Clarion Co., Ltd.

Published by Service Dept.

7-2, Shintoshin, Chuo-ku, Saitama-shi, Saitama 330-0081 Japan
298-6605-00 Oct.2008
Service Dept.: 7-2, Shintoshin, Chuo-ku, Saitama-shi, Saitama 330-0081 Japan
Tel: +81-48-601-3705 FAX: +81-48-601-3804 Printed in Japan

Service Manual
SUZUKI Automobile Genuine
RDS/FM/MW/LW Tuner 6CD Combi

Model PS-3141K-A
(Genuine No.39101-80JL0-CZT)
(ID No.CLCC16)

Model PS-3141K-B
(Genuine No.39101-80JM0-CZT)
PS-3141K-A/K-B
(ID No.CLCC16)

SPECIFICATIONS
Radio section CD section
Tuning system: PLL Frequeency synthesizer sys-
Disc: 12cm Disc
tem
Separation: More than 55dB
Receive range: FM 87.5MHz to 108.0MHz
S/N ratio: More than 70dB(JIS-A)
MW 531kHz to 1602kHz
Distortion: Less than 0.3%(20kHz-LPF)
LW 153kHz to 279kHz
Intermediate frequency:
MP3/WMA section
FM 10.7 +0.2/-0.2MHz
MP3 sampling rate: 11.025kHz to 48kHz
MW 1st 10.71 +0.2/-0.2MHz
MP3 bit rate: 8kbps to 320kbps/VBR
2nd 450 +3/-3kHz
WMA bit rate: 48kbps to 192kbps
LW 1st 10.71 +0.03/-0.03MHz
Logical format: ISO9660 level 1,2
2nd 450 +3/-3kHz
JOLIET or Romeo
FM Separation: 22 +5/-7dB
Quieting sensitivity: FM Less than 15dBu
(at 30dB S/N) General
MW Less than 34dBu (K-A) Rated Voltage : DC 13.2V
(at 20dB S/N) Quiting Output: More Than 12Wx4 (10% Dist.)
MW Less than 39dBu (K-B) More Than 16Wx4 (Max Output)
(at 20dB S/N) Back-up consumption: Less than 5mA
LW Less than 40dBu (K-A) Dimensions(mm): 178(W)x100(H)x143(D)
(at 20dB S/N) Weight: approx.2.5kg
LW Less than 45dBu (K-B)
(at 20dB S/N) * Please measure it auto loud function off.The auto loud
Auto tuning stop sensitivity: function off by pushed 1ch,2ch and the up button.
FM 22 +6/-6dBu
MW 32 +6/-6dBu (K-A)
MW 42 +6/-6dBu (K-B)
LW 32 +6/-6dBu (K-A)
LW 42 +6/-6dBu (K-B)

-1- PS-3141K-A/B
NOTE
3. Check for safety after repair.
* PS-3141K-A is a corresponding model of the antena
Check that the screws, parts and wires are put back securely
amplifier output.
in their original position after repair. Ensure for safety reasons
* We cannot supply PWB with component parts in
there is no possibility of secondary ploblems around the re-
principle. When a circuit on PWB has failure , please
paired spots.
repair it by component parts base.
If extended damage is caused due to negligence of repair, the
Parts which are not mentioned in service manual are
legal responsibility shall be with the repairing company.
not supplied.
4. Caution in removal and making wiring connection to the parts
* Specifications and design are subject to change without
for the automobile.
notice for further improvement.
Disconnect the battery terminal after turning the ignition key
* WMA is the abbreviation of Windows Media Audio,an
off. If wrong wiring connections are made with the battery con-
audio file format developed by Microsoft Corporation.
nected, a short circuit and/or fire may occur. If extensive dam-
* This product includes technology owned by Microsoft
age is caused due to negligence of repair, the legal responsi-
Corporation and cannot be used or distributed without
bility shall be with the repairing company.
a license from MSLGP.
5. Cautions in soldering
Please do not spread liquid flux in soldering.
COMPONENTS Please do not wash the soldering point after soldering.
PS-3141K-A,B 6. Cautions in soldering for chip capacitors
1. Main unit --------------- 1 Please solder the chip capacitors after pre-heating for replace-
ment because they are very weak to heat.
Please do not heat the chip capacitors with a soldering iron
COMPUTER ANTI-THEFT SYSTEM directly.
This unit has a built-in Computer Anti-Theft System(CATS) 7. Cautions in handling for chip parts.
which makes the radio inoperative if power to the unit is Do not reuse removed chips even when no abnormality is ob-
interrupted for any reason whatsoever(including disconnec- served in their appearance. Always replace them with new
tion and reconnection of the car battery).The radio will re- ones. (The chip parts include resistors, capacitors, diodes, tran-
sistors, etc).
Please make an operation test after replacement.
8. Cautions in handling flexible PWB
Before working with a soldering iron, make sure that the iron
tip temperature is around 270 . Take care not to apply the
iron tip repeatedly(more than three times)to the same patterns.
Also take care not to apply the tip with force.
9. Turn the unit OFF during disassembly and parts replacement.
Recheck all work before you apply power to the unit.
To engineers in charge of repair or 10. Cautions in checking that the optical pickup lights up.
The laser is focused on the disc reflection surface through the
inspection of our products. lens of the optical pickup. When checking that the laser opti-
Before repair or inspection, make sure to follow the cal diode lights up, keep your eyes more than 30cms away
from the lens. Prolonged viewing of the laser within 30cms
instructions so that customers and Engineers in charge
may damage your eyesight.
of repair or inspection can avoid suffering any risk or 11. Cautions in handling the optical pickup
injury. The laser diode of the optical pickup can be damaged by elec-
1. Use specified parts. trostatic charge caused by your clothes and body. Make sure
The system uses parts with special safety features against fire to avoid electrostatic charges on your clothes or body, or dis-
and voltage. Use only parts with equivalent characteristics charge static electricity before handling the optical pickup.
when replacing them. 11-1. Laser diode
The use of unspecified parts shall be regarded as remodeling The laser diode terminals are shorted for transportation in or-
for which we shall not be liable. The onus of product liability der to prevent electrostatic damage. After replacement, open
(PL) shall not be our responsibility in cases where an accident the shorted circuit. When removing the pickup from the mecha-
or failure is as a result of unspecified parts being used. nism, short the terminals by soldering them to prevent this
2. Place the parts and wiring back in their original positions after damage.
replacement or re-wiring. 11-2. Actuator
For proper circuit construction, use of insulation tubes, bond- The actuator has a powerful magnetic circuit. If a magnetic
ing, gaps to PWB, etc, is involved. The wiring connection and material is put close to it. Its characteristics will change. En-
routing to the PWB are specially planned using clamps to keep sure that no foreign substances enter through the ventilation
away from heated and high voltage parts. Ensure that they are slots in the cover.
placed back in their original positions after repair or inspec- 11-3. Cleaning the lens
tion. Dust on the optical lens affects performance.
If extended damage is caused due to negligence during re- To clean the lens, apply a small amount of isopropyl alcohol to
pair, the legal responsibility shall be with the repairing com- lens paper and wipe the lens gently.
pany.

PS-3141K-A/B -2-
 main inoperative unless you enter the correct CATS num-
ber.
MODE L NO. PS-3141K

CAUTIONS 1 2 V ( - ) GROUND
S E RI A L NO.

This appliance contains a laser system and is classified as

a "CLASS 1 LASER PRODUCT". To use this model prop-
erly, read this Owner's Manual carefully and keep this manual
FREQUENCY RANGE LW : 153k Hz- 279k Hz
for your future reference. In case of any trouble with this MW ; 531k Hz- 1602k Hz
FM ; 87. 5MHz- 108MHz
player, please contact your nearest"AUTHORIZED service
station". To prevent direct exposure to the laser beam, do
not try to open the enclosure.
Use of controls,adjustment,or performance of procedures 033942
PS2809
Su z u k i par t No .
39101-80J
I D: 39101-80J
Cla r io n Co . , L t d PART No . 286-6186-

other than those specified herein,may result in hazardous

radiation exposure.
EXPLANATION OF IC
amplifier.
052-3220-10 Renesas M30624MGP-E48GP System Controller pin 38: TEL out : O : Telephone control signal output.
pin 39: SYS ACC : O : ACC detection signal output.
Terminal Description
pin 40: CATS TP : IN : Pll up.
pin 1: PLL CK : O : PLL clock pulse output.
pin 41: NU : - : Not in use.
pin 2: PLL DO : O : PLL serial data output.
pin 42: RDS DATA : IN : RDS serial data input.
pin 3: PLL CE : O : PLL chip enable signal output.
pin 43: RDS DIS CHG : O : RDS dis-charge signal output
pin 4: NU : - : Not in use.
pin 44: Speed Up : O : The speed up signal output for RDS.
pin 5: NU : - : Not in use.
pin 45: RDS MUTE : O : RDS mute signal output.
pin 6: BYTE : IN : Data length selection(8bit/16bit).
pin 46: EEP CK : O : EEP-ROM clock pulse out.
pin 7: CN VSS : IN : Connect to VSS via a resistor.
pin 47: EEP CS : O : EEP-ROM chip select signal out.
pin 8: ANT ON : O : Antenna ON command output.
pin 48: EEP DO : O : Serial data output to EEP-ROM.
pin 9: BL CONT : O : Back light control signal output.
pin 49: EEP DI : IN : Serial data input from EEP-ROM.
pin 10: RESET : IN : Reset signal input.
pin 50: GIX SYS ACC : O : 6CD-mechanism system ACC control.
pin 11: X out : O : The crystal connection.
pin 51: GIX RESET : O : 6CD-mechanism reset pulse output.
pin 12: GND : - : Ground.
pin 52: V LCD ON : O : LCD power supply on signal output.
pin 13: X in : IN : The crystal connection.
pin 53: NU : - : Not in use.
pin 14: VDD : - : Positive voltage supply.
pin 54: NU : - : Not in use.
pin 15: NMI : IN : Nonmaskable interrupt. Connect to VDD
via a resistor. pin 55: NU : - : Not in use.
pin 16: ACC DET : IN : ACC detection signal input. pin 56: NU : - : Not in use.
pin 17: BU DET : IN : Backup detection signal input. pin 57: NU : - : Not in use.
pin 18: Speed Pulse : IN : Speed pulse input. pin 58: NU : - : Not in use.
pin 19: BL ON : O : Back light ON command output. pin 59: NU : - : Not in use.
pin 20: NU : - : Not in use. pin 60: VDD : - : Positive voltage supply.
pin 21: NU : O : Not in use. pin 61: NU : - : Not in use.
pin 22: E VOL EQ CK : O : Clock pulse output to electric volume and pin 62: GND : - : Ground.
equalizer. pin 63: NU : - : Not in use.
pin 23: E VOL DATA : O : Serial data output to the volume IC. pin 64: NU : - : Not in use.
pin 24: BEEP : O : Beep out. pin 65: NU : - : Not in use.
pin 25: RX : IN : Connect to the 27 pin. pin 66: NU : - : Not in use.
pin 26: NU : O : Not in use. pin 67: NU : - : Not in use.
pin 27: Ce-NET RX : IN : Serial data input from the Ce-NET. pin 68: NU : - : Not in use.
pin 28: Ce-NET TX : O : Serial data output to the Ce-NET. pin 69: NU : - : Not in use.
pin 29: NU : - : Not in use. pin 70: NU : - : Not in use.
pin 30: NU : - : Not in use. pin 71: NU : - : Not in use.
pin 31: NU : - : Not in use. pin 72: GIX REQ : IN : 6CD-mechanism request signal input.
pin 32: ILL DET : IN : Illumination ON signal input. pin 73: RDS CK : IN : RDS clock pulse input.
pin 33: GIX SDA : O : 6CD-mechanism serial data output. pin 74: LCD RESET : O : Reset pulse output to the LCD.
pin 34: GIX SCL : O : 6CD-mechanism serial clock output. pin 75: LCD CS : O : Chip select signal output to the LCD driv-
pin 35: SYS ON : O : System ON signal output. er.
pin 36: AMP ON : O : Audio power amplifier ON signal output. pin 76: LCD SCK : O : Clock pulse output to the LCD driver.
pin 37: AMP MUTE : O : Muting signal output to the Audio power pin 77: LCD DATA :I/O: Serial data input/output for the LCD driv-

