Hino 700 Series

FOREWORD(EWD).
fm
FOREWORD
This workshop manual has been prepared to provide information on electrical circuits for the following Hino Vehicles.
Applicable for FR1E, FS1E, FY1E, SH1E, SR1E and SS1E series, equipped with E13C engine
As for maintenance items, refer to the Owners Manual.
All information and specifications in this manual are based upon the latest product information available at the time of printing.
Hino Motors reserves the right to make changes at any time without prior notice.
Please note that the publications below have also been prepared as relevant service manuals for the components and systems in this vehicles.
Manual Name
Chassis Workshop Manual
E13C Engine Workshop Manual
Pub. No.
S1-YFSE17C 1/2
S1-YFSE17C 2/2
S5-YE13E02C
FOREWORD(EWD).fm
INDEX(EWD).fm 1
INDEX: CHASSIS GROUP
ELECTRIC WIRE
WORKSHOP
MANUAL
All rights reserved. This manual may not be

reproduced or copied in whole in part, without the written consent of Hino Motors, Ltd.
INDEX(EWD).fm 2
P_EL02_001.fm 1
ELECTRIC WIRE
ELECTRIC WIRE
EL02
DIAGRAM.................................................. EL02-2
HOW TO USE THIS CHAPTER........................EL02-2
CONTENTS OF DIAGRAMS ............................EL02-7
WIRING DIAGRAM.........................................EL02-11
DIAGRAM .......................................................EL02-12
WIRE TO WIRE CONNECTOR ....................EL02-142
JUNCITON CONNECTOR............................EL02-161
CONNECTOR LOCATION............................EL02-167
RELAY LOCATION .......................................EL02-240
FUSE AND RELAY BLOCK ..........................EL02-242
JUNCTION BLOCK ......................................EL02-254
WIRE TO WIRE BOX....................................EL02-258
ELECTRICAL EQUIPMENT BOX .................EL02-260
CONNECTOR INDEX...................................EL02-261
EL021
EL02-001
P_EL02_001.fm 2
EL022
ELECTRIC WIRE
DIAGRAM
HOW TO USE THIS CHAPTER
EN12Z1602J100001
WIRING DIAGRAM
(EXAMPLE)
Connector code
g7
CA-2
82560-3300
(-)
(M)
2
0.50 W-L
Serial number in the circuit diagram
(+)
1
Part number
Terminal number
5
0.50 Y-B
0.50 Y-R
f-a 4
(SLX)
(LDS+)
0.50 W-B
0.50 Y-G
(E- )
0.50 Y-G
13
($21)
15
Terminal code
($23)
Code of the wire to wire connector

"f" wiring harness side
0.50 B
(LDS- )
($22)
f-a 4
(SULK)
0.50 Y
14
f-a 4
(B+2)
Terminal code
0.50 Y-R
(B+ )
Code for the connector

of the male side
0.50 W-B
Terminal number
"a" wiring harness side
a75
IP-7
82580-6870
1
5 6
Code of the area specifying this connecor

in the section "CONNECTOR LOCATION"
3
7
Terminal number
c-a 3
c-a 3
Wiring color code
(#B3) 11
(#AU) 22
c-a 3
(#B2) 8
3.00 R-Y
0.50 W
Second letter: Stripe color
0.50 O
%2A
(ABS)
%29
(ABS)
0.01 SH-LD
Second letter: Stripe color

First letter: Ground wire color
Arabic numerals: Cross sectional area of wire
Example: 3.00 indicates 3 mm 2 {0.0047 in.2 }
0.50 BR
0.50 Y
15
(%AJ) 20
0.50 W
(%AF)15
2 (SRRE)
0.50 O
(%AE)14
2 (SRLE)
0.50 Y
Twisted-pair cable
0.50 BR
(%AD) 13
Shielded cable
d-c 1
d-c 1
%27
(ABS)
1(SRR+)
0.01 SH-LD
d-c 1
d-c 1
%28
(ABS)
1 (SRL+)
c-a 3
Serial number in the circuit diagram
(#AT) 27
1.
B: Black
BR: Brown
G: Green
L: Blue
LG: Light Green
R: Red
W: White
Y: Yellow
V: Violet
O: Orange
GR: Gray
P: Pink
16
SHTS12Z160200001
P_EL02_001.fm 3
ELECTRIC WIRE
2.
EL023
WIRE TO WIRE CONNECTOR
Connector code
[This case indicates that wire harness "a" (Cab main harness) and
wire harness "b" (Front wiring harness) should be connected, which is serial No.3 wire to wire connector.]
Name of the wiring harness to be connected.
a-b 3 / b-a 3
Cab main wiring harness to Front wiring harness 3
GE, HE, LA
IP-1, EG-5, EG-10
Code of the circuit diagram specifying this connecor

in the section "WIRING DIAGRAM"
Part number

Classification
by male/female
82560-2170, Gray, Male
82560-2180, Gray, Female
Connector color
2
3
11
10
22
21
32
31
30 29 28
20 19 18 17 16 15 14
13
12
27 26 25
24
23
12
13
23
24
14 15 16 17 18 19 20
25 26 27
10
11
21
22
31
32
28 29 30
Terminal number
LH side: Male connector or the wiring harness "a" (Cab main wiring harness)
RH side: Female connector or the wiring harness "b" (Front wiring harness)
SHTS12Z160200002
P_EL02_001.fm 4
EL024
3.
ELECTRIC WIRE
JUNCTION CONNECTOR
(EXAMPLE)
Code of the area
ELECTRIC WIRE
EL02205
EG-26 [ENGINE (3 of 3)] (Model: FM8J for Chile)
Connector code
b10
b14
b13
b11
b12
b24
ba1
bb2
ba-bc 1
bb1
bc1
sl1
b-ba 1
Code of the wire to wire connector
bc2
b45
b46
b-c 2
sk2
SHTS12Z160200166
ELECTRICAL EQUIPMENT CONNECTOR AND JUNCTION CONNECTOR

No.
Name
Circuit
No.
Name
Circuit
b10
Low pressure switch 1
BB
ba1
Battery (+) terminal (Battery 2)
AA
b11
BB
bb1
AA
b12
BB
bb2
Battery (-) terminal (Battery 2)
AA
b13
Air gauge sensor (Front)
BB
bc1
AA
b14
Air gauge sensor (Rear)
BB
bc2
Battery ground
b24
Exhaust brake magnetic valve
GE
sk2
P.T.O. magnetic valve
KB
b45
Dump up switch
KB
sl1
P.T.O. accelerator sensor
GK
b46
Service power (Tail)
AB
AA, BA,
MA

No.
b-c 2
b-ba 1
Name
Front wiring harness to
Intermediate wiring harness 2
No.
ba-bc 1
Name
Battery cable-1 to
Battery cable-3_1
Front wiring harness to

Battery cable-1_1
SHTS12Z160200003
P_EL02_001.fm 5
ELECTRIC WIRE
4.
EL025
JUNCTION CONNECTOR
Connector code
Ja13
Connector name
J/C Earth G3
AC, BA, CB, CE, DA, EA, EB, ED, EG, EO, HA, IA, KA, KB, KC, LA, MA
IP-3, IP-7

4
9
10 11 12
Terminal number
82580-8740, Blue
Part number
Internal wire connection

82550-1040, Blue
Connector color
SHTS12Z160200004
5.
FUSE AND RELAY BLOCK

TERMINAL ALIGNMENT
Terminal number
RELAY ALIGNMENT
Relay name
MZ12
Over-run
relay
85920-2680
MZ12
Power shift
relay
85920-2770
Part number
SHTS12Z160200005
P_EL02_001.fm 6
EL026
6.
ELECTRIC WIRE
CONNECTOR INDEX
(EXAMPLE)
EL02192
ELECTRIC WIRE
CONNECTOR INDEX

ELECTRICAL EQUIPMENT CONNECTOR

NAME
A
CONNECTOR
No.
PART No.
a100
82560-4100
ABS diagnosis switch
CIRCUIT OR AREA
HB
IP-4, 8

CONNECTOR
No.
a-b 1
NAME
Cab main wiring harness to

Front wiring harness 1
PART No.
MALE
CIRCUIT OR AREA
FEMALE
825602110
825602120
AA, AB, AD, AG, BA, BG, BH, CA, CB,

CE, CH, CI, GA, GB, GC, GE, HA, HB,
HC, HE, IA, LA, LE, MA
IP-1, 5, EG-1, 2, 3, 5, 6, 10, 11, 16, 17
JUNCTION CONNECTOR
CONNECTOR
No.
a606
NAME
J/C ETC 14P
PART No.
82560-3790
25880-1170
CIRCUIT OR AREA
FA, IE
IP-2

SHTS12Z160200006
P_EL02_001.fm 7
ELECTRIC WIRE
EL027
CONTENTS OF DIAGRAMS
EN12Z1602J100002
CIRCUIT
PAGE
POWER SUPPLY CIRCUIT (CONTINUOUS POWER SOURCE)
EL02-12
POWER SUPPLY CIRCUIT (STARTER SWITCH "ON")
EL02-14
BATTERY CUT SWITCH CIRCUIT (FOR TAIWAN EXPLOSION-PROOF MODEL)
EL02-16
GROUND CIRCUIT
EL02-18
EARTH SYSTEM (G2) (CAB SIDE)
EL02-20
EARTH SYSTEM (G2) (CHASSIS)
EL02-22
EARTH SYSTEM (G4-C AND G4-P)
EL02-24
ENGINE STARTING CIRCUIT (MODELS WITH MZ AND HX TRANSMISSION)
EL02-26
ENGINE STARTING CIRCUIT (MODELS WITH ZF AND EATON TRANSMISSION)
EL02-27
ENGINE STARTING ASSIST CIRCUIT
EL02-28
CHARGING CIRCUIT
EL02-29
SPARE POWER SOURCE CIRCUIT
EL02-30
ETC. SPARE POWER SOURCE CIRCUIT

(DOUBLE AS 12V SPARE POWER SOURCE)
EL02-31
12V SPARE POWER SOURCE CIRCUIT
EL02-32
METER CIRCUIT (EXCEPT SEMI-TRACTOR) (CAB SIDE)
EL02-34
METER CIRCUIT (EXCEPT SEMI-TRACTOR) (CHASSIS SIDE)
EL02-36
METER CIRCUIT (FOR SEMI-TRACTOR) (CAB SIDE)
EL02-38
METER CIRCUIT (FOR SEMI-TRACTOR) (CHASSIS SIDE)
EL02-40
TACHOGRAPH CIRCUIT
EL02-42
KIENZLE TACHOGRAPH CIRCUIT
EL02-43
FUEL FILTER WARNING CIRCUIT
EL02-44
OIL FILTER WARNING CIRCUIT
EL02-45
HEADLIGHT CIRCUIT
EL02-46
HEADLIGHT BEAM CONTROL CIRCUIT
EL02-48
TURN, STOP AND TAIL LIGHT CIRCUIT (EXCEPT SEMI-TRACTOR)

(CAB SIDE)
EL02-50
TURN, STOP AND TAIL LIGHT CIRCUIT (EXCEPT SEMI-TRACTOR)

(CHASSIS SIDE)
EL02-54
TURN, STOP AND TAIL LIGHT CIRCUIT (FOR SEMI-TRACTOR)
EL02-56
FOG LIGHT CIRCUIT
EL02-60
MARKER LIGHT CIRCUIT
EL02-61
BACK-UP LIGHT CIRCUIT (EXCEPT SEMI-TRACTOR)

(INT-W/H AND Rr-W/H INTEGRATED TYPE)
EL02-62
BACK-UP LIGHT CIRCUIT (EXCEPT SEMI-TRACTOR)

(INT-W/H AND Rr-W/H DIVIDED TYPE)
EL02-63
BACK-UP LIGHT CIRCUIT (FOR SEMI-TRACTOR)

(WITH HX, MZ TRANSMISSION)
EL02-64
BACK-UP LIGHT CIRCUIT (FOR SEMI-TRACTOR)

(WITH ZF TRANSMISSION)
EL02-65
ROOM LIGHT CIRCUIT
EL02-66
WORKING LIGHT CIRCUIT
EL02-67
HEADLIGHT WASHER CIRCUIT
EL02-68
HEADLIGHT AUTOLEVELING CIRCUIT
EL02-70
P_EL02_001.fm 8
EL028
ELECTRIC WIRE
CIRCUIT
PAGE
MIRROR HEATER CIRCUIT
EL02-72
REMOTE CONTROL MIRROR CIRCUIT
EL02-73
HORN CIRCUIT
EL02-74
CIGARETTE LIGHTER CIRCUIT (FOR RIGHT-HAND DRIVE MODEL)
EL02-75
CIGARETTE LIGHTER CIRCUIT (FOR LEFT-HAND DRIVE MODEL)
EL02-75
KEYLESS ENTRY CIRCUIT
EL02-76
POWER WINDOW CIRCUIT (FOR RIGHT-HAND DRIVE MODEL)
EL02-78
POWER WINDOW CIRCUIT (FOR LEFT-HAND DRIVE MODEL)
EL02-80
RADIO/AUDIO CIRCUIT
EL02-82
DIAGNOSIS CONNECTOR (16P) CIRCUIT
EL02-84
DIAGNOSIS MONITOR CIRCUIT
EL02-85
WIPER AND WASHER CIRCUIT
EL02-86
POWER DOOR LOCK CIRCUIT
EL02-88
POWER MIRROR CIRCUIT
EL02-89
AIR CONDITIONER CIRCUIT
EL02-90
COMMON RAIL CIRCUIT No.1 (CAB SIDE)
EL02-92
COMMON RAIL CIRCUIT No.1 (CHASSIS SIDE)
EL02-96
COMMON RAIL CIRCUIT No.2 (EGR AND VGT)
EL02-98
COMMON RAIL CIRCUIT No.3 (ABS)
EL02-100
COMMON RAIL CIRCUIT No.9 (ENGINE RETARDER)
EL02-102
COMMON RAIL CIRCUIT No.11 (SPEED LIMITER)
EL02-104
COMMON RAIL CIRCUIT No.13 (AUTO CRUISE)
EL02-105
COMMON RAIL CIRCUIT No.14 (STARTING IDLE UP CONTROL)
EL02-106
COMMON RAIL CIRCUIT No.15 (P.T.O.)
EL02-108
COMMON RAIL CIRCUIT No.17 (ETC.)
EL02-110
ABS CIRCUIT (EXCEPT SEMI-TRACTOR)

(EXCEPT AUSTRALIA AND NEW ZEALAND MODELS)
EL02-112

(FOR AUSTRALIA AND NEW ZEALAND MODELS)
EL02-114
ABS CIRCUIT (FOR SEMI-TRACTOR)
EL02-116
ES START CIRCUIT
EL02-118
ZF TRANSMISSION CIRCUIT
EL02-120
MZ TRANSMISSION CIRCUIT
EL02-122
CAB TILT WARNING CIRCUIT (MODELS WITH HX AND MZ TRANSMISSION)
EL02-124
H
I
CAB TILT WARNING CIRCUIT (MODELS WITH ZF AND EATON TRANSMISSION)
EL02-125
CAB TILT CIRCUIT (MODELS WITH HX AND MZ TRANSMISSION)
EL02-126
CAB TILT CIRCUIT (MODELS WITH ZF AND EATON TRANSMISSION)
EL02-128
P.T.O. (POWER TAKE-OFF) CONTROL CIRCUIT
EL02-130
AIR SUSPENSION CIRCUIT (FOR SEMI-TRACTOR)
EL02-132
AIR SUSPENSION CIRCUIT (FOR TAIWAN FR MODEL)
EL02-134
CAB SUSPENSION CIRCUIT
EL02-136
COUPLER LOCK CIRCUIT
EL02-137
INTER-AXLE DIFFERENTIAL LOCK CIRCUIT
EL02-138
REAR-REAR AXLE DIFFERENTIAL LOCK CIRCUIT
EL02-140
AIR DRYER CIRCUIT
EL02-141
P_EL02_001.fm 9
ELECTRIC WIRE
EL029
CONNECTOR LOCATION
CONTENTS
CODE
AREA
SPECIFICATION
PAGE
IP-1
INSTRUMENT PANEL
1 of 4
Models: Right-hand drive
EL02-167
IP-2
INSTRUMENT PANEL
2 of 4
EL02-170
IP-3
INSTRUMENT PANEL
3 of 4
EL02-172
IP-4
INSTRUMENT PANEL
4 of 4
EL02-173
IP-5
INSTRUMENT PANEL
1 of 4
Models: Left-hand drive
EL02-174
IP-6
INSTRUMENT PANEL
2 of 4
EL02-178
IP-7
INSTRUMENT PANEL
3 of 4
EL02-180
IP-8
INSTRUMENT PANEL
4 of 4
EL02-181
CA-1
CAB
1 of 2
EL02-182
CA-2
CAB
2 of 2
EL02-184
CA-3
CAB
1 of 2
EL02-186
CA-4
CAB
2 of 2
EL02-188
EG-1
ENGINE
1 of 3
Models: FS for Australia, Hong Kong, Ireland, New Zealand
EL02-190
EG-2
ENGINE
2 of 3
Models: FS for Australia, New Zealand
EL02-192
EG-3
ENGINE
2 of 3
Model: FS for Hong Kong
EL02-194
EG-4
ENGINE
2 of 3
Model: FS for Ireland
EL02-196
EG-5
ENGINE
3 of 3
Models: FS for Australia, Hong Kong, Ireland, New Zealand
EL02-198
EG-6
ENGINE
1 of 3
Models: FR, FS for Taiwan
EL02-200
EG-7
ENGINE
2 of 3
EL02-202
EG-8
ENGINE
3 of 3
EL02-204
EG-9
ENGINE
1 of 3
Models: FY for Hong Kong, Ireland, New Zealand
EL02-206
EG-10
ENGINE
2 of 3
Model: FY for Hong Kong
EL02-208
EG-11
ENGINE
2 of 3
Model: FY for Ireland
EL02-210
EG-12
ENGINE
2 of 3
Model: FY for New Zealand
EL02-212
EG-13
ENGINE
3 of 3
Models: FY for Hong Kong, Ireland, New Zealand
EL02-214
EG-14
ENGINE
1 of 3
Models: SH, SS for Hong Kong, Ireland
EL02-216
EG-15
ENGINE
2 of 3
Models: SH, SS for Hong Kong
EL02-218
EG-16
ENGINE
2 of 3
Model: SH for Ireland
EL02-220
EG-17
ENGINE
3 of 3
Models: SH, SS for Hong Kong, Ireland
EL02-222
EG-18
ENGINE
1 of 3
Models: SH, SR for Taiwan
EL02-224
EG-19
ENGINE
2 of 3
EL02-226
EG-20
ENGINE
3 of 3
EL02-228
RR-1
REAR
Model: FR with Leaf suspension
EL02-230
RR-2
REAR
Model: FR with Air suspension
EL02-231
RR-3
REAR
Model: FS except full-tractor
EL02-232
RR-4
REAR
Model: FS full-tractor
EL02-234
RR-5
REAR
Model: FY
EL02-236
RR-6
REAR
Model: SH
EL02-238
RR-7
REAR
Models: SR, SS
EL02-239
2A'.AHO
EL0210
ELECTRIC WIRE
QUICK REFERENCE
STEERING
DESTINATION MODEL SPECIFICATION INSTRUMENT PANEL
POSITION
Australia
Hong Kong
Right
Ireland
New Zealand
Taiwan
ENGINE
REAR
FS
IP-1, 2, 3, 4
CA-1, 2 EG-1, 2, 5
RR-4
FS
IP-1, 2, 3, 4
CA-1, 2 EG-1, 3, 5
RR-3
FY
IP-1, 2, 3, 4
CA-1, 2 EG-9, 10, 13
RR-5
SH
IP-1, 2, 3, 4
CA-1, 2 EG-14, 15, 17
RR-6
SS
IP-1, 2, 3, 4
CA-1, 2 EG-14, 15, 17
RR-7
FS
IP-1, 2, 3, 4
CA-1, 2 EG-1, 4, 5
RR-3
FY
IP-1, 2, 3, 4
CA-1, 2 EG-9, 11, 13
RR-5
SH
IP-1, 2, 3, 4
CA-1, 2 EG-14, 16, 17
RR-6
FS
IP-1, 2, 3, 4
CA-1, 2 EG-1, 2, 5
RR-4
FY
IP-1, 2, 3, 4
CA-1, 2 EG-9, 12, 13
RR-5
Leaf suspension
IP-5, 6, 7, 8
CA-3, 4 EG-6, 7, 8
RR-1
Air suspension
IP-5, 6, 7, 8
CA-3, 4 EG-6, 7, 8
RR-2
FR
Left
CAB
FS
IP-5, 6, 7, 8
CA-3, 4 EG-6, 7, 8
RR-3
SH
IP-5, 6, 7, 8
CA-3, 4 EG-18, 19, 20
RR-6
SR
IP-5, 6, 7, 8
CA-3, 4 EG-18, 19, 20
RR-7
P_EL02_001.fm 11
ELECTRIC WIRE
EL0211
WIRING DIAGRAM
EN12Z1602J100003
NOTICE
There is a case that the circuit diagrams in this section are different from that for your vehicle due to the model or
specification.
WIRING HARNESS CODE
CODE
NAME
Cab main wiring harness
CAB MAIN W/H
Front RH wiring harness
Fr-RH W/H
Front LH wiring harness
Fr-LH W/H
Intermediate wiring harness
INT W/H
Rear wiring harness
Rr W/H
Instrument panel wiring harness
INST W/H
Instrument panel switch wiring harness
INST SW W/H
Dash panel wiring harness
DASH W/H
Roof wiring harness
ROOF W/H
Door LH wiring harness
DOOR LH W/H
Door RH wiring harness
DOOR RH W/H
Floor wiring harness
FLOOR W/H
Headlight short circuit connector
12V spare power source wiring harness
12V W/H
Bonding earth cable
ba
Battery cable 1 (Starter to Battery relay)
bb
Battery cable 2 (Battery relay to Battery)
bc
Battery cable 3 (Battery to Battery)
bd
Battery cable 4 (Battery to Ground)
ea
Engine wiring harness
ENGINE W/H
ia
Injector sub wiring harness
ib
Link-up connector
sa
ZF transmission sub wiring harness
T/M W/H
sb
ZF transmission P.T.O. sub wiring harness
P.T.O. W/H
sc
Intake air heater sub wiring harness
I/A HEATER W/H
sd
Headlight sub wiring harness
H/LIGHT W/H
se
Cab tilt sub wiring harness
TILT W/H
sf
Air suspension valve box sub wiring harness
A/S W/H
sg
Brake valve box sub wiring harness
B/C W/H
sh
Side turn signal sub wiring harness
SIDE/F W/H
P_EL02_001.fm 12
EL0212
ELECTRIC WIRE
DIAGRAM
EN12Z1602J100004
NOTICE
Diagram may differ from the actual wiring according to the vehicle specification.
AA
FL 6
3.00 B -W
FL 5
FL 4
FL 3
FL 2
(S+)
11
2
1
(S+)
3
(B)
1
(S+)
3
(B)
3
(B)
1
(S+)
5
5
(LD)
2
(S)
5
(LD)
2
(S)
4
5
(LD)
2
(S)
1.25 W-G
0.50 W-R
To (AD,AI) J/C Earth

13P-G2
2
(S- )
5
(E )
a502
1 (ACC)
3 (M1 )
2 (M2 )
6 (ST )
a501
a503
1 (B)
3.00 W-R
FL 9
(LD) 2
FL 10
FL 4
FL 5
FL 6
AEL
(BUS2)
5
(LD)
FL 11
2 (LD)
b64
FL 12
2 (LD)
2
(39LD)
(34LD)
FUSE 39
10A
(DL) Wiper and washer
(CA) Head light (Dimmer) LH
(CA) Head light (Dimmer) RH
2 FUSE 33
(33LD)
2 FUSE 34
10A 10A
(CA) Head light (Main) LH
2 FUSE 31
(31LD)
FUSE 32
2
(32LD)
10A
(CA) Head light (Main) RH
(AL) Spare power source,

(AM) ETC. spare power source,
(AN) 12V spare power source
(+) 1
BUS BAR No.2
1
(33+)
1
(31+)
1
(22+)
FUSE 21
2
(21LD)
FUSE 22
2
(22LD)
(DD,DE) Cigarette lighter,

(CI) Radio/Audio unit,
(DF) Keyless entry,
(IG) Height control
12
b-a 4
(#6L)
(+) 1
b147
FL 3
50A
1 (+ )
50A
1 (+ )
50A
1 (+ )
60A
1 (+ )
50A
1 (+ )
60A
1 (+ )
Except Taiwan
explosion-proof model
1
(B)
To (AK) Alternator
To (AC) Battery relay No.4

(For Taiwan explosion-proof model)
Except Taiwan
explosion-proof model
6
3
(LD)
1
(S+)
60A
1 (+ )
100A
1 (+ )
AEM
(BUS3)
1
(21+)
(14+)
1
(1A+)
(AA) Starter relay (Excitation),

(BA,BC) Combination meter
FL 2
10A
3
(B)
5 (B)
2
(S-)
To Bus bar No.1

(For Taiwan explosion-proof model)
A4A
(+(2))
bb1
Battery No.1
(-(2))
1.25 B
FL 7
60A
1 (+ )
FL 1
10A
bb2
(LD) 2
15A
b70
3.00 B-W
5A
ba2
(LD) 2
5A
(13LD)
FUSE 14
2
(14LD)
2 FUSE 1A
(1ALD)
2 FUSE 11
(11LD)
2 FUSE 12
(12LD)
2 FUSE 13
5A
b70
3.00 W
1
(13+)
1
(11+)
1
(12+)
1
(LD) 2
(LD) 2
To (AH,AI) Starter
To (FA) Actuator power relay

To (EA) Air conditioner diode
(LD) 2
3.00 W-L
b63 b63 b88 b88 b61 b62
3.00 W-R
b60
(LD) 2
(LD) 2
b62
3.00 W
3.00 B-W
3.00 W-R
To (AJ) Intake air heater relay
KBM
G8Y
FUSE 17
2
(17LD)
2 FUSE 19
(19LD)
(FA) Common rail (PCV)
2
(16LD)
2
(15LD)
(FA) Common rail (ECU main relay)
(FA) Common rail (Actuator)
To (IC,ID) Cab tilt relay

1
(+B )
(LD) 2
3
(B)
3
(S)
1
(B)
5A
CAB MAIN W/H

Fr-RH W/H
3.00 W-L
To (AH,AI) Starter relay
10A
b-a 3
b-a 3
3.00 W
3.00 B-W
3.00 W-R
b-a 3
b-a 3
3.00 W-L
3.00 W
(#6C)
1
(#6B)
6
(#6A)
5
(#69)
2
(#68)
1
(#67)
b-a 4
(7K+)
b-a 4
10A 10A
FUSE 16
15A
FUSE 15
15A
1
(16+)
1
(17+)
1
(15+)
(39+)
5 (B)
6 (B)
3 (45+)
4 (51+)
0.50 W-G
(12+)
1
(S+ )
3
(B )
3.00 W
To (AB) Power supply circuit (Starter switch "ON" ) (FL 7)
B
ACC
M1
M2
ST
a501
(#6D)
6
To (AB) Power supply circuit (Starter switch "ON" ) (FL 9)
(92+)
2
3.00 W-L
b-a 4
CAB SIDE WIRING
b-a 4
1
3.00 W-R
16
(#6E)
11
5
(B)
KC5
To (FA) PCV diode
CHASSIS SIDE WIRING
L
O A O S
C C N T
K C
1
(S-)
FUSE 10
0.50 W-B
2
(10LD)
0.50 W
a510
10A
a510
1
(10+)
bc1
(+(1)) bc2 A48
Battery No.2
7
(&86)
To (AD,AF) J/C Earth
(-(1)) bd1 A49

(G4) bd2 Z12
Battery ground
SHTS12Z160200007
AA.
1.
2.
3.
4.
5.
6.
7.
8.
9.
POWER SUPPLY CIRCUIT (CONTINUOUS POWER SOURCE)

Starter switch
PCV relay
Power accessory relay
Headlight relay (Main)
Headlight relay (Dimmer)
Battery relay
Tail light relay No.1
Trailer tail light relay (For tractor model)
A4B
(+) 1
FL 14
2 (LD)
10A
FUSE 47
FUSE 49
3
(B)
5
(LD)
1
(S+)
2
(S-)
20A
FUSE 61
To Fuse 45
15A
0.50 R-B
(S+)
To (BA,BC) Combination meter
(S-)
3.00 B-W
3
(B)
1
ELECTRIC WIRE
(MI+)
16
0.50 R-B
(#KU)
(&1B)
8
(LD)
2
11 3
(LT) 3 2
(65+)
(61+)
1
(62+)
a500
To (CA) Light and

turn switch
2 FUSE 65
(65LD)
2
(62LD)
15A
FUSE 62
15A
(DG,DH) Power window
20A
2
(61LD)
(CC,CE) Turn signal light, Hazard light
(45+)
1
(51+)
1
(52+)
3.00 W-L
2 FUSE 51
(51LD)
FUSE 52
2
(52LD)
(4B+)
(#6A)
3.00 L-W
15A
1
(46+)
3
(B)
1
(S+)
3
(B)
1
(S+)
9 3
(DU) 14 2
(AA) Trailer tail light,

(AL) Spare power source (Trailer tail)
(49+)
1
3.00 W-L
10A
FUSE 46
3.00 W-L
1
(47+)
1
3.00 W-L
15A
1
(45+)
15A
FUSE 45
1
(44+)
10A
FUSE 44
5
(LD)
2
(S-)
2 FUSE 4B
(4BLD)
2
(49LD)
(GA,GB,GC) ABS (Actuator)
2
(46LD)
(DI) Radio/Audio unit, (BE,BF) Tachograph,

(BA,BC) Combination meter,
(DF) Keyless entry, (IG) Height control,
(DJ) DST-1, (IA,IB) Cab tilt,
(IH) Cab suspension
2
(47LD)
2
(45LD)
(CL) Dome light, Fluorescent light, Step light,

(DM) Power door lock, (DN) Power mirror
(GD) ES start (Solenoid valve)
2
(44LD)
(CN) Headlight washer
1
(43+)
1
(42+)
5
(LD)
2
(S-)
To FL 4
14 3
(DL) 16 2
(AL) Spare power source (P-BAT),

(AM) ETC. spare power source,
(AN) 12V spare power source,
CVO
FUSE 42
1
(41+)
7
11
10
4
(EA) Heater (Blower, Condenser)
FUSE 41
15A
(S-)
(S-)
(S-)
(CC,CE) Parking light
15A
2 FUSE 43
(43LD)
2
(42LD)
(AL) Spare power source (P-TAIL)
10A
(BA,BC) Cab interior illumination (Inter rocking tail light)

(CF) Fog light relay (Fr, Rr), Fog light (Fr, Rr),
(CB) DC-DC converter (For head light beam control),
(AA) Trailer tail light relay (Excitation)
2
(41LD)
(CC,CE) Licence plate light, Tail light,

