as 2872
UDC 669,3:
British Standards
Institution.
No part (If this publication
may be photocopied
or otherwise
621.73:
: 1989
620.1 : 001.4
reproduced withOut tba 1IiIf1I1is;5ionin writing
of Bsl
British Standard Snecificationtor
.
Copper and copper alloy
forging stock andforqinqs
.~
;~
,. ,-,
~
.
'
'!.
,;j
Ebauches de forgeage et pieces Iorqees en cuivre et alliages de cuivre - Specificalions
'r
Vormaterial
, ~
'~
und Schmiedestiicke
aus Kupferund
Kupferlegierungen
:t
..
c
.(/~, il .
~~I
'4W~'
British Standards Institution
..J
;'/
",
Foreword
This British Standard has been prepared under the direction
.of the Non-ferrous Metals Standards Policy Committee.
It is
the second metric revision of BS 2872, which was originally
publ ished in 1962 and subsequently
revised in 1969 and it
supersedes the 1969 edition, which is withdrawn. It is one
in a series of standards for copper and copper alloys in
various wrought forms, intended for general engi~eering
purposes, The others in the series are:
i
BS 2870
,BS 2871
~.
BS 2873
<; .--,
.
BS 2874
BS 2875
In this revision the standard
sections:
has been divided into three
Specification for rolled copper and copper
alloys: sheet, strip and foil
(a) section one specifies the general requirements
appl icable to both forging stock and forgings for the
alloys in this standard;
Specification
Tubes
(b) section two specifies those requirements
specific to forging stock;
for copper and copper alloys.
' ;
Specificationfor
copper and copper aVoysWire
',,'
Specification for copper and copper aU;oy rods
and sections (other than forging stock},',
Specification
Plate.
for copper and copper alloys.
In this revision, due regard has.been given to the work of
the International Organization for Standardization
(ISO)
and in particular to Technical Committee ISO/TC 26,
Copper and copper alloys, in respect of chemical
.
compositions,
testing requirements,
properties and
dimensional tolerances. Whenever possible and appropriate,
the requirements of this British Standard have been aligned
with those of corresponding
international
standards.
Certain alloys that are considered to be in sufficient
demand to warrant inclusion have been added. The
additions are:
C 101,
The demand for four of the alloys included in the last
edition of this standard is considered to be insufficient to
warrant their retention and they have consequently
been
withdrawn. The alloys withdrawn are CA 103, CA 106,
NS 101 and CS 101.
electrolytic, tough pitch high conductivity
copper
Cl02
fire refined, tough pitch high conductivity
copper
'~:
106
phosphorus de.oxidized, non-arsenical copper
,-.elll
copper-sulphur
C 112
copper-cobalt-beryllium
C 113 copper-nickel-phosphorus
CC 101 copper-chromium
CC 102 copper-chromium-zirconium
CA107 copper-aluminium-silicon
CN ,102 90/10 copper-nickel-iron
CN ;07 70/30 copper-nickel-iron
CZ 135 high tensile brass with silicon
CZ 136 manganese brass.
The alloy previously known as CZ 123 in BS 2872 has been
redesignated CZ 137 to avoid confusion with the similar
but purer alloy CZ 123 which is included in BS 2870 and
BS 2875.
which are
_ (c) section three specifies those requirements which are
specific to forgings.
In this revision, and for the purposes of this standard only,
each of the alloys has been placed in one of two alloy
groups, designated A and B according to their difficulty of
fabrication. This ailov grouping is shown in table 5 and use
has been made of the alloy groups in specifying the
dimens-ional tolerances forforging
rod in table 6. Prior to
this revision the dimensional tolerances for forging rod had
not been specified. but were subject to aqreernentbetween
the manufacturer
and the purchaser. The dimensional
tolerances specified in table 6 for groups A and B 'are
identical with the 'normal' tolerances specified in BS 2874
for groups I and II alloys and for group III alloys
respectively.
All mechanical properties
where appropriate.
have been reviewed and revised
The former appendix C is now considered redundant and
has been omitted from this revision. The forgeability test,
which was a requirement of the previous edition. has been
made an optional test in this editico,
In previous editions of this standard, clauses have been
included entitled 'Inspection'
and 'Facilities for testing'.
As these clauses are contractual and not relevant to the
standard for the product. they have been omitted from
this revision.
Technical Committee TC133, Copper and copper alloy
products, of the European Committee for Standardization
(CENj is about to embark on a programme of work to
develop European Standards (ENs) for copper and copper
alloy products. In due course, TC133 should produce an
fN for forging stock and forgings. When this EN is
approved by the CEN member bodies it will be fully
implemented as a British Standard, either by amending or
by revising this standard.
Compliance with a British Standard does not of itself
confer immunity from legal obligations.
,
/
..
BS 2872 :'1989
Contents
Page
Foreword
Committees
Page
responsible
Inside front cover
Back cover
Specification
Section one. Forging stock and forgings
1 Scope
2 Definitions
3 General requirements
4 Chemical composition
2
2
2
2
Section two. Forging stock
5 Material condition
6 Tensile prO;:Jerties
7 Resistance to dezincification
(applicable to alloy CZ 132 only)
8 Tolerances on dimensions
9 Selection of test samples
10 Preparation of test samples
11 Retests fOrforging stock
~.
3
3
3
3
3
3
4
Section three. Forgings
12
13
14
15
Material condition
Tensile properties
Residual stress
Resistance to dezincification
(applicable to forgings in CZ 132 only)
16 Tolerances on dimensions
17 Selection and preparation of test samples
18 Retests for forgings
Appendices
A Information
,.-.
-""',
to be supplied by the purchaser
Designations, nominal compositions and
product forms specified for alloys in the
BS 2870 to as 2875 series
5
'5
5
5
5
5
6
13
14
C Conversion of stress' units
D The rounding of numbers rule
E Methods for the determination of tensile
properties
F Method of test to establish dezincification
17
17
18
resistance of material designated CZ 132
Method for the detection of residual stress by
.the mercurous nitrate test
H Quality tolerances for forgings
18
Tables
1 Chemical composition
of coppers
and tensile properties
20
20
2 Chemical composition and tensile properties
of alloyed COppers
3 Chemical composition
of brasses
4 C~emical composition and'tensile properties
of aluminium bronzes and copper-nickel alloys
5 Alloy groups for tolerances on forging stock
6 Dimensional tolerances for round forging stock
7 Nominal batch sizes (masses) for sampling
forging stock
8 Nominal batch sizes (masses) for sampling
forgings
9 Designations, nominal compositions and
product forms specified for alloys in the
BS 2870 to BS 2875 series
10 Conversion of stress in N/mm2 to kgf/mm2
tonf/in2 and Ibf/in2
11 Quantity tolerances for forgings
Figure
1 Illustration
and tensife properties
of dezincification
resistance test
9
11
12
12
12
12
14
r
17
20
19
I
ElS 2872 : 1989
Specification.
Section one
Section one. 'Forging stock and forgings
1 Scope'
the products
manufacture.
This. British Standard specifies requirements for the
chemical composition,
tensile properties and other
charccterlstics for wrought or cast copper and copper alloy
forging stock, having a diameter or'width across flats
greater than 6 mm, and for forgings of these materials.
It applies to forging stock and forgings supplied in the
grades of copper and copper alloys listed in tables 1 to 4
ano the material conditions given in clause 5 for forging
stock and in clause 12 for forgings.
Details of information
r~n
in appendix A.
to be supplied
by' the purcha~~r are
.
1\ __ ~ 1. Table 9 in appendix B indicates the alloys included in the
whole series of copper and copper alloy' standards. BS'2870 to
as -2875. This gives nominal compositions.
product forms specified
and related ISO designations.
NOTE 2. For the convenience of users of this standard table 10 in
appendix C gives conversion factors for stress values in '51 and
imperial units. Throughout this standard. values for the tensile
strength and proof stress requirements are stated in newtons per
squaremlllirnetre
(N/mm2),
this unit now being in common use in
the industry.
NC-r;E 3. The titles of the publications
are I.ist;d on the inside back cover.
referred
to in this standard
2 Definitions
For the purposes of this British Standard
definitions apply.
the following
2.1 forging stock. Extruded, rolled, drawn or cast material
intended for the production of forgings, usually in the form
of rod or sections.
2:~pd.
A solid product of round, square, rectangular or
ret_.ar polygonal cross section, uniform throughout its
length, usually supplied in straight lengths, and which if
rectangular in cross section has a thickness that exceeds
one-tenth of the width.
2.3 forginglsl. A shape produced by hammering or
pressing, usually when hot, between open or closed dies,
including ha-nmerinq between flat surfaces. The term
'forging' includes the processes of forging, drop forging,
hot stamping, and hot pressing; the term 'forgings' includes
resulting
from any of these processes of
2.4 wrought. A material is considered to be wrought when
it has been subjected to sufficient mechanical and thermal
treatment to eradicate or change substantially the original
structure, usually cast.
