86731098

11 / 2011
00

109E ---a055WQ38 ---ML ---

86731031
( 38 --- T38 )
 MAINTENANCE LEGEND
PARTS TO CHANGE
Depending on applications.

Every 100 hours.

Every 400 hours.

Every 800 hours.

Every 1600 hours.

Long term, only if damaged.

CAUTION
If drifter settings are incorrect, wear parts can be damaged prematurely.

If the drifter is used with deflated accumulators, premature damage can be caused to all parts.

These inspection intervals can vary depending on ground conditions, use of drifter.......
 A PERCUSSION PART PARTIE FRAPPEUR 1.1

A B CENTRAL PART PARTIE CENTRALE 1.2

C HYDRAULIC STOP BUTE HYDRAULIQUE 1.3

D FRONT PART PARTIE AVANT 1.4

E ADAPTERS ADAPTEURS 1.5

Item Page
E MONTABERT -- 2011 Item CPN Qty

300 Nm 230 220 Percussion part Partie frappeur

220 ft.lb 10 86374030 1 LP Body Corps BP
300 Nm
506,7 mm mini
300 Nm 130 220 ft.lb
20 86385119 1 HP Body including: Corps HP comprenant :
19.95 mini
220 ft.lb 30 86264678 1 ( Helicoil thread UNF 3/4 ( Filet hlicol UNF 3/4
40 86374055 2 Cover Couvercle
210 S 50 86376191 2 Oring Joint torique
120 260 60 86634003 2 Diaphragm Membrane

150 270
70 86241403 2 BS ring Bague BS

250
80 86265048 2 Inflating screw Vis de gonflage
160 90 86223419 1 Pin Axe lisse
240 S 100 86265071 5 Oring Joint torique
170
180 S 110 86326493 2 Oring Joint torique
190 S 120 86570447 7 Tight seal Joint dtanchit
200 130 86313228 4 UNF 3/4, socket head screw Vis CHc UNF 3/4
140 86323672 1 Cylinder Cylindre
37 Nm 150 86333697 1 Distributor Distributeur
80
27 ft.lb
30
160 86333713 1 Thrust piston Cyl. E Piston de pousse Cyl. E
70 170 86578580 1 Strike piston Piston de frappe

50 60 +
1400 Nm
40 Distribution Distribution
1035 ft.lb 180 86324738 1 Cover Couvercle

120 S 190 86265071 1 Oring Joint torique

90 S 200 86326493 1 Oring Joint torique

110 140 210 86250867 1 UNF 3/4, socket head screw Vis CHc UNF 3/4

100
220 86333267 1 Plug Bouchon filet

20
S 230 86281979 1 Oring Joint torique

120
240 86223914 1 Distribution cover Couvercle de ditribution
120 250 86220944 1 Valve Clapet

100 260 86220951 1 Push rod Poussoir

PARTS TO CHANGE
270 86220969 1 Lining Chemise de poussoir
10
Depending on applications.
100 Every 100 hours.

110 Every 400 hours.

Every 800 hours.
Every 1600 hours.
Long term, only if damaged.

1.1
 1.2
E MONTABERT -- 2011 Item CPN Qty

600 Nm
440 ft.lb Central part Partie centrale
150 10 86475746 1 Motor body including: Corps de moteur comprenant :
190
140 20 86221561 3 ( Guiding ring ( Bague de guidage
90 30 86223997 1 ( Snap ring ( Jonc
110 40 86264678 2 ( Helicoil thread UNF 3/4 ( Filet hlicol UNF 3/4
200 50 86223476 1 Spring Ressort
90 170 60 86220811 2 Needle bearing Roulement aiguilles
110
160 S 70 86222825 1 Oring Joint torique

50 180 S 80 86265071 1 Oring Joint torique

120 S 90 86221918 2 Oring Joint torique

100 86220209 1 Shaft Arbre moteur
10 130
110 86344199 2 Distribution plate Platine de distribution
120 S 120 86261344 2 Oring Joint torique
40 130 130 86318516 2 Pin Axe lisse
30 140 86223559 1 Ball bearing Roulement billes
150 86344116 1 Bearing holder plate Plaque porte roulement
20 160 86313046 1 Nut Ecrou
60 170 86302841 1 Pin Goupille fendue
S 180 86222668 1 Oring Joint torique
190 86313053 1 Cover Couvercle
200 86638335 1 Cartridge (type 055) Cartouche moteur (type 055)
210 86653581 1 Slider Tiroir
220 86366242 1 Lining Chemise de tiroir
230 86366283 1 Spring Ressort
100 80 70
S 240 86234994 1 Oring Joint torique
S 250 86234853 1 Oring Joint torique
250 S 260 86288131 1 BS ring Bague BS
260
240 PARTS TO CHANGE 270 86312196 x Adjusting shim Rondelle de rglage
230
270 Depending on applications.
210 Every 100 hours.
220 Every 400 hours.

300 Nm Every 800 hours.

220 ft.lb Every 1600 hours.
Long term, only if damaged.
E MONTABERT -- 2011 Item CPN Qty

280
290 Hydraulic stop Bute hydraulique
300 250 10 86475001 1 Thrust housing including: Carter de bute comprenant :
290 20 86264678 4 ( Helicoil thread UNF 3/4 ( Filet hlicol UNF 3/4
250
300 250 30 86655354 1 Oiler Graisseur
260
40 86223419 1 Pin Axe lisse
290 280 50 95848107 2 UNF 3/4, socket head screw Vis CHc UNF 3/4
260 230
60 86322518 3 Valve Clapet
280 70 S 70 86570447 3 Tight seal Joint dtanchit
60 240 S 80 86616935 1 Face seal Joint de face
270 S 90 86502234 4 Oring Joint torique
S 100 86578895 1 Oring Joint torique
310
10 110 86611647 1 Front lining Chemise de bute avant

