERG3SJ 150 (15 Ω)
C29 4030011600 S.CERAMIC C1608 JB 1C 104KT-N R23 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)
C35 4030011600 S.CERAMIC C1608 JB 1C 104KT-N R24 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)
C41 4030011600 S.CERAMIC C1608 JB 1C 104KT-N C1 4010005740 CERAMIC HM60SJ SL 560J 500V
C42 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A C3 4030011790 S.CERAMIC GRM44-1 Y5V 684Z 100PT
C43 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A C4 4030011790 S.CERAMIC GRM44-1 Y5V 684Z 100PT
C44 4030011600 S.CERAMIC C1608 JB 1C 104KT-N C11 4030006480 S.CERAMIC GRM42-6 B 104K 50PT
C45 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A C13 4030006480 S.CERAMIC GRM42-6 B 104K 50PT
C46 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A C16 4030011790 S.CERAMIC GRM44-1 Y5V 684Z 100PT
C51 4030011790 S.CERAMIC GRM44-1 Y5V 684Z 100PT C17 4030011790 S.CERAMIC GRM44-1 Y5V 684Z 100PT
C52 4030011790 S.CERAMIC GRM44-1 Y5V 684Z 100PT C18 4030011790 S.CERAMIC GRM44-1 Y5V 684Z 100PT
C55 4030011600 S.CERAMIC C1608 JB 1C 104KT-N C19 4030011790 S.CERAMIC GRM44-1 Y5V 684Z 100PT
C56 4030006880 S.CERAMIC C1608 JB 1H 472K-T-A C23 4510006830 ELECTROLYTIC 63 MV 470CZ
C57 4030006880 S.CERAMIC C1608 JB 1H 472K-T-A C24 4510006830 ELECTROLYTIC 63 MV 470CZ
C25 4030006480 S.CERAMIC GRM42-6 B 104K 50PT
J2 6510017920 CONNECTOR 1811P342 C27 4030001170 S.CERAMIC GRM42-6 B 102K 50PT
J3 6510019970 S.CONNECTOR 52808-1090 C29 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
J4 6510019970 S.CONNECTOR 52808-1090 C35 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
J5 6510003390 CONNECTOR B03B-EH-S C37 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
W6 7030003860 S.JUMPER ERJ3GE JPW V C42 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A
WS1 8970022551 M.OTHER EX1900 J BOARD SET-1 (1)/PA-2 C45 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A
WS2 8970022560 M.OTHER EX1900 1.5D COAXIAL (1)/PA-2 C46 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A
EP1 6910011330 TERMINAL OT-009 M3 C55 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
EP2 6910011330 TERMINAL OT-009 M3 C56 4030006880 S.CERAMIC C1608 JB 1H 472K-T-A
EP3 6910000640 BEAD FSOH090RN C57 4030006880 S.CERAMIC C1608 JB 1H 472K-T-A
EP4 0910048706 PCB B 4884F
J2 6510017920 CONNECTOR 1811P342

J3 6510019970 S.CONNECTOR 52808-1090
J4 6510019970 S.CONNECTOR 52808-1090
[PA-3 BOARD]
REF ORDER W6 7030003860 S.JUMPER ERJ3GE JPW V
DESCRIPTION
NO. NO.
D1 1750000270 S.DIODE 1SS301 (TE85R) WS1 8970022571 M.OTHER EX1900 J BOARD SET-1 (1)/PA-3
D2 1750000270 S.DIODE 1SS301 (TE85R) WS2 8970022580 M.OTHER EX1900 1.5D COAXIAL (1)/PA-3
D3 1750000270 S.DIODE 1SS301 (TE85R)
D4 1750000270 S.DIODE 1SS301 (TE85R)
EP1 6910011330 TERMINAL OT-009 M3
EP2 6910011330 TERMINAL OT-009 M3
EP3 6910000640 BEAD FSOH090RN
EP4 0910048706 PCB B 4884F
S.=Surface mount
5-8
[PA-4 BOARD] [PA-4 BOARD]
REF ORDER REF ORDER
NO. NO. NO. NO.
D3 1750000270 S.DIODE 1SS301 (TE85R) EP3 6910000640 BEAD FSOH090RN
D4 1750000270 S.DIODE 1SS301 (TE85R) EP4 0910048706 PCB B 4884F
L1 6110001730 COIL LA-262

L2 6140003040 COIL LR-322B
L3 6140002590 COIL LR-296
L4 6140000720 COIL LR-95
L5 6180000900 COIL LAL 03NA 101K
[TUNER UNIT]
L6 6180000900 COIL LAL 03NA 101K REF ORDER
L7 6140002030 COIL LR-230 DESCRIPTION
NO. NO.
L9 6200003260 S.COIL NL 322522T-101J
L11 6200003950 S.COIL HF50ACC 322513-T C1 4620000130 VARIABLE UV55 150PF
C2 4620000130 VARIABLE UV55 150PF

R4 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ) MF1 2710000460 MOTOR MP28GA STEPING MOTOR
R5 7070000890 RESISTOR ERG3SJ 150 (15 Ω) MF2 2710000460 MOTOR MP28GA STEPING MOTOR
R6 7070000890 RESISTOR ERG3SJ 150 (15 Ω) MF3 2710000630 FAN FBA08T12HC (with bead core)
R9 7310003180 TRIMMER EVN-2ACA00 B24 (203) WS1 8970022910 M.OTHER EX1900 COAXIAL (1)/TU
R10 7310003180 TRIMMER EVN-2ACA00 B24 (203)
R11 7070000900 RESISTOR ERX3SJ 1R8 (1.8 Ω)
R12 7070000900 RESISTOR ERX3SJ 1R8 (1.8 Ω) EP7 9019001020 TUBE D=10, L=65 mm
[DET BOARD]
R23 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) REF ORDER
R24 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) DESCRIPTION
NO. NO.
IC1 1110001850 IC MC10116 L
C1 4010005740 CERAMIC HM60SJ SL 560J 500V IC2 1110001860 IC MC10125 L
C3 4030011790 S.CERAMIC GRM44-1 Y5V 684Z 100PT IC3 1120002250 S.IC TC74ACT32F
C4 4030011790 S.CERAMIC GRM44-1 Y5V 684Z 100PT IC4 1120002240 S.IC TC74AC112F
C11 4030006480 S.CERAMIC GRM42-6 B 104K 50PT IC5 1180000320 IC NJM79L05A
C17 4030011790 S.CERAMIC GRM44-1 Y5V 684Z 100PT Q1 1560000870 S.FET 2SK515-T1B (X33)
C23 4510006830 ELECTROLYTIC 63 MV 470CZ D3 1790000620 S.DIODE MA77 (TX)
C24 4510006830 ELECTROLYTIC 63 MV 470CZ D4 1790000620 S.DIODE MA77 (TX)
C25 4030006480 S.CERAMIC GRM42-6 B 104K 50PT D5 1790000620 S.DIODE MA77 (TX)
C26 4030003410 S.CERAMIC GRM42-6 B 473K 50PT D6 1790000620 S.DIODE MA77 (TX)
C27 4030001170 S.CERAMIC GRM42-6 B 102K 50PT D7 1750000270 S.DIODE 1SS301 (TE85R)
C29 4030011600 S.CERAMIC C1608 JB 1C 104KT-N D8 1750000270 S.DIODE 1SS301 (TE85R)
C40 4030011600 S.CERAMIC C1608 JB 1C 104KT-N D13 1790001530 DIODE 1SS286
C41 4030011600 S.CERAMIC C1608 JB 1C 104KT-N D14 1790001530 DIODE 1SS286
C44 4030011600 S.CERAMIC C1608 JB 1C 104KT-N L1 6180000960 COIL LAL 03NA 102K
C45 4030006900 S.CERAMIC C1608 JB 1E 103K-T-A L3 6140002660 COIL LR-299
C51 4030011790 S.CERAMIC GRM44-1 Y5V 684Z 100PT L5 6140002660 COIL LR-299
C52 4030011790 S.CERAMIC GRM44-1 Y5V 684Z 100PT L8 6180000990 COIL LAL 04NA 101K
C55 4030011600 S.CERAMIC C1608 JB 1C 104KT-N L9 6200003260 S.COIL NL 322522T-101J
C56 4030006880 S.CERAMIC C1608 JB 1H 472K-T-A L10 6200003260 S.COIL NL 322522T-101J
C57 4030006880 S.CERAMIC C1608 JB 1H 472K-T-A L11 6140002220 COIL LR-270
L12 6180000990 COIL LAL 04NA 101K
J2 6510017920 CONNECTOR 1811P342

J3 6510019970 S.CONNECTOR 52808-1090 R1 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω)
J4 6510019970 S.CONNECTOR 52808-1090 R2 7030000080 S.RESISTOR MCR10EZHJ 3.3 Ω (3R3)
J5 6510003390 CONNECTOR B03B-EH-S R3 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω)
R4 7030008320 S.RESISTOR ERJ1WYJ6R8H (6.8 Ω)
W6 7030003860 S.JUMPER ERJ3GE JPW V R6 7030000080 S.RESISTOR MCR10EZHJ 3.3 Ω (3R3)
WS1 8970022591 M.OTHER EX1900 J BOARD SET-1 (1)/PA-4 R9 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ)
WS2 8970022600 M.OTHER EX1900 1.5D COAXIAL (1)/PA-4 R11 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω)
S.=Surface mount
5-9
[DET BOARD] [CONNECT BOARD]
REF ORDER REF ORDER
NO. NO. NO. NO.
R14 7030009330 RESISTOR ERJ1WYJ300H C1 4030010210 S.CERAMIC C3216 JB 1C 105M-T-A
R15 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) C2 4030010210 S.CERAMIC C3216 JB 1C 105M-T-A
R16 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ) C3 4030010210 S.CERAMIC C3216 JB 1C 105M-T-A
R20 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ) C7 4030010210 S.CERAMIC C3216 JB 1C 105M-T-A
R21 7030009330 RESISTOR ERJ1WYJ300H C8 4030010210 S.CERAMIC C3216 JB 1C 105M-T-A
C1 4010005570 CERAMIC HM60SJ SL 060D 500V J1 6510017650 CONNECTOR 52045-1045

C2 4010005370 CERAMIC HM11SJ SL 331J 500V J2 6510003410 CONNECTOR B05B-EH-S
C3 4010005370 CERAMIC HM11SJ SL 331J 500V J3 6510003410 CONNECTOR B05B-EH-S
C6 4510005600 S.ELECTROLYTIC ECEV1CS100SR EP1 0910048814 PCB B 4941D
[L-NET BOARD]
C14 4030006880 S.CERAMIC C1608 JB 1H 472K-T-A REF ORDER
C15 4010005540 CERAMIC HM60SJ SL 030C 500V DESCRIPTION
NO. NO.
C17 4010005850 CERAMIC HM95SJ SL 181J 500V D1 1710000050 DIODE 1SS53
C18 4030006860 S.CERAMIC C1608 JB 1H 102K-T-A D2 1710000050 DIODE 1SS53
C29 4510005600 S.ELECTROLYTIC ECEV1CS100SR C1 4040000150 BARRIER UAT 05X 472K
C30 4030011600 S.CERAMIC C1608 JB 1C 104KT-N C2 4040000150 BARRIER UAT 05X 472K
C33 4010005110 CERAMIC DE0910 SL 220J 6KV C3 4040000260 BARRIER UZE 08X 104M
C34 4030006880 S.CERAMIC C1608 JB 1H 472K-T-A C4 4040000260 BARRIER UZE 08X 104M
C37 4030011600 S.CERAMIC C1608 JB 1C 104KT-N RL1 6330000570 RELAY AR-39251
C38 4030011600 S.CERAMIC C1608 JB 1C 104KT-N RL2 6330000570 RELAY AR-39251
C41 4030011600 S.CERAMIC C1608 JB 1C 104KT-N WS1 8600035830 M.OTHER EX1900 P01*J01L
C44 4510005600 S.ELECTROLYTIC ECEV1CS100SR EP1 6910011340 TERMINAL OT-010 M3
C45 4030006880 S.CERAMIC C1608 JB 1H 472K-T-A EP2 0910048727 PCB B 4886G
WS1 8970022630 M.OTHER EX1900 TEFLON COAXIAL (2)/DE

WS2 8600035821 M.OTHER EX1900 P01*J01DE-1
EP5 6910011330 TERMINAL OT-009 M3

[H-NET BOARD]
EP6 6910011330 TERMINAL OT-009 M3 REF ORDER
EP7 6910011330 TERMINAL OT-009 M3 DESCRIPTION
NO. NO.
EP8 6910011330 TERMINAL OT-009 M3
EP9 0910048738 PCB B 4887H D1 1710000050 DIODE 1SS53
EP10 9029703901 TUBE IRRAX 0.7 (d) L=5 mm D2 1710000050 DIODE 1SS53
D3 1710000050 DIODE 1SS53
D4 1710000050 DIODE 1SS53
D5 1710000050 DIODE 1SS53
D6 1710000050 DIODE 1SS53
D7 1710000050 DIODE 1SS53
D8 1710000050 DIODE 1SS53
D9 1710000050 DIODE 1SS53
D10 1710000050 DIODE 1SS53
L1 6180000990 COIL LAL 04NA 101K

L2 6180000990 COIL LAL 04NA 101K
L3 6180000990 COIL LAL 04NA 101K
L4 6180000990 COIL LAL 04NA 101K
L5 6180000990 COIL LAL 04NA 101K
L6 6180000990 COIL LAL 04NA 101K
L7 6180000990 COIL LAL 04NA 101K
L8 6180000990 COIL LAL 04NA 101K
S.=Surface mount
5 - 10
[H-NET BOARD] [C-NET BOARD]
REF ORDER REF ORDER
NO. NO. NO. NO.
L13 6110003510 COIL LA-544 C40 4010004790 CERAMIC DE1210 SL 680J 6KV
C44 4040000150 BARRIER UAT 05X 472K
C1 4040000260 BARRIER UZE 08X 104M C45 4010004300 CERAMIC DE1410 SL 221J 3KV
C5 4040000260 BARRIER UZE 08X 104M C49 4040000150 BARRIER UAT 05X 472K
C10 4040000260 BARRIER UZE 08X 104M C54 4040000150 BARRIER UAT 05X 472K
C11 4040000150 BARRIER UAT 05X 472K C55 4010004710 CERAMIC DE0707 SL 150J 3KV
C15 4040000150 BARRIER UAT 05X 472K C59 4040000150 BARRIER UAT 05X 472K
C20 4040000150 BARRIER UAT 05X 472K C64 4040000150 BARRIER UAT 05X 472K
RL1 6330000570 RELAY AR-39251 C67 4010004810 CERAMIC DE1310 SL 101J 6KV
RL3 6330000570 RELAY AR-39251 C69 4040000150 BARRIER UAT 05X 472K
WS1 8600035841 M.OTHER EX1900 P01*J01H-1 C84 4010004810 CERAMIC DE1310 SL 101J 6KV
EP2 6910011340 TERMINAL OT-010 M3 C88 4010004810 CERAMIC DE1310 SL 101J 6KV
EP3 0910049304 PCB B 5017D C89 4010004810 CERAMIC DE1310 SL 101J 6KV
[C-NET BOARD] C96 4010004710 CERAMIC DE0707 SL 150J 3KV
REF ORDER C97 4010004710 CERAMIC DE0707 SL 150J 3KV
DESCRIPTION
NO. NO.
D1 1710000050 DIODE 1SS53 RL1 6330001440 RELAY VS-12TBU-VD3
D2 1710000050 DIODE 1SS53 RL2 6330001440 RELAY VS-12TBU-VD3
D14 1710000050 DIODE 1SS53 RL3 6330000570 RELAY AR-39251
D15 1710000050 DIODE 1SS53 RL4 6330001490 RELAY VB-12MBU-UC (UL3)
D18 1710000050 DIODE 1SS53 RL7 6330000570 RELAY AR-39251
L1 6180000990 COIL LAL 04NA 101K WS1 8600035851 M.OTHER EX1900 P01*J01C-1
L2 6180000990 COIL LAL 04NA 101K WS2 8600035861 M.OTHER EX1900 P02*J02C-1
L14 6180000990 COIL LAL 04NA 101K
L15 6180000990 COIL LAL 04NA 101K
L16 6180000990 COIL LAL 04NA 101K EP3 0910049245 PCB B 5019E
L17 6180000990 COIL LAL 04NA 101K
L18 6180000990 COIL LAL 04NA 101K
L19 6180000990 COIL LAL 04NA 101K
L20 6180000990 COIL LAL 04NA 101K
L21 6180000990 COIL LAL 04NA 101K
S.=Surface mount
5 - 11
[JACK1 UNIT] [ANT-SW UNIT]
REF ORDER REF ORDER
NO. NO. NO. NO.
L1 6200003260 S.COIL NL 322522T-101J WS1 8600035743 M.OTHER EX1900 P01*J01AN-SW-3
L2 6200003260 S.COIL NL 322522T-101J
L3 6200003260 S.COIL NL 322522T-101J
L4 6200003260 S.COIL NL 322522T-101J EP1 6910011340 TERMINAL OT-010 M3
L5 6200003260 S.COIL NL 322522T-101J EP2 6910011340 TERMINAL OT-010 M3
L6 6200003260 S.COIL NL 322522T-101J EP3 0910048716 PCB B 4885F
R1 7310003820 TRIMMER EVN-D2AA03 B14

R2 7310003820 TRIMMER EVN-D2AA03 B14
C1 4030006880 S.CERAMIC C1608 JB 1H 472K-T-A [FRONT UNIT]

C2 4030006880 S.CERAMIC C1608 JB 1H 472K-T-A REF ORDER
C3 4030006880 S.CERAMIC C1608 JB 1H 472K-T-A DESCRIPTION
NO. NO.
C5 4030006880 S.CERAMIC C1608 JB 1H 472K-T-A DS1 5080000380 LAMP HRS-4160A-H9 L150
C6 4030006880 S.CERAMIC C1608 JB 1H 472K-T-A DS2 5080000380 LAMP HRS-4160A-H9 L150
J1 6450001590 CONNECTOR TCS5073-17-4151 ME1 5510000470 METER ME-39

J3 6450001130 CONNECTOR JPJ2042-01-110 ME2 5510000460 METER ME-38
J4 6450000140 CONNECTOR HSJ0807-01-010
J5 6450001590 CONNECTOR TCS5073-17-4151
J7 6450001130 CONNECTOR JPJ2042-01-110 WS1 8970022810 M.OTHER EX1900 J LEAD SET (4)/FR
J8 6450000140 CONNECTOR HSJ0807-01-010 WS2 8600035961 M.OTHER EX1900 P03*04FR-1
J9 6510019140 S.CONNECTOR 52610-1090
J11 6510003450 CONNECTOR B09B-EH-S EP1 6910011040 TUBE A-4210-G20
J12 6510018960 S.CONNECTOR B2B-PH-SM3-TB EP2 6910011040 TUBE A-4210-G20
S1 2220000570 SWITCH HSW1196-01-020
EP1 0910048776 PCB B 4898F

[SW BOARD]
REF ORDER DESCRIPTION
NO. NO.
IC1 1130000830 S.IC µPD4094BG-T1
IC2 1130000830 S.IC µPD4094BG-T1
[ANT-SW UNIT] IC3 1130000830 S.IC µPD4094BG-T1
REF ORDER IC4 1130000830 S.IC µPD4094BG-T1
DESCRIPTION IC5 1110003690 S.IC M62354GP 75EC
NO. NO.
IC6 1180001070 S.IC TA7805F (TE16L)
D1 1710000050 DIODE 1SS53 IC7 1130004670 S.IC BU4021BF-T1
D2 1710000050 DIODE 1SS53 IC8 1130007260 S.IC TC7W74FU (TE12L)
D3 1710000050 DIODE 1SS53 IC9 1130005820 S.IC TC4S584F (TE85R)
D4 1710000050 DIODE 1SS53

