12H CBK
Uploaded by
Marildo Dantas12H CBK
Uploaded by
Marildo DantasComponent Identifiers (CID) Wire Description Component Location Electrical Schematic Symbols And Definitions
Module Identifier (MID) Wire Wire Wire Wire Component
Schematic Machine
Component
Schematic Machine
RENR9555-01
Description Description Location Location Location Location
Caterpillar Monitoring System Number Color Number Color
Power Circuits Lighting Circuits (cont'd) Air Dryer K-13 1 Power Port - 12V C-3 14 November 2009
(MID No. 030) 35 15
101 RD Bat (+) 614 PU Tail Lamps Air Inlet Heater J-14 Radio - AM/FM C-3 T
CID Component
102 RD Headlamp Breaker 617 BR Not Used
Alarm - Action A-14 C Radio - AM/FM Cassette C-3 15 Pressure Temperature Level Flow Circuit Breaker
0096 Fuel Level Sender
Alarm - Backup L-18 2 Receptacle - Aux. Start K-13 1 Symbol
0248 Data Link 103 RD Tail Lamps/Panel Lamps 618 YL Not Used Symbol Symbol Symbol Symbol
0263 Sensor Power Supply Alternator J-13 3 Relay - Air Inlet Heater J-14 33
105 RD Key SW 619 GN Head Lamp (Low)
0271 Action Alarm Antenna - AM/FM Radio C-3 4 Relay - Aux. Backup Lamp D-8 16
106 RD Battery #1 To Battery #2 629 PK Lightbar Worklamp Normally open switch that will close with an increase of a specific condition (temp-press-etc.).
0324 Action Lamp Arc Suppressor AC Clutch G-15 5 Relay - Fuel Pump H-14 7
108 RD Dome Lamp 633 BU Moldboard Lamps
Arc Suppressor Differential Unlock K-16 6 Relay - Main H-13 7
The circle indicates that the component has screw terminals and a wire can be disconnected from it.
0615 Position Sensor (Articulation Angle)
109 RD Alt Output (+) Term. 647 GN Aux Backup Lamp SW
0819 Display Data Link Batteries - 12 Volt I-13 7 Relay - Secondary Steering J-13 12 Normally closed switch that will open with an increase of a specific condition.
0821 Display Power Supply 112 PU Main Power Relay Output 685 BR Blade Floodlamps 4 7
Beacon C-11 Relay - Starter H-13 No circle indicates that the wire cannot be disconnected from the component.
Electronic Engine Control System 113 OR Opr Mon Panel B (+) Switched Control Circuits Beacon - Open Rops C-15 4 Relay - Tail/Panel Lamps K-8 B
(MID No. 036) 114 RD Warning Horn (Forward) 718 BU Not Used Block - B+ Junction I-14 7 Resistor - Front Defroster C-2 24 This indicates that the component has a wire connected to it that is connected to ground.
CID Component 115 RD Lightbar Worklamp Breaker 719 GY Not Used Breaker - Alternator H-13 7 Resistor - Heater/AC B-16 E
0001 Injector Cylinder Solenoid #1 116 BR Floodlamp SW 727 GN Secondary Steering Motor Relay Breaker - Engine Control G-13 7 Resistor - Panel Lamp K-4 B
0002 Injector Cylinder Solenoid #2 117 YL Aux Backup Lamp 728 BU Primary Steering Pressure SW Breaker - Headlamp G-13 7 Resistor - Rear Defroster C-10 11 This indicates that the component does not have a wire connected to ground. It is grounded by
0003 Injector Cylinder Solenoid #3 118 GY Front Wipers 751 GN XMSN Shift Solenoid #3 Breaker - Lightbar Worklamp G-13 7 Resistor - Secondary Steering K-13 12 being fastened to the machine.
0004 Injector Cylinder Solenoid #4 Breaker - Main H-13 7 Sender - Articulation Angle H-11 17
119 PK Rear Wipers 752 YL XMSN Shift Solenoid #1
0005 Injector Cylinder Solenoid #5 C 3
122 BU Air Dryer 754 BU XMSN Shift Solenoid #2 Cap - Service Tool Connector A-11 Sender - Coolant Temperature J-15
0006 Injector Cylinder Solenoid #6 Reed Switch - A switch whose contacts are controlled by a magnet. A magnet closes the
124 GN A/C 755 OR XMSN Shift Solenoid #8 Control - Engine ECM I-18,D-18 8 Sender - Fuel Level G-14 8
0041 ECM 8 Volt DC Supply
Control - Secondary Steering A-16 E Sender - Inlet Air Temperature J-15 18
contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.
0042 Injector Actuation Pressure 126 PK XMSN Control A746 PK Turbo Outlet Pressure Sensor
Control - Transmission D-14,F-14 E Sender - Oil Temperature End I-14 34
0091 Throttle Sensor 127 OR Park Brake Solenoid A747 GY ATM Pressure Sensor
Converter - 24V To 12V (Comm. Radio) D-3 D Sender - Oil Temperature Middle I-14 35
0100 Oil Pressure Sensor 129 RD Lighter A755 PK Throttle Speed Set SW Sender - A component that is used with a temperature or pressure gauge. The sender measures
Converter - 24V TO 12V (Entertain. Radio) L-9 9 Sensor - Atmospheric Pressure J-16 18
0110 Engine Coolant Temperature Sensor 130 RD Stop Lamp Pressure SW E708 PK Opr Mon Display Module Clock the temperature or pressure. Its resistance changes to give an indication to the gauge of the
0164 High Injector Actuation Pressure Converter - 24V TO 12V (Power Port) L-11 9 Sensor - Crank Speed Timing I-16 5 T temperature or pressure.
134 RD Secondary Steering Test SW E735 PU Operator Mode SW
12H Motor Grader
0172 Inlet Air Temperature Sensor Flasher K-8 B Sensor - Run Speed Timing I-16 19
135 BU 12V Power Port E795 YL Oil Temperature Middle Sender
0175 Engine Oil Temperature Fuse Block - Overhead C-4,C-5 11 Sensor - Engine Oil Pressure J-15 8
136 GN Secondary Steering Control E797 WH IAP Pressure Control Solenoid (-)
0190 Engine Speed Signal Fuse Block - Switched Power J-5 B Sensor - Fan Drive Pressure J-18 2 Relay (Magnetic Switch) - A relay is an electrical component that is activated by electricity.
Electrical System
0248 CAT Data Link 137 RD Secondary Steering Motor E798 PK IAP Pressure Control Solenoid (+) Fuse Block - Unswitched Power J-7 B Sensor - Fuel Pressure J-15 8 It has a coil that makes an electromagnet when current flows through it. The electromagnet can
141 PK Front Defroster SW F715 PU Ground Level Shutdown SW open or close the switch part of the relay.
0253 Personality Module Mismatch Fuses - Overhead C-5 11 Sensor - Inching Pedal Position F-6 20
0254 Engine ECM 144 GN Beacon SW F716 WH Ground Level Shutdown SW Fuses - Switched Power I-4 B Sensor - Injection Actuation Pressure J-15 36
0261 Engine Speed Sensor 147 RD 24V To 12V Converter (Aux Power Port) F762 GY Not Used Fuses - Unswitched Power I-6 B Sensor - Throttle Position K-9 13 Solenoid - A solenoid is an electrical component that is activated by electricity. It has a coil that
0262 5 Volt Sensor Supply 148 WH Snow Wing Lamp SW F775 BU Centershift Pin Solenoid Gauge - LH Air Pressure G-1 A Sensor - Turbo Outlet Pressure J-16 18
CBK248-UP makes an electromagnet when current flows through it. The electromagnet can open or close
a valve or move a piece of metal that can do work.
0267
0268
Engine Shutdown Switch
Programmable Parameters
149 PU Floodlamp SW H746 YL Fan Drive Solenoid Gauge - RH Air Pressure G-1 A Sensor - XMSN Input Speed B-18 21 AMZ251-UP
0273 Turbo Outlet Pressure Sensor
150 RD Engine Control Breaker H747 BR Fan Drive Solenoid Return Ground - Cab Boss 2 (Cab Front) B-7 A Sensor - XMSN Output Speed Sensor #1 B-18 21
125 1-UP
0274 Atmospheric Pressure Sensor
151 GN Rear Defroster SW J702 BK Air Inlet Heater Ground - Cab Boss 3 (Upper Cab) D-3 15 Sensor - XMSN Output Speed Sensor #2 A-18 21 Harness And Wire Symbols
Ground - Engine Block Boss (RH Side) J-14 12 Sensor - XMSN Temperature B-17 29 * Harness identification letter(s) and a
0290 Fan Drive Pressure Sensor 155 PK AWD Control J764 BR XMSN Filter Bypass SW
160 PU Heated Mirrors SW J765 BU Inching Pedal Limit SW Ground - Front Frame Boss 2 (LH Side) I-9 20 Shifter - XMSN A-12 2 Harness identification code serializing code. The "C" stands for
0291 Fan Drive Solenoid This example indicates
Ground - Front Frame Boss 3 (LH Side) E-9 10 Solenoid - AC Clutch H-15 5 connector and the number indicates
0296 Unable to Communicate with Transmission ECM 162 YL Moldboard Lamp SW J766 PU Switch Return (Engine ECM) wire 135 in harness "AG". which connector in the harness.
0342 Cam Speed Timing Sensor Ground - Platform Boss 2 J-11 10 Solenoid - Blade Cushion #1 I-5 22 Wire, Cable, or Harness
165 YL Differential Lock SW K748 OR Secondary Steering Resistor
Ground - Rear Frame Boss 2 (RH Side) H-12 12 Solenoid - Blade Cushion #2 I-4 22 Assembly Identification
0548 Throttle Lock Indicator Lamp 169 PK Blade Cushion SW/Centershift Pin SW T725 WH Fuel Filter Bypass SW * * Part Number For
0549 Throttle Lock Switch Ground - Rear Frame Boss 3 (LH Side) K-15 8 Solenoid - Centershift Pin E-7 23 C-C4 AG-C3 AG-C4* L-C12*
170 RD Product Link (Connector #27) 823 GN Not Used
130-6795 130-6795 3E-5179 Connector Assembly
0562 Unable to Communicate with CAT Monitoring System Ground - Rear Frame Boss 4 (LH Side) K-15 8 Solenoid - Differential Unlock K-16 6 111-7898
173 RD Turn Signal SW/Flasher 892 BR (-) Cat Data Link 325-A135 PK-14
0617 Air Inlet Heater Ground - Service Center Boss 1 (LH Side) K-14 1 Solenoid - Forward Horn F-7 13 1
325-A135 PK-14
1627 Fuel Pump Relay 176 RD 24V To 12V Converter (Communication Radio) 893 GN (+) Cat Data Link
Ground - Service Center Boss 2 (RH Side) K-14 7 Solenoid - Fuel Injector #1 J-18 18
1715 Engine Oil Temperature Sensor 177 RD Main Breaker F842 BU AIH Indicator Ground Strap - Articulation Joint J-10 17 Solenoid - Fuel Injector #2 J-18 18 Socket
Pin Wire Wire Receptacle
Electronic Transmission Control System 179 RD 24V To 12V Converter (Entertainment Radio) F843 YL Inching Pedal Position Sensor Ground Strap - Engine Block To ECM D-18 8 Solenoid - Fuel Injector #3 I-18 18 Gauge Fuse
Color
(MID No. 081) 185 YL Fuel Pump Relay G826 BR Analog Sensor (+) Engine ECM Ground Strap - Platform To Cab K-11 17 Solenoid - Fuel Injector #4 I-18 18
Single Wire Ground Plug
CID Component Ground Circuits G827 BU Analog Sensor (-) Engine ECM Ground Strap - Platform To XMSN Control D-14 13 Solenoid - Fuel Injector #5 I-18 18
Connector Circuit Connection 2 200-L32 BK-14
0168 Electrical System Voltage 200 BK Main Chassis G828 WH Analog Sensor (+) Engine ECM Group - A/C B-16 E Solenoid - Fuel Injector #6 I-18 18 Number
0177 Temperature Sensor (Transmission Oil) 201 BK Operator Monitor Panel G829 BR Analog Sensor (-) Engine ECM Group - Heater B-16 E Solenoid - Hydraulic Fan K-9 31 Identification
0248 CAT Data Link
202 BK XMSN Control G833 PK Analog Sensor (-) Engine ECM Group - Light Duty Heater B-16 E Solenoid - IAP Pressure Control J-16 37 Pin or Socket 105-9344
0268 Programmable Parameter 12 13
Number
205 BK Console/Panel G849 BR Engine Actuation Pressure Sensor Heater - Jacket water I-15 Solenoid - Parking Brake E-6
0444 Magnetic Switch (Start Relay) Typical representation of Component
Jumper Plug - Secondary Steering A-15 E Solenoid - XMSN (1st) C-18 29 a Deutsch connector. The Typical representation of a
0520 Configuration (Transmission)
206 BK Battery #1 To Master Disconnect SW G850 BU Air Inlet Heater 1 Part Number
Lamp - Action J-1 A Solenoid - XMSN (2nd) C-18 29 plug contains all sockets 1 Sure-Seal connector. The plug
0562 Caterpillar Monitoring System 210 BK AM/FM Radio G854 PK HEP Motor 2 and the receptacle contains 2 and receptacle contain
Lamp - AIH Indicator K-1 A Solenoid - XMSN (3rd) C-18 29
0573 Position Sensor (Inching Pedal) 229 BK Product Link G855 PU HEP Motor all pins. both pins and sockets.
Lamp - Autoshift Indicator J-1 A Solenoid - XMSN (Forward High) D-18 29
0585 Speed Sensor (Transmission Output) (No. 1) 232 BK Not Used G856 WH (+) TDC Probe
Lamp - Centershift Pin Indicator K-1 A Solenoid - XMSN (Forward Low) D-18 29
0637 Backup Alarm 235 BK Fuel Pump Relay G857 YL (-) TDC Probe
0668 Transmission Control (Shift Lever) 290 BK Caterpillar Monitoring System (Service) G858 OR Not Used
Lamp - Differential Lock Indicator K-1 A Solenoid - XMSN (High Range) C-18 29 Volume 1
0669 Speed Sensor (Transmission Input) Lamp - Dome C-3 15 Solenoid - XMSN (Low Range) C-18 29
291 BK Caterpillar Monitoring System (Clear) J844 GY Fan Drive Pressure Sensor (+)
0673 Speed Sensor (Transmission Output) (No. 2) Lamp - High Beam Indicator K-1 A Solenoid - XMSN (Reverse) D-18 29 2009 Caterpillar Printed in U.S.A.
A287 BK Engine ECM Control K882 BU Oil Temperature End Sender
0674 Speed Sensor (Intermediate Transmission) (No. 1) Lamp - HVAC Panel C-16 C Speaker - Left Hand D-2 24 All Rights Reserved
0675 Speed Sensor (Intermediate Transmission) (No. 2) C203 BK Not Used R800 OR Digital Sensor (Power) Lamp - LH Blade Floodlamp G-4 20 Speaker - Right Hand B-2 16
0868 Indicator Lamp (Automatic Shift) Basic Machine Circuits 900 PU XMSN Shift Solenoid #4 Lamp - LH Cab High Beam Headlamp C-2 24 Switch - AC Pressure G-15 5
1401 Solenoid Valve (Forward High) 304 WH Starter Relay No. 1 Output 901 WH XMSN Shift Solenoid #6 Lamp - LH Cab Low Beam Headlamp C-2 24 Switch - Autoshift C-11 C
1402 Solenoid Valve (Forward Low) 306 GN Starter Relay Coil 902 BR XMSN Shift Solenoid #5 Lamp - LH Cab Turn Signal C-2 24 Switch - Aux Backup Lamp A-7 11
1403 Solenoid Valve (Reverse) 307 OR Key Start SW 903 GY XMSN Shift Solenoid #7 Lamp - LH Lightbar High Beam Headlamp F-1 25 Switch - Beacon B-10 30
1404 Solenoid Valve (Speed Clutch) (No. 2) Lamp - LH Lightbar Low Beam F-1 25 Switch - Blade Cushion C-12 C
308 YL Main Power Relay Coil 911 YL Not Used
1405 Solenoid Valve (Speed Clutch) (No. 3)
321 BR Backup Alarm 921 WH Solenoid Return #1 (XMSN) Lamp - LH Lightbar Turn Signal F-1 25 Switch - Blower (Heater/AC) C-16 C Connector Location
1406 Solenoid Valve (Speed Clutch) (No. 1)
322 GY Warning Horn (Forward) 922 BR Solenoid Return #2 (XMSN) Lamp - LH Lightbar Worklamp F-3 25 Switch - Brake Pedal Limit G-6 B Schematic Machine
1407 Solenoid Valve (Low Range) Connector Number
Monitoring Circuits 977 YL Autoshift SW Lamp - LH Moldboard I-4 22 Switch - Centershift Pin C-12 C Location Location
1408 Solenoid Valve (High Range)
Lamp - LH Rear Floodlamp L-13 27 Switch - Centershift Pin Indicator E-6 23 CONN 1 J-17 18
1484 Solenoid Valve (Inching Pedal) 403 GN Alternator (R) Term. 994 GY Engine Oil Pressure
CONN 2 I-17 34
Lamp - LH Rear Turn L-18 27 Switch - Differential Lock K-5 B
1580 Indicator Lamp (Transmission Filter) 404 YL Opr Mon Hydraulic Temperature 995 BU Coolant Temperature CONN 3 I-17 35
The CID is a diagnostic code that indicates which component is faulty. Lamp - LH Stop/Tail L-18 27 Switch - Floodlamp K-5 B
408 WH Opr Mon Brake System Pressure 998 BR Oil Grade Code Plug #1 CONN 4 B-17 29
The MID is a diagnostic code that indicates which electronic control module Lamp - LH Turn Indicator K-1 A Switch - Front Defroster A-10 30 25 CONN 5 A-17 32
RENR9555-01 VOL 1 of 2
410 WH Opr Mon Action Alarm A982 BR Throttle Speed Set SW
diagnosed the fault. Lamp - RH Cab High Beam Headlamp B-2 16 Switch - Front Lower Wiper (NOTE B) A-9 30
15 CONN 6 A-17 32
411 PK Opr Mon Action Lamp A983 BU Throttle Hold Mode SW 9 14
Lamp - RH Blade Floodlamp G-4 13 Switch - Front Lower Wiper (NOTE C) A-9 30 10 CONN 7 A-17 32
417 GY Opr Mon Primary Steering Pressure C912 GN Throttle Position Sensor (Signal) 24
Lamp - RH Cab Low Beam Headlamp B-2 16 Switch - Front Upper Wiper (NOTE B) B-9 30 27 36 37 50 4 CONN 8 D-16 29
8 20 22
419 YL Opr Mon Parking Brake C967 BU Intake Air Temperature Sender (Signal) 2 29 34 1 5 D CONN 9 L-16 2
Lamp - RH Cab Turn Signal B-2 16 Switch - Front Upper Wiper (NOTE C) B-9 30 33
35
426 BR XMSN Filter Bypass C975 WH Throttle Lock 26 38 CONN 30 Aux Backup Lamp L-16 2
Failure Mode Identifiers (FMI) Lamp - RH Lightbar High Beam Headlamp F-1 Switch - Fuel Filter Bypass I-14
6 19 17
E
B A
23
432 PK Service Brake SW (Engine ECM) C977 BU Inching Pedal Limit SW (N/O) 21 16 CONN 11 B-15 C
FMI No. Failure Description Lamp - RH Lightbar Low Beam E-1 26 Switch - Ground Level Shutdown D-17 29
38 18 31 CONN 12 A-15 C
439 YL Centershift Indicator SW C978 BR Speed Set/Accel 7 3
0 Data valid but above normal operational range. Lamp - RH Lightbar Turn signal F-1 26 Switch - Headlamp L-3 B 12
28 C CONN 13 C-14 32
1 Data valid but below normal operational range. 447 PK Fuel Level Gauge C979 OR Speed Resume/Decel Lamp - RH Lightbar Worklamp F-3 26 Switch - Headlamp Dimmer K-4 B 13 CONN 14 C-14 32
2 Data erratic, intermittent, or incorrect. 458 PK Opr Mon Display Module Power C991 PK Fuel Pressure Sensor (Signal) 22 11 11 30
Lamp - RH Moldboard I-4 Switch - Heated Mirrors B-7 32 CONN 15 C-13 32
3 Voltage above normal or shorted high. 462 YL Secondary Steering Motor Indicator E900 WH (+) XMSN Output Speed Sensor 1 Lamp - RH Rear Floodlamp L-13 28 Switch - Heater Thermostat C-16 E CONN 16 K-14 8
26
4 Voltage below normal or shorted low. Lamp - RH Rear Turn Signal A-18 28 Switch - Horn K-7 B CONN 17 L-14 8
486 PK Not Used E901 GN (-) XMSN Output Speed Sensor 1
5 Current below normal or open circuit. CONN 18 L-14 2
488 WH Brake System Pressure SW E902 PU (+) XMSN Int Speed Sensor 1 Lamp - RH Stop/Taillight A-18 28 Switch - Hydraulic Temperature E-6 17
6 Current above normal or grounded circuit. CONN 19 E-12 13
498 WH Differential Lock Indicator E903 YL (-) XMSN Int Speed Sensor 1 Lamp - RH Turn Indicator K-1 A Switch - Inching Pedal Limit G-6 B
7 Mechanical system not responding properly. CONN 20 F-12 32
Lamp - Shift Lever Panel B-12 C Switch - Key A-15 C
8 Abnormal frequency, pulse width, or period. A429 YL Opr Mon Articulation Angle E904 BR (+) XMSN Int Speed Sensor 2 CONN 21 F-12 12
Lamp - Snow Wing E-5 11 Switch - LH Brake System Pressure F-6 31
9 Abnormal update. C413 YL Opr Mon Display Module Load E905 BU (-) XMSN Int Speed Sensor 2 CONN 22 F-12 12
10 Abnormal rate of change. Lamp - Throttle Lock Indicator L-1 A Switch - Lightbar Worklamp K-4 B CONN 23 G-12 12
C414 BU Opr Mon Display Module Data E906 OR (+) XMSN Output Speed Sensor 2
11 Failure mode not identifiable. Lamp - XMSN Filter Bypass Indicator L-1 A Switch - Master Disconnect K-13 1 CONN 24 G-12 12
C436 BU XMSN Filter Bypass Indicator E907 GY (-) XMSN Output Speed Sensor 2
12 Bad device or component. Lighter - Cigar A-15 C Switch - Moldboard Lamps B-7 11 CONN 25 G-12 12
G460 GN XMSN Temperature Sensor E908 BR (+) XMSN Input Speed Sensor
13 Out of calibration. Mirror - LH Heated D-1 24 Switch - Open Rops Beacon C-15 4 CONN 26 I-12 20
H477 YL Oil Grade Code Plug #1 E909 WH (-) XMSN Input Speed Sensor CONN 27 I-12 20
14 Parameter failures. Mirror - RH Heated D-1 16 Switch - Operator Mode L-1 A
30 Page,
15 Parameter failures. H478 BU Oil Grade Code Plug #2 E937 PU Redundant Neutral CONN 28 I-12 20
Module - Caterpillar Monitoring System I-1 A Switch - Panel Lamp Dimmer L-4 B
16 Parameter not available. Accessory Circuits E938 OR First Gear CONN 29 L-12 32
Module - Quad Gauge H-1 A Switch - Parking Brake Pressure E-10 32
17 Module not responding. 500 BR Wiper - Front Upper (Park) E939 WH Second Gear CONN 30 Service Tool A-11 C
Module - Speedo/Tach H-1 A Switch - Primary Steering Pressure L-9 9
18 Sensor supply fault. CONN 31 C-10 11
501 GN Wiper - Front Upper (Low) E940 BU Third Gear 4
Motor - Blower (Heater/AC) B-15 E Switch - Rear Defroster A-10 C 24
19 Condition not met. D CONN 32 C-10 11
502 OR Wiper - Front Upper (HI) E941 YL Fourth Gear 38 30 15 11 16
Motor - Engine Fuel Pump H-14 Switch - Rear Wiper A-9 CONN 33 D-10 A
20 Parameter failures.
503 BR Wiper - Rear (Park) E942 GN Fifth Gear Motor - Front Defroster Fan C-2 24 Switch - RH Brake System Pressure E-6 31 CONN 34 E-10 A
The FMI is a diagnostic code that indicates what type of failure has occurred.
504 YL Wiper - Rear (Low) E943 BR Sixth Gear Motor - Front Lower Washer L-11 A Switch - Secondary Steering Test C-12 C CONN 35 E-10 A
505 BU Wiper - Rear (HI) E944 GY Seventh Gear Motor - Front Lower Wiper G-4 A Switch - Snow Wing Lamp A-7 11 CONN 36 C-9 11
14
31 CONN 37 C-9 11
Monitoring System Service Modes 506 PU Washer - Front Upper E945 PU Eighth Gear Motor - Front Upper Washer L-11 A Switch - Stop Lamp Pressure F-7
A CONN 38 C-8 11
Service Mode Number 507 WH Washer - Rear E946 OR Forward Direct Motor - Front Upper Wiper D-3 A Switch - Tail Lamp L-4 B 27 28 1 37 33 50 30 B
22 CONN 39 C-8 11
Operator Mode 0 Motor - HEP J-16 37 Switch - Throttle Hold Mode B-11 C 7 5 25
508 PU Radio Speaker - Left E947 WH Reverse Direct 18 CONN 40 G-6 20
34 C
Motor - Rear Defroster C-11 11 Switch - Throttle Speed Set A-11 C 35 36 3 26 CONN 41 G-6 13
Harness Code 1 509 WH Radio Speaker - Left (Common) E948 BU Park
Motor - Rear Washer K-11 D Switch - Turn Signal L-8 B 38 E CONN 42 H-6 13
Parameter Display 2 511 BR Radio Speaker - Right E949 YL Neutral 23
Motor - Rear Wiper C-11 D Switch - XMSN Filter Bypass K-13 1 CONN 43 H-6 20
Diagnostic Service 3 512 GN Radio Speaker - Right (Common) E963 BK Run Speed/Timing (-) 8 12 31 20 13
Motor - Secondary Steering J-12 10 2 19 CONN 44 I-6 20
Digital Tattletale 4 515 GY Blower Motor (HI) E964 WH Run Speed/Timing (+) 9 10
Motor - Starter J-14 12 6 CONN 45 I-6 13
21 32
Units 5 516 GN Blower Motor (Medium) E965 BU Crank Speed/Timing (-) CONN 46 I-6 13
Machine locations are repeated for components located close together.
29 17 CONN 47 CMS Service Tool L-5 B
Calibration (Articulation Gauge) 6 517 BU Blower Motor (Low) E966 YL Crank Speed/Timing (+)
A = Operator's compartment (Dash).
Calibration (Transmission Control) 7 521 YL A/C SW To Refrigerant SW E974 GN Inching Pedal Limit SW (N/C) CONN 48 E-4 20
B = Operator's compartment (Steering Console).
CONN 49 H-4 20
Calibration (Transmission Control) 8 522 WH A/C Clutch To Thermostat SW G939 PK Not Used C = Operator's compartment (Right side console). CONN 50 H-3 A
Module Configuration 9 537 GN Turn Signal SW To Flasher G946 OR Throttle Hold Indicator D = Operator's compartment (Headliner). CONN 51 H-3 A
Monitoring System Operator Modes 556 WH Differential Lock SW K917 BR Fan Drive Pressure Sensor (Signal) E = Operator's compartment (Under seat). CONN 52 H-2 A
Operator Mode Number 567 WH Front Defrost SW K995 OR Air Inlet Heater CONN 53 E-3 25,26
Service Meter 0 569 PK Rear Defrost SW L987 WH Not Used CONN 54 TDC Service Probe I-15 8
CONN 55 G-14 50
Odometer 1 570 BU Blade Cushion Solenoid M998 OR Autoshift Indicator Lamp
CONN 58 L-12 1
Digital Tachometer 2 575 YL Wiper - Front Lower (Park) R914 OR Throttle Hold Mode SW
CONN 59 B-16 C
Diagnostic Scrolling 3 576 PK Wiper - Front Lower ( Low) R998 BR Digital Sensor (Return) CONN 60 B-4 15
Cumulative Fuel 4 577 PU Wiper - Front Lower (High) T914 OR Throttle Hold (OFF) CONN 61 D-4 15
Trip Machine Hours 5 578 BU Wiper - Front Lower (Wash) T945 GY Brake #1 Return CONN 77 A-18 28
CONN 79 L-18 27
Trip Odometer
Trip Fuel
6
7
589
592
GN
BU
A/C Clutch Solenoid
24V To 12V Converter (Entertainment Radio)
T946
T947
PU
YL
Brake #2 Return
Brake #3 Return
Machine Harness Connector And Component Locations CONN 80 L-18 2
The connectors shown in this chart are for harness to harness connectors.
Reset Trip Values 8 A503 PK Front Defrost Fan (Low) T948 BR Brake #4 Return Connectors that join a harness to a component are generally located at or near
the component. See the Component Location Chart.
A504 GN Rear Defrost Fan (Low) T949 BU Brake #5 Return
A506 OR Front Defrost Fan (High) T950 GN Brake #6 Return
A507 YL Rear Defrost Fan (High) T951 YL Injector #1
Event Codes For Engine ECM A513 PK 24V To 12V Converter (Entertainment Radio) T952 BR Injector #2 Resistor, Sender and Solenoid Specifications
Part No. Component Description Resistance (Ohms)
Event Code Condition C542 GN Heated Mirrors SW T953 BU Injector #3 Off Machine Switch Specification
3E-1906 Solenoid - AC Clutch 17.6 0.6
E015 High Engine Coolant Temperature Derate Lighting Circuits T954 GY Injector #4 Part No. Function Actuate Deactuate Contact Position
3E-7842 Resistor - Secondary Steering 150 7.5
E017 High Engine Coolant Temperature Warning 600 BR Panel Lamp (Low) T955 GN Injector #5 60 kPa MAX 38 20 kPa 7T-4003 Resistors - Front & Rear Defrost 10 .5
3E-2026 Brake Air Pressure (Stop Lamp) Normally Open
E025 High Inlet Air Temperature Derate 601 GY Panel Lamp (High) T956 GY Injector #6 (8.7psi MAX) (5.5 2.9 psi) Overall 2.0 .1
9G-1950 Resistor - AC/Heater Blower Motor
E027 High Inlet Air Temperature Warning 603 PK Beacon T957 PU Injector #1 (Return) -1.1 0.8c 2.2 0.8c Tap 1.0 .05
3E-5464 Thermostat Normally Closed
E039 Low Engine Oil Pressure Derate 604 OR Stop Lamp T958 YL Injector #2 (Return) (30 1.4F) (36 1.4F) 112-2240 Solenoids - Blade Cushion (No. 1 & No. 2) 32.6 1.6
E100 Low Engine Oil Pressure Warning 605 YL Turn Lamp - LH T959 BR Injector #3 (Return) 1200 kPa MAX 700 100 kPa A-B, Normally Open Coolant Temperature
3E-6450 Primary Steering Pressure 130-9811 Senders - 1000
E164 High Injector Actuation Pressure 606 GY Turn Lamp - RH T960 BU Injector #4 (Return) (174 psi MAX) (101.5 14.5 psi) A-C, Normally Closed Intake Air Temperature
E190 Engine Overspeed Warning 608 GN Flood Lamp - Rear T961 GN Injector #5 (Return) Brake System Pressure (RH & LH) 640 kPa MAX 530 40 kPa 145-1144 Solenoids - XMSN (Fwd High,Fwd Low,and Reverse) 8.7 0.4
114-9281 Normally Open
609 YL Flood Lamp - Snow Wing T962 WH Injector #6 (Return) Park Brake Pressure (92.8 psi MAX) (76.9 5.8 psi) 148-2350 Solenoid - Hydraulic Fan 5.0 0.3
611 PU Head Lamp (High) T993 BR Fan Drive Pressure Sensor (-) 102 3C 90 MIN 152-8346 Solenoid - Centershift Pin 32.6 1.6
131-4135 Hydraulic Temperature Normally Closed
612 GY Aux Backup Lamp (215.6 5.4F) (194F MIN) Fuel Level Empty 239 To 255
Related Electrical Service Manuals 173-2018 Sender -
Fuel Level Full 25 To 29
275 to 1750 kPa -
Title Form Number 180-5462 A/C Pressure Normally Open
(40 to 255 psi) - 174-3705 Solenoid - Differential Unlock 32.6 1.6
Alternator: 169-3345: 50A (STD) 24V SENR4130
103.4 13.7 kPa 68.9 kPa 186-1526 Solenoids - XMSN (1st,2nd,3rd,High Range, and Low Range) 31.3 3.0
200-2232: 75A (ATCH) 24V SENR7508 212-2768 Fuel Filter Bypass Normally Closed
(15 2 psi) (10 psi) Articulation Angle 80 from Full CCW 10 3
Electric Starting Motor: 104-7044 SENR3581
Contact position at the contacts of the harness connector. 187-1008 Sender - Articulation Angle Mid-range 85 7
Electronic Monitoring System RENR5740
With increasing pressure the closed condition can be maintained up to 2800 kpa (405 psi), with decreasing pressure the close d condition can be maintained Articulation Angle 80 from Full CW 185 7
Engine Control Monitor SENR9504 down to 170 kpa (25psi).
Forward Horn
Starting and Charging SENR2947 188-9250 Solenoids - 74.0 7.4
Park Brake
Transmission Electronic Control RENR4104
194-4181 Resistor - Panel Lamp 10 .3
At room temperature unless otherwise noted.
