2016122954HYDROPONIC - Green Fodder - (Karad Satara)

RASHTRIY KRUSHI VIKAS YOJAN
COST EFFECTIVE GREEN FODDER

PRODUCTION BY HYDROPONIC
TECHNIQUE
TALUKA AGRICULTURE OFFICER

KOREGAON, DIST. SATARA
Introduction:-
In Satara district Koregaon taluka comes under Dryaland and rainfed

area. most of the crop production depends on rain. Annual income of
farmers in this area is comparatively low. So, that it is necessary to
promote dairy based farming system in this area. To overcome fodder
availability problem Hydroponic fodder production technique is unique
and cost efficiant than traditional fodder production method.
Traditional fodder production has a number of limitations regarding soil
& climatic conditions. In successful milch animal rearing green fodder has
its special significance. A suitable combination of green & dry fodder is
very important for maintaining animal health& milk production. But in
scarcity condition traditional green fodder production become impossible
because of lack of irrigation water. In such condition the technique of
green fodder production by Hydroponic method is very useful tool.With
this technique, it is possible to produce green fodder like Maize ,Wheat,
Bajra etc. This technique does not require soil. Hence limitations like
saline soil, inferior soil, water logged soil etc can be easily overcome. This
technique requires very less quantity of water. Hence it can be easily
undertaken in scarcity affected areas.
GREEN FODDER NEED FOR CATTLE
Green fodder is the natural diet of cattle. Green fodder is the most
viable method to not only enhance milk production, but to also bring about
a qualitative change in the milk produced by enhancing the content of
unsaturated fat,, Omega 3 fatty acids , vitamins, minerals and carotenoids.
Hydroponics fodder growing is the state-of-the-art technological
intervention to supplement the available normal green fodder resources
required by the dairy cattle. But, after the unfortunate Fometa experience,
Indian scientists and planners have not given any attention to this subject.
With increased pressure on farm lands to produce increasing needs of food
grains, providing green fodder by hydroponics fodder growing is a
necessity for the Indian dairy industry.
Modern researches have confirmed that grass fed cow’s milk is very rich
in EFAs (Essential Fatty Acids). Omega 3 is the most important
constituent of grass fed cow’s milk, particularly for brain and eyes. Some
clinical studies indicate that a 1:1 ingested ratio of Omega 6- to Omega 3-
(especially linoleic vs alpha-linolenic) fatty acids is important to
maintaining cardiovascular health.
INDIA & HYDROPONIC FODDER

Indian agriculture scientists have been familiar with Hydroponics
Fodder growing for more than 30 years. Govt. of India had in late 1980s
imported half a dozen ’Fometa’ Hydroponics Fodder devices for Indian
research establishments of ICAR. It is also reported that 50 more Fometa
device kits were imported and assembled in India.
Each Fometa occupied 30sq. mts. of space and was designed to
produce, on a daily basis, 1000 kg of highly nutritious clean green fodder
of more than 85% digestibility. These devices failed to be useful to India,
because they needed air-conditioning to maintain a temperature of 22+/- 2
C. They used large numbers of fluorescent tubes for photosynthesis. With
irregular electricity supplies, fodder could not be produced on a regular
basis.
Capital cost of these machines was so large, and electricity operating
expenses made the operational cost of these devices uneconomical to
produce fodder. The attempt to use hydroponics for growing fodder in
India was discarded as a bad dream; unsuitable and unaffordable in India.
The Objectives:
- To design a low technology rural device that can be the cheapest
hydroponic fodder production system.
- To Reduce the operating costs by using natural sunlight for
photosynthesis
- To Raise higher operating temperature range of these devices to at least
30degrees and
- To Eliminate air conditioning.
- To Utilize organic fungicides and growth promoters.
Activities conducted to promote hydroponics–
 computer aided training and awareness programme at Taluka and
village level
 Village level expert guidance programme