L1 6180000900 COIL LAL 03NA 101K Q2 1590002310 S.TRANSISTOR DTC114EE TL
R1 7540000190 ABSOBER SRYG-2000L Q8 1590002310 S.TRANSISTOR DTC114EE TL
C1 4010006900 CERAMIC HE80SJ YB 472K 50V Q11 1590002310 S.TRANSISTOR DTC114EE TL
C11 4010004310 CERAMIC DE0705 SL 100D 1KV Q19 1590002310 S.TRANSISTOR DTC114EE TL
RL1 6330001460 RELAY FTR-F1CA012V Q27 1590002310 S.TRANSISTOR DTC114EE TL
RL2 6330001460 RELAY FTR-F1CA012V Q31 1590001940 S.TRANSISTOR DTC144EE TL
RL3 6330001460 RELAY FTR-F1CA012V Q32 1520000460 S.TRANSISTOR 2SB1132 T100 R
RL4 6330001460 RELAY FTR-F1CA012V
S.=Surface mount
5 - 12
[SW BOARD] [SW BOARD]
REF ORDER REF ORDER
NO. NO. NO. NO.
D1 1750000270 S.DIODE 1SS301 (TE85R) C1 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
D5 1730002320 S.ZENER MA8051-M (TX) C5 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
D6 1750000270 S.DIODE 1SS301 (TE85R) C6 4510005860 S.ELECTROLYTIC ECEV1HA2R2SR
D8 1750000270 S.DIODE 1SS301 (TE85R) C8 4510004870 S.ELECTROLYTIC ECEV1CA330P
D10 1750000230 S.DIODE 1SS315 TPH-3 C9 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
D11 1750000230 S.DIODE 1SS315 TPH-3 C10 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
C11 4510004630 S.ELECTROLYTIC ECEV1CA100SR
L1 6200003260 S.COIL NL 322522T-101J C17 4030006880 S.CERAMIC C1608 JB 1H 472K-T-A
L2 6200003260 S.COIL NL 322522T-101J C18 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
L3 6200003260 S.COIL NL 322522T-101J C19 4510005600 S.ELECTROLYTIC ECEV1CS100SR
L4 6200003260 S.COIL NL 322522T-101J C20 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
L5 6200003950 S.COIL HF50ACC 322513-T C21 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
L6 6200003950 S.COIL HF50ACC 322513-T C24 4030011600 S.CERAMIC C1608 JB 1C 104KT-N
R1 7030003340 S.RESISTOR ERJ3GEYJ 151 V (150 Ω) C29 4030008920 S.CERAMIC C1608 JB 1C 473K-T-A
R2 7030003340 S.RESISTOR ERJ3GEYJ 151 V (150 Ω) C30 4030008920 S.CERAMIC C1608 JB 1C 473K-T-A
R5 7030003340 S.RESISTOR ERJ3GEYJ 151 V (150 Ω) C33 4510004630 S.ELECTROLYTIC ECEV1CA100SR
R9 7030003340 S.RESISTOR ERJ3GEYJ 151 V (150 Ω) J1 6510003450 CONNECTOR B09B-EH-S
R12 7030003340 S.RESISTOR ERJ3GEYJ 151 V (150 Ω) DS1 5040002080 S.LED CL-200YG-C-TU
R19 7030003340 S.RESISTOR ERJ3GEYJ 151 V (150 Ω) DS8 5040001870 S.LED SEC 2462C
R20 7030003340 S.RESISTOR ERJ3GEYJ 151 V (150 Ω) DS9 5040002010 S.LED CL-170PG-CD-T
R29 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ) DS17 5040002010 S.LED CL-170PG-CD-T
R30 7030008190 S.RESISTOR ERJ12YJ330H (33 Ω) DS18 5040002080 S.LED CL-200YG-C-TU
R31 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) DS19 5040002080 S.LED CL-200YG-C-TU
R41 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) S1 2260001890 S.SWITCH SKQDPA
R42 7030006060 S.RESISTOR ERJ12YJ100H (10 Ω) S2 2260001890 S.SWITCH SKQDPA
R54 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) W1 7030003860 S.JUMPER ERJ3GE JPW V
R56 7310002740 S.TRIMMER RV-150 (RH03A3A14X0FC) 103 W4 7030003860 S.JUMPER ERJ3GE JPW V
R57 7310002740 S.TRIMMER RV-150 (RH03A3A14X0FC) 103 W5 7030003860 S.JUMPER ERJ3GE JPW V
R59 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) W8 7120000380 JUMPER JPW 01 R-01
R62 7030009170 S.RESISTOR ERJ1WYJ1R5H (1.5 Ω) EP1 0910048766 PCB B 4893F
S.=Surface mount
5 - 13
SECTION 6 MECHANICAL PARTS AND DISASSEMBLY
6-1 FRAME DISASSEMBLY
[CHASSIS PARTS] [CHASSIS PARTS]
ORDER ORDER
REF NO. DESCRIPTION QTY. REF NO. DESCRIPTION QTY.
NO. NO.
J1 6510000410 Connector MR-DS-E 02 1 MP55 8810009620 Bind screw BT M3 × 6 ZK 2
J2 6510000410 Connector MR-DS-E 02 1 MP56 8810009350 Screw PH B0 M3 × 8 SUS ZK 2
J3 6510009290 Connector MR-DSE-02(AG) 1 MP57 8810009620 Bind screw BT M3 × 6 ZK 3
J5 6510009290 Connector MR-DSE-02(AG) 1 MP61 8810004300 Screw PH M3 ×10 ZK 2
W5 8900005410 Cable OPC-521 1 MP64 8810004430 Screw PH M3 × 6 ZK 4
W16 8900005410 Cable OPC-521 1 MP65 8810008450 Bind screw M4 × 8 ZK 4
W20 8900005380 Cable OPC-525 (N:10 L:400) 1 MP68 8830000360 Wing nut M5 NI 1
W21 8900007260 Cable OPC-712 (N:10 L:500) 1 MP69 8850000150 Flat washer M5 NI BS 3
W31 8900008030 Cable OPC-769 [USA], [EUR] 2 MP70 8830000210 Nut M5 NI BS 1
W32 8900008210 Cable OPC-805 1 MP71 8850000440 Spring washer M 5 NI 1
EP8 0880000320 PX-1981 USA Attachment unit [USA] 1 MP72 8930011680 Rubber standoff (G) 5
0880000330 PX-1981 EUR Attachment unit [EUR] 1 MP73 8930037420 Rubber sheet (P) 2
0880000570 PX-1981 EUR-1 Attachment unit[EUR-1] 1 MP74 8810009620 Bind screw BT M3 × 6 ZK 1
EP9 6910000310 B312D Isolating bush [USA], [EUR] 2 MP75 8810009620 Bind screw BT M3 × 6 ZK 2
EP11 6910000310 B312D Isolating bush 2 MP76 8810003360 Set screw C M3 × 6 1
EP13 6910010480 DL-7C OR-31-15-19H 5 MP77 8810003360 Set screw C M3 × 6 1
MP1 8210014270 1900 Front panel 1 MP78 8810003360 Set screw C M3 × 6 1
MP2 8110006231 1900 A-cover-1 1 MP79 8810003360 Set screw C M3 × 6 1
MP3 8010017072 1900 A-sub chassis-2 1 MP80 8810003360 Set screw C M3 × 6 1
MP4 8210014952 1900 A-rear panel-2 1 MP81 8810003360 Set screw C M3 × 6 1
MP5 8010017080 1900 A-cent chassis 1 MP82 8810003360 Set screw C M3 × 6 1
MP6 8110006243 1900 A-bottom cover-3 1 MP83 8810003360 Set screw C M3 × 6 1
MP7 8010017091 1900 A-side chassis-1 1 MP84 8810003360 Set screw C M3 × 6 1
MP8 8930042540 1900 Jack plate 2 MP85 8810003360 Set screw C M3 × 6 1
MP10 8510011342 1900 A-filter case-2 1 MP86 8310044320 IC-PW1 FCC sirial number seal [USA] 1
MP11 8510011360 1900 A-filter cover 1 8310039900 IC-PW1 FCC sirial number seal EUR] 1
MP12 8310039540 1900 hole plate 1 8310046130 IC-PW1 FCC sirial number seal [EUR-1] 1
MP16 8810009620 Bind screw BT M3 × 6 ZK 1 MP87 8810009620 Bind screw BT M3 × 6 ZK 3
MP21 8810003160 Set screw A M3 × 6 4 MP90 8930046310 1900 A-sheet 1
MP23 8810003160 Set screw A M3 × 6 4 MP95 8930037280 Poli-cap type M 4
MP26 8810003160 Set screw A M3 × 6 11 MP96 8930038820 Alumi-sheet V 1
MP30 8810004430 Screw PH M3 × 6 ZK 8 MP97 8930047150 1900 A-side sheet 1
MP31 8810004430 Screw PH M3 × 6 ZK 4 MP98 8930047160 1900 B-side sheet 1
MP32 8810009620 Bind screw BT M3 × 6 ZK 1 MP99 8930047170 Isolating plate FH 2
MP33 8810009620 Bind screw BT M3 × 6 ZK 1 MP100 8930047140 Isplating plate FI 1
MP34 8810009620 Bind screw BT M3 × 6 ZK 1 MP104 8810008660 Screw PH BT M3 × 8 NI-ZU 1
MP35 8810009620 Bind screw BT M3 × 6 ZK 1 MP105 8810008660 Screw PH BT M3 × 8 NI-ZU 1
MP36 8810009620 Bind screw BT M3 × 6 ZK 4 MP106 6910008240 59TN4772 1
MP37 8810009620 Bind screw BT M3 × 6 ZK 2 MP109 8930001170 Grounding spring (A) 1
MP38 8810009620 Bind screw BT M3 × 6 ZK 1 MP110 8510011840 1900 A-shield plate 1
MP39 8810009620 Bind screw BT M3 × 6 ZK 1 MP111 8930047270 Sponge (FH) 3
MP40 8810009620 Bind screw BT M3 × 6 ZK 1 MP112 8930047280 Sponge 1
MP41 8810009620 Bind screw BT M3 × 6 ZK 2 MP113 8930047260 Himeron sheet (BV) 1
MP42 8810009620 Bind screw BT M3 × 6 ZK 7 MP114 8930047440 Isolating plate 2
MP45 8810009620 Bind screw BT M3 × 6 ZK 5 MP116 6910008240 59TN4771 1
MP46 8810008660 Bind screw BT M3 × 8 ZK 4 MP117 8930046320 1900 B-Sheet 1
MP48 8810004430 Screw PH M3 × 6 ZK 2 MP119 8810009310 Screw FH BT M3 × 6 NI-ZU 1
MP49 8810008690 Screw PH BT M4 ×16 NI-ZU 5 MP120 8810009620 Bind screw BT M3 × 6 ZK 1
MP53 8810009620 Bind screw BT M3 × 6 ZK 6 WS1 8970022801 EX1900 Special coaxial cable-1 (2)/CH 1
MP54 8810009620 Bind screw BT M3 × 6 ZK 2 WS3 8970022520 EX1900 1.5D coaxial cable (2)/CH 1
Screw abbreviations: PH: Pan head BT: Self-tapping ZK: Black
6-1
MP66
MP65
MP2
MP66
ANT-SW UNIT
[JACK-1 UNIT] CHASSIS PARTS

ORDER
REF NO. DESCRIPTION QTY.
NO. MP65 MP21
J1 6450001590 Connector TCS5073-17-4151 1
M
J3 6450001130 Connector JPJ2042-01-110 1 W31 MP84
J4 6450000140 Connector HSJ0807-01-010 1 MP67 L MP85
J5 6450001590 Connector TCS5073-17-4151 1 MP21 N
H
J7 6450001130 Connector JPJ2042-01-110 1 MP37
W31
J8 6450000140 Connector HSJ0807-01-010 1 MP68 WS1 (AN) MP54
MP31 MP53
J10 6510003450 Connector B09B-EH-S 1 MP69
MP112 MP65 MP121
J11 6510003450 Connector B09B-EH-S 1 MP70
MP33 MP30 MP95
S1 2220000570 Switch HSW1196-01-020 1 MP71
MP7 MP56
MP32 MP67 MP95
MP69 MP64
I
[ANT-SW UNIT] MP116 MP121 MP95
MP105 PA UNIT
ORDER MP65 J
REF NO. DESCRIPTION QTY. MP56
NO. I
MP39 J
MP64
EP1 6910011340 Terminal OT-010 M3 1 MP63
MP48
EP2 6910011340 Terminal OT-010 M3 1
FILTER UNIT D
B
RL1 6330001460 Relay FTR-F1CA012V 1 E
COMBINR UNIT
D
RL2 6330001460 Relay FTR-F1CA012V 1 C MP12
B
RL3 6330001460 Relay FTR-F1CA012V 1 MP97 MP54 MP57
MP8
RL4 6330001460 Relay FTR-F1CA012V 1 F
E MP55
MP53
MP88 MP53
G
MP72 JACK-1 UNIT MP46 MP4

K MP6 F
MP17 C
A
MP46 G
MP49
TUNER UNIT
MP104 MP16 S
MP75 MP17 L
EP9 R M H
P
Q MP120
MP38
MP59 MP46
MP98 K
N
MP42 MP46
EP11 O
A
MP36 MP34 MP35
MP40 MP74 MP90
MP114 MP87
W32
MP73 O MP5
T
MP42
MP100
FRONT UNIT MP72
MP119
MP49 R
S P
MP87 Q
MP42 T
MP109 PX-1981
MP72 MP117
MP41
MP61 MP52 MP49 MP41
MP36
MP3
Note
MP42 MP110 (AN) : ANT-SW UNIT
EP8
MP1
6-2
MP15
MP19 MP15
MP16
SW BOARD
MP13
MP18
MP17
MP11 MP16
FRONT UNIT
MP17
DS1
MP14 MP18
MP16
EP1
MP45 (CH)
MP2
MP13
ME1 MP19
MP12 MP1
MP3 MP20 MP17

WS1 MP80 (CH)
DS2
MP11 WS1 (CH) MP45 (CH)
MP1
MP12
MP4 MP81 (CH)
WS1 WS1
MP4
EP2 MP26 (CH)
MP12 EP1
MP8 EP3
EP4 MP45 (CH)

MP14
MP5 FILTER UNIT EP2
MP45 (CH)
MP8 MP12 MP20
MP26 (CH)
ME2 MP11 (CH)
MP77 (CH)
MP8
MP10 (CH)
MP12
MP76 (CH)
MP6
MP26 (CH)
FILTER UNIT
COMBINR UNIT
MP2 (CO)
MP5
MP23 (CH) WS1 (CH)
MP26 (CH) MP99 (CH)
MP1 (CO)
L5 (CO)
EP5 (CO) EP1 (CO)
P2 (CO) EP2 (CO)
MP78 (CH)
Note
WS2 (CO) (CH) : CHASSIS PARTS (See page 6 - 1)
MP23 (CH)
(CO) : COMBINER UNIT
MP79 (CH)
MP23 (CH)
6-3
6-2 FRONT UNIT DISASSEMBLY 6-3 FILTER UNIT DISASSEMBLY
[FRONT UNIT] [FILTER UNIT]
ORDER ORDER
NO. NO.
DS1 5080000380 Lamp HRS-4160A-H9 L150 1 EP1 6910011330 Terminal OT-009 M3 1
DS2 5080000380 Lamp HRS-4160A-H9 L150 1 EP2 6910011330 Terminal OT-009 M3 1
EP1 6910011040 Tube A-4210-G20 1 EP3 6910011330 Terminal OT-009 M3 1
EP2 6910011040 Tube A-4210-G20 1 EP4 6910011330 Terminal OT-009 M3 1
ME1 5510000470 Meter ME-39 EX1900 1 MP1 8930014140 Grounding spring(D) 1
ME2 5510000460 Meter ME-38 1 MP4 8930014140 Grounding spring(D) 1
MP1 8210014260 1900 Control panel 1 MP5 8510011480 1900 AL cover 1
MP2 8110006101 1900 Control cover-1 1 RL1 6330000201 Relay VS-12TBU-E-UC 1
MP3 8610008431 Knob K202-1 1 RL2 6330000201 Relay VS-12TBU-E-UC 1
MP4 8610010371 Knob K155(A)-1 EX1900 2 RL3 6330000201 Relay VS-12TBU-E-UC 1
MP5 8610010381 Knob K155(B)-1 EX1900 1 RL4 6330000201 Relay VS-12TBU-E-UC 1
MP6 8610010391 Knob K155(C)-1 EX1900 1 RL5 6330000201 Relay VS-12TBU-E-UC 1
MP8 8610010411 Knob K200(B)-1 EX1900 4 RL6 6330000201 Relay VS-12TBU-E-UC 1
MP11 8930042550 1900 Meter angle 2 RL7 6330000201 Relay VS-12TBU-E-UC 1
MP12 8930017960 Push spring 9 RL8 6330000201 Relay VS-12TBU-E-UC 1
MP13 8930041660 Standoff cushion (B) 4 RL9 6330000201 Relay VS-12TBU-E-UC 1
MP14 8010002990 Meter holder 2 RL10 6330000201 Relay VS-12TBU-E-UC 1
MP15 8810004430 Screw PH M3 × 6 ZK 5 RL11 6330000201 Relay VS-12TBU-E-UC 1
MP16 8810008660 SCREW PH BT M3 × 8 NI-ZU 6 RL12 6330000201 Relay VS-12TBU-E-UC 1
MP17 8810008660 SCREW PH BT M3 × 8 NI-ZU 4 RL13 6330000201 Relay VS-12TBU-E-UC 1
MP18 8810002250 SCREW FH B0 M2.6 × 6 4 RL14 6330000201 Relay VS-12TBU-E-UC 1
MP19 8930006630 Himeron sheet G 2 RL15 6330001500 Relay AW3033 1
MP20 8930043290 Rubber sheet (AF) 4 RL16 6330001210 Relay VB-12TBU-UC (UL3) 1
WS1 8970022810 EX1900 J lead set (4)/FR 4 RL17 6330001210 Relay VB-12TBU-UC (UL3) 1
WS2 8600035961 EX1900 P03*04FR-1 1 WS1 8600035754 EX1900 P01*J01FI-4 1
WS2 8970022640 EX1900 1.5D coaxial cable (1)/FI 1
WS3 8970022650 EX1900 Tefron coaxial cable (1)/FI 1
Screw abbreviations: PH: Pan head

BT, B0: Self-tapping
ZK: Black
NI-ZU: Nickel-Zinc
[COMBINR UNIT]
ORDER
NO.
J1 6510017920 Connector 1811P342 1
J2 6510017920 Connector 1811P342 1
J3 6510017920 Connector 1811P342 1
J4 6510017920 Connector 1811P342 1
J5 6510003080 Connector RT01T-1.0B 1
J6 6510003080 Connector RT01T-1.0B 1
J7 6510003080 Connector RT01T-1.0B 1
J7 6510003080 Connector RT01T-1.0B 1
L5 6140003290 LR-365 1
EP1 6910011330 Terminal OT-009 M3 1
EP2 6910011330 Terminal OT-009 M3 1
EP5 0910049250 B5039 (#1900-3D) 1
MP1 8930000700 Tread spacer (T) 1
MP2 8810003380 Set screw C M3 ×10 2
WS1 8970022610 EX1900 0.8D coaxial cable (3)/CO 1
WS2 8600035730 EX1900 P01*J08CO 1
6-4
6-4 POWER UNIT DISASSEMBLY
[PA UNIT] [PA-1 BOARD]
ORDER ORDER
NO. NO.
W1 8900006990 Cable OPC-683 (N:10 L:110) 1 J2 6510017920 Connector 1811P342 1
W2 8900007360 Cable OPC-711 (N:10 L:250) 1 J5 6510003390 Connector B03B-EH-S 1
W3 8900006990 Cable OPC-683 (N:10 L:110) 1 J6 6510003080 Connector RT01T-1.0B 1
W4 8900007360 Cable OPC-711 (N:10 L:250) 1 EP1 6910011330 Terminal OT-009 M3 1
MF1 2710000620 Fan PUDC12Z4-992 1 EP2 6910011330 Terminal OT-009 M3 1
MF2 2710000620 Fan PUDC12Z4-992 1 EP3 6910000640 Bead FSOH090RN 1
MF3 2710000620 Fan PUDC12Z4-992 1 WS1 8970022531 EX1900 J boad set-1 (1)/PA-1 1
MP1 8930042520 1900 FHS angle 1 WS2 8970022540 EX1900 1.5D coaxial cable (1)/PA-1 1
MP2 8930042510 1900 RHS angle 1
MP3 8410002123 1900 PA heat sink-3 1
MP4 8810003160 Set screw A M3 × 6 16
MP5 8810008490 Set screw H M2.6 × 8 NI 16
MP6 8810009620 Bind screw BT M3 × 6 ZK 4 [PA-2 BOARD]
MP7 8810009620 Bind screw BT M3 × 6 ZK 6 ORDER
MP8 8810009620 Bind screw BT M3 × 6 ZK 8 NO.
MP9 8930043050 1900 Spacer angle 1 J2 6510017920 Connector 1811P342 1
MP10 8810003160 Set screw A M3 × 6 4 J5 6510003390 Connector B03B-EH-S 1
MP11 8820000550 Cap-bolt M4 × 8 ZK 12 J6 6510003080 Connector RT01T-1.0B 1
MP12 8810003360 Set screw C M3 × 6 1 EP1 6910011330 Terminal OT-009 M3 1
MP13 8810003360 Set screw C M3 × 6 1 EP2 6910011330 Terminal OT-009 M3 1
MP14 8810003360 Set screw C M3 × 6 1 EP3 6910000640 Bead FSOH090RN 1
MP15 8810003360 Set screw C M3 × 6 1 WS1 8970022551 EX1900 J boad set-1 (1)/PA-2 1
MP16 8810003360 Set screw C M3 × 6 1 WS2 8970022560 EX1900 1.5D coaxial cable (1)/PA-2 1
MP17 8810003360 Set screw C M3 × 6 1
MP18 8810003360 Set screw C M3 × 6 1
MP19 8810003360 Set screw C M3 × 6 1
MP21 8930047400 1900 C-sheeet 1
MP22 8930047410 1900 D-sheet 1 [PA-3 BOARD]
WS1 8970022930 EX1900 J boad (special) (4)/PA 1
ORDER
Screw abbreviations: PH: Pan head NO.
BT: Self-tapping J2 6510017920 Connector 1811P342 1
ZK: Black J5 6510003390 Connector B03B-EH-S 1
NI: Nickel J6 6510003080 Connector RT01T-1.0B 1
EP1 6910011330 Terminal OT-009 M3 1
EP2 6910011330 Terminal OT-009 M3 1
EP3 6910000640 Bead FSOH090RN 1
WS1 8970022571 EX1900 J boad set-1 (1)/PA-3 1
WS2 8970022580 EX1900 1.5D coaxial cable (1)/PA-3 1
[SPLITR UNIT] [PA-4 BOARD]

ORDER ORDER
NO. NO.
J1 6510007020 Connector TMP-J01X-V6 1 J2 6510017920 Connector 1811P342 1
J2 6510007020 TMP-J01X-V6 1 J5 6510003390 Connector B03B-EH-S 1
J4 6510007020 TMP-J01X-V6 1 J6 6510003080 Connector RT01T-1.0B 1
J5 6510007020 TMP-J01X-V6 1 EP1 6910011330 Terminal OT-009 M3 1
J6 6510007020 TMP-J01X-V6 1 EP2 6910011330 Terminal OT-009 M3 1
J7 6510007020 TMP-J01X-V6 1 EP3 6910000640 Bead FSOH090RN 1
J8 6510007020 TMP-J01X-V6 1 WS1 8970022591 EX1900 Jboad set-1(1)/PA-4 1
RL1 6330001330 AG 201344 1 WS2 8970022600 EX1900 1.5D coaxial cable (1)/PA-4 1
RL2 6330000470 NR-HD (12V) AE5343 1
WS1 8600035721 EX1900 P01*J03*09SP-1 1
6-5
J1 (CH) J2 (CH)
PA UNIT
WS3 (CH) MP4 MP11
f e
MP5
MP12 c
MP16 MP11
MF3
MP4
MP2
MP11
MP7
PA-2 BOARD
d
c
b
a
W1
W15 (CH)
MP10
f MP11
MP11
MP7
MP9
W4 MP8 MP7 MF2

