DA42 TwinStar Checklist Edit15 2 A4 PDF

Flight Training Division
Checklist for Diamond DA42 Twin Star

Edition #: 15.2 Edition date: 15.02.2012
Please observe:
The file you are receiving hereby combines all three sections of the checklist: Normal
Checklist, Emergency Checklist and Abnormal Checklist.
All pages of a new edition will have the same new edition # and edition date, even if
only one page was amended and all other pages still have the same, unchanged content.
Therefore the List of Effective Pages (LEP) is provided. It is here where you can see
whether a particular page was amended. Pages which have been amended by a new
edition will be marked yellow. For all other pages you will see which original edition #
(and of course any higher edition #) is still valid.
Note:
The system of assigning Edition # is as follows:
if the revision affects all types, a new edition # (without a decimal figure) will be
assigned to all of the checklists
if the revision does not affect all types, the affected checklists will get subsequent
decimal figures until a major revision affecting all checklists is issued.
Have a lot of nice flights and happy landings!
Peter Schmidleitner
Comments explaining Edition # 15.2 are on page 2 of this document
Checklist DA42 Twin Star - LEP

Following
Edition
Date
(or any higher)
is valid
Section : Normal Checklist
1
14
01.12.2006
2
15.2
15.02.2012
3
14.1
01.07.2008
4
15.2
15.02.2012
5
14.1
01.07.2008
6
14.1
01.07.2008
7
14
01.12.2006
8
15.2
15.02.2012
9
14
01.12.2006
10
15.2
15.02.2012
Page
Section: Emergency Checklist

1
15.2
15.02.2012
2
15.2
15.02.2012
3
15.2
15.02.2012
4
15.2
15.02.2012
5
15.2
15.02.2012
6
15.2
15.02.2012
7
15.2
15.02.2012
8
15.2
15.02.2012
9
15.2
15.02.2012
10
15.2
15.02.2012
11
15.2
15.02.2012
12
15.2
15.02.2012
13
15.2
15.02.2012
Section: Abnormal Checklist
14
15.2
15.02.2012
15
15.2
15.02.2012
16
15.2
15.02.2012
17
15.2
15.02.2012
18
15.2
15.02.2012
19
15.2
15.02.2012
Comments explaining Edition # 15

Emergency Checklist
All pages new, because of renumbering
Page 2:
New procedure: 2 ENGINES OUT LANDING
Page 6:
DOOR OPEN procedure revised
Page 7:
Engine restart procedure expanded with re-feathering procedure
Abnormal checklist:
All pages renumbered
Comments explaining Edition # 15.1

Emergency Checklist
Page 2:
2 ENGINES OUT LANDING: Fuel pumps deleted
Comments explaining Edition # 15.2

Normal Checklist:
Page 2:
Check of structural temp. indicator added
Page 4:
Lights added in gear warning test
Page 8:
Lights added in gear warning test
Page 10:
Increased mass options added
Emergency Procedures and Abnormal Procedures:
General:
in conformity with the AFM Land ASAP (land as soon as possible) changed to land at
nearest suitable airfield in most procedures.
Landing gear up landing modified
Graphic layout for both checklists updated
DA42 Twin Star
NORMAL CHECKLIST
Diamond DA42
Twin Star
This checklist is compiled according the guidelines of GAMA Specification No.1, SECTION 3, para 3.5,
SECTION 3A, para 3A.5 and SECTION 4, para 4.5.
The Amplified Normal Procedures, Amplified Emergency Procedures and Amplified Abnormal
Procedures according GAMA Specification No. 1 are in the DA42 Airplane Flight Manual Chapters 4A,
3 and 4B.
This checklist is a Recommended Operator Checklist and for reference only.
It is not a substitute for and does not supersede the current approved Airplane Flight Manual or any
of its supplements or parts thereof, or any training or procedures required by any regulatory or
advisory bodies.
This checklist may not contain all procedures shown in the Airplane Flight Manual. For a
comprehensive listing of all procedures consult the Airplane Flight Manual.
Use of the checklist is at the user's sole risk and discretion.
Any possible liability of Diamond Aircraft for any damages, injury or death resulting from its use is
excluded.
All such terms and conditions shall be deemed to be explicitly accepted in full by using the checklist.
If you do not understand, or if you disagree with, any of the above terms and conditions and in any
jurisdiction that does not give effect to all provisions of these terms and conditions any use of the
checklist is not permitted.
Use of the electronic checklist (if available):

Before using the electronic checklist on the G1000 the following sections have to
be completed using this paper checklist:
Preflight interior + exterior
Preflight exterior
Check before engine start items 1 to 21 (may be completed by heart).
This checklist also serves as a back up for the electronic checklist in case the
G1000 MFD is not available.
15.02.2012
Edition # 15.2
Diamond Aircraft Flight Training Division

Page 1
Does not replace the Airplane Flight Manual
DA42 Twin Star
PREFLIGHT PROCEDURES
Attention!
For refuelling with JET A1 no
additives (e.g. Aerojet) are
permitted.
*
if optional ice protection is

installed
** if optional AUX tanks are
installed
*** with option increased ZFM
and actual ZFM > 1650 kg
PREFLIGHT INTERIOR
+ EXTERIOR.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
Check airplane documents