2.5 cast. Cast material is material which has solidified
from the liquid state in a mould, and which has not
subssquent'v
been worked to eradicate or change
substantially the cast structure.
.
3 General requirements
Forging stock shall comply with the general requirements
specified in clause 4 and with the specific requirements for
forging stock specified in clauses 5 to 8.
NOTE. A forgeabilitY test on the forging stock supplied
requested by the purchaser (see item (d) of A.2L
may be
Forgings shall comply with the general requirements
specified in clause 4 and with the specific requirements
forgings specified in clauses 12 to 16.
for
Where tests are carried out to verify that the forging stock
or forgings comply with the requirements for chemical
composition
(see clause 4), tensile properties (see clauses 6
and 13), or resistance to dezincification
(see clauses 7
and 15), the sampling and test methods shall be in
accordance with clauses 9, 10 and11 for forging stock and
with clauses 17 and 18 for forgings.
The results obtained from chemical analysis and tensile
tests shall be rounded to the last place of figures specified
as limits, by the application of the rounding rule in
.accordance with BS 1957 (see appendix D).
When mercurous nitrate testing for the residual stress in
forgings is called for, the sampling shall be in accordance
with 17.4.
4 Chemical composition
The chemical composition
of the forging stock and forging!'
shall be as given for the appropriate
material in tables 1 to to.
e- "
,....
(I
u u u u
'II
(J
~".,
~ .
I}
' ' II ,'"
()
'"
l.
BS 2872 : 198t
Section two
Section two. Forging stock
5 Material condition
9 Selection of test samples
Wrought forging stock shall be supplied in the condition
resulting from one of the following final production
processes:
9.1 General
When tests are required to be carried out to verify that a
batch of forging stock complies with this standard (see
items (a) and (c) of A.2), samples for chemical analysis and
tensile tests shall be taken in accordance with 9.2.,
(a) hot workinq:
(b) cold working;
(c) annealing.
NOTE.
whether
At the request of the, purchaser, the supplier
should
j.he forging stock supplied
is wrought
or cast.
NOTE 1. If the supplier of the forging stock is also the producer
of
the forgings, the requirements
of this clause may be dispensed
with
and those in clause 17 taken to apply.
state
NOTE 2. No sampling requirements for forging stock are specifip,1 in
this standard
for the dezincification
resistance
test (alloy CZ132
only). When the purchaser requires this test to be carried out, the
sampling requirements
shciuld,be
agreed between
the supplier and
the purchaser
at the time of the enquiry and order (see item (c) of
A.2).
" .. ,
6 Tensile properties
'The tensile properties of forging stock in the size range
6 mm to 80 mm shall be as qiven in tables 1 to 4 when
tested in accordance with appendix E.
NOTE 1. The tensile property
'outside this size range Should
and the supplier.
9.2, Samples for analysis and tensile testing
'Forsampling, the forging stock shall be grouped into the
batch sizes (masses) given in table 7.
For each test, i.e. analysis and tensile, one sample shall be
taken at random from each batch and from any remaining
part of a batch.
requirements
for forging stock
be agreed between the purchaser
.
NOTE 2, Attention
is drawn to ths options available
to the
, supplier of the forging stock conceminq
the preparation
of the
tensile test sar-vples given in 10.1.
=:
.
10 Preparation of test samples
7 Resistance to dezim:ification (applicable
to alloy CZ 132 only)
.
10.1 Tensile test samples
"
When a sample of forging stock in alloy CZ 132, prepared
in accordance with 10.2, is subjected to the dezincification
resistance test carried out in accordance with appendix F, '
the maximum depth of penetration shall be as follows.
(a) For wrought forging stock:
parallel to the direction of extrusion, rolling or
drawing:
,
200 11m
perpendicular to the direction of extrusion,
rolling or drawing:
100 urn
(b) For cast forging stock:
in any direction:
100 urn
NOTE, If a sample representative
of the batch passes this test,
it indicates
that forgings produced
from the batch of forging stock
and correctly
heat treated will puss the dezincification
test
requirement
for forgings. The forging manufacturer
should,
however.
still verify this by testing the forgings (see' clause 15),
10.1.2 Materials C 772, C 173, CC 101 and CC 102. Test
samples in alloys C 112, C 113, CC 101 and CC 102,
selected in accordance with 9.2 shall, at the option of the
supplier, be prepared in accordance with (a) or (b) as
follows:
(al. directly from wrought forging stock produced by
hot working; or
NOTE 1, Each alloy in this standard
has been allotted
to oneof
two groups. designnted
A and B. for tolerancing
purposes.
A list
of the alloys and groupings,
which are specific"to
this standard,
is given in table 5,
The diameter of round forging stock shali.be within the
tolerances given in table 6 for the appropriate alloy group
and size.
(b) from wrought or cast forging stock subsequently hot
forged either to approximately 65 % of the original
cross-sectional area, or upset fornC'o by at Ipn~.1'iO ";, III
it!: orilllllill lo,,!,tl r.
NOTE 2, The dirncnsinnat
tolerances to be nJ'lpl;ed to round forging
stock oo tstoc the range of .si/j~~given in table 6. nnd to forgin9 stock
of other shapes, !'hould hl~;-)orflPrllwtwl'l!n till' nllfch;1';t'r ill1d Ihl'
1,li"1
'.I1/1
3
-
_..
7,:--
---=-=:-,_ --_."
--.-----
...-.~~ ....,.,,. .
(b) from wrought forging stock subsequently annealed
at a temperature of not less than 500C for not less
than 30 min; or
(c) from wrought, or cast, forging stock subsequently
hot forged either to approximately 65 % of the original
cross-sectional area, or upset forged by at least 50 % of
its original length.
NOTE. The method
of preparation
of the test sample. i.e. whether
in accordance with (a), (b) or (c) of 10.1.1. should be stated,
together
with the tensile test results obtained.
on any Cer-ti f ica teo r
Conformity
supplied
with the forging stock (see (a) of A.2 and (b)
ofA.31.
8 Tolerances on dimensions
------.
10.1.1 Materials other than C 112, C 113, CC 101, CC 102
and cz 132. Test samples in alloys other than C 112, C 113,
CC 101, CC 102 and CZ 132, selected in accordance
with 9'.2, shall, at the option of the supplier, be prepared in
accordance with (a), (b) or (e) as follows:
(8) directly from wrought forging stock produced by
hot working; or
.-".:.
as 2$72 : 1989
Section two
Samples prepared as in (a) or (b) above shall then be
solu~i?n treated and precipitation
hardened in conditions
specified by the supplier before testing.
~OTE.
The method of preparation of the test sample, i.e. whether
with (a) or (b) of 10.1.2, should be stated, together
\l\(1}hthe tensile test results obtained, on any Certificate ct.
Conformity supplied with the for9il)9 stock (see (a) of A.i ifnd (b)
ofA.3).
'.
I
In accordanc,:
10.1.3 Al!aterialCZ 132. Test samples in alloy CZ 1'32,
selected In accordance with 9.2, shall be heat treated in
the temperature
range 450C to 550 c before testfng.
10.2
Dezincification
resistance
test samples
Test samples of forging stock in alloy CZ 132 shall b~\heat
t~ed
in the temperature
range 450 c to 550 c b'efore
t
19.
.
.
....,.s ,
~.<",.-
:.
11 Retests for forging stock
1".1
Should both of the further samples pass the retest. the
batc.h represented shall be deemed to comply with that
particular requirement of this standard. Should either of
the further samples fail the test, the batch represented
shall be deemed not to comply with this standard.
11.2
. ~.
"<
shall. be permitted to be selected fo'r retesting that
particular property. One of these further samples shall be
taken from the same length of forging stock as that from
which the original failed test sample was taken, unless that
length had been withdrawn by the supplier.
Analysis and tensile properties
Should any of the test pieces fail the test for analysis :or
tensile properties two further samples
from the same batch
.
.-
Dezincification
resistance
test (alloy CZ 132 only)
Should any of the test pieces fail the dezincification
resistance test, further samples from the same batch shall
be permitted to be taken for retests. The number of
samples taken for the retests shall be twice the number
first selected (see note 2 to 9.1).
Should all of the further samples pass the test, the batch
represented shall be deemed to comply with the
dezincification
resistance requirements of this standard.
Should anyone of the further samples fail the test, the
batch represented shall be deemed not to comply with
this standard.
'-'
...--.,
(
,
.-/
~. " .""'_"11'" ";"i"~.;.:._~i.!.:"'!";~_!.
u u LJ
..J
I.
Ij
(.c) ('J
!) C')(
J.