18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
BACKUP ALARM AG-C8
123-6449 1552269 922-AG14 BR-18 STEERING CONSOLE
BK-18 1 321-AG13 BR-18 F-C7 AN-C1 AN-C2 GAGE CONSOLE
BK-18 2 1552269 3E3364 1552269
TAILLAMPS
HEADLAMPS
F-C4 F-C3
608-F7 GN-14 1 608-AN1 GN-14 608-AN2 GN-14 1 LH REAR FLOODLAMP CONN 58 P-C3 P-C43 G-C21
OPERATOR MODE SW
LH REAR TURN LAMP CONN 79 3E3364 CONN 10 1552269
200-F8 BK-14
200-F21 BK-18
200-F18 BK-14 2 200-AN4 BK-14
F-C9
200-AN5 BK-14 2 153-2073
AF-C4 R-C6 3E3382 1552273
147-P153 RD-16
1552269
9X-9688
OFF
135-0427 AG-C6 AG-C2
3E3370 1552267
AUX BACKUP
LAMP
1
2
612-F9 GY-14
200-F8 BK-14
321-F15 BR-18 321-F4 BR-18
321-F17 BR-18
CONN 18 3E3364 AN-C3
1552269
3E3382 1552273
150-AF3 RD-14 1 150-R13 RD-14
+24V UNSWITCHED 1
+24V SWITCHED 2
147-P163 RD-16
147-P166 RD-16 C-C2 201-G39 BK-18
1
2
BK-18
BK-18
RD-18 A CONNECTOR 604-F10 OR-18 608-AN3 GN-14 1 RH REAR FLOODLAMP 150-AF12 RD-14 2 150-R11 RD-14 GROUND 3 200-P8 BK-16 TURN SIGNAL SW 601-C60 GY-18 3E7996
BK-18 B 200-AG11 BK-18 AG-C1 F-C8 604-F11 OR-18 200-AN6 BK-14 2 153-2073 306-AF5 GN-16 3 306-R6 GN-16 +12V UNSWITCHED 4 173-3064 601-C61 GY-18
WH-18 C 3E5179 CONN 9 1552252 605-F13 YL-18 921-AF6 WH-16 4 921-R10 WH-16 +12V SWITCHED 5 135-P155 BU-16 205-C62 BK-18 A A
604-F10 OR-18
604-F11 OR-18
605-F13 YL-18
606-F14 GY-18
614-F12 PU-18
556-F3 WH-16
612-F9 GY-14
922-F5 BR-18
321-F4 BR-18
922-AG14 BR-18 8 922-F5 BR-18 606-F14 GY-18 5 GROUND 6 C-C1 C-C9 205-C63 BK-18 B B 1071984
1
122-F6 BU-16
608-F7 GN-14
3E3376 1552272
L
321-F17 BR-18
LH STOP TAIL LAMP 321-AG13 BR-18 2 321-F15 BR-18 612-F9 GY-14 150-AF3 RD-14 150-AF13 RD-14 6 150-R7 RD-14 614-C11 PU-18 1 1 1 C436-G55 BU-18 XMSN FILTER BYPASS IND
CONN 17
321-F17 BR-18
200-F21 BK-18
200-F21 BK-18
200-F16 BK-16
200-F18 BK-14
200-F18 BK-14
L
24 TO 12 VOLT CONVERTER 2 3 2 2
200-F8 BK-14
200-F16 BK-16
135-0426 AG-C3 3 604-F10 OR-18 614-F12 PU-18 150-AF13 RD-14 P-C44 P-C42 605-C46 YL-18 290-C88 BK-18 1 103-C34 RD-16 2 3 TAIL LAMP SW 2 922-G49 BR-18 115-1748
200-F8 BK-14
1552267 F-C2 AF-C1 (AUX POWER PORT) 1552273 3E3382 2 3
614-AG7 PU-18 4 604-F11 OR-18 922-F5 BR-18 306-AF5 GN-16 606-C45 GY-18 291-C87 BK-18 2 SERVICE TOOL 614-C11 PU-18 3 3E-9319 3 HEADLAMP SW
1552269 3E3364 205-4285 CMS 4
S RD-18 A 5 605-F13 YL-18 921-AF6 WH-16 179-P148 RD-18 1 +24V UNSWITCHED 3 614-C28 PU-18 4 4 3E-9317
CONNECTOR 5
G BK-18 B 200-AG12 BK-18 6 606-F14 GY-18 122-F6 BU-16 1 122-AF1 BU-16 150-AF4 RD-14 150-AF12 RD-14 2 +24V SWITCHED 6 201-C79 BK-18 4 102-C40 RD-14 5 5 G-C27
FRONT UPPER WASHER MOTOR 6
T WH-18 C 614-AG7 PU-18
614-AG8 PU-18 200-AG11 BK-18
7
1
614-F12 PU-18
200-F21 BK-18
200-F16 BK-16 321-F17 BR-18 2 321-AF15 BR-18 150-AF8 RD-16 SERVICE CENTER
CONN 29 7T-8891 P-C22
200-P16 BK-16
A513-P40 PK-18
3
4
GROUND
+12V UNSWITCHED
5
103-C51 RD-16
102-C40 RD-14
103-C34 RD-16 CONN 47 619-C36 GN-14
601-C61 GY-18
6
C
6
C 150-G77 RD-16
1071984
1 THROTTLE LOCK IND LAMP
200-AG9 BK-18 200-AG12 BK-18 9 200-F19 BK-16 321-AF15 BR-18 AF-C2 7T5957 592-P152 BU-18 5 +12V SWITCHED 173-C49 RD-18 103-C35 RD-16 205-C62 BK-18 D D G946-G51 OR-18 2 115-1748
c
200-AG10 BK-18 10 200-F20 BK-16 150-AF3 RD-14 1552272 F-C1 P-C24 1 506-P24 PU-16 210-P151 BK-18 6 GROUND 200-C84 BK-18 115-C41 RD-14
1552252 MOTOR
11 556-F3 WH-16 150-AF4 RD-14 150-AF8 RD-16 3 3E5179 + - 2 200-P26 BK-16 205-C74 BK-18 601-C31 GY-18
BRIGHT
24 TO 12 VOLT CONVERTER 4
606-AG6 GY-18 12 150-AF13 RD-14 F762-AF7 GY-18 1 1 ENTERTAINMENT RADIO 601-C73 GY-18 601-C32 GY-18
DIM
556-F1 WH-16 232-AF9 BK-18 232-AF9 BK-18 2 321-F4 BR-18 2 205-4285 605-C46 YL-18 611-C39 PU-14 C-C3
556-F2 WH-16 306-AF5 GN-16 200-AF14 BK-16 4 604-F10 OR-18 3 604-P41 OR-18 606-C45 GY-18 614-C28 PU-18 3E7996
537-C50 GN-18
FRONT LOWER WASHER MOTOR
- FRONT & REAR
426-AF10 BR-18 604-F11 OR-18 4 604-P45 OR-18 P-C45 PRIMARY STEERING PRESS SW 614-C52 PU-18 614-C30 PU-18 601-C59 GY-18 A
AF-C7 7T-8891
- FRONT ONLY
921-AF6 WH-16 605-F13 YL-18 5 605-P88 YL-18 P-C47 1552267 3E-6450 685-C48 BR-18 614-C33 PU-18 205-C64 BK-18 B
3E3376
F762-AF7 GY-18 606-F14 GY-18 6 606-P89 GY-18 7T5957 200-P25 BK-18 A BK-16 L987-C58 WH-18 619-C36 GN-14 600-C29 BR-18 1 1
2 PANEL LAMP DIMMER SW
J764-AF11 BR-18 614-F12 PU-18 7 1 578-P31 BU-16 728-P42 BU-18 B RD-16 J766-C89 PU-18 619-C37 GN-14 614-C33 PU-18 2 3
200-F20 BK-16
200-F19 BK-16
MOTOR
556-F1 WH-16
556-F2 WH-16
122-AF1 BU-16 612-F9 GY-14 8 612-P28 GY-14 + - 2 200-P131 BK-16 C BU-16 629-C43 PK-14 601-C31 GY-18 3 3E-9318 G-C26
- OFF
200-AF2 BK-16 200-AF2 BK-16 922-F5 BR-18 9 FLASHER 205-C66 BK-18 601-C59 GY-18 4 1071984
P-C51 108-0358
C912-P161 GN-18
H746-P158 YL-16
H747-P165 BR-16
R800-P159 OR-18
R998-P160 BR-18
10 5
135-P155 BU-16
147-P153 RD-16
200-P131 BK-16
200-P123 BK-16
179-P148 RD-18
210-P151 BK-18
592-P152 BU-18
A513-P40 PK-18
200-AF14 BK-16 426-AF10 BR-18 122-F6 BU-16 122-P81 BU-16 205-C63 BK-18 150-G54 RD-16 AIH INDICATOR LAMP
200-P26 BK-16
506-P24 PU-16
507-P32 WH-16
578-P31 BU-16
200-P16 BK-16
200-P25 BK-18
728-P42 BU-18
3E3370
CONN 16
200-P8 BK-16
J764-AF11 BR-18 556-F3 WH-16 11 556-P94 WH-16 173-C49 RD-18 601-C60 GY-18 C-C10 6 F842-G52 BU-18 115-1748
AF-C5 608-F7 GN-14 12 608-P20 GN-14 REAR WASHER MOTOR HORN SWITCH HHH-C1 C-C14 601-C65 GY-18 601-C67 GY-18 3E7996 C
1018108 7T-8891 P-C48 3E3364 1552269 205-C64 BK-18 601-C68 GY-18 D G-C11
UX-C14 AF-C3 122-AF1 BU-16 1 BK-22 7T5957 322-HHH1 GY-16 1 322-C7 GY-16 205-C69 BK-18 A 1071984
F-C5 F-C6 155-2252 3E5179 AIR DRYER
200-AF2 BK-16 2 BK-22 1 507-P32 WH-16 2 205-C70 BK-18 B C-C6 10 605-G12 YL-18 LH TURN INDICATOR LAMP
200-F21 BK-18
200-F16 BK-16
200-F18 BK-14
1552269 1552269 MOTOR 1
200-F8 BK-14
1 215-3005 2 1 1552269
150-AF3 RD-14 + - 200-P123 BK-16 WIRE ASSY 685-C22 BR-14 2 200-G76 BK-18 115-1748
C-C7
1
2
1
2
2 150-AF4 RD-14 200-AF2 BK-16 XMSN FILTER BYPASS SW 169-3145 103-C51 RD-16 601-C71 GY-18 685-C23 BR-14 2 600-C29 BR-18 1 YL-16 PANEL LAMP RESISTOR
AF-C6 P-C18 7T6365 3
3 232-AF9 BK-18 200-AF14 BK-16 200-GG1 BK-00 164-7577 THROTTLE POS SENSOR HORN GP 160-7758 155-C17 PK-14 601-C67 GY-18 149-C24 PU-14 3 FLOODLAMP SW 601-C32 GY-18 2 YL-16 194-4181 G-C7
1552269 1552267 160-2443 30 4
4 4
GN-18
GN-18
F762-AF7 GY-18 30
86 86 103-C51 RD-16 200-C84 BK-18 205-C72 BK-18 685-C23 BR-14 5 9X-9632 1071984
5 J764-AF11 BR-18 426-AF10 BR-18 1 BK-18 R800-P159 OR-18 A RD-18 BATTERY + 685-C48 BR-18 205-C74 BK-18 205-C70 BK-18 608-C26 GN-14 5 201-G39 BK-18 606-G11 GY-18 RH TURN INDICATOR LAMP
6
6 426-AF10 BR-18 J764-AF11 BR-18 2 BK-18 R998-P160 BR-18 B BK-18 GROUND 85 200-C84 BK-18 322-C7 GY-16 498-C4 WH-18 116-C25 BR-14 6 200-G75 BK-18 115-1748
7 SERVICE CENTER GND BOSS 1 C 85 87 C-C8 C
DIFF UNLOCK ARC SUPPRESSOR 306-AF5 GN-16 C912-P161 GN-18 WH-18 SIGNAL 87 614-C52 PU-18 601-C73 GY-18 556-C1 WH-16 601-C68 GY-18
(LH SIDE) 1552267
K
8 D
K
106-8704 921-AF6 WH-16 87a
87A 605-C46 YL-18 608-C26 GN-14 205-C69 BK-18 E735-G38 PU-18 G-C6
9 321-AF15 BR-18 A 155-C17 PK-14 606-C45 GY-18 685-C22 BR-14 1 201-G18 BK-18 1071984
DIFF UNLOCK SOLENOID 10 200-RR2 BK-00 P-C36 TAIL PANEL LAMPS RELAY B C203-C9 BK-18 614-C52 PU-18 201-G23 BK-18 611-G10 PU-18 HI BEAM INDICATOR LAMP
2
C912-P161 GN-18
H746-P158 YL-16
H747-P165 BR-16
R800-P159 OR-18
R998-P160 BR-18
HEADLAMP DIMMER SW
200-P26 BK-16
11 1552269 HYD FAN SOL C
147-P153 RD-16
179-P148 RD-18
200-P131 BK-16
200-P123 BK-16
135-P155 BU-16
210-P151 BK-18
592-P152 BU-18
A513-P40 PK-18
174-3705 3E-6477 G858-C10 OR-18 685-C48 BR-18 116-C25 BR-14 611-C39 PU-14 201-G36 BK-18 200-G74 BK-18 115-1748
200-P16 BK-16
200-P25 BK-18
506-P24 PU-16
507-P32 WH-16
578-P31 BU-16
728-P42 BU-18
200-P8 BK-16
REAR FRAME GND BOSS 3 12 150-AF13 RD-14 MASTER DISCONNECT SWITCH H746-P158 YL-16 1 148-2350 C203-C9 BK-18 149-C24 PU-14 C-C17 619-C37 GN-14 103-5678 201-G34 BK-16
REAR FRM GND BOSS 4 (LH SIDE) 7N-0718 AUX START RECEPTACLE STRAP 1S-2342 H747-P165 BR-16 2 5.5 G858-C10 OR-18 165-C13 YL-16 3E7996 201-G35 BK-16 G-C17
(LH SIDE) 1844467 4 AWG L987-C58 WH-18 601-C71 GY-18 113-G40 OR-16 1071984
UNLOCK
SERVICE CENTER GND BOSS 2 C-C12 J766-C89 PU-18 601-C3 GY-18 A 150-G54 RD-16 498-G1 WH-18 DIFF LOCK INDICATOR LAMP
LOCK
(RH SIDE) CCC CCC 3E7996 205-C72 BK-18 B 150-G53 RD-16 150-G77 RD-16 200-G73 BK-18 115-1748
A 601-C73 GY-18 205-C2 BK-18 4 200-G75 BK-18
B 205-C74 BK-18 5 A C-C4 200-G72 BK-18
PLATFORM GND BOSS 1 CAB GND BOSS 1 1 173-C49 RD-18 6 B 3E7996 200-G73 BK-18
SECONDARY STEERING RESISTOR AWX-C9 1
3E-7842 (LEFT REAR CAB) (LOWER LEFT REAR) 2 J766-C89 PU-18 498-C4 WH-18 1 2 601-C65 GY-18 A 200-G74 BK-18
INJECTOR ACTUATION PRESS. SNSR 1552269 3 L987-C58 WH-18 165-C13 YL-16 2 205-C66 BK-18 B 200-G71 BK-18 200-G76 BK-18
TURBO OUT PRESS. SNRS 194-6726 3 1
101-RR1 RD-00
161-1704 1 4 556-C1 WH-16 3 1 205-G65 BK-18 205-G70 BK-18
C 2
2 5 601-C3 GY-18 C 103-C35 RD-16 2 LIGHTBAR WORKLAMP SW 205-G68 BK-18 G-C25
ENG OIL PRESS. SNSR D 3
AWX-C10 6 205-C2 BK-18 D 614-C30 PU-18 3 9X-9631 205-G57 BK-18 1071984
UX-C16 ATMOSPHERIC PRESS. SNSR 161-1705 150 4
FAN DRIVE PRESS SENSOR 161-1703 FUEL PRESS. SNSR 3E-3364 C 4 205-G58 BK-18 439-G50 YL-18 CENTERSHIFT PIN IND LAMP
3E3370 5
GROUND
SIGNAL
167-1709 161-1705 D 115-C41 RD-14 5 205-G59 BK-18 200-G72 BK-18 115-1748
6
GROUND
SIGNAL
+5V OR-18 A AIR INLET HTR RELAY PLATFORM GND BOSS 2 629-C43 PK-14 6 205-G60 BK-18
+5V
GROUND YL-18 B 148-0757 CAB SUPPORT DIFF LOCK SWITCH C 290-G42 BK-18 G-C10
+5V
HEP MOTOR
GROUND
SIGNAL
SIGNAL GN-18 C STRUCTURE 177-C82 RD-6 139-2119 D 291-G43 BK-18 1071984
BK-18
BK-18
204-4945
GROUND
SIGNAL
C-C18 403-G5 GN-18 M998-G6 OR-18 AUTOSHFT IND LAMP
+5V
OR-18
YL-18
GN-18
C-C19
GROUND
SIGNAL
1747566
A
B
C
EX-C19 STRAP 134-3355 404-G78 YL-18 921-G7 WH-18 115-1748
+5V
MOTOR EX-C4 UNSWITCHED POWER 1747566
3E3364 00 AWG 112-C83 PU-6 408-G47 WH-18
+5V
1698670 FUSE BLOCK SWITCHED POWER
A
B
C
112-C21 PU-6 410-G41 WH-18 G-C9
1
2
EX-C8 FUSE BLOCK
A
B
C
EX-C9 SECONDARY STEERING RELAY 1071984
ALX-C17 EX-C5 1698670 3E-0154
1
2
A
B
C
205-P168 BK-18
BUSS BUSS
201-P129 BK-18
200-P136 BK-12
201-P126 BK-16
201-P122 BK-18
205-P169 BK-18
1552269 STRAP 7G-1060 417-G4 GY-18 486-G2 PK-18
A
B
C
200-P66 BK-14
1500375 EX-C13 1698670 EX-C2 EX-C3 17 POINT 1 POINT 1
4 AWG 419-G46 YL-18 C203-G3 BK-18
1 1552269 1698670 3E3370 AIR INLET HEATER 17
FUEL INJ 1 NOTE E TAIL LAMPS/ SECONDARY STEERING 439-G50 YL-18
188-4520 2 159-3537 FFF FFF 447-G44 PK-18
PANEL LAMPS TEST MONITOR BLADE FLOOD
103-C42 RD-16 10A 10A 134-C15 RD-16 113-C53 OR-16 10A 10A 149-C24 PU-14 458-G22 PK-18 G-C22
STARTING MTR 1 2 1 2 458-G17 PK-18 1071984
J ALX-C18
1500375
ALX-C23
1917823 CONN 1 EX-C16
1726062
104-7044
REAR FRAME GND BOSS 1 FRONT FRAME GND BOSS 1
(ARTICULATION JOINT) 105-C16 RD-16
KEY SWITCH
10A 10A
AUX PWR PORT
147-C78 RD-16
REAR FLOOD
10A 10A
AWD
155-C18 PK-14
458-G16 PK-18
486-G2 PK-18
411-G37 PK-18
201-G36 BK-18
ACTION LAMP
107-1983 J
G S (ARTICULATION JOINT) 3 4 3 4
FUEL INJ 2 1 1 TURN SIGNALS/ 498-G1 WH-18
188-4520 2 2 ALTERNATR HORN HAZARDS AIR DRYER DIFF LOCK LAMP CLUSTER
3 MTR BAT 114-C6 RD-16 10A 10A 173-C49 RD-18 122-C12 BU-16 10A 10A 165-C13 YL-16 601-G69 GY-18
169-3345
200-TT1 BK-00
ALX-C19 5 6 5 6 G-C8
BK-6
4 (50A STD) COMMUNICATIONS BLADE CUSHION / 601-G67 GY-18
1500375 5 200-8281 8T9834
205-P168 BK-18
205-P169 BK-18
201-P129 BK-18
201-P122 BK-18
200-P136 BK-12
ENGINE BLOCK GND BOSS
201-P126 BK-16
MOTOR 122-P81 BU-16 601-G66 GY-18 601-G62 GY-18
200-P66 BK-14
(75A ATCH) CIGAR LIGHTER RADIO HVAC CENTERSHIFT PIN
FUEL INJ 3 1 6 (RH SIDE) 129-C5 RD-18 10A 15A 176-C77 RD-14 124-C27 GN-14 15A 10A 169-C54 PK-16 601-G63 GY-18 113-G40 OR-16 1 BATTERY +
101-HH1 RD-00
188-4520 2 7 ALT 556-P94 WH-16 147-P153 RD-16 7 8 7 8 601-G64 GY-18 411-G37 PK-18 13 ACTION LAMP
INLET AIR TEMP SENDER OIL TEMP END SENDER ENTERTAINMENT
8 130-9811 R + 604-P41 OR-18 STOP LAMP SW RADIO XMSN CONTROL 601-G61 GY-18 410-G41 WH-18 4 ACTION ALARM
ALX-C20 9 191-6587 604-P45 OR-18 179-P148 RD-18 130-C8 RD-18 10A 10A 179-C80 RD-18 126-C20 PK-14 15A 605-G12 YL-18 7
-
1500375 10 CRANK SP TIMING SNSR 605-P88 YL-18 200-P8 BK-16 9 10 9 10 606-G11 GY-18 C414-G13 BU-18 15 DISPLAY MODULE LOAD
OIL TEMP MIDDLE SENDER 0
FUEL INJ 4 1 11 IAP PRESS. CONTROL VALVE 109-7195 606-P89 GY-18 200-P16 BK-16 DOME LAMP PARK BRAKE 611-G10 PU-18 C413-G14 YL-18 35 DISPLAY MODULE DATA
191-6587
SIGNAL
GROUND
188-4520 2 12 191-0651 COOLANT TEMPERATURE SENDER 608-P20 GN-14 200-P25 BK-18 108-C56 RD-16 10A 10A 127-C55 OR-16 10A 10A 185-C57 YL-16 892-G8 BR-18 E708-G15 PK-18 25 DISPLAY MODULE CLCK
130-9811 12 12
CONN 54
BK-18 SIGNAL
11 11
BK-18 GROUND
13 612-P28 GY-14 200-P26 BK-16 893-G9 GN-18 458-G16 PK-18 34 DISPLAY MODULE PWR
ALX-C21 14 RUN SP TIMING SNSR 137-KK1 RD-00 MOTOR 200-LL1 BK-00 200-P131 BK-16 921-G7 WH-18 10
1500375 SECONDARY STEERING
15 109-7194 TDC SERVICE 200-P123 BK-16 136-C14 GN-16 10A 922-G49 BR-18 11
BK-18 SIGNAL
BK-18 GROUND
SIGNAL
GROUND
14 13 14
1
2
FUEL INJ 5 1 16 PROBE 13 17
EX-C12
1
2
B
A
188-4520 2 17 CONNECTOR SECONDARY STEERING MOTOR (11) 10A FUSES BEACON A429-G45 YL-18 21
18 EX-C32 EX-C14 1552269 117-3915 10A 24
9W-1442 116-C25 BR-14 C203-G3 BK-18
ALX-C22 1407339 1112416 EX-C17 15 16 (1) 15A FUSES 15 16 26
3E3364 206-FF1 BK-00 C413-G20 YL-18
1500375 9W-1441 27
1
2
FRONT FRAME GND BOSS 2 C413-G25 YL-18
EX-C11
CONN 28
B
A
1
2
FUEL INJ 6 1 NEG POS C413-G14 YL-18 28
106-AA1 RD-00
(LH SIDE)
1
2
2 EX-C15 EX-C10 1552269 EX-C7 32
188-4520 1003320 1552269 122-P81 BU-16 108-C56 RD-16 165-C13 YL-16 C414-G26 BU-18 404-G78 YL-18 HYD TEMP SW
3E3364 AWX-C2 P-C32 556-P94 WH-16 130-C8 RD-18 149-C24 PU-14 C414-G21 BU-18 36
12V BATT 1 1552252 3E5179
1
2
3T-5760 (STD) 604-P41 OR-18 129-C5 RD-18 144-C90 GN-16 C414-G13 BU-18 37
EX-C6 12 38
3E3364 153-5700 (ATCH) 604-P45 OR-18 114-C6 RD-16 185-C57 YL-16 C436-G55 BU-18
153-5710 (ATCH) 11 605-P88 YL-18 105-C16 RD-16 169-C54 PK-16 E708-G24 PK-18 E735-G38 PU-18 20 OPERATOR MODE SW
10 606-P89 GY-18 103-C42 RD-16 155-C18 PK-14 E708-G19 PK-18 290-G42 BK-18 23 SERVICE
9 462-P99 YL-18 608-P20 GN-14 135-P155 BU-16 STEERING CONSOLE E708-G15 PK-18 291-G43 BK-18 33 CLEAR
1 308-P65 YL-16 210-P151 BK-18 F842-G52 BU-18 447-G44 PK-18 9 FUEL LEVEL
EX-C35 EX-C34
I
2 506-P24 PU-16 201-P122 BK-18 G946-G51 OR-18 A429-G45 YL-18 18 ARTICULATION ANGLE
I 3E3370 CONN 2 1698670 3 A429-P130 YL-18 507-P32 WH-16 200-P66 BK-14 M998-G6 OR-18 419-G46 YL-18 29 PARK BRAKE
101-CC1 RD-00
A NEG POS 4 201-P129 BK-18 612-P28 GY-14 578-P31 BU-16 200-P136 BK-12 102-C40 RD-14 408-G47 WH-18 19 BRAKE SYS PRESS
B 5 462-P99 YL-18 592-P152 BU-18 201-P126 BK-16 103-C34 RD-16 C-C16 P-C33 417-G4 GY-18 40 PRIMARY STEER PRESS
C
B+ JUNCT BLK 2 12V BATT 2
6 403-P59 GN-18 112-P144 PU-6 728-P42 BU-18 113-P92 OR-16 205-P169 BK-18 102-C40 RD-14 103-C35 RD-16 CONN 46 1275483 1275484
BLADE CUSHION SOL 1 BLADE CUSHION SOL 2 403-G5 GN-18 30 ALTERNATOR
3T-5760 (STD) 7 A513-P40 PK-18 113-P93 OR-16 200-P66 BK-14 103-C34 RD-16 103-C51 RD-16 112-C21 PU-6 1 112-P145 PU-6 112-2240 112-2240 893-G9 GN-18 5 CAT DATA LINK +
9W-0742 8 112-P144 PU-6 C912-P161 GN-18 113-P91 OR-16 200-P136 BK-12 103-C35 RD-16 103-C42 RD-16 892-G8 BR-18 14
153-5700 (ATCH) CAT DATA LINK -
153-5710 (ATCH) 177-P143 RD-6 H746-P158 YL-16 126-P1 PK-14 126-P110 PK-14 201-P126 BK-16 113-P92 OR-16 112-C21 PU-6 105-C16 RD-16 C-C13 P-C23 RH MOLDBOARD LAMP 31
J2
FUEL FILTER BYPASS SW
212-2768
UX-C17 AWX-C4
CONN 27 P-C21 201-P129 BK-18 H747-P165 BR-16 126-P114 PK-14 205-P169 BK-18 118-P76 GY-16 112-C83 PU-6 108-C56 RD-16 CONN 45 1275484 1275483
LH MOLDBOARD LAMP
153-2073 153-2073 3
1552269 1275483 1275484 308-P65 YL-16 177-P143 RD-6 R800-P159 OR-18 113-P93 OR-16 150-P56 RD-16 113-C53 OR-16 112-C21 PU-6 112-C83 PU-6 1 112-P144 PU-6 12
ENGINE ECM EX-C1 EX-C31 EX-C33 JACKET WATER HTR BK-18 2 1 112-P144 PU-6 403-P59 GN-18 R998-P160 BR-18 113-P92 OR-16 200-P63 BK-18 115-C41 RD-14 112-C83 PU-6 22
CONN 3
GN
GN
GN
GN
172-3353 1607690 3E3370 1698670 188-1334 BK-18 1 462-P99 YL-18 308-P65 YL-16 126-P110 PK-14 200-P61 BK-14 122-C12 BU-16 113-C53 OR-16 C-C15 P-C31 16
TDC PROBE (+) 22 A BK-16 AWX-C5
1275483
P-C26
1275484
403-P59 GN-18 205-P168 BK-18 126-P114 PK-14 200-P60 BK-16 124-C27 GN-14 114-C6 RD-16 CONN 44 1275484 1275483 AT-C9
3E3364
AT-C8
3E3364
AT-C7
3E3364
AT-C6
3E3364
6
TDC PROBE (-) 23 B BK-16 101-UU1 RD-4 113-P91 OR-16 200-P36 BK-14 126-C20 PK-14 115-C41 RD-14 177-C82 RD-6 1 177-P143 RD-6 201-G34 BK-16 2
1
2
1
2
4 C GN-16 JACKET WATER 1 177-P143 RD-6 105-P62 RD-16 126-P1 PK-14 200-P14 BK-14 127-C55 OR-16 122-C12 BU-16 39
1
2
1
2
FUEL PUMP RELAY UX-C18 C-C5 P-C1 AT-C2 AT-C3 AT-C4 AT-C5
1 HEATER GP 8
DIGITAL SENSOR RETURN 5 JACKET WATER 187-3068
3E-5239 9X-1054 CONN 26 124-P29 GN-14
129-P102 RD-18 169-P55 PK-16 169-P134 PK-18 201-P53 BK-16
136-C14 GN-16
144-C90 GN-16
124-C27 GN-14
126-C20 PK-14 CONN 43 1552252 3E5179 1552269 1552269 1552269 1552269
CATERPILLAR MONITORING SYSTEM
25 HEATER CORD 30 B+ JUNCT BLK 1 1
200-AT10 BK-14
30 134-P135 RD-16 169-P139 PK-16 169-P139 PK-16 205-P138 BK-18 155-C18 PK-14 127-C55 OR-16 105-C16 RD-16 105-P62 RD-16
570-AT3 BU-18
200-AT4 BK-18
570-AT5 BU-18
200-AT6 BK-18
633-AT7 BU-14
200-AT8 BK-14
633-AT9 BU-14
188-1336 86 86 9W-0742 AWX-C8 160-6567
6 136-P35 GN-16 169-P55 PK-16 169-P134 PK-18 200-P63 BK-18 403-P58 GN-18 169-C54 PK-16 129-C5 RD-18 114-C6 RD-16 2 114-P47 RD-16
1552269
200-GGGX1 BK-00
7 85 144-P101 GN-16 200-P8 BK-16 200-P61 BK-14 200-P61 BK-14 410-P96 WH-18 185-C57 YL-16 130-C8 RD-18 129-C5 RD-18 3 129-P102 RD-18
ANALOG SENSOR RETURN 18 85 1 4
87
87 112-R12 PU-6 PK-18 ARTICULATION ANGLE SENDER 200-P16 BK-16 200-P123 BK-16 200-P60 BK-16 200-P60 BK-16 417-P34 GY-18 201-C79 BK-18 134-C15 RD-16 130-C8 RD-18 130-P54 RD-18 498-P100 WH-18
8 87A R-C2 2 BK-18 169-P55 PK-16 200-P25 BK-18 200-P66 BK-14 200-P36 BK-14 419-P121 YL-18 205-C63 BK-18 136-C14 GN-16 134-C15 RD-16 5 134-P135 RD-16 629-P71 PK-14
87a 3E3364 187-1008
COOLANT TEMPERATURE 32 201-P95 BK-18 200-P26 BK-16 200-P63 BK-18 200-P13 BK-18 447-P128 PK-18 205-C64 BK-18 144-C90 GN-16 147-C78 RD-16 6 147-P153 RD-16
10 UX-C3 BK-18 1 308-R2 YL-16 205-P170 BK-18 200-P131 BK-16 200-P36 BK-14 200-P14 BK-14 570-P120 BU-16 205-C66 BK-18 147-C78 RD-16 176-C77 RD-14 7 176-P157 RD-14
11 1552269 BK-18 2 200-R1 BK-16 10 -185 308-P150 YL-16 200-P123 BK-16 200-P13 BK-18 200-P72 BK-18 575-P77 YL-16 205-C70 BK-18 155-C18 PK-14 8
INLET AIR TEMPERATURE 35 2 403-P57 GN-18 200-P106 BK-14 200-P136 BK-12 200-P67 BK-18 576-P74 PK-16 205-C72 BK-18 155-C17 PK-14 155-C19 PK-14 179-C80 RD-18 9 179-P148 RD-18 105-P62 RD-16
13 MOTOR 1 10
410-P96 WH-18 200-P104 BK-16 200-P8 BK-16 577-P75 PU-16 290-C88 BK-18 169-C54 PK-16 200-C84 BK-18 200-P13 BK-18
15 177-WW1 RD-4 417-P34 GY-18 200-P105 BK-16 200-P16 BK-16 601-P154 GY-18 291-C87 BK-18 322-C7 GY-16 11 322-P48 GY-16 112-P145 PU-6
17 ENG FUEL PUMP 570-P120 BU-16 201-P95 BK-18 200-P25 BK-18 201-P53 BK-16 605-P78 YL-18 498-C4 WH-18 176-C77 RD-14 205-C75 BK-18 12 205-P174 BK-18 112-P144 PU-6
19 MAIN RELAY G-C12 SPEEDO TACH MODULE
190-8977 167-0138 601-P172 GY-18 201-P107 BK-18 200-P106 BK-14 200-P14 BK-14 205-P138 BK-18 605-P83 YL-18 556-C1 WH-16 177-C82 RD-6 113-P93 OR-16
A429-G45 YL-18
C436-G55 BU-18
F842-G52 BU-18
G946-G51 OR-18
C203-G3 BK-18
M998-G6 OR-18
113-G40 OR-16
404-G78 YL-18
201-G35 BK-16
290-G42 BK-18
291-G43 BK-18
408-G47 WH-18
419-G46 YL-18
447-G44 PK-18
605-G12 YL-18
606-G11 GY-18
611-G10 PU-18
150-G53 RD-16
205-G65 BK-18
410-G41 WH-18
439-G50 YL-18
601-G66 GY-18
200-G71 BK-18
922-G49 BR-18
CRANK SPEED/TIMING (-) 59 C-C11 P-C38 1552273 153-8061
403-G5 GN-18
417-G4 GY-18
486-G2 PK-18
892-G8 BR-18
893-G9 GN-18
921-G7 WH-18
498-G1 WH-18
201-P140 BK-18 200-P131 BK-16 205-P174 BK-18 606-P79 GY-18 601-C60 GY-18 179-C80 RD-18 114-P47 RD-16
CRANK SPEED/TIMING (+) 58 101-UU1 RD-4 205-P170 BK-18 200-P26 BK-16 403-P58 GN-18 606-P80 GY-18 601-C65 GY-18 185-C57 YL-16 CONN 42 3E5179 1552252 458-G17 PK-18 1 OR-16 +V
RUN SPEED/TIMING (-) 49 1 2
633-AT11 BU-14
177-WW1 RD-4 728-P42 BU-18 205-P171 BK-18 200-P104 BK-16 601-P156 GY-18 611-P30 PU-14 601-C67 GY-18 200-C84 BK-18 201-C79 BK-18 122-P81 BU-16 201-G18 BK-18 BK-16 GROUND
570-AT1 BU-16
H 80A
H
200-AT2 BK-14
RUN SPEED/TIMING (+) 48 177-AAA1 RD-6 308-P65 YL-16 200-P72 BK-18 601-P154 GY-18 611-P33 PU-14 601-C71 GY-18 201-C79 BK-18 102-C40 RD-14 2 124-P29 GN-14 E708-G19 PK-18 3 GN-16 CLOCK
INLET AIR HEATER RELAY (-) 9 MAIN BREAKER F775-P51 BU-18 200-P105 BK-16 200-P67 BK-18 604-P68 OR-18 611-P39 PU-18 601-C31 GY-18 205-C64 BK-18 498-C4 WH-18 3 498-P100 WH-18 126-P114 PK-14 C413-G20 YL-18 4 WH-16 DATA