Remove pitot cover
Check interior for foreign
objects
Check circuit breakers
Start key PULLED OUT
Gear selector CHECKED DOWN
Electric Master ON
Check battery voltage
Gear 3 greens CHECKED
Check fuel quantity + temp
** Fuel transfer ON if L/R
AUX FUEL E caution ON:
AUX tank(s) empty
Fuel transfer OFF
External lights ON
Pitot heat ON
* Check de-ice fluid quantity
* Select de-ice pump 1
* De-ice HIGH/MAX
* Check DEIC PRES LO+HI out
* Select de-ice pump 2
* Check DEIC PRES LO+HI out
* Ice lights ON
* Check de-ice function
Check external lights
Check stall warning
Check pitot/static tube heat
Pitot heat OFF
External lights OFF
* De-ice, ice lights OFF
Electric Master OFF
15.02.2012
Edition # 15.2
PREFLIGHT EXTERIOR
Canopy left side
Left main gear
Strut (min 4cm bare piston) &
downlock
Tire condition, pressure (4,5 bar),
position mark
Brake, hydraulic line
Gear door & linkage
*** structural temp.indicator:
no red 55
Left engine nacelle
Drain cascolator
3 air inlets / 2 air outlets
Spinner, propeller
Gearbox oil level
Engine oil level
Cowling
Nacelle underside
Venting pipe
Exhaust
** Check AUX tank full ?
Left wing
Wing leading edge, top- and
bottom surface
Tank drain
Stall warning
Tank air vent
Fuel filler cap
Pitot, static probe (cover
removed)
Wing tip, position light
Static dischargers
Aileron (freedom of movement,
hinges, control linkage,
security)
Wing flap
Fuel cooler air in- & outlet
** AUX tank vent
** Drain AUX tank
Left fuselage
Step
Rear cabin door
Fuselage left side
Static source
Antennas

Page 2
DA42 Twin Star
PREFLIGHT PROCEDURES
Tail
Elevator & rudder (freedom of
movement, hinges)
Elevator & rudder trim - tabs
Tail skid & lower fin
Static dischargers
Right fuselage
Fuselage right side
Static source
Rear window
Step
Right wing
Fuel cooler air in- & outlet
** AUX tank vent
** Drain AUX tank
Wing flap
Aileron (freedom of movement,
hinges, control linkage,
security)
Static dischargers
Wing tip, position light
Wing leading edge, top- and
bottom surface
Fuel filler cap
Tank air vent
Tank drain
Canopy right side
Right engine nacelle

** Check AUX tank full ?
3 air inlets / 2 air outlets
Spinner, propeller
Gearbox oil level
Engine oil level
Cowling
Nacelle underside
Venting pipe
Exhaust
Drain cascolator
Ventilation air inlet
Right main gear
downlock
Tire condition, pressure (4,5 bar),
position mark
Brake, hydraulic line
Gear door & linkage
Nose section
* De-ice fluid tank
L + R front baggage door locked
OAT sensor
EPU connection
Landing / Taxi light
Nose gear
lock
Tire condition, pressure (6 bar),
position mark
Gear door & linkage
Chocks removed
Tow bar removed
15.02.2012
Edition # 15.2

Page 3
DA42 Twin Star
NORMAL PROCEDURES
CHECK BEFORE ENGINE START

1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
Preflight check ............................COMPLETED

Baggage and tow bar ...................... SECURED
Fuel selectors (2)........ ON, safety guard closed
Power levers (2) .................................... IDLE
Parking brake......................................... SET
Alternate Air .................................... CLOSED
Manual gear extension handle ............ PUSHED
Gear selector ..................................... DOWN
Avionic master ....................................... OFF
Electric master ....................................... OFF
Engine masters (2) ................................. OFF
Pitot heat .............................................. OFF
Alternate static................................. CLOSED
Alternators (2) ........................................ ON
ECU swap (2) ....................................... AUTO
All light switches..................................... OFF
Emergency switch.................... OFF/GUARDED
ELT ...................................................ARMED
Circuit breakers .......................... CHECKED IN
Flap selector ............................................ UP
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
If starting with external power:
21
22
23
24
25
26
27
28
a Prop area ....................... CHECK CLEAR a

b External power...................... CONNECT b
Electric master ........................................ ON
Rudder pedals ............................... ADJUSTED
Flight controls ................................ CHECKED
Trims ............................................ CHECKED
Gear warning + lights, fire detector..........TEST
* De-ice ANNUN TEST .............................. ON
* DEICE LVL LO caution . CHECKED ON if applic.
* Windshield de-icing ..... PUMP 1 + 2 CHECKED
21
22
23
24
25
26
27
28
Checklist continued next page
15.02.2012
Edition # 15.2

Page 4
DA42 Twin Star
NORMAL PROCEDURES
CHECK BEFORE ENGINE START continued
29
30
Flaps.....................................................LDG 29
Variable elevator backstop ................... CHECK 30
Control stick ............................... AFT and HOLD
Power levers ............................................. MAX
Check backstop limit decreasing
Power levers .............................................IDLE
Check backstop limit increasing
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
Flaps....................................................... UP
Passengers ............................... INSTRUCTED
Seat belts ..................................... FASTENED
Rear door .................... CLOSED and LATCHED
Front Canopy ................................POS 1 or 2
G1000.................POWERED, ACKNOWLEDGED
PFD/MFD ................................ BACKUP MODE
MFD...................................... ENGINE FUEL
Fuel Quantity .....CHECKED, RESET/SET if requ.
Fuel temperature ............................ CHECKED
Total time in service............................NOTED
MFD..................................ENGINE SYSTEM
* DEIC PRESS LO caution ........... CHECKED ON
* De-ice ANNUN TEST ............................. OFF
Start key ...................................... INSERTED
ACL (strobe) ........................................... ON
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
End of Checklist
ENGINE START PROCEDURE

Normal sequence: first start LH engine
Engine Master ............................................. ON
Annunciations / Eng.Instr. ................... CHECKED
Glow indication .......................................... OFF
Propeller area ........................................ CLEAR
Start key............................................... START
Oil pressure ............... OUTSIDE RED within 3 sec
Voltage, Electrical load ......... CHECK INDICATION
Annunciations / Eng.Instr. .......................CHECK
If external power was used:
External power................. DISCONNECT

