Settop-Box

Service Manual

Model : Srt4125
 CONTENTS INDEX

1. Block Diagram. 3 page

2. Features 4 page

3. Technical Specification 5~8 page

4. Trouble Shooting 9~17 page

5. Bill of Materials List.. 18~24 page

6. Circuit Drawing 25~37 page

6-1. Main / Front PCB Board
6-2. SMPS PCB Board

7. Firmware, OTA Software Downloading Method 38~39 page

1. BLOCK DIAGRAM
LNBP & 22K CONT
QPSK NIM
LNB OVER CURRENT PORT SERIAL SDRAM MEM
INTERFACE (16Mbit)
AC IN : 90 ~ 240 VAC
MAX 40W

SMPS
L64005F
3.3V
MPEG
5V L64108
A/V
7V CPU & MPEG
DECODER
12V DEMUX
22V
30V

FRONT BT864
(7-KEY VIDEO
IR RCV DRAM MEM (16Mbit) ENCODER
2-LED) FLASH MEM(8Mbit)
EEPROM(64Kbit).

VCR(WITOUT VOLUM CONTROL)

CVBS,L,R OUT

AUDIO-DAC CVBS,L,R IN

(PCM1723) VCR SCART

TV : CVBS,L,R,RGB OUT

TV SCART
SCART
CONT 4-RCA
(74HC4053 ) (CVBS,L,R,12V)
* 2 PCS
RF MODULATOR
(RMUP74055WT)
2. Features

Easy Graphic MENU Interface

RS232C Port for Updating Control Software and Additional Service

Supports DiSEqC1.0,1.2

2-SCART(TV,VCR) Connectors & RCA(CVBS,L,R)

Multi-language Function(Menu, Audio)

Last Channel Memory

OSD: Transparency & Blending, 16 Colors

Front Panel Buttons(S/B On & Off) & IR Remote Controller User Interface

Editing Functions(TV or Radio Channel, Channel Name, PID, Transponder Name)

EPG for On Screen Channel Information

Channels Memory for Multi-satellite(up to 64)

3 Operation Modes(Digital TV, Digital Radio, Favorite)

Receives QPSK Satellite Broadcasting RF Signal and Decodes the Digitally Encoded Signal

Digital Tuner with Loop-through

SCPC/MCPC Receivable from C/KU-band Satellite

Wide Symbol Rate 2~45 Mbps & 950~2150 MHz input Frequency
MPEG-2 Main Profile at Main Level

Teletext Supported

2100 Channels Memory(Digital 2000, Favorite 100)

PLL RF Modulator UHF 21~69 with PAL BG/I/DK

 3. TECHNICAL SPECIFICATIONS
Transmission Standards : DVB, MPEG2
1. TUNER & DEMODULATOR
Input Frequency Range 950MHz to 2150MHz
RF input Signal Level -25 ~ -65 dBm
RF impedance 75 ohms
IF Bandwidth 55MHz / 8MHz(under 5Msps)
LNB Power 13.5 / 18.5Vdc +/- 5%,0.5Amax,1.2Apeak
overload protected
LNB tone switch 22KHz +/- 2KHz, 0.6Vpp +/- 0.2V
DiSEqC Version1.0,1.2 Tone burst A/B
Demodulation QPSK
Symbol Rate 2 ~ 45 Msps / SCPC,MCPC

2. MPEG
Transport Stream MPEG-2 TS Specification(ISO/IEC 13818)
Input Rate Max. 15Mbit/s
VIDEO MPEG-2 MP@ML
AUDIO MPEG-1/2 Audio layer 1,2
Aspect Ratio 4:3, 16:9
Video Resolution 720 576(PAL), 720 480(NTSC)
Audio mode Stereo, Dual channel, Joint stereo, Mono
Audio Sampling Frequency 32/44.1/48KHz

3. Connector
LNB IF input 1 F Type
LNB IF loop through output 1 F Type
TV SCART RGB, CVBS, L, R out
AUX SCART CVBS, L, R out
RGB, CVBS, L, R in
RAC JACK CVBS
Audio L, R
0/12Vdc out

Serial Port RS232C D-sub maleType

 4. MEMORY
FLASH MEMORY 1 Mbytes
DRAM 2 Mbytes
SDRAM 2 Mbytes
EEPROM 16Kbit

5. RF-Modulator
RF Connect 75 W IEC169-2, Male/Female
Frequency 470 MHz to 860 MHz
Output Channel CH 21 69 for the Modulator
TV Standard PAL B/G/I/D/K selectable by Menu setting

6. POWER Supply
Supply Voltage 85Vac ~ 260Vac(SMPS)
Power Consumption Max 30W
Physical Size 280 m/m
Weight Approx. 2.5kg
Operating Temperature 0 C 40 C
Storage Temperature -40 C 65 C

SCART socket
PIN No. TV AUX
1 Audio out Right Audio out Right
2 - Audio in Right
3 Audio out Left Audio out Left
4 Audio ground Audio ground
5 Blue ground Blue ground
6 - Audio in Left-
7 BLUE out BLUE in
8 Function control out Function control in
9 Green ground Green ground
10 - -
11 GREEN out GREEN in
12 - -
13 Red ground Red ground
 14 Fast blanking ground Fast blanking ground
15 RED out RED in
16 Fast blanking out Fast blanking in
17 Cvbs ground Cvbs ground
18 Cvbs ground Cvbs ground
19 CVBS out CVBS out
20 - CVBS in
21 Ground Ground

Serial(RS-232) Connector

PIN No. Signal Name

1 -
2 RXD(Receive Data)
3 TXD(Transmit Data)
4 -
5 Ground
6 -
7 -
8 -
9 -

2pin 2pin

S P
E 3pin 3pin C
T

5pin 5pin

9PIN (E-MAIL) 9PIN (P-MAIL)

REAR Panel(BACK View)

AC IN
RF-MOD.
DIGITAL SCART ANT TV/VCR
AUDIO VIDEO
TV OUT
R CVBS

IF IN

L 0/12V
VCR IN/OUT

LOOP RS-232
OUT
4. Trouble Shooting
4-1. Apperance (Exterior) Test
Check the condition of install, joining of connectors, break or bend of PCB, cold-soldering or
Short of components and problem of part ,etc.
4-2. Power Test
5V Checking to BD(901,902,903)
3.3V Checking to BD(904,905)
30V Checking to BD906
23V Checking to BD907,908
12V Checking to BD909
7V Checking to BD910
4-3. System Test
Check whether CPU of L64108 , flash-Rom of TE28F800C3-T working
Check Message Display , Execute Hyper Terminal in PC - ERROR CODE LIST -
* Condition of Hyper Terminal configuraion E001 : Tunner Error
Baud rate(115,200 bps) E002 : EEPROM Error
Data bit(8bit) E003 : RF Error
Parity bit : none E004 : BT864 Error
Stop bit : 1 E005 : L64005 Error
Control : none E006 : DRAM Error

4-3-1. L64018 Clock uses VCXO as system clock(27Mhz) and L64108 output clock(54Mhz)
4-3-2. Flash-Rom of Start Control Signal uses reset, chip-Select
4-4. MPEG and Auduio Video Test
ckeck the whole process from MPEG Decoder(L64005) and Video Encoder(BT864) of R,G,B,CVBS
Also Check the Audio signal( U502(PCM1723 or (U501)AK4323)
Output port(SCART,Phone Jack,RF-Modurator)
4-4-1. L64005(MPEG-2 Audio/Video Decoder)
4-4-2. Video Filter from Bt864A (Digtal Video Encoder)
4-4-3. Audio DAC(U501(AK4363) & U502(PCM1723))
4-5. Channel Test
4-5-1. when NO SIGNAL Message display.
1. U106(KA317 Regrator)- pin3 at 21V ~24V check
R114 by 13(Vert) or 18(Horz) Voltage check
2. I2C Control signal
 4-5-2. 22Khz Control through , TS-Data and Data Error control signal

4-3-1. L64018 Clock uses VCXO as system clock(27Mhz) and L64108 output clock(54Mhz)

27Mhz --
Check point : U201 (7pin)

54Mhz --
Check point : U201 (20pin)

ST ---
Check point : U206 (4pin)

(LOW active) reset ---

Check point : U206(1pin) &
U202(12pin) & U201(145pin).

Failure Causes and Solution.

If the 27Mhz is acting unstably . VCXO with U105 or L64108 is damaged. Replacement of part is
required. Because 54Mhz clock and 27Mhz clock is not generated from inside of the chip , soldering or
Chip is considered as a cause.
 4-3-2. Flash-Rom of Start Control Signal uses reset, chip-Select

RESET --
Check Point : U202(12pin)

CE --
Check Pint : U202(26 pin)

Failure Causes and Solution.

If the flash-Rom(U202) not operation. , must be Checking chip-select pin from L64108. Replacement of part is required.
Because Reset and Chip-Select signal is not Booting.
Also , Checking soldering or Chip is consider flash-rom and CPU. Where are replace of component Part, and Check
the insertion of part
 4-4-1. L64005(MPEG-2 Audio/Video Decoder)

27Mhz(SCLKI, SYSCLK)--
Check pontU301 (82pin,87pin)

PD(0,1,2,3,4,5,6,7) --
Check Point : RA301,RA302

005_ACLK --
Check Point: RA303(4pin)

BICK --
Check Point : RA303 (1pin)

Failure Causes and Solution.