Clearance light, Cornering light,
(CG) Marker light
P_EL02_001.fm 13
EL0213
To Fuse 43
a511
0.50 B
To (AD,AE) J/C Earth 13P G2-a
IP-2,6
82580-6060
a52
1
2
3 4 5 6
EG-5,8,13,17,20
82580-8100
b70
2 1
1: Fuse 1A is connected directry with FL 1 and not connected terminals

between "1A+" and "13+" for Australia, Ireland and New Zealand models.
2: RHD
3: LHD
CAB MAIN W/H
INSTALLATION RELAY
SHTS12Z160200008
CHASSIS SIDE WIRING
AB. POWER SUPPLY CIRCUIT (STARTER SWITCH "ON")

2
(7NLD)
FUSE 7N
FUSE 7K
10A
(AK) Alternator
2
(7KLD)
FUSE 7H
FUSE 7C
15A
(EA) Air conditioner (Magnet clutch)
(7HLD)
(7CLD)
FUSE 7E
10A 10A
(CO) Autoleveling,
(DG,DH) Power window,
(DB) Remote control mirror,
(DN) Power mirror,
(DL) Wiper and washer
(DC) Horn
2
(7ELD)
5A
(CC,CE) Stop light, (DL) Wiper
2
(77LD)
10A
(IF,IG) Height control
FUSE 77
FUSE 76
5A
(7N+)
(7K+)
(7H+)
(7C+)
(7E+)
(77+)
(76+)
(73+)
(72+)
(71+)
1
3.00 W-L
(7K+)
3.00 W-L
(76LD)
1
(7F+)
EL0214
(GA,GB,GC) ABS (ECU)
FUSE 73
FUSE 72
FUSE 71
(73LD)
(72LD)
(71LD)
FUSE 7F
5A 10A 10A
(FA) Common rail (Main)
(BA,BC) Meter circuit, (BE,BF) Tachograph
To (AA) FL 7
(7FLD)
To (AA) FL 9
(AK) Alternator
(GD) ES start
CAB SIDE WIRING
P_EL02_001.fm 14
ELECTRIC WIRE
AB
(LD)
3.00 W-R
(LD)
3.00 W-L
3.00 W-L
a507
3.00 W-L
10A
SHTS12Z160200009
(IM) Air dryer
(9ALD)
(97LD)
FUSE 9A
FUSE 97
FUSE 99
FUSE 96
FUSE 95
FUSE 94
5A
(CM) Working light
(99LD)
(96LD)
(95LD)
(94LD)
2
5A 20A
(HA) ZF (Range),
(HB) MZ (Splitter, Power shift range)
2
(93LD)
FUSE 93
FUSE 92
10A
(CC,CE,GB,GC) ABS trailer
2
(92LD)
FUSE 91
10A 15A
(AL) Spear power source (P-M)
(DA) Mirror heater
2
(91LD)
15A
(FH) Starting idle up

(IE) P.T.O. (Power take-off)
(CH,CI,CJ,CK) Back-up light, Back buzzer,

(IK,IL) Differential lock,
(CC,CE) Trailer pick-up
1
(9A+)
(97+)
(99+)
(96+)
(95+)
(94+)
(93+)
(92+)
(91+)
3.00 W -R
3.00 W -R
3.00 W -R
3.00 W -R
3.00 W -R
P_EL02_001.fm 15
ELECTRIC WIRE
EL0215
10A 10A
SHTS12Z160200010
P_EL02_001.fm 16
EL0216
ELECTRIC WIRE
(161+)
1
(162+)
AC
AEL
15.00 W
FUSE 162
(162L)
0.4A
c-a 1
(#BR)
10
0.85 G
(+)
2
0.85 B
(-)
1
(S-)
1
(S+)
OFF
ON
5
(LD)
c122
EG-7,19
82580-7580
($9J)
b141
To (AA) Bus ber No.2
15.00 W-B
(+)
2.00 W-B
(&8A)
100A
(B)
Fr-LH W/H
(LD)
3
b145
FL17
(B)
1
b142
2
(LD)
b149
3A 15.00 W
b150
To (AA) Battery relay
15.00 B
b141
2.00 B-Y
5
30A
b144
b148
b146
3
($9H)
50A
FL16
b142
To (AK) Alternator
(B)
CHASSIS SIDE WIRING
(#6Z)
Fr-RH W/H
(+)
0.85 G
b-a 3
CAB MAIN W/H
To (CI) Radio/Audio unit, (BE) Tachograph
2.00 W-B
3.5A
CAB SIDE WIRING
2
(161L)
2
FUSE 161
10A 5A
2
b202
(BUS2)
8
Z09
(&8D) (G2)
To (AD,AF) Earth power and light No.2
J/C Earth G2-b

0.85 L
SHTS12Z160200011
AC.
1.
2.
3.
BATTERY CUT SWITCH CIRCUIT (FOR TAIWAN EXPLOSION-PROOF MODEL)

Battery cut switch (Front)
Battery cut switch (Rear)
Battery relay (For battery cut)
ELECTRIC WIRE
EL0217
INST W/H
f98
(BT+)
IP-6
82560-3010
OFF
ON
(BTI-)
3
0.85 W-G
(BT-)
2
1
2
14
J/C Earth 14P-G2

f604
Z01
(G1)
6
($52)
($58)
0.85 L
($0J)
18
a-f 1
0.85 L
0.85 W-G
a-f 1
12
($0C)
0.4A
0.50 B
20
Fr-RH W/H
(#VJ)
c-a 1
21
(#UA)
Fr-LH W/H
b-a 4
To (AD,AE) Earth AS-1
CAB MAIN W/H
0.85 W-G
P_EL02_001.fm 17
SHTS12Z160200012
P_EL02_001.fm 18
EL0218
ELECTRIC WIRE
AD
8.00 B
f39
J/C Earth 13P G2-a
(&49)
a612
1.25 B
2
(FTL-)
Z23
(G2)
Z21
(G2)
(#57)
3.00 B
a106
To (CC,CE) Front turn signal light LH
a107
(PGD1)
8.00 B
a-f 6
To (BE,BF) Tachograph, KINZLE tachograph
INST W/H
0.50 BR
a607
1
(&4C)
$58
a105
J/C Earth 14P
Joint
$58
Z01
(G1)
3.00 B
4
(#48)
1.25 BR
INST W/H
Earth AS-3
To (FA) Common rail ECU
($01)
Earth AS-2
a-f 1
CAB SIDE WIRING
SERVICE GROUND
#59
#59
Joint
b-a 2
b-a 1
(#65) 1
(#64)
b-a 1
2
(#61)
(#62)
b-a 2
3.00 BR
CAB MAIN W/H

Fr-RH W/H
1.25 BR
5.00 BR
Earth AS-1
0.50 BR
1
(M/V-)
b-c 1
(%04)
To (GD) ES start solenoid valve (G4-P)
5.00 BR
b-c 2
(%03)
Battery No.1
A4B
(-(2))
A48
(+(1))
Battery No.2
b202
Z08
(G1)
1: Detail: Refer to
b79
the "AA. POWER SUPPLY CIRCUIT".
2: RHD
Earth
power
and
3: For truck model
light No.1
4: For semi-tractor model
5: Except semi-tractor model
Battery ground
1.25 B
5.00 B
8.00 B
3.00 B
Z09
(G2)
b80
J/C Earth
b-c 2
3
1.25 B
b-c 2
5
8
(&85)
5 (%15)
c-se 1
(CM)
2
(CM)
3.00 B
To (IC,ID)
Cab tilt motor
TILT W/H
1.25 B
1.25 B
1.25 B
6
(%01)
6
3.00 B
(%01)
3.00 B
1.25 B
Earth power and

light No.2
(%15)
c-se 1
3.00 B
b78
1.25 B
(&8D)
Earth power and

light No.4
Z12
(G4)
J/C Earth G2
Earth power and
light No.3
c-se 1
Z11
(G5)
b87
b81
3.00 B
Z10
(G3)
(%15)
5
3.00 B
A49
(-(1))
3.00 B
Fr-LH W/H
2
(CM)
2
3.00 B
3.00 B
(&8J)
A4A (+(2))
5
3.00 BR
5.00 BR
8.00 B
3.00 B
CHASSIS SIDE WIRING
1.25 BR
J/C Earth
b201
c-d 1
c-d 1
3.00 B
(%A2)
3.00 B
2
(%A2)
b201
Fr-LH W/H
SHTS12Z160200013
AD. GROUND CIRCUIT
P_EL02_001.fm 19
ELECTRIC WIRE
EL0219
2.00 B
J/C Earth 14P
J/C Earth 14P-G2
(&4B)
a608
1.25 B
11
(&4A)
1.25 B
a607
2.00 B
Z24
a68 (G3)
Z22
a67 (G3)
Earth DR-3
CAB SIDE RH POWER AND LIGHT GROUND (G2)
J/C Earth 14P-G2
Earth DR-2
2.00 B
11
f-a 4
2.00 B
($0B)
(&52)
CAB MAIN W/H
Z02
a66 (G2)
Earth DR-1
f604
INST W/H
0.50 BR
2
(FSDE)
Fuel sender
2
7
(4 E2)
To (BK) ABS trailer socket (G4-P)
CHASSIS SIDE POWER AND LIGHT GROUND (G2-S)
J/C Earth G2-B

4
c202
3
J/C Earth G2-A
4
Fr-LH W/H
1.25 B
c201
5
(&99)
(&9A)
5.00 BR
4
5.00 B
Z19
(RR 1)
c116
Rr-W/H
INT-W/H
3
Z19
(RR 1)
Earth power and

light rear
Rr-W/H
e9
3.00 B
2
(%C5)
e-d 1
Earth power and

light rear
Z19
(RR 1)
e9
Earth power and

light rear
SHTS12Z160200014
P_EL02_001.fm 20
EL0220
ELECTRIC WIRE
AE
J/C Earth 14P-G2
(&4B)
14 (&3A) (NO-) 3
(BT) 8
2 (&38)
(HF) 9
7 (&33)
To (CC,CE) Stop light switch

To (CC,CE) Light and turn switch
To (CC,CE) Wiper and retarder switch
To (IE) Transmission P.T.O. switch
(For left-hand drive model)
2
1
2
To (CA) Light and turn switch
1
(ME) 2
10
(EP) 15
3
(EL) 2
#4H
(E)
3.00 B
a-f 1
3 (&37)
12 (&4H) (IND-) 2
0.85 B
9
(GND)
(GND)
a608
To (CI)
Radio/Audio unit
f39
($01)
3
(GND)
To (AM) ETC. sub power supply
SERVICE GROUND
5 (&35)
f16
4 (&36)
Earth audio
13 (&3B)
(-) 5
1 (&39)
INST W/H
To (CC,CE)
Front side turn signal light LH
To (DA) Mirror heater (Side under)
To (DA) Mirror heater (Back LH)
DOOR LH W/H
To (CF) Front fog light switch
10 (&3D) (FGI-) 4
INST W/H
1
2
(STN-)
8
(SU E)
5
(LH E)
(EW) 4
DOOR RH W/H
To (DL) Wiper and retarder switch
2
2
(STN-)
9
(&49)
a-j 1
a-k 1
7 (&1A)
CAB MAIN W/H
3 (&12)
5
(S-)
2
(S-)
6 (&1B)
To (CC,CE)
2
($A2)
To (AZ) Air conditioner condenser relay

To (AA) Trailer tail light relay
1: RHD
2: LHD
4 (&11)
3.00 B
CAB SIDE WIRING
1 (&14)
20
(S-)
5
(S0 E)
8
(LH E)
1
(S-)
To (DA) Mirror heater relay
2
(SML-)
To (CG) Front side marker light LH (For right-hand drive model)
2
(SML-)
To (CG) Front side marker light RH (For left-hand drive model)
13 (&15)
10 (&18)
5 (&10)
To (DA) Mirror heater (Side under)

To (DA) Mirror heater (Back LH)
Standard mirror
To (FA) PCV relay
8 (&19)
12 (&16)
a612
J/C Earth 13P G2-a

13
(&4A)
Z01
(G1)
a607
a105
Z21
(G2)
Earth AS-1
7
(IR-)
To (DL) Wiper controller
5
(S-)
To (HA) ZF range relay
5
(S-)
To (HB) MZ12 splitter relay
5
(S-)
To (HB) MZ12 range relay
5
(S-)
To (HB) MZ12 power shift relay
2
b-a 1
(#61)
2
b-a 2
(#62)
(RFI-) 4
12 (&44)
(RFE) 7
7 (&3V)
(DGDS) 2
6 (&3W)
(DGDO) 2
5 (&3X)
(E) 8
To (IL) Differential lock buzzer

To (CF) Rear fog light switch
To (DK) Diagnosis standard connector
To (DK) Diagnosis option connector,
(FG) Auto cruise main switch
To (CC,CE) Trailer Pick-up controller
J/C Earth 14P
CAB MAIN W/H
a106
Earth AS-2
(DLB-) 2
14 (&43)
Z23
(G2)
2
(FTL-)
2
(FTR-)
To (CC,CE) Front turn signal light LH (For right-hand drive model)

To (CC,CE) Front turn signal light RH (For left-hand drive model)
a107
Earth AS-3
To CHASSIS SIDE
Refer to the "AF. Earth SYSTEM (G2) (CHASSIS SIDE)"
.
SHTS12Z160200015
AE. EARTH SYSTEM (G2) (CAB SIDE)
P_EL02_001.fm 21
ELECTRIC WIRE
EL0221
INST W/H
To (CE) Pick-up controller
To (BA,BC) light check relay
To (DA) Headlight washer relay
To (EA) Air conditioner diode
To (EA) Air conditioner condenser
CAB MAIN W/H
1
(GND)
(P2) 5
(GND) 8
8
(E )
5
(S-)
2
(LD)
5
(GND)
1
(A)
5
(HCI-)
7
(E )
1
(E-)
2
(IUI-)
3
(GND)
To (EA) Cooler control switch

To (EA) Blower switch
To (CN) Wiper and retarder switch
To (DN) Power mirror controller
To (DM) Power door lock controller
To (FH) Start idle up switch (For left-hand drive model)
DASH W/H
3
(SCG)
2
(FTR-)
2
(FTR-)
4
(RH E)
To (IH) Front leveling valve
2
(LVF-)
To (BA,BC) Trailer hand brake switch

2
(THB-)
31 h-a 1
($5X)
18
($5J)
DOOR RH W/H
To (CC,CE) Front side turn signal light RH
(For right-hand drive model)
To (DG,DH) Power window switch (Driver's seat side)
To (DA) Mirror heater (Back RH)
(Models equipped with door mirror)
To (DM) Power door lock switch
(Driver's seat side)
6
(&52)
2
(STN-)
h-a 1
a-f 4
13
($21)
1
(&57)
j-h 1
To (EA) Pressure switch (Triple)

To (CC,CE) Front turn signal light RH
To (CC,CE) Front turn signal light LH
To (DA) Mirror heater (Back RH)
(Models equipped with standard mirror)
f604
11
a-f 1
($0B)
14
2
(BTI-)
(&58)
4
2
(&5U) (IND-)
2
8
(&5N) (IND-)
12
3
(&5A) (HMI-)
2
3
(&56)
(RM-)
5
1
(&54)
(E)
6
3
(&5V) (GND2)
To (AC) Battery cut switch (Front)

To (IE) Transmission P.T.O. switch
To (FJ) Economy running switch
To (DA) Mirror heater switch
To (DB) Remote control mirror switch
To (DF) Keyless entry controller
To (CB,CO) DC/DC converter
(For head light beam control)
J/C Earth 14P-G2
6
($96)
2
(SML-)
2
(SML-)
6 k-h 1
($96)
5 k-h 2
($9D)
To (CG) Front side marker light RH

To (CG) Front side marker light LH
6
(E)
5
(RH E)
6
(SCOM)
2
(THB-)
To (BA) Trailer hand brake switch
2
(ZFB-)
To (HB) Shift buzzer
8
(BSW)
To (EA) Air conditioner
4
(GND)
To (EA) Lock amp
DOOR LH W/H
To (CC,CE) Front side turn signal light LH
To (DG,DH) Power window switch (Driver's seat side)
2
(STN-)
6
(E )
CAB MAIN W/H
ROOF W/H
1
(-)
To (DD,DE) Cigarette lighter
2.00 B
3
($85)
a-i 1
2
(F/L-)
To (CL) Fluorescent light
2
(MLR+)
To (CG) Roof marker light RH
2
(MLL+)
To (CG) Roof marker light LH
Z24 (G3)
a68
Earth DR-3
Z02 (G2)
a66
Earth DR-1
INST W/H
FLOOR W/H
Z22 (G3)
a67
Earth DR-2
f-m 1
7
($77)
ENGINE SIDE WIRING

15
a-ea 4
(#1R)
1
(F/F )
To (BG) Fuel filter

warning switch
SHTS12Z160200016
P_EL02_001.fm 22
EL0222
ELECTRIC WIRE
AF
Refer to the "AE. EARTH SYSTEM (G2) (CAB SIDE)"
To CAB SIDE
Z10 b81
(G3)
b-a 1
Z11
b87 (G5)
5.00 B
Z09
(G2)
b80
Z08
(G1)
Earth power and

light No.1
To (AJ) Heater relay

To (AI) Starter relay
To (CD) Side turn signal light LH
SIDE/F W/H (For dump truck)

1
Z19
(RR)
c116
(%01)
Earth power and

light rear
b-c 2
2
2
(SW4-)
1
(GND1)
Earth power and
To (GC) ABS front modulator RH

(For semi-tractor)
To (HB) MZ12 splitter Hi magnetic valve No.1
CHASSIS SIDE WIRING
2
(CST-)
Fr-LH W/H
8.00 B
b79
To (CD) Side turn signal light RH
Before build body
Earth power and

light No.4
Earth power and

light No.3
1 (L)
2 (E)
2 (S-)
8.00 B
3.00 B
(&81) 4
(&82) 3
(&86) 7
(&85)
(#61)
b-a 2
(#62)
Fr-RH W/H
3.00 B
2
(CSR-)
c-sh 1
b201
J/C Earth
3
(%2D)
To (GC) ABS rear modulator LH

4
(For semi-tractor) (GND)
4
To (GC) ABS rear modulator RH
(For semi-tractor) (GND)
To (IK,IL) Differential lock magnetic valve
2
(For Australia truck) (E)
light No. 2
2
(GND)
3
(E)
To (HB) MZ12 splitter Lo magnetic valve No.2
4
(E)
To (HB) MZ12 splitter magnetic valve No.1
4
(E)
To (HB) MZ12 range Hi magnetic valve No.2
5
(E)
To (HB) MZ12 range Lo magnetic valve No.3
6
(E)
To (BB,BD) Low pressure switch No.4

2
(SW4-)
Fr-RH W/H

To (CE) Trailer socket (For semi-tractor)
2
(LLR-)
To (CI,CJ) License plate light LH (For semi-tractor)
2
(RFR-)
To (CF) Rear fog light (For semi-tractor)
2
(E)
To (HA) ZF High-Low magnetic valve
2
(E)
To (HA) ZF clutch magnetic valve
Fr-LH W/H
8
(&8D)
3
(&8A)
2
(-)
2
(TSL-)
4
(GND)
2
(&8B)
1
(&8C)
2
(SW2-)
7
(&8E)
2
(SW1-)
6
(&8F)
2
(SW3-)
5
(&8G)
To (IM) Air dryer

To (BB,BD) Trailer stop light switch
To (GA) ABS front modulator RH
(Except semi-tractor)
c-se 1
To (CM) Spot light
5
(%15)
2
(CM)
To (IC,ID) Cab tilt motor
3
(S-)
To (IC,ID) Cab tilt relay
2
(-)
2
(S-)
TILT W/H
H/LIGHT W/H
J/C Earth G2
b202
To (CD,CE) Cornering light RH
2
(E)
5
(&99)
4
(&91)
3
(&92)
To (IA,IB,IC,ID) Cab tilt buzzer

To (GA,GB,GC) ABS front modulator LH
To (CD,CE) Cornering light LH
2
2
(TBZ-) (&93)
4
1
(GND) (&94)
2
8
(E)
(&95)
c-sd 1
7
(%F0)
5
(E-)
To (CA)
Headlight RH
c-sd 2
7
(%E0)
5
(E-)
To (CA)
Headlight LH
7
(&96)
To (IE) Transmission P.T.O.

magnetic valve
2
(E)
6
(&97)
1
(E)
To (DC) Horn (Hi-Lo)
J/C Earth G2-A

c201
SHTS12Z160200017
AF. EARTH SYSTEM (G2) (CHASSIS)
ELECTRIC WIRE
EL0223
SIDE/F W/H (For dump truck)
After build body
e-sh 1
2
(RCB-)
To (CD) Rear combination light LH
2
(RCB-)
To (CD) Rear combination light RH
2
(LLP-)
To (CH) License plate light RH
Rr-W/H
(INT-W/H)
Fr-LH W/H
1
(%A2)
To (CC,CD,CE) Side turn

signal light RH (For dump truck)
2
(CST-)
To (CC,CD,CE) Side turn

signal light LH (For dump truck)
Rr-W/H (INT-W/H and Rr-W/H divided type)

d-e 1
(%C5)
To (CF) Rear fog light

(For truck
1
(GND1)
To (CD) Trailer socket (For full-tractor)
Earth power and

light rear
2
(RFR-)
To (CF) Rear fog light
2
(BLP-)
To (CH) Back-up light RH
2
(BLP-)
To (CH) Back-up light LH
2
(LLR-)
To (CH) License plate light LH
2
(BBZ-)
To (CH) Back buzzer (For Hong Kong except semi-tractor)

(INT-W/H and Rr-W/H integrated type)
4
(GND)
To (GB) ABS rear modulator RH (For Australia)
4
(GND)
2
(PSW-)
To (CD) Rear combination

light RH (For truck)
2
(RCB-)
To (CD) Rear combination

light LH (For truck)
Earth power and

light rear
Rr-W/H
(INT-W/H)
To (BB) Spring brake switch
4
(GND)
To (GA, GB) ABS rear modulator LH

(Except Australia truck)
4
(GND)
To (GA, GB) ABS rear modulator RH

(Except Australia truck)
To (IK) Differential lock magnetic valve
(Except Australia)
2
(E)
2
(RCB-)
INT-W/H and Rr-W/H integrated type

To (GB) ABS rear modulator LH (For Australia)
11
e-sg 1
(%1H)
2
(RFR-)
Z19
Z19 (RR 1)
e9
8
(%23)
c-e 10
8
(CSR-)
INT-W/H and Rr-W/H integrated type

sf-d 1
c-d 1
3
(%2D)
B/C W/H (Except semi-tractor)
(RR 1)
P_EL02_001.fm 23
e9
2
(BLP-)
To (CI) Back-up light RH

(For truck)
2
(LLP-)
To (CI) License plate light RH

(For truck)
2
(BLP-)
To (CI) Back-up light RH

(For truck)
2
(LLR-)
To (CI) License plate light LH

(For truck)
2
(BBZ-)
To (CI) Back buzzer

(For Hong Kong truck)
A/S W/H
5
(EXR-)
6
(EXL-)
4
(INL-)
To (IG) Height control magnetic valve

(For FR model)
J/C Earth G2-B

(For semi-tractor)
4
c202
(&9A)
2
(RML-)
A/S W/H
To (IF) Height control magnetic valve
(For semi-tractor)
2
(E)
2
(BLP-)
2
(RCB-)
To (CE) License plate light RH

To (CJ,CK) Back-up light RH
To (CE) Rear combination light LH
To (CJ,CK) Back-up light LH

To (CE) Rear combination light RH
Fr-LH W/H
2
(BBZ-)
2
(E)
To (CJ,CK) Back buzzer

(For Hong Kong semi-tractor)
To (IJ) Differential lock magnetic valve
(For semi-tractor)
11
(%1H)
To (CG) Rear endout maker RH

(For semi-tractor)
2
(LLP-)
2
(BLP-)
2
(RCB-)
sg-c 1
2
(RMR-)
2
c-sf 2
(%2A)
To (CG) Rear endout maker LH

(For semi-tractor)
2
(&9C)
1
(&9D)
8
(&9E)
7
(&9F)
6
(&9G)
5
(&9H)
2
(PSW-)
To (BD) Spring brake switch
B/C W/H (For semi-tractor)

1: For semi-tractor
2: Except semi-tractor
3: Except Australia, New Zealand
4: For Australia, New Zealand
SHTS12Z160200018
P_EL02_001.fm 24
EL0224
ELECTRIC WIRE
AG
FOR ECU POWER SYSTEM (G4-P)
#58
#58
CAB SIDE WIRING
6
(PGD1)
Joint
5.00 BR
3
(PGD3)
4
(PGD2)
To (GA,GB,GC) ABS ECU

To (GA,GB,GC) ABS diagnosis switch
To (GA,GB,GC) ABS ECU
CAB MAIN W/H

Fr-RH W/H
(#64)
b-a 1
4
(GND)
2
(-)
12
(VV1-)
b201
CHASSIS SIDE WIRING
5
0.85 BR
To (BB) Speed sensor (Except ZF transmission)
To (GD) ES start solenoid valve
(M/V-)
1,
b-c 2
(&8J)
6
(&8Q)
J/C Earth
Fr-LH W/H
5.00 BR
2
(SPS-)
Rr-LH W/H
5.00 BR
7
(%03)
5.00 BR
SAW
(4 E2)
SAV
(3 E1)
(4 E2)
2
(3 E1)
c-e 10 2
(%A4)
To (GB)
ABS trailer socket
A4A (+(2))
To (GC) ABS trailer socket
Battery No.1
A4B
(-(2))
A48
(+(1))
5.00 BR
A49
(-(1))
b78
Battery No.2
Z12
(64)
Battery ground
SHTS12Z160200019
AG. EARTH SYSTEM (G4-C AND G4-P)
P_EL02_001.fm 25
ELECTRIC WIRE
EL0225
FOR CPU AND GAUGE SYSTEM (G4-C)

J/C Earth 14P
0.50 BR
a607
Joint
#59
#59
4
(128)
3
(129)
9
(135)
a-h 1
7
($55)
2
(NO-)
0.50 BR
DASH W/H
2
(ESW-)
1
(MGE )
12
(SGND)
12
(PCE)

To (DJ) DST-1 connector
To (BA,BC) Pulse adjust computer
To (FA) Brake switch

To (GD) Clutch fluid pressure switch
(CGD2) 4
(CGD1) 5
(GND ) 3
(GND2) 16
To (GD) ES start ECU
(PGN1) 25
(PGN2) 26
4
($48)
To (BE,BF) Tachograph, KINZLE tachograph

26
(PGN2)
To (BF) KINZLE tachograph
26
(PGN2)
To (IG) Air suspension controller

(Remote control type)
INST W/H
Fr-RH W/H
(#65)
b-a 2
a-f 6
CAB MAIN W/H
To (IG) Air suspension ECU
0.50 BR
T/M W/H
To (BB,BD,BF) Speed sensor (For ZF transmission)
0.50 BR
b-c 1
(%2X)
c-sa 2
4
(SPS-)
0.50 BR
(%04)
(%A5)
2
1
(FSDE)
To (BD) Fuel gauge sender unit
3
1
(FSDE)
2
(WLE)
0.50 BR
To (BB) Fuel gauge sender unit

To (BB,BD) Coolant level warning switch
Fr-LH W/H
1: Full-tractor
2: Semi-tractor
SHTS12Z160200020
P_EL02_001.fm 26
EL0226
ELECTRIC WIRE
AH
31
0.50 R-B
(ST)
a609
To (HB) MZ12 range and

splitter change switch
To (AB) Fuse 91
2
(&AE)
0.50 R-B
0.50 R-B
0.50 R-B
0.50 B-O
(11LD)
b66
b68
b-a 4
7
0.85 B-Y
b68
0.85 R-B
1
3
(B)
A3W
(E)
5
A3Y
(C)
2
1
2
8.00 W-L
3
c-b 2
(+ )
b49
STARTER
EG-3,7,10,15,19
82580-6730
b28
EG-3,7,10,15,19
82580-7180
A3Z
(E )
Battery cable
(E )
To (AE,AF) J/C Earth (G2)
ba1
(B)
0.85 R-B
b49
3
(&82)
8.00 W-L
1
(C)
(LD)
50.00 B-R
0.50 B
(%07)
ENGINE SIDE WIRING
CHASSIS SIDE WIRING
2
(LD)
Fr-RH W/H
(#A8)
To (AA) FL 10
2
Fr-LH W/H
0.50 B-W
b66
EG-5,8,13,17,20
98060-6050
(SW)
b68
EG-5,8,13,17,20
82580-7320
(#6J)
Fr-RH W/H
c-a 1
b-a 4
CAB MAIN W/H
(#6K)
0.50 B-O
0.50 R-B
To (AA) Fuse 11
7
(61)
a102
a103
To (FA)
Common rail ECU
(&F5)
J/C Common rail 20P
(&C5)
(NTL)
(&AF)
0.50 B-O
(NUSW)
(91LD)
13
10
CAB SIDE WIRING
Body Earth
SHTS12Z160200021
AH.
1.
2.
3.
ENGINE STARTING CIRCUIT (MODELS WITH MZ AND HX TRANSMISSION)

Starter relay
Starter
Neutral switch
P_EL02_001.fm 27
ELECTRIC WIRE
EL0227
31
(MUSW)
b-a 4
7
1.25 B-Y
0.85 R-B
0.85 R-B
(+)
(-)
0.85 R-B
0.85 R-B
1
(%2T)
(3)
&82
(#6K)
5
35
37
c-a 2
(%2U)
2
1
0.50 B
8.00 W-L
b49
Battery cable
EG-2,4,12,16
82580-6730
b104
EG-2,12
82580-7180
A3Z
(E )
STARTER
sa3
EG-4,11,16
82560-1340
c-b 3
ba1
To (AE,AF) J/C Earth (G2)
(%07)
sa-c 2
(C)
(LD)
50.00 B-R
ENGINE SIDE WIRING
3
0.85 R-B
b49
Fr-RH W/H
1.25 B-Y
4
8.00 W-L
(+)
5
A3Y
b68
(B)
T/M W/H
(-)
A3W
(C)
b66
(#U4)
1.25 B-Y
(#6J)
b68
(E)
Fr-LH W/H
sa-c 2
2
(LD)
To (AA) FL10
(SW)
b66
EG-5,13
98060-6050
(B)
b68
EG-5,13
82580-7320
0.50 B-W
b-a 4
CAB MAIN W/H

Fr-RH W/H
(&F5)
1.25 B-Y
(11LD)
a102
a103
0.50 R-B
0.50 B-O
c-a 1
0.50 B-O
1.25 B-Y
0.50 R-B
10
To (AA) Fuse 11
(&AE)
J/C Common rail 20P
(&C5)
a609
(#A8)
13

6
(NTL)
To (AB) Fuse 91
2
(91LD)
(&AF)
0.50 B-O
(ST)
AI
Body Earth
1: ZF transmission
2: EATON transmission
SHTS12Z160200022
AI.
1.
2.
3.
4.
ENGINE STARTING CIRCUIT (MODELS WITH ZF AND EATON TRANSMISSION)

