L 65 - Prevention of Fire and Explosion, and Emergency Response On Offshore Installations - Approved Code of Practice and Guidance - HSE - 2010

Health and Safety
Executive
Prevention of fire and explosion,

and emergency response on
offshore installations
Offshore Installations (Prevention of Fire and Explosion, and
Emergency Response) Regulations 1995
Approved Code of Practice and guidance
This is a free-to-download, web-friendly version of L65, (Second edition,
published 1997). This version has been adapted for online use from HSEs
current printed version.
You can buy the book at www.hsebooks.co.uk and most good bookshops.
ISBN 978 0 7176 1386 1
Price 9.50
This publication contains the Offshore Installations (Prevention of Fire and
Explosion, and Emergency Response) regulations 1995.
It is aimed at all those who own, operate or work on offshore installations and
looks at how to prevent fires and explosions as well as how to protect people
working on offshore installations should they occur. It also looks at how to
respond to emergencies, considering issues such as escape, evacuation, rescue
and recovery.
HSE Books
Page 1 of 56
Health and Safety

Executive
Crown copyright 1997

First published 1995
ISBN 978 0 7176 1386 1
All rights reserved. No part of this publication may be reproduced, stored in
a retrieval system, or transmitted in any form or by any means (electronic,
mechanical, photocopying, recording or otherwise) without the prior written
permission of the copyright owner.
Applications for reproduction should be made in writing to:
The Office of Public Sector Information, Information Policy Team,
Kew, Richmond, Surrey TW9 4DU or e-mail: [email protected]
This Code has been approved by the Health and Safety Executive, with the
consent of the Secretary of State. It gives practical advice on how to comply with
the law. If you follow the advice you will be doing enough to comply with the law
in respect of those specific matters on which the Code gives advice. You may use
alternative methods to those set out in the Code in order to comply with the law.
However, the Code has a special legal status. If you are prosecuted for breach of
health and safety law, and it is proved that you did not follow the relevant provisions
of the Code, you will need to show that you have complied with the law in some
other way or a Court will find you at fault.
Page 2 of 56
Health and Safety

Executive
Contents
Notice of Approval 4
Preface 4
Introduction 5
Regulation
Regulation
Regulation
Regulation
Regulation
Regulation
Regulation
Regulation
Regulation
Regulation
Regulation
Regulation
Regulation
Regulation
Regulation
Regulation
Regulation
Regulation

Regulation
Regulation
Regulation
Regulation
Regulation

Regulation

Regulation
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
Citation and commencement 7

Interpretation 7
Application 10
General duty 11
Assessment 14
Preparation for emergencies 18
Equipment for helicopter emergencies 20
Emergency response plan 21
Prevention of fire and explosion 23
Detection of incidents 25
Communication 27
Control of emergencies 30
Mitigation of fire and explosion 32
Muster areas etc. 34
Arrangements for evacuation 36
Means of escape 38
Arrangements for recovery and rescue 39
Suitability of personal protective equipment for use in an
emergency 42
Suitability and condition of plant 44
Life-saving appliances 48
Information regarding plant 49
Certificates of exemption 49
Amendment of the Offshore Installations (Safety Representatives
and Safety Committees) Regulations 1989 50
Amendment of the Offshore Installations (Safety Case)
Regulations 1992 51
Revocation 51
Schedule
Revocation 52
Appendix 1

Appendix 2
Appendix 3
Co-operation: regulation 8 of the Management and Administration

Regulations 53
List of abbreviations used 54
Health and Safety Executive Offshore Safety Division Offices 55
Prevention of fire and explosion, and emergency response on offshore installations
Page 3 of 56
Health and Safety

Executive
Notice of approval
By virtue of section 16(4) of the Health and Safety at Work etc Act 1974, and
with the consent of the Secretary of State for the Environment, the Health and
Safety Commission has on 13 February 1997 approved the revision of the Code
of Practice entitled Prevention of fire and explosion, and emergency response on
offshore installations.
The Code of Practice gives practical guidance with respect to the Offshore
Installations (Prevention of Fire and Explosion, and Emergency Response)
Regulations 1995 (SI 1995 No 743).
The Code of Practice comes into effect on 1 June 1997 and on that date the first
edition of the Code of Practice shall cease to have effect.
Signed
T AGATES
Secretary to the Health and Safety Commission
13 February 1997
Preface
This publication contains the Offshore Installations (Prevention of Fire and
Explosion, and Emergency Response) Regulations 1995 (PFEER), together with
a revised Approved Code of Practice (ACOP) and additional guidance. The main
changes to the ACOP have been made to paragraphs 170, 173 and 174 to
incorporate the factors to be considered when selecting a vessel to provide the
recovery and rescue arrangements required by regulation 17.
For convenience, the text of the Regulations is included in italic type, with the
accompanying guidance in medium type and the ACOP in bold type. Some
sources of further information are also set out below the regulation to which they
relate. A list of abbreviations is given in Appendix 2.
Page 4 of 56
Health and Safety

Executive
Introduction
1 This publication has been prepared following widespread consultation with
representatives of the Confederation of British Industry and industry associations
representing offshore operators and contractors, the Trades Union Congress and
offshore unions, other interested organisations, and government departments.
2 The Regulations, ACOP and guidance deal with:
(a)

(b)

preventing fires and explosions, and protecting persons from the effects of any
which do occur; and
securing effective response to emergencies affecting persons on the installation
or engaged in activities in connection with it, and which have the potential to
require evacuation, escape and rescue from the installation.
Relationship between these Regulations and other health and

safety law
3 These Regulations complement some other health and safety regulations
in a number of areas. Specific interfaces are described under each regulation.
This section describes how the Regulations fit in with general health and
safety legislation, and the interface with the Offshore Installations (Safety
Case) Regulations (SI 1992/2885) (SCR) and the Offshore Installations (Safety
Representatives and Safety Committees) Regulations (SI 1989/971) (SRSCR).
General health and safety legislation
4 The Health and Safety at Work etc Act 1974 (HSW Act) places general duties
on employers to ensure, so far as is reasonably practicable, the health and safety
of their employees, and others who might be affected by their undertaking (HSW
Act, sections 2, 3 and 4). These general duties are supported by the requirement
in regulation 3 of the Management of Health and Safety at Work Regulations (SI
1992/2051) (MHSWR) for employers to undertake risk assessments for the purpose
of identifying the measures which need to be put in place to prevent accidents and
protect people against accidents.
5 The PFEER Regulations support these general requirements in two ways.
They specify particular goals for preventive and protective measures to manage
fire and explosion hazards, and to secure effective emergency response; and
they recognise that, on offshore installations, these measures are best made
the responsibility of one person - a primary duty holder - the operator or owner
(referred to from now on as duty holder). Compliance with these Regulations will
therefore aid duty holders to fulfil their duties as employers under general health
and safety legislation. This does not mean that individual employers who may be
involved in activities on offshore installations are absolved from meeting their duties
under the HSW Act and MHSWR. And those employers will have to co-operate
with the primary duty holder (see Appendix 1). Specific interfaces are explained in
the guidance to each regulation.
Safety Case Regulations
6 The SCR Regulations require a safety case to be submitted for acceptance by
the Health and Safety Executive for each installation.
Page 5 of 56
Health and Safety

Executive
7 Regulation 8(1)(a) of SCR requires a demonstration in the safety case of the

adequacy of the safety management system (SMS) for controlling risks to persons
on the installation or engaged in connected activities; and of arrangements for
independent audit of the SMS. The organisation and arrangements provided to
meet the requirements of the PFEER Regulations form part of the SMS for the
purposes of SCR.
8 Regulation 8(1)(c) and (d) of SCR requires a demonstration in the safety
case that major accident hazards have been identified, their risks evaluated, and
action taken to reduce the risks to as low as is reasonably practicable. PFEER,
regulation 5 specifies requirements for a fire and explosion, and evacuation, escape
and rescue assessment. The results of this assessment will contribute to the
demonstration required by SCR.
9 In addition, the PFEER Regulations specify goals for preventive and protective
measures for managing fire and explosion hazards, and emergency response.
Complying with these Regulations, taking account of the practical guidance
contained in this publication, will facilitate HSEs acceptance of the safety case.
The Regulations are in general expressed as broad goals rather than specific
requirements, allowing duty holders the flexibility to develop detailed arrangements
in the light of hazards, plant configuration and other circumstances specific to the
installation.
10 By virtue of regulation 8 (2) of SCR, safety cases submitted to HSE before the
PFEER Regulations came into force were assessed on the basis of what it was
reasonable to expect the duty holder to address at the time of the submission.
The bringing into force of the PFEER Regulations did not, in itself, prompt re
submission of any safety case. However, if anything arising from compliance with
these Regulations results in a revision to the safety case which makes it materially
different, it will need to be re submitted in line with the requirements of regulation
9(2)-(4) of SCR. Where compliance with PFEER does not result in such a revision to
a safety case, it need not be resubmitted.
11 The SCR Regulations have been amended by the Offshore Installations and
Wells (Design and Construction, etc) Regulations 1996 (DCR) to introduce a written
verification scheme for safety-critical elements (SCE). The interface with PFEER,
regulation 19 is described in paragraph 194.
Safety Representatives and Safety Committees Regulations
12 Another important interface is with SRSCR. These Regulations, as amended
by SCR, specify ways in which safety representatives and committees are to be
involved with the safety case (see pages 49 and 50 of A guide to the Offshore
Installations (Safety Case) Regulations 1992). In relation to the PFEER Regulations
safety representatives should be consulted on the measures to be taken to comply
with them, and in particular the arrangements made under regulation 6 and in
preparing the emergency response plan required by regulation 8.
Page 6 of 56
Health and Safety

Executive
Further information
13 A guide to the Offshore Installations (Safety Case) Regulations 1992 L30
HSE Books ISBN 0 11 882055 9
Management of health and safety at work Approved Code of Practice L21
HSE Books ISBN 0 7176 04128
Safety representatives and safety committees on offshore installations: guidance
notes HSE Books ISBN 0 11 885738 X
A guide to the installation verification and miscellaneous aspects of amendments
by the Offshore Installations and Wells (Design and Construction, etc) Regulations
1996 to the Offshore Installations (Safety Case) Regulations 1992 L83 HSE Books
ISBN 0 71761 1930
Regulation
Regulation 1 Citation and commencement
These Regulations may be cited as the Offshore Installations (Prevention of Fire and
Explosion, and Emergency Response) Regulations 1995 and shall come into force
on 20th June 1995.
Regulation
Regulation 2 Interpretation
(1) In these Regulations, unless the context otherwise requires the 1995 Order means the Health and Safety at Work etc. Act 1974 (Application
outside Great Britain) Order 1995(a);
the 1974 Regulations means the Offshore Installations (Construction and Survey)
Regulations 1974(b);
2
Guidance
2
Regulation
(a) SI 1995/263.
(b) SI 1974/289.
14 The Offshore Installations (Construction and Survey) Regulations (SI 1974/289)

(CSR) have been revoked by DCR, but transitional provisions relating to certification
remain in force until 30 June 1998 (see guidance on regulation 19).
the 1995 Regulations means the Offshore Installations and Pipeline Works
(Management and Administration) Regulations 1995(c);
(c) SI 1995/738
Guidance
2
15 The abbreviation MAR is generally used for these Regulations in the text of
this publication.
Regulation
acoustic signal means a coded sound signal which is released and transmitted by
a device designed for that purpose, without the use of a human or artificial voice;
concession owner in relation to a fixed installation has the same meaning as in

regulation 2(1) of the 1995 Regulations;
Page 7 of 56
Health and Safety

Executive
Guidance
2
16 Detailed guidance on the definition of concession owner is set out in

guidance to MAR, regulation 2.
Regulation
duty holder means -
2
Guidance
(a) in relation to a fixed installation, the operator; and

(b) in relation to a mobile installation, the owner;
17 The duty holder structure for these Regulations is the same as that in SCR
(the operator, in the case of a fixed installation, and the owner, in the case of a
mobile installation).
Regulation
2
emergency means an emergency of a kind which can require evacuation, escape

or rescue;
Guidance
2
18 An emergency includes any unexpected event of whatever nature with the

potential to cause harm and to require the evacuation, escape and rescue of one
or more persons from the installation.
Regulation
2
emergency response means action to safeguard the health and safety of persons
on or near an installation in an emergency;
Guidance
2
19 Emergency response covers action in response to potential major accidents;

and also to some lesser incidents, for example, persons overboard, sickness or
injuries to personnel which necessitate urgent evacuation from the installation for
medical treatment or recuperation.
Regulation
2
evacuation means the leaving of an installation and its vicinity, in an emergency, in

a systematic manner and without directly entering the sea;
Guidance
20 Evacuation refers to the planned and controlled method of leaving the

installation without directly entering the sea. Successful evacuation will result in
persons being transferred to a place of safety, by which is meant a safe onshore
location, or a safe offshore location or vessel. Means of evacuation offer protection
from the hazard, and have their own motive power to enable persons to move
quickly away from the installation.
Regulation
the Executive means the Health and Safety Executive;

explosion means unplanned explosion;
fire means unplanned or uncontrolled fire;
fixed installation means an installation other than a mobile installation;
illuminated sign means a sign produced by a device made of transparent or
translucent materials which are illuminated from the inside or the rear in such a way
as to give the appearance of a luminous surface;
installation means an offshore installation within the meaning of regulation 3 of the

1995 Regulations;
Guidance
2
21 Detailed guidance on the definition of installation is set out in guidance to

MAR, regulation 3.
Page 8 of 56
Health and Safety

Executive
Regulation
2
Guidance
major accident has the same meaning as in regulation 2(1) of the Offshore
Installations (Safety Case) Regulations 1992(d);
(d) SI 1992/2885.
22 Regulation 2(1) of SCR defines the term major accident and this is
reproduced in the box below. Guidance on the term is set out on pages 2 and 3 of
A guide to the Offshore Installations (Safety Case) Regulations 1992.
major accident means -
2
Regulation
2
Guidance
(a) a fire, explosion or other release of a dangerous substance involving death

or serious personal injury to persons on the installation or engaged in an
activity on or in connection with it;
(b) any event involving major damage to the structure of the installation or plant
affixed thereto or any loss in the stability of the installation;
(c) the collision of a helicopter with the installation;
(d) the failure of life support systems for diving operations in connection with
the installation, the detachment of a diving bell used for such operations
or the trapping of a diver in a diving bell or other subsea chamber used for
such operations; or
(e) any event arising from a work activity involving death or serious personal
injury to five or more persons on the installation or engaged in an activity in
connection with it;
mobile installation means an installation (other than a floating production platform)
which can be moved from place to place without major dismantling or modification,
whether or not it has its own motive power;
23 Detailed guidance on the definition of installation is set out in guidance to

