Partsmanual Onan K38-G3 PDF

Parts Catalog
DFJA
DFJB
DFJC
DFJD
Generator Set
Printed in U.S.A. 960–0277 DFJA, DFJB (Spec J–M) 12–99

DFJC (Spec J–R)
DFJD (Spec B–H)
Redistribution or publication of this document
by any means, is strictly prohibited.
To avoid errors or delay in filling your parts order, The following symbols are used in Onan manuals
always give the MODEL, SPEC NO. and SERIAL to alert users to the potentially dangerous condi-
NO. from the Onan nameplate. tions relating to maintenance of equipment and re-
placement of parts. Please read and observe.
For handy reference, insert your nameplate in-
formation in the spaces below.
This symbol warns of immedi-
ate hazards which will result in
severe personal injury or death.
MODEL AND SPEC NO.
This symbol refers to a hazard
or unsafe practice which can re-
SERIAL NO. sult in severe personal injury or
death.
This symbol refers to a hazard
DIGITAL CONTROL SOFTWARE VERSION or unsafe practice which can re-
AND DATE (IF APPLICABLE) sult in severe personal injury or
product or property damage.
Service and repair of Onan equipment must be performed by trained, experienced personnel only. Im-
proper service or repair may result in property damage, severe personal injury or death. Do not use this
catalog as a guide to servicing your equipment. Read and follow the IMPORTANT SAFETY INSTRUC-
TIONS in the Service Manual appropriate for the equipment you are working on.
Contact with USED ENGINE OILS has been identified by a United States federal agency and some USA
state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When checking or changing engine
oils take all necessary precautions not to ingest, breathe the fumes or contact the used oil.
Contact with ASBESTOS has been identified by a United States federal agency and some USA state
agencies as causing CANCER or REPRODUCTIVE TOXICITY. When handling engine gaskets take all
necessary precautions not to ingest, breathe or contact the dust from the gaskets! Use adequate ven-
tilation and wear protective gloves, masks and clothing!
Contact with BENZINE and LEAD, found in gasoline, fuel additives and solvents has been identified by
a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE
TOXICITY. When checking, draining or adding gasoline and fuel additives or using solvents take all nec-
essary precautions not to ingest, breathe the fumes or contact the liquids. Use adequate ventilation and
wear protective gloves, masks and protective clothing!
PSP-1

Introduction
This catalog applies to Onan Generator Models DFJA, DFJB, DFJC and DFJD as listed in the Generator Set Data
Table. Parts are arranged in groups of related items and each illustrated part is identified by a reference number corre-
sponding to the same reference number in the parts list. Parts illustrations are typical. Unless otherwise mentioned
in the description or page heading, parts are interchangeable between models. Throughout this catalog left and right
sides are determined by facing the engine end (front) of the set unless noted in the description column.
Engine parts that have been modified or added by Onan are identified in this catalog. All other engine replacement
parts must be ordered from the engine manufacturer by referring to the engine manufacturer’s nameplate and supply-
ing all available information. Contact your nearest engine parts distributor for assistance in ordering replacement
parts.
Replacement Engine
Onan/Cummins Generator Model Cummins Engine Model

DFJA KTA38–G1 Configuration No. D233019DX02
DFJB KTA38–G2 Configuration No. D233020DX02
DFJC KTA38–G3 Configuration No. D233030DX02
DFJD 50 Hertz KTA38–G5 Configuration No. D233031DX02
DFJD 60 Hertz KTA38–G4 Configuration No. D233031DX02
Replacement engines cannot be ordered from Onan. Order from your nearest Cummins
distributor.
Generator Set Data Table
Model and Electrical Data Battery

Specification Watts Volts Hertz Wire Phase Voltage
620DFJA/ +
620DFJA/*+ 620,000 # 50 6,12 1 or 3 24VDC
750DFJA/*+ 750,000 # 60 6,12 1 or 3 24VDC
660DFJB/*+ 660,000 # 50 6,12 1 or 3 24VDC
800DFJB/*+ 800,000 # 60 6,12 1 or 3 24VDC
800DFJC/* 800,000 # 50 6,12 1 or 3 24VDC
900DFJC/* 900,000 # 60 6,12 1 or 3 24VDC
880DFJD/* 880,000 # 50 6,12 1 or 3 24VDC
1000DFJD/* 1,000,000 # 60 6,12 1 or 3 24VDC
* – The diagonal line (/) in the model and specification number separates generator set characteristics from the
specification number and letter. The specification number denotes customer requested options or deviations from
the standard model. The specification letter advances (A to B, B to C, etc.) with major manufacturing changes.
+ – Models DFJA and DFJB were discontinued after Spec M.
# – Broad range reconnectible
1
Index
Absorber, Shock – Fan – DFJA, DFJB – DFJC Spec J Belt, Ribbed – Fan Drive – DFJA, DFJB – DFJC Spec J
Through M, 52 Through M, 52
Absorber, Shock – Fan – DFJC Begin Spec N, DFJD Sets Belt, Ribbed – Fan Drive – DFJC Begin Spec N, DFJD Sets
With 60” Diameter Fan, 54 With 60” Diameter Fan, 54
Absorber, Shock – Fan – DFJD Sets With 56” Diameter Fan, Belt, Ribbed – Fan Drive – DFJD Sets With 56” Diameter
53 Fan, 53
Alarm, Audible – Sets With Detector Control, 99 Block, Auxiliary Terminal – Sets With Detector Control, 113
Alarm, Bell – Circuit Breaker – Non–UL Listed – DFJA, Block, Terminal – Control Box – Sets With Detector Control,
DFJB Spec K Through M, DFJC Spec K Through N, DFJD 77
Spec E and F, 155 Block, Terminal – Engine Coolant Heater Control – DFJA,
Alarm, Bell – Circuit Breaker – Non–UL Listed – DFJA, DFJB Spec M, DFJC Begin Spec M, DFJD Begin Spec E,
DFJB, DFJC Spec J, 153 41
Block, Terminal – Engine to Control Wiring Harness – Sets
Alternator – 45 Amp, 57 With Detector Control, 84
Alternator – 75 Amp, 59 Block, Terminal – Engine to Control Wiring Harness – Sets
Ammeter – Sets With Detector Control, 79 With PowerCommand Control – DFJA, DFJB, DFJC Begin
Spec K, DFJD Begin Spec C, 83
Block, Terminal – Generator Heater, 71
Band, Mounting – Water Inlet – DFJA, DFJB Spec M, DFJC
Begin Spec M, DFJD Begin Spec E, 32 Block, Terminal – Paralleling Interconnect, 114
Bar, Bus – Circuit Breaker – IEC Conformity – DFJA, DFJB Block, Terminal – Woodward Governor, 61
Spec K Through M, DFJC Spec K Through N, DFJD Spec Board, Printed Circuit – Alarm Relay, 90
C Through F, 139 Board, Printed Circuit – Common Alarm – Sets With
Bar, Bus – Circuit Breaker – IEC Conformity – DFJC Begin Detector Control, 91
Spec P, DFJD Begin Spec G, 143 Board, Printed Circuit – Electronic Overspeed, 98
Bar, Bus – Circuit Breaker – UL Listed – DFJA, DFJB Spec Board, Printed Circuit – Engine Monitor – Sets With Detector
K Through M, DFJC Spec K Through N, DFJD Spec C Control, 77
Through F, 129 Board, Printed Circuit – Isolation Transformer – Sets With
Bar, Bus – Circuit Breaker – UL Listed – DFJC Begin Spec Detector Control, 89
P, DFJD Begin Spec G, 131 Board, Printed Circuit – Over/Under Voltage Relay – DFJA,
Bar, Bus – Disconnect Switch – Molded Case – UL Listed – DFJB Spec L and M, DFJC Begin Spec L, DFJD Begin
DFJA, DFJB Spec L and M, DFJC Spec L Through N, Spec D, 95
DFJD Spec D Through F, 147 Board, Printed Circuit – Time Delay Start/Stop, 116
Bar, Bus – Disconnect Switch – Molded Case – UL Listed – Board, Printed Circuit – Voltage Regulator – Sets With
DFJC Begin Spec P, DFJD Begin Spec G, 149 Detector Control, 89
Bar, Neutral – Circuit Breaker – IEC Conformity – DFJA, Box, Circuit Breaker – IEC Conformity – DFJA, DFJB Spec
DFJB Spec K Through M, DFJC Spec K Through N, DFJD K Through M, DFJC Spec K Through N, DFJD Spec C
Spec C Through F, 137 Through F, 137
Bar, Neutral – Circuit Breaker – IEC Conformity – DFJA, Box, Circuit Breaker – IEC Conformity – DFJA, DFJB, DFJC
DFJB, DFJC Spec J, DFJD Spec B, 135 Spec J, DFJD Spec B, 135
Bar, Neutral – Circuit Breaker – IEC Conformity – DFJC Box, Circuit Breaker – IEC Conformity – DFJC Begin Spec
Begin Spec P, DFJD Begin Spec G, 141 P, DFJD Begin Spec G, 141
Bar, Neutral – Circuit Breaker – Non–UL Listed – DFJA, Box, Circuit Breaker – Non–UL Listed – DFJA, DFJB Spec K
DFJB Spec K Through M, DFJC Spec K Through N, DFJD Through M, DFJC Spec K Through N, DFJD Spec E and
Spec E and F, 155 F, 155
Bar, Neutral – Circuit Breaker – UL Listed – DFJA, DFJB Box, Circuit Breaker – Non–UL Listed – DFJA, DFJB, DFJC
Spec K Through M, DFJC Spec K Through N, DFJD Spec Spec J, 153
C Through F, 127, 129 Box, Circuit Breaker – UL Listed – DFJA, DFJB Spec K
Bar, Neutral – Circuit Breaker – UL Listed – DFJC Begin Through M, DFJC Spec K Through N, DFJD Spec C
Spec P, DFJD Begin Spec G, 131 Through F, 125
Bar, Neutral – Circuit Breaker – UL Listed – DFJD Spec B, Box, Circuit Breaker – UL Listed – DFJA, DFJB, DFJC Spec
123 J, 121
Box, Circuit Breaker – UL Listed – DFJC Begin Spec P,
Bar, Neutral – Circuit Breaker and Disconnect Switch – UL DFJD Begin Spec G, 131
Listed, IEC Conformity – DFJC Begin Spec P, DFJD Begin
Spec G, 151 Box, Circuit Breaker – UL Listed – DFJD Spec B, 123
Bar, Neutral – Disconnect Switch – Molded Case – UL Box, Circuit Breaker and Disconnect Switch – UL Listed,
Listed – DFJA, DFJB Spec L and M, DFJC Spec L IEC Conformity – DFJC Begin Spec P, DFJD Begin Spec
Through N, DFJD Spec D Through F, 145 G, 151
Bar, Neutral – Disconnect Switch – Molded Case – UL Box, Control – Engine Coolant Heater – DFJA, DFJB Spec
Listed – DFJC Begin Spec P, DFJD Begin Spec G, 149 M, DFJC Begin Spec M, DFJD Begin Spec E, 41
Base, Heat Exchanger, 45 Box, Control – Sets With Detector Control, 77
Box, Disconnect Switch – Molded Case – UL Listed – DFJA,
Belt, Alternator – 45 Amp, 57 DFJB Spec L and M, DFJC Spec L Through N, DFJD
Belt, Alternator – 75 Amp, 59 Spec D Through F, 145

2 by any means, is strictly prohibited.
Index
Box, Disconnect Switch – Molded Case – UL Listed – DFJC Cable, Magnetic Pickup – Sets With PowerCommand
Begin Spec P, DFJD Begin Spec G, 149 Control – DFJA, DFJB, DFJC Begin Spec K, DFJD Begin
Box, Entrance – DFJA, DFJB Spec K Through M, DFJC Spec C, 83
Spec K Through N, DFJD Spec C Through F, 64 Cable, Shielded – Speed Adjusting Potentiometer, 106
Box, Entrance – DFJA, DFJB, DFJC Spec J, DFJD Spec B, Cap, Expansion Tank – Heat Exchanger, 45
63 Cap, Radiator – DFJA, 47
Box, Entrance – DFJC Begin Spec P, DFJD Begin Spec G, Cap, Radiator – DFJB, 49
65 Cap, Radiator – DFJC, DFJD, 51
Box, Junction – Engine Coolant Heater – DFJA, DFJB, Capacitor – Voltmeter – Sets With Detector Control, 79
DFJC Spec J Through L, DFJD Spec B Through D, 34
Cartridge, Generator Heater, 71
Box, Relay – Engine Coolant Heater – DFJA, DFJB, DFJC
Spec J Through L, DFJD Spec B Through D, 35 Cleaner, Air – Heavy Duty – DFJA, DFJB, 22
Cleaner, Air – Heavy Duty – DFJC, DFJD, 23
Box, Terminal – Generator Heater, 71
Cleaner, Air – Standard – DFJA, DFJB , 20
Brace, Air Starter, 55
Cleaner, Air – Standard – DFJC, DFJD, 21
Bracket, Adjusting – Alternator – 45 Amp, 57
Clip, End – Mounting Rail – Over/Under Frequency Relay,
Bracket, Adjusting – Alternator – 75 Amp, 59 96
Bracket, Mounting – Resistive Temperature Detectors, 117 Clip, End – Mounting Rail – Over/Under Voltage Relay –
Bracket, Retaining – Battery, 11 DFJA, DFJB, DFJC Spec J and K, DFJD Spec B and C,
94
Breaker, Circuit – AC Control Door, 103
Cock, Drain – Heat Exchanger, 45
Breaker, Circuit – IEC Conformity – DFJA, DFJB Spec K Connection, Water Inlet – DFJA, DFJB, DFJC Spec J
Through M, DFJC Spec K Through N, DFJD Spec C Through L, DFJD Spec B Through D, 31
Through F, 137
Contact, Auxiliary – Circuit Breaker – Non–UL Listed –
Breaker, Circuit – IEC Conformity – DFJA, DFJB, DFJC DFJA, DFJB Spec K Through M, DFJC Spec K Through
Spec J, DFJD Spec B, 135 N, DFJD Spec E and F, 155
Breaker, Circuit – IEC Conformity – DFJC Begin Spec P, Contact, Auxiliary – Circuit Breaker – Non–UL Listed –
DFJD Begin Spec G, 141 DFJA, DFJB, DFJC Spec J, 153
Breaker, Circuit – Non–UL Listed – DFJA, DFJB Spec K Control, Detector, 77
Through M, DFJC Spec K Through N, DFJD Spec E and
F, 155 Control, Engine Coolant Heater, 41
Control, Governor – Electronic, 62
Breaker, Circuit – Non–UL Listed – DFJA, DFJB, DFJC
Spec J, 153 Control, PowerCommand – DFJA, DFJB Spec K Through M,
DFJC Begin Spec K, DFJD Begin Spec C, 78
Breaker, Circuit – UL Listed – DFJA, DFJB Spec K Through
M, DFJC Spec K Through N, DFJD Spec C Through F, Controller, VAR Power Factor, 102
125 Cover, Circuit Breaker – IEC Conformity – DFJA, DFJB
Breaker, Circuit – UL Listed – DFJA, DFJB, DFJC Spec J, Spec K Through M, DFJC Spec K Through N, DFJD Spec
121 C Through F, 137
Cover, Circuit Breaker – IEC Conformity – DFJA, DFJB,
Breaker, Circuit – UL Listed – DFJC Begin Spec P, DFJD DFJC Spec J, DFJD Spec B, 135
Begin Spec G, 131
Cover, Circuit Breaker – IEC Conformity – DFJC Begin Spec
Breaker, Circuit – UL Listed – DFJD Spec D, 123 P, DFJD Begin Spec G, 141
Breaker, Circuit – UL Listed, IEC Conformity – DFJC Begin Cover, Circuit Breaker – Non–UL Listed – DFJA, DFJB Spec
Spec P, DFJD Begin Spec G, 151 K Through M, DFJC Spec K Through N, DFJD Spec E and
Bulb, Panel Light – Replacement – DC Control Door – Sets F, 155
With Detector Control, 81 Cover, Circuit Breaker – Non–UL Listed – DFJA, DFJB,
Bulb, Replacement – Emergency Stop Switch, 109 DFJC Spec J, 153
Cover, Circuit Breaker – UL Listed – DFJA, DFJB Spec K
Through M, DFJC Spec K Through N, DFJD Spec C
Cable, Battery – Sets With Detector Control – DFJA, DFJB Through F, 125
Spec M, DFJC Begin Spec M, DFJD Begin Spec E, 15
Cover, Circuit Breaker – UL Listed – DFJA, DFJB, DFJC
Cable, Battery – Sets With Detector Control – DFJA, DFJB, Spec J, 121
DFJC Spec J Through L, DFJD Spec B Through D, 13 Cover, Circuit Breaker – UL Listed – DFJC Begin Spec P,
Cable, Battery – Sets With PowerCommand Control – DFJA, DFJD Begin Spec G, 131
DFJB Spec K Through M, 17 Cover, Circuit Breaker – UL Listed – DFJD Spec B, 123
Cable, Battery – Sets With PowerCommand Control – DFJC Cover, Circuit Breaker and Disconnect Switch – UL Listed,
Begin Spec K, DFJD Begin Spec C, 19 IEC Conformity – DFJC Begin Spec P, DFJD Begin Spec
Cable, Generator – Ground Fault Relay – DFJA, DFJB Spec G, 151
L and M, DFJC Begin Spec L, DFJD Begin Spec D, 93 Cover, Control – Electronic Governor, 62
Cable, Heater – Control – Sets With Detector Control – Cover, Control Box – Sets With PowerCommand Control –
DFJA, DFJB, DFJC Begin Spec K, DFJD Begin Spec C, DFJA, DFJB Spec J Through M, DFJC Spec J Through N,
86 DFJD Spec B Through F, 67
Cable, Magnetic Pickup – Generator Sets With Detector Cover, Control Box – Sets With PowerCommand Control –
Control, 84 DFJC Begin Spec P, DFJD Begin Spec G, 69

Index
Cover, Damper Guard – Sets With Remote Radiator or Heat
Exchanger, 42 Fan – DFJA, DFJB – DFJC Spec J Through M, 52
Cover, Disconnect Switch – Molded Case – UL Listed – Fan – DFJC Begin Spec N, DFJD Sets With 60” Diameter
DFJA, DFJB Spec L and M, DFJC Spec L Through N, Fan, 54
DFJD Spec D Through F, 145
Fan – DFJD Sets With 56” Diameter Fan, 53
Cover, Disconnect Switch – Molded Case – UL LIsted –
DFJC Begin Spec P, DFJD Begin Spec G, 149 Fan, Alternator – 45 Amp, 57
Cover, Entrance Box – DFJA, DFJB Spec K Through M, Filter, Oil Bypass, 28
DFJC Spec K Through N, DFJD Spec C Through F, 64 Flange, Radiator – DFJA, 47
Cover, Entrance Box – DFJA, DFJB, DFJC Spec J, DFJD Fuse – Engine To Control Wiring Harness – Sets With
Spec B, 63 PowerCommand Control – DFJA, DFJB, DFJC Begin
Cover, Entrance Box – DFJC Begin Spec P, DFJD Begin
Spec G, 65 Fuse – Printed Circuit Board – Engine Monitor – Sets With
Detector Control, 77
Cover, Flange – Air Starter, 55
Fuse – Radio Frequency Interference Module , 111
Cover, Hand Hole – Fuel Transfer Pump – DFJA, DFJB
Spec L and M, DFJC Begin Spec L, DFJD Begin Spec D,
25 Gasket, Connection – Water Outlet, 33
Cover, Side – Control Housing – DFJA, DFJB Spec J Gasket, Flange – Heat Exchanger, 45
Through M, DFJC Spec J Through N, DFJD Spec B Gasket, Hand Hole – Fuel Transfer Pump – DFJA, DFJB
Through F, 67 Spec L and M, DFJC Begin Spec L, DFJD Begin Spec D,
Cover, Side – Control Housing – DFJC Begin Spec P, DFJD 25
Begin Spec G, 69 Gasket, Heat Exchanger, 45
Cover, Terminal Box – Engine Coolant Heater – DFJA, Gasket, Louvre – Generator, 72
DFJB Spec M, DFJC Begin Spec M, DFJD Begin Spec E,
39 Gasket, Mounting – Fuel Transfer Pump – DFJA, DFJB
Spec L and M, DFJC Begin Spec L, DFJD Begin Spec D,
Cover, Top – Control Housing – DFJA, DFJB Spec J 25
Through M, DFJC Spec J Through N, DFJD Spec B Gasket, Outlet Tube – Radiator – DFJA, 47
Through F, 67
Gasket, Thermostat Housing – Water Outlet, 33
Cover, Top – Control Housing – DFJC Begin Spec P, DFJD
Begin Spec G, 69 Gasket, Thermostatic Valve, 43
Gasket, Water Inlet Connection – DFJA, DFJB, DFJC Spec
J Through L, DFJD Spec B Through D, 31
Detectors, Resistive Temperature, 117
Gauge, Fuel Pressure, 26
Door, Control – AC – Sets With Detector Control, 79
Gauge, Oil Pressure – Control Mounted – Sets With
Door, Control – DC – Sets With Detector Control, 81 Detector Control, 81
Drive, Fan – DFJA, DFJB – DFJC Spec J Through M, 52 Gauge, Oil Temperature, 108
Drive, Fan – DFJC Begin Spec N, DFJD Sets With 60” Gauge, Water Temperature – Sets With Detector Control, 81
Diameter Fan, 54 Generator, 74
Drive, Fan – DFJD Sets With 56” Diameter Fan, 53 Governor, Electronic, 62
Drive, Fuel Transfer Pump – DFJA, DFJB Spec L and M, Governor, Woodward, 60, 61
DFJC Begin Spec L, DFJD Begin Spec D, 25
Grille, Control Housing – DFJA, DFJB Spec J Through M,
DFJC Spec J Through N, DFJD Spec B Through F, 67
Elbow, Exhaust – Sets With Pyrometer – Sets With Detector Grille, Control Housing – DFJC Begin Spec P, DFJD Begin
Control, 104 Spec G, 69
Elbow, Exhaust – Sets With Pyrometer – Sets With Grille, Radiator – DFJB, 49
PowerCommand Control – DFJA, DFJB, DFJC Begin Grille, Radiator – DFJC, DFJD, 51
Guard, Belt – Alternator – 45 Amp, 57
Elbow, Outlet – Heat Exchanger, 45
Guard, Belt – Alternator – 75 Amp, 59
Element, Air Cleaner – Heavy Duty – DFJA, DFJB, 22
Guard, Belt – Radiator – DFJA, 47
Element, Air Cleaner – Heavy Duty – DFJC, DFJD, 23
Guard, Belt – Radiator – DFJB, 49
Element, Oil Bypass Filter, 28
Guard, Belt – Radiator – DFJC, DFJD, 51
Exchanger, Heat, 45
Guard, Damper – Sets Wtih Remote Radiator or Heat
External Engine Parts – Sets With Detector Control – DFJA, Exchanger, 42
DFJB Spec M, DFJC Begin Spec M, DFJD Begin Spec E, Guard, Fan – Radiator – DFJA, 47
15
Guard, Fan – Radiator – DFJB, 49
External Engine Parts – Sets With Detector Control – DFJA,
DFJB, DFJC Spec J Through L, DFJD Spec B Through D, Guard, Fan – Radiator – DFJC, DFJD, 51
13 Guard, Heat Exchanger, 45
External Engine Parts – Sets With PowerCommand Control
– DFJA, DFJB Spec K Through M, 17 Harness, Wiring – AC – Engine Coolant Heater Control –
External Engine Parts – Sets With PowerCommand Control DFJA, DFJB Spec M, DFJC Begin Spec M, DFJD Begin
– DFJC Begin Spec K, DFJD Begin Spec C, 19 Spec E, 41

Index
Harness, Wiring – AC Control Door – Sets With Detector Heater, Control – Sets With Detector Control – DFJA, DFJB,
Control, 77 DFJC Begin Spec K, DFJD Begin Spec C, 86
Harness, Wiring – Adapter – Woodward Governor To Engine Heater, Control – Sets With Detector Control – DFJA, DFJB,
Harness, 61 DFJC Spec J, DFJD Spec B, 85
Harness, Wiring – Alarm Relay Board, 90 Heater, Control – Sets With PowerCommand Control –
DFJA, DFJB, DFJC Begin Spec K, DFJD Begin Spec C,
Harness, Wiring – Auxiliary Terminal Block – Sets With 87
Heater, Engine Coolant – DFJA, DFJB Spec M, DFJC Begin
Harness, Wiring – Common Alarm Board – Sets With Spec M, DFJD Begin Spec E, 39
Heater, Engine Coolant – DFJA, DFJB, DFJC Spec J
Harness, Wiring – Control Heater – Sets With Detector Through L, DFJD Spec B Through D, 37
Control – DFJA, DFJB, DFJC Spec J, DFJD Spec B, 85
Heater, Oil Pan, 27
Harness, Wiring – Current Transformer, 120
Hood, Air Inlet – Air Cleaner – Heavy Duty – DFJA, DFJB,
Harness, Wiring – DC – Engine Coolant Heater Control – 22
DFJA, DFJB Spec M, DFJC Begin Spec M, DFJD Begin
Spec E, 41 Hood, Air Inlet – Air Cleaner – Heavy Duty – DFJC, DFJD,
23
Harness, Wiring – DC Control Door – Sets With Detector Hose, Check Valve – Sets With Remote Radiator or Heat
Control, 77 Exchanger, 42
Harness, Wiring – Electronic Governor, 62 Hose, Flexible – Oil Bypass Filter, 28
Harness, Wiring – Electronic Overspeed, 98 Hose, Fuel Pump – Woodward Governor, 61
Harness, Wiring – Engine Coolant Heater – DFJA, DFJB, Hose, Heat Exchanger, 45
Hose, Heater – Engine Coolant Heater – DFJA, DFJB,
Harness, Wiring – Engine to Control – Sets With Detector DFJC Spec J Through L, DFJD Spec B Through D, 37
Control, 84
Hose, Oil Drain – Sets With Detector Control – DFJA, DFJB
Harness, Wiring – Engine To Control – Sets With Spec M, DFJC Begin Spec M, DFJD Begin Spec E, 15
PowerCommand Control – DFJA, DFJB, DFJC Begin
Spec K, DFJD Begin Spec C, 83 Hose, Oil Drain – Sets With Detector Control – DFJA, DFJB,
Harness, Wiring – Excitation Loss Module, 110 Hose, Oil Drain – Sets With PowerCommand Control –
Harness, Wiring – Governor – Paralleling Interconnect DFJA, DFJB Spec K Through M, 17
Terminal Block, 114 Hose, Oil Drain – Sets With PowerCommand Control –
Harness, Wiring – Ground Fault Relay – DFJA, DFJB Spec DFJC Begin Spec K, DFJD Begin Spec C, 19
L and M, DFJC Begin Spec L, DFJD Begin Spec D, 93 Hose, Radiator – DFJA, 47
Harness, Wiring – Junction Box – Engine Coolant Heater – Hose, Radiator – DFJB, 49
DFJA, DFJB, DFJC Spec J Through L, DFJD Spec B
Through D, 34 Hose, Radiator – DFJC, DFJD, 51
Harness, Wiring – Low Battery Voltage Sensor, 97 Hose, Water Inlet – DFJA, DFJB Spec M, DFJC Begin Spec
M, DFJD Begin Spec E, 32
Harness, Wiring – Low Coolant Level Sender – With Housing, Control – DFJA, DFJB Spec J Through M, DFJC
Continuously Monitored Low Coolant Level – 12 Light Spec J Through N, DFJD Spec B Through F, 67
Indicator Controls – Sets With Radiator Cooling, 30
Housing, Control – DFJC Begin Spec P, DFJD Begin Spec
Harness, Wiring – Neutral Sensor – Circuit Breaker – UL G, 69
Listed – DFJA, DFJB Spec K Through M, DFJC Spec K
Through N, DFJD Spec C Through F, 129 Housing, Thermostat – Water Outlet, 33
Harness, Wiring – Over/Under Frequency Relay, 96 Hub, Fan – DFJA, DFJB – DFJC Spec J Through M, 52
Harness, Wiring – Over/Under Voltage – DFJA, DFJB, DFJC Hub, Fan – DFJC Begin Spec N, DFJD Sets With 60”
Spec J and K, DFJD Spec B and C, 94 Diameter Fan, 54
Harness, Wiring – Over/Under Voltage Relay – DFJA, DFJB
Spec L and M, DFJC Begin Spec L, DFJD Begin Spec D, Idler Assembly, Fan – DFJA, DFJB – DFJC Spec J Through
95 M, 52
Harness, Wiring – Paralleling Interconnect Terminal Block, Idler Assembly, Fan – DFJC Begin Spec N, DFJD Sets With
114 60” Diameter Fan, 54
Harness, Wiring – Pigtail – Low Coolant Level Sender – Idler Assembly, Fan – DFJD Sets With 56” Diameter Fan, 53
Sets Without Continuously Monitored Low Coolant Level – Indicator, Service – Air Cleaner – Heavy Duty – DFJA,
Sets With Radiator Cooling, 29 DFJB, 22
Harness, Wiring – Power Factor Meter, 101 Indicator, Service – Air Cleaner – Heavy Duty – DFJC,
Harness, Wiring – Time Delay Start/Stop, 116 DFJD, 23
Harness, Wiring – Transformer – Auxiliary Terminal Block – Indicator, Service – Air Cleaner – Standard – DFJA, DFJB,
Sets With Detector Control, 113 20
Harness, Wiring – Wattmeter, 100 Indicator, Service – Air Cleaner – Standard – DFJC, DFJD,
21
Harness, Wiring – Woodward Governor Control, 61 Inlet, Water – DFJA, DFJB Spec M, DFJC Begin Spec M,
Head, Oil Bypass Filter, 28 DFJD Begin Spec E, 32
Heater Components, Engine Coolant – DFJA, DFJB, DFJC Inlet, Water – DFJA, DFJB, DFJC Spec J Through L, DFJD
Spec J Through L, DFJD Spec B Through D, 35 Spec B Through D, 31

Index
Isolator, Vibration – Control Box – Sets With Detector Light, Panel – DC Control Door – Sets With Detector
Control, 77 Control, 81
Isolator, Vibration – Pilot Solenoid – Sets With Line, Flexible – Radiator – DFJA, 47
PowerCommand Control – DFJA, DFJB Spec K Through Line, Flexible – Radiator – DFJB, 49
M, 17
Line, Flexible – Radiator – DFJC, DFJD, 51
Isolator, Vibration – Pilot Solenoid – Sets With
PowerCommand Control – DFJC Begin Spec K, DFJD Line, Fuel – Flexible – Fuel In and Fuel Out – Sets With
Begin Spec C, 19 Detector Control – DFJA, DFJB Spec M, DFJC Begin
Spec M, DFJD Begin Spec E, 15
Line, Fuel – Flexible – Fuel In and Fuel Out – Sets With
Kit, Repair – Radiator Sight Gauge – DFJA, 47 Detector Control – DFJA, DFJB, DFJC Spec J Through L,
DFJD Spec B Through D, 13
Lead, Circuit Breaker – IEC Conformity – DFJA, DFJB Spec Line, Fuel – Flexible – Fuel In and Fuel Out – Sets With
K Through M, DFJC Spec K Through N, DFJD Spec C PowerCommand Control – DFJA, DFJB Spec K Through
Through F, 137 M, 17
Line, Fuel – Flexible – Fuel In and Fuel Out – Sets With
Lead, Circuit Breaker – IEC Conformity – DFJA, DFJB, PowerCommand Control – DFJC Begin Spec K, DFJD
DFJC Spec J, DFJD Spec B, 135 Begin Spec C, 19
Lead, Circuit Breaker – IEC Conformity – DFJC Begin Spec Line, Fuel – Flexible – Fuel Transfer Pump – DFJA, DFJB
P, DFJD Begin Spec G, 143 Spec L and M, DFJC Begin Spec L, DFJD Begin Spec D,
Lead, Circuit Breaker – Non–UL Listed – DFJA, DFJB Spec 25
K Through M, DFJC Spec K Through N, DFJD Spec E and Louvre, Generator, 72
F, 155
Lug, Solderless – Circuit Breaker – IEC Conformity – DFJA,
Lead, Circuit Breaker – Non–UL Listed – DFJA, DFJB, DFJB Spec K Through M, DFJC Spec K Through N, DFJD
DFJC Spec J, 153 Spec C Through F, 137
Lead, Circuit Breaker – UL Listed – DFJA, DFJB Spec K Lug, Solderless – Circuit Breaker – IEC Conformity – DFJC
Through M, DFJC Spec K Through N, DFJD Spec C Begin Spec P, DFJD Begin Spec G, 141, 143
Through F, 125
Lug, Solderless – Circuit Breaker – Non–UL LIsted – DFJA,
Lead, Circuit Breaker – UL Listed – DFJA, DFJB, DFJC DFJB Spec K Through M, DFJC Spec K Through N, DFJD
Spec J, 121 Spec E and F, 155
Lead, Circuit Breaker – UL Listed – DFJC Begin Spec P, Lug, Solderless – Circuit Breaker – Non–UL Listed – DFJA,
DFJD Begin Spec G, 133 DFJB Spec K Through M, DFJC Spec K Through N, DFJD
Lead, Circuit Breaker – UL Listed – DFJD Spec B, 123 Spec E and F, 155
Lug, Solderless – Circuit Breaker – UL Listed – DFJA, DFJB
Lead, Circuit Breaker and Disconnect Switch – UL Listed, Spec K Through M, DFJC Spec K Through N, DFJD Spec
IEC Conformity – DFJC Begin Spec P, DFJD Begin Spec C Through F, 127, 129
G, 151
Lug, Solderless – Circuit Breaker – UL Listed – DFJC Begin
Lead, Disconnect Switch – Molded Case – UL Listed – Spec P, DFJD Begin Spec G, 131
DFJA, DFJB Spec L and M, DFJC Spec L Through N,
DFJD Spec D Through F, 145 Lug, Solderless – Circuit Breaker and Disconnect Switch –
UL Listed, IEC Conformity – DFJC Begin Spec P, DFJD
Lead, Disconnect Switch – Molded Case – UL Listed – Begin Spec G, 151
DFJC Begin Spec P, DFJD Begin Spec G, 149
Lug, Solderless – Disconnect Switch – Molded Case – UL
Lead, Thermocouple – Pyrometer – Sets With Detector Listed – DFJA, DFJB Spec L and M, DFJC Spec L
Control, 104 Through N, DFJD Spec D Through F, 145
Lead, Thermocouple – Pyrometer – Sets With Lug, Solderless – Disconnect Switch – Molded Case – UL
PowerCommand Control – DFJA, DFJB, DFJC Begin Listed – DFJC Begin Spec P, DFJD Begin Spec G, 149
Lug, Solderless – Grounding – Skid, 11
Lens, Indicator – Ground Fault Relay – DFJA, DFJB Spec L
and M, DFJC Begin Spec L, DFJD Begin Spec D, 93
Manifold, Inlet – Heat Exchanger, 45
Lens, Indicator – Low Battery Voltage Sensor, 97
Meter, Frequency – Sets With Detector Control, 79
Lens, Indicator – Over/Under Frequency Relay, 96
Meter, Power Factor, 101
Lens, Indicator – Over/Under Voltage – DFJA, DFJB Spec L
and M, DFJC Begin Spec L, DFJD Begin Spec D, 95 Meter, Time Totalizing – Sets With Detector Control, 81
Lens, Indicator Light – Low Coolant Level Sender – With Module, Audible Alarm – Sets With PowerCommand Control
Continuously Monitored Low Coolant Level – 12 Light – DFJA, DFJB, DFJC Begin Spec K, DFJD Begin Spec C,
Indicator Controls – Sets With Radiator Cooling, 30 92
Module, Excitation Loss, 110
Light Assembly, Indicator – DC Control Door – Sets With
Detector Control, 81 Module, Radio Frequency Interference, 111
Light, Indicator – Over/Under Voltage Relay – DFJA, DFJB, Mount, Shock – Ground Fault Relay – DFJA, DFJB Spec L
DFJC Spec J and K, DFJD Spec B and C, 94 and M, DFJC Begin Spec L, DFJD Begin Spec D, 93
Light, Indicator – Replacement – DC Control Door – Sets Mount, Shock – Over/Under Frequency Relay, 96
With Detector Control, 81 Mount, Shock – Over/Under Voltage Relay – DFJA, DFJB,
Light, Indicator – Upper/Lower Scale – Sets With Detector DFJC Spec J and K, DFJD Spec B and C, 94
Control, 79 Mount, Shock – Power Factor Meter, 101

