Parts Catalog

(2SA
GENERATOR SETS

Printed U.S.A. 934-0257 (Spec A, B) 6-93

Replaces (Spec A) 4-92
 Introduction

This catalog applies to the standard QSA Generator Sets as listed in the Generator

Set Data Table. Parts are srr=ma~I+ in -FnL~ns of related items and each illustrated
. ,.,, part is identified by a refere;;;-;umbe; ;;;respond ing to the same reference number
in the parts list. Parts illustrations are typical. Unless otherwise mentioned in
the description, parts are interchangeable between models. Throughout this catalog
left and right sides are daterisined by faci~g the air inlet guard of the housing or
engine end (front) of the set.

Engine parts that have been modified or added by Onan are identified in this catalog.
All other engine replacement parts must be ordered from the engine manufacturer by
referring to the engine manufacturers nameplate and supplying all available infor-
mation. Contact your nearest engine parts dealer for assistance in ordering reP~ace-
ment parts.

Replacomont Engine

Onan Cummin8
Part Number Mode 1

14QSA3 *1OO-2936 3A1.T

20QSA4 *~~0-2937 4A2.3
28QSM *~~0-2938 6A3.4

* Replacement engines cannot be ordered from Onan.

Order from your nearest Cummins distributor and
reference the above Onan part number.

13enerator Set Data Table

, -.

MOOEL AND ELECTRICAL DATA 1 ~ATIERY

SPECIFICATION s Vms RE PHASk VOLTAQE

14QSA3/* 14,000 # 60 12 lor3 12 Voc

20QSA4/* 20,000 # 60 12 lor3 12 VDC

28QSA6/* 28,000 # 60 12 lor3 12 VDC

* - The diagonal line (/) in the model and specification number separates
generator set characteristics from the specification number and
letter. The specification number denotes customer requested options
or deviations from a standa~d (36293A) model. The specification
letter advances (A to B, B to C, etc.) with major manufacturing changes.
#- Broad range reconnectable.

R
Actuator, 8rake 4 Fan, Cooling 25
Actuator, Governor 14 Fan, Generator 32 ,.,)-, .,

Adapter , Generator I@ Fender 4

Alarm , Low Fuel 15 Flywheel 26 ..*

Ammeter - AC 3$ Foam, Air Inlet - Fan 25

Arm, Governor 14 Foam, Air Inlet and Outlet - Housing 28
Axle, Trailer 4 Foam, Wrap - Air Inlet Cone 2S
Foot, Skid 18
Baffle, Air - Generator 32 Fuse, Engine Monitor 34
Baffle, Air - Housing 28
Band, Mounting - Air Cleaner 10 Gasket , Exhaust Elbow 24
Bar, Bue - Receptacle Panel 30 Gauge, Liquid Level - Fuel Tank 20
Bar, Lifting - Generator Set 20 Gauge, Oil Pressure 37
Bearing, Ball - Generator 32 Gauge, Oil Temperature 37
Bell, End 32 Gauge, Water Temperature 37
Block, Terminal - Generator Set Gear, Ring 16
Control 34 Generator 32
Block, Terminal - Receptacle Panel 30 Governor, Electronic 14
Board, PC - Day Tank 22 Guard, Air Inlet - Fan 25
Board, PC - Time Delay 34 Guard, Fan - Generator 32
Board. Voltage Regulator 34 Guard, Radiator 28
Box, Air Inlet 25
Box, Control - Day Tank 22 Harness, Wiring - AC Control Door 34
Box, Control - Generator Sat 34 Harness, Wiring - DC Control Door 34
Box, ::;;:;:g - AC Circuit Breaker 17 Harness, Wiring - Control Heater 42
Box , 24 Harneas, Wiring - Day Tank 22
Bracket, Controller 14 Harness, Wiring - Day Tank Control
Breaker, Circuit - AC - Control 36 Transformer 22
Breaker, Circuit - AC - Rear Panel 17 Harness, Wiring - Engine to Control 34
Breaker, Circuit - AC - Receptacle Harness, Wiring - Low Coolant Level
Panel 30 Sender 11
Breaker, Circuit - Day Tank 22 Harness, Wiring - Receptacle Panel 30
Harness, Wiring - Time Delay 34
Cable, Battery 8 Harness, Wiring - Wattmeter 40
Cmhlm
,v , Ragnetic Pickup 14 Heater , Control 42
Cap, Fan Retainer 2S Heater , Coolant - Cylinder Block 12 ,.
Cap, Fuel 20 Heater, Engine Tank 13
Cap, Radiator 26 Hitch 4
Cap, Rain 24 Hold-down, Battery 18
Catch, Door - Housing 28 Hold-down, Radiator 26
Chain, Safety 4 Hook , Clevis 4
Clamp, J - Engine Wiring Harneas 8 Hose, Air Cleaner 10
Clamp, Muffler 24 Hose, Brake 7
Clamp, Tube 7 Hose, Coolant Drain - Cylinder Block
Cleaner, Air 10 Hose, Overflow - Radiator 26
Clip, Brake Lins 7 Hose, Radiator - Flexible 26
Cone, Air Inlet - Fan 2S Housing, Generator Set 2$
Control , Day Tank 22 Housing, Trailer Light 4
Control, Generator Set 34
Control, Governor 14 Indicator, Service - Air Cleaner 10
Coupler, Fuel Pump Motor - Day Tank 22 Indicator, Timing 16
Cover, Box - Circuit Breaker 17 Insulation, Muffler Box 24
Cover , Control - Day Tank 22 Insulator, Vibration - Generator Set 18
Cover, Load Terminal 30 Isolator, Cooling Fan 2S
Cover , Selector Switch 30 Isolator. Vibration - Generator Set
Cover , Terminal Block 30 Control 34

Dial, Wattmeter 40 Jack, Screw 4

Diode, Control Hecter 42
Disk, Drive - Generator 32 Kit, Coolant Heater - Cylinder Block 12
Door , Generator Control - AC 36 Kit, Repair - Fuel Pump Motor - Day
Door, Generator Control - DC 37 Tank 22
Door , Housing 28 Kit, Taillight 7
t)raincock - Cylinder Block 8 Kit, Throttle 14
Duct, Air - Skid 18 Knob, Rotary Switch 36

Elbow, Exhaust 24
Element, Air Cleaner 10
Eyebolt, Lifting 28

2
Latch, Door - Housing 28 Tachometer 38
Light, Indicator - DC Control Door 37 Tank, Fuel/Oay 20
Light, Indicator - Day Tank 22 Tank, Overflow 26
Light. Indicator - Upper/Lower Taa
.--, Brake Line 7
Scale 36 Terminal Assembly - Ground 8
Light, Panel - OC Control Ooor 37 Thermostat , Control Heater 42
Line, 8rake 7 Thermostat, Coolant Heater 12
Line, Fuel 20 Tire, Trailer 4
Lug, Solderless - Set Grounding 18 Tongue, Hitch 4
Trailer 4
?4eter, Frequency 36 Transducer, Watts 40
Meter, Time Total izing 3? Transformer - Oay Tank 22
Monitor, Engine 34 Transformer, Current 43
Mount, Shock - Watts Transducer 40 Transformer, Voltage - Receptacle
Muffler, Exhaust 24 Panel 30
Tray, Battery 18
Paint 43 Tube, Radiator Inlet 26
Pan, Skid 20 Tube, Radiator Outlet 26
Panel , Housing 20
Panel , Radiator Support 28 Voltmeter - AC 36
Panel, Rear - AC Circuit Breaker 17 Voltmeter - OC 37
Panel , Receptacle 30
Panel , Terminal 30 Wattmeter 40
Pipe, Exhaust 24 Wheel , Trailer 4
Pipe, Suet ion - Fuel Tank 20
Point, Contact - Overspeed 32
Potentiometer 36
Pump - Oay Tank 22

Radiator 26
Rail, Mounting - Terminal Block 30
Receptacle 30
Rectifier, Generator Rotor 32
Relay, Pump - Oay Tank 22
Relay, Run 39
Relay. Start Solenoid 8
Resietor - Oil and Water Temperature
Gauges 37
Resistor, Voltage Regulator 34
Retainer, Fan 2S
Rod, Governor 14
Rotor, Exciter 32
Rotor, Generator 32

Seal, Fan 25
Sender. Low Coolant Level 11
Sender, Oil Pressure 8
Sender , Water Temperature 8
Sensor, Speed 14
Shield, Heat 12
Skid, Generator Set 18
Spacer, Fan 2S
Stator, Exciter 32
Stator. Generator 32
Strap, Fuel Tank 20
Strap, Ground - Engine 8
Strap, Ground - Generator Set
Control 34
Strip, Marker 34
Switch, Basin 15
Switch, Emergency Stop 37
Switch, Generator Reconnection 30
Switch, Liquid Level - Oay Tank 22
Switch, Oil Pressure 8
Switch, Overspeed 32
Switch, Rocker - OC Control Ooor 37
Switch, Rocker - Day Tank 22
Switch, Rotary 36
Switch, Thermostat 8
trailer