()
(J i;J '
BS 2872 : 1989
Section
three
Section three. Forgings
12 Material condition
12.1 All materials
C 112, C 113, CC 101, CC 102
except
and CZ 132
Forgings produced
in all materia!s except C 112, C 113,
CC 101, CC 102 and CZ 132 shall be supplied in the M
condition
('as manufactured')'
12.2 Materials
unless
oth~rwise
specified.
C 112, C 113, CG 101 ang CC 102
by the purchaser
(see item
(d)
---.
Ii
-.'.
~ ':..
direction
operatlons
in the forging.
16 Tolerances on dimensions
The forgings shall be made to the dimensions
specified on"
the order or drawing and subject to the dimensional
tolerances
agreed between the purchaser
and the supplier.
These temperature maxima are given for information only; they are
based on the lowest temperature that, if maintained for 2 h, would
give a reduction in hardness equivalent to 20 % of the difference
barwsan the hardest condition, as received, and the softest possible
condition of the alloy.
17 Selection and preparation of test
samples
CZ 132
Forgings produced
in alloy CZ 132 shall be heat treated in
the range 450 DC to 550C
as the final thermal operation
after forging. CZ 132 forgings which have undergone
this
heat treatment
are described
as being in the M condition
('as manufactured').
17.1
General
When tests are required to be carried out to verify that a
batch of forgings complies with this standard
(see items (a),
(b) and (c) of A.2l, samples for analysis, tensile,
dezincification
resistance
and mercurous
nitrate tests shall
be taken in accordance
with 17.2, 17.3 and 17.4.
NOTE. Heating the CZ 132 M condition forgings above 5250 C
should be avoided in any subsequent operation. including final
assembly of finished components.
NOTE. No sampling requirements for forgings are specified in this
standard for testing for analysis, dezinciflcation resistance or
residual stress. When the purchaser requires these tests to be
carried out on forgings. the sampling requirements including
provision for retests, should be agreed between the supplier and the'
purchaser at the time of the enquiry and order (see item (c) of A.2L.
13 Tensile properties
When tested in accordance
properties
of the forgings
fabrication
When forgings in alloy CZ 132 selected and prepared
in
accordance
with 17.3 are subjected
to the dezincification
resistance
test carried out in accordance
with appendix
F,
the maximum
depth of penetration
shall be 100 urn in any
NOTE 3. During subsequent processing operations. including final
assembly of finished components, the purchaser should avoid
heating the forgings above the following ternperature s:
C 112
copper-cobalt-beryllium
. 500 DC
C 113
cooper-ntckel-phospho-us
475 C
CC 101
copper-chromium
.::. 500 DC
CC 102
cr-pper-chromlum-zirconiurn
525 "c
Material
by the purchaser
(see item (b)
(b] shall be supplied.
15 Resistance to dezincification
(applicable to forgings In CZ 132 only)
table 2 are
NOTE 2. For some types of forging, the manufacturer. may. at his
discretion, carry out a cold working operation efther between
. solution treatment and precipitation or, excepticnallv. after
precipitation, to give enhanced mechanical properties.
12.3
or tested as in (a).
processed
NOTE. Care should be taken that subsequent
of A.1).
spep.ifiedJn
(b) Not specially
carried out in producing components.
or assemblies. from forgings
that have passed this test do not introduce
levels of internal str ess
which could cause failure.
NOT: 1. Material in the solution treated and P'1'CtlJitation hardened
condition is designated 'TF'. The properties
for material in this TF condition.
in appendix
G. When
tested in accordance
with
no evidence of cracking.
with the unaided eye,
if necessary.
If no option is expressed
of A.2), forgings of type
Forgings produced
in alloys C 1 '12, C 113: CC 101 or
.CC 102 shall be solution treated and precipi~ation
hardened
at an elevated temperature
as the final th~,!,mal 'operations
after forging unless un-heat treated forgiri9,s are specifically
requested
mercurous
nitrate test given
samples of such forgings are
appendix
G they shall show
upon Immediate examination
corrected
for normal vision
with appendix
E, the tensile
shall comply with tables 1 to 4.
17.2
NOTE. In oracrice the tensile test is normally carried out on the
lorying stock from which the forgings ar o nwnlJfact-:7,,:d but. at the
OPtion of the supplier. may occasionally be carried out on the
forgings themselves (see 17.21. If a purchaser !pecifically' raquir es
Samples
When analysis
either
for analysis
and tensile
tests are required
on a sample
they
strength
shall be carried
of the actual. forgings
(see note
out
to 17.1)
or on samples of the forging stock from which the forgings
have been manufactured.
In thelatter
case, the samples
shall be selected in accordance
with 9.2.
,,' " .
th~ test to be carried
out on the forgings then the oe tnils of the test
and the rate of sampling should be subject to agreement between
the purchaser and the supplier.
When tensile tests are required. they shall be carried out
either on samples of the forging stock from which the
forgings have been manufactured,
or; at the option of the
supplier, on the actual finished forgings, if these are of
sufficient
size. In the former case, the samples shall be
selected from the forging stock in accordance
with 9.2.
14 Residual stress
Batches of forgings
as follows.
ta) Specially
.stress
shall be supplied
processed
level which
as either
to achieve
is sufficiently
a residual
(a) or (b),
In the latter case the samples shall be selected from the
finished forgings at a rate of one sample forging per batch,
the size of the batch being in accordance
with table 8.
(internal)
low to pass the
8S 2872 : 1989
Section
three
".
Samples for tensile tests from forging stock in materials
other than C 112, C 113, CC 101, CC 102 and CZ 132 shall
be prepared in accordance with 10.1.1, before .testing.
Samples for tensile tests from forging stock in materials'
C 1.12, C 113, CC 101 or CC 102 shall be prepared-in
accordance with 10.1.2 and from forging stock in 'tnalerial
CZ 132, in accordance wit.h 10..1.3. The samples sh<a:!1then
be heat treated in the same furnace at the same time-as the
forgings they represent, before testing.
J7.3 Samples for dezincification
(for forgings in CZ 132)
resistance
test
r.
S,,"'-"'Ies for dezincificatlon
resistance testinq-shall be cut
tr; . finished, heat treated forgiflgs (see 'note to 17~1)..,:.
The samples should not be further treated before te~Jing.
17.4 Samples for mercurous
nitrate test (for residu~1 stress)
The. mercurous nitrate test for residual stress shall be
carried out on whole finished forging(s) taken from the
batch represented (see note to 17.1). The selected samples,
which constitute the test specimens, shall not be further
prepared before testing ~nd shall not be marked for
dentif ication by indenting.
"'
... ,, ..
18 Retests for forgings
Should any of the test pieces prepared from the above
samples fail any particular test, further samples from the
same batch shall be selected for testing. The number of
samples taken for retests shall be twice .the number first
seiected. One of these further samples shall be from the
same length of forging stock or from the same forging as
that from which the original failed sample was taken, unless
in the former case that length has been withdrawn.
Should all the further samples pass the test; the batch
represented shall be deemed to comply with the requirements of this standard for that test. Should anyone of the:.
further-samples fail, then the batch represented shall be
deemed not to comply with 'this standard.
NOTE. If a batch of forgings:
(a) in C 112. C 113. CC 101, CC 102 or CZ 132 fails the tensile
test;
(b) in CZ 132 fails the dezincification resistance test; or
(c) if any rn.rter iat fails the mercurous nitrate test,
the supplier has the option to heat treat further the whole batch
and to resubmit the batch for all the tests called for on the order.
"
.V
">
'-
-;,..
.y
,-
\.....
>---
..
Tobie 1. Chemical composition
r-
and tensile properties of coppers
'--
Chemical composition
as
Cu
designation
Sn
Tensile properties for forging
stock and forgings
Pb
Fe
Ni
As
Sb
Se
Te
Bi
Material
Total
impurities
Tensile
strength
. O.Z% proof
stress
I
C 101
EIectroly tic
toug h pitch
high conductivity
copper
C 102
C 106
-...J
Fi re refined
tough pitch
hig~ condctivity
copper
Phosphorus
deoxidized
nonarsenical
copper
99.90 min.
0.005
0.0010
(including
::'.... ,
.\
-. ~.
~! ,~.
0,005 -
..-
0.01l25
[including
silver)
(including
silver!
0.03
o and
.;
99.85 min.
/0
min.
min.
min.
N/mm'
N/mm'
150 .
20
, (excluding
~jlver.)
99.91l mine',
,.
Ag)
\
'
0.04'~i, : t ,
. (exciudiRg ,
and Ag)
0,01
0.010 0.030 0.10
(j.05
0.01
0.0130.050
O.OlG
0.0030
Se + Te
0.020
NOTE, For essential alloying elements, limits are in bold type. Unless otherwise stated, figures in the total impurities
Unless otherwise inc.cated all single limits are maxima.