Index
Mount, Shock – Watts Transducer, 100 Relay, Solenoid – Start – Sets With Detector Control –
Mounting, Generator, 73 DFJA, DFJB Spec M, DFJC Begin Spec M, DFJD Begin
Spec E, 15
Relay, Solenoid – Start – Sets With Detector Control –
Outlet, Water, 33 DFJA, DFJB, DFJC Spec J Through L, DFJD Spec B
Through D, 13
Paint, 10 Relay, Voltage – Over/Under – DFJA, DFJB, DFJC Spec J
and K, DFJD Spec B and C, 94
Panel, Control Housing – DFJA, DFJB Spec J Through M, Reservoir, Fuel – Fuel Transfer Pump – DFJA, DFJB Spec L
DFJC Spec J Through N, DFJD Spec B Through F, 67 and M, DFJC Begin Spec L, DFJD Begin Spec D, 25
Panel, Control Housing – DFJC Begin Spec P, DFJD Begin Resistor, Oil Temperature Gauge, 108
Spec G, 69
Pickup, Magnetic – Electronic Governor, 62
Seal, O–Ring – EFC Cavity Plug – Woodward Governor, 61
Pickup, Magnetic – Sets With Detector Control – DFJA,
DFJB, DFJC Spec J Through L, DFJD Spec B Through D, Seal, Thermostat – Water Outlet, 33
13 Sealant, Thread, 10
Pickup, Magnetic – Sets With PowerCommand Control – Sender Assembly – Low Coolant Level – Sets With
DFJA, DFJB Spec K Through M, 17 Continuously Monitored Low Coolant Level – 12 Light
Indicator Controls – Sets With Radiator Cooling, 30
Pickup, Magnetic – Sets With PowerCommand Control –
DFJC Begin Spec K, DFJD Begin Spec C, 19 Sender Assembly – Low Coolant Level – Sets Without
Continuously Monitored Low Coolant Level – Sets With
Pickup, Magnetic – Woodward Governor, 61 Radiator Cooling, 29
Plug – Fuel Pump EFC Cavity – Woodward Governor, 61 Sender, Oil Pressure – Sets With Detector Control – DFJA,
Potentiometer – Voltage Adjust – AC Control Door – Sets DFJB Spec M, DFJC Begin Spec M, DFJD Begin Spec E,
With Detector Control, 89 15
Potentiometer, Speed Adjusting – Governor Controller, 106 Sender, Oil Pressure – Sets With Detector Control – DFJA,
DFJB, DFJC Spec J Through L, DFJD Spec B Through D,
Pulley, Alternator – 45 Amp, 57 13
Pulley, Alternator – 75 Amp, 59 Sender, Oil Pressure – Sets With PowerCommand Control –
Pulley, Fan Drive – DFJA, DFJB – DFJC Spec J Through M, DFJA DFJB Spec K Through M, 17
52 Sender, Oil Pressure – Sets With PowerCommand Control –
Pulley, Fan Drive – DFJC Begin Spec N, DFJD Sets With DFJC Begin Spec K, DFJD Begin Spec C, 19
60” Diameter Fan, 54 Sender, Oil Temperature – Engine Block, Oil Pan – Sets
Pulley, Fan Drive – DFJD Sets With 56” Diameter Fan, 53 With PowerCommand Control – DFJC Begin Spec K,
DFJD Begin Spec C, 19
Pump, Fuel Transfer – DFJA, DFJB Spec L and M, DFJC
Begin Spec L, DFJD Begin Spec D, 25 Sender, Oil Temperature – Sets With PowerCommand
Control – DFJA, DFJB Spec K Through M, 17
Pyrometer – Sets With Detector Control, 104 Sender, Oil Temperature Gauge – Oil Pan Mounted, 108
Pyrometer – Sets With PowerCommand Control – DFJA, Sender, Water Temperature – Low Engine Coolant – Sets
DFJB, DFJC Begin Spec K, DFJD Begin Spec C, 105 With Detector Control – DFJA, DFJB Spec M, DFJC Begin
Radiator – DFJA, 47 Sender, Water Temperature – Low Engine Coolant – Sets
With Detector Control – DFJA, DFJB, DFJC Spec J
Radiator – DFJB, 49 Through L, DFJD Spec B Through D, 13
Radiator – DFJC, DFJD, 51 Sensor – Low Battery Voltage, 97
Rail, Mounting – Over/Under Frequency Relay, 96 Shim, Generator Mounting, 73
Rail, Mounting – Over/Under Voltage Relay – DFJA, DFJB, Shroud, Fan – Radiator – DFJC, DFJD, 51
DFJC Spec J and K, DFJD Spec B and C, 94
Skid, 11
Rectifier – Control Box Mounted – Sets With Detector Solenoid, Pilot – Sets With PowerCommand Control –
Control – Alternator – 75 Amp, 59 DFJA, DFJB Spec K Through M, 17
Regulator, Voltage – Alternator – 45 Amp, 57 Solenoid, Pilot – Sets With PowerCommand Control – DFJC
Regulator, Voltage – Manual, 88 Begin Spec K, DFJD Begin Spec C, 19
Regulator, Voltage – Sets With Detector Control, 89 Spacer, Fan – DFJA, DFJB – DFJC Spec J Through M, 52
Relay – Engine Coolant Heater – DFJA, DFJB, DFJC Spec Spacer, Fan – DFJC Begin Spec N, DFJD Sets With 60”
J Through L, DFJD Spec B Through D, 35 Diameter Fan, 54
Relay Assembly, Engine Coolant Heater – DFJA, DFJB, Spacer, Fan – DFJD Sets With 56” Diameter Fan, 53
DFJC Spec J Through L, DFJD Spec B Through D, 35 Spacer, Mounting – Water Filter Assembly – Sets With
Relay, Alarm, 90 Detector Control – DFJA, DFJB Spec M, DFJC Begin
Relay, Frequency – Over/Under, 96
Spacer, Mounting – Water Filter Assembly – Sets With
Relay, Ground Fault – DFJA, DFJB Spec L and M, DFJC Detector Control – DFJA, DFJB, DFJC Spec J Through L,
Begin Spec L, DFJD Begin Spec D, 93 DFJD Spec B Through D, 13
Relay, Power – Engine Coolant Heater Control – DFJA, Spacer, Mounting – Water Filter Assembly – Sets With
DFJB Spec M, DFJC Begin Spec M, DFJD Begin Spec E, PowerCommand Control – DFJA, DFJB Spec K Through
41 M, 17

Index
Spacer, Mounting – Water Filter Assembly – Sets With Switch, Rocker – DC Control Door – Sets With Detector
PowerCommand Control – DFJC Begin Spec K, DFJD Control, 81
Begin Spec C, 19 Switch, Rotary – Voltmeter/Ammeter – Sets With Detector
Standoff, Insulator – Circuit Breaker – IEC Conformity – Control, 79
DFJA, DFJB Spec K Through M, DFJC Spec K Through Switch, Selector – Left/Right Exhaust – Pyrometer –
N, DFJD Spec C Through F, 137 Generator Sets With Detector Control, 104
Standoff, Insulator – Circuit Breaker – IEC Conformity – Switch, Temperature – Low Engine Coolant – Sets With
DFJA, DFJB, DFJC Spec J, DFJD Spec B, 135 Detector Control – DFJA, DFJB Spec M, DFJC Begin
Standoff, Insulator – Circuit Breaker – IEC Conformity – Spec M, DFJD Begin Spec E, 15
DFJC Begin Spec P, DFJD Begin Spec G, 141 Switch, Temperature – Low Engine Coolant – Sets With
Standoff, Insulator – Circuit Breaker – Non–UL Listed – Detector Control – DFJA, DFJB, DFJC Spec J Through L,
DFJA, DFJB Spec K Through M, DFJC Spec K Through DFJD Spec B Through D, 13
N, DFJD Spec E and F, 155 Switch, Temperature – Low Engine Coolant – Sets With
Standoff, Insulator – Circuit Breaker – Non–UL Listed – PowerCommand Control – DFJA, DFJB Spec K Through
DFJA, DFJB, DFJC Spec J, 153 M, 17
Standoff, Insulator – Circuit Breaker – UL Listed – DFJA, Switch, Temperature – Low Engine Coolant – Sets With
DFJB Spec K Through M, DFJC Spec K Through N, DFJD PowerCommand Control – DFJC Begin Spec K, DFJD
Spec C Through F, 127, 129 Begin Spec C, 19
Standoff, Insulator – Circuit Breaker – UL Listed – DFJC Switch, Thermostat – High Engine Coolant Temperature –
Begin Spec P, DFJD Begin Spec G, 131 Sets With Detector Control – DFJA, DFJB DFJC Spec J
Through L, DFJD Spec B Through D, 13
Standoff, Insulator – Circuit Breaker – UL Listed – DFJD
Spec B, 123 Switch, Thermostat – High Engine Coolant Temperature –
Sets With Detector Control – DFJA, DFJB Spec M, DFJC
Standoff, Insulator – Circuit Breaker and Disconnect Switch Begin Spec M, DFJD Begin Spec E, 15
– UL Listed, IEC Conformity – DFJC Begin Spec P, DFJD
Begin Spec G, 151 Switch, Toggle – Cross Current Compensation Circuit, 115
Standoff, Insulator – Disconnect Switch – Molded Case – UL Switch, Toggle – Woodward Governor, 61
Listed – DFJA, DFJB Spec L and M, DFJC Spec L
Through N, DFJD Spec D Through F, 145
Tachometer, 107
Standoff, Insulator – Disconnect Switch – Molded Case – UL
Listed – DFJC Begin Spec P, DFJD Begin Spec G, 149 Tank, Expansion – Heat Exchanger, 45
Starter, Air, 55 Terminal Assembly (T26) – Sets With Detector Control –
DFJA, DFJB, DFJC Spec J Through L, DFJD Spec B
Strainer, Fuel – Sets With Detector Control – DFJA, DFJB Through D, 13
Spec M, DFJC Begin Spec M, DFJD Begin Spec E, 15
Thermostat – Control Heater – Sets With Detector Control –
Strainer, Fuel – Sets With Detector Control – DFJA, DFJB, DFJA, DFJB, DFJC Spec J, DFJD Spec B, 85
Thermostat, Engine Coolant Heater – DFJA, DFJB Spec M,
Strainer, Fuel – Sets With PowerCommand Control – DFJA, DFJC Begin Spec M, DFJD Begin Spec E, 39
DFJB Spec K Through M, 17
Transducer, Watts, 100
Strainer, Fuel – Sets With PowerCommand Control – DFJC Transducer, Watts – Power Factor Meter, 101
Begin Spec K, DFJD Begin Spec C, 19
Transformer – Auxiliary Terminal Block – Sets With Detector
Strap, Ground – Control Box – Sets With Detector Control, Control, 113
77
Transformer, Current, 120
Strip, Marker – Terminal Block – Woodward Governor, 61
Transformer, Current – Cross Current Compensation Circuit,
Support, Alternator – 45 Amp, 57 115
Support, Alternator – 75 Amp, 59 Transformer, Current – Differential, 119
Support, Fan – DFJA, DFJB – DFJC Spec J Through M, 52 Transformer, Current – VAR Power Factor Controller, 102
Support, Fan – DFJC Begin Spec N, DFJD Sets With 60” Trip, 24 Volt Shunt – Circuit Breaker – Non–UL Listed –
Diameter Fan, 54 DFJA, DFJB Spec K Through M, DFJC Spec K Through
Support, Fan – DFJD Sets With 56” Diameter Fan, 53 N, DFJD Spec E and F, 155
Switch, Disconnect – Molded Case – UL Listed – DFJA, Trip, 24 Volt Shunt – Circuit Breaker – Non–UL Listed –
DFJB Spec L and M, DFJC Spec L Through N, DFJD DFJA, DFJB, DFJC Spec J, 153
Spec D Through F, 145 Tube, Air Inlet – Air Cleaner – Heavy Duty – DFJA, DFJB,
Switch, Disconnect – Molded Case – UL Listed – DFJC 22
Begin Spec P, DFJD Begin Spec G, 149 Tube, Air Inlet – Air Cleaner – Heavy Duty – DFJC, DFJD,
Switch, Disconnect – UL LIsted, IEC Conformity – DFJC 23
Begin Spec P, DFJD Begin Spec G, 151 Tube, Air Inlet – Air Cleaner – Standard – DFJA, DFJB, 20
Switch, Oil Pressure – Sets With Detector Control – DFJA, Tube, Air Inlet – Air Cleaner – Standard – DFJC, DFJD, 21
DFJB Spec M, DFJC Begin Spec M, DFJD Begin Spec E,
15 Tube, Copper – Fuel Pressure Gauge, 26
Switch, Oil Pressure – Sets With Detector Control – DFJA, Tube, Heater – Engine Coolant Heater – DFJA, DFJB Spec
DFJB, DFJC Spec J Through L, DFJD Spec B Through D, M, DFJC Begin Spec M, DFJD Begin Spec E, 39
13 Tube, Inlet – Heat Exchanger, 45
Switch, Pushbutton – Emergency Stop, 109 Tube, Outlet – Heat Exchanger, 45

Index
Tube, Radiator Inlet – DFJA, 47 Valve, Shutoff – Oil Drain – Sets With Detector Control –
DFJA, DFJB DFJC Spec J Through L, DFJD Spec B
Tube, Radiator Inlet – DFJB, 49 Through D, 13
Tube, Radiator Inlet – DFJC, DFJD, 51 Valve, Shutoff – Oil Drain – Sets With Detector Control –
Tube, Radiator Outlet – DFJA, 47 DFJA, DFJB Spec M, DFJC Begin Spec M, DFJD Begin
Spec E, 15
Tube, Radiator Outlet – DFJB, 49 Valve, Shutoff – Oil Drain – Sets With PowerCommand
Tube, Radiator Outlet – DFJC, DFJD, 51 Control – DFJA, DFJB Spec K Through M, 17
Tube, Water Inlet – DFJA, DFJB Spec M, DFJC Begin Spec Valve, Shutoff – Oil Drain – Sets With PowerCommand
M, DFJD Begin Spec E, 32 Control – DFJC Begin Spec K, DFJD Begin Spec C, 19
Valve, Solenoid – Heat Exchanger, 45
Tube, Water Outlet, 33
Valve, Thermostatic, 43
Voltmeter, AC – Sets With Detector Control, 79
Valve, Check – Heat Exchanger Expansion Tank, 45 Voltmeter, DC – Sets With Detector Control, 81
Valve, Check – Radiator – DFJA, 47
Valve, Check – Radiator – DFJB, 49 Wattmeter, 100
Valve, Check – Radiator – DFJC, DFJD, 51 Wrapper, Control Box – Sets With PowerCommand Control
– DFJA, DFJB Spec J Through M, DFJC Spec J Through
Valve, Check – Sets With Remote Radiator or Heat N, DFJD Spec B Through F, 67
Exchanger, 42
Wrapper, Control Box – Sets With PowerCommand Control
Valve, Fuel Pressure Gauge, 26 – DFJC Begin Spec P, DFJD Begin Spec G, 69
Valve, Gate – Heat Exchanger, 45 Wrapper, Fan Shroud – Radiator – DFJA, 47
Valve, Shutoff – Fuel Transfer Pump – DFJA, DFJB Spec L Wrapper, Fan Shroud – Radiator – DFJB, 49
and M, DFJC Begin Spec L, DFJD Begin Spec D, 25 Wrapper, Fan Shroud – Radiator – DFJC, DFJD, 51

Abbreviations
Some of the following abbreviations may be used throughout this Parts Catalog:
AC Alternating Current mm Millimeter
Amp Ampere MOH Mobile Off Highway
A/R As Required NFS Not For Sale
AVR Automatic Voltage Regulator NPT National Pipe Thread
AWG American Wire Gauge OD Outside Diameter
DC Direct Current oz. Ounce
Deg Degree PC Printed Circuit
EFC Electronic Fuel Control Ph Phase
EIT External/Internal Tooth PMG Permanent Magnet Generator
EPROM Erasable Programmable Read PT/CT Potential Transformer/Current
Only Memory Transformer
ET External Tooth RFI Radio Frequency Interference
GFI Ground Fault Interrupter RT Right
ID Inside Diameter Spec Specification
IEC International Electrotechnical Thk Thick
Commission UL Underwriters Laboratories Inc.
IT Internal Tooth UNC Union National Coarse
kW Kilowatt UNF Union National Fine
LPG Liquid Petroleum Gas VAC Volts Alternating Current
LT Left VDC Volts Direct Current
M(meter number) Meter W/(ET, IT, EIT) With
Paint and Thread Sealant
REF PART QTY PART REF PART QTY PART

NO. NO. USED DESCRIPTION NO. NO. USED DESCRIPTION
Onan Green Enamel Cummins Beige Enamel

(Non–Metallic) 525–0551–02 – 12 oz. Pressurized
525–0305 – 12 oz. Pressurized Spray Can
Spray Can 525–0551–03 – Quart Can
525–0306 – Quart Can 525–0551–04 – Gallon Can
525–0304 – Gallon Can 518–0601 – Sealant, Thread (6 ml Tube)
10
Skid
3
1 6
13
3
15
14
8
10
3 9 7
12 3
11
4
CP01,P074,077

1 403–3155 1 Skid 10 870–0281 1 Nut, Locking – Hex Head

2 800–0163 2 Screw, Cap – Hex Head (3/8–16) DFJA, DFJB,
(3/4–10 x 4”) DFJC Spec J Through L,
3 526–0027 12 Washer, Flat (3/4”) DFJD Spec B Through D
4 850–0079 6 Washer, Lock – Spring (3/4”) 11 800–0158 8 Screw, Cap – Hex Head
5 862–0008 6 Nut, Hex (3/4–10) (3/4–10 x 2–3/4”) DFJA,
6 800–0158 4 Screw, Cap – Hex Head DFJB Spec M, DFJC Begin
(3/4–10 x 2–3/4”) Spec M, DFJD Begin Spec
7 332–2001 1 Lug, Solderless – Grounding E
– DFJA, DFJB, DFJC Spec 12 850–0079 8 Washer, Lock – Spring (3/4”)
J Through L, DFJD Spec B DFJA, DFJB Spec M,
Through D DFJC Begin Spec M, DFJD
8 800–0050 1 Screw, Cap – Hex Head Begin Spec E
(3/8–16 x 1”) DFJA, DFJB, 13 821–5004–03 7 Screw, Self–Locking – Hex
DFJC Spec J Through L, Washer Head (3/8–16 x 1”)
DFJD Spec B Through D DFJA, DFJB Spec M,
9 856–0010 1 Washer, Lock – EIT (3/8”) DFJC Begin Spec M, DFJD
DFJA, DFJB, DFJC Spec J Begin Spec E
Through L, DFJD Spec B 14 416–0850 8 Bracket, Retainer
Through D 15 800–0048 8 Screw, Cap – Hex Head
(3/8–16 x 3/4”)

External Engine Parts
Generator Sets With Detector Control
DFJA, DFJB, DFJC Spec J Through L
DFJD Spec B Through D
7
6 9 41
8
7
10 6
42
43
37
38 44
34
36
35 45
5
32 34
33
17 12 40
15
16 29
7
4 30
39
3
2
11 29
14
23 24
27
26
25
31
13
28
22 19
35 18
20
21
5 36 CP01
H461,529,542,546,547
33 P074,077
34


1 309–0269 1 Switch, Temperature – Low 22 503–0249 – Hose – Bulk (1” ID) (Order By
Engine Coolant (S4) The Foot – 3 Feet
2 800–0062 1 Screw, Cap – Hex Head Required)
(3/8–16 x 4”) 23 332–1292 1 Terminal Assembly (Includes
3 850–0050 1 Washer, Lock – Spring (3/8”) Parts Marked *) (T26)
4 193–0375 1 Sender, Water Temperature 24 332–1281 1 * Bracket, Terminal
(E2) 25 809–0036 1 * Screw, Sheet Metal – Round
5 503–0189 2 Clamp, Hose Head (#8 x 7/8”)
6 309–0437 2 Switch, Thermostat – High 26 508–0015 1 * Washer, Fiber
Engine Coolant 27 870–0196 1 * Nut, Insulation
Temperature (Opens at 202 28 332–2634 6 Clamp, “J”
Deg F – Closes at 222 Deg 29 505–0007 2 Bushing, Pipe – Reducer
F) (S2) (1/4” to 1/8”)
7 505–0019 3 Bushing, Pipe – Reducer 30 504–0028 1 Cock, Drain (3/8”)
(1/2” to 3/8”) 31 856–0010 1 Washer, Lock – EIT (3/8”)
8 309–0436 2 Switch, Thermostat – High 32 503–0249 – Hose – Bulk (1” ID) (Order By
Engine Coolant The Foot – 2 Feet
Temperature (Opens at 196 Required)
Deg F – Closes at 216 Deg 33 504–0171 2 Valve, Shutoff
F) (S6 Pre–Alarm) 34 505–0102 3 Nipple, Pipe (3/4” x 1–3/8”)
9 505–0131 2 Bushing, Pipe – Reducer 35 505–0324 2 Nipple, Pipe – Half (3/4” x 2”)
(3/4” to 3/8”) 36 505–0132 2 Elbow, Street – 90 Deg (3/4”)
10 Cable, Battery 37 505–0071 1 Nipple, Pipe (1/4” x 2”)
416–0680 3 10” – Starters and Engine 38 505–0027 1 Coupling, Pipe (1/4”)
Ground (With 2 Ring 39 130–3660–02 4 Spacer (1/2” ID x 1–3/4”)
Terminal Ends) 40 800–0059 4 Screw, Cap – Hex Head
416–0446 2 12–1/2” – Jumper (With (3/8–16 x 3–1/4”)
Red Colored Battery 41 307–2167 1 Relay, Solenoid – Start (K2)
Boot) 42 821–0010 2 Screw, Self–Locking – Hex
416–0964 2 35” – Battery To Starter Washer Head (1/4–20 x
(With 1 Ring End And 1 1/2”)
Bolted End) 43 856–0006 1 Washer, Lock – EIT (1/4”)
416–0639 2 60” – Battery To Starter 44 Line, Fuel – Flexible
(With 1 Ring End And 1 Generator Sets Without
Bolted End) Fuel Transfer Pump –
11 193–0244 1 Sender, Oil Pressure (E1) Feature Option C174
12 309–0641–07 1 Switch, Oil Pressure (Opens 501–0522 1 Fuel In (5/8” ID x 50”)
at 20 Lbs Descending) (S5 501–0520 1 Fuel Out (1/2” ID x 50”)
– Pre–Alarm) Generator Sets With Fuel
13 309–0561 1 Switch, Oil Pressure (Opens Transfer Pump –
at 14 Lbs Descending) (S1) Feature Option C174
14 151–0411 1 Pickup, Magnetic 501–0662 1 Fuel In (1” ID x 84” –
15 800–0090 1 Screw, Cap – Hex Head With 90 Deg Female
(1/2–13 x 1”) Swivel)
16 856–0013 1 Washer, Lock – EIT (1/2”) 501–0652 1 Fuel Out (3/4” ID x 72” –
17 850–0060 1 Washer, Lock – Spring (1/2”) With 90 Deg Female
18 102–1335 1 Plug, Oil Drain (Special) Swivel)
19 508–0292 1 Washer, Sealing – Copper 45 502–1275 1 Strainer, Fuel
20 505–0100 1 Nipple, Pipe (1/2” x 1–1/8”)
21 505–0021 1 Bushing, Pipe – Reducer
(3/4” to 1/2”) * – Parts Included In 332–1292 Terminal Assembly

DFJA, DFJB Spec M
DFJC Begin Spec M
DFJD Begin Spec E
38
8
6
10
7
9
39
40
36
37 41
32
34
33 42
5
30 32
31
19 26
17
18
7 15
4
28 27
35
29
3
2 11
27
1
14
13
12
16
25
24 21
33 20
22
23
5 34 CP01
C174
31 H461,529,542,546,547
32 P077

DFJA, DFJB Spec M
DFJC Begin Spec M
DFJD Begin Spec E

1 309–0269 1 Switch, Temperature – Low 19 850–0060 1 Washer, Lock – Spring (1/2”)

Engine Coolant (S4) 20 102–1335 1 Plug, Oil Drain (Special)
2 800–0062 1 Screw, Cap – Hex Head 21 508–0292 1 Washer, Sealing – Copper
(3/8–16 x 4”) 22 505–0100 1 Nipple, Pipe (1/2” x 1–1/8”)
3 850–0050 1 Washer, Lock – Spring (3/8”) 23 505–0021 1 Bushing, Pipe – Reducer
4 193–0447–01 1 Sender, Water Temperature (3/4” to 1/2”)
(E2) 24 503–0249 – Hose – Bulk (1” ID) (Order By
5 503–0189 2 Clamp, Hose The Foot – 3 Feet
6 309–0576 2 Switch, Thermostat – High Required)
Engine Coolant 25 332–2634 6 Clamp, “J”
Temperature (Opens at 202 26 800–0059 4 Screw, Cap – Hex Head
Deg F – Closes at 222 Deg (3/8–16 x 3–1/4”)
F) (S2) 27 505–0007 2 Bushing, Pipe – Reducer
7 505–0019 2 Bushing, Pipe – Reducer (1/4” to 1/8”)
(1/2” to 3/8”) 28 504–0028 1 Cock, Drain (3/8”)
8 309–0651–02 1 Switch, Thermostat – High 29 856–0010 1 Washer, Lock – EIT (3/8”)
Engine Coolant 30 503–0249 – Hose – Bulk (1” ID) (Order By
Temperature (Opens at 190 The Foot – 2 Feet
Deg F – Closes at 214 Deg Required)
F) (S6 Pre–Alarm) 31 504–0171 2 Valve, Shutoff
9 505–0131 2 Bushing, Pipe – Reducer 32 505–0102 3 Nipple, Pipe (3/4” x 1–3/8”)
(3/4” to 3/8”) 33 505–0324 2 Nipple, Pipe – Half (3/4” x 2”)
10 Cable, Battery 34 505–0132 2 Elbow, Street – 90 Deg (3/4”)
416–0680 3 10” – Starters and Engine 35 130–3660–02 4 Spacer (1/2” ID x 1–3/4”)
Ground (With 2 Ring 36 505–0071 1 Nipple, Pipe (1/4” x 2”)
Terminal Ends) 37 505–0027 1 Coupling, Pipe (1/4”)
416–0446 2 12–1/2” – Jumper (With 38 307–2167 1 Relay, Solenoid – Start (K2)
Red Colored Battery 39 821–0010 2 Screw, Self–Locking – Hex
Boot) Washer Head (1/4–20 x
416–0964 2 35” – Battery To Starter 1/2”)
(With 1 Ring End And 1 40 856–0006 1 Washer, Lock – EIT (1/4”)
Bolted End) 41 Line, Fuel – Flexible
416–0639 2 60” – Battery To Starter Generator Sets Without
(With 1 Ring End And 1 Fuel Transfer Pump –
Bolted End) Feature Option C174
11 193–0448 1 Sender, Oil Pressure 501–0522 1 Fuel In (5/8” ID x 50”)
(Includes Parts Marked *) 501–0520 1 Fuel Out (1/2” ID x 50”)
(E1) Generator Sets With Fuel
12 323–1549 1 * Connector, Receptacle – 4 Transfer Pump –
Place Feature Option C174
13 323–1548 1 * Wedge, Receptacle 501–0662 1 Fuel In (1” ID x 84” –
14 323–1492 4 * Socket, Contact With 90 Deg Female
15 309–0641–07 1 Switch, Oil Pressure (Opens Swivel)
at 20 Lbs Descending) (S5 501–0652 1 Fuel Out (3/4” ID x 72” –
– Pre–Alarm) With 90 Deg Female
16 309–0641–03 1 Switch, Oil Pressure (Opens Swivel)
at 14 Lbs Descending) (S1) 42 502–1275 1 Strainer, Fuel
17 800–0090 1 Screw, Cap – Hex Head
(1/2–13 x 1”)
18 856–0013 1 Washer, Lock – EIT (1/2”) * – Parts Included In 193–0448 Oil Pressure Sender

Generator Sets With PowerCommand Control
DFJA, DFJB Spec K Through M
1
24 13 38
23
36
13 39
20
21
31
33
30 18
34
19
17 25
35
27 18
16
1
13
23
6
2
32
29
36
13
3
4
26
11
9
28 14 37
17 12 8
15 10 10
22
35 19
16
18 1
4 5 7
CP01,C174,H530,532,555,P077


1 193–0432 3 Sender, Oil Temperature (S2 25 130–3660–02 4 Spacer (1/2” ID x 1–3/4”)

Engine Block, E4 Oil Pan) 26 504–0028 1 Cock, Drain (3/8”)
2 193–0444 1 Sender, Oil Pressure (S1) 27 503–0249 – Hose – Bulk (1” ID) (Order By
3 309–0269 1 Switch, Temperature – Low The Foot – 2 Feet
Engine Coolant (S4) Required)
4 505–0019 2 Bushing, Pipe – Reducer 28 503–0249 – Hose – Bulk (1” ID) (Order By
(1/2” to 3/8”) The Foot – 3 Feet
5 307–2621–02 1 Solenoid, Pilot (K4) Required)
6 856–0010 2 Washer, Lock – EIT (3/8”) 29 800–0061 1 Screw, Cap – Hex Head
7 319–2236 1 Bracket, Mounting (3/8–16 x 3–3/4”)
8 402–0610 2 Isolator, Vibration 30 800–0090 1 Screw, Cap – Hex Head
9 812–0067 2 Screw, Machine – Round (1/2–13 x 1”)
Head (#6–32 x 7/8”) 31 800–0059 4 Screw, Cap – Hex Head
10 870–0212 4 Nut, Locking (1/4–20) (3/8–16 x 3–1/4”)
11 151–0411 1 Pickup, Magnetic 32 850–0050 1 Washer, Lock – Spring (3/8”)
12 102–1335 1 Plug, Oil Drain 33 850–0060 1 Washer, Lock – Spring (1/2”)
13 332–2634 3 Clamp, “J” 34 856–0013 1 Washer, Lock – EIT (1/2”)
14 508–0292 1 Washer, Sealing – Copper 35 503–0189 2 Clamp, Hose
15 505–0100 1 Nipple, Pipe – Close (1/2” x 36 821–0033 2 Screw, Self–Locking – Hex
1–1/8”) Washer Head (7/16–14 x
16 504–0171 2 Valve, Shutoff 3/4”)
17 505–0324 2 Nipple, Pipe – Half (3/4” x 2”) 37 870–0183 2 Nut, Hex – W/ET (#6–32)
18 505–0102 3 Nipple, Pipe (3/4” x 1–3/8”) 38 Line, Fuel – Flexible
19 505–0132 2 Elbow, Pipe – 90 Deg (3/4”) Generator Sets Without
20 505–0071 1 Nipple, Pipe (1/4” x 2”) Fuel Transfer Pump –
21 505–0027 1 Coupling, Pipe (1/4”) Feature Option C174
22 505–0021 1 Bushing, Pipe – Reducer 501–0522 1 Fuel In (5/8” ID x 50”)
(3/4” to 1/2”) 501–0520 1 Fuel Out (1/2” ID x 50”)
23 505–0131 2 Bushing, Pipe – Reducer Generator Sets With Fuel
(3/4” to 3/8”) Transfer Pump –
24 Cable, Battery Feature Option C174
416–0680 3 10” – Starters and Engine 501–0662 1 Fuel In (1” ID x 84” –
Ground (With 2 Ring With 90 Deg Female
Terminal Ends) Swivel)
416–0446 2 12–1/2” – Jumper (With 501–0652 1 Fuel Out (3/4” ID x 72” –
Red Colored Battery With 90 Deg Female
Boot) Swivel)
416–0964 2 35” – Battery To Starter 39 502–1275 1 Strainer, Fuel
(With 1 Ring End And 1
Bolted End)
416–0639 2 60” – Battery To Starter
Bolted End)

