National Institute of Advanced Industrial Science and Technology (AIST)

March 31, 2017

Safety Data Sheet

1. Identification of the Substance/Mixture and the Supplier

Supplier : National Institute of Advanced Industrial Science and Technology
(AIST)
Address : 1-3-1, Kasumigaseki, Chiyoda, Tokyo, Japan
Office in Charge : Reference Materials Office, Center for Quality Management of
Metrology, National Metrology Institute of Japan
Person in Charge : Certified Reference Material Staff
Telephone No. : +81-29-861-4059 Fax No. : +81-29-861-4009
Emergency Contact : Same as above
Prepared on : July 14, 2009
Revised on : March 31, 2017
Reference No. : 7912001
Identity of : Certified Reference Material NMIJ CRM 7912-a Arsenate [As(V)]
Substance/Mixture Solution
Recommended Use : This CRM is intended for controlling the precision of analysis or to
of the Chemical and confirm the validity of analytical methods or instruments during
Restriction on Use the analysis of arsenate.
Do not use this reference material for other purposes than
testing/research.

2. Hazards Identification
GHS Classification: Acute toxicity (inhalation: dust and mist) : Class 4
Skin corrosivity/irritant : Class 1A
Severe damage to eye/eye irritant : Class 1
Particular target organ/systemic toxicity (Single exposure)
: Class 1 (respiratory
organ)
Particular target organ/systemic toxicity (repetitive exposure)
: Class 1 (respiratory
organ)

GHS Label element :

Signal word : Danger

Hazard and toxicity: Toxic if inhaled (Gas, vapor, dust, mist)
Severe dermal damage, eye damage
Severe eye damage
NMIJ CRM 7912-a 1/8
 National Institute of Advanced Industrial Science and Technology (AIST)
March 31, 2017

Damage to organs (respiratory organ)

Damage to organs due to longtime or repetitive exposure
(respiratory organ)

Precautionary : -
Statement

3. Composition/Information on Ingredients
Single or compound product : Compound product

・Component 1
Chemical name : Water
Chemical formula or ： H2O
structural formula
Content : Approximately 95 %
Reference Number in : Act on the Evaluation of Chemical Substances and
Gazetted List in Japan Regulation of Their Manufacture, etc. :-
Industrial Safety and Health Act :-
CAS No. : 7732-18-5

・Coomponent 2
Chemical name : Nitric acid
Chemical formula or : HNO3
structural formula
Content : Approximately 5 %
Reference Number in : Act on the Evaluation of Chemical Substances and
Gazetted List in Japan Regulation of Their Manufacture, etc : ( 1 ) - 3 9 4
Industrial Safety and Health Act : Published
CAS No : 7 6 9 7 -3 7 - 2

・Component 3
Chemical name : Arsenic acid
Chemical formula or : H3AsO4
structural formula
Content : Approximately 0.02 %
Reference Number in : Act on the Evaluation of Chemical Substances and
Gazetted List in Japan Regulation of Their Manufacture, etc. : ( 1 ) - 3 3
Industrial Safety and Health Act : Published
CAS No : 7 7 7 8 -3 9 - 4

Hazardous component : Nitric acid、Arsenic acid

4. First-aid Measures
◇If in eye
NMIJ CRM 7912-a 2/8
 National Institute of Advanced Industrial Science and Technology (AIST)
March 31, 2017

1.Flush carefully with plenty of clean water. If using contact lenses, take out if possible
and continue rinsing.
2.Get medical assistance
◇If on skin
1.Take off all the contaminated clothes, flush the skin with plenty of water using soap.
2.Get medical assistance
◇If inhaled
1.Move to get some fresh air and ease the breathing/respiration
2.Get medical assistance
◇If swallowed
1.Wash mouth thoroughly, do not induce vomit
2.Get medical assistance

◇Measures to be taken to protect the person applying first aid

1 Use personal protective equipment.

5. Fire-fighting Measures
Extinguishing media : This material itself is nonflammable、but use distinguishing
medium compatible with the fire in the surrounding area
Specific hazards at the : Decomposes when heated and may generates toxic gases such
time of fire as nitrogen oxide and arsenic compounds
Specific extinguishing : Transfer the movable containers to a safe place promptly. If
measures impossible to move, cool the periphery by water-spray,
Extinguishing activity from windward to avoid inhaling toxic
gas
Protecting fire-fighting : Fire-safe clothing、air-breathing apparatus、self-contained
personnel. compressed air breathing apparatus, rubber boots

6. Accidental Release Measures

Personal precaution, : If released indoor, ventilate well until the treatment is
protective equipment completed
and emergency Use appropriate protective equipment to avoid contact with eye
procedure and skin, inhaling vapor and mist.
Rope-off the leaked area to limit the access to authorized
personnel only.
Environmental : To prevent causing environmental impact, do not release the
precaution spilled material into rivers, etc. directly. Treat the contaminated
waste water appropriately before discharging.
Recovery, : Remove the spilled liquid as much as possible by adsorbing to
neutralization diatom earth and then neutralize the rest with sodium
carbonate, etc. and wash out the contaminated spot with plenty
of water.