WS1
SPLITR UNIT
MP7 MP11
MP4
g
MP7
MP10
MP106 (CH)
MP5
g MP11
d
MP13 MP11
MP8
MP4
MP8
MP17 MF1
MP4 MP8 MP11
W16 (CH)
MP22
PA-1 BOARD MP8
PA-4 BOARD MP4
W2
MP1 W18 (CH)
a
MP21
e
I W3 MP4
MP3 MP5
PA-3 BOARD I MP4
MP6 b h
h
MP14
EP13 (CH) MP18
MP4
WS1
MP113 (CH) Note
MP6 MP5 (CH) : CHASSIS PARTS (See page 6 - 1)
MP4
MP15
MP4
W17 (CH) MP19
6-6
6-5 TUNER UNIT DISASSEMBLY
[TUNER UNIT]
TUNER UNIT MP20
ORDER
NO.
MP111 (CH)
C1 4620000130 UV55 150pF 1
MP2 C2 4620000130 UV55 150pF 1
MP39 W21 (CH) H-NET BOARD EP7 9019001020 Enpire tube 1
MP111 (CH)
MF1 2710000460 Stepping motor MP28GA 1
MP20
MF2 2710000460 Stepping motor MP28GA 1
MP40 MF3 2710000630 Fan FBA08T12HC (w/beadscore) 1
MP16
MP1 8510011322 1900 A-TUN case-2 1
MP2 8510011351 1900 A-TUN cover-1 1
MP4 MP3 8930044041 1900 A-motor angle-1 1
MP4 8810006500 Bind screw M4 × 20 ZK 4
MP35 MP5 8810002160 Screw FH M3 × 5 6
MP6 8930030111 1414 Plate-1 2
MP4 MP7 8820000880 1528 Screw 4
MP8 8930044030 1900 TUN angle 1
MP9 8950003200 UJ6-5 (univ. cuppling) 2
MP20
EP2 (H-N) MP10 8930044050 1900 CU plate 1
MP34
W20 (CH) MP11 8810002160 Screw FH M3 × 5 1
MP96 (CH) MP12 8810009620 Bind screw BT M3 × 6 ZK 1
MF3 MP13 8510011332 1900 B-TUN case-2 1
MP14 8810009620 Tapping screw bind B0 M3 × 6 ZK(BT) 3
MP15 8810009620 Tapping screw bind B0 M3 × 6 ZK(BT) 3
MP14 MP16 8810009620 Tapping screw bind B0 M3 × 6 ZK(BT) 3
MP17 8810008660 Tapping screw bind PH B0 M3 × 8 NI-ZU (BT) 4
EP7
MP13 MP18 8810009620 Tapping screw bind B0 M3 × 6 ZK(BT) 4
Note C1 MP19 8810003160 Set screw A M3 × 6 4
(CH) : CHASSIS PARTS (See page 6 - 1) MP1 C2 MP20 8810008660 Tapping screw bind PH B0 M3 × 8 NI-ZU (BT) 4
(MA) : MAIN UNIT MP8 MP21 8810009310 Tapping screw bind PH B0 M3 × 6 NI-ZU (BT) 2
(DE) : DET BOARD MP22 8810003380 Set screw C M3 ×10 1
MP10
(H-N) : H-NET BOARD MP5 MP23 8810003160 Set screw A M3 × 6 2
MP3 MP9 MP24 8810003360 Set screw C M3 × 6 2
MP6 MP25 8950000180 Cable tie-80 2
CONNECT BOARD MP32
MP26 6910008240 Clip 59TN4772 2
MP23 MP12 MP27 8810003160 Set screw A M3 × 6 4
MP21 MP28 8930007100 Alumi-sheet C 3
MF1 MP31 8930047180 1900 A-grounding plate 1
MP11
MP32 8810008660 Tapping screw bind PH B0 M3 × 8 NI-ZU (BT) 1
MP7 MP22 MP34 8950001770 Filamen tape 9510 12 × 40 1
MP6 MP28
MP9 MP35 8950004950 Filamen tape 9510 12 × 195 1
DET BOARD MP5 MP31
MP36 8930047810 1900 Tun spring 1
EP7 (DE) MP15 MP38 MP37 8930047190 1900 B-grounding plate 1
MP19 MP1(DE) MF21 MP28 MP38 8810008630 Tapping screw bind PH B0 M3 × 6 NI-ZU (BT) 1
MP82 (CH) MF2 MP27
MP3 (DE) MP39 8930004070 Grounding spring (C) 1
MP7 C-NET MP3 (MA) MP40 8930008660 Tapping screw bind PH B0 M3 × 8 NI-ZU (BT) 1
MP83 (CH) BOARD MP37
MP25 WS1 8970022910 EX1900 Special coxial cable (1)/TU 1
MP19 EP5 (DE) MP17
EP8 (DE) MP27 Screw abbreviations: PH: Pan head FH: Flat head
MP2 (DE) BT: Self-tapping ZK: Black NI:Nickel
WS2 (DE) MP19 WS1 (DE) MAIN UNIT
EP6 (DE) MP4 (MA)
MP24 [DET BOARD]
MP36 MP2 (MA) ORDER
MP19 MP18 MP27 NO.
EP5 6910011330 Terminal OT-009 M3 1
WS2 EP6 6910011330 Terminal OT-009 M3 1
MP17 EP7 6910011330 Terminal OT-009 M3 1
MP18 EP8 6910011330 Terminal OT-009 M3 1
MP25 WS1
L-NET BOARD MP1 8510001080 Shild case (A) SX117 1
MP2 8510001101 Shild case (A) cover (A)-1 1
MP17
MP3 8510004370 506 Shild plate 1
WS1 8970022630 EX1900 Tefron coaxial cable (2)/DE 1
WS2 8600035821 EX1900 P01*J01DE-1 1
6-7
[MAIN UNIT] [ACCESSORIES]
ORDER ORDER
NO. NO.
J1 6510003080 Connector RT01T-1.0B 1 W1 8900007580 Cable OPC-730 1
J3 6510003450 Connector B09B-EH-S 1 W2 8900002260 Cable OPC-104 B 1
J4 6510003480 Connector B12B-EH-S 1 W3 8900002270 Cable OPC-125 B 1
J6 6510003410 Connector B05B-EH-S 1 W4 8900007290 Cable OPC-718 1
J8 6510003490 Connector B13B-EH-S 1 EP1 6510020330 Terminal 5.5-5 pin 1
J9 6510003410 Connector B05B-EH-S 1 EP2 6910010480 DL-7C OR-31-15-19H [USA], [EUR] 10
J10 6510003450 Connector B09B-EH-S 1 MP1 8310039530 1900 front plate 1
J14 6510017650 Connector 52045-1045 1 MP3 8930043080 Rubber (hole bush) 2
J17 6510003390 Connector B03B-EH-S 1 MP4 8810004430 Screw PH M3 × 6 ZK [EUR-1] only 2
J18 6510003410 Connector B05B-EH-S 1 MP6 8950001980 JIG cable tie-140 [EUR-1] only 2
J19 6510003420 Connector B06B-EH-S 1 MP7 8310045230 1900 Cable caution rabel(BJ) [EUR-1] only 1
J20 6510003430 Connector B07B-EH-S 1
S3 2260002220 Switch S-1010A 1 W2 W3 W1 W4 MP3 EP1 MP4
S4 2260002220 Switch S-1010A 1
MP1 8510000230 220 Shield case 1
MP2 8510000241 220 Shield case cover-1 1
MP3 8510005581 644 Shield plate-1 1 MP1
MP4 8510011820 1900 shield plate 1
RL2 6330001320 Relay AHY103 1
RL3 6330001320 Relay AHY103 1
EP2 MP6
[L-NET BOARD]
ORDER
NO.
EP1 6910011340 Terminal OT-010 M3 1
RL1 6330000570 Relay AR-39251 1
RL2 6330000570 Relay AR-39251 1
[H-NET BOARD]
ORDER
NO.
EP2 6910011340 Terminal OT-010 M3 1
RL1 6330000570 Relay AR-39251 1
RL2 6330000570 Relay AR-39251 1
RL3 6330000570 Relay AR-39251 1
RL4 6330000570 Relay AR-39251 1
RL5 6330000570 Relay AR-39251 1
RL6 6330000570 Relay AR-39251 1
RL7 6330000570 Relay AR-39251 1
RL8 6330000570 Relay AR-39251 1
RL9 6330000570 Relay AR-39251 1
RL10 6330000570 Relay AR-39251 1
[C-NET BOARD]
ORDER
NO.
RL1 6330001440 Relay VS-12TBU-VD3 1
RL2 6330001440 Relay VS-12TBU-VD3 1
RL3 6330000570 Relay AR-39251 1
RL4 6330001490 Relay VB-12MBU-UC (UL3) 1
RL7 6330000570 Relay AR-39251 1
6-8
SECTION 7 SEMI-CONDUCTOR
PARTS LIST INFORMATION
7-1 TRANSISTOR AND FET’s 7-2 DIODES

NAME SYMBOL INSIDE VIEW NAME SYMBOL INSIDE VIEW
A
C
2SA1588-GR SG 1SS300 A3
2SA1586-Y SY
K1 K2
B E
C 1SS301 B3
2SB1119S BB
2SB1123S BF A1 A2
2SB1132R BAR
B C E
1SS315 S2
A K
1SS373 S4
D2FS4-4063 2FS
C
2SC2714-O QO
2SC4116-GR GR
B E
HSM88AS-TR C1
A K
S
2SK302-Y TY
D G MA77 4B A K
2SK515-T1B X33
MA8051-M 5_1 A K
S D
K
C
RD4.7M-T2B2 472
DTC114EE 24 RD5.1M-T2B2 512
DTC144EE 26
A
B E
7-1
SECTION 8 BOARD LAYOUTS
8-1 ANT- SW UNIT

TO MAIN UNIT J9
5 4 3 2 1
GND
S1
S2
S3
S4
P1
EP5
GND
S1
S2
S3
S4
J1
GND EP2 C16 C15 C14

TO
DET J6 J5 J4
BOARD J3
TOUT EP1
2 1 2 1 2 1 2 1
CHASSIS UNIT
TO ANT4 TO ANT3 TO ANT2 TO ANT1
8-2 C-NET BOARD
TO DET BOARD TO DET BOARD TO DET BOARD

CP10 CP9 CP11
GND CIN COUT
TO TO
MAIN UNIT MAIN UNIT
J20 J19
P2 EP2 P1
1 TU2 J1 EP1
6 GND 6
2 VHCI 1 TU1 5
3 CI3B VHCO 4
4 CI2B J2 CO3B 3
5 CI1B 1 CO2B 2
6 GND 7 CO1B 1
7 GND
CHW
FROM H-NET BOARD L11
8-1
8-3 L-NET BOARD
TO
H-NET BOARD
EP2
EP1
LHW
EP3 P1
7M TO
7M 1 MAIN
35M 35M 2 UNIT
GND GND 3 J22
8-4 H-NET BOARD

P1
50M 1
28M 2
21M 3
14M 4 TO MAIN UNIT
10M 5 J21
GND 6
NC 7
EP1 NC 8
1
J1
TO
L-NET EP2 20mm
BOARD
EP1
TO C-NET BOARD
LHW
8-2
10
9
12V
PW
8-5 CONNECT BOARD
PX
J1
PY
PZ
12V
RW
RX
RY 12V
TO MAIN UNIT J14

RZ
2
PW
1
PX
PY
PZ
J3
5
1
12V
PZ
MF1
12V
PZ PW
12V
8-3
PX
PY RW
M
PY PY RW
PZ
PX RX
MOTOR STEPPER
PX RX
PW RY
M
PW RY
12V RZ
12V RZ
MF2
1
J2
MOTOR STEPPER
8-6 COMBINR UNIT
TO MAIN UNIT J17

P1
GND
BAL
–
J8 1 3
W5, W6
J8
MP5
MP3 MP4
W1, W2 W3, W4
GND FIN
EP1 EP2
J1 J2 J3 J4
PAO1 PAO2 PAO4 PAO3
TO PA1 TO PA2 EP2 EP1 TO PA4 TO PA3

BOARD BOARD BOARD BOARD
J2 J2 TO FILTER UNIT J2 J2
8-4
8-7 SPLITR UNIT
TO MAIN UNIT J10
TEMP
DRIV
GND
GND
PAF
T13
5V
IN
P1
F
TO PA1 BOARD J3
1 9
2 10
GND
GND
PAF
T8V
NC
J11
GND
GND
PAF
T8V
HV
EP4
1 9
GND
J9
1
F
5V
J11 TO PA BOARD
TEMP J4
PA2-J1
IN
DRIV J2
6 J5
PA1-J1
J1
J6 PA3-J1
J7
PA4-J1
J8 J3
1 3
GND
PAF
T13
TO CHASSIS TO
TO CHASSIS
IN1 FILTER UNIT
IN2
J2
8-5
8-8 PA UNIT
TO PA4 BOARD J3 TO PA3 BOARD J3 TO PA2 BOARD J3 NONE

J5 9 1 9 2 9 1 9 1
GND
GND
GND
GND
GND
GND
GND
GND
PAF
PAF
PAF
T8V
T8V
PAF
T8V
T8V
MF2
NC
NC
NC
NC
1
GND J4 J4 J4 J4
GND
GND
GND
GND
GND
GND
GND
GND
PAF
T8V
NC
PAF
PAF
–
PAF
T8V
T8V
T8V
NC
NC
NC
M
10 2 10 1 10 2 10 2
PAF 3 TO PX-1981
GND (OPTION)
PA1 BOARD J4 PA4 BOARD J4 (each PA bords) PA3 BOARD J4 (each PA bords) PA2 BOARD J4 (each PA bords)
EP2
J4 TO PA-2
BOARD
J5 EP1
EP2
TO PX-1981
HV (OPTION)
J2
TO PA-4 TO PX-1981
GND (OPTION)
BOARD
EP2 EP2
TO PA-3
BOARD
EP1
J1
TO PX-1981
EP1 HV (OPTION)
EP1
J3
(each PA bords)
PA4 PA3 PA2 PA1
2 10 BOARD J2 BOARD J2 BOARD J2
BOARD J2
GND
GND
PAF
T8V
NC
J3
GND
GND
PAF
T8V
HV
1 9
TO SPLITR UNIT J11
J3 J4 J2 J1
TO COMBINR UNIT
8-6
8-9 DET BOARD
TO C-NET BOARD
CP3
COUT
CP11
CP5 CP6 CP8 CP7
CP4
CP1 CP2 CP3 CP9
CP10
J1
1 5
TIN GND GND CIN GND TOUT
–13R
GND
RV
PV
5V
EP3 EP4 CP1 CP2 P1 EP2 EP1
TO FILTER UNIT TO C-NET BOARD TO MAIN UNIT J6 TO ANT-SW UNIT
8-7
8-10 JACK-1 UNIT
EXCITER REMOTE SEND1 ALC1 ACC1 REMOTE SEND2 ALC2 ACC2
1&2 1
ALC ALC
ADJ.1 adj.2
9 1
18 10 1 2 3 1 2 3
4 5 4 5
6 7 1 5 10 6 7
J12 1 10
FANV
GND
SEND2
SEND1
FANV
ALC2
ALC1
GND
GND
13_2
13_1
CI5
1 2 J9
TO MAIN UNIT J2
TUNER
UNIT
MF3
8-8
8-11 SW BOARD
¡TOP VIEW
The combination of this page and the next page shows

the unit layout in the same configuration as the actual
P.C. Board.
1
POWER
2
PO VD
S9
TRANSMIT
ID SWR
INPUT
S7
TEMP ALC
METER-1 METER-2
S1 S2 1
TUNER
2
S4 3
S3 S8
S6 S5
AMP/PROTECT DOWN AUTO 1.8 3.5 7 10 14 18 21 24 28 50 UP ANT
8-9
¡BOTTOM VIEW
The combination of this page and the previous page
shows the unit layout in the same configuration as the
actual P.C. Board.
1 1 CLK CLK 1
DATA DATA
DATK DATK
J1 STR STR TO
H12 H12 MAIN UNIT
S12 J3
S12
J1 DATA2 DATA2
9 9
STR2
GND
STR2
GND 9
P4 P3
CP2 CP5 CP1 CP3

CP4
CP6
GND DS-2 GND DS-1
ME2 ME1
FRONT UNIT
DS2 LAMP DS1 LAMP
8 - 10
8-12 FILTER UNIT The combination of this page and the next page shows
¡TOP VIEW TO COMBINR UNIT the unit layout in the same configuration as the actual
P.C. Board.
EP2
EP1
GND
50M
24M
18M
10M
14M
35M
19M
FIN
7M
GND
W12
MP6
EP3
EP4
FOR
GND
REF
T13
J1
EP6
J2 EP7
TRU TO 1 13
SPLITER
GND
GND
FOR
REF
10M
14M
18M
24M
50M
19M
35M
T13
7M
UNIT J8 TO MAIN UNIT J8 P1
8 - 11
¡BOTTOM VIEW The combination of this page and the previous page
actual P.C. Board.
TIN
EP7 TO TUNER UNIT
GND (DET BOARD)
EP8
8 - 12
TO SPLITR UNIT TO SPLITR UNIT TO TUNER UNIT TO TUNER UNIT TO TUNER UNIT TO TUNER UNIT
3 1 6 1 (DET BOARD) (C-NET BOARD) (L-NET BOARD) (H-NET BOARD)
TEMP
DRIV
GND
GND
PAF
8-13 MAIN UNIT
T13
5V
IN
VHCO
6 1
CO3B
CO2B
CO1B
5 1 6 1 3 1
35M
GND
–13R
GND
GND
GND
J9
TU1
10M
14M
21M
28M
50M
J3
7M
RV
PV
5V
J1 J1 J1 J1
¡TOP VIEW EP4
VHCO
TEMP
P1 P1 P1 P1 P1
CO3B
CO2B
CO1B
DRIV
35M
–13R
GND
GND
GND
GND
GND
GND
PAF
10M
14M
21M
28M
50M
TU1
T13
NC
NC
7M
RV
5V
PV
5V
IN
F
9 1 5 1 6 1 3 1 8 1
J10 J6 J19 J22 J21
1 GND GND 10 J20

GND GND 9 1 5 1 6 1 1 8 1 7
10 GND
FANV FANV
CI5 CI5 GND
TO JACK1 ALC2 ALC2 J2 CP47 7
UNIT J9 CP46 CI1B
ALC1 ALC1 CP45 TO TUNER UNIT
SEND2 SEND2 CP41 6 CI2B (C-NET BOARD J2)
CP42
SEND1 SEND1 CP43 5 CI3B
13_2 13_2 CP44 1
4 VHCI
10 13_1 13_1 1
TU2
J8 P1 3 1
1 1 1
BAL BAL 2
TO J17
COMBINR GND GND 1
UNIT J8
3 GND GND
3
3
J18
J1 5
P1 TTRC 5
1 1
T13 T13 1 2 4 6 8 10 ISTA
TO TO TUNER UNIT
IKEY
FILTER FOR FOR CPU WRITE
UNIT J1 REF REF 1 3 5 7 9 13.8
GND 1
4 GND GND
19M 19M
35M 35M
J8
7M 7M 9 9 P3 9 P4
TO 10M 10M GND GND
FILTER STR2 STR2
UNIT 14M 14M
DATA2 DATA2
18M 18M
S12 S12 TO SW
24M 24M J3 BOARD
H12 H12
J1
50M 50M STR STR
GND GND 13 13 DATK DATK
EP6 EP7 DATA DATA
5 1 CLK CLK
1
1 1
5 P1 1
J9
GND
S3
S4
S2
S1
1 12
1 5
GND
S3
S4
S2
S1
TO ANT-SW UNIT
J1
J14
2 10
12V
PW
RX
PY
RZ
12V
RW
RY
PX
PZ
1 9
J4
1 12
REGHC
9
REGF
REGT
MAXI
1
–13V
GND
GND
SEL
12V
H12
H12
PW
RX
PY
RZ
VD
The combination of this page and the next page shows

ID
P1
the unit layout in the same configuration as the actual
12V
RW
RY
PX
PZ
10 2 TO PX1981 (OPTIONAL UNIT) P.C. Board.