15.02.2012
Edition # 15.2
Start RH engine, procedure as above

Page 5
DA42 Twin Star
NORMAL PROCEDURES
CHECK AFTER ENGINE START

1
2
3
Oil pressure ................................... CHECKED

RPM 900 +/- 20.............................. CHECKED
Warm up time .................................... START
1
2
3
Warm up:
Idle ................................................. 2 minutes
Max 1400RPM ...... until Oil > 50C and Coolant > 60C
4
5
6
7
8
Fuel selectors (2)............................... X-FEED

Pitot heat ....ON, annunciation + Amps checked
Pitot heat .............................................. OFF
PFD/MFD ............................... NORMAL MODE
Avionics master ....................................... ON
4
5
6
7
8
FMS SETUP
I nitialize profile (AUX 4, MAP)
F light plan
R adios (COM, NAV, ADF, DME, CDI, BRG 1/2)
P erformance (speed bugs; Flight ID if applicable)
FMS setup ..................................COMPLETED
AUTOPILOT TEST
DISCONN press, check electric trim not working
AP ON, check overpowering servos
DISCONN press, check AP off
10
11
12
13
14
15
16
17
Autopilot test ..............................COMPLETED

Flood light .............. CHECKED, ON as required
Position lights..........................ON as required
Fuel Selectors (2) .................................... ON
Altimeters (3) ........................................ SET
Standby horizon ............................. CHECKED
Transponder ..............CODE / MODE CHECKED
Parking brake................................ RELEASED
10
11
12
13
14
15
16
17
End of Checklist
DURING TAXI
Check brakes
Check nose wheel steering
Check flight instruments
15.02.2012
Edition # 15.2

Page 6
DA42 Twin Star
NORMAL PROCEDURES
BEFORE TAKE OFF CHECK

1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16

Seat belts ..................................... FASTENED
Rear door ....................... CLOSED + LATCHED
Front canopy................... CLOSED + LATCHED
Front baggage doors ........... CHECKED CLOSED
Door warning light .................................. OFF
Engine instruments ......................... CHECKED
Fuel temperature (Diesel min. +5)... CHECKED
Circuit breakers .............................. CHECKED
Electric elevator trim .......... CHECKED, T/O SET
Fuel selectors (2)....................... CHECKED ON
Rudder trim ............................. AS REQUIRED
Flaps........................................ CHECKED UP
Flight controls ................................ CHECKED
ECU test (2)................................... PERFORM
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
ECU TEST
ECU test button........................... press and hold
L/R ECU A/B fail........ON / RPM increasing / OFF
L/R ECU B fail...............ON / prop cycling / OFF
L/R ECU A fail...............ON / prop cycling / OFF
RPM......................................... decrease to idle
ECU test button..................................... release
17
18
19
20
21
22
ECU swap (2) ......... ECU B, ENGINES CHECKED

ECU swap (2) ....................................... AUTO
Pitot heat ................................ AS REQUIRED
* Ice protection ........................ AS REQUIRED
Transponder ..............CODE / MODE CHECKED
Parking brake................................ RELEASED
17
18
19
20
21
22
End of Checklist
LINE UP PROCEDURE
Landing light............................................... ON
Approach sector ..................................... CLEAR
Runway..........................................IDENTIFIED
Power lever max (100% / 10 sec) ...........................
CHECK LOAD / RPM / FUEL FLOW / OP
15.02.2012
Edition # 15.2

Page 7
DA42 Twin Star
NORMAL PROCEDURES
AFTER TAKE-OFF PROCEDURE

Brakes ...................................................APPLY
Gear ...........................................................UP
Landing light.............................................. OFF
CLIMB TO CRUISE CHECK

1
2
3
Gear ........................................ CHECKED UP

Flaps........................................ CHECKED UP
Landing light ............................ CHECKED OFF
1
2
3
End of Checklist
PERIODICALLY DURING CRUISE

Fuel Radio Engine Direction Altitude
Maximum fuel unbalance: 5 USG
DESCENT / APPROACH CHECK

1
2
3
4
5
6
7
Landing data ................................. RECEIVED

Altimeters (3) ........................................ SET
COM / NAV / FMS ................................... SET
Seatbelts ...................................... FASTENED
Fuel selectors (2)....................... CHECKED ON
Parking brake..................CHECKED RELEASED
Gear warning + lights.............................TEST
1
2
3
4
5
6
7
End of Checklist
BEFORE LANDING PROCEDURE

Downwind, latest base leg:
Flaps ........................................................ APP
Gear ...........................DOWN, CHECK 3 GREENS
Landing light............................................... ON
On final when landing assured:
FINAL CHECK
1
2
Flaps.....................................................LDG
Gear .............................. 3 GREENS CHECKED
15.02.2012
Edition # 15.2
1
2

Page 8
DA42 Twin Star
NORMAL PROCEDURES
GO AROUND PROCEDURE
Power ...................................................... MAX
Flaps ........................................................ APP
Positive rate of climb:
Gear ...........................................................UP
Continue with take-off profile
At safe altitude:
Flaps ..........................................................UP
Landing light.............................................. OFF
AFTER LANDING CHECK

When clear of runway
1
2
3
4
5
Flaps....................................................... UP
Pitot heat .............................................. OFF
Alternate air..................................... CLOSED
* De-ice systems .................................... OFF
Landing/Taxi light ..................... AS REQUIRED
1
2
3
4
5
End of Checklist
PARKING CHECK
1
2
3
4
5
6
7
8
9
10
11
12

1
Power levers (2) ..................... IDLE for 2 min.
2
ELT ...................................... 121,5 CHECKED
3
Engine / System page ..................... CHECKED
4
Engine / Fuel page ..... TTL TIME IN SVC NOTED
5
Avionic master ....................................... OFF
6
Electrical consumers except ACL (strobe) ... OFF
7
Engine Masters (2).................................. OFF
8
ACL (strobe) .......................................... OFF
9
Electric Master........................................ OFF 10
Interior light ............................ CHECKED OFF 11
Start key .......................................REMOVED 12
End of Checklist
SECURING THE AIRCRAFT