-3- PS-3141K-A/B
 er. pin 92: S METER : IN : The input terminal of the internal A/D con-
pin 78: LCD REQ : IN : The key interrupt request signal input from verter to monitor the radio field strength.
the LCD driver. pin 93: S REMOCON : IN : Steering wheel remote controller input.
pin 79: VOL 1 L : IN : Volume control pulse input from the rota- pin 94: A VSS : - : Analog ground.
ry encoder.
pin 95: AUX/Tel/BTon : IN : The input terminal of the internal ADC.
pin 80: VOL 2 L : IN : Volume control pulse input from the rota-
pin 96: VREFI : IN : Reference voltage input.
ry encoder.
pin 97: A VCC : - : Positive voltage supply for the internal
pin 81: VOL 1 R : IN : Volume control pulse input from the rota-
analog section.
ry encoder.
pin 98: SD/ST : IN : At receiving the FM station, this port de-
pin 82: VOL 2 R : IN : Volume control pulse input from the rota-
tects the stereo signal. At seeking or
ry encoder.
scanning, this port detects the station de-
pin 83: SEL 1 : IN : L = 1CD, H = 6CD. tection signal.
pin 84: SEL 2 : IN : Refer Table 1. pin 99: SD CONT : O : SD control signal output for RDS.
pin 85: SEL 3 : IN : Refer Table 1. pin100: PLL DI : IN : PLL serial data input.
pin 86: SEL 4 : IN : L = Without the clock.
pin 87: POWER SW : IN : Power switch ON signal input. Table 1
pin 88: CD LOAD : IN : CD-loading detection signal input. YV1 ----- YY3 YT4
pin 89: CD EJECT : IN : CD eject switch signal input. SEL 2 ( pin 84 ) H H L L
SEL 3 ( pin 85 ) H L H L
pin 90: NU : - : Not in use.
pin 91: NOISE IN : IN : Input terminal of A/D converter to detect
the Noise of FM.

BLOCK DIAGRAM
AUDIO J801 (074-4007-20)
TUNER
MAIN BL101
FM E-VOL IC FL FL POWER-IC FL H,R
AM/FM AM IC401 CL7639V20 FR FR
IC391
TUNER CD RL RL
TA8276H FR
RR
G,Q
RR
AUTO LOUD Lo/Hi

TONE CONTROL
GAIN CONTROL

VOLUME/MUTE
INPUT SELECT

CAR VELOCITY
CAR VELOCITY
FADER/MUTE
(BASS/TRE)

Ce-NET
RDS NOISE AMP SP RL F,P
TEL/AUX
LOUD Lo

PROTECT
LOUD Hi

J701
IC151 RR
No CONNECTION
NJM4558V CIRCUIT E,O
1 GND LPF
2 B/U
3 L-ch (㧗)
4 N.C. RDS DECORDER
5 N.C.
PLL-IC IC152
6 BUS (㧗) SAA6581T
7 R-ch (㧗) LC72146M
X=7.2MHz X=4.332MHz
8 R-ch (㧙)
9 SYS-ACC IC121
10 BUS (㧙)
11 L-ch (㧙)
12 ILL (㧗)
13 N.C.

MODE BEEP

6CD
Gi X2
䯴MP3/WMA䯵
J701
CD/MD-CHG
Ce-NET CPU B/U-DET B/U J
Ce-NET
IC504 IC501 RESET
HA12187FP M30624MGP-E48GP AUDIO+8V
B/U
USB-BB/ PLL/RDS/CD/AUDIO TO AUDIO SECTION IC741
iPod-BB NJM2388 ACC B
POWER/DISPLAY/ ACC-DET
Ce-NET (SYS5)
OPERATION
TO TUNER SECTION

B/U
J721 (SYS5) TUNER+B ANT+B
BT/TEL/AUX/ Isolation AMP
CATS Ce-NET / OTHERS
EEP-ROM CD+9V Q711
H free 8pin IC351 A-ANT A
CONNECTOR NJM4558V IC503 ILL-DET IC272 (ANT-ON)
TO CD MECH SECTION

X=10MHz NJM2396F09
BR93L56F FM+B

MICOM/COMMUNICATION/
AVC VOLTAGE WATCH
AM+B VDD+5V
SPEED PLUS Q506
(SYS5) (CD1.5ON2)
2SD2118 B/U
SYS+3.3V VDD+3.3V D509
BUTTON ILL HZS7A1L
TO MICOM SECTION

STEARING LCD&KEY -DRIVER Q241 IC241

REMOCON PL100࡯PL102 Q242
IC100 NJU6625 PL104࡯PL111 NJU7780UI 33
VLCD+6.3V
VDD5 Q761 B/U
SYS+5V
Q502 2SC5810
LCD BACK LIGHT
J721 2SA2071 D761
No CONNECTION D100࡯D108 HZS7B2L
(SYS-ON)
1 ACC (VLCD-ON)
2 N.C.
3 GND KEY LCD B/U
4 AUX L-ch SWITCH LCD100 ILL+B ILL+ ILL+ I
5 N.C. J801
TO ILLUMI SECTION
TO LCD SECTION

6 AUX-ON No CONNECTION No CONNECTION

LCD / ILLUMI SW PWB SECTION A A-ANT K SR-G
7 S-GND
B ACC L SR-1
8 AUX R-ch
C N.C. M SPEED PULSE DIM ILL- S
D N.C. N N.C.
E REAR Rch(㧗) O REAR Rch (㧙)
F REAR Lch (㧗) P REAR Lch (㧙) B/U
LCD-B/L
G FRONT Rch (㧗) Q FRONT Rch (㧙) D771
H FRONT Lch (㧗) R FRONT Lch (㧙) MA4082L
I ILLUMI (㧗) S DIMMER-C
J BACK UP T GND

PS-3141K-A/B -4-
EXPLODED VIEW/PARTS LIST
Main section
20

15 25
23
19 24 27

25
21
25
25

18 15
30 MA
X
17 x8
mm
M5

6
25 7
25
28
25 22 25
3 8 9
28 29
5
28 3
10
25
16 3 2
25 28 11
1 28
3
25 25
31
28 14 14
13 12
3
26
25 25
28
25
28 4
28
26
25

* Clamping torque value of a screw is 0.4 +0.08/-0.08 Newton meter.

* The part number of TUNER PACK and SETPLATE is different in each model.

NO. PART NO. DESCRIPTION Q'TY NO. PART NO. DESCRIPTION Q'TY
1 076-3011-74 PLUG(24P) 1 17 285-1960-00 GUIDE LABEL 1
2 074-1237-69 OUTLET SOCKET 1 18 816-4055-50 FLAT WIRE 1
3 073-0762-90 TERMINAL 5 19 929-0420-80 CD-MECH-MODULE 1
4 311-1919-75 LOWER CASE 1 20 331-4091-10 CD BRKT(L) 1
5 331-4126-00 TR HOLDER 1 21 331-4092-10 CD BRKT(R) 1
6 313-1966-00 SUB HEAT SINK 1 22 310-1826-10 UPPER CASE 1
7 331-4548-00 IC HOLDER 1 23 286-6186-37 SETPLATE (PS-3141K-A) 1
286-6186-38 SETPLATE (PS-3141K-B) 1
8 074-1194-00 SOCKET (13P Ce-NET) 1
24 313-1962-00 HEAT SINK 1
9 074-1302-08 SOCKET (8P) 1
25 714-2606-8B MACHINE SCREW(M2.6x6) 20
10 074-4007-20 SOCKET (20P) 1
26 331-4193-20 SU-PLATE 2
11 092-0702-00 ANT-RECEPT 1
27 714-2610-89 MACHINE SCREW(M2.6x10) 2
12 941-0215-80 TUNER PACK (PS-3141K-A) 1
941-0221-80 TUNER PACK (PS-3141K-B) 1 28 716-0878-50 IT SCREW(M2.6x5) 11
13 --------------- Main PWB 1 29 331-4549-00 ANT HOLDER 1
14 778-3006-00 TAP-SCREW(3x6) 4 30 331-4547-00 SOCKET HOLDER 1
15 716-3552-00 IT SCREW(M2.3x2.5) 6 31 347-8651-00 PROTECTOR 1
16 309-0819-11 ES PLATE 1

-5- PS-3141K-A/B
 Escutcheon section

11

5 4 13
14

12

9
17x11
10

19

10

8 15
1 16
15
18
2 3 8
7

* Clamping torque value of a screw is 0.2 +0.04/-0.04 Newton meter.

NO. PART NO. DESCRIPTION Q'TY NO. PART NO. DESCRIPTION Q'TY
1 940-8120-43 ESCUTCHEON ASSY 1 11 331-4264-00 LCD COVER 1
2 947-0602-00 KNOB ASSY 2 12 379-1363-51 INDICATOR (LCD) 1
3 371-5854-00 DIAL COVER 1 13 335-7705-00 LCD HOLDER 1
4 345-5589-00 RUBBER SW (CENTER) 1 14 335-7929-00 COLOR FILTER 1
5 345-5590-00 RUBBER SW (LEFT) 1 15 001-7094-91 DIODE (VFR1112H RED) 8
6 345-5591-00 RUBBER SW (RIGHT) 1 16 001-7087-90 DIODE (RBR1112H C,D,E RED) 1
7 --------------- Switch PWB 1 17 017-0420-43 PL LAMP (14V 40mA RED) 11
8 016-0014-12 VR W/SHAFT 2 18 074-3013-74 SOCKET (24P) 1
9 345-6272-00 PROTECTOR 1 19 335-7356-30 MD COVER 1
10 716-0778-51 P-TITE SCREW (2x6) 11

ELECTRICAL PARTS LIST

Main PWB section (B1)
REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTION
ANT101 092-0702-50 ANT-RECEPT C123 168-1042-78 16V 0.1uF C157 168-2232-55 0.022uF K
BL101 941-0215-80 TUNER PACK C124 042-1458-90 50V 1uF LN C158 166-8211-50 820pF
(PS-3141K-A) C125 166-1501-50 15pF CH C159 168-1032-55 0.01uF K
941-0221-80 TUNER PACK C126 166-1011-50 100pF CH C160 168-1042-78 16V 0.1uF
(PS-3141K-B) C127 166-1011-50 100pF CH C161 188-4763-18 6.3V 47uF
C101 168-1022-55 1000pF K C128 166-1011-50 100pF CH C162 168-1042-78 16V 0.1uF
C103 168-1022-55 1000pF K C129 166-1011-50 100pF CH C163 166-5611-50 560pF CH
C104 188-1073-28 10V 100uF C130 168-2232-55 0.022uF K C164 168-1032-55 0.01uF K
C105 168-1042-78 16V 0.1uF C131 188-4763-38 16V 47uF C165 166-5601-50 56pF CH
C106 168-1042-78 16V 0.1uF C132 166-1811-50 180pF CH C166 166-3311-50 330pF CH
C107 188-1073-28 10V 100uF C133 168-1042-78 16V 0.1uF C167 188-2253-68 50V 2.2uF
C108 168-1042-78 16V 0.1uF C151 188-3363-27 10V 33uF C168 166-5601-50 56pF CH
C109 168-2232-55 0.022uF K C152 178-1052-78 1uF C169 168-1822-55 1800pF K
C112 168-4745-79 0.47uF Z C153 188-4753-57 35V 4.7uF C170 168-8222-55 8200pF K
C113 168-6832-78 0.068uF K C154 168-1042-78 16V 0.1uF C171 168-2232-55 0.022uF K
C114 168-6832-78 0.068uF K C155 168-2232-55 0.022uF K C212 188-4763-38 16V 47uF
C121 166-1501-50 15pF CH C156 166-6811-50 680pF C222 168-1042-78 16V 0.1uF

PS-3141K-A/B -6-
 Note) Several different parts of the same reference number are alternative parts.
One of those parts is used in the set.

REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTION
C241 168-2232-55 0.022uF K C513 189-1073-29 10V 100uF Q151 125-2032-92 RN1302
C243 188-4763-38 16V 47uF C514 168-1042-78 16V 0.1uF Q151 125-2041-92 RT1N141M
C244 168-1042-78 16V 0.1uF C515 166-1011-50 100pF CH Q152 192-4116-51 2SC4116 G,L
C245 168-1042-78 16V 0.1uF C516 188-1063-38 16V 10uF Q152 192-4155-51 2SC4155A S,T
C274 189-2273-29 10V 220uF C517 042-0559-00 5.5V 0.1F Q152 193-1819-50 2SD1819 AR,SL
C276 043-0328-90 0.1uF C722 168-1042-78 16V 0.1uF Q153 125-0021-91 DTA114EUA
C301 178-1052-78 1uF C731 172-1041-15 0.1uF Q153 125-0025-92 RN2302
C302 178-1052-78 1uF C732 188-1053-68 50V 1uF Q153 125-0034-92 RT1P141M
C305 178-1052-78 1uF C741 043-0328-90 0.1uF Q154 125-2027-91 DTC114EUA
C306 178-1052-78 1uF C744 188-1073-28 10V 100uF Q154 125-2032-92 RN1302
C309 168-1832-55 0.018uF K C761 188-1063-38 16V 10uF Q154 125-2041-92 RT1N141M
C310 168-1832-55 0.018uF K C762 188-1063-38 16V 10uF Q155 198-0669-00 2SK669
C311 188-2253-68 50V 2.2uF C771 188-1073-28 10V 100uF Q156 125-0021-91 DTA114EUA
C312 188-2253-68 50V 2.2uF C772 188-1063-38 16V 10uF Q156 125-0025-92 RN2302
C313 188-2253-68 50V 2.2uF C773 168-1042-78 16V 0.1uF Q156 125-0034-92 RT1P141M
C314 188-2253-68 50V 2.2uF C774 178-4755-79 4.7uF Q157 125-2027-91 DTC114EUA
C318 168-1522-55 1500pF K C811 172-1041-15 0.1uF Q157 125-2032-92 RN1302
C319 168-1522-55 1500pF K C821 188-1063-38 16V 10uF Q157 125-2041-92 RT1N141M
C334 166-4711-50 470pF CH CCT501 050-0140-54 1/32W 1k ohm x4J Q158 125-2027-91 DTC114EUA
C335 166-4711-50 470pF CH CCT504 050-0140-54 1/32W 1k ohm x4J Q158 125-2032-92 RN1302
C346 188-1073-28 10V 100uF CCT505 050-0140-54 1/32W 1k ohm x4J Q158 125-2041-92 RT1N141M
C352 168-1042-78 16V 0.1uF D101 001-0535-90 MA729 Q159 125-2038-92 RN1902
C353 042-1562-65 10V 220uF D151 001-0580-90 1SS352 Q241 125-0021-91 DTA114EUA
C354 166-2201-50 22pF CH D152 001-0580-90 1SS352 Q241 125-0025-92 RN2302
C355 166-2201-50 22pF CH D391 001-0580-90 1SS352 Q241 125-0034-92 RT1P141M
C356 166-1007-50 10pF CH D504 001-0580-90 1SS352 Q242 125-2027-91 DTC114EUA
C357 166-1007-50 10pF CH D505 001-0580-90 1SS352 Q242 125-2032-92 RN1302
C358 188-1063-38 16V 10uF D506 001-2403-90 M1F60 Q242 125-2041-92 RT1N141M
C359 188-1063-38 16V 10uF D507 001-4301-25 HZU4.7B1 Q243 193-0601-00 2SD601A
C360 188-1063-38 16V 10uF D508 001-0466-90 S5688B Q244 192-4116-51 2SC4116 G,L
C361 188-1063-38 16V 10uF D509 001-0504-36 HZS7 A1L Q244 192-4155-51 2SC4155A S,T
C391 168-1042-78 16V 0.1uF D701 001-0424-31 MA4180 Q244 193-1819-50 2SD1819 AR,SL
C392 168-1042-78 16V 0.1uF D702 001-0424-31 MA4180 Q245 125-2027-91 DTC114EUA
C393 168-1042-78 16V 0.1uF D703 001-0424-31 MA4180 Q245 125-2032-92 RN1302
C394 168-1042-78 16V 0.1uF D711 001-0466-90 S5688B Q245 125-2041-92 RT1N141M
C395 168-1032-55 0.01uF K D712 001-0466-90 S5688B Q246 125-0021-91 DTA114EUA
C396 163-1053-65 50V 1uF D731 001-0466-90 S5688B Q246 125-0025-92 RN2302
C397 042-1624-00 16V 4700uF D761 001-0504-39 HZS7 B2L Q246 125-0034-92 RT1P141M
C398 163-1063-35 16V 10uF D771 001-0347-43 MA4082L Q247 125-2027-91 DTC114EUA
C399 163-1053-65 50V 1uF D772 001-0347-24 MA4043H Q247 125-2032-92 RN1302
C400 166-2201-50 22pF CH D801 001-0592-00 RM4Z Q247 125-2041-92 RT1N141M
C401 166-3911-50 390pF CH D851 001-4301-68 HZU18B1 Q248 198-3018-00 2SK3018
C402 043-0570-90 16V 2.2uF K IC121 051-6201-90 LC72146M Q249 198-3018-00 2SK3018
C403 168-5632-78 16V 0.056uF IC151 051-3034-90 NJM4558V Q391 125-2027-93 DTC144EUA
C404 043-0570-90 16V 2.2uF K IC152 051-4607-90 SAA6581T Q502 190-2071-00 2SA2071 T100
C405 188-1063-38 16V 10uF IC241 051-3367-90 NJU7780U1-33-TE2 Q503 192-4116-51 2SC4116 G,L
C406 188-1073-28 10V 100uF IC272 051-3334-00 NJM2396F09 Q503 192-4155-51 2SC4155A S,T
C407 168-1042-78 16V 0.1uF IC351 051-3034-90 NJM4558V Q503 193-1819-50 2SD1819 AR,SL
C408 166-3911-50 390pF CH IC391 051-2040-00 TA8276H Q504 192-4116-51 2SC4116 G,L
C409 043-0570-90 16V 2.2uF K IC401 051-5046-90 CL7639V20 Q504 192-4155-51 2SC4155A S,T
C410 168-5632-78 16V 0.056uF IC501 052-3220-10 E30624MGP-E48GP Q504 193-1819-50 2SD1819 AR,SL
C411 043-0570-90 16V 2.2uF K IC502 051-0869-58 NJM2103M Q505 192-4116-51 2SC4116 G,L
C412 168-1042-78 16V 0.1uF IC503 051-9402-68 BR93L56F-W Q505 192-4155-51 2SC4155A S,T
C417 178-4742-78 0.47uF IC504 051-6600-58 HA12187FP Q505 193-1819-50 2SD1819 AR,SL
C418 168-4722-55 4700pF K IC741 051-3369-00 NJM2388F84 Q506 193-2118-50 2SD2118F5 R,S
C419 178-4742-78 0.47uF J241 074-1237-69 19PIN Q701 192-4116-51 2SC4116 G,L
C420 168-4722-55 4700pF K J701 074-1194-00 13P CE-NET Q701 192-4155-51 2SC4155A S,T
C421 178-4742-78 0.47uF J721 074-1302-08 TH8P-SOCKET Q701 193-1819-50 2SD1819 AR,SL
C422 168-4722-55 4700pF K J801 074-4007-20 20P Q711 190-2071-00 2SA2071 T100
C423 178-4742-78 0.47uF L101 010-2003-04 30uH Q712 192-4116-51 2SC4116 G,L
C424 168-4722-55 4700pF K L102 010-6009-76 22uH J Q712 192-4155-51 2SC4155A S,T
C501 168-1042-78 16V 0.1uF L103 010-6009-76 22uH J Q712 193-1819-50 2SD1819 AR,SL
C502 188-4763-18 6.3V 47uF L121 010-6009-76 22uH J Q761 192-5810-00 2SC5810 TE12L
C503 168-1032-55 0.01uF K L151 010-6027-00 220uH Q762 125-0021-91 DTA114EUA
C504 168-1032-55 0.01uF K L501 010-6009-76 22uH J Q762 125-0025-92 RN2302
C505 168-1032-55 0.01uF K L502 010-6009-76 22uH J Q762 125-0034-92 RT1P141M
C506 168-1042-78 16V 0.1uF L801 010-8026-00 210uH Q763 125-2027-91 DTC114EUA
C507 188-1053-68 50V 1uF P501 076-3011-74 24P Q763 125-2032-92 RN1302
C509 168-1022-55 1000pF K Q121 191-1197-50 2SB1197K Q,R Q763 125-2041-92 RT1N141M
C510 168-1022-55 1000pF K Q122 191-1197-50 2SB1197K Q,R Q771 192-5886-00 2SC5886
C511 168-1042-78 16V 0.1uF Q123 191-1197-50 2SB1197K Q,R Q772 192-4116-51 2SC4116 G,L
C512 168-1032-55 0.01uF K Q151 125-2027-91 DTC114EUA Q772 192-4155-51 2SC4155A S,T