If the 27Mhz is acting unstably . VCXO, U105(74HC04) is damaged. Replacement of part is required.
Because 27Mhz clock is not generated from inside of the chip , soldering or Chip is considered as a cause. Where are
replace of component Part, Check the insertion of part

4-4-2. Video Filter from Bt864A (Digtal Video Encoder)

CVBS --
Check Point : L402

(LOW active) RESET --

Check Point : U401(47pin)

RED --
Check Point : L403

GREEN --
Check Point : L404

BLUE --
Check Point : L405

Failure Causes and Solution.

If the Color signal is not operation. Shoud be Checking 43pin(SYSCLK) 27Mhz Of U401 and
VCC(3.3V) if you have checking, If No problem. Check the install chip-poistion and short of solder, cold solder, etc.
Where are replace of component Part, Check the insertion of part

4-4-3. Audio DAC(U501(AK4363) & U502(PCM1723))

SYSCLK --
Check Point : U502 (1pin)
U501(5pin)
005_ACLK --
Check Pont : U502 (2pin)
U501 (1pin)

LRCLK --
Check Point : U502 (18pin)
U501 (8pin)

BICK --
Check Point : U502 (16pin)
U501 (6pin)

R_AUDIO --
Check Point : U502 (11pin),
U501 (18pin) By U601 (2Pin)
L_AUDIO --
Check Point : U502 (14pin),
U501 (19pin) By U601 (6pin)

Failure Causes and Solution

If the Audio signal is no-output. must be Checking SYSCLK 27Mhz Of U501,U502 and
VCC(5V) if you have to checking, If No problem. Check the install chip-position and short of solder, cold solder, etc.
Where are replace of component Part, Check the insertion of part

4-5. Channel Test

4-5-1. when NO SIGNAL Message display.

1. U106(KA317 Ragrator)- pin3 at 21V ~24V check

R114 by 13(Vert) or 18(Horz) Voltage check

HOR (L)POLARITY --
Check Pont : R121
LNBA --
Check Point : R114, (18V)

VERT (H)POLARITY --
Check Point : R121

LNBA --
Check Point : R114, (13V)

Failure Causes and Solution

If the 13(V)/18(H) Voltage is no-output. must be Checking High(3.3V)/low(0V) of
R120(LNBP_OFF) and if it high. Checking about Q107 ,U106(KA317), Q106 Part
Check the insertion of part and replace of component part

2. I2C Control Signal

SCL --
Check Pont : R107
U201(155pin),U204(6pin),
U401(41pin),U501(11pin)
R452.

SDA --
Check Point : R108
U201(156pin),U204(5pin),
U401(40pin),U501(12pin)
R451.

Failure Causes and Solution

if Voltage is drop SCL as well as SDA. No Signal message will be Display at TV Screen.
therefore each of part check have to SCL with SDA of Voltage 3.2 ~3.5V.
Check the install chip-position and short of solder, cold solder, etc. Where are replace of component Part, Check the
insertion of part
 4-5-2. 22Khz Control through , BCLK and ERROROUT control signal

22Khz --
Check Point : R125

22Khz ON / OFF --
Check Point : R126

BCLK --
Check Pont : R112

ERROROUT --
Check Point : R109

Failure Causes and Solution

If the 22Khz with BCLK is no-output. Must be Voltage measurement supplied to Tunner
Therefore be have to Checking Voltage BD102(30V), BD110&BD103(5V), BD105(3.3V)
Check the install chip-position and short of solder, cold solder, etc.
 EM513S-IT201
LOW COST FTA MODEL
K1,K2,K3 MOLD NO DIGTAL AUDIO OUT PUT NO S-VIDEO SMPS : SMPS-DDI180A / rev B