TO TUNER UNIT
(CONNECT BOARD J1) 8 - 13
The combination of this page and the previous page
actual P.C. Board.
¡BOTTOM VIEW
8 - 14
SECTION 9 BLOCK DIAGRAM
CHASSIS UNIT
DET BOARD
SPLITR UNIT FILTER UNIT
ANT1
COUPLER COUPLER 1
D15, D16: MBD701
2
VSWR DET D3,D4, CAP SW CAP SW
D5,D6: MA77 RELAY RELAY
–13V ANT2
1 IC2: MC10125L
INPUT1 IC5: D11, D12: IC4: TA74AC112 1
PA UNIT TA79L05 MD701 D13, D14: 1SS286
2
Q1: MRF150 REF 2
–5V REG
PA1
LPF IMPEDANCE TUNER FAN MOTOR1 MOTOR2 C-NET BOARD ANT3
FREQ DET DET PHASE DET
FOR 1
1
INPUT2
HV –5V 2
2 Q1: MRF150
PA2
IC9: IC9: IC15: L-NET BOARD H-NET BOARD ANT4
SPLITTER NJM4558 NJM4558 TD62083 1
AMP AMP MOTOR

COMBINER DRIVER 2
D4, D5: HV
RG3D Q1: MRF150 IC7: X24C04S8
LIMITER PA3 EE-PROM COIL SW COIL SW

D1–D3: RELAY RELAY ANT-SW
1S953X3
IC14: TD62783 UNIT
HV UNBALANCE IC25: S-8045 IC12: M38022M2-138FP
DET RELAY Q9, Q10, Q11 IC18:
THERMO Q1: MRF150 TUNER CPU DRIVER Q12, Q13: 2SB1119 Q13, Q14: 2SB1119 TD62783
ATT RESET CTRL
DET
PA4 RELAY RELAY RELAY
DRIVER DRIVER DRIVER
Q7: 2SB1119
D3: IC31: NJM4558M FAN
IC1: TA7808 HSM88 HV
REFT
COMBINR DRIVER
T13 SWR AMP TRC
FORT
BIAS DRIVE DET UNIT
PA FAN Q3: 2SB1119
IC2: NJM4558 IC16:
IC2: NJM4558 µPD4069
T13V REG IC8: IC5:
FOR AMP SEND BA9700 TA7805
REF AMP BUFF 12 V
T13 –13V REG +5V REG 5V
Q5: IC28: TC4W66F
IC21: 2SB1119 IC3: NJM4558 IC1: NJM3403 IC3: NJM4558
NJM4558 IC21: SEND1
SEND –13 V
NJM4558 SWR/DRIVE SELECT SEND2
FAN DRIVER COMPARATOR ALC METER
FOR/DRIVE CTRL
PROTECT DRIVE AMP RL2: AHY103
ALC ALC1
SELECT ALC2
Q34: 2SC2714
Q35: 2SK302 IC19: IC4:
TD62783 IC1: NJM3403 NJM4558 REGURATOR 100/200 V
RF AMP
MAIN UNIT RELAY RF POWER ALC AMP IC1: NJM3403
DRIVER CTRL (PX-1981)
IC30: TC7S14
IC1: NJM3403 Id CTRL
IC34: TC4S584F HV
LIMIT AMP H12 (+12V)
IC17: X24C01AS
CPU DRIVE S12
IC20: TC74AC393 EE-PROM (+12V)
DET
RELAY CTRL
DEVIDER IC8: TC7W74 +5V REG
MAIN CPU IC9: TC4S584 IC6: TA7805
IC26: TMP90PM38F CI-V
ANT
POWER 5V
IC7: BU4021 UP
SHIFT DOWN
5V REGISTER
TUNER
TRANSMIT AUTO ALC TUNER Id OUTPUT
DATA AMP/
EXPANDER PROTECT
Po Vd SWR TEMP INPUT 1/2

METER1 IC1, IC2
H12 IC3, IC4: µPD4094
(+12V)
LED METER 1
METER IC5: M62354
LAMP
AMP/PROTECT 1-2 METER 2
1.8 – 50 METER2 D/A
BAND ANT1-4 INPUT1-2
LED SW BOARD
FRONT UNIT
9-1
SECTION 10 VOLTAGE DIAGRAM
P3 J8
TRU
10-1 WIRING DIAGRAM

1 2 3 4 5 6 7 8 9 10 J4 J1 P1 J4
PAI2 PAI2
GND
GND
GND
GND
PAF
PAF
T8V
T8V
NC
NC
J6
ANT1
ANT1 TOUT EP1 W9,W10 EP5 TOUT TIN
EP7 W1, W2 EP3 TIN
J2
J2 W16 J2 J1 J1
GND TRU EP1 W3,W4 EP2 P1
FIN FIN PAO2 PAO2 IN1
GND EP2 GND IN1
J5
EP6
DET
GND
J1
EP8 EP4
GND
GND
EP2 EP1
GND PA2 BOARD J5
–13R PAF
ANT2 1
ANT2 3 3
BOARD
GND
GND
GND
GND
5V MF3
PAF
PAF
T8V
T8V
MF3 2 2 2
NC
HV
GND
GND PV
HV
3 GND 1 1
RV 4
GND 5 EP1 EP2 10 9 8 7 6 5 4 3 2 1 J3
J4 ANT3 GND COUT CIN

ANT3 GND
W6
CP10 CP11 CP9 W2
FILTER COMBINR
W10
ANT4
J3
ANT4
GND
TUNER UNIT W5 W7 W6
UNIT UNIT 1 2 3 4 5 6 7 8 9 10 J4
GND
GND
GND
GND
PAF
PAF
T8V
T8V
CP1 CP3 CP2 J1 J6 J2 J2
NC
NC
J2 P1 P2
J3 W17 PAI3 PAI3 IN2
IN2
ANT-SW GND COUT CIN
PAO3 PAO3
PA3 BOARD J5
GND
UNIT
S4
S3
S2
S1
GND
GND
GND
GND
PAF
PAF
2
T8V
T8V
NC
HV
GND
J1 1
HV
5 4 3 2 1
C-NET BOARD GND EP1 EP2 10 9 8 7 6 5 4 3 2 1 J3
50M
J12 W8
24M
FANV W1
1 1 W12
VHCO
GND
CO1B
CO2B
CO3B
VHCI
2 2
CI3B
CI2B
CI1B
GND
GND
GND
18M
TU1
TU2
14M
J1 J2 1 2 3 4 5 6 7 8 9 10 J4 J1 P1 J7
1 2 3 4 5 6 1 2 3 4 5 6 7 J4 W18 J2 PAI4 PAI4
10M PAO4 PAO4
GND
GND
GND
GND
PAF
PAF
T8V
T8V
NC
NC
7M
C1 C2
35M PA4 BOARD J5
MF1 MF2 PAF 3 3
GND
GND
GND
GND
L11 19M
PAF
PAF
T8V
T8V
2 2
NC
HV
GND MF1
GND
1 1
HV
GND
FOR
REF
H-NET
T13
EP1 EP2 10 9 8 7 6 5 4 3 2 1 J3
J1
50M
1
2 28M
BOARD J1 4 3 2 1
JACK1 3
4
5
21M
14M
10M
GND 5 4 3 2 1 5 4 3 2 1
W7
W11
W4
UNIT 6
EP2
J8
J4
BAL 1 2 3 4 5 6 7 8 9 10 J1 P1 J5
1 J1 W15 J2 PAI1 PAI1
5 4 3 2 1 5 4 3 2 1 2 PAO1 PAO1
GND
GND
GND
GND
MP10
PAF
PAF
T8V
T8V
GND
NC
NC
J2 J3 3
12V
12V
RW
PW
RY
RX
PY
PX
RZ
PZ
EP1
PA1 BOARD J5
L-NET CONNECT PAF

3 3
GND
GND
GND
GND
PAF
PAF
T8V
T8V
2 2
GND
NC
MF2
HV
35M
GND
BOARD GND
7M
1 1
HV
BOARD HV
HV
EP1 EP2 10 9 8 7 6 5 4 3 2 1 J3
3 2 1 J1
PX-1981 GND
12V
12V
RW
PW
RY
RX
RZ
PY
PX
PZ
GND
J1
SEND1
SEND2
FANV
ALC1
ALC2
1 2 3 4 5 6 7 8 9 10 W5
GND
GND
13_1
13_2
PA UNIT
CI5
REGHC
W3
REGT
MAXT
REGF
–13V
GND
GND
W9
ACS
H12
H12
J9
VC
IC
10 9 8 7 6 5 4 3 2 1
12 1110 9 8 7 6 5 4 3 2 1
1 2 3 4 5 6 7 8 9 10 J11
GND
GND
GND
GND
PAF
PAF
T8V
T8V
NC
HV
W20 SPLITR UNIT
TEMP
W21
DRIV
GND
GND
PAF
T13
5V
IN
F
EP7 J9 1 2 3 4 5 6 1 2 3 J3
EP4
DS1 DS2
1 2 3 4 5 1 2 3 4 5 6 7 8 3 2 1 1 2 3 4 5 6 1 2 3 4 5 6 7 5 4 3 2 1 13 121110 9 8 7 6 5 4 3 2 1 1 2 3 12 11 10 9 8 7 6 5 4 3 2 1
1 2 3 4 5 6 7 8 9
P1 P1 P1 P1 P2 P1 P1 P1 P1
P1
FRONT ME1 ME2
J9
1 2 3 4 5 J2 1 2 3 4 5 6 7 8 9 10
J21
1 2 3 4 5 6 7 8
J22
3 2 1
J19
1 2 3 4 5 6
J20
1 2 3 4 5 6 7 J14 10 9 8 7 6 5 4 3 2 1
J6
5 4 3 2 1
J8
13 121110 9 8 7 6 5 4 3 2 1 1 2 3
J17 J4
12 11 10 9 8 7 6 5 4 3 2 1
J10
1 2 3 4 5 6 7 8 9
UNIT
REGHC
SEND1
SEND2
CP1 CP4 CP3 CP2 CP6 CP5

VHCO
REGT
REGF
TEMP
CO1B
CO2B
CO3B
FANV
ALC1
ALC2
MAXI
VHCI
–13R
DRIV
–13V
GND
13_1
13_2
GND
GND
GND
GND
GND
CI3B
CI2B
CI1B
GND
GND
GND
GND
GND
GND
GND
GND
GND
GND
FOR
REF
50M
28M
21M
14M
10M
35M
50M
24M
18M
14M
10M
35M
19M
PAF
TU1
TU2
BAL
SEL
H12
H12
12V
12V
T13
T13
RW
PW
CI5
NC
NC
7M
RY
RX
RV
7M
VD
RZ
PY
PX
PV
PZ
S4
S3
S2
S1
5V
5V
METER1
METER2
ID
IN
F
DS-1
DS-2
GND
GND
GND
GND
J3 P3 P4 J1
CLK 1 1 1 1 CLK
DATA 2 2 2 2 DATA
DATK
MAIN UNIT
DATK
STR
H12
S12
3
4
5
3
4
5
3
4
5
3
4
5
STR
H12
S12
SW
DATA2
STR2
6
7
8
6
7
8
6
7
8
6
7
8
DATA2
STR2
BOARD
GND 9 9 9 9 GND
10 - 1
10-2 SPLITER, PA AND COMBINR UNITS
PA2 BOARD
J4 J1 J2
P1 W16
PAI2 PAI2 PAO2
J8
TO TRU
FILTER UNIT
J2
W3, W4
EP2 FIN
EP1
TO FILTER
L5 EP1 GND
EP2
UNIT
LR-365
R3 50
J1 R4 50
P1 J1
IN1
R5 50
C2 L2 L3 L4
0.68 R6 50 LR-119 LR-119 LR-123
PAO1 L3
TO CHASSIS R11 J1 W1 C6 C3
R6
LR-211 W5
100 L1 22 p 68 p
50
C11 LR-119 W2 W6
J2 J2 RL2 56 p
P1 IN2 AE5343
C17
56 p PA1 BOARD R1
W1 W5
100
TX: 13.0 V R9 R10
RX: 0 V 100 100 J5
P1 J1 J2 W15 R9 R8
PAI1 PAI1 10 15
PAO1 R4
RL1 R7 10
C18 AG201344 4.7 k PAO2
GND
GND
GND
GND
PAF
PAF
10 p
T8V
T8V
IN 1: 0 V D2 J2
NC
HV
IN 2: 11.4 V 1SS301 R7
R1 4.7
33 k J3
10 9 8 7 6 5 4 3 2 1
C19 C3 C7 C5 C4
4.8 V 30 p 0.0047 R8 22 p 68 p D3
5p L6
C4 470 LR-123 1S953
J9 L7 0.47 TO SPLTIR UNIT
P1 100 mH
1 GND 1 GND R12 J11
2 F 2 F C14 100
3 5V 3 5V L1 L8 D3 56 p
TEMP TEMP 100 mH 100 mH HSM88AS
TO 4
IN
4
IN C1 D1 R2
MAIN 5 5 0.0047 1SS301 2.2 k C8
6 DRIV 6 DRIV 0.0047 PAO3
UNIT T13 J3
J10
7
8
9
PAF
GND
L10
C5
0.0047 PA UNIT L2
LR-119
W3
W4
W3
D1
1S953
C1
R3
100
100 mH L9 0.047
100 mH D4 L5 D5 R2
RG3D 100 mH RG3D 100
R17
1.5 k R10
R5 10
D2
10 1S953
C21 C20 C10
0.1 0.1 R13
1k C9 0.0047
C2
33 PAO4 R11 0.047
R16 J4 100
TX: 13.0 V ERT-D2FHL802S
R14 R15
J3
RX: 0 V 18 k 120 k PA3 BOARD PAO1 – PAO4 balanced: 0 V
1 T13 J6 P1 J1 J2 W17
2 PAF
PAI3 PAI3 PAO3
3 GND
IC1 8.0 V
R18 TA7808F
4.7
I O
G
C23 C24
C22 0.1 0.1 C25
10
COMBINR UNIT
10
GND
BAL
L11
J3 J11 100 mH
W3
HV 1 HV J8
10 3 2 1
NC 9 2 NC
GND 3 GND
8
GND GND
TO PA UNIT T8V
7 4
T8V W8 W7
BAL
GND
(PA1 BOARD) 6 5
T8V 6 T8V
J3 PAF 5 PAF
4 7
PAF 8 PAF
3 3 2 1
GND 9 GND
2 P1
GND 1 10 GND
TO MAIN UNIT J17
PA4 BOARD
J7 J1 J2 W18
P1
PAI4 PAI4 PAO4
SPLITR UNIT
10 - 2
10-3 FILTER UNIT
L29 L28 L27

EP1 LA-537 LA-537 LA-538
FIN
EP2
TO C130
J2
12 p
COMBINR P3 TRU TO
UNIT C95
SPLITR UNIT
EP1
EP2 GND
50 MHz RL17
VB-12TBU-UL3 15 p
RL16
VB-12TBU-UL3 RL15
AW3033
L23
J8
C96 100 µH
C86 C87
50 MHz ON : 11.5 V C83 12 p 12 p C88 C118 C119 C123 C89 C120 C90 C128 C129 12 p
12 p C91
50 MHz OFF: 0 V 22 p 27 p 27 p 12 p 12 p 12 p 12 p 12 p 12 p 12 p C104
L30 0.0047
50M 10 µH D17
1SS53 C75
0.0047
C103 C100 D18 50 MHz ON : 11.5 V
0.0047 0.0047 1SS53 50 MHz OFF: 0 V
L1 L2
LA-539 LA-405
RL2
VS-12TBU- E-UL3
24 MHz RL1
VS-12TBU-E-UL3
C76
47 p
C77
39 p
W12
24 MHz ON : 11.5 V EP3 T1N
L15 24 MHz OFF: 0 V C1 C116 EP7
C137 C4 C5 C6 C7 C8
24M 10 µH 39 p 39 p
39 p 47 p 47 p 39 p 33 p 39 p L22 TO
C102 C80
LR-123 TUNER UNIT
C101 C58 0.0047 10 p EP4 GND (DET BOARD)
0.0047 0.0047 EP8
R13
D2 24 MHz ON : 11.5 V 47 R14
1SS53 24 MHz OFF: 0 V C81 47
L3 L4 10 p
LA-540 LA-402
R15
RL4 DSA-701 MA
VS-12TBU- E-UL3 R7
47
18 MHz RL3
VS-12TBU-E-UL3
C78
22 p
C79
33 p
C115 C74
R9
47
R8
0.0047 270 p C73
100 p 47
W47 18 MHz ON : 11.5 V
L16 18 MHz OFF: 0 V C9 C10 C11 C12 C13 C14 C15 C16
18M 10 µH 82 p 68 p 56 p 100 p 56 p 56 p 56 p 39 p R10
47
C60 D4
0.0047 1SS53 C108 C107
18 MHz ON : 11.5 V 0.0047 0.0047
L31 18 MHz OFF: 0 V

L6
LA-541 LA-403 R11 R12
10 k 10 k
RL6
VS-12TBU- E-UL3
14 MHz RL5
VS-12TBU-E-UL3
C98
22 p
C126
68 p
D15 C133 C134 D16
MBD701 0.1 0.1 MBD701
14 MHz ON : 11.5 V
L17 14 MHz OFF: 0 V C20 C124
10 µH C19 C24 C125 C23 C18 C112
14M 68 p 56 p 82 p 82 p 82 p 82 p 82 p 82 p
C135 C136
C62 D6 470 p 470 p
0.0047 1SS53
14 MHz ON : 11.5 V
L8 L7 14 MHz OFF: 0 V C71 C72
L33 LR-201 LR-200 0.0047 0.0047
BL01RN1-A62-001
RL8
VS-12TBU- E-UL3
10 MHz RL7
VS-12TBU-E-UL3
10 MHz ON : 11.5 V R2 R3
TX: 13.2 V
RX: 0 V
10 MHz OFF: 0 V 10 k 10 k
L18 C31 C32 C27 C28 C29 C30 C25 C26 R4 R5
10M 100 µH 100 p 100 p 150 p 150 p 120 p 120 p 120 p 150 p 10 k 10 k
C64 D8
0.0047 1SS53
10 MHz ON : 11.5 V J1
L10 EP6 EP7 P1
L9 10 MHz OFF: 0 V
LR-198 LR-199 T13 1 1 T13
FOR 2 2 FOR
REF 3 3 REF
RL10
VS-12TBU- E-UL3 GND 4 4 GND
5 19M
RL9
7 MHz VS-12TBU-E-UL3
6
7
8
35M
7M
10M
TO
MAIN UNIT
7 MHz ON : 11.5 V 9 14M J8
L19 7 MHz OFF: 0 V 19M W9
C33 C34 C35 C36 C37 C38 C39 C40 C110 10 18M
100 µH 47 p 120 p 180 p 150 p 150 p 150 p 180 p
7M 11 24M
180 p 120 p 12
35M 50M
W8
C66 D10 13 GND
0.0047 1SS53
7 MHz ON : 11.5 V
7M W7
L11 L12 7 MHz OFF: 0 V
LR-369 LR-369
10M W6
RL12
VS-12TBU- E-UL3
14M
3.5 MHz RL11
VS-12TBU-E-UL3
W5
3.5 MHz ON : 11.5 V 18M W4

L20 3.5 MHz OFF: 0 V
C41 C117 C42 C43 C44 C45 C46 C131 C47 C48
100 µH 330 p 100 p
35M 330 p 270 p 220 p 270 p 270 p 180 p 150 p 150 p
24M W3
D12 L32
C68 100 µH
0.0047 1SS53
50M W2
3.5 MHz ON : 11.5 V
L13 L14
LR-195 LR-194 3.5 MHz OFF: 0 V
W1
1.9 MHz RL13

VS-12TBU-E-UL3
RL14
VS-12TBU- E-UL3
19M
L21
100 µH
1.9 MHz ON : 11.5 V
1.9 MHz OFF: 0 V C49
680 p
C50
680 p
C138
220 p
C139
220 p
C51
560 p
C52
560 p
C53
560 p
C54
560 p
C140
220 p
C141
220 p
C142
220 p
C143
220 p
C55
680 p
C56
680 p
FILTER UNIT
D14 1.9 MHz ON : 11.5 V
C70
0.0047 1SS53 1.9 MHz OFF: 0 V
10 - 3
10-4 PA UNIT
R18 R18
15 15
C51 R6 C51 R6
0.68 15 4.5 V 0.68 15 4.5 V
TX: 2.6 V C18 TX: 2.6 V C18
RX: 0 V 0.68 RX: 0 V 0.68
PAO2 J2 TO PAO1 J2 TO
L2 C4 L2
LR-322B 0.68 COMBINR R20 LR-322B
C4
0.68
COMBINR
R20 Q1A UNIT J2 Q1A C19
UNIT J1
OUT
OUT
C19 33
33 0.68
R7
MRF150 MP L4
0.68 MRF150 MP L4
R2 R7 R2
TO J1
R16
27 L1 56 2.2 k J6
LR-95 C16 TO J1
R16
27 L1 56 2.2 k J6 LR-95 C16
P1 LA-262 0.68 SPLITR P1 LA-262 0.68
SPLITR PAI2 L3 PAI1
C11 L3
UNIT
W1 LR-296 UNIT 0.1
W1 LR-296
C11
J4 R15 R21
820
R17 C1 0.1 J5 R15 R21
820
R17 C1
560 330 56 p D3 560 330 56 p C56 D3
C56
IN
1SS301 0.0047 1SS301
IN
0.0047 C17 C17
0.68 TX: 2.6 V 0.68
TX: 2.6 V
C3 C3
RX: 0 V 0.68 RX: 0 V
0.68 Q1B Q1B
MRF150 MP MRF150 MP
R8 R4 C52 R5 R8 R4 R5
56 2.2 k 0.68 4.5 V 56 2.2 k 4.5 V
15 15
C13 R19 C13 C52

0.1 D1 0.1 R19
D1 D2 15 D2 0.68 15
1SS301 1SS301 1SS301 1SS301
D4 D4
C57 1SS301 C57 1SS301
0.0047 0.0047
L5 L6 L5 L6
100 µH 100 µH 100 µH 100 µH
R12 R11 L7 R12 R11 L7

C37 C40 TX: 8.0 V 3.9 LR-230 R23 C37 C40 TX: 8.0 V 3.9 LR-230
R23 0.1 R9 R10 0.1 R24 3.9 0.1 R9 R10 0.1 R24 3.9
10 k 20 k 20 k RX: 0 V 10 k 20 k 20 k RX: 0 V
10 k
L9
100 µH W2
10 k
L9
100 µH W6
PX-1981
W6 W2
EP3 EP1 HV EP1 HV
W2 C41 C42 C43 C29 C44 C45 J3 C41 C42 C43 C29 C44 C45 C55
HV
J3 C46 C55 W3 C46
GND 0.1 0.01 0.001 0.1 0.1 0.01 0.001 0.1 0.1 0.01 0.001 0.1 0.1 0.01 0.001 0.1 EP3
1 GND HV
GND 1
2 GND
PAF EP2 GND 2 EP2 GND
3 PAF GND
PAF 3
4 PAF
T8V TO 4
T8V
5 C25 C26 C27 C23 C24 T8V
5 C25 C26 C27 C23 C24 GND
GND
6 0.1 0.047 0.001 470 470 SPLITR T8V
6 0.1 0.047 0.001 470 470
GND
7 UNIT GND
7
8 GND
NC J11 NC
8
9 9
HV HV
10 10
J4
W4 J4
GND 10 L11 GND
J5 10 L11 J5
GND 9 HF50ACC322513 GND
9 HF50ACC322513
PAF 8 13 PAF 3 PAF
MF3 8 1 PAF 3
PAF 7 22 GND 2 PAF MF2
7 2 GND 2
T8V 6 C35 31 GND 1 T8V
C35 GND 1
0.1 T8V 6 3
T8V 5 0.1
GND 5
GND 4
GND 3 GND 4
NC 3
NC 2
NC 1 PA2 BOARD NC
2
1 PA1 BOARD
R18 R18
15 15
C51 R6 C51 R6
0.68 15 0.68 15
4.5 V 4.5 V
TX: 2.6 V C18 TX: 2.6 V C18
RX: 0 V 0.68 RX: 0 V 0.68
PAO3 J2 PAO4 J2 TO
L2 C4 TO L2 C4
LR-322B 0.68 COMBINR R20 LR-322B 0.68
COMBINR
R20
Q1A C19 Q1A C19
OUT
UNIT J3
OUT
33 0.68 UNIT J4 33
MRF150 MP MRF150 MP 0.68
R2 L4 R2 L4
TO J1 R16 L1
R7
56 2.2 k LR-95 C16 TO J1
R16
27 L1
R7
56 2.2 k J6 LR-95 C16
J6
SPLITR P1
PAI3 27 LA-262
L3
0.68 SPLITR P1
PAI4
LA-262
L3
0.68
UNIT C11 W1 LR-296
UNIT W1 LR-296
C11
J6 R15 R21 R17 C1
0.1
J7 R15 R21 R17 C1 0.1
560 820 330 560 820 330
56 p C56 D3 56 p D3
IN
C56
IN
0.0047 1SS301 C17 1SS301 C17