-7- PS-3141K-A/B
 Note) Several different parts of the same reference number are alternative parts.
One of those parts is used in the set.
REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTION
Q772 193-1819-50 2SD1819 AR,SL R250 119-3331-15 1/10W 33k ohm R537 119-1031-15 1/10W 10k ohm
Q773 192-4116-51 2SC4116 G,L R253 119-4731-15 1/10W 47k ohm R538 119-1031-15 1/10W 10k ohm
Q773 192-4155-51 2SC4155A S,T R255 119-3331-15 1/10W 33k ohm R539 119-1031-15 1/10W 10k ohm
Q773 193-1819-50 2SD1819 AR,SL R256 119-0000-05 1/10W 0 ohm JW R540 119-4731-15 1/10W 47k ohm
Q774 192-4116-51 2SC4116 G,L R258 119-4731-15 1/10W 47k ohm R541 119-5621-15 1/10W 5.6k ohm
Q774 192-4155-51 2SC4155A S,T R271 119-4731-15 1/10W 47k ohm R542 119-2231-15 1/10W 22k ohm
Q774 193-1819-50 2SD1819 AR,SL R276 119-0000-05 1/10W 0 ohm JW R544 119-4731-15 1/10W 47k ohm
Q775 192-4116-51 2SC4116 G,L R301 119-1021-15 1/10W 1k ohm R545 119-6831-15 1/10W 68k ohm
Q775 192-4155-51 2SC4155A S,T R302 119-1021-15 1/10W 1k ohm R546 119-1021-15 1/10W 1k ohm
Q775 193-1819-50 2SD1819 AR,SL R305 119-1021-15 1/10W 1k ohm R547 119-1021-15 1/10W 1k ohm
Q776 125-0021-91 DTA114EUA R306 119-1021-15 1/10W 1k ohm R548 119-1031-15 1/10W 10k ohm
Q776 125-0025-92 RN2302 R309 119-1021-15 1/10W 1k ohm R549 119-3341-15 1/10W 330k ohm
Q776 125-0034-92 RT1P141M R310 119-1021-15 1/10W 1k ohm R550 032-0140-22 1/10W 68k ohm F
Q777 125-2027-91 DTC114EUA R311 119-5631-15 1/10W 56k ohm R551 032-0140-00 1/10W 56k ohm F
Q777 125-2032-92 RN1302 R312 119-5631-15 1/10W 56k ohm R552 117-6821-15 1/8W 6.8k ohm
Q777 125-2041-92 RT1N141M R313 119-5631-15 1/10W 56k ohm R553 119-4731-15 1/10W 47k ohm
Q821 190-2071-00 2SA2071 T100 R314 119-5631-15 1/10W 56k ohm R554 119-4731-15 1/10W 47k ohm
Q822 192-4116-51 2SC4116 G,L R323 119-0000-05 1/10W 0 ohm JW R555 119-5621-15 1/10W 5.6k ohm
Q822 192-4155-51 2SC4155A S,T R324 119-0000-05 1/10W 0 ohm JW R556 119-1021-15 1/10W 1k ohm
Q822 193-1819-50 2SD1819 AR,SL R325 119-0000-05 1/10W 0 ohm JW R557 119-4731-15 1/10W 47k ohm
R101 119-0000-05 1/10W 0 ohm JW R326 119-0000-05 1/10W 0 ohm JW R558 119-1031-15 1/10W 10k ohm
R102 119-0000-05 1/10W 0 ohm JW R351 119-8211-15 1/10W 820 ohm R568 119-4731-15 1/10W 47k ohm
R103 119-1041-15 1/10W 100k ohm R352 119-1021-15 1/10W 1k ohm R569 119-4731-15 1/10W 47k ohm
R104 119-0000-05 1/10W 0 ohm JW R353 032-0140-50 1/10W 10k ohm F R572 119-4731-15 1/10W 47k ohm
R105 119-4711-15 1/10W 470 ohm R354 032-0140-50 1/10W 10k ohm F R573 119-4731-15 1/10W 47k ohm
R106 119-2221-15 1/10W 2.2k ohm R355 032-0140-50 1/10W 10k ohm F R701 116-1211-15 1/4W 120 ohm
R107 116-1001-15 1/4W 10 ohm R356 032-0140-50 1/10W 10k ohm F R702 116-6801-15 1/4W 68 ohm
R108 119-2231-15 1/10W 22k ohm R357 032-0140-50 1/10W 10k ohm F R703 119-2231-15 1/10W 22k ohm
R109 119-4731-15 1/10W 47k ohm R358 032-0140-50 1/10W 10k ohm F R704 119-2231-15 1/10W 22k ohm
R111 119-0000-05 1/10W 0 ohm JW R359 032-0140-50 1/10W 10k ohm F R711 116-2221-15 1/4W 2.2k ohm
(PS-3141K-A) R360 032-0140-50 1/10W 10k ohm F R712 117-1031-15 1/8W 10k ohm
166-8201-50 82pF CH R391 119-5631-15 1/10W 56k ohm R713 116-2221-15 1/4W 2.2k ohm
(PS-3141K-B) R392 119-1221-15 1/10W 1.2k ohm R714 119-1031-15 1/10W 10k ohm
R122 119-2221-15 1/10W 2.2k ohm R393 119-2221-15 1/10W 2.2k ohm R715 119-3321-15 1/10W 3.3k ohm
R125 119-1021-15 1/10W 1k ohm R394 119-2221-15 1/10W 2.2k ohm R726 119-1021-15 1/10W 1k ohm
R127 119-5631-15 1/10W 56k ohm R395 119-2221-15 1/10W 2.2k ohm R731 116-5621-15 1/4W 5.6k ohm
R128 119-4731-15 1/10W 47k ohm R396 119-2221-15 1/10W 2.2k ohm R732 116-4721-15 1/4W 4.7k ohm
R130 119-2221-15 1/10W 2.2k ohm R397 119-1031-15 1/10W 10k ohm R761 032-0092-56 1/8W 22k ohm F
R131 119-1031-15 1/10W 10k ohm R400 119-1031-15 1/10W 10k ohm R762 032-0092-31 1/8W 150k ohm F
R132 119-1031-15 1/10W 10k ohm R401 119-2231-15 1/10W 22k ohm R763 032-0092-51 1/8W 1k ohm F
R133 119-2221-15 1/10W 2.2k ohm R402 119-2021-15 1/10W 2k ohm R764 119-1221-15 1/10W 1.2k ohm
R134 119-2221-15 1/10W 2.2k ohm R403 119-2231-15 1/10W 22k ohm R771 119-0000-05 1/10W 0 ohm JW
R135 119-1031-15 1/10W 10k ohm R404 119-2021-15 1/10W 2k ohm R772 119-2231-15 1/10W 22k ohm
R151 119-1021-15 1/10W 1k ohm R405 119-0000-05 1/10W 0 ohm JW R773 116-1021-15 1/4W 1k ohm
R152 119-5621-15 1/10W 5.6k ohm R502 119-4721-15 1/10W 4.7k ohm R775 119-2231-15 1/10W 22k ohm
R153 119-3311-15 1/10W 330 ohm R503 119-4721-15 1/10W 4.7k ohm R776 119-2231-15 1/10W 22k ohm
R154 119-1021-15 1/10W 1k ohm R504 119-4721-15 1/10W 4.7k ohm R777 117-4731-15 1/8W 47k ohm
R155 119-3331-15 1/10W 33k ohm R510 119-4721-15 1/10W 4.7k ohm R778 119-1031-15 1/10W 10k ohm
R156 119-1031-15 1/10W 10k ohm R511 119-4721-15 1/10W 4.7k ohm R779 116-1821-15 1/4W 1.8k ohm
R157 119-1231-15 1/10W 12k ohm R512 119-4721-15 1/10W 4.7k ohm R780 117-1821-15 1/8W 1.8k ohm
R158 119-3321-15 1/10W 3.3k ohm R513 119-4721-15 1/10W 4.7k ohm R783 119-2231-15 1/10W 22k ohm
R159 119-1041-15 1/10W 100k ohm R514 119-1021-15 1/10W 1k ohm R793 119-0000-05 1/10W 0 ohm JW
R160 119-2211-15 1/10W 220 ohm R515 119-1041-15 1/10W 100k ohm R801 119-0000-05 1/10W 0 ohm JW
R161 119-0000-05 1/10W 0 ohm JW R516 119-1041-15 1/10W 100k ohm R802 119-0000-05 1/10W 0 ohm JW
R162 119-1021-15 1/10W 1k ohm R517 116-1001-15 1/4W 10 ohm R821 116-1031-15 1/4W 10k ohm
R163 119-1021-15 1/10W 1k ohm R520 119-4731-15 1/10W 47k ohm R822 119-3321-15 1/10W 3.3k ohm
R164 119-2221-15 1/10W 2.2k ohm R521 119-4731-15 1/10W 47k ohm R823 119-1031-15 1/10W 10k ohm
R165 119-5631-15 1/10W 56k ohm R522 119-4731-15 1/10W 47k ohm R824 116-2221-15 1/4W 2.2k ohm
R166 119-1231-15 1/10W 12k ohm R524 119-1521-15 1/10W 1.5k ohm R825 116-2221-15 1/4W 2.2k ohm
R167 116-3311-15 1/4W 330 ohm R525 119-1021-15 1/10W 1k ohm R826 119-8221-15 1/10W 8.2k ohm
R168 119-1031-15 1/10W 10k ohm R526 119-3311-15 1/10W 330 ohm R903 119-0000-05 1/10W 0 ohm JW
R169 119-2711-15 1/10W 270 ohm R527 119-4721-15 1/10W 4.7k ohm (PS-3141K-B)
R170 119-1021-15 1/10W 1k ohm R528 032-0140-66 1/10W 220 ohm F R904 119-0000-05 1/10W 0 ohm JW
R171 119-0000-05 1/10W 0 ohm JW R529 119-1031-15 1/10W 10k ohm (PS-3141K-B)
R172 119-1021-15 1/10W 1k ohm R530 119-1041-15 1/10W 100k ohm R905 119-0000-05 1/10W 0 ohm JW
R173 119-1031-15 1/10W 10k ohm R531 119-1031-15 1/10W 10k ohm (PS-3141K-B)
R242 119-4731-15 1/10W 47k ohm R532 119-4721-15 1/10W 4.7k ohm R908 119-0000-05 1/10W 0 ohm JW
R243 119-1021-15 1/10W 1k ohm R533 119-4721-15 1/10W 4.7k ohm (PS-3141K-A)
R245 119-3331-15 1/10W 33k ohm R534 119-1021-15 1/10W 1k ohm SUP101 060-0122-20 DSP-141N-S00B
R246 119-4731-15 1/10W 47k ohm R535 119-1031-15 1/10W 10k ohm TH711 002-0318-21 THERMISTOR
R248 119-1041-15 1/10W 100k ohm R536 119-2221-15 1/10W 2.2k ohm TM101 073-0762-90 TERMINAL

PS-3141K-A/B -8-
REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTION
TM501 073-0762-90 TERMINAL X121 061-1066-00 7.2MHz PWB 039-3294-00 PWB(WITHOUT
TM502 073-0762-90 TERMINAL X151 061-3013-00 4.33MHz COMPONENT)
TM801 073-0762-90 TERMINAL X501 060-1533-90 CSTCE10M0G52-
TM802 073-0762-90 TERMINAL RO

Switch PWB section (B2)

REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTION REF No. PART No. DESCRIPTION
C100 168-1042-78 16V 0.1uF PL100 017-0420-43 14V 40mA RED R113 119-2221-15 1/10W 2.2k ohm
C101 168-1042-78 16V 0.1uF PL101 017-0420-43 14V 40mA RED R114 119-1821-15 1/10W 1.8k ohm
C102 168-1042-78 16V 0.1uF PL102 017-0420-43 14V 40mA RED R116 119-0000-05 1/10W 0 ohm JW
C103 168-1042-78 16V 0.1uF PL104 017-0420-43 14V 40mA RED R117 119-0000-05 1/10W 0 ohm JW
C104 168-1042-78 16V 0.1uF PL105 017-0420-43 14V 40mA RED R121 119-4341-15 1/10W 430k ohm
C105 178-1052-78 1uF PL106 017-0420-43 14V 40mA RED R122 119-0000-05 1/10W 0 ohm JW
D100 001-7094-91 VFR1112H-TR PL107 017-0420-43 14V 40mA RED R123 119-0000-05 1/10W 0 ohm JW
D101 001-7094-91 VFR1112H-TR PL108 017-0420-43 14V 40mA RED R125 119-0000-05 1/10W 0 ohm JW
D102 001-7094-91 VFR1112H-TR PL109 017-0420-43 14V 40mA RED R126 119-0000-05 1/10W 0 ohm JW
D103 001-7094-91 VFR1112H-TR PL110 017-0420-43 14V 40mA RED R128 119-1021-15 1/10W 1k ohm
D104 001-7087-90 RBR1112H C,D,E PL111 017-0420-43 14V 40mA RED R129 119-1021-15 1/10W 1k ohm
RED R100 119-1521-15 1/10W 1.5k ohm R131 119-0000-05 1/10W 0 ohm JW
D105 001-7094-91 VFR1112H-TR R101 119-1221-15 1/10W 1.2k ohm R132 119-0000-05 1/10W 0 ohm JW
D106 001-7094-91 VFR1112H-TR R102 119-1221-15 1/10W 1.2k ohm R140 119-0000-05 1/10W 0 ohm JW
D107 001-7094-91 VFR1112H-TR R103 119-1521-15 1/10W 1.5k ohm R200 119-1841-15 1/10W 180k ohm
D108 001-7094-91 VFR1112H-TR R104 119-1221-15 1/10W 1.2k ohm R201 119-1841-15 1/10W 180k ohm
D113 001-0580-90 1SS352 R105 119-1221-15 1/10W 1.2k ohm R202 119-1841-15 1/10W 180k ohm
D114 001-0580-90 1SS352 R106 119-1521-15 1/10W 1.5k ohm R203 119-1841-15 1/10W 180k ohm
D115 001-0580-90 1SS352 R107 119-1221-15 1/10W 1.2k ohm TH100 002-0306-90 SC20-3J153
D116 001-0580-90 1SS352 R108 119-1221-15 1/10W 1.2k ohm TM100 073-0778-90 TERMINAL
IC100 051-6084-00 NJU6625FG1-03 R109 119-1521-15 1/10W 1.5k ohm VR100 016-0014-12 VR W/SHAFT
J100 074-3013-74 24P R110 119-1221-15 1/10W 1.2k ohm VR101 016-0014-12 VR W/SHAFT
L100 010-3406-66 22uH J R111 119-1221-15 1/10W 1.2k ohm PWB 039-3290-00 PWB(WITHOUT
LCD100 379-1363-51 INDICATOR (LCD) R112 119-2221-15 1/10W 2.2k ohm COMPONENT)

-9- PS-3141K-A/B
CONNECTION

Rear view of unit

J801
J721 J701

TEL/AUX Ce-NET
Main Connector Connector Connector
(20P) (8P) (13P)
11 12
A B C D E F G H I J 1 2 3 4 7 8 9 10
K L M N O P Q RS T 5 6 7 8 4 5 6
3
1 13 2

No Description No Description No Description No Description

A A-ANT K SR-G 1 ACC 1 GND
B ACC L SR-1 2 N.C. 2 B/U
C N.C. M SPEED PULSE 3 GND 3 L-ch (㧗)
D N.C. N N.C. AUX L-ch
4 4 N.C.
E REAR Rch(㧗) O REAR Rch (㧙)
5 N.C. 5 N.C.
F REAR Lch (㧗) P REAR Lch (㧙)
6 AUX ON 6 BUS (㧗)
G FRONT Rch (㧗) Q FRONT Rch (㧙)
7 S-GND 7 R-ch (㧗)
H FRONT Lch (㧗) R FRONT Lch (㧙)
8 AUX R-ch 8 R-ch (㧙)
I ILLUMI (㧗) S DIMMER-C
9 SYS-ACC
J BACK UP T GND
10 BUS (㧙)
11 L-ch (㧙)
12 ILL(㧗)
13 N.C.

PS-3141K-A/B - 10 -
 R111

ANT101
FM-VT

C
SUP101

C
X121 R111 0

15p
7.2MHz 808-0204-00
0 ohm (PS-3141K-A)

C121
82p CH (PS-3141K-B)

C
C169
1800p
C C103

TM101
(GI-X)

C
Resistance for model confimation

8200p 12K
1000p

Q155
C170 R166

2SK669
L101
C125 15p C

C101
R102

1000p
AM-VT 0 0V

1
IC121 C104 AM-ANT
CIRCUIT DIAGRAM

LC72146M 100 R103 0V

2
10V R164 FM-ANT
100K

2.5V
XOUT AM-LO/DX 2.2K R101 0

1
3

24
XIN AM-LO/DX
Main PWB(B1) section 1/4

CE 0V 0V C105 FM-LO/DX

2
4

23
C
CE VSS FM-LO/DX
0V 0V 0.1

R167
DO C

3
5

22
AOUT

R122 C124
DI GND

330 1/4W

C123 0.1
CL 0V 0.9V FM-VT

2.2K 1 50V LN

4
6

21
CLK AIN C107 FM-VT FM:1.4V-6.5V
DI 0V 100 R104 0 0V

5
7

20
DO PD0 GND
10V

R169 270
R170 1K 0V

R168 10K
R125

6
8

19
1K N.C PD1 GND
0V 8.0V

7
9

AM-DX

18
AM-VCC
/LO VSS 2.3V C126 100p 0V
C

8
17
10

FM-DX C
GND
0V /LO FMIN 0V C127 100p 0V(A01)
OSC OSC

9
C108

16
11

RF- FM/AM-OSC

47K
C

R128
R107
MUTE AMIN 5.2V 0.1 R105 470 FM:8.0V

10 1/4W

10
15
12
BL101

R-ON FM-VCC

- 11 -
VDD 0V C128 100p C106 0.1 8.0V
IFC C

11
14
13

AM-ON FM/AM-VCC
C
HCTR 0V AM-VT

12
13
14

L102
22uH
C
AM-VT AM:1.8V-3.4V
FM-ON LCTR C129 R106 2.2K 0V
15

GND
100p
16

FM:8.3V
L-OUT

56K
C130 0.022
C

R127
0.022

R108
C109

C
17

R-OUT

FM:8.3V
22K
C131 47 16V
BL101

18

N.C
19

GND

L121
IFC

22UH
AM/FM:0.2V R165
20

ST/REQ SEEK:5.1V
56K
FM:0.2V

Q121
21

R130 VSM AM:4.6V/FM:3.0V

2SB1197
2.2K SD-CONT

10K
22

R131
SD/ST-IND
SD/ST
R109
23

AM-LO/DX SNC-IN/(RDS)NC-IN
47K AM:1.2V
24

DET-OUT FM:4.1V
25

FM/AM-VCC
C112 0.47 C AM:0V
26

MUTE-DRIVE
R133 R171 0 FM:0V

10K
TUNER PACK for model confimation

D101 VSM

Q156
R132
2.2K
941-0221-80 (PS-3141K-B)
941-0215-80 (PS-3141K-A)

MA729

DTA114EUA
Q122
AM/FM:8.3V

2SB1197

C151
R134 33
2.2K 10V
Q151
R172 1K
A01

Q123

Q157
DTC114EUA

SEEK:0V
2SB1197

ST.6:0V SD-S-UP

DTC114EUA
10K
R135

MONO:5.2V
FM-LO/DX
C132 180p C
R173 10K

C154 0.1
C
1K
R151

PS-3141K-A/B
Q159 RN1902

AM/FM:8.3V

1
8
VCC
1

2
7
C

C152

3
6

RDS-MUTE R154 1K
C

4
5

GND
R155 33K

Q153
C

IC151 DTA114EUA
NJM4558V
C155 0.022

C157 0.022
C
R156 10K
Q152

R157 12K
L103
22uH
2SC4116

C156 680p

R158 3.3K
C158 820p Q158
C DTC114EUA R152
D151 1SS352 5.6K
330
R153

0.1
C

C133

D152
4.7

1SS352
35V
C153

R159 100K
C

C159 0.01 C
0.022
C171

R160 220
C113 0.068 C
Q154

C114 0.068 C
C

DTC114EUA

RDS-DCHG
330p
C166

NOISE-IN

L151 220uH

C161 47 6.3V

IC152
C162 SAA6581T
C
0.1
RADIO-L
RADIO-R

XTAL-MODE
S-GND(1)

AUDIO+B(1)

9
8
0.01
C

C164

SC-OUT
C
560p

7
C163

10

TEST SC-IN
6

11

D-VSS A-VSS
C165 C To Main PWB 2/4 (page 12)
5

D-VDD A-VDD
12

56p
4

MPXIN
13

XIN
C
3

XOUT
14

VREF
X151
C167
2

T-57K
15

C168 4.332MHz R161

56p 0 2.2 50V
RDS-DATA
RDS-CLK
1

RDS-CLK
16

R162 1K QUAL-IND

RDS-DATA
R163 1K

C160 0.1
C
DI
CL
CE
DO
VSM

SD/ST
SD-S-UP
RDS-CLK
NOISE-IN

SD-CONT
RDS-DATA
NOISE-IN

PLL-DI
PLL-CL

U-GND(1)
PLL-CE

SYS+5V(1)
PLL-DO
SD/ST
RDS-CLK

S-METER
RDS-MUTE RDS-MUTE

SPEED-UP
RDS-DATA

SD-CONT
RDS-DCHG RDS-DCHG

To Main PWB 3/4 (Page 13)

 Main PWB(B1) section 2/4
J241
1 CD-9V
9.0V
2 CD-9V
2.8V(D03) R243 1K
3 REQ
3.3V
To J1 of CD mechanisum (page M13)

4 SYS-ACC
5 SCL
3.3V(D03) A01 D01
6 N.C
: Flat wire 816-4055-50

3.3V(D03)
7 SDA
8 N.C Q246
DTA114EUA
13.2V
9 B/U
3.3V
10 RESET
3.3V
11 VDD-3.3V
0V C C241 0.022
12 P-GND
13 P-GND 0V

R245 33K

R242
47K
C
14 R-CH
C306 1
15 A-GND
0V C C305 1
16 L-CH
0V
17 D-GND
C403 0.056

R250 33K
D03
C
18 N.C

R253 47K
R256 0

R255 33K
R246 47K
R306 1K
R305 1K

R258
10 16V
R402 2K

47K
19 N.C

C404

C405
Q244

2.2
C406 100 10V 2SC4116
C C
C407 0.1

C402
C
R401 C401

2.2

8.4V
GIX-SDA

3.8V
GIX-SDA

0V
22K 390p E-VOL

2SK3018
DTC114EUA
GIX-SCL

Q248
GIX-SCL

R248 100K
42 41 40 39 38 37 36 35 34 33 32 31 30 29

2SK3018
AGND

Q247
AVCC
GVL

3.8V LOUDL
3.8V TONEL

Q249
GIX-SACC GIX-SACC

N.C

N.C

N.C

N.C

N.C

N.C
VREFIN
3.8V(A01) VOLINL

3.8V FADINL

To Main PWB 3/4

3.8V (A01)