Starter relay
Starter
Neutral switch (ZF transmission)
Neutral switch (EATON transmission)
P_EL02_001.fm 28
EL0228
ELECTRIC WIRE
AJ
b67
(%0A)
(%17)
sc-c 1
sc-b 1
Fr-LH W/H
(B24V)
10.00 B
(%17)
INTAKE AIR HEATER W/H
sc2
c-b 3
4
(&81)
EG-1,9,14
9806-06150
10.00 B-W 1
10.00 B-W
10.00 B-W
(F)
To (CD,CF) J/C Earth (G2)
sc2
2
A6H
(E)
ENGINE SIDE WIRING
(HRY2)
6
3
(S)
b69
To Bus bar No.1
(SW)
b69
b67
EG-5,12,17
9806-06150
AEM
(BUS3)
(L)
b69
EG-5,12,17
82560-2810
0.50 B
CHASSIS SIDE WIRING
0.50 R-B
Fr-RH W/H
(#6M)
b-a 4
CAB-MAIN W/H
0.50 R-B
7
0.50 R-B
CAB SIDE WIRING
(HRY)
To (AA) Common rail ECU
2
Body Earth
1: RHD
2: LHD
SHTS12Z160200023
AJ. ENGINE STARTING ASSIST CIRCUIT

1. Intake air heater relay
2. Intake air heater
P_EL02_001.fm 29
ELECTRIC WIRE
EL0229

7
(MCHG)
(71LD)
To (AB) Fuse 71
CAB SIDE WIRING
AK
&9J
(3)
0.50 Y-G
11
ea-a 4
CAB MAIN W/H
0.50 Y-G
0.50 W-L
3A 15.00 W
1
ea20
b68
1
(B)
b44
ea20
b44
EG-1,6,9,14,18
82580-8640
EG-1,6,9,14,18
98060-6150
2
A41
(E)
ENGINE SIDE WIRING
3A 15.00 W
13
ea-a 4
Fr-RH W/H
(#1M)
1
(+ )
(L)
100A
0.50 W-L
FL 17
(#1P)
2
(LD)
(R)
To (AA) FL 11
(LD)
CHASSIS SIDE WIRING
1
Body earth
1
1: Taiwan explosion-proof
2: Except Taiwan explosion-proof
SHTS12Z160200024
AK. CHARGING CIRCUIT

1. Alternator
P_EL02_001.fm 30
EL0230
ELECTRIC WIRE
To (AA) Fuse 42
2
(42LD)
To (AA) Fuse 22
2
(22LD)
To (AB) Fuse 94
5,6,7
f38
7
1
10
a-f 1
1.25 Y
34
1
(3)
1.25 L
1.25 Y
(#BK)
c-a 2
1.25 L
c-a 2
(#BJ)
35
($0A)
1.25 Y
1
1.25 L
4
($0G)
a-f 1
16
($04)
c-a 1
28
39
(#BC)
c-a 1
10,11,12
(2)
(#BD)
2.00 R
(1)
1.25 W-L
c65
EG-3,8,10,11,
17,20
82580-4240
0.85 W-G
c66
EG-3,8,10,11,
17,20
82580-4240
c67
c68
c69
EG-3,8,10,11,
17,20
82580-4240
CHASSIS SIDE WIRING
28
CAB MAIN W/H

Fr-LH W/H
4
f35
(PTL2)
3
f34
(#BB)
2
f33
(PAC2)
1
f32
c-a 2
2.00 R
a-f 1
0.85 W-L
0.85 W-G
(PTL1)
2.00 R
1.25 W-L
0.85 W-G
(PAC1)
0.85 B-R
(PIG1)
1,2,3,4
(3)
f37
(2)
f36
10
a502
(42LD)
(22LD)
11
(A1A)
12
a504
f500
(42LD)
f-a 1
$0L
f502
(20)
(A5B)
1.25 W
(P1)
f32
f34
f33
f35
IP-2,6
97840-4050
CAB SIDE WIRING
f502
INST W/H
INST W/H
(1)
(94LD)
f36
f37
f38
IP-2,6
97840-4050
0.85 B-R
J/B
(52LD)
CAB MAIN W/H
To (AA) Fuse 52
AL
J/B
10
11
12
c67
c68
c69
9
SHTS12Z160200025
AL.
1.
2.
3.
4.
5.
6.
SPARE POWER SOURCE CIRCUIT

P/BAT
P/M
P/ACC CAB
P/TAIL CAB
SERVICE CAB 1
SERVICE CAB 2
7.
8.
9.
10.
11.
12.
SERVICE CAB 3
P/ACC CHASSIS
P/TAIL CHASSIS
SERVICE CHASSIS No.1
P_EL02_001.fm 31
ELECTRIC WIRE
EL0231
AM
1.25 W
(+B )
2
0.50 R-B
(A5B)
6
(ILL)
1
0.50 W-G
(A1Y)
13
(ACC)
3
1.25 B
(A1A)
f502 f501 f502
When installed 12V spare power source,

connect the 24V spare power source connector.
2
(52LD)
2
(43LD)
2
(22LD)
To (AA) Fuse 52
To (AA) Fuse 43
To (AA) Fuse 22
(GND)
INST W/H CAB MAIN W/H

1
($01)
f40
IP-2,6
82580-6920
3.00 B
1
(GND)
(AE) Ground circuit (G2)
1 2
3 4
SHTS12Z160200026
AM. ETC. SPARE POWER SOURCE CIRCUIT (DOUBLE AS 12V SPARE POWER SOURCE)
1. ETC. sub power supply connector
P_EL02_001.fm 32
EL0232
ELECTRIC WIRE
AN
Connect the ETC sub power supply connector.
12V W/H
4
0.85 R-Y
(ILL)
1
0.85 W-B
(12IL)
1
1.25 B-R
(12AC)
5
(GND)
(+12 )
1
2
(12+ )
6
(ACC)
3
CAB SIDE WIRING
1.25 W-L
(+B )
2
(12- )
1.25 W
(24+)
10
0.50 R-B
(24IL)
3
0.50 W-G
(24AC)
9
(24-)
1.25 B
4
(+B24)
2
(ILL)
1
(ACC)
3
(GND)
1.25 W-L
1.25 B-R
(GND )
SHTS12Z160200027
AN.
1.
2.
3.
4.
12V SPARE POWER SOURCE CIRCUIT

P12V connector
DC/DC converter
P24V connector
12V socket
P_EL02_001.fm 33
ELECTRIC WIRE
o1
IP-1
82580-6920
o3
o2
o4
IP-2
82580-7210
IP-2
82580-8380
IP-1
82580-4610
1 2
1 2
3 4
5 6 7 8 9 10
3 4
EL0233
2 1
4 3
SHTS12Z160200028
P_EL02_001.fm 34
EL0234
ELECTRIC WIRE
BA
a501
J/C CAN
2
(72LD)
14
(98)
4
(94)
To (AA) Fuse 43
To (AA) Fuse 46 2
(46LD)
To (FA) J/C CAN
0.50 L-Y
18
(&3J)
19
(&3S)
17
(&3K)
(#L5)
To (AB) Fuse 72
(72LD)
0.50 L-Y
2
(43LD)

To (DK) Diagnosis option connector
1
J/C ETC 13P-1
18
17
21
22
0.50 W-L
To (BE) Tachograph
(MM+B)
(MMT-)
a47
(MMT+)
(MI+)
3 4
CAB MAIN W/H
0.50 W-L
a48
9 10 11 12 13 14 15 16
(&24)
(&1N)
12
(&1W)
5
(&1D)
13
0.50 W-L
16
CPU
(MGE)
(MFLS)
(MARE)
(MARR)
12
0.50 P-B
0.50 W-B
0.50 BR
14
0.50 P-G
15
0.50 P-L
(MWL)
13
10
a48
0.50 P
a47
(MOLP)
(MAR+)
(MARF)
(MTM)
(SPMP)
11
a502
0.50 R-B
7
(#KU)
9
(RVSP)
10
(SPSP)
0.50 W-L
IP-1,5
82580-7960
a614
a47
CAB SIDE WIRING
1
(D+BS)
1
(D+BO)
20
(&3R)
a504
a25
a619
0.50 R
2
(&C2)
0.50 Y-R
0.50 R-L
0.50 Y-R
0.50 BR
To (AD,AG) J/C Earth 14P
0.50 L-R
0.50 L
(PCI+)
11
0.50 L-R
2
(&F2)
(PCO+)
(PCS+)
(PCR1)
9
(&46)
4
(&3Y)
16
(TACH)
ea-a 1
Fr-LH W/H
(#2E)18
c-a 2
(#DK) 22
c-a 2
(#DJ) 18
b-a 7
(#7Q) 8
b-a 7
b-a 7
(#7L) 5
(#7K) 4
b-a 7
Fr-RH W/H
(#7J) 3
b-a 5
b-a 5
(#6Q) 9
(#6P) 1
c-a 5
(#U5) 5
CAB MAIN W/H

Fr-LH W/H
a103
a102
(#U6) 6
To (GD)
ES start ECU
To (FA)
Common rail ECU
12
(PCE)
0.50 L
18
(VS)
c-a 5
4
(PC+)
(PCO3)
10
(SS1G)
CHASSIS SIDE WIRING
(PCRO)
2
(PC04)
16
1
(SS)
0.50 Y-R
To Chassis side
(Refer to the circuit "BB")
SHTS12Z160200029
BA.
1.
2.
3.
4.
5.
METER CIRCUIT (EXCEPT SEMI-TRACTOR) (CAB SIDE)

Combination meter
Pulse adjust computer
Light check relay
Trailer hand brake switch
Warning buzzer
Fr-RH W/H
5
f75
IP-2
82580-6820
1
2
0.50 G-O
(AE) Ground circut (G2)

(AI) Engine starting circuit
2
(#6J)
(G3)
INST W/H
11
($0B)
2.00 B
To (CC)
Pick-up controller
1 2 3 4 5 6 7 8 9 10 11
1 2 3 4 5 6 7 8 9 10 11
12 13141516171819202122
12 13141516171819202122
1
1
1
22pin
a47
To Chassis side
(Refer to the circuit "BB")
19
(PKB)
To (CC) Hong Kong 2

diode (K)
Z22
0.50 B
To (IG)
Air suspension ECU
a45
To (GD)
ES start ECU
CAB MAIN W/H
(WBZ-)
a49
12
(MBZ)
a49
IP-2,6
82560-2470
(WBZ+)
a49
11
(MHC+)
To (AA) Fuse 32
To (CC) Turn signal

flasher
To (IL)
Differential lock
To (IK,IL)
Differential lock
To (IE) P.T.O. position

switch (J/C ETC)
a48
IP-2,6
82560-2470
0.50 W-R
a49
(MHTC)
(MHCE)
a503
2
(21LD)
(MPAK)
5
(32LD)
9
(&3U)
9
(&3U)
9
(&3U)
2
(LHLD)
4
(RHLD)
4
(&3N)
To (AA) Fuse 21
(MTIN)
CAB MAIN W/H
19
1
(LP1)
20
2
(EBZ)
a48 a47 a48
(MOLF)
18
17
19
16
2
(N/O-)
To (HB)
MZ12 range relay
To (HB) MZ12 range
Lo switch
1 2 3 4 5 6 7 8 9
10 11 12 13 14 15 16 1718
18pin
0.50 BR-R
a49
(MABS)
(MCHG)
a49
(MHBM)
(MTUR)
(MTUL)
(MDL2)
(MDL3)
(MDLK)
(MPTO)
To (HB) MZ12 splitter

Hi switch
a47
IP-2,6
82560-2230
1
8
(IND)
To (GA) ABS ECU

To (BH)
Oil filter warning switch
7
2
(L)
11
9
(WL)
5
1
(O/C)
To (AK) Alternator
(MFFL)
(MSBT)
(MENG)
(MIIR)
(MTRB)
(MESS)
a48
a49
To Seat belt switch

To (BG)
Fuel filter warning switch
12 16
(CE/G)
1
6
(SBW+)
2
13
(F/S)
14
5
(PR)
21
10
a48
0.50 L-G
(&33)
($02)
0.50 B-O
f-a 1
a47
(THB+)
2 2
(ME)
(MHI2)

Lo switch
ELECTRIC WIRE
21
c-a 2
(#DM)
19
c-a 2
(#DN)
2.00 B
a49
(THB-)
3
1 0.50 L-G
0.50 B-O
10
(&AE)
0.50 G-O
2
a49
20
c-a 2
(#DL)
(G2)
0.50 B
b-a 7
Z21
(MLO2)
(M2HI)
(M2LO)
a49
9
(#7R)
(11LD)
(B)
3 0.50 B-O
(S+)
1
To (AD,AE)
J/C Earth
14P-G2
(LD)
5
(S-)
0.50 B 2
0.50 B
To (AA) Fuse 11
2
(N/O-)
4
(NC-)
2
(N/O-)
3
(S+)
4
(NC)
P_EL02_001.fm 35
EL0235
22pin
(21LD)
0.50 W-G
a49
IP-2,6
82580-6390
5
18
(PKB1)
(AE) Ground circut (G2)

6
(&52)
1: ZF transmission
2: Except ZF transmission
3: LHD
4: RHD
5: Australia
SHTS12Z160200030
P_EL02_001.fm 36
EL0236
ELECTRIC WIRE
CAB SIDE WIRING
BB
0.50 P-G
0.50 P-B
2 (ASRS)
1 (ASR-)
2
0.50 P-L
3 (ASR+)
b75
b76
0.50 Y-R
1
0.50 BR
(%04)
0.50 BR
0.50 P
0.50 P-L
0.50 BR
2 (SPS-)
3 (ASF+)
0.50 L-R
3 (SPSP)
0.50 P-B
0.50 L
1 (SPS+)
2 (ASFS)
0.50 BR
4 (SPS-)
1 (ASF-)
0.50 L
(WL+)
1
2
(FSDE)
6
(WLE)
(FSD+)
To (AD,AG) J/C Earth

(G4-C)
(&8Q)
4 (%2W)
5 (%2X)
sa-c 2
T/M W/H
0.50 L-R
sa-c 2
3 (%2V)
(AG) Ground circuit (G4-C)
1 (SPS+)
sa-c 2
(%04) 0.50 BR (%A5)
3 (SPSP)
CHASSIS SIDE WIRING
0.50 BR
(OIL+)
ENGINE SIDE WIRING
0.50 L-R
ea-a 1
(#2E)18
c-a 2
0.50 R-L
0.50 W-B
0.50 L
Fr-LH W/H
(#DK) 22
c-a 2
(#DJ) 18
b-a 7
b-a 7
(#7Q) 8
b-a 7
(#7L) 5
(#7J) 3
(#7K) 4
b-a 7
b-a 5
b-a 5
(#6P) 1
Fr-RH W/H
(#6Q) 9
(#U6) 6
(#U5) 5
c-a 5
CAB MAIN W/H

Fr-LH W/H
c-a 5
To Cab side
(Refer to the circuit "BA")
Body Earth
5.00 BR
(%04)
5
(%A5)
sa4
5
b35
b37
b75
b76
3
c50
4
c51
c47
EG-4,11
82560-1340
EG-2,3,7,12
82560-3570
EG-7,10
82560-1340
EG-5,8,13
82560-3190
EG-5,8,13
82560-4350
EG-5,13
82580-6600
EG-2,3,4,7,9
82580-7180
1 2 3
1 2 3
3,4
1 2 3
6
SHTS12Z160200031
BB.
1.
2.
3.
4.
5.
6.
7.
METER CIRCUIT (EXCEPT SEMI-TRACTOR) (CHASSIS SIDE)

Speed sensor (For ZF transmission)
8. Low pressure switch No.4
Speed sensor (Except ZF transmission)
Front air gauge sender unit
Rear air gauge sender unit
Fuel gauge sender unit
12. Spring brake switch
Coolant level warning switch
13. Buzzer cancel switch
Oil pressure warning switch
P_EL02_001.fm 37
ELECTRIC WIRE
EL0237
10 0.50 BR-R
sg-e 1
(%A6)
(%1G)
0.50 G-O
11
0.50 W-R
(PSW-)
(SW1+)
10
(SW3+)
(SW2+)
(SW4+)
sg-e 1
sg-d 1
sg-e 1
2
12 0.50 W-R
(%1J)
(%A7)
13 0.50 W-L
(%1K)
e-c 1
7
(%A8)
0.50 W-R
d-c 1
1
1
d-c 1
0.50 W-L
e-c 1
0.85 B
(BSW+)
1
1
13
(SW1-)
b71
(SW3-)
b73
(SW2-)
b72
(SW4-)
b74
sg-d 1
2 0.50 W-L
(BSW-)
0.50 B
c-a 2
Fr-LH W/H
Rr-W/H
(INT W/H)
12
8
(#DN) 19
e-c 1
0.50 BR-R
1
1
d-c 1
(PSW+)
0.50 G-O
(#DM) 21
c-a 2
20
1
sg-d 1
0.50 G-O
0.50 BR-R
0.50 G-O
(#DL)
(#7R)
b-a 7
CAB MAIN W/H

Fr-RH W/H
c-a 2
To Cab side
(Refer to the circuit "BA")
0.50 B
5.00 B
ea17
(&8F)
0.85 B
sg-d 1
(%1H)
Z09
(G2)
b71
b72
b73
b74
EG-5,8,13
82560-3590
8,9,10,11
3.00 B
(%A2)
To (AD,AF)
J/C Earth (G2)
(AF) Ground circuit (G2)
EG-1,6,9
82580-6830
0.50 B
11
7
1
(&8G)
6
8
(&8D)
(%01)
0.50 B
1.25 B
(&8E)
5
B/C W/H
(%C5)

sg5
sg7
RR-1,2,3,4,5
82580-6770
RR-1,2,3,4,5
82580-6820
12
1: Except full-tractor, Taiwan dump, mixer

2: Full-tractor, Taiwan dump, mixer
3: Except Australia, New Zealand
4: Australia, New Zealand
5: HX transmission
6: MZ transmission
13
SHTS12Z160200032
P_EL02_001.fm 38
EL0238
ELECTRIC WIRE
BC
a501
(72LD)
To (CF)
Rear fog light switch
2
(RFI+)

To (DK) Diagnosis option connector
J/C ETC 13P-1
(&24)
(&1N)
12
(&1W)
5
(&1D)
13
CAB MAIN W/H
(MM+B)
To (BE) Tachograph
(MGE)
(MFLS)
(MARE)
(MARR)
1
0.50 BR
12
0.50 W-B
ea-a 1
16
(TACH)
0.75 L
(#2E)18
0.50 R-L
ENGINE SIDE WIRING
2
(&C2)
4
(&3Y)
0.50 Y-R
0.50 BR
0.50 L-R
0.50 L
9
(&46)
2
(&F2)
9
(PCI+)
11
0.50 L-R
(PCS+)
a103
a102
To Chassis side
(Refer to the circuit "BD")
c-a 2
(#DK) 22
c-a 2
(#DJ) 18
b-a 7
(#7Q) 8
b-a 7
b-a 7
(#7L) 5
(#7K) 4
b-a 7
Fr-RH W/H
(#7J) 3
b-a 5
b-a 5
(#6Q) 9
(#6P) 1
c-a 5
(#U6) 6
c-a 5
(#U5) 5
CAB MAIN W/H

Fr-LH W/H
(PCR1)
1
(PCO+)
(PC+)
To (GD)
ES start ECU
To (FA)
Common rail ECU
0.50 L
4
(PCRO)
16
12
(PCE)
(MOLP)
3
0.50 P-B
0.50 Y-R
14
0.50 P-G
15
0.50 P-L
(MWL)
13
a48
0.50 P
10
11
a47
(OIL+)
(MAR+)
(MARF)
(MTM)
(SPMP)
2
(PC04)
CHASSIS SIDE WIRING
CPU
0.50 Y-R
10
(SS1G)
0.50 W-L
0.50 R
18
(VS)
3 4
a47
(MMT+)
(MI+)
(MMT-)
a48
9 10 11 12 13 14 15 16
18
17
0.50 W-L
21
0.50 W-L
22
7
(#KU) 0.50 R-B
16
a502
1
(D+BS)
1
(D+BO)
20
(&3R)
9
(RVSP)
10
(SPSP)
0.50 W-L
IP-1,5
82580-7960
a614
a47
CAB SIDE WIRING
a619
(#L5)
a504
0.50 L-Y
To (CF)
Front fog light switch
1
(FGI+)
2
(72LD)
a25
0.50 L-Y
18
(&3J)
19
(&3S)
To (AB) Fuse 72 17
(&3K)
To (AA) Fuse 46 2
To (FA) J/C CAN
14
(98)
4
(94)
To (AA) Fuse 43
2
(43LD)
J/C CAN
Body Earth
Fr-LH W/H
ea17
EG-14,18
82580-6830
3
SHTS12Z160200033
BC.
1.
2.
3.
4.
5.
METER CIRCUIT (FOR SEMI-TRACTOR) (CAB SIDE)

Combination meter
Warning buzzer
Fr-RH W/H
2
1.25 B
DASH W/H
6
($96)
f-a 1
0.50 B

($02)
($5V)
h-a 1
(THB+)
1
4
2
11
a49
a49 a48 a47 a48
(MOLF)
(MPAK)
a49
a48
a47
($0B)
2.00 B
To Chassis side
(Refer to the circuit "BD")
5
15
(WM6)
5
1
(O/C)
To (CO)
Autoleveling ECU
To (BH)
12
(MBZ)
(MDL2)
a49
IP-2,6
82560-2470
a45
To (CE) Hong Kong 2

diode (K)
1
CAB MAIN W/H

Fr-LH W/H
(WBZ-)
(MDLK)
To (AA) Fuse 32
a48
IP-2,6
82560-2470
(WBZ+)
9
(&3U)
19
(MPTO)
(MTUR)
1 2 3 4 5 6 7 8 9 10 11
1 2 3 4 5 6 7 8 9 10 11
12 13141516171819202122
12 13141516171819202122
1
1
1
22pin
0.50 W-R
(MRTD)
a48
0.50 BR-R
(MCHG)
(MPFL)
(MABS)
(MITN)
(MATB)
To (IK) Differential
lock switch (J/C ETC)
4
(118)
16
a47
1 2 3 4 5 6 7 8 9
10 11 12 13 14 15 16 1718
18pin
2
(L)
13
22
(MSBT)
(MENG)
(MIIR)
(MTRB)
To (IE) P.T.O. position switch
2
(32LD)
a48
To (CE) Turn signal flasher
To (IJ) Coupler lock switch
a48
(MTUL)
a49
(MHBM)
2
(N/O-)
U80
(G)
3
(LHLD)
10
2
(RHLD)
To (HB)
MZ12 range relay
To (HB) MZ12 range
Lo switch
(MCPL)

Hi switch
a49
a47
IP-2,6
82560-2230
To (AK) Alternator
To (GC) ABS ECU

To (BG) Fuel filter
warning switch
11
(WL)
2
(F/S)
To (GC) ABS trailer 3

socket (5 WR)
To (CE) 1
Pick-up controller (IND)
21
a49
To (AS) Seat belt switch
10
a49
12 16
(CE/G)
1
6
(SBW+)
0.50 L-G
0.50 L-G
(ME)
(MHI2)

Lo switch
ELECTRIC WIRE
21
c-a 2
(#DM)
19
c-a 2
(#DN)
($5X)
(ME)
2
a47
20
c-a 2
(#DL)
31
29
(&33)
0.50 L-G
0.50 L-G
0.50 G-O
IP-2, CA-4
82580-6820
(THB+)
7 0.50 B
b-a 7
4
(MLO2)
a49
9
(#7R)
1
3
4
1
To (AD,AE)
J/C Earth
14P-G2
(THB-)
f75
h17
(M2HI)
(M2LO)
2
(N/O-)
4
(NC-)
2
(N/O-)
3
(S+)
4
(NC)
P_EL02_001.fm 39
EL0239
22pin
CAB MAIN W/H
IP-2,6
82580-6390
INST W/H
(THB-)
0.50 B
(&52)
6
1: ZF transmission
2: Except ZF transmission
3: LHD
4: RHD
SHTS12Z160200034
P_EL02_001.fm 40
EL0240
ELECTRIC WIRE
CAB SIDE WIRING
BD
c-a 2
1: Except Hong Kong

2: Hong Kong
Fr-LH W/H
(#DK) 22
c-a 2
(#DJ) 18
b-a 7
b-a 7
(#7Q) 8
b-a 7
(#7K) 4
(#7J) 3
(#6P) 1
(#7L) 5
b-a 7
b-a 5
b-a 5
Fr-RH W/H
(#6Q) 9
(#U6) 6
(#U5) 5
c-a 5
CAB MAIN W/H

Fr-LH W/H
c-a 5
To Cab side
(Refer to the circuit "BC")
0.50 L
0.50 L-R
b37
b75
b76
EG-16
82560-1340
EG-15,19
82560-1340
EG-17,20
82560-3190
0.50 R-L
1
0.50 BR
0.50 BR
b76
b75

c50
EG-16,19
82560-4350
1 2 3
3,4
c47
EG-15,16,19
82580-7180
(%04)
sa4
6
(WLE)
0.50 P-B
1 (ASR-)
(WL+)
0.50 W-B
0.50 P-G
2 (ASRS)
0.50 P-L
3 (ASR+)
5
(FSDE)
0.50 P
0.50 P-L
0.50 BR
2 (SPS-)
3 (ASF+)
0.50 L-R
3 (SPSP)
0.50 P-B
0.50 L
1 (SPS+)
2 (ASFS)
0.50 BR
4 (SPS-)
1 (ASF-)
0.50 L
0.50 L-R
1 (SPS+)
T/M W/H
(FSD+)
To (AD,AG) J/C Earth

(G4-C)
(&8Q)
5 (%2X)
(%04) 0.50 BR (%A5)
sa-c 2
sa-c 2
sa-c 2
3 (SPSP)
CHASSIS SIDE WIRING
3 (%2V)
4 (%2W)
0.50 BR
1 2 3
c78
EG-15
82560-3340
5
SHTS12Z160200035
BD.
1.
2.
3.
4.
5.
6.
METER CIRCUIT (FOR SEMI-TRACTOR) (CHASSIS SIDE)

11. Spring brake switch
12. Buzzer cancel switch
P_EL02_001.fm 41
ELECTRIC WIRE
EL0241
3: RHD
4: LHD
(#DN) 19
0.50 W-L
#DN
c-a
2
(#DM) 21
0.50 W-R
c-a 2
20
0.50 BR-R
(#DL)
b-a 7
CAB MAIN W/H

Fr-LH W/H
(#7R)
Fr-RH W/H
#DM
c-a
2
To Cab side
(Refer to the circuit "BC")
10
0.50 G-O
(PSW+)
0.50 BR-R
0.50 G-O
0.50 G-O
Fr-LH W/H
b-c 2
4 0.50 G-O
11
(%0F)
5.00 B
(SW1+)
To (AD,AF)
J/C Earth (G2)
b73
b74
EG-17,20
82560-3590
(&8F)
7,8,9,10
13
(%1K)
0.85 B
(SW4+)
5.00 B
(%01)

b71
b72
(%1H)
1
sg-c 1
(%1J)
B/C W/H
0.85 B
0.50 B
6
(&8G)
(&8E)
5
1
(G2)
0.50 W-L
(BSW+)
12
(SW4-)
1
2
2
1
(%01)
0.50 B
0.50 B
(&8E)
(&8D)
sg-c 1
12
11
(BSW-)
0.50 B
1.25 B
0.50 W-R
(SW1-)
10
b71
(SW3+)
1
2
b73
(SW3-)
(SW2+)
1
2
(SW2-)
b72
1
2
(SW4-)
b74
(SW4+)
(PSW-)
0.50 G-O
sg-c 1
(%1G)
0.85 B
sg-c 1
To (AD,AF) J/C Earth G2-B
1
(RR 1)

sg13
sg14
EG-17,20
82580-6770
EG-17,20
82580-6820
11
12
SHTS12Z160200036
P_EL02_001.fm 42
EL0242
ELECTRIC WIRE
BE
To (AA) Fuse 43
To (AB) Fuse 72
2
(43LD)
2
(A1Y)
0.50 R-B
19
(TCI+)
1
0.50 W-L
3
(TCSW)
1
4
(TCCL)
0.50 L-Y
(72LD)
2
(46LD)
9 10
11 12 13 14 15 16 17 18 19 20
(A7K)
1 2 3 4 5 6 7 8
2
(72LD)
To (AA) Fuse 46
f31
IP-2,6
82580-7000
(TCE)
0.50 BR
4
($48)
10
(SPSP)
0.50 R
7
($07)
TO (AD,AG) Ground circuit (G4-C)
0.50 R
0.50 Y
16
(PCRO)
CAB MAIN W/H
a-f 1
a-f 1
INST W/H
($05)
0.50 Y
(RVSP)
BZR
SPEED
CLK
CAB SIDE WIRING
ILL
REV

10
(SPMP)
0.50 R
(PCO+)
SHTS12Z160200037
BE. TACHOGRAPH CIRCUIT

1. Tachograph
P_EL02_001.fm 43
ELECTRIC WIRE
EL0243
BF
To (AA) Fuse 46
To (AB) Fuse 72
2
0.50 R-B
f31
(TCI+)
19
(TCSW)
SPEED
WARNING SW
To (AA) Fuse 43
(A1Y)
2
(72LD)
0.50 W -L
(72LD)
2
(46LD)
1
(A7K)
0.50 L-Y
4
(TCCL)
CLOCK
CAB SIDE WIRING
2
(43LD)
3W
IP-2,6
82580-7000
3W
1 2 3 4 5 6 7 8
18
(TCI-)
7 (SPP2)
0.50 L-W
0.50 BR
20 (SPSP)
0.50 R
($0C)
4 (PCI+)
0.50 L-W
0.50 L
0.50 BR
5
(%A5)
c-sa 2
c-sa 2
c-sa 2
c-sa 2
8 (%D1)
0.50 L-W
sa4
4 (%2W)
0.50 L-R
3 (%2V)
0.50 L
EG-4,14,16
82560-1340
5 (%2X)
0.50 BR
0.50 BR
4 (SPS-)
1
2
(FSDE)
0.50 BR
2
4
2
(%04)
1
3
2
2 (SPP2)
(#U8)
c-a 5
0.50 L-W
c-a 5
(#U6)
8
(%04)
3 (PCS+)
0.50 L-R
3 (SPSP)
0.50 L
0.50 L-R
0.50 BR
FR-LH W/H
(#U5)
6
c-a 5
0.50 L-R
CAB MAIN W/H
To (AG) Ground circuit (G4-C)
a-f 1
7
($07)
12
a-f 1
INST W/H
($48)
1 (SPS+)
(TCE)
0.50 BR
CHASSIS SIDE WIRING
9 10
11 12 13 14 15 16 17 18 19 20
2: Semi-tractor
T/M W/H
SHTS12Z160200038
BF. KIENZLE TACHOGRAPH CIRCUIT

1. KIENZLE Tachograph
2. Speed sensor
P_EL02_001.fm 44
EL0244
ELECTRIC WIRE
13
(MFFL)
0.50 P
ea-a 4
14
(#1Q)
0.50 P
2
(F/S)
ea7
(F/F)
ENGINE SIDE WIRING
0.50 B
15
CAB MAIN W/H
(#1R)
ea-a 4
0.50 B
(&14)
CAB SIDE WIRING
To (AD,AE) J/C Earth 13P-G2
BG
EG-1,6,9,14,18
82580-9420
1
1
SHTS12Z160200039
BG. FUEL FILTER WARNING CIRCUIT

1. Fuel filter warning switch
P_EL02_001.fm 45
ELECTRIC WIRE
EL0245
19
KT2
Engine earth
(O/C)
0.75 LG
(#2F)
CAB MAIN W/H
ea-a 1
0.50 LG
(MOLF)
BH
ea21
ea21
EG-1,6,9,14,18
82580-6570
SHTS12Z160200040
BH. OIL FILTER WARNING CIRCUIT