0.06
"'
,\.
.'\
.."
150;,
; .. ':'
'~
..'
{.
:or'
'."
j~},
' ..;
,r
r :
C~
I
r--"
.-..
'-
CuETP
1'.
. r:
'-,,;
C'
Elongation
on5.6SJSo
Nearest
ISO
designation
C'
,
r: .
,~
'r-J
,J
' 20
CuFRHC
CJ
150
20
'.
~,,'"
CuDHP
"-.
(excluding
Ag, As, Ni
and P)
...
C-4111
C..
column include those that are not in bold type.
C~ ....
-;
C'4
.
cA
{
C..
.
C,-
CJ)co
C1l CJ)
o
::>.
:J
I\)
CD
"
.-+1\)
. ::;
.., .
(\)
CD
<0
00
<0
c-l
C,.a
.
~..
c..ll
c:~
~
aUI~
L.
cnerntcal cornp osition and tensile propertiesof
alloved copp ets
-.
._----.-"-:-----.. --'.
'.'
Chern ical composition
,
aS
ci esigi1atiim
Cu
Ni
Cr
Matfrial
\ Co
Be
Zr
Bi
Fe
Sb
I Si
: 111
113
Rem.
0.3
0.6
- -
Coppercobaltberyllium
Rem.
Ni +Fe
0.5
2.0
2.8
0.4
0.7
0.10
0.2
Copper-
Rem.
Copper-
nickerphosphorus
101
Copperchromium
Rem.
O.B
1.2
0.02
0.16
0.25
0.01, .0.3)
1.4
;102
' Yo
%
sulphur
:112
Sn
Cooper-
Rem.
0.02
0.01
chromium
zirconium
0.5:
1.4
specified are applicable
to material' in thesolution
0.001 0.08
0.2
0.002 0.08
- 0.2 0.008
..
O.QOl 0.08
alloying elements, limits are in bold type. Unless otherwise
indicated all single limits are maxima.
'he tensile properties
\~o;
)TE. For essential
less otherwise
stated,
0.002
0.2
0.008
figures in the total impurities
treated and precipitation
hardened
Tensile properties
and forgings
for forging stock
Tensile
strength
0.2 % proof
stress
Elongation
on 5.65"'/So
min.
min.
min.
N/mm2
N/mm2
0.2
150
20
0.05
(excluding
Fe, Ni
and Si)
620'
0.03
(excluding
.S)
380'
Total
impurities
~-
..
~~~
'360*)
0.05
(excl uding
Fe and sn
360'
-.
-.
18'
CuCo2Be
'l>
~I.~~.~~~
-
~\'f~":.
~!
.' ~1
\...1.
17'
CuCrl
17*
CuCrlZr
column include those that are not in bold type.
(TF) condition.
Cu S
.;.
0.05
{excluding
Fe,S
and sn
g'
Nearest
ISO
designation
..J
j
Table 3. Chemical composition and tensile properties of brasses
-
Chemical
BS
designat
rI
. Lead free
Z 112
Sn
60/40
brass
Naval
brass
High
tens'
..!
High tensile
brass
II
I'
I
i
CZ 116
(res tricted
atuminiurnj
High te nsile
brass
CZ 121
Pb3
Leaded
58%Cu
3 %Pb
CZ 121
Pb4
Leaded brass
58% Cu
4 %Pb
Pb
Fe
ISO
AI
"';n
As
Ni
Si
Zn
Total
impurities
brass
,..
I.:
Tensile
strenqth
0.2%
stress
min.
min.
min.
proof
Elongation
on 5.65.,}So
N/mm'
N/mm'
0.1
Rem,
0.3
(excludi
Pb~
310
25
CuZn40
15
CuZn38Snl
I
I
156.5.
58 5
,1 .
156.5
58 5
1 .
1.0
1.4
0.20.8
0.51.5
0.31.0
1.5
0.20.8
0.51.5
0.31.0
0.1
0.5-
2.~
Rem.
0.5
0.7
..
n9
340
,~
Rem.
.~.
0.5
(excluding
AI~
460.".
\
"".'"
Rem.
0.5
460
t
.
~
I
.,
.;, 18b"l. .,,!o-
:~
180
.' 15
.."'~.
CuZn39AIFeMn
15
CuZn39AI
2.0
.'
164.0.
56.558.5
56.558.5
Rem.
0.5
540
280
12
Rem.
0.7
350
25
CuZn39Pb3
Rem.
0.7
350
25
CuZn38Pb4
stated.
figures
0.25
1.2
4.05.0
0.3
2.0
2.5-
0.3
0.3
3.5
3.5-
68.0
4.5
NOTE. For essential alloying elements.
limits are in bold type.
Unless otherwise
indicated
all single limits are maxima.
Nearest
61 0
. .
63.5
brass
CZ: 115
stock
59.0
62 0
1 .
1
CZ i 14
for forging
designation
Cu
...
co
Tensile properties
and forgings
ion 1 Material
I
CZ 109
composition
Unless
otherwise
in the total
impurities
column
include
those
that
are not in bold
type.
FeMn
,--.-..L--:,
table-3
(co n clu de d)
"
Chemical
- /.
.'
,
-.--.--~
composition
Tensile properties
'a nd forgi ngs
BS
desillnat ion
CU
Sn
Pb
Fe
AI
Mn,
Material
As
Ni
Si
Zn
Total
impurities
for forging
stock
--r,::-----.-Nearest
ISO
designation
Tensile
strength
0.2% proof
stress
on 5.65.jSo
min.
min.
min.
N/mm'
N/mm'
25
CuZn40Pb2
25
CuZn38Pb2
C~,~Q39Pb1
Elongation
CZ 122
CZ 128
CZ 129
CZ 132
CZ135
I
I
56;5
-,
58.5
Leaded brass
60% Cu
2% Pb
58.5
61.0
Leaded bra ss
60% Cu
1 % Pb
58.561.0
Dezincification
resistant brass
Rem.
0.2
High'tensile
brass with
si! icon
57.060.0
0.3
1.52.5
0.3
'-
Rem.
0.7
350
1.52.5
0.2
O.B1.5
0.2
1.72.B
0.2
0.8
0.5
'%
Rem.
0.5
350
Rem.
0.5
350
25
0.08-
35.0
37.0
0.5
280
30
0.:2
0.31.3
Rem.
0.5
(excluding
550
200
15
CuZn37Mr3
A12Si
0.15
';02.0
1.5
3.5
Sn, Pb, Fe
and Nil
CZ 136
CZ 137
Leaded brass
58 %Cu
2 % Pb
Manga nese
brass
56.059.0
Leaded bra ss
60 % Cu
0.5% Pb
58.561.0
3.0
0.5
Rem.
0.7
(excluding
Pb)
350
25
Rem.
0.5
350
25
CuZn40Pb
1.5
0.3O.B
0.2
LNOTE.
For essential alloying elements, limits are in bold type,
Unless otherwise
Unless otherwise indicated all single limits are maxima.
stated, figures in the total impurities
column
include those that are not in bold tvpe,
'-
{II
i
I
II
--.- ..-- ... ---------------------~-----------------------------------,
-'J
\_
Tsb!e 4, Chemical composition
Material
07
\~.
'O%aluminium
, bronze (c oppe ralum inium-i ron-
AI
Mn
atu
Ii
90110 copper-
70/30 coppernickel-iron
L-
~0
Rem.
0.10
0,05
4.0
8,511,0
J~
1\
mmtum-siilcon
o/c0
nickel)
1 Copper-
"...
Ni
Si
Zn
Nearest
C,
designation
strength
stress
on 5.6S-!So
min.
min.
min.
--~--+--~_+-~~~--~~--~~~+I----------1-----+----~----~
'1I
CN102
'nickel-iron
Fe
11
r-
ii
Pb
i:
CA 107
Sn
ell
Tensile properties for forging stock
and forgings
Total
I,..'
-----r-----,------lISO
impur ities
Tensile
0.2 % proof
Elongation
!
eN'
,-
l'
CA 104
alloys
,III
'-
ChemIcal compositioa
BS..
designation\
1-----
and tensile properties of aluminium bronzes and copper-nickel
r-
Rem.
Rem.
Rem.
~_._
0.10
0.05"
0,0'
0,01
~
5.~
\ o/c0
0,50
4.0
0.2
0.40
-1
5,5
0,5
6,0
0.7
6.4
1.00
2.00
0,40
1,00
~_~L-
0,10
0.10
2,0-
0.50
1.00
10.0
11.0
N/mm2
N/mm2
0.5
700
350
14
'-r:
CuAI1 ONi5 Fe4
'-
,...