INLET AIR HEATER RELAY (+) 12 171-2210 605-P78 YL-18 619-P37 GN-14 601-C32 GY-18 205-C63 BK-18 556-C1 WH-16 4 556-P94 WH-16 127-P141 OR-16 G-C4 C414-G21 BU-18 5 YL-16 LOAD
G-C2 1552252 G-C5
26 462-P99 YL-18 201-P126 BK-16 605-P83 YL-18 619-P38 GN-14 608-C26 GN-14 205-C72 BK-18 144-C90 GN-16 5 129-P102 RD-18 3E3388 3E5179 6 BU-16 ADDRESS SEL
CONN 50
CONN 51
30 201-P90 BK-18 201-P53 BK-16 605-P86 YL-18 611-C39 PU-14 205-C70 BK-18 205-C75 BK-18 685-C47 BR-14 6 685-P23 BR-14 130-P54 RD-18 AT-C1 G-C23 LAMPS
CONN 52
31 201-P90 BK-18 606-P79 GY-18 685-P21 BR-14 614-C28 PU-18 205-C66 BK-18 115-C41 RD-14 7 134-P135 RD-16 3E3370 3E3382 7N-5876
CONN 49
OIL TEMP END 33 109-YY1 RD-4 612-P28 GY-14 403-P57 GN-18 201-P107 BK-18 606-P80 GY-18 685-P22 BR-14 614-C30 PU-18 205-C74 BK-18 608-C26 GN-14 8 608-P20 GN-14 136-P35 GN-16
REAR FRAME GROUND BOSS 2 P-C49 G-C14 G-C15
10
11
12
10
11
12
1
2
3
4
5
6
7
8
1
2
3
4
5
6
7
8
9
1
2
3
4
5
6
7
8
9
OIL TEMP MIDDLE 34 109-RRR1 RD-8 80 403-P59 GN-18 201-P95 BK-18 606-P87 GY-18 892-P5 BR-18 614-C33 PU-18 290-C88 BK-18 611-C39 PU-14 9 611-P69 PU-14
AC CLUTCH SOL (RH SIDE) 3E3370 3T3158 3T3158
HEP (+) 61 101-EEE1 RD-10 112-P145 PU-6 201-P140 BK-18 611-P30 PU-14 893-P4 GN-18 619-C36 GN-14 291-C87 BK-18 614-C44 PU-18 10 147-P153 RD-16 205-G58 BK-18
CA-C2
A
B
C
HEP (-) 62 3E-1906 ALTERNATOR BREAKER 118-P76 GY-16 601-P167 GY-18 205-P174 BK-18 611-P33 PU-14 921-P113 WH-18 619-C37 GN-14 322-C7 GY-16 619-C38 GN-14 11 619-P70 GN-14 169-P139 PK-16 601-G62 GY-18
69 1552269 171-2210 (80A) 135-P155 BU-16 601-P172 GY-18 205-P170 BK-18 205-P169 BK-18 611-P39 PU-18 922-P133 BR-18 629-C43 PK-14 498-C4 WH-18 12 P-C4 205-G57 BK-18
A429-P130 YL-18
C436-P164 BU-18
F842-P147 BU-18
G946-P146 OR-18
201-P53 BK-16
921-P113 WH-18
408-P119 WH-18
419-P121 YL-18
447-P128 PK-18
205-P138 BK-18
439-P142 YL-18
498-P100 WH-18
601-P154 GY-18
922-P133 BR-18
P-C2 P-C5
403-P58 GN-18
417-P34 GY-18
M998-P6 OR-18
113-P92 OR-16
605-P83 YL-18
606-P80 GY-18
611-P39 PU-18
150-P56 RD-16
410-P96 WH-18
200-P63 BK-18
70 GN-14 1
892-P5 BR-18
893-P4 GN-18
589-CA1 GN-16 601-P173 GY-18 205-P171 BK-18 205-P138 BK-18 611-P69 PU-14 685-C22 BR-14 556-C1 WH-16 176-P157 RD-14 3E5179 601-G61 GY-18
570-P120 BU-16
17.6 C-C20 P-C39 1552264 1552252
200-P61 BK-14
43 GN-14 2 522-CA4 WH-16 176-P157 RD-14 604-P41 OR-18 C436-P164 BU-18 601-C71 GY-18 177-P143 RD-6 P-C16
OIL GRADE CODE PLUG 1 50 R-C1 205-P171 BK-18 604-P45 OR-18 619-P37 GN-14 F842-P147 BU-18 103-C42 RD-16 601-C67 GY-18 CONN 41 1552252 3E5179 179-P148 RD-18 1552267 G-C13 QUAD GAUGE MODULE
51 1552269 210-P151 BK-18 605-P84 YL-18 619-P38 GN-14 G946-P146 OR-18 103-C51 RD-16 601-C60 GY-18 113-C53 OR-16 1 113-P93 OR-16 1552273 180-9285
52 CA-C3 BK-18 1 306-R6 GN-16 605-P88 YL-18 619-P70 GN-14 M998-P6 OR-18 105-C16 RD-16 601-C31 GY-18 601-C76 GY-18 122-C12 BU-16 2 122-P81 BU-16 200-P13 BK-18 458-G22 PK-18 1 OR-16 +V
STARTING RELAY
ANALOG SENSOR GROUND 3
ANALOG SENSOR POWER 2 ARC SUPPRESSOR AC 1
1552269
589-CA2 GN-16
CONN 55 118-3534 BK-18 2 921-R10 WH-16 506-P24 PU-16
507-P32 WH-16
606-P85 GY-18
606-P89 GY-18 308-P82 YL-16 685-P21 BR-14 408-P119 WH-18
108-C56 RD-16
114-C6 RD-16
601-C32 GY-18
601-C65 GY-18
124-C27
127-C55
GN-14
OR-16
3
4
124-P29 GN-14
127-P141 OR-16 205-P174 BK-18
201-G23 BK-18
E708-G24 PK-18
2
3
BK-16
GN-16
GROUND
CLOCK
53 106-8704 2 522-CA5 WH-16 CA-C1 UX-C4 575-P77 YL-16 611-P52 PU-14 685-P22 BR-14 439-P142 YL-18 129-C5 RD-18 601-C73 GY-18 126-C20 PK-14 5 126-P114 PK-14 322-P48 GY-16 C413-G25 YL-18 4 WH-16 DATA
56 1552269 3E3364 6 5
109-RRR1 RD-8 304-R8 WH-8 150-R13 RD-14 576-P74 PK-16 619-P49 GN-14 403-P57 GN-18 685-P23 BR-14 130-C8 RD-18 605-C46 YL-18 155-C19 PK-14 C414-G26 BU-18 YL-16 LOAD
57 522-CA7 WH-16 1 150-R11 RD-14 577-P75 PU-16 403-P59 GN-18 403-P58 GN-18 408-P119 WH-18 134-C15 RD-16 606-C45 GY-18 169-C54 PK-16 7 169-P139 PK-16 556-P94 WH-16 6 BU-16 ADDRESS SEL
OIL GRADE CODE PLUG 2 60 AC PRESSURE SW CA-C4 521-CA6 YL-16 2 306-R6 GN-16 578-P31 BU-16 601-P156 GY-18 439-P142 YL-18 147-C78 RD-16 608-C26 GN-14 185-C57 YL-16 8 601-P156 GY-18 LAMPS
IAP CONTROL VALVE (+) 63 180-5462 3E3364 101-EEE1 RD-10 921-R10 WH-16 592-P152 BU-18 601-P172 GY-18 601-P154 GY-18 126-P110 PK-14 155-C17 PK-14 611-C39 PU-14 108-C56 RD-16 9 605-P86 YL-18 7N-5876
UX-C7
ATMOSPHERIC PRESSURE 14 BK-18 1 589-CA3 GN-16 1552269 150-R11 RD-14 150-R9 RD-14 150-R7 RD-14 601-P173 GY-18 601-P167 GY-18 169-P134 PK-18 614-C33 PU-18 136-C14 GN-16 10 136-P35 GN-16 606-P87 GY-18
TURBO OUTLET PRESSURE 40 BK-18 2 11 G-C16 G-C18
521-CA6 YL-16 15A 150-R13 RD-14 150-R5 RD-16 605-P84 YL-18 601-P173 GY-18 200-P72 BK-18 176-C77 RD-14 614-C28 PU-18 290-C88 BK-18 608-P20 GN-14 3T3158 3T3158
ENGINE OIL PRESS 24 STRAP AS. 186-3223 150-R9 RD-14 606-P85 GY-18 922-P108 BR-16 604-P45 OR-18 200-P67 BK-18 177-C82 RD-6 614-C30 PU-18 291-C87 BK-18 12 611-P69 PU-14 205-G59 BK-18
FUEL PRESSURE 16 ENGINE CONTROL BREAKER CONN 25 611-P52 PU-14 J765-P111 BU-18 604-P41 OR-18 179-C80 RD-18 614-C52 PU-18 614-C44 PU-18 601-G63 GY-18
ANALOG SENSOR POWER 41 6T-3643 R-C5 JJJ-C1 619-P49 GN-14 201-P122 BK-18 200-C84 BK-18 619-C36 GN-14 C-C21 P-C35 619-P70 GN-14 205-G60 BK-18
ANALOG SENSOR GROUND 42 1275486 1275485 105-P62 RD-16 604-P68 OR-18 604-P68 OR-18 205-C74 BK-18 619-C37 GN-14 619-C38 GN-14 CONN 40 3E5179 1552252 685-P23 BR-14 601-G64 GY-18
RAIL PRESSURE 27 304-R8 WH-8 1 A513-P40 PK-18 605-P86 YL-18 F775-P51 BU-18 322-C7 GY-16 629-C43 PK-14 C203-C9 BK-18 1 P-C41
INJECTOR 1 36 112-P145 PU-6 605-P78 YL-18 105-P62 RD-16 F843-P112 YL-18 601-C73 GY-18 685-C48 BR-18 601-C76 GY-18 2 601-P156 GY-18 1552269
LH AIR PRESS GAUGE RH AIR PRESS GAUGE
INJECTOR 2 37 101-NNN1 RD-10 15A 102-R4 RD-14 CONN 24 201-P140 BK-18 112-P144 PU-6 605-P88 YL-18 605-P83 YL-18 605-C46 YL-18 685-C22 BR-14 685-C47 BR-14 G858-C10 OR-18 3 685-P21 BR-14 1 LH BLADE FLOODLAMP 1W-3306 1W-3306
G INJECTOR 3 38
INJECTOR 4 39 HEADLAMP BREAKER
3T-2662
R-C3
1552273
AWX-C1
3E3382
419-P121 YL-18
118-P76 GY-16
605-P84 YL-18
606-P89 GY-18 606-P80 GY-18
112-P145 PU-6
112-P144 PU-6
114-P47 RD-16
127-P141OR-16
606-C45 GY-18
614-C52 PU-18
C203-C9 BK-18 L987-C58 WH-18
J766-C93 PU-18
4
5
L987-P175 WH-18 200-P14 BK-14 2 153-2073
LAMP LAMP G
INJECTOR 5 54 150-R5 RD-16 1 113-P91 OR-16 122-P81 BU-16 606-P85 GY-18 606-P87 GY-18 130-P54 RD-18 685-C48 BR-18 G858-C10 OR-18 605-C46 YL-18 10 605-P86 YL-18 L987-P175 WH-18 P-C40 7N-5876 7N-5876
FUEL LEVEL SENDER UX-C10 3E3364
INJECTOR 6 55 173-2018 200-R1 BK-16 2 113-P91 OR-16 126-P1 PK-14 124-P29 GN-14 606-P79 GY-18 118-P76 GY-16 322-P48 GY-16 C203-C9 BK-18 L987-C58 WH-18 606-C45 GY-18 11 606-P87 GY-18
INJECTOR 1 RET 44 1552269 3 12 G-C29 G-C30
308-R2 YL-16 126-P1 PK-14 129-P102 RD-18 611-P69 PU-14 122-P81 BU-16 130-P54 RD-18 G858-C10 OR-18 J766-C89 PU-18 J766-C93 PU-18 629-C43 PK-14 629-P71 PK-14 3T3158 3T3158
INJECTOR 2 RET 45 PK-18 1 101-NNN1 RD-10 15A 115-R3 RD-14 115-R3 RD-14 4 134-P135 RD-16 611-P30 PU-14 124-P29 GN-14 114-P47 RD-16 L987-C58 WH-18 J766-C94 PU-18 432-C95 PK-18 8
INJECTOR 3 RET 46 BK-18 2 102-R4 RD-14 5 201-P107 BK-18 136-P35 GN-16 611-P33 PU-14 129-P102 RD-18 127-P141 OR-16 J766-C89 PU-18 E974-C91 GN-18 6 P-C8 205-G68 BK-18
INJECTOR 4 RET 47 22 -255 LIGHT BAR WORKLAMP BREAKER 6 201-P107 BK-18 205-P168 BK-18 147-P153 RD-16 611-P39 PU-18 134-P135 RD-16 322-P48 GY-16 J765-C92 BU-18 7 1552269 601-G67 GY-18
INJECTOR 5 RET 67 3T-2662 205-P168 BK-18 611-P52 PU-14 136-P35 GN-16 C977-C96 BU-18 9 1 RH BLADE FLOODLAMP 205-G70 BK-18
INJECTOR 6 RET 68 CONN 23 619-P37 GN-14 147-P153 RD-16 2 153-2073 601-G69 GY-18
BRAKE 1 RET 20 SERVICE CENTER R-C4 AWX-C3 176-P157 RD-14 619-P38 GN-14 150-P56 RD-16 C977-C96 BU-18
BRAKE 2 RET 21 1275484 1275483 177-P143 RD-6 619-P70 GN-14 105-P62 RD-16 P-C46 GAGE CONSOLE
RENR9555-01 VOL 1 of 2
COM NO INCHING PEDAL LIMIT SW 3E3364
BRAKE 3 RET 28 112-R12 PU-6 1 447-P128 PK-18 179-P148 RD-18 619-P49 GN-14 685-P21 BR-14 176-P157 RD-14 J765-C92 BU-18
BRAKE 4 RET 29 601-P167 GY-18 685-P22 BR-14 177-P143 RD-6 112-P145 PU-6 112-6175 P-C19
BRAKE 5 RET 65 CONN 22 410-P96 WH-18 685-P23 BR-14 179-P148 RD-18 112-P144 PU-6
NC
1552273
GND
L
BRAKE 6 RET 66 UX-C11 J1 XMSN CONTROL AAA-C1 AWX-C6 601-P167 GY-18 417-P34 GY-18 113-P93 OR-16 E974-C91 GN-18 200-P60 BK-16 2 BK-16 MOTOR H
IAP CONTROL VALVE (-) 64 1010205 172-9389 1275484 1275483 419-P121 YL-18 410-P96 WH-18 1
1 + BATTERY 177-AAA1 RD-6 1 417-P34 GY-18 122-P81 BU-16 576-P74 PK-16 4 GN-16 T AK-C5
COM NO 1552269
36 6 + BATTERY 921-P113 WH-18 447-P128 PK-18 419-P121 YL-18 124-P29 GN-14 J766-C94 PU-18 BRAKE PEDAL LIMIT SW 118-P76 GY-16 6 GY-16 P
37 28 YY-C1 AWX-C7 3 BR-16 B+
LOCATION CODE ENABLE 922-P108 BR-16 556-P94 WH-16 126-P114 PK-14 NC 112-6175 575-P77 YL-16 619-AK3 GN-14 1 LTBAR LH LO BEAM HEADLAMP
38 8 STARTING RELAY 1275484 1275483 921-P113 WH-18 C912-P161 GN-18 570-P120 BU-16 447-P128 PK-18 129-P102 RD-18 498-P100 WH-18 577-P75 PU-16 5 OR-16 200-AK7 BK-14 2 161-3509
39 40 KEYSWITCH 'S' 109-YY1 RD-4 1 922-P108 BR-16 C436-P164 BU-18 575-P77 YL-16 556-P94 WH-16 134-P135 RD-16 432-C95 PK-18 629-P71 PK-14 113-P92 OR-16
BATTERY (+) 48 7 FRONT LOWER WIPER
SOL RETURN 1 C912-P161 GN-18 576-P74 PK-16 570-P120 BU-16 136-P35 GN-16 150-P56 RD-16
BATTERY (+) 52 22 LOCATION CODE 0 CONN 21 C436-P164 BU-18 F842-P147 BU-18 577-P75 PU-16 575-P77 YL-16 200-P63 BK-18
3E-6388 AK-C2
1552267
BATTERY (+) 53 21 LOCATION CODE 1 F843-P112 YL-18 608-P20 GN-14 576-P74 PK-16 169-P139 PK-16 200-P61 BK-14
55 38 LOCATION CODE 2 F842-P147 BU-18 G946-P146 OR-18 577-P75 PU-16 147-P153 RD-16 113-P92 OR-16 201-P53 BK-16 605-AK5 YL-18 A RD-18 LH LTBAR TURN LAMP
57 14 F843-P112 YL-18 H746-P158 YL-16 608-P20 GN-14 118-P76 GY-16 205-P138 BK-18 AJ-C2 200-AK6 BK-18 B BK-18 135-0427
CAT DATA LINK +
CAT DATA LINK -
8
9
15
16
SWITCH RETURN
SENSOR RETURN
CONN 20 G946-P146
H746-P158
OR-18
YL-16
H747-P165
J765-P111
BR-16
BU-18 J765-P111 BU-18
922-P133 BR-18 176-P157 RD-14
179-P148 RD-18
150-P56
200-P14
RD-16
BK-14
AJ-C1
3E5179 629-AJ1 PK-14
1552269
629-AJ3 PK-14 1 LH LTBAR WORKLAMP
C WH-18
1 9 + CAT DATA LINK P-C52 P-C53 H747-P165 BR-16 921-P113 WH-18 177-P143 RD-6 200-P63 BK-18 403-P58 GN-18 1 200-AJ2 BK-14 200-AJ4 BK-14 2 161-3509
6 3 - CAT DATA LINK 3E3382 1552273 J765-P111 BU-18 126-P110 PK-14 200-P61 BK-14 2
KEY SWITCH "S" 64 18 1 L987-P175 WH-18 200-P13 BK-18 201-P122 BK-18 200-P60 BK-16 408-P119 WH-18 3 AK-C4
1552269
F F
7 33 XMSN FILTER BYPASS SW PRODUCT 2 M998-P6 OR-18 C436-P164 BU-18 921-P113 WH-18 200-P36 BK-14 410-P96 WH-18 4
10 12 AUTOSHIFT INDICATOR LINK 3 L987-P175 WH-18 R800-P159 OR-18 A429-P130 YL-18 205-P174 BK-18 F843-P112 YL-18 5 AJ-C3 611-AK1 PU-14 1 LTBAR LH HI BEAM HEADLAMP
22 27 INCHING PEDAL LIMIT SW N/O CONNECTOR 4 M998-P6 OR-18 P-C50 INCHING PEDAL POS SENSOR 201-P53 BK-16 417-P34 GY-18 6 1552269 200-AK8 BK-14 2 180-1300
11 10 XMSN SOL 3 5 R800-P159 OR-18 R998-P160 BR-18 F775-P51 BU-18 C436-P164 BU-18 556-P94 WH-16 1552267 147-1680 205-P138 BK-18 419-P121 YL-18 7 629-AJ5 PK-14 1 RH LTBAR WORKLAMP
12 4 XMSN SOL 1 6 F842-P147 BU-18 601-P156 GY-18 A OR-18 PWR (+24V) 403-P58 GN-18 439-P142 YL-18 8 200-AJ6 BK-14 2 161-3509
THROTTLE LOCK 44 17 XMSN SOL 2 R998-P160 BR-18 F843-P112 YL-18 605-P86 YL-18 B BK-18 GROUND 447-P128 PK-18 9
SPEED CENTER POSITION 23 11 XMSN SOL 8 CONN 19 F775-P51 BU-18 606-P87 GY-18 C WH-18 SIGNAL 408-P119 WH-18 10 AK-C6
THROTTLE HOLD 35 34 UX-C13 P-C34 G946-P146 OR-18 F842-P147 BU-18 608-P20 GN-14 P-C29 410-P96 WH-18 498-P100 WH-18 11 1552269
13 32 AUTOSHIFT SW 9X0141 9X1343 F843-P112 YL-18 611-P69 PU-14 1552269 570-P120 BU-16 12 611-AK2 PU-14 1 LTBAR RH HI BEAM HEADLAMP
14 36 INCH PEDAL LIMIT SW N/C 1 113-P91 OR-16 130-P54 RD-18 1 BK-18
STOP LAMP SWITCH
3E-2026
P-C27 LH BRAKE SYSTEM PRESS SW
114-9281 417-P34 GY-18 601-P154 GY-18 CONN 48 CONN 53 200-AK10 BK-14 2 180-1300
SPEED SET/ACCEL 40 2 - BATTERY 2 126-P1 PK-14 L987-P175 WH-18 G946-P146 OR-18 619-P70 GN-14 604-P68 OR-18 2 BK-18 1552269 419-P121 YL-18 605-P83 YL-18
16 5 - BATTERY 3 201-P107 BK-18 200-P106 BK-14 M998-P6 OR-18 685-P23 BR-14 488-P44 WH-18 1 BK-18 439-P142 YL-18 606-P80 GY-18 P-C17 AM-C1 AM-C2 AK-C1
SPEED RESUME/DECEL 41 37 NEUTRAL 4 205-P168 BK-18 200-P104 BK-16 2 BK-18 447-P128 PK-18 611-P39 PU-18 1552252 3E-5179 155-2252 3E5179 AK-C3
24 25 PARK 5 307-P17 OR-16 307-P17 OR-16 200-P105 BK-16 L987-P175 WH-18 P-C30 575-P77 YL-16 200-P36 BK-14 1 1 200-AK12 BK-14 605-AK5 YL-18 1552267
25 31 REVERSE 6 521-P116 YL-16 M998-P6 OR-18 1552269 570-P120 BU-16 893-P4 GN-18 2 2 619-AK3 GN-14 606-AK13 GY-18 A RD-18
FORWARD HORN SOL RH LTBAR TURN LAMP
THROTTLE LOCK IND 28 39 FORWARD 7 522-P97 WH-16 114-P47 RD-16 1 RD-18 RH BRAKE SYSTEM PRESS SW 576-P74 PK-16 892-P5 BR-18 605-P78 YL-18 3 3 605-AK5 YL-18 611-AK1 PU-14 200-AK9 BK-18 B BK-18 135-0427
34 13 EIGHTH 8 977-P11 YL-18 L987-P175 WH-18 322-P48 GY-16 2 RD-18 188-9250 P-C28 577-P75 PU-16 921-P113 WH-18 606-P79 GY-18 4 4 606-AK13 GY-18 200-AK6 BK-18 C WH-18
1552269 114-9281
AIH INDICATOR 30 19 SEVENTH 9 J764-P109 BR-18 601-P154 GY-18 922-P133 BR-18 629-P71 PK-14 5 5 200-AK7 BK-14
17 23 SIXTH 10 521-P116 YL-16 408-P119 WH-18 1 BK-18 605-P78 YL-18 A429-P130 YL-18 611-P33 PU-14 6 6 611-AK1 PU-14 200-AK8 BK-14
SWITCH RETURN 18 35 FIFTH 11 522-P97 WH-16 488-P44 WH-18 2 BK-18 605-P83 YL-18 C436-P164 BU-18 7 7 200-AK12 BK-14 200-AK9 BK-18
FUEL PUMP 19 29 FOURTH 12 8 8 AK-C7
200-P106 BK-14
200-P104 BK-16
200-P105 BK-16
601-P167 GY-18 606-P79 GY-18 611-P30 PU-14 611-AK2 PU-14 200-AK10 BK-14
20 20 THIRD 13 606-P80 GY-18 F842-P147 BU-18 9 9 200-AK11 BK-14 1552269
26 24 SECOND 14 611-P30 PU-14 G946-P146 OR-18 619-P38 GN-14 10 10 619-AK3 GN-14 619-AK4 GN-14 1 LTBAR RH LO BEAM HEADLAMP
29 30 FIRST 15 611-P33 PU-14 M998-P6 OR-18 11 11 200-AK11 BK-14 2 161-3509
PARK BRAKE PRESS SW
30 Page, Color 2,
31 26 REDUNDANT NEUTRAL 16 P-C15 611-P39 PU-18 118-P76 GY-16 619-P37 GN-14 12 12 619-AK4 GN-14 619-AK4 GN-14
1552269 114-9281
32 17 619-P37 GN-14 200-P14 BK-14 P-C37 611-AK2 PU-14
SHUTDOWN SW N/C 56 5 18 419-P121 YL-18 1 BK-18 P-C9 CENTERSHIFT PIN SOL 619-P38 GN-14 200-P60 BK-16 606-AK13 GY-18
152-8346 3E5179
SHUTDOWN SW N/O 54 6 19 921-P113 WH-18 201-P140 BK-18 2 BK-18 1552269 200-P36 BK-14
FAN DRIVE PRESS SENSOR 15 9 20 922-P108 BR-16 F775-P51 BU-18 1 GN-18 685-P21 BR-14
50 4 INCHING PEDAL POS SENSOR 21 977-P11 YL-18 200-P67 BK-18 2 GN-18 P-C6 575-P77 YL-16
FAN DRIVE SOL RETURN 51 11 22 C436-P164 BU-18 CENTERSHIFT INDICATOR SW 1552269 921-P113 WH-18 576-P74 PK-16
P-C10 HYD TEMP SWITCH
FAN DRIVE SOL 43 12 23 1 BK-18
200-P106 BK-14
200-P105 BK-16
200-P104 BK-16
C912-P161 GN-18 3E-3636 922-P133 BR-18 577-P75 PU-16
CONN 35 1552272 131-4135
E E
ANALOG SENSOR PWR 2 13 24 2 WH-18 A429-P130 YL-18 605-P78 YL-18
P-C25 K-C5 1 2
ANALOG SENSOR RETURN 3 15 25 F842-P147 BU-18 112-P145 PU-6 1 WH-18 WH-18 606-P79 GY-18
1275483 1275484 4 3 T
27 16 26 F843-P112 YL-18 118-P76 GY-16 439-P142 YL-18 4 WH-18 WH-18 C436-P164 BU-18 611-P30 PU-14
58 17 27 G946-P146 OR-18 135-P155 BU-16 112-P145 PU-6 1 112-K40 PU-6 169-P134 PK-18 3 F842-P147 BU-18 611-P33 PU-14
60 18 28 H746-P158 YL-16 2 G946-P146 OR-18
33 19 FILTER BYPASS IND 29 H747-P165 BR-16 176-P157 RD-14 CONN 34 M998-P6 OR-18 619-P37 GN-14
21 21 30 J764-P109 BR-18 205-P171 BK-18 P-C20 K-C3 P-C11 892-P5 BR-18 619-P38 GN-14
62 22 31 J765-P111 BU-18 210-P151 BK-18 1552252 3E5179 1552269 893-P4 GN-18 629-P71 PK-14
KEY SWITCH "ON" 70 32 32 308-P82 YL-16 118-P76 GY-16 1 118-K58 GY-16 127-P141 OR-16 1 GN-16 PARK BRAKE SOL 685-P21 BR-14
THROTTLE POSITION 66 26 33 L987-P175 WH-18 135-P155 BU-16 2 135-K35 BU-16 127-P141 OR-16 200-P72 BK-18 2 GN-16 188-9250
DIGITAL SENSOR RETURN 5 10 XMSN TEMP SENSOR 34 M998-P6 OR-18 506-P24 PU-16 3 144-K62 GN-16 200-P72 BK-18
DIGITAL SENSOR PWR 4 27 35 R800-P159 OR-18 507-P32 WH-16 176-P157 RD-14 4 176-K67 RD-14 108-K61 RD-16
68 28 36 5 108-K61 RD-16 112-K40 PU-6
SERVICE BRAKE SW 59 25 + XMSN OUTPUT SPEED SENSOR 2 37 R998-P160 BR-18 575-P77 YL-16 6 633-K63 BU-14 118-K58 GY-16
69 31 - XMSN OUTPUT SPEED SENSOR 2 38 576-P74 PK-16 205-P171 BK-18 7 205-K2 BK-18 135-K35 BU-16 FRONT FRAME GND BOSS 3
SOLENOID RETURN 67 33 39 447-P128 PK-18 577-P75 PU-16 210-P151 BK-18 8 210-K36 BK-18 176-K67 RD-14 (LH SIDE) M-C2
BATTERY (-) 65 3 SOL RETURN 2 40 578-P31 BU-16 308-P82 YL-16 9 308-K34 YL-16 210-K36 BK-18 1552269
BATTERY (-) 61 34 592-P152 BU-18 10 321-K15 BR-18 308-K34 YL-16 609-M1 YL-16 1 SNOW WING LAMP
BATTERY (-) 63 36 + XMSN INT SPEED SENSOR 2 601-P173 GY-18 506-P24 PU-16 11 506-K5 PU-16 592-K37 BU-18 200-M2 BK-16 2 153-2073
FUEL FILTER BYPASS SWITCH 49 UX-C19 30 - XMSN INT SPEED SENSOR 2 605-P84 YL-18 507-P32 WH-16 12 507-K7 WH-16 605-K31 YL-18
42 1552267 38 606-P85 GY-18 606-K32 GY-18
45 BK-18 A 24 + XMSN INT SPEED SENSOR 1 611-P52 PU-14 CONN 33 611-K57 PU-14
46 WH-18 C 35 - XMSN INT SPEED SENSOR 1 612-P28 GY-14 P-C7 K-C32 619-K59 GN-14
THROTTLE HOLD OFF 47 RD-18 B 39 619-P49 GN-14 3E5179 1552252 A513-K3 PK-18
29 + XMSN INPUT SPEED SENSOR 575-P77 YL-16 1 575-K8 YL-16
UX-C15 23 - XMSN INPUT SPEED SENSOR A513-P40 PK-18 576-P74 PK-16 2 576-K10 PK-16 144-K62 GN-16
1607689 GROUND LEVEL SHUTDOWN SW 40 577-P75 PU-16 3 577-K9 PU-16 205-K2 BK-18
J1 139-2116 20 + XMSN OUTPUT SPEED SENSOR 1 578-P31 BU-16 4 578-K6 BU-16 321-K15 BR-18
14 AWG 14 - XMSN OUTPUT SPEED SENSOR 1 592-P152 BU-18 5 592-K37 BU-18 506-K5 PU-16 LH HEATED MIRROR
2 XMSN SOL 7 307-P17 OR-16 601-P173 GY-18 6 601-K33 GY-18 507-K7 WH-16 K-C39
STRAP 7X-6315 1552269 192-1994
ENGINE BLOCK 8 XMSN SOL 5 521-P116 YL-16 605-P84 YL-18 7 605-K31 YL-18 575-K8 YL-16
1 XMSN SOL 6 522-P97 WH-16 606-P85 GY-18 8 606-K32 GY-18 576-K10 PK-16 K-C8 L C542-K66 GN-16 1 WH-16
1552273 ABBREV COLOR
7 XMSN SOL 4 977-P11 YL-18 611-P52 PU-14 9 611-K57 PU-14 577-K9 PU-16 200-K71 BK-16 2 BK-16
D GND
D
A503-K21 PK-16
A506-K22 OR-16
C542-K60 GN-16
144-K62 GN-16
321-K15 BR-18
576-K10 PK-16
601-K33 GY-18
612-K17 GY-14
117-K14 YL-14
118-K23 GY-16
141-K12 PK-16
148-K18 WH-16
151-K20 GN-16
160-K11 PU-16
162-K64 YL-14
200-K54 BK-14
500-K25 BR-16
501-K24 GN-16
502-K26 OR-16
37 BACKUP ALARM 10 N-C1 2 MOTOR H
205-K2 BK-18
506-K5 PU-16
507-K7 WH-16
575-K8 YL-16
577-K9 PU-16
578-K6 BU-16
119-K1 PK-16
J764-P109 BR-18 612-P28 GY-14 612-K17 GY-14 578-K6 BU-16 200-K45 BK-16 BK-16
633-K63 BU-14
9X1054 K-C40 RD RED
T-C1 UX-C1 619-P49 GN-14 11 619-K59 GN-14 601-K33 GY-18 1
XMSN SOL 3 (REVERSE)
145-1144
T-C2 3E5179 CONN 8 1552252 UX-C12 J2 A513-P40 PK-18 12 A513-K3 PK-18 612-K17 GY-14 117-N1 YL-14 1
86
30
108-K61 RD-16 501-K24 GN-16 4 GN-16 T 3E3364 WH
OR
WHITE
ORANGE
1552269 751-T1 GN-16 1 3E6287 633-K63 BU-14 647-N2 GN-18 5 112-K40 PU-6 118-K56 GY-16 6 GY-16 P
B+ K-C41 RH HEATED MIRROR YL YELLOW
8.5 GN-16 1 751-T1 GN-16 752-T3 YL-16 2 14 AWG 200-N3 BK-18 2 117-K14 YL-14 112-K40 PU-6 500-K25 BR-16 3 BR-16 200-K70 BK-16 192-1994 PK PINK
85 K-C31 1552269
GN-16 2 921-T2 WH-16 754-T5 BU-16 3 STRAP 7X-6315 612-N4 GY-14 4 118-K58 GY-16 118-K56 GY-16 117-K14 YL-14 502-K26 OR-16 5 OR-16 200-K71 BK-16 BK BLACK
87 1747566 WH-16
755-T7 OR-16 4 PLATFORM SHIFT CONSOLE RIGHT CAB HEADLINER 3 118-K23 GY-16 118-K55 GY-16 FRONT UPPER WIPER MOTOR C542-K66 GN-16 C542-K68 GN-16 1 GY GRAY
87a OVERHEAD FUSE
XMSN SOL 1 (FWD HIGH) 751-T1 GN-16 5 108-K61 RD-16 118-K55 GY-16 119-K1 PK-16 112-K40 PU-6 3E-6388 C542-K68 GN-16 200-K70 BK-16 2 BK-16 PU PURPLE
T-C3 BLOCK
145-1144 752-T3 YL-16 900-T9 PU-16 6 119-J5 PK-16 AUX BACKUP LAMP RELAY 112-K40 PU-6 119-K1 PK-16 141-K12 PK-16 K-C42 BR BROWN
1552269 K-C17
8.5 GN-16 1 752-T3 YL-16
754-T5 BU-16
755-T7 OR-16
901-T11 WH-16
902-T13 BR-16
7
8
200-J1 BK-16
200-J11 BK-16
200-J9 BK-16 3E-5239 118-K58 GY-16
135-K35 BU-16
135-K35 BU-16
141-K12 PK-16
148-K18 WH-16
151-K20 GN-16
BUSS
POINT 1 CONN 61 6T6505
3E3364 GN
BU
GREEN
BLUE
CONN 38
2 9 17
GN-16 921-T4 WH-16 900-T9 PU-16 903-T15 GY-16 200-J12 BK-16 176-K67 RD-14 148-K18 WH-16 160-K11 PU-16 508-K48 PU-18 + LH SPEAKER
10 K-C12 AR-C1 +24V IN -
C542-K60 GN-16
A506-K22 OR-16
A503-K21 PK-16
901-T11 WH-16 503-J7 BR-16 210-K36 BK-18 151-K20 GN-16 162-K64 YL-14 509-K49 WH-18 6T-7695
160-K11 PU-16
162-K64 YL-14
633-K63 BU-14
601-K33 GY-18
118-K23 GY-16
576-K10 PK-16
141-K12 PK-16
151-K20 GN-16
148-K18 WH-16
117-K14 YL-14
321-K15 BR-18
500-K25 BR-16
501-K24 GN-16
502-K26 OR-16
144-K62 GN-16
200-K54 BK-14
612-K17 GY-14
FRONT WIPERS AUX BACKUP LAMPS
205-K2 BK-18
507-K7 WH-16
119-K1 PK-16
578-K6 BU-16
506-K5 PU-16
575-K8 YL-16
577-K9 PU-16
GY-14
BK-18
GN-18
YL-14
902-T13 BR-16 921-T18 WH-16 11 504-J6 YL-16 308-K34 YL-16 160-K11 PU-16 118-K55 GY-16 15A 10A 1552269 3E3364 200-AR3 BK-12 GROUND K-C18
A504-J3 GN-16
A507-J2 YL-16
505-J8 BU-16
200-J9 BK-16