1. Oil filter warning switch
P_EL02_001.fm 46
EL0246
ELECTRIC WIRE
3
(B)
1
(S+)
3
(B)
1
(S+)
CA
a100
5
(LD)
2
(S-)
1
FUSE 31
2
(31LD)
FUSE 32
0.50 R-Y
(S-)
(32LD)
2
5
(S-)
5 (#S2)
(31LD)
0.50 R-W
4
3 (#S1)
5 4 3 2 1
a505 a500
a503
(32LD)
FUSE 33
2
4
n1
10A
a500
(33LD)
0.50 R-Y 10
a100
10A
(33LD)
FUSE 34
2
3
(34LD)
CAB SIDE WIRING
a502
Halogen headlight
0.50 B-L
(34LD)
10A 10A
IP-1,5
82560-2540
(31+)
(33+)
5
(LD)
2
(S-)
1: RHD
2: LHD
n1
n2
IP-1,5
82560-2550
IP-1
82560-2550
1 2 3 4 5
1 2 3 4 5
ED DL DU EP
HF
0.50 B
(&35)
To (CO) Autoleveling ECU
c-a 1
c-a 1
32
(#AB)
33
c-a 1
34
Fr/LH W/H
c-a 1
3
(HLSW)
CAB MAIN W/H
(EP)
2
1
(ED)
10 2
15 1
8
17
0.50 R-Y
0.50 R-L
0.50 R-Y
0.50 R-W
0.50 R-W
0.50 R
HU
(MHBM)
(#AA)
To (CN) Headlight washer circuit
0.50 R-Y
n2
HN
(#A9)
Hong Kong
only
B-L
Discharge headlight
0.50 L
(DU)
14 1
9 2
14 2
16 1
(DL)
1 (#S3)
18
(HDLP)
0.50 R-L
25
(#AJ)
0.50 R-W
0.50 R-Y
0.50 R
0.50 R-G
sd-c 2
1
(%E8)
0.50 R-G
3
CLEARANCE
To (AD,AF) J/C Earth G2-A
2
3
Halogen headlight
0.85 B
7
(%E0)
sd1
IP-1,6,9,14,18
82580-6970
(CLR+)
sd-c 2
(%E7)
0.50 R-W 2
4
(HI +)
MAIN
3
0.50 R
2
(LOW+)
H/LIGHT W/H
(E-)
(%E6)
sd-c 2
FOG
DIMMER
0.50 O
1
3
(LCR+)
(FLL+)
4
5
(E-)
CLEARANCE
MAIN
4
(HI+)
2
(LCW+)
DIMMER
1
(FLL+)
FOG
Discharge headlight
(%E5)
sd-c 2
CHASSIS SIDE WIRING
0.50 O
sd-c 2
1.25 B
(&96)
SHTS12Z160200041
CA.
1.
2.
3.
4.
5.
6.
7.
8.
9.
10.
HEADLIGHT CIRCUIT
Headlight short circuit connector (Cab side)
Light and turn switch
Headlight LH
Cornering light diode
Headlight RH
P_EL02_001.fm 47
3
(B)
1
(S+)
EL0247
3
(B)
1
(S+)
ELECTRIC WIRE
a54
(LD)
2
(S-)
(43+)
FUSE43
a809
IP-1,5
82560-3800
(43LD)
FUSE41
2
(41LD)
1
(42+)
10A
FUSE42
2
(42LD)
11
11
3
(S-)
8 9 1011121314151617
10A
(LT)
4 5 6 7
2
1 0.50 R-G
a500
1 2 3
8
1
5
(41+) (LD)
2
(S-)
IP-2,6
82580-9310
EL LT LH
OFF
T
(&36)
a615
1
(A)
(K)
J/C ETC 13P-2
To (AD,AE) J/C Earth

14P-G2
(LH)
4 1
5 2
0.50 R-L
(EL)
0.50 B
3
2
2
1
12
0.50 R-L
(&29)
4
0.50 R-Y
20
(S-)
(&23)
5
(CHW)
(RFLH)
7
(P)
22
0.50 O
To (CC,CE) Cornering light relay LH
To (CF) Rear fog light switch
To (CC,CE) Parking light switch

To (CF) Front fog light switch
c-a 1
23
(#AL)
0.50 O
13
7
(%F0)
sd-c 1
1.25 B
3
(CRH+)
CLEARANCE
MAIN
4
(HI +)
Discharge headlight
0.85 B
EG-1,6,9,14,18
82580-6970
5
(E-)
DIMMER
10
FOG
1
(FLR+)
2
(LOW+)
sd4
CLEARANCE
1
3
0.50 R-G
MAIN
(%F8)
sd-c 1
0.85 R-G
Fr/LH W/H
(E-)
DIMMER
5
FOG
10
Halogen headlight
CAB MAIN W/H
(CRH+)
sd-c 1
2
(%F7)
(HI+)
(%F6)
0.50 R-W
(LOW+)
sd-c 1
2
(FLR+)
0.50 R
(%F5)
sd-c 1
1
0.50 O
H/LIGHT W/H
(#AW)
c-a 1
(LD)
3
(&92)
2
3
10
To (AD,AF)
J/C Earth G2-A
SHTS12Z160200042
P_EL02_001.fm 48
EL0248
ELECTRIC WIRE
CB
0.50 R-B
19
To (BE,BF) Tachograph
(TCI+)
0.50 R-B
3
(&5V)
0.50 B
0.50 B-R
(GND)
(GND2)
f-a 5
($2C)
f-a 5
($2B)
INST W/H
f1
IP-1,5
82560-3290
1
a73
4 5 6
IP-2,6
82560-2290
0.50 B-R
0.50 R-G
1
1
(HLI-)
1 2 3
(H/L0)
0.50 B-R
CAB SIDE WIRING
0.50 R
(VOUT)
(VIN1)
0.50 R
(#LB)
(HLI+)
To (AA) Fuse 43
0.50 R-G
0.50 B-R
(LVA+)
sd-c 2
0.50 R
0.50 R-G
sd-c 2
(#E9)
sd2
EG-1,6,9,14,18
82580-6970
0.50 R-G
CHASSIS SIDE WIRING
(%EB)
(#C3)
30
29
Fr/LH W/H
(#BX)
c-a 1
CAB MAIN W/H
c-a 1
2
2
(LVE-)
(SIG)
0.50 B-R
H/LIGHT W/H
6
(%EA)
sd-c 2
0.50 B-R
SHTS12Z160200043
CB.
1.
2.
3.
4.
HEADLIGHT BEAM CONTROL CIRCUIT

DC/DC converter (Leveling)
Headlight leveling switch
Headlight leveling actuator LH
Headlight leveling actuator RH
P_EL02_001.fm 49
EL0249
(#C4)
0.50 R 18
c-a 1
0.50 R
ELECTRIC WIRE
5
3
(LVR+)
0.50 R
(%FB)
sd-c 1
0.50 R
sd5
EG-1,6,9,14,18
82580-6970
M
1
8
0.50 R-G
(%F9)
3
1
0.50 B-R
c-sd 1
6
(%FA)
2
(SIGR)
(LVR-)
c-sd 1
0.50 B-R
H/LIGHT W/H
SHTS12Z160200044
P_EL02_001.fm 50
EL0250
ELECTRIC WIRE
9 (HF)
0.50 R
0.50 R-G
J/C ETC 13P-2
(S-)
16 (HL)
11 (HR)

14P-G2
10
(#KN)
0.85 W-R
0.50 W-R
(B)
1
(S+)
(7ELD)
To (AA) Fuse 4B
2
(4BLD)
1.25 GR
(LD)
2
To (BA) Combination meter

2
0.50 R-G
(&2C)
0.50 R
(&2K)
1 1.25 R-B
(RHSW)
6
0.50 R
a615
(B)
3
5
(RHLD)
(LHLD)
4
0.50 G
0.50 G-B
0.50 R-W
(TECU)
1
(E)
(STOT)
8
10
(P1)
5
(&3X)
To (AE) J/C Earth 14P
0.50 G-B
1
To (BA) Combination
meter
15
1.25 G-B
(#AF)
2
1.25 BR
(65LD)
To (AA) Fuse 65
1.25 R
(95LD)
1.25 GR
c-a 2
(#CP)
36
c-a 2
24
(#CX)
c-a 2
11
(#CW)
(#CD)
c-a 2
29
15
c-a 2
To (GB) ABS trailer socket
(#CL)
c-a 2
(#CM)
c-a 2
0.50 B
(MTIN)
To (AA) Fuse 95
(#CN)
21
(TRCN)
0.50 B-W
0.85 LG
To (CA) Head 13
light RH
(#AW)
19
0.50 R-W
(IND)
2
(&1A)
0.50 LG-R
7
(TSTP)
10
7
(#6K)
(91LD)
0.50 B-Y
9
(PUP+)
(ABS+)
2
1.25 B
(P)
0.85 LG
Installed shortcircuit connector
1.25 B-Y
(STIN)
3
OFF
ON
(AI) Engjne starting circuit (Fuse 91)

4
6 (TB)
8 (B2)
0.85 GR
0.85 G-Y
(41LD)
6
10 (T)
(CCH)
10
0.50 LG
1.25 G
(FTL-)
0.85 G-Y
0.85 R-G
To (CH) License 9
plate light RH (#BS)
0.50 B
Z23
10
(MTUR)
($A2)
(STN-)
($A2)
a-j 1
(&1F)
a502
(G2-)
(STN+)
0.50 G
DOOR LH W/H
1
2
0.50 B
2
0.50 B
2
0.50 B
(&37)
CHASSIS SIDE WIRING
0.50 B
(&38)
3
0.50 G
To (AD,AE)
Earth AS-3
CAB MAIN W/H

Fr-LH W/H
0.50 G
j-a 1
($A3)
a505
HF HL HR RT
OFF
ON
(LHSW)
2
3
a-h 1
DOOR LH W/H
(CCG)
7
DASH W/H
DASH W/H
j-h 1
(&95)
0.50 G
0.50 G
5
28
($5U)
(STN-)
To (AB) Fuse 7E
(MTUL)
2
1
0.50 G
CAB SIDE WIRING
(FTL-)
1.25 B
(FTL+)
(&96)
1.25 B
h-j 1
(STN+)
1.25 B
31
($5X)
0.50 B
(SCG)
(EA) Air conditioner circuit (G2)
CC
2
To (AA) Fuse 41 (41LD)
To Chassis side
(Refer to the circuit "CD")
SHTS12Z160200045
CC. TURN, STOP AND TAIL LIGHT CIRCUIT (EXCEPT SEMI-TRACTOR) (CAB SIDE)
1. Front side turn signal light LH
7. Front turn signal light LH
8. Parking light short circuit connector
9. Parking light switch
3. Wiper and retarder switch
10. Trailer pick-up controller
4. Stop light relay
11. Light and turn switch
5. Turn signal flasher
12. Cornering light relay RH
13. Cornering light relay LH
14. Hong Kong diode (For Hong Kong model)
P_EL02_001.fm 51
ELECTRIC WIRE
EL0251
1: RHD
2: LHD
BT TL TR BC CL CR
L
(#KF)
1
2
7 (CR)
1 (CL)
15 (TR)
2 (BC)
17 (BT)
16 (TL)
(#KG)
a500
(#KE)
3
11
1
2
0.50 W-L
0.50 R-G
0.50 W-L
0.50 R-G
1
2
0.50 W-L
0.50 R-G
1
2
0.50 Y-B
0.50 Y-R
(B)
CAB MAIN W/H

To (AA) Fuse 61
(S+)
1
2
(61LD)
(LD)
5
(S-)
2
1
2
0.50 R-L
(LD)
1
2
0.50 R-G
0.50 R
(CLT+)
2
0.50 R
0.50 R
(#K1)
0.50 R-Y
c-a 2
26
(#EJ)
27
c-a 2
(A)
(#EH)
0.50 LG-R
To (CA) Cornering light diode
(ESW-)
(BSW2)
To (FG) Common rail ECU
(ESW+)
(NO+)
2
0.50 BR-B
0.50 B
20
14
2
($A2)
(#CH)
10
(#ER)
c-a 2

c-a 2
a-k 1
(K)
To (FE) Brake blending diode
(STN+)
(STN-)
2
2 0.50 B
(K)
k-a 1
3
($A3)
DOOR RH W/H
19
(G2)
(&1A)
1.25 W-R
0.50 W-R
0.50 G-B
1
(FTR-)
0.50 B
6
($96)
(FTR+)
1
2
0.50 B
DOOR RH W/H
2
h-k 1
18
To (AD,AE) J/C
Earth 13P-G2
17
1.25 B
(STN+)
(FTR+)
1 0.50 G-B
2
0.50 B
(FTR-)
31
16
($5X)
1.25 B
5
($95)
0.50 G-B
h-k 1
(STN-)
0.50 G-B
1.25 B
28
($5U)
(SCG)
(EA) Air Conditioner circuit (G2)
a-h 1
(AD) Common rail

circuit No.1
(Actuator power relay)
(S-)
2
15
0.50 G-B
0.50 G-B
DASH W/H
13
(NO-)
4
14
(A)
0.50 LG-R
(A)
0.50 BR-R
(&3A)
2
(K)
0.50 R-G
0.50 R
0.50 LG-R
(B)
3
(S+)
1
12
To Chassis side
(Refer to the circuit "CD")
SHTS12Z160200046
15. Brake blending stop diode

16. Front turn signal light RH
17. Front side turn signal light RH
20. Stop light switch
P_EL02_001.fm 52
EL0252
ELECTRIC WIRE
CONNECTORS FOR CIRCUIT "CC"
j2
h14
a53
CA-4
82580-7580
CA-4
82580-7660
IP-2,6
82580-9320
1 2 3 4
2
1
5 6 7
8 9 101112131415161718
j15
a1
a123
CA-1
82580-7660
IP-2,6
82560-2890
1
2
3 4 5 6
CA-1
82580-7660
a120
IP-1,5
82580-6060
1 2
3 4
5 6 7 8 9 10
a122
IP-2,6
82560-2900
1 2
3 4
5 6 7 8 9 10
SHTS12Z160200047
P_EL02_001.fm 53
ELECTRIC WIRE
EL0253
a18
a54
a805
a808
h4
IP-1
82580-7210
IP-2,6
82580-9310
IP-2
82560-3800
IP-1,5
82560-3800
CA-2
82580-7660
1 2
3 4
5 6 7 8 9 10
1
1 2 3
8 9 1011121314151617
10
4 5 6 7
14
15
16
11
k2
a1
k15
a60
CA-3
82580-7580
CA-3
82580-7660
CA-2
82580-7660
IP-2,6
82560-3030
2
1
17
18
19
20
SHTS12Z160200048
P_EL02_001.fm 54
EL0254
ELECTRIC WIRE
CAB SIDE WIRING
CD
(%2B)
(CST-)
c-a 2
36
(#CP)
c-a 2
24
1.25 R
(#CX)
c-a 2
11
(#CW)
1.25 BR
29
1.25 B
e-c 1
22
(%AP)
e-c 9
5
(%BY)
e-c 9
3
(%BW)
(%BX)
e-c 9
d-c 1
1
(%A1)
e-c 1
1.25 G-B
0.85 R-G
0.85 R-G
e-d 1
4
(%C8)
1.25 G-B
e-d 1
0.85 G-Y
0.85 G-Y
e-d 1
After
build body
(%C4)
1.25 G
1.25 G
0.50 G
(%A1)
d-c 1
3
(%A3)
e-c 1
3
(%A3)
16
d-c 1
2
1
CHASSIS SIDE WIRING
1.25 G-B
(%C7)
(%AG)
16
(%2B)
sh3
RR-3
82580-6600
e-c 1
e-sh 1
SIDE/F W/H
Fr-LH W/H
Before
build body
1
Rr-W/H
(INT-W/H)
(#CD)
15
0.50 G
sh-c 1
(%AG)
0.50 G
1.25 G
1
(CST+) 0.50 G 1
c-a 2
c-a 2
c-a 2
0.85 G-Y
(#CL)
2
(CSR-)
0.85 R-G
0.50 B
3
(%2D)
(#CM)
19
To Side turn signal light RH
(#CN)
21
c-a 2
To Cab side
(Refer to the circuit "CC")
0.85 G-Y
(RTN+)
(S/L+)
1
(T/L+)
4
0.85 R-G
0.85 G-Y
0.85 R-G
(RR 1)
0.50 B
2
(RCB-)
e2
(%A2)
3.00 B
To (CJ) Back-up light LH

1
(RTN+)
(S/L+)
1
(T/L+)
4
1.25 G
e40
RR-4,5
82580-6040
1 2 3 4
5 6 7 8
3
GND
TAIL BACK PARK
RH TURN
LH TURN
STOP
1
(BLP+)
0.50 B
e2
e8
6 (TIL6)
1.25 BR
7 (BAK7)
3 (T L3)
1.25 Y
2 (P 2)
1.25 B
5 (T R5)
1.25 G
4 (STP4)
1.25 R
1 (GND1)
(RCB-)
e8
RR-1,2,3,4,5
82580-8350
1 2
3 4
1.25 W
5.00 B
(%01)
Z19
2,4
(RR 1)
(E) Ground circuit (G2)

SHTS12Z160200049
CD.
1.
2.
3.
4.
5.
6.
7.
8.
9.
10.
TURN, STOP AND TAIL LIGHT CIRCUIT (EXCEPT SEMI-TRACTOR) (CHASSIS SIDE)
Side turn signal light LH (For Taiwan dump truck)
Rear combination light LH
Trailer socket
Cornering light relay LH
Cornering light relay RH
Side turn signal light RH (For Taiwan dump truck)
Left turn buzzer (For Taiwan dump truck)
Right turn buzzer (For Taiwan dump truck)
Trailer stop light switch
P_EL02_001.fm 55
ELECTRIC WIRE
EL0255
1
(RR 1)
RR-4
82560-3610
c-a 2
26
0.50 R-L
(CO+)
1
2
(E)
0.50 B
($91)
e-d 1
e63
EG-8
82580-7140
10
c139
EG-7
82580-7140
(%CD)
c49
RR-3
82580-6600
11
sh4
EG-1,7,9
82560-3340
(%CE)
e-d 1
c17
c18
4
10
6 0.50 BR-R
5.00 B
(%1G)
2
(LLP-)
(2)
(#EJ)
c-a 2
27
10
(%CF)
0.50 BR-R
(%A6)
(TSL-)
0.85 B
5,6
To (BA) Spring
brake switch
10
2G 0.85 B -
2
8
8
0.50 R-G
After build body
Rr-W/H
(INT-W/H)
0.50 BR-R
0.50 R-G
(TAIL)
d-c 1
e-c 9
9
3
(%BT)
1 0.50 LG-R 8
(TAIL)
Fr-LH W/H
(TSL+)
2
(LH+)
(RH+)
(RH+)
0.50 G-B
0.50 G
0.50 B
0.50 B
0.50 LG-R
To (BA) License
plate light RH
(20)
%AM
0.85 R-G
0.50 B
#BS
(59)
1
(LH+)
(CSR-)
(#EH)
0.50 R-Y
sh-c 1
3
2
c17
To (AD,AE) J/C
Earth G2-A
0.50 G-B 1
After
build body
sh-e 1
0.50 B
Before
build body
0.50 B
0.50 G-B
3
(%2D)
(%2C)
1
(CSR+)
0.50 G
c18
(%2D)
sh-c 1
2
(%2C)
SIDE/F W/H
0.50 G-B
e-sh 1
0.50 BR-R
Before
build body
(CO+)
2
(%A2)
0.50 B
0.50 G-B
(E)
3.00 B
(%01)
($95)

6
10
(#ER)
Fr-LH W/H
(#CH)
c-a 2
c-a 2
To Cab side
(Refer to the circuit "CC")
0.50 BR-R
10
1: Except Taiwan mixer, full-tractor

2: Taiwan mixer, full-tractor
SHTS12Z160200050
P_EL02_001.fm 56
EL0256
ELECTRIC WIRE
9 (HF)
16 (HL)
11 (HR)

14P-G2
(S+)
(S-)
0.50 R
(&1F)
0.50 R-G
0.50 B
(&37)
J/C ETC 13P-2
(7ELD)
10
(#KN)
0.85 W-R
0.50 W-R
3
5
0.50 B
0.50 R-G
(&2C)
0.50 R
(&2K)
0.50 R
a615
(B)
3
(PUSW)
0.50 R-W
(RHLD)
(LHLD)
4
(LHSW)
0.50 B
5
(&3X)
To (BA) Combination
meter
18
0.50 G-B
1.25 G-B
1.25 R
(65LD)
1.25 BR
LH TURN
(RCB-)
STOP
2 (P 2)
1.25 B
5 (T R5)
1.25 G
4 (STP4)
1.25 R
1 (GND1)
1.25 W
1
0.50 B
8
(&9E)
c-a 2
(#CP)
5.00 B
(%01)
(RTN+)
13
2
1.25 Y
(RCB-)
RH TURN
1.25 BR
7 (BAK7)
3 (T L3)
0.50 B
GND
TAIL BACK PARK
6 (TIL6)
(S/L+)
1
12
11
2
1
(BLP+)
(T/L+)
4
1.25 G
0.85 G-Y
To (CJ) Back-up light LH
(RTN+)
(S/L+)
1
(T/L+)
4
0.85 R-G
1.25 G-B
36
24
(#CX)
c-a 2
c-a 2
To (AA) ABS trailer socket
11
(#CD)
To (AD,AE) J/C
Earth 14P (G2)
To (AA) Fuse 65
c-a 2
29
0.50 R-W
2
1.25 B
0.85 LG
c-a 2
15
(#CL)
c-a 2
5
(TRCN)
(MTIN)
To (CO)
Autoleveling ECU
(#CM)
c-a 2
(#CN)
21
19
0.50 LG-R
0.50 B-W
To (AB) Fuse 95
(#AW)
CAB MAIN W/H

Fr-LH W/H
(STOT)
8
10
(P1)
(P)
#6K
(5)
7
(TSTP)
(E)
0.50 R-W
6 (TB)
(IND)
0.50 G-B
(#AF)
0.85 G-Y
(41LD)
0.85 GR
8 (B2)
6
0.85 R-G
10 (T)
(CCH)
10
(CCG)
7
0.85 G-Y
0.50 LG
0.85 LG
13
(TECU)
1
1.25 GR
(G2-)
Z23
(&1A)
To (CA)
Headlight RH
10
(#CW)
a-j 1
To (AD,AE)
Earth AS-3
(ABS+)
2
10
(MTUR)
1.25 B-Y
(91LD)
0.50 B-Y
9
(PUP+)
(STIN)
3
Installed short
circuit connector
To (AB) Fuse 91
4
OFF
ON
0.50 B
1.25 G
1
2
(#BS)
(FTL-)
(STN-)
(95LD)
0.50 G
To (CJ) License
plate light RH
(FTL+)
(STN+)
a502
($A2)
2
0.50 B
2
0.50 B
7
1.25 R-B
(RHSW)
6
0.50 G
j-a 1
0.50 G
DOOR LH W/H
3
($A3)
CHASSIS SIDE WIRING
(B)
1
(4BLD)
To (AA) Fuse 4B

2
a-h 1
DOOR LH W/H
(&38)
3
CAB SIDE WIRING
DASH W/H
HF HL HR RT
OFF
ON
4
(LD)
2
(&95)
a505
1.25 GR
j-h 1
DASH W/H
0.50 G
1
0.50 G
0.50 G
28
($5U)
(STN+)
To (AB) Fuse 7E
(MTUL)
2
(FTL+)
1.25 B
(&96)
(FTL-)
1.25 B
h-j 1
(STN-)
1.25 B
31
($5X)
0.50 B
(SCG)
CE
2
To (AA) Fuse 41 (41LD)
Z19
(RR 1)
5
(&9H)
To (AD,AF)
J/C Earth G2-B
SHTS12Z160200051
CE. TURN, STOP AND TAIL LIGHT CIRCUIT (FOR SEMI-TRACTOR)

8. Parking light switch short circuit connector
9. Parking light switch
10. Pick-up controller
11. Rear combination light LH
3. Wiper and retarder switch
12. Trailer socket
4. Stop light relay
13. Rear combination light RH
5. Turn signal flasher
14. Light and turn switch
15. Cornering light relay RH
16. Cornering light relay LH
17. Hong Kong diode (For Hong Kong model)
18. Brake blending stop diode
P_EL02_001.fm 57
ELECTRIC WIRE
EL0257
1: RHD
2: LHD
BT TL TR BC CL CR
2
(#KF)
1
32
0.50 W-L
7 (CR)
1 (CL)
9 (TR)
6 (BC)
8 (BT)
10 (TL)
(#KG)
a500
(#KE)
3
14
(TRSW)
To (FF) Common rail ECU
0.50 W-L
0.50 W-L
0.50 Y-B
0.50 Y-R
(B)
To (AA) Fuse 61
(S+)
1
CAB MAIN W/H
2
(61LD)
(LD)
5
(S-)
2
c-a 2
26
1
(CO+)
0.50 R-L
(#EJ)
c-a 2
27
(#EH)
0.50 R-Y
1
(E)
0.50 B
4
($91)
b-a 7
1
(#7T)
To (AD,AE) J/C Earth G2-A
Fr-LH W/H
(TSL+)
0.50 LG-R
14
Fr-RH W/H
(CO+)
0.50 LG-R
(E)
25
($A2)
Fr-LH W/H
0.50 R-L
(LD)
24
0.50 B
(BSW2)
To (CA) Cornering light diode
($95)
14
(ESW-)
0.50 BR-B
To (FG) Common rail ECU
(ESW+)
(NO+)
2
1
3
(NO-)
4
(K)
To (FE) Brake blending diode
(STN+)
(STN-)
(S-)
2
(K2X)
5
0.50 R
0.50 R
CLT+
(K)
k-a 1
3
($A3)
DOOR RH W/H
1
0.50 B
a-k 1
23
(A)
1
(#ER)
2 0.50 B
(&1A)
(KBP)
0.50 W-R
22
2
(G2)
0.50 R-Y
1.25 W-R
0.50 BR-R
10
(FTR-)
2
Z23
(FA) Common rail

circuit No.1
1
0.50 G-B
6
($96)
c-a 2
h-k 1
0.50 B
(STN+)
0.50 G-B
1
2
20
1.25 B
21
(STN-)
0.50 G-B
(FTR+)
1
2
0.50 B
(FTR-)
31
($5X)
1.25 B
5
($95)
19
(SCG)
h-k 1
To (AD,AE) J/C
Earth 13P-G2
0.50 G-B
1.25 B
28
($5U)
(FTR+)
DOOR RH W/H
DASH W/H
a-h 1
16
17
0.50 G-B
0.50 G-B
0.50 B
18
(A)
0.50 LG-R
(A)
0.50 BR-R
(&3A)
(K)
0.50 R-G
0.50 LG-R
2
(B)
3
(S+)
1
15
To (BC) Spring 10
brake switch
(%1G)
0.50 BR-R
20
(#DL)
To (BC) Combination meter
To (AD,AF) J/C Earth G2
(TSL-)
26
0.50 B
(&8C)
SHTS12Z160200052

23.
24.
25.
26.
Stop light switch

Cornering light LH
Cornering light RH
P_EL02_001.fm 58
EL0258
ELECTRIC WIRE
CONNECTORS FOR CIRCUIT "CE"
j2
CA-4
82580-7580
h14
a53
CA-4
82580-7660
IP-2,6
82580-9320
1 2 3 4
1
5 6 7
a1
a123
CA-1
82580-7660
IP-2,6
82560-2890
j15
1
2
3 4 5 6
8 9 101112131415161718
CA-1
82580-7660
a120
IP-1,5
82580-6060
1 2
3 4
5 6 7 8 9 10
a122
IP-2,6
82560-2900
1 2
3 4
5 6 7 8 9 10
a18
c105
c33
c111
IP-1,5
82580-7210
RR-6,7
82580-8350
EG-15,16,19
82580-6040
RR-6,7
82580-8350
1 2
3 4
5 6 7 8 9 10
10
1 2
3 4
11
1 2 3 4
5 6 7 8
12
1 2
3 4
13
SHTS12Z160200053
P_EL02_001.fm 59
ELECTRIC WIRE
EL0259
a54
IP-2,6
82580-9310
1 2 3
a805
a808
h4
IP-2
82560-3800
IP-1,5
82560-3800
CA-2
82580-7660
4 5 6 7
8 9 1011121314151617
18
17
19
14
k2
a1
k15
a60
CA-3
82580-7580
CA-3
82580-7660
CA-2
82580-7660
IP-2,6
82560-3030
2
1
20
22
21
c18
c17
b90
EG-14,18
82560-3340
EG-14,18
82560-3340
EG-17,20
82560-3610
24
25
23
26
SHTS12Z160200054
P_EL02_001.fm 60
EL0260
ELECTRIC WIRE
CF
(43LD)
To (AA) Fuse 43
0.85 R-B
1
(#KS)
(#KT)
2
a74
a502
IP-2,6
82580-7660
0.85 R-B
0.50 R-B
0.50 R-B
(LD)
(43LD)
(#AL)
0.50 O
23
0.50 O
(#KU)
0.50 R-B
16
(MI+)
(FGI+)
(FGI-)
(&3D)
10
0.50 B
(-)
2
c-a 2
Z19
(RFR-)
e13
5
0.85 G-B
1
(RFR+)
82580-6600
2
0.85 G-B
0.85 B
(RFR-)
1
2
(%A2)
Rr-W/H
(RFR+)
0.85 G-B
1
0.85 B
(%C3)
e-c 1
Except semi-tractor
(INT W/H and Rr-W/H integrated type)
(RFR+)
0.85 B
(RFR-)
e5
RR-3,5
82580-6600
0.85 B
c108
RR-6
82580-6600
(#VA)
5.00 B
5
0.85 G-B
(%01)
0.85 G-B
For semi-tractor
6
(%C6)
d-e 1
INT W/H
(#VB)
0.85 G-B
4
(%C3)
(RR 1)
13
(#D0)
c-d 1
Except semi-tractor
(INT W/H and Rr-W/H divided type)
CHASSIS SIDE WIRING
To (CA) Light and

turn switch
To (AD,AE) J/C Earth 14P (G2)
Fr-LH W/H
13
(&44)
0.50 B
0.50 R-L
0.50 B
3 4 5 6 7 8
CAB MAIN W/H
OFF
ON
(LH)
0.50 B
14
a615
(&1K)
3
(&43)
12
0.85 G-B
(&23)
(&3B)
(RFE)
IP-2
82560-2560
1
J/C ETC 13P-2
(RFLH)
(RFI-)
7
a76
(IND-)
4
(RFFS)
0.50 R-L
5
(RFL)
a502
0.50 R-B
(RFB)
1
0.50 G-B
To (AA) Fuse 43
To (CA) Headlight LH
0.50 R-G
(+)
(RFI+)
0.50 R-G
0.50 R-B
(S-)
(LD)
5
0.50 R-L

5
(+B)
3
16
(MI+)
(#KU)
(S-)
2
(S+)
(NO)
3
CAB SIDE WIRING
0.50 R-B
To (AA) Fuse 43
(S+)
1
(RR 1)
2
(%C5)
Z19
3.00 B
3.00 B
Z19
(RR 1)