DATE : 2001. 11.08

VER : M/P 1.2
MODEL : STRONG
OPTION : R/F MODUL,SAMSUNG TUNNER
Etc :
1. Strong MAN PCB ASS'Y

1-1 SMD
Item Type Quantity Reference Part Number Vendor CORD Remark
1 SMD 23 BD451,BD452,BD501,BD702,BD704 FCM2012C-101 TAI-Tech I3301-001375 FCM2012C-101 (2012 size)
BD901,BD902,DB903,BD904,BD905
BD906,BD907,BD908,BD909,BD910
BD951,BD952,BD953,BD102,BD103
BD105,BD109,BD110,R114
1-1 SMD 1 R114 FCM2012C-470 TAI-Tech I3301-001378 FCM2012C-470 (2012 size)
2 SMD 3 L201,L301,L401 FCI2012-100K TAI-Tech I2703-000125 10uH (2012 size)
3 SMD 4 L402,L403,L404,L405 FCI1608-1R8K TAI-Tech I2703-001896 1.8uH (1608 size)
4 SMD 77 CB101,CB103,CB104,CB105,CB106 CS1608Y5V104Z500NR SAMWHA I2203-006000 C-Ceramic, 0.1uF (1608 size)
CB107,CB201,CB202,CB203,CB204
CB205,CB206,CB207,CB208,CB209
 CB210,CB211,CB212,CB213,CB214
CB215,CB216,CB217,CB218,CB219
CB220,CB221,CB232,CB233,CB236
CB238,CB240,CB302,CB305,CB306
CB307,CB308,CB309,CB310,CB311
CB312,CB313,CB314,CB315,CB401
CB402,CB403,CB404,CB405,CB406
CB407,CB408,CB451,CB453,CB454
CB501,CB502,CB503,CB504,CB505
CB506,CB603,CB604,CB701,CB704
CB705,CB711,CB715,CB716,CB717
CB718,CB719,CB901,CB903,CB905
CB906,CB907
5 SMD 3 CB102,CB904,CB452 CS2012Y5V104Z500NR SAMWHA I2203-000192 C-Ceramic, 0.1uF (2012 size)
6 SMD 6 C501,CB951,CB952,CB953,CB954, CS2012Y5V224Z500NR SAMWHA I2203-000563 C-Ceramic, 0.22uF (2012 size)
CB955
7 SMD 15 C107,C229,C237,C301,C304, CS1608X7R102K500NR SAMWHA I2203-000440 C-Ceramic, 1nF (1608 size)
C702,C703,C707,C708,C709,
C710,C712,C713,C956,C957
8 SMD 7 C108,C235,C409,C412,C415, CS1608C0G220J500NR SAMWHA I2203-006001 C-Ceramic, 22pF (1608 size)
C418,C226
9 SMD 10 C222,C225,C227,C228,C230 CS1608X7R103K500NR SAMWHA I2203-000257 C-Ceramic, 0.01uF (1608 size)
C231,C238,C239,C240,C241
10 SMD 1 C223 CS1608Y5V105Z500NR SAMWHA I2203-040216 C-Ceramic, 1uF (1608 size)
11 SMD 1 C224 CS1608C0G510J500NR SAMWHA I2203-040217 C-Ceramic, 51pF (1608 size)
13 SMD 1 C234 CS1608X7R152K500NR SAMWHA I2203-005663 C-Ceramic, 1.5nF (1608 size)
14 SMD 1 C303 CS1608C0G200J500NR SAMWHA I2203-000548 C-Ceramic, 20pF (1608 size)
15 SMD 4 C410,C413,C416,C419 CS1608C0G680J500NR SAMWHA I2203-040223 C-Ceramic, 68pF (1608 size)
16 SMD 4 C411,C414,C417,C420 CS1608C0G331J500NR SAMWHA I2203-005661 C-Ceramic, 330pF (1608 size)
17 SMD 2 C601,C605 CS1608C0G470J500NR SAMWHA I2203-005000 C-Ceramic, 47pF (1608 size)
18 SMD 2 C602,C606 CS1608C0G391J500NR SAMWHA I2203-002017 C-Ceramic, 390pF (1608 size)
19 SMD 2 C706,C714 CS1608C0G100J500NR SAMWHA I2203-000296 C-Ceramic, 10pF (1608 size)
20 SMD 1 R116 CR 1/10 241 JT HAN RYUK I2007-040210 240ohm (2012 size)
21 SMD 4 R117,R118,R129,R130 CR 1/10 472 JT HAN RYUK I2007-000872 4.7Kohm (2012 size)
22 SMD 1 R119 CR 1/10 122 JT HAN RYUK I2007-000221 1.2Kohm (2012 size)
23 SMD 6 R709,R711,R715,R718,R719, CR 1/10 620 JT HAN RYUK I2007-001100 62ohm (2012 size)
R738
24 SMD 1 R135 CR 1/10 102 JT HAN RYUK I2007-000468 1Kohm (2012 size)
25 SMD 2 R763,R768 CR 1/10 202 JT HAN RYUK I2007-000671 2Kohm (2012 size)
26 SMD 1 R122 CR 1/10 911 JT HAN RYUK I2007-001239 910ohm (2012 size)
27 SMD 2 R127,R901 CR 1/10 121 JT HAN RYUK I2007-000023 120ohm (2012 size)
28 SMD 1 BD701 CR1/10 152 JT HAN RYUK I2007-000241 1.5Kohm (2012 size)
29 SMD 1 BD703 CR1/10 332 JT HAN RYUK I2007-000686 3.3kohm (2012 size)
30 SMD 3 RA206,RA207,RA210 CN 164 330 JT HAN RYUK I2011-001282 33ohm
31 SMD 2 RA201,RA202 CN 164 102 JT HAN RYUK I2011-001279 1Kohm
32 SMD 5 RA203,RA204,RA205,RA208,RA209 CN 164 472 JT HAN RYUK I2011-001280 4.7Kohm
33 SMD 6 RA301,RA302,RA303,RA101,RA102 CN 164 101 JT HAN RYUK I2011-001281 100ohm
RA103
34 SMD 25 R104,R106,R115,R120,R121 CR 1/16 103 JT HAN RYUK I2007-000090 10Kohm (1608 size)
R125,R126,R128,R131,R132
R243,R453,R455,R605,R607
R707,R708,R713,R714,R742
R746,R751,R755,R766,R767
35 SMD 19 R216,R225,R229,R230,R235 CR 1/16 472 JT HAN RYUK I2007-000084 4.7Kohm (1608 size)
R236,R237,R301,R306,R454
R743,R744,R748,R749,R750
R752,R753,R754,R781
36 SMD 9 R207,R209,R210,R401,R402 CR 1/16 330 JT HAN RYUK I2007-000113 33ohm (1608 size)
R451,R452,R501,R502
37 SMD 11 R112,R133,R143,R146,R204 CR 1/16 000 JT HAN RYUK I2007-000070 0ohm (1608 size)
 R232,R234,R238,,R239,R245
R780
38 SMD 3 R148,R603,R610 CR 1/16 473 JT HAN RYUK I2007-000939 47Kohm (1608 size)
39 SMD 19 R140,R206,R224,R227,R606 CR 1/16 102 JT HAN RYUK I2007-000078 1Kohm (1608 size)
R608,R710,R712,R717,R720
R740,R747,R764,R770,R771
R723,R760,R761,R762
40 SMD 1 R141 CR 1/16 153JT HAN RYUK I2007-000092 15Kohm (1608 size)
41 SMD 2 R105,R211 CR 1/16 621 JT HAN RYUK I2007-001093 620ohm (1608 size)
42 SMD 1 R212 CR 1/16 622 FT HAN RYUK I2007-040209 6.2K(F)ohm (1608 size)
43 SMD 1 R213 CR 1/16 1692 FT HAN RYUK I2007-007893 16.9K 1%ohm (1608 size)
44 SMD 2 R222,R223 CR 1/16 332 JT HAN RYUK I2007-000082 3.3Kohm (1608 size)
45 SMD 1 R226 CR 1/16 100 JT HAN RYUK I2007-000309 10ohm (1608 size)
46 SMD 2 R252,R253 CR 1/16 105JT HAN RYUK I2007-000109 1Mohm (1608 size)
47 SMD 1 R302 CR 1/16 151 JT HAN RYUK I2007-000402 150ohm (1608 size)
48 SMD 2 R303,R305 CR 1/16 180 JT HAN RYUK I2007-000463 18ohm (1608 size)
49 SMD 1 R304 CR 1/16 201 JT HAN RYUK I2007-000539 200ohm (1608 size)
50 SMD 1 R307 CR 1/16 270 JT HAN RYUK I2007-000659 27ohm (1608 size)
51 SMD 5 R403,R404,R406,R408,R410 CR 1/16 750 FT HAN RYUK I2007-001164 75 1%ohm (1608 size)
52 SMD 1 R503 CR 1/16 512 JT HAN RYUK I2007-040211 5.1Kohm (1608 size)
53 SMD 1 R504 CR 1/16 4R7 JT HAN RYUK I2007-000882 4.7ohm (1608 size)
54 SMD 2 R601,R612 CR 1/16 683 JT HAN RYUK I2007-000100 68Kohm (1608 size)
55 SMD 2 R602,R609 CR 1/16 333 JT HAN RYUK I2007-000134 33Kohm (1608 size)
56 SMD 8 R705,R706,R721,R722,R726, CR 1/16 221 JT HAN RYUK I2007-000075 220ohm (1608 size)
R727,R730,R731
57 SMD 16 R724,R725,R728,R729,R732, CR 1/16 223 JT HAN RYUK I2007-000094 22Kohm (1608 size)
R733,R734,R739,R756,R757,
R758,R759,R772,R773,R774,
R778
58 SMD 3 R735,R736,R737 CR 1/16 682 JT HAN RYUK I2007-000087 6.8Kohm (1608 size)
59 SMD 3 R775,R776,R777 CR 1/16 113 JT HAN RYUK I2007-000329 11Kohm (1608 size)
60 SMD 2 R741,R779 CR 1/16 822 JT HAN RYUK I2007-000089 8.2Kohm (1608 size)
61 SMD 1 R745 CR 1/16 302 JT HAN RYUK I2007-000083 3Kohm (1608 size)
62 SMD 3 R765,R214,R215 CR 1/16 470 JT HAN RYUK I2007-000072 47ohm (1608 size)
63 SMD 5 R769,R109,R107,R108,R138 CR 1/16 101 JT HAN RYUK I2007-000074 100ohm (1608 size)
64 SMD 2 R144,R145 CR 1/16 1R0 JT HAN RYUK I2007-002425 1ohm (1608 size)
65 SMD 4 R405,R407,R409,R411 CR 1/16 132 FT HAN RYUK I2007-000231 1.3K 1%ohm (1608 size)
66 SMD 21 Q104,Q107,Q108,Q109,Q110, KST3904-MTF(SOT-23) KEC I0501-002275 SOT-23
Q111,Q113,Q114,Q452,Q703,
Q704,Q708,Q709,Q710,Q712,
Q713,Q715,Q716,Q717,Q718,
Q719
67 SMD 7 Q701,Q702,Q705,Q706,Q707, MMBT2222A(SOT-23) KEC I0501-002283 SOT-23
Q720,Q721
68 SMD 1 U103 AMS1117CD-3.3V AMS I1203-001921 AMS1117CD-3.3V
69 SMD 1 Q711 KN3906S(SOT-23) KEC I0501-002276 SOT-23
70 SMD 1 U105 74HC04(SOP) Fairchild I0801-002385 74HC04(SOP)
71 SMD 1 U201 L64108E(PQFP) LSI logic I0902-001285 L64108E
72 SMD 1 U202 TE28F800C3TA90 INTEL I1107-001163 TE28F800C3TA90
73 SMD 1 U203 KM416V1204CJ-6 samsung I1105-001299 KM416V1204CJ-6
74 SMD 1 U204 AT24C64N-10SC-2.7 ATMEL IMD13-00125D AT24C64N-10SC-2.7
75 SMD 1 U206 DS1819 Dallas i1203-001932 DS1819 3.3V(Vcc)
76 SMD 1 U301 L64005 LSI logic I1204-001621 L64005
77 SMD 1 U302 KM416S1020BT-G/F10 samsung I1105-001300 KM416S1020BT-G/F10
78 SMD 1 U401 BT864AKPF(PQFP) Rockwell I1204-001610 BT864AKPF
79 SMD 1 U502 PCM1723E(24SSOP) borbrown i1002-001180 Or U501AK4363
80 SMD 1 U601 KA358D(SOP) Fairchild I1201-000166 KA358
81 SMD 2 U701,U702 CD74HC4053M(SOP) PHILIP I0801-003010 CD74HC4053M(SOP)
82 SMD 1 U951 SP232ECN(SOP) SIPEX I1006-000002 SP232ECN
83 Ass'y 1 SMPS DDI-180/A rev B Dongdo SMPS-DDI180B
84 1 MAINPCB IT513SS-MAIN ,ver. M/P 1.0, 2001.09.21 P-IT513-R1.3 SAMSUNG TUNER applied