603-J4 PK-16
504-J6 YL-16
119-J5 PK-16
503-J7 BR-16
XMSN SOL 2 (FWD LOW)
609-M1 YL-16
200-M2 BK-16
T-C4 903-T15 GY-16 922-T17 BR-16 12 505-J8 BU-16 592-K37 BU-18 162-K64 YL-14 1 2 176-K67 RD-14 1 176-AR1 RD-14 6T8047 SYMBOL DESCRIPTION
145-1144 1552269 Y-C7
921-T6 WH-16 603-J4 PK-16 605-K31 YL-18 176-K67 RD-14 108-K61 RD-16 REAR WIPERS 308-K34 YL-16 2 308-AR2 YL-16 CAB GND BOSS 3 +12V OUT BLADE, SPADE, RING,
SNOW WING LAMP
200-N3
647-N2
117-N1
612-N4
3E7996
CONN 31
8.5 GN-16 1 754-T5 BU-16 921-T8 WH-16 A504-J3 GN-16 606-K32 GY-18 118-K56 GY-16 119-K1 PK-16 10A 10A K-C16 (UPPER CAB) K-C25
A 4 OR SCREW TERMINAL
J764-P109 BR-18
2 A M-C1 K-C35 3 1552269
129-P102 RD-18
134-P135 RD-16
144-P101 GN-16
205-P170 BK-18
308-P150 YL-16
570-P120 BU-16
601-P172 GY-18
F775-P51 BU-18
521-P116 YL-16
GN-16 921-T6 WH-16 921-T4 WH-16 921-T18 WH-16 601-Y15 GY-18 A507-J2 YL-16 K-C2 K-C1 N-C2 611-K57 PU-14 200-K52 BK-16 135-K35 BU-16 3E3364 IGNITION
105-P62 RD-16
124-P29 GN-14
136-P35 GN-16
169-P55 PK-16
201-P95 BK-18
403-P57 GN-18
410-P96 WH-18
417-P34 GY-18
462-P99 YL-18
728-P42 BU-18
307-P17 OR-16
522-P97 WH-16
977-P11 YL-18
921-T2 WH-16 205-Y18 BK-18 B 3E3364 1552272 3E5179 1552252 3E3376 619-K59 GN-14 200-K65 BK-16 200-K53 BK-16 176-K67 RD-14 619-K28 GN-14 1 LH CAB LO BEAM HDLAMP
B FRONT DEFROSTER MOLDBOARD LAMPS
922-T12 BR-16 169-Y20 PK-16 1 A513-K3 PK-18 200-K69 BK-16 200-K45 BK-16 141-K12 PK-16 10A 10A 24V TO 12V CONVERTER 3 200-K4 BK-14 2
CONN 39
XMSN SOL 8 (HIGH RANGE) 2 L-C14 L-C15 161-0908 CIRCUIT CONNECTED
CONN 37
T-C5 922-T10 BR-16 922-T17 BR-16 169-Y2 PK-16 2 J-C4 117-K14 YL-14 200-K69 BK-16 200-K52 BK-16 5 6 (COMMUNICATIONS RADIO)
186-1526 1552269 Y-C9 3E3364 3E3376 K-C6 CIRCUIT NOT CONNECTED
922-T14 BR-16 570-Y19 BU-16 3 3E3388 118-K23 GY-16 200-K71 BK-16 200-K53 BK-16 3E-8646
3 REAR DEFROSTER HEATED MIRRORS
10
11
12
10
11
12
3E7996 K-C26 3E3364 ELECTRICAL CONNECTION
1
2
3
4
5
6
7
8
1
2
1
2
3
4
5
6
7
8
9
7
8
6
4
3
5
9
1
2
1
2
3
4
31 GN-16 1 755-T7 OR-16 922-T16 BR-16 4 119-K1 PK-16 200-K70 BK-16 210-K36 BK-18 151-K20 GN-16 10A 10A
1
2
3
4
K-C36 NOTE D
CONN 32
A BEACON LAMP J-C5 J-C1 L-C1 7 8 1552269 TO MACHINE STRUCTURE
GN-16 2 921-T8 WH-16 5 601-Y40 GY-18 A 141-K12 PK-16 200-K4 BK-14 308-K34 YL-16
20
128-6983 3E3376
6 B 3E3364 1552269 1552264 1 LH CAB HI BEAM HDLAMP
C542-L62 GN-16
BLOWER SWITCH OPEN ROPS BEACON SW BLADE CUSHION SW 205-Y38 BK-18 148-K18 WH-16 200-K46 BK-14 200-K13 BK-14 500-K25 BR-16 611-K27 PU-14 INTERNAL ELECTRICAL
160-L45 PU-16
162-L63 YL-14
633-L64 BU-14
GY-14
609-L40 YL-16
200-L59 BK-16
BK-18
GN-18
YL-14
B
CONN 36
A504-L3 GN-16
A507-L2 YL-16
576-L29 PK-16
148-L22 WH-16
612-L21 GY-14
L-C3
A503-L12 PK-16
200-L60 BK-16
BK-18
PK-16
151-L15 GN-16
A506-L11 OR-16
117-L13 YL-14
321-L19 BR-18
578-L28 BU-16
506-L35 PU-16
500-L34 BR-16
501-L37 GN-16
575-L33 YL-16
502-L36 OR-16
577-L30 PU-16
144-L32 GN-16
200-L61 BK-14
GY-18
GY-16
WH-16
505-L6 BU-16
603-L4 PK-16
504-L8 YL-16
119-L5 PK-16
503-L7 BR-16
L-C19
141-L9 PK-16
6P-3236 AE-C4 222-1536 C 9X-9629 1 BULB RD-16 1 603-J4 PK-16 L-C13 L-C2 L-C11 151-K20 GN-16 200-K16 BK-14 501-K24 GN-16 ANTENNA 200-K19 BK-14 2 157-0305 CONNECTION TO SURFACE
XMSN SOL 4 (2ND) T-C6 3E7996 2 9X-7849 3E3376 3E5179 9 10
186-1526 D J764-Y8 BR-18 2 BK-16 2 200-J12 BK-16 1552269 1552252 1552272 160-K11 PU-16 200-K47 BK-14 200-K19 BK-14 502-K26 OR-16 ANTENNA 8E-1118 OF COMPONENT
1552269 A A 977-Y30 YL-18 3 162-K64 YL-14 592-K37 BU-18 K-C15 WH/BK-18 LH FRONT SPKR - CABLE AS. K-C9 K-C19 CONNECTOR
612-L21
200-L58
647-L18
117-L14
3
205-L56
119-L24
601-L57
118-L41
507-L27
31 GN-16 1 900-T9 PU-16 B Y-C8 4 500-K25 BR-16 200-K39 BK-16 A513-K3 PK-18 1552264 GN/BK-18 LH REAR SPKR - 9W-3073 1552267 3E3364
B 1 3E7996 J-C6 J-C2 12 ATCH WIRE, CABLE &
GN-16 2 922-T10 BR-16 1 5 L 501-K24 GN-16 200-K41 BK-18 11 509-K49 WH-18 1 WH-18 LH FRONT SPKR + 605-K31 YL-18 A RD-18 LH CAB TURN LAMP COMPONENT
1 2 A 3E3382 1552273
124-H8 GN-14 2 601-Y21 GY-18 A 6 AUTOSHIFT SWITCH GND 502-K26 OR-16 200-K51 BK-16 200-K45 BK-16 508-K48 PU-18 508-K48 PU-18 2 GN-18 LH REAR SPKR + 200-K41 BK-18 B BK-18 135-0427
2 3 L# CIRCUIT GROUPING
3 B C 102-9861 H MOTOR BK-16 2 3 C
129-P102 RD-18
521-P116 YL-16
200-P103 BK-14
601-P172 GY-18
134-P135 RD-16
F775-P51 BU-18
308-P150 YL-16
570-P120 BU-16
205-P170 BK-18
144-P101 GN-16
C C
521-H9 YL-16 205-Y22 BK-18 200-J11 BK-16 A503-K21 PK-16 200-K44 BK-18 509-K49 WH-18 210-K36 BK-18 BK-18 GROUND WH-18
J764-P109 BR-18
522-P97 WH-16
124-P29 GN-14
105-P62 RD-16
307-P17 OR-16
169-P55 PK-16
136-P35 GN-16
403-P57 GN-18
XMSN SOL 6 (1ST) T-C7 5 4 B DESIGNATION
977-P11 YL-18
462-P99 YL-18
201-P95 BK-18
410-P96 WH-18
728-P42 BU-18
417-P34 GY-18
4 1 D 1 A506-K22 OR-16 511-K43 BR-18 13 14 4 YL-18 NC K-C22
186-1526 1552269 THERMOSTAT SW 4 5 2 T
5 6 169-Y2 PK-16 2 GN-16 4 504-J6 YL-16 C542-K60 GN-16 210-K36 BK-18 512-K42 GN-18 (7) 10A FUSES A513-K3 PK-18 5 YL-18 B+ MEMORY 12V 3E3370
3E-5464 3
31 GN-16 1 901-T11 WH-16 6 F775-Y17 BU-18 3 P GY-16 6 119-J5 PK-16 200-K46 BK-14 308-K34 YL-16 9W-1442 592-K37 BU-18 6 RD-18 B+ 12V
C 3 B+
BK-14
BK-16
BK-16
118-L41 GY-16
119-L24 PK-16
BK-18
205-L56 BK-18
601-L57 GY-18
16
117-L13 YL-14
15
117-L14 YL-14
119-L5 PK-16
GN-16 2 922-T12 BR-16 522-H10 WH-16 200-H7 BK-16 C 4 BR-16 3 503-J7 BR-16 200-K47 BK-14 500-K25 BR-16 512-K42 GN-18 (1) 15A FUSES 512-K42 GN-18 7 GY/BK-18 RH FRONT SPKR -
T D 5 Y-C11 OR-16 5 505-J8 BU-16 200-K51 BK-16 501-K24 GN-16 511-K43 BR-18 9W-1441 511-K43 BR-18 8 PU/BK-18 RH REAR SPKR - FRT DEFROST RES
D P-C12 3E7996 BUSS AM/FM RADIO
H-C7 H-C6 6 CENTERSHIFT PIN SW 7T-4003
CONN 13
XMSN SOL 5 (3RD) 200-K52 BK-16 502-K26 OR-16 509-K49 WH-18 GY-18 RH FRONT SPKR +
CONN 14
1552252 REAR WIPER POINT 2 18 173-6530
CONN 15
200-L61
200-L60
T-C8 6T6505 6T6505 K-C4 K-C24 K-C23
200-L59
200-L58
186-1526 C 9X-9634 601-Y27 GY-18 A 3E-6388 200-K65 BK-16 592-K37 BU-18 508-K48 PU-18 PU-18 RH REAR SPKR +
1552269 P-C14 D B J-C7 J-C3 3E3388 6T6505 6T6505
OPEN ROPS BEACON LAMP P-C13 205-Y31 BK-18 200-K46 BK-14 605-K31 YL-18 200-K4 BK-14 AM/FM CASSETTE
A503-L12 PK-16
A506-L11 OR-16
C542-L62 GN-16
3E3382
NORMAL
144-L32 GN-16
148-L22 WH-16
151-L15 GN-16
321-L19 BR-18
500-L34 BR-16
576-L29 PK-16
578-L28 BU-16
609-L40 YL-16
A507-L2 YL-16
160-L45 PU-16
162-L63 YL-14
633-L64 BU-14
501-L37 GN-16
502-L36 OR-16
506-L35 PU-16
507-L27 WH-16
575-L33 YL-16
577-L30 PU-16
647-L18 GN-18
A504-L3 GN-16
1 128-6983 1 3E3364 1552269 K-C13
141-L9 PK-16
503-L7 BR-16
504-L8 YL-16
505-L6 BU-16
603-L4 PK-16
31 GN-16 902-T13 BR-16 3E5179 719-Y36 GY-18 200-K47 BK-14 606-K32 GY-18 200-K13 BK-14 173-6532 A503-K21 PK-16
HVAC PANEL LAMP
TEST
10
11
12
10
11
12
1552267
GY-18
BK-18
1
2
3
4
5
6
1
2
3
4
5
6
7
8
9
1
2
3
4
5
6
7
8
9
2 2 1
PK-16
GN-16 922-T14 BR-16 BULB G939-Y45 PK-18 MOTOR BK/RD-16 A507-J10 YL-16 200-K51 BK-16 200-K16 BK-14 160-K11 PU-16
GN-16
8D-1429 Y-C6 Y-C10 3 2 A
9X-7849 911-Y48 YL-18 BK-16 200-J1 BK-16 200-K52 BK-16 611-K57 PU-14 611-K27 PU-14 200-K19 BK-14 162-K64 YL-14 108-K61 RD-16 RD-18 A506-K22 OR-16
RD-16
BK-16
Y-C3 Y-C4 1552252 3E7996 DOME LAMP
XMSN SOL 7 (LOW RANGE) 517-H3 BU-14 823-Y37 GN-18 4 200-K65 BK-16 611-K30 PU-14 200-K39 BK-16 148-K18 WH-16 C WH-18 3E-6389 A506-K50 OR-16
T-C9 1552273 3E5179 A A 5 FRONT DEFROST FAN
B
601-AE2
205-AE3
G939-Y45 PK-18
F775-Y17 BU-18
516-H2 GN-14 601-Y23 GY-18 911-Y48 YL-18 200-K54 BK-14 200-K41 BK-18 117-K14 YL-14 200-K53 BK-16 BK-18
603-AE7
144-AE4
521-Y26 YL-16
522-Y25 WH-16
200-Y47 BK-14
200-Y51 BK-14
105-Y10 RD-16
134-Y16 RD-16
570-Y19 BU-16
169-Y20 PK-16
144-Y13 GN-16
YL-18
YL-18
GN-16
BK-18
BR-18
BU-18
GY-18
GN-18
118-L23 GY-16
601-Y44 GY-18
136-Y53 GN-16
403-Y56 GN-18
BK-18
WH-18
BU-18
GY-18
186-1526 H-C2 170-5334
129-Y6 RD-18
124-Y1 GN-14
307-Y9 OR-16
308-Y3 YL-16
RESISTOR
200-L20 BK-16
200-L42 BK-16
1552269 205-Y24 BK-18 B 718-Y35 BU-18 6 REAR DEFROST FAN 619-K59 GN-14 619-K29 GN-14 200-K44 BK-18 K-C11 K-C34
200-L1 BK-16
118-L31 GY-16
119-L25 PK-16
BK-18
BK-18
BK-18
BK-18
BK-18
GY-18
GY-18
GY-18
GY-18
GY-18
117-L17 YL-14
118-L38 GY-16
118-L39 GY-16
119-L26 PK-16
3T3158 B
31 GN-16 1 903-T15 GY-16 UX-C9 H-C3 H-C4 1 C 170-4820 J-C8 7T4003 J-C9 619-K28 GN-14 200-K70 BK-16 1552269 3E3364
1
2
2 3E3370 6T6505 6T6505 AE-C2 2 2 D 6T6505 6T6505 K-C14 AP-C1 1
GN-16 922-T16 BR-16 134-Y16 RD-16 200-K71 BK-16 AP-C2 A506-K50 OR-16 BK/RD-16 MOTOR
977-Y30
462-Y32
727-Y33
201-Y29
205-Y34
410-Y28
J764-Y8
718-Y35
719-Y36
823-Y37
728-Y55
417-Y57
PWR (+24) OR-16 A 601-H11 GY-18 200-H6 BK-18 515-H1 GY-14 1552269 727-Y50 GN-16 3 A503-K21 PK-16 605-K31 YL-18 1552269 3E3364 7T5957 200-K39 BK-16 2 BK-16
205-L52
205-L51
205-L50
205-L49
205-L47
601-L55
601-L54
601-L53
601-L43
601-L48
603-AE7 PK-16
C
200-AE1 BK-16
B 4 3 1
GROUND BK-16 515-H4 GY-14 A507-J2 YL-16 A506-K22 OR-16 606-K32 GY-18 135-K35 BU-16 135-AP1 BU-16 12V POWER PORT
SIGNAL WH-16 C 5 10 A513-K3 PK-18 611-K27 PU-14 200-K52 BK-16 2 200-AP2 BK-16 K-C10
H-C5 D 117-2311
200-H5 BK-14
2 6 A504-J3 GN-16 611-K30 PU-14 K-C7 1552267
XMSN TEMP SENSOR 6T6505 RESISTOR H
3E-8700
9G-1950
462-Y32
200-Y46
YL-18
BK-18
C
D
C542-K60 GN-16 C542-K66 GN-16
C542-K68 GN-16
619-K28 GN-14
619-K29 GN-14
CONN 60
3E3364 606-K32 GY-18
200-K44 BK-18
A
B
RD-18
BK-18
RH CAB TURN LAMP
135-0427
CONN 4 H-C1 SECONDARY STER TEST SW 601-W29 GY-18
W-C7
3E7996
A503-K21 PK-16
A506-K22 OR-16
C WH-18
200-K51 BK-16
200-K65 BK-16
200-K52 BK-16
200-K47 BK-14
200-K46 BK-14
200-K54 BK-14
K-C33
A503-L12 PK-16
A506-L11 OR-16
C542-L62 GN-16
144-L32 GN-16
151-L15 GN-16
205-L50 BK-18
205-L51 BK-18
205-L52 BK-18
601-L53 GY-18
601-L54 GY-18
601-L55 GY-18
A504-L3 GN-16
A507-L2 YL-16
118-L23 GY-16
118-L31 GY-16
118-L38 GY-16
118-L39 GY-16
119-L26 PK-16
501-L37 GN-16
506-L35 PU-16
575-L33 YL-16
577-L30 PU-16
200-L20 BK-16
200-L42 BK-16
119-L25 PK-16
500-L34 BR-16
502-L36 OR-16
507-L27 WH-16
576-L29 PK-16
578-L28 BU-16
1552269 AE-C1 Y-C2
117-L17 YL-14
148-L22 WH-16
160-L45 PU-16
162-L63 YL-14
205-L47 BK-18
205-L49 BK-18
321-L19 BR-18
601-L43 GY-18
601-L48 GY-18
609-L40 YL-16
633-L64 BU-14
647-L18 GN-18
141-L9 PK-16
603-L4 PK-16
503-L7 BR-16
505-L6 BU-16
200-L1 BK-16
9X-9633
504-L8 YL-16
205-Y31 BK-18 601-W31 GY-18 A L-C18 C542-K66 GN-16 3E3370
1 WH/RD-14 MOTOR 3E3376 1552272 205-Y38 BK-18 205-W32 BK-18 A C542-K68 GN-16 K-C27
BEACON SWITCH L-C4 3E7996 1552269
200-H12 BK-14 2 BK-14 1 200-Y12 BK-16 601-Y40 GY-18 205-W30 BK-18 B
200-Y47 BK-14
205-Y34 BK-18
601-Y44 GY-18
727-Y33 GN-16
B 1 222-1536
308-Y3 YL-16
2 205-Y11 BK-18 601-Y27 GY-18 C975-W24 WH-18 1 3E7996 601-L68 GY-18 A 611-K30 PU-14 1 RH CAB HI BEAM HDLAMP
3 601-Y5 GY-18 718-Y35 BU-18 J766-W33 PU-18 2 A A 601-L55 GY-18 205-L67 BK-18 B 200-K16 BK-14 2 157-0305
2 3
BLOWER 4 144-Y13 GN-16 719-Y36 GY-18 J766-W34 PU-18 3 B B 205-L50 BK-18 1
174-1494 4 1 K-C20
Y-C13 823-Y37 GN-18 R914-W36 OR-18 4 1 160-L45 PU-16 2
3E3376 CONN 11 977-Y30 YL-18 T914-W37 OR-18 5
2
2 144-L32 GN-16 C542-L62 GN-16 3 2 3 3E3364
B 5 3
B
200-Y51 BK-14
6 3 4 K-C28
F775-Y17 BU-18
G939-Y45 PK-18 R914-W36 OR-18 603-L4 PK-16
G939-Y45 PK-18
105-Y10 RD-16
134-Y16 RD-16
136-Y53 GN-16
144-Y13 GN-16
GY-18
169-Y20 PK-16
GN-18
YL-16
WH-16
718-Y35 BU-18
728-Y55 BU-18
J764-Y8 BR-18
BU-16
YL-18
719-Y36 GY-18
823-Y37 GN-18
977-Y30 YL-18
4
410-Y28 WH-18
C 6
201-Y29 BK-18
124-Y1 GN-14
307-Y9 OR-16
CONN 59 3E3382
129-Y6 RD-18
H-C8 Y-C1 J764-Y8 BR-18 A983-W25 BU-18 C 4 5 1552269
1552273 5 HEATED MIRRORS SW
601-W29 GY-18 D 6 5 6 619-K29 GN-14 1 RH CAB LO BEAM HDLAMP
1 SHIFT LEVER PANEL LAMP D 6 C 123-5858 2
124-H8 GN-14 124-Y1 GN-14 601-W4 GY-18 FRONT UPPER WIPER SWITCH 200-K13 BK-14 161-0908
403-Y56
417-Y57
521-Y26
522-Y25
570-Y19
462-Y32
2 7N-5876 C C D
205-W30 BK-18 112-6174 CAB GND BOSS 2
200-H12 BK-14 3 200-Y51 BK-14 205-W21 BK-18 D (NOTE B) K-C21
200-Y39 BK-16
200-Y46 BK-18
200-Y43 BK-18
200-Y12 BK-16
205-Y42 BK-18
205-Y11 BK-18
205-Y18 BK-18
205-Y24 BK-18
205-Y22 BK-18
205-Y31 BK-18
205-Y38 BK-18
601-Y41 GY-18
601-Y15 GY-18
601-Y23 GY-18
601-Y21 GY-18
601-Y27 GY-18
601-Y40 GY-18
727-Y50 GN-16
727-Y49 GN-16
Y-C14 D L-C17 (CAB FRONT)
200-Y7 BK-18
601-Y5 GY-18
601-Y4 GY-18
308-Y54 YL-16
308-Y52 YL-16
521-H9 YL-16 4 521-Y26 YL-16 FRONT UPPER WIPER SW K-C29 3E3364
3T3158 3E-0155 3E7996 6T6505
522-H10 WH-16 5 522-Y25 WH-16 183-2151 601-L66 GY-18
(NOTE C)
601-Y41 GY-18
205-Y42 BK-18
601-H11 GY-18 6 601-Y4 GY-18 L-C7 601-L68 GY-18 A 511-K43 BR-18 + RH SPEAKER
W-C8 L-C5 1552264 H B B B - 6T-7695
Y-C12 RD-14 WIPER B+ 205-L67 BK-18 512-K42 GN-18
LIGHT DUTY HEATER GP 174-4547 3E7996 3E7996 118-L39 GY-16 1 RD-16 RD-18 WASHER B+ 205-L65 BK-18 1 K-C30
3E3382
OR 601-W4 GY-18 A 118-L38 GY-16 2 RD-16 BK-18 GROUND 162-L63 YL-14 2 3 6T8047
UX-C6 W-C4 Y-C16 Y-C15 A A 2
HEATER GP 173-5322 601-W22 GY-18 B 200-L42 BK-16 3 WH-14 HIGH 633-L64 BU-14 3
3E5179 CONN 5 1552252 OR 3E5179 1552252 205-W21 BK-18 B B 1
1
2 1 A507-L2 YL-16 502-L36 OR-16 4 WH-16 L YL-14 LOW 4 WIRE GROUP COLOR DESCRIPTIONS THIS SCHEMATIC IS FOR 12H
1
2
E937-W10 PU-18
E938-W11 OR-18
AC GP 174-4548 + BATTERY RD-18
GROUND BK-18
1
2 200-Y14 BK-18
1
2
136-Y53 GN-16
200-Y39 BK-16
205-W23 BK-18
C979-W26 OR-18
1
2
2 3 2
3
151-L15
569-L10
GN-16
PK-16
501-L37
500-L34
GN-16
BR-16
5
6
YL-16
BU-16
P W BU-14
BR-18
PARK
WASH
5
6 MOLDBOARD LAMPS SW
MOTOR GRADERS (172-9934 CHG 00).
3 E939-W12 WH-18 (THERMOSTAT SW INCLUDED W/ A/C GP ONLY) KEY SW YL-18 3 3 308-Y54 YL-16 J766-W34 PU-18 3
3 4
4 A504-L3 GN-16 506-L35 PU-16 7 BR-16 UNUSED C 123-5847 WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS OFF.
4 5
4 E940-W13 BU-18 UNUSED OR-18 4 SECONDARY STEERING 4 A982-W27 BR-18 4 6 5 569-L10 PK-16 8 D
5 WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS ON.
5 E941-W14 YL-18 GROUND BU-18 5 JUMPER PLUG 5 200-Y7 BK-18 A755-W35 PK-18 5 6 FRONT LOWER WIPER SWITCH
6 L-C12
6 199-8382 6 6 C
G939-Y45 PK-18
F775-Y17 BU-18
E942-W15 GN-18 STEER SW PU-18 6 728-Y55 BU-18 A982-W27 BR-18 601-L54 GY-18 112-6174
105-Y10 RD-16
144-Y13 GN-16
200-Y12 BK-16
200-Y39 BK-16
200-Y43 BK-18
200-Y51 BK-14
205-Y11 BK-18
308-Y54 YL-16
308-Y52 YL-16
403-Y56 GN-18
417-Y57 GY-18
521-Y26 YL-16
522-Y25 WH-16
728-Y55 BU-18
169-Y20 PK-16
200-Y46 BK-18
205-Y18 BK-18
205-Y22 BK-18
205-Y24 BK-18
205-Y31 BK-18
205-Y38 BK-18
205-Y42 BK-18
462-Y32 YL-18
570-Y19 BU-16
601-Y15 GY-18
601-Y21 GY-18
601-Y23 GY-18
601-Y27 GY-18
601-Y40 GY-18
601-Y41 GY-18
719-Y36 GY-18
823-Y37 GN-18
977-Y30 YL-18
136-Y53 GN-16
727-Y49 GN-16
134-Y16 RD-16
718-Y35 BU-18
727-Y50 GN-16
J764-Y8 BR-18
C 3E7996
124-Y1 GN-14
200-Y7 BK-18
307-Y9 OR-16
601-Y4 GY-18
601-Y5 GY-18
129-Y6 RD-18
7 E943-W16 BR-18 UNUSED BR-18 7 7 205-W32 BK-18 C978-W28 BR-18 C D 205-L51 BK-18 (NOTE B) FRONT LOWER WIPER SW 601-L66 GY-18 VOLTAGE CONVERTER OUTPUT CIRCUIT.
8 E944-W17 GY-18 ALTERNATOR 'R' WH-18 8 8 403-Y56 GN-18 601-W31 GY-18 601-W22 GY-18 D 3E-0155 601-L48 GY-18 A
D (NOTE C)
9 E945-W18 PU-18 UNUSED PK-18 9 9 A755-W35 PK-18 205-W23 BK-18 205-L49 BK-18 B STARTING CIRCUIT.
10 E946-W19 OR-18 RELAY GN-18 10 10 727-Y49 GN-16 A983-W25 BU-18 L-C8 RD-14 WIPER B+ 205-L65 BK-18 1
11 11 11 1552264 H B B 2
E947-W7 WH-18 MONITOR PANEL GY-18 200-Y14 BK-18 417-Y57 GY-18 C975-W24 WH-18 REAR DEFROST SW RD-18 WASHER B+ 148-L22 WH-16
12 E948-W8 BU-18 NC 12 12 C978-W28 BR-18 THROTTLE SPEED SET SW 9X-9638 118-L23 GY-16 1 RD-16 BK-18 GROUND 609-L40 YL-16 3 GROUND CIRCUIT.
185-2197 2 4
UX-C5 W-C3 SECONDARY STEERING CONTROL CONN 12 C979-W26 OR-18
J766-W33 PU-18 L-C6
118-L31
200-L20
GY-16
BK-16 3
RD-16 WH-14
YL-14
HIGH
LOW 5 SNOW WING LAMP SW STARTING AID CIRCUIT.
1552252 CONN 6 3E5179 132-6640
T914-W37 OR-18 3E7996 577-L30 PU-16 4 WH-16 L BU-14 PARK 6 123-5847
1 W-C2 A 5 C
E937-W10 PU-18
E938-W11 OR-18
E939-W12 WH-18
E940-W13 BU-18
E941-W14 YL-18
E942-W15 GN-18
E943-W16 BR-18
E944-W17 GY-18
E945-W18 PU-18
E946-W19 OR-18
E949-W9 YL-18 113-W2 OR-16 576-L29 PK-16 YL-16 BR-18 WASH CATERPILLAR MONITORING SYSTEM CIRUIT.
E947-W7 WH-18
E948-W8 BU-18
E949-W9 YL-18
126-W20 PK-16
P W
202-W3 BK-16
2 113-W2 OR-16 Y-C17 201-W1 BK-18 9W1951 B 575-L33 YL-16 6 BU-16 UNUSED D
R 1552272 1
3 126-W20 PK-16 892-W5 BR-18 113-W2 OR-16 A 1 A506-L11 OR-16 578-L28 BU-16 7 BR-16
A RH STOP TAIL LAMP
135-0426 AG-C4
4
5
201-W1 BK-18
202-W3 BK-16
OFF C YL-16
PU-16
1
2
308-Y52 YL-16 893-W6 GN-18
126-W20 PK-16
201-W1 BK-18 B
C
3
2
2
3
141-L9 PK-16
567-L16 WH-16
8 L-C10
3E7996
AUX BACKUP LAMP SW
161-1415
ENGINE CONTROL CIRCUIT.
A
1552267 ON S 4 TRANSMISSION / ENGINE PUMP CONTROL CIRCUIT.
6 892-W5 BR-18 ST B OR-16 3 307-Y9 OR-16 202-W3 BK-16 893-W6 GN-18 D SERVICE TOOL 5 4 A503-L12 PK-16 REAR WIPER SWITCH 601-L43 GY-18
S RD-18 A 604-AG3 OR-18 7 893-W6 GN-18 BR-16 4 105-Y10 RD-16 E937-W10 PU-18 892-W5 BR-18 E CONNECTOR 5 567-L16 WH-16 L-C9 L-C16 601-L44 GY-18 A
6 1552264 3E3388 3E-0155
G BK-18 B 200-AG9 BK-18 8 A983-W25 BU-18 KEY SWITCH ACTION ALARM
Y-C5
E938-W11 OR-18 W-C1 F SERVICE TOOL CONN CAP 6 205-L47 BK-18 B HEATER AND AIR CONDITIONER CIRCUIT.
T WH-18 C 614-AG8 PU-18 9 C975-W24 WH-18 200-Y43 BK-18 3E-6328 E939-W12 WH-18 7X6222 G 8C-6354 C 601-L53 GY-18 119-L25 PK-16 1 RD-14 WIPER B+ 205-L46 BK-18 1
10 110-7887 1552269 H D 2 RD-18 2
C978-W28 BR-18 129-Y6 RD-18 E940-W13 BU-18 205-L52 BK-18 119-L26 PK-16 WASHER B+ 321-L19 BR-18 TURN SIGNAL/WIPER/WASHER CIRCUIT.
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
1
2
3
4
5
6
7
8
9
11 A755-W35 PK-18 RD-16 1 410-Y28 WH-18 E941-W14 YL-18 J 200-L1 BK-16 3 BK-18 GROUND 647-L18 GN-18 3
RH REAR TURN LAMP 12 C979-W26 OR-18 BK-16 2 201-Y29 BK-18 E942-W15 GN-18 505-L6 BU-16 4 WH-14 HIGH 117-L17 YL-14 4
AG-C5 CONN 30
RED NEUT
GROUND
FIRST
SECOND
THIRD
FOURTH
FIFTH
SIXTH
SEVENYH
EIGHTH
FORWARD
REVERSE
PARK
NEUTRAL
BATTERY(+)
135-0427 E943-W16 BR-18 504-L8 YL-16 5 YL-14 LOW 5
1552267 UX-C8 W-C5 Y-C18 CIGAR LIGHTER E944-W17 GY-18 XMSN SHIFTER FRONT DEFROST SW 503-L7 BR-16 6 BU-14 PARK 6
RD-18 A 606-AG6 GY-18 1552272 CONN 7 3E3376 8T9670 9W-0335 E945-W18 PU-18 180-3531 9X-9638 507-L27 WH-16 7 BR-18 WASH 601-L44 GY-18 C
BK-18 B 200-AG10 BK-18 1 205-W32 BK-18 Y-C19 E946-W19 OR-18 8 UNUSED 205-L46 BK-18 D
WH-18 C 2 601-W31 GY-18 6T6505 E947-W7 WH-18
AG-C7 3 J766-W33 PU-18 E948-W8 BU-18 LOWER CAB SWITCH PANEL UPPER CAB SWITCH PANEL
3E3370 CONN 77 4 T914-W37 OR-18 E949-W9 YL-18
SHIFT CONSOLE
18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
Component Identifiers (CID) Wire Description Component Location Electrical Schematic Symbols And Definitions
Module Identifier (MID) Wire Wire
Description
Wire Wire
Description Component
Schematic Machine
Component
Schematic Machine RENR9555-01
Number Color Number Color Location Location Location Location
Caterpillar Monitoring System November 2009
Power Circuits Lighting Circuits (cont'd) Air Dryer K-13 1 Power Port - 12V C-3 14
(MID No. 030)
101 RD Bat (+) 614 PU Tail Lamps Air Inlet Heater J-14 35 Radio - AM/FM Cassette C-3 15 T
CID Component
Alarm - Action A-14 C Receptacle - Aux. Start K-13 1 Circuit Breaker
0096 Fuel Level Sender 102 RD Headlamp Breaker 617 BR Not Used Pressure Temperature Level Flow
Alarm - Backup L-18 2 Relay - Air Inlet Heater J-14 33 Symbol
0248 Data Link 103 RD Tail Lamps/Panel Lamps 618 YL Not Used Symbol Symbol Symbol Symbol
0263 Sensor Power Supply Alternator J-13 3 Relay - Aux. Backup Lamp D-8 16
105 RD Key SW 619 GN Head Lamp (Low)
0271 Action Alarm Antenna - AM/FM Radio C-3 4 Relay - Cab Floodlamps K-8 B
106 RD Battery #1 To Battery #2 629 PK Lightbar Worklamp
0324 Action Lamp Arc Suppressor AC Clutch G-15 5 Relay - Fuel Pump H-14 7 Normally open switch that will close with an increase of a specific condition (temp-press-etc.).
108 RD Dome Lamp 633 BU Moldboard Lamps The circle indicates that the component has screw terminals and a wire can be disconnected from it.
0615 Position Sensor (Articulation Angle) Arc Suppressor Differential Unlock K-16 6 Relay - LH Position Lamps K-8 B
109 RD Alt Output (+) Term. 647 GN Aux Backup Lamp SW
0819 Display Data Link Batteries - 12 Volt I-13 7 Relay - Main H-13 7
112 PU Main Power Relay Output 685 BR Blade Floodlamps Normally closed switch that will open with an increase of a specific condition.
0821 Display Power Supply Beacon C-11 4 Relay - Position Lamps Coupler J-8 B
113 OR Opr Mon Panel B (+) Switched Control Circuits
No circle indicates that the wire cannot be disconnected from the component.
Electronic Engine Control System Beacon - Open Rops C-15 4 Relay - RH Position Lamps J-8 B
(MID No. 036) 114 RD Warning Horn (Forward) 718 BU Not Used Block - B+ Junction I-14 7 Relay - Secondary Steering J-13 12 This indicates that the component has a wire connected to it that is connected to ground.