7. Handling and Storage

NMIJ CRM 7912-a 3/8

 National Institute of Advanced Industrial Science and Technology (AIST)
March 31, 2017

Handling
・ Use appropriate protective equipment to prevent inhaling vapor, contact with eye and
skin.
・ Wash hands, face well, and gargle. after handling.
・ No eating, drinking and smoking when handling.
Storage
・ Protect from light at room temperature in a clean place. Store in a lockable cabinet.

◇ An appropriate storage condition as a reference material and the precautionary

statement of the use should be referred to the certificate.

8. Exposure Controls/Personal Protection

Administrative levels
Standards of work environment evaluation :3 μg/m3（as As）
Occupational exposure limit
1.Arsenic acid
・ACGIH TLV-TWA : 0.2 mg(As)/m3
・Japan Society for Occupational : 3 μg/m3（excess lifetime carcinogenesis risk level of
Health Recommended 10-3）
Reference Value 0.3 μg/m3（excess lifetime carcinogenesis risk level
of 10-4）
・OSHA PEL 8H-TWA : 0.5 mg(As)/m3
2.Nitric acid
・ACGIH TLV-TWA : 2 ppm
・Japan Society for Occupational : 2 ppm, 5.2 mg/m3
Health Recommended
Reference Value
Facility engineering control
・Use local ventilation system when handling
・Install emergency eye washer and shower near the handling place and indicate the
facility location conspicuously.
Protective equipment
・Breathing apparatus、protective gloves, safety goggles、protective clothing, protective
mask

9. Physical and Chemical Properties

・Appearance, etc. : Liquid (normal temperature)
・Color : Clear and colorless
・Odor : No data
・pH : Strong acidity
・Melting point : No data
・Boiling point : No data
・Flashing point : No data
・Explosive range : No data

NMIJ CRM 7912-a 4/8

 National Institute of Advanced Industrial Science and Technology (AIST)
March 31, 2017

・Vapor pressure : No data

・Relative vapor density(Air=1) : No data
・Specific gravity or bulk : No data
specific gravity
・Solubility : No data
・n-Octanol/water partition : No data
coefficient (Log Po/w)
・Auto-ignition temperature : No data

10. Stability and Reactivity

◇Stability
・Stable under normal condition
・Decomposes when heated、generates nitrogen oxide gas
・Generates arsenic compound gas when heated, and may inhale as vapor
◇Reactivity
・Reacts in contact with alkaline materials
◇Conditions to avoid
・Sunlight, heat and alkaline substances
◇Hazardous decomposition products
・Nitrogen oxide、arsenic compound

11. Toxicological information

＜Nitric acid＞
Acute toxicity (Inhalation:dust and Rat inhalation LC50=0.067mg/L/4H (HNO3)
mist) Classified 4, as it contains approximately 5 % of
class 2 nitric acid
Skin corrosivity and irritancy Classified 1A, as it contains approximately 5 % of
Class 1A nitric acid
Severe damage to eye/eye irritancy Classified 1, as it contains approximately 5% of
Class 1 nitric acid
Particular target organ/systemic It is stated that when humans inhale the vapor
toxicity (Single exposure) generated from nitric acid, irritation in upper
respiratory track, cough, breathing difficulty, chest
pain occurred; moreover, depending on the
exposure concentration or time, it may cause
Particular target organ/systemic emphysema
toxicity (repetitive exposure)
It is stated that occupational exposures to the mist
or vapor generated from nitric acid caused chronic
bronchitis and dental erosion, etc.
＜Arsenic acid＞
Acute toxicity (Inhalation:dust and Oral-rat LD50:48mg/kg
mist) Oral-rat LDLo:5mg/kg
Based on the test using peroral administration to

NMIJ CRM 7912-a 5/8

 National Institute of Advanced Industrial Science and Technology (AIST)
March 31, 2017

rats LD50 48mg/kg (RTECS (2006))