,,

16
 REF PART QTY REF PART PART
NR. E@. NO. no. DESCRIPTION

1 Actuator - Surge Brake 11 862-0003 Nut, Hex (3/8-16)

410-1035 1 3 Lunette Eye 12 410-1052 Tongue, Hitch
410-1036 1 Ball, 2 D~a 13 410-1033 ~ack, Scrau
2 800-0103 7 Screw, Hex Heed 14 410-1050 Hitch Assembly
[1/2-13 x 4-1/4) 15 800-0092 Screw, Hex Head
3 526-0219 31 Waaher, Flat (1/2) (1/2-l3x 1-1/2)
4 850-0060 27 Waeher, Lock (1/2) 16 410-1110 Tire &Wheel Assembly
5 862-0016 7 Nut, Hex [1/2-13] Tire - G78-14ST
6 880-0443 2 Chain, Safety wheel 14 x5.5, 5Bolt
7 880-0444 2 Hook, Clevis Slip 17 410-1062-01 Axie Aseambly
8 800-0052 2 Screw, Hex Head 18 410-1048 Fender, LH
:3;8-16 x 1-1/2) 19 410-1049 Fender, RH
9 526-0030 2 Waeher, Flat (3/8) 20 410-1047 Houeing, Light
10 850-0050 2 Washer, Lock (3/8) 21 98-6409 Label, Warning

,.

5
,

2
./?

*
 Traflw Brakes & Lights

I
I
1
I
I
16 I
I i

-s

-----=-D=
I
12

REF PART QTY PART REF PART QTY PART

W. NO. WED DE8(XIPTION No. MD. U8ED 0E8CIUPTION

1 501-0564 3 Hose Assembly - Brake 17 322-0413 1 Kit, Taillight (Includes

.
2 410-1063 3 Clip, Brake Line License Plate BrackaL, 4
3 518-0599 5 Clamp, Tube Trunk Cable, 25 Wishbone
4 815-0261 5 Screw, Hex Washer Head Cable, Bolts, Nuts, Lock-
Thread Form washers, Wire Clips, Wire
L\:(4;+0k: 1/2) Nuts, Wire Tap Connectors
5 121-0090 1 # and Parts Marked *)
6 121-0088 1 Line, Brake 322-0427-01 2 *Light, Marker (Amber -
7 121-00B7 1 Line, Brake Includes Lens)
8 410-1064 1 Tee, Brake Line 322-0427-03 1 *Tailligt?t - Right Side
9 800-0024 1 Screw, Hex Head (Includes Lens)
(5/16-l8x 1/2) 322-0427-04 1 *Taillight - Left Side
10 850-0045 1 Washer, Lock (5/16) (Includes, Lens)
12 508-0298 4 Grommet l/4ID 322-0427-02 2 Lens - Marker Light (Amber)
13 518-0600 1 Clamp, Tube 322-0427-05 2 Lens Set - Taillight (Red)
15 898-0016 1 Sleeving, 5Lg
16 856-0006 3 Lockwasher
* - Parts Included in 322-0413 Taillight Kit

1
External Engirm Parts

-w [ &4mTilI

\ \

$
 Ext@rnal Engine Parts

REF Pml QTY PART REF PART (JTY

rm. w. DE8fXtIPTIOR iio. %0. DE8CiTPhlw

1 clq, J 21 505-0104 1 Nipple, Pipa (1/8 x 1-1/2)

332-2634 14QSA 14QSA
332-2634 : 20QSA, 28QSA 22 502-0079 1 Tee, Union - 14QSA
2 502-0029 1 Adapter, Reducing 23 502-0057 1 Tea, Male 8ranch - 14QSA
(1/4 to 1/8) 24 502-0028 1 Plug, Hex (1/8) 14QSA
3 502-1103 1 Oraincock 25 193-0318 1 Sender, Water Temperature (E2
4 503-0276 Hoee. Drain - Bulk (5/16 ID) 26 309-0437 1 Switch, Thermostat - High
(Order by the foot - Engine Coolant Temperature
3 required) (S2) (Opens at 202F. -
5 .309-02?2 1 Switch, 0!? Pressure (S5 - Closes at 222F.)
Pre-Alarm) Closes at 20 lbs. 27 309-0436 1 Switch, Thermostat - High
Descending Engine Coolant Temperature
6 307-1031 1 Relay, Start Solenoid (K4) (S6 - Pre-Alarm) (Opens at
7 337-1837 1 S?rap, Ground 196*F. - Closes at 216F.)
8 815-0290 2 Screw, Thread Forming - Hex 28 332-1292 1 Terminal Assembly (Includes
Washer Head (1/4-20 x 5/8) Parts Marked *) (T26)
9 800-0051 1 Screw, Cap - Hex Head 29 809-0036 1 *Straw, Sheet Metal - Round
w:3;16L:c:-1/4 ) Head ($8 x 7/8)
10 - EIT (3/8) 30 508-0015 1 %asher, Fiber
11 ; Waaher: Lock - Spring (3/8) 31 870-0196 *Nut. Insulation
12 1 Nut, Hex (3/8) 32 332-1281 : *Bracket, Terminal
13 1 Cable, Battery (24) 14QSA, 33 193-0244 1 Sender, Oil Pressure (El)
20QSA 20QSA. 28QSA
416-0530 Cable, 8attery - 16 34 309-0561 1 Switch, Oil Pressure (S1)
416-0921-01 1 Cable, Battery (24) 28QSA Closes at 14 Ibs. Cesceiiding
800-2110 1 Straw, CaD - Hex Head - 20QSA, 28QSA
(M12 X 2ti) 28QSA 35 505-0059 1 Tee, Pipe (1/8) 20QSA, 28QSA
17 866-0013 2 Washer, Lock - EIT (1/2) 36 505-0098 1 Nipple, Pipa (1/8 x 3/4)
28QSA 20QSA, 28QSA
1 Sender, Oil Pressure (El) 37 503-0731 1 Clasp, Hose
14QSA
19 309-0561 1 Switch, Oil Pressure (S1)
closes at 14 lbs. Oascending * - Parts Included in 332-1292 Terminal Assembly.
- 14QSA
20 502-0053 1 Elbow, Street - 45 (1/8)
14QSA

,,, ~
 Air Cleaner

1,
-%=__..
-..
w -_--=

12 Lv)- 873C
Y

PART QTY PART REF PART QTY PART

REF
USED DESCRIPTION No. No. USED OESCRIPTIffl
No. No.

1 140-1869 1 Cleaner, Air (Includes 7 503-1222 1 Elbow - 90

Element) 8 140-2227 2 Band, Mounting
2 140-1204 1 Element 9 800-0026 4 Screw, Cap - Hex Head
Hose, Air Inlet (5/16-18 x 3/4)
3
503-1?40-01 1 33-1/2 - 14QSA 10 503-1736 1 Clamp, Support
503-1740-02 1 35-1/2 - 20QSA 11 821-0005 1 Screw, Cap - Hex Locking Head
503-1740-03 1 37-1/2 - 28QSA (#lo-32 x 1)
4 140-2524 1 Tube, Air Inlet 12 870-0257 4 Nut, Self Locking (Flange)
4 Clamp, Hose (5/16-18)
5 503-0354
6 140-1791 1 Indicator, Service

10
 Low Coolant Level Sender

861A

PhRT REF PA$T QTV PART

REF PhRT QTY
,. WSCRIPTICN No. m. USED lXSCRXPTI~
Uo. m.

1 193-0322
-. 1 Sender, Low Coolant Level
(s7)
2 338-2552 1 Harness, Wiring (Includes
Housing)
4 526-0028 5 Shim

11
 !Eogine Coolant Heater

890A

REF PART QTY PART REF PART QTY PART

NO. No. USED CHCRIPTI@l No. NO. USED DESCRIPTIOl

3 Thermostat t
1 Kit, Heater - Engine Coolant
(750W) (Includes Parts 333-0292-01 1 120 Volt. AC
Listed Below) 333-0292-02 1 240 Volt AC
333-0386 1 120 Volt AC 4 155-2353 1 Shield, Heat
333-0387 1 240 Volt AC 5 503-0183 1 C1amp
2 Heater, Engine Coolant (750W)
333-0291-01 1 120 Volt AC
333-0291-02 1 240 Volt AC

12
 Engine Tank Heater

872A

REF PART QTY PART REF PART QTY PART

No. No. USED DESCRIPTION NO. NO. USED DESCRIPTION

1 503-0183 4 Clamp, Hose 8 870-0257 1 Nut, Self-Locking - }{ex Washer

2 Hose, Flexible Head (5/16-18)
503-1429-02 1 14QSA, 20QSA (5/8 10 X 17) 9 Heater, Engine (includes
503-1429-01 1 28QSA (5/8 ID X 20) Barbed Hose Fittings)
,,,. 3 505-0020 1 Bushing, Reducer (3/4 to 1/4) 333-0203 14QSA, 20QSA (850 Watt, 120V)
f,,
4 505-0011 1 Elbow, Street (1/4) 333-0204 ; 28QSA (1500 Wart, 120V)
~,t,. 5 503-1429-05 1 Hose, Flexible (5/8 10 x 36) 10 856-0006 1 Washer, Lock - EIT (1/4)
6 130-0755 1 Bracket, Mounting
7 821-0016 1 Screw, Self-Locking - Hex
Washer Head (5/16-18 x 3/4)