CID Component 115 RD Lightbar Worklamp Breaker 719 GY Not Used Breaker - Alternator H-13 7 Relay - Starter H-13 7
0001 Injector Cylinder Solenoid #1 116 BR Floodlamp SW 727 GN Secondary Steering Motor Relay Breaker - Engine Control G-13 7 Resistor - Front Defroster C-2 24
0002 Injector Cylinder Solenoid #2 117 YL Aux Backup Lamp 728 BU Primary Steering Pressure SW Breaker - Headlamp/RH Position Lamps G-13 7 Resistor - Heater/AC B-16 E
0003 Injector Cylinder Solenoid #3
This indicates that the component does not have a wire connected to ground. It is grounded by
118 GY Front Wipers 751 GN XMSN Shift Solenoid #3 Breaker - Turn/Hazard/LH Position Lamps G-13 7 Resistor - Panel Lamp K-4 B being fastened to the machine.
0004 Injector Cylinder Solenoid #4 Breaker - Main H-13 7 Resistor - Rear Defroster C-10 11
119 PK Rear Wipers 752 YL XMSN Shift Solenoid #1
0005 Injector Cylinder Solenoid #5
122 BU Air Dryer 754 BU XMSN Shift Solenoid #2 Cap - Service Tool Connector A-11 C Resistor - Secondary Steering K-13 12
0006 Injector Cylinder Solenoid #6
124 GN A/C 755 OR XMSN Shift Solenoid #8 Control - Engine ECM I-18,D-18 8 Sender - Articulation Angle H-11 17 Reed Switch - A switch whose contacts are controlled by a magnet. A magnet closes the
0041 ECM 8 Volt DC Supply contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.
126 PK XMSN Control A746 PK Turbo Outlet Pressure Sensor Control - Secondary Steering A-15 E Sender - Coolant Temperature J-15 3
0042 Injector Actuation Pressure
Control - Transmission D-14,F-14 E Sender - Fuel Level G-14 8
0091 Throttle Sensor 127 OR Park Brake Solenoid A747 GY ATM Pressure Sensor
Converter - 24V To 12V (Comm. Radio) D-3 D Sender - Inlet Air Temperature J-15 18
0100 Oil Pressure Sensor 129 RD Lighter A755 PK Throttle Speed Set SW
Converter - 24V TO 12V (Entertain. Radio) L-9 9 Sender - Oil Temperature End I-14 34 Sender - A component that is used with a temperature or pressure gauge. The sender measures
0110 Engine Coolant Temperature Sensor 130 RD Stop Lamp Pressure SW E708 PK Opr Mon Display Module Clock the temperature or pressure. Its resistance changes to give an indication to the gauge of the
Converter - 24V TO 12V (Power Port) L-11 9 Sender - Oil Temperature Middle I-14 35
0164 High Injector Actuation Pressure 134 RD Secondary Steering Test SW E735 PU Operator Mode SW T temperature or pressure.
12H Motor Grader
0172 Inlet Air Temperature Sensor Diode - Floodlamps J-8 B Sensor - Atmospheric Pressure J-16 18
135 BU 12V Power Port E795 YL Oil Temperature Middle Sender
0175 Engine Oil Temperature Diode - LH Turn Indicator L-2 A Sensor - Crank Speed Timing I-16 5
136 GN Secondary Steering Control E797 WH IAP Pressure Control Solenoid (-)
0190 Engine Speed Signal Diode - Moldboard Lamp E-9 10 Sensor - Run Speed Timing I-16 19 Relay (Magnetic Switch) - A relay is an electrical component that is activated by electricity.
Electrical System
0248 CAT Data Link 137 RD Secondary Steering Motor E798 PK IAP Pressure Control Solenoid (+) A It has a coil that makes an electromagnet when current flows through it. The electromagnet can
Diode - RH Turn Indicator L-2 Sensor - Engine Oil Pressure K-15 8
0253 Personality Module Mismatch 141 PK Front Defroster SW F715 PU Ground Level Shutdown SW Diode - Snow Wing Lamp E-9 10 Sensor - Fan Drive Pressure J-18 2 open or close the switch part of the relay.
0254 Engine ECM 144 GN Beacon SW F716 WH Ground Level Shutdown SW Flasher K-8 B Sensor - Fuel Pressure J-15 8
0261 Engine Speed Sensor 147 RD 24V To 12V Converter (Aux Power Port) F762 GY Not Used Fuse Block - Overhead C-4,C-5 11 Sensor - Inching Pedal Position F-6 20 Solenoid - A solenoid is an electrical component that is activated by electricity. It has a coil that
0262 5 Volt Sensor Supply 148 WH Snow Wing Lamp SW F775 BU Centershift Pin Solenoid Fuse Block - Switched Power J-5 B Sensor - Injection Actuation Pressure J-15 36
CBK248-UP makes an electromagnet when current flows through it. The electromagnet can open or close
0267 Engine Shutdown Switch
149 PU Floodlamp SW H746 YL Fan Drive Solenoid Fuse Block - Unswitched Power J-7 B Sensor - Throttle Position K-9 13 AMZ251-UP a valve or move a piece of metal that can do work.
0268 Programmable Parameters
0273 Turbo Outlet Pressure Sensor
150 RD Engine Control Breaker H747 BR Fan Drive Solenoid Return Fuses - Overhead C-5 11 Sensor - Turbo Outlet Pressure J-16 18 125 1-UP
0274 Atmospheric Pressure Sensor
151 GN Rear Defroster SW J702 BK Air Inlet Heater Fuses - Switched Power I-4 B Sensor - XMSN Input Speed B-18 21 Harness And Wire Symbols
155 PK AWD Control J764 BR XMSN Filter Bypass SW Fuses - Unswitched Power I-6 B Sensor - XMSN Output Speed Sensor #1 B-18 21 * Harness identification letter(s) and a
0290 Fan Drive Pressure Sensor
160 PU Heated Mirrors SW J765 BU Inching Pedal Limit SW Gauge - LH Air Pressure G-1 A Sensor - XMSN Output Speed Sensor #2 A-18 21 Harness identification code serializing code. The "C" stands for
0291 Fan Drive Solenoid
Gauge - RH Air Pressure G-1 A Sensor - XMSN Temperature B-17 29 This example indicates connector and the number indicates
0296 Unable to Communicate with Transmission ECM 162 YL Moldboard Lamp SW J766 PU Switch Return (Engine ECM) wire 135 in harness "AG".
Ground - Cab Boss 2 (Cab Front) B-7 A Shifter - XMSN A-12 2
which connector in the harness.
0342 Cam Speed Timing Sensor 165 YL Differential Lock SW K748 OR Secondary Steering Resistor Wire, Cable, or Harness
0548 Throttle Lock Indicator Lamp Ground - Cab Boss 3 (Upper Cab) D-3 15 Solenoid - AC Clutch H-15 5 Assembly Identification
169 PK Blade Cushion SW/Centershift Pin SW T725 WH Fuel Filter Bypass SW
* * Part Number For
L-C12*
Ground - Engine Block Boss (RH Side) J-14 12 Solenoid - Blade Cushion #1 I-5 22
0549 Throttle Lock Switch
170 RD Product Link (Connector #27) 823 GN Not Used C-C4 AG-C3 AG-C4* Connector Assembly
0562 Unable to Communicate with CAT Monitoring System Ground - Front Frame Boss 2 (LH Side) J-9 20 Solenoid - Blade Cushion #2 I-4 22 130-6795 130-6795 111-7898 3E-5179
173 RD Turn Signal SW/Flasher 892 BR (-) Cat Data Link
0617 Air Inlet Heater Ground - Front Frame Boss 3 (LH Side) E-9 10 Solenoid - Centershift Pin E-7 23
1 325-A135 PK-14
176 RD 24V To 12V Converter (Communication Radio) 893 GN (+) Cat Data Link 325-A135 PK-14
1627 Fuel Pump Relay Ground - Platform Boss 2 J-12 10 Solenoid - Differential Unlock K-16 6
1715 Engine Oil Temperature Sensor 177 RD Main Breaker F842 BU AIH Indicator 12 13
Ground - Rear Frame Boss 2 (RH Side) H-12 Solenoid - Forward Horn F-7 Socket
179 RD 24V To 12V Converter (Entertainment Radio) F843 YL Inching Pedal Position Sensor Pin Wire Wire Receptacle
Electronic Transmission Control System Ground - Rear Frame Boss 3 (LH Side) K-15 8 Solenoid - Fuel Injector #1 J-18 18 Gauge Fuse
185 YL Fuel Pump Relay G826 BR Analog Sensor (+) Engine ECM Color
(MID No. 081) Ground - Rear Frame Boss 4 (LH Side) K-15 8 Solenoid - Fuel Injector #2 J-18 18
CID Component Ground Circuits G827 BU Analog Sensor (-) Engine ECM Ground - Rear Frame Boss 5 (RH Side) F-12 12 Solenoid - Fuel Injector #3 I-18 18 Single Wire Ground Plug
Connector Circuit Connection 2 200-L32 BK-14
0168 Electrical System Voltage 200 BK Main Chassis G828 WH Analog Sensor (+) Engine ECM Ground - Service Center Boss 1 (LH Side) K-14 1 Solenoid - Fuel Injector #4 I-18 18
Number
0177 Temperature Sensor (Transmission Oil) 18
201 BK Operator Monitor Panel G829 BR Analog Sensor (-) Engine ECM Ground - Service Center Boss 2 (RH Side) K-14 7 Solenoid - Fuel Injector #5 I-18 Identification
0248 CAT Data Link Ground Strap - Articulation Joint J-10 17 Solenoid - Fuel Injector #6 I-18 18 Pin or Socket
202 BK XMSN Control G833 PK Analog Sensor (-) Engine ECM 105-9344
0268 Programmable Parameter
205 BK Console/Panel G849 BR Engine Actuation Pressure Sensor Ground Strap - Engine Block To ECM D-18 8 Solenoid - Hydraulic Fan K-9 31 Number
0444 Magnetic Switch (Start Relay)
Ground Strap - Platform To Cab K-11 17 Solenoid - IAP Pressure Control J-16 37 Typical representation of Component
206 BK Battery #1 To Master Disconnect SW G850 BU Air Inlet Heater a Deutsch connector. The Typical representation of a
0520 Configuration (Transmission) 1 Part Number
210 BK AM/FM Radio G854 PK HEP Motor Ground Strap - Platform To XMSN Control D-14 13 Solenoid - Parking Brake E-6 13 plug contains all sockets 1 Sure-Seal connector. The plug
0562 Caterpillar Monitoring System
29
2 and the receptacle contains 2 and receptacle contain
229 BK Product Link G855 PU HEP Motor Group - A/C B-16 E Solenoid - XMSN (1st) C-18
0573 Position Sensor (Inching Pedal) all pins. both pins and sockets.
Group - Heater B-16 E Solenoid - XMSN (2nd) C-18 29
0585 Speed Sensor (Transmission Output) (No. 1) 232 BK Not Used G856 WH (+) TDC Probe
Heater - Jacket water I-15 12 Solenoid - XMSN (3rd) C-18 29
0637 Backup Alarm 235 BK Fuel Pump Relay G857 YL (-) TDC Probe
0668 Transmission Control (Shift Lever) 290 BK Caterpillar Monitoring System (Service) G858 OR Not Used
Lamp - Action J-1 A Solenoid - XMSN (Forward High) D-18 29 Volume 2: EU Equipped Machines
0669 Speed Sensor (Transmission Input) Lamp - AIH Indicator K-1 A Solenoid - XMSN (Forward Low) D-18 29
291 BK Caterpillar Monitoring System (Clear) J844 GY Fan Drive Pressure Sensor (+) 2009 Caterpillar Printed in U.S.A.
0673 Speed Sensor (Transmission Output) (No. 2) Lamp - Autoshift Indicator J-1 A Solenoid - XMSN (High Range) C-18 29
A287 BK Engine ECM Control K882 BU Oil Temperature End Sender All Rights Reserved
0674 Speed Sensor (Intermediate Transmission) (No. 1) Lamp - Centershift Pin Indicator K-1 A Solenoid - XMSN (Low Range) C-18 29
C203 BK Not Used R800 OR Digital Sensor (Power)
0675 Speed Sensor (Intermediate Transmission) (No. 2) Lamp - Differential Lock Indicator K-1 A Solenoid - XMSN (Reverse) D-18 29
0868 Indicator Lamp (Automatic Shift) Basic Machine Circuits 900 PU XMSN Shift Solenoid #4 Lamp - Dome C-3 15 Speaker - Left Hand D-2 24
1401 Solenoid Valve (Forward High) 304 WH Starter Relay No. 1 Output 901 WH XMSN Shift Solenoid #6 Lamp - Hazard Indicator K-1 A Speaker - Right Hand B-2 16
1402 Solenoid Valve (Forward Low) 306 GN Starter Relay Coil 902 BR XMSN Shift Solenoid #5 Lamp - High Beam Indicator K-1 A Switch - AC Pressure G-15 5
1403 Solenoid Valve (Reverse) 307 OR Key Start SW 903 GY XMSN Shift Solenoid #7 Lamp - HVAC Panel C-16 C Switch - Autoshift C-11 C
1404 Solenoid Valve (Speed Clutch) (No. 2) 308 YL Main Power Relay Coil 911 YL Not Used 20 11
Lamp - LH Blade Floodlamp G-4 Switch - Aux Backup Lamp A-7
1405 Solenoid Valve (Speed Clutch) (No. 3) Connector Location
321 BR Backup Alarm 921 WH Solenoid Return #1 (XMSN) Lamp - LH Cab Position D-2 24 Switch - Beacon B-10 30
1406 Solenoid Valve (Speed Clutch) (No. 1)
322 GY Warning Horn (Forward) 922 BR Solenoid Return #2 (XMSN) Lamp - LH High/Low/Position/Turn F-1 25 Switch - Blade Cushion C-12 C Schematic Machine
1407 Solenoid Valve (Low Range) Connector Number
Lamp - LH Inner Cab Floodlamp D-2 24 Switch - Blower (Heater/AC) C-16 C Location Location
1408 Solenoid Valve (High Range) Monitoring Circuits 977 YL Autoshift SW
CONN 1 J-17 18
403 GN Alternator (R) Term. 994 GY Engine Oil Pressure Lamp - LH Moldboard I-4 22 Switch - Brake Pedal Limit G-6 B
1484 Solenoid Valve (Inching Pedal) CONN 2 I-17 34
Lamp - LH Outer Cab Floodlamp D-2 24 Switch - Centershift Pin C-12 C
1580 Indicator Lamp (Transmission Filter) 404 YL Opr Mon Hydraulic Temperature 995 BU Coolant Temperature CONN 3 I-17 35
The CID is a diagnostic code that indicates which component is faulty. Lamp - LH Rear Floodlamp L-13 27 Switch - Centershift Pin Indicator E-6 23
408 WH Opr Mon Brake System Pressure 998 BR Oil Grade Code Plug #1 CONN 4 B-17 29
The MID is a diagnostic code that indicates which electronic control module Lamp - LH Stop/Tail/Turn L-18 27 Switch - Differential Lock K-5 B CONN 5 A-17 32
RENR9555-01 VOL 2 of 2
410 WH Opr Mon Action Alarm A982 BR Throttle Speed Set SW 25
diagnosed the fault. Lamp - LH Turn Indicator K-1 A Switch - Floodlamp K-5 B CONN 6 A-17 32
411 PK Opr Mon Action Lamp A983 BU Throttle Hold Mode SW
Lamp - License Plate L-18 2 Switch - Front Defroster A-10 30 15 CONN 7 A-17 32
9 14 10
417 GY Opr Mon Primary Steering Pressure C912 GN Throttle Position Sensor (Signal) 24
Lamp - RH Blade Floodlamp G-4 13 Switch - Front Lower Wiper A-9 30 CONN 8 D-16 29
419 YL Opr Mon Parking Brake C967 BU Intake Air Temperature Sender (Signal) 27 36 37 50 4
Lamp - RH Cab Position C-2 16 Switch - Front Upper Wiper B-9 30 34 1 8 20 22 CONN 9 L-16 2
2 29 33 5 D
426 BR XMSN Filter Bypass C975 WH Throttle Lock 35 CONN 30 Aux Backup Lamp L-16 2
Failure Mode Identifiers (FMI) Lamp - RH High/Low/Position/Turn F-1 26 Switch - Fuel Filter Bypass I-14 38
17 B A CONN 11 B-15 C
432 PK Service Brake SW (Engine ECM) C977 BU Inching Pedal Limit SW (N/O) 6 19 E 23
FMI No. Failure Description Lamp - RH Inner Cab Floodlamp C-2 16 Switch - Ground Level Shutdown D-17 29 21 16 CONN 12 A-15 C
0 Data valid but above normal operational range. 439 YL Centershift Indicator SW C978 BR Speed Set/Accel Lamp - RH Moldboard I-4 22 Switch - Headlamp L-3 B 38 18 3
31
7 12 CONN 13 C-14 32
447 PK Fuel Level Gauge C979 OR Speed Resume/Decel 28 C
1 Data valid but below normal operational range. Lamp - RH Outer Cab Floodlamp C-2 16 Switch - Headlamp Dimmer K-4 B CONN 14 C-14 32
13
2 Data erratic, intermittent, or incorrect. 458 PK Opr Mon Display Module Power C991 PK Fuel Pressure Sensor (Signal) Lamp - RH Rear Floodlamp L-13 28 Switch - Heated Mirrors B-7 11 11 30 CONN 15 C-13 32
32
3 Voltage above normal or shorted high. 462 YL Secondary Steering Motor Indicator E900 WH (+) XMSN Output Speed Sensor 1 Lamp - RH Stop/Tail/Turn A-18 28 Switch - Heater Thermostat C-16 E CONN 16 K-14 8
4 Voltage below normal or shorted low. 26
486 PK Not Used E901 GN (-) XMSN Output Speed Sensor 1 Lamp - RH Turn Indicator K-1 A Switch - Horn K-7 B CONN 17 L-14 8
5 Current below normal or open circuit. CONN 18 L-14 2
488 WH Brake System Pressure SW E902 PU (+) XMSN Int Speed Sensor 1 Lamp - Shift Lever Panel B-12 C Switch - Hydraulic Temperature E-6 17
6 Current above normal or grounded circuit. CONN 19 E-12 13
498 WH Differential Lock Indicator E903 YL (-) XMSN Int Speed Sensor 1 Lamp - Snow Wing E-5 11 Switch - Inching Pedal Limit G-6 B
7 Mechanical system not responding properly. CONN 20 F-12 32
A429 YL Opr Mon Articulation Angle E904 BR (+) XMSN Int Speed Sensor 2 Lamp - Throttle Lock Indicator L-1 A Switch - Key A-15 C
8 Abnormal frequency, pulse width, or period. CONN 21 F-12 12
Lamp - XMSN Filter Bypass Indicator L-1 A Switch - LH Brake System Pressure F-6 31
9 Abnormal update. C413 YL Opr Mon Display Module Load E905 BU (-) XMSN Int Speed Sensor 2 CONN 22 F-12 12
10 Abnormal rate of change. Lighter - Cigar A-15 C Switch - Master Disconnect K-13 1 CONN 23 G-12 12
C414 BU Opr Mon Display Module Data E906 OR (+) XMSN Output Speed Sensor 2
11 Failure mode not identifiable. Mirror - LH Heated D-1 24 Switch - Moldboard Lamps B-7 11 CONN 24 G-12 12
C436 BU XMSN Filter Bypass Indicator E907 GY (-) XMSN Output Speed Sensor 2
12 Bad device or component. Mirror - RH Heated D-1 16 Switch - Open Rops Beacon C-15 4 CONN 25 G-12 12
G460 GN XMSN Temperature Sensor E908 BR (+) XMSN Input Speed Sensor
13 Out of calibration. Module - Caterpillar Monitoring System I-1 A Switch - Operator Mode L-1 A CONN 26 I-12 20
H477 YL Oil Grade Code Plug #1 E909 WH (-) XMSN Input Speed Sensor CONN 27 I-12 20
14 Parameter failures. A
30 Page,
Module - Quad Gauge H-1 Switch - Panel Lamp Dimmer L-4 B
15 Parameter failures. H478 BU Oil Grade Code Plug #2 E937 PU Redundant Neutral CONN 28 I-12 20
Module - Speedo/Tach H-1 A Switch - Parking Brake Pressure E-10 32
16 Parameter not available. Accessory Circuits E938 OR First Gear CONN 29 L-12 32
Motor - Blower (Heater/AC) B-15 E Switch - Primary Steering Pressure L-9 9
17 Module not responding. CONN 30 Service Tool A-11 C
500 BR Wiper - Front Upper (Park) E939 WH Second Gear Motor - Engine Fuel Pump H-14 38 Switch - Rear Defroster A-10 C
18 Sensor supply fault. CONN 31 C-10 11
501 GN Wiper - Front Upper (Low) E940 BU Third Gear Motor - Front Defroster Fan C-2 24 Switch - Rear Wiper A-9 30 4
24 CONN 32 C-10 11
19 Condition not met. D
502 OR Wiper - Front Upper (HI) E941 YL Fourth Gear Motor - Front Lower Washer L-11 A Switch - RH Brake System Pressure E-6 31 16 CONN 33 D-10 A
20 Parameter failures. 15 11
503 BR Wiper - Rear (Park) E942 GN Fifth Gear Motor - Front Lower Wiper G-4 A Switch - Secondary Steering Test C-12 C CONN 34 E-10 A
The FMI is a diagnostic code that indicates what type of failure has occurred. CONN 35 E-10 A
504 YL Wiper - Rear (Low) E943 BR Sixth Gear Motor - Front Upper Washer L-11 A Switch - Snow Wing Lamp A-7 11
A 31 CONN 36 C-9 11
505 BU Wiper - Rear (HI) E944 GY Seventh Gear Motor - Front Upper Wiper D-3 Switch - Stop Lamp Pressure F-7
14 CONN 37 C-9 11
Monitoring System Service Modes 506 PU Washer - Front Upper E945 PU Eighth Gear Motor - HEP J-16 37 Switch - Tail Lamp L-4 B
CONN 38 C-8 11
Service Mode Number 507 WH Washer - Rear E946 OR Forward Direct Motor - Rear Defroster C-11 11 Switch - Throttle Hold Mode B-11 C 30 A
1 37 33 50 B CONN 39 C-8 11
27 28 22
Operator Mode 0 508 PU Radio Speaker - Left E947 WH Reverse Direct Motor - Rear Washer K-11 D Switch - Throttle Speed Set A-11 C CONN 40 G-6 20
7 5 25
Motor - Rear Wiper C-11 D Switch - Turn Signal L-8 B 18 C CONN 41 G-6 13
Harness Code 1 509 WH Radio Speaker - Left (Common) E948 BU Park 34 35 36 3 26
Motor - Secondary Steering J-12 10 Switch - XMSN Filter Bypass K-13 1 38 CONN 42 H-6 13
Parameter Display 2 511 BR Radio Speaker - Right E949 YL Neutral E
23
Motor - Starter J-14 12 CONN 43 H-6 20
Diagnostic Service 3 512 GN Radio Speaker - Right (Common) E963 BK Run Speed/Timing (-)
8 12 31 20 13 CONN 44 I-6 20
Digital Tattletale 4 515 GY Blower Motor (HI) E964 WH Run Speed/Timing (+) 2 19
9 10 CONN 45 I-6 13
Machine locations are repeated for components located close together.
Units 5 516 GN Blower Motor (Medium) E965 BU Crank Speed/Timing (-) 21 6 CONN 46 I-6 13
32
A = Operator's compartment (Dash).
Calibration (Articulation Gauge) 6 517 BU Blower Motor (Low) E966 YL Crank Speed/Timing (+) 29 CONN 47 CMS Service Tool L-5 B
B = Operator's compartment (Steering Console). 17
CONN 48 E-4 20
Calibration (Transmission Control) 7 521 YL A/C SW To Refrigerant SW E974 GN Inching Pedal Limit SW (N/C)
C = Operator's compartment (Right side console). CONN 49 H-4 20
Calibration (Transmission Control) 8 522 WH A/C Clutch To Thermostat SW G939 PK Not Used
D = Operator's compartment (Headliner). CONN 50 H-3 A
Module Configuration 9 537 GN Turn Signal SW To Flasher G946 OR Throttle Hold Indicator E = Operator's compartment (Under seat). CONN 51 H-3 A
Monitoring System Operator Modes 556 WH Differential Lock SW K917 BR Fan Drive Pressure Sensor (Signal) CONN 52 H-2 A
Operator Mode Number 567 WH Front Defrost SW K995 OR Air Inlet Heater CONN 53 E-3 25,26
569 PK Rear Defrost SW L987 WH Not Used CONN 54 TDC Service Probe I-15 8
Service Meter 0
CONN 55 G-14 50
Odometer 1 570 BU Blade Cushion Solenoid M998 OR Autoshift Indicator Lamp
CONN 56 I-6 13
Digital Tachometer 2 575 YL Wiper - Front Lower (Park) R914 OR Throttle Hold Mode SW CONN 58 L-12 1
Diagnostic Scrolling 3 576 PK Wiper - Front Lower ( Low) R998 BR Digital Sensor (Return) CONN 59 B-16 C
Cumulative Fuel 4 577 PU Wiper - Front Lower (High) T914 OR Throttle Hold (OFF) CONN 60 B-4 15
578 BU Wiper - Front Lower (Wash) T945 GY Brake #1 Return CONN 61 D-4 15
Trip Machine Hours 5
CONN 77 A-18 28
Trip Odometer
Trip Fuel
6
7
589
592
GN
BU
A/C Clutch Solenoid
24V To 12V Converter (Entertainment Radio)
T946
T947
PU
YL
Brake #2 Return
Brake #3 Return
Machine Harness Connector And Component Locations CONN 79
CONN 80
L-18
L-18
27
2
Reset Trip Values 8 A503 PK Front Defrost Fan (Low) T948 BR Brake #4 Return The connectors shown in this chart are for harness to harness connectors.
A504 GN Rear Defrost Fan (Low) T949 BU Brake #5 Return Connectors that join a harness to a component are generally located at or near
the component. See the Component Location Chart.
A506 OR Front Defrost Fan (High) T950 GN Brake #6 Return
A507 YL Rear Defrost Fan (High) T951 YL Injector #1
Resistor, Sender and Solenoid Specifications
Event Codes For Engine ECM A513 PK 24V To 12V Converter (Entertainment Radio) T952 BR Injector #2 Part No. Component Description Resistance (Ohms)
Event Code Condition C542 GN Heated Mirrors SW T953 BU Injector #3
Off Machine Switch Specification 3E-1906 Solenoid - AC Clutch 17.6 0.6
Part No. Function Actuate Deactuate Contact Position 3E-7842 Resistor - Secondary Steering 150 7.5
E015 High Engine Coolant Temperature Derate Lighting Circuits T954 GY Injector #4
60 kPa MAX 38 20 kPa 7T-4003 Resistors - Front & Rear Defrost 10 .5
E017 High Engine Coolant Temperature Warning 600 BR Panel Lamp (Low) T955 GN Injector #5 3E-2026 Brake Air Pressure (Stop Lamp) Normally Open
(8.7psi MAX) (5.5 2.9 psi) Overall 2.0 .1
E025 High Inlet Air Temperature Derate 601 GY Panel Lamp (High) T956 GY Injector #6 9G-1950 Resistor - AC/Heater Blower Motor
-1.1 0.8c 2.2 0.8c Tap 1.0 .05
E027 High Inlet Air Temperature Warning 603 PK Beacon T957 PU Injector #1 (Return) 3E-5464 Thermostat Normally Closed
(30 1.4F) (36 1.4F) 112-2240 Solenoids - Blade Cushion (No. 1 & No. 2) 32.6 1.6
E039 Low Engine Oil Pressure Derate 604 OR Stop Lamp T958 YL Injector #2 (Return)
1200 kPa MAX 700 100 kPa A-B, Normally Open Coolant Temperature
E100 Low Engine Oil Pressure Warning 605 YL Turn Lamp - LH T959 BR Injector #3 (Return) 3E-6450 Primary Steering Pressure 130-9811 Senders - 1000
(174 psi MAX) (101.5 14.5 psi) A-C, Normally Closed Intake Air Temperature
E164 High Injector Actuation Pressure 606 GY Turn Lamp - RH T960 BU Injector #4 (Return)
Brake System Pressure (RH & LH) 640 kPa MAX 530 40 kPa 145-1144 Solenoids - XMSN (Fwd High,Fwd Low,and Reverse) 8.7 0.4
E190 Engine Overspeed Warning 608 GN Flood Lamp - Rear T961 GN Injector #5 (Return) 114-9281 Normally Open
Park Brake Pressure (92.8 psi MAX) (76.9 5.8 psi) 148-2350 Solenoid - Hydraulic Fan 5.0 0.3
609 YL Flood Lamp - Snow Wing T962 WH Injector #6 (Return)
102 3C 90 MIN 152-8346 Solenoid - Centershift Pin 32.6 1.6
611 PU Head Lamp (High) T993 BR Fan Drive Pressure Sensor (-) 131-4135 Hydraulic Temperature Normally Closed
(215.6 5.4F) (194F MIN) Fuel Level Empty 239 To 255
612 GY Aux Backup Lamp 173-2018 Sender -
275 to 1750 kPa - Fuel Level Full 25 To 29
180-5462 A/C Pressure Normally Open
Related Electrical Service Manuals (40 to 255 psi) - 174-3705 Solenoid - Differential Unlock 32.6 1.6
Title Form Number 103.4 13.7 kPa 68.9 kPa 186-1526 Solenoids - XMSN (1st,2nd,3rd,High Range, and Low Range) 31.3 3.0
212-2768 Fuel Filter Bypass Normally Closed
Alternator: 200-2232: 75A (STD) 24V SENR7508 (15 2 psi) (10 psi) Articulation Angle 80 from Full CCW 10 3
Electric Starting Motor: 104-7044 SENR3581 Contact position at the contacts of the harness connector. 187-1008 Sender - Articulation Angle Mid-range 85 7
Electronic Monitoring System RENR5740 With increasing pressure the closed condition can be maintained up to 2800 kpa (405 psi), with decreasing pressure the close d condition can be maintained Articulation Angle 80 from Full CW 185 7
down to 170 kpa (25psi).
Engine Control Monitor SENR9504 Forward Horn
188-9250 Solenoids - 74.0 7.4
Starting and Charging SENR2947 Park Brake
Transmission Electronic Control RENR4104 194-4181 Resistor - Panel Lamp 10 .3
At room temperature unless otherwise noted.
