Maintenance of Micro Irrigation System

Getting the Most from Your Irrigation System
Maintenance of Microirrigation Systems
Larry Schwankl
UC Cooperative Extension
(559) 646-6569 [email protected]
Powerpoint at: http://ucanr.edu/schwankl

Powerpoint presentation on Microirrigation

Maintenance.
Web site on Maintenance of Microirrigation

http://micromaintain.ucanr.edu

Powerpoint presentation on Microirrigation

Maintenance.

Emitters:
Small passageways make clogging a major
problem.

Clogging of Microirrigation Systems
Sources: Physical Clogging Particulates

Chemical Precipitates
Biological Clogging

Clogging of Microirrigation Systems
Sources: Physical Clogging Particulates
Solution: Filtration
Filters:
Screen, disk, and sand media filters are
all available.
They can all filter to the same degree

BUT
they req. different frequency of cleaning.
Screen Filters
Mesh size recommended by

emitter manufacturer
Screen Filters
Screen Filters
The degree of filtration is measured by mesh size.

Disk Filters
Also rated by mesh size

Sand Media Filters
Sand Media Filters
Sand Media Filters
Backwash Systems
Chemical Precipitate Clogging
Lime (calcium carbonate) and iron are the
most common problems.
Calcium Carbonate (Lime)
Iron Problems
Chemical Precipitate Clogging
Water quality levels of concern:

Calcium: pH > 7.5 and 2.0 meq/l (120 ppm)
of bicarbonate
Iron: pH > 4.0 and 0.5 ppm iron

Special water sample reqd.
Chemical Precipitation - Solutions
Source: Lime
Solution: pH Control (Acidification)

+
filtration
Iron Precipitation - Solutions
Precipitate iron in a pond / reservoir.
Iron Precipitation - Solutions
1. Precipitate iron in a pond / reservoir.
2. Chemicals (e.g. phosphonic acid,

phosphonate) may keep iron in solution.
Maintenance, not clean-up products.
Biological Clogging Problems
Biological Clogging - Solutions
Solution: Filtration (usually media filters)
+
Biocide
Most common biocides are chlorine and copper.

Biological Clogging - Solutions
Solution: Filtration (usually media filters)
+
Biocide
Most common biocides are chlorine and copper.
Acid may deter biological growth but not

eliminate it.
Chlorine - Sources
Liquid Sodium Hypochlorite
Solid Calcium Hypochlorite
Gas Chlorine
Chlorine - Sources
Liquid Sodium Hypochlorite
Solid Calcium Hypochlorite
Gas Chlorine
When add chlorine to water:

Forms hypochlorous acid + hypochlorite.
Hypochlorous acid is the more powerful biocide.
If pH is lower (acidic), more hypochlorous acid is
present better biocide.
Chlorine as a Biocide
Chlorine Recommended Rates
Free Chlorine
Continual Injection 1-2 ppm

Periodic Injection 10-20 ppm
Contact time is important inject for at least a few

hours. Longer is better.
Test for chlorine using a pool / spa test kit

Chlorine Injection Rates
Sodium hypochlorite (liquid)
Example: Household bleach with 5.25% ac?ve chlorine.
Chlorine injec?on = System ow x Desired Cl x 0.006 Strength of

Rate (gal/hr) Rate (gpm) Conc. (ppm) Cl solu?on (%)

Calcium hypochlorite (solid)

65-70% available chlorine.
12.8 lbs. of calcium hypochlorite added to 100 gallons of
water forms a 1% solu?on.
Then use above formula for injec?on rate.
Flushing of Microirrigation Systems
Silts and clay particles pass through even

the best filters.
Silts and clay particles pass through even the

best filters.
Need to flush the system - mainlines,
submains, and laterals (in that order).
Flush laterals by hand or use automatic flushing
end caps.
Questions:
Microirrigation Maintenance Website
Scenario 1: Determining the appropriateness
of water, lets say it is groundwater, for
microirrigation.
Do you need to worry about clogging?
Microirrigation Maintenance Website
Scenario 2: Choosing a filter
What types of filters are available and how can
you choose the best filter for your situation?
Scenario 3: Solving a clogging problem.
Youve noticed that the drip emitters are clogging
and youve seen some reddish, slimy material on
the filters and in the drip lines. You think it might
be iron bacterial slime.
What do you do about it?

Questions???
Larry Schwankl
559-646-6569 [email protected]
Presentations available at:

http://ucanr.edu/schwankl

Maintenance of Micro Irrigation System

Uploaded by

Copyright:

Available Formats

Maintenance of Micro Irrigation System

Uploaded by

Document Information

Original Description:

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

Maintenance of Micro Irrigation System

Uploaded by

Copyright:

Available Formats

Getting the Most from Your Irrigation System

Maintenance of Microirrigation Systems

Powerpoint at: http://ucanr.edu/schwankl

Powerpoint presentation on Microirrigation

Web site on Maintenance of Microirrigation

Powerpoint presentation on Microirrigation

Sources: Physical Clogging Particulates

Sources: Physical Clogging Particulates

They can all filter to the same degree

Mesh size recommended by

Also rated by mesh size

Water quality levels of concern:

Iron: pH > 4.0 and 0.5 ppm iron

Solution: pH Control (Acidification)

2. Chemicals (e.g. phosphonic acid,

Most common biocides are chlorine and copper.

Most common biocides are chlorine and copper.

Acid may deter biological growth but not

When add chlorine to water:

Continual Injection 1-2 ppm

Contact time is important inject for at least a few

Test for chlorine using a pool / spa test kit

Chlorine injec?on = System ow x Desired Cl x 0.006 Strength of

Calcium hypochlorite (solid)

Silts and clay particles pass through even

Silts and clay particles pass through even the

What do you do about it?

Presentations available at:

You might also like