1-2
Item Quantity Reference Part Number Vendor CORD Remark
1 1 CE106 1uF/50V-5*11*5,FORMING CUT TYPE DAEWOO I2401-000602 C-AL ; 1uF/50V-5*11*5,FORMING CUT TYPE
2 DIP 1 CE401 47uF/25V-5*11*5 DAEWOO I2401-001075 C-AL ; 47uF/25V-5*11*5, FORMING CUT TYPE
3 DIP 5 CE102,CE904,CE905,CE452,CE453 47UF/50V DAEWOO I2401-003510 C-AL ; 47uF/50V-6.3*11*5, FORMING CUT TYPE
4 DIP 3 CE704,CE906,CE907 100uF, 20%, 25V, GP, TP, 6X11, 5 DAEWOO I2401-002347 C-AL ; 100uF, 20%, 25V, GP, TP, 6X11, 5
5 DIP 36 CE202,CE203,CE204,CE205,CE206 10uF/25V-5*7*5 DAEWOO I2401-001077 C-AL ; 10uF/25V-5*7*5, FORMING CUT TYPE
CE301,CE451,CE501,CE502,CE503
CE601,CE602,CE603,CE604,CE701
CE702,CE703,CE708,CE711,CE712
CE713,CE714,CE715,CE716,CE717
CE718,CE719,CE720,CE721,CE723
CE724,CE730,CE731,CE732,CE733
CE951
6 DIP 6 CE101,CE103,CE104,CE105,CE901 330uF, 20%, 16V, GP, TP, 8X11.5, 5 DAEWOO I2401-001100 C-AL ; 330uF, 20%, 16V, GP, TP, 8X11.5, 5
CE903
7 DIP 1 D101 1N4004A PHILIP, ROHM I0402-001242 Diode
8 DIP 1 D901 MTZ J 33B PHILIP, ROHM I0403-001406 30V ZENER DIODE
9 DIP 1 D103 MTZ J 3.6B PHILIP, ROHM I0403-001407 3V ZENER DIODE
10 DIP 4 Q103,Q106,Q112,Q116,Q451 KTA1273(TO92) KEC I0502-001107 TO-92
Q714
10-1 DIP 2 Q106,Q112 KSB772-Y Fairchild I0502-000249 TR-POWER,KSB772-Y,PNP,10W,TO-126
11 DIP 1 CON201 SW 0500-12 HAN LIM IAJ37-00605G 2.0mm, 12-Pin Wafer
12 DIP 1 CON701 2203-42ST (-A- Type) ILSSAN I3722-001410 ILSSAN:DUAL SCART 2203-42T
13 DIP 1 CON702 JS0401315N I3722-001211 PHONO RCA JACK-4PACK
14 DIP 1 CON901 5267-11 I3711-005000 5267-11
15 DIP 1 CON951 3302-09S-AFS-0 ILSSAN I3710-001563 DB9
16 DIP 2 JP451,JP452 PLUG-CONNECTOR ; 2250-10P-DS-T ILSSAN I3711-005001
17 DIP 1 TU101 TBMU30311IMP(SAMSUNG) Samsung i4703-000002
18 DIP 2 U102,U451 KA7805TU Fairchild I1203-001922 : KA7805;
19 DIP 1 U205 VCXO27M Kony I2806-001223 OSCILLATOR-VCXO ; 13T-63AP,27MHz-3.3V
20 DIP 1 SWRST KPT1115 KYUNGIN I3403-001097 SW PUSHBUTTON
21 DIP 1 U106 KA317TU(TO220) Fairchild I1203-001923 LM317
22 DIP 1 H1(FOR U106) 002A-1 I6203-000002 HEAT SINK 27mm(w) * 40mm(L)
23 DIP 1 H1 SCREW(FOR U106) TT2, BIN(+)*WTH 3*6 (BLACK) T I6009-001019 SCREW
24 1 CABLE-POWER ; KKJ640 CABLE-POWER ; KKJ640 I3801-000001
25 1 Shielding Foam Gasket Shielding Foam Gasket ESONG I6302-000001 10mm(W)*10mm(H) * 15mm(L)tunner top at attach

2. IT513S FRONT ASS'Y(K1 PCB)-EF513S-IT101

Auto/ Hand Insertion NEW FRONT

Item Type Quantity Reference Part Number Vendor CORD Remark
1 DIP 1 U3B HI-M602H3-2 I1204-001623 (supporter ) , (U3A)TSOP1238
2 DIP 2 R1,R9 RNL 1/6 331 JT-52 HAN RYUK I2001-040213 330ohm
3 DIP 3 R6,R7,R8 RNL 1/6 102 JT-52 HAN RYUK I2001-003113 1K
4 DIP 1 R5 RNL 1/6 330 JT-52 HAN RYUK I2001-003115 33
5 DIP 3 Q1,Q2,Q3 2N3904(TO92) KEC I0501-002277 TO-92
6 DIP 1 CE1 47uF/25V-5*11*5 DAEWOO I2401-001075 C-AL ; 47uF/25V-5*11*5, FORMING CUT TYPE
7 DIP 1 CB1 CR051BX7R104Z500R SAMWHA I2202-000857 C-CERAMIC, MLC-RADIAL ; 100nF, 10%, 50V,X7R
8 DIP 1 CON2 2.0mm pitch, 130mm,12pin Molex I3711-001146 2.0mm, 12-Pin Cable Ass'y
9 DIP 7 S1,S2,S3,S4,S5,S6,S7 KPT1115 KYUNGIN I3403-001097 SW PUSHBUTTON
10 DIP 1 LED1 LH3330 LIGITEK I0601-001378 LED ; ROUND ; LH3330,RED,5mm,565mm
11 DIP 1 LED2 LG3330 LIGITEK I0601-001377 LED ; ROUND ; LG3330,GREEN,5mm,565mm
12 DIP 2 LED support support hight : 7mm ya young I6103-001040 LED support
13 DIP 12 JP1~JP10,JP12,JP13 7.5mm, JUMPER I3811-000548 7.5mm, JUMPER
14 1 FRONT PCB(IT513S) IT513S-K1; P/P VER 1.2 2001.05.09 P-IT513F-1.2

3. IT513S RF_SUB ASS'Y

M_code : ES513S-IT002 PART LIST VER : IT513_S SUB ver:R1.0
Auto/hand insertion M_code name : PCB SUB ASSY ; 512, SATELLITE, SAMSUNG, VER R1.0

Item Type Quantity Reference Part Number Vendor CORD Remark

1 1 RF_SUB PCB IT612_R1.3 VER 1.3, 1Layer PSIT513-R1.2 1
2 1 U16 RMUP74055WT SAMSUNG IRMUP74055WT 1
3 DIP 2 JP7,JP10 I3710-001567 2
 A B C D E
S5V S5V S5V

LED1 LED2
Red R8 GREEN
1K(DIP)

4 4

R1 R9
330 (DIP) 330 (DIP)

R6 Q2
1K(DIP) 2N3904(TO92)
R7 Q1 Q3 SINGLE LAYER PCB DESIGN
2N3904(TO92) 2N3904(TO92) RESISTOR AXIAL TYPE
CON1 1K(DIP) S5V CAPACITOR RADIAL TYPE
1
2 S5V
3
4
5 S1
3 3
6 POWER(STBY) R5
7
8 KPT1115 33(DIP)
9 U3B
10 1
11 2 OUT
12 S2 3 GND
CH UP VS
HEADER 12 (HUNIN)
KPT1115 + HI-M602H3-2

U3A
S3 1
S5V CH DOWN 2 GND
3 VS
KPT1115 OUT
CB1
CE1
2 0.1uF TSOP1238 2
S4 47uF/25V
(TEMIC)
VOL UP
KPT1115

S5
VOL DOWN
KPT1115

S6
MENU/SEL
KPT1115
1 1
INTEGRA TELECOM CO.LTD.,
S7 Title
EXIT FRONT CIRCUIT
KPT1115
Size Document Number Rev
A front_512LOW 1.1

Date: Friday, November 02, 2001 Sheet 1 of 1

A B C D E
 A B C D E

CB953 BD953 S5V

0.22uF(2012) FCM2012C-101

2
DELETE U951 0.22uF(2012) 3.3V
0.22uF(2012) 16

VO-

VO+
S5V 3.3V 1 VCC 4
U901 C1+ C2+
CE901 CB951 CB952 CB955 + CE951 BD954
BD901 NC(AMS1117CD-3.3) CB903
FCM2012C-101 330uF/16V 0.22uF(2012) NC(FCM2012C-101)
3 2 0.1uF SS(PHILIPS) 10uF/25V
IN OUT R136,137 : DELETE 3 5 CB954

GND
BD902 Q115 : DELETE C1- C2- CON951
FCM2012C-101 U101 0.22uF(2012) BD951
CB901 + + + CE903 11 14 FCM2012C-101
CE902 3.3V 10 TIN1 TO1 7 1 6
4 330uF/16V TXD1 TXD 4
BD903 0.1uF 115-T-7121TP 12 TIN2 TO2 13 2 7
RXD

1
FCM2012C-101 RO1 RI1 3 8
9 8
NC(0.1uF) NC(330uF/16V) RXD1 RO2 RI2 4 9
R136 15 BD952

ERROROUT
BD904 CB902 GND 5
FCM2012C-101 FCM2012C-101

AUX_CK
SP232ECN(SOP)

FSTART
NC(4.7K)

5V(RF)