DTC114EUA
C311 2.2 50V R311 56K

G
L(+) R323
43 DEFL+ FLT 28 GIX-RST GIX-RST
0

Q245
C312 2.2 50V R312 56K 3.8V (A01)

(Page 13)
G
L(-)
GIX-REQ

3.8V (A01)

D
44 DEFL- FLOUT 27 GIX-REQ

S
R(+) C313 2.2 50V R313 56K 3.8V (A01) C417 FL Q243
C
45 DEFR+ FLFILL 26 0.47

D
S
2SD601A
R(-) C314 2.2 50V R314 56K 3.8V (A01) C C418 R325
46 DEFR- FLFILH 25 U-GND(2)
C301 1 R301 1K 3.8V (A01) 4700p 0
AUX-L C
47 AUXL RLOUT 24

GIX-SACC
3.8V (A01) C419

GIX-REQ
C302 1 R302 1K RL

GIX-SDA
GIX-RST

GIX-SCL
AUX-R C C
48 AUXR RLFILL 23 0.47
C
49 N.C IC401 RLFILH 22
CL7639V20
50 N.C N.C 21 C420 R324
3.8V (A01) 4700p 0 SYS+5V(2)
51 CDL FROUT 20
3.8V (A01) C421 FR

0Vor5.1V (D01)
0Vor5.1V (D01)
C
52 CDR FRFILL 19 0.47
3.8V (A01)

3.8V (A01)
53 N.C FRFILH 18
C C422
C309 4700p GIX VDD+3.3V
R309 54 N.C RROUT17 SYS+3.3V
0.018
5.1V

1K 3.8V (A01) C423

3.8V
3.8V
3.8V

C C R326 RR GI-X
0V
55 FML RRFILL 16 0.47

C
0
3.8V (A01) Q241
FADINR

C C 4 5
VOLINR

CLOCK
TONER
LOUDR

56 FMR RRFILH 15 DTA114EUA

VDDD

DGND
DATA

IC272

C244 0.1
R310
GVR

N.C

N.C
N.C

C310 N.C C424

1K IC241 NJM2396F09
0.018 1 2 3 4 5 6 7 8 9 10 11 12 13 14 N.C 4700p

47 16V
NJU7780U1-33 4 3 2 1
To Main PWB 1/4

C243
C346 100 10V
C

C409

RADIO-L 3 2 1
2.2

0V
5.2V

9.0V
13.2V
C411
(Page 11)

C335 470p

C
C318 1500p
C319 1500p

C
C334 470p

2.2

RADIO-R

0V
3.3V

0.1 50V
C408
390p

C212

C276
C410 0.056

C
AUDIO+B(1) R404 2K C245 47
C

To Main PWB 4/4

C
Q242 0.1 16V
S-GND(1) R403 22K R276 0 13.2V B/U(2)
DTC114EUA C

(Page 14)
AUX-R R271

C222
C

0.1
CLK

VOL-DATA 47K

C274
220
10V
U-GND
0V P-GND(2)
SYS+5V R405 0
C
C C412
To Main PWB 3/4

VOL/EQ-CLK C355 22p 0.1

CLK
C357

IC391
C

10p

MAIN-POWER
(Page 13)

VOL-DATA VOL-DATA R356 10K 1% TA8276H

R353 10K 1%

PRE-GND

DIAG-OUT
P-GND2

P-GND1

P-GND3

P-GND4
AUX-IN
OUT2+

OUT1+

OUT3+

OUT4+
OUT2-

OUT1-

OUT3-

OUT4-
ST-BY

MUTE
VCC2

VCC1
R358 TEL/AUX-R

TAB

RIP

IN2

IN4
IN3
C359

IN1
10K 1% 10
AMP-MUTE AMP-MUTE 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25
8.4V
4.6V
4.6V
4.6V

16V
R351 820

AMP-ON AUX&TEL
0V
0V
6.1V
4.9V
RL+ 6.1V
13.2V
AMP-ON

FL+ 6.1V

1.4V
1.4V

1.3V
6.1V

6.1V
6.1V
0V
C

7.5V

1.4V
1.4V

0V
0V

6.1V
RR- 13.2V

6.1V
FR+ 4.1V

0V
R354 10K 1%
C353 220 10V

8 7 6 5
VCC

NJM4558V

BEEP
R357

BEEP
10K
1%
C352 0.1

IC351

RR+
RL-

FL-

FR-
GND

AUDIO+B(3)
R352 1K

C358

R-CH(-) 1 2 3 4
16V

R(-)
10
To Main PWB 4/4

0V

R-CH(+) R(+)
4.6V
4.6V
4.6V

TEL/AUX-G AMP-ON R397 B/U(3)

(Page 114)

L-CH(-) L(-)
10K R393 2.2K

C395
C391 0.1

R396 2.2K

0.01
FL C
L-CH(+) L(+) FL+ FL+

To Main PWB 4/4

RL C392 0.1 R394 2.2K C399

R400
TEL/AUX-L

10K
C
AUX-L R359 C360 1 FL- FL-
10K 1% 10 FR C393 0.1

(Page 14)
C356

C 50V
10p

16V FR+ FR+

TEL/AUX-L TEL/AUX-L

1SS352
RR C394 0.1 R395 2.2K

D391
C
R355 R360 C361 FR- FR-
TEL/AUX-R TEL/AUX-R 10K 1% 10K 1% 10 16V BEEP
C

C RL+ RL+
TEL/AUX-G TEL/AUX-G R391 Q391
R392

1 50V

C397
4700
C400
1.2K

C396

16V

DTC144EUA RL-
C398
RL-
22p

C354 22p 56K 16V

10
C

RR+ RR+
RR- RR-
AMP-MUTE
GND(3)

- 12 - PS-3141K-A/B
 Main PWB(B1) section 3/4

D01

B/L(+)
B/L(-)
VLCD
P501
LCD-TH
24 N.C 0V or 5.2V (D01)
23 N.C
R502 4.7K CD-EJ
22 CD-EJECT ANT-ON
R503 4.7K LOAD D506 ANT
TM501 TM502 CATS TP R542
21 CD-LOAD M1F60

To Main PWB 4/4

R504 4.7K 22K SR SR
P-SW

R515

R516
100K

100K
20 POWER-SW
R531 10K SR-G SR-GND

(Page 14)
VOL2-R
19 VOL2-R

C515
100p
B/L-ON B/L-ON
VOL1-R
To J100 of Switch PWB (Page 17)

C
18 VOL1-R

RX
TX
VOL2-L
17 VOL2-L R532 4.7K VLCD-ON
VOL1-L 5.2V VLCD-ON

SPD
16 VOL1-L VDD+5V
SPEED

AMP-MUTE
SYS+5V

AMP-ON
SYS-ACC
LCD-REQ

SYS-ON

GIX-SDA
GIX-SCL
15 LCD-REQ Q506

EEP-DO
Q502 2SA2071

VLCD-ON
R533 4.7K SYS-ACC

GIX-SACC

0V RDS-DCHG
EEP-CS
GIX-RST

0V RDS-MUTE
EEP-CL
2SD2118 SYS-ACC

0V RDS-DATA
LCD-DATA

EEP-DI

S-UP
5.2V
14 LCD-DATA
LCD-SCL T/A-ON TEL/AUX-ON
D508

13.2V
R548
13 LCD-SCL

10K
S5688B

6.8K 1/8W
LCD-CS BUS+ BUS(+)

3.3V
3.3V

4.5V
12 LCD-CS

R552
C
BUS(-)

0V
0V
0V
0V

0V

0V
LCD-RESET 3.3V BUS-

10 1/4W

1SS352
11 LCD-RST

R517

D505

C514 0.1
C513 100 10V
50

49

48

47

46

RDS-MUTE 45
(FLASH-CE)/SPEED-UP 44
RDS-DCHG 43
RDS-DATA 42
41

CATS-TP 40
(FLASH-EPM)SYS-ACC 39
N.C 38
AMP-MUTE 37
AMP-ON 36
SYS-ON 35
GIX-SCL 34
GIX-SDA 33
ILL-DET 32
N.C 31
N.C 30
N.C 29
TX 28
RX 27
N.C 26
0V

6.5V
CCT505

R547
10 U-GND

R546
N.C

1K
1K
5.2V 3.3V RX
1Kx4
9 SYS+5V

51

25
GIX-RST
B/L ON:7.5V BEEP BEEP
8 B/L(+) 52

24
VLCD-ON

HZS7A1L
0V

L501 22UH
VOL-DATA R536

0.1F 5.5V
7 B/L(-)

D509
53

23

2SC4116
N.C VOL-DATA

16V
C516
2.2K

10
Q503
ILL ON:13.2V

C517
CLK
6 ILL(+)
54

22
N.C VOL/EQ-CLK
0V

R535
10K
5 ILL(-)
55

21
N.C N.C
6.4V U-GND
56

20
4 VLCD+6.3V N.C N.C

EEP-DO
GIX-SYSACC

EEP-CS
EEP-CL
0V EEP-DI 5.2V B/L-ON SYS+5V
3 P-GND
57

19
N.C B/L-ON
SPD C C503

SYS-ON
58

18
2 LCD-TH N.C SPEED 0.01
R541 5.6K
59

17
1 P-GND N.C B/U-DET

To Main PWB 2/4

5.2V C502
60

16
VDD ACC-DET R537 10K 47 6.3V

BUS+
BUS-

(Page 12)
C
61

15
N.C IC501 NMI X501
M30624MGP-E48GP 10MHz C505 L502
62

14
GND VDD 0.01 22UH

C
C501 5.2V
63

13
- N.C XIN 0.1
CLK VOL/EQ-CLK
64

12
N.C GND
EEP-CS VOL-DATA VOL-DATA
65

11
N.C XOUT

5.2V

2.5V
2.5V
EEP-CL
AMP-MUTE
66

10

C
N.C RESET AMP-MUTE
GIX-SDA GIX-SDA

C
To Main PWB 2/4

AMP-ON
67

N.C N.C

9
4 3 2 1 8 7 6 5 AMP-ON

C511 0.1
C512 0.01

HA12187FP
ANT

VDD
BUS+
GIX-SCL

STB
GIX-SCL

GND BUS-
ANT-ON/CHECK-TP
0V or 5.2V (D01)