MAR, regulation 3; this includes guidance on when a mobile installation becomes,
or ceases to be, an installation.
Regulation
muster areas shall be construed in accordance with regulation 14(1) (a);

operator in relation to -
(a) a fixed installation means the person appointed by a concession owner

to execute any function of organising and supervising any operation to
be carried out by such installation or, where no such person has been
appointed, the concession owner; and
(b) a mobile installation means the person for whom the owner has agreed
to carry out the operation concerned or, where no such person has been
appointed, the concession owner;
Guidance
2
24 Detailed guidance on the definition of operator is set out in guidance to

MAR, regulation 2.
Regulation
2
owner in relation to a mobile installation means the person who controls the
operation of the installation;
Page 9 of 56
Health and Safety

Executive
Guidance
2
25 Detailed guidance on the definition of owner is set out in guidance to MAR,

regulation 2.
Regulation
personal protective equipment has the same meaning as in regulation 2 (1) of the
Personal Protective Equipment at Work Regulations 1992(e).
(2) Unless the context otherwise requires, any reference in these
Regulations to (a) a numbered regulation is a reference to the regulation in these
Regulations so numbered;
(b) a numbered paragraph is a reference to the paragraph so numbered in
the regulation in which the reference appears.
(e) SI 1992/2966
Guidance
Further information
26 A guide to the Offshore Installations and Pipeline Works (Management and

Administration) Regulations 1995 L70 HSE Books ISBN 0 7176 0938 3
Regulation 3 Application
Regulation
(1) These Regulations shall apply (a) in Great Britain, and

(b) to and in relation to installations and activities outside Great Britain to
which sections 1 to 59 and 80 to 82 of the 1974 Act apply by virtue of
articles 4(1) and (2) (b), 5 and 6 of the 1995 Order.
3
Guidance
(2) Regulations 4 to 22 shall not apply in relation to an installation which is

in transit to or from a station; and an installation is not in transit to or from a station
while it is being manoeuvred at the station.
27 The Regulations apply equally to mobile and fixed installations although
they do not apply to mobile installations while in transit to or from a station. An
installation is in transit when it is not at, or in the immediate vicinity of, a previous or
new working station. Manoeuvring preparatory to leaving a station, or after arrival
in order to position the installation, is not part of transit and is therefore within the
scope of these Regulations. Detailed guidance on the terms used in this regulation
is contained in guidance to MAR, regulation 4.
28 The Regulations and ACOP apply to existing and new installations throughout
their life cycle, taking into account that different measures may be appropriate at
different stages of the life cycle of the installation.
29 The Regulations and ACOP apply equally to attended and normally

unattended installations. Duty holders will need to pay particular attention to the
measures for fire and explosion hazard management and emergency response on
normally unattended installations, when there are persons on board, ie when one
or more persons alight on the installation to carry out work. Emergency response
arrangements need to be established and confirmed before each visit, including
arrangements for effective management of the emergency and the allocation of
emergency duties. Operating parameters should be defined to ensure that normally
unattended installations are not visited in conditions which could compromise
arrangements for evacuation and escape.
Page 10 of 56
Health and Safety

Executive
Guidance
30 Particular attention should be paid to the arrangements for managing fire and
explosion hazards and emergency response during combined operations, to ensure
that the measures and arrangements take account of all the installations involved.
There is a particular need for duty holders to ensure that emergency arrangements
are co-ordinated. For example, in some combined operations the availability of
facilities for evacuation and escape may be affected, and duty holders should take
this into account in: their emergency response plans (required by regulation 8);
meeting the requirements for safe evacuation and escape in regulations 15 and 16;
and the availability of the life-saving appliances (regulation 20).
Relationship with other Regulations

31 Most mobile installations are also classed as ships, and as such may be
subject to various international maritime conventions. Codes issued by bodies such
as the International Maritime Organisation (IMO) may also be relevant.
32 In addition, mobile installations will be required to comply with the relevant
maritime legislation and conventions of their flag states and with UK port
state requirements, where appropriate, as well as with the provisions of these
Regulations. Compliance with the relevant provisions of maritime legislation and
conventions may contribute towards discharging duties under these Regulations.
Further information
33 Code for the construction and equipment of mobile offshore drilling units
(MODU Code) IMO ISBN 9280112821
A guide to the Offshore Installations and Pipeline Works (Management and

Regulation
Regulation 4 General duty

(1) The duty holder shall take appropriate measures with a view to (a) protecting persons on the installation from fire and explosion; and
(b) securing effective emergency response.
4
Guidance
4
(2) Any more detailed requirement in regulations 6 to 21 for the purposes

referred to in paragraph (1) shall be without prejudice to the generality of paragraph
(1).
34 Regulation 4 is a general duty on duty holders to protect people on their
installations from all fires and explosions, and to provide effective emergency
response. The duty holder has a responsibility to all people on the installation - not
just their own employees.
Page 11 of 56
Health and Safety

Executive
Guidance
35 This paragraph explains a number of important terms used in the Regulations:

n

n

n

n

protecting persons from fire and explosion covers all the measures which may
be needed to safeguard people from fires and explosions, ie inherent safety by
design, preventive, detection, control and mitigation measures;
measures includes both plant and equipment (ie hardware) and also
management systems (ie software);
appropriate measures with a view to protecting people and securing effective
emergency response should be suitable for their purpose. They should also,
taken together, enable the requirements of the Regulations to be met in the
light of the circumstances on the installation, the stage in its life cycle,
the nature of the hazard, the likelihood of it being realised and the potential
consequences. In determining what is appropriate duty holders should take
account of any specific requirements in the Regulations, the outcome of the
assessments required by regulation 5 of these Regulations and regulation 3 of
MHSWR, and the risks and the costs of various measures. Appropriate
measures should be adequate to achieve the objectives set out in the
regulation but would not require expenditure which is completely out of
proportion to the risk their implementation avoids;
emergency and emergency response are defined in regulation 2 (see
paragraphs 18 and 19).

36 Regulation 4 sets out a general objective, with more specific requirements
in the other regulations. Compliance with the other regulations will contribute
substantially to satisfying regulation 4. Duty holders will need to satisfy themselves
that what they have done to comply with the other regulations is enough to meet
the overall duties in regulation 4 to protect people from fire and explosion and
secure effective emergency response.
37 Plant and equipment on offshore installations provided to comply with these

Regulations may also be subject to the Provision and Use of Work Equipment
Regulations (SI 1992/2932) (PUWER). Where such equipment is safety-critical as
defined in the amended SCR, it will be subject to verification arrangements under
regulation 15A of SCR Personal protective equipment for use in an emergency
is covered by both the Personal Protective Equipment at Work Regulations (SI
1992/2966) (PPEWR) and by regulation 18 of PFEER.
Page 12 of 56
Health and Safety

Executive
ACOP
38 The purpose of the Regulations overall is to promote a risk-based,

systematic approach to managing fire and explosion hazards and emergency
response. The general principles of risk control and health and safety
management set out in the Approved Code of Practice on MHSWR are
relevant to this process and should be followed. They are summarised in the
following box:
Principles for preventive and protective measures
n
n
n
n

n

n
n
n

it is always best if possible to avoid a risk altogether;

combat risks at source, rather than by palliative measures;
wherever possible, adapt work to the individual;
take advantage of technological and technical progress to improve
work methods and make them safer;
risk prevention measures should form part of a coherent policy
and approach to reduce risks progressively that cannot be prevented
or avoided altogether;
give priority to measures which protect the whole workplace;
make sure workers understand what they need to do;
create an active health and safety culture which affects the
organisation as a whole.
Principles for health and safety management

n

n

n

n

Planning. Adopting a systematic approach which identifies priorities

and sets objectives. Whenever possible, risks are eliminated by the
careful selection and design of facilities, equipment and processes or
minimised by the use of physical control measures;
Organisation. Putting in place the necessary structure with the aim
of ensuring that there is a progressive improvement in health and
safety performance;
Control. Ensuring that the decisions for ensuring and promoting health
and safety are being implemented as planned;
Monitoring and review. Like quality, progressive improvement in health
and safety can only be achieved through the constant development of
policies, approaches to implementation and techniques of risk control.
39 These principles should be applied for fire and explosion hazard

management and emergency response by:
n

n

developing an approach to fire and explosion hazard management

based on hazard identification and risk assessment, involving a
balanced and integrated approach to designing hazards out, preventing
hazardous events occurring, detecting that they have occurred, or are
occurring, controlling their escalation, and mitigating their
consequences;
a systematic approach to emergency response by considering the
various stages of an emergency and how each of those stages can be
most effectively managed, to reduce risks to health and safety.
Page 13 of 56
Health and Safety

Executive
Guidance
Further information
40 Management of health and safety at work Approved Code of Practice L21
HSE Books ISBN 0717604128
A guide to the Offshore Installations (Safety Case) Regulations 1992 L30 HSE
Books ISBN 0 11 882055 9
Successful health and safety management HS(G)65 HSE Books
ISBN 071760425 X
Human factors in industrial safety HS(G)48 HSE Books ISBN 0 11 885486 0
Regulation 5 Assessment
Regulation
(1) The duty holder shall perform, and thereafter repeat as often as may
be appropriate a process (in this regulation called Can assessment) described in
paragraph (2) in relation to the installation.
(2) An assessment shall consist of(a) the identification of the various events which could give rise to (i)
(ii)
a major accident involving fire or explosion; or

the need (whether or not by reason of fire or explosion) for
evacuation, escape or rescue to avoid or minimise a major
accident;
(b) the evaluation of the likelihood and consequences of such events;

(c) the establishment of appropriate standards of performance to be
attained by anything provided by measures for (i)
(ii)
ensuring effective evacuation, escape, recovery and rescue to avoid

or minimise a major accident; and
otherwise protecting persons from a major accident involving fire or
explosion; and
(d) the selection of appropriate measures.

(3) The duty holder shall-
5
Guidance
(a) record the assessment (including each repetition of it);

(b) keep the record at an address in Great Britain; and
(c) notify the Executive of such address.
41 The regulation requires the duty holder to assess major accident hazards
arising from fire and explosion and events which may require evacuation, escape
and rescue, and identify appropriate arrangements for dealing with them.
Information from the assessment has to be recorded, and the record kept at an
address in Great Britain. HSE has to be told about the address. Notifications
should be sent to the HSE office which normally deals with the installation. Fax or
other electronic transmission of the address is acceptable.
Page 14 of 56
Health and Safety

Executive
Guidance
42 Regulation 5(3) requires the assessment to be recorded but does not specify
how. Duty holders may decide on the best approach; for example, to prepare
a single, stand-alone document; or a series of documents; or to record the
assessment as an integral part of the safety case document. Duty holders are free
to keep supporting information in separate documents, or reference information
already held in other documentation. A summary of the assessment has to be
provided in the safety case (see regulation 24).
43 The regulation requires the duty holder to repeat the assessment as often as
may be appropriate. This would include, for example, taking account of changes
to the installation or to working activities, and the introduction of new equipment or
systems.
44 The regulation does not itself stipulate the measures to be taken and the
arrangements to be made as a result of the assessment. But the assessment
should be used as the basis for determining the detailed measures and
arrangements to be made to comply with the other PFEER Regulations.
45 Some of the terms used in this regulation are explained in the guidance on
regulation 4. These explanations are relevant here unless otherwise indicated. Other
key terms in the regulation are:
n
n
n
assessment is the process described in the regulation (see paragraph 50);

major accident is defined in regulation 2(1) of SCR (see paragraph 22);
performance standards are explained in the box below:
A performance standard is a statement, which can be expressed in qualitative or

quantitative terms, of the performance required of a system, item of equipment,
person or procedure, and which is used as the basis for managing the hazard eg planning, measuring, control or audit - through the life cycle of the installation.
The regulation does not specify what performance standards should be - that
is for the duty holder to decide, taking account of the circumstances on the
particular installation.

