Revision

1.0.0

WI.FS24-100ST
(WI.FREESTAR)
DATASHEET
WI.FS24-100ST-R DATASHEET

RADIOTRONIX, INC.

WI.FS24-100ST/ WI.FREESTAR DATASHEET

© Radiotronix
905 Messenger Lane
Moore, Oklahoma 73160
Phone 405.794.7730 • Fax 405.794.7477
www.radiotronix.com

1
WI.FS24-100ST-R DATASHEET

Document Control
SIGNED DATE
CREATED BY TJE 6/13/2007
ENGINEERING REVIEW
MARKETING REVIEW TJE 6/13/2007
APPROVED- ENG.
APPROVED- MAR. TJE 6/13/2007

Revised History
REVISION SIGNED DATE DESCRIPTION
1.0.0 TJE 6/13/2007 Document created

2
WI.FS24-100ST-R DATASHEET

Table of Contents
1. INTRODUCTION .......................................................................................................................................... 5
1.1. MODULE OVERVIEW .................................................................................................................................. 5
1.2. FEATURES ................................................................................................................................................ 5
1.3. APPLICATIONS ........................................................................................................................................... 6
2. MODULE SPECIFICATIONS ....................................................................................................................... 7

3. APPLICATION INFORMATION ................................................................................................................... 8

3.1. PIN-OUT DIAGRAM ..................................................................................................................................... 8
3.2. PIN DESCRIPTION ...................................................................................................................................... 9
3.3. MECHANICAL DRAWINGS ......................................................................................................................... 10
3.4. EXAMPLE CIRCUIT ................................................................................................................................... 11
4. RADIATION PATTERNS ........................................................................................................................... 12

5. TYPICAL PERFORMANCE/ CURVES ...................................................................................................... 13

6. ELECTRICAL SPECIFICATIONS.............................................................................................................. 15
6.1. ABSOLUTE MAXIMUM RATINGS ................................................................................................................. 15
6.2. RECOMMENDED OPERATING CONDITIONS ................................................................................................ 15
6.3. DETAILED ELECTRICAL SPECIFICATIONS ................................................................................................... 15
6.3.1. AC Specifications ............................................................................................................................ 15
6.3.2. DC Specifications............................................................................................................................ 16
7. CUSTOM APPLICATIONS ........................................................................................................................ 17

8. ORDERING INFORMATION ...................................................................................................................... 18

8.1. CONTACT INFORMATION .......................................................................................................................... 18
8.1.1. Technical Support ........................................................................................................................... 18
8.1.2. Sales Support.................................................................................................................................. 18

3
WI.FS24-100ST-R DATASHEET

Index of Tables
Table 1, Module Pin Descriptions.......................................................................................................................... 9
Table 2, Radiation Patterns................................................................................................................................. 12
Table 3, Typical Output Power vs. MC13192 power setting (Vdd 3.3V, 25OC ..................................................... 13
Table 4, Power Settings ...................................................................................................................................... 13
Table 5, Absolute Maximum Ratings................................................................................................................... 15
Table 6, AC Specifications- Rx............................................................................................................................ 15
Table 7, DC Specifications .................................................................................................................................. 16

Table of Figures
Figure 1: Wi.FreeStar Block Diagram.................................................................................................................... 5
Figure 2: Pin-out Diagram ..................................................................................................................................... 8
Figure 3: Module Mechanical Drawings .............................................................................................................. 10
Figure 4: PCB Footprint....................................................................................................................................... 10
Figure 5: Sample Connection Diagram using Serial Interface ............................................................................ 11
Figure 6: Sample Connection Diagram using Host Processor Interface.............................................................11
Figure 7: Radiation Patterns (Orientation)........................................................................................................... 12
Figure 8: Typical Output Spectrum of Transmitter .............................................................................................. 14
Figure 9: Receive Port Input Impedance at Antenna .......................................................................................... 14