BEEP
68

N.C

8
BEEP
(Page 12)

IC504
R538 10K
GIX-SACC GIX-SACC

R539 10K
CNVSS IC503
69

N.C

OUT
GIX-RST BR93L56F

IN1

IN2
GIX-RST N.C BYTE
70

6
GIX-REQ 5 6 7 8 1 2 3 4
GIX-REQ N.C
71

N.C

5
C

0V

0V

0V

0V
GIX-REQ

0.1V
EEP-DO
SYS+5V(2) 5.2V

EEP-DI
CD-SBSY 2.8V N.C
72

4
C504
5.2V

U-GND(2) 0V RDS-CLK PLL-CE 0.01

93 S-REMOCON

RDS-CLK PLL-CE

RX
95 TEL/AUX-ON
73

TX
3
87 POWER-SW

PLL-DO
LCD-DATA

89 CD-EJECT

LCD-

99 SD-CONT
78 LCD-REQ

88 CD-LOAD

91 NOISE-IN

PLL-DO
74

2
RESET
VOL1-R
VOL2-R
VOL1-L
VOL2-L

LCD-RESET PLL-CL PLL-CL

98 SD/ST
97 AVCC
94 AVSS

96 VREF

LCD-CS
83 SEL1

84 SEL2

85 SEL3

86 SEL4
75

1
92 VSM

PLL-DI
90 N.C

NOISE-IN NOISE LCD-CS

LCD-

CCT501
SCL

100
76

77

79

80

81

82

RDS-DCHG RDS-DCHG 1Kx4 R554

RDS-CLK 5.2V 47K
RDS-CLK
R514 1K

CCT504

R529 10K
R525 1K

R527 4.7K

RDS-DATA SYS+5V(5)

To Main PWB 4/4

RDS-DATA
1Kx4

R530 100K

R550 68K 1%
RDS-MUTE B/U(4)
R568 47K SEL4

R569 47K SEL3

R572 47K SEL2

SEL1

R544
RDS-MUTE

47K
To Main PWB 1/4

(Page 14)
S-METER VSM R534 1K ACC(4)

R553
47K
LCD-DATA
R573 47K
(Page 11)

SD-CONT
LCD-REQ
LCD-SCL

SPEED-UP S-UP D507 ILL+13V

VOL1-R
VOL2-R

5.2V
2.3V
VOL1-L
VOL2-L

T/A-ON
NOISE

PLL-DI
CD-EJ

SD/ST
LOAD

HZU4.7B1
P-SW
SEL1
SEL2
SEL3
SEL4

SD-CONT
VSM

SD-CONT ILL(+)
SR

SD/ST 8 7 6 5
SD/ST

C510 1000p
ILL(-)

C506 0.1
IC502
1SS352
D504

NJM2103M

R557
47K
R551 56K 1%

2SC4116
C
R512 4.7K
R511 4.7K

PLL-CE PLL-CE
SR-G

Q504
1.6V

2.2V
R528 220 1%
R520 47K
R521 47K

R522 47K

PLL-DO PLL-DO 1 2 3 4

C
R540
R524 1.5K

R555
R526 330

2SC4116
0V
47K

0V
PLL-CL PLL-CL 5.6K

Q505
R513
4.7K
R510
4.7K

PLL-DI PLL-DI

R556

R558
10K
1K
1 50V
SYS+5V(1) 5.2V

C507
R549
330K

C
U-GND(1) 0V

1000p
R545

C509
68K
- 13 - PS-3141K-A/B
 Main PWB(B1) section 4/4

RR+

FR+
RL+

FL+
R821 10K 1/4W

ANT+B
ILL+ Q821
13.2V 2SA2071
J801 13.2V
Q711 L801

13.2V
12.5V

13.2V

13.2V
S5688B

6.1V

6.1V

6.1V

6.1V
2SA2071 210UH

D731
13.2V

R823
No Description No Description

10K
P
A A-ANT K SR-G

C821 10 16V
FL+

C811 0.1
A B C D E F G H I J FL+

R712
B ACC L SR-1

10K

R826 8.2K
FL-

TH711
R731
1/4W
5.6K
FL-

1/4W
C M

2.2K 1/4W

2.2K 1/4W
N.C. SPEED PULSE
K L M N O P Q R S T FR+ FR+

R825
R824
D N.C. N N.C.

2SC4116 S5688B
FR- FR-

R732 4.7K
REAR Rch (㧙)

D712
E REAR Rch(㧗) O

R711

R713
1/4W

1/4W
2.2K

2.2K

0V

0V
5.0V
0V
REAR Lch (㧙) RL+ RL+

6.1V

6.1V

6.1V
F REAR Lch (㧗) P
G FRONT Rch (㧗) Q FRONT Rch (㧙) RL- RL-
P

RM4Z

To Main PWB 2/4

D801
R801
Q712
C732 1 50V

H RR+
C731 0.1

FRONT Lch (㧗) R FRONT Lch (㧙) D851 RR+

R802

R822 3.3K
HZU18B1

0
S5688B

(Page 12)
I ILLUMI (㧗) S DIMMER-C RR-

RR-
RR-

FR-
RL-
D711

FL-
Q822

R715
3.3K
R714
2SC4116

10K
J BACK UP T GND
GND(3)

B/U(3)

SR-G
AUDIO+B(3)

SPD
ANT

SR
TM801 TM802

R793 0
B/L(+)
B/L(-)

VLCD+6.3V BACK-LIGHT AUDIO+8V

VLCD Q761 2SC5810 13.2V Q771 2SC5886 13.2V IC741

NJM2388F84
To Main PWB 3/4

LCD-TH

To Main PWB 2/4

R773
1K 1/4W 13.2V 1 2 3 4
ANT-ON P-GND(2)
(Page 13)

ANT R763 R764 Q762

(Page 12)
DTA114EUA

0V
1K 1% 1.2K DTA114EUA

13.2V
8.4V

5.0V
SR SR D772 Q772

R779

Q776
1/4W
R777
MA4043H

1.8K
47K
22K 1%

2SC4116 Q774

2SC4116
SR-GND
R761

SR-G 2SC4116
C771 100 10V

Q775
B/U(2)
C772 10 16V

SPEED SPD
D771 MA4082L

Q773

C
C762 10 16V
D761 HZS7B2L

R775 22K

R776 22K
2SC4116 Q777

C774 4.7
B/L-ON

C744 100 10V

B/L-ON DTC114EUA

50V
DTC114EUA

R780
1.8K
150K 1%

R778 10K
VLCD-ON VLCD-ON

C773 0.1
Q763

R771 0
R762
10 16V

C741 0.1
C761

SYS-ACC SYS-ACC

C
TEL/AUX-ON T/A-ON R772
22K
BUS(+) ILL+13V

To Main PWB 3/4

BUS(-)
VLCD-ON B/L-ON ACC(4)

(Page 13)
ILL(-)
SYS-ACC

T/A-ON SYS+5V(5)
R783 22K

J721 ILL(+)

13.2V

4.0V
No Description R701

0V
B/U(4)
1 GND Ce-NET 120
R726 1K

2 B/U 1/4W
R704

R-CH(-)
1 2 3 4
22K

R(-)
3 L-ch (㧗) J721
To Main PWB 3/4

R(-)
D702 MA4180
D701 MA4180

R-CH(+) R(+)
4 N.C.
0.1V
3.8V

L(-) 3.8V No Description

(Page 12)

L-CH(-) L(-)
JW for model distinction
5 N.C. 5 6 7 8 1 ACC
L-CH(+) L(+) 6 BUS (㧗) R702
11 12 68 Q701 2 N.C.
D703 MA4180

R-ch (㧗)
4.0V
7 3.8V 2.5V 1/4W 2SC4116
TEL/AUX-L
3 GND
TEL/AUX-L 8 R-ch (㧙) 7 8 9 10
R(+) 4 AUX L-ch
TEL/AUX-R 3.8V 2.5V
TEL/AUX-R 9 SYS-ACC 3 4 5 6 5 N.C.
R703 22K

TEL/AUX-G 10 L(+) 6
BUS (㧙)
R908 0

TEL/AUX-G AUX ON
R904 0

R905 0
R903 0

1 13 2
TEL/AUX-G

TEL/AUX-R

TEL/AUX-L
11 L-ch (㧙) 7 S-GND
C722

8
0.1

12 ILL(㧗) J701 AUX R-ch

C

13 N.C.

REF.No PS-3141K-A PS-3141K-B

R903 No use 0 ohm JW
R904 No use 0 ohm JW
R905 No use 0 ohm JW
R908 0 ohm JW No use

- 14 - PS-3141K-A/B
PRINTED WIRING BOARD
Main PWB(B1)section 1/2 J801
J721 No Description No Description
A A-ANT K SR-G
No Description
B ACC L SR-1
Ce-NET 1 ACC C N.C M SPEED PULSE
3
2 N.C.
GND
D N.C N N.C T S R Q P ON M L K
E REAR R-ch (+) O REAR R-ch(-)
2 13 1 4 AUX L-ch (+) F REAR L-ch (+) P
J I H G F E D C B A
87 65 REAR L-ch (-)
6 5 4 3 5 N.C. G FRONT R-ch (+) Q FRONT R-ch (-)
10 9 8 7
4 321 6 AUX-ON H FRONT L-ch (+) R FRONT L-ch (-)
7 S-GND I ILLUMI (+) S DIMMER-C
12 11 8 AUX R-ch (+) J BACK UP T GND