Release parking brake, use chocks.
Attach tie down ropes to mooring points.
15.02.2012
Edition # 15.2

Page 9
DA42 Twin Star
IMPORTANT DATA AND LIMITATIONS
OPERATING SPEEDS KIAS for MTOM 1785
Stalling speed (VS0) Flaps LDG

Stalling speed (VS) Flaps APP
Stalling speed (VS) clean
In Ice: + 4 Kt
Best gliding angle (Flaps UP)
Best angle of climb (VX)
Best rate of climb (VY)
Best rate of climb 1-eng. (VYSE)
Min. control speed (VMCA)
Min. control speed for TRG(VSSE)
Min. control speed (VMCA) in ice
Operating speed in ice
Cruising climb speed
Rotation speed
Max. flap speed (VFE) Flaps APP
Max. flap speed (VFE) Flaps LDG
Max. LG extension (VLOE)
Max. LG extended (VLE)
Max. LG retraction (VLOR)
Approach VREF Flaps UP
Approach VREF Flaps APP
Approach VREF Flaps LDG
Min. Go-around speed Flaps UP
Max. cruising speed (VNO)
Never exceed speed (VNE)
Manoeuvring speed (VA)
1400 kg 1785 kg
49
57
53
61
56
64
82
79
79
82
68
82
72
121 - 160
86
72
137
111
194
194
156
1700 kg 1785 kg
85
86
82
82
76
78
82
82
155
194
up to
above 1542 kg 1542 kg
120
126
MASS
Increased
LM
Max. TKOF mass

Max. ZF mass
Max. LDG mass
Empty mass
Max. baggage in NOSE
Max. baggage in COCKPIT
Max. baggage in rear EXTENSION
Max. total of COCKPIT + EXTENSION
15.02.2012
Edition # 15.2
1785
1650
1700
1295
30
45
18
45
kg
kg
kg
kg
kg
kg
kg
kg
ZFM
1674 kg
1785 kg
LM + ZFM
1730 kg
1785 kg

Page 10
DA42 Twin Star
EMERGENCY + ABNORMAL CHECKLIST

For conditions to use this
Emergency + Abnormal Checklist
see page 1 of the Normal Checklist.
All such conditions are fully
applicable also for this checklist.
2 engines out landing ............................................page 2

G1000 Warnings ...................................................page 3
Engine
Engine fire / failure during take-off .............page 6
Engine fire / failure in flight .......................page 6
Engine troubleshooting .............................page 7
Engine restart..........................................page 8
Oscillating RPM ........................................page 9
RPM overspeed ........................................page 9
Landing Gear
Landing with defective main gear tire..........page 9
Landing with defective brakes ....................page 9
Landing gear unsafe warning ................... page 10
Manual extension of landing gear ............. page 10
Landing gear up landing .......................... page 10
Smoke and fire
Engine fire on ground ............................. page 11
Electrical fire on ground .......................... page 11
Electrical fire in flight .............................. page 11
If Oxygen System is installed
Cabin smoke, cabin fire, loss of oxygen pressure

above 10.000 ft ..................................... page 12
Other Emergencies
Oxygen pressure loss above 10.000 ft....... page 12
Emergency descent ................................ page 12
Suspicion of carbon monoxide.................. page 12
Unintentional flight into icing, Inadvertent icing
encounter & excessive ice accumulation .... page 13
Ice protection failure .............................. page 13
Electrical System
Complete electrical failure ....................... page 13
15.02.2012
Edition # 15.2
Page 1
DA42 Twin Star
EMERGENCY PROCEDURES
2 ENGINES OUT LANDING

1 Mayday call ...................................CONSIDER
2 Engine masters (2) .................................. OFF
3 Alternators (2) ........................................ OFF
4 Fuel selectors (2) .................................... OFF
5 Avionic master ........................................ OFF
6 Safety harnesses............ FASTENED and TIGHT
When sure of making landing area:
7 Flaps ......................... APP or LDG, as required
8 Approach speed .... min (APP)82/(LDG)78 KIAS
Gear UP landing
After touchdown:
9 Electric master ........................................ OFF
Gear DOWN landing
10
9 Gear .................... DOWN, 3 GREENS CHECKED
10 Electric master ........................................ OFF 10

11
15.02.2012
Edition # 15.2
Page 2
DA42 Twin Star
G1000 WARNINGS
L/R OIL PRES
Pg. 3
Oil pressure low (red range)
L/R OIL TEMP
Pg. 3
Oil temperature high (red range)
L/R GBOX TEMP
Pg. 4
Gearbox temperature high (red range)
L/R ENG TEMP
Pg. 4
Coolant temperature high (red range)
L/R FUEL TEMP
Pg. 4
Fuel temperature high (red range)
L/R ALTN AMPS
Pg. 5
High Current (red range)
L/R STARTER
Pg. 5
Starter not disengaging
DOOR OPEN
Pg. 5
Unlocked doors
L/R ENG FIRE
Pg. 6
Pg. 6
Pg. 11
Engine fail/fire during take-off

Engine fail/fire in flight
Engine fire on ground
For other parameters out of green range see Abnormal Checklist

Abnormal Checklist starts at page 14
L/R OIL PRES
Reduce power on affected engine

Be prepared for loss of oil and an engine failure;
land at nearest suitable airfield
L/R OIL TEMP
OIL PRESSURE LOW
OIL TEMPERATURE HIGH
Check oil pressure

If oil pressure too low (outside green range):
Expect loss of engine oil
Be prepared for an engine failure
If oil pressure in green range
Increase airspeed
z If oil temperature not returning to green range:
Be prepared for an engine failure;
15.02.2012
Edition # 15.2
Page 3
DA42 Twin Star
L/R GBOX TEMP

