Document ID: 1469805 Page 1 of 1

2008 Chevrolet Aveo | Aveo, Wave, G3, Barina (VIN S/T) Service Manual | Safety and Security | Theft Deterrent |
Component Locator | Document ID: 1469805

Content Theft Components

(1) Door Latch Left - Right Similar

(2) Theft Deterrent Alarm
(3) Lock Cylinder Switch - Rear Compartment Lid

© 2010 General Motors Corporation. All rights reserved.

http://localhost:9001/si/showDoc.do?docSyskey=1469805&from=sm 7/6/2010
Document ID: 1973309 Page 1 of 1

2008 Chevrolet Aveo | Aveo, Wave, G3, Barina (VIN S/T) Service Manual | Safety and Security | Theft Deterrent |
Component Locator | Document ID: 1973309

Front of Vehicle

(1) Hood Ajar Switch (Except North America)

© 2010 General Motors Corporation. All rights reserved.

http://localhost:9001/si/showDoc.do?docSyskey=1973309&from=sm 7/6/2010
Document ID: 1973251 Page 1 of 1

2008 Chevrolet Aveo | Aveo, Wave, G3, Barina (VIN S/T) Service Manual | Safety and Security | Theft Deterrent |
Component Locator | Document ID: 1973251

Remote Control Door Lock Receiver (Notchback)

(1) Remote Control Door Lock Receiver (RCDLR)/Theft Deterrent Control Module

© 2010 General Motors Corporation. All rights reserved.

http://localhost:9001/si/showDoc.do?docSyskey=1973251&from=sm 7/6/2010
Document ID: 1824854 Page 1 of 1

2008 Chevrolet Aveo | Aveo, Wave, G3, Barina (VIN S/T) Service Manual | Safety and Security | Theft Deterrent |
Component Locator | Document ID: 1824854

Remote Control Door Lock Receiver (RCDLR) (Hatchback)

(1) Remote Control Door Lock Receiver (RCDLR)

© 2010 General Motors Corporation. All rights reserved.

http://localhost:9001/si/showDoc.do?docSyskey=1824854&from=sm 7/6/2010
Document ID: 1735783 Page 1 of 5

2008 Chevrolet Aveo | Aveo, Wave, G3, Barina (VIN S/T) Service Manual | Safety and Security | Theft Deterrent |
Component Locator | Document ID: 1735783

Theft Deterrent System Connector End Views

(Notchback)
Table 1: Door Handle Switch - Left (LHD)
Table 2: Door Handle Switch - Left (RHD)
Table 3: Door Handle Switch - Right (LHD)
Table 4: Door Handle Switch - Right (RHD)
Table 5: Hood Ajar Switch
Table 6: Rear Compartment Lid Tamper Switch
Table 7: Remote Control Door Lock Receiver (RCDLR)/Theft Deterrent Control Module
Table 8: Theft Deterrent Alarm
Door Handle Switch - Left (LHD)

• AK 32421
Connector Part Information
• 4-Way M (GY)
Pin Wire Circuit Function
A L-BU -- Lock Signal
B BK -- Ground
C WH -- Unlock Signal
D L-GN -- Door Latch Switch Signal
Door Handle Switch - Left (RHD)

© 2010 General Motors Corporation. All rights reserved.

http://localhost:9001/si/showDoc.do?docSyskey=1735783&pubCellSyskey=151729&pubO... 7/6/2010
Document ID: 1735783 Page 2 of 5

• AK 32421
Connector Part Information
• 4-Way M (GY)
Pin Wire Circuit Function
A -- -- Not Used
B BK -- Ground
C -- -- Not Used
D D-BU/RD -- Door Latch Switch Signal
Door Handle Switch - Right (LHD)

• AK 32421
Connector Part Information
• 4-Way M (GY)
Pin Wire Circuit Function
A -- -- Not Used
B BK -- Ground
C -- -- Not Used
D D-BU/RD -- Door Latch Switch Signal
Door Handle Switch - Right (RHD)

http://localhost:9001/si/showDoc.do?docSyskey=1735783&pubCellSyskey=151729&pubO... 7/6/2010
Document ID: 1735783 Page 3 of 5

• AK 32421
Connector Part Information
• 4-Way M (GY)
Pin Wire Circuit Function
A L-GN -- Door Latch Switch Signal
B WH -- Unlock Signal
C BK -- Ground
D L-BU -- Lock Signal
Hood Ajar Switch

• KET MG 610392
Connector Part Information
• 2-Way F Series, Sealed (WH)
Pin Wire Circuit Function
1 PK/D-BU -- Hood Ajar Switch Signal
2 RD/WH -- Battery Positive Voltage
Rear Compartment Lid Tamper Switch

http://localhost:9001/si/showDoc.do?docSyskey=1735783&pubCellSyskey=151729&pubO... 7/6/2010
Document ID: 1735783 Page 4 of 5