13
 El*ctronlc Qov8rnor

REF PART QTY PART REF PART QTY PART

m. No. USED 0E8CRIPTIU NO. No. U8Eo OESCRIPTI(M

1 151-0566 1 Actuator, Governor 11 151-0565 1 Control, Governor (Includes

4 Screw, Cap - Hex Head Jumper) (A12) ,
2 8000006
(1/4-20 X 7/8) 12 813-0103 4 Screw, Machine - Round Head
3 850-0040 4 Washer, Lock - Spring ( 1/4) (#10-32 X 3/4)
4 150-1996 1 Bracket, Mounting 13 850-0030 4 Washer, Lock - Spring (#10)
5 151-0567 1 Arm, Governor (Includes 14 870-0065 1 Nut, Self-Locking (1/4-20)
Screw and Nut) 15 147-0779 1 Sleeve, Throttle Stop
6 150-1923 1 R~d, Governor Control 16 130-1107 2
7 800-2071 4 Screw, Cap - Hex Head 17 338-1765-04 1 ;%% Magnetic Pickup (60)
(M6 x 9omm) 18 151-0603-02 1 Sensor, Magnetic Speed
8 870-0131 2 Nut, Hex - With ET (#10-32) 19 800-0007 1 Screw, Cap - Hex Head
9 150-0939 2 Joint, Ball (1/4-20 X 1)

10 151-0437 1 Kit, Throttle Modification

(Fuel in~ection Pump)

14
 Low Fuel Alarm

/3
e

REF PART QTY PART REF PART QTY PART

ND. ND. USED DESCRIPTIOl ND. ND. USED DESCRIPTI~

1 505-0136 1 Pipe, Nipple (1/8) 3 S05-0026 1 Coupling

Used on Fuel Tank 4 505-1478 1 Plug, Pipe-Square Head (Use
(25 & 40 Gallons) Sealant 524-0109 to Seal
2 308-0963-01 1 Switch, 8asin Hole Around Wire in Plug) -
. ,,,
,.
!
,. ,,-
 ~enerator Adapter

32A

REF PART QTY PART

No. ND. USED DESCRIPTION

1 231-0267 1 Adapter Assembly, Generator

(Includes Timing Indicator)
2 160-1292 1 Indicator, Timing

Flywheel ,.,
4

.,

REF PART QTY PART

NO. NO. USED DESCRIPTION

1 Flywheel Assembly (Includes

Ring Gear and Alignment Pin) %,
1$
104-1659 1 14CjSA I F
i!.,,,,,.
::I,J
104-1462 1 20QSA, 28QSA
2 104-1690 Pin, Alignment
3 104-1678 1 Gear, Ring
 Rear Panel
8

9
\

/
4 12

A.
1
/
s
\ o /
. *\

b.
\
\
\
2

883C
3

REF PART PART REF PART QTY Mm

ND. MD. DESCRIPTION w. ND. USED Di%CRWTION

1 Panel, Rear 5 128-0129 1 Foam

319-0868 Without Circuit Breaker 6 301-9668 1 Box. Circuit Breaker
Open i ng 7 301-9669 Pan~l, Box
319-0930 With Circuit Breaker Opening 8 821-0010 1: Screw, Cap - Hex Locking Head
2 Tape, Sealing - Bulk (Order (1/4-20 X 1/21})

by the foot) 9 Breaker, Circuit

895-0308 1/8 Thk x 1 Wide - 9 320-1511-12 1 2 Pole - 80 Amp, 240 Volt
required 320-1458-12 1 3 Pole - 80 Amp, 240 Volt
895-0170 3/8 Thk x 3/4 Wide - 3 10 301-9682 1 Cover
required 11 812-0094 4 Screw, Machine - Round Head
,,,

1, 3 821-0018 Screw, Cap -- Hex Locking Head (#8-32 X 3-1/2)

(1/4-20 X 5/8) 12 526-0048 4 Washer, Flat (#8)

,. ,i, 4 Bracket, Box Mounting 13 850-0025 4 Washer, Lock - Spring (#8)
319-0973 Left Side 14 508-0305-02 1 Edging
319-0974 Right Side
Skid

16 Y

E 19

21

L 17

,,,

i
I
,,,/

30
31 \

18
 Skid

REF PART QTY PART REF PART QTY PART

No. w. USED DESCRIPTION No. No. USED DESCRIPTION

. Skid 17 800-OICO ~ #Screw, Cap - Hex Head (1/2-13

403-3001 1 14QSA ;. 3-1/2) Generator End
403-3006 1 20QSA 18 403-3041 2 #Spncer, Mount - Generator End
403--3013 1 28QSA 19 402-0639 1 #Insulator, Vibration - Engine
2 Duct, Air End
405-4260 1 14QSA 20 402-0637 2 81nsulator, Vibration -
405-4266 1 20QSA Generator End
405-4265 1 28QSA 21 403-3004 1 #Spacer (2 00) Engine End
3 416-0959 1 Tray, Battery 22 403-3005 2 #Spacer (3 00) Generator- End
4 821-0030 4 Screw, Cap - Hex Locking Head 23 403-3062 4 Foot, Skid
(3/8-16 X 1) 24 300-0091 8 Screw, Cap - Hex Head
5 816-0099 1 Bolt, Carriaae (5/16-18 x 3/4) (1/2-20 x 1-1/4)
6 870--0281 2 Nut, Self Locking- Hex 25 416-0896 2 Hold--down, 8attery
Flange (3/8-16) 26 416-0963-01 1 Hold-down, Battery
7 815-0290 4 Screw, Thread Forming - Hex 27 862-0001 2 Nut, kif?x (1/4-20)
Washer Head (1/4-20 x 5/8) 28 850-0040 2 Washer, Lock - Spring (5/16)
8 *Screw, Cap - Hex Head 29 526-0015 2 Washer, Flat (1/4)
800-CJC96 1 Engine End (1/2-13 x 2-1/2) 30 800-0030 1 Screw, Cap - Hex Head
800-0102 2 Generator End (1/2-13 x 4) (5/16-18x 1-1/4)
9 *[nsulator, Vibration 31 332-1473 1 Lug, Solderless - Generator
402-0635 1 Engine End Set Grounding
402-0636 2 Generator End 32 856-0008 2 Washer, Lock - EIT (5/16)
10 403-3042-01 3 *#Washer, Retainer (2-3/4 00) 33 850-0045 1 Washer, Lock - Sprirlg (5/16)
12 870-0490 3 *#Nut, Locking - Hex (1/2-13) 34 862-0015 1 Nut, Hex (5/16-18)
12
13 800-0026 *Screw, Cap Hex Head 35 870-0257 i Nut, Self Locking
(5/16-18 X 3/4)

14 850-0045 12 *Washer, Lock - Spring (5/16)

15 862-0015 12 *Nut, Hex (5/16-18) * - Mounting Hardware for 14QSA
16 800-G095 1 #Screw, Cap - Hex Head # - Mounting Hardware for 20QSA and 28QSA
(1/2-13 x 2-1/2) Engine End

I
Fuel Tank

876C

20
 Fuel Tank

REF PART CJTY PAK I REF PART QTY PART

m. NO. USEO lUWTDTT#lhl
--.&r 1 *- m. NO. W&D DESCRIPTION

1 8?0-0257 4 Nut, Self-Locking - Hex 11 502-0003 1 Connector, Inverted Male

Flange (5/16-18) 12 502-0020 1 Elbow, Street - 90 (1/8)
2 800-00$1 4 SCF%W, Gap - Hex Head 13 502-0054 2 Elbow, Street - 90 (1/~1
(1/2-13 X 1-1/4) 14 505-0018 1 Bushing, Reducer
3 159-1264 2 Strap, Fuel Tank (1/2 to 1/4)
4 1S9-1208 1 Cap, Fuel Tank 15 505-0172 1 Nipple, Close (2)
s Tank, Fuel 16 821-0018 28 Screw, Self-Locking - Hex
159-1241 1 14QSA, 20QSA (25 Gallon) Washer Head (1/4-20 x 5/8)
159-1242 1 28QSA (40 Gallon) 17 332-2634 Clamp, J
6 Pan, !%id 18 800-0026 Screw. Cap - Hex head
405--4185 1 14QSA (5/16-18 X 3/4)

405-4262 1 20QSA 19 862-0002 1 Nut, Hex (5/16-18)