DFJC Begin Spec K
DFJD Begin Spec C
1
24 14 38
4
14 8
21
22
31
33
30 19
34
20
18 25
35
27 19
17
1
14
4
6
2
32
29 37
3 14
4
26
12
10
28 15 36
18 13 9
16 11 11
23
35 20
17
19 1
4 5 7
CP01,C174,H530,532,555,P077

DFJC Begin Spec K
DFJD Begin Spec C

1 193–0432 3 Sender, Oil Temperature (S2 25 130–3660–02 4 Spacer (1/2” ID x 1–3/4”)

Engine Block, E4 Oil Pan) 26 504–0028 1 Cock, Drain (3/8”)
2 193–0444 1 Sender, Oil Pressure (S1) 27 503–0249 – Hose – Bulk (1” ID) (Order By
3 309–0269 1 Switch, Temperature – Low The Foot – 2 Feet
Engine Coolant (S4) Required)
4 505–0019 2 Bushing, Pipe – Reducer 28 503–0249 – Hose – Bulk (1” ID) (Order By
(1/2” to 3/8”) The Foot – 3 Feet
5 307–2621–02 1 Solenoid, Pilot (K4) Required)
6 856–0010 2 Washer, Lock – EIT (3/8”) 29 800–0061 1 Screw, Cap – Hex Head
7 319–2236 1 Bracket, Mounting (3/8–16 x 3–3/4”)
8 502–1275 1 Strainer, Fuel 30 800–0090 1 Screw, Cap – Hex Head
9 402–0610 2 Isolator, Vibration (1/2–13 x 1”)
10 812–0067 2 Screw, Machine – Round 31 800–0059 4 Screw, Cap – Hex Head
Head (#6–32 x 7/8”) (3/8–16 x 3–1/4”)
11 870–0212 4 Nut, Locking (1/4–20) 32 850–0050 1 Washer, Lock – Spring (3/8”)
12 151–0411 1 Pickup, Magnetic 33 850–0060 1 Washer, Lock – Spring (1/2”)
13 102–1335 1 Plug, Oil Drain 34 856–0013 1 Washer, Lock – EIT (1/2”)
14 332–2634 3 Clamp, “J” 35 503–0189 2 Clamp, Hose
15 508–0292 1 Washer, Sealing – Copper 36 870–0183 2 Nut, Hex – W/ET (#6–32)
16 505–0100 1 Nipple, Pipe – Close (1/2” x 37 505–0007 1 Bushing, Pipe – Reducer
1–1/8”) (1/4” to 1/8”)
17 504–0171 2 Valve, Shutoff 38 Line, Fuel – Flexible
18 505–0324 2 Nipple, Pipe – Half (3/4” x 2”) Generator Sets Without
19 505–0102 3 Nipple, Pipe (3/4” x 1–3/8”) Fuel Transfer Pump –
20 505–0132 2 Elbow, Pipe – 90 Deg (3/4”) Feature Option C174
21 505–0071 1 Nipple, Pipe (1/4” x 2”) 501–0522 1 Fuel In (5/8” ID x 50”)
22 505–0027 1 Coupling, Pipe (1/4”) 501–0520 1 Fuel Out (1/2” ID x 50”)
23 505–0021 1 Bushing, Pipe – Reducer Generator Sets With Fuel
(3/4” to 1/2”) Transfer Pump –
24 Cable, Battery Feature Option C174
416–0680 3 10” – Starters and Engine 501–0662 1 Fuel In (1” ID x 84” –
Ground (With 2 Ring With 90 Deg Female
Terminal Ends) Swivel)
416–0446 2 12–1/2” – Jumper (With 501–0652 1 Fuel Out (3/4” ID x 72” –
Red Colored Battery With 90 Deg Female
Boot) Swivel)
Bolted End)
Bolted End)

Air Cleaner
Standard
DFJA, DFJB
2
3
4 6
5 1
4 8
6 10 7 9
4
1 4
4
7 12
9 4
8 6
6
13 5
4
11 3
14
17 15 2
16 D041

1 140–2501 2 Cleaner, Air (Disposable) 12 870–0281 8 Nut, Hex – Locking (3/8–16)

2 503–1870–11 2 Clamp, Hose 13 140–2515 1 Bracket, Mounting
3 503–1675 2 Hose, Rubber – Reducer (7” 14 821–0033 8 Screw, Self–Locking – Hex
ID to 5” ID) Washer Head (7/16–14 x
4 503–1870–14 10 Clamp, Hose 3/4”)
5 140–2519 2 Tube, Air Inlet (7” x 9”) 15 821–0016 2 Screw, Self–Locking – Hex
6 503–0970 4 Elbow (90 Deg) Washer Head (5/16–18 x
7 140–2509 2 Tube, Air Inlet 3/4”)
8 140–1548 2 Indicator, Service 16 870–0257 2 Nut, Hex – Locking (5/16–18)
9 140–1260 2 Fitting, Safety Filter 17 518–0548–08 2 Clamp, “J”
10 140–2502 4 Band, Mounting
11 821–0029 8 Screw, Self–Locking – Hex
Washer Head (3/8–16 x
3/4”)

Air Cleaner
Standard
DFJC, DFJD
12
8 1
13
1
15
9 10 11
6
7 10 5 15
15
2
17 4
16
20
22
16
21
14
16
17 14
3
18
D041
19

1 140–2501 2 Cleaner, Air (Disposable) 14 821–0029 7 Screw, Self–Locking – Hex

2 140–2514 1 Bracket, Mounting Washer Head (3/8–16 x
3 140–2504–01 1 Bracket – Right Side 3/4”)
4 140–2504–02 1 Bracket – Left Side 15 870–0281 8 Nut, Locking – Hex (3/8–16)
5 140–2502 4 Band, Mounting 16 821–0033 6 Screw, Self–Locking – Hex
6 140–2688 2 Tube, Air Inlet Washer Head (7/16–14 x
7 503–1722 2 Elbow, Reducer (45 Deg) (6” 3/4”)
ID to 5–1/2” ID) 17 870–0437 4 Nut, Locking – Hex (7/16–14)
8 503–1717 2 Elbow, Reducer (45 Deg) (7” 18 800–0153 4 Screw, Cap – Hex Head
ID to 6” ID) (3/4–10 x 1–1/2”)
9 503–1870–10 2 Clamp, Hose 19 850–0079 4 Washer, Lock – Spring (3/4”)
10 503–1870–12 4 Clamp, Hose 20 140–2528 1 Shield
11 503–1870–14 2 Clamp, Hose 21 821–0030 1 Screw, Self–Locking – Hex
12 140–1548 2 Indicator, Service Washer Head (3/8–16 x 1”)
13 140–1260 2 Fitting, Service Indicator 22 526–0124 1 Washer, Flat (3/8”)

Air Cleaner
Heavy Duty
DFJA, DFJB
9 20 10
11
20
13
4
1 6
14
15 5
20
16
20
2 7
8
19 12
17 18
22
21 D036

1 140–2301 2 Cleaner, Air (Includes 13 503–1870–12 2 Clamp, Hose

Elements) 14 800–0033 12 Screw, Cap – Hex Head
2 140–2515 1 Bracket, Mounting (7/16–14 x 3/4”)
3 503–1703 2 Elbow, Reducer – Rubber (90 15 870–0437 6 Nut, Locking – Hex (7/16–14)
Deg) (7” to 6”) 16 821–0028 2 Screw, Self–Locking – Hex
4 140–2509 2 Tube, Air Inlet Washer Head (3/8–16 x
5 503–0970 2 Elbow (90 Deg) 1/2”)
6 140–2519 2 Tube, Air Inlet (7” x 9”) 17 332–2634 2 Clamp, “J”
7 503–1675 2 Hose, Reducer – Rubber (7” 18 821–0018 2 Screw, Self–Locking – Hex
ID to 5–1/2” ID) Washer Head (1/4–20 x
8 140–2052 4 Band, Mounting 5/8”)
9 140–1545 2 Hood, Air Inlet 19 870–0212 2 Nut, Locking – Hex (1/4–20)
10 140–1548 2 Indicator, Service 20 503–1870–14 8 Clamp, Hose
11 140–1260 2 Fitting, Safety Filter 21 140–2465 2 Element, Primary (Outer)
12 503–1870–11 2 Clamp, Hose 22 140–2466 2 Element, Safety (Inner)

Air Cleaner
Heavy Duty
DFJC, DFJD
7
12
8
13 5
15
10 11
9 11 6
2 4
18 15
14
14
14
3 15
20
16
D036
19
17

1 140–2301 2 Cleaner, Air (Includes 11 503–1870–12 6 Clamp, Hose

Elements) 12 140–1548 2 Indicator, Service
2 140–2514 1 Bracket, Mounting 13 140–1260 2 Fitting, Service Indicator
3 140–2504–01 1 Bracket – Right Side 14 821–0033 14 Screw, Self–Locking – Hex
4 140–2504–02 1 Bracket – Lift Side Washer Head (7/16–14 x
5 140–2052 4 Band, Mounting 3/4”)
6 140–2520 2 Tube, Air Inlet 15 870–0437 12 Nut, Locking – Hex (7/16–14)
7 140–1545 2 Hood, Air Inlet 16 800–0152 4 Screw, Cap – Hex Head
8 503–1723 2 Elbow, Rubber – (45 Deg) (3/4–10 x 1–1/4”)
(6”) 17 850–0079 4 Washer, Lock – Spring (3/4”)
9 503–1722 2 Elbow, Reducer (45 Deg) (6” 18 140–2528 1 Shield
ID to 5–1/2” ID) 19 140–2465 2 Element, Primary (Outer)
10 503–1870–10 2 Clamp, Hose 20 140–2466 2 Element, Safety (Inner)

Fuel Transfer Pump
DFJA, DFJB Spec L and M
DFJC Begin Spec L
DFJD Begin Spec D
20
21
19
18
8
13
1
27 22
24 3
23
10 17
9 11
7
14 6 16
25
26 3
3 12
15
3 2
2
4
C174

Fuel Transfer Pump
DFJC Begin Spec L
DFJD Begin Spec D

1 502–1267 1 Connector, Straight (7/8–14 x 12 518–0633 1 Clamp, “J”

1–3/16–12) 13 501–0654 1 Line, Fuel – Flexible (3/4” ID
2 821–5004–02 3 Screw, Self–Locking – Hex x 40”)
Washer Head (3/8–16 x 14 159–1450 2 Bracket
3/4”) 15 159–1448 1 Bracket
3 518–0548–29 5 Clamp, Hose 16 502–1270 1 Valve, Shutoff
4 501–0651 1 Line, Fuel – Flexible (3/4” ID 17 502–1271 1 Elbow – 90 Deg (1–5/16–12
x 67”) x 1–5/16–12)
5 501–0653 1 Line, Fuel – Flexible (1” ID x 18 502–1268 1 Connector, Straight (7/8–14 x
26”) 1–5/16–12)
6 502–1266–02 1 Elbow – 45 Deg (1–5/16–12 19 159–1451 1 Pump, Fuel Transfer
x 1–7/16–12) 20 800–0050 2 Screw, Cap – Hex Head
7 502–1266–01 1 Elbow – 45 Deg (1–1/16–12 (3/8–16 x 1”)
x 1–3/16–12) 21 850–0050 2 Washer, Lock – Spring (3/8”)
8 159–1445 1 Reservoir, Fuel 22 121–0113 1 Gasket, Pump
9 800–0081 2 Screw, Cap – Hex Head 23 121–0111 1 Drive, Pump
(7/16–14 x 3–1/2”) 24 509–0336 1 Seal, O–Ring
10 850–0055 2 Washer, Lock – Spring 25 121–0117 1 Gasket, Hand Hole
(7/16”) 26 121–0116 1 Cover, Hand Hole
11 502–1269 1 Tee (1–3/16–12 x 1–3/16–12 27 509–0337 1 Seal, O–Ring
x 1–1/16–12)

Fuel Pressure Gauge
4
8
5 6
H095

1 193–0128 1 Gauge, Fuel Pressure 6 505–0007 1 Bushing, Pipe – Reducer

(Includes Mounting (1/4” to 1/8”)
Hardware) 7 518–0350 2 Clamp, Insulated
2 193–0029 1 Bracket, Mounting 8 502–0067 1 Connector, Compression –
3 504–0064 1 Valve Male
4 149–2291–01 1 Tube, Copper (82”)
5 502–0034 1 Elbow, Compression – 90
Deg (Includes Nut and
Ring)

Oil Pan Heater
H479,487,488
2

1 Heater, Oil (300 Watt) 2 333–0407–05 1 Heater, Oil (300 Watt, 480 Volt)
333–0407–02 1 120 Volt
333–0407–04 1 240 Volt
27 Redistribution or publication of this document

Oil Bypass Filter
10
8 9
3
1
7
6
7
6
3
5
2
4
H393

1 122–0776 1 Head, Oil Filter 7 509–0272–01 2 Seal, O-Ring

2 122–0777 2 Element, Oil Filter 8 800–0075 2 Screw, Cap – Hex Head
3 501–0537–49 2 Hose, Flexible (18”) (7/16–14 x 2”)
4 502–1043–12 1 Elbow, Male Adapter 9 850–0055 2 Washer, Lock – Spring
5 502–1072–14 2 Elbow, Male Union (7/16”)
6 505–1428 2 Plug, O-Ring 10 502–1072–30 1 Elbow, Male Union

Low Coolant Level Sender
Without Continuously Monitored Low Coolant Level
Generator Sets With Radiator Cooling
3
5
H389,527

193–0481 1 Sender Assembly – Low 4 323–1709 4 *# Socket, Contact

Coolant Level (Includes 5 323–1708 4 *# Seal, Cable
Parts Marked *)
1 193–0468 1 * Sender, Low Coolant Level
(S7) * – Parts Included In 193–0481 Low Coolant Level Sender
2 338–3594 1 * Harness, Wiring – Pigtail – Assembly
Low Coolant Level Sender # – Parts Included In 338–3594 Pigtail Wiring Harness
(Includes Parts Marked #)
3 323–1765 1 *# Connector, Housing – 4 Pin
(S3)

Low Coolant Level Sender
With Continuously Monitored Low Coolant Level
12 Light Indicator Controls
Generator Sets With Radiator Cooling
1
6
4 5
3
7
H389

193–0481 1 Sender Assembly – Low 6 323–1709 4 *# Socket, Contact

Coolant Level (Includes 7 323–1708 4 *# Seal, Cable
Parts Marked *) 8 338–3035–02 1 Harness, Wiring (3 Wire,
1 322–0431–07 1 Lens, Indicator Light (Marked 308”) (S7 to A11)
”Coolant Lo”) 9 226–4661–02 2 Lead (4”) (No Markings)
2 357–0030 1 Diode (6 Amp) (A11TB2–1 to Diode and
3 193–0468 1 * Sender, Low Coolant Level A11TB2–16 to Diode)
(S7)
4 338–3594 1 * Harness, Wiring – Low
Coolant Level Sender * – Parts Included In 193–0481 Low Coolant Level Sender
(Pigtail – 6”) (Includes Parts Assembly
Marked #) (S3 toS3) # – Parts Included In 338–3594 Pigtail Wiring Harness
5 323–1765 1 *# Connector, Housing – 4 Pin
(S3)

Water Inlet
E038

1 130–3681 1 Connection, Water Inlet 5 850–0060 2 Washer, Lock – Spring (1/2”)

2 130–3682 1 Brace, Connection 6 526–0028 2 Washer, Flat (1/2”)
3 130–3685 1 Gasket
(1/2–13 x 1–1/4”)

Water Inlet
DFJA, DFJB Spec M
DFJC Begin Spec M
DFJD Begin Spec E
1
3
E080

1 130–4517 1 Tube, Water Inlet 6 895–0182 – Stripping, Weather – Bulk

2 140–0519 1 Band, Mounting (1/4” Thk x 3/4” Wide)
3 800–0006 2 Screw, Cap – Hex Head (Order By The Foot – 2
(1/4–20 x 7/8”) Feet Required)
4 503–1726 1 Hose (5” ID x 6”) 7 526–0128 4 Washer, Flat (15/32” ID x
5 503–1872–10 2 Clamp, Hose 1–1/2” OD x 1/4” Thk)
8 526–0015 2 Washer, Flat (1/4”)

Water Outlet
4
1
3 2
E038,80

1 309–0612 2 Housing, Thermostat 5 130–3686 2 Tube, Water Outlet

(Includes Seals) 6 800–0051 8 Screw, Cap – Hex Head
2 309–0613 4 Seal, Thermostat (3/8–16 x 1–1/4”)
3 130–3679 2 Gasket, Thermostat Housing 7 850–0050 8 Washer, Lock – Spring (3/8”)
4 130–3680 2 Gasket, Connection

Junction Box
Engine Coolant Heater
3
7 2
6
4
5 1
K505

1 330–0005 1 Box, Junction 7 Harness, Wiring – Junction

2 330–0004 1 Cover, Junction Box Box to Coolant Heater (3
3 812–0079 2 Screw, Machine – Round Wire) (GND,Black,White to
Head (#8–32 x 1/2”) GND–GND,HTR–TH,
4 331–0027 4 Connector, Knockout HTR–EL)
5 332–2634 1 Clamp, “J” 338–2544 1 36”
6 815–0340 2 Screw, Locking – Hex Washer 338–2545 1 70”
Head (#10–32 x 3/8”)

Engine Coolant Heater Components
3
4 2
6
8 12
11 7
10
13
1
14

Heater, Coolant (4000 Watt) 8 331–0531–02 1 Conduit, Flexible (1/2” ID x

333–0512–02 2 120 Volt 11–1/2”)
333–0512–01 2 208, 240, 480 Volt 9 813–0100 4 Screw, Machine – Round
1 179–2661 2 Relay Assembly, Heater Head (#10–32 x 1/2”)
(Includes All Parts Listed 10 813–0103 2 Screw, Machine – Round
Below) (Quantities Listed Head (#10–32 x 3/4”)
Below Are For 1 Heater 11 821–0010 2 Screw, Self–Locking – Hex
Relay Assembly) Washer Head (1/4–20 x
2 130–4079 1 Box, Relay 1/2”)
3 130–4082 1 Cover, Box 12 331–0533 4 Bushing, Antishort (1/2”)
4 307–2762 1 Relay (K1, K2) 13 331–0532 1 Locknut, Sealing (1/2”)
5 331–0027 1 Connector, Romex (3/8”) 14 130–4083 1 Bracket, Mounting
6 331–0010 4 Connector (1/2” x 90 Deg)
7 331–0531–01 1 Conduit, Flexible (1/2” ID x
6”)

2 15
8 8
2 3
7
16
5
8
16
13 7
8
8
9
6
8 11
9 10
14
12
H501,502,556,557


1 Heater, Coolant (4000 Watt) 6 503–1779 – Hose, Heater – Bulk (1” ID)
(Includes Thermostat (Order By The Foot – 4
Indented Below) (See Feet Required)
Separate Page For 7 130–3692 2 Adapter, Heater Hose
Components) 8 503–1872–01 12 Clamp, Hose
333–0512–02 2 120 Volt 9 505–0759 2 Nipple, Combination (1” Pipe
333–0512–01 2 208, 240, 480 Volt to 1” Hose)
333–0468 2 Thermostat, Heater 10 505–1430 1 Tee, Pipe – Reducing (1–1/4”
(Service x 1” x 1”)
Replacement) (Not 11 505–0177 1 Nipple, Pipe (1–1/4” x 1–5/8”)
Illustrated) 12 505–0041 1 Elbow, Pipe – 90 Deg (1”)
2 503–1779 – Hose, Heater – Bulk (1” ID) 13 518–0548–02 2 Clip, Retainer
(Order By The Foot – 5 14 505–0004 1 Nipple, Pipe (1” x 1–1/2”)
Feet Required) 15 Harness, Wiring (K1, K2 to
3 503–1779 – Hose, Heater – Bulk (1” ID) ENG–GND, T26)
(Order By The Foot – 9 338–2760–01 1 Left Side (121”)
Feet Required) 338–2760–02 1 Right Side (85”)
4 130–3866 2 Bracket, Mounting 16 509–0283–01 2 Seal, Retangular Ring
5 870–0212 8 Nut, Locking – Hex Head
(1/4–20)

DFJA, DFJB Spec M
DFJC Begin Spec M
DFJD Begin Spec E
12 1
2
12 3
11
11 1 17
2 4
3
34
30 3
4
15
14 34
13 6 26
7 32
8 9
31
5 4
4
10 3
6
4
7
3 3 36
8
16
9 4 18
35 27
29 38 19
20
4 19 33 28
3
26 27
4 27
36
21
25 19
35 23
24 37
22

DFJA, DFJB Spec M
DFJC Begin Spec M
DFJD Begin Spec E

1 502–1259 2 Coupler (1/2” Male) 25 319–2815 1 Cover, Terminal Box

2 502–1257 2 Connector, Hose – Barbed 26 Heater, Coolant
(Fits 3/4” ID Hose) 333–0639–01 2 4990 Watt
3 503–1634–01 8 Hose, Rubber (3/4” ID x 4”) 333–0639–02 2 6420 Watt
4 503–1136 16 Clamp, Hose 27 332–2634 4 Clamp, “J”
5 505–0041 1 Elbow, Pipe – 90 Deg (1”) 28 130–4538 1 Bracket, Retainer
6 505–0022 2 Bushing, Pipe – Reducer (1” 29 130–4540 1 Tube, Heater
to 1/2”) 30 130–4844 1 Tube, Heater
7 505–0100 2 Nipple, Pipe (1/2” x 1–1/8”) 31 309–0649 1 Thermostat (Opens At 110
8 502–1260 2 Coupler, Brass (1/2”) Deg F, Closes At 130 Deg
9 502–1261 2 Nipple, Brass (1/2”) F) (S11)
10 502–0827 2 Fitting, Hose – Barbed (1/2” 32 Bushing, Pipe – Reducer
ID Pipe to 3/4” ID Hose) 505–0131 1 DFJA, DFJB (3/4” to 3/8 “)
11 130–4519 2 Tube, Heater 505–0019 1 DFJC, DFJD (1/2” to 3/8”)
12 509–0283–01 2 Seal 33 526–0029 1 Washer, Flat (3/8”)
13 505–0004 1 Nipple, Pipe (1” x 1–1/2”) 34 128–0108 – Insulation, Hose – Bulk
14 505–1430 1 Tee, Pipe – Reducing (1–1/4” (Order By The Foot – 7
x 1” x 1”) Feet Required)
15 505–0177 1 Nipple, Pipe (1–1/4 x 1–5/8”) 35 815–0539 6 Screw, Machine – Round
16 130–4539 1 Tube, Heater Head – Cross Recessed
17 130–4541 1 Tube, Heater W/IT (#8–32 x 5/8”)
18 155–3021 2 Clamp, Mounting 36 870–0131 6 Nut, Hex – W/ET (#10–32)
19 870–0550–09 7 Nut, Hex – Flange (3/8–16) 37 – 1 Control Assembly, Coolant
20 130–4546 2 Bracket, Mounting – Coolant Heater (See Separate
Heater Page For Components)
21 821–5004–03 1 Screw, Self–Locking – Hex 38 821–5004–02 5 Screw, Self–Locking – Hex
Washer Head (3/8–16 x 1”) Washer Head (3/8–16 x
22 520–0544 2 Stud, Mounting (3/8–16 x 3/4”)
1–3/16”)
23 526–0128 2 Washer, Flat (3/8”)
24 821–5002–03 4 Screw, Self–Locking – Hex
1/2”)

Engine Coolant Heater Control
DFJA, DFJB Spec M
DFJC Begin Spec M
DFJD Begin Spec E
7 12
11
8
13
16
10
15
14 21
9
19
6 21
23
24
1 22
4 5 21
4
24
3 20
1
4
4 18
17

Engine Coolant Heater Control
DFJA, DFJB Spec M
DFJC Begin Spec M
DFJD Begin Spec E

1 130–4552 2 Cover, Coolant Heater 10 323–1494 1 * Connector, Receptacle (3

2 338–3335–02 1 Harness, Wiring – AC – Pin) (J3)
Coolant Heater (From 11 323–1502 1 * Wedge, Receptacle (Used
Coolant Heater Bottom To With J3)
Coolant Heater Control 12 323–1504 2 * Connector, Plug (2 Pin)
Box) (Includes Conduit (P4,P5)
Connectors) (108”) 13 323–1500 2 * Wedge, Plug (Used With
3 338–3335–01 1 Harness, Wiring – AC – P4,P5)
Coolant Heater (From 14 323–1652 1 * Connector, Plug – 2–Way (2
Coolant Heater Bottom To Pin) (P11)
Coolant Heater Control 15 323–1718 2 * Pin, Contact (Used In P11)
Box) (Includes Conduit 16 323–1445 2 * Seal, Cable (Used With P11)
Connectors) (30”) 17 517–0138–02 2 Plug, Hole (Fits 1–1/8” Hole)
4 331–0554 4 Connector, Conduit – 90 Deg 18 319–2814 1 Box, Terminal
(3/4”) 19 332–3440 2 Jumper, Terminal
5 331–0042 1 Connector, Wiring – DC – 20 307–2859 1 Relay, Power – 24VDC (K11)
Romex (3/4”) 21 815–0447 4 Screw, Machine – Round
6 338–3330 1 Harness, Wiring – DC – Head – Cross Recessed
Engine Heater (From W/IT – Thread Forming
Coolant Heater Control Box (#8–32 x 3/4”)
To Engine And Main 22 332–1469 1 Strip, Marker
Engine Harness) (Includes 23 332–1468 1 Block, Terminal – 12 Place
Parts Marked *) (TB1)
7 357–0030 1 * Rectifier (6 Amp) (Located At 24 331–0555 4 Nut, Connector Lock (3/4–14)
K11 End Of Harness)
(CR1)
8 323–1491 3 * Pin, Contact (Used In J3) * – Parts Included In 338–3330 DC Engine Heater Wiring
9 323–1492 4 * Socket, Contact (Two Used Harness
In P4, Two Used In P5)

Damper Guard
Sets With Remote Radiator or Heat Exchanger
4 5
3 5
11
10
13
7
12
E043

1 130–3715 1 Cover, Damper Guard 8 503–1620 – * Hose – Bulk (3/8” ID) (Order
2 130–3714–01 1 Guard, Damper – Right Side By The Foot – 5 Feet
3 130–3714–02 1 Guard, Damper – Left Side Required)
4 130–3713 1 Guard, Damper – Top 9 505–0018 2 * Bushing, Pipe – Reducer
5 821–5002–03 22 Screw, Self-Locking – Hex (1/2” to 1/4”)
Washer Head (1/4–20 x 10 502–1162 2 * Connector, Hose (3/8”)
1/2”) 11 503–0685 2 * Clamp, Hose
6 821–5004–03 2 Screw, Self-Locking – Hex 12 309–0635–02 2 * Valve, Check
Washer Head (3/8–16 x 1”) 13 505–0153 2 * Coupling, Pipe – Reducer
7 870–0281 2 Nut, Self-Locking – Hex (3/8” x 1/4”)
Washer Head (3/8–16)
* – Parts Used On Sets With Remote Radiator

Thermostatic Valve
3
6
2 7
7 8
9
E045

1 309–0607 1 Valve, Thermostatic 6 800–0138 8 Screw, Cap – Hex Head

2 155–2514 2 Gasket (5/8–11 x 3”)
3 505–1440 1 Flange, Blind 7 526–0112 16 Washer, Flat (5/8”)
4 155–0899 1 Flange, Companion (2–1/2” 8 850–0070 8 Washer, Lock – Spring (5/8”)
ID) 9 862–0007 8 Nut, Hex (5/8–11)
5 505–0103 1 Nipple, Pipe (2–1/2” ID x
2–1/2”)

Heat Exchanger
32
22 30
28 26 21 43 37
27
28
32 40 43
30 41
42 42
61
41 57
17 41
62 24 34
31 23 32 25 29
20 20 30
20
26
18 18
35
19
14 38
20 3
16 20
16 25 52
24 5
9
2 7 51
15 15 60
13 12
52 10
58 8
60 13 59 6 55
58
56
12
59
7
44 4
33 50
54
11
53
45
46 39
48
47 1 E079
36 49

Heat Exchanger

1 130–3772 1 Exchanger, Heat 34 518–0548–08 4 Clamp, Hose

2 130–3773 1 Elbow, Outlet 35 130–3592–02 1 Guard, Heat Exchanger –
3 130–3774 1 Manifold, Inlet Right Side
4 307–2711 1 Valve, Solenoid (2–1/2”) 36 130–3592–01 1 Guard, Heat Exchanger –
5 504–0175 1 Valve, Gate (2–1/2”) Left Side
6 155–0899 1 Flange, Companion (2–1/2”) 37 130–3769 1 Panel, Top
7 505–0103 2 Nipple, Pipe (2–1/2” ID x 38 130–3767 1 Panel, Front
2–1/2”) 39 130–3770 1 Base, Heat Exchanger
8 505–1442 1 Elbow, Flange – 90 Deg 40 508–1090 1 Grommet, Rubber (Fits
(2–1/2” x 2–5/8”) 3–1/4” Hole)
9 505–0044 1 Elbow, Pipe – 90 Deg 41 821–5003–03 15 Screw, Self–Locking – Hex
(2–1/2”) Washer Head (5/16–18 x
10 155–2514 1 Gasket, Flange 3/4”)
11 504–0028 1 Cock, Drain (3/8”) 42 870–0550–07 6 Nut, Flange Head (5/16–18)
12 505–1441 2 Bushing, Pipe – Hex (2–1/2” 43 821–5004–02 13 Screw, Self–Locking – Hex
x 4”) Washer Head (3/8–16 x
13 155–2503 2 Gasket 3/4”)
14 130–3765 1 Tube, Outlet 44 821–0033 6 Screw, Self–Locking – Hex
15 503–1726 2 Hose, Radiator (5” ID x 6”) Washer Head (7/16–14 x
16 503–1872–10 4 Clamp, Hose 3/4”)
17 130–3764 2 Tube, Inlet 45 800–0094 6 Screw – Cap – Hex Head
18 503–1762 2 Hose, Coolant (3” ID x (1/2–13 x 2”)
8–1/2”) 46 526–0219 6 Washer, Flat (1/2”)
19 503–1727 2 Hose, Coolant (3” ID x 10”) 47 850–0060 6 Washer, Lock – Spring (1/2”)
20 503–1872–05 8 Clamp, Hose 48 403–2733–01 6 Washer, Bevel (9/16” ID)
21 130–3766 1 Tank, Expansion 49 862–0016 6 Nut, Hex (1/2–13)
22 130–0449 1 Cap, Expansion Tank 50 800–0133 4 Screw, Cap – Hex Head
23 503–1764 1 Hose, Flexible (1–1/2” ID x (5/8–11 x 1–3/4”)
30”) 51 800–0135 4 Screw, Cap – Hex Head
24 505–1429 2 Nipple, Combination (1–1/2” (5/8–11 x 2–1/4”)
Pipe to 1–1/2” Hose) 52 800–0160 16 Screw, Cap – Hex Head
25 503–1872–02 2 Clamp, Hose (3/4–10 x 3–1/4”)
26 505–0011 4 Elbow, Pipe – Street (1/4”) 53 526–0112 4 Washer, Flat (5/8”)
27 505–0054 1 Plug, Square Head (1/4”) 54 850–0070 4 Washer, Lock – Spring (5/8”)
28 503–1620 – Hose – Bulk (3/8” ID) (Order 55 862–0007 4 Nut, Hex (5/8–11)
By The Foot – 11 Feet 56 505–0114 1 Nipple, Pipe – Short (2–1/2” x
Required) 3”)
29 503–1418 – Hose – Bulk (1/4” ID) (Order 57 870–0550–09 6 Nut, Flange Head (3/8–16)
By The Foot – 9 Feet 58 850–0079 16 Washer, Lock – Spring (3/4”)
Required) 59 862–0008 16 Nut, Hex (3/4–10)
30 502–1162 6 Connector, Hose – Barbed 60 526–0027 16 Washer, Flat (3/4”)
(1/4” Pipe to 3/8” Hose) 61 505–0153 2 Coupling, Pipe – Reducer
31 505–0020 2 Bushing, Pipe – Reducer (3/8” to 1/4”)
(3/4” to 1/4”) 62 309–0635–02 2 Valve, Check (3/8” Pipe to
32 503–0685 7 Clamp, Hose 1/4” Pipe)
33 505–0019 1 Bushing, Pipe – Reducer
(1/2” to 3/8”)

Radiator
DFJA
48 35
35
41 48
35 32 35 41
48 48 66
32 41 53
41 51
67 39 31
34 37
17 66
28
52 50
36 29
16 42
6
55 12
20
62 11 43 56 8
47
14 7 63
14
64
49
13
49 12
14 14 46
9
12 14 1
10
58 43
30 61
17 35 44
34
57 66 48
54
38
13 9
62 13 30 41
9
59
60 68 48
23 65 35
25 4 3
33 27 45
18 24 7
23 26
27 15 44
5 24 21
25 45
24 23
27 2
40 25 21 25
26
22
24
19 E074
27