18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
AG-C5 AG-C2 STEERING CONSOLE
3E3364 1552269
BACKUP ALARM BK-18 1 321-AG1 BR-18
TAILLAMPS
HEADLAMPS
123-6449 BK-18 2 922-AG2 BR-18
CONN 10 F-C7 AN-C1 AN-C2
CONN 80 F-C4 F-C3 200-F8 BK-14 1552269 CONN 18 3E3364 1552269 P-C43 147-P153 RD-16 G-C21 OPERATOR MODE SW
OFF
3E3364 1552269 CONN 58 1552273 1552269 9X-9688
200-F21 BK-18 608-F7 GN-14 1 1 608-AN1 GN-14 608-AN2 GN-14 1 LH REAR FLOODLAMP
CONN 79 AUX BACKUP
LAMP 1 612-F9 GY-14 321-F4 BR-18 200-F18 BK-14 2 2 200-AN4 BK-14 200-AN5 BK-14 2 153-2073 +24V UNSWITCHED 1 147-P163 RD-16 C-C2 1 BK-18
CL-C1 AG-C6 CONNECTOR 2 200-F8 BK-14 F-C9 AF-C4 R-C6 +24V SWITCHED 2 147-P166 RD-16 601-C60 GY-18 3E7996 201-G39 BK-18 2 BK-18
3E3376 1552272 321-AG1 BR-18 604-F10 OR-18 3E3364 AN-C3 3E3382 1552273 24 TO 12 VOLT CONVERTER 2 GROUND 3 200-P8 BK-16 601-C61 GY-18
1552269 (AUX POWER PORT) TURN SIGNAL SW
TU 3 605-AG3 YL-18 604-AG5 OR-18 AG-C1 F-C8 604-F11 OR-18 1 +12V UNSWITCHED 4 173-3064 205-C62 BK-18 A G-C1
S 1 604-AG5 OR-18 605-AG3 YL-18 3E5179 CONN 9 1552252 605-F13 YL-18 608-AN3 GN-14 1 RH REAR FLOODLAMP 2 205-4285 +12V SWITCHED 5 135-P155 BU-16 205-C64 BK-18 B
1
1552269 G-C28
TA 2 922-AG2 BR-18 200-AG20 BK-18 1 200-F21 BK-18 606-F14 GY-18 200-AN6 BK-14 2 153-2073 3 GROUND 6 C-C1 C-C9 668-C11 BU-18 1 1 1071984
2 LH-TURN IND DIODE
L G 4 200-AG16 BK-18 321-AG1 BR-18
604-AG5 OR-18
2
3 604-F10 OR-18
612-F9 GY-14 4
5
P-C3
3E3382 P-C44 P-C42 3
605-C46 YL-18 290-C88 BK-18
3E3376
1
1552272 2
3
3
HEADLAMP SW
106-8704 2 C436-G55 BU-18 XMSN FILTER BYPASS IND
115-1748 L
200-F16 BK-16
604-F10 OR-18
604-F11 OR-18
605-F13 YL-18
606-F14 GY-18
200-F18 BK-14
200-F21 BK-18
200-F21 BK-18
200-F16 BK-16
2 4
556-F3 WH-16
612-F9 GY-14
922-F5 BR-18
321-F4 BR-18
122-F6 BU-16
608-F7 GN-14
200-F8 BK-14
200-F8 BK-14
LH STOP/TAIL/TURN LAMP 200-AG16 BK-18 200-AG20 BK-18 604-AG4 OR-18 4 604-F11 OR-18 922-F5 BR-18 F-C2 AF-C1 6 1552273 3E3382 606-C45 GY-18 291-C87 BK-18 2 SERVICE TOOL 668-C11 BU-18 4 3E-9317
5C-9931 200-AG17 BK-18 605-AG3 YL-18 5 605-F13 YL-18 1552269 CONN 17 3E3364 179-P148 RD-18 1 +24V UNSWITCHED 3 CMS 5
5 G-C3
AG-C4 AG-C3 CONNECTOR 6 1552269
200-AG18 BK-18 606-AG8 GY-18 6 606-F14 GY-18 122-F6 BU-16 1 122-AF1 BU-16 308-P115 YL-16 2 +24V SWITCHED 6 201-C79 BK-18 4 6 G-C27
3E3364 1552269 FRONT UPPER WASHER MOTOR
7 200-F16 BK-16 2 7T-8891 200-P16 BK-16 3 GROUND 205-C74 BK-18 CONN 47 601-C61 GY-18 C 1 1071984
8 4 5 D RH-TURN IND DIODE
1 1 922-AG2 BR-18 922-F5 BR-18 P-C22 A513-P40 PK-18 +12V UNSWITCHED 205-C62 BK-18 106-8704 2 150-G77 RD-16 THROTTLE LOCK IND LAMP
2 2 200-AG17 BK-18 604-AG4 OR-18 9 200-F19 BK-16 7T5957 592-P152 BU-18 5 +12V SWITCHED 601-C73 GY-18 G946-G51 OR-18 115-1748
CE-C1 606-AG8 GY-18 10 200-F20 BK-16 SERVICE CENTER F-C1 P-C24 MOTOR 1 506-P24 PU-16 210-P151 BK-18 6 GROUND 605-C46 YL-18
3E3364 11 556-F3 WH-16 AF-C2 1552252 CONN 29 3E5179 + - 2 200-P26 BK-16 24 TO 12 VOLT CONVERTER 1 4 606-C45 GY-18
12 1552272 1 G-C9
ENTERTAINMENT RADIO
BRIGHT
556-F1 WH-16 3 321-F4 BR-18 2 205-4285 1071984
556-F2 WH-16 1 604-F10 OR-18 3 604-P41 OR-18 537-C50 GN-18 C-C3
DIM
2 604-F11 OR-18 4 604-P45 OR-18 FRONT LOWER WASHER MOTOR P-C45 3E7996 HAZARDS INDICATOR LAMP
LICENSE PLATE LAMP 7T-8891
- FRONT & REAR
CE-C2 4 605-F13 YL-18 5 605-P88 YL-18 P-C47 1552267 200-G56 BK-18 115-1748
- FRONT ONLY
117-8319 1552269 AF-C7 606-F14 GY-18 6 606-P89 GY-18 7T5957 200-P25 BK-18 A BK-16 601-C59 GY-18 A
RD-18 1 3E3376 7 MOTOR 1 578-P31 BU-16 728-P42 BU-18 B RD-16 685-C48 BR-18 205-C64 BK-18 205-C63 BK-18 B
200-F20 BK-16
200-F19 BK-16
556-F1 WH-16
556-F2 WH-16
RD-18 2 J764-AF11 BR-18 122-AF1 BU-16 612-F9 GY-14 8 612-P28 GY-14 + - 2 200-P131 BK-16 C BU-16 205-C63 BK-18 600-C29 BR-18 1 1 G-C26
C-C4 2 PANEL LAMP DIMMER SW
- OFF
200-AF2 BK-16 200-AF2 BK-16 922-F5 BR-18 9 PRIMARY STER PRESS. SW 601-C31 GY-18 2 3 1071984
3E-9318
C912-P161 GN-18
H746-P158 YL-16
H747-P165 BR-16
R800-P159 OR-18
R998-P160 BR-18
10 1552273 3
135-P155 BU-16
147-P153 RD-16
200-P131 BK-16
200-P123 BK-16
179-P148 RD-18
210-P151 BK-18
308-P115 YL-16
592-P152 BU-18
A513-P40 PK-18
426-AF10 BR-18 122-F6 BU-16 122-P81 BU-16 3E-6450 601-C32 GY-18 601-C31 GY-18 150-G54 RD-16 AIH INDICATOR LAMP
200-P26 BK-16
506-P24 PU-16
507-P32 WH-16
578-P31 BU-16
200-P16 BK-16
200-P25 BK-18
728-P42 BU-18
C-C10
200-P8 BK-16
J764-AF11 BR-18 556-F3 WH-16 11 556-P94 WH-16 BATT 30b 1 601-C60 GY-18 3E7996 601-C59 GY-18 4 F842-G52 BU-18 115-1748
202-UX75 BK-16 608-F7 GN-14 12 608-P20 GN-14 REAR WASHER MOTOR TURN LIGHTS 49a 2 L987-C58 WH-18 611-C39 PU-14 601-C67 GY-18 5
AF-C5 7T-8891 NOT USED 49 3 6
P-C48 601-C68 GY-18 G-C11
202-UX77 BK-16 UX-C14 AF-C3 1018108 7T5957 TURN IND C 4 205-C69 BK-18 A C 1071984
202-UX76 BK-16
F-C5 F-C6 1552252 3E5179 122-AF1 BU-16 1 BK-22 1 507-P32 WH-16 HAZARD IND C2 5 205-C70 BK-18 B D LH TURN INDICATOR LAMP
200-F21 BK-18
200-F16 BK-16
200-F18 BK-14
1552269 1552269 MOTOR 1
200-F8 BK-14
1 2 BK-22 AIR DRYER 2 GROUND 31 6 1
200-AF2 BK-16 203-2423 + - 200-P123 BK-16 685-C22 BR-14 2 201-G39 BK-18 115-1748
HORN SWITCH
1
2
1
2
2 FLASHER 205-C70 BK-18 2
P-C18 169-3145 HHH-C1 C-C14 3 C-C6
3 THROTTLE POS SENSOR 173-4490 205-C72 BK-18 685-C23 BR-14 3 FLOODLAMP SW E735-G38 PU-18 G-C7
4 10
GN-18
GN-18
4 AF-C6 XMSN FILTER BYPASS SW 1552267 160-2443 3E3364 1552269 498-C4 WH-18 685-C23 BR-14 4 9X-9632 1552269 1071984
1552269 OR-18 5
5 200-AF2 BK-16 164-7577 R800-P159 OR-18 A BATTERY + 1 322-C7 GY-16 205-C74 BK-18 556-C1 WH-16 608-C26 GN-14 5 600-C29 BR-18 1 RD-16 PANEL LAMP RESISTOR RH TURN INDICATOR LAMP
BK-18 6
6 426-AF10 BR-18 426-AF10 BR-18 1 BK-18 R998-P160 BR-18 B GROUND 2 322-C7 GY-16 601-C67 GY-18 116-C25 BR-14 6 601-C32 GY-18 2 RD-16 194-4181 115-1748
DIFF UNLOCK ARC SUPPR 7 J764-AF11 BR-18 2 BK-18 C912-P161 GN-18 C WH-18 SIGNAL 601-C71 GY-18 601-C68 GY-18 C 201-G18 BK-18
FAN DRIVE PRESS SNSR UX-C16 SERVICE CENTER GND BOSS 1
K
106-8704 8 D
K
601-C73 GY-18 608-C26 GN-14 205-C69 BK-18 201-G23 BK-18 G-C6
167-1709 3E3370 DIFF UNLOCK SOL 9 AIR HORN GP 605-C46 YL-18 685-C22 BR-14 201-G36 BK-18 1071984
174-3705 P-C36 CAB FLOODLAMPS RELAY C-C7 1 HI BEAM INDICATOR LAMP
+5V OR-18 A 10 3E-6477 160-7758 606-C45 GY-18 116-C25 BR-14 HEADLAMP DIMMER SW 201-G34 BK-16 611-G10 PU-18
2
C912-P161 GN-18
H746-P158 YL-16
H747-P165 BR-16
R800-P159 OR-18
R998-P160 BR-18
200-P26 BK-16
GROUND YL-18 B 11 1552269 7T6365 115-1748
147-P153 RD-16
179-P148 RD-18
200-P131 BK-16
200-P123 BK-16
308-P115 YL-16
135-P155 BU-16
210-P151 BK-18
592-P152 BU-18
A513-P40 PK-18
HYD FAN SOL 165-C13 YL-16 611-C39 PU-14 103-5678 201-G35 BK-16 200-G74 BK-18
200-P16 BK-16
200-P25 BK-18
506-P24 PU-16
507-P32 WH-16
578-P31 BU-16
728-P42 BU-18
C-C17
200-P8 BK-16
SIGNAL GN-18 C REAR FRAME GND BOSS 4 REAR FRM GND BOSS 3 12 1 30 30 B
H746-P158 YL-16 148-2350 86 86 3E7996 113-G40 OR-16
(LEFT SIDE) 2 C-C27
(LH SIDE) CONN 16 STRAP 1S-2342 H747-P165 BR-16 5.5 150-G54 RD-16 G-C17
UNLOCK
MASTER DISC SW 4 AWG 85 685-C48 BR-18 1552267 601-C71 GY-18 150-G53 RD-16 1071984
7N-0718 85 87
LOCK
SERVICE CENTER GND BOSS 2 AUX START RECPT A 601-C3 GY-18 A 150-G77 RD-16 498-G1 WH-18 DIFF LOCK INDICATOR LAMP
0 184-4467 87 87A B 205-C72 BK-18 B 200-G56 BK-18 200-G73 BK-18 115-1748
87a
ENGINE ENGINE C 685-C48 BR-18 205-C2 BK-18 4 A 200-G72 BK-18
C-C28 5 200-G73 BK-18
PLATFORM GND BOSS 1 CAB GND BOSS 1 3E3370 6 B 200-G74 BK-18
SEC STER RESISTOR AWX-C10 LH POSITION LAMPS RELAY C-C25 1 DIFF LOCK SWITCH
(LEFT REAR CAB) (LOWER LEFT REAR) 498-C4 WH-18 1 2 200-G71 BK-18
TURBO OUTLET PRESS SENSOR INJECTOR ACTUATION PRESS SENSOR 3E-7842 1552269 3E-6477 7T6365 2 139-2119
161-1704 165-C13 YL-16
194-6726 1 30 30 3 3
K748-AWX6 OR-16 86 86 L987-C58 WH-18 556-C1 WH-16 205-G65 BK-18 205-G70 BK-18 G-C25
2 601-C3 GY-18 C C 205-G68 BK-18 1071984
ENGINE OIL PRESS SENSOR D
ATMOSHERIC PRESS SENSOR 161-1705 AWX-C11 85 205-C2 BK-18 D 205-G57 BK-18 439-G50 YL-18 CENTERSHIFT PIN IND LAMP
150 85 87 115-1748
161-1703 FUEL PRESS SENSOR 3E3364 87 205-G58 BK-18 200-G72 BK-18
GROUND
SIGNAL
GROUND
SIGNAL
101-MM1 RD-4 87A 205-G59 BK-18
161-1705 87a
PLATFORM GND BOSS 2 205-G60 BK-18 G-C19
+5V
+5V
HEP MOTOR INLET AIR HTR RELAY 290-G42 BK-18 1071984
204-4945 CAB SUPPORT
GROUND
SIGNAL
148-0757 STRUCTURE RH POSITION LAMPS RELAY C-C26 177-C82 RD-6 C-C19 291-G43 BK-18
GROUND
SIGNAL
A
B
C
174-7566 403-G5 GN-18
+5V
C-C18
BK-18
BK-18
3E-6477
OR-18
YL-18
GN-18
EX-C4
GROUND
SIGNAL
MOTOR EX-C19 K995-NN1 OR-4 K748-AWX6 OR-16 7T6365 112-C83 PU-6 SWITCHED POWER 404-G78 YL-18
1747566
+5V
1698670 3E3364 30 30 FUSE BLOCK
UNSWITCHED POWER 112-C21 PU-6 408-G47 WH-18 G-C10
+5V
86 86
A
B
C
FUSE BLOCK 410-G41 WH-18 1071984
EX-C8 SEC STER RLY
1
2
A
B
C
85 BUSS M998-G6 OR-18 AUTOSHIFT INDICATOR LAMP
1
2
205-P168 BK-18
201-P129 BK-18
200-P136 BK-12
201-P126 BK-16
201-P122 BK-18
205-P169 BK-18
200-P66 BK-14
200-P13 BK-14
EX-C13 EX-C5 1698670 EX-C9 3E-0154 85 87 POINT 1
A
B
C
STRAP 7G-1060 BUSS 417-G4 GY-18 921-G7 WH-18 115-1748
A
B
C
ALX-C17 1552269 1698670 EX-C2 EX-C3 1552269 87 87A POINT 1 17
4 AWG 87a 419-G46 YL-18
1500375 1698670 3E3370 INLET AIR HEATER 17 FUSE 1 FUSE 2
SECONDARY STEERING MONITOR BLADE FLOOD 439-G50 YL-18
FUEL INJECTOR 1 1 159-3537 FUSE 2 113-C53 OR-16 10A 10A 149-C24 PU-14 447-G44 PK-18
POS LAMPS COUPLER RELAY C-C24 NOT USED TEST 1 2
188-4520 2 CONN 1 10A 134-C15 RD-16 458-G22 PK-18 G-C22
STARTING MOTOR 3E-6477 7T6365 1 2 FUSE 4
REAR FLOOD FUSE 3 458-G17 PK-18 1071984
J ALX-C18
ALX-C23
1917823
EX-C16
1726062
104-7044 REAR FRAME GND BOSS 1
(ARTICULATION JOINT)
FRONT FRAME GND BOSS 1
(ARTICULATION JOINT)
30 30
86 86
105-C16 RD-16
KEY SWITCH FUSE 3
10A
FUSE 4
10A
AUX PWR PORT
147-C78 RD-16
116-C25 BR-14
3
10A 10A
4
458-G16 PK-18 411-G37 PK-18
201-G36 BK-18
ACTION LAMP
107-1983 J
1500375 1 G S 85 3 4 AIR DRYER FUSE 5 FUSE 6 DIFF LOCK 498-G1 WH-18
ALTERNATOR 85 87
1 2 101-MM1 RD-4 FUSE 5 122-C12 BU-16 10A 10A 165-C13 YL-16
205-P168 BK-18
205-P169 BK-18
201-P129 BK-18
201-P126 BK-16
201-P122 BK-18
200-P136 BK-12
FUEL INJECTOR 2 200-8281 HORN
200-P66 BK-14
2 3 MTR BAT 87 87A 10A NOT USED 5 6
188-4520 (75A) 87a 114-C6 RD-16 BLADE CUSHION / 601-G69 GY-18
6
BK-6
4 5 HVAC FUSE 7 FUSE 8 CENTERSHIFT PIN 601-G67 GY-18 G-C8
COMMUNICATIONS
5 INLET AIR TEMP SENDER MOTOR ALT CIGAR LIGHTER FUSE 7 FUSE 8 RADIO 124-C27 GN-14 15A 10A 169-C54 PK-16 601-G66 GY-18 601-G62 GY-18 8T9834
ALX-C19 6 R + 109-AWX9 RD-4 C-C8 C-C23 129-C5 RD-18 10A 15A 176-C77 RD-14 7 8 601-G63 GY-18 113-G40 OR-16 1 BATTERY +
1500375 130-9811 3E-3364 1552269
7 ENGINE BLOCK GND BOSS - 7 8 XMSN CONTROL FUSE 9 FUSE 10 601-G64 GY-18 411-G37 PK-18 13 ACTION LAMP
(RH SIDE) ENTERTAINMENT
FUEL INJECTOR 3 1 8 1 STOP LAMP SW FUSE 9 FUSE 10 RADIO 126-C20 PK-14 15A 15A 601-G61 GY-18 410-G41 WH-18 4 ACTION ALARM
2 9 COOLANT TEMP SENDER 2 10A 9 10 7
188-4520 130-9811 200-AWX10 BK-4 130-C8 RD-18 10A 179-C80 RD-18 UNUSED
SIGNAL
GROUND
10 403-AWX11 GN-18 MOTOR 9 10 PARK BRAKE FUSE 11 FUSE 12 FUEL PUMP C414-G13 BU-18 15 DISPLAY MODULE LOAD
CRANK SPEED TIMING SENSOR FLOODLAMPS COUPLER DIODE
11 IAP PRESSURE CONTROL VALVE 109-7195 OIL TEMP END SENDER 106-8704 FUSE 11 FUSE 12 127-C55 OR-16 10A 10A 611-G10 PU-18 C413-G14 YL-18 35 DISPLAY MODULE DATA
12 191-0651 191-6587 147-P153 RD-16 10A 10A 11 12 892-G8 BR-18 E708-G15 PK-18 25 DISPLAY MODULE CLOCK
SIGNAL
GROUND
ALX-C20 13 OIL TEMP MIDDLE SENDER SEC STER MTR 179-P148 RD-18 11 12 SECONDARY STEERING FUSE 13 FUSE 14 RESERVED 893-G9 GN-18 458-G16 PK-18 34 DISPLAY MODULE PWR
1500375 TDC SERVICE
1
2
14 RUN SPD TIMING SNSR 191-6587 117-3915 200-P8 BK-16 C-C12 136-C14 GN-16 10A 921-G7 WH-18 10
1 15 PROBE EX-C12 SPARE SPARE 13 14 11
FUEL INJECTOR 4 109-7194 1552269 200-P16 BK-16 3E7996 922-G49 BR-18
CONNECTOR
SIGNAL
GROUND
188-4520 2 16 200-P25 BK-18 FRONT FRAME GND BOSS 2 13 14 FUSE 15 FUSE 16 RESERVED A429-G45 YL-18 17
EX-C17
1
2
B
A
1
2
17 200-P26 BK-16 A 601-C73 GY-18 10A 21
EX-C32 EX-C14 3E3364 EX-C11
SIGNAL
GROUND
18 200-P131 BK-16 B 205-C74 BK-18 SPARE SPARE 15 16 24
1407339 1112416 1552269 16
1
2
200-P123 BK-16 1 15 18 26
ALX-C21 EX-C10 2 18 27
1552269 308-P115 YL-16 C413-G20 YL-18
BK-18
BK-18
1500375
CONN 54
B
A
NEG POS 122-P81 BU-16 3 L987-C58 WH-18 165-C13 YL-16 C413-G25 YL-18 28
EX-C15 CONN 28
BK-18
BK-18
FUEL INJECTOR 5 1 556-P94 WH-16 4 C413-G14 YL-18 404-G78 YL-18 32 HYD TEMP SW
2 1003320 AWX-C2 P-C32 5 36
188-4520 604-P41 OR-18 130-C8 RD-18 C414-G26 BU-18
12V BATTERY 1 1552252 3E5179 604-P45 OR-18 135-P155 BU-16 6 129-C5 RD-18 169-C54 PK-16 C414-G21 BU-18 37
3T-5760 (STD)
1
2
12 605-P88 YL-18 210-P151 BK-18 C 114-C6 RD-16 C414-G13 BU-18 38
EX-C7 153-5700 (ATCH)
1
2
11 606-P89 GY-18 506-P24 PU-16 D 105-C16 RD-16 149-C24 PU-14 C436-G55 BU-18 E735-G38 PU-18 20 OPERATOR MODE SW
ALX-C22 3E3364 EX-C6 B+ JUNCT BLK 2 153-5710 (ATCH) 10 23 SERVICE
3E3364 608-P20 GN-14 507-P32 WH-16 E708-G24 PK-18 290-G42 BK-18
9W-0742
G828-EX70 WH-18
G828-EX83 WH-18
G829-EX19 GN-18
G829-EX21 GN-18
1500375 9 462-P99 YL-18 578-P31 BU-16 E708-G19 PK-18 291-G43 BK-18 33 CLEAR
FUEL INJECTOR 6 1 308-AWX1 YL-16 1 308-P65 YL-16 592-P152 BU-18 E708-G15 PK-18 447-G44 PK-18 9 FUEL LEVEL
CONN 2 C-C22 P-C56
I
188-4520 2 2 728-P42 BU-18 201-P122 BK-18 F842-G52 BU-18 A429-G45 YL-18 18 ARTICULATION ANGLE
I EX-C35
3E3370
EX-C34
1698670 NEG POS
3
4
A429-P130 YL-18
201-P129 BK-18 612-P28 GY-14
A513-P40 PK-18
C912-P161 GN-18 113-P92 OR-16 200-P66 BK-14 113-P92 OR-16
1552273 CONN 56 3E3382
1
G946-G51 OR-18
M998-G6 OR-18
419-G46 YL-18
408-G47 WH-18
29 PARK BRAKE
19 BRAKE SYS PRESS.
A 150-AWX12 RD-16 5 462-P99 YL-18 H746-P158 YL-16 113-P93 OR-16 200-P136 BK-12 118-P76 GY-16 2 417-G4 GY-18 40 PRIMARY STER PRESS.
B 403-AWX11 GN-18 6 403-P59 GN-18 H747-P165 BR-16 113-P91 OR-16 201-P126 BK-16 105-C16 RD-16 3 403-G5 GN-18 30 ALTERNATOR
C 12V BATTERY 2 7 R800-P159 OR-18 126-P1 PK-14 126-P110 PK-14 205-P169 BK-18 4 893-G9 GN-18 5 CAT DATA LINK +
3T-5760 (STD) 8 5 14 CAT DATA LINK -
153-5700 (ATCH) 112-P144 PU-6 R998-P160 BR-18 126-P114 PK-14 200-P66 BK-14 150-P56 RD-16 112-C21 PU-6 112-C21 PU-6 BLADE CUSHION SOL1 BLADE CUSHION SOL2 892-G8 BR-18
153-5710 (ATCH) 200-P136 BK-12 112-C83 PU-6 112-C83 PU-6 6 112-2240 112-2240 LH MOLDBOARD LAMP RH MOLDBOARD LAMP 31
AWX-C4 P-C21 205-P168 BK-18 201-P126 BK-16 200-P63 BK-18 113-C53 OR-16 113-C53 OR-16 153-2073 153-2073 3
J2 UX-C17 1275483 CONN 27 1275484 177-P143 RD-6 113-P91 OR-16 205-P169 BK-18 200-P61 BK-14 122-C12 BU-16 114-C6 RD-16 C-C16 P-C33 12
ENGINE ECM EX-C1 EX-C31 EX-C33 1552269 112-AWX8 PU-6 1 112-P144 PU-6 126-P1 PK-14 113-P93 OR-16 200-P60 BK-16 124-C27 GN-14 1275483 CONN 461275484 22
GN
GN
GN
GN
172-3353 1607690 3E3370 CONN 3 1698670 FUEL FILTER BYPASS SW BK-18 2 308-P65 YL-16 113-P92 OR-16 200-P36 BK-14 126-C20 PK-14 112-C21 PU-6 1 112-P145 PU-6
AT-C6 AT-C7
AT-C9
3E3364
AT-C8
3E3364
16
TDC PROBE (+) 22 G856-EX11 WH-18 A 212-2768 BK-18 1 101-UU1 RD-4 AWX-C5 P-C26 403-P59 GN-18 126-P110 PK-14 201-P53 BK-16 127-C55 OR-16 6
TDC PROBE (-) 23 G857-EX10 YL-18 B 1275483 CONN 26 1275484 169-P55 PK-16 169-P55 PK-16 126-P114 PK-14 205-P138 BK-18 136-C14 GN-16 C-C13 P-C23 3E3364 3E3364
201-G34 BK-16 2
1
2
1
2
1275484 CONN 45 1275483 AT-C4 AT-C5
1
2
1
2
4 C 177-AWX3 RD-6 1 177-P143 RD-6 105-P62 RD-16 200-P8 BK-16 169-P139 PK-16 403-P58 GN-18 122-C12 BU-16 39
1 1 AT-C2 AT-C3 1552269 1552269 8
124-P29 GN-14 200-P16 BK-16 169-P134 PK-18 410-P96 WH-18 124-C27 GN-14 112-C83 PU-6 112-P144 PU-6 1552269 1552269
DIGITAL SENSOR RETURN 5 129-P102 RD-18 200-P25 BK-18 200-P123 BK-16 200-P61 BK-14 417-P34 GY-18 126-C20 PK-14
570-AT5 BU-18
200-AT6 BK-18
B+ JUNCT BLK CATERPILLAR MONITORING SYSTEM
200-AT4 BK-18
25 UX-C18 144-P101 GN-16 200-P26 BK-16 200-P60 BK-16 419-P121 YL-18 169-C54 PK-16 127-C55 OR-16 C-C15 P-C31
570-AT3 BU-18
9W-0742 160-6567
6
30
9X-1054 AWX-C8 134-P135 RD-16 200-P131 BK-16 200-P66 BK-14 169-P134 PK-18 447-P128 PK-18 129-C5 RD-18 1275484 CONN 44 1275483 290-P118 BK-18
7 30 1552269 136-P35 GN-16 200-P123 BK-16 200-P63 BK-18 169-P139 PK-16 570-P120 BU-16 130-C8 RD-18 177-C82 RD-6 1 177-P143 RD-6 291-P117 BK-18
ANALOG SENSOR RETURN 18 86 86 1 PK-18
G833-EX1 PK-18 FUEL PUMP RELAY 112-R12 PU-6 169-P55 PK-16 200-P106 BK-14 200-P36 BK-14 200-P63 BK-18 575-P77 YL-16 201-C79 BK-18 134-C15 RD-16 498-P100 WH-18
8 3E-5239 85 R-C2 2 BK-18 ART ANGLE SENDER 201-P95 BK-18 200-P104 BK-16 200-P136 BK-12 200-P61 BK-14 576-P74 PK-16 205-C64 BK-18 136-C14 GN-16 C-C5 P-C1
COOLANT TEMPERATURE 32 995-EX4 BU-18
85 87 MAIN RELAY
167-0138
3E3364 187-1008 205-P170 BK-18 200-P105 BK-16 200-P8 BK-16 200-P60 BK-16 577-P75 PU-16 205-C63 BK-18 1552252 CONN 43 3E5179
10 87 87A BK-16 1 1
87a 308-R2 YL-16 308-P150 YL-16 201-P95 BK-18 200-P16 BK-16 200-P36 BK-14 601-P154 GY-18 205-C70 BK-18 147-C78 RD-16 105-C16 RD-16 105-P62 RD-16
11 BK-16 2 200-R1 BK-16 403-P57 GN-18 201-P107 BK-18 200-P25 BK-18 200-P188 BK-18 605-P78 YL-18 205-C72 BK-18 114-C6 RD-16 2 114-P47 RD-16 105-P62 RD-16
INLET AIR TEMPERATURE 35 C967-EX5 BU-18 10 -185 410-P96 WH-18 201-P140 BK-18 200-P106 BK-14 200-P67 BK-18 605-P83 YL-18 290-C88 BK-18 129-C5 RD-18 3 129-P102 RD-18
13 JACKET WTR HEATER 417-P34 GY-18 205-P170 BK-18 200-P131 BK-16 606-P87 GY-18 291-C87 BK-18 130-C8 RD-18 4 130-P54 RD-18 112-P145 PU-6
15 188-1334 177-WW1 RD-4 112-AWX8 PU-6 570-P120 BU-16 205-P171 BK-18 200-P26 BK-16 606-P80 GY-18 498-C4 WH-18 169-C54 PK-16 134-C15 RD-16 5 134-P135 RD-16 112-P144 PU-6
17 BK-16 UX-C3 150-AWX12 RD-16 601-P172 GY-18 308-P65 YL-16 200-P104 BK-16 201-P9 BK-18 611-P30 PU-14 556-C1 WH-16 147-C78 RD-16 6 147-P153 RD-16 113-P93 OR-16
19 BK-16 1552269 177-AWX3 RD-6 728-P42 BU-18 308-P82 YL-16 200-P105 BK-16 200-P67 BK-18 201-P53 BK-16 611-P33 PU-14 601-C31 GY-18 176-C77 RD-14 176-C77 RD-14 7 176-P157 RD-14 114-P47 RD-16 G-C12 SPEEDOMETER/TACH MODULE
A429-G45 YL-18
C436-G55 BU-18
F842-G52 BU-18
G946-G51 OR-18
M998-G6 OR-18
OR-16
YL-18
BK-16
BK-18
BK-18
WH-18
YL-18
PK-18
611-G10 PU-18
150-G53 RD-16
205-G65 BK-18
410-G41 WH-18
439-G50 YL-18
601-G66 GY-18
200-G71 BK-18
922-G49 BR-18
CRANK SPEED/TIMING - 59 GN-16 2 8 1552273 109-0598
403-G5 GN-18
417-G4 GY-18
892-G8 BR-18
893-G9 GN-18
921-G7 WH-18
498-G1 WH-18
E965-EX60 BU-18 JACKET WATER ENGINE FUEL PUMP 308-AWX1 YL-16 F775-P51 BU-18 308-P150 YL-16 200-P188 BK-18 205-P138 BK-18 611-P39 PU-18 601-C32 GY-18 177-C82 RD-6
570-AT1 BU-16
200-AT2 BK-14
CRANK SPEED/TIMING + 58 MOTOR 1
E966-EX59 YL-18 HEATER GP 190-8977 101-UU1 RD-4 403-AWX11 GN-18 462-P99 YL-18 308-P137 YL-16 201-P9 BK-18 205-P174 BK-18 601-C60 GY-18 179-C80 RD-18 179-C80 RD-18 9 179-P148 RD-18 122-P81 BU-16 458-G17 PK-18 1 OR-16 +V DISPLAY
RUN SPEED/TIMING (-) 49 E963-EX62 BK-18 JACKET WATER 187-3068 177-WW1 RD-4 308-P115 YL-16 201-P90 BK-18 201-P126 BK-16 601-C67 GY-18 10 200-P13 BK-14 124-P29 GN-14 201-G18 BK-18 2 BK-16 GROUND
H HEATER CORD 80A
H
113-G40
404-G78
201-G35
290-G42
291-G43
408-G47
419-G46
447-G44
RUN SPEED/TIMING (+) 48 E964-EX61 WH-18 177-AAA1 RD-6 201-P53 BK-16 403-P58 GN-18 619-P37 GN-14 601-C71 GY-18 322-C7 GY-16 11 322-P48 GY-16 126-P114 PK-14 E708-G19 PK-18 3 GN-16 CLOCK
IN AIR HEAT RELAY (-) 9 188-1336 MAIN BREAKER 612-P28 GY-14 403-P57 GN-18 601-P156 GY-18 619-P38 GN-14 608-C26 GN-14 205-C75 BK-18 12 205-P174 BK-18 127-P141 OR-16 C413-G20 YL-18 4 WH-16 DATA
IN AIR HEAT RELAY (+) 12 G850-EX14 BU-18 171-2210 403-P59 GN-18 201-P90 BK-18 601-P154 GY-18 611-C39 PU-14 129-P102 RD-18 G-C4 C414-G21 BU-18 5 YL-16 LOAD
C-C11 P-C38 AT-C1 G-C20 G-C2 1552252 G-C5
26 200-AWX2 BK-16 112-P145 PU-6 201-P107 BK-18 604-P68 OR-18 685-P21 BR-14 130-P54 RD-18 3E3388 3E5179 6 BU-16 ADDRESS SELECT
30 3E5179 CONN 42 1552252 3E3370 3E3364
118-P76 GY-16 601-P167 GY-18 201-P95 BK-18 605-P78 YL-18 685-P22 BR-14 201-C79 BK-18 134-P135 RD-16 G-C23 LAMPS
CONN 51
CONN 52
CONN 50
1
2
31 1
CONN 49
200-AWX10 BK-4 135-P155 BU-16 601-P172 GY-18 201-P140 BK-18 605-P83 YL-18 892-P5 BR-18 685-C22 BR-14 205-C64 BK-18 201-C79 BK-18 201-P9 BK-18 136-P35 GN-16 3E3382 7N-5876
A
B
C
OIL TEMP END 33 109-YY1 RD-4 601-P173 GY-18 205-P174 BK-18 605-P86 YL-18 893-P4 GN-18 205-C63 BK-18 2 P-C49 G-C30 G-C14 G-C15
10
11
12
10
11
12
1
2
3
4
5
6
7
8
1
2
3
4
5
6
7
8
9
1
2
3
4
5
6
7
8
9
OIL TEMP MIDDLE 34 994-EX12 GY-18 109-RRR1 RD-8 80A 604-P41 OR-18 205-P170 BK-18 205-P169 BK-18 606-P87 GY-18 921-P113 WH-18 205-C72 BK-18 498-C4 WH-18 3 498-P100 WH-18 147-P153 RD-16 3E3370 1552269 3T3158
HEP (+) 61 REAR FRAME GROUND BOSS 2 4 3T3158
995-EX4 BU-18 101-EEE1 RD-10 176-P157 RD-14 604-P45 OR-18 205-P171 BK-18 205-P138 BK-18 606-P80 GY-18 922-P133 BR-18 205-C70 BK-18 205-C75 BK-18 556-C1 WH-16 556-P94 WH-16 205-G58 BK-18
CA-C2
A
B
C
HEP (-) 62 A746-EX41 PK-18 ALTERNATOR BREAKER (RH SIDE) 205-P171 BK-18 605-P88 YL-18 606-P79 GY-18 102-C40 RD-14 205-C74 BK-18 5 169-P139 PK-16 601-G62 GY-18
69 A747-EX17 GY-18 A/C CLUTCH SOL 1552269 171-2210 200-AWX10 BK-4 210-P151 BK-18 606-P89 GY-18 308-P137 YL-16 611-P30 PU-14 C436-P164 BU-18 290-C88 BK-18 685-C47 BR-14 6 685-P23 BR-14 P-C4 205-G57 BK-18
P-C16 P-C2 P-C5
290-P118 BK-18
3E5179
A429-P130 YL-18
C436-P164 BU-18
F842-P147 BU-18
G946-P146 OR-18
GN-14
201-P53 BK-16
70 1 7
921-P113 WH-18
291-P117 BK-18
408-P119 WH-18
419-P121 YL-18
447-P128 PK-18
205-P138 BK-18
439-P142 YL-18
498-P100 WH-18
601-P154 GY-18
922-P133 BR-18
C967-EX5 BU-18 3E-1906 589-CA1 GN-16 308-P82 YL-16 308-P115 YL-16 611-P33 PU-14 F842-P147 BU-18 105-C16 RD-16 291-C87 BK-18 176-P157 RD-14 1552264 1552252 601-G61 GY-18
570-P120 BU-16
403-P58 GN-18
417-P34 GY-18
M998-P6 OR-18
113-P92 OR-16
605-P83 YL-18
606-P80 GY-18
611-P39 PU-18
150-P56 RD-16
410-P96 WH-18
200-P63 BK-18
1552267
200-P61 BK-14
892-P5 BR-18
893-P4 GN-18
43 C991-EX85 PK-18 17.6 GN-14 2 522-CA4 WH-16 R-C1 403-AWX11 GN-18 506-P24 PU-16 308-P150 YL-16 611-P39 PU-18 G946-P146 OR-18 322-C7 GY-16 608-C26 GN-14 8 608-P20 GN-14 177-P143 RD-6
OIL GRADE CODE 1 50 1552269 507-P32 WH-16 308-P65 YL-16 611-P69 PU-14 M998-P6 OR-18 114-C6 RD-16 498-C4 WH-18 611-C39 PU-14 9 611-P69 PU-14 179-P148 RD-18 G-C13 QUAD GAGE MOD
51 BK-18 1 306-R6 GN-16 109-AWX9 RD-4 575-P77 YL-16 308-P82 YL-16 614-C44 PU-18 10 1552273 180-9285
52 CA-C3 STARTING RELAY BK-18 2 921-R10 WH-16 576-P74 PK-16 408-P119 WH-18 556-C1 WH-16 619-C38 GN-14 11 619-P70 GN-14 200-P13 BK-14 458-G22 PK-18 1 OR-16
ANALOG SENSOR GROUND 3 E963-EX62 BK-18 ARC SUPPRESSOR A/C 1552269 118-3534 577-P75 PU-16 403-P57 GN-18 439-P142 YL-18 601-C71 GY-18 12 201-P9 BK-18 201-G23 BK-18 2 BK-16 GROUND
ANALOG SENSOR POWER 2 E964-EX61 WH-18 106-8704 1 589-CA2 GN-16 578-P31 BU-16 403-P59 GN-18 403-P58 GN-18 129-C5 RD-18 601-C67 GY-18 205-P174 BK-18 E708-G24 PK-18 3 GN-16 CLOCK
53 E965-EX60 BU-18 2 522-CA5 WH-16 CA-C1 UX-C4 109-RRR1 RD-8 592-P152 BU-18 408-P119 WH-18 130-C8 RD-18 601-C31 GY-18 601-C76 GY-18 C-C20 P-C39 322-P48 GY-16 C413-G25 YL-18 4 WH-16 DATA
56 E966-EX59 YL-18 1552269 3E3364 601-P173 GY-18 601-P156 GY-18 439-P142 YL-18 134-C15 RD-16 601-C60 GY-18 1552252 CONN 41 3E5179 C414-G26 BU-18 5 YL-16 LOAD
57 G826-EX9 BR-18 522-CA7 WH-16 1 1 522-UX66 WH-16 150-R13 RD-14 601-P172 GY-18 601-P154 GY-18 126-P110 PK-14 147-C78 RD-16 601-C32 GY-18 113-C53 OR-16 1 113-P93 OR-16 556-P94 WH-16 6 BU-16 ADDRESS SELECT
OIL GRADE CODE 2 60 G827-EX8 BU-18 A/C PRESSURE SW CA-C4 521-CA6 YL-16 2 2 521-UX65 YL-16 150-R11 RD-14 922-P108 BR-16 601-P167 GY-18 619-P37 GN-14 169-P134 PK-18 601-C73 GY-18 122-C12 BU-16 2 122-P81 BU-16 LAMPS (2)