405-4259 1 28QSA 20 850-0045 1 Washer, Lock - Spring (5/16)
1 415-0565-11 1 Gauge, Liquid Level 21 526-0022 1
. Washer, Flat (5/16)
8 415-0566-11 ?
. Pipe, Suet ion 22 526-0219 4 Washer, Flat (1/2)
9 501-0441 1 Line, Fuel - Flexible
(1/4 ID X 40)
Tank to Fuel Pump
Line, Fuel - Flexible
(3/16 ID) Nozzle Leak Off
To Tank
501-0094-02 14QSA (40)
501-0094-01 : 20QSA (50)
501-0094 1 28QSA (60)
 -,<,
i
&
., ,,+

22
 REF PART PART REF PART QTY PRftT
NO. ND. DESCRIPTION m. NO. WED DESCRIPTION

1 319-0486 130x: Control 20 B70-0221 4 Nut, Hex - With ET (#8-32)

2 319-0485 Cover, Control Box 21 526-0003 4 Washer, Flat (#8)
3 307-2677-02 %1 ay - Pump (K130) 22 308-0913-04 1 Switch - 5 Float
4 322-0403-02 Light Assembly, Indicator - 23 505-0025 1 Reducer, Pipe (1-1/2 to 1-1/4)
Seven Light (Includes Wiring 24 370-4066 4 Spacer, Control Mounting
Harness) 25 800-0010 4 Screw, Cap - Hex Head
5 322-0369-02 Lamp, Indicator - Replacement (1/4-20 x 1-1/2)
6 308-0912 Switch, Rocker - On/Off/ 26 850-0040 4 Washer, Lock - Spring (1/4)
Emergency Run (S102) 27 399-0117 1 Pump (P1O:3)
7 308-0739 Switch, ,.,.
Rocker - ~~=+l%eset 28 800-0028 4 Screw, Cap - Hex Head
(s111) (5/16-18 X i)
8 320-16!53 Breaker, Circuit - DC (CB107) 29 526-0022 4 Washer, Flat (5/16)
9 320-1654 Breaker, Circuit - AC (CB101) 30 850-0045 4 Washer, Lock - Spring (5/16)
10 300-3464 tifi..A
--- , Printed Circuit 31 862-0015 4 Nut, Hex (5/16)
11 870-0458 Spacer - Printed Circuit Board 32 338-2567 1 Harness, Wiring (Pump to
12 338-2382 Harness, Wiring - Control Box Control Box Printed Circuit
13 815-0350 Screw, Self-Tapping - Slotted Board TB1)
Hex Washer Head 33 502-0942 2 Elbow, Hose - Beaded - 90
(#10-32 X 3/8) 34 503-0183 2 Clamp, Hose
14 812-0075 Screw, Machine - Round Head 35 503-1660-02 1 Hose, Fuel (5/8 ID x 20)
(#8-32 X 1/4) 36 399-0122 1 Coupler (Drive Piece Between
15 815-03S5 Screw, Machine - Round Head Motor and Pump)
(#6-32 X 1/2) 37 399-0121 1 Kit, Repair - Pump (Includes
16 332-2605 Jumper, Terminal Lip Seal, Bearing, Gasket,
17 331-0027 Connector, Romex Drive Gear, Idle Gear and
18 331-0042 Connector, Knockout Coupler]
19 315-0686 Transformer (Does Not Include
Primary and Secondary
Harnesses) (T105)
338-2403 Harness, Wiring - Primary
(10) T105H1, H4 to TB1-5,
TB1-9)
338-2404 Harness, Wiring - Secondary
(6] (T105X1, X2 toP4)
323-1302 Pin, Contact
323-1374-04 Housing, Connector
(4 Place) (P4)

II,

,,

23
 Muffler

\,5

QTY PART REF PART QTY PART

REF PART
WED DE8CRIPTI~ m. No. WED 0E60RIPTI~
m. m.

Pipe, Exhaust. 9 Cap, Rain

1 155-2468 .
Elbow, Exhaust 155-2559 1 14QSA,20QSA - Modified
2
14QSA 155-2062-07 1 28QSA
155-2466
155-2463 2QQSA 800-0100 1 Screw, Hex Head (1/2-13 x 3.5
28QSA 862-0016 1 Nut, Hex (1/2-13)
155-2469
3 155-2515 Gasket 526-0219 6 Washer, Flat (1/2)
4 800-2085 Screw, Cap - Hex Head 155-2459 1 Insulation - Top
(M12 x 2olwn) 15!5-2460 1 Insulation - Bottom
5 850-2010 2 !%eher, Lock - Spring {M12) 155-2461 2 Insulation - End
6 821-0021 4 Screw, Self-Locking - Hex 870-0462 37 Nut, Push On
155..~376-ol ,.,,
Flange Head (5/16-18 x 1) 1 Muffler
4 Nut. Self-Locking - Hex 405-4268 1 Box, Muffler :!
7 870-0048
155-2548 2 Clamp, Muffler ~,.,,,,,,
Li
Head (5/16-18)

24
 Fan

12 1
15
10

,13 I
b

875C
18

REF PART QIY PART REF PART QTY PART

No. m. WED tJE8CRIPTI~ No. No. USED DE8CRXPTKM

1 Spacer, Fan 11 130-3638 1 Seal, Fan (Fore)

1 130-3604
1 Spacer, Fan Backing 12 128-0123 Foan, Cone Wrap
2 130-3618
2 Isolator, Fan (Rubber) 13 821-0018 1: Screw, Self-Locking - Hex
3 130-3620
1 Fan Washer Head (1/4-20 x 5/8)
4 130-3416
1 Cap, Fan Retainer 14 128-0126 1 Foam, 80X - Front
5 130-3619
4 Screw, Cap - Hex Head 15 895-0308 Tape, Sealing - Bulk
6 718-1815
(MB x 150MM) (1/8 Thkx 1 Wide) (Order
7 850-2008 4 Washer, Lock - Spring (M8) by the foot - 6 Required)
1 Cone, Air Inlet 16 128-0125 Foam, Box - Left Side
8 405-4195
2 Retainer, Cone 17 128-0124 Foan, BOX - Right Side
9 405-4261
10 130-3752 1 Guard, Air Inlet 18 405-4291 Box, Air Inlet
,, $,,
jr
i*,,
,,

25
 4 \
6
9

/
/
. /

17

t
878C

26
 Radfa~or

REF PART QTY PART REF PART QTY PART

ND. NO. USED DESCRIPTION NO. ND. USED DESCRIPTION

1 i30-3415 1 Radiator 14 503-1739 p Hose, Reducer

2 821-0018 10 Screw, Cap - Hex Locking Head 15 508-0021 1 Grommet. Rubber (3~4 Iiole)
(1/4-20 x 1) 16 508-0051 1
~ Grommet, Rubber (2- 1/3 Hole)
3 130-.3605 2 Hold-down, Radiator 17 130-3665 1 Tube, Radiator Inlet
4 895-01.82 Tape, Sealing - Bulk 18 5031733 1 Hose, Radiator - Flexible
(1/4 Thkx 3/4 Wide)
(Order by the foot - 9 19 NA~%~elf-l.ock ing (1/4-20)
required) 870-0212 1 E~rly Spec A (1/4-20)
5 130-3669 i Tube, Radiator Outlet 870-0257 4 Later Spec A (5/1618)
6 895-0170 Tape, Sealing - Bulk (3/8 20 Tank, Overflow
Thk x 3/4 Wide) (Order by 130-3671 1 Early Spec A
the foot 4 required) 130-3983 1 Later Spec A
1 503-0365 10 Clamp, Hose 21 821-0005 1 Screw, Self-Locking - Hex
8 503-1732 1 Hose, Radiator - Flexible (11) Washer Head (#IO-32 x l)
9 130-3666 1 ltjbe, Radiator Inlet 22 503-1734 1 Clamp, Support
10 130-3670 1 Tube, Radiator Outlet 23 503-0980 2 Hose, Radiator (3) 14QSA
11 130-3929 1 Cap, Radiator 24 503-1737 2 Hose, Reducer - 20QSA, 28QSA
12 503-0731 2 Clamp, Hose 2s 502-0153 1 Pipe Plug - Hex (1/4 NPT)
13 503-0276 Hose, Overflow - Bulk 26 503-0429 2 Clamp, Hose
(5/16 IO) (Order by the
foot - 4 required)