0.68 0.0047
TX: 2.6 V TX: 2.6 V 0.68
C3 RX: 0 V C3 RX: 0 V
0.68 0.68
Q1B Q1B
MRF150 MP MRF150 MP
R8 R4 R5 R8 R4 R5
56 4.5 V 56 15 4.5 V
2.2 k 15 2.2 k
C13 C52 R19 C13 C52 R19

D1 D2 0.1 0.68 D1 D2 0.1 0.68 15
1SS301 15
1SS301 1SS301 1SS301
D4 D4
C57 1SS301 C57 1SS301
0.0047 0.0047
L5 L6 L5 L6
100 µH 100 µH 100 µH 100 µH
R12 R11 L7 R12 R11 L7
C37 C40 3.9 3.9 LR-230 C37 C40 3.9 LR-230
R23 R9 R10 R24 TX: 8.0 V R23 0.1 R9 R10 R24 TX: 8.0 V 3.9
0.1 0.1 20 k 0.1
10 k 20 k 20 k 10 k RX: 0 V 10 k 20 k 10 k RX: 0 V
L9 L9
100 µH W6 W2 100 µH W6 W2
EP3 EP1 HV J3 EP3 EP1 HV
W1 J3 W4
C41 C42 C43 C29 C44 C45 C46 C55 C41 C42 C43 C29 C44 C45 C46 C55
GND 0.1 0.01 0.001 0.1 0.1 0.01 0.1 GND 1 0.1 0.01 0.001 0.1 0.1 0.01 0.1
1 0.001 0.001
GND GND 2
2 PAF
PAF 3 EP2 GND 3 EP2 GND
PAF PAF 4
4 T8V
T8V 5 5
T8V C25 C26 C27 C23 C24 T8V 6 C25 C26 C27 C23 C24
6 0.1 0.047 0.001 470 470 GND 0.1 0.047 0.001 470 470
GND 7 7
GND GND 8
8 NC
NC 9 9
HV HV 10
10
J4 W1 J4
W2
GND GND
10 10 L11 J5
GND L11 J5 GND 9
9 HF50ACC322513 HF50ACC322513
PAF PAF 8 PAF 3
8 1 PAF 1 MF1
PAF PAF GND 2
7 2 GND 7 2
T8V T8V GND 1
6 C35 3 6 C35 3
T8V GND T8V 0.1
5 0.1 5
GND GND
4 4
GND GND
3 3
NC
NC
NC
2
1
PA3 BOARD NC
2
1 PA4 BOARD
10 - 4
10-5 FRONT UNIT
Io SELET: 0 V Io SELET: 4.7 V
Io UNSELECT: 3.2 V Io UNSELECT: 0 V
R2 R3 R4 TUNER ON: 0 V
R1 150 150 470
150 TUNER OFF: 3.2 V
DS1 DS3 DS4
CL-200YG DS2 CL-200YG CL-200YG
CL-200YG
Q1
DTC114EE Q2 Q3 Q4
DTC114EE DTC114EE DTC114EE PROTECT ON 3.2 V
AMP ON 0V
AMP OFF 3.2 V
Vo METER ALC METER
DATK
STR
R5 R6 R7 R25 PROTECT ON 0 V STR
R8 D1 D2 D6
150 150 150 150
STR
CLK
120 AMP ON 3.2 V 1SS301 1SS301 1SS301
TUNER ON: 4.7 V C2 R39 R40 R41 R43 R60 R61
AMP OFF 3.2 V 0.1
DS8 DATA C1 47 k 47 k 47 k 47 k 47 k 47 k
TUNER OFF: 0 V SEC2462C DATA 0.1
DS5 DS6 DS7 IC1 IC7 +5V
CL-200YG
Po METER
CL-200YG
TEMP METER
CL-200YG
SWR METER W1 µPD4094BG BU4021BF R44 C25
Q25 CLK 1 16 +5V ANT 1 16 CLK
1k 0.001
DTC114EE Q8 CLK 2
STR VDD
15 2
H VDD
15 I1/2
D OE QF G
DTC114EE 3 14 A1L DATK 3 14 BDOWN R45 C26
Q5 Q6 Q7 I1L 4
CLK Q5
13 A2L TUNER 4
QH F
13 BUP DATA
1k 0.001
Q1 Q6 D E
DTC114EE DTC114EE DTC114EE I2L 5 Q2 Q7 12 A3L PA 5 C QG 12
R46
PROL
TUNL
6 Q3 Q8 11 A4L MET2 6 B SER 11 C27
PML
VML
SML
AML
TML
1k
PAL
IML
7 10 MET1 7 10 CLK DATK 0.001

Q4 QS A CLK
GND 8 9 GND 8 9 STR
VSS QS VSS P/S R47 C28
1k 0.001
STR
PROTECT ON 0V
AMP ON 4.7 V R58 C31
R9 R10 R11 R12 1k
150 AMP OFF 0V STR DATA2 0.001
150 150 150 C3
3.5 MHz STR 0.1
PROTECT ON 4.7 V R59 C32
3.5 MHz SELET: 0 V 1k
AMP ON 0V 0.001
DS9 3.5 MHz UNSELECT: 3.2 V 10 MHz 18 MHz 24 MHz IC2 STR2
CL-170PG-CD-D DS10 DS11 DS12 AMP OFF 0V CLK
CL-170PG-CD-D CL-170PG-CD-D CL-170PG-CD-D CLK
µPD4094BG
3.5 MHz 10 MHz 18 MHz 24 MHz +5V
1 STR VDD 16
2 D OE 15
3 CLK Q5 14 PML
Q9 Q10 Q11 Q12 VML 4 13 IML
Q1 Q6
DTC114EE DTC114EE DTC114EE DTC114EE SML 5 Q2 Q7 12 TML
AML 6 Q3 Q8 11
3.5 MHz SELET: 4.7 V 7 10 R31 D3 D4 D7
Q4 QS 1SS300 1SS300 1SS300
3.5 MHz UNSELECT: 0 V GND 8 9 47 k
VSS QS
S1
MET1 METER 1 J1 P4 P3
R13 R14 R15 R16
150 150 150 150 L1 100 µH 1 CLK
1 1
L2 100 µH 2 DATA
2 2
STR R32 L3 100 µH 3 DATK
1.8 MHz 7 MHz 14 MHz 21 MHz C4 47 k S2 L4 100 µH 3 3
STR 0.1 4 STB
DS13 DS14 DS15 DS16 MET2 METER 2 L5 HF50ACC3225-B 4
H12
4
TO
CL-170PG-CD-D CL-170PG-CD-D CL-170PG-CD-D 5 5 5
CL-170PG-CD-D L6 HF50ACC3225-B
1.8 MHz 7 MHz 14 MHz 21 MHz IC3 6 6
S12
6 MAIN UNIT
CLK L7 100 µH DATA2
CLK µPD4094BG R33 L8 100 µH
7
8
7
STB2
7 J3
47 k S3 8 8
1 16 +5V GND
Q13 Q14 Q15 Q16 2
STR VDD
15 PA AMP/PROTECT R62 C30 C29
9 9 9
D OE
DTC114EE DTC114EE DTC114EE DTC114EE 3 14 18ML 1.5 0.047 0.047
1_9ML
CLK Q5
3_5ML
10ML
14ML
18ML
21ML
24ML
50ML 4 Q1 Q6 13 14ML
7ML
28ML 5 Q2 Q7 12 10ML R34

24ML 6 11 7ML 47 k S4
Q3 Q8
TUNER TUNER C16 C17
21ML 7 Q4 QS 10
0.0047 0.0047
GND 8 VSS QS 9 H12
R17 R18 R19 R35

150 150 150 47 k S5 S12 R51
BUP UP 1k
DS17 STR
CL-170PG-CD-D DS18 TX: 4.7 V C5
CL-200YG DS19 STR 0.1
RX: 0 V CL-200YG
TX: 0 V R36
Q17 RX: 3.2 V Q18 Q19 IC4 47 k S6
DOWN
DTC114EE BDOWN
DTC114EE DTC114EE CLK
µPD4094BG R29
CLK R53 R52
220 k
INPUT2 SELECT: 4.7 V 1 16 +5V 47 k 47 k C24
STR VDD
INPUT2 UNSELECT: 0 V 2 15 R37 0.1 R54 D5
D OE MA8051
3 14 TRANS 47 k S7 47 k 13.3 V
CLK Q5 INPUT
3_5ML 4 Q1 Q6 13 TUNL I1/2
50 MHz INPUT2 SELECT: 0 V 1_9ML 5 Q2 Q7 12 PAL C6
INPUT2 UNSELECT: 3.2 V 11 PROL 2.2
6 Q3 Q8 IC8 C19
AUTOL 10 10
7 Q4 QS R38
47 k S8 TC7W74FU 8 6 12.5 V Q32
GND 8 9
R20 R21 R22 VSS QS ANT 5 R48 2SB1132
150 150 150 ANT
1k FRONT UNIT
V
CLR
2 4 1 5
28 MHz AUTO CK Q
INPUT1 SELECT: 0 V
DS21 DS22 2 3
CL-170PG-CD-D INPUT1 UNSELECT: 3.2 V C7 0.1 S9 3 D Q
DS20 CL-200YG +5V
PR
AUTO SELECT: 0 V C18
G
CL-170PG-CD-D 0.1 Q31
AUTO UNSELECT: 3.2 V
1 DO VCC 16 DTC144EE
STR2 2 15 7 4
LD VDD
CLK 3 CLK AO6 14 IC9
Q20 Q21 Q22 INPUT1 SELECT: 4.7 V DATA2 4 13 TC4S584F DS2
DI AO5 LAMP
DTC114EE DTC114EE DTC114EE INPUT1 UNSELECT: 0 V 5 AO1 AO4 12
CP2 DS-2
6 11
TRANS
AUTOL
AO2 AO3 IC6

28ML
50ML
AUTO SELECT: 4.7 V 7 NC NC 10 4.9 V 9.2 V R55

I1L
I2L
28 MHz
AUTO UNSELECT: 0 V W3 GND 8 9 TA7805F 47 k
GND VSS R30 R42
W4 C34 10
+5V 33
0.001 S12
IC5 O I
D10 M62354GP
1SS315 G
C8 C9 C10 C11 C33
R23 R24 0.1 0.1 10
150 150 D11 33 10
1SS315 R63 10.2 V
4.7 k CP1 DS-1
ANT2 SELECT: 4.7 V
2 4 DS1
ANT2 UNSELECT: 0 V
W6 LAMP
DS23 DS24 ANT4 W5
ANT2 SELECT: 0 V CL-200YG CL-200YG
ANT2 UNSELECT: 3.2 V
ME1
Q23 Q24 R56

METER1 CP3
DTC114EE DTC114EE RV-150
C20 10 k CP4
0.1
R26 R27 METER
150 150
R57
RV-150
1 3 10 k
DS26 ME2
CL-200YG DS27 ANT3
CL-200YG C21
ANT1 0.1
Q27 METER
DTC114EE
Q26 METER2
A1L
A2L
A3L
A4L
CP5
DTC114EE
CP6
SW BOARD
10 - 5
10-6 MAIN UNIT R155
47 k
C107
TX ON 140 µS 1
8 7 6 5 RX: 0.8 V 3.4 V 2
C111 TX: 4.0 V 9 8 TRC 3
0.1 IC28 Q32 D76 4
TC4W66F DTC114EE 1SS373 RX: 4.7 V USA 50MF 5
CP41 D73 IC16D TX: 0 V TI4
6
1SS301 0.6 V
1 2 3 4 R38 R233 PD4069UBG D18 MA77 [USA] 7
CP42 1.2 k 1M AMP. ON : 4.6 V
ACC81
R223 D20 MA77 ASE AMP. OFF: 0 V
CP43 47 k D4 BOUT
R39 ACC82
4.7 M R234
CP44 1.2 k 1M SEND R53 R54 R55
L8, L11–L14: 100 µH 0.1 µS
D54 D55 L15 100 µH 47 k
ALC1
47 k 47 k IC17 X24C01AS-3.0
REGC
50MF
24MF
REGF
PATH
DATA2
STA
TUF
PAF
ANT1
L9, L10 : 10 µH
ANT4
ANT3
ANT2
J2 R222 MA77 MA77 D6
L14 47 k 4.7 M 1.0 V S4 S-1010A 3.4 V
13_1 1 C34 R170 C106
13_2 L13 8 100 k 2 1 A0 8 0.1
2 L12 0.1 3 ALC1 1 ADR0 VCC
SEND1 3 D7 1SS373 1 1 3 ADR1 2 7
SEND2 L11 C 2 A1 WC C123
4 L10 2 4 3 6
JACK1 4 ADR2 A2 SCL 0.047
ALC1
ALC2
5
6
L9 D8 1SS373
4
IC4A 5 ADR3 60 59 58 57 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41 0.6 V 4
VSS SDA
5
UNIT J9 L8 8
CI5 NJM4558M
P93(M13)
P92(M12)
P91(M11)
P90(M10)
P23(M03)
P22(M02)
P21(M01)
P20(M00)
P07(AD7)
P06(AD6)
P30(RD)
7
P11(A9)
P10(A8)
P17(A15)
P16(A14)
P15(A13)
P14(A12)
P13(A11)
P12(A10)
VSS
FANV 8 RL2 SDA R165
4.0 V C125
GND 9 AHY103 SCL 100 k 0.00 4 5
GND 10 R45
L16 220 k R117
C205 0.1 100 µH C35 R44 ALC2 61 P31(WR) P05(AD5) 40 18MF IC16C 22 k
C17 C18 C19 C20 C21 C22 0.1 220 k R56 R57 R58 R59 ACC81 62 1 5 3
0.0047 0.0047 0.1 0.1 0.1 0.1 S3 S-1010A 47 k 47 k 47 k 47 k ACC82 63
P32 P04(AD4) 39 14MF PD4069UBG 2 R166
IC4B P33 P03(AD3) 38 10MF 100 k
CP45 2 ADR4 ADR0 64 5 3 4
1 P40 P02(AD2) 37 7MF SEND 6 R118
R152
NJM4558M R171
1
C
2 3 ADR5 ADR1 65 P41 36 35M C207 22 k 0.51 µS
CP46 D63 5 100 k ALC2 ADR2 66 P01(AD1) 0.1 TX ON
1SS301 100 k 4 4 ADR6 P42 35 19M IC27
7 ADR3 67 P00(AD0)
CP47 5 P43 34 AMP. ON and TX: 4.5 V 4.5 V
6 2.0 V 8 ADR4 68 P44
VCC
33 I1/2 OTHER: 0 V TC4S81F
D11 ADR5 69 ALE(P83)
D61 D12 P45 STBY(P82) 32 SEND
1SS301 R47 ADR6 70
J3 L117–L120, L123, L124: 100 µH 1SS301 1SS301 4.0 V R46 220 k 4.2 V P46 INT0(P81) 31 INT0
L121, L122: HF50ACC322513-B 220 k R60 R61 R62 71 P47 IC26 WDTOUT(P80) 30 STR2 0.4 V
R51 1 k CK 47 k 47 k 47 k BOUT 72
CLK 1 L117 R50 1 k DATA REGT 73
P50 TMP90PM38F P77(TXD2) 29 DATA
DATA 2 P51(TO4) 28 STR
FRONT DATK 3
L118
R49 1 k DATK L37 100 µH BALA 74 P52(TO5)
P76(SCLK2)
L119 P75(RXD2) 27 DATK C203 R119
STR 4 75 D21
UNIT 5
L120 R48 1 k STR VCC EA 26 0.1 680 k MA77
(SW BOARD
H12
S12 6
L121 IC1D 76 P53(INT1/T14) X2 25 IC2
DATA2 7
L122 R199 1 k R226 NJM3403AM-T1 L113 100 µH 77 P54(INT2/T15) X1 24 X2 14
1 NJ
D14 0V 2 R132
J1) L123 R200 1 k D13 470 k 78 VSS 9.8304 MHz
P73(SCLK1/CTS1)
STR2 8 1SS300 C36 KEY VSS 23 33 k
L124 1SS300 79
GND 9 13 C216 0.1 P55(WAIT/T01)
CLK 22 Q1
14 4.2 V 0.1 MAXI 80 P56(INT3/T12) 21
7 R120
D56
12 RESET 47 k 2SA1586 R157 1SS373
P72(RXD1)
P74(TXD1)
R224 10 k
P57(TO3)
P60(AN0)
P61(AN1)
P62(AN2)
P63(AN3)
P64(AN4)
P65(AN5)
P66(AN6)
P67(AN7)
D62 R121 IC16A
1SS300 STR2 470 k R227 R225 5
C201 C202 47 k
AVCC
10 k PD4069UBG
AVSS
C222 C223 C224 C225 C226 C227 C228 C229 100 k 2
P100
P101
4 R122
VCC
C206 0.1 12 p L116 12 p
NMI
P70
P71
0.001 0.001 0.001 0.0010.047 0.047 0.001 0.001 R139 R140
47 k 47 k 10 µH 3 4
18 k
R197 D67 3
D26 1SS301 1SS373 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20
RV-152
22 k IC33
0V Q2 R12
100
2SC4116 TEMP
ALCM
TEMP
R198 L115 C108 IC16B
DPO
FOR
TC4S584F
USA
SDA
CK
REF
10 µH
SCL
47 k REGC 0.1 DPO
CK
PD4069UBG
Vc
C237
Ic
C221 13.0 V
0.001
0.1 L17 10 µ H Q107 R194
IC
J4 DTC114 EE Q36 15 k
L19 100 µH Vc RL3 NJ
ID 1 AHY103 DTC114EE
VD 2 L21 100 µH 11 10
REGF 3
REGF R52 IC5 R1
REGHC 4 L22 100 µH REGHC 10 TA7805F IC16E 1
MAXI 5 O
REG UNIT REGT 6 L24 100 µH MAXI G PD4069UBG L75 C
GND 7 C38 100 µH
(PX-1981) –13V 8
REGT C37
47 0.1
C39
0.1
C40
47
0
GND 9 L25 100 µH Ic Q106
H12 R213
10 2.2 k
H12 11 L27 10 µH 2SC4116 13.3 V
SEL 12
C23 C25 C26 C28 C29 C31 C33

0.1 0.1 0.1 0.1 0.1 0.1 0.0047
L107 D16
2943-66663 MA77
IC13
L108 C210
2943-66663 0.0047 S-8054ALB-LM
13.5 V R116
100 k
O
Q103
G C88 D17 R115
2SC4116
C87 0.22 MA77 220 k
0.1
L28 LR-270
C41 R66 R64 6.8 k IC7 C209

0.0047 6.8 k 0.1
Q100 X24C04S8
DTC114EE C43 R65 L36 1 8
680 p 47 k 100 µH A0 VCC
4.9 V 2 A1 7
2.6 V R108 R107 WC
4.7 V L109 10 k 10 k 3 A2 SCL 6
100 µH 4 VSS SDA 5
R67 C44
0.1 14 13 12 11 10 9 8 R238
12 k R63 L4
1M IC1A R1 2.2 M TX: –9.6 V
100 µH
C214 0.1
IC2A
C13
IC31A C211
NON
1/2VREF
INV
VREF
SW
VCC
82 k
NC
0.1 0.1 TX: 4.2 V

R68 TX: 4.6 V NJM3403AM RX: 4.2 V R24 NJM4558M R201 NJM4558M RX: 0 V
39 k RX: 4.6V 390 k 8
R2 330 k 2 4 D1 3 220 k 3 8
R28 1 k FOR
1SS373 1 FORT
D-TIME
1 1
IC8 3 R25
2
Q111 2 16 µS
GND
R202
OUT
PZ
PX
PY
RZ
CI1
CI2
CI3
CO1
CO2
CO3
PW
RX
RY
RW
R206
FB
BA9700AF 390 k
NC
TX: 2.0 V
RT
CT
4 DTC114EU 220 k 4
TX: 2.2 V R3 100 k 11 TX: –14 V L6 RX: 0 V R205 1k 3.5 V
RX: 0.3 V R26
1 2 3 4 5 6 7 RX: –14 V 100 µH RV-156 22 k R203
220 k
Q104 220 k 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33
2.0 V R69 10 k L110
C5 R235 220 k DTC114EE 100 µH
P15AD13
P12/AD10
P13/AD11
P16/AD14
P17/AD15
P03AD3
P14/AD12
P00/AD0
P01/AD1
P02/AD2
P04/AD4
P05/AD5
P06/AD6
P07/AD7
P10/AD8
P11/AD9
R4 0.1 C231 0.1 R27 56 k R240 0.9 V
R204
RV-108 R6
C.P R29
IC2B RV-160 56 k
RV-110 C212
C45 0.001 100 k
100 k CP100 D75 390 k 5 NJM4558M 1M
0.1 32 35T
12.0 V R5 1SS301 7 R33 1 k REF P20/DB0
49 31 7T
0.3 V Q101 R71
R241
27 k
RV-160
R30 6 50 P37/RD P21/DB1
30 10T
1 M [USA, EUR] P36/WR P22/DB2
2SB1123 330 390 k TX: 0.4 V 51
P35/SYNC 29 14T
Q33 Q109 R31 RX: 0 V
IC31B 52
P34
P23/DB3
28 21T
0.3 V D74 P24/DB4
R70 D15 C48 C49 L35 –14.2 V
2SC4116GR DTC114EE 1SS133
RV-158
NJM4558M TX: 0.6 V 53
P33/RESETOUT P25/DB5
27 28T
330 LR-270 C52 C53 470 k R32 56 k 50MF R207 54 26 50T
D2FS4 470 470 47 47 RX: 0 V P32/ONW P26/DB6
D70 220 k 55 25
1SS373 R229 5 P31/DA2 P27/DB7 C69
R228 7 REFT 56 24 15 p
L29 180 k 57 P30/DA1 IC12 VSS
C46 C47 C50 C51 10 k L5 C234 0.1 6 23
100 µH 1 R9 2.2M R208 58 VCC XOUT
220 1 1 100 µH R212 M38022M2-138FP 22
R7 TX: –6.2 V 220 k R210 59 VREF XIN
390 k R209 1k AV88 21 X1
R73 1 6 RX: 4.0 V R35 33 k 220 k 60 P40/INT4 TR
7 C208 20 6.144 MHz
68 k C6 61 P67/AN7 P41/INT0
D69 5 0.1 0.1 P66/AN6 RESET 19
TX: –9.3 V 62 18
MA77 D2 MA77 R211 P65/AN5 CNV66 D52
R75 100 k IC1B RX: 0.5 V 63 17 C70 1SS
L30 100 µH R34 100 k 64 P64/AN4 P42/INT1 15 p R88
R10 NJM3403AM-T1 270 k 2 4 D60 P63/AN3 1k
P53/SRDY2
P47/SRDY1
P55/CNTR1
P54/CNTR0
P51/SOUT2
Q105
P46/SCLK1
P52/SCLK2
C56 C65 390 k 1SS373
P56/PWN
ALCM
P50/SIN2
1
P43/INT2
P44/RXD
P45/TXD
P60/AN0
P62/AN2
P61/AN1
P57/NT3
C55 10 R76 0.1 DTC114EE
0.1 3.9 k 8
IC9A 3
R89
3
1 NJM4558M D71 R37 8
TX: 2.3 V
47 k
0V 2 L7 IC1C R13 680 k MA77 82 k IC3A R196 C14 12
RX: –0.1 V 0.1 R90
R77 4 R79 R80
10 k
100 µH
NJM3403AM NJM4558M 10K IC16F 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16
330 R91 1 k
1.2 M C235 TX: –6.8 V PD4069UBG
100 k
J6 L32 C8 R11 9 0.001 RX: 2.4 V
100 µH C59
0.1 1.2 M 8 13 IC25
C57 R78 TX: 2.5 V 10
TUNER –13R 1
0.1 2.2 k RX: 2.3 V 0.1 W3 D3 R133
R97 R92 100 k C68 0.1 S-8054ALB-LM
5V 2 R85 100 k R237 C236 CNTR0
UNIT PV 3 MA77 27 k 27 k R98 R93 220 k
(DET RV 4 R12 R14 R135 1 Q25 O
GND 5 L31 R82 IC9B Q108 100 k 120 k 33 k
5
D59
R97–R100: 47 k
R99 2SC4116 R96 G
BOARD J1) 100 µH 0V 4.7 k 5 NJM4558M DTC114E R15 7 1SS373 BALA R100
R94 R95
470 k
D27 C110 1 k
C109
7 RV-150 220 k MA77 0.1
6 0V 6 CP1 0.1
R232 10 k 3.4 V
R86 R87
47
C61 R84
R83
100 k
1M 10 k R23 R136 C204 R137 Q26 R101 IC10 R112 R114
10 k IC3B 0.1 10 k R109
C60
0.1
0.1 2.2 k R22 6.8 k C66 2SA1588 47 k TC4S69F 5 5
IC11 D24 47 k 47 k 1k
C64 RV-152 NJM4558M 10
4
2 4 2 TC4S69F RD5.1 M R110
0.1 C213 100 k R102 R104 10 k
10 270 10 k R113
BALANCE PA1 – PA4: 0 V 100 k
D66 3 3
D2FS4 R111 Q23
Q27 R192 Q102 R103
1k 10 k 2SA1586
C54 2SB1119 2.2 k Q28 R106 R105 C67 D23 Q24
0.1 DTC114EE 1k 56 k 0.0047 RD5.1 M 2SC4116
R148 DTC114EE
2.2 k
TUNER ON : 4.4 V
R193 TUNER OFF: 0 V
2.2 k
TUNER ON : 13.8 V TUNER ON : 13.0 V TUNER ON : 0 V

