Scribd
Upload
70 views2 pages

Material Safety Data Sheet: Page 1 of 2

Msds

Uploaded by

Suli Harto
Copyright
© © All Rights Reserved
We take content rights seriously. If you suspect this is your content, claim it here.
Available Formats
Download as PDF, TXT or read online on Scribd
70 views2 pages

Material Safety Data Sheet: Page 1 of 2

Msds

Uploaded by

Suli Harto
Copyright
© © All Rights Reserved
We take content rights seriously. If you suspect this is your content, claim it here.
Available Formats
Download as PDF, TXT or read online on Scribd
You are on page 1/ 2

MATERIAL SAFETY DATA SHEET

MAGNAFLUX® WHITE CONTRAST PAINT WCP-2

1. IDENTIFICATION
Company: MAGNAFLUX
Address: 3624 West Lake Avenue, Glenview, Illinois 60025
Telephone No.: 847-657-5300 (Off-Hour Emergency Number - CHEMTREC - 1-800-424-9300).
Product Use: Magnetic particle inspection aid
NFPA Rating: Health 1, Flammability 3, Reactivity 0
PIN (Canada): None
Revision Date: April 7, 2013

2. HAZARDOUS INGREDIENTS
Ingredient Wt./Wt. % CAS # TLV PEL LD50 LC50
2-propanone 60-100 67-64-1 750 ppm 750 ppm 6 g/kg (oral/rat) not avail.
Titanium oxide 10-30 13463-67-7 10 mg/m; not avail. 24g/kg (oral/rat) not avail.
Carbon dioxide (propellant)** 9 124-38-9 not avail. 5000 ppm not avail. not avail.
**aerosol only
3. HAZARDS IDENTIFICATION

EMERGENCY OVERVIEW
Extremely flammable aerosol.
Fast evaporating vapors can reach hazardous levels quickly in unventilated spaces.

POTENTIAL HEALTH EFFECTS


Skin Contact: Can irritate by removing natural skin oils on long or repeated exposures.
Eyes: Irritating
Inhalation: Causes dizziness and nausea.
Ingestion: Not significant in small (mouthful) amounts.
Medical conditions known to be aggravated by exposure to product: None

4. FIRST AID
Skin Contact: Wash off with soap and water. Use soothing lotion.
Eyes: Rinse carefully under upper and lower eyelids using plenty of water.
Inhalation: Remove to fresh air if dizzy or nauseated.
Ingestion: Do not induce vomiting. Accidental ingestion of a single mouthful is not expected to cause significant harm.
NOTE: In all severe cases, contact physician immediately. Local telephone operators can furnish number of regional poison control center.

5. FIRE HAZARD
Conditions of flammability: Ignition will occur if used near flames, arcs or other ignition sources.
Flash point: 2°F (-16°C) (Pensky-Martens closed cup).
Flammable limits in air: 2% to 13%.
Extinguishing media: Carbon dioxide, foam, water.
Special fire fighting procedures: Keep containers cool with water spray.
Hazardous combustion products: Soot, oxides of carbon.
Unusual fire hazards: Aerosol cans may burst over 130°F (54°C) and add contents to existing fire.

6. ACCIDENTAL RELEASE MEASURES


Turn off or remove sources of ignition.
Mop up or sweep up with absorbent. (For disposal, see Section 13).

7. HANDLING AND STORAGE


Avoid breathing vapors. Avoid eye contact. Avoid repeated or prolonged skin contact.
Store away from heat source. Do not spray around arcs or flame.
Storage Level 2 Aerosols per NFPA 30B

8. EXPOSURE CONTROLS/PERSONAL PROTECTION


Controls: Use where ventilation will carry vapors away from occupied areas.
Personal protection: Wear safety glasses to protect eyes. Wear nitrile rubber gloves if hand exposure is unavoidable.
Respirator with filter if sprayed in enclosed, unventilated space.

Page 1 of 2
9. PHYSICAL PROPERTIES
Initial boiling point (bulk): 133° F (55°C) (ASTM D-86) Vapor pressure: Aerosol: 110 psi @ 75°F(24°C)
Percent volatile: 80% Vapor density: 2
Density/sp.gravity: 0.9 Evaporation rate: 1.5 of ether
Water solubility: 80% Appearance: White liquid
pH: Neutral Odor: Acetone odor

10. STABILITY AND REACTIVITY


Stability: Stable
Incompatibility: None
Hazardous decomposition products: When burning, soot, oxides of carbon
Reactivity: None

11. TOXICOLOGICAL INFORMATION


Carcinogenicity: Contains no known or suspected carcinogens listed with OSHA, IARC, NTP, or ACGIH.
Threshold limit value (Bulk): Not established.
WHMIS information (Canada): According to available information, the ingredients have not been found to show reproductive toxicity,
teratogenicity, mutagenicity, skin sensitization, or synergistic toxic effects with other materials.

12. ECOLOGICAL INFORMATION


No data is available on WCP-2.

13. DISPOSAL
All disposal practices must be in compliance with all Federal, State/Provincial and local laws and regulations. Regulations may vary in different
locations. Waste characterizations and compliance with applicable laws are the responsibility solely of the waste generator.

RCRA: Hazardous waste.


U.S. EPA Waste Number: F003 and D001.

14. TRANSPORTATION
U.S. DOT: 49 CFR 172.101 Hazardous Materials Table
Aerosol
Proper shipping name: Consumables
Hazard class or division: None
Identification No.: None
Packing Group: None

IATA: List of Dangerous Goods Aerosol


Proper shipping name: Aerosols, flammable
Hazard class or division: 2.1
Identification No.: UN1950
Packing Group: -

IMDG: General Index Aerosol


Proper shipping name: Aerosols
Hazard class or division: 2.1
Identification No.: UN1950
Packing Group: -

15. REGULATORY INFORMATION


TSCA: All ingredients are listed in TSCA inventory.
CERCLA: Reportable quantity (RQ) for Acetone = 5000 lbs.
SARA TITLE III, Section 313: Acetone.
California Proposition 65: Contains nothing on this list
WHMIS Class (Canada): Aerosol: A, B-5, D-2B
Note: This MSDS has been prepared to meet WHMIS (Canada) requirements with the exception of using 16 headings.

16. OTHER INFORMATION


Revision Statement: Section 13
Supersedes: April 16, 2010

Page 2 of 2

You might also like