4
 Chapter
WI.FS24-100ST-R DATASHEET

1
1. Introduction
The Wi.FreeStar module is a 2.4 GHz 802.15.4 data transceiver module intended for Very Low Cost Wireless
Applications. The module design is based on the MC13192/3 RF transceiver from Freescale which is based on
the IEEE 802.15.4 standard and intended for use in Zigbee applications. It provides for enhanced range
performance over standard 802.15.4/Zigbee implementations with the integrated 100mW power amplifier. It
implements a proprietary communications protocol based on the 802.15.4 standard streamlined to lower cost and
power consumption. The Wi.FreeStar module design consists of the MC13192, the MC9S08GT16CFD uP, 100
mW PA, and integrated PCB trace antenna. The module is FCC and CE certified for fast and simple integration
into end applications. The Wi.FreeStar Module provides the lowest cost, best in class range in an extremely small
form factor.

1.1. Module Overview

Figure 1: Wi.FreeStar Block Diagram

1.2. Features
• Networking

5
WI.FS24-100ST-R DATASHEET

o Point-to-Point
o Point-to-Mulitpoint
• Range: up to 4000ft.
• Very Small Form Factor (1.4” x 1.0”)/ (36.2mm x 24.8mm)
• Inverted-F PCB Trace Antenna
• FCC, IC, and CE Certified
• Direct Sequence Spread Spectrum
• CSMA-CA
• Flash based/ Upgradable
• 10 bits A/D (2 inputs)
• General Purpose Digital I/O (8 pins)
• Windows® Based Configuration and Test Tool

1.3. Applications
• Direct RD-232/422/485 Wire replacement (requires external RS-232 to 3V CMOS conversion
circuitry)
• Asset tracking
• Automated meter reading
• Industrial and/ or Home automation
• RFID
• Wireless sensors
• Remote data logging
• Fleet management

6
 Chapter
WI.FS24-100ST-R DATASHEET

2
2. Module Specifications
Frequency 2400 to 2483.5 MHz
Output Power 10mW – 100mW (software controlled)
Receiver Sensitivity -92 dBm @ 1% PER
RF Data Rate 250 kbps
Host Data Rate 19.2 kbps
RF Channels 16 (channel 16 is set at a reduced power level)
FCC Part 15.247 Module Certified (Portable)
EMC Certifications
EN 300 328 1 Certified/ CE Approved
Voltage Operating Range 2.4 to 3.6 V
Power Consumption
Transmit Mode (10mW) 125 mA
Transmit Mode (100mW) 150 mA
Receive Mode <45 mA
Standby Mode <5 uA
Host Interface Serial TTL
o
Operating Temperature -40 to +85 C
o
Storage Temperature -55 to +125 C

7
 Chapter
WI.FS24-100ST-R DATASHEET

3
3. Application Information

3.1. Pin-out Diagram

Figure 2: Pin-out Diagram

Note: PIN Numbering begins at top left-hand side with pin number 1 and follows counter-clockwise about the
perimeter of the module.