TUNER OFF: 0 V TUNER OFF: 13.8 V TUNER OFF: 13.0 V
COMPLETE VIEW 10 - 6
C107 0.1
TX: 1.1 V J8
RX: 0 V L1 100 µH 1 T13 TO
L2 100 µH
TX ON 140 µS 2 FOR
1 14 L3 100 µH 3 REF FILTER
2 13 0V GND UNIT J1
3.4 V 4
3 12 5 19M
W10 C1 C2 C3
4 11 IC20 0.0047 0.0047 0.1 6 35M
5 10 AMP. ON and TX: 13.2 V 7M
TI4 TC74AC393F OTHER: 0 V
7
10M TO
6 9 IC19 8
0.6 V 7 8 9 14M FILTER
AMP. ON : 4.6 V SELECTED: 4.7 V TD62783AF SELECTED: 13.2 V L38–L45 10 18M
UNIT
UNSELECTED: 0 V UNSELECTED: 0 V HF50ACC322513-B 11 24M
AMP. OFF: 0 V 9 10
VS GND 12 50M
19M 8 IN8 O8 11 L45 13 GND
35M 7 IN7 O7 12 L44
0.1 µS 7MF 6 IN6 O6 13 L43
IC17 X24C01AS-3.0 10MF 5 IN5 O5 14 L42
3.4 V L82 4.8 V C230 14MF 4 15 L41
C106 100 µH IN4 O4
1 A0 8 0.1 L81 0.1 18MF 3 IN3 O3 16 L40
2
VCC
7 100 µH 24MF 2 17 L39
A1 IN2 O2
WC C123 R163 50MF 1 18 L38
3 6 D51 IN1 O1
A2 SCL 0.047 680
0.6 V 4 5 IC30 MA77
VSS SDA L114
TC7S14FU C121 IC18 100 µH
SDA R165 C125 R161 0.047 C98 C99 C100 C101 C102 C103 C104 C105
SCL 100 k 0.00 4 5
2 R162 330 R231 TD62783AF 0.1 0.1 0.1 0.1 0.1 0.1 0.1 0.1 J9
R117 39 k 470 k ANT1 1 O1 18
IC16C IN1 5 GND
8MF 22 k ANT2 2 O2 17
1 5 3 0.7 V IN2 L48 HF50ACC322513-B 4
4MF PD4069UBG 2 R166
ANT3
ANT4
3 IN3 O3 16
15 L47 HF50ACC322513-B 3
S1
TO
0MF C122 4 IN4 O4 S2
100 k
S3 ANT-SW
5 3 4 I1/2 5 14 L46 HF50ACC322513-B 2
7MF SEND 6 R118 470 p IN5 O5
13
S4 UNIT J1
ASE 6 L111 HF50ACC322513-B
35M C207 22 k 0.51 µS C124 R164 R160 D50 R230 7
IN6 O6
12
1
0.1 TX ON 0.0047 33 470 k MA77 IN7 O7
19M
AMP. ON and TX: 4.5 V
IC27 4.5 V
10 k R123 8 IN8 O8 11
TC4S81F 1k PAF 9 GND 10
I1/2 OTHER: 0 V VS
END Q34 Q35 TUF
NT0 2SC2714 2SK302 R124 1 k C215 C95 C96 C97
J10
TR2 0.4 V 0.1 0.1 0.1 0.1 1
ATA GND
STR 2 F
ATK C203 R119 3 5V
0.1 680 k
D21 Q3 L101 100 µH 4 TEMP
J9
MA77
IC21B 2SB1119 5 IN SPLITR
14 R158 L49 100 µH 6
X2 2 1 R132 NJM4558M 5 100 k DRIV
UNIT
9.8304 MHz 33 k 7 7 T13
R172 L100 100 µH
7 R120 Q1 6 2.2 k
8 PAF J3
D56 9 GND
47 k 2SA1586 R157 1SS373 C126 R159 C92 C93 C94
R121 IC16A 10 k 100 k Q4 0.1 0.1 0.0047 C220 C219
0.1 0.1 0.1
01 C202 47 k
PD4069UBG R122
DTC114EE
L116 12 p R149
10 µH 3 4
18 k
D68 2.2 k
L76 L52
Q2 R125
1SS373
100 µH
R173
2.2 k 100 µH NOTE:
100 k
IC16B 2SC4116 TEMP
DPO
C90
0.1 PA FAN DRIVE OFF: 0 V L51 MEASURMENT CONDITION
PD4069UBG 100 µH
R194
PA FAN DRIVE ON: 4.3 V
Volt meter : 10 kΩ/V
IC21A TX: 0.5 V
Q36 15 k
NJM4558M 8
3 RX: 0 V L50 Oscilloscope : 20 MHz, 1 MΩ, 25 pF
DTC114EE R174 PA FAN OFF: 0 V HF50ACC322513
11 10
1
2 R130
Q6
2.2 k
Q5 PA FAN ON: 13.0 V C232
0.1
Amp : ON
R126 150 k
IC16E 1k 4
R128
R167
DTC114EE R150 2SB1119 Tuner : ON
470 2.2 k
PD4069UBG 220 k
L75
100 µH
C89
0.1 PA FAN DRIVE OFF: 13.3 V Frequency : 1.91 MHz
R175 PA FAN DRIVE ON: 12.2 V
R127 560 k 2.2 k Mode : RTTY
Output power : 1 kW
[TUNER ON] / [AMP. ON] / [TX ON]: 13.3 V

Q7 OTHER : 0 V
IC15 CP17 CP18 CP19 CP20 CP21 CP22 CP23 CP24
J14
2SB1119 TD62597FN
1 12V
L54 PW 1 18 L58
I1 O1 2 PW
R176 HF50ACC322513 PX 2 17 L57
2.2 k I2 O2 3 PX
C233 PY 3 16 L56
10 I3 O3 4 PY TUNER UNIT
Q103 PZ 4 I4 O4
15 L55 5 PZ
2SC4116 R151 RW 5 I5 O5 14 6 12V
(CONNECT
2.2 k 6 13 L105
RX
7
I6 O6
L106
7 RW BOARD J1)
RY I7 O7 12 8
R177 2.2 k RX
Q8 RZ 8
9
I8 O8 11 L104 9 RY
10 L59
DTC114EE CI3 GND COM 10 RZ
CI2
D72 C86
1SS301 IC14 0.1
L60–L67 J20
CI1 TD62783AF HF50ACC322513
1 TU2
CO1 1 18 L67 CI3B 2
IN1 O1 VHCI
2 17 L66 VHCI
3
IN2 O2
16 L65 CI2B
3 CI3B TUNER UNIT
IN3 O3 4 CI2B
4 IN4 O4 15 L64 CI1B 5 CI1B
(C-NET
CO2 5 IN5 O5 14 L63 6 GND BOARD J2)
CO3 6 IN6 O6 13 L62 7 GND
7 IN7 O7 12 L61
8 IN8 O8 11 L60
9 VS GND 10
J19
R178 C78 C79 C80 C81 C82 C83 C84 C85 CO1B
2.2 k Q9 0.1 0.1 0.1 0.1 0.1 0.1 0.1 0.1
CO2B
1 CO1B
16 µS 2SB1119 CO3B
2 CO2B TUNER UNIT
R141 2.2 k 3 CO3B
3.5 V 50T VHCO 4 VHCO (C-NET
R186
2.2 k Q13 5 TU1 BOARD J1)
Q16 Q20 2SB1119 6 GND
DTC114EE R179 DTC114EE
2.2 k R145
0.9 V 2.2 k
28T
32 35T
P20/DB0 R180
31 7T R187
P21/DB1
30 2.2 k Q10
TUON
10T 2.2 k
P22/DB2
P23/DB3
29 14T 2SB1119
28 21T 21T R142 2.2 k
P24/DB4
27 28T R188
P25/DB5
26 50T Q21 2.2 k Q14
P26/DB6
25 C69
Q17 DTC114EE 2SB1119
L68–L74
P27/DB7 R181 HF50ACC322513 J21
VSS
24 15 p 14T
DTC114EE 2.2 k R146 2.2 k
L74
23 1 50M
XOUT L73
22 2 28M
XIN L72
21 X1 R182 3 21M
P40/INT4 TRC R189 L71
P41/INT0
20 6.144 MHz 2.2 k Q11 2.2 k
4 14M TUNER UNIT
19 L70 5
RESET
18 D52 R143 2.2 k
2SB1119 L69
10M (H-NET
CNV66 10T 6 GND
P42/INT1
17 C70
15 p R88 1SS301
R190
L68 7 NC BOARD J1)
1k Q22 2. 2 k Q15 8 NC
Q18 DTC114EE
DTC114EE R183
R147 2.2 k
2SB1119
R89 7T 2.2 k
47 k J22
C71 C72 C73 C74 C75 C76 C77
0.1 0.1 0.1 0.1 0.1 0.1 0.1
R90
330
Q19 R184 R191 1 7M TUNER UNIT
R91 1 k 2.2 k 2.2 k
DTC114EE 2 35M (L-NET
R144 2.2 k 3 GND
IC25 35T
Q12 BOARD J1)
R92 100 k C68 0.1 S-8054ALB-LM 2SB1119
R93 220 k R185
25 O 2.2 k
SC4116 R94 R95 D27
R96
C110 1 k
G
220 k 470 k MA77 0.1 C109 J18
0.1
L77 10 µH (TTRC)
5
Q30 Q29 L78 10 µH (ISTA) TUNER UNIT
4
R112 L79 10 µH
11 R109
47 k
R114 2SC4116 2SC4116 L80 2943-666663
3 (IKEY) CPU
D24 47 k 1k 2 (13.8)
C4S69F RD5.1 M R110 R153
1 (GND) WRITE
10 k 47 k
R113
100 k
R111 Q23 S5 C112 C113 C114 C115
10 k 2SA1586 SW-161 0.1 0.1 470 p 0.1
C67 D23
0.0047 RD5.1 M
Q24
2SC4116 MAIN UNIT J17
1 BAL
KEY
STA
2 GND COMBINR
3 GND UNIT J8
COMPLETE VIEW
10-6 MAIN UNIT R155
47 k
C107 0.1
TX: 1.1 V J8
RX: 0 V L1 100 µH 1 T13 TO
L2 100 µH
TX ON 140 µS 2 FOR
1 14 L3 100 µH 3 REF FILTER
8 7 6 5 RX: 0.8 V 2 13 0V GND UNIT J1
3.4 V 4
C111 TX: 4.0 V 9 8 TRC 3 12
0.1 IC28 Q32 W10 C1 C2 C3 5 19M
DTC114EE
D76
1SS373 50MF
4 11 IC20 0.0047 0.0047 0.1 6 35M
TC4W66F D73 IC16D
RX: 4.7 V
TX: 0 V
USA
TI4 5 10 TC74AC393F AMP. ON and TX: 13.2 V 7 7M
TO
CP41 6 9 OTHER: 0 V 8 10M
1 2 3 4 R38 R233 1SS301
µPD4069UBG D18 MA77 [USA] 0.6 V 7 8
IC19 9 14M FILTER
CP42 1.2 k 1M ACC81 AMP. ON : 4.6 V SELECTED: 4.7 V TD62783AF SELECTED: 13.2 V L38–L45 10 18M
UNIT
R223 D20 MA77 ASE UNSELECTED: 0 V UNSELECTED: 0 V HF50ACC322513-B 11 24M
CP43 AMP. OFF: 0 V 9 10
47 k D4 ACC82 BOUT VS GND 12 50M
R39 4.7 M R234 19M 8 11 L45 GND
1.2 k 1M IN8 O8 13
CP44 SEND 35M 7 IN7 O7 12 L44
L8, L11–L14: 100 µH R53 R54 R55
D55 0.1 µS 7MF 6 IN6 O6 13 L43
D54 L15 100 µH 47 k
ALC1
47 k 47 k IC17 X24C01AS-3.0
REGC
50MF
24MF
REGF
PATH
DATA2
STA
TUF
PAF
ANT1
L9, L10 : 10 µH
ANT4
ANT3
ANT2
J2 R222 MA77 MA77 D6 10MF 5 IN5 O5 14 L42
L14 47 k 4.7 M 1.0 V S4 S-1010A 3.4 V L82 4.8 V C230 14MF 4 15 L41
13_1 1 C34 R170 C106 100 µH IN4 O4
L13 8 100 k 1 A0 8 0.1 L81 0.1 18MF 3 IN3 O3 16 L40
13_2 2 0.1 3 ALC1 2 ADR0 VCC 100 µH
SEND1 L12 1 2 7 24MF 2 17 L39
3 L11 D7 1SS373 1 1 3 ADR1 A1 IN2 O2
SEND2 4 C 2 WC C123 R163 50MF 1 18 L38
L10 2 4 ADR2 3 6 D51 IN1 O1
JACK1 ALC1 5 D8 1SS373 IC4A 4 60 59 58 57 56 55 54 53 52 51 50 49 48 47 46 45 44 43 42 41 0.6 V 4
A2 SCL
5 0.047 680
ALC2 6
L9 4 8 5 ADR3 VSS SDA IC30 MA77 L114
UNIT J9 L8 NJM4558M 100 µH
CI5 TC7S14FU
P93(M13)
P92(M12)
P91(M11)
P90(M10)
P23(M03)
P22(M02)
P21(M01)
P20(M00)
P07(AD7)
P06(AD6)
IC18
P30(RD)
7
P11(A9)
P10(A8)
P17(A15)
P16(A14)
P15(A13)
P14(A12)
P13(A11)
P12(A10)
VSS
FANV SDA C121
8 RL2 4.0 V R165 C125 R161 0.047 C98 C99 C100 C101 C102 C103 C104 C105
GND 9 AHY103 R45
SCL 100 k 0.00 4 5
2 R162 330 R231 TD62783AF 0.1 0.1 0.1 0.1 0.1 0.1 0.1 0.1 J9
GND 10 L16 R117 470 k ANT1 1 18
220 k 39 k IN1 O1
C205 0.1 100 µH C35 R44 ALC2 61 P31(WR) P05(AD5) 40 18MF IC16C 22 k ANT2 2 IN2 O2 17
L48 HF50ACC322513-B
5 GND
C17 C18 C19 C20 C21 C22 0.1 220 k R56 R57 R58 R59 ACC81 62 1 5 3 0.7 V 4
0.0047 0.0047 0.1 0.1 0.1 0.1 S3 S-1010A 47 k 47 k 47 k 47 k ACC82 63
P32 P04(AD4) 39 14MF µPD4069UBG 2 R166
ANT3
ANT4
3 IN3 O3 16
15 L47 HF50ACC322513-B
S1
TO
P33 38 10MF C122 4 O4 3 S2
CP45 IC4B 2 ADR4 ADR0 64 P40
P03(AD3)
37 7MF SEND 5 6
3 4 100 k
470 p I1/2 5
IN4
IN5 O5 14 L46 HF50ACC322513-B 2 S3 ANT-SW
1 P02(AD2) R118
R152
NJM4558M R171
1
C
2 3 ADR5 ADR1 65 P41 36 35M C207 22 k 0.51 µS C124 R164 R160 D50
ASE 6 IN6 O6 13 L111 HF50ACC322513-B 1 S4 UNIT J1
CP46 D63 5 100 k ALC2 ADR2 66 P01(AD1) 0.1 TX ON 0.0047 R230 7 O7 12
1SS301 100 k 4 4 ADR6 P42 35 19M IC27 33 470 k MA77 10 k IN7
7 ADR3 67 P00(AD0) R123 8 O8 11
5 P43 34 AMP. ON and TX: 4.5 V 4.5 V 1k IN8
CP47 6 8 VCC TC4S81F PAF 9 GND 10
2.0 V ADR4 68 P44 33 I1/2 OTHER: 0 V VS
D11 ADR5 69 ALE(P83) Q34 Q35
D61 D12 P45 32 SEND TUF
1SS301 R47 ADR6 70 STBY(P82)
J3 L117–L120, L123, L124: 100 µH 1SS301 1SS301 4.0 V R46 220 k 4.2 V P46 INT0(P81) 31 INT0 2SC2714 2SK302 R124 1 k J10
L121, L122: HF50ACC322513-B 220 k R60 R61 R62 71 P47 IC26 WDTOUT(P80) 30 STR2 0.4 V
C215 C95 C96 C97
0.1 0.1 0.1 0.1
R51 1 k CK 47 k 47 k 47 k BOUT 72
CLK 1 L117 R50 1 k DATA REGT 73
P50 TMP90PM38F P77(TXD2) 29 DATA 1 GND
DATA 2 P51(TO4) 28 STR 2 F
FRONT DATK 3
L118
R49 1 k DATK L37 100 µH BALA 74 P52(TO5)
P76(SCLK2)
3
27 DATK C203 R119 5V
STR 4
L119 75 P75(RXD2) D21 Q3 L101 100 µH 4 J9
UNIT 5
L120 R48 1 k STR VCC EA 26 0.1 680 k MA77 TEMP
(SW BOARD
H12 L121 IC1D 76 P53(INT1/T14) 25 IC21B 2SB1119 5 IN SPLITR
S12 6 L122 R199 1 k L113 100 µH 77 X2 14 R158 L49 100 µH 6
J1) DATA2 7 L123 R200 1 k D13 D14 0V R226 NJM3403AM-T1 78
P54(INT2/T15) X1 24 X2 2 1 R132 NJM4558M 5 100 k DRIV
UNIT
470 k VSS 9.8304 MHz 7 T13
P73(SCLK1/CTS1)
STR2 8 1SS300 C36 KEY VSS 23 33 k 7
L124 1SS300 79 R172
GND 9 13 C216 0.1 P55(WAIT/T01)
CLK 22 Q1 6 L100 100 µH 8 PAF J3
14 4.2 V 0.1
MAXI 80 P56(INT3/T12) 21
7 R120
D56
2.2 k
9 GND
12 RESET 47 k 2SA1586 R157 1SS373 C126 R159 C92 C93 C94
P72(RXD1)
P74(TXD1)
R224 10 k Q4 0.1 0.1 0.0047 C220 C219
P57(TO3)
P60(AN0)
P61(AN1)
P62(AN2)
P63(AN3)
P64(AN4)
P65(AN5)
P66(AN6)
P67(AN7)
D62 R121 IC16A 100 k
STR2 470 k R227 R225 5 0.1 0.1 0.1
1SS300 C201 C202 47 k DTC114EE
AVCC
10 k µPD4069UBG
AVSS
C222 C223 C224 C225 C226 C227 C228 C229 100 k 2
P100
P101
4 R122
VCC
C206 0.1 12 p L116 12 p R149
NMI
P70
P71
0.001 0.001 0.001 0.0010.047 0.047 0.001 0.001 R139 R140
47 k 47 k 10 µH 3 4
18 k
D68 2.2 k
R197 D67 3 L76 L52
RV-152
D26 1SS301 1SS373
0V
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20
Q2 R125
1SS373
100 µH
R173
2.2 k 100 µH NOTE:
22 k IC33 100 k
2SC4116 TEMP
MEASURMENT CONDITION
ALCM
TEMP
R198 L115 C108 IC16B C90
DPO
FOR
TC4S584F
USA
SDA
CK
REF
10 µH L51
SCL
47 k REGC 0.1 DPO 0.1 PA FAN DRIVE OFF: 0 V
CK
µPD4069UBG 100 µH
Vc
C237
Ic
13.0 V
0.001 C221
0.1 L17 10 µ H Q107 R194
PA FAN DRIVE ON: 4.3 V
Volt meter : 10 kΩ/V
IC21A TX: 0.5 V
J4
L19 100 µH Vc RL3
DTC114 EE Q36 15 k
NJM4558M 8
3 RX: 0 V L50 Oscilloscope : 20 MHz, 1 MΩ, 25 pF
ID DTC114EE R174 PA FAN OFF: 0 V HF50ACC322513
1
VD
REGF
2 L21 100 µH
REGF
AHY103
R52 IC5 11 10
1
2 R130
Q6
2.2 k
Q5 PA FAN ON: 13.0 V C232
0.1
Amp : ON
3 R126 150 k
REGHC 4 L22 100 µH REGHC 10 TA7805F IC16E 1k 4
R128
R167
DTC114EE R150 2SB1119 Tuner : ON
MAXI 5 O 470 2.2 k
REG UNIT REGT 6 L24 100 µH MAXI G µPD4069UBG 220 k
(PX-1981) GND
–13V
7 REGT C37 C38 C39 C40
L75
100 µH
C89
0.1 PA FAN DRIVE OFF: 13.3 V Frequency : 1.91 MHz
8 47 0.1 0.1 47 R175 PA FAN DRIVE ON: 12.2 V
L25 100 µH R127 560 k
GND
H12
9
10
Ic Q106 R213 2.2 k Mode : RTTY
H12 2SC4116 2.2 k
11 L27 10 µH
SEL 12 13.3 V Output power : 1 kW
C23 C25 C26 C28 C29 C31 C33
0.1 0.1 0.1 0.1 0.1 0.1 0.0047 [TUNER ON] / [AMP. ON] / [TX ON]: 13.3 V
L107 D16 Q7 OTHER : 0 V
IC15 CP17 CP18 CP19 CP20 CP21 CP22 CP23 CP24
J14
2943-66663 MA77 2SB1119 TD62597FN
IC13 PW 1 18 L58
1 12V
L108 C210 L54 I1 O1 2
2943-66663 0.0047 S-8054ALB-LM R176 HF50ACC322513 PX 2 I2 O2 17 L57 3
PW
R116 2.2 k C233 PX
13.5 V PY 3 I3 16 L56 4
100 k 10 O3 PY TUNER UNIT
O
Q103 PZ 4 I4 O4
15 L55 5 PZ
G 2SC4116 R151 RW 5 I5 O5 14 6 12V
(CONNECT
C88 D17 R115 2.2 k 6 13 L105
C87 0.22 MA77 220 k
RX
7
I6 O6
L106
7 RW BOARD J1)
RY I7 O7 12 8
0.1 R177 2.2 k RX
Q8 RZ 8
9
I8 O8 11 L104 9 RY
10 L59
DTC114EE CI3 GND COM 10 RZ
CI2
L28 LR-270 D72 C86
1SS301 IC14 0.1
L60–L67 J20
CI1 TD62783AF HF50ACC322513 1 TU2
C41 R66 IC7 C209 CO1 1 18 L67 CI3B 2
R64 6.8 k IN1 O1 VHCI
0.0047 6.8 k 0.1 2 17 L66 VHCI
Q100 X24C04S8 3
IN2 O2
16 L65 CI2B
3 CI3B TUNER UNIT
IN3 O3 4 CI2B
DTC114EE C43 R65 L36 1 8 4 IN4 O4 15 L64 CI1B 5 CI1B
(C-NET
680 p 47 k 100 µH A0 VCC CO2 5 14 L63 6 BOARD J2)
4.9 V 2 7 IN5 O5 GND
2.6 V R108 R107 A1 WC CO3 6 13 L62
IN6 O6 7 GND
4.7 V L109 10 k 10 k 3 A2 SCL 6 7 12 L61
100 µH 4 VSS SDA 5 IN7 O7
R67 C44 8 IN8 O8 11 L60
0.1 14 13 12 11 10 9 8 R238 9
12 k R63 L4 10
1M IC1A R1 2.2 M TX: –9.6 V
100 µH C214 0.1
IC2A
C13
IC31A C211 VS GND
NON
1/2VREF
INV
VREF
SW
VCC
82 k
NC
0.1 0.1 TX: 4.2 V