30 120 86611621 1 Rear lining Chemise de bute arrire

280
50 80 40 S 130 86611654 2 Composite seal Joint composite
140 86220258 1 Snap ring Jonc
300 Nm 150 86611639 1 Hydraulic stop piston Piston de bute
220 ft.lb S 160 86611662 1 Seal Joint
20
170 86345022 1 Guide Guide
S 180 86221652 1 Centering part Centreur
160 S 190 86221645 1 Centering part Centreur
200 86223492 1 Shank stop Bute demmanchement
130 210 86220241 1 Ring Bague bronze
100 220 86221603 1 Needle bearing Roulement aiguilles
90
120 230 86313087 1 Shaft Arbre de transmission
240 86484755 1 Ball bearing Roulement billes
150 250 86223435 3 Tight ring Bague dtanchit
260 86313095 2 Tight ring Bague dtanchit
110 270 86313103 1 Tight ring Bague dtanchit
S 280 86232808 9 Oring Joint torique
140 S 290 86292786 3 Oring Joint torique
PARTS TO CHANGE
170 S 300 86613254 2 Seal Joint
Depending on applications.
310 86223021 1 Needle bearing Roulement aiguilles
Every 100 hours.
200 Every 400 hours.
210 Every 800 hours.
190
Every 1600 hours.
220 7,3 mm mini 180
0.28 mini Long term, only if damaged.

1.3
 1.4
E MONTABERT -- 2011 Item CPN Qty

10 mm maxi
0.39 maxi Fronthead Partie avant
38 10 86484771 1 Front guide Guide avant
S 20 86234507 3 Oring Joint torique
S 30 86375870 1 Ball Bille
54 mm maxi S 40 86322583 1 Spring seat Sige de ressort
2.1 maxi S 50 86220480 1 Spring Ressort
5 mm mini 60 86251840 1 Plug Bouchon
100
0.19 mini S 70 86223740 2 Oring Joint torique
110
80 86223443 4 UNF 3/4 , screw Vis UNF 3/4
170 90 90 86222882 4 Nut Ecrou
140 300 Nm 100 86313129 1 Gear drive Pignon moteur
160 220 ft.lb 110 86223021 1 Needle bearing Roulement aiguilles
120 86221116 1 Thrust washer Rondelle de bute
150 130 86221595 1 Needle bearing Roulement aiguilles

20
140 86221678 1 Thrust washer Rondelle de bute
130
6,35 mm mini 150 86511474 1 Gear driven including : Pignon rcepteur comprenant :
0.25 mini 120 70 160 86511458 1 ( Splined shank ( Ecrou cannel
40 170 86220779 1 ( Snap ring ( Jonc
30 180 86645967 1 Shank retainer Douille de dcaleur

60 190 86645959 1 Flushing nozzle including : Nez dinjection comprenant :

50 200 86605219 1 ( Guiding ring ( Bague de guidage

230
210 86223997 1 ( Snap ring ( Jonc

230
220 86313186 1 ( Packing ( Garniture
10 230 86307162 3 Lip seal Joint lvres
230 240 86619350 1 Shank male 38, T38 Emmanchement 38, T38
250 86310034 1 Shield Protection

240 80
180
220 PARTS TO CHANGE
190 Depending on applications.

200 Every 100 hours.

210 Every 400 hours.

250 Every 800 hours.

Dia.>39 Every 1600 hours.
Long term, only if damaged.
E MONTABERT -- 2011 Item CPN Qty

7/8 ---JIC
10 Adapters Adapteurs
P1A 15/16---JIC 10 86321056 2 Adapter Adapteur
P1R 20 20 95219762 1 Adapter Adapteur

40 30 86257979 2 Adapter Adapteur

40 86578770 1 Adapter Adapteur

BP 50 95279329 1 Adapter Adapteur

P2
3/4 ---JIC 11/16---JIC
30
Pressu.

Drain

Flushing
Injection

50 PARTS TO CHANGE
11/16---JIC Depending on applications.
Every 100 hours.
Every 400 hours.
Every 800 hours.
Every 1600 hours.
Long term, only if damaged.

1.5
 1.6
E MONTABERT -- 2011 Item CPN Qty

40
Fixation Fixation
10 86220860 2 Gudgeon Goujon
20 86220878 8 Spacer Bague
30 86220886 4 Nut Ecrou
40 86249265 1 Plug Bouchon

For drifter delivered Pour perforateur livr

without shank sans emmanchement

86495363 1 Plastic plug (dia.38) Bouchon plastique ( 38)

30 10 20 86488475 1 Plastic plug (dia.45) Bouchon plastique ( 45)
500 Nm
368 ft.lb

Accessories Accessoires

86640299 1 Seals package including: Pochette de joints comprenant :

( All parts marked S ( Toutes les pices notes S

PARTS TO CHANGE
Depending on applications.
Every 100 hours.
Every 400 hours.
Every 800 hours.
Every 1600 hours.
Long term, only if damaged.
E MONTABERT -- 2011 Item CPN Qty

Oil restrictor Gicleur rglable

40 20 86374964 1 Oil restrictor including : Gicleur rglable comprenant :
10 86374972 1 ( Tee piece ( T
20 86374980 1 ( Adjusting screw ( Vis de rglage
30 86374998 1 ( Plug ( Bouchon

50 30 40 86249190 1 ( Nut ( Ecrou

50 86262656 1 ( Oring ( Joint torique

10

PARTS TO CHANGE
Depending on applications.
Every 100 hours.
Every 400 hours.
Every 800 hours.
Every 1600 hours.
Long term, only if damaged.

1.7
 www.montabert.com

203 , route de Grenoble

BP 671
69805 Saint--Priest Cedex
France