27
Housing

44

20
 Housing

REF PART QTY Mm REF PART QTY PART

NO. No. USER lM==lPTT~
------- . --- m. /40. 0E8CRIPTMN
1 Panel, Top 19 405-4175 2 Catch, Access Door
405-4343 1 14QSA, 20QSA 20 405-4240 1 Panel, Inner
405-4342 1 23QSA 21 405-4244 1 Panel, Front - Left
2 Screw, Locking - Hex Washer 22 405-4181 1 Panel, Front
Head (1/4-20 x 5/8) 23 405-4247 1 Panel, Front - Right
821-0018 61 14QSA, 20QSA 24 405-4172 1 Baffle - Air In
821-0018 63 28QSA 25 405-4173 1 Baffle - Air Out
3 Tape, Sealing - 8ulk (Order 26 405-4174 Panel, Front - Center
by the foot) 27 405-4250 ; Panel, Radiator Support
1.,/8 Thk x 1 Wide 28 870-0131 7 *Nut, Hex - Locking Head
895-0308 1.4QSA, 20QSA - 66 Required (#10-32)
895-0308 28QSA - %? Required 29 406-0700 3 Latch, Door
895-0172 11/16 Thk x 1-1/4 Wide 30 Screw, Cap - Hex Head
- 3 Required (3/8-16 x 1/2)
895-0170 3/8 Thk x 3/4 Wide - 800-0050 28 14QSA, 20QSA
12; Required 800-0050 28 28QSA
895-0182 1/4 Thk x 3/4 Wide - 31 Washer, Flat (3/8)
17 Required 526-2120 36 14QSA, 20QSA
4 130-3607 1 Guard, Radiator 526-2120 36 28QSA
5 232-3542 1 Eyebolt, Lifting 32 128-0121 1 Foam - Air Out
6 526-0081 1 Washer, Flat (1-1/64 ID x 33 850-0050 Washer, Lock - Spring (3/8]
1-5/8 OD X 1/8 Thk) 34 870-0212 1; Nut, Self-Locking - Hex
7 850-0109 1 Washer, Lack - Spring Flange Head (1/4-20)
(1-3/64 ID) 35 821-0018 103 Screw, Locking - Hex Washer
8 862-0018 1 Nut, Hex (#l-8) Head (1/4-20 x 5/8)
9 405-4263 1 Retainer, Top Panel Seal 36 815-0607 12 Screw, Machine - Round Head
10 Panel, Rear - Left (#10-32 X 1/2)
405-4249 1 14QSA, 20QSA 37 870-0235 12 Nut, Hex - With ET (#10-32)
405-4257 1 28QSA 38 815-0771 4 Screw, Machine - Flat Head
11 Panel, Rear - Right {1/4-20 X 1/2)
405-4248 14QSA, 20QSA 39 403-2965 1 Angle, Skid
~Q~=@& : 28QSA 40 128-0119 2 Seal, Foam
12 319-0811 1 Panel, Control Housing 41 128-0120 Foam - Air In
13 319-0812 1 Panel, Control Housing 42 862-0003 1; Nut, Hex (3/8-16)
14 405-4285 1 Door Assembly, Control 43 870-1063 1 Nut, Pal
(Includes Parts Marked *) 44 319-1320-01 1 Panel, Generator 28QSA
(Note: Single window door 45 128-0130 1 Foam, Acoustical
replaces door with two 46 405-4428 2 *Clamp, Control Door - Sides
47 405-4429 1 *clap, Control DOOr -
windows used during the
early portion of Spec A) 8ottom
15 405-4264 1 Catch, Control Door 48 319-1369 1 *Window, Control
16 405-4283 8ar, Lifting
17 405-4216 1: Shim
18 405-4579-01 2 Door, Access *- Parts Included in 405-4285 Control Door Assembly
 Receptacle panel
/z

20
 Receptacle Panel

REF PART QTY PART REF PhRT QTY PART

MO. !40. Uslm DESCRIPTION NO. No. WED DEsGRIPTNw

1 Tape, Sealing -- 8ulk (Order 22 812-0066 6 Screw, Machine - Round Pead

by the foot) (#6-32 X 3/4)
895-0308 1/8 Thk x 1 Wide - 9 23 323-0866 1 Receptacle (20 Amp - 125 Volt)
required (32)
895-0170 3/8 Thk x 3/4 Wide - 24 323-1104 1 Receptacle, Duplex (20 Amp -
3 required 125 Volt) (Jl)
2 821-0018 13 Scl-ew, cap - Hex Locking Head 25 517-0131 1 Plug, Hole - 14QSA
( 1/4-20 X 5/8) 26 319-0967 1 Bracket, Terminal
3 319-0936 1 Panel, Receptacle 27 319-0939 1 Panel, Terminal (T131)
4 319-0938 1 Cover, Terminal 810ck 28 800-0028 4 Screw, Cap - Hex Head
5 812-0082 16 Screw, Machine - Round l-lead (5/16-18 X 1 )
(#8-32 X 3/4) 29 854-0017 4 Washer, Lock - IT (.21)
853-0005 16 Washer, Lock - ET (#8) 30 526-0022 4 Washer, Flat (5/16)
319-0937 1 Cover, Selector Switch 31 862-0002 A Nut, Hex (5/16-18)
870-02?1 8 Nut, Hex - With ET (#8-32) 32 337-2463 4 Bar, 5US (TB~-LO,Ll,L~,L~)
319-0968 1 Cover, Load Terminal 33 815-0786 4 Screw, Cap - Hex Head
815-0162 3 Screw, Machine - Fillister (3/8-16 x 2)
Head (#10-32 x 1/2) 34 526-0026 12 Washer. Flat (3/8)
11 Breaker, Circuit - 6 Pole 35 850-0050 8 Washer, Lock - Spring (3/8)
(C131,2,3,7,8,9) 36 862-0003 8 Nut, Hex (3/8-16)
320-1675-02 1 14QSA (38 Amp) 37 332-3040 5 Block, Te~minal (Triple Block)
320-1675-03 20QSA (55 Amp) 14QSA. 20QSA (TE12-O Thru 14)
320-1675-04 i 28QSA (75 Amp) 38 332-3041 13 Block, Terminal (Single IIlock
12 812-0061 12 Screw, Machine - Round Head 28QSA (T82 - 1 Thru 13)
(#6-32 X 3/8) 39 Rail, Mounting - Terminal
13 853-0003 14 Washer, Lock - ET (#6) Block
14 8reaker. Circuit - 2 Pole 332-3043-01 1 14QSA, 20QSA (61/4)
(CB13) 332-3043-02 1 28QSA (8-1/8)
320-1676-01 1 14QSA (40 Amp) 40 406-0709 1 Hinge, Terminal Cover
320-1676-02 1 20QSA, 28QSA (50 Amp) 41 813-0103 5 Screw, Machine - Round Head
15 320-1674 1 Breaker, Circuit (Includes (#10-32 X 3/4)
Adapter Plate) - 1 Pole (CB15) 42 870-0131 5 Nut, Hex - With ET (#10-32)
16 320-0541 1 Breaker, Circuit (Includes 43 406-0710-02 1 Hinge, Switch Cover
.!; Mounting Hardware) (CB14) 44 Harness, wiring - Receptacle
20QSA, 28QSA Pane 1
17 320-0541 1 8reaker, Circuit (Includes 338-2566-02 1 14QSA
Mounting Hardware) (CB12) 338-2566-03 1 20QSA
18 Switch, GeneratUr Reconnection 338-2566-04 1 28QSA
(s1) 45 31.5-0431 1 Transformer, Voltage (1x1)
308-0933-02 14QSA 46 815-0418 1 Screw, Machine - Fill ister
308-0932-01 : 20QSA Head (#6-32 x 1/4)
308-0932-02 1 28QSA 47 800-0005 3 Screw, Cap - Hex Head
19 870-0183 4 Nut, Hex - With ET (#6-32) ( 1/4-20 X 3/4)
20 323-1471 1 Receptacle, Twist Lock (50 48 850-0040 3 Washer, Lock - Spring (1/4)
Amp - 120/250 Volt) (J4) 49 821-0008 4 Screw, Self Locking, Iiex
21 323--1.109 1 Receptacle (30 Amp - 125/250 (1/4-20 X 5/16)