SHTS12Z160200055
CF.
1.
2.
3.
4.
5.
6.
FOG LIGHT CIRCUIT

Rear fog light relay
Front fog light relay
Rear fog light
Rear fog light LH (In case of with 2 pieces)
P_EL02_001.fm 61
ELECTRIC WIRE
EL0261
CG
2
(#55)
To (AA) Fuse 41
(#KK)
0.50 R-G
0.50 R-G
CA-1,3
82580-8100
(MLL-)
i2
2
2 1
3,4
0.50 B
0.50 B
12
(&16)
i2
i8
i8
0.50 B
(SML-)
(SML-)
0.50 B
ROOF W/H
(MLL+)
7
0.50 R-G
(MLR-)
(SML+)
a2
($81)
1
3
1.25 B
31
($5X)
(SCG)
i-a 1
0.50 R-G
h-a 1
1
(SML+)
0.50 R-G
16
($5G)
h-a 1
($5G)
16
0.50 R-G
(SML+ )
1
2
0.50 B
31
($5X)
1.25 B
(MLR+)
9
0.50 R-G
h5
(SCG)
(SML- )
0.50 B
12
(&16)
To (AD,AE)
J/C Earth 13P-G2
h15
a2
(SML-)
0.50 R-G
(SML+ )
DASH W/H
a2
CA-3
82560-1670
a500
0.50 R-G
(#KH)
CAB SIDE WIRING
(#KJ)
a500
a500
h5
CA-2
82560-1670
0.50 B
2
(F/L-)
($85)
(CL) Room light circuit (G2)

13P-G2
CAB MAIN W/H

Fr-LH W/H
CA-1
82560-1670
CA-4
82560-1670
h15
0.50 R-G
(#BS)
To (AA) Fuse 41
a2
(RML+)
0.85 R-G
c94
2
RR-6
82580-7180
1
(LLP+)
0.50 B
c95
c94
c95
(RML-)
(RMR+)
(RMR-)
0.50 B
CHASSIS SIDE WIRING
0.50 R-G
5,6
To (CJ,CK) License plate light RH

4
1: LHD
2: RHD
3: Semi-tractor model for Ireland
(&9A)
1
(%01)
1.25 B
5.00 B
Z19
(RR 1)
SHTS12Z160200056
CG.
1.
2.
3.
4.
5.
6.
MARKER LIGHT CIRCUIT

Front side marker light LH
Front side marker light RH
Roof marker light RH
Roof marker light LH
Rear endout marker light LH (Semi-tractor for Ireland)
Rear endout marker light RH (Semi-tractor for Ireland)
P_EL02_001.fm 62
EL0262
ELECTRIC WIRE
CH
To (AA) Fuse 41
(&2H)
(&2F)
1.25 R-B
sa-c 2
RR-1,2,3,4,5
82580-6820
1.25 R-B
0.85 R-G
6
1
(LLR+)
0.85 R-G
0.85 B
3.00 B
2
0.85 B
0.85 B
Z19
(RR1)
(LLR-)
0.85 B
2
e11
RR-4
82580-6600
(LLP-)
5
(%A2)
e6
RR-1,2,3,4,5
82580-6600
0.50 R-G
2
(BLP-)
(BLP-)
3
4
(BBZ-)
RR-3,5
82580-7660
RR-4,5
82580-7660
(BAK7)
(%AM)
21
0.85 R-B
Rr-W/H
(LLP+)
1.25 R-B
1.25 R-B
e12
3,
(BLP+)
1.25 L
e10
1
(BBZ+)
0.50 R-B
(BAK7)
7
1.25 L
1
(BSW+)
(+)
c-b 1
(BLP+)
0.50 R-B
To (CD) Trailer socket
To (AH) Neutral switch
(%2Y)
(%A9)
1
(+)
2
3 (BSW-)
4 (-)
1.25 B-Y
7
(#6K)
1.25 R-B
e-c 1
2
4
c-a 1
Fr-RH W/H
(%0D)
e-c 1
CHASSIS SIDE WIRING
1
3
CAB MAIN W/H

Fr-LH W/H
1.25 R-B
82560-1340
T/M W/H
sa5
1.25 B-Y
0.50 R-B
(-)
EG-2,12
82580-7180
To (AB) Fuse 91
0.50 R-B
1.25 B-Y
(+)
e7
EG-7
82580-6820
(#BS)
22
To (AB) Fuse 91
1
1
4
b52
3
b36
0.85 R-G
(%2U)
To (CC) Parking light switch
a614
c-a 1
0.50 R-B
2
1.25 B-Y
4
(+)
(T)
(#AM)
9
(RVS)
7
To (AI) Neutral
switch
10
0.85 R-G
(&2G)
0.50 R-B
0.85 R-G
0.50 R-B
6
(41LD)
J/C ETC 13P-1
16
CAB SIDE WIRING
(BACK)
To (FH) Common rail ECU
1: RHD
2: LHD
3: HX transmission
4: EATON transmission
5: ZF transmission
SHTS12Z160200057
CH. BACK-UP LIGHT CIRCUIT (EXCEPT SEMI-TRACTOR)

(INT-W/H AND Rr-W/H INTEGRATED TYPE)
1. Back-up light switch (Models with ZF transmission)
2. Back-up light switch (Models with HX and EATON transmission)
3. Back buzzer
4. Back-up light RH
5. Back-up light LH
6. License plate light RH
7. License plate light LH
P_EL02_001.fm 63
ELECTRIC WIRE
EL0263
CI
(&2H)
(RVS)
(&2F)
10
To (CC) Parking light switch
(T)
0.85 R-G
0.50 R-B
(&2G)
0.85 R-G
(41LD)
a614
To (AA) Fuse 41
0.50 R-B
J/C ETC 13P-1
16
(BACK)
b36
e7
EG-3,7,10
82580-6820
RR-1,2,3,5
82580-6820
0.50 R-B
22
T/M W/H
1.25 R-B
c-a 1
9
sa-c 2
(-)
(+)
(%0D)
(%C5)
e-d 1
10
1.25 R-B
0.85 R-G
1
6
1
0.50 B
(BLP+)
0.85 R-B
e12
(LLR+)
1 (BLP+)
RR-1,2,3,5
82580-6600
RR-3,5
82580-6600
3.00 B
0.85 B
0.85 B
(LLR-)
0.85 B
(LLP-)
0.85 B
(BLP-)
2
(BLP-)
(BLP-)
e11
RR-1,2,3
82580-7660
0.85 B
2
0.50 R-G
(BBZ-)
1.25 R-B
0.85 R-G
e6
2
0.50 R-B
1.25 R-B
INT-W/H
(%CG)
d-c 1
e-d 1
e-d 1
(%CB) 8
(%CB) 8
(BBZ+)
0.50 R-B
0.85 R-G
Rr-W/H
RR-1,2,3,5
82580-7660
(%A9)
9
1.25 L
(BAK7)
e10
c-b 1
(%AM)
1.25 R-B
(BAK7)
7
(%2Y)
1.25 L
To (CD) Trailer socket
1.25 R-B
1.25 R-B
c-d 1
Fr-RH W/H
INT-W/H
2
4
(+)
(LLP+)
1
3
1.25 R-B
1.25 B-Y
(BSW+)
(BSW-)
sa5
EG-4,11
82560-1340
1: ZF transmission
2: HX, MZ transmission
3: LHD
5: Hong Kong
6: Ireland
2
(#6K)
0.85 R-G
1.25 B-Y
1
4
Fr-RH W/H
To (AB) Fuse 91
To (AB) Fuse 91
(%2U)
0.50 R-B
(+)
1.25 B-Y
0.50 R-B
1.25 B-Y
To (AI) Neutral
switch
(#AM)
Fr-LH W/H
(#BS)
c-a 1
CAB MAIN W/H
Z19
(RR1)
SHTS12Z160200058
CI.
1.
2.
3.
4.
5.
6.
7.
BACK-UP LIGHT CIRCUIT (EXCEPT SEMI-TRACTOR) (INT-W/H AND Rr-W/H DIVIDED TYPE)
Back-up light switch (Models with ZF transmission)
Back-up light switch (Models with HX and MZ transmission)
Back buzzer
Back-up light RH (For right-hand drive model)
Back-up light LH (For left-hand drive model)
License plate light RH
License plate light LH (For Ireland model)
P_EL02_001.fm 64
EL0264
ELECTRIC WIRE
CJ
To (AA) Fuse 41
(&2H)
(RVS)
(&2F)
1.25 B-Y
(N65)
(#6K)
To (CE) Parking light switch
(T)
0.50 R-B
10
0.85 R-G
(&2G)
0.50 R-B
0.85 R-G
a614
6
(41LD)
0.50 R-B
J/C ETC 13P-1
16
(BACK)
CAB SIDE WIRING
To (AB) Fuse 91
1: Hong Kong
2: LHD
3: Except Hong Kong
1.25 R-B
b-c 1
(BSW-)
(%2Y)
CAB MAIN W/H

Fr-LH W/H
c-a 1
9
1
(BSW+)
3
22
(#BS)
c-a 1
(#AM)
1.25 B-Y
b36
EG-15,19
82580-6820
c114
0.50 R-B
RR-6,7
82580-6820
0.85 R-G
(&9D)
1
(%01)
0.85 B
(LLR+)
(LLP+)
2
0.85 B
(LLR-)
4
(&9A)
(BLP+)
0.85 R-G
(LLP-)
0.85 B
(BLP-)
To (AD,AF) J/C
Earth G2-B
(BLP-)
(&9G)
c110
RR-6,7
82580-7660
(BLP+)
c106
1.25 R-B
0.50 B
1.25 R-B
(BAK7)
(BBZ-)
1.25 B
0.50 R-B
0.50 R-G
(BBZ+)
1.25 L
(BAK7)
1.25 L
7
RR-6,7
82580-7660
2
0.50 R-B
To (CE) Trailer socket
c109
RR-6,7
82580-6600
(&9C)
(+)
c107
RR-6,7
82580-6600
0.85 B
0.50 R-B
1.25 R-B
CHASSIS SIDE WIRING
0.50 R-B
Fr-RH W/H
Z19
5.00 B
(RR1)
SHTS12Z160200059
CJ.
1.
2.
3.
4.
5.
6.
BACK-UP LIGHT CIRCUIT (FOR SEMI-TRACTOR) (WITH HX, MZ TRANSMISSION)

Back-up light switch
Back buzzer
Back-up light LH (For left-hand drive model)
License plate light LH
P_EL02_001.fm 65
ELECTRIC WIRE
EL0265
CK
10
To (CE) Parking light switch
(T)
(&2G)
(&2H)
(RVS)
7
(&2F)
0.85 R-G
0.50 R-B
0.85 R-G
(41LD)
0.50 R-B
To (AA) Fuse 41
J/C ETC 13P-1
16
(BACK)
a614
c-a 1
9
22
1
4
(+)
(-)
1.25 R-B
sa-c 2
2
c107
c109
RR-6
82580-6600
RR-6
82580-6600
1.25 R-B
3
1
To (C,E) J/C Earth G2-B
(&9D)
1
(%01)
0.85 B
0.85 B
0.85 R-G
(BLP+)
c106
RR-6
82580-7660
0.50 R-G
1.25 L
7
(BAK7)
(BLP-)
To (CE) Trailer socket
(BBZ-)
(LLP+)
1
(BBZ+)
0.50 R-B
(+)
0.50 R-B
(LLP-)
(&9C)
(LLR+)
c114
RR-6
82580-6820
0.85 B
(LLR-)
To (AB) Fuse 91
0.85 R-G
2
(%2U)
1.25 B-Y
sa5
EG-16
82560-1340
2
1.25 B-Y
4
(+)
(#AM)
To (AI) Neutral switch
0.50 R-B
T/M W/H
CAB MAIN W/H

Fr-LH W/H
(#BS)
c-a 1
0.50 R-B
Z19
2A 5.00 B
(RR1)
SHTS12Z160200060
CK.
1.
2.
3.
4.
5.
BACK-UP LIGHT CIRCUIT (FOR SEMI-TRACTOR) (WITH ZF TRANSMISSION)

Back buzzer
Back-up light RH
P_EL02_001.fm 66
EL0266
ELECTRIC WIRE
CL
0.50 W-L
0.50 W-L
(DLR+)
2
1
(DLL-)
0.50 R
1
2
Body Earth
a-i 1
5
0.50 R
($88)
1
(F/L+)
i7
i9
a801
IP-1,5
82560-2030
(A)
1 0.50 W
(SLL-)
2
0.50 R
CAB MAIN W/H
CA-1,3
82580-7330
h-k 1
Body Earth
ROOF W/H
($92)
(SLR-)
2
0.50 R
h-j 1
($92)
CAB SIDE WIRING
ROOF W/H
1
($83)
2 0.50 W
CA-2
82580-6600
CA-1
82580-3360
i-a 1
0.50 W-L
2
INST W/H
(DLL-)
(DLP-)
1
0.50 W
k1
OFF
ON
1
2
(DLL+)
1 2
1
2
($08)
CA-4
82580-6600
a-f 1
DOOR RH W/H
k-h 1
3
1
(SLL+)
0.50 W-L
($93)
DOOR LH W/H
j-h 1
3
($93)
0.50 W-L
1
(SLR+)
82560-3010
0.50 R
a501
f60
IP-3,7
(DLP+)
0.85 W-L
a-i 1
($86)
(45LD)
j1
CA-3
82580-3360
0.50 W-L
5
(A59)
0.50 W-L
i10
f500
2
0.50 W-L
($5H)
2
(45LD)
h-a 1
To (AA) Fuse 45
CAB MAIN W/H

DASH W/H
0.50 B
2
0.50 R-B
3
0.50 R-B
(A)
10
($79)
0.50 R
1
0.50 R
(LH +)
1
2
1: RHD
2: LHD
FLOOR W/H
8
m1
m4
IP-4,8
82580-6170
IP-3,7
82580-6170
(RH +)
10
Body Earth
0.50 R-B
($7A)
0.50 R-B
9
IP-2,6
82560-2030
m-f 1
(K)
f800
0.50 R-B ($03)
f-a 1
INST W/H
($0D)
(K)
(DR)
20
0.50 R-B
($19)
0.50 R
f-a 1
($85)
a-i 1
3
0.50 R
CAB MAIN W/H
(F/L-)
0.50 R
m-f 1
0.50 R 13
2
0.50 B 2
($5W)
a-h 1
13 0.50 R

1
Body Earth
2
1
10
SHTS12Z160200061
CL.
1.
2.
3.
4.
5.
6.
7.
8.
9.
10.
ROOM LIGHT CIRCUIT

Step light LH (Left-hand drive)
Step light RH (Right-hand drive)
Fluorescent light switch
Dome light LH (Left-hand drive)
Dome light RH (Right-hand drive)
Fluorescent light
Room light diode No.2
Courtesy switch LH
Courtesy switch RH
P_EL02_001.fm 67
ELECTRIC WIRE
EL0267
CM
0.85 R
(97LD)
CAB SIDE WIRING
To (AB) Fuse 97
14
0.85 R
1
ON1
ON2
0.85 R-W
(+)
(-)
To (IC,ID) Cab tilt motor
Z19
(RR 1)
3.00 B
0.50 B
(%15)
c31
EG-15,16,19
82580-6600
CHASSIS SIDE WIRING
(WLO)
(WLO1)
c30
EG-15,16,19
82580-7140
(#AV)
c-a 1
CAB MAIN W/H

Fr-LH W/H
0.50 B
1
(%01)
SHTS12Z160200062
CM. WORKING LIGHT CIRCUIT

1. Spot light switch
2. Spot light
P_EL02_001.fm 68
EL0268
ELECTRIC WIRE
CN
To (DL) Wiper and washer circuit
M 1
4 (HLCS)
f-a 5
22
($3T)
0.30 R-Y
11
($3F)
f-a 5
0.30 R-W
(G1)
8.00 B
8.00 B
1.25 B
(G2)
(GND)
To (AE) Ground circuit (G2)
2
2
(HLCM)
1
(IG)
(WASH)
3 (HLSW)
(E)
0.50 L-B
3
(WW)
To (DL) Wiper and washer circuit
CAB SIDE WIRING
0.30 L-B
(#61)
1.25 B-W
0.30 W-G
1
(+)
(E)
7
(#LJ)
(+)
1.25 L-W
0.30 L-W
3 FREE
PUSH
2
(A1Y)
(HLC-) 3
(HCI+) 5
0.30 R-W
(33LD)
To (CA) Headlight circuit
4 (HCI+)
0.50 R-Y
(#AA)
2 (HLC+)
0.50 R-B
33
0.50 R-B
19
(TCI+)
0.50 B
To (BE) Tachograph circuit
11
($0B)
2.00 B
6
($52)
To (AE) Ground circuit (G2)
SHTS12Z160200063
CN.
1.
2.
3.
HEADLIGHT WASHER CIRCUIT

Washer pump motor
Headlight washer relay
Wiper and retarder switch
5
(44LD)
a502
ELECTRIC WIRE
2
(44LD)
EL0269
To (AA) Fuse 44
2G 0.30 L -W
P_EL02_001.fm 69
a3
CA-1
82580-8350
1 2
3 4
1
a34
IP-1
82560-2790
2
f48
IP-2
82560-3250
1 2 3 4 5
SHTS12Z160200064
P_EL02_001.fm 70
EL0270
ELECTRIC WIRE
CO
1
To (AB) Fuse 7H
0.50 W-G
0.50 BR
3
(GND)
f-a 5
($2C)
(VOUT)
(GND2)
f-a 5
($2B)
($2A)
a-f 5
a-f 5
21
($4A)
0.50 BR-B
0.50 W-R
(VIN1)
1.2A
(#LL)

0.50 W-R
(#64)
(#58)
12
To (CA) J/C ETC 13P-2
10
3
(#S1) (S-)
To (CA) Headlight relay

(Dimmer)
(HDLP)
(IG)
IP-1
82560-3290
(AG) Ground circuit(G4-P)
18
(PGD3)
5.00 BR
1A
f1
(A)
0.30 R-Y
(#S3)
1.25 BR
0.50 BR-B
CAB SIDE WIRING
0.50 R-Y
0.50 BR
(E1 )
2
(SGR)
(SHR)
9
0.50 G-W
9mA
1mA
c-a 1
41
(#BN)
42
(#BM)
c-a 1
0.50 G-B
10
(SBR)
10mA
11
43
c-a 1
0.50 G
20
0.50 Y-B
9mA
b-a 4
20
(#VJ)
(#BL)
(SHF)
1mA
0.50 Y
10mA
b-a 4
19
(#VH)
15
(#VG)
b-a 4
0.50 Y-R
22
21
(SBF)
4 5 6
(SGF)
1 2 3
b140
0.50 Y
0.50 Y-B
0.50 G
0.50 G-B
0.50 G-W
0.50 Y-R
1 2 3
(CHM)
(HHL)
(CHK)
(SGF)
RR-6
82580-9960
(SHF)
c150
(SBF)
CHASSIS SIDE WIRING
EG-17
82560-4750
4
SHTS12Z160200065
CO.
1.
2.
3.
4.
5.
6.
7.
8.
HEADLIGHT AUTOLEVELING CIRCUIT

Autoleveling ECU
Vehicle height sensor (Front)
Vehicle height sensor (Rear)
Interface ECU
P_EL02_001.fm 71
ELECTRIC WIRE
EL0271
0.50 W-R
(GND) 22
19
(TX-S)
20
(+12V) 11
0.50 BR
(TX-2)
14
0.50 R-G
(LVTX)
(RX-2)
(RX-S)
0.50 B-Y
(LVRX)
6
(PCGD)
To (DJ) Diagnosis connector (16P)

To (DJ) Diagnosis connector (16P)
0.50 BR
a167
(PCO4)
1 2 3 4 5 6 7 8 9 10 11
0.50 W
1
0.50 W -B
(INIT) 16
12 13141516171819202122
2
9
15 (RH2)
1 2 3 4 5 6 7 8 9 10 11
5 4 3 2 1
12 13141516171819202122
(#BP)
c-a 1
40
a168
IP-1
82560-2470
IP-1
82560-2540
1mA
0.50 R-G
13 (LH3)
400mA
0.50 B-R
c-a 1
30
(#C3)
4 (LH2)
0.50 R-G
1mA
(#BX)
0.50 R-G 29
To (DJ) Diagnosis
connector (16P)
0.50 R
(LVR+)
(%FB)
sd-c 1
3
0.50 R
(%F9)
sd-c 1
8
0.50 R-G
0.50 B-R
5
0.50 R
(%EB)
(LVA+)
sd5
EG-14
82580-6970
sd2
EG-14
82580-6970
2
(SIGR)
(LVE-)
(SIG)
0.50 B-R 6
(%EA)
sd-c 2
0.50 B-R
c-sd 1
0.50 B-R
(LVR-)
(%E9)
sd-c 2
sd-c 2
0.50 R
0.50 R-G
18
(#C4)
c-a 1
c-a 1
2 (LH1)
0.50 R
(LVL)
a100
IP-1
82560-2470
(&F1)
7
(SPDR)
2mA
15
16mA (MRTD)
0.30 G
To (BA) Pulse adjust computer
0.30 W
(WNG)
0.30 L-B
19
(RX)
0.30 L
(TX)
(%FA)
SHTS12Z160200066
P_EL02_001.fm 72
EL0272
ELECTRIC WIRE
DA
CAB MAIN W/H
To (AB) Fuse 93
0.50 B
(STN-)
($96)
(RH E)
1.25 B
0.50 B
0.50 B
j14
CA-1
82560-2660
(RH+)
4
(LH +)
3
(SU +)
0.85 W
0.85 W
(HMI-)
(HM-)
3
OFF
ON
1
(SU E)
(LH E)
0.50 B
15
(STN-)
0.50 W
(HM+)
($A2)
($0F)
f-a 1
(93LD) 2
(CC,CE) Turn, Stop, Tail light circuit (G2)
(CC,CE) Turn, Stop, Tail light circuit (G2)
DOOR RH W/H
DASH W/H
h-k 1
($97)
0.50 W-R
0.85 W-R
0.50 W-R
0.50 W-R
(LD)
(S-)
1
2
3 4 5 6
24
a-h 1
(RH +)
(S+)
1 (+B)
0.50 W-L
IP-3,7
82580-6060
(&A7)
0.85 W-R
To (AD,AE) J/C
Earth 14P-G2
0.85 W-R
f69
DOOR LH W/H
a-j 1
12
($0H)
17
a-f 1
CAB SIDE WIRING
INST W/H
(&5A)
0.50 B
0.50 W-L
2,3
1: Except Australia, Ireland,

New Zealand
2: Australia, Ireland,
New Zealand
0.50 W-R
(&5Q)
k14
a7
CA-2
82560-2660
CA-1,3
82560-2650
DASH W/H
0.50 W-R
a-h 1
24
4 3 2 1
8 7 6 5
(RH +)
(LH +)
0.85 W-R
0.50 W-R
1
(SU +)
0.50 B
0.50 W-R
(&5Q)
6,7
h3
4
0.50 B
(&16)
31
(&5X)
(RH E)
(LH E)
8
0.50 B
10
13
(&15)
(&11)
0.50 B
(SU E)
CA-2,4
82560-2640
1.25 B
3
(SCG)
8
SHTS12Z160200067
DA.
1.
2.
3.
4.
5.
6.
7.
8.
MIRROR HEATER CIRCUIT

Mirror heater switch
Mirror heater (Side under) (For Australia, Ireland, New Zealand models)
Mirror heater (Back LH) (For Australia, Ireland, New Zealand models)
Mirror heater (Back RH) (For Australia, Ireland, New Zealand models)
Mirror heater relay
Mirror heater (Side under) (Except Australia, Ireland, New Zealand models)
Mirror heater (Back LH) (Except Australia, Ireland, New Zealand models)
Mirror heater (Back RH) (Except Australia, Ireland, New Zealand models)
P_EL02_001.fm 73
ELECTRIC WIRE
EL0273
DB
(7HLD)
To (AB) Fuse 7H
h3
j14
CA-2,4
82560-2640
CA-1
82560-2660
1 2
(#LK)
f502
f64
IP-3
82580-6870
3
4 5 6 7 8
(RMUR)
(RMUL)
6
UR
0.50 L-R
(RM-) 3
0.50 L-W
UL
0.50 L-B
VR
0.50 L
VL
(RMVR)
8
(RMVL)
5
(RMC)
0.50 L-Y
0.85 W-G
a7
k14
CA-1,3
82560-2650
CA-2
82560-2660
4 3 2 1
8 7 6 5
(RM+)
20
($2Q)
a-f 5
10
a-f 5
a-f 5
($2R)
($2H)
($2J)
a-f 5
13
0.30 B
2
2
(&56)
($2G)
INST W/H
CAB MAIN W/H
a-f 5
0.50 L-R
0.50 L-W
j-a 2
7
6
(RH)
0.50 L-R
($AB)
j-a 2
6
($AA)
j-a 2
0.50 L-W
(UP)
5
DOOR LH W/H
(RH)
(UP)
(LH)
($A9)
0.50 L-Y
(RH)
2
2
(UP)
(LH)
(RH)
(LH)
(LH)
0.50 L-R
0.50 L-Y
h-a 1
($57)
0.50 L-B
0.50 L-W
0.50 L-B
h-a 1
8
($58)
0.50 L
0.50 L-Y
k-h 2
($9B)
0.50 L-B
k-h 2
6
0.50 L
0.50 L-Y
($9A)
2
($94)
k-h 2
0.50 L
0.50 L-B
(UP)
0.50 L-Y
($56)
h-a 1
0.50 L
0.50 L-Y
0.50 L-Y
0.50 L-Y
CAB SIDE WIRING
4
DASH W/H
DOOR RH W/H
SHTS12Z160200068
DB.
1.
2.
3.
4.
5.
REMOTE CONTROL MIRROR CIRCUIT

Remote control mirror switch
Remote control mirror RH
Remote control mirror LH
Remote control mirror RH (For Ireland model)
Remote control mirror LH (For Ireland model)
P_EL02_001.fm 74
EL0274
ELECTRIC WIRE
DC
0.50 V
(S+)
0.50 V
1
(B)
3
CAB SIDE WIRING
(7CLD)
To (AB) Fuse 7C
(S-)
a56
IP-2,6
82580-8110
(HORN)
(LD)
5
0.50 G-R
1
0.50 B-L
2
1
2
Body earth
0.50 B-L
c19
c20
EG-1,6,9,14,18
82580-5680
1
(B)
0.50 B-L
1
(B)
3,4
4
c20
1
c19
(L)
CHASSIS SIDE WIRING
(#CT)
c-a 2
CAB MAIN W/H

Fr-LH W/H
1.25 B
1.25 B
(%F0)
3
(&92)
To (AE,AF) J/C Earth G2-A
(CA) Headlight circuit (G2)

SHTS12Z160200069
DC.
1.
2.
3.
4.
HORN CIRCUIT
Horn relay
Horn switch
Horn (Hi)
Horn (Lo)
P_EL02_001.fm 75
ELECTRIC WIRE
EL0275
DD
DE
INST W/H
2
(21LD)
10
To (AA) Fuse 21
(#KW)
2
(21LD)
To (AA) Fuse 21
1
1
(-)
(&DP)
f-g 1
18
(+)
f81
IP-6
82580-4610
1.25 B
CAB SIDE WIRING
g6
IP-2
82580-4610
(-)
(+)
1.25 G-Y
30
INST SW W/H
(&DN)
g-f 1
1.25 G-Y
1.25 G-Y
f500
10
(#KW)
f500
INST W/H
1.25 B
1.25 B
INST W/H
(&52)
2.00 B
11
a-f 1
CAB MAIN W/H
TO (AD,AE) Earth DR-1
2.00 B
2.00 B
CAB MAIN W/H
8.00 B
TO (AD,AE) Earth DR-1
(G2)
2
(#61)
(&0B)
(&0B)
a-f 1
11
2.00 B
(&52)
8.00 B
1
(G1)
2
(#61)
8.00 B
(G2)
8.00 B
(G1)
SHTS12Z160200070
DD. CIGARETTE LIGHTER CIRCUIT

(FOR RIGHT-HAND DRIVE MODEL)
1. Cigarette lighter
DE. CIGARETTE LIGHTER CIRCUIT

(FOR LEFT-HAND DRIVE MODEL)
1. Cigarette lighter
P_EL02_001.fm 76
EL0276
ELECTRIC WIRE
DF
CAB MAIN W/H
To (DI) Radio/Audio circuit

(Fuse 46)
To (DD) Cigarette lighter circuit

(Fuse 21)
To (CL) Room light circuit
f500
10
(A18)
(A7K)
f500
0.50 R-B
3
($03)
($7A)
f43
1 2
0.50 W-G
CAB SIDE WIRING
IP-2
82580-7210
3 4
5 6 7 8 9 10
0.50 L-Y
10
(ACC)
(DLSW)
0.30 R-B
(B+)
(LKS)
0.50 Y-R
0.50 Y-G
(E)
(ULKS)
(RX)
4
(TX)
J/C Earth 14P-G2

Lock signal
0.30 G-B
(KLS+)
11
0.50 B
2.00 B
(&54)
6
($0B)
To (DM) Power door lock controller
(&52)
To (DD) Cigarette lighter circuit (G2)

Unlock signal
f604
0.30 G
(KLS-)
SHTS12Z160200071
DF. KEYLESS ENTRY CIRCUIT

1. Keyless entry controller
2. Power door lock switch (Drivers side)
ELECTRIC WIRE
EL0277
DOOR RH W/H
k6
INST W/H
CA-2
82560-3300
2
($99)
5 (SIG-)
a-h 1
($5R)
h-k 2
6 (SCOM)
($9D)
0.50 Y-G
1
0.50 B
0.50 Y-G
($5J)
25
h-k 2
2.00 B
CAB MAIN W/H
a-h 1
0.50 Y-R
27
a-h 1
(&52)
DASH W/H
($5T)
18
h-k 2
0.50 Y-R
4 (SIG+)
($9C)
0.50 B
5
0.50 B
13
11
($21)
f-a 4
0.50 B
(&0B)
(DD) Cigarette lighter circuit (G2)
P_EL02_001.fm 77
14
($22)
13
($23)
f-a 4
f-a 4
0.50 Y-R
0.50 Y-G
SHTS12Z160200072
P_EL02_001.fm 78
EL0278
ELECTRIC WIRE
DG
(62LD)
2
(7HLD)
To (AB) Fuse 7H To (AA) Fuse 62
1.25 W
h-a 1
10
($5A)
h-a 1
1.25 W
k-h 1
8
($98)
26
($5S)
0.50 W-G
k-h 1
1
($91)
k-h 2
1.25 L-W
1.25 W
0.50 W-G
10
DOOR RH W/H
($9E)
(+IG)
CAB SIDE WIRING
CAB MAIN W/H

DASH W/H
(+B)
8
0.50 W-G
(A6D)
a504
1
MAIN
RLY
7 (DB)
1.25 L-W
4
W/L
SW
OPEN
CLOSE
($9G)
3
ATTO
k-h 2
1.25 L-R
1.25 L-Y
DS RLY
(DS O)
PS SW
DS SW
(DS C)
OPEN
CLSE
($9F)
k-h 2
1.25 L-R
1.25 L-Y
($96)
1.25 B
(CC,CE)
Turn, Stop, Tail light
circuit (G2)
(DM O)
(DM C)
k4
k3
CA-2
82580-7210
CA-2
82560-4400
1 2
1.25 L
1.25 L-B
(E)
1.25 B
AUTO CIRCUIT
3 4
5 6 7 8 9 10
(STN-)
2
2
(PWM2)
1
(PWM1)
SHTS12Z160200073
DG.
1.
2.
3.
4.
POWER WINDOW CIRCUIT (FOR RIGHT-HAND DRIVE MODEL)