Radiator
DFJA

1 130–4354 1 Radiator (Includes Cap, 34 821–5004–03 24 Screw, Self–Locking – Hex

Overflow Hose and Sight Washer Head (3/8–16 x 1”)
Gauge) 35 870–0550–09 16 Nut, Locking – Flange Head
2 130–3694 1 Support, Radiator (3/8–16)
3 130–3701 2 Bracket, Radiator 36 130–3693–01 1 Guard, Fan – Left Side
4 130–3702 2 Support, Radiator 37 130–3693–02 1 Guard, Fan – Right Side
5 130–3644 2 Support 38 130–4218 1 Tube, Radiator
6 501–0615 2 Line, Flexible (1/4” ID x 39 130–3775 1 Angle, Stiffener
52–1/4”) 40 800–0092 4 Screw, Cap – Hex Head
7 130–3695 2 Wrapper, Fan Shroud – (1/2–13 x 1–1/2”)
Sides 41 526–0399–19 16 Washer, Flat (3/8”)
8 130–3697 2 Shroud, Fan – Top and 42 505–0376 2 Elbow, Pipe – 45 Deg (3/8”)
Bottom 43 821–5003–01 28 Screw, Self–Locking – Hex
9 503–1872–09 4 Clamp, Hose Washer Head (5/16–18 x
10 130–4217 1 Tube, Radiator Outlet 1/2”)
11 130–3706 1 Tube, Radiator Inlet – Left 44 130–1419 2 Flange, Radiator – Top and
Side Bottom
12 503–1728 4 Hose, Radiator (3” ID x 45 130–3215 2 Flange, Radiator – Sides
5–1/2”) 46 821–0010 8 Screw, Self–Locking – Hex
13 503–1872–01 4 Clamp, Hose Washer Head (1/4–20 x
14 503–1872–05 6 Clamp, Hose 1/2”)
15 800–0156 2 Screw, Cap – Hex Head 47 130–3588 1 Cap, Radiator
(3/4–10 x 2–1/4”) 48 850–0114–07 16 Washer, Lock – Spring (3/8”)
16 821–5002–03 20 Screw, Self–Locking – Hex 49 503–1870–05 2 Clamp, Hose
Washer Head (1/4–20 x 50 130–3712 1 Guard, Belt – Bottom
1/2”) 51 130–3711 1 Guard, Belt – Top
17 850–0050 6 Washer, Lock – Spring (3/8”) 52 130–3710 1 Guard, Belt – Left Side
18 130–3700 4 Bracket, Radiator Support 53 130–3709 1 Guard, Belt – Right Side
19 862–0008 2 Nut, Hex (3/4–10) 54 518–0548–20 2 Clip, Retainer
20 130–3705 1 Tube, Radiator Inlet – Right 55 309–0635–02 2 Valve, Check (3/8” Pipe to
Side 1/4” Pipe)
21 526–0027 4 Washer, Flat (3/4”) 56 130–3699 2 Shroud, Fan Tip
22 850–0079 2 Washer, Lock – Spring (3/4”) 57 130–3660–01 2 Spacer
23 800–0094 10 Screw, Cap – Hex Head 58 800–0050 4 Screw, Cap – Hex Head
(1/2–13 x 2”) (3/8–16 x 1”)
24 850–0060 14 Washer, Lock – Spring (1/2”) 59 130–3703 1 Adapter, Outlet Tube
25 526–0219 12 Washer, Flat (1/2”) 60 130–1229 1 Gasket, Outlet Tube
26 403–2733–01 8 Washer, Bevel 61 870–0437 2 Nut, Hex (7/16–14)
27 862–0016 14 Nut, Hex (1/2–13) 62 503–1634 2 Hose, Rubber (1” ID x 4”)
28 130–3778 1 Angle, Engine 63 503–1418 – Hose – Bulk (1/4” ID) (Order
29 130–4362 1 Kit, Repair – Radiator Sight By The Foot – 7 Feet
Gauge (Includes Glass Required)
Bulb and O–Ring) 64 332–2634 2 Clamp, “J”
30 503–1726 2 Hose, Radiator (5” ID x 6”) 65 526–0141 2 Washer, Flat (7/16”)
31 130–4219 1 Angle, Stiffener 66 821–0030 6 Screw, Self–Locking – Hex
32 821–0035 2 Screw, Self–Locking – Hex Washer Head (3/8–16 x 1”)
Washer Head (3/8–16 x 67 800–0051 2 Screw, Cap – Hex Head
1–1/4”) (3/8–16 x 1–1/4”)
33 815–0384 8 Screw, Hex Washer Head – 68 800–0075 2 Screw, Cap – Hex Head
Thread Forming (3/8–16 x (7/16–14 x 2”)
3/4”)

Radiator
DFJB
30
35
30 35
35 35
16
40 51
15
17 52
36
39
16 37
28
53 34
18 50
11 6 8
6
11
6 14
32
7 1
29 24
38 49
48
46 20
35 45
30 25 54
13
12 22 42
14
43
14
31 41
13 7
22 33
43
13 34
31
9
10
42
9
16
23 43
47
25 35
44
4 26
24
8 45
23 15 19
27
27 25 17
5 24 2 27
25 21 25
21 3
24 25
25
21 24 E074
27

Radiator
DFJB

1 130–3615 1 Radiator (Includes Cap) 28 130–3778 1 Angle, Engine

2 130–3642 2 Spacer, Radiator 29 309–0635–02 2 Valve, Check (3/8” Pipe to
3 130–3639 2 Bracket, Radiator 1/4” Pipe)
4 130–4860 2 Support, Radiator 30 821–0035 4 Screw, Self–Locking – Hex
5 130–3644 2 Support Washer Head (3/8–16 x
6 501–0613 2 Line, Flexible (1/4” ID x 1–1/4”)
53–1/2”) 31 503–1726 2 Hose, Radiator (5” ID x 6”)
7 130–3696 2 Wrapper, Fan Shroud – 32 505–0376 2 Elbow, Pipe – 45 Deg (3/8”)
Sides 33 815–0384 12 Screw, Hex Washer Head –
8 130–3698 2 Shroud, Fan – Top and Thread Forming (3/8–16 x
Bottom 3/4”)
9 503–1872–09 4 Clamp, Hose 34 821–5004–02 24 Screw, Self–Locking – Hex
10 130–4152 1 Tube, Radiator Outlet Washer Head (3/8–16 x
11 130–3648 2 Tube, Radiator Inlet 3/4”)
12 503–1728 4 Hose, Radiator (3” ID x 35 870–0550–09 29 Nut, Lock (3/8–16)
5–1/2”) 36 130–3693–01 1 Guard, Fan – Left Side
13 503–1872–02 4 Clamp, Hose 37 130–3693–02 1 Guard, Fan – Right Side
14 503–1872–05 6 Clamp, Hose 38 130–3660 2 Spacer
15 800–0051 6 Screw, Cap – Hex Head 39 130–3775 1 Angle, Stiffener
(3/8–16 x 1–1/4”) 40 130–4219 1 Angle, Stiffener
16 821–5004–03 10 Screw, Self–Locking – Hex 41 130–4155 1 Tube, Radiator
Washer Head (3/8–16 x 1”) 42 870–0212 8 Nut, Lock (1/4–20)
17 850–0048 6 Washer, Lock – Spring (3/8”) 43 821–5003–01 36 Screw, Self–Locking – Hex
18 821–5002–03 20 Screw, Self–Locking – Hex Washer Head (5/16–18 x
Washer Head (1/4–20 x 1/2”)
1/2”) 44 130–3827 2 Grille
19 403–2733–02 4 Washer, Bevel 45 130–3826 2 Support, Grille – Sides
20 503–1870–05 2 Clamp, Hose 46 518–0633 2 Clip, Retainer
21 800–0092 16 Screw, Cap – Hex Head 47 130–3663 2 Support, Grille – Bottom
(1/2–13 x 1–1/2”) 48 130–3662 2 Support, Grille – Top
22 503–1863 2 Hose, Rubber (1–1/2” ID x 4”) 49 800–0090 8 Screw, Cap – Hex Head
23 800–0094 10 Screw, Cap – Hex Head (1/2–13 x 1”)
(1/2–13 x 2”) 50 130–3712 1 Guard, Belt – Bottom
24 850–0060 34 Washer, Lock – Spring (1/2”) 51 130–3711 1 Guard, Belt – Top
25 526–0219 44 Washer, Flat (1/2”) 52 130–3709 1 Guard, Belt – Right Side
26 403–2733–01 4 Washer, Bevel 53 130–3710 1 Guard, Belt – Left Side
27 862–0016 22 Nut, Hex (1/2–13) 54 130–3588 1 Cap, Radiator

Radiator
DFJC, DFJD
46
35 35
46 16
35
35
51
39 22
52 36
15
16 37
17 28
53 34
50
18 11
6 8
6
14 20
12 7
14 1
54 49 41
40
46 11
14 48
45
35
14 12
30 13
12 25 42
24
31 14
38 43
13
30 7
33
13 34
43
31
9
10 35
29 9
6 16 43
32 23 27
25 24
47
4 26 44
25 8 45
21 27 15
24 23 19
24
5 25 25 17
25 27 2
21
3
25 27
21 25 24 E074
24 27

Radiator
DFJC, DFJD

1 Radiator (Includes Cap and 24 850–0060 34 Washer, Lock – Spring (1/2”)

Overflow Tube) 25 526–0219 44 Washer, Flat (1/2”)
130–3615 1 DFJC 26 403–2733–01 4 Washer, Bevel
130–4167 1 DFJD 27 862–0016 26 Nut, Hex (1/2–13)
2 130–3642 2 Spacer, Radiator 28 130–3778 1 Angle, Engine
3 130–3639 2 Bracket, Radiator 29 309–0635–02 2 Valve, Check (3/8” Pipe to
4 130–4860 2 Support, Radiator 1/4” Pipe)
5 130–3644 2 Support 30 503–1863 2 Hose, Rubber (1–1/2” ID x 4”)
6 501–0614 2 Line, Flexible (1/4” ID x 31 503–1726 2 Hose, Radiator (5” ID x 6”)
59–1/4”) 32 505–0020 2 Bushing, Pipe – Reducer
7 Wrapper, Fan Shroud – (3/4” to 1/4”)
Sides 33 815–0384 12 Screw, Hex Washer Head –
130–3696 2 DFJC Thread Forming (3/8–16 x
DFJD 3/4”)
130–3696–01 2 Sets With 56” Diameter 34 821–5004–02 24 Screw, Self–Locking – Hex
Fan Washer Head (3/8–16 x
130–3696 2 Sets With 60” Diameter 3/4”)
Fan 35 870–0550–09 29 Nut, Locking (3/8–16)
8 130–3698 2 Shroud, Fan – Top and 36 130–3693–01 1 Guard, Fan – Left Side
Bottom 37 130–3693–02 1 Guard, Fan – Right Side
9 503–1872–09 4 Clamp, Hose 38 130–4155 1 Tube, Radiator
10 130–4152 1 Tube, Radiator Outlet 39 130–3775 1 Angle, Stiffener
11 130–3648 2 Tube, Radiator Inlet 40 526–0029 2 Washer, Flat (3/8”)
12 503–1728 4 Hose, Radiator (3” ID x 41 800–0090 8 Screw, Cap – Hex Head
5–1/2”) (1/2–13 x 1”)
13 503–1872–02 4 Clamp, Hose 42 870–0212 8 Nut, Lock (1/4–20)
14 503–1872–05 8 Clamp, Hose 43 821–5003–01 36 Screw, Self–Locking – Hex
15 800–0051 6 Screw, Cap – Hex Head Washer Head (5/16–18 x
(3/8–16 x 1–1/4”) 1/2”)
16 821–5004–03 10 Screw, Self–Locking – Hex 44 130–3827 2 Grille
Washer Head (3/8–16 x 1”) 45 130–3826 2 Support, Grille – Sides
17 850–0048 6 Washer, Lock – Spring (3/8”) 46 821–0035 4 Screw, Self–Locking – Hex
18 821–5002–03 20 Screw, Self–Locking – Hex Washer Head (3/8–16 x
Washer Head (1/4–20 x 1–1/4”)
1/2”) 47 130–3663 2 Support, Grille – Bottom
19 403–2733–02 4 Washer, Bevel 48 130–3662 2 Support, Grille – Top
20 130–3588 1 Cap, Radiator 49 130–3660 2 Spacer
21 800–0092 16 Screw, Cap – Hex Head 50 130–3712 1 Guard, Belt – Bottom
(1/2–13 x 1–1/2”) 51 130–3711 1 Guard, Belt – Top
22 130–4219 1 Angle, Stiffener 52 130–3709 1 Guard, Belt – Right Side
23 800–0094 10 Screw, Cap – Hex Head 53 130–3710 1 Guard, Belt – Left Side
(1/2–13 x 2”) 54 518–0633 2 Clip, Retainer

Fan Drive
DFJA, DFJB
DFJC Spec J Through M
18,19
20 17
13,23
3,6,11,12
5
4
2,3
22
3,16 14
1
3,10,12
7
19,21
15
8

1 130–3667 1 Idler Assembly, Fan (Includes 13 850–0070 4 Washer, Lock – Spring (5/8”)
Idler Lever Assembly, Idler 14 511–0161–04 1 Belt, Ribbed
Pulley and Ring Dowel) 15 815–0769–01 8 Screw, Cap – 12 Point
2 800–0500 2 Screw, Cap – Hex Head (3/4–16 x 4–1/2”)
(7/16–14 x 5–1/2”) Grade 8 16 800–0507 1 Screw, Cap – Hex Head
3 850–0055 5 Washer, Lock – Spring (7/16–14 x 1–1/2”) Grade 8
(7/16”) 17 130–4153 1 Spacer, Fan
4 130–3635 1 Support, Fan 18 800–0106 6 Screw, Cap – Hex Head
5 402–0612 1 Absorber, Shock (1/2–13 x 5–1/2”)
6 800–0077 1 Screw, Cap – Hex Head 19 526–0219 6 Washer, Flat (1/2”)
(7/16–14 x 2–1/2”) 20 130–4533 1 Fan (8 Blade)
7 130–3627 1 Cover 21 800–0088 3 Screw, Cap – Hex Head
8 130–3631 1 Pulley, Fan Drive (1/2–13 x 3/4”)
9 130–3636 1 Hub, Fan 22 800–0163 6 Screw, Cap – Hex Head
10 800–0078 1 Screw, Cap – Hex Head (3/4–10 x 4”)
(7/16–14 x 2–3/4”) 23 800–0135 4 Screw, Cap – Hex Head
11 130–3660 1 Spacer (5/8–11 x 2–1/4”)
12 526–0141 2 Washer, Flat (7/16”)

Fan Drive
DFJD Sets With 56” Diameter Fan
17,24
19
16
22,23
3,6,11,12
5
2,3 4
21
3,15
13
3,10,12
8
1
18,20 7
14

1 130–3667 1 Idler Assembly, Fan (Includes 15 Screw, Cap – Hex Head –

Idler Lever Assembly, Idler Grade 8
Pulley and Ring Dowel) 800–0580 1 7/16–14 x 1–5/8” – Spec
2 800–0500 2 Screw, Cap – Hex Head B Through E
(7/16–14 x 5–1/2”) Grade 8 800–0605 1 7/16–14 x 1–1/4” – Begin
3 Washer (7/16”) Spec F
850–0055 5 Lock – Spring –Spec B 16 130–4153 1 Spacer, Fan
Through E 17 800–0106 6 Screw, Cap – Hex Head
526–0032 3 Flat – Begin Spec F (1/2–13 x 5–1/2”)
4 130–3635 1 Support, Fan 18 850–0060 3 Washer, Lock – Spring (1/2”)
5 402–0612 1 Absorber, Shock Spec B Through E
6 800–0077 1 Screw, Cap – Hex Head 19 130–4537 1 Fan (8 Blade)
(7/16–14 x 2–1/2”) 20 800–0088 3 Screw, Cap – Hex Head
7 130–3627 1 Cover – Spec B Through E (1/2–13 x 3/4”) Spec B
8 Pulley, Fan Drive Through E
130–3631 1 Spec B Through E 21 800–0163 6 Screw, Cap – Hex Head
130–4768 1 Begin Spec F (3/4–10 x 4”)
9 130–4154 1 Pulley,Fan Drive 22 800–0135 4 Screw, Cap – Hex Head
(7/16–14 x 2–3/4”) 23 Washer (5/8”)
11 130–3660 1 Spacer 850–0070 4 Lock – Spring – Spec B
12 526–0141 2 Washer, Flat (7/16”) Through E
13 511–0161–10 1 Belt, Ribbed 526–0038 4 Flat – Begin Spec F
14 815–0769–01 8 Screw, Cap – 12 Point 24 526–0219 6 Washer, Flat (1/2”)
(3/4–16 x 4–1/2”)

Fan Drive
DFJC Begin Spec N
DFJD Sets With 60” Diameter Fan
18 16,17
15
20,21
5 3,6,10,11
4
2,3
19
3,14 12
3,9,11
7
1
13

1 130–3667 1 Idler Assembly, Fan (Includes 14 Screw, Cap – Hex Head

Idler Lever Assembly, Idler (7/16–14 x 1–1/4”)
Pulley and Ring Dowel) 800–0605 1 DFJC – Grade 8
2 800–0500 2 Screw, Cap – Hex Head DFJD
(7/16–14 x 5–1/2”) Grade 8 800–0072 1 Spec B Through E
3 Washer (7/16”) 800–0605 1 Begin Spec F – Grade
526–0032 3 DFJC – Flat 8
DFJD 15 130–4153 1 Spacer, Fan
850–0055 5 Spec B Through E – Lock 16 800–0106 6 Screw, Cap – Hex Head
– Spring (1/2–13 x 5–1/2”)
526–0032 3 Begin Spec F – Flat 17 526–0219 6 Washer, Flat (1/2”)
4 130–3635 1 Support, Fan 18 Fan (8 Blade)
5 402–0612 1 Absorber, Shock DFJC
6 800–0077 1 Screw, Cap – Hex Head 130–4533 1 Spec N and P
(7/16–14 x 2–1/2”) 130–4880 1 Begin Spec R
7 Pulley, Fan Drive DFJD
130–4768 1 DFJC 130–4533 1 Spec F and G
DFJD 130–4880 1 Begin Spec H
130–4165 1 Spec B Through E 19 800–0163 6 Screw, Cap – Hex Head
130–4769 1 Begin Spec F (3/4–10 x 4”)
8 130–3636 1 Hub, Fan 20 800–0135 4 Screw, Cap – Hex Head
(7/16–14 x 2–3/4”) 21 Washer (5/8”)
10 130–3660 1 Spacer 526–0038 4 DFJC – Flat
11 526–0141 2 Washer, Flat (7/16”) DFJD
12 Belt, Ribbed 850–0070 4 Spec B Through E – Lock
511–0161–04 1 DFJC – Spring
511–0161–11 1 DFJD 526–0038 4 Begin Spec F – Flat
13 815–0769–01 8 Screw, Cap – 12 Point
(3/4–16 x 4–1/2”)

Air Starter
5
5
8 7
A300

1 127–0390–01 1 Starter, Air 7 800–2526 2 Screw, Cap – Hex Head

2 127–0395 1 Brace, Starter Motor (M10 x 20)
3 127–0422 1 Cover, Flange – Starter 8 815–0724 4 Screw, Cap – Hex Head
4 502–1054–08 1 Elbow, Street Pipe – 90° (3/8–16 x 1.25)
5 526–0030 6 Washer, Flat (13/32)
(5/8–11 x 1.00)

Alternator
45 Amp
11 14
15 13
12
4
16
2 3
9
10
8
17
1 22 21
20
5
6
19
19
25
7
19
18
22
24
19
23 A333

Alternator
45 Amp

1 130–3870 1 Guard, Belt 16 191–1990 1 Support, Alternator

2 718–1067 1 Screw, Cap – Hex Head 17 191–1983–02 1 Alternator – 45 Amp
(M10 x 90mm) (Includes M16 Nut, Spring
3 191–1989–07 1 Spacer, Mounting Washer and Regulator)
4 821–0022 3 Screw, Self–Locking – Hex 191–2121 1 Regulator – Service
Washer Head (5/16–20 x Replacement (Not
1–1/4”) Illustrated)
5 191–1981 1 Fan, Alternator 18 130–3868 1 Guard, Belt
6 191–1984 1 Pulley, Alternator 19 821–5002–04 21 Screw, Self–Locking – Hex
7 511–0119 1 Belt, V Washer Head (1/4–20 x
8 800–2059 1 Screw, Cap – Hex Head (M8 5/8”)
x 30mm) 20 191–2110 1 Bracket, Adjusting
9 850–2008 1 Washer, Lock – Spring (M8) 21 800–0071 1 Screw, Cap – Hex Head
10 526–0030 1 Washer, Flat (3/8”) (7/16–14 x 1”)
11 191–2021–01 1 Bracket, Alternator 22 850–0055 2 Washer, Lock – Spring
12 800–0500 2 Screw, Cap – Hex Head (7/16”)
(7/16–14 x 5–1/2”) 23 130–3871–02 1 Bracket, Belt Guard
13 526–0098 2 Washer, Flat (7/16”) 24 800–0069 1 Screw, Cap – Hex Head
14 191–2023 2 Sleeve (7/16–14 x 3/4”)
15 191–2017 1 Bracket, Alternator 25 130–3869 1 Guard, Belt

Alternator
75 Amp
9
20
21
4
3
19
24
14 23
6 22
7 16
1 15 3
12 2
3
13
11
5
13 8
13 10
16
18
13
17 A035

Alternator
75 Amp

1 130–3870 1 Guard, Belt 14 191–1942 1 Bracket, Adjusting

(1/2–20 x 6–1/2”) (7/16–14 x 1–3/4”)
3 526–0353 3 Washer, Flat (1/2”) 16 850–0055 2 Washer, Lock – Spring
4 870–0452 1 Nut, Locking (1/2–20) (7/16”)
5 511–0161–02 1 Belt, V 17 130–3871–02 1 Bracket, Belt Guard
(1/2–13 x 1–1/2”) (7/16–14 x 3/4”)
7 850–0060 1 Washer, Lock – Spring (1/2”) 19 305–0653 1 Rectifier (35 Amp) Control
8 130–3869 1 Guard, Belt Box Mounted – Generator
9 821–5004–03 1 Screw, Self–Locking – Hex Sets With Detector Control
Washer Head (3/8–16 x 1”) 20 191–2111 1 Bracket, Alternator
10 130–3868 1 Guard, Belt 21 191–2108 1 Support, Alternator
11 191–1926–02 1 Alternator – 75 Amp 22 800–0500 2 Screw, Cap – Hex Head
12 191–2112 1 Pulley, Alternator (7/16–14 x 5–1/2”)
13 821–5002–04 21 Screw, Self–Locking – Hex 23 526–0098 2 Washer, Flat (7/16”)
Washer Head (1/4–20 x 24 191–2023 2 Sleeve
5/8”)

Woodward Governor
5
17
3
4
16
11
10
13
6
2
1
15
14
9 12
18
7
A131,135,211,212,267

Woodward Governor

1 150–2334 1 Plug – Fuel Pump EFC 6 308–0226 1 * Switch, Toggle – 3 Pole (S16)
Cavity 7 * Block, Terminal (6 Place)
2 509–0272–02 1 Seal, O–Ring – EFC Cavity 332–0699 1 Without Load Sharing
Plug 332–0699 2 With Load Sharing
3 151–0411 1 * Pickup, Magnetic 8 * Strip, Marker
4 338–2526 1 * Harness, Wiring – Woodward 332–0970 1 Without Load Sharing
Governor (7 Wire, 110”) 332–0970 2 With Load Sharing
DFJA, DFJB, DFJC Spec J 9 * Screw, Machine – Round
Through L, DFJD Spec B Head (#8–32 x 3/4”)
Through D (A16 to 822–1050 2 Without Load Sharing
P1,GND,T26,ACT) 822–1050 4 With Load Sharing
5 * Harness, Wiring – Adapter – 10 813–0103 4 * Screw, Machine – Round
Woodward Governor To Head (#10–32 x 3/4”)
Engine Harness (12”) (ACT 11 151–0663–02 1 Spacer (21/64” ID x 1/4”)
to ACT) 12 502–1307 1 Adapter, Female Pipe (1/4”
338–2536 1 Used With Adder Code Female x 1/2–20 Male)
A135 (Hydraulic 13 502–1308 1 Elbow, Male – 90 Deg (1/4”
governor, motorized Male x 3/4–16 Male Flare)
head for remote speed 14 800–0072 4 Screw, Cap – Hex Head
adjustment, externally (7/16–14 x 1–1/4”)
adjustable for a speed 15 850–0055 4 Washer, Lock – Spring
droop of 0% (7/16”)
(isochronous) to 7%) 16 Nut, Hex – Jam (5/16–24)
338–2538 1 Used With Adder Code 864–0017 1 Right Handed Threads
A211 (Electronic 864–0020–01 1 Left Harnded Threads
governor with magnetic 17 501–0537–46 1 Hose, Fuel Pump (15”)
speed pickup, hydraulic 18 502–1045–04 1 Connector, Male (3/8–18
actuator, adjustable for Pipe x 3/4–16 Flare)
a speed droop of 0%
(isochronous) to 5%)
338–2537 1 Used With Adder Code * – Not Used On All Models
A212 (Electronic
governor with magnetic
speed pickup, hydraulic
actuator and hydraulic
backup, load sharing,
adjustable for a speed
droop of 0%
isochronous) to 5% and
load sharing within 5%)
338–2538 1 Used With Adder Code
A267 (Electronic
governor with magnetic
speed pickup, hydraulic
actuator, load sharing,
adjustable for a speed
droop of 0%
(isochronous) to 5%
and load sharing within
5%)

Electronic Governor
3 4
2
6
A332

1 338–2526 1 Harness, Wiring – Electronic 5 850–0030 4 Washer, Lock – Spring (#10)

Governor (7 Wire, 110”) DFJA, DFJB Spec J Through
DFJA, DFJB, DFJC Spec J M, DFJC Spec J Through N,
Through L, DFJD Spec B DFJD Spec B Through F
Through D (A16 to 6 150–2213 1 Cover, Governor Control
P1,GND,T26,ACT) 7 Screw, Self–Locking – Hex
2 151–0411 1 Pickup, Magnetic Washer Head
3 151–0637–01 1 Control, Governor 821–5002–03 4 DFJA, DFJB Spec J
4 Screw Through M, DFJC Spec J
813–0103 4 DFJA, DFJB Spec J Through Through N, DFJD Spec B
M, DFJC Spec J Through N, Through F (1/4–20 x 1/2”)
DFJD Spec B Through F – 821–6002–03 4 DFJC Begin Spec P, DFJD
Machine – Round Head Begin Spec G (M6 x
(#10–32 x 3/4”) 20mm)
821–6001–03 4 DFJC Begin Spec P, DFJD
Begin Spec G –
Self–Locking – Hex Washer
Head (M5 x 16mm)

Entrance Box
DFJA, DFJB, DFJC Spec J
DFJD Spec B
4
2
3 K882

1 319–0890 1 Box, Entrance 4 821–0010 52 Screw, Self–Locking – Hex

2 319–0892 2 Cover Washer Head (1/4–20 x
3 319–0888 1 Cover 1/2”)

Entrance Box
DFJC Spec K Through N
DFJD Spec C Through F
10
3 1
13
11
5
8
8
9 12
6
4
7
7
2 K882

1 319–1957 1 Box, Entrance 9 821–0011 5 Screw, Self–Locking – Hex

2 319–2378 1 Cover Washer Head (1/4–20 x
3 319–1961 1 Cover – Upper 7/8”)
4 319–1925 1 Cover – Lower 10 870–0494 26 Nut, Retaining (1/4–20)
5 319–2377–01 1 Brace, Cover 11 319–2399 2 Brace, Cover (40–1/2”)
6 319–2398 2 Brace, Cover (24”) 12 816–0098 36 Bolt, Carriage (5/16–18 x
7 821–0010 24 Screw, Self–Locking – Hex 5/8”)
Washer Head (1/4–20 x 13 870–0257 36 Nut, Locking (5/16–18)
1/2”)
8 821–0018 21 Screw, Self–Locking – Hex
5/8”)

Entrance Box
DFJC Begin Spec P
DFJD Begin Spec G
8
2
3
8
10
6
8
7
K882
8
1 319–3184 1 Box, Entrance 7 319–3288 2 Brace, Cover (40–1/2”)

2 319–3265 1 Cover 8 821–6002–03 89 Screw, Self–Locking – Hex
3 319–1925 1 Cover – Lower Washer Head (M6 x 16mm)
4 319–1961 1 Cover – Upper 9 821–2035 5 Screw, Self–Locking – Hex
5 319–3264 1 Brace, Cover Washer Head (M6 x 25mm)
6 319–3286 2 Brace, Cover (24”) 10 870–0504 26 Nut, Retaining (M6)

Control Housing
DFJA, DFJB Spec J Through M
DFJC Spec J Through N
DFJD Spec B Through F
18
19
19
21
21
23
24 22
35
28
34
18
36 25
27
31 28
32
30 33
28
18 29
7 17
27 18
18
15
37
38 CP01
H529,530,532,546,547,555

Control Housing
DFJA, DFJB Spec J Through M
DFJC Spec J Through N
DFJD Spec B Through F

1 Panel – Bottom 22 Washer, Flat (3/8”)

319–2771–03 1 Model HC6 Generators 526–0141 10 Model HC6 Generators
319–2771–04 1 Model HC7 Generators 526–0141 6 Model HC7 Generators
2 319–2781–01 1 Panel – Right Side – Lower 23 319–1090 1 Angle, Support (5–1/2”)
3 319–2781–02 1 Panel – Left Side – Lower 24 319–1118 1 Angle, Support (6–1/2”)
4 319–2778 1 Panel – Rear 25 Screw, Self–Locking – Hex
5 319–2779–01 1 Panel – Right Side – Upper Washer Head (5/16–18 x
6 319–2779–02 1 Panel – Left Side – Upper 3/4”)
7 Panel – Front – Sets With Model HC6 Generators
Detector Control 821–5003–03 9 Sets With Detector
319–1089 1 Model HC6 Generators Control
319–1088 1 Model HC7 Generators 821–5003–03 11 Sets With
8 319–1093 1 Cover, Top PowerCommand
9 319–0881 2 Cover, Side – Lower Control
10 319–0879 2 Support – Control Box Model HC7 Generators
11 Bracket, Saddle 821–5003–03 8 Sets With Detector
319–1097 2 Model HC7 Generators 821–5003–03 10 Sets With
12 319–0883 2 Angle, Housing PowerCommand
13 Bracket, Panel Control
319–1091 1 Model HC6 Generators 26 319–1203–01 2 Gusset
319–1092 1 Model HC7 Generators 27 319–2244 2 Wrapper, Control Box – Sets
14 319–2767 1 Grille With PowerCommand
15 508–1057 1 Grommet, Rubber – Sets Control
With Detector Control (Fits 28 870–0550–05 10 Nut, Hex (1/4–20)
2–1/4” Hole) 29 870–0550–07 2 Nut, Hex (5/16–18) Sets With
16 821–5004–02 12 Screw, Self–Locking – Hex PowerCommand Control
Washer Head (3/8–16 x 30 526–1115 2 Washer, Flat (5/16”) Sets
3/4”) With PowerCommand
17 Screw, Self–Locking – Hex Control
Washer Head (1/4–20 x 31 517–0131 2 Plug, Hole (Fits 3/8” Hole)
1/2”) Sets With PowerCommand
821–5002–03 50 Model HC6 Generators Control
821–5002–03 46 Model HC7 Generators 32 332–2634 4 Clamp, “J” – Sets With
18 Screw, Self–Locking – Hex PowerCommand Control
Washer Head (5/16–18 x 33 402–0610 4 Isolator, Vibration
1/2”) 34 870–0550–09 6 Nut, Hex (3/8–16) Sets With
821–5003–01 58 Sets With Detector HC7 Generators
Control 35 Cover, Side – Upper
821–5003–01 80 Sets With 319–1095 2 Without Circuit Breaker,
PowerCommand Entrance Box or BUS Box
Control 319–1095 1 With Circuit Breaker,
19 Screw, Cap – Hex Head Entrance Box or BUS Box
(M10 x 25mm) 36 319–2245 1 Cover, Control Box – Sets
800–2086 15 Model HC6 Generators With PowerCommand
20 Washer, Lock – EIT (1/4”) 37 508–1090 3 Grommet, Rubber – Sets
856–0006 1 Sets With Detector Control With PowerCommand
856–0006 2 Sets With PowerCommand Control
Control 38 Panel, Front – Sets With
21 Washer Lock – Spring (M10) PowerCommand Control
850–2010 15 Model HC6 Generators 319–2243 1 Model HC6 Generators
850–2010 11 Model HC7 Generators 319–2242 1 Model HC7 Generators

Control Housing
DFJC Begin Spec P
DFJD Begin Spec G
24
37
8 24
21
12
11
28
24 22 9
19
24
20 18
21
9 29
32 13
18 9 10
22
16
15
21
36 30 20 24
12
9 23
35 9
2 1 14
9 15
9 24
25 31
17 15
38 3
24 9 33
30
39
24
24
27 9
24 6
34
25
9 39
4
26
9
CP01
H529,530,532,546,547,555