Increase airspeed
z If gearbox temperature still in red range:
Land at nearest suitable airfield
L/R ENG TEMP
COOLANT TEMPERATURE HIGH
Check G1000 for LOW COOL LVL caution light

If LOW COOL LVL caution light OFF
During climb:
Reduce power on affected engine by 10% or more as rqrd
Increase airspeed by 10 KIAS or more as required
z If coolant temp. not returning to green range
within 60:
reduce power on affected engine as much as
possible and increase airspeed
During cruise:
Increase airspeed
z If coolant temp. not returning to green range:
Be prepared for an engine failure;
If LOW COOL LVL caution light ON
Expect loss of coolant fluid
L/R FUEL TEMP
GEARBOX TEMPERATURE HIGH
FUEL TEMPERATURE HIGH

Increase airspeed
Transfer fuel from AUX to MAIN tank if applicable
z If not returning to green range:
15.02.2012
Edition # 15.2
Page 4
DA42 Twin Star
L/R ALTN AMPS

Reduce electrical load and land at nearest suitable airfield
L/R STARTER
STARTER NOT DISENGAGING
Affected power lever IDLE

Affected engine master OFF
Electric master OFF
DOOR OPEN
HIGH CURRENT
UNLOCKED DOORS
Reduce airspeed immediately

Check canopy visually
z If open:
airspeed below 140 KIAS, land at nearest suitable airfield
Check rear door visually
z If open:
airspeed below 140 KIAS, land at nearest suitable airfield
do not try to lock door in flight
Check front baggage doors visually
z If one or both open:
reduce airspeed to keep door(s) in stable position,
15.02.2012
Edition # 15.2
Page 5
DA42 Twin Star
ENGINE FAILURE
ENGINE FIRE
DURING TAKE-OFF
REJECTED TAKE-OFF OR EMERGENCY RE-LANDING
1 Power .................................................... OFF

2 Brakes ................................................ APPLY
3 ATC ................................................. INFORM
If necessary:
4 Engine Masters (2) .................................. OFF
6 Electric Master ........................................ OFF
In case of fire:
7 Cabin heat & defrost ................................ OFF
ENGINE FAILURE
ENGINE FIRE
1
2
3
4
5
6
7
IN FLIGHT
If airspeed below 68 KIAS:
Perform Vmca recovery procedure
Airspeed above 68 KIAS:
1
2
3
4
5
6
Power ............................ INCREASE up to MAX

Airspeed..............................min Vyse 82 KIAS
Landing gear ............................................ UP
Flaps ....................................................... UP
Power lever (affected engine)................... IDLE
Engine Master (affected engine) ................ OFF
Above safe altitude
7 Alternator (dead engine) .......................... OFF
8 Fuel selector (dead engine)....................... OFF
1
2
3
4
5
6
7
8
In case of fire:
9 Cabin heat & defrost ................................ OFF
9
10 Canopy ......................... UNLATCH if necessary 10
Max airspeed 120 KIAS
15.02.2012
Edition # 15.2
Page 6
DA42 Twin Star
ENGINE TROUBLESHOOTING
1 Power lever (good engine) INCREASE up to MAX
2 Power lever (affected engine)................... IDLE
z If in icing conditions:
1
2
3 Alternate air ......................................... OPEN
4
5
6
7
4
5
6
7
Fuel
AUX
Fuel
ECU
quantity ...................................... CHECK

transfer (affected engine) .........CONSIDER
selector (affected engine) .... ON or X-FEED
swap (affected engine) ................... ECU B
If successful: land ASAP
If unsuccessful:
8 ECU swap (affected engine) .................... AUTO

9 Circuit breakers....................... CHECK / RESET
If successful: land ASAP
If unsuccessful:
8
9
continue with ENGINE FAILURE IN FLIGHT checklist
15.02.2012
Edition # 15.2
Page 7
DA42 Twin Star
ENGINE RESTART
1
2
3
4
5
6
7
8
Airspeed.........110 (80 *) KIAS - max 120 KIAS

Pressure Altitude ............... max 8000 (6000 *) ft
Power (affected engine) .......................... IDLE
Fuel selector (affected engine) ................... ON
Alternate air ............................. AS REQUIRED
Alternator (affected engine) ....................... ON
Engine Master (affected engine) ................. ON
Starter........................... if necessary ENGAGE
1
2
3
4
5
6
7
8
If engine started:
9 Power (affected engine) ................. MODERATE

9
10 Engine instruments.......... check GREEN RANGE 10
*) TAE 125-01 Centurion 1.7 engine
If engine did not start (re-feathering procedure):
9
10
11
12
13
14
15
16
17
(One attempt only, expect altitude loss of up to 500 ft)
Airspeed........................................... 82 KIAS
Power lever (affected engine)................... MAX
Engine Master (affected engine) ....... CHECK ON
Airspeed.......... INCREASE to achieve 1800 RPM
Engine Master (affected engine) ................ OFF
Airspeed........................... REDUCE to 82 KIAS
Propeller ...........................CHECK FEATHERED
Alternator (dead engine) .......................... OFF
Fuel selector (dead engine)....................... OFF
15.02.2012
Edition # 15.2
9
10
11
12
13
14
15
16
17
Page 8
DA42 Twin Star
OSCILLATING RPM
1 Power lever ............................. change setting
z If no success:
2 ECU swap............................................ ECU B
z If no success:
3 ECU swap............................................. AUTO
1
2
3
RPM OVERSPEED
1 Power setting.................................... REDUCE
z If no success:
2 ECU swap............................................ ECU B
z If no success:
3 ECU swap............................................. AUTO
Be prepared for ENGINE FAILURE IN FLIGHT
1
2
3
LANDING WITH DEFECTIVE MAIN GEAR TIRE