Power window switch (Driver's side)
Power window motor (Driver's side)
Power window switch (Assistant's side)
Power window motor (Assistant's side)
ELECTRIC WIRE
EL0279
DASH W/H
11
h-a 1
1.25 L-W
($5B)
22
h-a 1
1.25 L-R
($5N)
11
h-a 1
1.25 L-Y
j-a 1
1.25 L-W
8
($A8)
j-a 1
6
($A6)
1.25 L-R
1.25 L-Y
(PSC)
OPEN
4
2
1.25 L
CA-1
82580-9420
(PB )
(PM O)
j3
(PM C)
CLOSE
CAB MAIN W/H

DOOR LH W/H
(PSO)
j4
CA-1
82580-7660
($A5)
j-a 1
($5B)
1.25 L-B
P_EL02_001.fm 79
(PWM4)
1
(PWM3)
SHTS12Z160200074
P_EL02_001.fm 80
EL0280
ELECTRIC WIRE
DH
(62LD)
(7HLD)
To (AB) Fuse 7H To (AA) Fuse 62
1.25 W
h-a 1
10
($5A)
1.25 W
j-h 1
DOOR LH W/H
($98)
j-h 1
1
($91)
6
($9E)
1.25 W
0.50 W-G
10
(+IG)
CAB SIDE WIRING
CAB MAIN W/H

DASH W/H
(+B)
8
0.50 W-G
26
($5S)
h-a 1
0.50 W-G
(#LH)
a504
j-h 2
1.25 L-W
1
MAIN
RLY
7 (DB)
1.25 L-W
4
OPEN
CLOSE
W/L
SW
j-h 2
1.25 L-R
($9G)
3
j-h 2
1.25 L-Y
ATTO
3
DS RLY
(DS O)
PS SW
DS SW
(DS C)
OPEN
CLSE
($9F)
1.25 L-R
1.25 L-Y
9
1.25 L
(DM O)
(DM C)
8
1.25 L-B
(E)
1.25 B
AUTO CIRCUIT
j10
j9
CA-4
82580-7210
CA-4
82580-9420
1 2
3 4
5 6 7 8 9 10
6
1.25 B
($96)
(STN-)
(CC,CE)
Turn, Stop, Tail light
circuit (G2)
2
2
(PWM2)
1
(PWM1)
SHTS12Z160200075
DH.
1.
2.
3.
4.
POWER WINDOW CIRCUIT (FOR LEFT-HAND DRIVE MODEL)

ELECTRIC WIRE
EL0281
DASH W/H
11
h-a 1
1.25 L-W
($5B)
22
h-a 1
1.25 L-R
($5N)
11
h-a 1
1.25 L-Y
k-a 1
8
1.25 L-W
($A8)
k-a 1
6
($A6)
1.25 L-R
1.25 L-Y
(PSC)
OPEN
(PB )
1.25 L
(PM O)
k10
CA-3
82560-4400
(PM C)
CLOSE
CAB MAIN W/H

DOOR RH W/H
(PSO)
k11
CA-3
82580-7660
($A5)
k-a 1
($5B)
1.25 L-B
P_EL02_001.fm 81
4
4
2
(PWM4)
1
(PWM3)
SHTS12Z160200076
P_EL02_001.fm 82
EL0282
ELECTRIC WIRE
DI
f500
9
11 0.50 W-G
7
10 0.50 L-Y
(A18)
f500
(A7K)
2
(21LD)
To (AA) Fuse 21
2
(46LD)
To (AA) Fuse 46
f24
f24
(+)
(ACC)
ANT
8 ($1C) 0.50 P-B
7 ($1B) 0.50 P
a-f 3
INST W/H
CAB MAIN W/H
a-f 3
CAB SIDE WIRING
(SPL1)
(SPL2)
0.50 P
($8B)
i-a 1
i-a 1
0.50 LG
9
0.50 LG-B
($8C)
i-a 1
($89)
i-a 1
(RH)
CA-1,3
82580-8610
i5
2 (SR+)
(LH)
i6
1 (SRE)
i5
2 (SL+)
a8
1 (SLE)
($8A)
7
0.50 P-B
2 (FL+)
1 (FLE)
a8
IP-1,6
82580-8610
0.50 P
0.50 P
0.50 P-B
0.50 P-B
i6
4
SHTS12Z160200077
DI.
1.
2.
3.
4.
RADIO/AUDIO CIRCUIT
Radio/Audio unit
Front speaker (LH)
Front speaker (RH)
Center speaker
ELECTRIC WIRE
EL0283
2
(43LD)
To (AA) Fuse 43
f24
IP-2,6
82580-8810
1 2 3
4 5 6
7 8 9 10
0.50 R-B
(A1Y)
f500
11 12 13 14
f24
(ILLM)
Body earth
9
2.00 B
(SPR2)
#4H
6 ($1A) 0.50 LG-B
f16
5 ($19) 0.50 LG
Earth audio
2 (FR+)
0.50 LG
a-f 3
a-f 3
0.50 LG
0.50 LG-B
0.50 LG-B
(E)
(SPR1)
(GND)
1 (FRE)
P_EL02_001.fm 83
a51
a51
IP-2,5
82580-8610
1
SHTS12Z160200078
P_EL02_001.fm 84
EL0284
ELECTRIC WIRE
DJ
CAB MAIN W/H
9
(TX-2)
16
(INIT)
To (CO) Autoleveling ECU
18
(RX-2)
01
02
03
14
(LVTX)
04
05
12
0.50 BR
(SGND)
(&40)
06
08
J/C ETC 13P-1

10
0.50 LG
(ISOK)
9
(LVL)
a614
(&1E)
10
(&1P)
11
(&2B)
09
10
11
(&25)
6
(LVRX)
2
(ISOK)
26
(ISOK)
14
(ISOK)
To (GA,GB,GC) ABS ECU (E)

12
13
14
15
16
J/C ETC 13P-1

2
0.50 P
(ISOL)
1
a614
(&1C)
8
(&1M)
(+24V)
0.50 L-Y
8
(#L7)
a501
CAB SIDE WIRING
07

(G4-C)
7
(ISOL)
To (GA,GB,GC) ABS ECU (E)
2
(96LD)
To (AA) Fuse 46
a41
IP-2,6
82560-4320
9 10 11 12 13 14 15 16
1
SHTS12Z160200079
DJ. DIAGNOSIS CONNECTOR (16P) CIRCUIT

1. Diagnosis connector (16P)
P_EL02_001.fm 85
ELECTRIC WIRE
EL0285
DK
GROUND
START (ENGINE)
OUTPUT (ENGINE)
1
(D+BS)
2
(&3R)
17
POWER
(&3K)
20
To (BA,BC) J/C ETC 14P (Fuse 46)
0.50 L-Y
0.50 B
(DGDS)
3
(DSW0)
8
(DCD0)
29
(DGSW)
12
(CE/G)
START (ES START)

OUTPUT (ES START)
6
(DSW3)
11
(DCD3)
21
(DIC)
5
(PR)
a64
IP-2,6
82560-2620
1
1
POWER
GROUND
START (AIR SUSPENSION)

OUTPUT (AIR SUSPENSION)
(D+BO)
2
3 4 5 6 7
0.50 L-Y
8 9 10 11 12
0.50 B
(DGDO)
5
(DSWJ)
10
(DCDJ)
21
(DISW)
1
(LP1)
a65
IP-6
82560-2620
3 4 5 6 7
(&3W)
(&3V)
6
8 9 10 11 12
To (AD,AE) J/C Earth 14P (G2)
SHTS12Z160200080
DK. DIAGNOSIS MONITOR CIRCUIT

1. Diagnosis standard connector
2. Diagnosis option connector
P_EL02_001.fm 86
EL0286
ELECTRIC WIRE
DL
To (AB) Fuse 7H
2
(7HLD)
CAB MAIN W/H
0.85 W-R
10
To (AB) Fuse 7E
(#KN)
(B)
To (CC,CE) Stop light relay
0.50 W-G
(39LD)
To (AA) Fuse 39
0.50 W-R
(#LJ)
a504
(E)
0.50 L-B
(IR+)
(IR2)
14
1
6
(PWR)
13
1
(+)
1.25 L
0.50 W-G
(WSHS) 8
12
(WIPS)
4
(IRSI) 1
(IRSL) 2
(IRHL)
5
CAB SIDE WIRING
(IRSH) 3
(IR-)
10
1.25 L-Y
(IRMS)
(IRI-)
7
1.25 B
0.30 R
0.30 G
I
-
11
4
1: RHD
2: LHD
(&39)
0.50 B
(EW)
OFF
ON
LO
HI
WASHER
2
1
I
+
5 (I-)
0.30 L-Y
14 (WH)
W E W W W
w w i l h
15 (I+)
0.30 L-R
12 (WI)
13 (WL)
3 (WW)
0.30 L-W
0.50 L-B
(IRI+)
11
(IRHI)
8.00 B
(GI)
2
(#61)
To (AD,AE) J/C Earth14P-G2
SHTS12Z160200081
DL.
1.
2.
3.
4.
WIPER AND WASHER CIRCUIT

Washer pump
Wiper relay
Wiper motor
ELECTRIC WIRE
EL0287
a3
a121
a53
CA-1,3
82580-8350
IP-1,5
82580-5820
IP-2,6
82580-9320
1 2 3
1 2
3 4
4 5 6
7 8 9 10 11 12 13 14
1 2 3 4
5 6 7
8 9 10 11 12 13 14 15 16 17 18
1.25 L
1.25 L-R
Hi
h-a 1
21
1.25 L
($5M)
($5C)
(LOW)
1
1.25 L-B
1.25 L-R
($51)
12
h-a 1
CAB MAIN W/H

DASH W/H
h-a 1
1.25 L-B
(HIGH)
2
Lo
M
4
(RUN)
3
(INT)
P_EL02_001.fm 87
h10
Body earth
a-h 1
23
(&5P)
1.25 L-Y
CA-2,4
82580-8350
1 2
3 4
SHTS12Z160200082
P_EL02_001.fm 88
EL0288
ELECTRIC WIRE
DM
CAB MAIN W/H
2
k12
1
j5
f23
3
f79
CA-3
82580-7660
CA-1
82580-7660
IP-2,6
82580-6870
IP-2
82580-6870
1 2
1 2
0.85 Y
4 5 6 7 8
4 5 6 7 8
0.85 W-L
4
0.85 Y
(PWR+)
a-f 6
1
($20)
0.85 Y
8
(LDS+)
3
3
(TX)
LOCK
LOCK
LOCK
24V
2,3
COM
0.50 B
3
(B+2)
0.50 Y-G
2
(SULK)
5 (KLS-)
(E-)
0.50 Y-R
5
(SLX)
To (DF)
Keyless entry controller
4
(RX)
0.85 B
(LDS-)
(PWR-)
0.85 Y-B
11
($A4)
2.00 B
6
(&52)
(CN) Cigarette lighter circuit (G2)

5
a-f 6
($EK)
EARTH
To (DF)
3 (KLS+)
(&0B)
a-k 1
a-j 1
($A4)
0.85 Y-B
0.85 Y-B
(PWR-)
UNLOCK
UNLOCK
24V
To (CL) Fluorescent light switch
(B+)
k-a 1
1
(DLP+)
POWER
0.85 W-L
(45LD)
0.85 Y
($A1)
To (AA) Fuse 45
DOOR LH W/H
($A1)
DOOR RH W/H
(PWR+)
CAB SIDE WIRING
j-a 1
INST W/H
0.85 Y-B
1: RHD
2: LHD
3: With keyless entry
SHTS12Z160200083
DM.
1.
2.
3.
4.
POWER DOOR LOCK CIRCUIT

Power door lock actuator (Assistant's side)
Power door lock controller
Keyless entry door lock controller
Power door lock switch (Driver's side)
P_EL02_001.fm 89
ELECTRIC WIRE
EL0289
DN
f67
DOOR RH W/H
IP-3
82560-6840
DOOR LH W/H
2 (SIG-)
1
5
3
(DLF+)
0.85 W
($99)
(CLS)
0.50 W
2
($5R)
0.30 V-Y
0.30 V-G
0.85 W-L
a-h 1
a-h 1
(CLSS)
(SETS)
(B+)
3
0.85 W-B
(SET)
(E)
7
0.85 B
(&0B)
0.85 B-R
18
($0J)
a-f 1
CLOSE
24V
($09)
(PWR)
a-f 1
SET
24V
(&52)
k6
CA-2
82560-3300
(CSL)
0.50 Y-G
11
INST W/H
CAB MAIN W/H
a5
f22
CA-4
82560-3300
IP-1
82580-6870
1 2
3
4 5 6 7 8
0.85 W-B
j13
0.85 B-R
f-a 4
0.50 B
2.00 B
15
($23)
f-a 4
0.50 Y-R
13
($21)
f-a 4
To (AA) Fuse 45
(DD) CIigarette lighter circuit (G2)
($22)
a-h 1
CAB MAIN W/H

14
(45LD)
SET
N
CLS
(SET)
3
0.50 Y-G
0.85 W-L
h-j 2
($9D)
0.50 Y-G
1
h-j 2
0.50 Y-R
8
($9C)
0.50 B
5
h-j 2
0.50 Y-R
0.50 B
($99)
h-k 2
($9D)
0.50 Y-G
1
0.50 Y-G
($5J)
25
h-k 2
0.50 Y-R
8
($9C)
0.50 B
5
0.50 B
h-k 2
0.50 Y-R
27
INST W/H
($5T)
18
DASH W/H
(#LL)
f502
To (AB) Fluorescent light switch
(PMC)
5 (SIG-)
4 (SIG+)
1
1 (SCOM)
2
3 (SIG+)
1
6 (SCOM)
2
(#HK)
To (AB) Fuse 7H
1
2
(SET)
CA-1
82580-9420
1
(RSET)
3
SHTS12Z160200084
DN.
1.
2.
3.
POWER MIRROR CIRCUIT

Power mirror switch
Power mirror controller
Power mirror motor
P_EL02_001.fm 90
EL0290
ELECTRIC WIRE
2
(51LD)
To (AB) Fuse 7K (Key ON)
2
(7KLD)
a505
0.50 W-R
3
(AHK)
INST W/H
5
(LD)
2
(S-)
(B)
1
(S+)
9
(LD)
1
(S-)
5
(#LE)
1
2
(43LD)
0.50 L
0.50 B-G
0.50 R-B
0.85 L
To (AA) Fuse 43
4
(51LD)
f502
To (AA) Fuse 51 (Direct battery)
f500
CAB MAIN W/H
a505
EA
0.50 W -R
f5
(AC)
(BSW)
SW
(+)
1 2
3
4 5 6 7 8
M2
4 (P1)
5 (P2)
1 (LO)
8 (GND)
f28
3 (M1)
Hi
6 (HI)
4
($18)
2 (M2)
5
(M2)
IP-2,6
82560-4480
0.50 L-W
3 4 5
8
0.50 B
0.50 L-R
11
Lo
0.85 L-B
6
(M1)
a-f 3
4
M2 M1
M1
1 2
OFF
0.85 B
0.50 W
2
IP-1,5
82580-6870
0.85 L-B
f19
(+)
1
(ASW)
AMP
2
8
0.50 W
CAB SIDE WIRING
IP-1,5
82560-2990
0.50 R-B
3
($17)
(GND)
a-f 3
2.00 B
(&52)
($0B)
0.50 B
(DD,DE) Cigarette lighter circuit (G2)
0.50 B
4
0.50 GR-R
EG-1,6,9,14,18
82580-6970
2
3
0.50 R-W
3 (+)
ea10
1 (RNDP)
2 (RNDG)
ENGINE SIDE WIRING
0.50 G
Engine Earth
SHTS12Z160200085
EA.
1.
2.
3.
4.
5.
6.
AIR CONDITIONER CIRCUIT

Heater relay
Air conditioner unit
Blower motor
Blower switch
Air conditioner compressor
Air conditioner switch
7.
8.
9.
10.
11.
12.
Air conditioner relay

Lock amp
Air conditioner diode
Air conditioner condenser relay
Pressure switch (Triple)
Air conditioner condenser
ELECTRIC WIRE
EL0291
0.85 W
10
7
0.50 L
6
(G4N)
(B)
3
(LD)
5
(S+)
(S-)
0.50 B
a511

(G4N)
3
0.85 B
3
31
a-h 1
a-h 1
1 2 3
12
0.50 R-W
(#2B)
1.25 B
ea-a 1
14
(#2C)
ea-a 1
17
(#2D)
ea-a 1
CA-1,3
82580-7780
($5X)
($5F)
15
a4
1.25 B
0.50 R-W
0.50 B
(SCG)
(GND)
12
0.50 G
10
0.85 L-B
1
(PC+)
(SC+)
0.50 L-Y
0.50 L-Y
($54)
($53)
h-a 1
0.50 L
3
1
0.50 Y-R
16
M
2
0.50 R-W
(&52)
0.50 B
2.00 B
(&0B)
($16)
11
(ACIN)
(LOCK)
0.50 R-W
($15)
2
0.50 R-W
0.50 GR-W
DASH W/H
(RES+)
a-f 3
CAB MAIN W/H
a-f 3
0.50 GR-R
11
a-f 3
($1F)
0.50 G
9
10
(SHR)
(SG)
0.50 B-G
(GND)
(K)
7
(ACLD)
2
(&12)
11
1
(A)
3
(TACH)
4
(DD,DE) Cigarette lighter

circuit (G2)
0.50 B-W
(TACH)
f-a 6
(OFF)
(GND)
0.50 Y-R
($3P)
(MGC)
(A/C)
9
(IG+)
&C2
Joint
0.50 L
LED
0.50 Y-G

13P-G2
h-a 1
0.50 Y-R
&F2
0.50 Y
0.50 Y-R
(S-)
4
0.50 Y-L
(A/C)
(+)
(IND+)
f502
(7KLD)
f501
INST W/H
11
(MTM)
a501
(MO+)
5
(LD)
2
(S-)
a501
3
(B)
1
(S+)
(GND)
P_EL02_001.fm 91
f29
f13
a810
h13
IP-1,5
82580-7210
IP-1,5
82560-3800
CA-2,4
82560-4270
(G3)

8.00 B
(G2)
2
8.00 B
(#61)
Z01
(G1)
2
1 2
Z22
2.00 B
(G2)
Z02
IP-2,6
82560-2400
Z21
To (AC,AE) Earth DR-1
3 4
5 6 7 8 9 10
1
2
3
4
11
SHTS12Z160200086
FA.
1.
2.
3.
4.
5.
6.
7.
8.
9.
3
1
To Chassis side
(Refer to the circuit "FB")
COMMON RAIL CIRCUIT No.1 (CAB SIDE)

Common rail ECU
Accelerator sensor
Idol volume
ECU main relay
Actuator power relay
Brake blending resistor (Models with auto cruise)
PCV relay
Brake switch
PCV diode
INST W/H
3
ea-a 1
ea-a 1
0.85 B-W
9
8
0.50 B-W
0.50 B-W
a21
(#0A) 5
10
11
0.50 W-B
0.50 W-B
(SPV1)
(SP1S)
(SPV2)
(SP2S)
(INJ1)
(IJ1+)
(MRL2) 2
(MRL1) 3
0.30 R
0.50 LG
(&C8)
0.50 Y-R
11
(&F8)
11
(MENG)
(NTM)
(&F2)
16
2
0.50 V
To (FJ) Transmission
1
To (DK) Diagnosis
PCS switch
(+)
standard connector
11
To (FG)
To (DJ) J/C ETC
Light and turn switch (STCM)
13P-1 (DST-1)
2
To (CE) Stop
light switch (ESW+)
1
To (FG)
0.30 V
ICC main switch (COM)
2
To (FE) Clutch
pedal switch (CLT+)
(DSW0)
(DCD0)
3
(&2B)
To (FC) DC/DC
Converter
(#25) 3
0.85 W-R
0.85 W-R
(&AH)
6
J/C Common-rail 13P
(VB3) 1
(VB2) 2
(VB1) 3
a24
ea-a 1
ea-a 1
1.25 V
(INJ2)
(DGSW) 29
(ISOK) 26
2
(&C2)
2
a103
a102
(#23) 15
ea-a 5
ea-a 5
To (FI) P.T.O.
accelerator sensor
(#24) 13
(#21) 11
a21
1.25 R
(#1X) 9
(INJ3)
(I1+S)
(IJ2+)
(INJ4)
(INJ5)
(I2+S)
a23
(#20) 10
1.25 P
a20
a24
ea-a 5
1.25 O
ea-a 5
(#1U) 8
ea-a 5
1.25 L
0.50 G-R
1.25 Y
(#1T) 7
1.25 G
1.25 BR
ea-a 5
(#08) 6
ea-a 5
ea-a 5
(INJ6)
(CE/G) 12
0.50 V
0.50 Y-R
0.50 BR
(#07) 5
(#04) 4
a20
1.25 W
a21
1.25 B
a24
ea-a 5
ea-a 5
(CASE)
a22
(#02) 2
18
a24
(#01) 1
0.50 BR
a22
(TACH) 16
0.50 O
ea-a 5
(AVC4)
(CA2L) 18
a23
(IVS)
(&2X)
(#03)3
20
a24
0.50 O
(AGD4) (CA2H) 14
0.50 L
f-a 4
0.50 O
(ACS1)
2
3
To (DJ) Diagnosis connecter (16P)
(&LN) (CAN-)
J/C CAN
0.50 O
1
14
15
5
To (GA,GC) ABS ECU
(&2Y) (CANL)
(&LR)
(&32)
($1N)
f-a 4
32
(AVC5)
a23
0.50 G-O
0.50 G-O
27
24
0.50 G
(ACS2)
a24
($1N)
0.50 O 3
0.50 O
0.50 G-R
32
a23
0.50 G-O 2
To (FI) P.T.O.
accelerator sensor
f-a 4
23
J/C ETC 14P
($1N)
0.50 G-R 1
(&AJ)
5
0.50 O
(PGD1) 6
(CGD1) 5
(CGD2) 4
(AGD5)
(AGD1)
a22
(SIG1)
15 0.50 G-R
0.50 L
26
30
(PGD3) 3
(PGD2) 4
a21
(&AT)
16
0.50 G-R
(&AV)
17 0.50 G-R
3
2
1
(&AK)
2
a21
1
(SIG2)
4 0.50 O
(VCC1)
(GND1)
(PIM)
(AVC1)
(STOP)
7
(HRY)
11
(GND)
(SIG)
(+)
ea-a 2
ea-a 2
ea-a 2
a609
(#0D) 3
17
a23
0.50 Y-B
19
11
a20
(#0C) 2
3
0.50 Y-R
8 0.50 G-R
(&AU)
(#CS)
6
(HRY2)
0.50 R-B
a619
(#0B) 1
(#64)
a609
0.50 L-W
0.50 R-B
J/C Common rail 20P
EL0292
3
(GND)
2
(SIG)
1
(+)
CAB MAIN W/H

1.25 BR
(&2S)
J/C CAN a619
a22
0.50 Y
Joint
1.25 BR
1.25 BR
0.50 BR
CAB MAIN W/H
(#CQ)
#59
(G4-C)
To (GA,GC,GD)
ABS ECU
(&LS)
33
c-a 2
(#EG)
0.50 O
#58
3.00 BR
14
(CANH)
(MMT-)
#58
(#65)
(&2W)
5
(&2T)
1
CAB SIDE WIRING

4
a606
5.00 BR
0.50 L
(MMT+)
21
0.50 O 9
J/C Common rail 20P
To (AG)
Ground circuit (G4-P)
To (BA,BC)
Combination meter
22
9
b-a 4
(#6M)
CHASSIS SIDE WIRING
P_EL02_001.fm 92
ELECTRIC WIRE
1
(DC24)
FA
1.25 W-L
1.25 W-L
1.25 W-L
0.50 W-R
0.50 W-R
a22
a20
(&A5)
7
(&AC)
6
a613
(&AD)
To Chassis side
SHTS12Z160200087
ELECTRIC WIRE
EL0293
1
(+)
To (FH) Start idle up switch

To (FJ) Mixer idle up switch
To (FJ) Economy running switch
0.50 W-R
(KBP)
15
13
(SSWS)
a23
(SWSS)
(ST)
(VS)
18
0.50 LG
(B)
2
(S-)
1
(S-)
1
(S+)
h-a 1
20
KC5
KC4
(K)
(A)
2
(73LD)
8.00 B
(&49)
a612
(&10)
0.50 LG
5
2
(E)
To (GD) Clutch fluid

pressure switch
DASH W/H
($5L)
To (BA,BC) Pulse adjust

computer
(PC04)
7
1
J/C Earth 13P-G2
0.50 LG
ea-a 2
6
(&1H)
(NO+)
0.50 W
a503
(#0Q) 14
0.50 LG
(&F1)
(17LD)
(17+)
FUSE 17
0.50 P
(STP)
(G4-C)
FUSE 19
ea-a 2
7
(&1G)
#59
3.00 BR
a615
J/C ETC 13P-2
(NO-)
a102
a103
0.50 W
0.50 P
a504
To (CE)
Stop light switch
h-a 1
(PCR1)
(AVC2)
24
(PCR2)
24
(THF+)
32
31
ea-a 2
0.50 R-W
(#0M) 11
0.50 R-B
ea-a 2
(#0L) 10
0.50 Y
0.50 BR
ea-a 2
ea-a 2
(#0J) 8
ea-a 2
0.01 DR-N
a613
J/C Common rail 13P
(&A9)
(#0K) 9
1
(&C1)
(19LD)
0.50 G-W
10
(#0H) 7
(ESW-)
Refer to "A. POWER SUPPLY CIRCUIT"

for detail of this area.
ea-a 2
0.50 GR
(A5R) 6
8
(BSW2)
20
0.50 BR
(&A8)
To (AH,AI) Starter relay
(A5R) 2
(&A3)
(&AA)
0.50 LG
a609

11
0.50 G-Y
a24
2
(#6J)
(BSW1)
(&A4)
0.85 B-R
0.50 P
(17LD)
0.50 GR-B
a23
(&AB)
(#0N) 12
J/C Common-rail 13P
a613
(19LD)
ea-a 3
(#2Q) 11
ea-a 3
(#2B) 12
ea-a 3
(&AF)
(#65)
(#2P) 10
a21
(#0P) 13
(+BF2)
(AGD2)
(THW+)
a20
24
(NE1+)
1
(#0G) 9
(#0F) 7
(#0E) 12
a102
a103
10
(&AE)
a23
a21 a20
29
(NE1-)
(NESD)
3
31
a23
2
(G3+)
(GVCC)
(+BF1)
25
33
a21
0.50 B-O
0.50 GR
0.50 GR
a23
(GGND)
a22
J/C Common rail 20P
To (AA) Fuse 16
(S+)
(S+)
a504
2
(S-)
0.50 W-R
25
(K7L) 4
2
(16LD)
To (AA) Fuse 15
0.50 BR
3
(B)
2
(15LD)
($55)
5
(E)
(K7L) 8
(S-)
8.00 B
(K7M) 2
a503
(K7M) 3
3
(B)
(ESW-)
(K7M) 7
5
(LD)
1.25 W-R
0.50 W-R
a505
(RST+)
(IU-) 6
(IUP+) 2
(SW+) 3
(RST-)
To (FE) Retarder check switch
To (AA) Fuse 73
P_EL02_001.fm 93
1: RHD
2: LHD
To Chassis side
SHTS12Z160200088
P_EL02_001.fm 94
EL0294
ELECTRIC WIRE
CONNECTORS FOR CIRCUIT "FA"
a24
a23
IP-1,5
82580-4430
IP-1,5
82560-4440
35pin-1
a22
a21
IP-1,5
82560-4420
IP-1,5
82560-4450
8 9 10 11 12 13 14 15 16 17
30
34pin
18 19 20 21 22 23 24 25 26 27
28 29
33 34
18 19 20 21 22 23 24 25 26 27
28 29 30 31 32
8 9 10 111213 141516171819
20212223
2425
2627
282930 31
3233
3435
8 9 10 11 12 13 14 15 16 17
31 32
32pin
7 8 9 10 11 12 13 14 15 16
17 18 19 20 21 22 23 24 25 26 27
28 29 30
31 32 33 34 35
35pin-2
SHTS12Z160200089
P_EL02_001.fm 95
ELECTRIC WIRE
EL0295
a20
IP-1,5
82560-4410
a62
f80
(RHD)
IP-2
82580-8660
(LHD)
IP-6
82580-8660
8 9 1011121314151617
181920212223
2425
2627
2829
3031
a70
IP-2,6
82580-9450
31pin
1 2 3 4 5
a816
h8
IP-1
82560-2990
CA-4
82580-6820
1
2
SHTS12Z160200090
P_EL02_001.fm 96
EL0296
ELECTRIC WIRE
ea-a 1
ea-a 1
ea-a 1
ea-a 1
(#25) 3
12 11
(#0A) 5
(#23) 15
1.25 V
2
(#24) 13
(#21) 11
1.25 R
ea-a 5
ea-a 5
(#20) 10
1.25 P
1 (IJ2+)
ea-a 5
(#1X) 9
1.25 O
ea-a 5
ea-a 5
(#1T) 7
(#1U) 8
1.25 L
9 10
2 (IJ3-)
ea-a 5
ea-a 5
(#08) 6
(#07) 5
ea-a 5
(#04) 4
ea-a 5
ea-a 5
(#02) 2
(#03) 3
ea-a 2
ea-a 2
ea-a 2
0.01 DR-N
Fr-LH W/H
0.75 W-B
0.75 B-R
0.75 B-W
1 (SP1+)
2 (SP1-)
0.75 W-R
ea
ib
ia
12
10 9
2 (IJ4-)
K32
2
(LN/C) (EC+)
ea-ib 1
ia-ib 1
1 (IJ3+)
2 (SP2-)
1.25 L
1.25 Y
11
1.25 G
1.25 BR
1.25 Y
1.25 W
0.50 Y-B
0.50 Y
0.50 Y-R
1.25 B
1.25 DR-N
0.50 Y-B
(CPU)
K33
CAB MAIN W/H
(#0D) 3
(#0B) 1
0.50 L-W
(#0C) 2
2
(SW)
CHASSIS SIDE WIRING
(#01) 1
ea-a 5
c-a 2
33
Fr-RH W/H
To (AS) Intake
air heater relay
To Cab side
(Refer to the circuit "FA")
(#EG)
9
(#6M)
b-a 4
To Cab side
1 (IJ4+)
CAB SIDE WIRING
FB
2 (IJ2-)
1 (IJ1+)
2 (IJ1-)
ia7
ia6
ia5
ia4
ia3
ia2
1 (SP2+)
2 (IJ5-)
1 (IJ5+)
Z28
(EGND)
2 (IJ6-)
1 (IJ6+)
(GND)
2
(SIG)
(VCC)
ENGINE SIDE WIRING
To (IA,IB,IC,ID)
Tilt lock switch
ea5
10
Engine earth
(Earth shield cable)
ea9
EG-1,6,9,14,18
82580-8980
ia2
ia3
ia4
ia5
ia6
ia7
ea14
ea13
1 2 3
EG-2,3,4,7,9,15,16
82580-9600
EG-1,6,9,14,18
82580-8260
EG-1,6,9,14,18
82580-8260
2 1
1 2
1 2
10
3,4,5,6,7,8
SHTS12Z160200091
FB.
1.
2.
3.
4.
5.
6.
7.
8.
COMMON RAIL CIRCUIT No.1 (CHASSIS SIDE)