Mn)
0.5
520
220
20
CuAI7Si2
030t
280
100
27
CuNil0Fel
'-r:
005005
_0.08
0.06 ~0._3_0
._L_3_1_0
__
....J._l0_0
..L..2_7
Mn
r:
__'__C_U_N_i3_0_M_n_'_F_e-l
-J __
NOTE.
For essential alloying elements, limits are in bold type. Unless otherwise stated. figures in the total impurities column include those that are not in bold type.
Unless otherwise indicated all single limits are maxima .
For welding, lead should be 0.01 % rnax.
t For welding, the zinc should be 0,1-5 % maximum and the phosphorus 0,020 %'maximum
--'.
r- ~
'
0..50
3(),0
1.5() '32.0
__L-_-L
II-
0.40
2.4
o/c0
I (excluding
I
_
;.-,II
(see item (I) of A.21.
(fJ CO
co (fJ
0
,-+
:l
.-+
I\.)
OJ
-...J
I\.)
::J
....
C1l
ro
<D
CXl
CD
BS 2872 : 1989
Section three
Table
5.
tolerances
Alloy
..
Table 7. Nominal
forging stock
grOl!PS for
on forging
stock
BS designation
Alloy group
C 101
C 102
C 106
B
B
B
C 111
C 112
'C 113
Ordered nominal
dimension of
forging stock
mm
mm
kg
12
40
80
12
40
80
300
600
1200
:;
.,1'
"B
GZ
A
A
A
"
116
CZ 121 Pb3
CZ 121 Pb4
12500
batch size (mass)
'
,
'*
Table
8. Nominal
batch
sizes (masses)
for sampling
forgings
Mass of individual
Ovor
Up to and
including
kg
kg
kg
0.5
2.0
10.0
300
600
1200
2500
A
A
A
CZ 137
CA 104
CA 107
A
B
B
CN 102
CN 107
Nominal batch size (mass)
forgings in batch
CZ 132
CZ 135
CZ 136
0.5
2.0
10.0
--",-6.
for sampling
CZ 122
CZ 128
CZ 129
Table
Nominal
Up,to and
including
"
CZ 112
. """:""CZ114
\
CZ 115
:
sizes (masses)
Over
CC 101
CC 102
'CZ 109
batch
Dimensional
.cified \liameter
tolerances
for round
forging
stock
Alloy grQup
Over
Up to and
including
Group A
.Group B
mm
mm
mm
mm
6
10
18
30
50
10
18
30
50
80
0.08
0.18
0.22
0.26
O.32
O~14
0.16
0.20
0.37
-N
0.60
'
\....,
8S 2872 : 1989
Appendix
!~
Appendices
Appendix A. Information to be supplied by
the purchaser
A.l It is essential that the following information is
supplied by the purchaser in the enquiry and/or order to
assist the manufacturer in supplying the correct material:
(a) the designation of the material required (see tables
1 to 4);
(b) the nominal dimensions for forging stock and a
toleranced drawing for forgings;
(c) the quantity of material required'(see appendix H
for information on quantity tolerances for forgings);
(d) for forgings, the condition required if different
from that given in clause 12.
(d) whether a forgeability test is required on the forging
stock and if so, the procedure for the selection and
preparation of the sample, the test procedure and
temperature, and the criteria for acceptance (which
should be agreed with the supplier);
(e) whether a statement of compliance, or a certificate
of conformity of the forging stock or forgings' is required
(see A.3);
,..
(f) for alloy eN 102, whether the material is to be
welded (see footnote totabla 4).
In normal commercial practice, two levels of
certification of the quality of the product are available at
the request of the purchaser (see item (e) of A.2), as...
follows.
(a) Statement of comptience. This is usually available
.
"'I
.
from the supplier when traceability of the product is not
a requirement. The goods will have been manufactured
to comply with the conditions and requirements of the
purchaser in accordance with the supplier's quality.
control procedures. The goods supplied may not ..... ,
themselves have been tested before del ivsrv ..
A.3
i><
A.2 The purchaser should also be awar-~:of the importance
of including the following information in the enquiry and/or
order, as appropriate:
(a) whether tensile tests are to be ca~ried out
(see 9.1 and 17.1);
(b) for forgings, whether they are required to pass the
mercurous nitrate test (see clause 14);
(c) whether other tests are to be carried out (see 9,1
and 17.1), and jf the testing for the dezincification
resistance of forging stock or forgings in CZ 132, or the
testing of forgings for analysis or residual stress is
required, the batch size to be used, the method of
selection of samples and the provisions for retests, if
permitted, for these tests: .
13
(b) Certificate of conformity. This is normally supplied
with material for which the purchaser has requested
. traceabil ity to a manufacturing batch. The certificate is
issued on the basis of tests, requested by the purchaser,
having been carried out on the manufacturing batch
from which the material supplied has been taken.'
Appendix B, Designations, nominal compositions ...
Designations,
nominal
BS designation
nominal
Material
compositions
and product
forms specified for alloys in the BS 2870
Nominal
descr\ption
composition
t()
as
tough pitch high conductivity
2871
,,'
99.90 70 min. Cu
Nearest
ISO designati on
in BS
Pt 1
Electrolytic,
to
(X)
to
2875 series
Specified
2870
C 101
2870 to BS 2875 series' .
and product forms specifiec:l'for alloys in the 8S' 2870 to 8S 2875 series are given in table 9.
compositions
Table 9. Designations,
lJ product forms specified for alloysintht-JS
2873
2872
Pt 2
2874
Pt 3
.,.
Fire refined.
tough pitch high conductivity
99.90 % min. Cu
99.95 % min. Cu
J
J
,,'
"
copper
C 102
-,
,I
"I
,l
copper
C 103
Oxvqen
free. high conductlvitv
C 104
Tough
pitch
non-arsenical
C 105
Tough
pitch
arsenical
copper
99'.85 % min. Cu
copper
99.20 % min. Cu, 0.4 % As
copper
Ph osphorus
deoxid ized, non-arsenical
C 107
Phosphorus
deoxidized,
C 11)8
Copper-cadmium
Cu-0.8 %
C 109
Coppertellurium
Cu-0.5 % Te
C 111
Copper-sulphur
Cu-O.4 % S
C 112
Copper-cobalt-bervtliurn
Cu-2.4 % Co. 0.5 % Be
C 113
Copper- nickel-phosphorus
Cu-l.O
CA 102
7 % aluminium
CA 104
10 % aluminium
bronze
ICu-AIFeNil
Cu-10 % AI. 5% Fe, 5 % Ni
CA 105
10 % aluminium
bronze
ICu-AINiFeMn)
Cu-9.5 % AI, 5 % Ni,2
CA 106
7 % aluminium
CA 107
6 % aiurninium-silicon
bronze
bronze
copper
arsenical copper
99.~0 % min. Cu, 0.4 % As. 0.04 % p .
% Ni,
". ".J
bronze ICuAISi)
Cu-6 % AI, 2 %
CC 101
Cu-1 %Cr
CC 102
Copp er-chro.niurn-z
NO TE. Th e product
forms
ircoo-urn
co-t
take account
of the alloys to be included
%Cr,O.l
\,
si. 0.6
. 'i"
I
"
,0
....I'
-,
Cu-7 % AI, 2 %Fe
Copp er-chr orniurn
'e
0.2 % P
ICu-AI-Fe)
Copp er-berv lliurn
"v
Cu-7 % AI
ICu-AI)
calQ'\
indicated
ce
Cu-1.8 % Be
"-- _.
. 99.85 % min. Cu, .0,04 % P
C 106
'.,
-!
in the revisions of
BS
2871
: Part 1 : 1971, Part 2:
1972 and Part 3:
1972 which
CuOF
CuFRTP
CuDHP
CuCdl
CuTe
CuS
,,'
CuCo2 Be
J
'v
CuFRHC
J
J
J
J
V
,/
,,'
"
..../
CuETP
% Fe. I % Mn
% Fe
"
./
% Zr
2875
"
CuAI7
CuAIlONi5Fe4
CuAIlOFe3
CuAI8Fe3
CuAl7Si2
CuBe1.7
J
V
are in preparation.
CuCrl
CuCrlZr
C'~
)
~
"
')
C.
Table 9 (continued)
.BS designation
C~
, Material
description
':,'
95/5
CN 102
90/10
coppernickel.iron
80/20
75(25
coppernickel
cop'per.nickel
CN 107
I
I
Coppersilicon
90/10
85/15
brass
80/20
brass
CZ 104
Leaded,80nO
CZ 106
CZ 107
CZ 108
70/30
70/30
.