Control Housing
DFJC Begin Spec P
DFJD Begin Spec G
1 Panel – Bottom 22 319–3260 2 Angle, Housing – Model HC6
319–3270–03 1 Model HC6 Generators Generators
319–3270–04 1 Model HC7 Generators 23 Bracket, Panel
2 821–6004–01 12 Screw, Self–Locking – Hex 319–1091 1 Model HC6 Generators
Washer Head (M10 x 319–1092 1 Model HC7 Generators
20mm) Model HC6 24 Screw, Self–Locking – Hex
Generators Washer Head (M8 x 20mm)
3 319–3283–01 1 Panel – Right Side – Bottom Sets With Detector
4 508–1057 1 Grommet, Rubber (Fits Control
2–1/4” Hole) Sets With 821–6003–02 63 Model HC6
Detector Control Generators
5 508–1090 3 Grommet, Rubber (Fits 821–6003–02 62 Model HC7
3–1/4” Hole) Sets With Generators
PowerCommand Control Sets With
6 Panel – Front – Sets With PowerCommand
Detector Control Control
319–3262 1 Model HC6 Generators 821–6003–02 87 Model HC6
319–3261 1 Model HC7 Generators Generators
7 Panel – Front – Sets With 821–6003–02 86 Model HC7
PowerCommand Control Generators
319–3276 1 Model HC6 Generators 25 870–2055 2 Nut, Locking (M8) Sets With
319–3275 1 Model HC7 Generators PowerCommand Control
8 319–1093 1 Cover, Top 26 319–3277 2 Wrapper, Control Box – Sets
9 Screw, Self–Locking – Hex With PowerCommand
Washer Head (M6 x 16mm) Control
Model HC6 Generators 27 Clamp, Retainer – Sets With
821–6002–03 50 Without Circuit Breaker, PowerCommand Control
Entrance Box or BUS 332–2634 2 Engine Side (3/4” ID)
Box 518–0548–42 2 Control Side (1–1/16” ID)
821–6002–03 40 With Circuit Breaker, 28 Washer, Flat (3/8”)
Entrance Box or BUS 526–0141 10 Model HC6 Generators
Box 526–0141 6 Model HC7 Generators
Model HC7 Generators 29 319–3263 1 Angle, Support (5–1/2”)
821–6002–03 46 Without Circuit Breaker, 30 Plug, Hole (Fits 3/8” Hole)
Entrance Box or BUS 517–0131 1 Sets With Detector Control
Box 517–0131 3 Sets Wtih PowerCommand
821–6002–03 36 With Circuit Breaker, Control
Entrance Box or BUS 31 402–0729 4 Isolator, Vibration
Box 32 319–3269 1 Angle, Support (6–1/2”)
10 319–3283–02 1 Panel – Left Side – Bottom 33 319–1203–01 2 Gusset
11 Washer, Lock – EIT (1/4”) 34 526–1115 2 Washer, Flat (5/16”) Sets
856–0006 1 Sets With Detector Control With PowerCommand
856–0006 2 Sets With PowerCommand Control
Control 35 870–2056 6 Nut, Hex (M10) Model HC7
12 319–3258 2 Support, Control Box Generators
13 319–2778 1 Panel – Rear 36 Cover, Side – Upper
14 319–2767 1 Grille 319–1095 2 Without Circuit Breaker,
15 870–2054 10 Nut, Locking (M6) Entrance Box or BUS Box
16 319–3281–01 1 Panel – Right Side – Upper 319–1095 1 With Circuit Breaker,
17 319–0881 2 Cover, Side – Lower Entrance Box or BUS Box
18 Bracket, Saddle 37 800–2086 6 Screw, Cap – Hex Head
319–3267 2 Model HC6 Generators (M10 x 25mm) Model HC7
19 319–3281–02 1 Panel – Left Side – Upper 38 319–2245 1 Cover, Control Box – Sets
20 Screw, Cap – Hex Head With PowerCommand
(M10 x 25mm) Control
800–2086 15 Model HC6 Generators 39 517–0135 1 Plug, Hole (Fits 5/8” Hole)
800–2086 5 Model HC7 Generators
21 Washer, Lock – Spring (M10)

Generator Heater
6
5
15 12
4
10 13
18 11
17
14
2
1 16
3
9 A292,293

Generator Heater

1 Cartridge, Heater (300 Watt) 10 850–2003 1 Washer, Lock – Spring (M3)

333–0438–05 1 120 Volt 11 822–3047 1 Screw, Machine – Pan Head
333–0438–06 1 240 Volt (M3 x 20mm)
2 232–3849 1 Bracket, Mounting – Heater 12 508–0228 1 Grommet
3 332–3024–14 2 Clamp, Loop 13 332–3023 1 Block, Terminal
4 822–3075 6 Screw, Machine – Slotted 14 898–1254–25 1 Sleeving – Heater Leads
Pan Head (M4 x 16mm) (59”)
5 850–2004 2 Washer, Lock – Spring (M4) 15 330–0142 1 Box, Terminal
6 860–2005 2 Nut, Hex (M4) 16 517–0021 1 Plug, Dot Button
7 850–2005 2 Washer, Lock – Spring (M5) 17 330–0141–03 1 Cover, Box
8 860–2006 2 Nut, Hex (M5) 18 330–0141–04 1 Gasket, Cover
9 800–2008 2 Screw, Cap – Hex Head (M5
x 16mm)

Generator Louvre
DFJD

1 Louvre 3 821–2023 12 Screw, Self–Locking – Hex

234–0900–01 2 Frame 6 Generators Washer Head (M5 x 20mm)
234–0900–02 2 Frame 7 Generators
2 Gasket, Louvre

Generator Mounting
7 10
6
8
11
3
4
B246,252,258,259,260,276,282,283,284,288,300,301
302,312,313,314,324,325,326,348,360,372,373,374
CP01

1 Screw, Cap – Hex Head 4 862–0017 2 Nut, Hex (1–1/4–7)

800–0304 2 Model HC6 Generators 5 526–0445 4 Washer, Flat (1–3/8” ID x 3”
(1–1/4–7 x 5–1/2”) OD x .136 Thk) Model HC7
(1–1/4–7 x 4”) 6 850–0060 16 Washer, Lock – Spring (1/2”)
2 Shim (Quantity Used As 7 805–0035 6 Bolt, Place (5/8–11 x 1–1/2”)
Required) Grade 8
Model HC6 Generators 8 526–0416 6 Washer, Flat (5/8”)
232–3552–01 4 1/64” Thk 9 332–3196 1 Clamp, “J”
232–3552–02 4 5/64” Thk 10 Screw, Cap – Hex Head –
403–2921 4 7/64” Thk Grade 8
Model HC7 Generators 800–0576 16 Model HC6 Generators
232–3710–01 4 1/64” Thk (1/2–13 x 1–3/4”)
232–3710–02 4 5/64” Thk 800–0596 16 Model HC7 Generators
232–3710–03 4 1/8” Thk (1/2–13 x 2–1/4”)
3 850–0092 2 Washer, Lock – Spring 11 232–3551 2 Spacer – Model HC6
(1–1/4”) Generators

Generator
Frame 6 (with mounting points 27” wide on center) and Frame 7 (with mounting points 29–17/32” wide on center)
generator component parts cannot be ordered from Onan. Refer to the Newage nameplate and supply all avail-
able information. Contact your nearest Newage distributor for assistance in ordering component parts. For
COMPLETE generator replacement use the 249–XXXX–XX Onan identification number listed below.
Onan Generator
Identification Model
Number
249–0192–04 MV734WE
249–0192–05 MV734WF
249–5061–03 HC634J
249–5061–07 HC634K
249–5063–01 HC634G
249–5063–02 HC634H
249–5063–03 HC634J
249–5063–07 HC634K
249–5064–01 HC734E
249–5064–02 HC734F
249–5065–01 HC634G
249–5065–02 HC634H
249–5065–03 HC634J
249–5065–07 HC634K
249–5066–01 HC634G
249–5066–02 HC634H
249–5066–03 HC634J
249–5066–07 HC634K
249–5067–01 HC734E
249–5088–01 HC634G
249–5088–02 HC634H
249–5088–03 HC634J
249–5088–07 HC634K
Continued...

Generator
Onan Generator
Identification Model
Number
Continued...
249–5089–01 HC634G
249–5089–02 HC634H
249–5089–03 HC634J
249–5089–07 HC634K
249–5090–01 HC634G
249–5090–02 HC634H
249–5090–03 HC634J
249–5090–07 HC634K
249–5092–01 HC734E
249–5092–02 HC734F
249–5093–01 HC734E
249–5095–04 MV734WE
249–5095–05 MV734WF
B246,252,258,259,260,276,282,283,284,
288,300,301,302,312,313,314,324,325,
326,348,360,361,362,372,373,374,392

Detector Control
28
4
32
6
12
13
5
26 18
27 32 2
25
ÂÂ
3
16
10
ÂÂ
ÂÂ
1 21
11 22
ÂÂ
23
14
17
13 8
15 32 7 24
31
30
29
9 20
19
H461,462,529,546,547,
K001

Detector Control

1 815–0388 4 Screw, Pan Head – Cross 13 402–0527 4 Isolator, Vibration

Recessed (#6–32 x 1/2”) 14 526–0018 1 Washer, Flat (1/4”)
2 821–0004 5 Screw, Self–Locking – Hex 15 821–5000–05 3 Screw, Self–Locking – Hex
Washer Head (#10–32 x 5/16”) Washer Head (#10–32 x 1/2”)
3 301–8851 1 Bracket, Mounting – Used On 16 508–0001 1 Grommet (Fits 1–1/16” Hole)
Some Early Models 17 508–0051 1 Grommet (Fits 2” Hole)
4 338–3252 1 Harness, Wiring – DC Control 18 406–0332 2 Receptacle, Fastener
Door Assembly to Engine 19 406–0333 2 Stud, Fastener
Monitor Board (Includes 20 406–0334 2 Washer, Stud Retainer
Connector Housing and 21 332–0052 2 Clip, Wire
Contact Pins) 22 870–0131 5 Nut, Hex – W/ET (#10–32)
5 323–1308 1 Housing, Connector (12 Place) 23 – 1 Door, Assembly – Control – DC
(J4) (See Separate Page For
6 323–1302 11 Pin, Contact Components)
7 Board Assembly, Printed 24 821–0004 8 Screw, Self–Locking – Hex
Circuit – Engine Monitor Washer Head (#10–32 x 5/16”)
(Includes Fuses) (A11) 25 Strap, Ground
300–4295 1 7 Light Control 337–0049 1 Sets Without AC Meters
300–4297 1 12 Light Control 337–0049 3 Sets With AC Meters
8 Fuse 26 800–0024 3 Screw, Cap – Hex Head
Cylinder Shaped (Used On (5/16–18 x 1/2”)
Some Early Models) 27 856–0008 4 Washer, Lock – EIT (5/16”)
321–0270 2 20 Amp (F1,F2) 28 338–2278 1 Harness, Wiring – AC Control
321–0231 1 15 Amp (F3) Door Assembly to TB21
321–0094 2 5 Amp (F4,F5) Terminal Block (Includes TB21
U Shaped Terminal Block)
321–0307–03 2 5 Amp (Tan) (F4, F5) 29 332–0607 1 Block, Terminal – 12 Place
321–0307–06 1 15 Amp (Light Blue) (F3) (TB21)
321–0307–07 2 20 Amp (Yellow) (F1, F2) 30 332–2723 1 Strip, Marker
9 – 1 Door Assembly – Control – AC 31 815–0901–06 2 Screw, Machine – Hex Head
(See Separate Page For (#6–32 x 5/8”)
Components) 32 821–0014 8 Screw, Self–Locking – Hex
10 871–0015 1 Nut, Hex (1/4–20) Washer Head (5/16–18 x 1/2”)
11 853–0008 1 Washer, Lock – ET (#10)
12 Box, Control
Sets Without AC Meters
301–8065 1 Sets With PC Boards
Mounted On 301–8851
L–Shaped Bracket
319–3030 1 Sets With PC Boards
Mounted To Control Box
301–8065 1 Sets With AC Meters

PowerCommand Control
DFJC Begin Spec K
DFJD Begin Spec C
H530,532,555

1 – 1 Control, PowerCommand Note: For PowerCommand Control Service Replacement

Parts, Order PowerCommand Control For Generator Sets
Parts Catalog Number 960–0205.

AC Control Door Assembly
6
2
1
3
11
12
10
5
7
8

1 Door, Control – AC 6 308–1052 1 Switch, Rotary – Voltmeter/

301–9054–01 1 With Four Meter Holes Ammeter (Includes Knob)
301–9054–04 1 With Six Meter Holes (S21)
2 322–0363 1 Light, Indicator – Upper/ 7 355–0189 1 Capacitor – Voltmeter
Lower Scale (DS21, DS22) (.1 Mfd., 500 WVDC) (C21)
3 Voltmeter (M21) 8 517–0302 1 Plug, Hole (Fits 2–1/4” Hole)
302–1148 1 Scale Reads 0–300/600 9 517–0131 1 Plug, Hole (Fits 3/8” Hole) Used
302–1753 1 Scale Reads 0–750 On Some Early Models
302–1938 1 Scale Reads 0–5200 10 303–0032 1 Knob, Rotary Switch (Earlier
4 Ammeter (M22) Round Style) Used On Some
302–1684 1 Scale Reads 0–150/0–300 Early Models
302–1685 1 Scale Reads 0–200/0–400 11 308–1082 1 Knob, Rotary Switch (Later
302–1798 1 Scale Reads 0–1000/0–2000 Wedge Style)
302–1799 1 Scale Reads 0–1500/0–3000 12 815–0875–02 3 Screw, Machine – Round Head
302–1800 1 Scale Reads 0–2000/0–4000 (M4 x 8mm)
5 302–1968 1 Meter, Frequency (M23)

DC Control Door Assembly
3 11 4
2
6
19 5
13
7
14
2
15
18
12
1 8
20
16
22
21
9
10
17

DC Control Door Assembly

1 Door, Control – DC 12 517–0131 1 Plug, Hole (Fits 3/8” Hole) Used

301–9055–02 1 Doors With Three Round On Some Early Models
Gauge Holes 13 193–0250 2 Resistor (Mounted on Oil
301–9055–01 1 Doors With Five Round Pressure and Water
Gauge Holes Temperature Gauges)
2 815–0385 4 Screw, Machine – Round Head (R12, R13)
(#6–32 x 1/2”) 14 308–1010 1 Switch, Rocker – Lamp
3 870–0183 4 Nut, Hex – W/ET (#6–32) Test/Reset Panel Lamp –
4 Light Assembly, Indicator Preheat (S11)
(Includes Wiring Harness and 15 308–1011 1 Switch, Rocker –
Connector Housing) (A12) Run/Stop/Remote (S12)
322–0359–02 1 7 Light Assembly 16 517–0137 1 Plug, Hole (Fits 7/8” Hole) Used
322–0360–02 1 12 Light Assembly On Some Early Models
5 322–0369–02 1 Light, Indicator – Replacement 17 517–0301 1 Plug, Hole (Fits 2” Hole)
6 322–0361 1 Light, Panel (DS11) Quantity Used As Required –
7 322–0017 1 Bulb, Panel Light – Used On Some Early Models
Replacement 18 850–0030 8 Washer, Lock – Spring (#10)
8 193–0466 1 Gauge, Oil Pressure (M11) 19 871–0010 16 Nut, Hex – Brass (#10–32)
9 193–0351 1 Gauge, Water Temperature 20 853–0008 1 Washer, Lock – ET (#10)
(M12) 21 526–0409 8 Washer, Nylon (3/8” OD x .194”
10 302–1642 1 Voltmeter (M13) ID x 1/8” Thk)
11 302–0885 1 Meter, Time Totalizing (M14) 22 526–0049 16 Washer, Flat (#10)

Wiring Harness
Engine to Control
DFJA, DFJB, DFJC Begin Spec K
DFJD Begin Spec C
3
8
4
16 9
5
10 6
11
17
12
18
13
28
19 14
27
20
21
7
29 25
24
22 15
30 26
31
23
H530,532,555

Wiring Harness
Engine to Control
DFJD Begin Spec C

1 Harness, Wiring – Engine To 16 323–1445 10 *#Seal (Used In E2, E3, E4, E6,
Control – Generator Sets With E7)
PowerCommand Control 17 323–1540 3 *#Socket, Connector (2 Place)
338–2606 1 DFJA, DFJB, DFJC Spec K (E2, E3, E4)
and L, DFJD Spec C and D 18 323–1444 4 *#Socket, Contact (Used In E6,
(Includes Parts Marked *) E7)
338–3340 1 DFJA, DFJB Spec M, DFJC 19 332–3096–01 6 *#Socket, Contact (Used In E2,
Begin Spec M, DFJD Begin E3, E4)
Spec E (Includes Parts 20 323–1643–01 1 *#Plug, Connector (6 Place) (P10)
Marked #) 21 323–1666 1 *#Socket, Connector (3 Place)
2 Plug, Connector (23 Place) (E1)
323–1605–03 1 *# Colored Grey (P5) 22 323–1667 3 *#Socket, Contact (Used In E1)
323–1605–02 2 *# Colored Natural (P4, P6) 23 Bracket, Mounting – Terminal
3 323–1614–01 49 *#Socket, Contact (Used In P4, 319–2006–01 1 *# Marked ”26” (T26)
P5, P6) 319–2006–02 1 *# Marked ”GND” (GND–ENG)
4 323–1493 1 #Plug, Connector (3 Place) 24 332–0604 2 *#Block, Terminal (5 Place)
DFJA, DFJB Spec M, DFJC 25 332–1043 8 *#Jumper
Begin Spec M, DFJD Begin 26 815–0538 4 *#Screw, Machine – Round
Spec E (P3) Head – W/IT (#8–32 x 1/2”)
5 323–1503 1 #Wedge – DFJA, DFJB Spec M, 27 332–0604 1 *#Block, Terminal (5 Place)
DFJC Begin Spec M, DFJD (TB–BAT)
Begin Spec E (Used In P3) 28 332–1043 3 *#Jumper (Used On TB–BAT)
6 338–2592–02 1 *#Cable, Magnetic Pickup (97”) 29 321–0339 1 *#Holder Assembly, Fuse (Used
(Includes Indented Sockets On TB–BAT) (Includes
Listed Below) (P1) Indented Parts Listed Below)
323–1614–01 3 *# Socket, Contact 321–0325 1 *# Holder, Fuse
7 323–1580 1 *#Housing, Connector (12 Place) 321–0307–07 1 *# Fuse – 20 Amp (Colored
(J12) Yellow)
8 323–1581 1 *#Wedge (Used In J12) 30 338–3285 2 *#Harness Assembly, Jumper
9 323–1491 5 *#Pin, Contact (Used In J12) (Includes Parts Indented
10 323–1648 5 *#Socket, Contact (Used In P10) Below) (Used On E6, E7)
11 323–1624 1 *#Wedge (Used In P7) 323–1652 2 *# Socket, Connector (2 Place)
12 323–1623 1 *#Plug, Connector (6 Place) (P7) 323–1445 4 *# Seal, Cable
13 Socket, Contact 323–1718 4 *# Pin, Contact
323–1492 6 * DFJA, DFJB, DFJC Spec K 31 332–3496 2 #Pin, Contact – DFJA, DFJB
and L, DFJD Spec C and D Spec M, DFJC Begin Spec M,
(Used In P7) DFJD Begin Spec E (Used In
332–1492 9 # DFJA, DFJB Spec M, DFJC TB1)
Begin Spec M, DFJD Begin
Spec E (Used In P3, P7)
14 323–1615 1 *#Plug (Used In P4, P5, P6) * – Parts Included In 338–2606 Engine Wiring Harness
(Quantity Used As Required) # – Parts Included In 338–3340 Engine Wiring Harness
15 323–1637 2 *#Socket, Connector (2 Place)
(E6, E7)

Wiring Harness
Engine to Control
2
6 1
3
4
7 5
15
8
10
13
17 16 14
9
12
18
11
CP01
H529,546,547

1 Harness, Wiring – Engine To 9 323–1492 6 #Socket, Contact (Used In E1,

Control – Generator Sets With P3)
Detector Control 10 323–1546 1 #Plug, Connector (4 Place) (E1)
338–2996 1 DFJA, DFJB, DFJC Spec J 11 Bracket, Mounting – Terminal
Through L (Includes Parts 319–2006–01 1 *# Marked ”26” (T26)
Marked *) 319–2006–02 1 *# Marked ”GND” (GND–ENG)
338–3346 1 DFJA, DFJB Spec M, DFJC 12 332–0604 2 *#Block, Terminal (5 Place)
Begin Spec M, DFJD Begin 13 332–1043 8 *#Jumper
Spec E (Includes Parts 14 815–0538 4 *#Screw, Machine – Round
Marked #) Head – W/IT (#8–32 x 1/2”)
2 323–1591 1 #Plug, Seal (Used In E1) 15 323–1493 1 #Plug, Connector (3 Place) (P3)
3 323–1548 1 #Wedge (Used in E1) 16 323–1503 1 #Wedge (Used In P3)
4 323–1200 11 *#Socket, Contact (Used In J1, J2) 17 359–0051 1 *#Diode
5 323–1304 1 *#Housing, Connector (6 Place) 18 338–1765–03 1 *Cable, Magnetic Pickup (42”)
(J2)
6 323–1306 1 *#Housing, Connector (8 Place)
(J1) * – Parts Included In 338–2996 Wiring Harness
7 353–0094–01 1 *#Resistor (R1) # – Parts Included In 338–3346 Wiring Harness
8 357–0030 1 *#Rectifier (CR1)

Control Heater
DFJD Spec B
10
2 3
8
11 1
8
6
12
7 5
H362,363,529,546,547

1 333–0151 1 Heater (300 Watt, 240 Volt) 6 130–1107 2 Spacer

(HR1) 7 812–0070 2 Screw, Machine – Round Head
2 335–0161 1 Harness, Wiring (7’) (P1) (#6–32 x 1–1/4”)
3 800–0034 2 Screw, Cap – Hex Head 8 854–0006 4 Washer, Lock – IT (#6)
(5/16–18 x 2–1/4”) 9 860–0006 2 Nut, Hex (#6–32)
4 526–0113 2 Washer, Flat (5/16”) 10 870–0183 2 Nut, Hex – W/ET (#6–32)
5 870–0257 2 Nut, Self–Locking – Hex Head 11 301–1886 1 Cover
(5/16–18) 12 309–0128 1 Thermostat – Adjustable (S1)

Control Heater
DFJD Begin Spec C
5 4
7
1 6
H362,363,529,546,547

1 332–3338 2 *#Mount, Cable 6 870–0257 1 *Nut, Locking – Hex (5/16–18)

2 Heater Assembly, Control – 100 7 856–0008 2 *Washer, Lock – EIT (5/16”)
Watt (Includes Rectifier)
300–4515–01 1 * 120 Volt
300–4515–02 1 # 240 Volt * – Parts Used in 120 Volt Control Heater Application
3 357–0114 1 *#Rectifier (3 Amp) # – Parts Used in 240 Volt Control Heater Application
4 335–0173 1 *Cable, Heater (7’)
5 800–0024 1 *Screw, Cap – Hex Head
(5/16–18 x 3/4”)

Control Heater
DFJD Begin Spec C
A362,363

1 Heater Assembly, Control – 100 2 357–0114 1 Rectifier (3 Amp)

Watt (Includes Rectifier) 3 332–3338 1 Mount, Cable
300–4515–01 1 120 Volt
300–4515–02 1 240 Volt

Manual Voltage Regulator
K939

1 305–0817 1 Regulator, Voltage – Manual 3 870–0131 4 Nut, Hex – W/ET (#10–32)

(MVR)
2 821–0005 4 Screw, Self-Locking – Hex
Washer Head (#10–32 x
1/2”)

Voltage Regulator
2
8
4
6
1
5
11 9
12
10
H529,546,547
K001,994

1 303–0285 1 *Potentiometer – Voltage Adjust 7 812–0084 4 Screw, Machine – Round Head

(5K Ohms) (Used With Model (#8–32 x 1”)
MX321 Voltage Regulator) 8 332–1043 1 Jumper (Used On TB21)
(R21) 9 305–0868 1 *Board, Printed Circuit – Isolation
2 305–0823 1 Board, Printed Circuit – Voltage Transformer (T30)
Regulator (MX321) (VR21) 10 813–0108 4 *Screw, Machine – Round Head
3 319–0652 1 Plate, Mounting (#10–32 x 1–1/2”)
4 815–0544 6 Screw, Machine – Round 11 526–0008 4 *Washer, Flat (#10)
Head – Cross Recessed W/IT 12 850–0030 4 *Washer, Lock – Spring (#10)
(#6–32 x 1/2”)
5 350–1222 1 Resistor (1.5K Ohms) (Used On
TB21) * – Not Used On All Models
6 517–0131 1 Plug, Hole (Fits 3/8” Hole)

Alarm Relay Board
8
5
7
1 6
11
KJ02,KJ03
10

1 Board, Printed Circuit – Alarm 5 323–1291 2 *Plug – 9 Place (P1,P2)

Relay (Includes Relay) 6 323–1199 9 *Pin, Contact (Used In P1)
300–4111–02 1 Without Form C Relays 7 323–1200 12 *Socket, Contact (Used In P2,3)
300–4111–04 1 With Form C Relays 8 323–1292 1 *Plug – 4 Place (P3)
2 307–1056 1 Relay (Quantity Used As 9 870–0517–01 4 Standoff (Clear) (1–15/16”)
Required (K1,K2,K3) 10 870–0517–02 2 Standoff (Yellow) (2”)
3 815–0544 6 Screw, Machine – Round 11 307–1157 1 Spring, Relay Hold–Down
Head – Cross Recessed W/IT (Quantiry Used As Required)
(#6–32 x 1/2”)
4 338–2875 1 Harness, Wiring (Includes Parts
Marked *) (A11 To P1,P2,P3) * – Parts Included in 338–2875 Wiring Harness

Common Alarm Board
H542,546
3

1 300–4218–02 1 Board, Printed Circuit – 3 812–0063 4 Screw, Machine – Round Head

Common Alarm (A27) (#6–32 x 1/2”)
2 338–3033 1 Harness, Wiring (12 Wire) (A27
to A11)

Audible Alarm Module
DFJD Begin Spec C
1
4
2
KA08

1 300–3998–01 1 Module, Audible Alarm (DS2) 3 850–0040 2 Washer, Lock – Spring (1/4”)
2 800–0006 2 Screw, Cap – Hex Head 4 862–0001 2 Nut, Hex (1/4”)
(1/4–20 x 7/8”)

Ground Fault Relay
DFJC Begin Spec L
DFJD Begin Spec D
6 11
8 10
13
1
9
3
2
12
8
4
9
H550

1 Harness, Wiring 6 812–0081 2 Screw, Machine – Round Head

338–3235 1 Generator Sets With (#8–32 x 5/8”)
Detector Control (7 Wire, 92”) 7 319–0030 1 Plate, Mounting
(GFA to A11, GND, 8 853–0005 8 Washer, Lock – ET (#8)
NEUTRAL, CONT GND) 9 870–0221 10 Nut, Hex – W/ET (#8–32)
338–3233 1 Generator Sets With 10 226–4406–06 2 Cable, Generator (Generator
PowerCommand Control (7 Neutral to Generator
Wire, 119”) (GFA to TB1, GEN Grounding Bolt) (24”)
NEUTRAL, GND) 11 332–2420 2 Mount, Cable Tie
2 301–6987 1 Bracket, Mounting 12 322–0431–09 1 Lens, Indicator Light (Amber
3 821–0017 2 Screw, Self–Locking – Hex Color, Marked ”GROUND
Washer Head (5/16–18 x 1/2”) FAULT”) Generator Sets With
4 870–0257 2 Nut, Hex – Self–Locking Detector Control
(5/16–18) 13 307–2843 1 Relay (GFA)
5 402–0354 4 Mount, Shock

Over/Under Voltage Relay
DFJA, DFJB, DFJC Spec J and K
DFJD Spec B and C
11
2
15
7
3
6
13
5
12
6
8
10
14
7 K881

1 307–2921–01 1 Relay, Voltage (A17) 9 323–1411–01 2 Clip, End

2 338–3752 1 Harness, Wiring – 10 870–0048 2 Nut, Hex – Self–Locking
Over/Under Voltage (5/16–18)
(TB21,A11,GND to A17) (4 11 813–0100 2 Screw, Machine – Round
Wire, 67”) Head (#10–32 x 1/2”)
3 301–9941 1 Plate, Mounting 12 870–0131 2 Nut, Hex – W/ET (#10–32)
4 301–6987 1 Bracket, Mounting 13 526–0008 2 Washer, Flat (#10)
5 402–0354 4 Mount, Shock 14 322–0384–09 1 Light, Indicator – Marked
6 853–0005 8 Washer, Lock – EIT (#8) “O/U VOLT”
7 870–0221 8 Nut, Hex – W/ET (#8–32) 15 332–2879–07 1 Rail, Mounting
8 526–0115 2 Washer, Flat (5/16”)

Over/Under Voltage Relay
DFJC Begin Spec L
DFJD Begin Spec D
K881

1 307–2868 1 Board, Printed Circuit – 3 815–0388 4 Screw, Pan Head – Cross

Over/Under Voltage Relay Recessed (#6–32 x 1/2”)
(A17) 4 322–0431–03 1 Lens, Indicator Light (Marked
2 338–3366 1 Harness, Wiring (6 Wire) (30”) ”O/U VOLT”)

Over/Under Frequency Relay
11
9 15
14
13
6
5 12
8 7
10 K906
4

1 Relay, Frequency – Over/Under 8 526–0115 2 Washer, Flat (5/16”)

(A18) 9 813–0100 2 Screw, Machine – Round Head
307–2920 1 50 Hertz Sets (#10–32 x 1/2”)
307–2919 1 60 Hertz Sets 10 870–0048 2 Nut, Hex – Self-Locking
2 338–2347 1 Harness, Wiring – Over/Under (5/16–18)
Frequency (6 Wire, 62”) 11 323–1411–01 2 Clip, Rail
(TB21,A11,GND to A19) 12 322–0431–04 1 Lens, Replacement – Marked
3 301–9941 1 Plate, Relay Mounting “O/U HZ” (DS20)
4 301–6987 1 Bracket, Mounting 13 870–0131 2 Nut, Hex – W/ET (#10–32)
5 402–0354 4 Mount, Shock 14 526–0008 2 Washer, Flat (#10)
6 853–0005 8 Washer, Lock – ET (#8) 15 332–2879–07 1 Rail, Mounting
7 870–0221 8 Nut, Hex – W/ET (#8–32)

Low Battery Voltage Sensor
4
6
5
H542,543,546

1 322–0431–08 1 Lens, Indicator Light (Marked 5 870–1221 2 *Nut, Hex – W/ET (#8–32)
”Lo Battery”) 6 305–0901 1 *Sensor – Low Battery
2 338–3034 1 *Harness, Wiring (4 Wire) (36”) Voltage (K15)
(K15 to A11)
3 323–1410–03 1 *Base, Relay
4 812–0084 2 *Screw, Machine – Round Head * – Not Used on All Models
(#8–32 x 1”)

Electronic Overspeed
1 B184

1 305–0902–02 1 Board, Printed Circuit – 4 812–0082 4 Screw, Machine – Round Head

Electronic Overspeed (A16) (#8–32 x 3/4”)
2 319–0754 1 Plate, Mounting 5 815–0388 4 Screw, Pan Head – Cross
3 338–2529 1 Harness, Wiring – Electronic Recessed – Thread Forming
Overspeed (AUX to A11, A16) (#6–32 x 1/2”)
(6 Wire, 74”)

Audible Alarm
KA08

1 333–0133 1 Alarm, Audible (DS2) 4 870–0183 2 Nut, Hex – W/ET (#6–32)

2 319–0898 1 Plate, Mounting
3 815–0385 2 Screw, Machine – Round Head
(#6–32 x 1/2”)

Wattmeter
12
4
8
3
11
7
9 1
10
8
5 2
K185

1 302–1722 1 Wattmeter (Dial Not Included) 5 301–6987 1 Bracket, Mounting

(M24) 6 402–0354 4 Mount, Shock
2 Dial, Wattmeter 7 853–0005 8 Washer, Lock – W/ET (#8)
302–1721–15 1 0–700 kW Rating 8 870–0221 8 Nut, Hex – W/ET (#8–32)
302–1721–16 1 0–800 kW Rating 9 526–0115 2 Washer, Flat (5/16”)
302–1721–17 1 0–1200 kW Rating 10 870–0048 2 Nut, Locking (5/16–18)
302–1721–18 1 0–1500 kW Rating 11 319–0030 1 Plate, Mounting
3 Harness, Wiring – Wattmeter 12 Transducer, Watts (A21)
338–1936 1 Reconnectable WYE, Three 302–1833–01 1 2–1/2 Element, Three Phase,
Phase 4 Wire
338–2479 1 120/240 Volt Delta, Three 302–1833–05 1 2 Element, Three Phase,
Phase 3 Wire
4 815–0905–06 2 Screw, Machine – Pan Head –
Cross Recessed (#10–32 x
5/8”)

Power Factor Meter
11
3
8
10
9
5 8
K264

1 302–1883 1 Meter, Power Factor (M25) 7 853–0008 8 Washer, Lock – ET (#10)

2 526–0115 2 Washer, Flat (5/16”) 8 870–0221 8 Nut, Hex – W/ET (#8–32)
3 338–2368 1 Harness, Wiring – Meter (6 Wire, 9 870–0048 2 Nut, Locking (5/16–18)
44”) (M25,TB21,GND to A22) 10 319–0030 1 Plate, Mounting
4 302–1833–03 1 Transducer, Watts (A21) 11 815–0905–06 2 Screw, Machine – Pan Head –
5 301–6987 1 Bracket, Mounting Cross Recessed (#10–32 x
6 402–0354 4 Mount, Shock 5/8”)

VAR Power Factor Controller
3
K940

1 Transformer, Current (CT25) 2 870–0131 4 Nut, Hex – W/EIT (#10–32)

302–1845–03 1 Ratio 150/5 3 813–0103 4 Screw, Machine – Round Head
302–1845–05 1 Ratio 300/5 (#10–32 x 3/4”)
302–1845–10 1 Ratio 1000/5 4 526–0008 4 Washer, Flat (#10)
302–1794–11 1 Ratio 1500/5 5 305–0870 1 Controller, Power Factor (VAR)
302–1794–13 1 Ratio 3000/5
302–1794–14 1 Ratio 4000/5

Circuit Breaker
AC Control Door
KJ35,K600

1 Breaker, Circuit (CB21)

320–1688–01 1 Without Auxiliary Contacts
320–1688–02 1 With Auxiliary Contacts

Pyrometer
5 4
H244

1 302–1874 1 Pyrometer (M26) 4 155–2531–01 1 Elbow, Exhaust – With Tapped

2 Lead, Thermocouple Hole On The Elbow Side
DFJA, DFJB Illustrated Above
193–0299 1 140” 5 155–2531–04 1 Elbow, Exhaust – With Tapped
193–0299–01 1 200” Hole On The Elbow Side
193–0299–01 2 DFJC, DFJD – 200” Illustrated Above
3 308–0987 1 Switch, Selector (Left/Right
Exhaust)