46 The assessment feeds into the safety case. The information about fire and
explosion major accident hazards and those events requiring evacuation, escape
and rescue will contribute to the demonstration required by regulation 8(1)(c)
and (d) of SCR; and the measures taken to reduce risks will contribute to the
demonstration required by regulation 8(1)(d).
47 A summary of the assessment is required to be included in the safety case
(see regulation 24). Guidance on inclusion of the summary is given in paragraph
213, and paragraph 10 also explains the relationship with the safety case.
48 The assessment is only required to cover major accident hazards relating to
fire and explosion, and evacuation, escape and rescue. Measures for non-major
accident hazards should take into account the findings of the risk assessment
required by regulation 3 of MHSWR.
49 Compliance with this regulation will be sufficient to ensure compliance with

regulation 3 of MHSWR in respect of major accidents from fire and explosion and
major accidents resulting in evacuation, escape and rescue.
Page 15 of 56
Health and Safety

Executive
ACOP
50 The process of assessment should involve the following steps:

n

n
n

n

identifying fire and explosion major accident hazards, and major

accident hazards with the potential to require evacuation, escape or
rescue;
identifying the likelihood of them occurring and their consequences;
identifying the measures needed to meet the requirements of these
Regulations, in respect of major accident hazards from fire and
explosion, and major accident hazards requiring evacuation, escape and
rescue;
identifying performance standards for those measures to protect
persons from fire and explosion and to ensure effective evacuation,
escape and rescue.
51 There may be considerable iteration between the steps. The aim is

to come out of the assessment process with measures for the effective
management of fire and explosion hazards and for evacuation, escape and
rescue, and appropriate performance standards for them.
52 Although a wide range of potential major accident events may be
identified initially, duty holders should focus on those which are reasonably
foreseeable. These events should be considered in depth. The assessment
process should identify the factors which influence the way an event may
occur and develop, and which will affect the ability of any of the measures
put in place to deal with the hazard.
53 Assessment involves judgements against criteria or standards. Duty
holders should determine those criteria and assure themselves that they are
appropriate as part of the assessment process. The assessment process
should provide for a clear decision-making process. Assumptions should be
justified, and sensitivities identified and considered.
54 Interactions between safety systems, where the action of one may inhibit
the performance of the other, need to be identified and taken into account.
Any potential for a system to introduce or exacerbate a hazard should also be
identified and addressed.
55 In recording the assessment process enough information should be

provided to justify decisions on appropriate measures. Since the assessment
will form the basis for such matters as selecting plant and equipment, and
drawing up procedures, information from the assessment should be recorded
in an appropriate way and at an appropriate level of detail, to meet the needs
of those who may have to use it, including designers, management on the
installation, contractors, and auditors. For fire and explosion this should
include the causes, characteristics, likelihood and consequences of fire and
explosion hazards and the means to prevent, detect, control, and mitigate
their effects in an emergency.
Page 16 of 56
Health and Safety

Executive
ACOP
56 That part of the assessment dealing with evacuation, escape and rescue
should address:
n

n

n
n

n

the organisation and arrangements for the management of an

emergency which might lead to evacuation, escape and rescue,
including the formal command structure;
the means of evacuation - including type, capacity and location available for the evacuation of personnel from temporary refuge, muster
areas and other parts of the installation from which access to temporary
refuge is not readily available;
types, capacity and location of means of escape to the sea;
the performance of the rescue and recovery facilities, including their
function, capacity and availability;
the types, numbers and locations of personal survival and escape
equipment;
57 The assessment should identify the factors which might affect the
availability of the measures and arrangements. This should include the
environmental and weather conditions which may limit the capacity to carry
out effective evacuation, escape and rescue. Further guidance on effective
recovery and rescue arrangements is given in the ACOP and guidance to
regulation 17.
5
Guidance
58 Setting performance standards for measures is a crucial aspect of the

assessment process. Performance standards should relate to the purpose of
the system, item of equipment, procedure etc which they describe. They may
be described in terms of functionality, survivability, reliability and availability.
They should be measurable and auditable.
Further information
59 A guide to the Offshore Installations (Safety Case) Regulations 1992 L30
Guidelines on fire and explosion hazard management and Guidelines for the
management of emergency response for offshore installations, published by
UKOOA
Successful health and safety management HS(G)65 HSE Books

ISBN 0 7176 0425 X
Page 17 of 56
Health and Safety

Executive
Regulation 6 Preparation for emergencies

Regulation
(1) The duty holder shall establish such appropriate organisation and
arrangements as are to have effect in, or in anticipation of, an emergency and
which shall include arrangements (a) for command by competent persons which can be maintained, so far as
is practicable, throughout an emergency;
(b) for there to be a sufficient number of persons on the installation
competent to undertake emergency duties and operate relevant
equipment;
(c) in the case of an installation on which personnel are present, for a
sufficient number of such persons to be in attendance at the helicopter
landing area during helicopter movements; and
(d) for lists of persons referred to in sub-paragraphs (a), (b) and (c) above
to be posted at suitable locations on the installation when persons are
present.
(2) The duty holder shall ensure that every person on the installation -
6
Guidance
(a) is provided with adequate instruction and training in the appropriate

action to take in an emergency; and
(b) can consult written information on the use of emergency plant.
60 This regulation reflects the importance of adequate preparation for
emergencies. The regulation requires the duty holder to prepare for emergencies,
and identifies a number of key areas to address, including the command structure;
the selection and competence of personnel to undertake emergency duties; and
instruction and training for everyone on the installation on the appropriate action to
take in an emergency.
61 In complying with regulation 6(1) duty holders should ensure that they have
in place arrangements for effective management at all times and through all the
stages of an emergency; this will include contingency arrangements.
62 Regulation 6(1)(d) requires the duty holder to display lists of those with
emergency duties on the installation. Such lists may refer to the names of
individuals or, where appropriate, the relevant job positions, so long as it is clear to
everyone who needs to know who is responsible for specific emergency duties. In
the case of normally unattended installations such persons should be identified in
advance. They should carry with them to the installation the relevant notification,
so that the identity of those with emergency duties is clear to all those visiting the
normally unattended installation.
63 Competence is defined in regulation 6(5) of MHSWR as having sufficient
training and experience or knowledge and other qualities. Further guidance on
competence in relation to this regulation is provided in paragraph 69.
64 This regulation needs to be considered alongside regulation 8. Where other

PFEER regulations impact on management issues - for example, in complying
with the requirements of regulation 12 for controlling emergencies - further specific
guidance is provided in the guidance to those regulations. Elements of instruction
and training are also a vital part of general management systems and complying
with other PFEER regulations will require appropriate levels of instruction and
training.
Page 18 of 56
Health and Safety

Executive
Guidance
65 In making the arrangements to appoint persons to undertake emergency

duties, duty holders will need to consult safety representatives in line with
requirements in regulation 23 of SRSCR, as amended by regulation 23 of PFEER.
66 Section 2 of the HSW Act and regulation 11 of MHSWR require employers
to provide health and safety training. Nothing in this regulation changes those
requirements. But regulation 6 of PFEER places a duty on the operator or
owner both to ensure that appropriate emergency training has been provided by
employers - for example, training in personal survival - and, where appropriate, to
provide training themselves. This would include training on the emergency response
arrangements for the installation as the operator or owner is best placed to provide
this type of installation-specific training.
6
ACOP
67 Requirements for the provision of medics and first-aiders in emergency

situations are covered in the Offshore Installations and Pipeline Works (First-Aid)
Regulations 1989 (OFAR).
68 In establishing a command structure to comply with regulation 6(1)(a)
duty holders should take the following points into account:
n

n

n

one person should be given responsibility for taking overall charge in the
emergency. This should be the offshore installation manager (OIM)
and any circumstances when this would not be appropriate should be
identified, and a clear system established for someone other than the
OIM to take charge. Whoever is in charge should be given clear authority
to take decisions on emergency response;
the roles and responsibilities of those in the command structure should
be clearly defined and understood. Responsibilities vis--vis others, eg
the onshore emergency team, should be clear;
contingency arrangements should be drawn up, in case the person in
charge, or those with emergency duties, are unable to carry out their
role.
69 Those who have command responsibilities, or who have been allocated

emergency duties, must be competent. Duty holders should have a system to
assure themselves of the competence of the OIM and others in the command
team to manage in an emergency and of those who have specific duties in
an emergency. Competence can be gained through training, experience and
knowledge, backed up by practice and refresher training.
70 Duty holders should identify the tasks likely to be carried out during an
emergency. Duty holders should then ensure that in selecting people to carry
them out, no one is allocated conflicting tasks. During combined operations
duty holders will need to consider where people with emergency duties are
likely to be located under normal working arrangements, and ensure that
sufficient numbers of persons able to undertake the necessary emergency
duties are available on each installation.
71 Appropriate information, instruction and training on what to do in the

event of an emergency should be given to all persons on the installation
on or before arrival at the installation. This should include visitors and
all employees whether employed by the duty holder or by contractors.
It should include general training in emergencies, including training in
personal survival, installation-specific induction training and training based
on the emergency response plan. Duty holders should take steps to assure
themselves that the information, training and instruction given is sufficient for
people to be able to respond in an appropriate manner.
Page 19 of 56
Health and Safety

Executive
Guidance
Further information
72 Management of health and safety at work Approved Code of Practice L21 HSE
Books ISBN 0 7176 0412 8
Guidelines for offshore emergency training and Guidelines for the management of
emergency response for offshore installations, published by UKOOA
OPITO produces standards for emergency training in the offshore industry
First aid on offshore installations and pipeline works Approved Code of Practice
and guidance COP32 HSE Books ISBN 011 885472 0
Regulation 7 Equipment for helicopter emergencies

Regulation
7
Guidance
The duty holder shall ensure that there is kept available near the helicopter landing
area equipment necessary for use in the event of an accident involving a helicopter.
73 The purpose of the regulation is to ensure that the duty holder provides
equipment which might be needed to deal with an accident involving a helicopter,
including crash rescue equipment. The requirements of the regulation are additional
to those dealing with helicopter accidents involving fire and explosion, for which
provision would be made under regulations 9, 12 and 13. Equipment needed
for helicopter accidents should be adequate to deal with a range of reasonably
foreseeable accident scenarios as identified in the assessment required by
regulation 5. The purpose of the equipment should be to enable the timely and
effective rescue of persons involved in an accident. Equipment should be readily
identifiable and protected from the elements. It should be located so that it is
readily accessible for rapid deployment on the helideck.

74 Regulation 6(1)(c) requires a sufficient number of personnel trained to deal with
helicopter emergencies to be available during helicopter movements. Equipment
provided under this regulation will need to comply with regulation 19(1). Regulation
13 of MAR and associated guidance deals with normal day-to-day helicopter
operations.
Further information
75 Guidelines for the management of offshore helideck operations, published by
UKOOA
Offshore helicopter landing areas: a guide to criteria, recommended minimum
standards and best practice (chapter 5) CAP 437 Civil Aviation Authority
ISBN 0 86039558 8

Page 20 of 56
Health and Safety

Executive
Regulation 8 Emergency response plan

Regulation
(1) The duty holder shall, after consulting persons who are likely to become
involved in emergency response, prepare and, as often as is appropriate, revise
a document (in this regulation called the emergency response plan) containing
sufficient information, for the guidance of such persons, on (a) the organisation and arrangements which are to have effect in an
emergency; and
(b) procedures by way of emergency response to be followed in different
circumstances.
(2) The duty holder shall ensure that (a) the emergency response plan is available to all persons on the
installation; and
(b) each person on the installation, and each person who may be called
upon to assist in implementing the emergency response plan, are given
such notification of its contents as are sufficient for them.
(3) The duty holder shall ensure that the organisation, arrangements and
procedures referred to in paragraph (1) are tested, by practice and otherwise, as
often as may be appropriate.
8
Guidance
(4) Every person on the installation shall, in an emergency, so far as is

practicable, conform to the appropriate procedure in the plan.
76 This regulation requires the duty holder to prepare an emergency response
plan, which documents the organisation and arrangements for dealing with an
emergency on the installation. It requires duty holders to consult those who may
become involved in emergency response.
77 Organisation and arrangements will include the organisational structure
for handling emergencies, including the chain of command, the roles and
responsibilities of key people, communication arrangements and the action to be
taken in response to specific emergencies.
78 Procedures are the actions which specific people need to take in response
to particular emergencies. The emergency response plan should include
general procedures for everyone on the installation about what to do when
the alarm sounds. It should also include more detailed procedures on the role
and responsibilities of those with specific duties in an emergency. Although the
emergency response plan would not necessarily contain all the detailed procedures
required for different types of emergency, it should refer to them.
79 Regulation 8(1) requires duty holders to consult those who may become
involved in emergency response. Paragraph 83 of the ACOP gives some specific
guidance on complying with this requirement. In addition, duty holders should
take into account the range of organisations who may become involved in an
emergency and who may be able to offer constructive comment on specific
aspects of the emergency response plan. This might include owners of vessels
who provide recovery and rescue facilities; local authority fire services, which have
particular expertise in fire-fighting and could make a useful contribution to the
preparation of emergency plans for emergencies involving fire. It would also include
the police, and other emergency services, who would be likely to have a role in
shore-based aspects of the emergency.
Page 21 of 56
Health and Safety

Executive
Guidance

80 The organisation and arrangements and procedures to be covered in the
plan will need to reflect the preparatory arrangements required by regulation 6, and
some of the specific measures required by regulations 10-17.
81 Regulation 7 of MHSWR requires employers to draw up emergency
procedures. This regulation builds on the requirement by making specific provision
for an emergency response plan. It also places the duty to draw up the plan on the
operator or owner, in recognition of who is best placed to co-ordinate emergency
response on the installation. Appendix 1 of this publication provides guidance on
how the duty of co-operation in MAR might apply in emergency situations.
8
ACOP
82 The emergency response plan should also include arrangements for medical
and first-aid provision under OFAR.
83 The duty holder should consult and take into account the views of those
who are likely to have a role in implementing the plan. This should include
HM Coastguard who will be able to advise on aspects of the plan dealing
with evacuation, escape, recovery, and search and rescue. It should also
include pipeline owners, and operators and owners of other installations,
as necessary to ensure that the emergency response plan reflects their
agreement on the circumstances in which it may be necessary to shut down
a pipeline as part of emergency response and procedures to be followed.
Duty holders should also consult internally with those who will be affected by,
or need to play a part in, the plan. In particular, safety representatives should
be consulted (regulation 23(b) of SRSCR).
84 The plan should cover the arrangements and procedures needed to
respond to all reasonably foreseeable emergencies, ie it should set out
who does what, when, where, how and to what effect, in the event of an
emergency. It should describe both the offshore and onshore arrangements
and ensure that they dovetail. It should reflect the arrangements made under
regulation 6, and should cover all stages of the emergency from the time
it is detected until it is over. The plan should indicate the point at which it
should be initiated, and give guidance on the factors to consider in choosing
particular courses of action, including the choice of external evacuation,
rescue and recovery services in specific circumstances. It should be concise,
readable, and in a format which can be used readily in real emergencies, as
well as in training, exercises and drills.
85 The plan should be exercised and tested with sufficient frequency and
depth so that it can be relied upon to work effectively in an emergency,
taking into account the range of different people who may be involved in
implementing the plan. The plan should be monitored and reviewed in the
light of exercises and tests and of any practical experience gained from
operating the plan in a real emergency, and remedial action identified and
taken.
Page 22 of 56
Health and Safety

Executive
Guidance
Further information
86 Guidelines for the management of emergency response for offshore
installations, published by UKOOA
Management of health and safety at work Approved Code of Practice L21
Offshore Installations (Safety Representatives and Safety Committees) Regulations