1 ATC ............................................. INFORMED
For landing:
Land on RWY side with good tire
Keep wing on good side low
Support directional control with brake
LANDING WITH DEFECTIVE BRAKES

After touchdown (if necessary):
1 Engine Masters (2) .................................. OFF
3 Electric Master ........................................ OFF
15.02.2012
Edition # 15.2
1
2
3
Page 9
DA42 Twin Star
LANDING GEAR UNSAFE WARNING

If on for more than 20 seconds:
1 Airspeed...................................max 156 KIAS
In cold temperature:
3 Gear selector ................................... RECYCLE
If landing gear extension unsuccessful:
Continue with MANUAL EXTENSION
If landing gear retraction unsuccessful:
Consider flight with landing gear down
1
2
3
MANUAL EXTENSION OF LANDING GEAR

1
2
3
4
5
6
7
Airspeed...................................max 156 KIAS

Gear indicator lights ...............................TEST
Electric master ............................... CHECK ON
Bus voltage ........................... CHECK NORMAL
Circuit breaker .................................... CHECK
Gear selector ...................................... DOWN
Manual extension handle ......................... PULL
If necessary
Apply moderate yawing
9 Gear indicator lights ............. CHECK 3 GREENS
1
2
3
4
5
6
7
8
9
LANDING GEAR UP LANDING

1
2
3
4
5
(Landing gear completely retracted)

Approach .........................................NORMAL
If time/situation allows: just before touchdown:
Power lever ........................................... IDLE
Engine Masters (2) .................................. OFF
Fuel selectors (2) .................................... OFF
Immediately after touchdown:
Electric Master ........................................ OFF
15.02.2012
Edition # 15.2
1
2
3
4
5
Page 10
DA42 Twin Star
ENGINE FIRE ON GROUND

1
2
3
4
5
Power levers (2)..................................... IDLE

Engine masters (2) .................................. OFF
Mayday call ...................................CONSIDER
Electric master ........................................ OFF
When engine and aircraft stopped:
6 Canopy ................................................ OPEN
Evacuate
1
2
3
4
5
6
ELECTRICAL FIRE ON GROUND

1
2
3
4
5

Electric Master ........................................ OFF
Power levers (2)..................................... IDLE
Engine Masters (2) .................................. OFF
When engine and aircraft stopped:
6 Canopy ................................................ OPEN
Evacuate
1
2
3
4
5
6
ELECTRICAL FIRE IN FLIGHT

1
2
3
4
5
6
7
Emergency switch .................................... ON

Avionic master ........................................ OFF
Electric master ........................................ OFF
Cabin heat & defrost ................................ OFF
Emergency windows ........... OPEN as necessary
Canopy ......................... UNLATCH if necessary
1
2
3
4
5
6
7
Max airspeed 120 KIAS

15.02.2012
Edition # 15.2
Page 11
DA42 Twin Star
1 Oxygen ......................................... CHECK ON

2 Emergency descent .......................... INITIATE
When passing 10.000 ft
3 Oxygen .................................................. OFF
1
2
3
CABIN FIRE ABOVE 10.000 FT

1 Oxygen ..........................................PUSH OFF
2 Emergency descent ........................ INTITIATE
1
2
OXYGEN PRESSURE LOSS ABOVE 10.000 FT

1 Oxygen ..........................................PUSH OFF
2 Oxygen pressure .............CHECKED, note down
3 Emergency descent ........................... INTIATE
1
2
3
CABIN SMOKE ABOVE 10.000 FT
When passing 10.000 FT:

4 Oxygen pressure ....................... CHECK AGAIN
4
If oxygen pressure constant:..... Continue flight
If oxygen pressure dropped: ....Land at nearest
suitable airfield
EMERGENCY DESCENT
1
2
3
4
Flaps ....................................................... UP
Landing Gear ...................................... DOWN
Power levers .......................................... IDLE
Airspeed................................... AS REQUIRED
1
2
3
4
SUSPICION OF CARBON MONOXIDE

1
2
3
4
5
Cabin heat & defrost ................................ OFF

Ventilation............................................ OPEN
Emergency windows .............................. OPEN
Airspeed...................................max 120 KIAS
Canopy .......................................... UNLATCH
1
2
3
4
5
Push up and lock in cooling gap position

15.02.2012
Edition # 15.2
Page 12
DA42 Twin Star
UNINTENTIONAL FLIGHT INTO ICING

Leave icing area, continue with item 1
* INADVERTENT ICING ENCOUNTER & EXCESSIVE ICE ACCUMULATION
1
2
3
4
5
6
Pitot heat ................................................ ON

Cabin heat & defrost ................................. ON
Power ...................... INCREASE PERIODICALLY
* De-ice systems................ USE as appropriate
Alternate air ........................ OPEN as required
Emergency windows ............. OPEN as required
z When pitot heat fails:
7 Alternate static valve ............................. OPEN
8 Emergency windows .......................... CLOSED
z
* When de-ice system does not work properly:
Continue with ICE PROTECTION FAILURE
1
2
3
4
5
6
7
8
* ICE PROTECTION FAILURE

1
2
3
4
5
Airspeed................................... MIN 121 KIAS

Flaps ....................................................... UP
Slip angle .......................................MINIMIZE
Approach with residual ice .................. 91 KIAS
Landing distance ................................... x 1,4
1
2
3
4
5
COMPLETE ELECTRICAL FAILURE

* Leave icing area
1 Circuit breakers...........................CHECK all IN
1
z If no success:
2 Emergency switch .................................... ON
2
3 Flood light, if necessary............................. ON
3
4 Power .................................................... SET
4
according power lever position and/or engine noise
5 Flaps ..................................VERIFY POSITION
5
Landing gear may slowly extend
For landing apply Manual extension of landing gear
15.02.2012
Edition # 15.2
Page 13
DA42 Twin Star
ABNORMAL PROCEDURES
G1000 CAUTION LIGHTS