Pyrometer
DFJD Begin Spec C
3 2
H244

1 Lead, Thermocouple 3 155–2531–04 1 Elbow, Exhaust – With Tapped

DFJA, DFJB Hole On The Elbow Side
193–0446–01 1 12” Illustrated Above
193–0446–03 1 50”
193–0446–02 2 DFJC, DFJD – 30”
2 155–2531–01 1 Elbow, Exhaust – With Tapped
Hole On The Elbow Side
Illustrated Above

Potentiometer
Speed Adjusting
A068,211,267

1 Potentiometer, Speed 2 334–0116 – Cable, Shielded – Bulk (Order

Adjusting – Governor by the Foot – 7 Feet
Controller (R21) Required)
303–0223–05 1 100 Ohms
303–0280 1 5K Ohms

Tachometer
K145

1 302–1873–01 1 Tachometer (0–4000 RPM, 2 301–6257 1 Switch, Blank

12 Volt) (M16) 3 302–1723 1 Ammeter – Blank Scale

Oil Temperature Gauge
1
6
4 3
K486

1 505–0151 1 Bushing, Pipe – Reducer (1/2” 4 193–0250 1 Resistor, Gauge (R13)

to 1/8”) Oil Pan Mounted 5 517–0137 1 Plug, Hole (7/8” Hole)
2 301–6257 1 Switch – Blank 6 193–0388 1 Sender, Oil Temperature – Oil
3 193–0435 1 Gauge, Oil Temperature (M15) Pan Mounted (E4)

Emergency Stop Switch
K796

1 302–1723 2 Ammeter – Blank Scale 4 308–0853 1 Switch, Pushbutton –

2 301–6257 1 Switch – Blank Emergency Stop (Includes
3 322–0394 1 Bulb, Replacement Bulb) (S14)

Excitation Loss Module
KJ35, K991

1 338–2455 1 Harness, Wiring – Excitation 3 813–0103 4 Screw, Machine – Round Head

Loss Module (AUX to A11) (#10–32 x 3/4”)
2 305–0821–02 1 Module (ELM) 4 870–0131 4 Nut, Hex – W/ET (#10–32)

Radio Frequency Interference Module
5
1
ÂÂÂ
ÂÂÂ
ÂÂÂ
ÂÂÂ
ÂÂÂ
ÂÂÂ 6
3
4
B220

1 314–0212 1 Module (RFI) 6 314–0213 – Shielding, Wire – Bulk (3” Wide)

2 813–0107 4 Screw, Machine – Round Head (Order By The Foot – 12 Feet
(#10–32 x 1–1/4”) Required) Used On AC Control
3 526–0008 4 Washer, Flat (#10) Harness And Leads For RFI
4 870–0131 4 Nut, Hex – W/ET (#10–32) Module And Current
5 321–0327–01 4 Fuse (5 Amp) Transformer

Auxiliary Terminal Block
3
6 7
5
15
2 1
14
4
8 2
11
16
18
17 10
19 9
13
12
B246,252,258,259,260,276,282,283,284,288,300,301,302,312,
313,314,324,325,326,348,360,361,362,372,373,374,392

Auxiliary Terminal Block

1 Harness, Wiring – Auxiliary 7 850–0025 3 Washer, Lock – Spring (#10)

Terminal Block 8 319–1245 1 < Bracket, Mounting
DFJA, DFJB, DFJC 9 < Transformer (PTW,PTV,PTU)
Spec J Through L, 315–0717 3 380–480 and 600 Volt Wye
DFJD Spec B Through Generators
D 240–480 Volt Delta
338–2530 1 190–240, 380–480 Generators
Volt 12 Lead 315–0717 1 Mounted In The PTV
Reconnectable Position
Generators (AUX to 315–0717–01 2 Mounted In The PTW
TB21,VR21,A16,X, And PTU Positions
XX,P2,P3,P4,5,8,7, 10 812–0079 3 < Screw, Machine – Round
4,6) Head (#8–32 x 1/2”)
338–2713 1 240–480 Delta, 11 870–0221 12 < Nut, Hex – W/ET (#8–32)
380–480, 600 Volt 12 Screw
Wye Generators 821–0016 4 DFJA, DFJB, DFJC Spec J
(Includes Parts Through L, DFJD Spec B
Marked *) (AUX to Through D –
TB21,VR21,A16,X, Self–Locking – Hex
XX,P2,P3,P4,TB2, Washer Head (5/16–18 x
TB1,8,7,6,5) 3/4”)
338–2867 1 4160–2400 Volt Wye 800–2088 4 DFJA, DFJB Spec M,
Generators (AUX to DFJC Begin Spec M,
TB21,VR21,A16,X, DFJD Begin Spec E –
XX,P2,P3,P4,TB1) Cap – Hex Head (M10 x
DFJA, DFJB Spec M, 35mm)
DFJC Begin Spec M, 13 870–0257 4 Nut, Locking – Hex Flange
DFJD Begin Spec E Head (5/16–18)
338–2530 1 190–240, 380–480 14 323–1644–01 1 # Plug, Connector (9 Place)
Volt 12 Lead (P1)
Reconnectable 15 323–1647 8 # Pin, Contact
Generators (AUX to 16 338–3337 1 Harness, Wiring –
TB21,VR21,A16,X, Transformer (Includes
XX,P2,P3,P4,5,8,7, Parts Marked +) DFJA,
4,6) DFJB Spec M, DFJC Begin
338–3360 1 380–480, 600 Volt Spec M, DFJD Begin Spec
Wye Generators E (J1 to PTW, PTV, PTU)
(Includes Parts 17 323–1644–02 1 + Housing, Connector (9 Place)
Marked #) (AUX to DFJA, DFJB Spec M,
8,7,6,5,P1,X,XX,P2, DFJC Begin Spec M, DFJD
P3,P4,A16,VR21, Begin Spec E (J1)
TB21) 18 323–1648 9 + Socket, Contact – DFJA,
338–2867 1 4160–2400 Volt Wye DFJB Spec M, DFJC Begin
Generators (AUX to Spe M, DFJD Begin Spec
TB21,VR21,A16,X, E
XX,P2,P3,P4,TB1) 19 526–2120 4 < Washer, Flat (M10)
2 332–3007 3 *#< Block, Terminal (AUX)
3 232–3536 1 *#< Base, Terminal Block
4 812–0085 3 *#< Screw, Machine – Round * – Parts Included In Wiring Harness 338–2713
Head (#8–32 x 1–1/8”) # – Parts Included In Wiring Harness 338–3360
5 509–0065 1 *# Seal, O–Ring + – Parts Included In Wiring Harness 338–3337
6 870–0221 3 Nut, Hex – W/ET (#8–32) < – Not Used On All Models

Paralleling Interconnect Terminal Block
7 2
6
5
10
KJ35
K904

1 319–1137 1 Panel, Mounting 6 853–0005 8 Washer, Lock – W/ET (#8)

2 338–2590 1 Harness, Wiring (Includes Four 7 813–0100 4 Screw, Machine – Round Head
Terminal Blocks And Diode) (#10–32 x 1/2”)
(30 Wire, 84”) (TB11, CR1 to 8 870–0131 4 Nut, Hex – W/ET (#10–32)
VR21, CB21, ELM, A11 and 9 338–2172 1 Harness, Wiring – Governor
GND) (Shielded) (5 Wire, 39”)
3 332–2315 4 Block, Terminal (TB11) 10 508–0051 1 Grommet, Rubber (Fits 2” Hole)
4 357–0030 1 Diode (6 Amp) (CR1) (Control Knockout)
5 812–0085 8 Screw, Machine – Round Head
(#8–32 x 1–1/8”)

Cross Current Compensation Circuit
2
4
KJ35,K611

1 Transformer, Current (CT) 2 308–0069 1 Switch, Toggle (S22)

302–1852–02 1 600:0.37 Ratio – DFJC Begin 3 301–9657 1 Bracket, Mounting
Spec P, DFJD Begin Spec G 4 813–0100 2 Screw, Machine – Round Head
302–1852–03 1 600:0.38 Ratio – DFJA, DFJB (#10–32 x 1/2”)
Spec J Through M, DFJC 5 850–0030 2 Washer, Lock – Spring (#10)
Spec J Through N, DFJD 6 870–0053 2 Nut, Hex (#10–32)
Spec B Through F 7 302–1926–30 1 Transformer, Current – 1667/1
302–1852–07 1 1000:0:38 Ratio – DFJC Begin Ratio (CT)
Spec P, DFJD Begin Spec G

Time Delay Start/Stop
1 K634

1 815–0544 4 Screw, Machine – Round 3 300–2899 1 Board, Printed Circuit – Time

Head – Cross Recessed W/IT Delay (A15)
(#6–32 x 1/2”)
2 338–1904 1 Harness, Wiring (5 Wire)
(21–1/2”) (A15 to A11)

Resistive Temperature Detectors
1 4
B312,313,314,372,373,374

1 319–1293 1 Bracket 4 812–0070 4 Screw, Machine – Round

2 800–2080 2 Screw, Cap – Hex Head Head (#6–32 x 1–1/4”)
(M10 x 12mm) 5 526–0002 4 Washer, Flat (#6)
3 850–2010 2 Washer, Lock – Spring (M10)

Differential Current Transformer
3
12
11
6
10
8
5
4
2
13
7 1
10
8 9
K993

Differential Current Transformer

1 Transformer, Current – 5kV 10 526–0022 12 * Washer, Flat (5/16”)

(U1,V1,W1) 11 850–0045 6 * Washer, Lock – Spring
302–1945–02 3 Ratio 150/5 (5/16”)
302–1945–01 3 Ratio 200/5 12 862–0015 6 * Nut, Hex (5/16–18)
302–1945–04 3 Ratio 250/5 13 Transformer, Current – 600V
2 813–0098 12 * Screw, Machine – Round (CT1,CT2,CT3)
Head (#10–32 x 3/8”) 302–1961–09 3 Ratio 1000/5
3 319–1265 1 * Bracket, Current Transformer 302–1961–10 3 Ratio 1200/5
4 850–0030 12 * Washer, Lock – Spring (#10) 302–1961–11 3 Ratio 1500/5
5 526–0008 12 * Washer, Flat (#10) 302–1961–12 3 Ratio 1600/5
6 517–0090 1 Plug, Hole (Fits 5/16” Hole) 302–1961–13 3 Ratio 1800/5
(Quantity Used As 302–1961–14 3 Ratio 2000/5
Required)
7 332–3178–01 1 Block, Terminal (6 Place)
(SCB) * – Mounting Hardware And Brackets Used With 5kV
8 319–3297 6 * Bracket, Foot Current Transformers
9 800–0039 6 * Screw, Cap – Hex Head
(5/16–18 x 3–1/2”)

Current Transformer
4
1
K001,H530,532,555
6

1 Transformer, Current 3 856–0008 2 Washer, Lock – EIT (5/16”)

(CT21, CT22, CT23) (Grounding Wires)
Generator Sets With 4 338–3019 1 Harness, Wiring – Generator
Detector Control Sets With PowerCommand
302–1845–05 3 Ratio 150/5 or 300/5 Control – DFJA, DFJB, DFJC
302–1845–06 3 Ratio 200/5 or 400/5 Begin Spec K, DFJD Begin
302–1794–12 3 Ratio 1000/5 or 2000/5 Spec C (Includes Plug And
302–1794–13 3 Ratio 1500/5 or 3000/5 Sockets) (10 Wire, 60”) (P9 To
302–1794–14 3 Ratio 2000/5 or 4000/5 CT21,CT22,CT23 And
Generator Sets With Power 5,6,7,8)
Command Control – DFJA, 5 323–1644–03 1 Plug – 12 Place – Generator
DFJB, DFJC Begin Spec Sets With PowerCommand
K, DFJD Begin Spec C Control – DFJA, DFJB, DFJC
302–1922–36 3 Ratio 2141/1 or 4282/1 Spec C (P9)
302–1922–37 3 Ratio 2279/1 or 4558/1 6 323–1648 10 Socket, Contract – Generator
302–1922–38 3 Ratio 2366/1 or 4732/1 Sets With PowerCommand
302–1922–39 3 Ratio 2523/1 or 5046/1 Control – DFJA, DFJB, DFJC
302–1926–09 3 Ratio 3039/1 Spec C
302–1922–42 3 Ratio 3154/1 or 6308/1
2 338–2532 1 Harness, Wiring – Generator
Sets With Detector Control (7
Wire, 79”) (TB21 To GND,
CT21,CT22,CT23)

Circuit Breaker
UL Listed
2
13 5
14
15
12
11
10
8
9
6 5
7
5
5
1
4
3 KH33,35,36,39,43

1 319–0890 1 Box, Circuit Breaker 7 800–0031 4 Screw, Cap – Hex Head

2 319–0892 2 Panel (5/16–18 x 1–1/2”)
3 319–0893 1 Cover 8 526–0115 4 Washer, Flat (5/16”)
4 319–0891 1 Bracket, Mounting 9 850–0045 4 Washer, Lock – Spring
5 821–0010 60 Screw, Self–Locking – Hex (5/16”)
Washer Head (1/4–20 x 10 Lead, Circuit Breaker
1/2”) (Quantity Used As
6 Breaker, Circuit (Includes Required) (#1/0 Wire)
Lugs And Interchangeable 226–3371 1 40”
Trip) (CB21) 226–3376 1 56”
Standard 11 091–0002 1 Strip, Copper (Used for
320–1461–09 1 1000 Amp wrapping end of leads
320–1461–10 1 1200 Amp before securing to circuit
With Auxiliary Contacts breakers) (Quantity Used
320–1465–09 1 1000 Amp As Required)
320–1465–10 1 1200 Amp 12 800–0094 8 Screw, Cap – Hex Head
With Shunt Trip (1/2–13 x 2”)
320–1473–09 1 1000 Amp 13 862–0005 8 Nut, Hex (1/2–13)
320–1473–10 1 1200 Amp 14 850–0060 8 Washer, Lock – Spring (1/2”)
With Auxiliary Contacts 15 526–0219 16 Washer, Flat (1/2”)
and Shunt Trip
320–1493–09 1 1000 Amp
320–1493–10 1 1200 Amp

Circuit Breaker
UL Listed
DFJD Spec B
12
11
13
10 12
7
2
4
15 3
1 14
3
4
5
6
16 KH36,39,43

Circuit Breaker
UL Listed
DFJD Spec B

1 Breaker, Circuit – 3 Pole – 6 862–0003 13 Nut, Hex (3/8–16)

100% Rated – Frame Size 7 Lead – Circuit Breaker (1/2”
CM2000–HH Circuit Ring Terminal End to 3/8”
Breakers Include Bus Bars Ring Terminal End)
(T–bars). (Quantity Used As
Standard Required) (#1/0 Wire)
320–1783–01 1 Frame Size 226–4498–01 1 56” (Marked “LO”)
CM1250–HH 226–4498–02 1 40” (Without Markings)
320–1783 1 Frame Size 8 319–0890 1 Box, Circuit Breaker
CM1600–HH 9 319–0892 2 Panel
320–1783–02 1 Frame Size 10 319–1121 1 Cover
CM2000–HH 11 319–1120 1 Bracket, Mounting – Circuit
With 24 Volt Shunt Trip Breaker
320–1783–05 1 Frame Size 12 821–0010 60 Screw, Self–Locking – Hex
CM1250–HH Washer Head (1/4–20 x
320–1783–04 1 Frame Size 1/2”)
CM1600–HH 13 821–0031 6 Screw, Self–Locking – Hex
320–1783–06 1 Frame Size Washer Head (3/8–16 x
CM2000–HH 3/4”)
2 800–0052 8 Screw, Cap – Hex Head 14 332–2744–07 2 Standoff, Insulator
(3/8–16 x 1–1/2”) 15 337–2702 1 Bar, Neutral
3 526–0030 30 Washer, Flat (3/8”) 16 800–0048 2 Screw, Cap – Hex Head
4 850–0050 19 Washer, Lock – Spring (3/8”) (3/8–16 x 3/4”)
(3/8–16 x 2”)

Circuit Breaker
UL Listed
52 51 55
28
57
56
59 56 57
54
23 53
57
31 56
19 10
12 56
49 57
58
6 50
34
2
7
30
5 9
12
14
5 33 11
12 13
11
44
43 35
8
22
48
1
18 15
17 16 21
5
29 47 3
32
46
45
19
5
38
20
37
36
25 4
26
27
24 41 42
40
39
KH33,35,36,39,43
5

Circuit Breaker
UL Listed

1 Breaker, Circuit (Includes With Auxiliary

Mounting Screws) 3 Pole Contacts and Bell
(CB21) Alarm
This first group of 320–1783–18 1 Frame Size
circuit breakers have CM1250–HH
interchangeable trip 320–1783–17 1 Frame Size
and include the lugs. CM1600–HH
Standard 320–1783–19 1 Frame Size
320–1461–09 1 1000 Amp CM2000–HH
320–1461–10 1 1200 Amp With Auxiliary
With Auxiliary Contacts, Bell
Contacts Alarm and 24 Volt
320–1465–09 1 1000 Amp Shunt Trip
320–1465–10 1 1200 Amp 320–1783–09 1 Frame Size
With 24 Volt Shunt CM1250–HH
Trip 320–1783–08 1 Frame Size
320–1473–09 1 1000 Amp CM1600–HH
320–1473–10 1 1200 Amp 320–1783–10 1 Frame Size
With Auxiliary CM2000–HH
Contacts and 24 2 319–1957 1 Box, Circuit Breaker
Volt Shunt Trip 3 Cover, Circuit Breaker
320–1493–09 1 1000 Amp 319–1964 1 1000 and 1200 Amp
320–1493–10 1 1200 Amp Breakers
This second group of 319–1959–01 1 CM1250–HH to
circuit breakers are CM2000–HH Breakers
100% rated. Frame 4 Lead – Circuit Breaker
size CM2000–HH (Quantity Used As
circuit breakers Required) (Without
include bus bars Markings) (#1/0 Wire)
(T–bars). 1000 and 1200 Amp
Standard Breakers (39”)
320–1783–01 1 Frame Size 226–4406–03 1 1/2” Ring Terminal
CM1250–HH End to 1” Stripped
320–1783–02 1 Frame Size End
CM2000–HH 226–4406–04 1 1/2” Ring Terminal
With 4 Wire Ground End to 1/2” Ring
Fault Terminal End
320–1783–13 1 Frame Size 226–4498–03 1 CM1250–HH to
CM1250–HH CM2000–HH Breakers
320–1783–12 1 Frame Size – 1/2” Ring Terminal
CM1600–HH End to 1/2” Ring
320–1783–14 1 Frame Size Terminal End (30”)
CM2000–HH 5 Screw, Self–Locking – Hex
With 24 Volt Shunt Washer Head (1/4–20 x
Trip 1/2”)
320–1783–05 1 Frame Size 821–0010 52 1000 and 1200 Amp
CM1250–HH Breakers
320–1783–04 1 Frame Size 821–0010 44 CM1250–HH to
320–1783–06 1 Frame Size
CM2000–HH
Continued...

Circuit Breaker
UL Listed
52 51 55
28
57
56
59 56 57
54
23 53
57
31 56
19 10
12 56
49 57
58
6 50
34
2
7
30
5 9
12
14
5 33 11
12 13
11
44
43 35
8
22
48
1
18 15
17 16 21
5
29 47 3
32
46
45
19
5
38
20
37
36
25 4
26
27
24 41 42
40
39
KH33,35,36,39,43
5

Circuit Breaker
UL Listed

Continued... The following four

hardware items are used
to fasten the load leads to
6 Bracket, Mounting – Circuit the generator and neutral
Breaker bar. Quantity used as
319–1963 1 1000 and 1200 Amp required.
Breakers 24 800–0094 1 Screw, Cap – Hex Head
319–1962 1 CM1250–HH to (1/2–13 x 2”)
CM2000–HH Breakers 25 862–0005 1 Nut, Hex (1/2–13)
7 300–4480–01 1 Bar Assembly, Neutral 26 850–0060 1 Washer, Lock – Spring (1/2”)
(Includes Neutral Bars, 27 526–0219 1 Washer, Flat (1/2”)
Labels and Parts Marked *) 28 821–0018 5 Screw, Self–Locking – Hex
(Note: Used In All Circuit Washer Head (1/4–20 x
Breaker Applications 5/8”)
Except CM1250–HH to 29 821–0011 5 Screw, Self–Locking – Hex
CM2000–HH With 4 Wire Washer Head (1/4–20 x
Ground Fault) 7/8”)
8 332–3303–01 1 * Lug, Solderless 30 508–1109 – Edging – Bulk (Order By The
9 332–2744–07 4 * Standoff, Insulator Foot – 3 Feet Required)
10 800–0048 4 * Screw, Cap – Hex Head 31 319–1961 1 Panel – Top
(3/8–16 x 3/4”) 32 319–1925 1 Panel – Bottom
11 526–2120 7 * Washer, Flat (M10) 33 Brace, Cover
12 850–2010 11 * Washer, Lock – Spring (M10) 319–1926–01 1 1000 and 1200 Amp
13 800–0052 4 * Screw, Cap – Hex Head Breakers
(3/8–16 x 1–1/2”) 319–1926–02 1 CM1250–HH to
14 800–2089 3 * Screw, Cap – Hex Head CM2000–HH Breakers
(M10 x 40mm) 34 Brace, Mounting Bracket –
15 800–0050 1 Screw, Cap – Hex Head Circuit Breaker
(3/8–16 x 1”) 319–2316–01 1 1000 and 1200 Amp
16 850–0050 1 Washer, Lock – Spring (3/8”) Breakers
17 Washer, Flat (3/8”) 319–2316–02 1 CM1250–HH to
526–0029 4 1000 and 1200 Amp CM2000–HH Breakers
Breakers 35 Stripping, Weather – Bulk
526–0029 2 CM1250–HH to (Order By The Foot)
CM2000–HH Breakers 895–0182 – 1000 and 1200 Amp
18 332–2001 1 Lug, Solderless Breakers (1 Foot
19 870–0494 26 Nut, Self–Retaining – Required)
Floating (1/4–20) 895–0182 – CM1250–HH to
20 319–2398 2 Brace, Cover (Vertical) CM2000–HH Breakers
21 319–2431–18 1 Cup, Circuit Breaker (4 Feet Required)
22 870–0212 6 Nut, Locking (1/4–20)
23 091–0002 1 Strip, Copper (Used for
wrapping ends of leads * – Parts Included In 300–4480–01 Neutral Bar Assembly
before securing to circuit
breakers and neutral bar
lug) (Quantity Used As Continued...
Required)

Circuit Breaker
UL Listed
52 51 55
28
57
56
59 56 57
54
23 53
57
31 56
19 10
12 56
49 57
58
6 50
34
2
7
30
5 9
12
14
5 33 11
12 13
11
44
43 35
8
22
48
1
18 15
17 16 21
5
29 47 3
32
46
45
19
5
38
20
37
36
25 4
26
27
24 41 42
40
39
KH33,35,36,39,43
5

Circuit Breaker
UL Listed

Continued... 46 526–0115 4 Washer, Flat (5/16”)

47 850–0045 4 Washer, Lock – Spring
(5/16”)
36 319–2399 2 Brace, Cover (Horizontal) 48 856–0010 1 Washer, Lock – EIT (3/8”)
37 816–0098 36 Bolt, Carriage (5/16–18 x 49 337–2794 1 Bar Assembly, Neutral
5/8”) (Includes Neutral Bars,
38 870–0257 36 Nut, Locking (5/16–18) Label and Parts Marked #)
39 098–5854–06 3 Label, Marker (10 Characters (Note: Used With
Per Card) Marked “L” CM1250–HH to
40 098–5854–07 1 Label, Marker (10 Characters CM2000–HH Circuit
Per Card) Marked “1” Breaker Applications With 4
41 098–5854–08 1 Label, Marker (10 Characters Wire Ground Fault)
Per Card) Marked “2” 50 332–3303 1 # Lug, Solderless
42 098–5854–09 1 Label, Marker (10 Characters 51 332–2744–07 2 # Standoff, Insulated
Per Card) Marked “3” 52 800–0048 2 # Screw, Cap – Hex Head
43 Screw, Self–Locking – Hex (3/8–16 x 3/4”)
Washer Head 53 800–0053 3 # Screw, Cap – Hex Head
821–0010 6 1000 and 1200 Amp (3/8–16 x 1–3/4”)
Breakers (1/4–20 x 54 800–0051 2 # Screw, Cap – Hex Head
1/2”) (3/8–16 x 1–1/4”)
821–0030 6 CM1250–HH to 55 862–0003 6 # Nut, Hex (3/8”)
CM2000–HH Breakers 56 526–0030 22 # Washer, Flat (3/8”)
(3/8–16 x 1”) 57 850–0050 13 # Washer, Lock – Spring (3/8”)
44 Bar, Bus (T–Bar) (Includes 58 800–0055 6 # Screw, Cap – Hex Head
Mounting Hardware) (3/8–16 x 2–1/4”)
337–2789 4 Sets With CM1250–HH 59 338–3012 1 Harness, Wiring – Neutral
and CM1600–HH Sensor to Circuit Breaker (2
Breakers Wire, 30”) Used With
337–2789 1 Sets With CM2000–HH CM1250–HH to
Breakers CM2000–HH Circuit
45 Screw Breakers With 4 Wire
800–0031 4 Cap – Hex Head – 1000 Ground Fault
and 1200 Amp Breakers
(5/16–18 x 1–1/2”)
800–0033 4 Cap – Hex Head – * – Parts Included In 300–4480–01 Neutral Bar Assembly
CM1250–HH to # – Parts Included In 337–2794 Neutral Bar Assembly
CM2000–HH Breakers
(5/16–18 x 2”)

Circuit Breaker
UL Listed
DFJC Begin Spec P
DFJD Begin Spec G
34
37
4 38
22
39
36
7 12 15
8 22
18
19
40
1
35
14 9
15 42
11 16 41
26
21 33
22 23
13
29 28 2
14
15
31
3
17
30 10
22 32 24
27 20
18
6
25
22
22
KH33,35,36,39,43

Circuit Breaker
UL Listed
DFJC Begin Spec P
DFJD Begin Spec G

1 319–3184 1 Box, Circuit Breaker 5 319–3266–01 1 Cover, Circuit Breaker

2 Breaker, Circuit – 3 Pole, 6 319–1925 1 Panel – Bottom
100% Rated (Includes 7 319–1961 1 Panel – Top
Mounting Screws) Frame 8 319–3253–02 1 Brace, Mounting – Circuit
Size CM2000–HH Circuit Breaker
Breakers Include Bus Bars 9 300–4480–01 1 Bar Assembly, Neutral
(T–bars) (CB21) (Includes Neutral Bars,
Standard Labels and Parts Marked *)
320–1783–01 1 Frame Size 10 332–3303–01 1 * Lug, Solderless
CM1250–HH 11 332–2744–07 4 * Standoff, Insulator
320–1783 1 Frame Size 12 800–0048 4 * Screw, Cap – Hex Head
CM1600–HH (3/8–16 x 3/4”)
320–1783–02 1 Frame Size 13 800–2089 3 * Screw, Cap – Hex Head
CM2000–HH (M10 x 40mm)
320–1783–03 1 Frame Size 14 526–2120 7 * Washer, Flat (M10)
CM2500–HH 15 850–2010 11 * Washer, Lock – Spring (M10)
With 24 Volt Shunt 16 800–0052 4 * Screw, Cap – Hex Head
Trip (3/8–16 x 1–1/2”)
320–1783–05 1 Frame Size 17 850–2010 9 Washer, Lock – Spring (M10)
CM1250–HH CM1250–HH, CM1600–HH
320–1783–04 1 Frame Size Breakers
CM1600–HH 18 870–0504 26 Nut, Self–Retaining (M6)
320–1783–06 1 Frame Size 19 319–3252–02 1 Brace, Cover
CM2000–HH 20 332–3303–01 3 Lug, Solderless
320–1783–07 1 Frame Size 21 821–6003–02 6 Screw, Self–Locking – Hex
CM2500–HH Washer Head (M8 x 20mm)
With Auxiliary 22 821–6002–03 85 Screw, Self–Locking – Hex
Contacts and Bell Washer Head (M6 x 16mm)
Alarm 23 895–0182 – Stripping, Weather – Bulk
320–1783–18 1 Frame Size (Order By The Foot – 4
CM1250–HH Feet Required)
320–1783–17 1 Frame Size 24 319–3286 2 Brace, Cover (Vertical)
CM1600–HH 25 319–3288 2 Brace, Cover (Horizontal)
320–1783–19 1 Frame Size 26 Bar, Bus (T–Bar) (Includes
CM2000–HH Mounting Hardware)
320–1783–20 1 Frame Size 337–2789 4 Sets With CM1250–HH,
With Auxiliary 337–2789 1 Sets With CM2000–HH,
Contacts, Bell CM2500–HH Breakers
Alarm and 24 Volt 27 821–2035 5 Screw, Self–Locking – Hex
Shunt Trip Washer Head (M6 x 25mm)
320–1783–09 1 Frame Size 28 332–2001 1 Lug, Solderless
CM1250–HH 29 856–0010 1 Washer, Lock – EIT (3/8”)
320–1783–08 1 Frame Size 30 526–2120 1 Washer, Flat (M10)
CM1600–HH 31 850–2010 1 Washer, Lock – Spring (M10)
320–1783–10 1 Frame Size 32 800–2086 1 Screw, Cap – Hex Head
CM2000–HH (M10 x 25mm)
320–1783–11 1 Frame Size
CM2500–HH
3 800–2089 9 Screw, Cap – Hex Head * – Parts Included In 300–4480–01 Neutral Bar Assembly
(M10 x 40mm)
CM1250–HH, CM1600–HH
Breakers Continued...
4 319–3153 1 Bracket, Mounting

Circuit Breaker
UL Listed
DFJC Begin Spec P
DFJD Begin Spec G
34
37
4 38
22
39
36
7 12 15
8 22
18
19
40
1
35
14 9
15 42
11 16 41
26
21 33
22 23
13
29 28 2
14
15
31
3
17
30 10
22 32 24
27 20
18
6
25
22
22
KH33,35,36,39,43

Circuit Breaker
UL Listed
DFJC Begin Spec P
DFJD Begin Spec G

Continued...
33 800–2063 4 Screw, Cap – Hex Head (M8 37 860–2010 1 Nut, Hex (M12)
x 50mm) 38 850–2012 1 Washer, Lock – Spring (M12)
34 226–4498–03 1 Lead – Circuit Breaker 39 526–2140 1 Washer, Flat (M12)
(Quantity Used As 40 Label, Marker (10 Characters
Required) 30” (Without Per Card) (Quantity Used
Markings) (#1/0 Wire) As Required)
35 508–1109 – Edging – Bulk (Order By The 098–5854–06 3 Marked “L”
Foot – 3 Feet Required) 098–5854–07 1 Marked “1”
The following four 098–5854–08 1 Marked “2”
hardware items are used 098–5854–09 1 Marked “3”
to fasten the load leads to 41 850–2008 4 Washer, Lock – Spring (M8)
the generator and neutral 42 526–2100 4 Washer, Flat (M8)
bar. Quantity used as
required.
36 800–2116 1 Screw, Cap – Hex Head * – Parts Included In 300–4480–01 Neutral Bar Assembly
(M12 x 50mm)

Circuit Breaker
IEC Conformity
DFJD Spec B
12
11
13
12
9
10
7
2
4
15 3
1 14
3
4
5
6
16 KH61,62,63,64,78,79,80,81

Circuit Breaker
IEC Conformity
DFJD Spec B

1 Breaker, Circuit (CB21) 5 800–0054 9 Screw, Cap – Hex Head

Three Pole Breakers (3/8–16 x 2”)
Standard 6 Nut, Hex (3/8–16)
320–1699–01 1 Frame Size CM1250 862–0003 13 3 Pole Breakers
320–1699 1 Frame Size CM1600 862–0003 9 4 Pole Breakers
320–1699–02 1 Frame Size CM2000 7 Lead – Circuit Breaker (1/2”
320–1699–03 1 Frame Size CM2500 Ring Terminal End to 3/8”
With 24 Volt Shunt Trip Ring Terminal End)
320–1699–05 1 Frame Size CM1250 (Quantity Used As
320–1699–04 1 Frame Size CM1600 Required) (#1/0 Wire)
320–1699–06 1 Frame Size CM2000 226–4498–01 1 56” (Marked “LO”)
320–1699–07 1 Frame Size CM2500 226–4498–02 1 40” (Without Markings)
Four Pole Breakers 8 319–0890 1 Box, Circuit Breaker
Standard 9 319–0892 2 Panel
320–1699–21 1 Frame Size CM1600 10 319–1121 1 Cover
320–1699–23 1 Frame Size CM2000 11 319–1120 1 Bracket, Mounting – Circuit
320–1699–24 1 Frame Size CM2500 Breaker
With 24 Volt Shunt Trip 12 821–0010 60 Screw, Self–Locking – Hex
320–1699–25 1 Frame Size CM1600 Washer Head (1/4–20 x
320–1699–27 1 Frame Size CM2000 1/2”)
320–1699–28 1 Frame Size CM2500 13 821–0031 6 Screw, Self–Locking – Hex
2 Screw, Cap – Hex Head Washer Head (3/8–16 x
(3/8–16 x 1–1/2”) 3/4”)
800–0052 8 3 Pole Breakers 14 332–2744–07 2 Standoff, Insulator (3 Pole
800–0052 4 4 Pole Breakers Breakers)
3 Washer, Flat (3/8”) 15 337–2702 1 Bar, Neutral (3 Pole
526–0030 22 4 Pole Breakers 16 800–0048 2 Screw, Cap – Hex Head
4 Washer, Lock – Spring (3/8”) (3/8–16 x 3/4”) (3 Pole
850–0050 13 4 Pole Breakers

Circuit Breaker
IEC Conformity
28 4
25
26
27
31 24
19 43
10
12 41 42
40
6 39
34
1
7
30
5 9
12
14
33 11
12
13
5 11
22
8
21
35
15
18 2
17 16
5 3
29
32
44
46
45
19 38 23
20
37
36
5 KH61,62,63,64,78,79,80,81