IAP CONTROL VALVE (+) 63 180-5462 3E3364 101-EEE1 RD-10 306-R6 GN-16 J765-P111 BU-18 601-P173 GY-18 619-P38 GN-14 200-P188 BK-18 605-C46 YL-18 124-C27 GN-14 3 124-P29 GN-14 601-P156 GY-18 7N-5876
UX-C7
ATMOSPHERIC PRESSURE 14 A747-EX17 GY-18 G828-EX23 WH-18 BK-18 1 589-CA3 GN-16 1552269 CONN 55 150-R11 RD-14 921-R10 WH-16 604-P45 OR-18 619-P70 GN-14 200-P67 BK-18 176-C77 RD-14 606-C45 GY-18 127-C55 OR-16 4 127-P141 OR-16 605-P86 YL-18 G-C16
TURBO OUTLET PRESSURE 40 BK-18 2 5 G-C18
A746-EX41 PK-18 521-CA6 YL-16 15A 150-R13 RD-14 150-R9 RD-14 105-P62 RD-16 604-P41 OR-18 177-C82 RD-6 608-C26 GN-14 126-C20 PK-14 126-P114 PK-14 606-P79 GY-18 3T3158 3T3158
ENGINE OIL PRESS 24 994-EX12 GY-18 G828-EX70 WH-18 150-R9 RD-14 A513-P40 PK-18 179-C80 RD-18 611-C39 PU-14 6 608-P20 GN-14 205-G59 BK-18
FUEL PRESSURE 16 C991-EX85 PK-18 G828-EX83 WH-18 ENGINE CONTROL BREAKER 201-P140 BK-18 112-P145 PU-6 604-P68 OR-18 685-P21 BR-14 201-P122 BK-18 614-C28 PU-18 169-C54 PK-16 7 169-P139 PK-16 611-P69 PU-14 601-G63 GY-18
ANALOG SENSOR POWER 41 G829-EX19 GN-18 6T-3643 R-C5 JJJ-C1 419-P121 YL-18 112-P144 PU-6 605-P86 YL-18 685-P22 BR-14 604-P68 OR-18 8 205-G60 BK-18
ANALOG SENSOR GROUND 42 1275486 CONN 25 1275485 113-P91 OR-16 605-P78 YL-18 685-P23 BR-14 205-C74 BK-18 9 601-G64 GY-18
RAIL PRESSURE 27 G829-EX84 GN-18 1 126-P1 PK-14 118-P76 GY-16 605-P88 YL-18 605-P83 YL-18 892-P5 BR-18 322-C7 GY-16 614-C44 PU-18 136-C14 GN-16 10 136-P35 GN-16 619-P70 GN-14 P-C41
INJECTOR 1 36 G829-EX21 GN-18 ENGINE 122-P81 BU-16 893-P4 GN-18 F775-P51 BU-18 290-C88 BK-18 11 290-P118 BK-18 685-P23 BR-14 1552269
INJECTOR 2 37 12 1 LH AIR PRESS. GAGE RH AIR PRESS. GAGE
G833-EX1 PK-18 15A 124-P29 GN-14 606-P89 GY-18 606-P80 GY-18 F843-P112 YL-18 601-C73 GY-18 291-C87 BK-18 291-P117 BK-18 LH BLADE FLOODLAMP
G R-C3 AWX-C1 1W-3306 1W-3306
INJECTOR 3
INJECTOR 4
INJECTOR 5
38
39
54
G833-EX2 PK-18
G833-EX3 PK-18
HEADLAMP/RH POS LAMPS BKR
3T-2662
1552273 CONN
1
24 3E3382
150-AWX12 RD-16
113-P91 OR-16
126-P1 PK-14
201-P107 BK-18
205-P168 BK-18
308-P137 YL-16
129-P102 RD-18
134-P135 RD-16
136-P35 GN-16
606-P79 GY-18
606-P87 GY-18
611-P69 PU-14
114-P47 RD-16
127-P141 OR-16
605-C46
606-C45
614-C28
YL-18
GY-18
PU-18 619-C38 GN-14
C-C21
3E5179 CONN
P-C35
40 1552252
685-P21 BR-14 2
P-C40
153-2073
LAMP
7N-5876
LAMP
7N-5876
G
FUEL LEVEL SENDER UX-C10 3E3364
INJECTOR 6 55 173-2018 200-R1 BK-16 2 200-AWX2 BK-16 147-P153 RD-16 611-P30 PU-14 130-P54 RD-18 685-C48 BR-18 1
INJECTOR 1 RET 44 1552269 3 2 G-C29 G-C24
308-R2 YL-16 308-AWX1 YL-16 201-P107 BK-18 150-P56 RD-16 611-P33 PU-14 105-P62 RD-16 322-P48 GY-16 685-C22 BR-14 685-C47 BR-14 601-C76 GY-18 601-P156 GY-18 3T3158 3T3158
INJECTOR 2 RET 45 PK-18 1 15A 4 205-P168 BK-18 611-P39 PU-18 3
INJECTOR 3 RET 46 BK-18 2 5 447-P128 PK-18 112-P145 PU-6 114-P47 RD-16 L987-C58 WH-18 4 P-C8 205-G68 BK-18
INJECTOR 4 RET 47 TURN/HAZZARD/LH-POS/PANL LMP 6 308-P137 YL-16 601-P167 GY-18 176-P157 RD-14 112-P144 PU-6 127-P141 OR-16 685-C48 BR-18 5 1552269 601-G67 GY-18
22 -255 3T-2662
INJECTOR 5 RET 67 177-P143 RD-6 130-P54 RD-18 605-C46 YL-18 10 605-P86 YL-18 1 RH BLADE FLOODLAMP 205-G70 BK-18
INJECTOR 6 RET 68 R-C4 AWX-C3 179-P148 RD-18 118-P76 GY-16 322-P48 GY-16 606-C45 GY-18 11 606-P79 GY-18 2 153-2073 601-G69 GY-18
BRAKE 1 RET 20 J702-EX26 BK-18 SERVICE CENTER 1275484 CONN 231275483 122-P81 BU-16 12
BRAKE 2 RET 21 112-R12 PU-6 1 112-AWX8 PU-6 410-P96 WH-18 124-P29 GN-14 105-P62 RD-16 L987-C58 WH-18 8 P-C46
RENR9555-01 VOL 2 of 2
BRAKE 3 RET 28 601-P167 GY-18 921-P113 WH-18 417-P34 GY-18 129-P102 RD-18 L987-C58 WH-18 6 3E3364
BRAKE 4 RET 29 202-UX76 BK-16 AAA-C1 AWX-C6 922-P108 BR-16 419-P121 YL-18 134-P135 RD-16 112-P145 PU-6 7 P-C19 L
BRAKE 5 RET 65 202-UX77 BK-16 XMSN CONTROL
1275484 CONN 221275483 C912-P161 GN-18 136-P35 GN-16 112-P144 PU-6 9 1552273
GND
BRAKE 6 RET 66 UX-C11 J1 177-AAA1 RD-6 1 177-AWX3 RD-6 C436-P164 BU-18 447-P128 PK-18 619-P37 GN-14 147-P153 RD-16 113-P93 OR-16 200-P60 BK-16 2 BK-16 MOTOR H
1010205 172-9389
IAP CONTROL VALVE (-) 64 126-UX30 PK-16 556-P94 WH-16 619-P38 GN-14 150-P56 RD-16 COM NO 1
126-UX31 PK-16 126-UX30 PK-16 1 + BATTERY YY-C1 AWX-C7 921-P113 WH-18 570-P120 BU-16 619-P70 GN-14 122-P81 BU-16 INCHING PEDAL LIMIT SW 576-P74 PK-16 4 GN-16 T
36 126-UX32 PK-18 126-UX31 PK-16 6 + BATTERY 1275484 CONN 211275483 922-P108 BR-16 F842-P147 BU-18 575-P77 YL-16 124-P29 GN-14 NC 112-6175 290-P118 BK-18 113-P92 OR-16 118-P76 GY-16 6 GY-16
B+ P
37 126-UX47 PK-14 126-UX32 PK-18 28 LOCATION CODE ENABLE 109-YY1 RD-4 1 109-AWX9 RD-4 C912-P161 GN-18 F843-P112 YL-18 576-P74 PK-16 176-P157 RD-14 126-P114 PK-14 291-P117 BK-18 150-P56 RD-16 575-P77 YL-16 3 BR-16
38 126-UX79 PK-16 8 CRANKING RELAY C436-P164 BU-18 G946-P146 OR-18 577-P75 PU-16 685-P21 BR-14 177-P143 RD-6 129-P102 RD-18 498-P100 WH-18 577-P75 PU-16 5 OR-16
39 202-UX75 BK-16 126-UX17 PK-18 307-UX57 OR-16 40 KEYSWITCH 'S' H746-P158 YL-16 608-P20 GN-14 685-P22 BR-14 179-P148 RD-18 134-P135 RD-16 200-P63 BK-18 LH HIGH/LOW/POSITION/TURN LAMP
FRONT LOWER WIPER
BATTERY (+) 48 921-UX24 WH-16 7 SOL RETURN 1 H747-P165 BR-16 685-P23 BR-14 136-P35 GN-16 COM NO 200-P61 BK-14 3E-6388 105-4849 (RH TRAFFIC)
BATTERY (+) 52 202-UX76 BK-16 J764-UX28 BR-18 22 LOCATION CODE 0 308-UX91 YL-16 F842-P147 BU-18 J765-P111 BU-18 417-P34 GY-18 BRAKE PEDAL LIMIT SW 201-P53 BK-16
BATTERY (+) 53 21 LOCATION CODE 1 112-6175 AK-C8
55
308-UX91 YL-16
432-UX101 PK-18
202-UX77 BK-16 J764-UX26 BR-18
38 LOCATION CODE 2
432-UX101 PK-18
C912-UX102 GN-18
CONN 20 F843-P112
G946-P146
YL-18
OR-18
921-P113 WH-18
J765-P111 BU-18
922-P133 BR-18 410-P96 WH-18
419-P121 YL-18
147-P153 RD-16 NC 113-P92 OR-16
118-P76 GY-16
205-P138 BK-18
290-P118 BK-18 1552273
57 892-UX68 BR-18 126-UX17 PK-18 307-UX57 OR-16 14 F842-UX90 BU-18 P-C58 P-C57 H746-P158 YL-16 M998-P6 OR-18 C436-P164 BU-18 169-P139 PK-16 291-P117 BK-18 5
CAT DATA LINK + 8 893-UX67 GN-18 751-UX1 GN-16 J764-UX27 BR-18 15 SWITCH RETURN G946-UX89 OR-18 3E3382 1552273 H747-P165 BR-16 R800-P159 OR-18 447-P128 PK-18 403-P58 GN-18 611-AK1 PU-14 4 BU-18
CAT DATA LINK - 9 752-UX2 YL-16 J765-UX29 BU-18 16 SENSOR RETURN H746-UX100 YL-16 1 J765-P111 BU-18 R998-P160 BR-18 556-P94 WH-16 176-P157 RD-14 150-P56 RD-16 619-AK3 GN-14 6 RD-18
1 A983-UX88 BU-18 754-UX5 BU-16 751-UX1 GN-16 893-UX58 GN-18 9 + CAT DATA LINK H747-UX107 BR-16 PRODUCT 2 200-P98 BK-14 F775-P51 BU-18 892-P5 BR-18 570-P120 BU-16 177-P143 RD-6 408-P119 WH-18 3 WH-18
6 C912-UX102 GN-18 755-UX6 OR-16 752-UX2 YL-16 892-UX59 BR-18 3 - CAT DATA LINK R800-UX104 OR-18 LINK 3 200-P103 BK-14 F842-P147 BU-18 575-P77 YL-16 126-P110 PK-14 200-P63 BK-18 410-P96 WH-18 1 YL-18
KEYSWITCH "S" 64 900-UX7 PU-16 754-UX5 BU-16 18 R998-UX103 BR-18 CONNECTOR 4 M998-P6 OR-18 F843-P112 YL-18 576-P74 PK-16 201-P122 BK-18 200-P61 BK-14 417-P34 GY-18 200-AK7 BK-14 2 BK-18
F F
7 C978-UX86 BR-18 901-UX8 WH-16 755-UX6 OR-16 33 XMSN FILTER BYPASS SW 5 R800-P159 OR-18 200-P103 BK-14 G946-P146 OR-18 577-P75 PU-16 200-P60 BK-16 419-P121 YL-18
10 902-UX9 BR-16 M998-UX51 OR-18 12 AUTOSHIFT INDICATOR 6 R998-P160 BR-18 200-P98 BK-14 608-P20 GN-14 179-P148 RD-18 F843-P112 YL-18 200-P36 BK-14 439-P142 YL-18
22 F842-UX90 BU-18 903-UX10 GY-16 892-UX73 BR-18 27 INCHING PEDAL LIMIT SW N/O 892-UX68 BR-18 200-P98 BK-14 200-P13 BK-14 P-C50 201-P53 BK-16 447-P128 PK-18
11 G946-UX89 OR-18 921-UX3 WH-16 751-UX1 GN-16 10 XMSN SOL 3 893-UX67 GN-18 200-P103 BK-14 200-P106 BK-14 M998-P6 OR-18 201-P9 BK-18 1552267 205-P138 BK-18 498-P100 WH-18
12 H746-UX100 YL-16 922-UX4 BR-16 892-UX68 BR-18 892-UX59 BR-18 752-UX2 YL-16 4 XMSN SOL 1 200-P103 BK-14 200-P104 BK-16 921-P113 WH-18 205-P174 BK-18 A OR-18 PWR (+24V) INCHING PEDAL POS SNSR 403-P58 GN-18
THROTTLE LOCK 44 C975-UX78 WH-18 H747-UX107 BR-16 G460-UX19 GN-18 892-UX71 BR-18 754-UX5 BU-16 17 XMSN SOL 2 A983-UX88 BU-18 200-P98 BK-14 200-P105 BK-16 A429-P130 YL-18 B BK-18 GROUND 570-P120 BU-16
SPEED CENTER POS 23 J765-UX18 BU-18 755-UX6 OR-16 11 XMSN SOL 8 C975-UX78 WH-18 CONN 19 307-P17 OR-16 C436-P164 BU-18 556-P94 WH-16 C WH-18 SIGNAL
147-1680
408-P119 WH-18 601-P154 GY-18
THROTTLE HOLD 35 R800-UX104 OR-18 893-UX74 GN-18 34 C978-UX86 BR-18 UX-C13 P-C34 521-P116 YL-16 601-P156 GY-18 P-C29 410-P96 WH-18 605-P83 YL-18 RH HIGH/LOW/POSITION/TURN LAMP
13 R998-UX103 BR-18 E900-UX23 WH-18 977-UX50 YL-18 32 AUTOSHIFT SW C979-UX87 OR-18 9X0141 9X1343 522-P97 WH-16 605-P86 YL-18 1552269 417-P34 GY-18 606-P80 GY-18 105-4850 (RH TRAFFIC)
14 E901-UX22 GN-18 893-UX67 GN-18 893-UX58 GN-18 E974-UX82 GN-18 36 INCH PEDAL LIMIT SW N/C 113-UX46 OR-16 1 113-P91 OR-16 977-P11 YL-18 F775-P51 BU-18 606-P79 GY-18 130-P54 RD-18 1 BK-18 STOP LAMP SW P-C27 419-P121 YL-18 611-P39 PU-18
SPEED SET/ACCEL 40 E902-UX13 PU-18 893-UX72 GN-18 202-UX76 BK-16 2 - BATTERY 126-UX47 PK-14 2 126-P1 PK-14 J764-P109 BR-18 F842-P147 BU-18 608-P20 GN-14 604-P68 OR-18 2 BK-18 3E-2026 1552269 439-P142 YL-18 AK-C9
16 E903-UX14 YL-18 900-UX7 PU-16 202-UX77 BK-16 5 - BATTERY 892-UX68 BR-18 3 201-P107 BK-18 F843-P112 YL-18 611-P69 PU-14 488-P44 WH-18 1 BK-18 LH BRAKE SYSTEM PRESS SWITCH 447-P128 PK-18 892-P5 BR-18 P-C17 AM-C1 AM-C2 AK-C1 1552273
SPEED RESUME/DECEL 41 C979-UX87 OR-18 E904-UX16 BR-18 901-UX8 WH-16 E949-UX45 YL-18 37 NEUTRAL 893-UX67 GN-18 205-UX109 BK-18 4 205-P168 BK-18 G946-P146 OR-18 2 BK-18 114-9281 570-P120 BU-16 893-P4 GN-18 1552252 CONN 48 3E5179 1552252 CONN 53 3E5179 5
24 E905-UX15 BU-18 902-UX9 BR-16 E948-UX44 BU-18 25 PARK 5 307-P17 OR-16 P-C30 575-P77 YL-16 921-P113 WH-18 200-P36 BK-14 1 1 200-AK12 BK-14 611-AK2 PU-14 4 BU-18
25 903-UX10 GY-16 E947-UX43 WH-18 31 REVERSE A983-UX88 BU-18 308-UX91 YL-16 6 308-P137 YL-16 619-P70 GN-14 1552269 576-P74 PK-16 922-P133 BR-18 2 2 200-AK11 BK-14 619-AK4 GN-14 6 RD-18
THROTTLE HOLD IND 28 921-UX24 WH-16 E946-UX42 OR-18 39 FORWARD C975-UX78 WH-18 432-UX101 PK-18 7 M998-P6 OR-18 685-P23 BR-14 114-P47 RD-16 1 RD-18 FORWARD HORN SOLENOID 577-P75 PU-16 A429-P130 YL-18 605-P78 YL-18 3 3 200-AK12 BK-14 200-AK7 BK-14 3 WH-18
34 E908-UX21 BR-18 921-UX55 WH-18 E945-UX41 PU-18 13 EIGHTH C978-UX86 BR-18 8 322-P48 GY-16 2 RD-18 188-9250 P-C28 601-P154 GY-18 606-P87 GY-18 4 4 1 YL-18
AIH INDICATOR 30 E909-UX20 WH-18 921-UX3 WH-16 E944-UX40 GY-18 19 SEVENTH C979-UX87 OR-18 9 1552269 605-P78 YL-18 C436-P164 BU-18 5 5 200-AK11 BK-14 2 BK-18
17 202-UX75 BK-16 E943-UX39 BR-18 23 SIXTH 521-UX65 YL-16 10 521-P116 YL-16 408-P119 WH-18 1 BK-18 RH BRAKE SYSTEM PRESS SWITCH 605-P83 YL-18 611-P33 PU-14 6 6 611-AK1 PU-14 611-AK1 PU-14
SWITCH RETURN 18 892-UX71 BR-18 922-UX4 BR-16 E942-UX38 GN-18 35 FIFTH 522-UX66 WH-16 11 522-P97 WH-16 488-P44 WH-18 2 BK-18 114-9281 606-P87 GY-18 F842-P147 BU-18 7 7 611-AK2 PU-14
FUEL PUMP 19 29 FOURTH 12 8 8
200-P106 BK-14
200-P104 BK-16
200-P105 BK-16
200-P103 BK-14
893-UX72 GN-18 922-UX25 BR-16 E941-UX37 YL-18 601-UX110 GY-18 601-P167 GY-18 606-P80 GY-18 G946-P146 OR-18 611-P30 PU-14 611-AK2 PU-14
200-P98 BK-14
20 126-UX79 PK-16 922-UX48 BR-16 E940-UX36 BU-18 20 THIRD 307-UX57 OR-16 13 P-C9 CENTERSHIFT PIN SOLENOID 611-P30 PU-14 M998-P6 OR-18 9 9
26 E937-UX33 PU-18 977-UX50 YL-18 E939-UX35 WH-18 24 SECOND 14 1552269 152-8346 611-P33 PU-14 118-P76 GY-16 619-P38 GN-14 10 10 619-AK3 GN-14 619-AK3 GN-14
29 E938-UX34 OR-18 C436-UX106 BU-18 E938-UX34 OR-18 30 FIRST 205-UX109 BK-18 15 F775-P51 BU-18 1 GN-18 611-P39 PU-18 11 11 619-AK4 GN-14
31 26 REDUNDANT NEUTRAL 16 P-C15 2 GN-18 12 12
30 Page, Color 2,
E939-UX35 WH-18 E937-UX33 PU-18 126-UX47 PK-14 892-UX73 BR-18 200-P67 BK-18 619-P37 GN-14 619-AK4 GN-14
32 E940-UX36 BU-18 E900-UX23 WH-18 601-UX110 GY-18 17 1552269 200-P60 BK-16
SHUTDOWN SWITCH N/C 56 E941-UX37 YL-18 E901-UX22 GN-18 5 892-UX73 BR-18 893-UX74 GN-18 18 419-P121 YL-18 1 BK-18 PARK BRAKE PRESS SW P-C10 CENTERSHIFT INDICATOR SWITCH 619-P37 GN-14 200-P36 BK-14
SHUTDOWN SWITCH N/O 54 E942-UX38 GN-18 E902-UX13 PU-18 6 113-UX46 OR-16 921-UX55 WH-18 19 921-P113 WH-18 201-P140 BK-18 2 BK-18 114-9281 1552272 3E-3636 619-P38 GN-14 575-P77 YL-16
1 2
FAN DRIVE PRESS SENS 15 E943-UX39 BR-18 E903-UX14 YL-18 9 893-UX74 GN-18 922-UX48 BR-16 20 922-P108 BR-16 1 WH-18 WH-18 576-P74 PK-16
4 3 P-C6
50 E944-UX40 GY-18 E904-UX16 BR-18 F843-UX54 YL-18 4 INCHING PEDAL POS SENSOR 921-UX55 WH-18 977-UX50 YL-18 21 977-P11 YL-18 439-P142 YL-18 4 WH-18 WH-18 685-P21 BR-14 577-P75 PU-16
FAN DRIVE SOL RETURN 51 E945-UX41 PU-18 E905-UX15 BU-18 11 922-UX48 BR-16 C436-UX106 BU-18 22 C436-P164 BU-18 169-P134 PK-18 3 1552269 605-P78 YL-18
FAN DRIVE SOL 43 E946-UX42 OR-18 12 977-UX50 YL-18 C912-UX102 GN-18 23 C912-P161 GN-18 P-C54 P-C51 2 1 BK-16 HYD TEMP SWITCH 892-P5 BR-18 606-P87 GY-18
3E3364 131-4135
BK-14
BK-16
BK-14
BK-14
BK-16
1552269 K-C39
E E
ANALOG SENSOR PWR 2 E947-UX43 WH-18 13 C436-UX106 BU-18 E974-UX82 GN-18 24 2 BK-16 893-P4 GN-18 611-P30 PU-14
ANALOG SENSOR RETURN 3 E948-UX44 BU-18 E908-UX21 BR-18 15 F842-UX90 BU-18 25 F842-P147 BU-18 1 921-P113 WH-18 611-P33 PU-14 1552269
P-C25 K-C5 T LH HEATED MIRROR
27 E949-UX45 YL-18 E909-UX20 WH-18 16 E974-UX82 GN-18 F843-UX54 YL-18 26 F843-P112 YL-18 2 922-P133 BR-18 619-P37 GN-14 1 WH-16
1275483 CONN 35 1275484 192-1994
200-P106
200-P105
200-P103
200-P104
58 J766-UX105 PU-18 E937-UX33 PU-18 17 F843-UX54 YL-18 G946-UX89 OR-18 27 G946-P146 OR-18 A429-P130 YL-18 619-P38 GN-14 2 BK-16
200-P98
SNOW WING LAMP COUPLER DIODE
60 113-UX46 OR-16 E938-UX34 OR-18 18 J764-UX52 BR-18 H746-UX100 YL-16 28 H746-P158 YL-16 112-P145 PU-6 1 112-K40 PU-6 106-8704 C436-P164 BU-18 K-C40
33 201-UX81 BK-18 E939-UX35 WH-18 C436-UX106 BU-18 19 FILTER BYPASS IND J765-UX53 BU-18 H747-UX107 BR-16 29 H747-P165 BR-16 F842-P147 BU-18 685-P21 BR-14 3E3364
21 205-UX109 BK-18 E940-UX36 BU-18 21 J764-UX52 BR-18 30 J764-P109 BR-18 P-C20 K-C3 127-P141 OR-16 P-C11 G946-P146 OR-18
62 601-UX110 GY-18 E941-UX37 YL-18 22 M998-UX51 OR-18 J765-UX53 BU-18 31 J765-P111 BU-18 1552252 CONN 34 3E5179 112-K40 PU-6 P-C55
3E3364
P-C52 200-P188 BK-18 1552269 M998-P6 OR-18
KEY SWITCH "ON" 70 A755-UX113 PK-18 E942-UX38 GN-18 32 201-UX81 BK-18 32 118-P76 GY-16 1 118-K58 GY-16 118-K58 GY-16 1552269 127-P141 OR-16 1 YL-18 PARK BRAKE SOLENOID K-C41
THROTTLE POSITION 66 A983-UX88 BU-18 E943-UX39 BR-18 26 33 135-P155 BU-16 2 135-K35 BU-16 135-K35 BU-16 1 200-P188 BK-18 2 YL-18 188-9250 1552269
DIGITAL SENSOR RETURN 5 ENGINE C975-UX78 WH-18 E944-UX40 GY-18 G460-UX19 GN-18 10 XMSN TEMP SENSOR M998-UX51 OR-18 34 M998-P6 OR-18 3 144-K62 GN-16 176-K67 RD-14 2 1 WH-16 RH HEATED MIRROR
DIGITAL SENSOR PWR 4 C978-UX86 BR-18 E945-UX41 PU-18 27 R800-UX104 OR-18 35 R800-P159 OR-18 176-P157 RD-14 4 176-K67 RD-14 210-K36 BK-18 2 BK-16 192-1994
MOLDBOARD LAMPS COUPLER DIODE
68 C979-UX87 OR-18 E946-UX42 OR-18 28 36 5 308-K34 YL-16 106-8704 K-C42
SERVICE BRAKE SW 59 E947-UX43 WH-18 25 + XMSN OUTPUT SPEED SENSOR 2 521-UX65 YL-16 R998-UX103 BR-18 37 R998-P160 BR-18 6 592-K37 BU-18 FRONT FRAME GND BOSS 3 3E3364
69 113-UX46 OR-16 E948-UX44 BU-18 31 - XMSN OUTPUT SPEED SENSOR 2 522-UX66 WH-16 38 205-P171 BK-18 7 205-K2 BK-18 (LH SIDE)
SOLENOID RETURN 67 201-UX81 BK-18 E949-UX45 YL-18 33 39 447-P128 PK-18 210-P151 BK-18 8 210-K36 BK-18 M-C2
BATTERY (-) 65 205-UX109 BK-18 E974-UX82 GN-18 922-UX25 BR-16 3 SOL RETURN 2 40 308-P82 YL-16 9 308-K34 YL-16 1552269 K-C17
BATTERY (-) 61 601-UX110 GY-18 F843-UX54 YL-18 34 10 321-K15 BR-18 A513-K3 PK-18 609-M1 YL-16 1 SNOW WING LAMP 6T6505
GROUND LEVEL SHUTDOWN SW
BATTERY (-) 63 139-2116 A755-UX113 PK-18 G460-UX19 GN-18 E904-UX16 BR-18 36 + XMSN INT SPEED SENSOR 2 506-P24 PU-16 11 506-K5 PU-16 144-K62 GN-16 200-M2 BK-16 2 153-2073 508-K48 PU-18 + LH SPEAKER
FUEL FILTER BYPASS SW 49 A983-UX88 BU-18 J764-UX26 BR-18 E905-UX15 BU-18 30 - XMSN INT SPEED SENSOR 2 507-P32 WH-16 12 507-K7 WH-16 205-K2 BK-18 509-K49 WH-18 - 6T-7695
42 UX-C19 C979-UX87 OR-18 J764-UX27 BR-18 38 321-K15 BR-18 K-C18
45 1552267 C978-UX86 BR-18 J764-UX28 BR-18 E902-UX13 PU-18 24 + XMSN INT SPEED SENSOR 1 506-K5 PU-16 6T8047
46 BK-18 A E903-UX14 YL-18 35 - XMSN INT SPEED SENSOR 1 P-C7 K-C32 507-K7 WH-16
THROTTLE HOLD OFF 47 WH-18 C C975-UX78 WH-18 J764-UX52 BR-18 39 3E5179 CONN 33 1552252 575-K8 YL-16
RD-18 B 126-UX47 PK-14 E908-UX21 BR-18 29 + XMSN INPUT SPEED SENSOR 575-P77 YL-16 1 575-K8 YL-16 576-K10 PK-16 K-C9
UX-C15 307-UX57 OR-16 J765-UX29 BU-18 E909-UX20 WH-18 23 - XMSN INPUT SPEED SENSOR 576-P74 PK-16 2 576-K10 PK-16 577-K9 PU-16 1552269
1607689 921-UX55 WH-18 J765-UX53 BU-18 40 577-P75 PU-16 3 577-K9 PU-16 578-K6 BU-16 1 WH-16 LH CAB POS LAMP
J1 922-UX48 BR-16 J765-UX18 BU-18 E900-UX23 WH-18 20 + XMSN OUTPUT SPEED SENSOR 1 578-P31 BU-16 4 578-K6 BU-16 601-K33 GY-18 2 BK-16 212-3924
14 AWG 977-UX50 YL-18 E901-UX22 GN-18 14 - XMSN OUTPUT SPEED SENSOR 1 592-P152 BU-18 5 592-K37 BU-18 612-K17 GY-14
2 XMSN SOL 7 6 K-C22
STRAP 7X-6315 C436-UX106 BU-18 903-UX10 GY-16 601-P173 GY-18 601-K33 GY-18 3E3364
ENGINE BLOCK 902-UX9 BR-16 8 XMSN SOL 5 7 ABBREV COLOR
E974-UX82 GN-18 901-UX8 WH-16 1 XMSN SOL 6 8 K-C8
A503-K21 PK-16
A506-K22 OR-16
L
144-K62 GN-16
321-K15 BR-18
576-K10 PK-16
601-K33 GY-18
612-K17 GY-14
117-K14 YL-14
118-K23 GY-16
141-K12 PK-16
148-K18 WH-16
151-K20 GN-16
200-K54 BK-14
501-K24 GN-16
502-K26 OR-16
500-K25 BR-16
205-K2 BK-18
506-K5 PU-16
507-K7 WH-16
575-K8 YL-16
577-K9 PU-16
578-K6 BU-16
119-K1 PK-16
F843-UX54 YL-18 J766-UX105 PU-18 900-UX7 PU-16 7 XMSN SOL 4 9 AUX BACKUP LAMP RLY 1552273
D T-C1 UX-C1
J764-UX52
J765-UX53
BR-18
BU-18
M998-UX51 OR-18 37 BACKUP ALARM 612-P28 GY-14 10
11
612-K17 GY-14 N-C1
9X1054
3E-5239 200-K45 BK-16 2
1
BK-16
GND MOTOR H K-C25
1552269
RD
WH
OR
RED
WHITE
ORANGE
D
T-C2 3E5179 CONN 8 1552252 UX-C12 J2 A513-P40 PK-18 12 A513-K3 PK-18 117-N1 YL-14 1
30
108-K61 RD-16 501-K24 GN-16 4 GN-16 T 1 LH OUTER CAB FLOODLAMP YL YELLOW
1552269 1 3E6287 5 86 6 GY-16 2
751-T1 GN-16 751-UX1 GN-16 647-N2 GN-18 112-K40 PU-6 112-K40 PU-6 118-K56 GY-16 B+ P 200-K4 BK-14 153-2073 PK PINK
XMSN SOL 3 (REVERSE) GN-16 1 751-T1 GN-16 752-T3 YL-16 2 752-UX2 YL-16 M998-UX51 OR-18 14 AWG 200-N3 BK-18 2 118-K58 GY-16 117-K14 YL-14 112-K40 PU-6 500-K25 BR-16 3 BR-16
145-1144 85 K-C31 K-C6 BK BLACK
GN-16 2 921-T2 WH-16 754-T5 BU-16 3 754-UX5 BU-16 892-UX68 BR-18 STRAP 7X-6315 612-N4 GY-14 4 135-K35 BU-16 118-K58 GY-16 118-K56 GY-16 117-K14 YL-14 502-K26 OR-16 5 OR-16 GY GRAY
8.5 87 1747566 3E3364
755-T7 OR-16 4 755-UX6 OR-16 893-UX67 GN-18 PLATFORM SHIFT CONSOLE RIGHT CAB HEADLINER 3 176-K67 RD-14 118-K23 GY-16 118-K55 GY-16 PU PURPLE
87a OVERHEAD FUSE FRONT UPPER WIPER MOTOR K-C26
751-T1 GN-16 5 892-UX73 BR-18 210-K36 BK-18 118-K55 GY-16 119-K1 PK-16 112-K40 PU-6 3E-6388 BR BROWN
609-M1 YL-16
T-C3 BLOCK 1552269
752-T3 YL-16 900-T9 PU-16 6 900-UX7 PU-16 893-UX74 GN-18 119-J5 PK-16 308-K34 YL-16 119-K1 PK-16 141-K12 PK-16 GN GREEN
200-M2 BK-16
GY-14
BK-18
GN-18
YL-14
XMSN SOL 1 (FWD HIGH) 1552269 754-T5 BU-16 901-T11 WH-16 7 901-UX8 WH-16 200-J1 BK-16 200-J9 BK-16 592-K37 BU-18 135-K35 BU-16 148-K18 WH-16 BUSS 1
145-1144 LH INNER CAB FLOODLAMP BU BLUE
GN-16 1 752-T3 YL-16 755-T7 OR-16 902-T13 BR-16 8 902-UX9 BR-16 200-J11 BK-16 141-K12 PK-16 151-K20 GN-16 POINT 1 200-K19 BK-14 2 153-2073
8.5 17
A506-K22 OR-16
A503-K21 PK-16
GN-16 2 921-T4 WH-16 900-T9 PU-16 903-T15 GY-16 9 903-UX10 GY-16 200-J12 BK-16 148-K18 WH-16
601-K33 GY-18
118-K23 GY-16
576-K10 PK-16
141-K12 PK-16
151-K20 GN-16
148-K18 WH-16
117-K14 YL-14
321-K15 BR-18
500-K25 BR-16
501-K24 GN-16
502-K26 OR-16
144-K62 GN-16
200-K54 BK-14
612-K17 GY-14
205-K2 BK-18
507-K7 WH-16
119-K1 PK-16
578-K6 BU-16
506-K5 PU-16
575-K8 YL-16
577-K9 PU-16
200-N3
647-N2
117-N1
612-N4
901-T11 WH-16 10 503-J7 BR-16 151-K20 GN-16 FUSE 1 FUSE 2 K-C12 AR-C1 +24V IN K-C19
FRONT WIPERS AUX BACKUP LAMPS 1552269 3E3364
902-T13 BR-16 921-T18 WH-16 11 921-UX3 WH-16 504-J6 YL-16 118-K55 GY-16 15A 10A 3E3364 200-AR3 BK-12 GROUND SYMBOL DESCRIPTION
A504-J3 GN-16
A507-J2 YL-16
505-J8 BU-16
200-J9 BK-16
603-J4 PK-16
504-J6 YL-16
119-J5 PK-16
503-J7 BR-16
T-C4 903-T15 GY-16 922-T17 BR-16 12 922-UX4 BR-16 505-J8 BU-16 A513-K3 PK-18 1 2 176-K67 RD-14 1 1 176-AR1 RD-14
XMSN SOL 2 (FWD LOW) 1552269 N-C2 BLADE, SPADE, RING,
921-T6 WH-16 Y-C7 603-J4 PK-16 117-K14 YL-14 176-K67 RD-14 REAR WIPERS FUSE 3 FUSE 4 SNOW WING LAMP 308-K34 YL-16 2 2 308-AR2 YL-16 +12V OUT OR SCREW TERMINAL
145-1144 GN-16 1 754-T5 BU-16 921-T8 WH-16 126-UX17 PK-18 3E7996 A504-J3 GN-16 3E3376 118-K23 GY-16 200-K52 BK-16 118-K56 GY-16 119-K1 PK-16 10A 10A CAB GND BOSS 3 FR DEFROST RES
A M-C1 K-C35 K-C2 K-C1 4 K-C16
J764-P109 BR-18
8.5 7T-4003
CONN 39
GN-16 2 A 3 (UPPER CAB)
129-P102 RD-18
134-P135 RD-16
144-P101 GN-16
205-P170 BK-18
308-P150 YL-16
570-P120 BU-16
601-P172 GY-18
F775-P51 BU-18
200-P103 BK-14
521-P116 YL-16
921-T6 WH-16 921-T4 WH-16 921-T18 WH-16 J765-UX18 BU-18 601-Y15 GY-18 A507-J2 YL-16 119-K1 PK-16 135-K35 BU-16 IGNITION
CONN 31
1552272
124-P29 GN-14
105-P62 RD-16
136-P35 GN-16
169-P55 PK-16
201-P95 BK-18
403-P57 GN-18
410-P96 WH-18
417-P34 GY-18
462-P99 YL-18
728-P42 BU-18
200-P98 BK-14
307-P17 OR-16
522-P97 WH-16
977-P11 YL-18
3E3364 3E5179 1552252 3E3364 K-C24 K-C23
B FUSE 5 FUSE 6
1
2
3
4
921-T2 WH-16 G460-UX19 GN-18 205-Y18 BK-18 141-K12 PK-16 200-K53 BK-16 176-K67 RD-14
CONN 36
CONN 38
CIRCUIT CONNECTED
CONN 37
B FRONT DEFROSTER
CONN 61
CONN 32
6T6505 6T6505
1
2
922-T12 BR-16 169-Y20 PK-16 1 Y-C9 148-K18 WH-16 200-K45 BK-16 141-K12 PK-16 10A 10A 24V TO 12V CONVERTER 3
1
2
3
4
2 L-C14 K-C36 L-C15 CIRCUIT NOT CONNECTED
T-C5 922-T10 BR-16 922-T17 BR-16 169-Y2 PK-16 2 3E7996 J-C4 3E3376 151-K20 GN-16 200-K52 BK-16 5 6 (COMMUNICATIONS RADIO) A503-K21 PK-16
A 3E3364 3E3376
10
11
12
10
11
12
XMSN SOL 8 (HIGH RANGE) 1552269 3E-8646
1
2
3
4
5
6
7
8
9
7
8
6
4
3
5
9
1
2
3 A FUSE 7 FUSE 8 ELECTRICAL CONNECTION
1
2
3
4
922-T14 BR-16 570-Y19 BU-16 601-Y40 GY-18 3E3388 200-K53 BK-16 REAR DEFROSTER
186-1526 3 NOTE C FRONT DEFROSTER FAN TO MACHINE STRUCTURE
1
2
3
4
5
6
7
8
1
2
GN-16 1 755-T7 OR-16 922-T16 BR-16 4 205-Y38 BK-18 B 210-K36 BK-18 151-K20 GN-16 10A 10A A506-K22 OR-16
1
2
3
4
31 B J-C5 J-C1 L-C1 L-C11 8 K-C11 170-5334
612-L21 GY-14
GN-16 2 921-T8 WH-16 5 1 BEACON LAMP 308-K34 YL-16 7 INTERNAL ELECTRICAL
612-L21 GY-14
A506-L11 OR-16
A503-L12 PK-16
BR-18
BU-16
PU-16
BR-16
GN-16
YL-16
OR-16
PU-16
GN-16
OPEN ROPS BEACON SW L-C19
647-L18 GN-18
200-L58 BK-18
2 L-C13 L-C2 L-C3
BK-18
PK-16
576-L29 PK-16
GY-16
151-L15 GN-16
GY-18
WH-16
BLADE CUSHION SWITCH 3E3364 1552269 1552264 1552272 1552269
141-L9 PK-16
BLOWER SWITCH AE-C3 6 J764-Y8 BR-18 2 128-6983 200-K4 BK-14 500-K25 BR-16 A506-K50 OR-16 CONNECTION TO SURFACE
A504-L3 GN-16
A507-L2 YL-16
222-1536 3E3376
200-L60 BK-16
1552269 1552252 3E5179
505-L6 BU-16
603-L4 PK-16
504-L8 YL-16
119-L5 PK-16
503-L7 BR-16
6P-3236 3E7996 C 9X-9629 977-Y30 YL-18 3 BULB RD-16 1 603-J4 PK-16 200-K46 BK-14 200-K13 BK-14 501-K24 GN-16 SPARE SPARE ANTENNA A506-K50 OR-16 1 WH/RD-14 MOTOR OF COMPONENT
T-C6 A A D 4 3 BK-16 2 9 10 200-K39 BK-16 2 BK-14
9X-7849 200-J12 BK-16 500-K25 BR-16 200-K16 BK-14 502-K26 OR-16 ANTENNA 8E-1118 CONNECTOR
321-L19
578-L28
506-L35
500-L34
501-L37
575-L33
502-L36
577-L30
144-L32
205-L56
119-L24
601-L57
118-L41
507-L27
XMSN SOL 4 (2ND) 1552269 B 5 501-K24 GN-16 200-K47 BK-14 200-K19 BK-14 592-K37 BU-18 K-C15 WH/BK-18 LH FRONT SPKR - CABLE AS.