• KET MG 610070
Connector Part Information
• 2-Way F 090 (2.3 mm) Series (WH)
Pin Wire Circuit Function
1 PU -- Rear Compartment Lid Switch Signal
2 BK -- Ground
Remote Control Door Lock Receiver (RCDLR)/Theft Deterrent Control
Module

• KET MG 611336
Connector Part Information
• 26-Way F PCB Connector (WH)
Pin Wire Circuit Function
1 YE -- Arm Alarm Signal
2 BK -- Ground
3 -- -- Not Used
4 PU -- Rear Compartment Lid Switch Signal
5 OG/BK -- Rear Compartment Lid Ajar Switch Signal
6 -- -- Not Used
7 PK/D-BU -- Hood Ajar Switch Signal

http://localhost:9001/si/showDoc.do?docSyskey=1735783&pubCellSyskey=151729&pubO... 7/6/2010
Document ID: 1735783 Page 5 of 5

8 WH -- Door Ajar Signal

9 L-BU -- Door Lock Control
10 GY/D-GN -- Driver Door Lock Relay Lock Control
11 YE -- Driver Door Lock Relay Unlock Control
12 PU -- Door Latch Switch Signal
13 D-BU -- Right Turn Signal Lamps Supply Voltage
14 BN -- Rear Compartment Lid Switch Signal
15 PK -- Ignition 1 Voltage
16 -- -- Not Used
17 BK/WH -- Serial Data
18 L-GN -- Key In Ignition Switch Signal
19 YE -- Security Indicator Control
20 PU -- Door Latch Switch Signal
21-24 -- -- Not Used
25 RD/WH -- Battery Positive Voltage
26 L-BU -- Left Turn Signal Lamps Supply Voltage
Theft Deterrent Alarm

• KUM PB 625-02027
Connector Part Information
• 2-Way F NMWP 04F-B Assembly (BK)
Pin Wire Circuit Function
1 YE -- Arm Alarm Signal
2 RD/WH -- Battery Positive Voltage

http://localhost:9001/si/showDoc.do?docSyskey=1735783&pubCellSyskey=151729&pubO... 7/6/2010
Document ID: 1791627 Page 1 of 4

2008 Chevrolet Aveo | Aveo, Wave, G3, Barina (VIN S/T) Service Manual | Safety and Security | Theft Deterrent |
Component Locator | Document ID: 1791627

Theft Deterrent System Connector End Views

(Hatchback)
Table 1: Hood Ajar Switch
Table 2: Lock Cylinder Switch - Rear Compartment
Table 3: Remote Control Door Lock Receiver (RCDLR)
Table 4: Theft Deterrent Alarm
Table 5: Theft Deterrent Control Module
Hood Ajar Switch

• KET MG 610392
Connector Part Information
• 2-Way F Series Sealed (WH)
Pin Wire Circuit Function
1 BN/BK 109 Hood Ajar Switch Signal
2 OG 1440 Battery Positive Voltage
Lock Cylinder Switch - Rear Compartment

© 2010 General Motors Corporation. All rights reserved.

http://localhost:9001/si/showDoc.do?docSyskey=1791627&pubCellSyskey=151729&pubO... 7/6/2010
Document ID: 1791627 Page 2 of 4

• KET MG 610070
Connector Part Information
• 2-Way F 090 (2.3 mm) Series (WH)
Pin Wire Circuit Function
1 D-BU 737 Rear Compartment Lid Ajar Switch Signal
2 BK 850 Ground
Remote Control Door Lock Receiver (RCDLR)

• KET MG 611336
Connector Part Information
• 26-Way F PCB Connector (WH)
Pin Wire Circuit Function
1 D-GN/WH 261 Arm Alarm Signal
2 BK 650 Ground
3 -- -- Not Used
4 D-BU 49 Tamper Switch Signal (4 Door)
5 OG/BK 737 Rear Compartment Lid Ajar Switch Signal
6 -- -- Not Used
7 BN/BK 109 Hood Ajar Switch Signal
8 D-GN/WH 157 Courtesy Lamp Control
9 GY 195 Door Lock Control
10 GY/D-GN 355 Low Speed Cooling Fan Relay Control
11 YE/D-GN 356 Driver Door Lock Relay Unlock Control
12 D-BU 49 Tamper Switch Signal
13 D-BU 15 Right Turn Signal Lamps Supply Voltage
14 -- -- Not Used
15 PK 239 Ignition 1 Voltage
16 -- -- Not Used
17 BK/WH 2051 Serial Data
18 L-GN 80 Key In Ignition Switch Signal
19 YE 749 Security Indicator Control

http://localhost:9001/si/showDoc.do?docSyskey=1791627&pubCellSyskey=151729&pubO... 7/6/2010
Document ID: 1791627 Page 3 of 4