8
WI.FS24-100ST-R DATASHEET

3.2. Pin Description

PIN TYPE SIGNAL NAME DESCRIPTION
ANT2 AO/ AI ANT2 Integrated PBC F-Antenna
TPRF1 AO/ AI TPRF1 Coaxial RF Test Point- 50 Ohms
1 GND GND Ground
2 GND GND Ground
3 GND GND Ground
4 GND GND Ground
General Purpose Digital I/O Firmware Configurable Port
5 DI/ DO PTD3
D, BIT 3
General Purpose Digital I/O Firmware Configurable Port
6 DI/ DO PTD4
D, BIT 4
7 AI PTB0 Analog to Digital Converter Input, Port B, Input 0
8 AI PTB1 Analog to Digital Converter Input, Port B, Input 1
9 PI VCC Primary Power Input: VCC= 2.7 – 3.6, TBD mA max.
10 GND GND Ground
11 DI MODE0 FCC/ Production Test Mode Input Word, BIT 0
12 DI MODE1 FCC/ Production Test Mode Input Word, BIT 1
13 DI MODE2 FCC/ Production Test Mode Input Word, BIT 2
General Purpose Digital I/O Firmware Configurable Port
14 DI/ DO PTA4
A, BIT 4, (KBI1P4) Keyboard Interrupt
General Purpose Digital I/O Firmware Configurable Port
15 DI/ DO PTA5
A, BIT 5, (KBI1P5) Keyboard Interrupt
General Purpose Digital I/O Firmware Configurable Port
16 DI/ DO PTA6
A, BIT 6, (KBI1P6) Keyboard Interrupt
Digital Input configured to Interrupt on rising edge of
17 DI PTA7 signal to wake up module from sleep mode, Port A, BIT 7
(KBI1P7) Keyboard Interrupt
Port G, BIT 0 (BKGD/ MS) Background/ Mode Select for
18 DI/ DO PTG0
Programming and Firmware Debug
19 DI /RESET Master Reset, Active Low
General Purpose Digital I/O Firmware Configurable Port
20 DI/ DO PTC0 C, BIT 0 (SCI2, TXD2) Serial Communication Interface 2,
Transmit Data
General Purpose Digital I/O Firmware Configurable Port
21 DI/ DO PTC1 C, BIT 0 (SCI2, RXD2) Serial Communication Interface 2,
Receive Data
22 DI/ DO PTC5 Reserved
Application Transmit Data Output (SCI1, TXD1) Serial
23 DO TXD
Communication Interface 1, Transmit Data
Application Receive Data Input (SCI1, RXD1) Serial
24 DI RXD
Communication Interface 1, Receive Data
25 GND GND Ground
26 GND GND Ground
27 GND GND Ground
28 GND GND Ground
29 GND GND Ground
30 GND GND Ground
Table 1, Module Pin Descriptions

Legend
DI Digital Input Logic Input High: 0.8 (VCC) < VIH < (VCC)
DO Digital Output Logic Input Low: 0 < VIL < 0.2 (VCC)
AI Analog Input Logic Output High: (VCC – 0.4) < VOH < VCC
AO Analog Output Logic Output Low: 0 < VOH < 0.4
PI Power Input
GND Ground

9
WI.FS24-100ST-R DATASHEET

3.3. Mechanical Drawings

Figure 3: Module Mechanical Drawings

Figure 4: PCB Footprint

10
WI.FS24-100ST-R DATASHEET

3.4. Example Circuit

Figure 5: Sample Connection Diagram using Serial Interface

Figure 6: Sample Connection Diagram using Host Processor Interface

11
 Chapter
WI.FS24-100ST-R DATASHEET

4
4. Radiation Patterns
Wi.FreeStar Rev B (2440 MHz)
Device of Gain (dBi)
Polarization
Orientation Max Avg
(V) Vertical 0.60 -1.72
(V) Horizontal -7.27 -12.37
(H) Vertical -4.00 -10.91
(H) Horizontal 0.02 -5.90
(F) Vertical -6.60 -13.52
(F) Horizontal 0.85 -4.67
Total Avg Gain (dBi) -3.15
Table 2, Radiation Patterns
90
5
120 60
0
-5
-10
150 -15 30
-20
-25
-30

180 0

210 330

240 300

270

____Vertical Polarization
------- Horizontal
90 Polarization
5
120 60
0
-5
-10
150 -15 30
-20
-25
-30

180 0

210 330

240 300

270

____Vertical Polarization
------- Horizontal Polarization
90
5
120 60
0
-5
-10
150 -15 30
-20
-25
-30

180 0

210 330

240 300

270

Figure 7: Radiation Patterns (Orientation) ____Vertical Polarization

------- Horizontal Polarization

12
 Chapter
WI.FS24-100ST-R DATASHEET

5
5. Typical Performance/ Curves
Typical TX Power and TX Current vs Supply Voltage over Temperature

350 25

TX Power
300 20

250 15

Power (dBm)
Current (mA)

200 10

150 5

Current

100 0

+25ºC
-40ºC
50 +85ºC -5

0 -10
3.6 3.3 3 2.7 2.4
Supply Voltage (V)