RESET
22KHZ
LNB A
LNB B

VALID
T30V C956 C957

BCLK

SCLK
3302-09S-AFS-0

Port 1
AGC

GND
5VD

SDA
3.3V
BD905

5VA

5VA

D0
D1
D2
D3
D4
D5
D6
D7
VT
CON901 FCM2012C-101 BD906 R901

Q
I
FCM2012C-101 120(2012) 1nF 1nF
Q115 3.3V
1

1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
2 NC(KST3904-MTF(SOT-23))
3 CB904 CH_RST
LNB_23V + D901 R137 NC(4.7K)
4 R111
5 BD907 MTZ J 33B(30V,ZENER)
0.1uF(2012) R138 NC(4.7K) 3.3V S5V DELETE
6 FCM2012C-101
100 TS104
7 SDA
LNBA MTS_RST MTS_TS0
8 BD908 R109 100 1 2
FCM2012C-101 MTS_ERROR CH_ERROR
9 CB905 + CE905 CE904 SCL
10 LNBP_IN MTS_TS1
R107 100 3 4
11 47uF/50V 47uF/50V SCL
0.1uF R108 100 R110 NC(33) Q105 MTS_TS2
SDA 5 6
S12V S5V NC(KST3904-MTF(SOT-23))
5267-11 BD101 RA101 100(RA) SS(PHILIPS) MTS_RST
NC(FCM2012C-101) PTO[7..0] MTS_TS3
BD909 MTS_TS71 8 PTO7 R110,111 : DELETE 7 8
FCM2012C-101 MTS_ERROR
MTS_TS6 2 7 PTO6 Q105 : DELETE MTS_TS4
CB101 MTS_TS5 3 6 PTO5 3.3V 9 10
CE101 4 5 MTS_SYNC
+ MTS_TS4 PTO4 MTS_TS5
T7V CB906 + CE906 MTS_TS3 1 8 PTO3 11 12
3 330uF/16V 0.1uF MTS_VALID 3
100uF/25V MTS_TS2 2 7 PTO2 R112 0 CB106 MTS_TS6
BD910 0.1uF MTS_TS1 3 6 PTO1 13 14
FCM2012C-101 MTS_CLK
MTS_TS0 4 5 PTO0 0.1uF MTS_TS7
T30V SS(PHILIPS) 15 16
BD102 RA102 100(RA) U105A R113 :
CB907 FCM2012C-101 17 18
+ CE907 4 5 DELETE
100uF/25V MTS_SYNC 3 6
CH_SYNC
1 2 R113
CH_CLK
0.1uF MTS_VALID 2 7 NC(33) 19 20
CH_VALID
CE102 + MTS_CLK 1 8 NC
47uF/50V RA103 100(RA) 74HC04(SOP) R114
CB102
FCM2012C-470
MTS_TS[0..7]
0.1uF(2012)
R143
0 ohm BD110 D101 1N4004A Q106 F101
FCM2012C-101 KSB772-Y NC(RXE065)
U102 LNBA
T7V Q101 H1
KA7805TU BD103
NC(KTA1273(TO92)) FCM2012C-101 heat sink
R115
DELETE
1 3
IN OUT 10K
3 2 Q112 KSB772-Y
GND

H : TU5V,TU3.3V,RF-MOD ON CB104 IN OUT

LNBP_IN

ADJ
LOOP-OUT OFF R101 CB103
DELETE NC(10K)
+ U106
L : TU5V,TU3.3V,RF-MOD OFF CE103 0.1uF R116 R117 R118
LOOP-OUT ON KA317TU(TO220)
2

0.1uF 330uF/16V 240(2012) 4.7K(2012) 4.7K(2012)

1
2 PWR_CNTL 2
R103 R102
NC(10K) NC(4.7K) H : ON R134 R129 R130
R119 1.2K(2012) R120
Q102 DELETE Q107
L : OFF NC(47K) 4.7K(2012) 4.7K(2012)
10K
NC(KST3904-MTF(SOT-23)) 3.3V C107
KST3904-MTF(SOT-23) LNBP_OFF
BD104 R135 1K(2012) 1nF
NC(FCM2012C-101)
S5V
R131
U103 10K
S5V Q103 AMS1117CD-3.3 BD105 3.3V Q113
KTA1273(TO92) FCM2012-101 R121 PWR_CNTL
3 2 R122 KST3904-MTF(SOT-23)
IN OUT 10K
910(2012) R146
GND

POLARITY
Q108 0 Q114
R104 CE104 + H : 14V R123 R124 R132
10K KST3904-MTF(SOT-23) 10K
330uF/16V CB105 L : 18V H : LNBP-DOWN NC(10K) NC(100K)
L : LNBP-OK
1

0.1uF KST3904-MTF(SOT-23) KST3904-MTF(SOT-23)

120(2012)
R125 LNB_DOWN R147
Q109 R127
R106 R105 10K
22KHz C108
10K 620 NC(0)
R133 DELETE 22pF Q111
Q104 3.3V R126
0 22ON/OFF 10K KST3904-MTF(SOT-23)
KST3904-MTF(SOT-23) Q110
D102 BD108
NC(FCM2012C-101) KST3904-MTF(SOT-23)
NC(1N4004A) H : 22KHz-OFF
U104
L : 22KHz-ON R128
LNB_23V Q116 10K
NC(LD1117DT250 BD109 R141
1 FCM2012C-101 1 47K 1
3 2 R144 KTA1273(TO92) R148
IN OUT
GND

15K
CE105 + CB107 R142 + D103
R145 1
330uF/16V 0.1uF
R139
NC(4.7K) Z3V(3.6V,ZENER) Integra Telecom co.,ltd.
1

NC(0.6,1/2W) R140 Title

DELETE 15 M/M PITCH

1K QPSK DEMODULATOR
CE106 Size Document Number Rev
1uF/50V Custom IT612 1.1

Date: Friday, November 09, 2001 Sheet 9 of 11

A B C D E
 A B C D E
ROM_VPP
SST FLASH R201 3.3V 3.3V
NC(0) for intel rom
WEn U201 R211
CEn 620
CS_008N 136
OEn 145 CS_008 60
RESETN RESET AREQ AREQN R212 U205
127 58
AS AVALID AVALID PWMOUT0 6.2K(F)
128 54 1 14
DSACK0N DS AVD7 AVD7 VCO_IN VDD
129 53
R/WN WR AVD6 AVD6
R231 3.3V 3.3V 55 52 C222 C223 C224 C225
R232 OE AVD5 AVD5
3.3V 131 51 8 7
RA201 NC(0) U202 0 R233 SIZE1 AVD4 AVD4 OUT GND

R235

R236

R237
13 130 50 0.01uF 1uF 51pF 0.01uF
Vpp NC(0) SIZE0 AVD3 AVD3
1 8 14 9 133 49
WP ADDR19 DSACK1 AVD2 AVD2 VCXO27M
2 7 132 48
R234 0 DSACK0 AVD1 AVD1
INTEL FLASH 3 6 R202 27 12 47

4.7K

4.7K

4.7K
GND RESET AVD0 AVD0
PIN 15 -> A20 4 5 46 47 106 56
PIN 10 -> A21 NC(0) GND BYTE ADDR23 AVERR ERRORN
37 11 105 59
PIN 9 -> A22 VCC WE ADDR22 VREQ VREQN U105D
4 28 104 57 C226 4
1K(RA) OE ADDR21 VVALID VVALID

1
2
3
4
PIN 12-> RPn 15 26 EADDR20 103 R214 8 9
RY/BY CE ADDR20 27MHZ 22pF
PIN 13 -> Vpp 16 EADDR19 102 RA205
PIN 14 -> WPn CB201 ADDR18 ADDR19 47 74HC04(SOP)
17 EADDR18 101 3.3V 4.7K(RA)
PIN 47 -> Vccq 3.3V S5V R203 0.1uF ADDR17 48 100 ADDR18 147 U105E
NC(0) EADDR17
45 ADDR16 1 99 ADDR17 ACLK 236 R215 10 11
EDATA15 EADDR16 SYSCLK
43 DATA15 ADDR15 2 96 ADDR16 AVDD 235 R213
EDATA14 EADDR15 16.9K 1% 47 74HC04(SOP)
41 DATA14 ADDR14 3 95 ADDR15 AVSS 234
EDATA13 EADDR14

8
7
6
5
39 DATA13 ADDR13 4 94 ADDR14 IREF U105F
EDATA12 EADDR13 74HC04(SOP)
R204 36 DATA12 ADDR12 5 93 ADDR13 12 13
0 EDATA11 EADDR12 33(RA)
34 DATA11 ADDR11 6 90 ADDR12 RA206 3.3V
0 EDATA10 EADDR11
R238 32 DATA10 ADDR10 7 89 ADDR11 157 4 5
EDATA9 EADDR10
30 DATA9 ADDR9 8 88 ADDR10 STROBE 158 3 6
ROM_WP 0 EDATA8 EADDR9
R239 44 DATA8 ADDR8 18 87 ADDR9 AUTOFD 159 2 7
EDATA7 EADDR8
42 DATA7 ADDR7 19 86 ADDR8 INIT 160 1 8
EDATA6 EADDR7
40 DATA6 ADDR6 20 85 ADDR7 SELECTIN 171
EDATA5 EADDR6
38 DATA5 ADDR5 21 84 ADDR6 ACK/AUXV 172 4 5
EDATA4 EADDR5
DATA4 ADDR4 ADDR5 BUSY

1
2
3
4

1
2
3
4
CB240 Q201 EDATA3 35 22 EADDR4 83 173 3 6 RA209 S5V
33 DATA3 ADDR3 23 82 ADDR4 PERROR 174 2 7
0.1uF EDATA2 EADDR3 4.7K(RA)
NC(KTA1273,TO92) 31 DATA2 ADDR2 24 81 ADDR3 SELECT 175 1 8
EDATA1 EADDR2
29 DATA1 ADDR1 25 80 ADDR2 FAULT 6 RA208
EDATA0 EADDR1 4.7K IR_IN
DATA0 ADDR0 79 ADDR1 OP_MODE2/PDATA_DIR 170 R216 RA207
ADDR0 PDATA7 FNC_IN1 33(RA) 4.7K(RA)
EDATA[0..15] U207 169
R240 TE28F800C3TA90 PDATA6 FNC_IN2
EDATA15 126 168