20 D-BU 49 Tamper Switch Signal

21-24 -- -- Not Used
25 OG 1340 Battery Positive Voltage
26 L-BU 14 Left Turn Signal Lamps Supply Voltage
Theft Deterrent Alarm

• KUM PB 625-02027
Connector Part Information
• 2-Way F NMWP 04F-B Assembly (BK)
Pin Wire Circuit Function
1 D-GN/WH 261 Arm Alarm Signal
2 BN 641 Ignition 3 Voltage
Theft Deterrent Control Module

• SD 35508-0700
Connector Part Information
• 7-Way Connector F (WH)
Pin Wire Circuit Function
1 PK 239 Ignition 1 Voltage
2 OG 240 Battery Positive Voltage

http://localhost:9001/si/showDoc.do?docSyskey=1791627&pubCellSyskey=151729&pubO... 7/6/2010
Document ID: 1791627 Page 4 of 4

3 -- -- Not Used
4 BK 450 Ground
5 D-BU/WH 1800 Battery Positive Voltage
6 BK/WH 2051 Serial Data
7 YE 749 Security Indicator Control

http://localhost:9001/si/showDoc.do?docSyskey=1791627&pubCellSyskey=151729&pubO... 7/6/2010
Document ID: 1293325 Page 1 of 2

2008 Chevrolet Aveo | Aveo, Wave, G3, Barina (VIN S/T) Service Manual | Safety and Security | Theft Deterrent |
Repair Instructions | Document ID: 1293325

Theft Deterrent Alarm Replacement

Caution: Unless directed otherwise, the ignition and start switch must be in the OFF or LOCK
position, and all electrical loads must be OFF before servicing any electrical component. Disconnect
the negative battery cable to prevent an electrical spark should a tool or equipment come in
contact with an exposed electrical terminal. Failure to follow these precautions may result in
personal injury and/or damage to the vehicle or its components.

Removal Procedure

1. Remove the theft deterrent alarm electrical connector.

2. Remove the theft deterrent alarm bracket mounting bolts and the theft deterrent alarm.

Installation Procedure

Notice: Refer to Fastener Notice in the Preface section.

© 2010 General Motors Corporation. All rights reserved.

http://localhost:9001/si/showDoc.do?docSyskey=1293325&pubCellSyskey=149040&pubO... 7/6/2010
Document ID: 1293325 Page 2 of 2

1. Install the theft deterrent alarm with the mounting bolts.

Tighten
Tighten the theft deterrent alarm bracket mounting bolts to 11 N·m (97 lb in).

2. Connect the theft deterrent alarm electrical connector.

http://localhost:9001/si/showDoc.do?docSyskey=1293325&pubCellSyskey=149040&pubO... 7/6/2010
Document ID: 1415982 Page 1 of 1

2008 Chevrolet Aveo | Aveo, Wave, G3, Barina (VIN S/T) Service Manual | Safety and Security | Theft Deterrent |
Repair Instructions | Document ID: 1415982

Programming Theft Deterrent System Components

(Tech 2)
Important: To confirm if the vehicle has an immobilzer system, please check the vehicle SPID
label or the VIN in GMVIS for the presence of RPO BAH (engine immobilizer).

Important: Turn ON the ignition before installing in the scan tool. Failure to connect in this
procedure may cause communication errors and the programming procedure will not complete.
Any keys that are not programmed at this time will no longer function.

Important: Try to obtain all the keys. At least 2 keys are necessary to successfully program the
immobilizer system.

A maximum of 5 keys may be programmed.

Conditions

Use these procedures after replacing:

• Theft deterrent control module (Immobilizer)

• Engine control module (ECM)
• Any key

Immobilizer Programming Procedure

1. Turn the ignition switch to the ON position.

2. Install the scan tool.
3. Select IMMOBILIZER PROGRAMMING FUNCTION from the BODY menu.
4. Follow the scan tool instructions with each key until all keys are programmed.
5. Turn the ignition to the LOCK position, disconnect the scan tool and test all the keys.
6. If any key does not function, perform this procedure again with all keys.
7. If any key does not accept the programming, replace it with a new key and perform this
procedure again with all the keys.

© 2010 General Motors Corporation. All rights reserved.

http://localhost:9001/si/showDoc.do?docSyskey=1415982&pubCellSyskey=150468&pubO... 7/6/2010