Volt) (J3) 50 98-6361 1 Label, Danger

.,,
$

31
Generator

1 885A

32
 (N9nerator

REF PART PART REF PART QTY PART

No. NO. OESCRIPTIW No. m. WED DESCRIPTION
1 821-0005 Screw, Self-Lacking - Hex 22 234-0690 1 Guard, Fan - Lower
Washer Head 23 Stud
(#lo-32 x 1/2] 520-0986-01 4 11-1/2
2 850-0030 Washer, Lock - Spring (#IO) 520-0986-02 4 12-1/4
3 862-1001 Nut, Hex (1/4-20) 520-0986-03 4 13-1/2
4 853-0013 Washer, Lock - ET (1/4) 520-0986-04 4 15-1/8
5 870-0250 Nut, Insulating 520-0986-05 4 16-7/8
6 150-0723 Point, Contact 24 862-0011 4 Nut, Hex (3/8-16)
7 150-2453 Bracket, Mounting 25 850-0050 5 Washer, Lock - Spring (3/8 )
8 800-0048 Screw, Cap - Hex Head 26 800-2033 6 Screw, Cap - Hex Head
(3/8-16 x 3/4) (M6 X 16t01)
Stator, Generator (Includes 27 850-2006 6 Washer, Lock - Spring (M6)
Gronnnat ) 28 800-2029 8 Screw, Cap - Hex Head
14Q8h (Ma x 12k@l)
220-4259-01 Standard 29 526-0280 8 Washer, Flat {5/16)
220-4259-02 EXt~nded Stack 30 800-2085 8 Bolt, Hex Head (M1O x 20M4)
Environmentally 31 850-2010 8 Washer, Lock - Spring (M1O)
Protected 32 Rotor Assembly, Generator
220-4301-01 Standard (Includes Parts Marked *)
220-4301-02 Extended Stack 1-A
20QSA 201-3462-01 1 Standard
220-4259-02 Standard 201-3462-02 1 Extended Stack
220-4259-03 Extended Stack 20QSA
Environmental ly 201-3462-02 1 Standard
Protected 201-3462-03 1 Extended Stack
220-4301-02 Standard 28QSA
220-4301-03 Extended Stack 201-3462-04 1 Standard
220-4363-02 600 Volt 201-3462-05 1 Extended Stack
28Q8A 33 510-0112 1 *Bearing, Ball
220-4259-04 Standard 34 232-2921 1 *Disk, Drive
220-4259-05 Extended Stack 35 526-0249 8 *Washer, Flat - Special
220-4301-04 E,. ironmentally ( 15/32 ID X 100 X 1/8 Thk)
Protected 36 805-0025 8 *Bolt, Slotted - Hex Head -
150-0717 Switch, Overspeed Special (7/16-14 x 3/4)
211-0370 Bell, End 37 205-0145 1 *Fan, Generator
Stator, Exciter 38 201-2151 1 *Rotor Assembly, Exciter
220-2009 Standard ( Includes Parts Marked #)
220-4304 Environmentally Protected 39 358-0069 1 *#Rectifier Assembly - Positive
13 802-0038 Screw, Cap - Socket Head 40 853-0008 4 *#Washer, Lock - ET (#10)
(1/4-20x 1-1/2) 41 813-0100 4 *#Screw, Machine - Round Head
14 853-0013 Washer, Lock - ET (1/4) (#10-32 X 1/2)
15 815-0181 Screw, Cap - Hex Head - 42 358-0070 *#Rectifier Assembly - Negative
Thread Forming with ET 43 526-0008 1: *#Washer, Flat (#10)
Lockwasher (#10-32 x 1/2) 44 870-0131 8 *#Nut, Self-Locking - Hex With
16 509-0094 Seal, O-Ring ET Lockwasher (#10-32)
232-2418 Board, Terminal 45 508-1073 1 Grommet - Generator Stator
H 232-3038 Bracket, Terminal Board Leixis (2-3/4 Dia)
19 815-0194 Screw, Cap - Hex Head - Threa
Forming with ET Lockwasher
(#10-32 X 3/8) * - Parts Included in Generator Rotor Assembies
20 234-0688 Baffle, Air #- Parts Included in Exciter Rotor Assembly.
21 234-0689 Guard, Fan - Upper

33
Control

.,,,,

34
 Contfwl

REF PART QTY P4RT REF PhRT

--------
m. ND. Mxxmlrl &m RD. MO.
1 191-1541 ~ Spacer 30 Board, Printed Circuit - Time
2 821-0021 2 Screw, Self-Locking - Hex D;:::e:15)
Washer Head (5/16-18 x 1) 300-3344
3 821-0014 2 Screw, Self-Locking - Hex 300-2898 Start/Stop/Preheat
Washer Head (5/16-18 x 1/2) 300-2897 Start/Stop
4 508-1078 1 Grosmet (2 Hole) 31 338-1904 Harness, Wiring - Time Delay
5 301-8065 1 Box, Control Start/Stop (A15 to A1lTB1)
6 402-0527 4 Isolator, Vibration 32 332-2957 Terminal, Tab - Double
7 800-0045 4 Screw, Cap - Hex Head (AT15TBI-7)
(5/16-18x 3/8) 33 815-0544 Screw, Machine - Round Head -
850-0045 4 Washer, Lock - Spring (5/16:) Cross Recessed With IT
508-0001 1 Grommet (1-1/16 Hole) (#6-32 X 1/2)
406-0332 Receptacle, Fastener 34 301-8851 Bracket, Mounting
406-0333 ; Stud, Fastener 35 338-2277 ,He~aee~, #ir+n
406-0334 2 Washer, Stud Retainer (Includes Con~e~t% Housing
332-0052 2 Clip, Wire and Contact Pins) (W Ooor
870-0131 3 Nut, Hex -With ET (#10-32) Assambly to Engine Monitor)
871-001S 1 Nut, Hex (1/4-20) Grounding 36 323-1308 Housing, Connector - 12 Place
Stud (J4)
16 853-0013 1 Washer, Lock - ET {1/4) 37 323-1302 Pin, Contact
Grounding Stud 38 300-2809 Monitor, Engine (Includes
17 337-0049 1 Strap, Ground Fuses) (7 Light Control)
18 800-0024 1 Screw, Cap - Hex Head (All)
(5/16-18x 1/2) 39 Fuse
19 856-0008 Washer, Lock - EIT (5/16) 321-0270 20 Amp (Fl, F2)
20 821-0004 : Screw, Self-Locking - Hex 321-0231 15Amp (F3)
Washer Head (#10-32 x 5/16) 321-0094 5 Amp (F4, F5)
21 332-0607 1 Block, Terminal - 12 Place 40 - Door Assembly, Control - AC
(T821) (See Separate Page for
22 332-2723 1 Strip, Marker - 12 Place Components)
23 812-0065 2 Screw, Machine - Round Head 41 - Door Assembly, Control - DC
(#6-32 x5/8) (See Separate Page for
24 338-2278 1 Harness, Wiring - AC (Includes Componentaj
TB21 Terminal Block) (AC 42 Harness, Wiring - Engine to
Door Assembly to TB21 Control (Includes Grommet,
Terminal Block) Connector Housing and Socket
25 300-2880 1 Board, Voltage Regulator 338-2539 14QSA
( Includes Jumper) (VR21) 338-2540 20QSA
26 332-2605 1 Jumper, Terminal (VR21TBI-3 338-2541 28QSA
to -4) (Wl) 43 508-0258 Grommet (1-1/2 Hole)
27 350-1220 1 Resistor (VR21TB1-7 to -8) 44 Housing, Connector
(Controls Without Panel 323-1304 6 Place (J2)
Voltage Adjust) 323-1306 8 Place (Jl)
28 815-0544 4 Screw, Machine - Round Head - 45 323-1200 Socket, Female
Cross Receosed With IT
(#6-32 X l,C? )
29 815-0544 4 Screw, Machine - Round Head -
Cross Recessed With IT
(#6-32 X 1/2)

35
 AC Control l)oor Assembly

0
e

t? 2

o @

(?

3-

.
W36B

REF PART QTY PART FtEF PART QTY PART

DESCRXPTI~ .
ND. ND. USED DESCRIPTION NO. No. USED

1 Door, Control - AC 4 302-1968 1 Meter, Frequency (M23)

301-9054-03 Without Meters 5 320-1121 Breaker, Circuit (C821)
301-9054-02 : With Three Meters 6 322-0363 : Light, Indicator - Upper/
2 Voltmeter (M21) Lower Scale (0S21, DS22)
302-1148 1 0-300/600 7 303-0261 1 Potentiometer (f?21)
302-1753 1 0-750 8 308-0882 1 Switch, Rotary - Voltme~er/
3 Ammeter (M22) Ammeter (Knob Not Included)
302-1473 0-50/100 (s21)
302-1147 i 0-75/150 9 303-0032 1 Knob, Rotary Switch
302-1683 1 0-100/200

36
 DC Control Door Assembly

\.

\.

21

REF PART QTY PART REF PART QTY PART

No. MO. USED DESCRIPTION MO. No. U6E0 DESCRIPTI~

1 Door, Control - DC 10 302-1642 1 Voltmeter (M13)

301-9055-02 1 D~;~~With Three Gauge 11 302-0885 1 Meter, Time Total izing (M14)
12 308-0785 1 Switch, Rocker - Restart/
301-9055-01 1 Doors With Five Gauge Panel Light (S11]
Holes and Emsrgency 13 308-0784 1 Switch, Rocker - Run/Stop/
Stop Switch Hole Ramote (S12)
2 815-0385 4 Screw, Machine - Round Head 14 517-0131 1 Plug, Hole (3/8 Hole)
(#6-32 X 1/2) 15 193-0250 3 Resistor (Mounted on Oil
3 870-0183 4 Nut, Hex - With ET (#6-32) Pressure, Oil Temperature
4 Light Assembly, Indicator Gauges, and Water Tamperatur
(Includes Wiring Harness and Gauges (R11,R12,R13)
Connector Housing) (A12) 16 302-1723 Anmneter - Blank Scale
322-0358-02 1 2 Light Assembly 17 301-6257 : Switch - Blank
322-0360-02 12 Light Assembly 18 308-0853 1 Switch, Pushbutton - Emerqenc
5 322-0369-02 ; Light, Indicator - Replacement Stop (Includes Bulb) (S14)
6 322-0381 1 Light, Panel (DS1l) 19 322-0223 1 Bulb, Pushbutton Switch -
7 322-0017 1 Bulb, Panel Light - Replacement
Replacement 21 193-0435 1 Gauge, Oil Temperature
.,, 22 517-0138-08 1 Plug, Hole (2 Hole)
8 193-0352 1 Gauge, Oil Pressure (Mll)
1
,, 9 193-0351 1 Gauge, Water Teinperature (M12)
 Tachometer

\
\

Y
\

3 I

REF PART Q(JD PART

No. ND. DHORIPTN)N
1 302-18?3-01 1 Tachometer (0-4000 RPM) (M16)
2 301-6257 Blank, Switch
3 302-1723 ; Amater, Blank Scale
.
 Run Relay

/
/-
./-. 6
,. / ,. ./

\ .