R68 TX: 4.6 V NJM3403AM RX: 4.2 V R24 NJM4558M R201 NJM4558M RX: 0 V
RX: 4.6V 390 k 8 J19
39 k R2 330 k 4 D1 3 220 k 3 8 R178 C78 C79 C80 C81 C82 C83 C84 C85
2 R28 1 k FOR CO1B
1SS373 1 FORT 2.2 k Q9 0.1 0.1 0.1 0.1 0.1 0.1 0.1 0.1 1 CO1B
D-TIME
1 1
IC8 3 R25
2
Q111 2 16 µS 2SB1119
CO2B 2 CO2B TUNER UNIT
GND
R202
OUT
PZ
PX
PY
RZ
CI1
CI2
CI3
CO1
CO2
CO3
PW
RX
RY
RW
R206 CO3B
FB
BA9700AF 390 k 3 CO3B

NC
TX: 2.0 V
RT
CT
4 DTC114EU 220 k R141 2.2 k

TX: 2.2 V R3 100 k 11 TX: –14 V L6 R26 RX: 0 V R205
4 1k 3.5 V 50T VHCO 4 VHCO (C-NET
RX: 0.3 V R186
1 2 3 4 5 6 7 RX: –14 V 100 µH RV-156 Q104 22 k R203 2.2 k Q13 5 TU1 BOARD J1)
2.0 V R69 10 k
220 k 220 k L110 48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33 Q16 Q20 2SB1119 6 GND
C5 R235 220 k DTC114EE 100 µH DTC114EE R179 DTC114EE R145
P15AD13
P12/AD10
P13/AD11
P16/AD14
P17/AD15
P03AD3
P14/AD12
P00/AD0
P01/AD1
P02/AD2
P04/AD4
P05/AD5
P06/AD6
P07/AD7
P10/AD8
P11/AD9
R4 0.1 C231 0.1 R27 56 k R240 0.9 V 2.2 k
R204 2.2 k
RV-108 R6
C.P R29
IC2B RV-160 56 k
28T
RV-110 C212
C45 0.001 100 k
100 k CP100 D75 390 k 5 NJM4558M 1M
0.1 32 35T
12.0 V R5 1SS301 7 R33 1 k REF P20/DB0
49 31 7T R180
0.3 V Q101 R241 RV-160 6 50 P37/RD P21/DB1
30 2.2 k Q10 R187
TUON
R71 27 k 1 M [USA, EUR] R30 P36/WR 10T 2.2 k
2SB1123 P22/DB2
330 390 k TX: 0.4 V 51
P35/SYNC 29 14T 2SB1119
Q33 Q109 R31 RX: 0 V
IC31B 52
P34
P23/DB3
28 21T 21T R142 2.2 k
0.3 V D74 P24/DB4
R70 D15 C48 C49 L35 –14.2 V
2SC4116GR DTC114EE 1SS133
RV-158
NJM4558M TX: 0.6 V 53
P33/RESETOUT P25/DB5
27 28T
Q21 R188
330 LR-270 C52 C53 470 k R32 56 k 50MF R207 RX: 0 V
54 26 50T 2.2 k Q14
D2FS4 470 470 47 47 D70 220 k 55 P32/ONW P26/DB6
25 C69
Q17 DTC114EE 2SB1119
L68–L74
1SS373 R229 5 P31/DA2 P27/DB7 R181 HF50ACC322513 J21
R228 7 REFT 56
P30/DA1 VSS
24 15 p 14T
DTC114EE 2.2 k R146 2.2 k
C46 C47 L29 C50 C51
180 k 10 k L5 C234 0.1 6 57
VCC
IC12 23 L74 1 50M
220 100 µH 1 R9 2.2M R208 58 XOUT L73
1 1
R7 TX: –6.2 V 100 µH 220 k R210
R212
59 VREF M38022M2-138FP XIN
22
L72
2 28M
390 k R209 1k AV88 21 X1 R182 3 21M
6 RX: 4.0 V R35 220 k 60 P40/INT4 TRC R189 L71
R73 1 7 68 k C6
33 k C208
61 P67/AN7 P41/INT0
20 6.144 MHz 2.2 k Q11 2.2 k
4 14M TUNER UNIT
19 L70 5
D69
MA77
5
D2 MA77
TX: –9.3 V 0.1 0.1
62 P66/AN6 RESET
18 D52 R143 2.2 k
2SB1119 L69 6
10M (H-NET
R211 P65/AN5 CNV66 10T GND
L30 100 µH R75 100 k IC1B RX: 0.5 V
R34 100 k
63
P64/AN4 P42/INT1
17 C70
15 p R88 1SS301
R190
L68 7 NC BOARD J1)
64 Q22
R10 NJM3403AM-T1 270 k 2 4 D60 P63/AN3 1k 2. 2 k Q15 8 NC
P53/SRDY2
P47/SRDY1
P55/CNTR1
P54/CNTR0
P51/SOUT2
Q105 Q18
P46/SCLK1
P52/SCLK2
C56 C65 390 k 1SS373 DTC114EE
P56/PWN
ALCM 2SB1119
P50/SIN2
1
P43/INT2
P44/RXD
R183
P45/TXD
P60/AN0
P62/AN2
P61/AN1
P57/NT3
C55 10 R76 0.1 DTC114EE DTC114EE
0.1 3.9 k 8
IC9A 3
R89 7T 2.2 k R147 2.2 k
3
1 NJM4558M D71 R37 8
TX: 2.3 V
47 k J22
0V R13 680 k IC3A C14 12 C71 C72 C73 C74 C75 C76 C77
2 L7 IC1C MA77 82 k R196 0.1 0.1 0.1 0.1 0.1 0.1 0.1
RX: –0.1 V
R79 R80 100 µH NJM4558M 10K 0.1
IC16F 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 R90 Q19 R184 R191 1 7M TUNER UNIT
R77 4 10 k NJM3403AM 330 R91 1 k
DTC114EE 2.2 k 2.2 k 35M
100 k
1.2 M C235 TX: –6.8 V µPD4069UBG 2 (L-NET
C8 9 0.001 R144 2.2 k 3 GND
J6 L32
100 µH 0.1
R11
8
RX: 2.4 V
IC25 35T
Q12 BOARD J1)
TX: 2.5 V C59 1.2 M 13
C57 R78 10
TUNER –13R 1
0.1 2.2 k RX: 2.3 V 0.1 W3 D3 R133
R97 R92 100 k C68 0.1 S-8054ALB-LM 2SB1119
5V 2 R85 100 k R237 C236 CNTR0
UNIT PV 3 MA77 27 k 27 k R98 R93 220 k R185
(DET RV 4 R12 R14 R135 1 Q25 O 2.2 k
GND 5 L31 R82 IC9B Q108 100 k 120 k 33 k
5
D59
R97–R100: 47 k
R99 2SC4116 R96 G
BOARD J1) 100 µH 0V 4.7 k 5 NJM4558M DTC114E R15 7 1SS373 BALA R100
R94 R95
470 k
D27 C110 1 k
C109
7 RV-150 220 k MA77 0.1 J18
6 6 CP1 0.1
R232 0V 10 k 3.4 V L77 10 µH (TTRC)
R87 5
47 R86 Q30 Q29 L78 10 µH TUNER UNIT
C61 R84
R83 1M 10 k R23 R136 C204 R137 Q26 R101 IC10 R112 L79 10 µH
4 (ISTA)
C60 0.1 2.2 k
100 k 10 k 6.8 k IC3B 0.1 10 k C66 2SA1588 47 k IC11 R109
47 k
R114 2SC4116 2SC4116 L80 2943-666663
3 (IKEY) CPU
0.1 C64
R22
NJM4558M 10 TC4S69F 5 5 D24 47 k 1k
R153
2 (13.8)
WRITE
2 TC4S69F
RV-152 2 4 RD5.1 M R110 (GND)
0.1 100 k 4 47 k 1
C213 R102 R104 10 k
10 270 10 k R113
BALANCE PA1 – PA4: 0 V 100 k
D66 3 3
D2FS4 R111 Q23 S5 C112 C113 C114 C115
Q27 R192 Q102 R103
1k 10 k 2SA1586 SW-161 0.1 0.1 470 p 0.1
C54
0.1
2SB1119 2.2 k
R148
Q28
DTC114EE
DTC114EE R106
1k
R105
56 k
C67 D23
0.0047 RD5.1 M
Q24
2SC4116 MAIN UNIT J17
1 BAL
KEY
2.2 k
STA
TUNER ON : 4.4 V
2 GND COMBINR
3 GND UNIT J8
R193 TUNER OFF: 0 V
2.2 k
TUNER ON : 13.8 V TUNER ON : 13.0 V TUNER ON : 0 V

TUNER OFF: 0 V TUNER OFF: 13.8 V TUNER OFF: 13.0 V
LEFT SIDE 10 - 6 RIGHT SIDE

10-7 TUNER UNIT
TUNER UNIT
RL1
AR39251 MORE THAN 50 MHz BAND : 13.0 V
50 MHz
CHW
LESS THAN 50 MHz BAND : 0 V
L1
100 µH
H-NET BOARD
L11 D1 C1
LA-535 C11
1SS53 0.0047 0.1
–5V
TO FILTER RL2
UNIT D3 C5
C6 AR39251
TIN EP7 MA77 10 C7
EP3 R2 0.0047 D13 L2
16 0.1 C29 C27 100 µH
3.3 1SS286 0.0047 50M
12 14 10
C1 R1
EP8
6p 470
13 2
1 IC2A D2 C12 C2
EP4 15
4 MC10125L C30 R8
C12 R9 1SS53 0.0047 0.1
L1 0.0047 2.2 k
C4 IC1C 0.1 47
1 mH 3
0.0047
C2 C3 MC10116L R3 8 IC3A RL3
330 p 330 p 470
TC74ACT32F AR39251 MORE THAN 24 MHz BAND : 13.0 V
D4 1 2 3 4 5 6 7 8
MA77 L12
1CK
1K
1J
1PR
1Q
1Q
2Q
GND
28/24 MHz LA-534 L3
C11 100 µH
14 0.1 –5.0 V
1 IC4
D3
3 TC74AC112F IC5 1SS53
C13
0.0047
C3
0.1
D6 2
1CLR
2CLR
–11.8 V NJM79L05A
VCC
2CK
2PR
R5 MA77 L12
2Q
2K
2J
470 R6 D7 7 D14 100 µH
CP1 CP5 1 1SS286
4 3.3 1SS301 RL4
2 16 15 14 13 12 11 10 9 AR39251
C8 14
0.0047
5 3 13 R11 C45 C44 L4
W1 10
L3 R4 C9 L4
15 47 0.0047 100 µH
6.8 56 p D5 1M C10 8 IC1A 28M
R7
MA77 0.1 MC10116L 470 IC2D
C13 R12 D4 C14 C4
CP6
MC10125L 0.0047 2.2 k R13 L8 J1 P1
1SS53 0.0047 0.1
CP2 C14
10 k 100 µH –13V
D11 0.0047 1 1 –13R
5V
MBD701 11
L9 100 µH PV
2 2 5V TO
9 6 3 3 PV MAIN UNIT
R17 C18 C36 C37 D8 RV RL5
4 4 RV MORE THAN 18 MHz BAND : 13.0 V
C40 10 k 0.001 0.01 0.1 1SS301
IC3B L10 5 5 GND
J6 AR39251
10 7 L13
0.1 100 µH
TC74ACT32F 21/18 MHz LA-544 L5
C35 C15
IC1B C24 C26 100 µH
180 p 3p 0.0047 0.0047 C34
MC10116L 4
9 6 0.0047
C16 C17
6 5 IC3D C25 D5 C15 C5
CP3 270 p 180 p 0.0047 1SS53 0.0047 0.1
CP8 5 IC2B TC74ACT32F 4.9 V 0V 0V
R18 C23 7 MC10125L 12
10 k 0.001 11 TX
W2 L5 R14
R21 R15 R16 TX: 0.2 V 16 IC3C 13 (MATCHING OK) RL6
30 10 k 1M
30 R19 TC74ACT32F AR39251
1k 9
1SS53 L6
8
CP4 CP7 D12 10 100 µH
10 21M
MBD701
R20 12 IC2C
TX: –0.7 V D6 C16 C6
L11 TX: 0 V 4.7 k 11 MC10125L 1SS53 0.0047 0.1
LR-270
C20 C21 C22

C19 0.0047 0.001 0.0047 RL7
100 p AR39251 MORE THAN 14 MHz BAND : 13.0 V
Q1 L14
LESS THAN 14 MHz BAND : 0 V J1
CIN CP9 2SK515 X33 14 MHz LA-532 L7
E
100 µH 50M 1
28M 2
C43
CP10 27 p C41 C38 C39 21M 3
0.1 0.1 0.01 D7 C17 C7 14M
1SS53 0.0047 0.1 4
10M 5
6
RL8
AR39251
CP11 TOUT
EP5
L8
100 µH 14M
C33
22 p
EP6 GND D8 C18 C8
C42
22 p DET BOARD 1SS53 0.0047 0.1
RL9
10 MHz L15 LESS THAN 10 MHz BAND : 0 V
LA-531
L9
100 µH
J2 EP2 P2
7, 3.5MHz ON: 11.8 V
RL5 ON: 11.8 V RL6 ON: 11.8 V tu2 1 D9 C19 C9
Other Freq. : 0 V 1 TU2
OFF: 0 V OFF: 0 V VHCI 1SS53 0.0047 0.1
2 VHCI
CI3B 2
3 CI3B
3 TO
VHCI
CI2B 4 RL10
CI1B CI3B CI2B CI2B
CI1B
4
5 CI1B
MAIN UNIT AR39251
5 J20
CIN CP2 6 GND
RL3 RL4 *RL5 **RL6 6 L10
AR39251 VB-12MBU-UC VB-12MBU-UC VB-12MBU-UC 7 GND 100 µH
7 10M
L14 L15 L16 L17
100 µH 100 µH 100 µH 100 µH tu1 J1 EP1 P1 D10 C20 C10
CP1 1SS53 0.0047 0.1
RL1 50MHz ON: 0 V CO1B 1
GND 1 CO1B
VS12TBU-VD3 Other Freq.: 11.8 V CO2B 2 EP2
D15 D16 D17 2 CO2B
1SS53 1SS53 1SS53 CO3B
3 3 CO3B TO
L1 VHCO
4 4 VHCO MAIN UNIT LHW
100 µH D14 C39 C44 C49
5 J19
tu2 1SS53 0.0047 0.0047 5 TU1
0.0047
6 6 GND
C1 LHW
C1 D1 0.0047
0.0047 1SS53 C34
0.0047 C40 C41 C50 C51 C82 EP1
C75 C94 68 p 68 p 100 p 100 p 100 p
15 p C45 C46 CHW L3
15 p 220 p
C74 C95 220 p 7 MHz LA-530
15 p 15 p
RL2
CP3 VS12TBU-VD3
C42 C43 C47 C48 C52 C53 C84
C77 C96 68 p 68 p 220 p 220 p 100 p 100 p 100 p
COUT L2 15 p 15 p RL1
C97 J2
100 µH C76 AR39251
tu1 15 p 15 p 12V 1 12V 1 MORE THAN 7 MHz BAND: 13.2 V
PW 2 PW 2 LESS THAN 7 MHz BAND : 0 V
D2 PX 3 PX 3
1SS53 L1
PY
C2
0.0047
C60
82 p
C61
82 p
C65
100 p
C66
100 p
C86
100 p
C87
100 p
C70
150 p
C71
150 p M PZ
4
5
PY
PZ
4
5
TO
100 µH
C3 C1
MF1 C8 C7 C6 C5 MAIN D1 0.1 0.0047
L4
MOTOR STEPPER 1 1 1 1 13.3 V UNIT 3.5 MHz LA-529 1SS53
C90 C91 C62 C63 C67 C68 C88 C89 C72 C73
J1 J14
15 p 15 p 82 p 82 p 100 p 100 p 100 p 100 p 150 p 150 p 12V 10 1 12V
RL7 PW 9 2
RL8 **RL9 *RL10 PW RL2
AR39251 PX AR39251
VB-12MBU-UC VB-12MBU-UC VB-12MBU-UC 8 3 PX
C92 PY
15 p C2 7 4 PY MORE THAN 7 MHz BAND: 13.2 V
50MHz ON: 0 V C55 C56 C93 0.0047 J3 PZ LESS THAN 7 MHz BAND : 0 V
15 p 15 p 6 5 PZ
Other Freq.: 11.8 V 15 p 12V 12V
1 12V 1 5 6 12V L2
C54 RW 2 RW 2 RW 4 100 µH
0.0047 D19 C59 D20 C64 D21 C69 7 PW
1SS53 0.0047 1SS53 0.0047 1SS53 0.0047 RX 3 RX 3 RX 3
C57 8 PX
L18
100 µH
D18
1SS53
15 p
C58
15 p
M RY
RZ
4
5
RY
RZ
4
5
RY
RZ
2
1
9
10
PY
PZ
D2
1SS53
C4
0.1
C2
0.0047
MF2 C4 C3 C2 C1 L5
MOTOR STEPPER 1 1 1 1 13.3 V 1.9 MHz LA-528
L19 7, 3.5MHz ON: 11.8 V RL9 ON: 11.8 V L21 RL10 ON: 11.8 V
100 µH Other Freq.: 0 V L20 OFF: 0 V 100 µH OFF: 0 V
100 µH
C-NET BOARD VHCO CO1B CO3B CO2B

CONNECT BOARD L-NET BOA
Note: An 1.9 MHz band select the relay by condition either RL5 and RL10 (*) or RL6 and RL9 (**).
COMPLETE VIEW
ALC adj2
MORE THAN 50 MHz BAND : 13.0 V R1
10 k
L1
100 µH
H-NET BOARD J8
REMOTE
C11 C1
53 0.0047 0.1
J7
ALC 2 ALC2O
L2 10 18
100 µH
50M
SEND2O 1 1& 2 S1
C12 C2 EXCITER TUNER UNIT
53 0.0047 0.1 SEND 2 1 9
MF3
MORE THAN 24 MHz BAND : 13.0 V J12