1989 SI 1989/971 HMSO ISBN 0 11 096971 5
Regulation 9 Prevention of fire and explosion

Regulation
(1) The duty holder shall take appropriate measures with a view to
preventing fire and explosion, including such measures to (a) ensure the safe production, processing, use, storage, handling,
treatment, movement and other dealings with flammable and explosive
substances;
(b) prevent the uncontrolled release of flammable or explosive substances;
(c) prevent the unwanted or unnecessary accumulation of combustible,
flammable or explosive substances and atmospheres; and
(d) prevent the ignition of such substances and atmospheres.
(2) The measures to prevent ignition referred to in paragraph (1) shall
include -
9
Guidance
(a) identifying and designating areas in which there is a risk of a flammable

or explosive atmosphere occurring;
(b) controlling the carrying on of hazardous activities in such areas;
(c) ensuring that, save under procedures pursuant to sub-paragraph (b)
above, no plant is used in such areas unless suitable for use within them;
and
(d) controlling the placing or use in such areas of electrical fixtures or other
sources of ignition.
87 This regulation requires the duty holder to take appropriate measures to
prevent fire and explosion. In general, the best way to achieve this is to eliminate
the hazard by design. Where this is not practicable, prevention will need to be
achieved in other ways, eg through design measures, engineering and procedural
controls or management systems. Regulation 9(1)(a)-(d) sets out some specific
goals which the duty holder must meet in order to prevent a fire and explosion.
These relate only to the contribution such measures make to preventing fire and
explosion, and are to be considered in the context of the overall requirement of
regulation 9(1) to take appropriate measures with a view to preventing fire and
explosion.
Page 23 of 56
Health and Safety

Executive
Guidance
88 Good design is the most effective means of preventing fire and explosion. This
involves addressing issues such as:
n

n

n
the choice of process and production method to minimise the risk of fire and
explosion;
the need to minimise the frequency, rate and quantity of releases by, for
example, reducing the number of release points and addressing causes of
failure, and limiting the inventory available for release;
optimising the plant layout.
89 Regulation 9(2) includes some specific measures which need to be taken to

prevent ignition, including the classification of areas where there may be a risk of
an accumulation of flammable or explosive atmospheres. But the specific measures
set out in regulation 9(2) are without prejudice to any other measures which may be
needed, in the light of the hazards, and the circumstances of the installation.
90 The regulation requires duty holders to address fires and explosions from all
sources, eg fires in accommodation areas and storage areas besides fires and
explosions arising from loss of well control or from process plant. But the scope of
the regulation does not prevent flammable or explosive atmospheres accumulating
where they are permitted by design, for example within process plant.
9
ACOP
91 The assessment required by regulation 5 and the requirements of regulation

19(1) are relevant. Equipment provided and measures taken to comply with this
regulation may also be used to facilitate compliance with others. For example,
equipment used to prevent a fire may also have a role in controlling fires and
explosions. The requirements of PUWER also apply to plant where this is work
equipment for the purposes of those Regulations. Companies handling explosives
offshore are also subject to the requirements of the Placing on the Market
and Supervision of Transfers of Explosives Regulations 1993 (SI 1993/2714)
(POMSTER). The requirements for permits-to-work in regulation 10 of MAR are also
relevant.
92 Prevention measures, including the designation of areas where there
may be a particular risk that flammable and explosive atmospheres could
accumulate, for major accident hazards from fire and explosion should be
based on the assessment required by regulation 5.
93 In determining appropriate measures, duty holders should take account
of the principles of risk control and hazard management set out in paragraph
38. The most important principle is that prevention should be achieved by
designing out the hazard or in so far as the hazard cannot be designed out,
reducing it by an appropriate combination of engineering measures and
procedural or managerial controls.
94 Measures should be designed to achieve sufficient levels of reliability

and availability to meet the demands placed upon them.
Page 24 of 56
Health and Safety

Executive
ACOP
95 Measures to control activities which might lead to a release or ignition

hazard should include adequate procedures and arrangements for:
n

n
n

9
Guidance
control of hot work, eg welding, flame-cutting, and use of electrical

equipment not designed for use in areas of flammable and explosive
atmospheres;
control of maintenance activities;
control of modifications, start-up and shut-down of plant and equipment,
storage, handling and use of flammable substances.
96 Personnel required to implement procedures should be competent to

do so; adequate training, supervision and information about the hazards
should be provided. Human factors issues should be identified and taken into
account in the design of procedures and systems.
Further information
97 Guidelines on fire and explosion hazard management, published by UKOOA
Electrical apparatus for use in potentially explosive atmospheres HS(G)22 HSE
Books ISBN 0 11 883746 X
British Standard 5345 Code of practice for selection, installation and maintenance
of electrical apparatus for use in potentially explosive atmospheres
British Standard 5501 Electrical apparatus for potentially explosive atmospheres
Model code of safe practice in the petroleum industry: Part 15: Area classification
code for petroleum installations Institute of Petroleum ISBN 0 47 192160 2
Classification of areas for electrical installation at drilling rigs and production facilities
on land and marine fixed and mobile platforms American Petroleum Institute (API
recommended practice 500B)
Oil Industry Advisory Committee Guidance on permit-to-work systems in the

petroleum industry HSE Books ISBN 0 7176 1281 3 and The safe isolation of plant
and equipment HSE Books ISBN 0 7176 0871 9
Regulation 10 Detection of incidents

Regulation
The duty holder shall take appropriate measures (a) with a view to detecting fire and other events which may require
emergency response, including the provision of means for (i)
(ii)
10
detecting and recording accumulations of flammable or toxic gases;

and
identifying leakages of flammable liquids; and
(b) with a view to enabling information regarding such incidents to

be conveyed forthwith to places from which control action can be
instigated.
Page 25 of 56
Health and Safety

Executive
Guidance
98 This regulation requires the duty holder to take appropriate measures to

detect emergencies. This means that detection measures need to be provided for
the full range of reasonably foreseeable events which require emergency response.
Regulation 10(a)(i) and (ii) contains some specific requirements for provision
of means for detecting and recording flammable and toxic gas and identifying
leakages of flammable liquids.
99 Detection arrangements will vary widely according to the type of incident to be
detected. The following are illustrative examples:
(a) particular vigilance where automatic detection is not available, for example,
during overside working where there may be a risk of a person falling
overboard;
(b) use of radar by a standby vessel or on an installation to detect an
approaching vessel;
(c) systems relying substantially on responsible staff, eg monitoring of incoming
helicopter flights; diving operations; supply vessel operations;
(d) automatic detection systems for fire, heat, smoke, flammable and toxic gas;
and
(e) ballast control room inclinometers; mooring tension gauges; position
monitoring systems.
100 This paragraph explains a number of important terms used in the regulation:
n

n

n

n

detecting and recording accumulations of flammable or toxic gases means

that the duty holder should take steps to ensure that predetermined levels of
gas in a designated location are detected and that a record is kept of all
instances where gas is detected at or above a level which prompts automatic
or manual executive action;
identifying leakages of flammable liquids requires measures to detect those
leakages which could reasonably be foreseen to give rise to an emergency. In
some circumstances these measures could be procedural, eg plant watch
keeping tours. For incidents where a quick response is required detection
equipment linked to automatic action might be necessary;
forthwith in the context of regulation 10(b) means without delays that would
jeopardise the instigation of control action;
information regarding such incidents refers only to information that needs to
be conveyed to enable control action to be taken.
10
ACOP
10
101 The assessment required by regulation 5 is relevant to measures for detecting

major accident hazards. Detection measures need to be considered in conjunction
with the communication arrangements required by regulation 11, control measures
required by regulation 12 and, for fire and explosions, mitigation measures required
by regulation 13. Regulation 19(1) provides for the suitability and maintenance of
all detection plant provided under this regulation. All the requirements of regulation
19 will apply to plant provided for detecting fire and for detecting and recording
accumulations of flammable gases.
102 Detection measures for major accident hazards should be based on
the findings of the assessment required by regulation 5. The risk assessment
made under MHSWR will also be relevant for non-major accident hazards.
Page 26 of 56
Health and Safety

Executive
ACOP
103 Detection systems should be appropriate for the range of incidents

for which they may be needed. Detection systems should provide sufficient
levels of availability and reliability to meet the demands placed on them,
Equipment should be appropriately located, taking account of the type
of incident, how it may develop, and the capacity of the equipment to
respond and to relay the right information for effective control action to take
place. Detection measures should be automatic where this is reasonably
practicable. Transmission of information from detection systems to the point
at which control action is instigated should also be automatic where this is
reasonably practicable. Where detection and relay of information cannot be
done automatically, adequate arrangements should be in place to detect
incidents and to instigate control action.
104 Detection systems for fire and explosion hazards should be able to
ensure the timely detection of flammable and explosive atmospheres, and
toxic gas where appropriate. Appropriate measures include automatic
systems which detect flammable and explosive atmospheres, and toxic gas
and smoke where their presence presents a risk to people, or where there
is non-automatic plant necessary for the safety of people. Such areas are
likely to include accommodation and work areas, control points, enclosed or
partially enclosed routes to temporary refuge and to evacuation and escape
points, and evacuation and escape points.
10
105 Duty holders should establish effective contingency arrangements

for circumstances when all or part of the detection system is not available
because of maintenance or because of damage during an emergency,
Detection systems need to remain operational during the emergency to the
extent necessary to do the job required of them.
Guidance
Further information
10
Guidelines on fire and explosion hazard management, published by UKOOA
Regulation 11 Communication
Regulation
(1) The duty holder shall make appropriate arrangements (a) for giving warning of an emergency, by audible and, where necessary,
visual alarm systems, to all persons on the installation; and
(b) for the purpose of emergency response, for communication between (i)
(ii)
persons on the installation;

the installation and persons not on it and engaged in activities in
connection with it; and
(iii) the installation and persons beyond it;
11
and shall ensure that, so far as is reasonably practicable, the arrangements are
capable of remaining effective in an emergency.
Page 27 of 56
Health and Safety

Executive
Regulation
(2) Subject to paragraph (3), the duty holder shall ensure that (a) an illuminated sign provided pursuant to paragraph (1) (a) is(i)
(ii)
in the case of a warning of toxic gas, a red flashing sign; and

in all other cases, a yellow flashing sign; and
(b) an acoustic signal provided pursuant to paragraph (1) (a) is (i)
in the case of a warning to prepare for evacuation, a continuous

signal of variable frequency;
(ii) in the case of a warning of toxic gas, a continuous signal of a
constant frequency; and
(iii) in all other cases, an intermittent signal of a constant frequency.
11
Guidance
(3) Where an illuminated sign or acoustic signal is in lawful use immediately

before the date of coming into force of these Regulations, but it does not meet the
requirements of paragraph (2), it shall be sufficient compliance with that paragraph
if a change to a sign or signal so complying is made before 20th December 1997.
107 This regulation requires the duty holder to make appropriate arrangements
for rapidly alerting all personnel on the installation that an emergency has occurred,
or is occurring. The acoustic signal and colour of lights used for general platform,
prepare to abandon and toxic gas alarms are specified in the Regulations, which
reflect the industry agreed standard. It is not necessary to provide a toxic gas alarm
where there is no toxic gas hazard.
108 On some installations lights may be used to provide information and warning
in addition to the general platform, prepare to abandon and toxic gas alerts.
The colours of information and warning lights provided for purposes other than
general platform, prepare to abandon and toxic gas alerts, are not specified in
this regulation. However, such lights - if their function is to give warning rather
than information - may still be subject to the Health and Safety (Safety Signs and
Signals) Regulations 1996 (SSR). In addition, duty holders should ensure that there
is no conflict or possibility of confusion between such lights and those provided in
compliance with regulation 11(2)(a) for general platform, prepare to abandon and
toxic gas alerts.
11
109 The regulation requires arrangements for communications between persons

on the installation for the purpose of emergency response. This would include
those responsible for the management of the emergency and those persons
with specific emergency duties. It also includes arrangements for communicating
information to all personnel on the installation. The regulation also requires
arrangements for communications with persons engaged in activities in connection
with the installation, such as diving, heavy lifts or supply vessel operations, and
with persons not on the installation who have a role in the emergency plan.
Arrangements are needed to alert those persons to an incident on the installation,
and for those persons to communicate with personnel on the installation. This
might include HM Coastguard, other installations, shore-based personnel and
rescue and recovery services. Where the incident is likely to lead to an evacuation,
the Coastguard should be alerted and this should be provided for in the emergency
response plan.
Page 28 of 56
Health and Safety

Executive
Guidance
110 During an emergency communications have a vital role and the regulation
therefore requires duty holders to do what is reasonably practicable to ensure
that the alarms and communications arrangements remain available during the
emergency. This means that duty holders will need to consider not only the events
for which alarms and communications might be necessary but also the impact
of the various emergencies on the effectiveness of those arrangements. Where
appropriate contingency arrangements should be put in place.
111 The effectiveness of communications in an emergency depends heavily on
the ability of those who operate communications equipment. Duty holders should
ensure that such personnel are competent, and have clear procedures to follow.