Circuit Breaker
IEC Conformity

1 319–1957 1 Box, Circuit Breaker 3 Cover, Circuit Breaker

2 Breaker, Circuit (Includes 319–1959–01 1 Sets With 3 Pole Breaker
Mounting Screws) (CB21) Mounted On Left Or Right
Three Pole Breakers Side When Facing
Standard Control
320–1699–01 1 Frame Size CM1250 319–1959–01 1 Sets With 4 Pole Breaker
320–1699 1 Frame Size CM1600 Mounted On Left Side
320–1699–02 1 Frame Size CM2000 When Facing Control
With 24 Volt Shunt 319–1959–02 1 Sets With 4 Pole Breaker
Trip Mounted On Right Side
320–1699–05 1 Frame Size When Facing Control
CM1250 4 226–4498–03 1 Lead – Circuit Breaker
320–1699–04 1 Frame Size (Quantity Used As
CM1600 Required) 30” (Without
320–1699–06 1 Frame Size Markings) (#1/0 Wire)
CM2000 5 821–0010 44 Screw, Self–Locking – Hex
With Auxiliary Washer Head (1/4–20 x
Contacts, Bell Alarm 1/2”)
and 24 Volt Shunt 6 319–1962 1 Bracket, Mounting – Circuit
Trip Breaker
320–1699–09 1 Frame Size 7 300–4480–01 1 Bar Assembly, Neutral
CM1250 (Includes Neutral Bars,
320–1699–08 1 Frame Size Labels and Parts Marked *)
CM1600 (Used With 3 Pole Circuit
320–1699–10 1 Frame Size Breakers)
CM2000 8 332–3303–01 1 * Lug, Solderless
Four Pole Breakers 9 332–2744–07 4 * Standoff, Insulator
Standard 10 800–0048 4 * Screw, Cap – Hex Head
320–1699–22 1 Frame Size CM1250 (3/8–16 x 3/4”)
320–1699–21 1 Frame Size CM1600 11 526–2120 7 * Washer, Flat (M10)
320–1699–23 1 Frame Size CM2000 12 850–2010 11 * Washer, Lock – Spring (M10)
Trip (3/8–16 x 1–1/2”)
CM1250 (M10 x 40mm)
320–1699–25 1 Frame Size 15 800–0050 1 Screw, Cap – Hex Head
CM1600 (3/8–16 x 1”)
320–1699–27 1 Frame Size 16 850–0050 1 Washer, Lock – Spring (3/8”)
CM2000 17 526–0029 2 Washer, Flat (3/8”)
With Auxiliary 18 332–2001 1 Lug, Solderless
Contacts, Bell Alarm 19 870–0494 26 Nut, Self–Retaining –
and 24 Volt Shunt Floating (1/4–20)
Trip
320–1699–30 1 Frame Size
CM1250 * – Parts Included In 300–4480–01 Neutral Bar Assembly
320–1699–29 1 Frame Size
CM1600
320–1699–31 1 Frame Size Continued...
CM2000

Circuit Breaker
IEC Conformity
28 4
25
26
27
31 24
19 43
10
12 41 42
40
6 39
34
1
7
30
5 9
12
14
33 11
12
13
5 11
22
8
21
35
15
18 2
17 16
5 3
29
32
44
46
45
19 38 23
20
37
36
5 KH61,62,63,64,78,79,80,81

Circuit Breaker
IEC Conformity

Continued...
20 Brace, Cover (Vertical) 35 856–0010 1 Washer, Lock – EIT (3/8”)

319–2398 2 Sets With 3 Pole Circuit 36 319–2399 2 Brace, Cover (Horizontal)
Breakers 37 Bolt, Carriage (5/16–18 x
319–2398 1 Sets With 4 Pole Circuit 5/8”)
Breakers 816–0098 36 Sets With 3 Pole Breaker
21 821–0030 6 Screw, Self–Locking – Hex Mounted On Left Or
Washer Head (3/8–16 x 1”) Right Side When
22 Bar, Bus (T–Bar) (Includes Facing Control
Mounting Hardware) 816–0098 36 Sets With 4 Pole Breaker
337–2789 4 Sets With Frame Size Mounted On Left Side
CM1250 and CM1600 When Facing Control
Circuit Breakers 816–0098 28 Sets With 4 Pole Breaker
337–2789 1 Sets With Frame Size Mounted On Right Side
CM2000 Circuit When Facing Control
Breakers 38 Nut, Locking (5/16–18)
23 Stripping, Weather – Bulk 870–0257 36 Sets With 3 Pole Breaker
(Order By The Foot) Mounted On Left Or Right
895–0182 – Sets With 3 Pole Circuit Side When Facing
Breakers (4 Feet Control
Required) 870–0257 36 Sets With 4 Pole Breaker
895–0182 – Sets With 4 Pole Circuit Mounted On Left Side
Breakers (6 Feet When Facing Control
Required) 870–0257 28 Sets With 4 Pole Breaker
The following four Mounted On Right Side
hardware items are used When Facing Control
to fasten the load leads to 39 Label, Marker (10 Characters
the generator. Quantity Per Card) Marked “L”
used as required. 098–5854–06 3 3 Pole Breakers
24 800–0094 1 Screw, Cap – Hex Head 098–5854–06 4 4 Pole Breakers
(1/2–13 x 2”) 40 098–5854–07 1 Label, Marker (10 Characters
25 862–0005 1 Nut, Hex (1/2–13) Per Card) Marked “1”
26 850–0060 1 Washer, Lock – Spring (1/2”) 41 098–5854–08 1 Label, Marker (10 Characters
27 526–0219 1 Washer, Flat (1/2”) Per Card) Marked “2”
28 821–0018 5 Screw, Self–Locking – Hex 42 098–5854–09 1 Label, Marker (10 Characters
Washer Head (1/4–20 x Per Card) Marked “3”
5/8”) 43 098–5854–10 1 Label, Marker (10 Characters
29 821–0011 5 Screw, Self–Locking – Hex Per Card) Marked “0” (4
Washer Head (1/4–20 x Pole Breakers)
7/8”) 44 850–0045 4 Washer, Lock – Spring
30 508–1109 – Edging – Bulk (Order By The (5/16”)
Foot – 3 Feet Required) 45 800–0033 4 Screw, Cap – Hex Head
31 319–1961 1 Panel – Top (5/16–18 x 2”)
32 319–1925 1 Panel – Bottom 46 526–0115 4 Washer, Flat (5/16”)
33 319–1926–02 1 Brace, Cover
34 319–2316–02 1 Brace, Mounting – Circuit
Breaker Bracket * – Parts Included In 300–4480–01 Neutral Bar Assembly

Circuit Breaker
IEC Conformity
DFJC Begin Spec P
DFJD Begin Spec G
34
37
4 38
22
39
36
7 12 15
8 22
18
19
40
1
35
14 9
15 42
11 16 41
26
21 33
22 23
13
29 28 2
14
15
31
3
17
30 10
22 32 24
27 20
18
6
25
22
22
KH61,62,63,64,78,79,80,81

Circuit Breaker
IEC Conformity
DFJC Begin Spec P
DFJD Begin Spec G

1 319–3184 1 Box, Circuit Breaker 9 300–4480–01 1 Bar Assembly, Neutral

2 Breaker, Circuit (Includes (Includes Neutral Bars,
Mounting Screws) (CB21) Labels and Parts Marked *)
Three Pole Breakers (Used With 3 Pole Circuit
Standard Breakers)
320–1699 1 Frame Size CM1600 10 332–3303–01 1 * Lug, Solderless
320–1699–02 1 Frame Size CM2000 11 332–2744–07 4 * Standoff, Insulator
Trip (3/8–16 x 3/4”)
CM1600 (M10 x 40mm)
320–1699–06 1 Frame Size 14 526–2120 7 * Washer, Flat (M10)
CM2000 15 850–2010 11 * Washer, Lock – Spring (M10)
With Auxiliary 16 800–0052 4 * Screw, Cap – Hex Head
Contacts, Bell Alarm (3/8–16 x 1–1/2”)
and 24 Volt Shunt 17 Washer, Lock – Spring (M10)
Trip 850–2010 9 Sets With CM1600 3 Pole
320–1699–08 1 Frame Size Circuit Breakers
CM1600 850–2010 12 Sets With CM1600 4 Pole
320–1699–10 1 Frame Size Circuit Breakers
CM2000 18 870–0504 26 Nut, Self–Retaining (M6)
Four Pole Breakers 19 319–3252–02 1 Brace, Cover
Standard 20 Lug, Solderless
320–1699–21 1 Frame Size CM1600 332–3303–01 3 Sets With 3 Pole Circuit
320–1699–23 1 Frame Size CM2000 Breakers
With 24 Volt Shunt 332–3303–01 4 Sets With 4 Pole Circuit
Trip Breakers
320–1699–25 1 Frame Size 21 821–6003–02 6 Screw, Self–Locking – Hex
CM1600 Washer Head (M8 x 20mm)
320–1699–27 1 Frame Size 22 Screw, Self–Locking – Hex
CM2000 Washer Head (M6 x 16mm)
With Auxiliary 821–6002–03 89 Sets With 3 Pole Circuit
Contacts, Bell Alarm Breakers
and 24 Volt Shunt 821–6002–03 81 Sets With 4 Pole Circuit
Trip Breakers
320–1699–29 1 Frame Size 23 Stripping, Weather – Bulk
CM1600 (Order By The Foot)
320–1699–31 1 Frame Size 895–0182 – Sets With 3 Pole Circuit
CM2000 Breakers (4 Feet
3 Screw, Cap – Hex Head Required)
(M10 x 40mm) 895–0182 – Sets With 4 Pole Circuit
800–2089 9 Sets With CM1600 3 Pole Breakers (6 Feet
Circuit Breakers Required)
800–2089 12 Sets With CM1600 4 Pole
Circuit Breakers
4 319–3153 1 Bracket, Mounting
5 Cover, Circuit Breaker * – Parts Included In 300–4480–01 Neutral Bar Assembly
319–3266–01 1 Sets With 3 Pole Circuit
Breakers
319–3266–02 1 Sets With 4 Pole Circuit
Breakers
6 319–1925 1 Panel – Bottom
7 319–1961 1 Panel – Top
8 319–3253–02 1 Brace, Mounting – Circuit Continued...
Breaker

Circuit Breaker
IEC Conformity
DFJC Begin Spec P
DFJD Begin Spec G
34
37
4 38
22
39
36
7 12 15
8 22
18
19
40
1
35
14 9
15 42
11 16 41
26
21 33
22 23
13
29 28 2
14
15
31
3
17
30 10
22 32 24
27 20
18
6
25
22
22
KH61,62,63,64,78,79,80,81

Circuit Breaker
IEC Conformity
DFJC Begin Spec P
DFJD Begin Spec G

Continued...
24 Brace, Cover (Vertical) The following four

319–3286 2 Sets With 3 Pole Circuit hardware items are used
Breakers to fasten the load leads to
319–3286 1 Sets With 4 Pole Circuit the generator. Quantity
Breakers used as required.
25 319–3288 2 Brace, Cover (Horizontal) 36 800–2116 1 Screw, Cap – Hex Head
26 Bar, Bus (T–Bar) (Includes (M12 x 50mm)
Mounting Hardware) 37 860–2010 1 Nut, Hex (M12)
337–2789 4 Sets With Frame Size 38 850–2012 1 Washer, Lock – Spring (M12)
CM1600 Circuit 39 526–2140 1 Washer, Flat (M12)
Breakers 40 Label, Marker (10 Characters
337–2789 1 Sets With Frame Size Per Card) (Quantity Used
CM2000 Circuit As Required)
Breakers Marked “L”
27 821–2035 5 Screw, Self–Locking – Hex 098–5854–06 3 Sets With 3 Pole Circuit
Washer Head (M6 x 25mm) Breakers
28 332–2001 1 Lug, Solderless 098–5854–06 4 Sets With 4 Pole Circuit
29 856–0010 1 Washer, Lock – EIT (3/8”) Breakers
30 526–2120 1 Washer, Flat (M10) 098–5854–07 1 Marked “1”
31 850–2010 1 Washer, Lock – Spring (M10) 098–5854–08 1 Marked “2”
32 800–2086 1 Screw, Cap – Hex Head 098–5854–09 1 Marked “3”
(M10 x 25mm) 098–5854–10 1 Marked “0” (Sets With 4
33 800–2063 4 Screw, Cap – Hex Head (M8 Pole Circuit Breakers)
x 50mm) 41 850–2008 4 Washer, Lock – Spring (M8)
34 226–4498–03 1 Lead – Circuit Breaker 42 526–2100 4 Washer, Flat (M8)
(Quantity Used As
Required) 30” (Without
Markings) (#1/0 Wire) * – Parts Included In 300–4480–01 Neutral Bar Assembly
35 508–1109 – Edging – Bulk (Order By The
Foot – 3 Feet Required)

Disconnect Switch
Molded Case – UL Listed
DFJC Spec L Through N
DFJD Spec D Through F
28
23
31
19 10
12
6
34
2
7
30
5 9
12
14
5 33 11
12 13
11
44
49 52
43 35
50
8
51
22
48
18 15 1
17 16 21
47
5
29
46 3
32 45
19
5
38
20
37
36
25 4
26
27
41 42
24 40
39 KK53,54,55,56
5

Disconnect Switch

1 Switch, Disconnect – 3 Pole 15 800–0050 1 Screw, Cap – Hex Head

(Includes Lugs for 1000, (3/8–16 x 1”)
1200 Amp Switches) 16 850–0050 1 Washer, Lock – Spring (3/8”)
(CB21) 17 Washer, Flat (3/8”)
320–1906–20 1 1000 Amp 526–0029 4 1000, 1200 Amp Switches
320–1906–21 1 1200 Amp 526–0029 2 1600, 2000 Amp Switches
320–1907–01 1 1600 Amp 18 332–2001 1 Lug, Solderless
320–1907–02 1 2000 Amp 19 870–0494 26 Nut, Self–Retaining –
2 319–1957 1 Box, Disconnect Switch Floating (1/4–20)
3 Cover, Disconnect Switch 20 319–2398 2 Brace, Cover (Vertical)
319–1964 1 1000, 1200 Amp Switches 21 319–2431–18 1 Cup, Disconnect Switch –
319–1959–01 1 1600, 2000 Amp Switches 1000, 1200 Amp Switches
4 Lead – Disconnect Switch 22 870–0212 6 Nut, Locking (1/4–20) 1000,
(Quantity Used As 1200 Amp Switches
Required) (Without 23 091–0002 1 Strip, Copper (Used for
Markings) (#1/0 Wire) wrapping ends of leads
1000, 1200 Amp before securing to
Switches (39”) disconnect switches and
226–4406–03 1 1/2” Ring Terminal neutral bar lug) (Quantity
End to 1” Stripped Used As Required) 1000,
End 1200 Amp Switches
226–4406–04 1 1/2” Ring Terminal The following four
End to 1/2” Ring hardware items are used
Terminal End to fasten the load leads to
226–4498–03 1 1600, 2000 Amp the generator and neutral
Switches – 1/2” Ring bar. Quantity used as
Terminal End to 1/2” required.
Ring Terminal End (30”) 24 800–0094 1 Screw, Cap – Hex Head
5 Screw, Self–Locking – Hex (1/2–13 x 2”)
Washer Head (1/4–20 x 25 862–0005 1 Nut, Hex (1/2–13)
1/2”) 26 850–0060 1 Washer, Lock – Spring (1/2”)
821–0010 52 1000, 1200 Amp 27 526–0219 1 Washer, Flat (1/2”)
Switches 28 821–0018 5 Screw, Self–Locking – Hex
821–0010 44 1600, 2000 Amp Washer Head (1/4–20 x
Switches 5/8”)
6 Bracket, Mounting – 29 821–0011 5 Screw, Self–Locking – Hex
Disconnect Switch Washer Head (1/4–20 x
319–1963 1 1000, 1200 Amp 7/8”)
Switches 30 508–1109 – Edging – Bulk (Order By The
319–1962 1 1600, 2000 Amp Foot – 3 Feet Required)
Switches 31 319–1961 1 Panel – Top
7 300–4480–01 1 Bar Assembly, Neutral 32 319–1925 1 Panel – Bottom
(Includes Neutral Bars, 33 Brace, Cover
Labels and Parts Marked *) 319–1926–01 1 1000, 1200 Amp Switches
8 332–3303–01 1 * Lug, Solderless 319–1926–02 1 1600, 2000 Amp Switches
9 332–2744–07 4 * Standoff, Insulator
(3/8–16 x 3/4”) * – Parts Included In 300–4480–01 Neutral Bar Assembly
11 526–2120 7 * Washer, Flat (M10)
12 850–2010 11 * Washer, Lock – Spring (M10)
13 800–0052 4 * Screw, Cap – Hex Head Continued...
(3/8–16 x 1–1/2”)
(M10 x 40mm)

Disconnect Switch
28
23
31
19 10
12
6
34
2
7
30
5 9
12
14
5 33 11
12 13
11
44
49 52
43 35
50
8
51
22
48
18 15 1
17 16 21
47
5
29
46 3
32 45
19
5
38
20
37
36
25 4
26
27
41 42
24 40
39 KK53,54,55,56
5

Disconnect Switch

Continued...
34 Brace, Mounting Bracket – 44 Bar, Bus (T–Bar) (Includes

Disconnect Switch Mounting Hardware) 1600,
319–2316–01 1 1000, 1200 Amp 2000 Amp Switches
Switches 337–2789 4 Sets With 1600 Amp
319–2316–02 1 1600, 2000 Amp Switches
Switches 337–2789 1 Sets With 2000 Amp
35 Stripping, Weather – Bulk Switches
(Order By The Foot) 45 Screw
895–0182 – 1000, 1200 Amp 800–0031 4 Cap – Hex Head – 1000,
Switches (1 Foot 1200 Amp Switches
Required) (5/16–18 x 1–1/2”)
895–0182 – 1600, 2000 Amp 800–0033 4 Cap – Hex Head –
Switches (4 Feet 1600, 2000 Amp
Required) Switches (5/16–18 x 2”)
36 319–2399 2 Brace, Cover (Horizontal) 46 526–0115 4 Washer, Flat (5/16”)
37 816–0098 36 Bolt, Carriage (5/16–18 x 47 850–0045 4 Washer, Lock – Spring
5/8”) (5/16”)
38 870–0257 36 Nut, Locking (5/16–18) 48 856–0010 1 Washer, Lock – EIT (3/8”)
39 098–5854–06 3 Label, Marker (10 Characters 49 862–0003 12 Nut, Hex (3/8”) 1600, 2000
Per Card) Marked “L” Amp Switches
40 098–5854–07 1 Label, Marker (10 Characters 50 850–0050 25 Washer, Lock – Spring (3/8”)
Per Card) Marked “1” 1600, 2000 Amp Switches
41 098–5854–08 1 Label, Marker (10 Characters 51 526–0029 36 Washer, Flat (3/8”) 1600,
Per Card) Marked “2” 2000 Amp Switches
42 098–5854–09 1 Label, Marker (10 Characters 52 800–0054 13 Screw, Cap – Hex Head
Per Card) Marked “3” (3/8–16 x 2”) 1600, 2000
43 Screw, Self–Locking – Hex Amp Switches
Washer Head
821–0010 6 1000, 1200 Amp
Switches (1/4–20 x * – Parts Included In 300–4480–01 Neutral Bar Assembly
1/2”)
821–0030 6 1600, 2000 Amp
Switches (3/8–16 x 1”)

Disconnect Switch
Molded Case
UL Listed
DFJC Begin Spec P
DFJD Begin Spec G
26
29 27
6
28
25
32 10 12
35 6
21
34
39
1
31
11 7
12 41
9 13 42
36
23 40
6 37
14
19 20 2
11
30 12
16
24
18 15 8 17
6 22
5
21
33
38
6
KK53,54,55,56

Disconnect Switch
Molded Case
UL Listed
DFJC Begin Spec P
DFJD Begin Spec G

1 319–3184 1 Box, Disconnect Switch 29 319–3153 1 Bracket, Mounting

2 Switch, Disconnect – 3 Pole 30 821–2035 5 Screw, Self–Locking – Hex
(Includes Mounting Washer Head (M6 x 25mm)
Screws) (CB21) 31 508–1109 – Edging – Bulk (Order By The
320–1907–01 1 1600 Amp Foot – 3 Feet Required)
320–1907–02 1 2000 Amp 32 319–1961 1 Panel – Top
3 319–3266–01 1 Cover, Disconnect Switch 33 319–1925 1 Panel – Bottom
4 226–4498–03 1 Lead – Disconnect Switch 34 319–3252–02 1 Brace, Cover
(Quantity Used As 35 319–3253–02 1 Brace, Mounting –
Required) 30” (Without Disconnect Switch
Markings) (#1/0 Wire) 36 Bar, Bus (T–Bar) (Includes
5 332–3303–01 3 Lug, Solderless Mounting Hardware)
6 821–6002–03 89 Screw, Self–Locking – Hex 337–2789 4 Sets With 1600 Amp
Washer Head (M6 x 16mm) Disconnect Switches
7 300–4480–01 1 Bar Assembly, Neutral 337–2789 1 Sets With 2000 Amp
(Includes Neutral Bars, Disconnect Switches
Labels and Parts Marked *) 37 895–0182 – Stripping, Weather – Bulk
8 332–3303–01 1 * Lug, Solderless (Order By The Foot – 4
9 332–2744–07 4 * Standoff, Insulator Feet Required)
10 800–0048 4 * Screw, Cap – Hex Head 38 319–3288 2 Brace, Cover (Horizontal)
(3/8–16 x 3/4”) 39 Label, Marker (10 Characters
11 526–2120 7 * Washer, Flat (M10) Per Card) (Quantity Used
12 850–2010 11 * Washer, Lock – Spring (M10) As Required)
13 800–0052 4 * Screw, Cap – Hex Head 098–5854–06 3 Marked “L”
(3/8–16 x 1–1/2”) 098–5854–07 1 Marked “1”
14 800–2089 3 * Screw, Cap – Hex Head 098–5854–08 1 Marked “2”
(M10 x 40mm) 098–5854–09 1 Marked “3”
15 800–2086 1 Screw, Cap – Hex Head 40 800–2063 4 Screw, Cap – Hex Head (M8
(M10 x 25mm) x 50mm)
16 850–2010 1 Washer, Lock – Spring (M10) 41 526–2100 4 Washer, Flat (M8)
17 850–2010 9 Washer, Lock – Spring (M10) 42 850–2008 4 Washer, Lock – Spring (M8)
1600 Amp Switches
18 526–2120 1 Washer, Flat (M10)
19 856–0010 1 Washer, Lock – EIT (3/8”) * – Parts Included In 300–4480–01 Neutral Bar Assembly
20 332–2001 1 Lug, Solderless
21 870–0504 26 Nut, Self–Retaining (M6)
22 319–3286 2 Brace, Cover (Vertical)
23 821–6003–02 6 Screw, Self–Locking – Hex
Washer Head (M8 x 20mm)
(M10 x 40mm) 1600 Amp
Disconnect Switches
The following four
hardware items are used
the generator and neutral
bar. Quantity used as
required.
(M12 x 50mm)
26 860–2010 1 Nut, Hex (M12)
27 850–2012 1 Washer, Lock – Spring (M12)
28 526–2140 1 Washer, Flat (M12)

Circuit Breaker and Disconnect Switch
UL Listed, IEC Conformity
DFJC Begin Spec P
DFJD Begin Spec G
34
37
4 38
39
36
7 12 15
8
18
19
42
1
35
14 9
15
11 16 3
21
Î
ÎÎ
22
13 14
14
29 28
31 33
10 15 17
30 23 2
22 32 24
20
27
18
6
25
22
22
40
26 KK54
KM50,51,63,64
41

Circuit Breaker and Disconnect Switch
UL Listed, IEC Conformity
DFJC Begin Spec P
DFJD Begin Spec G

1 319–3184 1 Box, Circuit Breaker 25 319–3288 2 Brace, Cover (Horizontal)

2 The following listed Circuit 26 091–0002 1 Strip, Copper (Used for
Breakers and Disconnect wrapping end of leads
Switch include lugs and before securing to circuit
mounting hardware. breakers and disconnect
Circuit Breakers switch) (Quantity Used As
3 Pole (UL, IEC) Required)
320–1964–02 1 1000 Amp 27 821–2034 5 Screw, Self–Locking – Hex
320–1964–01 1 1200 Amp Washer Head (M6 x 20mm)
4 Pole (IEC) 28 332–2001 1 Lug, Solderless
320–1964–07 1 1000 Amp 29 856–0010 1 Washer, Lock – EIT (3/8”)
320–1964–06 1 1250 Amp 30 526–2120 1 Washer, Flat (M10)
320–1992–01 1 Disconnect Switch 31 850–2010 1 Washer, Lock – Spring (M10)
(3 Pole) (UL, IEC) 1200 32 800–2086 1 Screw, Cap – Hex Head
Amp (M10 x 25mm)
3 320–1986–01 1 Package, Hardware – 33 870–2054 6 Nut, Hex – Flange (M6)
Mounting (Includes Screws, 34 Lead (Quantity Used As
Nuts and Lock Washers – 1 Required) 39” (Without
Package Required Per Markings) (#1/0 Wire)
Switch) Used With 226–4406–03 1 1/2” Ring Terminal End to
320–1964–XX Circuit 1” Stripped End
Breakers 226–4406–04 1 1/2” Ring Terminal End to
4 319–3153 1 Bracket, Mounting 1/2” Ring Terminal End
5 319–3300 1 Cover 35 508–1109 – Edging – Bulk (Order By The
6 319–1925 1 Panel – Bottom Foot – 3 Feet Required)
7 319–1961 1 Panel – Top The following four
8 319–3253–01 1 Brace, Cover hardware items are used
9 300–4318–01 1 Bar Assembly, Neutral – to fasten the load leads to
Used on 3 Pole Circuit the generator and neutral
Breakers and Disconnect bar. Quantity used as
Switch (Includes Neutral required.
Bars, Labels and Parts 36 800–2114 1 Screw, Cap – Hex Head
Marked *) (M12 x 40mm)
10 332–2001 3 * Lug, Solderless 37 860–2010 1 Nut, Hex (M12)
11 332–2744–07 2 * Standoff, Insulator 38 850–2012 1 Washer, Lock – Spring (M12)
12 800–0048 2 * Screw, Cap – Hex Head 39 526–2140 1 Washer, Flat (M12)
(3/8–16 x 3/4”) Accessories, Circuit
13 862–0003 3 * Nut, Hex (3/8”) Breaker: The following
14 526–0029 8 * Washer, Flat (3/8”) are used on 320–1964–XX
15 850–0050 7 * Washer, Lock – Spring (3/8”) Circuit Breakers
16 800–0051 2 * Screw, Cap – Hex Head 40 320–1977–01 1 Switches – Includes 1
(3/8–16 x 1–1/4”) Trip Alarm and 1
17 800–0052 3 * Screw, Cap – Hex Head Auxilliary Contact
(3/8–16 x 1–1/2”) 41 320–1977–03 1 24 Volt Shunt Trip
18 870–0504 30 Nut, Self–Retaining (M6) 42 Label, Marker (10 Characters
19 319–3252–01 1 Brace, Cover Per Card) (Quantity Used
20 319–2431–28 1 Cup As Required)
21 821–6003–02 6 Screw, Self–Locking – Hex 098–5854–06 3 Marked “L”
Washer Head (M8 x 20mm) 098–5854–07 1 Marked “1”
22 821–6002–03 91 Screw, Self–Locking – Hex 098–5854–08 1 Marked “2”
Washer Head (M6 x 16mm) 098–5854–09 1 Marked “3”
23 895–0182 – Stripping, Weather – Bulk
(Order By The Foot – 1
Foot Required) * – Parts Included In 300–4318–01 Neutral Bar Assembly
24 319–3286 2 Brace, Cover (Vertical)

Circuit Breaker
Non–UL Listed
10
8
13
14
12
17 16
11 2
4
15
9 6 5
4
4 4
1
3
KA47
KH60,61,77,78
7 K884,888

1 319–0890 1 Box, Circuit Breaker 9 320–1755–15 1 Lug Set – Circuit Breaker

2 319–0892 2 Panel (Packaged In Sets – Two
3 319–0891 1 Bracket, Mounting Lugs Per Set) (Quantity
4 821–0010 74 Screw, Self–Locking – Hex Used As Required)
Washer Head (1/4–20 x 10 332–2744–07 1 Standoff, Insulator (3 Pole
1/2”) Circuit Breakers)
5 508–0239 – Edging – Bulk (Order By The 11 098–5854–04 1 Label, Marker (10 Characters
Foot – 9 Feet Required) Per Card) (Marked “N”) (3
6 Breaker, Circuit (Includes Pole Circuit Breakers)
Mounting Hardware) (Lugs (Quantity Used As
Not Included) (CB21) Required)
3 Pole Breakers 12 800–0050 2 Screw, Cap – Hex Head
320–1730–03 1 1000 Amp (3/8–16 x 1”)
320–1730–04 1 1250 Amp 13 850–0050 2 Washer, Lock – Spring (3/8”)
4 Pole Breakers 14 526–0029 2 Washer, Flat (3/8”)
320–1730–07 1 1000 Amp 15 320–1747–18 1 Contact, Auxiliary
320–1730–08 1 1250 Amp 16 320–1748–14 1 Alarm, Bell
7 319–1410 1 Cover, Circuit Breaker 17 320–1749–14 1 Trip, 24 Volt Shunt
8 Lead, Circuit Breaker
(Quantity Used As
Required) 39” (#1/0 Wire)
226–4406–04 1 Without “LO” Marking
226–4537 1 With “LO” Marking

Circuit Breaker
Non–UL Listed
DFJD Spec E and F
28
25 4
26
27
31 44 24
23
19 10 43
12 41 42
40
6 39
34
1
7
30
5 9
12
14
5 33 11
12 13
11
35
8
22
48
15 2
18
17 16 21
5
29 3
47
32
46
45
19
5
38
20
37
36
51
49 KA47
KH60,61,77,78
50 K884,888
5

Circuit Breaker
Non–UL Listed
DFJD Spec E and F

1 319–1957 1 Box, Circuit Breaker 24 800–0092 1 Screw, Cap – Hex Head

2 Breaker, Circuit (Includes (1/2–13 x 1–1/2”)
Mounting Screws) (CB21) 25 862–0016 1 Nut, Hex (1/2–13)
Three Pole Breakers 26 850–0060 1 Washer, Lock – Spring (1/2”)
320–1730–03 1 1000 Amp 27 526–0219 1 Washer, Flat (1/2”)
Four Pole Breakers Washer Head (1/4–20 x
320–1730–07 1 1000 Amp 5/8”)
3 319–1964 1 Cover, Circuit Breaker Washer Head (1/4–20 x
4 226–4406–04 1 Lead – Circuit Breaker 7/8”)
(Quantity Used As 30 508–1109 – Edging – Bulk (Order By The
Required) 39” (#1/0 Wire) Foot – 3 Feet Required)
5 821–0010 58 Screw, Self–Locking – Hex 31 319–1961 1 Panel – Top
Washer Head (1/4–20 x 32 319–1925 1 Panel – Bottom
1/2”) 33 319–1926–01 1 Brace, Cover
6 319–1963 1 Bracket, Mounting – Circuit 34 319–2316–01 1 Brace, Mounting Bracket –
Breaker Circuit Breaker
7 300–4480–01 1 Bar Assembly, Neutral 35 895–0182 – Stripping, Weather – Bulk
(Includes Neutral Bars, (Order By The Foot – 1
Labels and Parts Marked *) Foot Required)
(Used With 3 Pole 36 319–2399 2 Brace, Cover (Horizontal)
Breakers) 37 816–0098 36 Bolt, Carriage (5/16–18 x
8 332–3303–01 1 * Lug, Solderless 5/8”)
9 332–2744–07 4 * Standoff, Insulator 38 870–0257 36 Nut, Locking (5/16–18)
10 800–0048 4 * Screw, Cap – Hex Head 39 Label, Marker (10 Characters
(3/8–16 x 3/4”) Per Card) Marked “L”
11 526–2120 7 * Washer, Flat (M10) 098–5854–06 3 3 Pole Breakers
12 850–2010 11 * Washer, Lock – Spring (M10) 098–5854–06 4 4 Pole Breakers
13 800–0052 4 * Screw, Cap – Hex Head 40 098–5854–07 1 Label, Marker (10 Characters
(3/8–16 x 1–1/2”) Per Card) Marked “1”
14 800–2089 3 * Screw, Cap – Hex Head 41 098–5854–08 1 Label, Marker (10 Characters
(M10 x 40mm) Per Card) Marked “2”
15 800–0050 1 Screw, Cap – Hex Head 42 098–5854–09 1 Label, Marker (10 Characters
(3/8–16 x 1”) Per Card) Marked “3”
16 850–0050 1 Washer, Lock – Spring (3/8”) 43 098–5854–10 1 Label, Marker (10 Characters
17 526–0029 4 Washer, Flat (3/8”) Per Card) Marked “0” (4
18 332–2001 1 Lug, Solderless Pole Breakers)
19 870–0494 26 Nut, Self–Retaining – 44 320–1755–15 1 Lug Set – Circuit Breaker
Floating (1/4–20) (Packaged In Sets – Two
20 319–2398 2 Brace, Cover (Vertical) Lugs Per Set) (Quantity
21 319–2431–20 1 Cup, Circuit Breaker Used As Required)
22 870–0212 6 Nut, Locking (1/4–20) 45 800–0033 4 Screw, Cap – Hex Head
23 091–0002 1 Strip, Copper (Used for (5/16–18 x 2”)
wrapping ends of leads 46 526–0115 4 Washer, Flat (5/16”)
before securing to circuit 47 850–0045 4 Washer, Lock – Spring
breakers and neutral bar (5/16”)
lug) (Quantity Used As 48 856–0010 1 Washer, Lock – EIT (3/8”)
Required) 49 320–1747–18 1 Contact, Auxiliary
The following four 50 320–1748–14 1 Alarm, Bell
hardware items are used 51 320–1749–14 1 Trip, 24 Volt Shunt
the generator and neutral
bar. Quantity used as * – Parts Included In 300–4480–01 Neutral Bar Assembly
required.