3
/

577B

REF PART c& PART REF PART yYD PART

MO. W. DESCRIPTION NO. No. DE8CRIPTKN

1 307-1056 3 Relay, Run (Kll) 4 323-0804 3 Socket, Relay

2 815-0388 6 Screw, Pan Head - Cross 5 307-1987 6 Holddown, Re_lay
Recessed Thread 6 815-0544 3 Screw, Machine - Round Head
(#6-32 X 1/2) with IT Lock Washer
3 319-0447 1 Bracket, Mounting - Relay (#6-32 X 1/2)

39
 Uattmeter

,. 1

8/

46
 WwRtmeter

REF Mm QTV VART ~F PART QTV PART

MO. No. 0E8CRIPTIW m. m. U8m 0E30RXPTI(N
.
1 302-1722 1 Wattmeter (Dial Not Included) 5 301-6987 1 Bracket, Mounting
(?424) 6 402-0354 Mount, Shock
2 Dial, Wattmeter 7 856--0002 1: Washer, Lock - ET (#8)
302-1721-01 1 0-35 kw Rating 8 860-0008 8 Nut, Hex (#8-32)
302-1721-02 1 0-50 kw Ratina 9 821-0017 2 Screw, Locking - Hex Washer
3 Harness. Wiring-- Wattmeter Head (5/16-18 x 1/2)
338-2478 1 120/240 Volt, Single Phase 10 850-0045 2 Washer. Lock - Spring (5/16)
338-1936 1 Reconnectable WYE, Three 11 862-0014 2 Nut, Hex (5/16-18)
Phase 12 319-0030 1 Plate, Mounting
338-2479 1 120/240 Volt Delta, Three 13 813-0102 2 Screw, Machine - Round Head
Phase (#10-32 X 5/8)
4 Transducer, Watts (A21)
302-1833-01 1 2-1/2 Element, Three Phase,
Four Wire
302-1833-04 1 1-1/2 Element, Single Phase,
Three Wire
302-1833-05 1 2 Element, Three Phase,
Three Wire

4.,
 Control Heater

:.
Ii I

/-1 ~

i d (--l //

fq
J- I y

(~ I
--A..%@ @ I
G&
& \\. / ,12
.. , . ..
-----

-s

p>-----
-. ---- ,.,
------
---25-
.,-.
-----

4-?

-1

REF PART QTV PART REF PART QTY PART

Wo. ND. WED DESORIPTItM No. ND. USED DESCRIPTl~
. 2 Nut, Self-Lacking - Hex Head
1 Heater (HR1) 5 870-025?
333-0151 75 Watt, 120 Volt (5/16-18)
333-0378 : 150 Watt, 240 Volt 6 130-1107 2 Spacer
2 Harness, Wiring (Pi) 7 812-0070 2 Screw, Machine - Round Head
335-0161 1 120 Volt Heater (#6-32 X 1-1/4]
338-2181 1 240 Volt Heater - Includes 8 854-0006 4 Washer, Lock - IT (#6)
Diode (Three Prong Plug 9 860-0006 2 Nut, Hex (#6-32)
not Included) 10 870-0183 2 Nut, Hex - With ET (#6-32)
3 800-0034 2 Screw, Cap - Hex Head 11 301-1886 1 Cover
(5/16-18 X 2-1/4) 12 309-0128 Thermostat (S1)
4 526-0113 2 Washer. Flat (11/32 ID x 13 357-0013 : Diode (3 Amp, 400 Volt DC)
1 00 X 3/32 Thk)

42
 Current Transformer

REF PART QTY PART REF PART QTY PART

No. ND. USED DESCRIPTIffl No. ND. USED DESCRIPTION

1 Transformer, Current 4 870-0131 6 Nut, H@xW/ET (#10-32)

302-1868-02 3 Ratio 100/5 5 850-2010 2 Washer, Lock (M1O)
302-1868-04 3 Ratio 200/5 6 800-2085 2 Screw, Hex Head
2 302-1937 1 8racket, Mounting {M1OX 1.5x20j
3 821-0005 6 Screw, Round Head, Mach ne 7 860-2009 2 Nut, Hex (M1O X 1.5)
(#10-32 X .50)

Paint

REF PART QTY PART REF PART QTY PART

ND. No. DESCRIPTI(M ND. IUD. USED DESCRIPTION
525-0308-02 - Onan Black Enamel - 13 oz. Cummins Beige Enamel
Pressurized Spray Can 525-0551-02 - 13 oz. Pressurized Spkay Can
y~!,,, (Spec A) 525-0551-03 - Quart Can
, Onan Green Enamel (Non-
. 525-0551-04 - Gallon Can
:., Metalic) (Spec B)
525-0305 - 13 oz. Pressurized Spray Can
525-0306 - Quart Can
525-0304 - Gallon Can

43
 14tmitrfcal Index

Part NO* Paga part Mo. Paga Part No. Paga Part No. Paga

98-6361 31 151-0437 14 220-4363-02 33 303-0261 36

98-6409 5 151-0565 14 307-1031 9
104-1462 16 151-0566 14 231-0267 16 307-1056 39
104-1659 16 151-0567 14 232-2418 33 307-1987 39
104-1678 16 151-0603-02 14 232-2921 33 307-2677-02 23
104-1690 16 155-2062-07 24 232-3038 33 308-0739 23
121-0087 7 155-2353 12 232-3542 29 308-0784 37
121-0088 7 155-2376-01 24 234-0688 33 308-0785 37
121-0090 7 155-2459 ~~ 234-0689 33 308-0853 37
128-0119 29 155-2460 24 234-0690 33 308-0882 36
128-0120 29 155-2461 24 300-2809 35 anQ_nci*9
Vww W* ?6 23
128-0121 ~e ~~5_2463 24 300-2880 35 308-0913-04 23
128-0123 ;; 155-2466 24 300-2897 35 308-0932-01 31
128-0124 25 155-2468 24 300-2898 35 308-0932-02 31
128-0125 25 155-2469 24 300-3344 35 308-0933-02 31
128-0126 25 155-2515 24 300-3464 23 308-0963-01 15
128-0129 17 155-2548 24 301-1886 42 309-0128 42
128-0130 29 155-2559 24 301-6257 37 309-0272 9
130-0755 13 159-1208 21 301-6257 38 309-0436 9
130-1107 14 159-1241 21 301-6987 41 309-0437 ~
130-1107 42 159-1242 21 301-8065 35 309-0561 9
130-3415 27 159-1264 21 301-8851 35 315-0431 31
130-3416 25 160-1292 16 301-9054-02 36 315-0686 23
f~~-mm~
----- 25 191-1541 35 301-9054-03 36 319-0030 41
130-3605 27 193-0244 9 301-9055-01 37 31!9-044? %a
Oa
130-3607 29 193-0250 37 301-9055-02 37 319-0485 23
130-3618 25 193-0318 9 301-9668 17 319-0486 23
130-3619 25 193-0322 11 301-9669 17 319-0811 29
130-3620 25 193-0351 37 301-9682 17 319-0812 29
130-3638 25 193-0352 37 302-0885 37 319-0$68 17
130-3665 2? 193-0435 37 302-1147 36 319-0930 17
130-3666 27 201-2151 33 302-1148 36 319-0936 31
130-3669 27 201-3462-01 33 302-1473 36 319-0937 31
130-3670 27 201-3462-02 33 302-1642 37 319-0938 31
130-3671 27 201-3462-03 33 302-1683 36 319-0939 31
130-3752 25 201-3462-04 33 302-1721-01 41 319-0967 31
130-3929 27 201-3462-05 33 302-1721-02 41 319-0968 31
130-3983 27 205-0145 33 302-1722 41 319-0973 17
140-1204 10 211-0370 33 302-1723 37 319-0974 17
140-1791 10 220-2009 33 302-1723 38 319-1320-01 29
140-1869 10 220-4259-01 33 302-1753 36 319-1369 29
140-2227 10 220-4259-02 33 302-1833-01 41 320-0541 31
140-2524 10 220-4259-03 33 302-1833-04 41 320-1121 36
147-0779 14 220-4259-04 33 302-1833-05 41 320-1458-12 17
150-0717 33 220-4259-05 33 302-1868-02 43 320-1511-12 17
150-0723 33 220-4301-01 33 302-1868-04 43 320-1653 23
150-0939 14 220-4301-02 33 302-1873-01 38 320-1654 23
150-1923 14 220-4301-03 33 302-1937 43 320-1674 31
150-1996 14 220-4301-04 33 302-1968 36 320-1675-02 31
150-2453 33 220-4304 33 303-0032 36 320-1675-03 31