B 1 SPARE SPARE 1552264
K-C34 ATCH WIRE, CABLE &
186-1526 GN-16 1 900-T9 PU-16 1 Y-C8 6 AUTOSHIFT SWITCH 502-K26 OR-16 A513-K3 PK-18 GN/BK-18 LH REAR SPKR - 9W-3073 3E3364
2 3E7996 102-9861 J-C6 J-C2 12 COMPONENT
31 GN-16 2 922-T10 BR-16 2 C L A503-K21 PK-16 200-K39 BK-16 11 509-K49 WH-18 1 WH-18 LH FRONT SPKR +
1 3 A 3E3382 1552273 L# CIRCUIT GROUPING
124-H8 GN-14 3 4 601-Y21 GY-18 A D GND A506-K22 OR-16 200-K51 BK-16 200-K45 BK-16 508-K48 PU-18 508-K48 PU-18 2 GN-18 LH REAR SPKR +
2 SPARE SPARE DESIGNATION
H MOTOR
144-P101 GN-16
J764-P109 BR-18
4 B BK-16 2 3
601-P172 GY-18
134-P135 RD-16
F775-P51 BU-18
308-P150 YL-16
570-P120 BU-16
205-P170 BK-18
C C
521-H9 YL-16 205-Y22 BK-18 200-J11 BK-16 509-K49 WH-18 210-K36 BK-18 BK-18 GROUND
105-P62 RD-16
307-P17 OR-16
136-P35 GN-16
403-P57 GN-18
201-P95 BK-18
129-P102 RD-18
521-P116 YL-16
200-P103 BK-14
5 5 B
522-P97 WH-16
200-P98 BK-14
124-P29 GN-14
169-P55 PK-16
T-C7 K-C27
977-P11 YL-18
462-P99 YL-18
410-P96 WH-18
728-P42 BU-18
417-P34 GY-18
5 1 1 511-K43 BR-18 13 14 4 YL-18 NC RH INNER CAB FLOODLAMP
XMSN SOL 6 (1ST) 1552269 THERMOSTAT SW 4 6 2 T 1552269
6 169-Y2 PK-16 2 GN-16 4 504-J6 YL-16 200-K54 BK-14 210-K36 BK-18 512-K42 GN-18 A513-K3 PK-18 5 YL-18 B+ MEMORY 12V 153-2073
186-1526 3E-5464 3 C SPARE
GN-16 1 901-T11 WH-16 C F775-Y17 BU-18 3 P GY-16 6 119-J5 PK-16 200-K46 BK-14 308-K34 YL-16 RESERVED 592-K37 BU-18 6 RD-18 B+ 12V 1
3 B+
119-L24 PK-16
205-L56 BK-18
601-L57 GY-18
200-L60 BK-16
31 Y-C11 15 16
119-L5 PK-16
200-L58 BK-18
GN-16 2 922-T12 BR-16 522-H10 WH-14 200-H7 BK-14 D 4 BR-16 3 503-J7 BR-16 200-K47 BK-14 500-K25 BR-16 512-K42 GN-18 512-K42 GN-18 7 GY/BK-18 RH FRONT SPKR - 200-K16 BK-14 2
118-L41 GY-16
D 3E7996
5 OR-16 5 505-J8 BU-16 200-K51 BK-16 501-K24 GN-16 511-K43 BR-18 511-K43 BR-18 8 PU/BK-18 RH REAR SPKR -
H-C7 T H-C6 6 CENTERSHIFT PIN SWITCH 601-Y27 GY-18 A 200-K52 BK-16 502-K26 OR-16 509-K49 WH-18 BUSS GY-18 RH FRONT SPKR + K-C20
T-C8 6T6505 6T6505 9X-9634 REAR WIPER POINT 2 18 K-C4 3E3364
OPEN ROPS BEACON LAMP C 205-Y31 BK-18 B 592-K37 BU-18 508-K48 PU-18 PU-18 RH REAR SPKR +
CONN 13
3E-6388
CONN 15
CONN 14
XMSN SOL 5 (3RD) 1552269 P-C14 P-C12 P-C13 D 1 J-C7 J-C3 3E3388 K-C28
128-6983 719-Y36 GY-18 AM/FM CASSETTE RH OUTER CAB FLOODLAMP
NORMAL
A503-L12 PK-16
A506-L11 OR-16
3E3382 1552252 3E5179
501-L37 GN-16
A504-L3 GN-16
A507-L2 YL-16
144-L32 GN-16
151-L15 GN-16
506-L35 PU-16
575-L33 YL-16
577-L30 PU-16
321-L19 BR-18
500-L34 BR-16
502-L36 OR-16
507-L27 WH-16
576-L29 PK-16
578-L28 BU-16
647-L18 GN-18
186-1526 GN-16 1 2 3E3364 1552269 K-C13 1552269
141-L9 PK-16
503-L7 BR-16
505-L6 BU-16
504-L8 YL-16
603-L4 PK-16
902-T13 BR-16 BULB G939-Y45 PK-18 200-K4 BK-14 146-3090 153-2073
TEST
RD-16
BK-16
10
11
12
10
11
12
31 HVAC PANEL LAMP 1552267
1
2
3
4
5
6
1
2
3
4
5
6
7
8
9
1
2
3
4
5
6
7
8
9
GN-16 2 922-T14 BR-16 8D-1429 9X-7849 Y-C4 911-Y48 YL-18 3 MOTOR WH/RD-14 1 A507-J10 YL-16 200-K13 BK-14 1
Y-C3 3E5179 Y-C6 Y-C10 4 BK-14 2 A RD-18 2
1552273 1552252 823-Y37 GN-18 200-J1 BK-16 200-K16 BK-14 108-K61 RD-16 200-K13 BK-14
3E7996 DOME LAMP
118-L39 GY-16
517-H3 BU-14 911-Y48 YL-18 5 200-K19 BK-14 148-K18 WH-16 C WH-18
GN-16
PK-16
GY-18
BK-18
T-C9 A A 6 B BK-18 3E-6389 K-C21
G939-Y45 PK-18
F775-Y17 BU-18
H-C2 516-H2 GN-14 601-Y23 GY-18 718-Y35 BU-18 200-K39 BK-16 117-K14 YL-14 200-K53 BK-16
124-Y1 GN-14
105-Y10 RD-16
119-L26 PK-16
521-Y26 YL-16
522-Y25 WH-14
200-Y47 BK-14
200-Y51 BK-14
601-Y44 GY-18
134-Y16 RD-16
570-Y19 BU-16
169-Y20 PK-16
144-Y13 GN-16
136-Y53 GN-16
403-Y56 GN-18
YL-18
BK-18
YL-18
GN-16
BK-18
WH-18
BR-18
BU-18
GY-18
GN-18
BU-18
GY-18
119-L25 PK-16
609-L40 YL-16
129-Y6 RD-18
307-Y9 OR-16
308-Y3 YL-16
XMSN SOL 7 (LOW RANGE) REAR DEFROST FAN
200-L20 BK-16
200-L42 BK-16
1552269 3E3364
1
2
3T3158 205-Y24 BK-18 B C RESISTOR
118-L31 GY-16
118-L38 GY-16
205-L52 BK-18
205-L51 BK-18
205-L50 BK-18
205-L49 BK-18
205-L47 BK-18
601-L55 GY-18
601-L54 GY-18
601-L53 GY-18
601-L43 GY-18
601-L48 GY-18
B
CONN 60
200-L1 BK-16
186-1526 GN-16 1 UX-C9 H-C3 H-C4 AE-C2 1 D 170-4820 J-C8 7T4003 J-C9 K-C10
903-T15 GY-16
205-AE3
144-AE4
603-AE7
601-AE2
31 GN-16 2 3E3370 6T6505 6T6505 1552269 2 2 6T6505 6T6505 K-C14 AP-C2 1552269
603-AE7 PK-16
922-T16 BR-16 134-Y16 RD-16 AP-C1
977-Y30
205-Y34
462-Y32
727-Y33
201-Y29
410-Y28
J764-Y8
718-Y35
719-Y36
823-Y37
728-Y55
417-Y57
PWR (+24) OR-16 A 601-H11 GY-18 200-H6 BK-18 515-H1 GY-14 727-Y50 GN-16 3 A503-K21 PK-16 1552269 3E3364 7T5957 1 WH-16
C 3
GROUND BK-16 B 515-H4 GY-14 4 A507-J2 YL-16 A506-K22 OR-16 135-K35 BU-16 1 1 135-AP1 BU-16 12V POWER PORT 2 BK-16
SIGNAL WH-16 C 5 D 10 A513-K3 PK-18 200-K52 BK-16 2 2 200-AP2 BK-16 117-2311 K-C33
200-H5 BK-14
XMSN TEMP SENSOR H-C5 RESISTOR H 6 A504-J3 GN-16 K-C7 RH CAB POS LAMP
6T6505 9G-1950 3E3364 212-3924
152-0659 462-Y32 YL-18 C THROTTLE HOLD MODE SW 3E3364
200-Y46 BK-18 D 183-2151 K-C29
W-C7 6T6505
CONN 4 SECSTER TEST SW 601-W29 GY-18 A503-K21 PK-16
200-K51 BK-16
200-K52 BK-16
200-K47 BK-14
200-K46 BK-14
200-K54 BK-14
A503-L12 PK-16
A506-L11 OR-16
Y-C2 3E7996
119-L25 PK-16
500-L34 BR-16
502-L36 OR-16
507-L27 WH-16
576-L29 PK-16
578-L28 BU-16
144-L32 GN-16
151-L15 GN-16
205-L50 BK-18
205-L51 BK-18
205-L52 BK-18
601-L53 GY-18
601-L54 GY-18
601-L55 GY-18
A504-L3 GN-16
A507-L2 YL-16
118-L31 GY-16
118-L38 GY-16
118-L39 GY-16
119-L26 PK-16
501-L37 GN-16
506-L35 PU-16
575-L33 YL-16
577-L30 PU-16
200-L20 BK-16
200-L42 BK-16
AE-C1 9X-9633
BK-18
BK-18
BR-18
GY-18
GY-18
YL-16
647-L18 GN-18
504-L8 YL-16
141-L9 PK-16
603-L4 PK-16
503-L7 BR-16
505-L6 BU-16
200-L1 BK-16
205-Y31 BK-18 601-W31 GY-18 A A506-K22 OR-16 511-K43 BR-18 + RH SPEAKER
148-L22 WH-16
1 WH/RD-14 MOTOR 3E3376 1552272 205-Y38 BK-18 205-W30 BK-18 A L-C18 512-K42 GN-18 - 6T-7695
BEACON SWITCH
200-H12 BK-14 2 BK-14 1 1 200-Y12 BK-16 601-Y40 GY-18 205-W32 BK-18 B L-C4 3E7996 K-C30
200-Y47 BK-14
205-Y34 BK-18
601-Y44 GY-18
727-Y33 GN-16
B 1 222-1536
308-Y3 YL-16
205-L47
205-L49
321-L19
601-L43
601-L48
609-L40
H-C1 2 2 205-Y11 BK-18 601-Y27 GY-18 C975-W24 WH-18 1 3E7996 A 6T8047
1552269 3 3 601-Y5 GY-18 718-Y35 BU-18 2 A A 601-L55 GY-18 B
BLOWER 2 3
4 4 144-Y13 GN-16 719-Y36 GY-18 3 B B 205-L50 BK-18 1
174-1494 4 4 1
Y-C13 CONN 11 823-Y37 GN-18 2 1 2 3
5 2 3 2
CONN 59 3E3376 977-Y30 YL-18 144-L32 GN-16
B 5 3
B
200-Y51 BK-14
6 3 4
F775-Y17 BU-18
G939-Y45 PK-18
G939-Y45 PK-18 603-L4 PK-16
105-Y10 RD-16
201-Y29 BK-18
WH-18
134-Y16 RD-16
136-Y53 GN-16
144-Y13 GN-16
169-Y20 PK-16
GN-18
GY-18
YL-18
YL-16
WH-14
BU-16
718-Y35 BU-18
719-Y36 GY-18
728-Y55 BU-18
823-Y37 GN-18
977-Y30 YL-18
J764-Y8 BR-18
C 6 4
124-Y1 GN-14
307-Y9 OR-16
129-Y6 RD-18
H-C8 Y-C1 J764-Y8 BR-18 A983-W25 BU-18 C 4 5
3E3382 1552273 5 HEATED MIRRORS SW
SHIFT LEVER PANEL LAMP 601-W29 GY-18 D 6 5 6
1 1 D 6 C 123-5858
124-H8 GN-14 124-Y1 GN-14 7N-5876 601-W4 GY-18
410-Y28
417-Y57
570-Y19
403-Y56
462-Y32
521-Y26
522-Y25
2 2 C C D
205-W30 BK-18
200-H12 BK-14 3 3 200-Y51 BK-14 205-W21 BK-18 D CAB GND BOSS 2
200-Y46 BK-18
200-Y43 BK-18
200-Y12 BK-16
205-Y42 BK-18
205-Y11 BK-18
205-Y18 BK-18
205-Y24 BK-18
205-Y22 BK-18
205-Y31 BK-18
205-Y38 BK-18
601-Y41 GY-18
GY-18
GY-18
GY-18
GY-18
GY-18
727-Y50 GN-16
727-Y49 GN-16
D L-C17
601-Y5 GY-18
(CAB FRONT)
308-Y54 YL-16
308-Y52 YL-16
521-H9 YL-16 4 4 521-Y26 YL-16 Y-C14
3T3158 L-C7 FRONT UPPER WIPER SW 3E7996
522-H10 WH-14 5 5 522-Y25 WH-14 W-C6 3E-0155
1552264
601-Y41 GY-18
205-Y42 BK-18
601-H11 GY-18 6 6 3E7996 A
601-Y15
601-Y23
601-Y21
601-Y27
601-Y40
Y-C12 601-W4 GY-18 L-C5 118-L39 GY-16 1 RD-14 WIPER B+ B
A A
3E3382 601-W22 GY-18 3E7996 118-L38 GY-16 2 RD-18 WASHER B+ 1
UX-C6 W-C4
Y-C15 205-W21 BK-18
205-W23 BK-18
B
1 B 1
A
B
200-L42 BK-16
502-L36 OR-16
3
4
BK-18
WH-14
GROUND
HIGH
2
3 2 3 WIRE GROUP COLOR DESCRIPTIONS
1552252 2 1
3E5179
E937-UX33 PU-18
CONN
1
5 1552252
E937-W10 PU-18 + BATTERY RD-18 1 136-Y53 GN-16
C979-W26 OR-18 2
3
3
4 3
2 1
2
A507-L2 YL-16
151-L15 GN-16
501-L37 GN-16
500-L34 BR-16
5
6
YL-14
BU-14
LOW
PARK
4
5
MOLDBOARD LAMPS SW
WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS OFF. THIS SCHEMATIC IS FOR 12H
2 GROUND BK-18 2 4 3 569-L10 PK-16 7 BR-18 WASH 6
MOTOR GRADERS (172-9933 CHG 00).
E938-UX34 OR-18 E938-W11 OR-18 A982-W27 BR-18 5 4 506-L35 PU-16
E939-UX35 WH-18 3 E939-W12 WH-18 KEY SW YL-18 3 308-Y54 YL-16 5 4 A504-L3 GN-16 8 UNUSED C 123-5847 WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS ON.
6 5
E940-UX36 BU-18 4 E940-W13 BU-18 UNUSED OR-18 4 A982-W27 BR-18 6 6 5 569-L10 PK-16 D
5 C 6
E941-UX37 YL-18 5 E941-W14 YL-18 GROUND BU-18 C978-W28 BR-18 C VOLTAGE CONVERTER OUTPUT CIRCUIT.
6 6 D C L-C12
STEER SW PU-18
F775-Y17 BU-18
G939-Y45 PK-18
E942-UX38 GN-18 E942-W15 GN-18 728-Y55 BU-18 601-W22 GY-18 601-L54 GY-18
105-Y10 RD-16
144-Y13 GN-16
205-Y11 BK-18
200-Y12 BK-16
200-Y51 BK-14
308-Y54 YL-16
403-Y56 GN-18
521-Y26 YL-16
522-Y25 WH-14
134-Y16 RD-16
169-Y20 PK-16
200-Y46 BK-18
205-Y22 BK-18
205-Y24 BK-18
205-Y31 BK-18
205-Y38 BK-18
462-Y32 YL-18
570-Y19 BU-16
601-Y15 GY-18
601-Y21 GY-18
601-Y23 GY-18
601-Y27 GY-18
601-Y41 GY-18
718-Y35 BU-18
719-Y36 GY-18
823-Y37 GN-18
977-Y30 YL-18
136-Y53 GN-16
200-Y43 BK-18
308-Y52 YL-16
417-Y57 GY-18
727-Y49 GN-16
728-Y55 BU-18
205-Y18 BK-18
205-Y42 BK-18
601-Y40 GY-18
727-Y50 GN-16
J764-Y8 BR-18
D FRONT LOWER WIPER SW 3E7996
124-Y1 GN-14
129-Y6 RD-18
307-Y9 OR-16
601-Y5 GY-18
E943-UX39 BR-18 7 E943-W16 BR-18 UNUSED BR-18 7 205-W32 BK-18 205-W23 BK-18 D 205-L51 BK-18 L-C8
E944-UX40 GY-18 8 E944-W17 GY-18 ALTERNATOR 'R' WH-18 8 403-Y56 GN-18 601-W31 GY-18 1552264 3E-0155
601-L48 GY-18 A
STARTING CIRCUIT.
E945-UX41 PU-18 9 E945-W18 PU-18 UNUSED PK-18 9 THROTTLE SPEED SET SW 1 RD-14 WIPER B+ 205-L49 BK-18 B
E946-UX42 OR-18 10 E946-W19 OR-18 RELAY GN-18 10 727-Y49 GN-16 A983-W25 BU-18 185-2197 118-L31 GY-16 2 RD-18 WASHER B+ 1 GROUND CIRCUIT.
E947-UX43 WH-18 11 E947-W7 WH-18 MONITOR PANEL GY-18 11 417-Y57 GY-18 C975-W24 WH-18 REAR DEFROST SW 200-L20 BK-16 3 BK-18 GROUND 2
E948-UX44 BU-18 12 E948-W8 BU-18 NC 12 C978-W28 BR-18 9X-9638 577-L30 PU-16 4 WH-14 HIGH 609-L40 YL-16 3 STARTING AID CIRCUIT.
UX-C5 W-C3
SECONDARY STEERING CONTROL Y-C16 CONN 12 C979-W26 OR-18 576-L29 PK-16 5
6
YL-14
BU-14
LOW
PARK
4
5 SNOW WING LAMP SW
132-6640 3E5179 L-C6 575-L33 YL-16 CATERPILLAR MONITORING SYSTEM CIRUIT.
1552252 CONN 6 3E5179 W-C2 3E7996 578-L28 BU-16 7 BR-18 WASH 6 123-5847
1 A 8 UNUSED C
E937-W10 PU-18
E938-W11 OR-18
E939-W12 WH-18
E940-W13 BU-18
E941-W14 YL-18
E942-W15 GN-18
E943-W16 BR-18
E944-W17 GY-18
E945-W18 PU-18
E946-W19 OR-18
E949-UX45 YL-18 E949-W9 YL-18 113-W2 OR-16
E947-W7 WH-18
E948-W8 BU-18
E949-W9 YL-18
126-W20 PK-16
9W1951 ENGINE CONTROL CIRCUIT.
202-W3 BK-16
113-UX46 OR-16 2 113-W2 OR-16 Y-C17 201-W1 BK-18 B D
R 1552272 1
126-UX79 PK-16 3 126-W20 PK-16 892-W5 BR-18 113-W2 OR-16 A 1 A506-L11 OR-16
A CONN 77 201-UX81 BK-18
202-UX75 BK-16
4
5
201-W1 BK-18
202-W3 BK-16
KEY SWITCH
110-7887
OFF C
YL-16
PU-16
1
2
308-Y52 YL-16 893-W6 GN-18
126-W20 PK-16
201-W1 BK-18 B
C
3
2
2
3
141-L9 PK-16
567-L16 WH-16 L-C9 REAR WIPER SWITCH L-C10
3E7996
AUX BACKUP LAMP SW
139-0695
TRANSMISSION / ENGINE PUMP CONTROL CIRCUIT. A
CR-C1 AG-C7 ON S 4 1552264 3E-0155
892-UX71 BR-18 6 892-W5 BR-18 ST B OR-16 3 307-Y9 OR-16 202-W3 BK-16 893-W6 GN-18 D SERVICE TOOL 5 4 A503-L12 PK-16 HEATER AND AIR CONDITIONER CIRCUIT.
3E3376 1552272 893-UX72 GN-18 7 893-W6 GN-18 BR-16 4 105-Y10 RD-16 E937-W10 PU-18 892-W5 BR-18 E CONNECTOR 5 567-L16 WH-16 119-L25 PK-16 1 RD-14 WIPER B+ 601-L43 GY-18 A
TU 3 606-AG8 GY-18 A983-UX88 BU-18 8 A983-W25 BU-18 E938-W11 OR-18 F 6 6 119-L26 PK-16 2 RD-18 WASHER B+ 205-L47 BK-18 B
W-C1 TURN SIGNAL/WIPER/WASHER CIRCUIT.
S 1 604-AG4 OR-18 C975-UX78 WH-18 9 C975-W24 WH-18 200-Y43 BK-18 E939-W12 WH-18 7X6222 G C 601-L53 GY-18 200-L1 BK-16 3 BK-18 GROUND 1
2 1
TA 2 C978-UX86 BR-18 10 C978-W28 BR-18 129-Y6 RD-18 E940-W13 BU-18 H D 205-L52 BK-18 505-L6 BU-16 4 WH-14 HIGH 321-L19 BR-18 2
3
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
1
2
3
4
5
6
7
8
9
G 4 200-AG18 BK-18 A755-UX113 PK-18 11 ACTION ALARM Y-C5 E941-W14 YL-18 J CAP 504-L8 YL-16 5 YL-14 LOW 647-L18 GN-18 3
C979-UX87 OR-18 12 C979-W26 OR-18 3E-6328 E942-W15 GN-18 CONN 30 W-C8 503-L7 BR-16 6 BU-14 PARK 4
1552269
RED NEUT
GROUND
FIRST
SECOND
THIRD
FOURTH
FIFTH
SIXTH
SEVENYH
EIGHTH
FORWARD
REVERSE
PARK
NEUTRAL
BATTERY(+)
RH STOP/TAIL/TURN LAMP Y-C18 E943-W16 BR-18 XMSN SHIFTER 8C6354 507-L27 WH-16 7 BR-18 WASH 5
5C-9930 UX-C8 W-C5 CIGAR LIGHTER RD-16 1 410-Y28 WH-18 E944-W17 GY-18 180-3531 FRONT DEFROST SW 8 UNUSED 6
8T9670
1552272 CONN 7 3E3376 9W-0335 BK-16 2 201-Y29 BK-18 E945-W18 PU-18 9X-9638 L-C16 C
205-UX109 BK-18 1 205-W32 BK-18 Y-C19 E946-W19 OR-18 D
6T6505 3E3388
601-UX110 GY-18 2 601-W31 GY-18 E947-W7 WH-18
J766-UX105 PU-18 3 E948-W8 BU-18
4 E949-W9 YL-18
SHIFT CONSOLE
18 17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
You might also like
- 12H, 140H, and 160H Electrical System Motor Grader Standard Version86% (7)12H, 140H, and 160H Electrical System Motor Grader Standard Version2 pages
- Standard Operating Procedure On Coal Loss Accounting100% (2)Standard Operating Procedure On Coal Loss Accounting62 pages
- D3G, D4G, and D5G HYSTAT Electrical System Track-Type Tractors100% (1)D3G, D4G, and D5G HYSTAT Electrical System Track-Type Tractors4 pages
- C9 On-Highway Engine Electrical System: Harness and Wire Electrical Schematic SymbolsNo ratings yetC9 On-Highway Engine Electrical System: Harness and Wire Electrical Schematic Symbols2 pages
- 735, 740, and 740E Electrical System Articulated Truck100% (1)735, 740, and 740E Electrical System Articulated Truck2 pages
- 966H and 972H Wheel Loader With Steel Mill Electrical System100% (2)966H and 972H Wheel Loader With Steel Mill Electrical System6 pages
- Electronic Control Module (Power Train) : Operación de Sistemas100% (3)Electronic Control Module (Power Train) : Operación de Sistemas4 pages
- Excav 329D - Diagnostic Capabilities (KENR8635-05)No ratings yetExcav 329D - Diagnostic Capabilities (KENR8635-05)3 pages
- Cargador 938h Jkmrenr9764renr9764-06 - Sis100% (2)Cargador 938h Jkmrenr9764renr9764-06 - Sis20 pages
- Interactive Schematic: This Document Is Best Viewed at A Screen Resolution of 1024 X 768No ratings yetInteractive Schematic: This Document Is Best Viewed at A Screen Resolution of 1024 X 76831 pages
- Diagrama 950H M1G Renr8882renr8882-08 - SisNo ratings yetDiagrama 950H M1G Renr8882renr8882-08 - Sis13 pages
- Interactive Schematic: This Document Is Best Viewed at A Screen Resolution of 1024 X 768100% (1)Interactive Schematic: This Document Is Best Viewed at A Screen Resolution of 1024 X 76835 pages
- 980G Wheel Loader Electrical System: Machine Harness Connector and Component LocationsNo ratings yet980G Wheel Loader Electrical System: Machine Harness Connector and Component Locations2 pages
- Machine Harness Connector and Component Locations: 12H, 140H and 160H Electrical System Motor Graders (NA Version)No ratings yetMachine Harness Connector and Component Locations: 12H, 140H and 160H Electrical System Motor Graders (NA Version)2 pages
- Interactive Schematic: This Document Is Best Viewed at A Screen Resolution of 1024 X 768No ratings yetInteractive Schematic: This Document Is Best Viewed at A Screen Resolution of 1024 X 76813 pages
- 325C FM & 325C LL Electrical System: Electrical Schematic Symbols and DefinitionsNo ratings yet325C FM & 325C LL Electrical System: Electrical Schematic Symbols and Definitions2 pages
- 735, 740, & 740 EJECTOR Electrical System Articulated Truck: Harness and Wire Electrical Schematic Symbols100% (1)735, 740, & 740 EJECTOR Electrical System Articulated Truck: Harness and Wire Electrical Schematic Symbols2 pages
- 773E (BDA1-258) & 775E (BEC1-201) Off-Highway Truck Electrical SystemNo ratings yet773E (BDA1-258) & 775E (BEC1-201) Off-Highway Truck Electrical System2 pages
- Sistema Electrico 330D Motor c-9 330 PDFNo ratings yetSistema Electrico 330D Motor c-9 330 PDF2 pages
- 735, 740 & 740E Electrical System Articulated Truck: Harness and Wire Electrical Schematic SymbolsNo ratings yet735, 740 & 740E Electrical System Articulated Truck: Harness and Wire Electrical Schematic Symbols2 pages
- Radio Shack TRS-80 Expansion Interface: Operator's Manual Catalog Numbers: 26-1140, 26-1141, 26-1142From EverandRadio Shack TRS-80 Expansion Interface: Operator's Manual Catalog Numbers: 26-1140, 26-1141, 26-1142No ratings yet
- Electronic Automotive Transmission Troubleshooter Honda Acura vehiclesFrom EverandElectronic Automotive Transmission Troubleshooter Honda Acura vehiclesNo ratings yet
- Jai Gurudev Maharishi Vidya Mandir, Mangadu Physics - Worksheet Electric Fields & ChargesNo ratings yetJai Gurudev Maharishi Vidya Mandir, Mangadu Physics - Worksheet Electric Fields & Charges3 pages
- Swahili Names For Fish, Animals and Coastal "Things".: Samaki Ya Maji Ya Chumvi-Salt Water FishNo ratings yetSwahili Names For Fish, Animals and Coastal "Things".: Samaki Ya Maji Ya Chumvi-Salt Water Fish5 pages
- Resume - Suchita Sanjeev Kamble - Format1No ratings yetResume - Suchita Sanjeev Kamble - Format13 pages
- The Law and The Practice Relating To Transferable Securities in EthiopiaNo ratings yetThe Law and The Practice Relating To Transferable Securities in Ethiopia7 pages
- Rubrics For Student Engagement or Class ParticipationNo ratings yetRubrics For Student Engagement or Class Participation2 pages
- Chapter Four Structure of Cooperatives in Ethiopia100% (1)Chapter Four Structure of Cooperatives in Ethiopia3 pages
- Blockchain Beyond The Hype: What Is The Strategic Business Value?No ratings yetBlockchain Beyond The Hype: What Is The Strategic Business Value?22 pages
- A Journey Through Time - Us Forces in Malir Ww2No ratings yetA Journey Through Time - Us Forces in Malir Ww27 pages