112 This regulation needs to be considered alongside: regulation 6, which covers
the preparatory arrangements for an emergency, eg the requirement for persons
with emergency duties to be competent; regulation 8, which requires such matters
to be set out in the plan; and regulation 14(4)(b), which covers procedures for
mustering. The assessment required by regulation 5 is relevant. Regulation 19(1)
provides for the suitability and maintenance of all plant provided in compliance with
regulation 11. The whole of regulation 19 will apply for plant provided for giving
warning of an emergency under regulation 11(1)(a).
11
ACOP
11
113 The SSR Regulations set out requirements for safety signs, including acoustic
signals and illuminated signs for use in emergencies. SSR specify tones, colours
and other matters. However, the tones of acoustic signals and the colours of
the illuminated signs specified in PFEER, regulation 11(2) will take precedence in
respect of the signals and signs required under PFEER, regulation 11(1)(a).
114 Arrangements should be based on the findings of the assessment
required by regulation 5 for major accident hazards and should take into
account the findings of the risk assessment required by regulation 3 of
MHSWR for non-major accident hazards. The alarm and communication
systems provided should be appropriate for the range of reasonably
foreseeable emergencies identified by the duty holder and capable of
performing their function during the emergency. They should be capable of
transmitting clear information to personnel wherever they are likely to be on
the installation, taking account of the conditions likely to be encountered
in an emergency. In areas where an acoustic alarm may not be audible
above the ambient noise level, a visual alarm should also be provided to
alert persons in the area that an emergency message is being transmitted
and to enable them to take appropriate action. Where the method of raising
the alarm does not automatically initiate general visual or acoustic alarms,
there should be clear procedures for instituting the appropriate alarm and
conveying information to the relevant personnel.
115 Duty holders should ensure that everyone on the installation is aware
of the meaning of different alarm signals, and this should be included in
installation induction and refresher training.
Page 29 of 56
Health and Safety

Executive
Guidance
Further information
Signpost to the Health and Safety (Safety Signs and Signals) Regulations 1996
IND(G) 184L (free leaflet available from HSE Books)
Health and Safety (Safety Signs and Signals) Regulations 1996 (SI 1996/341)
HMSO ISBN 0 11 054093 X
11
Safety signs and signals Guidance on Regulations L64 HSE Books

ISBN 0 7176 0870 0
Regulation 12 Control of emergencies

Regulation
The duty holder shall (a) take appropriate measures with a view to limiting the extent of an
emergency, including such measures to combat fire and explosion; and
(b) shall ensure that(i)
(ii)
12
Guidance
where appropriate, those measures include provision for the remote

operation of plant; and
so far as is reasonably practicable, any arrangements made and
plant provided pursuant to this regulation are capable of remaining
effective in an emergency.
117 Regulation 12 covers all types of emergencies, including fire and explosion
to which the regulation specifically refers. The purpose of the regulation is for duty
holders to have appropriate control measures to limit escalation of an emergency.
Control measures may comprise structural measures, operational and management
procedures, plant and equipment, and their control systems.
118 Control in the context of this regulation includes measures to monitor the
extent of an emergency for the purpose of exercising managerial command and
control.
119 This paragraph explains a number of important terms used in the regulation:
12
n

n

n

measures has the same meaning as in paragraph 35. In the context of this
regulation measures for control purposes include plant, equipment and
workplace procedures. Examples are listed in the box below;
to remain effective in an emergency, arrangements and plant should, so far as
is reasonably practicable, be capable of remaining operational in an
emergency, for as long as they are needed to fulfil their functions, taking into
account the conditions to which they may be exposed;
remote operation in the context of this regulation refers to plant to control the
hazard which is operated away from the immediate hazard.
Page 30 of 56
Health and Safety

Executive
Guidance
ESD systems
ballast control system
vents and drains
emergency response procedures, ie sending key personnel to determine the
appropriate actions
automatic isolation valves
blowdown and flare systems
portable fire-fighting equipment

120 The SCR Regulations require the safety case to demonstrate that adequate
facilities are provided within the temporary refuge for the monitoring and control of
incidents involving explosion, fire, heat, smoke, toxic gases or fumes. Regulation 12
is a broader requirement for control measures for all types of emergencies. Control
measures for major accident hazards should take account of the assessment
required by regulation 5 of PFEER, and for non-major accident hazards the
assessment required by regulation 3 of MHSWR.
121 Equipment provided and measures taken in compliance with this regulation
may also be used in compliance with others. For example, equipment used to
control the extent of a fire may also have a role in preventing or mitigating fires and
explosions. The requirements in regulation 6 for persons with emergency duties
to be competent will apply to those who have to undertake control actions in an
emergency. Plant provided under this regulation will be subject to regulation 19(1).
Plant provided to combat fire and explosion will be subject to all the requirements
of regulation 19.
12
ACOP
122 There are also specific requirements in respect of emergency shut-down

valves in the Pipelines Safety Regulations (SI 1996/825).
123 For major accident hazards, measures should be based on the
assessment required by regulation 5. For non-major accident hazards,
measures should be appropriate in terms of scale, duration, frequency and
effectiveness.
124 Equipment used to control the extent of an emergency should, so far as
is reasonably practicable, be designed on the principle that it does not fail to
danger. Additionally, the design of such equipment should take into account
human factors - including ergonomic factors -with respect to its operation in
an emergency.
12
125 Plant used to limit the spread of fire should, where appropriate, be
operable from a safe location.
Page 31 of 56
Health and Safety

Executive
ACOP
126 Appropriate measures to control the emergency should include suitably

staffed control points which can be used safely, so far as is reasonably
practicable, for the period necessary to control the emergency. Control points
will vary between installations and according to the nature of the incident.
Some installations may provide a central control point, though local control
points may be necessary depending on the hazards, and the systems needed
to control the hazards. Control points should be appropriately staffed, taking
account of the type of installation, and the events for which control points
are needed. For normally attended installations central control points should
be staffed at all times. For normally unattended installations appropriate
arrangements need to be made to ensure that necessary control action
can be taken in an emergency to ensure an effective response. Personnel
allocated to control points should be competent for the range of duties
required of them.
12
127 Measures should provide for the timely and effective shut-down of
systems which could exacerbate an emergency; for example, by providing a
source of ignition for flammable releases or by escalating a fire and/or release
of toxic gas or fumes. Emergency shut-down should be capable of initiation
from the control point.
Guidance
Further information
128 A guide to the Offshore Installations (Safety Case) Regulations 1992 (page 71,
paragraph 106) L30 HSE Books ISBN 0 11 8820559
Offshore installations: guidance on design construction and certification (sections
90 and 91) HSE Books ISBN 0 11 8821164
12
A guide to the Pipelines Safety Regulations 1996 L82 HSE Books

ISBN 0 7176 1182 5
Regulation 13 Mitigation of fire and explosion

Regulation
13
Guidance
13
The duty holder shall (a) take appropriate measures with a view to protecting persons on the
installation during an emergency from the effects of fire and explosion;
and
(b) ensure that, so far as is reasonably practicable, any arrangements made
and plant provided pursuant to this regulation are capable of remaining
effective in an emergency.
129 Regulation 13 requires the duty holder to put in place measures that will
mitigate the effects of fire and explosion, ie to protect persons on the installation
from them. The duty holder must take into account not just direct hazards to
persons, but also hazards to structures or plant upon which their safety depends.
Measures include active and passive measures to mitigate the effects of fire and
explosion.
Page 32 of 56
Health and Safety

Executive
Guidance
130 This paragraph explains some of the important terms used in the regulation:
n

n

measures has the same meaning as in paragraph 35. In the context of this
regulation measures may provide active or passive protection, and include
plant, equipment, structures and workplace procedures. Examples of these
are set out in the box below;
to remain effective in an emergency, mitigation measures should, so far as
is reasonably practicable, be capable of remaining operational in major
accident conditions, for as long as they are needed to fulfil their functions,
taking into account the conditions to which they may be exposed.
deluge systems
fixed extinguishing systems
fire-resistant coatings
manual response equipment and procedures
ventilation control systems
fire and blast walls
13
ACOP
131 The assessment required by regulation 5 and the requirements for plant in
regulation 19 are relevant to this regulation. Equipment provided and action taken
in compliance with this regulation may also be used in compliance with others. For
example, equipment used to mitigate the effect of a fire or explosion may also have
a role in controlling fires.
132 The measures selected for major accident hazards should be based
on the assessment required by regulation 5. The roles of different measures
should be considered in an integrated way so that the functioning of one
measure does not prevent another from meeting its required performance
standard.
133 The measures taken should:
n
n

n

n

13
be appropriate for the hazards;

include provision of appropriate fire-fighting media and portable
equipment;
provide for automatic systems, or manual operation where this can be
justified in the assessment;
provide adequate levels of protection for key locations (eg temporary
refuge and escape routes) and emergency systems where they have
been identified as requiring protection.
134 Fire and blast barriers should be capable of providing the insulation,
stability, integrity, and overpressure resistance identified as necessary for
the period required to protect personnel, structures and plant. Duty holders
should identify from the assessment any conflicts between blast and fire
protection measures and consider how to achieve the best balance between
them.
Page 33 of 56
Health and Safety

Executive
ACOP
135 The objective of active systems should be to deliver the required

quantities of the fire-fighting media within the required time to the required
locations.
136 In determining what portable equipment is to be provided duty
holders should take into account the numbers and location of personnel
on the installation, the practicality of its effective use, the hazards and the
availability of other systems.
13
137 For measures to remain effective in an emergency duty holders will

need to consider suitable contingency arrangements, including operational
arrangements and diversity and redundancy in protective systems. These
should take into account the hazards, the role of the system in mitigating
them and the consequences of its failure, where all or part of the main system
may be unavailable; for example, because of damage during an accident,
or when equipment is undergoing maintenance. They should also take into
account any increased vulnerability to the system as a whole by the addition
of redundancy.
Guidance
Further information
138 Offshore installations: guidance on design construction and certification
(section 13) HSE Books ISBN 0 11 882116 4
13
Regulation 14 Muster areas etc.

Regulation
(1) The duty holder shall make appropriate provision for (a) areas for persons to muster safely in an emergency (in these Regulations
referred to as muster areas);
(b) safe egress from accommodation and work areas, and safe access to
muster areas, temporary refuge, and evacuation and escape points; and
(c) safe evacuation and escape points.
(2) The duty holder shall ensure that the muster areas, egress, access and
evacuation and escape points referred to in paragraph (1) (a) are kept unobstructed;
(b) are provided with adequate emergency lighting; and
(c) are marked by suitable signs,

and shall take appropriate measures to ensure that, so far as is

reasonably practicable, the egress and access remain passable in an
emergency.
(3) The duty holder shall ensure that (a) doors for use in an emergency (i)
14
(ii)
open in the appropriate direction or, if this is not possible, are

sliding doors; and
are not so fastened that they cannot readily be opened by any
person who may require to use them in an emergency; and
Page 34 of 56
Health and Safety

Executive
(b) accommodation areas are provided at each level with at least two means
of egress situated a proper distance apart.
Regulation
(4) The duty holder shall (a) ensure that(i)

(ii)
each person on the installation is assigned to a muster area; and

for each muster area a list of names of persons assigned to it is
kept up-to-date and displayed; and
(b) establish procedures (i)

(ii)
14
Guidance
for mustering at such areas; and

for accounting for persons.
139 The regulation requires the duty holder to make provision for personnel on
the installation to assemble safely while the emergency is assessed and control
action taken. It also requires provision for personnel to access safely means for
leaving the installation if necessary. This should include sufficient available routes so
that persons can safely get to:
n

n
muster areas and temporary refuge from wherever they are likely to be on the
installation;
evacuation and escape points from the muster areas and temporary refuge.
140 Everyone on the installation should be assigned to a muster area and know
where it is. The regulation also requires the duty holder to put in place procedures
for accounting for personnel. This should cover both the circumstances where
personnel have the opportunity to muster, and where immediate evacuation is
required.
141 The access and egress routes and muster areas and evacuation and escape
points required by the regulation should be clearly identifiable, with adequate
emergency lighting so that they may still be used if normal lighting fails.
142 In determining what constitutes a proper distance apart to comply with
regulation 14(3)(b) duty holders should take into account the risks to personnel and
the need to ensure that in the event of an incident there remains available at least
one exit leading to a safe access or egress route.
14
143 This regulation should be considered in conjunction with SCR, Schedules

1-3 which specify that safety cases include particulars of temporary refuge and
associated facilities for protecting persons on the installation from hazards of
explosion, fire, heat, smoke, toxic gases or fumes. Under regulation 14 duty
holders will also need to consider providing muster areas in addition to temporary
refuge, for dealing with those identified emergencies for which the temporary refuge
may not be relevant, eg structural failure or, for a mobile installation, loss of stability.
Page 35 of 56
Health and Safety

Executive
Guidance
15
ACOP
144 It should also be considered in conjunction with the requirements of

regulations 15 and 16 for arrangements for evacuation and escape, and the
requirements in regulation 18 and PPEWR for personal protective equipment for
use in an emergency. The muster arrangements required by regulation 14(4) should
be developed in conjunction with the arrangements required by regulation 6 and
should be reflected in the plan required by regulation 8. The communications
facilities at muster points should be developed in conjunction with other
communications arrangements provided to comply with regulation 11. Regulation
19(1) also applies to any plant provided in compliance with regulation 14.
145 Muster points should remain usable, and access and egress routes
passable for the time required to safeguard personnel, based on the
scenarios identified in the assessment and the emergency response plan.
This may be achieved by various means but protecting routes should be
given priority over providing personal protective equipment, which should
be regarded as a last resort. Muster areas need to be clearly identified,
protected from the immediate effects of the emergency and provided with
appropriate communications facilities, so that information can be passed
on the progress of the emergency and further action may be taken where
necessary.
146 Adequate emergency lighting should include, where appropriate, floor
level illumination and direction of escape indicators.
14
147 Personnel should be given appropriate information about the location of

their muster station, including alternatives, and arrangements for mustering,
as soon as they arrive on the installation. This should be part of the
arrangements required by regulation 6 (see paragraph 71 of the ACOP).
Guidance
Further information
148 Offshore installations: guidance on design construction and certification
(sections 10, 53 and 90) HSE Books ISBN 011 882116 4
Guidelines on fire and explosion hazard management and Guidelines for the
management of emergency response for offshore installations, published by
UKOOA
A guide to the Offshore Installations (Safety Case) Regulations 1992 (pages 26-38,
71) L30 HSE Books ISBN 0 11 8820559
14
Health and Safety (Safety Signs and Signals) Regulations 1996 (SI 1996/341)
HMSO ISBN 0 11 054093 X
Regulation 15 Arrangements for evacuation

Regulation
15
The duty holder shall ensure that such arrangements are made which include, to
the extent necessary (a) the provision of plant on the installation; and
(b) such arrangements with suitable persons beyond the installation, as
will ensure, so far as is reasonably practicable, the safe evacuation
of all persons and their being taken to a place of safety, or to a place
from which they can be recovered and taken to a place of safety under
arrangements made pursuant to regulation 17.
Page 36 of 56
Health and Safety