1 1
L3
100 µH 2
FANV
GND 2 M
C13 C3
53 0.0047 0.1
J9
GND 1 GND
GND 2 GND
J5
6
ACC2 L1–L6
100 µH
FANV
CI5
3 FANV
L4 4 CI5
100 µH 7 L1 ALC2
28M 1 L2 ALC1
5 ALC2 TO MAIN UNIT
6 ALC1
3
C1 L3 SEND2 7 SEND2
J2
C14 C4 0.0047 L4 SEND1
4 8 SEND1
53 0.0047 0.1 2 L5 13_2 9 13_2
5 L6 13_1 10 13_1
MORE THAN 18 MHz BAND : 13.0 V

LESS THAN 18 MHz BAND : 0 V ALC adj1
L5 C2 C3 C4 C5 C6
100 µH R2 0.0047 0.0047 0.0047 0.0047 0.0047
10 k
J4
C15 C5
53 0.0047 0.1
EXCITER (POWER ON)
REMOTE WITH ACC: 14.0 V
L6 J3
100 µH
21M ALC10
53
C16 C6 ALC 1
0.0047 0.1
SEND10
TO MAIN
MORE THAN 14 MHz BAND : 13.0 V UNIT J21 SEND 1
LESS THAN 14 MHz BAND : 0 V J1
EP1 P1
L7
100 µH 50M 1 1 50M
28M 2 2 28M
21M 3 3
C17 C7 21M
14M 4 4
53 0.0047 0.1 14M
10M 5 5 10M
6 6 GND
7 NC J1
ACC1
8 NC 6
7
L8 1
100 µH 14M 3
4
2
C18 C8 5
53 0.0047 0.1
MORE THAN 10 MHz BAND : 13.0 V

JACK1 UNIT
L9
100 µH
C19 C9
53 0.0047 0.1
TO ANT1
L10 J3
100 µH 10M 1
ANT 4 SELECT: 11.8 V 2

C20 C10
53 0.0047 0.1 ANT 4 UNSELECT: 0 V
RL1 L1
FTR-F1 CA120V 100 µH
TOUT EP1 C1 D1 C6
0.0047 1SS53 0.0047
LHW TO ANT2
J4
EP1 1
L3 R1
SRYH-600L C16
7 MHz LA-530
10 p 2
GND EP2 TO
ANT 3 SELECT: 11.8 V MAIN UNIT
RL2 ANT 3 UNSELECT: 0 V J9
FTR-F1 CA120V EP5 P1
RL1 J1
AR39251 L2 GND
MORE THAN 7 MHz BAND: 13.2 V 100 µH S1
1 5 GND
2 4 S1
LESS THAN 7 MHz BAND : 0 V S2 3 3 S2
C2 D2 C7 S3 4 2 S3
L1 0.0047 1SS53 0.0047 S4 5 1 S4
100 µH TO ANT3
7M J5
C3 C1 1
D1 0.1 0.0047 J1 EP3 P1 C15
L4 C12
3.5 MHz LA-529 1SS53 TO 0.0047 10 p 2
1 1 7M
2 2
MAIN
35M C13
3 3 GND
UNIT 0.0047 L3
J22 RL3 100 µH
RL2 FTR-F1 CA120V
AR39251 D3
C3 C8
MORE THAN 7 MHz BAND: 13.2 V 0.0047 1SS53 0.0047
L2 ANT 2 SELECT: 11.8 V TO ANT4
100 µH ANT 2 UNSELECT: 0 V J6
3.5M
1
D2 C4 C2 C11 C14
0.1 0.0047 10 p 2
1SS53 0.0047
L5
C9
1.9 MHz LA-528
RL4 L4 0.0047
C4 D4
0.0047 1SS53
L-NET BOARD ANT 2 SELECT: 11.8 V

ANT 2 UNSELECT: 0 V CHASSIS
ANT-SW UNIT UNIT
10 - 7
COMPLETE VIEW
10-7 TUNER UNIT ALC adj2
TUNER UNIT
RL1
AR39251 MORE THAN 50 MHz BAND : 13.0 V R1
10 k
50 MHz
CHW
L1
100 µH
H-NET BOARD J8
REMOTE
L11 D1 C1
LA-535 C11
1SS53 0.0047 0.1
–5V
J7
TO FILTER RL2
UNIT D3 C5
C6 AR39251 ALC 2
TIN EP7 MA77 10 C7 ALC2O
EP3 R2 0.0047 D13 L2 18
16 0.1 10
3.3 C29 1SS286
C27 100 µH
12 14 10 0.0047 50M
C1 R1
SEND2O 1 1& 2 S1
EP8
6p 470
13 2
1 IC2A D2 C12 C2 EXCITER TUNER UNIT
EP4 15
4 MC10125L C30 R8
C12 R9 1SS53 0.0047 0.1 SEND 2 1 9
L1 0.0047 2.2 k MF3
C4 IC1C 0.1 47
1 mH 3
0.0047
C2 C3 MC10116L R3 8 IC3A RL3
330 p 330 p 470 J12
TC74ACT32F AR39251 MORE THAN 24 MHz BAND : 13.0 V
D4 1 2 3 4 5 6 7 8
MA77 L12 1 1
FANV
M
1CK
1K
1J
1PR
1Q
1Q
2Q
GND
28/24 MHz LA-534 L3
C11 100 µH 2 GND 2
14 0.1 –5.0 V
1 IC4
D3
3 TC74AC112F IC5 1SS53
C13
0.0047
C3
0.1
D6 2
1CLR
2CLR
–11.8 V NJM79L05A
VCC
2CK
2PR
R5 MA77 L12
2Q
J9
2K
2J
470 R6 D7 7 D14 100 µH GND
CP1 CP5 1 1SS286 1 GND
4 3.3 1SS301 RL4
2 16 15 14 13 12 11 10 9 AR39251 GND 2 GND
C8
0.0047
14 J5
6
ACC2 L1–L6
100 µH
FANV
CI5
3 FANV
5 3 13 R11 C45 C44 L4 4 CI5
W1 10 7 L1 ALC2
L3 R4 C9 L4
15 47 0.0047 100 µH 5 ALC2 TO MAIN UNIT
6.8 56 p D5 1M C10 8 IC1A 28M 1 L2 ALC1 6 ALC1
MA77 0.1 MC10116L R7
IC2D 3
C1 L3 SEND2 7 SEND2
J2
470 R12 0.0047
C13 D4 C14 C4 L4 SEND1
CP6
MC10125L 0.0047 2.2 k R13 L8 J1 P1
1SS53 0.0047 0.1
4
13_2
8 SEND1
CP2 C14
10 k 100 µH –13V 2 L5 9 13_2
D11 0.0047 1 1 –13R 5 L6 13_1
5V 10 13_1
MBD701 11
L9 100 µH PV
2 2 5V TO
9 6 3 3 PV MAIN UNIT
R17 C18 C36 C37 D8 RV RL5
4 4 RV MORE THAN 18 MHz BAND : 13.0 V
C40 10 k 0.001 0.01 0.1 1SS301
IC3B L10 5 5 GND
J6 AR39251
LESS THAN 18 MHz BAND : 0 V ALC adj1
10 7 L13
0.1 100 µH
TC74ACT32F 21/18 MHz LA-544 L5 C2 C3 C4 C5 C6
C35 C15
IC1B C24 C26 100 µH R2 0.0047 0.0047 0.0047 0.0047 0.0047
180 p 3p 0.0047 0.0047 C34 10 k
MC10116L 4
9 6 0.0047 J4
C16 C17
6 5 IC3D C25 D5 C15 C5
CP3 270 p 180 p 0.0047 1SS53 0.0047 0.1
CP8 5 IC2B TC74ACT32F 4.9 V 0V 0V
EXCITER (POWER ON)
C23 7 MC10125L 12 REMOTE WITH ACC: 14.0 V
R18
10 k 0.001 11 TX
W2 L5 R14
R21 R15 R16 TX: 0.2 V 16 IC3C 13 (MATCHING OK) RL6
30 10 k 1M
30 R19 TC74ACT32F AR39251
1k 9
1SS53 L6 J3
8
CP4 CP7 D12 10 100 µH
10 21M ALC10
MBD701
R20 12 IC2C
TX: –0.7 V D6 C16 C6 ALC 1
L11 TX: 0 V 4.7 k 11 MC10125L 1SS53 0.0047 0.1
LR-270
C20 C21 C22 SEND10

C19 0.0047 0.001 0.0047 RL7 TO MAIN
100 p AR39251 MORE THAN 14 MHz BAND : 13.0 V UNIT J21 SEND 1
Q1 L14
LESS THAN 14 MHz BAND : 0 V J1 P1
CIN CP9 2SK515 X33 14 MHz LA-532 L7
EP1
100 µH 50M 1 1 50M
28M 2 2
C43 28M
CP10 27 p C41 C38 C39 21M 3 3
0.1 0.1 0.01 D7 C17 C7 21M
14M 4 4
1SS53 0.0047 0.1 14M
10M 5 5 10M
6 6 GND
RL8 7 NC J1
ACC1
AR39251 8 NC 6
CP11 TOUT 7
EP5
L8 1
100 µH 14M
C33 3
22 p 4
EP6 GND D8 2
C18 C8 5
C42
22 p DET BOARD 1SS53 0.0047 0.1
RL9
JACK1 UNIT
10 MHz L15 LESS THAN 10 MHz BAND : 0 V
LA-531
L9
100 µH
J2 EP2 P2
7, 3.5MHz ON: 11.8 V
RL5 ON: 11.8 V RL6 ON: 11.8 V tu2 1 D9 C19 C9
Other Freq. : 0 V 1 TU2
OFF: 0 V OFF: 0 V VHCI 1SS53 0.0047 0.1
2 VHCI
CI3B 2
3 CI3B
3 TO
VHCI
CI2B 4 RL10
CI1B CI3B CI2B CI2B
CI1B
4
5
MAIN UNIT AR39251
5 CI1B
J20 TO ANT1
CIN CP2 6 GND
RL3 RL4 *RL5 **RL6 6 L10 J3
AR39251 VB-12MBU-UC VB-12MBU-UC VB-12MBU-UC 7 GND 100 µH 1
7 10M
L14 L15 L16 L17
100 µH 100 µH 100 µH 100 µH 2
tu1 J1 EP1 P1 D10 C20 C10 ANT 4 SELECT: 11.8 V
CP1 1SS53 0.0047 0.1 ANT 4 UNSELECT: 0 V
RL1 50MHz ON: 0 V CO1B 1
GND 1 CO1B
VS12TBU-VD3 Other Freq.: 11.8 V CO2B 2 EP2
D15 D16 D17 2 CO2B RL1 L1
1SS53 1SS53 1SS53 CO3B
3 3 CO3B TO FTR-F1 CA120V 100 µH
L1 VHCO
4 4 VHCO MAIN UNIT LHW
100 µH
tu2
D14 C39 C44 C49
5 5 TU1 J19 TOUT EP1 C1 D1 C6
1SS53 0.0047 0.0047 0.0047 0.0047 1SS53 0.0047
6 6 GND
C1
C1
0.0047
LHW TO ANT2
D1 J4
0.0047 1SS53 C34
0.0047 C40 C41 C50 C51 C82 EP1 1
C75 C94 68 p 68 p 100 p 100 p 100 p R1
15 p C45 C46 CHW L3
15 p 220 p SRYH-600L C16
C74 C95 220 p 7 MHz LA-530 2
15 p 10 p
15 p
RL2 GND EP2 TO
CP3 VS12TBU-VD3 ANT 3 SELECT: 11.8 V MAIN UNIT
C48
C77 C96
C42 C43
68 p
C47
220 p 220 p C52 C53
100 p
C84 RL2 ANT 3 UNSELECT: 0 V J9
COUT 68 p 100 p 100 p FTR-F1 CA120V
L2 15 p 15 p J2 RL1 J1 EP5 P1
C76 C97
100 µH tu1 15 p
AR39251 L2 GND
15 p 12V 1 12V 1 MORE THAN 7 MHz BAND: 13.2 V 100 µH S1
1 5 GND
2 4 S1
PW 2 PW 2 LESS THAN 7 MHz BAND : 0 V S2 3 3 S2
D2 PX C2 D2 C7 S3 4 2 S3
3 PX 3 L1 0.0047 1SS53 S4
1SS53 PY 0.0047 5 1 S4
TO ANT3
C2
0.0047
C60
82 p
C61
82 p
C65
100 p
C66
100 p
C86
100 p
C87
100 p
C70
150 p
C71
150 p M PZ
4
5
PY
PZ
4
5
TO
100 µH
7M J5
C3 C1 1
MF1 C8 C7 C6 C5 MAIN D1 0.1 0.0047 J1 EP3 P1 C15
L4 C12
MOTOR STEPPER 1 1 1 1 13.3 V UNIT 3.5 MHz LA-529 1SS53 TO 0.0047 10 p 2
J14 1 1 7M
C90 C91 C62 C63 C67 C68 C88 C89 C72 C73
J1
2 2
MAIN
15 p 35M C13
15 p 82 p 82 p 100 p 100 p 100 p 100 p 150 p 150 p 12V 10 12V 3 3 GND
UNIT 0.0047 L3
1
RL7 PW J22 RL3 100 µH
RL8 **RL9 9 2 PW RL2 FTR-F1 CA120V
AR39251 *RL10 PX
VB-12MBU-UC VB-12MBU-UC VB-12MBU-UC 8 3 PX AR39251 D3
C92 C3 C8
C2 PY 7 MORE THAN 7 MHz BAND: 13.2 V 1SS53 0.0047
15 p 4 PY 0.0047
50MHz ON: 0 V C55 C56 C93 0.0047 J3 PZ LESS THAN 7 MHz BAND : 0 V
15 p 15 p 6 5 PZ
Other Freq.: 11.8 V 15 p 12V 12V
1 12V 1 5 6 12V L2 ANT 2 SELECT: 11.8 V TO ANT4
C54 RW 2 RW 2 RW 4 100 µH ANT 2 UNSELECT: 0 V J6
0.0047 D19 C59 D20 C64 D21 C69 7 PW 3.5M
1SS53 0.0047 1SS53 0.0047 1SS53 0.0047 RX 3 RX 3 RX 3 1
C57 8 PX
L18
100 µH
D18
1SS53
15 p
C58
15 p
M RY
RZ
4
5
RY
RZ
4
5
RY
RZ
2
1
9
10
PY
PZ
D2
1SS53
C4
0.1
C2
0.0047
C11
0.0047
C14
10 p 2
MF2 C4 C3 C2 C1 L5
C9
MOTOR STEPPER 1 1 1 1 13.3 V 1.9 MHz LA-528
RL4 L4 0.0047
L19 7, 3.5MHz ON: 11.8 V RL9 ON: 11.8 V L21 RL10 ON: 11.8 V
100 µH Other Freq.: 0 V L20 OFF: 0 V 100 µH OFF: 0 V
C4 D4
100 µH 0.0047 1SS53
C-NET BOARD VHCO CO1B CO3B CO2B

CONNECT BOARD L-NET BOARD ANT 2 SELECT: 11.8 V
ANT 2 UNSELECT: 0 V CHASSIS
Note: An 1.9 MHz band select the relay by condition either RL5 and RL10 (*) or RL6 and RL9 (**).
ANT-SW UNIT UNIT
LEFT SIDE 10 - 7
RIGHT SIDE
INTRODUCTION DANGER
This service manual describes the latest service information for HIGH VOLTAGE! NEVER touch the antenna con-
the IC-PW1 HF/50 MHz ALL BAND LINEAR AMPLIFIER at nector or the power supply section in the linear amplifier
the time of publication. while connecting the IC-PW1 to an AC outlet.
MODEL VERSION SYMBOL
NEVER carry the linear amplifier by yourself. At least two
U.S.A. USA persons must carry the linear amplifier since it weights ap-
prox. 25 kg (55.12 lb).
IC-PW1 Europe EUR
Europe-1 EUR-1 NEVER expose the IC-PW1 to rain or moisture since fire
or shock hazard could occur.
To upgrade quality, all electrical or mechanical parts and inter-
nal circuits are subject to change without notice or obligation. NEVER touch the IC-PW1 with metal strips, wire, etc.
These materials may cause fires and electric shocks.
6-9-16, Kamihigashi, Hirano-ku, Osaka 547-0002, Japan

Phone : 06 6793 5302
Fax : 06 6793 0013
URL : http://www.icom.co.jp/world/index.html
ORDERING PARTS REPAIR NOTES < Corporate Headquarters > Communication Equipment
2380 116th Avenue N.E., Bellevue, WA 98004, U.S.A. Himmelgeister Str. 100, D-40225 D sseldorf, Germany
Be sure to include the following four points when ordering 1. Make sure a problem is internal before disassembling the Phone : (425) 454-8155 Fax : (425) 454-1509 Phone : 0211 346047 Fax : 0211 333639
URL : http://www.icomamerica.com URL : http://www.icomeurope.com
replacement parts: linear amplifier or the remote controller. < Customer Service >
Phone : (425) 454-7619
1. 10-digit order numbers 2. DO NOT open the linear amplifier or the remote controller Crta. de Gracia a Manresa Km. 14,750
2. Component part number and name until the linear amplifier is disconnected from its power 08190 Sant Cugat del Valles Barcelona, SPAIN
Glenwood Centre #150-6165 Phone : (93) 590 26 70 Fax : (93) 589 04 46
3. Equipment model name and unit name source. Highway 17 Delta, B.C., V4K 5B8, Canada URL : http://www.icomspain.com
Phone : (604) 952-4266 Fax : (604) 952-0090
4. Quantity required 3. DO NOT force any of the variable components. URL : http://www.icomcanada.com
Unit 9, Sea St., Herne Bay, Kent, CT6 8LD, U.K.
Turn them slowly and smoothly. Phone : 01227 741741 Fax : 01227 741742
<SAMPLE ORDER> 4. DO NOT short any circuits or electronic parts. An insu- A.C.N. 006 092 575
290-294 Albert Street, Brunswick, Victoria, 3056, Australia
URL : http://www.icomuk.co.uk
1140003830 S.IC TC4W66F IC-PW1 MAIN UNIT 1 piece lated tuning tool MUST be used for all adjustments. Phone : 03 9387 0666 Fax : 03 9387 0022
8810003160 SET Screw 3 × 6 ZK IC-PW1 CHASSIS 6 pieces URL : http://www.icom.net.au Zac de la Plaine, Rue Brindejonc des Moulinais
5. DO NOT keep power ON for a long time when the linear BP 5804, 31505 Toulouse Cedex, France
Phone : 561 36 03 03 Fax : 561 36 03 00
Addresses are provided on the inside back cover for your amplifier is defective. 6F No. 68, Sec. 1 Cheng-Teh Road, Taipei, Taiwan, R.O.C. URL : http://www.icom-france.com
Phone : (02) 2559 1899 Fax : (02) 2559 1874
convenience. 6. READ the instructions of test equipment thoroughly
before connecting equipment to the linear amplifier.
Count on us!
HF/50 MHz ALL BAND

LINEAR AMPLIFIER
iC-PW1
A-5449MZ-S-1
6-9-16, Kamihigashi, Hirano-ku, Osaka 547-0002, Japan  1999 Icom Inc.

Icom Pw-1 F Amplifier Repair Manual-E

Uploaded by

Copyright:

Available Formats

Icom Pw-1 F Amplifier Repair Manual-E

Uploaded by

Document Information

Original Description:

Original Title

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

Icom Pw-1 F Amplifier Repair Manual-E

Uploaded by

Copyright:

Available Formats

What safety precautions should be taken when handling the linear amplifier?

What safety precautions should be taken when handling the linear amplifier?

What are the components of the linear amplifier?

What are the components of the linear amplifier?

HF/50 MHz ALL BAND

ORDERING PARTS REPAIR NOTES

SECTION 2 INSIDE VIEWS

SECTION 3 CIRCUIT DESCRIPTION

SECTION 4 ADJUSTMENT PROCEDURES

SECTION 5 PARTS LIST

SECTION 6 MECHANICAL PARTS AND DISASSEMBLY

SECTION 7 SEMI-CONDUCTOR INFORMATION

SECTION 8 BOARD LAYOUTS

SECTION 9 BLOCK DIAGRAM

SECTION 10 VOLTAGE DIAGRAM

*1 EUR-1 version is 450–550 W;

All stated specifications are subject to change without notice or obligation.

JACK1 UNIT FRONT

DET BOARD H-NET BOARD

3-1 LINEAR AMPLIFIER CIRCUITS 3-1-3 POWER AMPLIFIER CIRCUITS

The filtered signal is applied to the matching circuit.

"T8V" to PA1 board

From FILTER unit To C-NET board

RL5 FILTER UNIT

Main CPU IC26

EQUIPMENT GRADE AND RANGE EQUIPMENT GRADE AND RANGE

Connect 2-conductor plug to REMOTE

1/8" (3.5 mm)

to the ANT1 connector

4 • Same adjustments as steps 1–4 for PA2–PA4 boards.

• METER-1 : [PO] scale TEMP

• METER-2 : [VD] scale METER-1

2 [METER-2] Set as below : R57

Front side (after removed front panel)

• Meter maximum point adjustment

• SWR detector circuit adjustment Rear panel

ACC-2 ALC2 SEND2 ACC-1 ALC1 SEND1 INPUT2

• Tuner basis voltage adjustment

2 REAR Connect the RF 1050 W MAIN R4

2 REAR Connect the RF 520 W MAIN R6

ACC-2 ALC2 SEND2 ACC-1 ALC1 SEND1 INPUT2

Front side (after removed front panel)

• ID ALC and ID meter adjustment

Front side (after removed front panel)

Front side (after removed front panel)

[MAIN UNIT] [MAIN UNIT]

WS1 8600035721 M.OTHER EX1900 P01*J03*09SP-1

J2 6510017920 CONNECTOR 1811P342

W6 7030003860 S.JUMPER ERJ3GE JPW V

L1 6110001730 COIL LA-262

J2 6510017920 CONNECTOR 1811P342

L1 6110001730 COIL LA-262

R2 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ)

J2 6510017920 CONNECTOR 1811P342

C1 4010005570 CERAMIC HM60SJ SL 060D 500V J1 6510017650 CONNECTOR 52045-1045

WS1 8970022630 M.OTHER EX1900 TEFLON COAXIAL (2)/DE

EP5 6910011330 TERMINAL OT-009 M3

L1 6180000990 COIL LAL 04NA 101K

WS1 8600035721 M.OTHER EX1900 P01J0309SP-1