8
7
6
5

8
7
6
5
EDATA[0..15] DS1811-10% TSOP48 DATA15 PDATA5 FBK_VCR CON201
EDATA14 125 167
NC(10K) DATA14 PDATA4 FBK_OUT
EDATA13 124 166 LED_ON
NC(KST3904-MTF,SOT-23)

3.3V DATA13 PDATA3 FNC_OUT2 1

3
2
1

R241 RA203 EDATA12 123 165 KEY_IN

DATA12 PDATA2 FNC_OUT1 2
DELETE 4.7K(RA) EDATA11 122 164
NC(4.7K) DATA11 PDATA1 HW_MUTE 3
S5V 3.3V EDATA10 119 163 IR_IN
EADDR1 DATA10 PDATA0 TV/VCR 4
EDATA9 118
EADDR2 DATA9 5
EDATA8 117 S5V CH_UP
EADDR3 DATA8 6
R245 EDATA7 114 CH_DWN
R242 NC(10K) U206 DATA7 7
Q202

EDATA6 113 230 VOL_UP

3 DATA6 TTXREQ TTXREQ 8 3

5
6
7
8
R244 3 EDATA5 112 229 R223 VOL_DWN
0 PBRSTn DATA5 TTXDATA TTXDATA 9
4 EDATA4 111 R222 3.3K MENU
R243 10K NC(0) ST DATA4 10
2 EDATA3 110 3.3K EXIT
5 GND 109 DATA3 11
EDATA2
VCC 1 108 DATA2 155 12
RESETN R206 EDATA1 SCL
RSTn 107 DATA1 SCL 156
1K EDATA0 SDA HEADER 12
DATA0 SDA
R252

4
3
2
1
WD_ST DS1819A_B(10%)
CB202 3.3V 137
RA202 1K(RA) 138 BRQ C227 C228 C229 C230 C231 CB232 C238 C239 C240 C241
R253 0.1uF BGA
3.3V 8 1 146 7 10nF 10nF 1nF 10nF 10nF 0.1uF 10nF 10nF 10nF 10nF
1M 1M BG SCLK 27MHz
7 2 8
SDET PWMOUT0 R225
6 3 148
R246 NC(0) DMRQ 4.7K
5 4 144 3.3V
D201 DMAK
R226 10
R205 NC(1N4004A) CS_005N 152 237
151 CS3 PLLVDD 239 S5V
NC(10K) U105B U105C CS2 LP2 CB236 L201
150 238
CS1 PLLAGND 0.1uF 10uH
CS0n 149 240 R224 CB238 +
3 4 5 6 CS0 PLLVSS C237
R207 33 1K 0.1uF
INTN4 143 CB233 1nF
142 INTR4 C235
IR_IN 0.1uF
+ 141 INTR3 36 22pF
74HC04(SOP) 74HC04(SOP) INTN2 INTR2 ECLK
CB239 140 3 CE206
INTR1 IDDTN

1
2
3
4
CE201 139 233 C234
NC(0.1uF) R208 NC(0) INTR0 ZTEST 1.5nF
CLOSE TO 10uF/25V
NC(10uF/10V) RA204
54MHz 20 CHIP 4.7K(RA)
SWINT4 T1 MCLK 74
pin 5 mm 5 SC_CLK1 73
NC(KPT1115) OP_MODE1 SC_DETECT1
4 75
SWRST OP_MODE0 SC1-I/O 76

8
7
6
5
L64108 VDD GND 187 SC_VCC_EN1 71
KPT1115 CTS1 SC_VPP_EN1
VDD: 2,22,35,38,46,62,92,98,116,121,135, 188 72
CTS0 SC_RST1 RA210 LNBP_OFF
2 154,162,180,182,196,214,232 178 2
RTS1 LNB_DOWN
GND:1,21,34,37,45,61,77,78,91,97,115,120, 183 66 4 5
RTS0 SC_CLK0 WD_ST 22ON/OFF
184 65 3 6
134,153,161,179,181,190,191,195,213,231 DTR0 SC_DETECT0 ML_AUD POLARITY
189 67 2 7
DSR0 SC0-I/O MC_AUD
29 68 1 8
RXD2 SC_VCC_EN0 MD_AUD
186 63 R227
RXD1 RXD1 SC_VPP_EN0 33(RA)
185 64 EADDR3
RXD0 SC_RST0 ROM_WP
28 69 EADDR2
177 TXD2 SC0_C4 70 1K
TXD1 TXD1 SC0_C8
176 R228 EADDR1
3.3V TXD0 ROM_VPP
NC(10K) EADDR0
BA[9..0] 224
228 WE1 11
U204 CH_CLK EADDR17
R209 8 222 WE0 CCLK 10
33 CH_ERROR EADDR16
5 VCC 226 CAS1H CERR 9
SDA SDA CAS0H CVALID CH_VALID
6 1 223 19 EADDR15
SCL SCL E0 CAS1L CDATA7 PTO7
2 227 18 EADDR14
R210 E1 CAS0L CDATA6 PTO6
7 3 3.3V 225 17
33 WC E2 CB203 RAS0 CDATA5 PTO5
BA9 221 16 EADDR13
0.1uF U203 BA9/RAS1 CDATA4 PTO4
4 BA8 220 15 EADDR12
GND BA8 CDATA3 PTO3
21 42 BA7 219 14
VCC VSS BA7 CDATA2 PTO2
AT24C64N-10SC-2.7 6 37 BA6 218 13 EADDR11
VCC VSS BA6 CDATA1 PTO1
SOIC 1 22 BA5 217 12 EADDR10
CB220 CB221 VCC VSS BA5 CDATA0 PTO0
BA4 216
215 BA4
BA3 EADDR9
0.1uF 0.1uF 29 12 212 BA3
BA2 EADDR8
13 OE NC 11 211 BA2 27
BA1
31 W NC 210 BA1 TRST 23
BA0 EADDR7
30 LCAS 41 209 BA0 TDI 24 3.3V
BD15 EADDR6
3.3V 3.3V 14 UCAS I/O16 40 208 BD15 TDO 25
BD14 R229
RAS I/O15 39 207 BD14 TMS 26
BD13 4.7K EADDR5
I/O14 38 206 BD13 TCK
BD12 EADDR[0..17] EADDR4
15 I/O13 36 205 BD12
BD11 EADDR[0..17]
1
CB204 CB205 CB206 CB207 + CE202 CB208 CB209 CB210 CB211 + CE203 16 NC I/O12 35 204 BD11 1
BD10
28 NC I/O11 34 203 BD10 33
10uF/25V 10uF/25V BA9 BD9 D_RSTN
27 A9 I/O10 33 202 BD9 GPIO49 32
0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF BA8 BD8 12V_ON/OFF 701 HWA-YOUNG BLD.
26 A8 I/O09 10 201 BD8 GPIO48 31
BA7 BD7 PWR_CNTL 112-2 KARAK-DONG, SONG-PA-GU
25 A7 I/O08 9 200 BD7 GPIO47 30
BA6 BD6
3.3V 3.3V 24 A6 I/O07 8 199 BD6 GPIO46 44 SEOUL, 138-160, KOREA
BA5 BD5 SP_RSTN
23 A5 I/O06 7 198 BD5 GPIO45 43
BA4 BD4 R230 4.7K
20 A4 I/O05 5 197 BD4 GPIO44 42
BA3 BD3
19 A3 I/O04 4 194 BD3 GPIO43 41 INTEGRA TELECOM
BA2 BD2
CB212 CB213 CB214 CB215 + CE204 CB216 CB217 CB218 CB219 + CE205 18 A2 I/O03 3 193 BD2 GPIO42 40 Title
BA1 BD1 CH_RST
17 A1 I/O02 2 192 BD1 GPIO41 39 L64108 BLOCK
10uF/25V 10uF/25V BA0 BD0 V_RSTN
A0 I/O01 BD0 GPIO40
0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF
Size Document Number Rev
KM416V1204CJ-6 L64108E(PQFP)
Custom IT612 1.1
400mil 42SOJ 240p PQFP
Date: Friday, November 02, 2001 Sheet 1 of 11
A B C D E
 A B C D E