Executive
Guidance
149 The regulation requires the duty holder to make suitable arrangements for
all persons to leave the installation safely in the event of an emergency which
requires evacuation, and to be taken to a place of safety. The regulation covers the
means of evacuation which the duty holder may provide on the installation, such
as TEMPSC, and the arrangements the duty holder may make with others off the
installation, such as helicopter operators.
150 The regulation is phrased in terms that duty holders have to ensure that
arrangements are made. This recognises that duty holders may be dependent on
the actions of others to achieve safe evacuation (for example search and rescue
services). Duty holders themselves are not therefore required to take all the actions
needed during an evacuation; but rather to ensure arrangements are made for
actions to be taken, as necessary, by others. Arrangements made should be
agreed between the parties and documented, for example in the assessment and
emergency response plan.
151 For some mobile installations the practice has been for operators to
contribute to the arrangements for evacuation, recovery and rescue. The regulation
is worded to allow for this; the duty is to ensure that the arrangements have been
made, and this would include an arrangement whereby the owner of the mobile
installation had agreed that the relevant operator would make the arrangements.
The duty of co-operation in MAR is relevant here (see Appendix 1).
152 This paragraph explains some important terms used in the regulation:
n

n

evacuation is defined in regulation 2 (see paragraph 20); means of evacuation

may include helicopters, direct sea transfer, bridge-links, and TEMPSC;
place of safety means an onshore or safe offshore location or vessel where
medical treatment and other facilities for the care of survivors are available.
15
ACOP
15
153 The arrangements required by this regulation should take into account the
findings of the assessment required by regulation 5. Where the arrangements
depend on the co-operation of others, the duty of co-operation in regulation
8 of MAR is relevant; guidance on this is given in Appendix 1. The evacuation
arrangements will need to be covered in the emergency response plan required by
regulation 8 of the PFEER Regulations. Regulation 19 will apply to plant provided in
compliance with regulation 15. Regulation 20 is also relevant.
154 Duty holders should select means of evacuation on the basis of their
contribution to reducing the risks of those who might have to use them to as
low as is reasonably practicable. When making arrangements for evacuation
duty holders should identify and take into account any constraints on their
use by weather conditions, the nature and location of the emergency and the
time available to evacuate. There are a number of means of evacuation and
the preferred means should be the normal means of getting persons to and
from the installation, unless the emergency, or the circumstances in which
it takes place, makes this impracticable. Alternative means of evacuation
should be provided to take account of scenarios where the normal means of
getting persons to and from the installation could not operate because of the
nature of the incident, or because of environmental or weather conditions, or
because of insufficient capacity to evacuate everyone in the time available.
Page 37 of 56
Health and Safety

Executive
ACOP
155 Duty holders should ensure that the preferred and alternative means of
evacuation provide sufficient capacity to enable all persons to evacuate the
installation to a place of safety in reasonably foreseeable emergencies. In
most cases alternative means would be means of evacuation by sea provided
by TEMPSC. In these circumstances there should be sufficient TEMPSC
places for 150% of the persons on board, unless an alternative standard is
justified, or called for, on the basis of the assessment required by regulation
5. Means of evacuation by sea should be suitably located so as to be readily
accessible to all persons on board from temporary refuge. TEMPSC provided
in compliance with this regulation should be easy to deploy, reliable in launch,
and able to get away quickly from the installation. Where it is reasonably
practicable to do so, TEMPSC should be oriented away from the installation
on completion of launch,
15
156 In certain circumstances, justified in the assessment required by

regulation 5, it may only be reasonably practicable to rely on one evacuation
system. In these circumstances duty holders should make arrangements for
the preferred means of evacuation to remain available while personnel are on
the installation. Where the nature of the incident makes that impracticable,
duty holders should ensure that their arrangements for escape do not put
personnel at more risk than they would have been had an alternative means
of evacuation by sea been available.
Guidance
Further information
157 A guide to the Offshore Installations (Safety Case) Regulations 1992
(Schedule 4 guidance on combined operations) L30 HSE Books
ISBN 0 11 882055 9
15
Guidelines for the management of emergency response for offshore installations,

published by UKOOA.
Regulation 16 Means of escape

Regulation
16
Guidance
The duty holder shall provide such means as will ensure, so far as is reasonably
practicable, the safe escape of all persons from the installation in case
arrangements for evacuation fail.
158 The regulation requires the duty holder to provide means of escape so
that persons may escape from the installation in the event of the failure of
the evacuation system in a catastrophic incident when a planned and orderly
evacuation cannot be achieved.
159 This paragraph explains some of the terms relevant to the regulation:
16
n

n

escape means the process of leaving the installation in an emergency when

the evacuation system has failed; it may involve entering the sea directly and
is a last resort method of getting persons off the installation;
means of escape cover items which assist with descent to the sea, such as
davit-launched life-rafts, chute systems, ladders, and individually controlled
descent devices; and items in which personnel can float on reaching the sea,
such as throw-over life-rafts.
Page 38 of 56
Health and Safety

Executive
Guidance
16
160 The provision of means of escape required by this regulation should be

based on the findings of the assessment required by regulation 5. The escape
arrangements should be set out in the emergency response plan required by
regulation 8. Training requirements are set out in regulation 6. Other requirements
relevant to the suitability and maintenance of means of escape are in regulations 19
and 20.
ACOP
161 Duty holders should select means of escape on the basis of their
contribution to reducing the risks of those who may have to escape from
the installation to as low as is reasonably practicable. This means that
duty holders should give preference to means which offer some protection
from the elements and avoid the need to enter the sea directly. In addition,
sufficient means of descent to the sea should be provided on all installations,
including fixed ladders or stairways, where reasonably practicable, and
personal devices for controlled descent.
16
162 The duty holder should provide enough means of escape to ensure
that they are available for all personnel who may have to use them. Duty
holders should also ensure that means of escape and any protective clothing
provided for use in an emergency are compatible.
Guidance
Further information
16

Regulation 17 Arrangements for recovery and rescue

Regulation
The duty holder shall ensure that effective arrangements are made, which include
such arrangements with suitable persons beyond the installation, for (a) recovery of persons following their evacuation or escape from the
installation; and
(b) rescue of persons near the installation; and
(c) taking such persons to a place of safety,
17
Guidance
17
and for the purposes of this regulation arrangements shall be regarded as being
effective if they secure a good prospect of those persons being recovered,
rescued, and taken to a place of safety.
164 The regulation requires duty holders to make effective arrangements
to enable persons who have to evacuate or to escape from the installation
to be recovered or rescued to a place of safety. The regulation also requires
arrangements to be made to rescue persons from the sea near the installation,
such as persons falling overboard, or a helicopter ditching on landing or takeoff. The scope of the regulation covers incidents involving one person as well as
multiple-person incidents. It is open to duty holders to agree formally that another
person (for example, the operator in respect of a mobile installation) makes the
arrangements required by this regulation.
Page 39 of 56
Health and Safety

Executive
Guidance
165 This paragraph explains some of the key terms used in this regulation:
n
recovery and rescue arrangements are:

(i)
(ii)
n

n

facilities and services external to the installation, such as vessels, public

sector and commercially provided search and rescue facilities;
facilities on the installation such as installation-based fast rescue craft;
good prospect of being recovered, rescued and taken to a place of safety

means arrangements designed to give a good probability - in all but the most
severe storm conditions and sea states - of rescuing, recovering and taking to
a place of safety persons who have to evacuate or escape from an
installation, or who fall overboard or are involved in a helicopter ditching on
take-off or landing;
place of safety has the same meaning as in paragraph 152 (an onshore or
safe offshore location or vessel where medical treatment and other facilities for
the care of survivors is available).
166 The term reasonably foreseeable is used in the ACOP. This would include,
for example, a catastrophic failure, a ship collision, a helicopter ditching near the
installation, and a person falling from the installation during overside working.
It would not, for example, include such things as a jumbo jet crashing into the
installation.

167 Regulation 8 requires duty holders to consult appropriate organisations
in drawing up their emergency plan. Paragraphs 79 and 83 give guidance on
consultation with organisations which may be involved in recovery and rescue.
168 Regulation 8 of MAR requires all persons to co-operate with duty holders
to enable them to discharge their responsibilities. Additional guidance is given in
Appendix 1 of this publication. Those involved in arrangements for recovery and
rescue agreed with the duty holder will be covered by this duty. This may involve
providing information reasonably requested by the duty holder on, for example,
operating limits, capacity, time and availability constraints on recovery and rescue
services.
17
169 The duty holder should take account of the findings of the assessment
required by regulation 5 in respect of major accident hazards requiring evacuation,
escape or rescue. It will not, however, be sufficient to aggregate all risks as a
basis for arguing for arrangements which do not meet the requirements of the
regulation. The assessment therefore needs to consider the effectiveness of the
arrangements in their own right. The performance standards required by regulation
5 are particularly appropriate for recovery and rescue arrangements. For non-major
accident hazards - in particular, person overboard incidents - the assessment
required by regulation 3 of MHSWR should be used to determine what needs to be
done to achieve the objective of the regulation, and the necessary arrangements
put in place.
Page 40 of 56
Health and Safety

Executive
ACOP
170 Effective arrangements should be capable of securing a good prospect

that persons evacuating or escaping from the installation, or who fall
overboard, or who are in a helicopter which ditches near the installation on
landing or take-off are recovered or rescued and taken to a place of safety.
Performance standards should be set to achieve this for the weather and sea
conditions likely to be encountered. However, it should be recognised that
there is a possibility of exceptional conditions in which normal emergency
response arrangements may no longer be effective. Duty holders should,
therefore, define such exceptional conditions and the measures to be taken in
them to reduce the likelihood of an event which requires evacuation, escape
and rescue.
171 The arrangements for recovery and rescue should take into account:
n
n

n

n

n
the numbers of personnel who may need to be recovered or rescued;

the capacity of the recovery and rescue services, including realistic
response times;
possible restrictions on availability, including distance; operating limits of
helicopters, vessels and fast rescue craft; sea states and weather
conditions; and any consequential limitations on operational activities;
the need to cover all stages of the recovery and rescue operation,
including proper provision for personnel, both direct and contract
employees, once they have reached a place of safety;
the nature, duration and time of day of work activities being carried out.
172 Recovery and rescue arrangements should be appropriate to cope with

all reasonably foreseeable events likely to lead to the need for evacuation,
escape or rescue. Duty holders should consider the relative merits of
recovery and rescue arrangements taking into account the risks faced by the
person once they have entered the water and the risks to those carrying out
recovery and rescue activities, taking into account the risk inherent in such
activities. Some installations may need a combination of recovery and rescue
arrangements. Duty holders should set out in their assessment a justification
of their choice of arrangements to demonstrate the effectiveness of their
contribution to securing the survival of persons in the water, including, in
particular, a realistic time of response.
173 There are many circumstances for which only a suitable vessel standing
by will provide effective arrangements and in these circumstances such
a vessel will need to be provided. The vessel should meet the following
minimum criteria in all but exceptional weather and sea conditions:
17
n
n

n

n

n

n

it should be highly manoeuvrable and able to maintain its position;

the areas where survivors are brought on board (ie the rescue areas) and
the fast rescue craft (FRC) launch area should be in full view from the
bridge. The Master should be able to approach a person or object in the
water (within the vessels direct rescue capability) while retaining control
of the vessel;
it should have at least two 360 searchlights capable of being remotely
controlled;
it should have at least two suitable power-driven FRCs kept ready for
immediate use;
the FRCs should be equipped with adequate means of communicating
with the vessel by VHF radio, and carry an adequate portable
searchlight;
it should have the means of rapidly and safely launching and recovering
the FRCs;
Page 41 of 56
Health and Safety

Executive
ACOP
n

n

n

it should have adequate means of communication by radio with its

support craft, the installation, nearby vessels, helicopters and the shore;
it should have at least two effective methods of retrieving survivors from
the sea including those who may be incapacitated and medical facilities
for the immediate care of survivors;
it (and its support craft) should be staffed by an adequate number of
competent, medically fit crew. The crew should be competent in
recovery and rescue activities and first aid. Work patterns should ensure
they are ready to carry out their full range of duties whenever required.
The duty holders assessment as required by regulation 5 may identify the

need for further criteria to be met in addition to these minimum criteria.
17
174 Where a vessel is provided it should be maintained, so far as is

reasonable, in a position from which it can be best used for the recovery and
rescue functions required of it, taking account of the nature and time of day
of work activities - such as overside working -being carried out. Such vessels
may be shared between installations provided that this does not compromise
the object of securing a good prospect of recovery and rescue.
Guidance
Further information
175 Guidelines for the survey of vessels standing by offshore installations and
Guidelines for operation of vessels standing by offshore installations, published by
UKOOA
17
Guidelines for the management of emergency response for offshore installations,

published by UKOOA
Regulation 18 Suitability of personal protective

equipment for use in an emergency
Regulation
(1) In relation to personal protective equipment which protects a person in

an emergency against risks to his health and safety (a) in conditions of fire, heat, smoke, fumes or toxic gas; or
(b) in the event of his immersion in the sea,
the duty holder shall, for the purposes of the Personal Protective Equipment at
Work Regulations 1992(a), be treated as the only employer of all persons on the
installation, and such persons shall be treated as only employed by him.
(2) The duty holder shall ensure that there is prepared and operated a
written scheme for the systematic examination and, where appropriate, testing,
by a competent person, of the equipment referred to in paragraph (1) and for
recording the results thereof.
18
(a) SI 1992/2966.
Page 42 of 56
Health and Safety

Executive
Guidance
176 The effect of this regulation is to make the owner or operator of an offshore
installation responsible, in relation to all persons on the installation, for the personal
protective equipment for use in an emergency required by PPEWR, including
the provision of this equipment. This does not include clothes or equipment
provided for normal working activities, which remain the responsibility of the
employer. Personal protective equipment for use in an emergency should always
be considered as a risk control measure of last resort, when the risk cannot be
adequately controlled by other means.
177 The regulation also requires the duty holder to establish a written scheme
for the systematic examination and, where appropriate, testing by a competent
person of the personal protective equipment for use in an emergency. Records of
the results of the examinations must be kept. The written scheme should specify
which equipment is to be covered and the nature and frequency of examinations,
and tests where appropriate. This should take into account what the equipment
may be needed for, the performance standards set for availability and reliability,
and the effect on the equipment of conditions on the installation. Examinations
should also verify the location of equipment against plans. Examination and testing
arrangements should be reviewed and modified as appropriate, taking into account
the findings of the examination. The written scheme may be recorded electronically.
178 This paragraph explains two of the terms used in this regulation:
n

n

personal protective equipment for use in an emergency covers equipment

such as survival suits, life jackets and smoke hoods. The written scheme of
examination and testing should specify which equipment is to be covered;
competent in the context of this regulation includes having sufficient expertise
in the equipment being examined and tested, and in its intended use. This
competence may be available in-house or through a suitably qualified external
person or organisation.