Carcinogenicity As arsenic series inorganic compound, it is
categorized as K (Arsenic Compounds, inorganic)
by NTP (2005)、Group 1 (ARSENIC AND
ARSENIC COMPOUNDS) by IARC (1987)、A1
(Arsenic and inorganic compounds) by ACGIH
(2001)、and Class 1 (Arsenic and arsenic
compounds (as As)) by Japan Society for
Occupational Health
Reproductive toxicity Peroral administration test performed by giving
dosages having general toxicity impact to mother
animals resulted in the increase of absorbing
embryo and weight loss of fetus (EHC 224 (2001))
Particular target organ/systemic To humans, it is stated that 'acute toxicity of
toxicity (Single exposure) arsenic compounds affects digestive tract,
circulatory organ, nerves, hematological
symptoms, conjunctival inflammation, dermatitis,
and also the irritation of nasal membrane, pharynx
and trachea, frequent micturition or anuria due to
tubular blockage by hemoglobin clot’ (IARC 84
(2004)), ‘suppression of bone-marrow function,
enlargement of the liver’ (EHC 224 (2001)) etc.
Based on this description, digestive tract,
circulatory organ, nerve, blood system, respiratory
organ, skin, kidney, bone marrow and liver are
considered the particular target organs
Particular target organ/systemic Chronic toxicity to humans are stated as ‘various
toxicity (repetitive exposure) upper respiratory symptoms including
nasopharyngitis and nasal septal perforation’,
‘breathing problem deriving from drinking water’,
‘pigment deposition and keratosis’, ‘hepatic
cirrhosis’, ‘cardiovascular abnormality’, ‘peripheral
vascular disorder’ (IARC 84 (2004)), etc.
Based on the description, respiratory organ, skin,
liver, cardiovascular are considered the related
target organs

12. Ecological Information

Degradability, concentration
・No data available
Bioaccumulation
・No data available
Ecotoxicity
・Fish (striped bass) 96 hours LC50=30.5 mg As/L (EHC224, 2001)

NMIJ CRM 7912-a 6/8

 National Institute of Advanced Industrial Science and Technology (AIST)
March 31, 2017

13. Disposal Considerations

・Disposal shall be in compliance with the ordinances and regulations of local authorities
・Disposal of an empty container shall be after removing/decontaminating the content
completely.

14. Transport Information

UN Number : 1553
UN Classification : Class 6.1(Poisonous substance） GroupⅠ
Material name : Arsenic acid (liquid）
Marine pollutant : Not applicable
Precautions : Transfer with care avoiding direct sunlight, leakage or spill due to fall
or drop.
Keep the container away from fire sources.

15. Regulatory Information

◇Poisonous and Deleterious Substances Control Act
・Article 2 Appended Table No. 1 Poisonous Substances (Arsenic compounds and the
formulation containing the substances)
◇Industrial Safety and Health Act
・Article 57-2 (Enforcement Order: Article 18) Hazardous substance whose name, etc.
must be labeled.
・Article 57-2 (Enforcement Order: Article 18-2) Hazardous substance whose name, etc.
must be notified No.307
・Cabinet Order Appended Table No. 3 Ordinance on Prevention of Hazards Due to
Specified Chemical Substances (Class 3 Substance) (Formulation containing nitric acid)
◇Law Relating to the Prevention of Marine Pollution and Maritime Disaster
・Enforcement Order Appended Table No. 1 Toxic liquid substance (Group Y) (Nitric acid)
◇Ship Safety Act
・Regulations for the Carriage and Storage of Dangerous Goods in Ships Article 3
Hazardous Materials Public Notice Appended Table No. 1 Corrosive substances (Nitric
acid)
・Regulations for the Carriage and Storage of Dangerous Goods in Ships Article 3
Hazardous Materials Public Notice Appended Table No. 1 Poisonous substances (Arsenic
acid (liquid))
◇Civil Aeronautics Act
・Enforcement Order Article 194 Hazardous Materials Public Notice Appended Table No.1
Corrosive substances (Nitric acid)
・ Enforcement Order Article 194 Hazardous Materials Public Notice Appended Table No.1
Poisonous substances (Arsenic acid (liquid))

◎ This SDS is originally prepared for the use of the material in Japan, thus the stated laws
and regulations are stipulated and carried out in Japan. The use of the material in other
countries should be referred to and by application of the relevant laws and regulations of

NMIJ CRM 7912-a 7/8

 National Institute of Advanced Industrial Science and Technology (AIST)
March 31, 2017

the country in which the material will be used.

16. Other Information

Others
The information in this document is not intended to be exhaustive and is based on currently
available information and data. The measures given in this document are applicable only to
normal handling conditions. When handling this reference material under special conditions
etc., it is recommended to take safety measures appropriate to each specific application and
context of use. This document is intended to provide information and not intended to
guarantee anything in handling this reference material.

NMIJ CRM 7912-a 8/8