L/R ECU A FAIL
Page 15
ECU A failed
L/R ECU B FAIL
Page 15
ECU B failed
L/R ALTN FAIL
Page 15
Alternator failed
L/R VOLTS LOW
Page 15
Bus voltage too low
L/R COOL LVL
Page 16
Engine coolant level low
PITOT FAIL
Page 16
Pitot heating system failed
PITOT HT OFF
Page 16
Pitot heating system OFF
STALL HT FAIL
Page 16
Stall warning heating failed
STALL HT OFF
Page 16
Stall warning heating OFF
L/R FUEL LOW
Page 16
Main tank fuel qty low
L/R AUX FUEL E
Page 16
L/R auxiliary fuel tank empty
STICK LIMIT
Page 16
Stick limiting system failed
DEICE LVL LO
Page 17
De-icing fluid level low
DEIC PRES LO
Page 17
De-icing pressure low
DEIC PRES HI
Page 17
De-icing pressure high
Engine instrument indications outside of green range

COOLANT temperature high/low .................. page 18
OIL temperature high/low........................... page 18
OIL pressure high/low ................................ page 18
FUEL temperature high/low......................... page 18
VOLT low.................................................. page 19
RPM high.................................................. page 19
Other abnormal situations
Both Alternators failed .......................... page 19
Hydraulic pump fail or continuous ops... page 19
AUX fuel transfer fail ............................. page 19
15.02.2012
Edition # 15.2
Page 14
DA42 Twin Star
ABNORMAL PROCEDURES
CAUTION ALERTS ON THE G1000
L/R ECU A OR B FAIL
Discontinue operation, terminate flight preparation
L/R ECU A FAIL
DURING FLIGHT
Press ECU TEST button for more than 2 seconds

If ECU B caution message re-appears or cannot be reset:
If ECU B caution message can be reset
Continue flight. Engine must be serviced after LDG
L/R ALTN FAIL

z
DURING FLIGHT
Remark: in case of ECU A fail the system automatically switches to ECU B

Press ECU TEST button for more than 2 seconds
If ECU A caution message re-appears or cannot be reset:
If ECU A caution message can be reset
Continue flight. Engine must be serviced after LDG
L/R ECU B FAIL
ON GROUND
ALTERNATOR FAILED
If in icing conditions:
Leave icing area as soon as practicable
Alternator on affected side OFF
Monitor bus voltage
Reduce electrical consumers
If both alternators failed:
See Abnormal Checklist Both Alternators failed, page 19
L/R VOLTS LOW
BUS VOLTAGE TOO LOW
Remark: possible reasons are

- fault in the electrical power supply
- Alternators OFF
Continue with Engine instrument indications outside of green range

VOLTS low, page 19
15.02.2012
Edition # 15.2
Page 15
DA42 Twin Star
ABNORMAL PROCEDURES
L/R COOL LVL
ENGINE COOLANT LEVEL LOW
Monitor annunciations / engine instruments

Check coolant temperature
See Engine instrument indications outside of green range
COOLANT TEMPERATURE
PITOT FAIL
STALL HT FAIL
PITOT HT OFF
STALL HT OFF
check pitot heat ON, if in icing conditions

expect failure of the
expect loss of
pitot-static-system
aural stall warning
alternate static valve: OPEN
leave area with icing conditions (see Emergency Checklist page 13
Unintentional flight into icing)
L/R FUEL LOW
MAIN TANK FUEL QTY LOW
Check fuel quantity
z If LH & RH quantities show remarkable difference:
Expect loss of fuel on side with lower indicaton

Use x-feed: Fuel selector to x-feed on side
with LOW FUEL indication
L/R AUX FUEL E
AUXILIARY FUEL TANK EMPTY
L/R auxiliary fuel pump OFF
VARIABLE ELEVATOR BACKSTOP

SYSTEM FAILED
1 or 2 power levers set for MORE than 20% load:
Elevator variable backstop is INOP
Do not stall in any configuration!
2 power levers set for LESS than 20% load:
Elevator variable backstop always ACTIVE
Reduced elevator capacity
For approach min VREF 76/78 KIAS
STICK LIMIT
15.02.2012
Edition # 15.2
Page 16
DA42 Twin Star
ABNORMAL PROCEDURES
DEICE LVL LO
Maximum duration of ice protection in

NORMAL mode: 45 min, in HIGH mode: 22 min
DEIC PRES LO
DE-ICING PRESSURE LOW
Switch DE-ICE to HIGH

If DEIC PRES LO light still ON
PUMP1 / PUMP2: select other pump
If necessary prime pump by activating
windshield pump
Activate ALTERNATE switch
Go to Emergency Checklist page 13
ICE PROTECTION FAILURE
DEIC PRES HI
DE-ICING FLUIS LEVEL LOW
If DEIC PRES LO light OFF

Continue flight
(de-icing fluid flow: 30 lt/hr)
Monitor ice protection system operation
Check de-icing fluid level periodically
DE-ICING PRESSURE HIGH
Possible reduced system performance

Filter cartridge to be replaced at next scheduled maintenance
15.02.2012
Edition # 15.2
Page 17
DA42 Twin Star
ABNORMAL PROCEDURES
ENGINE INSTRUMENT INDICATIONS

OUTSIDE OF GREEN RANGE
COOLANT temperature high
Refer to Emergency Checklist page 4, L/R ENG TEMP
COOLANT temperature low
Remark: During low power descent from high altitude coolant temperature
may decrease. Consider increasing power.
Check G1000 for LOW COOLANT LVL caution light
z If LOW COOLANT LVL caution light ON
Expect loss of coolant fluid
OIL temperature high
Refer to Emergency Checklist page 3, L/R OIL TEMP
OIL temperature low
Increase power
Reduce airspeed
OIL pressure high
Check oil temperature and coolant temperature