44
Part W. Page Part ~. Part N9. Part ?40.

320-16?5-04 31 333-0151 42 403-3004 19 410-1049 5

320-1676-01 31 333-0203 13 403-3005 19 410-1050 5
320-1676-02 31 333-0204 13 403-3006 19 410-1052 5
321-0094 35 333-0291-01 12 403-3013 19 410-1062-01 5
321-0231 35 333-0291-02 12 403-3041 19 410-1063 7
321-0270 35 333-0292-01 12 403-3042-01 19 410-1064 7
322-0017 37 333-0292-02 12 405-4172 29 410-1110 5
322-0223 37 333-0378 42 405-4173 29 415-0565-11 21
322-0358-02 37 333-0386 !2 405-4174 29 415-0566-lfl 21
322-0&30-02 37 333-0387 12 405-4175 29 416-0530 9
322-0361 37 335-0161 42 405-4181 2$ 416-8896 19
322-0363 36 337-0049 35 405-4185 21 416-0921-01 9
322-0369-02 23 337-1837 9 405-4195 25 416-0959 19
322-0369-02 37 337-2463 31 405-4216 29 416-0963-01 19
322-0403-02 23 338-1765-04 14 405-4240 29 501-0094 21
322-0413 7 338-1904 35 405-4244 29 501-0094-01 21
322-0427-01 7 338-1936 41 405-4247 29 501-0094-02 21
32~+j4~7-~~ 7 338-2181 42 405-4248 29 501-0441 21
322-0427-03 7 338-2277 35 405-4249 29 501-0564 7
322-0427-04 7 338-2278 35 405-4250 29 502-0003 *+
322-0427-05 7 338-2382 23 405-4256 29 502-0020 ;;
323-0804 39 338-2403 23 405-4257 29 502-0028 9
323-0866 31 338-2404 23 405-4259 21 502-0029 9
**%4*nA
i?L*-1 #u* 31 338-2478 41 405-4260 19 502-0053 9
--- ,----
323-1109 31 338-2479 41 405-4261 25 3UZ-UU04 21
323-1200 35 338-2539 35 405-4262 21 502-0057 9
323-1302 23 338-2540 35 405-4263 29 502-0079 9
323-1302 35 338-2541 35 405-4264 29 502-0153 27
323-1304 35 338-2552 11 405-4265 19 502-0942 23
323-1306 35 338-2566-02 31 405-4266 19 502-1103 9
323-1308 35 338-2566-03 31 405-4268 24 503-0183 12
323-1374-04 23 338-2566-04 31 405-4283 29 503-0183 13
323-1471 31 338-2567 23 405-4285 29 503-0183 23
331-0027 23 350-1220 35 405-4291 25 503-0276 9
331-0042 23 357-0013 42 405-4342 29 503-0276 27
332-0052 35 358-0069 33 405-4343 29 503-0354 10
332-0607 35 358-0070 33 405-4428 29 503-0365 27
332-1281 9 370-4066 23 405-4429 29 503-0429 27
332-1292 9 399-0117 23 405-4579-01 29 503-0731 9
332-1473 19 399-0121 23 406-0332 35 503-0731 27
332-2605 23 399-0122 23 406-0333 35 503-0980 27
332-2605 35 402-0354 41 406-0334 35 503-1222 10
332-2634 9 402-0527 35 406-0700 29 503-1429-01 13
332-2634 21 402-0635 19 406-0709 31 503-1429-02 13
332-2723 35 402-0636 19 406-0710-02 31 503-1429-05 13
332-2957 35 402-0637 19 410-1033 5 503-1660-02 23
332-3040 31 402-0639 19 410-1035 5 503-1732 27
332-3041 31 403-2965 29 410-1036 5 503-1733 27
332-3043-01 31 403-3001 19 410-1047 5 503-1734 27
332-3043-02 31 403-3002 19 410-1048 5 503-1736 10

45
P8rt No. Page Part w. Pa@ Part No. Paf$n Part No. Pa@

~f~=~~~f ,..,!
503-1737 27 526-0026 31 31 850-0040 14
503-1739 27 526-0028 11 812-0065 35 850-0040 19
503174001 10 526-0030 5 812-0066 31 850-0040 23
503-1740-02 10 526-0048 17 812-0070 42 850-0040 31
503-1740-03 10 526-0081 29 812-0075 23 850-0045 7
!$05-0011 13 526-0113 42 812-0082 31 850-0045 19
505-0018 21 526-0219 5 812-0094 17 850-0045 21
505-0020 13 526-0219 21 813-0100 33 850-0045 23
505-0025 23 526-0219 24 813-0102 41 850-0045 35
505-0026 15 526-0249 33 813-0103 14 850-0045 41
506-0059 9 526-0280 33 813-0103 31 85Q-Q050 5
505-0098 g ~~6-~~20 29 850-0050 9
505-0104 9 718-1815 25 815-0162 31 850-0050 29
505-0136 15 800-0005 31 815-0181 33 850-0050 31
505-0172 21 800-0006 14 815-0194 33 850-0050 33
505-1478 15 800-0007 14 815-0261 7 850-0060 5
508-0001 35 800-0010 23 815-0290 9 850-0109 29
508-00!5 g 800-0024 7 815-0290 19 850-2006 33
508-0021 27 800-0024 35 815-0350 23 850-2008 25
508+0051 27 800-0026 10 815-0385 23 850-2010 24
508-0258 35 800-0026 19 815-0385 37 850-2010 33
508-0298 7 800-0026 21 815-0388 39 850-2010 43
508-0305-02 17 800-0028 23 815-0418 31 853-0003 31
~Q&fo73 33 800-=0028 31 815-0544 35 853-0005 31
508-1078 35 800-0030 19 815-0544 39 853-00!38 ~~
509-0094 33 800-0034 42 815-0607 29 853-0013 33
510-0112 33 800-0045 35 815-0771 29 853-0013 35
517-0131 31 800-0048 33 815-0786 31 8!54-0006 42
!517-0131 37 800-0050 29 816-0099 19 854-0017 31
517-0138-08 37 800-0051 9 821-0004 35 856-0002 41
518-0599 7 800-0052 5 821-0005 10 856-0006 7
518-0600 7 800-0091 19 821-0005 27 856-0006 13
520-0986-01 33 800-0091 21 821-0005 43 856-0008 19
520-0986-02 33 800-0092 5 821-0008 31 856-0008 35
520-0986-03 33 800-0095 19 821-0010 17 856-0010 9
520-0986-04 33 800-0096 19 821-0014 35 856-0013 9
520-0986-05 33 800-0100 19 821-0016 13 860-0006 42
525-0304 43 800-0100 24 821-0017 41 860-0008 41
525-0305 43 800-0102 19 821-0018 17 860-2009 43
525-0306 43 800-0103 5 821-0018 21 862-0001 19
525-0308-02 43 800-2029 33 821-0018 25 862-0002 21
525-0551-02 43 800-2033 33 821-0018 27 862-0002 31
525-0551-03 43 800-2071 14 821-0018 29 862-0003 5
525-0551-04 43 800-2085 24 821-0018 31 862-0003 9
526-0003 23 800-2085 33 821-0021 24 862-0003 29
526-0008 33 800-2085 43 821-0021 35 862-0003 31
526-0015 19 800-2110 9 821-0030 19 862-0011 33
526-0022 21 802-0038 33 850-0025 17 862-0014 41
526-0022 23 805-0025 33 850-0030 14 862-0015 19
526-0022 31 80!3-0036 9 850-0030 33 862-0015 23 ,,
 Wm9rical Index

Part woe PaQ@ Palm No. P8gtit Part MO. Part MO.

862--0016 5
862-0016 24
862-0018 29
862-1001 33
870-0048 24
870-0065 14
870-0131 14
870-0131 29
870-0131 31
870-0131 33
870-0131 35
870-0131 43
870-0183 31
870-0183 37
870-0183 42
870-0196 9
870-0212 27
870-0212 29
870-0221 23
870-0221 31
870-0235 29
870-0250 33
870-0257 10
870-0257 13
870-0257 19
870-0257 21
870-0257 27
870-0257 42
870-0281 19
870-0458 23
870-0462 24
870-0490 19
870-1063 29
$71-0015 35
880-0443 5
880-0444 5
895-0170 17
895-0170 27
895-0170 29
895-0170 31
895-0172 29
895-0182 27
895-0182 29
895-0308 17
895-0308 25
895-0308 29
895-0308 31
898-0016 7

47