U301
3.3V R301
4.7K
131
118 BYPASS 61
BLANKN XDD0
123 BLANK SCLK 60 XDD1
159 CREF SDQM 59 CSKE
96 OSD SCKE 58
HSYNCN SRASN
97 HS SRAS 57
VSYNCN SCASN
VS SCAS 56
100(RA) SWEN
RA301 4 5 88 SWE 55
YCRCB0 SCSN
3 6 89 PD0 SCS 54
YCRCB1 SBA9
2 7 90 PD1 SBA9
YCRCB2 PD2
4 1 8 91 53 SBA10 4
YCRCB3 PD3 SBA10
92 52 SBA11
4 5 93 PD4 SBA11 50
YCRCB4 PD5 NC
3 6 94 49
YCRCB5 PD6 NC
2 7 95 48
YCRCB6 PD7 NC
1 8 45
YCRCB7 NC 44
NC 43
RA302 NC U302
100(RA)
38 SBD0 2 21 R307
SBD0 37 3 DQ0 A0 22
SBD1 27
103 SBD1 36 5 DQ1 A1 23
AVD0 SBD2
104 D0 SBD2 35 6 DQ2 A2 24
AVD1 SBD3
105 D1 SBD3 34 8 DQ3 A3 27
AVD2 SBD4
106 D2 SBD4 33 9 DQ4 A4 28
AVD3 SBD5
107 D3 SBD5 32 11 DQ5 A5 29
AVD4 SBD6
108 D4 SBD6 31 12 DQ6 A6 30
AVD5 SBD7
109 D5 SBD7 30 39 DQ7 A7 31
AVD6 SBD8
110 D6 SBD8 29 40 DQ8 A8 32
AVD7 SBD9
D7 SBD9 26 42 DQ9 A9 20
SBD10
125 SBD10 25 43 DQ10 A10 19
EADDR1 SBD11
126 A0 SBD11 24 45 DQ11 A11
EADDR2 SBD12
127 A1 SBD12 23 46 DQ12 34
EADDR3 SBD13
A2 SBD13 22 48 DQ13 CKE 35
SBD14
SBD14 21 49 DQ14 CLK 18
SBD15
SBD15 DQ15 CS 17
RAS 16
132 19 33 CAS 15
CS_005N CS NC NC WE
3 121 18 37 14 3
137 AS NC 17 NC LDQM 36
INTN2 INTR NC UDQM
133 16 3.3V
R/WN READ NC
134 15 26 1 C316
DSACK0N WAIT NC VSS VDD
14 50 25 NC(5pF)
79 NC 13 VSS VDD
AREQN AREQ NC
80 10 4 7
AVALID AVALID NC VSSQ VDDQ
R302 150 124 10 13
ERRORN ERROR VSSQ VDDQ
82 9 41 38
27MHz SCLKI NC VSSQ VDDQ
114 8 47 44
111 SERI NC 7 VSSQ VDDQ
VREQN VREQ NC
135 6
VVALID VVALID NC KM416S1020BT-G/F10
5
102 NC 4 50p TSOP(II)
D_RSTN RESET NC
87 3
RA303 SYSCLK NC 158
100(RA) NC CB314
4 5 42
005_ACLK ACLK 0.1uF
3 6 41 157
PCMDATA ASDATA NC
2 7 2 156
LRCLK BCLK NC
1 8 1 155
BICK LRCLK NC CB315
L301 0.1uF
68 151
3.3v 10uH AVDD NC
69 150
R303 70 LP2 NC 149
18 AGND NC 148
CB302 R304 NC
C303 147
200 NC
0.1uF 146
CE301 + 20pF NC 145
2 NC 2
C301 142
10uF/25V NC
1nF 141
C304 3.3V NC 140
1nF NC 139
11 NC 138
R305 CLOSE TO CHIP 20 VDD NC
18 VDD
27 84 XDA0
40 VDD SBA0 83 XDA1
46 VDD SBA1 78 XDA2
62 VDD SBA2 77 XDA3
72 VDD SBA3 76 XDA4
86 VDD SBA4 75 XDA5
112 VDD SBA5 74 XDA6
129 VDD SBA6 73 XDA7
143 VDD SBA7 71 XDA8
152 VDD SBA8
160 VDD 67
VDD NC 66
NC 65
12 NC 64
28 GND NC
CB305 CB306 CB307 CB308 CB309 CB310 CB311 CB312 CB313 39 GND
0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 0.1uF 47 GND 130
51 GND TESTCLK
63 GND
85 GND 81 3.3V
98 GND NC 100
99 GND NC 119
1 101 GND NC 128 R306 1
GND NC 701 HWA-YOUNG BLD.
113 4.7K 112-2 KARAK-DONG, SONG-PA-GU
115 GND
117 GND 116 SEOUL, 138-160, KOREA
122 GND RSVD 120
136 GND RSVD 154
144 GND RSVD INTEGRA TELECOM
153 GND Title
GND L64005 BLOCK

Size Document Number Rev

Custom IT612 1.1
L64005 160p PQFP
Date: Friday, November 09, 2001 Sheet 2 of 11
A B C D E
 A B C D E

3.3V
L401 C409
10uH 22pF
L402
1.8uH(TDK:NL252018T-1R8J)
CVBS

U401 R404 C410 C411 R405

CB401 + 75 1% 1.3K (1%)
BT864AKPF(PQFP)

26
25
24
23
22
21
20
19
18
17
16
15
14
68pF 330pF
0.1uF

Y7
Y6

Y5
Y4
Y3
Y2
Y1
Y0
VDD
GND

RGBOUT
FIELD
ALTADDR
CB402 CB403 CB404 CE401
4
C412 4
0.1uF 0.1uF 0.1uF 47uF/25V 22pF
27 13 L403
TTXDATA TTXDAT Y/CVBS 1.8uH(TDK:NL252018T-1R8J)
28 12
YCRCB0 P0 C/R RED
29 11
YCRCB1 P1 AGND
30 10
YCRCB2 P2 CVBS/G
31 9 R406 C413 C414
YCRCB3 P3 AGND
32 8 75 1% R407
YCRCB4 P4 CVBS/B
33 7 68pF 330pF 1.3K (1%)
YCRCB5 P5 AGND CB405
34 6
YCRCB6 P6 AGND
35 5 BT864P5
YCRCB7 P7 COMP 0.1uF
36 4
37 GND VAA 3 C415
BT864P3 22pF
38 VDD VREF 2
TTXREQ BT864P2
39 TTXREQ VBIAS 1 L404
BT864P1 1.8uH(TDK:NL252018T-1R8J)
SLEEP FS_ADJUST
GREEN

HSYNC
VSYNC
RESET
BLANK
VDD3V
SLAVE

AGND
AGND
CB406 CB407 CB408

GND
VDD
SDA
SCL

CLK
R403 R408 C416 C417 R409
0.1uF 0.1uF 0.1uF 75 1% 75 1% 1.3K (1%)
68pF 330pF

40
41
42
43
44
45
46
47
48
49
50
51
52
C418
52pin PQFP 22p
L405
R401 33 1.8uH(TDK:NL252018T-1R8J)
SDA BLUE
SCL
R402 33
SYSCLK R410 C419 C420
75 1% R411
V_RSTN
3 68pF 330pF 1.3K (1%) 3
BLANKn
VSYNCn
S5V
HSYNCn
BD501
R504 4.7 10uF/25V FCM2012C-101 OPTION
RF
MODULATOR
CE502 CB502
R451 33 RF_AUDIO
+
U501 SDA
0.1uF R452 33 RF_VIDEO
1 24 10uF/25V
005_ACLK MCKO DZF SCL
2 23 T7V
CE501 CB501 TX FLT CE503 CB503 S5V
R503 5.1K BD451 JP451 U451
10uF/25V + 3 22 + Q451
DVDD AVDD FCM2012C-101 40 mA,max KA7805TU
0.1uF C501 0.1uF
4 21 1 2 90 mA,max 3 1 KTA1273(TO92)
DVSS AVSS 0.22uF(2012) 3 4 OUT IN
CB451

GND
5 20 CE451 + 5 mA,max 5 6 CB453 CB454
SYSCLK MCKI VCOM 7 8 R453
10uF/25V 0.1uF CE453 +
9 10 10K
6 19 47uF/50V 0.1uF 0.1uF
BICK BICK AOUTL L_AUDIO

2
2250-10P-DS-T
7 18
PCMDATA SDTI AOUTR R_AUDIO
T30V 2.0 mm Pitch
8 17 BD452 R454
LRCLK LRCK CAD1 FCM2012C-101 JP452
4.7K
9 16
SP_RSTN PDN CAD0 1 2
S5V CB452
10 15 CE452 + 3 4
CSN I2C 5 6 PWR_CNTL R455
Less Than 7mm 47uF/50V 0.1uF(2012)
R501 33 7 8 10K
11 14 Q452
SCL SCL/CCLK TTL 9 10
BD551 KST3904-MTF(SOT-23)
R502 33
2 12 13 FCM2012C-101 DUMMY 2
SDA SDA/CDTI TST 2250-10P-DS-T

AK4363VF(24P VSOP)
CB551
I2C ADDR : 20H CON551
0.1uF
1 : GND
1 2 : VCC
2 3 : INPUT
3 4 : CASE
4 5 : CASE
OPTION 5
DIGITAL AUDIO OUTPUT
TOTX178S
(S/PDIF)
U502
1 24
SYSCLK XTI XTO
2 23
005_ACLK SCKO PGND
3 22
VCP DGND
CB504 4 21
NC1 VDD
0.1uF
5 20 CB505
MCKO RES
0.1uF
6 19
ML_AUD ML NC2
7 18
MC_AUD MC LRCIN LRCLK
8 17
MD_AUD MD DIN PCMDATA
9 16
SP_RSTN RSTB BCKIN BICK
10 15
1 ZERO CAP 1

11 14
ROUT LOUT L_AUDIO
12 13
AGND VCC
CB506
PCM1723E(24SSOP)
0.1uF
INTEGRA TELECOM CO.LTD.,
Title
VIDEO ENCODER
R_AUDIO
Size Document Number Rev
CustomIT612 1.1