Engine stop switch
Boost pressure sensor
Fuel injector No.6
Fuel injector No.5
Fuel injector No.4
Fuel injector No.3
Fuel injector No.2
Fuel injector No.1
9.
10.
11.
12.
13.
14.
15.
PCV (Pump control valve) No.2

PCV (Pump control valve) No.1
Engine speed sub sensor
Engine speed main sensor
Coolant temperature sensor
Fuel temperature sensor
Common rail pressure sensor
11
ea15
ea16
ea19
ea11
EG-1,6,9,14,18
82580-9960
EG-1,6,9,14,18
82560-1230
EG-1,6,9,14,18
82580-8760
EG-1,6,9,14,18
82580-7120
2
1 2
3
1 2
12
13
14
1 2 3
11
13
14
1
VCD
GND
SIG
12
+
3 (PCR+)
2 (PCR)
1 (PCR-)
2 (THF-)
1 (THF+)
2 (WTM-)
1 (WTM+)
1 (NE-)
2 (NE+)
1 (MRES)
3 (MREV)
2 (MREG)
(#0L) 10
(#0M) 11
0.50 R-B
0.50 R-W
0.50 LG
0.50 P
(#0Q) 14
(#0P) 13
(#0N) 12
(#0J) 8
0.50 W
0.50 G-W
(#0K) 9
(#0H) 7
0.50 DR-N
(#2B) 12
0.50 GR
0.50 BR
(#2P) 10
(#2Q) 11
0.50 GR-B
0.50 G-Y
ea-a 2
ea-a 2
ea-a 2
ea-a 2
ea-a 2
ea-a 2
ea-a 2
ea-a 2
ea-a 3
ea-a 3
ea-a 3
P_EL02_001.fm 97
ELECTRIC WIRE
EL0297
To Cab side
0.50 R-B
15
EG-1,6,9,14,18
82580-6630
ea12
1 2 3
15
SHTS12Z160200092
P_EL02_001.fm 98
EL0298
ELECTRIC WIRE
FC
CAB MAIN W/H
21
a20
IP-1,5
82560-4410
0.50 L
0.50 Y
22
18
a20
0.50 W-L
17
0.50 W-L
0.50 W-L
CAB SIDE WIRING
16
a23
(CANL)
(CANH)
(ER3C)
(ER3B)
(ER3A)
a609
4
(&AL)
3
8 9 1011121314151617
181920212223
2425
2627
2829
3031
(&AM)
2
(&AN)
1
(&AP)
#58
(G4-P)
J/C Common rail 20P

(FA) Common rail
circuit No.1
6
82828-1080
31pin
1
a21
IP-1,5
82560-4450
5.00 BR
1 2 3 4
ea-a 4
7
ea-a 3
6
5 (#JR)
(#JS) 8
0.50 L
EG-1,6,9,14,18
82560-3560
16
(VNTL)
13
(VNTV)
0.50 W-R
14
(VNTG)
(EGRV)
1 2 3 4
5 6 7 8
9 10 11 12
13 14 15 16
0.50 W-R
3
(EGRG)
14
(JEG+)
4 5 6
0.50 BR
35pin-2
ea4
0.50 Y
(EGRL)
(EGRH)
0.50 BR
EG-1,6,9,14,18
82580-8490
31 32 33 34 35
(#JP) 3
(#JQ) 4
(VNTH)
15
15
0.50 W-L
28 29 30
2 (#JN)
1 (#JM)
ea1
1 2 3
17 18 19 20 21 22 23 24 25 26 27
0.50 L
ea3
J/C ENGINE CAN

0.50 Y
(JEG-)
13
ENGINE SIDE WIRING
(#0R)
ea-a 2
(#2V)
13 14 15 16
0.50 L
12
ea-a 3
10 11
7 8 9 10 11 12 13 14 15 16
1.25 BR
(PGD2)
(#2U)
0.50 Y
6 7
0.50 BR
(#1G)
0.50 W-L
(#84)
0.75 W-R
SHTS12Z160200093
FC.
1.
2.
3.
4.
5.
6.
7.
8.
COMMON RAIL CIRCUIT No.2 (EGR AND VGT)

Common rail ECU
JAKE EGR (Solenoid valve)
EGR control
VNT control
Turbocharger revolution sensor
EGR coolant temperature sensor
Air flow sensor
DC/DC converter (Common rail)
5
3
7
1 2
3
EG-1,6,9,14,18
82828-1630
1 2 3 4 5
ea8
6
0.50 R-Y
0.50 W-B
3 (AFSG)
1 (AFVB)
0.50 R-W
0.50 R-B
0.50 BR
0.50 W-R
12
(KBP)
a505
ea-a 1
3
(DCGD)
1
(DC24)
(KBP)
7
(#28)
8
0.50 BR
0.50 W-R
ea-a 1
18 19 20 21 22 23 24 25 26 27
(DC12)
23
30
28
(ETHW)
(AFT+)
(AFSG)
ELECTRIC WIRE
(KBP)
To (FA) Common rail circuit No.1
(AGD6)
a21
0.50 BR
0.50 W-B
0.50 R-Y
0.50 R
0.50 R-L
27
a24
(#29)
ea-a 1
ea-a 1
ea-a 1
ea-a 4
0.50 BR
3
(NESD)
a24
(#26) 4
(#1K) 10
(#1J) 9
(#1H)
(&CD)
0.01 DR-N
(TUN-)
(TUN+)
a21
2 (AFGD)
0.50 R
4 (AFT+)
5 (AFT-)
0.50 R-L
33 34
a102
a103
8 9 10 11 12 13 14 15 16 17
13
a19
(ETSG)
13
IP-1,5
82560-3290
2
(ETGD)
EG-1,6,9,14,18
82560-8760
9
(#0K)
5
a24
(&FD)
IP-1,5
82580-4430
(#0L)
ea18
(FA) Common rail
circuit No.1
IP-1,5
82560-4440
(WTM-)
ea6
10
To (FB) Coolant temperature

sensor
EG-1,6,9,14,18
82828-1100
0.01 DR-N
8 9 10 111213 141516171819
20212223
2425
2627
282930 31
3233
3435
0.50 R-B
34pin
ea-a 4
35pin-1
(#1B) 6
0.50 DR-N
28 29 30 31 32
6
3 (TBSD)
5
0.50 R-W
0.50 R-B
a24
ea-a 4
ea-a 4
1
6
(#19) 4
(#1A) 5
0.50 R-W
1
2
0.50 R-B
1 (TSR-)
a23
2 (TSR+)
P_EL02_001.fm 99
EL0299
8
a505
1 2 3
4 5 6
SHTS12Z160200094
P_EL02_001.fm
100
EL02100
ELECTRIC WIRE
FD
CAB MAIN W/H
(ABS)
28
a23
a23
8 9 10 111213 141516171819
20212223
2425
2627
282930 31
3233
3435
5
(S-)
CAB SIDE WIRING
IP-1,5
82560-4440
35pin-1
To (GA,GB,GC) ABS sub brake cut relay
SHTS12Z160200095
FD. COMMON RAIL CIRCUIT No.3 (ABS)

1. Common rail ECU
P_EL02_001.fm
101
ELECTRIC WIRE
EL02101
SHTS12Z160200096
P_EL02_001.fm
102
EL02102
ELECTRIC WIRE
CAB MAIN W/H
(CLT-)
1.25 W-R
(&AX)
12
14
(&FE)
0.50 GR
0.50 GR-L
14
1
2
(&CE)
0.50 GR
2
1
0.50 GR-L
a23
a22
17
J/C Common rail 20P
23
0.50 B
(IDLE)
2
1
(ACL-)
(CLSW)
a103
a102
IP-2,6
82580-8110
a609
(&AY)
14
(&AW)
(ACL+)
0.50 GR-L
(B)
IP-2,6
82560-3030
5
(LD)
13
0.50 R
a61
(KBP)
(CLT+)
0.50 R
a42
a505
FE
4
ENGINE SIDE WIRING
6
(&F6)
a103
a102
(EBMV)
a-c 1
(+)
12
0.50 GR
1
6
(&C6)
(#AH)
3
4
18
8
(RTR1)
0.50 L-Y
7
2
3
0.50 G-B
(RTR2)
(E)
3
4
8
18
EG-2,3,4,7,9,15,16
82580-7180
(RTR3)
0.50 W-R
a-c 1
27
c37
(#AG)
CHASSIS SIDE WIRING
1: Models without ABS

2: Models with ABS
3: RHD
4: LHD
3
4
1
(NO+)
2
(K)
(A)
9
2
0.50 GR-B
0.50 L
0.50 G-B
12
14
OFF
(KBP)
(EBSW)
(RTSW)
(S+)
(S-)
(LD)
5
3
4
(RTC2)
To (CC,CE)
Stop light switch
0.50 G-B
12
0.50 W-R
0.50 L-R
a23
a22
EB E1 E3 BE E2
(FC) Common rail circuit No.2

(#28)
1
9
3
4
(&2D)
(RTC1)
0.50 GR
0.50 GR
10
0.50 GR
0.50 GR
0.50 GR
9
(&2E)
(B)
3
0.50 L-R
(NC)
J/C ETC 13P-2
17
9
CAB SIDE WIRING
3
a615
0.50 GR-B
7
a53
a814
IP-2,6
82580-9320
IP-1,5
82560-3800
1 2 3 4
5 6 7
8 9 101112131415161718
6
SHTS12Z160200097
FE.
1.
2.
3.
4.
5.
6.
7.
8.
9.
10.
COMMON RAIL CIRCUIT No.9 (ENGINE RETARDER)

Clutch switch
Accelerator switch
ABS sub brake cut relay
Brake blending relay
Brake blending diode
Exhaust brake check switch
Common rail ECU
JAKE retarder (Solenoid valve)
P_EL02_001.fm
103
ELECTRIC WIRE
0.50 GR-G
($1K)
0.50 W-R
(-)
(+)
8
(KBP)
5
(LD)
f501
15
a-f 3
EL02103
f50
IP-2,6
82580-5600
0.50 GR-G
INST W/H
(EBCS)
31
a22
a22
a23
IP-1,5
82580-4420
IP-1,5
82560-4440
a21
IP-1,5
82560-4450
8 9 10 11 12 13 14 15 16 17
18 19 20 21 22 23 24 25 26 27
28 29
30
7 8 9 10 11 12 13 14 15 16
35pin-1
17 18 19 20 21 22 23 24 25 26 27
31 32 33 34 35
ea-a 1
CAB MAIN W/H
82828-1080
0.50 R
16
(RTD1)
0.50 W-L
($2L)
ea-a 1
35pin-2
($2A)
12
10
4
8
10 11
12
14
13 14 15 16
To (FC) Common rail circuit No.2
0.75 W-R
(JEG+)
15
28 29 30
31 32
8 9 10 111213 141516171819
20212223
2425
2627
282930 31
3233
3435
(+)
4
0.50 R
a23
0.50 R
0.50 W-L
13
a21
(BTD2)
(BTD1)
(RTD3)
10
(#28)
SHTS12Z160200098
P_EL02_001.fm
104
EL02104
ELECTRIC WIRE
FF
CAB MAIN W/H
a22
IP-1
82580-4420
To (AB) FUSE 92
0.50 B-L
4
(+)
(92LD)
To (IE) P.T.O. position switch (For ZF transmission)

1
(CL3+)
8 9 10 11 12 13 14 15 16 17
a59
18 19 20 21 22 23 24 25 26 27
28 29
IP-2
82560-3030
1
(CL3-)
1
(+)
a23
IP-1
82560-4440
J/C Common rail 20P

0.50 L
19
(&AR)
18
0.50 L
(&AS)
20
(&AQ)
a609
8 9 10 111213 141516171819
20212223
2425
2627
282930 31
3233
3435
3
(A)
To (IE) P.T.O. diode
21
35pin-1
a22
(CLST)
CAB SIDE WIRING
31 32
2
4
To (HA) ZF clutch magnetic valve
30
a22
32
(TRSW)
a23
31
(NUSW)
For tractor
Neutral signal
To (CC,CE) Trailer pick-up controller
To (AI) Neutral switch

(For ZF transmission)
1
(-)
5
(TRCN)
SHTS12Z160200099
FF. COMMON RAIL CIRCUIT No.11 (SPEED LIMITER)

1. Clutch stroke switch
2. Common rail ECU
P_EL02_001.fm
105
ELECTRIC WIRE
EL02105
FG
To (AA) Fuse 43
0.50 R-B
(A1Y)
To (BA,BC)
Combination meter
16
(MI+)
Common rail circuit
To (FE)
Clutch pedal switch
1.25 W-R
(CLT+)
To (FA)
Acutuater power relay
(SET)
14
0.30 Y-G
0.30 Y-B
0.30 Y
Z02
(G2)
8.00 B
0.50 B
(ESW-)
To (FA) Earth DR-1
a607
0.50 BR-B
CAB SIDE WIRING
To (CC,CE)
Stop light switch
(CIL-)
PUSH
RESUME (RSM)
SET
(STCM)
(CIL+)
FREE
13
11
(FSC)
1
CANCEL
(COM)
3
0.50 W-R
0.50 R-B
0.50 W-R
(KBP)
13 1.25 B
(&4A)
(&3W)
J/C Earth 14P

8.00 B
Z01
(G1)
(#61)
(SET)
21
a22
a23
(CRSW)
a22
(RES)
15
a23
(BSW2)
22
Ground circuit (G2)
a54
a22
a23
IP-2
82580-9310
IP-1
82580-4420
IP-1
82560-4440
1 2 3
4 5 6 7
8 9 1011121314151617
8 9 10 11 12 13 14 15 16 17
18 19 20 21 22 23 24 25 26 27
28 29
30
31 32
a71
IP-2
82560-4080
6
8 9 10 111213 141516171819
20212223
2425
2627
282930 31
3233
3435
2
3
35pin-1
SHTS12Z160200100
FG.
1.
2.
3.
COMMON RAIL CIRCUIT No.13 (AUTO CRUISE)

Auto cruise main switch
Common rail ECU
P_EL02_001.fm
106
EL02106
ELECTRIC WIRE
FH
1
(PSW+)
a59
IP-6
82560-3030
1
4
(CL3-)
(CL3+)
0.50 B-L
CAB MAIN W/H
(92LD)
To (AB) FUSE 92
J/C Common rail 20P

19
0.50 L
(&AR)
18
0.50 L
20
(&AQ)
U8W
(A)
To (BV) P.T.O. diode
21
a609
a22
(CLST)
CAB SIDE WIRING
(&AS)
a22
IP-5
82580-4420
8 9 10 11 12 13 14 15 16 17
18 19 20 21 22 23 24 25 26 27
28 29
30
31 32
SHTS12Z160200101
FH.
1.
2.
3.
COMMON RAIL CIRCUIT No.14 (STARTING IDLE UP CONTROL)

Clutch stroke switch
Starting idle up switch
Common rail ECU
107
ELECTRIC WIRE
EL02107
INST W/H
(KBP)
f501
f82
3
5
(LD)
To (FA) Acutuator power relay
IP-6
82560-4120
INST SW W/H
1
3
0.50 BR-W
0.50 W-R
0.50 B
11
(&0B)
(IUI-)
(IU-)
(IU+)
6
To (AD,AE) Cab main

wiring harness
(Earth DR-1)
J/C Earth 14P-G2

f604
10
0.50 BR-W
a-f 5
16
2.00 B
(&52)
OFF
ON
($2M)
2
(&5M)
a23
(RANG)
a22
35pin-1
1
(E)
To (HA) ZF range front switch

(Models with ZF transmission)
2
(N/O-)
To (HB) MZ12 range front switch

(Models with MZ12 transmission)
2
(BSW-)
8 9 10 111213 141516171819
20212223
2425
2627
282930 31
3233
3435
To (CH,CI,CJ) Back-up light switch
a23
IP-1,5
82560-4440
29
a22
16
(BACK)
(SSUP)
P_EL02_001.fm
SHTS12Z160200102
P_EL02_001.fm
108
EL02108
ELECTRIC WIRE
FI
2
(PSW-)
CAB MAIN W/H
25
(PTO)
+B/OPEN input
a22
(AVC4)
(ASCS)
a21
a24
22
20
(AGD4)
a23
27
CAB SIDE WIRING
a609
0.50 O
15
0.50 G-R
0.50 O
7
(&AH)
6
(&AV)
16
0.50 G-R
0.50 O
(&AJ)
5
a609
(&AU)
17
(&AT)
(&AK)
0.50 G-R
J/C Common rail 20P
J/C Common rail 20P

0.50 R-L
(VCC1)
0.50 O
(GND1)
4
0.50 G-R
32
(AVC5)
26
(AGD5)
c-a 2
(#CR)
7
0.50 R-L
2 (SIG)
6
c-a 2
(#CQ)
0.50 O
1 2
3 4
1 (VCC)
c48
IP-2,3,4,7,9,15,16,19
82560-1260
0.50 G-R
CHASSIS SIDE WIRING
Fr-LH W/H
3 (GND)
8
c-a 2
(#CS)
To (FA) Accelerater
sensor
2
2
SHTS12Z160200103
FI.
1.
2.
3.
COMMON RAIL CIRCUIT No.15 (P.T.O.)

Common rail ECU
Engine stop switch
P_EL02_001.fm
109
ELECTRIC WIRE
EL02109
7
(IUP-)
To (FJ) Mixer idle up switch
a23
26
(MIXI)
IP-1,5
82560-4440
a22
8 9 10 111213 141516171819
20212223
2425
2627
282930 31
3233
3435
35pin-1
a22
IP-1,5
82580-4420
15
8 9 10 11 12 13 14 15 16 17
17 18 19 20 21 22 23 24 25 26 27
18 19 20 21 22 23 24 25 26 27
28 29 30
28 29
31 32 33 34 35
30
31 32
8 9 10 11 12 13 14 15 16 17
18 19 20 21 22 23 24 25 26 27
28 29 30 31 32
33 34
34pin
33
(#EG)
0.50 L-W
#5A
(CPU)
0.50 L-W
#59
3
(G4-C)
K33
(CPU)
(FA) Common rail circuit No.1
21
c-a 1
35pin-2
IP-1,5
82580-4430
(ASR)
7 8 9 10 11 12 13 14 15 16
0.50 GR
(SSWS)
0.50 GR
a24
(#UA)
a21
IP-1,5
82560-4450
0.50 GR
For Body builder
SHTS12Z160200104
P_EL02_001.fm
110
EL02110
ELECTRIC WIRE
FJ
ECONOMY RUNNING CONTROL CIRCUIT
5
(LD)
OVER-RUN
PREVENTION CIRCUIT
TRANSMISSION PCS
(POWER CUT SYSTEM) CIRCUIT
To (FA) Actuator
power relay
7
3
(SW+)
0.50 W-R
(KBP)
f501
(SW-)
2
0.50 B
0.50 V-W
($2L)
15
8
(&5N)
To (AD,AE) J/C
Earth 14P-G2
a-f 5
CAB MAIN W/H
30
0.50 V-W
a22
(AFSW)
CAB SIDE WIRING
INST W/H
(IND-)
OFF
ON
6
(PCS)
a21
a23
9
(MZ12)
a-b 4
14
0.50 W-R
(#7W)
13
(#7V)
0.50 P
2
(-)
3
1
CAB MAIN W/H

Fr-RH W/H
(+)
1 2
0.50 P
1 2
b98
EG-3,7
82560-2950
(-)
b32
EG-3,7
82560-2950
(+)
CASSIS SIDE WIRING
a-b 4
(FA) Common rail

circuit No.1
To (HB) MZ12 over-run relay
1.25 W-R
2
6
(KBP)
0.50 W-R
0.50 P
5
(S-)
(CLT+)
f49
IP-2,6
82560-4120
0.50 W-R
SHTS12Z160200105
FJ.
1.
2.
3.
4.
5.
6.
COMMON RAIL CIRCUIT No.17 (ETC.)

Economy running switch
Common rail ECU
Transmission PCS (Power cut system) switch No.1
Transmission PCS (Power cut system) switch No.2
Mixer idle up switch
Chill car idle up
111
ELECTRIC WIRE
EL02111
HONG KONG MIXER IDLE UP CIRCUIT
a21
a22
a23
IP-1,5
82560-4450
IP-1,5
82580-4420
IP-1,5
82560-4440
8 9 10 11 12 13 14 15 16 17
17 18 19 20 21 22 23 24 25 26 27
18 19 20 21 22 23 24 25 26 27
28 29 30
28 29
31 32 33 34 35
30
7 8 9 10 11 12 13 14 15 16
31 32
35pin-2
8 9 10 111213 141516171819
20212223
2425
2627
282930 31
3233
3435
35pin-1
a169
IP-1
82580-6170
(MIXI)
a23
0.50 Y-B
0.50 Y-B
(2)
($49)
0.50 W-R
(IUP+)
(IUP-)
0.50 Y-B
1
(&E1)
g-f 1
0.50 Y-B
10
INST SW W/H
($49)
f-a 6
26
CAB MAIN W/H
g17
IP-2
82580-7210
f-g 1
P_EL02_001.fm
INST W/H
1 2
0.50 W-R
1
(+)
3 4
5 6 7 8 9 10
0.50 W-R
(FE) Common rail circuit No.9

(Retarder check switch)
8
(KBP)
SHTS12Z160200106
GA.
1.
2.
3.
4.
5.
6.
c24
EV
2
c25
3
GND
AV
b47
Fr-RH W/H
EV
1
2
3
1
2
3
b48

(EXCEPT AUSTRALIA AND NEW ZEALAND MODELS)
ABS ECU
7.
ABS front modulator LH
8.
ABS front wheel sensor LH
9.
ABS front modulator RH
10.
ABS front wheel sensor RH
11.
ABS rear modulator LH
EV
AV
5
1
2
3
d67
6
sg8
2
(PSW-)
0.50 B
0.85 B
7
8
d16
d21
0.85 B
(%1H)
(BB) Ground circuit (G2)
ABS rear wheel sensor LH

ABS rear wheel sensor RH
ABS rear modulator RH
(HV)
(DV)
3
0.85 L-O
sg-e 1
0.85 L-B 19
sg-d 1 3
(%1A) (%AK)
4 0.85 L-O 20
sg-d 1
(%1B) (%AL)
sg-e 1
e-c 1
e-c 1
d-c 1
d-c 1
(HV)
(#B7)
(#B6)
(DV)
3 0.85 L-O 2
1 0.85 L-B
0.50 GR-R(#B3)
c-a 3
c-a 3
c-a 3
c-a 3
0.85 L-O
0.85 L-B
0.50 GR-R
0.50 Y-R
0.50 B
(RRHV)
(RRDV)
10
16
(RRS-)
(RRS+)
13
(RLS-)
(RLS+)
8
FR SENSOR
FR SENSOR
RL AV
RL EV
RL SENSOR
RL SENSOR
RR SENSOR
RR SENSOR
RR AV
RR EV
12
13
5
2
11
14
17
18
9
8
13 14 15 16 17 18
11
AV
d-c 1
(#AU)
11
22
(#B2)
c-a 3
0.50 Y
c-a 3
27
(#AT)
8
FR EV
7 8 9 10 11 12
11
e-c 1
0.50 Y-R
0.50 B
0.50 Y
(RLDV)
12
11
(FRS-)
(RLHV)
0.85 L-W
0.85 L-G
0.50 W-R
(#B8)
c-a 3
c-a 3
b-a 5
FR AV
1 2 3 4 5 6
(%AJ)
(SRRE) 0.50 GR-R
d-c 1
e-c 1
(#B1)
0.85 L-W 1
0.85 L-G
(#6W)
0.50 W-R
(FRS+)
2
0.50 B-R
14
(#6V)
15
0.50 B-R
b-a 5
(FRHV)
FL SENSOR
15
1 2 3 4 5
(GND)
1
0.85 L-B
(%AF)
18
(FRDV)
6
0.85 L-Y
0.85 L-R
(#6G)
b-a 5
b-a 5
(FLS-)
FL SENSOR
12
a33
IP-1,5
82580-9480
GND
15
0.50 Y-R
3
(#6F)
4
0.50 R
FLEV
(SRR+)
2
e-c 1
d-c 1
d-c 1
e-c 1
e-c 1
d-c 1
d-c 1
e-c 1
0.85 L-Y
0.85 L-R
c-a 3
FL AV
6 7 8 9 10
12 13 14
(%AE)
13
(SRLE) 0.50 B
0.50 Y
(%19) (%AC)
(%AD)
14
sg-e 1
sg-d 1
(#AQ)
(FLS+)
14
15
c-a 3
0.50 W
17
(FLDV)
18
30
(#AP)
20
(%AB)
(%18)
2 0.85 L-W 12
1 0.85 L-G 11
(SRL+)
2
0.85 L-W
sg-d 1
sg-e 1
12
(&8C)
0.50 R
0.50 W
0.85 L-B
0.85 L
(FRHV)
c-a 3
c-a 3
(#AY)
(#B0)
7
a32
IP-1,5
82580-9490
1
2
3
d68
9
sg4
EV
(HV)
(DV)
3
(GND)
1
0.85 L-G
(SFRE)
0.85 B
0.85 L-B
28

0.85 L
EL02112
(SFR+)
2
(HV)
(DV)
3
(GND)
1
(SFLE)
(SFL+)
2
(HV)
1
(&94)
CAB MAIN W/H

Fr-LH W/H
(DV)
3
0.50 B
AV
4
(GND)
1
CAB SIDE WIRING
112
GND
GND
CHASSIS SIDE WIRING
P_EL02_001.fm
ELECTRIC WIRE
GA
c-e 1, e-sg 1 1: INT-W/H and Rr-W/H integrated type

c-d 1, d-sg 1 2: INT-W/H and Rr-W/H divided type
a33
18P
Fr-L/H W/H
Rr W/H
(INT W/H)
B/C W/H
SHTS12Z160200107
CAN H
DIAG K
DIAG L
EXH RELAY
VALVE POWER1
ECU POWER
10
11
14
1
2
3
4
2,4
2
b47
c24
b48
c25
EG-3,4,7,10,11
82560-1340
EG-3,4,7,10,11
82560-4720
3,5
1
1
d67
d68
2
sg4
sg8
RR-2,3,5
82560-1340
1
2
3
4
6,9
2
1
7,8
d16
d21
RR-2,3,5
82560-4720
(#64)
3
5.00 BR
(AG) Ground circuit (G4-P)
0.85 W-R
0.85 BR
3
(#64)
11
0.50 W-R
(76LD)
To (AB) Fuse 76
To (AA) Fuse 49
ELECTRIC WIRE
(G4-P)
5.00 BR
(GND)
(G4-P)
#58
ECU EARTH1
#58
(VV1-)
N
CHK
VALVE EARTH1
1
(+)
2
(49LD)
(-)
3
(S+)
To (FE)
To (FE) Accelerator switch
9
4
(NC) (&2E)
2
(ACL-)
To (FD) Common rail ECU
To (DJ) J/C ETC 13P-1
To (FA) J/C CAN
(MABS)
0.50 W-G
0.85 BR
0.50 GR-B
12
(&FA)
0.50 GR-B
0.50 W-R
28
(ABS)
10
12
a32
11
(S-)
1
(B)
0.50 GR-B
(&1M)
(&1P)
8
10
(&2T)
0.50 W-G
(WL)
10
(IGM)
a102
a103
10
(VV1)
(&CA)
(EXHR)
0.50 P
0.50 LG
15
(&2Y)
5
(DST-1)
(ISOL)
(ISOK)
7
(CANH)
0.50 L
0.50 O
(CAN)
WARNING
5
(CANL)
14
113
15
CAN L
P_EL02_001.fm
EL02113
0.50 BR
14P
CAB MAIN W/H
1: Ireland
2: Hong Kong, Taiwan
a40
IP-2,6
82560-4100
11
SHTS12Z160200108
GB.
1.
2.
3.
4.
5.
6.
1
2
c24
3
3
4
Fr-RH W/H
1
2
b47
5
EV
3
b48
EV
1
2
3
e67
7
sg8
Rr W/H
(B/C W/H)
6
(PSW-)
2
(%A2)
5.00 B
0.50 B
0.85 B

(FOR AUSTRALIA AND NEW ZEALAND MODELS)
ABS trailer socket
7. ABS rear modulator LH
ABS ECU
8. ABS rear wheel sensor LH
9. ABS rear wheel sensor RH
10. ABS rear modulator RH
11. ABS sub brake cut relay
12. ABS diagnosis switch
e21
0.85 B
9
Z19
0.85 B
(%1H)
11
(BB) Ground circuit (G2)

(RR 1)
1
2
3
e68
10
0.85 L-O
sg-e 1
0.85 L-O
(%AL)
e-c 1
(%1B) 0.85 L-O
e-c 1
Fr-L/H W/H
(%AK)
20
19
3 0.85 L-B
(%1A)
(#B7)
(#B6)
0.85 L-O 2
0.85 L-B
c-a 3
c-a 3
16
(RRHV)
(RRDV)
10
0.85 L-O
0.85 L-B
RR SENSOR
RR SENSOR
RR AV
RR EV
17
18
9
8
2
(TECU)
(#AF)
(HV)
0.85 L-B
1
(DV)
3
(GND)
7
(RRS+)
13
0.50 GR-R (RRS-)
0.50 Y-R
7
(%03)
To (AG)
Ground circuit (G4-P)
0.50 GR-R (#B3)
c-a 3
c-a 3
RL SENSOR
18
sg-e 1
e-c 1
11
(#AU)
22
0.50 Y-R
(RLS-)
14
c-a 3
4 0.85 L-B
(SRRE) 0.50 GR-R(%AJ)
18
e-c 1
0.50 B
RL SENSOR
11
1.25 GR
(SRR+)
2
(%AF)
15
(#B2)
c-a 3
(RLS+)
8
(%BV)
EV
e16
0.50 Y-R
0.50 Y
c-a 3
RL EV
Fr-LH W/H
GND
0.50 B
(#AT)
27
RL AV
0.50 B
0.50 Y
(RLDV)
12
(2 UA)
e-c 9
0.85 L-W
(RLHV)
c-a 3
c-a 3
(#B8)
(#B1)
0.85 L-W 1
11
(%19) 0.85 L-W