2. Response -
Total 67 farmer from the taluka benefited from hydroponic unit Mr.
Suresh Appa Shinde (Mob no. 9850112439) From Asangaon village attend
training program conducted at Taluka agriculture office koregaon where
he saw this technique for the first time. Then he decided to establish it on
his own farm. He was properly guided by the experts of Agriculture
department.
The seed of desired fodder crop like Maize, Bajara, Wheat or Oat is
soaked in water for 12 hours. After which it is kept in gunny bag for
another 12 hours. Then it is put in 72 plastic trays which are arranged on
HDPE racks. The total production unit is covered with shade net structure.
The size of plastic tray is 2ft. x 1.5ft x 3 inches. In each tray around 1 kg
(dry weight) seed is put. The partially germinated seed is regularly
sprinkled with water. For effective & uniform water application, sprinklers
& timer assembly is used. The timer is useful for periodically switching on
fogger. Within a period of 7 to 8 days, there is profuse growth of fodder
which is ready for feeding to the animals. The technique has its utility
because of high ratio of seed to fodder. One kg of seed can yield 8 to 10 kg
of green fodder within limited time span of 7 days.
The green fodder produced from each tray is approximately 10 kg
which is sufficient for 1 cow (here it is assumed that the animal is feed
with dry fodder as per requirement.) Thus one tray is sufficient for one
animal daily. Hence for a week one animal requires seven trays in rotation.
Thus a farmer with ten cows will required 80 trays with him. the with
proper planning and seed growth cycles from one unit 10 trays of green
fodder can be available ( around 100 kg green fodder / day )
This technique requires less labour because of the speedy growth &
atomization done for irrigation. It is user-friendly & cost effective. It can
be easily done by farmer. The cost of production of maize fodder works
out to be Rs1.63 per kg
He was successful in erecting the necessary structure. The floor
space of his project is of 80. He had used plastic trays, HDPE pipes
structure, 1 HP electric motor, fogger and timer assembly for which he had
incurred an expenditure of Rs. 25000/-.He was able to overcome certain
difficulties & the smooth runing of the project. Under RVVY scheme he
received Rs.6000/- grant for 1 unit. Now he have 2 hydroponic units and
producing quality green fodder under kind guidance of Agriculture
department.
Program Result –
Mr. Suresh Appa Shinde used 80 plastic trays in this
project from which he is successful in obtaining 110 kg. green fodder per
day. He is able to get 3300 kg of green fodder per month & 40 M.Ton per
year. He has 3 cows and 2 bullocks with him this project helped him to
reduced the cost on constricted animal feed significantly. Before this
project he has been spending Rs. 16000 on concentrated feed which has
now come down to Rs. 4000 per month.
More fodder production in limited space, lower water requirement,
fodder production free from pests and diseases, more palatability are the
characteristics of this project. It is possible to produce green fodder maize,
wheat, bajara by this technique..
4. Program Impact -
Lot of farmers have visited to Asangaon 4 units, and

Banawadi 9 units and took information about this project. The model of
this project is displayed in various agriculture exhibitions for which there
was good response from farmers
His farm has been serving as a training center regarding animal
husbandry, hygienic milk production, hydroponic fodder production etc.
This center also plays a role as Farmer-led Extension. It was supported
from ATMA, Satara as a Training-cum Demonstration Center.
Since last eight months, about 200 farmers received quality training.
In each training the trainee farmers got opportunity to do things by
themselves, so that they can learn effectively. Large number of farmers
visited this center. Some of them have started their own hydroponic units.
This technique has a good potential of replicability.
After seeing the Hydroponic project at Asangaon, various farmers
have established it on their farms.
Hon. DSAO and TAO visit to Hydrophonic Unit

.Future Potential –
1. To increase milk production and quality of milk green fodder is very
important.
To make more and more green fodder available trainings to farmers will
be arranged on hydroponics with the help of ATMA.
2. Production of vegetables through hydroponics.
3.Organic milk production .
4. To promote Time and space utility in fodder development sector.
Benefits of hydroponic fodder production.
servation
Profuse growth of maize crop
Maize fodder crop with age of 8 days
Good growth of hydroponic maize fodder crop
TALUKA AGRICULTURE OFFICER KOREGAON

2016122954HYDROPONIC - Green Fodder - (Karad Satara)

Uploaded by

Copyright:

Available Formats

2016122954HYDROPONIC - Green Fodder - (Karad Satara)

Uploaded by

Document Information

Original Description:

Original Title

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

2016122954HYDROPONIC - Green Fodder - (Karad Satara)

Uploaded by

Copyright:

Available Formats

RASHTRIY KRUSHI VIKAS YOJAN

COST EFFECTIVE GREEN FODDER

TALUKA AGRICULTURE OFFICER

In Satara district Koregaon taluka comes under Dryaland and rainfed

INDIA & HYDROPONIC FODDER

 Village level expert guidance programme

Lot of farmers have visited to Asangaon 4 units, and

Hon. DSAO and TAO visit to Hydrophonic Unit

2. Production of vegetables through hydroponics.

3.Organic milk production .

4. To promote Time and space utility in fodder development sector.

Benefits of hydroponic fodder production.

Maize fodder crop with age of 8 days

Good growth of hydroponic maize fodder crop

TALUKA AGRICULTURE OFFICER KOREGAON

You might also like