Date: Friday, November 02, 2001 Sheet 5 of 11

A B C D E
 A B C D E
S12V

FNC_OUT1 FNC_OUT2 MODE R757 S12V ADD FOR RF

R601 LOW LOW -> 4 : 3 OUT
68K 22K
S12V LOW HIGH -> 16 : 9 OUT R763 R768
BD701 HIGH X -> S/B(NO_OUT)
CE601 2K(2012) 2K(2012)
CB719 CB718
10uF/25V R602 R603 C601
R765 R756

KST3904-MTF(SOT-23)
R_AUDIO 33K 47K 47pF R701 NC(0)

+
CB701 0.1uF 47 22K 0.1uF
1.5K (2012) + VOL_OUT_R
R702 NC(0)
0.1uF VOL_OUT_L R766
R604 C602 CE701 10K Q716
CE702 Q718
NC(33K) 390pF 10uF/25V 10uF/25V R705 VOL_OUT_R

16
U701 R764
U601A 220 FNC_OUT1

8
12 14 KST3904-MTF(SOT-23) 1K
KA358D(SOP) X0 X

VDD
S12V 3 13

+
+
1 X1 15
4 4
2 2 Y CE703
- Y0 10uF/25V R706 R767
1 4 S12V 220 10K
Y1 Z FNC_OUT2
R606 Q717 Q715

CD74HC4053M(SOP)
R605 1K 5 BD702 KST3904-MTF(SOT-23)

+
Z0 VOL_OUT_L
10K 3 FCM2012C-101 C702 C703 KST3904-MTF(SOT-23)
Z1
R707 10K CON701A
6 1nF 1nF R758 R759
CE602 + 11 INH
A 22K 22K
CB603 10 CB704 1 2

VSS

VEE
10uF/25V R708 10K B AOUTR AINR
0.1uF 9 + 0.1uF R761
R607 C Q701 3 4 R760
U601B MMBT2222A(SOT-23) AOUTL RTN5 1K

8
10K + KA358D(SOP) 1K RF_AUDIO

7
CB604 5 CE704 R709 5 6
+
7 RTN1 AINL
0.1uF 100uF/25V

+
62(2012)
6 7 8
CE603
-
S12V Q702 BLUE MODE R762 CE724
10uF/16V
10uF/25V Q703 R711 9 10 1K
R608 RTN2 RESERVED
4
62(2012)
1K 11 12
Q705 GREEN RESERVED
CE604 C605 R713 Q704 BD703 13 14
10uF/25V R609 R610 47pF R715 RTN3 RTN6
10K R714 3.3K (2012) 62(2012)
L_AUDIO 33K 47K
+

10K 15 16
HW_MUTE RED BLANK
H : OUTPUT ON MMBT2222A(SOT-23) 17 18
R612 RTN4 RTN7 HEADER 4P(S-VHS JACK)
R611 L : OUTPUT OFF R710 MMBT2222A(SOT-23)
68K TV/VCR CON703
NC(33K) R717 R712 1k 19 20
C606 H : TV OUT + VOUT VIN
KST3904-MTF(SOT-23) 1K 1k S_VID_Y 1
390pF L : VCR OUT KST3904-MTF(SOT-23) 21
SHIELD S_VID_C 2
CB705 3
HW_MUTE 4
3 TV/VCR 0.1uF R718 ILSSAN:DUAL SCART 2203-42T 3
CE708 MMBT2222A(SOT-23) 62(2012) C715 C716
10uF/25V S12V
Q706 22pF 22pF
S_VID_Y
OPTION
S_VID_C
R772 R773 R774 R719
S-VIDEO
R716 Q720 R753 OUTPUT
22K 22K 22K NC(0) MMBT2222A(SOT-23) 62(2012) PHONO RCA JACK-4PACK

16
CE730 U702

MMBT2222A(SOT-23)
10uF/16V CON702 4.7K
+

12 14 Q714
BLUE
13 X0 X CE711

VDD
Q721 R721 6
CE731 X1 10uF/25V Video KTA1273(TO92)
15 220
10uF/16V Y VOL_OUT_R
+

2 2
GREEN Y0 Audio R
1 4

+
CE732 Y1 Z 3 R754
10uF/16V Audio L

CD74HC4053M(SOP)
+

5 4.7K

+
RED Z0 VOL_OUT_L R722
3 220 5 1
CE733 Z1 R770 R720 CE712 R780
10uF/16V 10uF/25V 0 Q713
+

6 S12V R771 1k 1k
CVBS INH KST3904-MTF(SOT-23)
11 1K R752
10 A

VSS

VEE
B 4.7K
R775 R776 R777 9 C706 C707 C708 R755
C
11K 11K 11K CE713 10pF 1nF 1nF 10K
R782 R783 R724 R725
10uF/16V

7
NC(0) NC(0) 22K 22K

+
ADD FOR RF R723 RF_VIDEO 12V_ON/OFF
1K
3.3V S5V
CE714 10uF/16V R781
4.7K

+
R726 220
Q710

+
R727 KST3904-MTF(SOT-23)
2 220 R743 R744 2
R728 R729 CE715 C709 C710 CB715
10uF/16V 4.7K 4.7K
22K 22K 3.3V
1nF 1nF 0.1uF
Q719
FNC_IN1 R769
CE716 R742 FBK_OUT 100 KST3904-MTF(SOT-23)
10uF/16V R730 220 10K FNC_IN2
Q708
S12V KST3904-MTF(SOT-23) H : TV_RGB R749
+

R731 220 CON701B

BD704 L : TV_CVBS 4.7K
FCM2012C-101 R745
+

CE717 22 23 CB717
10uF/16V AOUTR AINR 3K TV_FBK_OUT
C712 C713
1nF 1nF 24 25 0.1uF 3 2
CE718 + R732 R733 R734 AOUTL RTN5
Q711
CB711 26 27
MMBT2222A(SOT-23)

10uF/16V 22K 22K 22K CE719 RTN1 AINL R746 R748 KN3906S(SOT-23)
0.1uF 10K S12V
10uF/16V CE720 4.7K
28 29 Q709

1
10uF/16V BLUE MODE
R778 KST3904-MTF(SOT-23)
22K 30 31 CB716 R750
+

RTN2 RESERVED R747 4.7K

+

32 33 1K 0.1uF
+
GREEN RESERVED
R735 R736 R737 CE721 34 35
10uF/16V RTN3 RTN6
6.8K 6.8K 6.8K R751
Q707 36 37 10K
RED BLANK Q712
38 39 KST3904-MTF(SOT-23)
RTN4 RTN7
FBK_VCR
R779 40 41
R739 VOUT VIN FNC_IN1 FNC_IN2 MODE H : TV_FBK
8.2K R738 62(2012)
22K 42 LOW LOW -> 4 : 3 IN L : VCR_FBK
R740 C714 SHIELD LOW HIGH -> 16 : 9 IN
1 HIGH X -> NO_IN 1
1K 10pF
ILSSAN:DUAL SCART 2203-42T

R741
CE723
8.2K 10uF/16V
+

Title
{Title}

Size Document Number Rev

Custom{Doc} {RevCode}

Date: Friday, November 02, 2001 Sheet 0 of 4

A B C D E
 A B C D E

4 4

U11

40 mA,max 1
2 BSTB+
3 AUDIOIN
90 mA,max 4 SDA
5 MODB+
6 SCL
5 mA,max 7 VIDEOIN
VT+
3 3
8
GND

JP11 RMUP74055WT (samsung)

1 2 HSM-3052MPY(hansea)
3 4
5 6
7 8
9 10
2250-10S-DS-T
2.0mm
PITCH
2 2
JP12

1 2
3 4
5 6
7 8
9 10
2250-10S-DS-T DUMMY

1 1

Title
RF MODULATOR SUB PCB

Size Document Number Rev

A ITF
1.0
Date: Friday, September 21, 2001 Sheet 0 of 8
A B C D E
PROGRAM DOWNLOAD

Firmware Download
You can download firmware to receiver.
- Press "BROWE" button to select firmware(ELF) to downloading.
- After selecting firmware, you can start downloading by pressing "START" button.
- You can see progressing bar while downloading.
- The receiver will automatically restart when downloading is finished.

Channel Information upload

You can save channel information of receiver to PC file by using this function
- You have to select a file to save in PC by pressing "BROWSE" button.
- Press "START" button to start uploading.

Channel Information download

You can download channel information saved above to receiver.
- You have to select a file to download to receiver by pressing "BROWSE" button.
- Press " START" button to start downloading.
 SYSTEM UPGRADE

If there is a new version of software available for your receiver, you are able to download
it automatically via the satellite signal of ASTRA19.2 East.

1. Please wait while your receiver is checking if your software version is the newest one available.

2. If you already have the newest version nothing will happen, and you can leave the menu.
When you need the newest version software, the receiver will automatically download that
version from the satellite signal. After the download is finished, your screen will turn green
for a few seconds while the receiver is re-bootiong.
When the screen is back is to normal, you can leave the menu.

Tips
Do not turn off your receiver while you are downloading new software.
Be sure that your receiver is connected to the satellite signal of ASTRA19.2 East.