Numerical Index
Part No. Page Part No. Page Part No. Page Part No. Page
091–0002, 121, 127, 145, 130–3660–02, 13, 15, 17, 19 130–3774, 45 140–1548, 20, 21, 22, 23
151, 155
130–3662, 49, 51 130–3775, 47, 49, 51 140–2052, 22, 23
098–5854–04, 153
130–3663, 49, 51 130–3778, 47, 49, 51 140–2301, 22, 23
098–5854–06, 129, 133,
139, 143, 147, 149, 151, 130–3667, 52, 53, 54 130–3826, 49, 51 140–2465, 22, 23
155 130–3679, 33 130–3827, 49, 51 140–2466, 22, 23
098–5854–07, 129, 133, 130–3680, 33 130–3866, 37 140–2501, 20, 21
139, 143, 147, 149, 151,
155 130–3681, 31 130–3868, 57, 59 140–2502, 20, 21
098–5854–08, 129, 133, 130–3682, 31 130–3869, 57, 59 140–2504–01, 21, 23
139, 143, 147, 149, 151,
155 130–3685, 31 130–3870, 57, 59 140–2504–02, 21, 23
098–5854–09, 129, 133, 130–3686, 33 130–3871–02, 57, 59 140–2509, 20, 22

139, 143, 147, 149, 151, 130–3692, 37 130–4079, 35 140–2514, 21, 23
155
130–3693–01, 47, 49, 51 130–4082, 35 140–2515, 20, 22
098–5854–10, 139, 143, 155
130–3693–02, 47, 49, 51 130–4083, 35 140–2519, 20, 22
102–1335, 13, 15, 17, 19
130–3694, 47 130–4152, 49, 51 140–2520, 23
121–0111, 25
130–3695, 47 130–4153, 52, 53, 54 140–2528, 21, 23
121–0113, 25
130–3696, 49, 51 130–4154, 53 140–2688, 21
121–0116, 25
130–3696–01, 51 130–4155, 49, 51 149–2291–01, 26
121–0117, 25
130–3697, 47 130–4165, 54 150–2213, 62
122–0776, 28
130–3698, 49, 51 130–4167, 51 150–2334, 61
122–0777, 28
130–3699, 47 130–4217, 47 151–0411, 13, 17, 19, 61, 62
127–0390–01, 55
130–3700, 47 130–4218, 47 151–0637–01, 62
127–0395, 55
130–3701, 47 130–4219, 47, 49, 51 151–0663–02, 61
127–0422, 55
130–3702, 47 130–4354, 47 155–0899, 43, 45
128–0108, 39
130–3703, 47 130–4362, 47 155–2503, 45
130–0449, 45
130–3705, 47 130–4517, 32 155–2514, 43, 45
130–1107, 85
130–3706, 47 130–4519, 39 155–2531–01, 104, 105
130–1229, 47
130–3709, 47, 49, 51 130–4533, 52, 54 155–2531–04, 104, 105
130–1419, 47
130–3710, 47, 49, 51 130–4537, 53 155–3021, 39
130–3215, 47
130–3711, 47, 49, 51 130–4538, 39 159–1445, 25
130–3588, 47, 49, 51
130–3712, 47, 49, 51 130–4539, 39 159–1448, 25
130–3592–01, 45
130–3713, 42 130–4540, 39 159–1450, 25
130–3592–02, 45
130–3714–01, 42 130–4541, 39 159–1451, 25
130–3615, 49, 51
130–3714–02, 42 130–4546, 39 179–2661, 35
130–3627, 52, 53
130–3715, 42 130–4552, 41 191–1926–02, 59
130–3631, 52, 53
130–3764, 45 130–4768, 53, 54 191–1942, 59
130–3635, 52, 53, 54
130–3765, 45 130–4769, 54 191–1981, 57
130–3636, 52, 54
130–3766, 45 130–4844, 39 191–1983–02, 57
130–3639, 49, 51
130–3767, 45 130–4860, 49, 51 191–1984, 57
130–3642, 49, 51
130–3769, 45 130–4880, 54 191–1989–07, 57
130–3644, 47, 49, 51
130–3770, 45 140–0519, 32 191–1990, 57
130–3648, 49, 51
130–3772, 45 140–1260, 20, 21, 22, 23 191–2017, 57
130–3660, 49, 51, 52, 53, 54
130–3773, 45 140–1545, 22, 23 191–2021–01, 57
130–3660–01, 47

Numerical Index
191–2023, 57, 59 232–3710–02, 73 249–5095–05, 75 302–1800, 79

191–2108, 59 232–3710–03, 73 300–2899, 116 302–1833–01, 100
191–2110, 57 232–3849, 71 300–3998–01, 92 302–1833–03, 101
191–2111, 59 234–0900–01, 72 300–4111–02, 90 302–1833–05, 100
191–2112, 59 234–0900–02, 72 300–4111–04, 90 302–1845–03, 102
191–2121, 57 234–0901–01, 72 300–4218–02, 91 302–1845–05, 102, 120
193–0029, 26 234–0901–02, 72 300–4295, 77 302–1845–06, 120
193–0128, 26 249–0192–04, 74 300–4297, 77 302–1845–10, 102
193–0244, 13 249–0192–05, 74 300–4318–01, 151 302–1852–02, 115
193–0250, 81, 108 249–5061–03, 74 300–4480–01, 127, 131, 302–1852–03, 115
137, 141, 145, 149, 155
193–0299, 104 249–5061–07, 74 302–1852–07, 115
300–4515–01, 86, 87
193–0299–01, 104 249–5063–01, 74 302–1873–01, 107
300–4515–02, 86, 87
193–0351, 81 249–5063–02, 74 302–1874, 104
301–1886, 85
193–0375, 13 249–5063–03, 74 302–1883, 101
301–6257, 107, 108, 109
193–0388, 108 249–5063–07, 74 302–1922–34, 120
301–6987, 93, 94, 96, 100,
193–0432, 17, 19 249–5064–01, 74 101 302–1922–36, 120
193–0435, 108 249–5064–02, 74 301–8065, 77 302–1922–37, 120
193–0444, 17, 19 249–5065–01, 74 301–8851, 77 302–1922–38, 120
193–0446–01, 105 249–5065–02, 74 301–9054–01, 79 302–1922–39, 120
193–0446–02, 105 249–5065–03, 74 301–9054–04, 79 302–1922–41, 120
193–0446–03, 105 249–5065–07, 74 301–9055–01, 81 302–1922–42, 120
193–0447–01, 15 249–5066–01, 74 301–9055–02, 81 302–1926–09, 120
193–0448, 15 249–5066–02, 74 301–9657, 115 302–1926–30, 115
193–0466, 81 249–5066–03, 74 301–9941, 94, 96 302–1938, 79
193–0468, 29, 30 249–5066–07, 74 302–0885, 81 302–1945–01, 119
193–0481, 29, 30 249–5067–01, 74 302–1148, 79 302–1945–02, 119
226–3371, 121 249–5088–01, 74 302–1642, 81 302–1945–04, 119
226–3376, 121 249–5088–02, 74 302–1684, 79 302–1961–09, 119
226–4406–03, 125, 145, 151 249–5088–03, 74 302–1685, 79 302–1961–10, 119
226–4406–04, 125, 145, 249–5088–07, 74 302–1721–15, 100 302–1961–11, 119
151, 153, 155
249–5089–01, 75 302–1721–16, 100 302–1961–12, 119
226–4406–06, 93
249–5089–02, 75 302–1721–17, 100 302–1961–13, 119
226–4498–01, 123, 135
249–5089–03, 75 302–1721–18, 100 302–1961–14, 119
226–4498–02, 123, 135
249–5089–07, 75 302–1722, 100 302–1968, 79
226–4498–03, 125, 133,
137, 143, 145, 149 249–5090–01, 75 302–1723, 107, 109 303–0032, 79
226–4537, 153 249–5090–02, 75 302–1753, 79 303–0223–05, 106
226–4661–02, 30 249–5090–03, 75 302–1794–11, 102 303–0280, 106
232–3536, 113 249–5090–07, 75 302–1794–12, 120 303–0285, 89
232–3551, 73 249–5092–01, 75 302–1794–13, 102, 120 305–0653, 59
232–3552–01, 73 249–5092–02, 75 302–1794–14, 102, 120 305–0817, 88
232–3552–02, 73 249–5093–01, 75 302–1798, 79 305–0821–02, 110
232–3710–01, 73 249–5095–04, 75 302–1799, 79 305–0823, 89

Numerical Index
305–0868, 89 319–0030, 93, 100, 101 319–1963, 127, 145, 155 319–3264, 65
305–0870, 102 319–0652, 89 319–1964, 125, 145, 155 319–3265, 65
305–0901, 97 319–0754, 98 319–2006–01, 83, 84 319–3266–01, 131, 141, 149
305–0902–02, 98 319–0879, 67 319–2006–02, 83, 84 319–3266–02, 141
307–1056, 90 319–0881, 67, 69 319–2236, 17, 19 319–3267, 69
307–1157, 90 319–0883, 67 319–2242, 67 319–3268, 69
307–2167, 13, 15 319–0888, 63 319–2243, 67 319–3269, 69
307–2621–02, 17, 19 319–0890, 63, 121, 123, 319–2244, 67 319–3270–03, 69
135, 153
307–2711, 45 319–2245, 67, 69 319–3270–04, 69
319–0891, 121, 153
307–2762, 35 319–2316–01, 127, 147, 155 319–3275, 69
319–0892, 63, 121, 123,
307–2843, 93 135, 153 319–2316–02, 127, 139, 147 319–3276, 69
307–2859, 41 319–0893, 121 319–2377–01, 64 319–3277, 69
307–2868, 95 319–0898, 99 319–2378, 64 319–3281–01, 69
307–2919, 96 319–1088, 67 319–2398, 64, 127, 139, 319–3281–02, 69
145, 155
307–2920, 96 319–1089, 67 319–3283–01, 69
319–2399, 64, 129, 139,
307–2921–01, 94 319–1090, 67 147, 155 319–3283–02, 69
308–0069, 115 319–1091, 67, 69 319–2431–18, 127, 145 319–3286, 65, 131, 143,
149, 151
308–0226, 61 319–1092, 67, 69 319–2431–20, 155
319–3288, 65, 131, 143,
308–0853, 109 319–1093, 67, 69 319–2431–28, 151 149, 151
308–0987, 104 319–1095, 67, 69 319–2767, 67, 69 319–3297, 119
308–1010, 81 319–1096, 67 319–2771–03, 67 319–3300, 151
308–1011, 81 319–1097, 67 319–2771–04, 67 320–1461–09, 121, 125
308–1052, 79 319–1118, 67 319–2778, 67, 69 320–1461–10, 121, 125
308–1082, 79 319–1120, 123, 135 319–2779–01, 67 320–1465–09, 121, 125
309–0128, 85 319–1121, 123, 135 319–2779–02, 67 320–1465–10, 121, 125
309–0269, 13, 15, 17, 19 319–1137, 114 319–2781–01, 67 320–1473–09, 121, 125
309–0436, 13 319–1203–01, 67, 69 319–2781–02, 67 320–1473–10, 121, 125
309–0437, 13 319–1245, 113 319–2814, 41 320–1493–09, 121, 125
309–0561, 13 319–1265, 119 319–2815, 39 320–1493–10, 121, 125
309–0576, 15 319–1293, 117 319–3030, 77 320–1688–01, 103
309–0607, 43 319–1410, 153 319–3153, 131, 141, 149, 320–1688–02, 103
309–0612, 33 151
319–1925, 64, 65, 127, 131, 320–1699, 135, 137, 141
309–0613, 33 139, 141, 145, 149, 151, 319–3184, 65, 131, 141,
155 149, 151 320–1699–01, 135, 137
309–0635–02, 42, 45, 47, 320–1699–02, 135, 137, 141
49, 51 319–1926–01, 127, 145, 155 319–3252–01, 151
319–1926–02, 127, 139, 145 319–3252–02, 131, 141, 149 320–1699–03, 135
309–0641–03, 15
319–1957, 64, 125, 137, 319–3253–01, 151 320–1699–04, 135, 137, 141
309–0641–07, 13, 15
145, 155 320–1699–05, 135, 137
309–0649, 39 319–3253–02, 131, 141, 149
319–1959–01, 125, 137, 145 320–1699–06, 135, 137, 141
309–0651–02, 15 319–3258, 69
319–1959–02, 137 320–1699–07, 135
314–0212, 111 319–3260, 69
319–1961, 64, 65, 127, 131, 320–1699–08, 137, 141
314–0213, 111 139, 141, 145, 149, 151, 319–3261, 69
155 319–3262, 69 320–1699–09, 137
315–0717, 113
319–1962, 127, 137, 145 319–3263, 69 320–1699–10, 137, 141
315–0717–01, 113

Numerical Index
320–1699–21, 135, 137, 141 320–1964–02, 151 323–1493, 83, 84 331–0532, 35

320–1699–22, 137 320–1964–06, 151 323–1494, 41 331–0533, 35
320–1699–23, 135, 137, 141 320–1964–07, 151 323–1500, 41 331–0554, 41
320–1699–24, 135 320–1977–01, 151 323–1502, 41 331–0555, 41
320–1699–25, 135, 137, 141 320–1977–03, 151 323–1503, 83, 84 332–0052, 77
320–1699–26, 137 320–1986–01, 151 323–1504, 41 332–0604, 83, 84
320–1699–27, 135, 137, 141 320–1992–01, 151 323–1540, 83 332–0607, 77
320–1699–28, 135 321–0094, 77 323–1546, 84 332–0699, 61
320–1699–29, 137, 141 321–0231, 77 323–1548, 15, 84 332–0970, 61
320–1699–30, 137 321–0270, 77 323–1549, 15 332–1043, 83, 84, 89
320–1699–31, 137, 141 321–0307–03, 77 323–1580, 83 332–1281, 13
320–1730–03, 153, 155 321–0307–06, 77 323–1581, 83 332–1292, 13
320–1730–04, 153, 155 321–0307–07, 77, 83 323–1591, 84 332–1468, 41
320–1730–07, 153, 155 321–0325, 83 323–1605–02, 83 332–1469, 41
320–1730–08, 153, 155 321–0327–01, 111 323–1605–03, 83 332–2001, 11, 127, 131, 137,
143, 145, 149, 151, 155
320–1747–18, 153, 155 321–0339, 83 323–1614–01, 83
332–2315, 114
320–1748–14, 153, 155 322–0017, 81 323–1615, 83
332–2420, 93
320–1749–14, 153, 155 322–0359–02, 81 323–1623, 83
332–2634, 13, 15, 17, 19,
320–1755–15, 153, 155 322–0360–02, 81 323–1624, 83 22, 34, 39, 47, 67, 69
320–1783, 123, 131 322–0361, 81 323–1637, 83 332–2723, 77
320–1783–01, 123, 125, 131 322–0363, 79 323–1643–01, 83 332–2744–07, 123, 127,
320–1783–02, 123, 125, 131 322–0369–02, 81 323–1644–01, 113 129, 131, 135, 137, 141,
145, 149, 151, 153, 155
320–1783–03, 131 322–0384–09, 94 323–1644–02, 113
332–2879–07, 94, 96
320–1783–04, 123, 125, 131 322–0394, 109 323–1644–03, 120
332–3007, 113
320–1783–05, 123, 125, 131 322–0431–03, 95 323–1647, 113
332–3023, 71
320–1783–06, 123, 125, 131 322–0431–04, 96 323–1648, 83, 113, 120
332–3024–14, 71
320–1783–07, 131 322–0431–07, 30 323–1652, 41, 83
332–3096–01, 83
320–1783–08, 125, 131 322–0431–08, 97 323–1666, 83
332–3178–01, 119
320–1783–09, 125, 131 322–0431–09, 93 323–1667, 83
332–3196, 73
320–1783–10, 125, 131 323–1199, 90 323–1708, 29, 30
332–3303, 129
320–1783–11, 131 323–1200, 84, 90 323–1709, 29, 30
332–3303–01, 127, 131,
320–1783–12, 125 323–1291, 90 323–1718, 41, 83 137, 141, 145, 149, 155
320–1783–13, 125 323–1292, 90 323–1765, 29, 30 332–3338, 86, 87
320–1783–14, 125 323–1302, 77 330–0004, 34 332–3440, 41
320–1783–17, 125, 131 323–1304, 84 330–0005, 34 332–3496, 83
320–1783–18, 125, 131 323–1306, 84 330–0141–03, 71 333–0133, 99
320–1783–19, 125, 131 323–1308, 77 330–0141–04, 71 333–0151, 85
320–1783–20, 131 323–1410–03, 97 330–0142, 71 333–0407–02, 27
320–1906–20, 145 323–1411–01, 94, 96 331–0010, 35 333–0407–04, 27
320–1906–21, 145 323–1444, 83 331–0027, 34, 35 333–0407–05, 27
320–1907–01, 145, 149 323–1445, 41, 83 331–0042, 41 333–0438–05, 71
320–1907–02, 145, 149 323–1491, 41, 83 331–0531–01, 35 333–0438–06, 71
320–1964–01, 151 323–1492, 15, 41, 83, 84 331–0531–02, 35 333–0468, 37

Numerical Index
333–0512–01, 35, 37 338–3035–02, 30 501–0613, 49 503–1717, 21

333–0512–02, 35, 37 338–3233, 93 501–0614, 51 503–1722, 21, 23
333–0639–01, 39 338–3235, 93 501–0615, 47 503–1723, 23
333–0639–02, 39 338–3252, 77 501–0651, 25 503–1726, 32, 45, 47, 49, 51
334–0116, 106 338–3285, 83 501–0652, 13, 15, 17, 19 503–1727, 45
335–0161, 85 338–3330, 41 501–0653, 25 503–1728, 47, 49, 51
335–0173, 86 338–3335–01, 41 501–0654, 25 503–1762, 45
337–0049, 77 338–3335–02, 41 501–0662, 13, 15, 17, 19 503–1764, 45
337–2702, 123, 135 338–3337, 113 502–0034, 26 503–1779, 37
337–2789, 129, 131, 139, 338–3340, 83 502–0067, 26 503–1863, 49, 51
143, 147, 149
338–3346, 84 502–0827, 39 503–1870–05, 47, 49
337–2794, 129
338–3360, 113 502–1043–12, 28 503–1870–10, 21, 23
338–1765–03, 84
338–3366, 95 502–1045–04, 61 503–1870–11, 20, 22
338–1904, 116
338–3594, 29, 30 502–1054–08, 55 503–1870–12, 21, 22, 23
338–1936, 100
338–3752, 94 502–1072–14, 28 503–1870–14, 20, 21, 22
338–2172, 114
350–1222, 89 502–1072–30, 28 503–1872–01, 37, 47
338–2278, 77
353–0094–01, 84 502–1162, 42, 45 503–1872–02, 45, 49, 51
338–2347, 96
355–0189, 79 502–1257, 39 503–1872–05, 45, 47, 49, 51
338–2368, 101
357–0030, 30, 41, 84, 114 502–1259, 39 503–1872–09, 47, 49, 51
338–2455, 110
357–0114, 86, 87 502–1260, 39 503–1872–10, 32, 45
338–2479, 100
359–0051, 84 502–1261, 39 504–0028, 13, 15, 17, 19, 45
338–2526, 61, 62
402–0354, 93, 94, 96, 100, 502–1266–01, 25 504–0064, 26
338–2529, 98 101
502–1266–02, 25 504–0171, 13, 15, 17, 19
338–2530, 113 402–0527, 77
502–1267, 25 504–0175, 45
338–2532, 120 402–0610, 17, 19, 67
502–1268, 25 505–0004, 37, 39
338–2536, 61 402–0612, 52, 53, 54
502–1269, 25 505–0007, 13, 15, 19, 26
338–2537, 61 402–0729, 69
502–1270, 25 505–0011, 45
338–2538, 61 403–2733–01, 45, 47, 49, 51
502–1271, 25 505–0018, 42
338–2544, 34 403–2733–02, 49, 51
502–1275, 13, 15, 17, 19 505–0019, 13, 15, 17, 19,
338–2545, 34 403–2921, 73 39, 45
502–1307, 61
338–2590, 114 403–3155, 11 505–0020, 45, 51
502–1308, 61
338–2592–02, 83 406–0332, 77 505–0021, 13, 15, 17, 19
503–0189, 13, 15, 17, 19
338–2606, 83 406–0333, 77 505–0022, 39
503–0249, 13, 15, 17, 19
338–2713, 113 406–0334, 77 505–0027, 13, 15, 17, 19
503–0685, 42, 45
338–2760–01, 37 416–0446, 13, 15, 17, 19 505–0041, 37, 39
503–0970, 20, 22
338–2760–02, 37 416–0639, 13, 15, 17, 19 505–0044, 45
503–1136, 39
338–2867, 113 416–0680, 13, 15, 17, 19 505–0054, 45
503–1418, 45, 47
338–2875, 90 416–0850, 11 505–0071, 13, 15, 17, 19
503–1620, 42, 45
338–2996, 84 416–0964, 13, 15, 17, 19 505–0100, 13, 15, 17, 19, 39
503–1634, 47
338–3012, 129 501–0520, 13, 15, 17, 19 505–0102, 13, 15, 17, 19
503–1634–01, 39
338–3019, 120 501–0522, 13, 15, 17, 19 505–0103, 43, 45
503–1675, 20, 22
338–3033, 91 501–0537–46, 61 505–0114, 45
503–1703, 22
338–3034, 97 501–0537–49, 28

Numerical Index
505–0131, 13, 15, 17, 39 518–0350, 26 526–0416, 73 800–0094, 45, 47, 49, 51,
121, 127, 139, 145
505–0132, 13, 15, 17, 19 518–0548–02, 37 526–0445, 73
800–0106, 52, 53, 54
505–0151, 108 518–0548–08, 20, 45 526–1115, 67, 69
800–0130, 55
505–0153, 42, 45 518–0548–20, 47 526–2100, 133, 143, 149
800–0133, 45
505–0177, 37, 39 518–0548–29, 25 526–2120, 113, 127, 131,
137, 141, 143, 145, 149, 800–0135, 45, 52, 53, 54
505–0324, 13, 15, 17, 19 518–0548–42, 69 151, 155
800–0138, 43
505–0376, 47, 49 518–0601, 10 526–2140, 133, 143, 149,
151 800–0152, 23
505–0759, 37 518–0633, 25, 49, 51
718–1067, 57 800–0153, 21
505–1428, 28 520–0544, 39
800–0006, 32, 92 800–0156, 47
505–1429, 45 525–0304, 10
800–0024, 77, 86 800–0158, 11
505–1430, 37, 39 525–0305, 10
800–0031, 121, 129, 147 800–0160, 45
505–1440, 43 525–0306, 10
800–0033, 22, 129, 139, 800–0163, 11, 52, 53, 54
505–1441, 45 525–0551–02, 10
147, 155 800–0237, 59
505–1442, 45 525–0551–03, 10
800–0034, 85 800–0273, 73
508–0001, 77 525–0551–04, 10
800–0039, 119 800–0304, 73
508–0015, 13 526–0002, 117
800–0048, 11, 123, 127, 129, 800–0500, 52, 53, 54, 57, 59
508–0051, 77, 114 526–0008, 89, 94, 96, 102, 131, 135, 137, 141, 145,
111, 119 149, 151, 155 800–0507, 52
508–0228, 71
526–0015, 32 800–0050, 11, 25, 47, 127, 800–0576, 73
508–0239, 153 137, 145, 153, 155
526–0018, 77 800–0580, 53
508–0292, 13, 15, 17, 19 800–0051, 33, 47, 49, 51,
526–0022, 119 129, 151 800–0596, 73
508–1057, 67, 69
526–0027, 11, 45, 47 800–0052, 123, 127, 131, 800–0605, 53, 54
508–1090, 45, 67, 69
526–0028, 31 135, 137, 141, 145, 149, 800–2008, 71
508–1109, 127, 133, 139, 151, 155
143, 145, 149, 151, 155 526–0029, 39, 51, 127, 137, 800–2059, 57
145, 147, 151, 153, 155 800–0053, 129
509–0065, 113 800–2063, 133, 143, 149
526–0030, 55, 57, 123, 129, 800–0054, 123, 135, 147
509–0272–01, 28 135 800–2080, 117
800–0055, 129
509–0272–02, 61 526–0032, 53, 54 800–2086, 67, 69, 131, 143,
800–0059, 13, 15, 17, 19 149, 151
509–0283–01, 37, 39 526–0038, 53, 54 800–0061, 17, 19 800–2088, 113
509–0336, 25 526–0049, 81 800–0062, 13, 15 800–2089, 127, 131, 137,
509–0337, 25 526–0098, 57, 59 141, 145, 149, 155
800–0069, 57, 59
511–0119, 57 526–0112, 43, 45 800–2114, 151
800–0071, 57
511–0161–02, 59 526–0113, 85 800–2116, 133, 143, 149
800–0072, 54, 61
511–0161–04, 52, 54 526–0115, 94, 96, 100, 101, 800–2526, 55
800–0074, 59
511–0161–10, 53 121, 129, 139, 147, 155
800–0075, 28, 47 805–0035, 73
511–0161–11, 54 526–0124, 21
800–0077, 52, 53, 54 809–0036, 13
517–0021, 71 526–0128, 32, 39
800–0078, 52, 53, 54 812–0063, 91
517–0090, 119 526–0141, 47, 52, 53, 54,
67, 69 800–0081, 25 812–0067, 17, 19
517–0131, 67, 69, 79, 81, 89 812–0070, 85, 117
526–0219, 45, 47, 49, 51, 800–0088, 52, 53
517–0135, 69 52, 53, 54, 121, 127, 139, 812–0079, 34, 113
145, 155 800–0090, 13, 15, 17, 19,
517–0137, 81, 108 49, 51 812–0081, 93
526–0353, 59
517–0138–02, 41 800–0091, 31 812–0082, 98
526–0399–19, 47
517–0301, 81 800–0092, 47, 49, 51, 59, 812–0084, 89, 97
526–0409, 81 155
517–0302, 79

Numerical Index
812–0085, 113, 114 821–0030, 21, 47, 129, 139, 850–0060, 13, 15, 17, 19, 862–0017, 73
147 31, 45, 47, 49, 51, 53, 59,
813–0098, 119 73, 121, 127, 139, 145, 155 864–0017, 61
821–0031, 123, 135
813–0100, 35, 94, 96, 114, 850–0070, 43, 45, 52, 53, 54 864–0020–01, 61
115 821–0033, 17, 20, 21, 23, 45
850–0079, 11, 21, 23, 45, 47 870–0048, 94, 96, 100, 101
813–0103, 35, 61, 62, 102, 821–0035, 47, 49, 51
110 850–0092, 73 870–0053, 115
821–2023, 72
813–0107, 111 850–0114–07, 47 870–0131, 39, 77, 88, 94,
821–2034, 151 96, 102, 110, 111, 114
813–0108, 89 850–2003, 71
821–2035, 65, 131, 143, 149 870–0183, 17, 19, 81, 85, 99
815–0340, 34 850–2004, 71
821–5000–05, 77 870–0196, 13
815–0384, 47, 49, 51 850–2005, 71
821–5002–03, 39, 42, 47, 870–0212, 17, 19, 22, 37,
815–0385, 81, 99 49, 51, 62, 67 850–2008, 57, 133, 143, 149 49, 51, 127, 145, 155
815–0388, 77, 95, 98 821–5002–04, 57, 59 850–2010, 67, 69, 117, 127, 870–0221, 93, 94, 96, 100,
131, 137, 141, 143, 145, 101, 113
815–0447, 41 821–5003–01, 47, 49, 51, 67 149, 151, 155
870–0257, 20, 64, 85, 86,
815–0538, 83, 84 821–5003–03, 45, 67 850–2012, 133, 143, 149, 93, 113, 129, 139, 147, 155
815–0539, 39 821–5004–02, 25, 39, 45, 151
870–0281, 11, 20, 21, 42
49, 51, 67 853–0005, 93, 94, 96, 100,
815–0544, 89, 90, 116 870–0437, 21, 22, 23, 47
821–5004–03, 11, 39, 42, 47, 114
815–0724, 55 49, 59 870–0452, 59
853–0008, 77, 81, 101
815–0769–01, 52, 53, 54 821–6001–03, 62 870–0494, 64, 127, 137,
854–0006, 85
815–0875–02, 79 145, 155
821–6002–03, 62, 65, 69, 856–0006, 13, 15, 67, 69
815–0901–06, 77 131, 141, 149, 151 870–0504, 65, 131, 141,
856–0008, 77, 86, 120 149, 151
815–0905–06, 100, 101 821–6003–02, 69, 131, 141,
149, 151 856–0010, 11, 13, 15, 17, 19, 870–0517–01, 90
816–0098, 64, 129, 139, 129, 131, 139, 143, 147,
147, 155 821–6004–01, 69 149, 151, 155 870–0517–02, 90
821–0004, 77 822–1050, 61 856–0013, 13, 15, 17, 19 870–0550–05, 67
821–0005, 88 822–3047, 71 860–0006, 85 870–0550–07, 45, 67
821–0010, 13, 15, 35, 47, 822–3075, 71 860–2005, 71 870–0550–09, 39, 45, 47,
63, 64, 121, 123, 125, 129, 49, 51, 67
850–0025, 113 860–2006, 71
135, 137, 145, 147, 153, 870–1221, 97
155 850–0030, 62, 81, 89, 115, 860–2010, 133, 143, 149,
119 151 870–2054, 69, 151
821–0011, 64, 127, 139, 145,
155 850–0040, 92 862–0001, 92 870–2055, 69
821–0014, 77 850–0045, 119, 121, 129, 862–0003, 123, 129, 135, 870–2056, 69
139, 147, 155 147, 151
821–0016, 20, 113 871–0010, 81
850–0048, 49, 51 862–0005, 121, 127, 139,
821–0017, 93 871–0015, 77
850–0050, 13, 15, 17, 19, 145
821–0018, 22, 64, 127, 139, 25, 33, 47, 123, 127, 129, 895–0182, 32, 127, 131,
145, 155 862–0007, 43, 45 139, 141, 147, 149, 151,
135, 137, 145, 147, 151,
153, 155 862–0008, 11, 45, 47 155
821–0022, 57
850–0055, 25, 28, 52, 53, 862–0015, 119 898–1254–25, 71
821–0028, 22
54, 57, 59, 61
821–0029, 20, 21 862–0016, 45, 47, 49, 51,
155


!"
#!" $$% %

&
'( )

''

&
'( ) ''
&
'*


Partsmanual Onan K38-G3 PDF

Uploaded by

Copyright:

Available Formats

Partsmanual Onan K38-G3 PDF

Uploaded by

Document Information

Original Title

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

Partsmanual Onan K38-G3 PDF

Uploaded by

Copyright:

Available Formats

Parts Catalog

Printed in U.S.A. 960–0277 DFJA, DFJB (Spec J–M) 12–99

Redistribution or publication of this document

Onan/Cummins Generator Model Cummins Engine Model

Generator Set Data Table

Model and Electrical Data Battery

+ – Models DFJA and DFJB were discontinued after Spec M.

# – Broad range reconnectible

Redistribution or publication of this document

Redistribution or publication of this document

Redistribution or publication of this document

Redistribution or publication of this document

Redistribution or publication of this document

Redistribution or publication of this document

Redistribution or publication of this document

Redistribution or publication of this document

Paint and Thread Sealant

REF PART QTY PART REF PART QTY PART

Onan Green Enamel Cummins Beige Enamel

REF PART QTY PART REF PART QTY PART

1 403–3155 1 Skid 10 870–0281 1 Nut, Locking – Hex Head

Redistribution or publication of this document

Redistribution or publication of this document

REF PART QTY PART REF PART QTY PART

Redistribution or publication of this document

Redistribution or publication of this document

REF PART QTY PART REF PART QTY PART

1 309–0269 1 Switch, Temperature – Low 19 850–0060 1 Washer, Lock – Spring (1/2”)

Redistribution or publication of this document

Redistribution or publication of this document

REF PART QTY PART REF PART QTY PART

1 193–0432 3 Sender, Oil Temperature (S2 25 130–3660–02 4 Spacer (1/2” ID x 1–3/4”)

Redistribution or publication of this document

Redistribution or publication of this document

REF PART QTY PART REF PART QTY PART

1 193–0432 3 Sender, Oil Temperature (S2 25 130–3660–02 4 Spacer (1/2” ID x 1–3/4”)

Redistribution or publication of this document

REF PART QTY PART REF PART QTY PART

1 140–2501 2 Cleaner, Air (Disposable) 12 870–0281 8 Nut, Hex – Locking (3/8–16)

Redistribution or publication of this document

REF PART QTY PART REF PART QTY PART

1 140–2501 2 Cleaner, Air (Disposable) 14 821–0029 7 Screw, Self–Locking – Hex

Redistribution or publication of this document

REF PART QTY PART REF PART QTY PART

1 140–2301 2 Cleaner, Air (Includes 13 503–1870–12 2 Clamp, Hose

Redistribution or publication of this document

REF PART QTY PART REF PART QTY PART

1 140–2301 2 Cleaner, Air (Includes 11 503–1870–12 6 Clamp, Hose

Redistribution or publication of this document

Redistribution or publication of this document

REF PART QTY PART REF PART QTY PART

1 502–1267 1 Connector, Straight (7/8–14 x 12 518–0633 1 Clamp, “J”

Redistribution or publication of this document

REF PART QTY PART REF PART QTY PART

1 193–0128 1 Gauge, Fuel Pressure 6 505–0007 1 Bushing, Pipe – Reducer

Redistribution or publication of this document

REF PART QTY PART REF PART QTY PART

27 Redistribution or publication of this document

REF PART QTY PART REF PART QTY PART