,
Naval brass
CZ 115
High tensile brass (restricted
0,04 % As,
J
J
.J
J
J
.J
aluminium)
High tensile brass
CZ118
Leaded brass, 64 % copper, 1 % lead
CZ 119
Leaded brass,,62 % copper, 2 % lead
t'!,
Zn
s, remainder
CZ 120
Leaded brass, 59 % copper, 2 % lead
CZ 12 t Pb3
Leaded brass, 58 % copper. 3 % lead
J
J
CZ 121 Pb4
Leaded brass;58
CZ 122
Leaded brass, 58 % copper, 2 % lead
~0/40 brass, low lead
% copper, 4 % lead
Leaded brass, 52 % copper, 3 % lead
Cap Copper
CZ 126
________
co. 2
co. 4
J
J
% Pb, remainder Zn
CuZn10
e,1
,.I
CuZn15
"
J
J
"-'
~,J
CuZn30As
CuZn30
CuZn35
CuZn37
CuZn40
'-
cJ
CuZn20AI2
J
J
,./
r,l
;.J
CuZn38Sn1
CuZn39AIFeMn
'-
'--
~.J
J
J
,./
.I
"
_.__
" L;.__ ~__
L___
.
~_._L.'
CuZn38Pb2
.j
J
J
CuZn39Pb3
,../
Culn38Pb4
\.uln40Pb2
pro
Culn40Pb
"OC/)
"ON
co
(;uln36Pb3
CD
Culn5
9:1'0
X
OJ
CuZn30As
"
CuZn37Pb2
,I
Zn
,.:
-.J
CuZn39AIFeMn
CuZn35Pbl
62 % Cu, 3 % Pb, remainder Zn
~~~_~s~aindel~n
r-,J
"-
'-
% Pb, remainder Zn
60 % Cu, 0.5 % Pb, remainder Zn
.__ :"0
CuSi3Mnl
CuZn20
J
J
.j
remainder Zn
co. remainder
C"'~
Fe
CuZn28Snl
58 % Cu, 2 % Pb, remainder Zn
96 %
Zn
58 % Cu, 3 % Pb, remainder Zn
58 %
64 % Cu, 1 % Pb; remainderZn
59 %
CuNi30Mnl
CuNi30Fe2Mn2
J
J
J
65 % Cu, 4,5 % AI, 1 % Mn, 1 % Fe, '
remainder' Z n
co. 2 % Pb,
s. ~
J
J
J
58%Cu,1
%Pb,l
% Mn, 0,7 % Fe,
0,5 % Sn, remainder Zn
62 %
C.
CuNil0FelMn
CU,Ni25
58 % Cu, 1 % Pb, 1 % Mn, 1 % AI,
0,7 % Fe, 0.5 %
Special 70/30arsenic~~~~~~
% As,
62 % Cu, 1,2 % Sn, remainder
CZ 116
CZ 125
6~ % Cu, remainder Zn
so. 0.04
C,J
.J
.J
71 % Cu, 1,2 %
remainder Zn
High tensile brass
,J
Zn
60 % Cu, remainder Zn
brass'
CZ 112
,/
Zn
7~ %
remainder Zn
63 % Cu, remainder Zn
n % Cu, 2 % AI,
C~
2875
.J
~,l ~ 'i:
I,
C..
.J
.J
co.
brass,
CZ 114
2874
Pt 3
remainder Zn
Admiralty
2873
Pt 2
71 % Cu, 0.04 % As, remainder
brass
Lead free 60/40 brass
CZ 124
i'
"
co. remainder 2n
80 % co. 0.5 % Pb, remainder
2/1 brass
Aluminium
CZ 123
Cu3 % Si, 1 % Mn
81) %
brass
CZ 109
CZ 111
Cu-30 % Ni, 2 % Fe, 2 % Mn
85 % Cu, remainder Zn
CZ 110
2872
V
"I
Cu-30 % Ni, 1 % Mn, 0,7 % Fe
90 % Cu, remainder Zn
arsenical brass
brass
Cornrnon
Cu25 '% N i, 0.3 % Mn
(silicon bronze)
brass
CZ 103
,I
Gu20 % Ni, 0.3 % Mn
CS 101
CZ 101
2871
Pt 1
. -.~. -
Cu-10 % Ni, 1.5 % Fe, 0,7 % Mn
CN i08
CZ 10')
(J1
Nearest
ISO designation
Cu5 % Ni, 1,1 % Fe,O,5 % Mn
70f30 coppernickel
55f30/2/2 copper-nickel.iron.manganese
CZ 102
Specified in BS
2870
capper.nickel.iran
CN 104
CN 105
composition
'
CN 1'01
Nominal
C..
:::l,
-...,J
to
co
:J
:J
:J
~,l
'-,
,_.J
-"
.,
fabia'S
(concluded).
as de,ignation
j\
"
,/
------.--- )
..
Material description
Nominal composition
127
CZ 128
CZ129
CZ 130
CZ 131
CZ 132
CZ 133
CZ 134
CZ 135
Pt 1
Alum inlurn-nick el-sjlicon-brass
83 % Cu, 1 % AI, 1 % Ni, 1 % Si,
remainder Zn
Leaded brass, 60 % copper, 2 % lead
Leaded brass, 60 % copper, 1 % .Iead
Leaded brass for sections
Leaded brass, 62% copper, 2 % lead
Dezincification
resistant. brass
Naval brass (uninhibited)
Naval brass (high leaded)
High tensile brass with silicon
60
60
56
62
CZ 136
CZ 137
Manganese brass
Leaded.brass, 60 % copper,
NS 101
L%ded, 10 % nickel brass
NS
NS
NS
NS
NS
NS
;03
104
105
106
107
108
% nickel
% nickel
% nickel
% nickel
% nickel
% nickel
25 % nickel silver
NS 111
Leaded 10% nickel silver
PB
PB
PB
PB
101
102
103
104
0.5 % lead
silver
silver
silver
silver
silver (low copper)
silver
NS 109
4
5
7
.8
% phosphor
% phosphor
% phosphor
% phosphor
bronze
bronze
bronze
bronze
remainder
remainder
0.3 % AI,
remainder
Zn:
2n
remainder
Zn
2872
Pt 2
2873
0.2
0.2
0.2
0.2
0.2
0.3
~o Mn.
%
%
%
%
%
Mn,
Mn,
Mn,
Mn,
Mn,
.V
Zn
y'
Zn
.~
"
,,/
"I
.J
remainder
remainder
remaipder
remainder
remainder
Zn
Zn
Zn
Zn
Zn
J
J
J
J
J
Ni, 0.5 % Mn,
Ni, 1.5 % Pb, 0.3 % Mn,
Cu4 % Sn, 0.2 % P
Cu5 <y., Sn, 0.2 % P
Cui% Sri, 0.2 % P
Cu8 % Sn, 0.2 % P
(0
OJ
(0
CuZn38Pb2
CuZn39Pb1
CuZn43Pb2
CuZn37Pb2
CuZn37Mn3AI2Si
J
J
45 % Cu, 10% Ni.2 % Pb, 0.3 % Mn,
rem a lnder Z n
Ni.
Ni,
Ni,
Ni,
Ni,
Ni,
X
OJ
2875
,.
Zn
57 % Cu, 2 % Pb, 1 % Mn, rernainder-Zn
60 % Cu, 0.5 % Pb, remainder Zn
10 %
12 %
15 %
18 %
18 %
20 %
Zn
25 %
Zn
10 %
Zn
N
OJ
:::l -....J
e:N
.J
62 % Cu, 2 % Pb, 0.1 % As, remainder
60 % Cu, 0.7 % Sn, remainder Zn
60 % Cu, 2 %Pb, 0.7. % Sn, remainder
58%Cu,2%Mn,l,5%AI,1
%5i,
remainder Zn
6:3 % Cu,
63 % Cu,
63 % Cu,
63 % Cu.