Table 3, Typical Output Power vs. MC13192 power setting (Vdd 3.3V, 25OC

Power Setting Output Power Units

>= 30 20 dBm
28 19.6 dBm
26 18.3 dBm
24 18 dBm
22 17.6 dBm
20 17 dBm
18 11.4 dBm
16 10.8 dBm
14 10.1 dBm
12 9.5 dBm
10 1.9 dBm
8 1.4 dBm
6 0.9 dBm
4 0.3 dBm
2 -9.7 dBm
Table 4, Power Settings

13
WI.FS24-100ST-R DATASHEET

Figure 8: Typical Output Spectrum of Transmitter

Figure 9: Receive Port Input Impedance at Antenna

14
 Chapter
WI.FS24-100ST-R DATASHEET

6
6. Electrical Specifications

6.1. Absolute Maximum Ratings

Parameter Min Max Units
Vdd- Power Supply 2.7 3.6 VDC
Input RF Level 10 dBm
o
Storage Temperature -55 +125 C
Table 5, Absolute Maximum Ratings

6.2. Recommended Operating Conditions

Parameter Min Typ Max Units
Vdd- Power Supply 2.7 3.3 3.6 VDC
Input Frequency 2405 2480 MHz
o
Ambient Temperature Range -40 25 +85 C
Logic Input Low Voltage 0 30% Vdd V
Logic Input High Voltage 70% Vdd Vdd V

6.3. Detailed Electrical Specifications

6.3.1. AC Specifications
Parameter Min Typ Max Units Notes
Sensitivity for 1% packet error rate (-40 to +85ºC) -92 dBm
Sensitivity for 1% packet error rate (25ºC) -92 -87 dBm
Saturation (maximum input level) 10 dBm
Nominal Output Power 20 dBm
Output Power Control Range (+20 to -10 dBm) 30 dB
Error Vector Magnitude (EVM) 35 %
Over the Air Data Rate 250 kbps
On-board antenna gain (peak) 0.8 dBi
On-board antenna gain (average) -3.1 dBi
Table 6, AC Specifications- Rx

15
WI.FS24-100ST-R DATASHEET

6.3.2. DC Specifications
Parameter Min Typ Max Units Notes
Power Supply Current
Transmit Mode (10 dBm) 125 mA 10 dBm
Transmit Mode (20 dBm) 150 mA 20 dBm
Receive Mode 42 mA
Sleep Mode 1 2 5 µA
Output High Voltage 80% Vdd V All digital outputs
Output Low Voltage 0 20% V All digital outputs
Table 7, DC Specifications

16
 Chapter
WI.FS24-100ST-R DATASHEET

7
7. Custom Applications
For cost-sensitive applications, such as wireless sensors and AMR, Radiotronix can embed the application
software directly into the microcontroller built into the module. For more information on this service, please
contact Radiotronix.

17
 Chapter
WI.FS24-100ST-R DATASHEET

8
8. Ordering Information
Product Part Number Description
Wi.FS24-100ST ZigBee-Ready Module (2.4 GHz)

8.1. Contact Information

Corporate Headquarters:
905 Messenger Lane
Moore, Oklahoma 73160
405-794-7730
website: www.radiotronix.com
support: [email protected]

8.1.1. Technical Support

Radiotronix has built a solid technical support infrastructure so that you can get answers to your questions
when you need them. Our primary technical support tools are the support forum and knowledge base found
on our website. We are continuously updating these tools. To find the latest information about these
technical support tools, please visit http://www.radiotronix.com/support. Our technical support engineers are
available Mon-Fri between 9:00 am and 5:00 pm central standard time. The best way to reach a technical
support engineer is to submit a Webcase. Webcase submissions can be made at
http://www.radiotronix.com/support/webcase.asp. For customers that would prefer to talk directly to a support
engineer, we do offer phone support free of charge.

8.1.2. Sales Support

Our sales department can be reached via e-mail at [email protected] or by phone at 405-794-
7730. Our sales department is available Mon-Fri between 8:30 am and 5:00 pm central standard time.
Visit our web site at http://www.radiotronix.com/corpsales.asp for information on where to buy our
products.

18