179 The regulation modifies the application of the PPEWR Regulations, in so far
as they relate to personal protective equipment for use in an emergency. It provides
that the duty holder for the PFEER Regulations, rather than the employer, is
responsible for providing personal protective equipment for use in an emergency for
persons on the installation. Other duties under PPEWR (eg to ensure the suitability
of equipment, maintenance and training in use) in respect of personal protective
equipment for use in an emergency likewise fall on the operator or owner for that
equipment. But this does not affect the employers responsibility under PPEWR in
respect of other types of personal protective equipment.
18
ACOP
18
180 The requirements for the written scheme in regulation 18(2) are in addition to
the requirements of PPEWR. Paragraphs 181 and 182 of the ACOP give guidance
on complying with PPEWR in respect of personal protective equipment for use in
an emergency.
181 Provision of personal protective equipment for use in major accident
hazards should be based on the findings of the assessment required by
regulation 5, and for non-major accident hazards on the assessment required
by regulation 3 of MHSWR. It should be suitable for:
n
n
the circumstances in which it may have to be used;

the individuals who may have to use it.
Page 43 of 56
Health and Safety

Executive
ACOP
18
182 Provision of personal protective equipment for use in an emergency

should include:
n

n

n

n

personal protective equipment for all persons on the installation for use
in conditions of fire, heat, gas escape, or smoke, to enable them to
reach muster areas, temporary refuge, evacuation or escape points; this
should include a smoke hood, portable light source and heat proof
gloves located in the accommodation for every individual, with additional
equipment at appropriate locations on the installation;
appropriate personal protective equipment for use by those with specific
emergency duties;
life jackets and survival suits for all persons on the installation to
maximise their chance of survival in the sea, located in the
accommodation (or at another location where the assessment required
by regulation 5 shows it to be more appropriate);
sufficient further life jackets and survival suits at other suitable locations
so that all persons will have ready access to them in the event of
evacuation or escape.
Further information
Guidance
18
183 Personal protective equipment at work Guidance on Regulations L25

Regulation 19 Suitability and condition of plant

Regulation
(1) The duty holder shall ensure that all plant on the installation provided
in compliance with these Regulations (other than aircraft, or equipment to which
regulation 18 applies) (a) is so constructed or adapted as to be suitable for the purpose for which
it is used or provided; and
(b) is maintained in an efficient state, in efficient working order and in good
repair.
(2) Without prejudice to the generality of paragraph (1) and subject to
paragraph (3), the duty holder shall ensure that there is prepared and operated
a suitable written scheme for the systematic examination, by a competent and
independent person, of plant (other than aircraft, or equipment to which regulation
18 applies), provided (a) in compliance with regulations 11(1)(a), 13, 15 and 16;
(b) as means required to be provided by regulation 10 (i)
(ii)
for detecting fire; and

for detecting and recording accumulations of flammable gases; and
(c) pursuant to the measures required by regulation 12 to combat fire and

explosion,
19
and for recording results thereof.
Page 44 of 56
Health and Safety

Executive
Regulation
(3) A scheme prepared pursuant to paragraph (2) shall (a) specify the nature and frequency of examination;
(b) provide for an examination to be carried out, where appropriate, before
plant is(i)
(ii)
first used on the installation; and

first used on the installation after modification or repairs (other than
running repairs);
and it may make different provision for different plant or categories of plant.
(4) In this regulation, reference to examination is reference to careful
and critical scrutiny of plant, in or out of service as appropriate, using suitable
techniques, including testing where appropriate (a) to assess its suitability for the purpose for which it is used or provided;
(b) to assess its actual condition; and
(c) to determine any remedial measures that should be taken.
(5) Subject to paragraph (6), reference in paragraph (2) to the suitability of
the scheme is reference to its suitability for the purpose of discharging the duties
specified in paragraph (1).
(6) The scheme referred to in paragraph (2) need not provide for the
examination, while a Certificate of Fitness is in force in relation to the installation, of
any equipment, which was attached to or formed part of the installation at the time
of a survey, if (a) the equipment was included in the survey;
(b) the survey found that the installation complied with Schedule 2 of the
1974 Regulations; and
(c) a declaration of such survey was considered before the Certificate of
Fitness was issued.
(7) For the purpose of paragraph (2) a person is independent where, even
though he may be employed by the duty holder, he is sufficiently independent of
any other persons accountable to the duty holder for the discharge of his duties
under these Regulations in respect of the installation to ensure that the discharge
of his duty under the scheme will not be prejudiced.
19
Guidance
19
(8) In paragraph (6) Certificate of Fitness, equipment and survey have

the same meaning as in regulation 2(1) of the 1974 Regulations.
184 This regulation requires the duty holder to ensure that plant provided on the
installation to meet the requirements of these Regulations is suitable for its purpose
and is maintained effectively. In addition, the duty holder is required by regulation
19(2) to establish a suitable written scheme of systematic examination for plant
provided to meet certain requirements of regulations 10 to 13 and 15 and 16;
examinations under this scheme have to be undertaken by competent persons
who are also independent within the meaning of regulation 19(7).
185 Plant includes machinery, equipment or appliances. It does not cover
structural items, or helicopters, which may be used as a means of evacuation, or
standby vessels. In addition, the regulation does not apply to equipment within the
scope of regulation 18.
Page 45 of 56
Health and Safety

Executive
Guidance
186 Maintaining plant in an efficient state, in efficient working order and in good
repair, as is required by regulation 19(1)(b), relates only to health and safety
matters; it does not cover productivity. It sets the goal to be achieved rather
than prescribing how it should be carried out. Duty holders will need effective
maintenance and associated inspection examination and testing programmes to
meet this goal.
187 In addition, the written scheme of examination required by regulation 19(2)
requires the duty holder to establish a system to check that certain plant provided
in compliance with the relevant requirements of PFEER (see paragraph 184) is and
remains fit for its purpose. This scheme is above and beyond any checks carried
out as part of routine maintenance and testing programmes. The requirement is
for the duty holder to ensure that the scheme is prepared and operated, and for a
competent and independent person to carry out the systematic examinations. The
scheme replaces examinations of life-saving appliances and fire-fighting equipment
required under previous law; the scope of the scheme is similar, but now the duty
holder is responsible for preparing the scheme, determining both the frequency of
examinations and the competent and independent person required to undertake
them.
188 Results of examinations carried out under this written scheme should be
taken account of in the duty holders maintenance programmes for relevant plant,
in particular where the results indicate deficiencies in the programme.
189 The written scheme of examination should record the plant to be examined
and when, and the types of examination to be undertaken. The regulation also
requires the scheme to provide for an initial examination where appropriate before
relevant plant is brought into operation on the installation and after modification and
repair. Examinations under the scheme would not be required for minor repairs, the
need for which may have been identified during routine maintenance. Examinations
include testing as well as other suitable techniques, as appropriate to achieve the
purposes set out in regulation 19(4), ie a careful and critical scrutiny to assess the
suitability of the plant for its purpose, its condition, and any remedial measures that
should be taken.
190 The written scheme may be set out in a single document, or a series of
documents or recorded electronically, but information about the scheme should be
readily accessible.
19
191 A competent person to carry out examinations under the written scheme may
be employed by the duty holder or another employer, or be self-employed. It is
the responsibility of the duty holder to select a competent person. In some cases
the necessary expertise may lie within the duty holders organisation. In other
cases, duty holders may need to appoint a competent person from a properly
qualified and experienced body. Competent persons must also be independent
(see paragraph 198). Competence is not defined in the regulation but it includes
having the necessary theoretical and practical knowledge, and actual experience
of the type of plant to be examined, to enable, in the case of initial examinations, a
judgement to be made on the suitability of plant, to enable defects or weaknesses
to be detected, and for their importance in relation to the performance required of
the particular plant to be assessed.
Page 46 of 56
Health and Safety

Executive
Guidance

192 Plant provided to comply with regulations 4, 7 and 9-17 must also meet the
requirements of this regulation.
193 Regulations 5 and 6(1) of PUWER set out general requirements on employers
to ensure that work equipment is suitable and maintained properly. The definition
of work equipment in PUWER is wide ranging, but does not cover permanently
installed systems such as fire detection systems, mitigation systems such as
sprinklers or life-saving appliances. Regulation 19(1) requires that plant used
to manage fire and explosion hazards, or for emergency response, is suitable
for purpose and maintained. The duty is placed on the operator and owner
because they are best placed to achieve this. Compliance with regulation 19(1)
will contribute towards compliance with regulation 5 and 6(1) of PUWER where
appropriate.
19
ACOP
194 Regulation 19(6) excludes from the PFEER scheme of examination equipment
covered by a current certificate of fitness (COF) under the Offshore Installations
(Construction and Survey) Regulations (CSR). CSR were revoked by DCR, but
in some circumstances a COF may continue in force until 30 June 1998. DCR
also amended SCR to introduce a requirement for written verification schemes
for safety-critical equipment (SCE) of offshore installations. SCE may include plant
subject to regulation 19. Work done to comply with the requirement of PFEER,
regulation 19 for a written scheme of examination may contribute to the SCR
verification scheme. The verification scheme will contribute to ensuring compliance
with PFEER.
195 Regulation 19(1)(a) requires plant to be suitable, by design, construction
or adaptation, for the actual work it is provided to do. Performance
standards, determined in the assessment required by regulation 5, should
be the basis for assessing that plant required to deal with major accident
hazards is suitable for its purpose.
196 The following approaches might contribute to ensuring the initial
suitability of plant:
n

n

n

19
design, construction or adaptation by reference to appropriate, relevant

standards. These may be international or national standards recognised
by an appropriate standards-making body; appropriate industry
recognised standards; or appropriate company standards;
where relevant standards do not exist, ensuring that the scheme of
examination includes scrutiny to ensure that plant and equipment
chosen is fit for its purpose (eg through design review, testing,
assessment of operational experience in similar situations); or
a combination of these approaches. For example, a duty holder may
wish to use an existing standard in a novel situation. In these
circumstances, the use of that standard should be checked as suitable.
197 In selecting competent persons to undertake examinations of plant

under the written scheme provisions of regulation 19(2), duty holders should
ensure that the person chosen has adequate levels of technical expertise
and experience for the job. An adequate examination of some equipment
may require access to specialised technical knowledge. In other situations, a
lesser degree of technical specialisation may be appropriate.
Page 47 of 56
Health and Safety

Executive
ACOP
198 Competent persons are also required to be independent. They must

have sufficient freedom from the influence of other persons responsible
within the duty holders organisation for achieving compliance with the
Regulations to ensure examinations will be objective, taking account only of
health and safety considerations. For example, a maintenance crew managed
by a person responsible for keeping plant in an efficient state should not also
be given responsibility for carrying out examinations of the plant under the
written scheme.
199 Arrangements for the examinations will differ for different plant,
depending on such things as its function, complexity, conditions of operation
and environment, failure rate, age, running hours and frequency of use. The
scheme of examination should take these matters into account. Duty holders
may find it helpful to consider the scope of examinations and their frequency
against any standards of reliability and availability established through the
assessment required by regulation 5.
19
200 Arrangements should be made to ensure that defects identified as a

result of the examinations are brought promptly to the attention of the duty
holder so that any remedial measures identified can be taken.
Guidance
Further information
201 Work equipment Guidance on Regulations L22 HSE Books
ISBN 0 7176 0414 4
19
A guide to the installation verification and miscellaneous aspects of amendments

by the Offshore Installations and Wells (Design and Construction, etc) Regulations
1996 to the Offshore Installations (Safety Case) Regulations 1992 L83 HSE Books
ISBN 0 7176 1193 0
Regulation 20 Life-saving appliances

Regulation
20
Guidance
20
The duty holder shall ensure that survival craft, life-rafts, life-buoys, life-jackets and
plant for like purposes (a) are of such colour as will make them conspicuous when in use;
(b) are (where applicable) suitably equipped; and
(c) are kept available for immediate use in sufficient numbers.
202 This regulation sets out the criteria to which life-saving appliances must
conform. They must be of a colour that can be easily spotted in the sea. They
should be adequately equipped for their purpose which may include, where
appropriate, communications equipment and medical equipment, and devices to
enable them to be tracked effectively once they are in the sea. Duty holders should
also consider what provision should be made in survival craft and life-rafts for those
who might have been injured in an incident.
203 The regulation does not mean that all life-saving appliances must be available
at all times. Life-saving appliances may have to be taken out of service for routine
preventive maintenance and inspection etc. This is allowed under the regulation
provided that it does not compromise the arrangements made for evacuation and
escape in reasonably foreseeable emergencies, ie where persons on the installation
have to evacuate or escape from the installation, or where life-saving appliances are
needed to assist a person who has fallen from the installation.
Page 48 of 56
Health and Safety

Executive
Guidance

204 Life-saving appliances may be provided under regulation 15 (TEMPSC),
regulation 16 (life-rafts) or PPEWR (life-jackets). Guidance on life-saving appliances
in the context of their role in evacuation and escape is set out in paragraphs 154,
155, 161 and 162. Regulations 18 and 19 also deal with aspects of suitability and
maintenance.
Further information
20

Regulation 21 Information regarding plant

Regulation
The duty holder shall ensure that information, giving the location of (a) areas in which there is a risk of a flammable or explosive atmosphere
occurring;
(b) non-automatic plant for fighting fire; and
(c) plant to which regulations 18(1) and 20 apply (other than plant issued to
particular persons),
21
Guidance
is available to all persons on the installation.