J701 IC Q
No Description
J701 IC391
1 GND IC391
1 2 24

R701
R702
2 B/U 2 13 J801

R393
R394
R395
R396
C395
R392
C400
J721
3 L-ch (+) 6 5 4 3 1 25

D801
4 N.C. 10 9 8 7
5 N.C. 12 11 ANT101

R397

C398
6 BUS (+) C396

R391
C394
C393
C391
C392
7 R-ch (+) Q701
8 R-ch (-) D851
D703 T S R Q P O N M L K Q701
8 7 6 5

D701
D702
9 SYS-ACC

L801

808-0204-00
R703
10 BUS (-) 4 3 2 1 C722

R726
R704

C811
J I H G F E D C B A

SUP101
11 L-ch (-) C397
TM101
12 ILL (+)
D711
13 N.C. D506

TH711
D391 R400
D712

C731
R825
R824

C732
R823
Q821
C359

Q822
C361 C360 Q391 Q711 R713

L101
R731
R732
R821
C399 C821

Q771
Q391

R711
C212 R111
Q771 Q821 Q711
TM802

Q822
C358

R826 Q712

D731
R908 R793 R822 Q712

R773
R779

R715
R714
TM801 R712

D772
D771
R102

R777
C772

Q775
1
4

C741 C353 Q775

D101
R103

C771
R358

R780
C357 R353

Q774
R354
REF.No

R359
R101 PS-3141K-A PS-3141K-B
Q774

Q156
R351R352 R771 R164 C101 Q156

R778
C773
IC741

R111 0 ohm JW 82p CH

C774
Q776 Q777 IC741 Q776 Q777
C314 R356 R357

Q763

Q157
R764
R355 R360
C354 C356

R783
Q761
C744 IC351 R775 Q763 Q157
Q772 5 IC351 Q761 Q772
1

R104

R169
R166
R122
R776 Q762
1

C355 C352 Q762 R168 C103 Q773

C762
Q773

Q155
C761
C104

R772
Q155
D761 C105
C274

C123
R170
C169
C170
C124
R761
C313

C346

R763 R167 R107

R549
R904
R905
R903

Q122 Q121
10
4

C121
C507
R762
R326

C107 R105 Q121

R325
C312

R271 C509
R324

24 13

BL101
R323

R539

X121
R545
IC272

IC121 C108 IC272 IC121 Q122

R544

5 8
IC502
13
C276

1 12
C311

C417

C419

C421

IC502 Q123
C418

C420

C422

R547
R546
L103

C125
C406

4
C106 L102

R551

R106
C506
R550
C510

Q123
C133 C131
1

C126

R548
C424

R125 R128
C423

C109
C127

L121
R130 15 REF.No PS-3141K-A PS-3141K-B

R540

R108
Q503 C130 R131 Q503
28 15 C129 R133 BL101 941-0215-80 941-0221-80 Q502

C152
C407 R535 C128
29

14

R132
C405

R536

C132
Q502 R127
D509

R153
R134
C516

R151
IC401

R135

R542
C412 R405 L502 IC401
D507
C403

R552 C404 C411 R555

C410

REF.No PS-3141K-A PS-3141K-B R402 R403 D505 C512 R553 C161 C153 Q504
C502
42

C408
C401

20

R152C171
R404

No use
1

R903 0 ohm JW
R311 R537 Q504 R556
C513

43 56 C515

R802
R801
5

4
D508

R401

R904 No use C503 Q158 Q158 Q506

IC504

0 ohm JW R312 R165

C163
C504 R171 IC504

R109
R313 C402 C409
R305
C319
C318
R306

R309
R310

R905 No use 0 ohm JW Q506 R517 C501

C514

R541
R314 L151
8

0 ohm JW No use C244

R908

R530
R526
C505

8
R528
R538
X501
R558

9
L501 Q153 Q153 Q152

C166 C164
C160
C113
C114

C162

R534
IC241

R554
R557

R173
Q505

IC152
CCT505

R161 C165
25 1 IC152 IC241 Q505
25 Q159

100
Q159 Q151
26
Q242 C309
C310

D504

X151
C305
C306
R302 C301
C334 C302

R533
R532

26

R162
C243 C112

R156 R163 16
R524
C511 R516

R527
R529

1
C517
C245
R276

R258
Q241
R253

C151

C167 C168
1

8
R301
C335

IC501 R525 IC501 Q242

IC503

Q241 CCT504

R157
C157
IC503

C154
4

5
R515
R531

R255 Q249 Q248

8 5

1 4
50

76

R242

C158
R250 R256 IC151
R245

Q249
Q248

IC151
Q244 51 75 Q244
Q243 R521 Q152 Q243 Q245 Q246
CCT501 Q247 Q154
Q245
R246
R243

R520 R522
Q247
Q246

R248 R154

R573
R569
R514
R510
R511
R512
R513

Q151
R159 R568

C155 R572
R504
R502
R503
R172
TM502

C222
C241 COMPONENT SIDE

Q154
R160
C159
D152
D151
R155
C156
R158
1 24
P501
TM501
Caution:
1 J241 19 COMPONENT SIDE: Parts on the component side
seen from the component side are indicated.

FLAT WIRE
To J1 of CD Mechnism (page M14) To J100 of Switch PWB
816-4055-50
(page 18)

- 15 - PS-3141K-A/B
Main PWB(B1) section 2/2

J721
̪ The parts of adotted line express the parts on a component side. No Description
Ce-NET
1 ACC
2 N.C. 11 12
3 GND
A B C D E F G H I J 4 AUX L-ch (+)
7 8 9 10
5
123 4 3 4 5 6
N.C.
K L M NO P Q R S T 6 AUX-ON 56 78 1 13 2
SOLDER SIDE 7 S-GND
8 AUX R-ch (+)
J801 J701
No Description No Description
A A-ANT J701 1 GROUND
B ACC IC391
24 2 2 B/U
C N.C J801 1 13 2
J721 3 L-ch (+)
D N.C 3 4 5 6
25 1 4 N.C.
E REAR R-ch (+) 7 8 9 10
F 5 N.C.
REAR L-ch (+) 11 12
G FRONT R-ch (+) 6 BUS (+)
H ANT101 7 R-ch (+)
FRONT L-ch (+)
ILLUMI (+) 8 R-ch (-)
I
K L M N O P Q R S T

GND
ANT SRG
9 SYS-ACC

L801
J BACK UP 5 6 7 8
K SR-G 10 BUS (-)
L SR-1 A B C D E F G H I J 1 2 3 4 11 L-ch (-)

B/U
M SPEED PULSE TM101 12 ILL (+)
N N.C 13 N.C.
O REAR R-ch(-)
P REAR L-ch (-)
Q FRONT R-ch (-)
R FRONT L-ch (-)
S DIMMER-C

TM802
T GND

TM801
1

IC741
5

1
10

4
BL101

X121

IC272
13

1
15

20

25
X151

26
C517

CATS TP CATS

TM502
Caution:
SOLDER SIDE: Parts on the solder side seen TM501
from the solder side are indicated.

- 16 - PS-3141K-A/B
CIRCUIT DIAGRAM
Switch PWB (B2) section

COMMK
COM1
COM2
COM3
COM4
COM5
COM6
COM7
S1
S2
S3
S4
S5
S7
S8
S9
S10
S11
S13
S14
S15
S16
S17
S19
S20
S21
S22
S23
S25
S26
S27
S28
S29
S31
S32
S33
S34
S35
S37
S38
S39
S40
S41
S43
S44
S45
S46
S47
S49
S50
S51
S52
S53
S55
S56
S57
S58
S59
S61
S62
S63
S64
S65
S67
S68
S69
S70
S71
1

10

20

30

40

50

60

70
J100 LCD100
0V TM100
1 P-GND
2.4V
2 LCD-TH TH100
0V
3 P-GND
6.4V
4 VLCD+6.3V
0V
5 ILL(-)
To P501 of Main PWB 3/4 (page 13)

13.1V
6 ILL(+)
7 B/L(-)

R106 1.5K

R108 1.2K

R109 1.5K
R110 1.2K
R111 1.2K

R112 2.2K
R113 2.2K
R114 1.8K
R107 1.2K

S58
S57
S56
S55

S53
S52
S51
S50
S49

S47
S46
S45
S44
S43

S41
S40
S39
S38
S37

S35
S34
R100 1.5K

R101 1.2K
R102 1.2K

R103 1.5K
R104 1.2K
R105 1.2K
7.5V
8 B/L(+)

PL110
PL109
PL100

PL101

PL102

PL104

PL105

PL106

PL107

PL108

PL111
5.2V
9 SYS+5V
0V
10 U-GND
11 LCD-RST LCD-RST
75 74 73 72 71 70 69 68 67 66 65 64 63 62 61 60 59 58 57 56 55 54 53 52 51
LCD-CS

S58
S57
S56
S55
S54
S53
S52
S51
S50
S49
S48
S47
S46
S45
S44
S43
S42
S41
S40
S39
S38
S37
S36
S35
S34
12 LCD-CS
LCD-SCL S59 S33
13 LCD-SCL 76 S59 S33 50

D100

D101

D102

D104
D103
LCD-DATA 77 S60 PIN14 to 96:0V or 5.2V (D05) S32 49
S32
14 LCD-DATA PL100㨪PL102 , PL104㨪L111 ----------- 017-0420-43 (14V 40mA RED) x11
LCD-REQ S61 S31
15 LCD-REQ 78 S61 S31 48

D107

D108
S62

D105

D106
16 VOL1-L V1-L 79 S62 S30 47
D100㨪D103 , D105㨪D108 ----------- 001-7094-91 (VFR1112H-TR) x8
V2-L S63 S29
17 VOL2-L D104 ---------- 001-7087-90 (RBR1112H C.D.E RED) x1 80 S63 S29 46
V1-R S64 S28
18 VOL1-R 81 S64 S28 45
V2-R S65 S27
19 VOL2-R 82 S65 S27 44
P-SW S26
20 POWER-SW 83 S66 S26 43
CD-LO S67 S25
21 CD-LOAD 84 S67 S25 42
CD-EJ S68
22 CD-EJECT 85 S68 S24 41
S69 S23
23 N.C 86 S69 S23 40
KS3

KS1

KS0
KS2
S70 S22
24 N.C 87 S70 S22 39
S71 IC100 S21
88 S71 NJU6625 S21 38
P-SW

CD-LD

COM1 S20
CD-EJ

V1-R

V2-R
V1-L

V2-L

89 COM1 S20 37
COM2 S19
90 COM2 S19 36
COM3
91 COM3 S18 35
KI0
COM4 S17
0Vor5.2V (D01)

92 COM4 S17 34
R117

COM5 S16
0
R131

93 COM5 S16 33
0

COM6 S15
94 COM6 S15 32
COM7 S14
95 COM7 S14 31
KI1 COMMK S13
96 COMMK S13 30
C100 0.1 1.6V
VR100(2/2)

VR101(1/2)

C
VR100(1/2)

VR101(2/2)

OSC1 2.6V (A01)

97 V4 S12 29
R122 0

A B A B C101 0.1 C 3.2V S11

98 V2 S11 28
C C C102 0.1 C 4.7V 0 or 5.2V (D01) S10
99 V1 S10 27
C103 0.1 5.2V

S1/KS0
S2/KS1
S3/KS2
S4/KS3
S5/KS4
S6/KS5
S7/KS6
S8/KS7
RESET
C VLCD2 S9
S9 26

DATA
100

VLCD1
KI2

REQ
VDD

VSS
SCL

KI0
KI1
KI2
KI3
CS
P0
P1
P2
P3
L100 22UH
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25
R116 0
R126 0
R125 0
R132 0

6.4V

5.2V

0V
R128 1K

R129 1K
R123

KI3
0

C105 1

R140
C

0
KI2
C C104 0.1
KS1

LCD-DATA

S2
S3
S1

S4

S8
S5

S7
LCD-REQ

LCD-RST
LCD-SCL
LCD-CS
R121
430K

D113 1SS352
D114 1SS352
D115 1SS352
D116 1SS352
R200 180K
R201 180K
R202 180K
A01 D01 D05 R203 180K

KS0
KS1
KS2
KS3
KI0
KI1
KI2
KI3
- 17 - PS-3041K-A/B
PRINTED WIRING BOARD
Switch PWB(B2) section

COMPONENT SIDE ̪ The parts of adotted line express the parts on a component side.
SOLDER SIDE

RUBBER SW (R) PL100

(345-5591-00)
PL101

R126
PL102

R131
R132
VR101

R116
PL104

Caution:
COMPONENT SIDE: Caution:
Parts on the component side seen SOLDER SIDE:
TH100
from the component side are indicated. Parts on the solder side seen

70
70

D100 from the solder side are indicated.

R102

24
PL105

23
R101

To P501 of Main PWB

R100
R105
R104

(Page 15)
R103
D105

R114
R113

J100
R112

C100
C101
C102
C103
C104
D101

2
1
100 76
D106

75
IC100
D104

LCD100
LCD100

25

51
26 50
PL106

TM100
RUBBER SW (C)
(345-5589-00)
D107

R121
C105
D102

R129
L100
R106
R107
R108
R109
R110

R128
D103

R111
PL107

R201
R200
R202
D108

R203
D116
D115

D114
1

1
D113

RUBBER SW (L)
(345-5590-00)

R123
PL108
PL109 R122

R125
PL110 VR100

R117

PL111

- 18 - PS-3141K-A/B