55 % Cu,
63 % cu.
remainder
57 % Cu.
remainder
60 % Cu.
remainder
2874
Pt 3
.p
10
12
15
18
18
20
% Cu, 2 % Pb,
% Cu, 1 % Pb,
% Cu, 3 % Pli,
% Cu,'2 % Pb,
Nearest
ISO designation
2871
C/)
(1)
Specified in BS
2870
CZ
00
-0
-0
CuZn40Pb
CuNil0Zn42Pb2
J
V
V
V
CuNi10Zn27
CuNi12Zn24
CuNi15Zn21
CuNi18Zn20
CuNi18Zn27
J
J
J
J
.J
J
,/
CuNil0Zn2BPb1
J
J
J
.J
v
,/
CuSn4
CuSn5
CuSn6
CuSn8
.,;F
.0 () 0 (;
BS 2872 : 1989
C and
Appendices
Appendix C. Conversion of stress units
r- ..
r:
Conversions
Table
of stress
in N/mm2
10. Conversion
to kgf/mm2,
of stress
tont/in"
in N/mm2
and Ibf/in
2
tokgf/mm ,
10.
are given in table
tonf/in
and Ibf/in
tonf/in2
Ibflin2
Ibf/in2
N/min2
kgf/mm
11 500
14000
1'5000
16000
16500
310
320
325
330
340
31.5
37..5
33.0
33.5
34.5
20.0
20.5
21.0
21.5
22.0
44500
46000
47000
48000
49000
8.0
8.5
10.0
10.5
12.0
18000
19 ((00
225'00
23{QOO
270 0
345
350
355
370
380
35.0
35.5
36.0
37.5
38.5
22.5
22.5
23.0
24.0
24.5
50500
50 500
51500
5400q
55000
20.0
22.0
23.0
23.5
24.5
12.5
14.0
14.5
15.0
15.5
28'200
31 pOO
32~500
33'500
35600
385
395
400
410
435
39.5
40.5
41.0
42.0
44.5
25.0
25.5
26.0
26.5
28.0
56000
57000
58000
59500
63500
245
250
260
265
270
25.0
25.5
26.5
27.0
27.5
16.0
16.0
17.0
17.0
17.5
35500
36500
37 ~OO
38500
39000
465
485
495
510
525
47.5
49.5
50.5
52.0
53.5
30.0
31.5
32.0
33.0
34.0
67 000
69500
72 000
74 000
76000
275
280
290
295
305
28.0
28.5
29.5
30.0
31.0
18.0
18.0
19.0
19.0
19.5
40500
40500
41 500
42000
43500
540
550
650
700
55.0
56.0
66.5
71.5
35.0
35.5
42.0
45.5
78500
80 000
94500
101 500
tonf/in2
N/mm2
kgf/mm
80
95
105
110
115
8.0
9.5
10.5
11.0
11.5
5.0
6.0
7.0
7.0
7.5
125
130
155
160
185
12.5
13.5
16.0
16.5
19.0
195
215
225
230
240
NOTE
tonf/in2
.'
1. Conversions
have been rounded to the following degree of accuracy:
to the nearest 0.5 unit; Ibl/in2 to the nearest 500 tbflin2.
Conversion factors:
1 N/mm2 = 1 MN/m2
10 bar:
0.1 h bar:
0.101972 kgf/mm2
kgflmm
"
".,
'and
0.064749 lonflin
= 145.038 tbllin'.
NOTE
2. For more detailed conversions see BS 350.
(a) If the figure immediately
after the last figure to be
retained is less than five, the last figure to be retained
should be kept unchanged.
Appen~ix D. The rounding of numbers rule
For the purposes
of determining
compliance
with
compositional
limits and mechanicai
properties
(not
dimensional
tolerances),
an observed value or a calculated
value.obtained
from 'the analysis or testis rounded to the
same number of decimal places as used in the relevant
(b) If the
retained
followed
figure to
standard
in expressing
the specified limit. The following
rules, based on those given in BS 1957, should be used for
(e) If the figure
immediately
retained
to five and followed
rounding.
figure immediately
after the last figure to be
is either greater than five, or equal to five and
by at least one figure other than zero, the last
be retained should be increased by one.
is equal
after
the last figure
to
by zeros only,
the last figure to be retained should be left unchanged
if even and increased
by one if odd ..
17
be
'
i,I'
BS 2872 : 1989
Appendices
E andF
Appendix E. Methods for the determination
of tensile properties
E.1 Tensile strength
E.1.1
J.
F.1 Principle
General
Prepare the tensile test piece from the test samote of the
product in accordance with E.1.2 and E.1.3..
Carry out the tensile test on the prepared
accordance withthe method in BS 18 ..
I:~
E.1.2
',:
test piece in
The susceptibil ity of a brass specimen to dezincification
is
determined by immersing the specimen in a controlled test
solution for a fixed time, followed by microscopic
examination
of sections of the specimen to measure the
depth of dezincification
that has occurred.
Shape of the test piece
From the test sample machine a proportional test piece of
circular, square or rectangular cross section to the
dimensions given in 8S.1B.
Appendix F. Method of test to establish
dezincification resistance of material
designated CZ 132
NOTE. Products having a constant cross section may be tested
without being machined provided a proportional
gauge length
of 5.65
is used.
.JSo
E.l.3 Location
of the test piece in the test sample of the
product
Machine the test pieces (E.l.21 from the following
locations in the test samples of the product.
.
(a) For test samples from forging stock up to and
including 30 mm in diameter, or minor cross-sectional
dimension, machine the test piece axially.
(b) For test samples from forging stock over 30 mm UP
to and including 75 mm in diameter, or minor crosssectional dimension, machine the ter t piece so that the:
longitudinal axis of the test piece is parallel to, and not
less than 15 mm from, the surface of the test sample.
(c) For test samples from forging stock over 75 mm in
diameter, or minor cross-sectional dimension, machine
the test piece so that the longitudinal axis of the test
piece lies midway between the surface furthest from the
centre and the centre of the test sample.
(d) For forgings, machine proportional
test pieces to the
dimensions of one of the standard machined test pieces
given in
1B, such that the axis of the test piece is
parallel to the major dimension of the forging.
as
E.2 Test for 0.2 % proof stress
F.2 Reagents
F.2.1 Test solution. Copper (II) chloride solution prepared
by toe following method. Dissolve 12.7 g CuCI2 .2H2 0
(analytical quality) in distilled or demineralized wat ir and
dilute to 1000 mL. Mix well.
F.2.2
F.3 Apparatus
F.3.1 Optical microscope with scale, to provide a suitable
magnification
(a combination
of x 100 and x500 is
satisfactory)
and a method of measurement of
dezincification
depth.
NOTE. An eyepiece graticule calibrated
satisfactory for measu ri n9 the depth.
using a stage qraticule
F.3.2 Water bath or oil bath, thermostatically
to a temperature
of 75 '3 C.
is
controlled
F.3.3 Glass beaker, covered with plastics film or other seal
of inert non-metallic material.
F .3.4 Material for mounting specimens, e.g. phenol ic resins
or materials with similar properties and not electrically
conductive.
F .3.5 Waterproof abrasive paper, in a range of grit sizes
down to 500 grade or finer.
F.3.6
Diamond polishing peste, grit size 1 urn or less.
F.4 Procedure
F.4.1
Test.the test pieces, prepared in accordance with,~.1.2
and E.1.3, in accordance with the method for proof stress
determination
given in BS 18. If in determining the proof
stress a small tensioning stress is applied, ensure that it is
equal to approximately
20 % of the specified minimum
proof stress, but does not exceed 45 N/mm2.
Ethanol or methanol, for cleaning test pieces.
Preparation
of test pieces
Take two test pieces from each sample supplied for testinq
in such a way that the properties of the material are
unaffected (e.g. by sawinqand grinding with light pressure).
For forgings and castings take one test piece from the area
with the thinnest section and one from the area with the
th ickest section.
(J
tJ U
t)
CI U
U U U U U
BS 2872 : 1989
Appendix F .
"'.ft>
For materials with a specific extrusion or roll ing direction
(e.g. tube, rod or section), take one test piece to expose a
surface parallel to, and the other piece to expose a surface
perpendicular- to, the extrusion or rolling'direction (see'
figure 1 (a)). Cut test pieces from rod-samples in such a
way as to include points midway bet.;!,eln the axis and the
. periphery.
ec,
. .. .
For each test piece ensure that the area'tc be exposed to .
the test solution is approximately 100 _If.\.m2.If the size of
the component or the cross section of'l!te rod to be tested
is too small to provide test areas of this siie take the largest
possible test area.
"'"....:,,{
Embed the test pieces in the mountin~~ium
(F.3.4) and
grind the test surface using successively liner grades of wet
abrasive paper (F.3.5), finishing with 500;~:irade or finer.
r= .
F .4.2 Exposure of samples to the test--;~I~tion
Clean the test surfaces with ethanol o/~";;hanol
(F.2.2).
Place a beaker (F.3.3) containing fresh test solution (F.2.1)
in the watcr bath or oil bath (F.3.2). Maintain the temper-
ature of the test solution during the entire exposure at
75 3C. Use at least 250 mL of the test solution for each
100 mm2 of exposed test piece surface.
'Place the test pieces in the beaker (F .3.3) containing the
test solution in such a way that the test surface is vertical
and at least 15 mm above the bottom of the beaker. Do not
test different alloys simultaneously in the same beaker.
After 24 h, remove the test pieces from the beaker and
wash in distilled or demineralized water to remove residual
test solution from the surface.
F .4.3
Preparation
of rnicrojections for examination
Resection each of the test pieces in the mount at right
angles to the exposed test surface (see figure 1(b) ).~Embed
each of these test piece sections in the mounting medium,
(F.3.4) such that the resectioned surface can be examined:'
(see figure 1 (cl), Grind the surfaces of these microsections
using successively finer grades of wet abrasive paper
.