206 The regulation requires duty holders to ensure that information is available to
every person on the installation about the location of manual fire-fighting equipment
(referred to in the regulation as non-automatic plant), life-saving appliances, and
personal protective equipment for use in an emergency (other than that issued
to individuals), in order to help personnel to locate them quickly in an emergency.
The regulation also requires persons on the installation to be informed about the
location of areas where a flammable or explosive atmosphere may occur. This may
be provided in a number of ways; for example display of plans, electronic media,
written information and signs.
21
207 Regulation 9(2)(a) requires the identification and designation of areas where
there is a risk of a flammable or explosive atmosphere occurring. Training and
practice requirements for possible emergencies are set out in regulations 6 and 8.
Regulation 22 Certificates of exemption

Regulation
22
(1) Subject to paragraph (2) and to any of the provisions imposed by the
Communities in respect of the encouragement of improvements in the safety and
health of workers at work, the Executive may, by a certificate in writing, exempt
any person, installation or class of persons or installations from any requirement or
prohibition imposed by these Regulations and any such exemption may be granted
subject to conditions and with or without limit of time and may be revoked by a
certificate in writing at any time.
Page 49 of 56
Health and Safety

Executive
Regulation
(2) The Executive shall not grant any such exemption unless, having regard
to the circumstances of the case and, in particular, to (a) the conditions, if any, which it proposes to attach to the exemption; and
(b) any other requirements imposed by or under any enactments which
apply to the case,
22
Guidance
it is satisfied that the health and safety of persons who are likely to be affected by
the exemption will not be prejudiced in consequence of it.
208 The PFEER Regulations are goal-setting and require duty holders to take
appropriate measures; such measures will take into account the circumstances of
the installation. Nevertheless, there may be circumstances where it is necessary to
apply the Regulations flexibly. The exemption provision in this regulation provides
that flexibility.
209 Under regulation 22, HSE must not grant an exemption unless satisfied that
the health and safety of people who are likely to be affected will not be prejudiced
by it. In addition, the regulation means that HSE may not grant exemptions from
any of the provisions of these Regulations which implement specific provisions
of the Extractive Industries Directive. When applying for an exemption, any
compensatory measures which will be taken to maintain standards of health
and safety should be described, including any additional management controls.
In line with the Health and Safety Commissions general policy, HSE will consult
representatives of the workforce (through the statutory safety committee where
practicable) before agreeing to proposals for exemption.
22
210 HSE may grant exemptions subject to conditions; and exemption may be
given for a limited period to cover short-term arrangements.
Regulation 23 Amendment of the Offshore

Installations (Safety Representatives and Safety
Committees) Regulations 1989
Regulation
Regulation 23(2)(c) of the Offshore Installations (Safety Representatives and Safety

Committees) Regulations 1989(a) shall be amended (a) by deleting the word and after paragraph (ii); and
(b) by adding the following paragraph:

23
Guidance
23
and (iv) the arrangements for the appointment of persons referred to in

regulation 6(1) of the Offshore Installations (Prevention of Fire and
Explosion, and Emergency Response) Regulations 1995.
(a) SI 1989/971.
211 Paragraph 65 explains the effect of this amendment to SRSCR. Further

guidance on amendments made to SRSCR is contained in the guidance to MAR,
regulation 23 (the latter also amends SRSCR).
Page 50 of 56
Health and Safety

Executive
Regulation 24 Amendment of the Offshore

Installations (Safety Case) Regulations 1992
Regulation
Regulation 8 of the Offshore Installations (Safety Case) Regulations 1992(a) shall be

amended by adding, after paragraph (1), the following paragraph:

24
Guidance
(1A) The particulars required by paragraph (1) shall include a summary of the
record kept pursuant to regulation 5(3) of the Offshore Installations (Prevention
of Fire and Explosion, and Emergency Response) Regulations 1995.
(a) SI 1992/2885
212 The regulation requires a summary of the assessment performed in

compliance with regulation 5 to be included in the safety case submitted to HSE for
acceptance under SCR. Sufficient information on the results of the assessment - in
particular covering the events and risks, measures which have been selected, and
performance standards which have been established - should be included to show
that the arrangements are adequate, as part of the demonstration required by
regulation 8(1)(d) of SCR that risks from major accident hazards have been reduced
to as low as is reasonably practicable. (Reference can also be made to the SCR
guidance, especially paragraphs 4 and 5 on page 51, as regards the appropriate
balance between material to be included in the safety case, and more detailed
information to be provided to HSE on request.)
213 Complying with the requirement to include a summary of the assessment
required by regulation 5 does not in itself count as a revision for the purposes of
regulation 9(2)-(4) of SCR.
Further information
214 A guide to the Offshore Installations (Safety Case) Regulations 1992 L30 HSE
Books ISBN 0 11 882055 9
24

Regulation 25 Revocation
Regulation
25
The instruments specified in column 1 of the Schedule hereto are hereby revoked
to the extent specified in column 3 of the Schedule.
Page 51 of 56
Health and Safety

Executive
Schedule Revocation
Schedule
Regulation 25
(1)
Title
(2)
Reference
(3)
Extent of revocation
The Offshore Installations (Operational

Safety, Health and Welfare)
Regulations 1976
SI 1976/1019
Regulations 2(1),
4(6) and 18(4)
The Offshore Installations (Emergency

Procedures) Regulations 1976
SI 1976/1542
The whole
Regulations
The Offshore Installations (Life-saving

Appliances) Regulations 1977
SI 1977/486
The whole
Regulations
The Offshore Installations (Fire-fighting

Equipment) Regulations 1978
SI 1978/611
The whole
Regulations
The Health and Safety (Fees)

Regulations 1993
SI 1993/1321
Regulation 2
Page 52 of 56
Health and Safety

Executive
Appendix 1 - Co-operation:
regulation 8 of the Management
and Administration Regulations
Guidance
What the regulation means for emergency response

1 Regulation 8 of MAR places a duty on every person to co-operate with the
operator or owner of the installation so far as is necessary to enable them to
fulfil all their legal responsibilities. This will include those parties who have made
arrangements with the duty holder to cover emergency response. This would
include, for example:
n

n

n

n

n
operators and owners of other installations, or pipeline owners, where it

may be necessary to activate procedures to shut down pipelines or to receive
personnel;
providers of commercial helicopter and vessel services, where these had been
contracted to provide, respectively, evacuation or recovery and rescue
facilities;
parties working in connection with the installation, such as supply vessels or
diving contractors, who need to be covered by the arrangements in the
emergency response plan;
employers (other than the operator or owner) of persons working on the
installation;
persons on the installation.
2 Duty holders should ensure that those elements of the emergency

arrangements which require the co-operation of others are agreed with them,
and that they are informed about the action they need to take in an emergency.
This should include changes to the emergency response arrangements.
Different employers - including other duty holders under the Regulations - who
have employees working in connected activities, or in a combined operation,
should co-operate with the duty holder and with each other so that emergency
response arrangements can be properly co-ordinated. This should ensure that
procedures and other arrangements for preventing, controlling and mitigating
fires and explosions are mutually consistent and that there will be an adequately
co-ordinated response in an emergency. This is particularly important where
contractors employees have designated emergency responsibilities.
Appendix 1
3 Other regulations require emergency procedures for specific activities

connected with offshore installations. Diving contractors should co-operate with the
duty holder so that information about the diving rules for diving operations required
by the Diving Operations at Work Regulations (SI 1981/399) and later amendments
may be taken into account in the emergency response plan. Likewise, pipeline
operators and other installations should co-operate so the pipeline emergency
procedures, required by the Pipelines Safety Regulations (SI 1996/825), and action
to be taken by other installations, can be taken into account in the emergency
response plan for the installation.
Page 53 of 56
Health and Safety

Executive
Guidance
4 For employees, MAR duties to co-operate complement and reinforce in

respect of emergencies the general duty in section 7(b) of the HSW Act. In addition,
there is a duty on employees under regulation 12(2) of MHSWR to inform their
employees of serious and immediate danger. For employers, the duty to co-operate
in MAR complements that in regulation 9 of MHSWR.
Further information
5 A guide to the Offshore Installations and Pipeline Works (Management and
Appendix 1
A guide to the Pipelines Safety Regulations 1996 L82 HSE Books

ISBN 0 7176 1182 5
Appendix 2 - List of
abbreviations used
ACOP
Approved Code of Practice
API
American Petroleum Institute
BSI
British Standards Institution
COF
Certificate of fitness
CSR
Offshore Installations (Construction and Survey) Regulations 1974
DCR

Offshore Installations and Wells (Design and Construction, etc)

Regulations 1996
ESD
Emergency shutdown system
FRC
Fast rescue craft
HSE
Health and Safety Executive
HSW Act
Health and Safety at Work etc Act 1974
IMO
International Maritime Organisation
MAR

Offshore Installations and Pipeline Works (Management and

Administration) Regulations 1995
MHSWR
Management of Health and Safety at Work Regulations 1992
OFAR

Offshore Installations and Pipeline Works (First-Aid)

Regulations 1989
OIM
Offshore installation manager
OPITO
Offshore Petroleum Industry Training Organisation
PFEER

Offshore Installations (Prevention of Fire and Explosion, and

Emergency Response) Regulations 1995
Page 54 of 56
Health and Safety

Executive
PPEWR
Personal Protective Equipment at Work Regulations 1992
PUWER
Provision and Use of Work Equipment Regulations 1992
SCE
Safety-critical element
SCR
Offshore Installations (Safety Case) Regulations 1992
SMS
Safety management system
SSR
Health and Safety (Safety Signs and Signals) Regulations 1996
SRSCR

Offshore Installations (Safety Representatives and Safety

Committees) Regulations 1989
TEMPSC
Totally enclosed motor propelled survival craft
UKOOA
United Kingdom Offshore Operators Association
Appendix 3 - Health and Safety

Executive Offshore Safety
Division Offices
LONDON

Rose Court, 2 Southwark Bridge, London SE1 9HS

Tel: 0171 7176000 (switchboard)
Fax: 0171 7176910/6911/6678
ABERDEEN

Lord Cullen House, Fraser Place, Aberdeen AB9 1UB

Fax: 01224 252577/252555
Telex: 739040
BOOTLE

Merton House, Stanley Road, Bootle, Merseyside L20 3DL

Tel: 0151 951 4000 (switchboard)
Fax: 0151 9513131/3098/3158
NORWICH

122A Thorpe Road, Norwich, Norfolk NR1 1RN

Fax: 01603 275050/275055
Page 55 of 56
Health and Safety

Executive
Further information
HSE priced and free publications can be viewed online or ordered from
www.hse.gov.uk or contact HSE Books, PO Box 1999, Sudbury, Suffolk
CO10 2WA Tel: 01787 881165 Fax: 01787 313995. HSE priced publications
are also available from bookshops.
For information about health and safety ring HSEs Infoline Tel: 0845 345 0055
Fax: 0845 408 9566 Textphone: 0845 408 9577 e-mail: [email protected] or
write to HSE Information Services, Caerphilly Business Park, Caerphilly CF83 3GG.
British Standards can be obtained in PDF or hard copy formats from BSI:
http://shop.bsigroup.com or by contacting BSI Customer Services for hard
copies only Tel: 020 8996 9001 e-mail: [email protected].
Published by HSE
02/10
Page 56 of 56

L 65 - Prevention of Fire and Explosion, and Emergency Response On Offshore Installations - Approved Code of Practice and Guidance - HSE - 2010

Uploaded by

Copyright:

Available Formats

L 65 - Prevention of Fire and Explosion, and Emergency Response On Offshore Installations - Approved Code of Practice and Guidance - HSE - 2010

Uploaded by

Document Information

Original Title

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

L 65 - Prevention of Fire and Explosion, and Emergency Response On Offshore Installations - Approved Code of Practice and Guidance - HSE - 2010

Uploaded by

Copyright:

Available Formats

What is the purpose of the document?

What is the purpose of the document?

What regulations does the document discuss?

What regulations does the document discuss?

Health and Safety

Prevention of fire and explosion,

Health and Safety

Crown copyright 1997

Health and Safety

Citation and commencement 7

Co-operation: regulation 8 of the Management and Administration

Prevention of fire and explosion, and emergency response on offshore installations

Health and Safety

Prevention of fire and explosion, and emergency response on offshore installations

Health and Safety

Relationship between these Regulations and other health and

Prevention of fire and explosion, and emergency response on offshore installations

Health and Safety

7 Regulation 8(1)(a) of SCR requires a demonstration in the safety case of the

Prevention of fire and explosion, and emergency response on offshore installations

Health and Safety

Regulation 1 Citation and commencement

14 The Offshore Installations (Construction and Survey) Regulations (SI 1974/289)

concession owner in relation to a fixed installation has the same meaning as in

Prevention of fire and explosion, and emergency response on offshore installations

Health and Safety

16 Detailed guidance on the definition of concession owner is set out in

duty holder means -

(a) in relation to a fixed installation, the operator; and

emergency means an emergency of a kind which can require evacuation, escape

18 An emergency includes any unexpected event of whatever nature with the

19 Emergency response covers action in response to potential major accidents;

evacuation means the leaving of an installation and its vicinity, in an emergency, in

20 Evacuation refers to the planned and controlled method of leaving the

the Executive means the Health and Safety Executive;

installation means an offshore installation within the meaning of regulation 3 of the

21 Detailed guidance on the definition of installation is set out in guidance to

Prevention of fire and explosion, and emergency response on offshore installations

Health and Safety

(a) a fire, explosion or other release of a dangerous substance involving death

23 Detailed guidance on the definition of installation is set out in guidance to

muster areas shall be construed in accordance with regulation 14(1) (a);

(a) a fixed installation means the person appointed by a concession owner

24 Detailed guidance on the definition of operator is set out in guidance to

Prevention of fire and explosion, and emergency response on offshore installations

Health and Safety

25 Detailed guidance on the definition of owner is set out in guidance to MAR,

26 A guide to the Offshore Installations and Pipeline Works (Management and

(1) These Regulations shall apply (a) in Great Britain, and

(2) Regulations 4 to 22 shall not apply in relation to an installation which is

29 The Regulations and ACOP apply equally to attended and normally

Prevention of fire and explosion, and emergency response on offshore installations

Health and Safety

Relationship with other Regulations

A guide to the Offshore Installations and Pipeline Works (Management and

Regulation 4 General duty

(2) Any more detailed requirement in regulations 6 to 21 for the purposes

Prevention of fire and explosion, and emergency response on offshore installations

Health and Safety