If within green range
Oil pressure indication may be faulty; watch temperatures
If outside of green range
Reduce power on affected engine;
Be prepared for an engine faiure;
OIL pressure low
Refer to Emergency Checklist page 3, L/R OIL PRES
FUEL temperature high
Refer to Emergency Checklist page 4, L/R FUEL TEMP
FUEL temperature low (JET Fuel operation)
Monitor fuel temperature

z If fuel temperature decreases to red range (< 30C):
Increase power on affected engine
Reduce airspeed
z If not returning to yellow range:
FUEL temperature low (Diesel Fuel operation)
Increase power on affected engine

Reduce airspeed
z If not returning to green range:
15.02.2012
Edition # 15.2
Page 18
DA42 Twin Star
ABNORMAL PROCEDURES
VOLTS low
On ground:
Check alternators ON
z If LOW VOLTS CAUTION still indicated on the G1000:
Discontinue operation; terminate flight preparation
In flight:
Check alternators ON
Switch off unnecessary electrical equipment
z If LOW VOLTS CAUTION still indicated on the G1000:
Apply L/R ALTN FAIL caution procedure, page 15
RPM high

Keep RPM in green range with appropriate power lever setting
z If problem not solved:
Refer to Emergency Checklist page 9 RPM overspeed
OTHER ABNORMAL SITUATIONS

Both alternators failed
Avionic Master: OFF

LH/RH Alternator: OFF
Transponder: STBY
Gear: DOWN
z When down and locked:
Pull manual gear extension handle
Stall/Pitot heat: OFF
All lights:OFF
Expect battery power to last for 30 minutes
Expect engine stoppage after this time
Land ASAP
Hydraulic pump: failure or continuous operation
Check gear indication lights

Prepare for manual landing gear extension
L/R Auxiliary fuel XFER FAIL
Both x-fer pumps OFF

Check fuel quantity
Use X-feed to keep main tank fuel unbalance within 1 USG
Switch remaining x-fer pump ON
Use X-feed to keep main tank fuel unbalance within 1 USG
Amend flight plan to allow for reduced amount of available fuel
15.02.2012
Edition # 15.2
Page 19
FMS Intitialization AUX 4 page

Recommended and compulsory settings
MFD DATA BAR FIELDS 1 GS
TIME FORMAT
UTC
NAV ANGLE
AUTO
2 DIS
DIS. SPD
NAUTICAL
3 ETE
ALT. VS
FEET
4 TRK
TEMP
CELSIUS
FUEL, FF
GALLONS
SELECTED
AUTO
POSITION
HDDDMM.MM
25,0 KHZ
AIRSPACE ALERTS
As desired
COM CHANNEL
SPACING
ARRIVAL ALERT
As desired
VOICE
As Desired
GPS CDI
NEAREST APT
RWY SURFACE
As desired
MIN LENGHT
As desired
Compulsory:
ARINC 424 Distance Coding:
A
1
F
6
K
11
P
16
U
21
B
2
G
7
L
12
Q
17
V
22
C
3
H
8
M
13
R
18
W
23
D
4
I
9
N
14
S
19
X
24
E
5
J
10
O
15
T
20
Y
25

DA42 TwinStar Checklist Edit15 2 A4 PDF

Uploaded by

Copyright:

Available Formats

DA42 TwinStar Checklist Edit15 2 A4 PDF

Uploaded by

Document Information

Original Title

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

DA42 TwinStar Checklist Edit15 2 A4 PDF

Uploaded by

Copyright:

Available Formats

What is the purpose of the document?

What is the purpose of the document?

What are the different sections of the checklist?

What are the different sections of the checklist?

Flight Training Division

Checklist for Diamond DA42 Twin Star

Checklist DA42 Twin Star - LEP

Section: Emergency Checklist

Comments explaining Edition # 15

Comments explaining Edition # 15.1

Comments explaining Edition # 15.2

DA42 Twin Star

Use of the electronic checklist (if available):

Diamond Aircraft Flight Training Division

DA42 Twin Star

if optional ice protection is

Check airplane documents

Diamond Aircraft Flight Training Division

DA42 Twin Star

Right engine nacelle

Diamond Aircraft Flight Training Division

DA42 Twin Star

CHECK BEFORE ENGINE START

Preflight check ............................COMPLETED

If starting with external power:

a Prop area ....................... CHECK CLEAR a

Checklist continued next page

Diamond Aircraft Flight Training Division

DA42 Twin Star

CHECK BEFORE ENGINE START continued

ENGINE START PROCEDURE

External power................. DISCONNECT

Start RH engine, procedure as above

DA42 Twin Star

CHECK AFTER ENGINE START

Oil pressure ................................... CHECKED

Fuel selectors (2)............................... X-FEED

FMS setup ..................................COMPLETED

Autopilot test ..............................COMPLETED

Diamond Aircraft Flight Training Division

DA42 Twin Star

BEFORE TAKE OFF CHECK

Parking brake......................................... SET

ECU swap (2) ......... ECU B, ENGINES CHECKED

Diamond Aircraft Flight Training Division

DA42 Twin Star

AFTER TAKE-OFF PROCEDURE

CLIMB TO CRUISE CHECK

Gear ........................................ CHECKED UP

PERIODICALLY DURING CRUISE

DESCENT / APPROACH CHECK

Landing data ................................. RECEIVED

BEFORE LANDING PROCEDURE

Diamond Aircraft Flight Training Division

DA42 Twin Star

AFTER LANDING CHECK

Parking brake......................................... SET

SECURING THE AIRCRAFT

Diamond Aircraft Flight Training Division