(F.3.5), finishing with 500 grade or finer.
1
I
(a)
.;-
exposure
to te st
/ .
solution
r .
,f..,..
~o,,;..
(b)
r.
V--)
I
Depth of penetratIon~.
rne a s ur e rn e nt
(c)
Fig.uril 1. Illustration
of dezincificatiori
resistance test
BS 2872 : 1989
Appendices
F, G and
F .4.4 Examination of microsections
dezincification
depth
and recording
of
Carry out final polishing of the microsections with diamond
paste of particle size 1 urn or less (F.3.6), using a suitable
light oil lubricant. Clean the microsections
in ethanol or
methanol (F.2.2j after polishing and ensure freedom from
stains and tarnishing.
Using the microscope (F.3.1), examine the microsection
prepared from each test area and record the depth of
dezincification,
adjusting the degree of magnification
to
ensure the greatest accuracy. Examine a total length of
section of 5 rnm for each of the test pieces (10 rnrn for rod
over 25 rnrn diameter). If this is not possible, due to the
.
dimensions of the test area, examine the maximum possibje
length of the section and record this length wh~n reportinq,
the results.
;.
.: NOTE. In some cases there is a greater depth of dezincification
along the line of the interface between the mounting material and
the brass during exposure to the test solution (edge effect!' Ensur.e
that the measurement of the maximum depth of dezincification is
at a sufficient distance from this interface for edae effects to be
negligible.
Appendix G. Method for the detection of
residual stress by the ":'1ercurousnitrate test
G.1 Principle
The test specimen is degreased and cleaned. The presence
of an unacceptable level of residual (internal) stress in the
test specimen is revealed by the development of cracks
when it is immersed in an acidified mercury (I). nitrate
solution.
G.2 Reagents
,G.2.1 Nitric acid, p 1.42 g/mL, 50 % V/V aqueous solution.
G.2.2 Mercury (/) -oitrste test solution. Dissolve 11.4 9 of
mercury (I) nitrate dihydrate (HgN03.2H20)
or 10.7 g of
mercury (I) nitrate monohydrate
(HgN03 .H2 0) in
approximately
40 mL distilled water acidified with 10 mL
. ',' nitric acid (p1.42 g/mL). When the crystals are completely
dissolved, dilute the solution with distilled water to
.1000 mL.
'NOTE. If heating is used to aid dissolution care should be exercised'
prevent loss of nitric acid.
._
.:Warning. Mercury II) nitrate is highly toxic and should be treated
to
with due care.
G.3 Procedure
of the test specimen, take precautions to ensure that it is
not subjected to mechanical working that could raise the
level of internal stress in the specimen, such as bending or
straightening.
Degrease the specimen (e.g. in acetone). Totally immerse it
in 50 % V/V nitric acid solution (G.2.1) for a period not
exceeding 30 s to remove all traces of carbonaceous
matter
and oxide films.
Remove the specimen, wash it well in cold water and totally
immerse it in the mercury (I) nitrate test solution (G.2.2).
Use at least 1,5 mL of test solution for each 100 rnrn" of
exposed surface of the specimen.
After 30 min. remove the specimen and wash it well in
cold water. Wipe off excess mercury from the surface of
the specimen and examine the specimen immediately for'
evidence of cracks with the unaided eye, corrected for
normal vision if necessary.
.Appendix H. Quantity tolerances for
forgings
Quantity tolerances for forgings, i.e, the permissible
. over/under-run
allowed on each order, are given for
information in table 11. Any delivery quantity within the
. iimits of over/under-run
given in table 11 should be
considered as completing the order. Intermediate
quantities should be assessed pro rata to the nearest smaller
quantity shown in the 'table. The tolerances given in the,
table are those adopted by the National Association of
Drop Forgers and Stampers, and are given for information
only.
Table 11. Ouantitv
for forgings'
Quantity tolerance
Number of pieces
ordered
Up
Up
Up
Up
Up
to
to
to
to
to
50
100
300
600
1000
Up to 5000
Up to 10 000
Up to 15000
Up to 20 000
Any quantity over 25 000
L...- ____ "
E,nsure that the test specimen is not marked for identification by indenting. During the selection and preparation
tolerances
Over-run
pieces
Under-run
pieces
2
3
6
18
24
40
9
112
20
100
50
200
100
300
400
500
200
150
250
----
,-
-.-.-~---....
.._-----
--
u u
UUUU
LJ LJ
Publications referred to
BS
BS
BS
BS
1B
350
1957
2870
as 2871
BS 2873
Method for tensile testing of metals (including aerospace materials)
Conversion factors and tables
Presentation of numerical values (fineness of expression; rounding of numbers)
Specification for rolled copper and copper alloys: sheet, strip and foil
Specification for copper and copper alloys. Tubes
Specification for copper and copper alloys.cWire
BS 2874
BS 2875
Specification
Specification
for copper and copper alloy rods and sections (other than forging stock)
for copper and copper alloys. Plate
"'"
0:'0
This British Standard, having been prepared under the direction of
the Non-ferrous Metals Standards Policy Committee,
was published
under the authority of the Board of BSI and comes into effect on
28 April 1989
British Standards
Institution.
19B9
ISBN 0 580 17276 7
.First published February 1962
First revision March 1969
' ,
Second revision April 1989
BS 2872
1989
reproduced in any form without the prior permission in writing of
851, This does not preclude the free use. in the course of
implementing the st sndar d, of necessary dct~ils such as symbols and
siz e , type or grade designations,
Enquiries should be addressed to
the Publications Manager. 8SI, Linford Wood. Milton Keynes
MK14 6LE. The number for telephone enquiries is 0908220022
and for telex 825777.
Contract requirements.
A British Standard does not purport to
include al/ the necessary provisions of a contract. Users of British
Standards are responsible fortheir correct application.
The following BSI references relate to the work on this standard:
Committee reference NFM/34 Draft for comment 88/37973 DC
'01-'
British Standards Institution.
Incorporated
by Royal charter. 6S1 is
!liv in(!e:1cnGcnt national body f(Jr the preparation of Br ijish
,Sta"dards.
It is the UK member of the International
Organization
'Idr Standardization
and UK sponsor of the BritIsh National
Cornrni t tec of the International
Electrotechnieal
Commission.
. In addition to the preparation and promulgation
of standards, BSI
~ offers soecianst services including 'the provision of information.
~r'.ou9h
the BSI Library andStandardline
Database; Technical Help
(0 E xporters:
and other services. Advice can be obteined-fnorn the
,En'quiry Section, BSI, Milton Keynes 'MK14 6LE, teleph;ne
09'08 22,1166, telex 82Sn7.
Copyright'. Users of British .Standards are reminded that 60pyright
subsists in all 6S1 publications.
No part of this publication may be
Revision of British Standards. British Standards are revised, when
necessary, by the issue either of amendments or of revised editions,
It is important that users of British Standards should ascertain that
they are in possession of the latest amendments Or editions.
Automatic updating service. BSI provides an economic, individual
and automatic standards updating service called PLUS. Details are
available from BSI Enquiry Section at Milton Keynes. telephone
0908221166,
telex 825777 .
Information on al/ BSI publications is in The eSt Cetetoque,
supplemented each month by eSI News which is available to
subscribing members of BSI and gives details of new publications.
revisions, amendments and withdrawn standards. Any person who,
when making use of a British Standard, encounters an inaccuracy Or
ambiguity, is requ~sted to notify BSI without delay in order that
the matter may be investigated and appropriate action taken.
Committees responsible for this British Sta!1dard
The preparation of this British Standard was entrusted by the
Non-ferrous Metals Standards Policy Committee (NFM/-flo
Technical Committee NFM/34, upon which the following bodies
were.represented:
Br itisn
British
British
British
British
British
Copper
~ ondon
Bathroom Council
Cable Makers' Confederation
Gas pic
Malleable Tube Fittings Association
Non-ferrous Metals Federation
Valve and Actuator Manufacturers'
Association
Development Association
Metal EXChange
',
Amendments
Arnd. No.
Non-ferrous Metal Stockists
Society of British Aerospace
Coopted members
Companies
Limited
,The following bodies were also represented in the drafting
standard, through subcommittees
and panels:
British Plumbing Fittings Manufacturers'
British Telecommunications
pic
British
Turned-parts
Manufacturers'
of the
Association
Association
Copper Srnet+ers' and Refiners' Association
Electronic Engineering Association
Spring Research and Manufacturers'
Association
Telecommunication
Engineering and Manufacturing
Association
issued since publication
Date of issue
Text affected
co
CO
CD
'.
" -Brit:ishS1andards'lnstitution
2 Park Street London W1A 2BS . Telephone
01-629 9090 . Telex 266933
._'