(%AD)
13
1 0.50 Y
e-c 1
(SRL+)
14
2
e-c 1
(%AE)
(SRLE) 0.50 B
(%AC)
e-c 1
e-c 1
0.85 L-G
(1 F+)
1
0.85 L-W
(%AB)
12
0.85 L-G 6
5.00 BR
sg-e 1
0.85 L-W
11
0.85 L-G
3 1.25 L
(5 WR)
6 5.00 R
1.25 GR
(HV)
(DV)
3
1
(%18)
sg-e 1
0.85 L-G
(3 E1)
(4 E2)
1.25 BR-W 2
(MTAB)
4 0.85 L-G
(GND)
1
FR SENSOR
13
Rr W/H
AV
6
(FRS-)
FR SENSOR
12
(%BU)
AV
GND
0.50 W-R
3
(FRS+)
2
FR EV
22
(#6W)
0.50 B-R
(FRHV)
FR AV
c-e 9
b-a 5
b-a 5
5
(FRDV)
6
(#A4)
(#6V)
15
0.85 L-Y
0.85 L-R
1.25 L
14
(#6G)
b-a 5
b-a 5
(#AS)
c-e 9
(SFRE)
3
(#6F)
4
5.00 R
0.50 W-R
0.50 B-R
0.85 L-Y
0.85 L-R
Fr-LH W/H
(SFR+)
2
6
(%01)
FL SENSOR
15
EL02114
(HV)
(DV)
3
5.00 B
(FLS-)
(FLS+)
14
19
(GND)
1
Z09
0.50 R
0.50 L
a-c 3
16
0.85 B (G2)
c-a 3
FL SENSOR
12
a-c 1
AV
(#AP)
20
FLEV
CAB MAIN W/H
GND
c25
(#AQ)
FL AV
(96LD)
0.50 R
15
c-a 3
30
0.50 W
17
(FLDV)
18
3.00 R
(SFLE)
0.50 W
0.85 L-B
0.85 L
(FRHV)
c-a 3
c-a 3
(#AY)
(#B0)
7
28
(SFL+)
2
0.85 L-B
0.85 L
(HV)
4
(&94)
(DV)
3
0.50 B
To (AB) Fuse 96
EV
CAB MAIN W/H

Fr-LH W/H
(GND)
1
CAB SIDE WIRING
114
AV
GND
CHASSIS SIDE WIRING
P_EL02_001.fm
ELECTRIC WIRE
GB
CAB MAIN W/H
(%C0)
1
1.25 GR
To (CC) Trailer pick-up

controller
(%A4)
e-c 10
a33
18P
sg4
1
1: New Zealand
2: Australia
SHTS12Z160200109
To (AB) Fuse 76
0.50 W-R
5.00 BR
#58
(G4-P)
(#64)
#58
ECU EARTH1
4
(GND)
VALVE EARTH1
12
0.85 BR
15
12
WARNING
11
(WL)
(IGN)
ECU POWER
7
VALVE POWER1
8
(VV1)
EXH RELAY
14
(EXHR)
(ISOL)
DIAG L
11
(ISOK)
7
DIAG K
10
(CANH)
CAN H
3
CAN L
(CANL)
14
0.50 W-G
(VV1-)
0.85 BR
0.85 W-R
a32
(#64)
3
(-)

5.00 BR
(&FA)
0.50 GR-B
0.50 BR
(AG) Ground curcuit (G4-P)
0.50 GR-B
10
12
0.50 W-R
N
CHK
(S-)
1
(B)
a102
a103
10
(&CA)
(+)
(76LD)
2
3
9
(MABS)
(S+)
(49LD)
To (AA) Fuse 49
To (FE)
4
9
(NC) (&2E)

2
(ACL-)

28
0.50 P
0.50 W-G
EL02115
11
0.50 GR-B
(&1M)
10
0.50 LG
(&2T)
15
(&2Y)
5
0.50 L
0.50 O
(&1P)
8
(DST-1)
(CAN)
(ABS)
To (FA) J/C CAN
ELECTRIC WIRE
(G4-P)
115
P_EL02_001.fm
14P
CAB MAIN W/H

a32
IP-1
82580-9490
a33
IP-1
82580-9480
1 2 3 4 5
1 2 3 4 5 6
6 7 8 9 10
7 8 9 10 11 12
11
13 14 15 16 17 18
e59
RR-4,5
82580-7550
1 2
5
6
3 4
8
12 13 14
2
b48
c25
EG-2,12
82560-4720
4,6
1
sg4
sg8
2
e67
e68
RR-4,5
82560-1340
1
7,10
b47
c24
EG-2,12
82560-1340
1
3,5
2
e16
e21
RR-4,5
82560-4720
8,9
a40
IP-2
82560-4100
12
SHTS12Z160200110
GC.
1.
2.
3.
4.
5.
6.
1
2
c24
3
3
ABS CIRCUIT (FOR SEMI-TRACTOR)

ABS trailer socket
ABS ECU
1
2
3
b47
Fr-RH W/H
7.
8.
9.
10.
11.
12.
EV
6
AV
b48
1
2
3
7
6
(%01)
5.00 B
c135

(RR 1)
Z19
10
EV
0.50 B
c-a 3
c-a 3
16
0.85 L-B
(RRHV)
(RRDV)
10
0.85 L-O
(RRS-)
(RRS+)
13
0.50 GR-R
0.50 Y-R
RL SENSOR
RR SENSOR
RR SENSOR
RR AV
RR EV
14
17
18
9
8
2
(TECU)
(#B7)
(#B6)
2
(#B3)
c-a 3
c-a 3
(RLS-)
RL SENSOR
11
(#AF)
(HV)
0.85 L-O
0.85 B
0.85 L-B
9
(DV)
3
(SRRE) 0.50 GR-R
22
(#AU)
11
9
(RLS+)
8
RL EV
18
AV
0.50 Y-R
0.50 B
0.50 Y
(RLHV)
RL AV
(2 UA)
(1 F+)
1
c-a 3
(GND)
1
8
(SRR+)
2
c-a 3
c-a 3
c-a 3
11
(RLDV)
12
0.85 L-W
0.85 L-G
FR SENSOR
13
3
(5 WR)
6
1.25 GR
(#B2)
(SRLE) 0.50 B
27
(#AT)
8
0.50 Y
(SRL+)
2
(#B8)
0.85 L-W
c-a 3
(FRS-)
(FRS+)
2
FR SENSOR
12
(3 E1)
(4 E2)
1.25 BR-W
2
Fr-LH W/H
GND
(HV)
6
(#B1)
1
0.50 W-R
0.85 L-G
b-a 5
0.50 B-R
(%03)
(DV)
3
(GND)
1
(#6W)
(#6V)
15
b-a 5
FR EV
5.00 BR
GND
(SFRE)
0.50 W-R
(SFR+)
2
14
(FRHV)
(FRDV)
6
0.85 L-Y
FR AV
0.50 B-R
b-a 5
0.85 L-R
(#6G)
(#6F)
4
0.85 L-Y
b-a 5
(HV)
0.85 L-R
(MTAB)
(DV)
3
6
(%01)
22
(GND)
1
5.00 B
FL SENSOR
15
EL02116
EV
c25
AV
Z09
(FLS-)
FL SENSOR
12
19
0.85 B (G2)
0.50 R
15
(FLS+)
14
0.50 L
GND
c-a 3
c-a 3
(FRHV)
FLEV
a-c 3
(#AQ)
(#AP)
20
0.50 W
FL AV
a-c 1
(SFLE)
0.50 R
(SFL+)
2
17
(FLDV)
18
0.85 L-B
0.85 L
3.00 R
30
(#AY)
c-a 3
c-a 3
(96LD)
0.50 W
28
(#B0)
7
CAB MAIN W/H
0.85 L-B
0.85 L
(HV)
4
(&94)
(DV)
3
0.50 B
CAB MAIN W/H

Fr-LH W/H
2
EV
To (AB) Fuse 96
(GND)
1
CAB SIDE WIRING
116
AV
GND
CHASSIS SIDE WIRING
P_EL02_001.fm
ELECTRIC WIRE
GC
CAB MAIN W/H
(#AS)
1.25 L
5.00 R
(#A4)
1.25 GR
To (CE) Trailer pick-up

controller
To (AG) Ground circuit (G4-P)
1
2
3
a33
18P
Fr-L/H W/H
c136
SHTS12Z160200111
To (AB) Fuse 76
0.50 W-R
5.00 BR
#58
(G4-P)
3
(#64)
0.85 BR
0.85 W-R
#58
ECU EARTH1
4
VALVE EARTH1
9
(GND)
(VV1-)
0.85 BR
12
15
12
WARNING
11
a32
(WL)
(IGN)
ECU POWER
7
VALVE POWER1
8
EXH RELAY
14
(VV1)
DIAG L
11
(EXHR)
(ISOL)
DIAG K
10
(ISOK)
7
(CANH)
CAN H
3
CAN L
(CANL)
14
0.50 W-G
(#64)
3
(-)

5.00 BR
(&FA)
0.50 GR-B
0.50 BR
(AG) Ground curcuit (G4-P)
12
0.50 W-R
(S-)
1
(B)
N
CHK
0.50 GR-B
10
a102
a103
10
(&CA)
(+)
(76LD)
9
(MABS)
(S+)
(49LD)
To (AA) Fuse 49
To (FE)
4
9
(NC) (&2E)

2
(ACL-)

28
0.50 W-G
EL02117
11
0.50 GR-B
(&1M)
0.50 P
0.50 LG
10
(&2T)
15
(&2Y)
5
0.50 L
0.50 O
(&1P)
8
(DST-1)
(CAN)
(ABS)
To (FA) J/C CAN
ELECTRIC WIRE
(G4-P)
117
P_EL02_001.fm
14P
CAB MAIN W/H

a32
IP-1,5
82580-9490
a33
IP-1
82580-9480
1 2 3 4 5
1 2 3 4 5 6
6 7 8 9 10
7 8 9 10 11 12
11
13 14 15 16 17 18
c32
EG-15,16,19
82580-7550
1 2
5
6
3 4
8
12 13 14
2
c99
c98
RR-6,7
82560-1340
RR-5,6
82560-4720
RR-5,6
82560-4720
2
4
7,10
b48
c25
EG-15,16,19
82560-1340
EG-15,16,17
82560-4720
a40
IP-2
82560-4100
1
1
4,6
3,5
c135
c136
b47
c24
12
SHTS12Z160200112
P_EL02_001.fm
118
EL02118
ELECTRIC WIRE
0.50 B-Y
(&DC) 12
0.50 B-O
(&DD) 24
0.50 B-O
15
a14
a14
(KY2)
(SLSW)
(FTSW)
(OFF)
(ON)
24
11
a14
0.50 L
($3X)
a-f 6
(RHD)
3 4 5 6 7
3 4 5 6 7
(#9Q)
a-b 5
CAB MAIN W/H

FR-RH W/H
(M/V+)
b91
EG-5,10
82580-9250
1
a58
IP-2,6
82580-7140
(M/V-)
2
0.50 L
h9
0.85 BR
CHASSIS SIDE WIRING
($38)
9
7
0.50 G-B
3
(C+B)
g16
IP-2
82560-1100
CA-4
82580-6600
(LHD)
IP-6
82560-1100
(NO-)
(FA) Common rail circuit No.1 (G4-C)
a-f 6
(M/V+)
(S-S)
f84
(CSS)
0.50 BR
3
0.50 BR
0.50 G-W
(C-S)
(ESW+)
(ESW-)
($55)
0.50 L-W
14
DASH W/H
($5E)
a-h 1
(G4-C)
a14
0.50 G
3
#59
a15
(GND2)
(CSS)
(CLT)
(C+B)
(GND)
0.50 L-W
3.00 BR
0.50 BR-B
0.50 B-W
a14
a14
(#65)
0.50 B-O
0.50 B-Y
a14
(+B)
a-f 6
(KYSW)
($39)
0.30 BR-B
0.50 B-Y
0.50 B-O
6 (ESOF)
1 (E3F-)
2 (ESS-)
($3K)
3
0.30 B-W
CAB MAIN W/H
16
g-f 1
a-f 6
0.50 B-L
7 (ESON)
0.50 B-L
0.50 BR
g-f 1
g-f 1
INST SW W/H
INST W/H
0.50 BR
g-f 1
0.30 B-W
(&DB) 33
($3L)
(ESC-)
0.50 B-R
0.30 BR-B
0.50 B-L
CAB SIDE WIRING
6 (ESOF)
1(E3F-)
2 (ESS-)
0.30 BR-R
(ESC-)
a-f 6
(&DA) 23
22
9
0.50 B-L
0.30 B-W
0.50 B-Y
0.50 B-L
($D9)
7 (ESON)
5
11 0.50 B-L
f-g 1
(7FLD)
(7FLD)
To (AA) Fuse 47
To (AB) Fuse 7F
GD
3
(#64)
5
5.00 BR
Z12
(G4)
SHTS12Z160200113
GD.
1.
2.
3.
4.
5.
ES START CIRCUIT
ES start main switch
ES start ECU
Clutch fluid pressure switch
Clutch stroke sensor
ES start control valve
P_EL02_001.fm
119
ELECTRIC WIRE
EL02119
2
(E)
(DSW3)
(DCD3)
6
0.30 Y
0.50 Y
11
To (DK) Diagnosis
standard connector
To (AH) Neutral switch (Models with HX, MZ transmission)
1
(-)
To (AI) Neutral switch (Models with ZF transmission)
1
(BLP+)
0.30 Y-B
14
(MESS)
To (BA,BK) Combination meter
To (CH,CI,CJ,CK) Back-up light LH
2
0.50 W
0.50 BR-R
0.50 W-R
(&F1)
20
(#DL)
0.50 W-R
(BA,BC) Meter circuit

(Buzzer cancel switch)
1
(RH +)
Common rail
025 Wire To Wire
To (CL) Courtesy switch RH
1
(LH +)
To (CL) Courtesy switch LH

21
(#DM)
20
0.50 W
18
(VS )
0.50 L-G
(&5L)
(&1H)

(Brake switch)
a15
a14
IP-1,5
82580-6890
IP-1,5
82560-1220
1 2 3 4 5 6
1 2 3 4 5 6 7 8 9 10 11 12 13
7 8 9 10 1112
14 15 1617181920212223 24 2526
12pin
1
(&C1)
0.50 L-G
(BA,BC) Meter circuit

(Spring brake switch)
(WBZ+)
0.50 W
20
a14
10
a103
a102
(RVS )
(DR )
(NTL )
a14
18
(STP )
(DIC )
a14
19
a14
0.50 BR-R
8
(MPAK)
(SSIG)
(PKB1)
a14
(PKB )
a14
a14
21
a14
(PR )
5
a14
(PCO4)
26pin
SHTS12Z160200114
P_EL02_001.fm
120
EL02120
ELECTRIC WIRE
HA
0.50 G-O
CAB MAIN W/H

INST W/H
($1U)
21
(RLC2)
5
(NC)
($1T)
Z22
(G3)
0.50 L
4
0.50 L
19
(&AQ)
(CL3-)
0.50 P
(G2)
2.00 B
18
(&AR)
a-f 4
(M2LO)
(&AS)

Z21
J/C Common rail 20P

a609
0.50 P
0.50 Y-R
(S-)
0.50 B
0.50 Y
0.50 G-O
0.50 L
Hi
Lo
(CLST)
0.50 W-B
1

(RLC)
0.50 G-O
1
(+B)
0.50 Y
3
(S+)
0.50 Y
f-a 4
11
(M2HI)
11
a102
a103
(&FB)
CAB SIDE WIRING
(99LD)
To (AB) Fuse 99
(&CB)
0.50 Y
29
(RANG)
To (FF,FH) Common rail ECU
20
0.50 L
3
(A)
To (FH) Clutch stroke switch
c-a 5
17
0.50 L
(E)
0.50 Y
5
2
(E)
(+)
(+)
0.50 P
1
(#BG)
c-a 5
18
(#BH)
c-a 5
13
(#UE)
(%33)
sa-c 2
10
0.50 Y
(#UD)
sa-c 2
T/M W/H
0.50 B
0.50 B
0.50 B
0.50 B
(E)
1
0.50 G-O
CHASSIS SIDE WIRING
0.50 G-O 12
Fr-LH W/H
(%32)
CAB MAIN W/H
c-a 5
(+)
3.00 B
6
3.00 B
(%01)
(%15)
To (ID) Cab tilt circuit

(Cab tilt motor)
(%A2)
2: semi-tractor
SHTS12Z160200115
HA.
1.
2.
3.
4.
5.
ZF TRANSMISSION CIRCUIT
ZF range relay
ZF splitter change switch
ZF range Hi switch
ZF Hi-Lo magnetic valve
ZF Clutch magnetic valve
ELECTRIC WIRE
EL02121
f57
c46
IP-2
82580-6060
EG-4,11,16
82580-9250
1
2
3 4 5 6
2
4
sa7
c45
EG-4,11,16
82560-1340
EG-4,11,16
82580-9250
6
Z19
(RR 1)
5.00 B
3.00 B
(%01)
121
(%15)
P_EL02_001.fm
To (ID) Cab tilt circuit

(Cab tilt motor)
SHTS12Z160200116
P_EL02_001.fm
122
EL02122
ELECTRIC WIRE
(NC)
0.50 B
0.50 Y
(MLO2)
7
0.50 G-W
0.50 Y-R
0.50 Y
0.50 G-L
(M2LO)
6
0.50 G-W
(M2HI)
3
(MHI2)
0.50 B
0.50 B
0.50 B
0.50 B
8
b-a 6
6
0.50 G-O
1.25 B
(&8D)
5.00 B
8
(#TR)
0.50 G-W
2
1
0.50 G-O
1
(%01)
(N/O+)
(N/O+)
(N/O+)
10
0.50 G-O
(N/O-)
b-a 6
(#TQ)
0.50 Y
2
(N/O-)
b-a 6
(#TP)
0.50 G-L
2
1
5,6
8
(N/O+)
(N/O-)
b-a 6
3
(#TN)
0.50 G-W
2
(N/O-)
b-a 6
(#TM)
4
(E)
3
(E)
0.50 G-O
1 2
3 4
0.50 G-L
0.50 G-O
(2SLO)
($1L)
(#TK)
2
(+)
1
(+)
b100
0.50 R-G 14
b-a 6
(#TJ)
0.50 R-L 13
b100
To (BA,BC)
Combination meter
b-a 6
0.50 R-L
CAB MAIN W/H

Fr-RH W/H
a-f 3
0.50 R-G
0.50 G-W
19
a-f 4
1
2
3 4 5 6
(2S+)
2 0.50 L
0.50 R-L 4
Hi
Lo
($1R)
(2SHI)
16 0.50 R-G 6
f57
IP-2,6
82580-6060
($0K)
f-a 1
(AF) Ground
circuit (G2)
INST W/H
EG-7,10,15,19
82580-8350
a103
a102
(B)
(S+)
(A)
(S-)
(K)
2
1
(NC)
0.50 L
0.50 B
2.00 B
(G2)
(&CB)
a518
Z21
a804
CHASSIS SIDE WIRING
3
2
(A)
3
(B)
(S+)
3
5
(S-)
0.50 L
19
2
0.50 G-O
(CL3-)
0.50 L
(&AR)
(&AS)
18
20
a518
IP-2,6
82560-4180
11
0.50 G-R
11
(&FB)
0.50 G-O
0.50 G-O
a609
(A)
0.50 L
CAB SIDE WIRING
0.50 L
J/C Common rail 20P
0.50 Y
(99LD)
To (FH)
Clutch pedal stroke switch
21
(CLST)
(&AQ)
To (FH)
Common rail ECU
HB
To (AB) Fuse 99
1.25 B
(&8D)
3.00 B
(%01)
SHTS12Z160200117
HB.
1.
2.
3.
4.
5.
6.
7.
8.
MZ TRANSMISSION CIRCUIT
MZ12 splitter relay
MZ12 transmission diode
MZ12 range relay
MZ12 range and splitter change switch
MZ12 splitter Hi magnetic valve No.1
MZ12 splitter Lo magnetic valve No.2
MZ12 splitter front switch
MZ12 splitter rear switch
9.
10.
11.
12.
13.
14.
15.
16.
MZ12 range rear switch

MZ12 range front switch
MZ12 power shift relay
Shift buzzer
MZ12 over-run relay
MZ12 power shift magnetic valve
MZ12 range Hi magnetic valve No.2
MZ12 range Lo magnetic valve No.3
P_EL02_001.fm
123
ELECTRIC WIRE
29
f-a 4
(RANG)
2
(B)
0.50 Y
EL02123
($1U)
0.50 W -B
1
($1T)
a-f 4
0.50 P
1
(B)
0.50 P
3
(S+)
0.50 O
0.50 R-L
12
0.50 LG
(NC)
0.50 V
(NO)
4
0.50 L-R
1
2
(S-)
2
21
0.50 R-L
(ZFB+)
1
0.50 B
2
IP-1,6
82560-2990
13
(ZFB-)
(&52)
2.00 B
11
f78
12
($0B)
(DD,DE) Cigarette lighter circuit (G2)
(#A4)
f-a 5
a-f 4
0.50 O
0.50 L
Z22
(G3)
(RLC2)
Hi
Lo
3
4
0.50 B
(RLC)
(NC)
(NO)
4
(S-)
2
a518
($1S)
(RLC1)
0.50 P
5
6
(B)
(S+)
11
INST W/H
INST W/H
(#TX)
(+)
b-a 6
0.50 LG 12
Fr-RH W/H
0.50 B
b101
6
(E)
0.50 B
b43
EG-7,10,15,19
82580-6820
2
0.50 B
0.50 B
b42
EG-7,10,15,19
82560-2950
1 2
16
1
0.50 B
4
(E)
0.50 B
15
5
(E)
14
1 2
CAB MAIN W/H
b-a 6
11
(#TW)
0.50 O
2
b101
(+)
b-a 6
(#TL)
(+)
0.50 L-R
b41
EG-7,10,15,19
82580-7180
b40
EG-7,10,15,19
82560-2950
To (FJ) Common rail ECU
(MZ12)
EG-7,10,15,19
82580-8490
10
2
1 2 3
1
4 5 6
Z09
(G2)
Z09
(G2)
14,15,16
2: Semi-tractor
SHTS12Z160200118
P_EL02_001.fm
124
EL02124
ELECTRIC WIRE
IA
(BA,BC) Meter circuit (Fuse 46)
8
18
0.50 L-Y
(&3J)
0.50 L-Y
(#L5)
0.50 L-Y 12
($1G)
f-a 3
CAB MAIN W/H
CAB SIDE WIRING
0.50 L-Y
($72)
m-f 1
INST W/H
m7
IP-4,8
82580-7140
3 (LCOM)
1
(LN/O)
(STK-)
c-a 1
24
(#U1)
(STK+)
0.50 Y-L
0.50 L-R
8
(%09)
6
1
(TBZ+)
0.50 B
(TBZ-)
2
(&93)
c-b 2
0.50 L-R
Fr-RH W/H
0.50 L
0.50 Y-L
(%08)
c-b 2
(NSW+)
6
5
(NSW-)
(STP-)
(2)
q1
EG-1,6,9,14,18
82560-2790
c8
EG-3,7,9,15,19
82580-6820
($71)
f-m 1
13 0.50 L-B
a-f 3
0.50 L-B
(STP+)
5
2
(#BA)
31
0.50 L
0.50 L-W
1
4
(%14)
2
5
(%16)
3
6
(1)
CHASSIS SIDE WIRING
EG-1,6,9,14,18
82560-2780
To (IH) Cab suspension circuit

(Front leveling valve)
0.50 L-B
c10
19
($5K)
c-a 1
0.50 L
0.50 L 19
(#B9)
c-a 1
CAB MAIN W/H

Fr-LH W/H
(#1H)
($73)
f-m 1
14 0.50 L
a-f 3
INST W/H
0.50 L-B
(#1J)
FLOOR W/H
2
0.50 L
(LN/C)
c7
c6
EG-1,6,9,14,18
82580-6600
EG-1,6,9,14,18
82580-6600
b29
EG-3,7,10,15,19
82580-7180
0.50 L-R
SHTS12Z160200119
IA.
1.
2.
3.
4.
5.
6.
7.
CAB TILT WARNING CIRCUIT (MODELS WITH HX AND MZ TRANSMISSION)

Cab tilt lock switch
Cab tilt short circuit connector (Front LH wiring harness side)
Cab tilt short circuit connector
Cab tilt stop switch
Cab tilt stroke switch
Cab tilt buzzer
Cab tilt neutral switch
P_EL02_001.fm
125
ELECTRIC WIRE
EL02125
IB
8
To (A) Fuse 46
0.50 L-Y
18
0.50 L-Y
CAB MAIN W/H
(&3J)
13 0.50 L-B
INST W/H
(LN/O)
($71)
a-f 3
14
a-f 3
($1J)
0.50 L
($1H)
2
0.50 L-Y
f-m 1
0.50 L
(LCOM)
(LN/C)
($73)
1
1
0.50 L-B
m7
IP-4
82580-7140
f-m 1
FLOOR W/H
($72)
m-f 1
0.50 L-Y 12
INST W/H
($1G)
f-a 3
(#L5)
CAB MAIN W/H
(%14)
(STK-)
24
(STK+)
(STP+)
(2)
(1)
4
2
c7
c6
EG-1,9,14
82580-6600
EG-1,9,14
82580-6600
0.50 L-R
(STP-)
0.50 L
q1
EG-1,9,14
82560-2790
EG-2,4,9,16
82580-6820
c8
(#U1)
(#BA)
c-a 1
0.50 L-B
31
0.50 L-W
1
4
(%16)
2
5
0.50 L

(Front levering valve)
0.50 L
0.50 L
EG-1,9,14
82560-2780
3
6
c-a 1
0.50 L
c-a 1
19
c10
(#B9)
Fr-LH W/H
19
($5K)
1
(TBZ+)
2
(TBZ-)
0.50 B
2
(&93)
6
0.50 L-R

SHTS12Z160200120
IB.
1.
2.
3.
4.
5.
6.
CAB TILT WARNING CIRCUIT (MODELS WITH ZF AND EATON TRANSMISSION)

Cab tilt short-circuit connector (Front LH wiring harness side)
Cab tilt short-circuit connector
Cab tilt buzzer
P_EL02_001.fm
126
EL02126
ELECTRIC WIRE
IC
0.50 L-Y
8
(#L5)
EG-1,6,9,14,18
82580-9770
0.50 L-Y
m-f 1
INST W/H
se4
CAB SIDE WIRING
0.50 L-Y12
3 0.50 L-Y 2
f-a 3
CAB MAIN W/H

1
se5
EG-1,6,9,14,18
82580-7180
EG-1,6,9,14,18
82580-7290
EG-3,7,9,15,19
82580-6820
0.50 L
EG-1,6,9,14,18
82580-6600
14
c8
2
(%12)
1 (NSW+)
(S+)
(#6B)
0.50 Y-L
b-c 2
0.50 B
0.50 L-R
0.50 Y-L
0.50 L-W
1
(STP+)
TILT W/H
c-se 1
c-b 2
8
3.00 B
3
(%13)
4
(%14)
1
(%11)
c-se 1
(%08)
5
(%15)
se-c 1
0.50 L-R
(%09)
0.50 L-R
(CM-)
0.50 Y-L
0.50 Y-L
(NSW-) 2
2 (E)
1 (+)
3.00 R
(CM+)
To (AA) FL 5
(LD)
5
(STP-)
3.00 W
0.50 L-W
a-f 3
19 0.50 L
Fr-LH W/H
FREE
PUSH
Fr-LH W/H
Fr-RH W/H
3.00 W
c-b 1
(%02)
1
2
2
3.00 W
se-c 1
TILT W/H
(LD)
INST W/H
CAB MAIN W/H
(S-)
3.00 W
(+B)
c-a 1
0.50 L-W
(#1J)
c7
f-m 1
FLOOR W/H
b29
EG-3,7,10,15,19
82580-7180
(LN/O)
2
0.50 L
($73)
(#B9)
(LN/C)
0.50 L-B 1
1
1
CHASSIS SIDE WIRING
($1G)
IP-4,8
82580-7140
18
(&3J)
($72)
se2
(LCOM)
m7
Fr-LH W/H
7
1
0.50 L-R
(TBZ+)
2
(TBZ-)
0.50 B
5
(&99)
2
J/C Earth G2-A
(&93)
c201
se-c 1
Z09
(G2)
Z19
(RR 1)
SHTS12Z160200121
IC.
1.
2.
3.
4.
5.
6.
7.
8.
9.
CAB TILT CIRCUIT (MODELS WITH HX AND MZ TRANSMISSION)

Cab tilt relay
Cab tilt motor
Cab tilt switch
Cab tilt buzzer
Cab tilt position switch
P_EL02_001.fm
127
EL02127
FLOOR W/H
(#1H)
13 0.50 L-B
f-m 1
($71)
ELECTRIC WIRE
a-f 3
INST W/H
(Front leveling valve)
0.50 L-B
0.50 L
24
0.50 L
Fr-LH W/H
(#U1)
c-a 1
CAB MAIN W/H
(#BA)
31
c-a 1
0.50 L-B
19
($5K)
3
2
(PN/C)
se3
c6
EG-1,6,9,14,18
82580-7140
EG-1,6,9,14,18
82580-6600
(STK-)
(STK+)
0.50 L
(PN/O)
(PCOM)
1
6
(%16)
se-c 1
0.50 L-R
SHTS12Z160200122
P_EL02_001.fm
128
EL02128
ELECTRIC WIRE
ID
0.50 L-Y
EG-1,9,14
82580-9770
CAB MAIN W/H
f-a 3
0.50 L-Y 12
0.50 L-Y 2
se5
EG-1,9,14
82580-7180
EG-1,9,14
82580-7290
CAB SIDE WIRING
m-f 1
INST W/H
se4
($72)
0.50 L-Y
IP-4
82580-7140
(&3J)
($1G)
se2
18
(#L5)
m7
3 (LCOM)
0.50 L
3.00 W
(S-)
3.00 W
(PN/O)
(PN/C)
1
(E)
TILT W/H
0.50 L-W
0.50 Y-L
(+)
se-c 1
(%16)
TILT W/H
4 FREE
PUSH
1
0.50 B
(PCOM)
0.50 L-W
0.50 L
1
(#6B)
(S+)
($71)
0.50 L
3.00 R
(LD)
c-a 1
(%02)
31
(#BA)
c-b 1
19
3.00 W
(#B9)
se-c 1
1
(A30)
(%12)
(+B)
(CM+)
CHASSIS SIDE WIRING
3.00 W
CAB MAIN W/H

Fr-LH W/H
Fr-RH W/H To (AA) FL 5
Fr-LH W/H
c-a 1
0.50 L
a-f 3
INST W/H
f-m 1
f-m 1
13 0.50 L-B
0.50 L-B
14 0.50 L
(#1J)
FLOOR W/H
a-f 3
EG-2,4,9,16
82580-6820
c8
EG-1,9,14
82580-7140
0.50 L-B
($73)
se3
(#1H)
(LN/O)
1
1
(LN/C)
4
(%14)
1
(%13)
0.50 L-W
se-c 1
0.50 L-R
se-c 1
0.50 L-R
3
0.50 L-R
se-c 1
0.50 L-R
(%11)
2
(CM-)
3.00 B
5
(%15)
(TBZ+)
2
(TBZ-)
se-c 1
Z09
(G2)
Z19
(RR 1)
0.50 B
2
(&93)
5
(&99)
J/C Earth G2-A

c201
SHTS12Z160200123
ID.
1.
2.
3.
4.
5.
6.
7.
8.
CAB TILT CIRCUIT (MODELS WITH ZF AND EATON TRANSMISSION)

Cab tilt relay
Cab tilt motor
Cab tilt switch
Cab tilt buzzer
ELECTRIC WIRE
EL02129
19
($5K)

(Front levering valve)
CAB MAIN W/H

Fr-LH W/H
a-c 1
0.50 L-B
24
129
(#U1)
P_EL02_001.fm
7
2
(STK-)
(STK+)
8
2
(STP-)
c6
c7
EG-1,9,14
82580-6600
EG-1,9,14
82580-6600
1
(STP+)
0.50 L-R
SHTS12Z160200124
P_EL02_001.fm
130
EL02130
ELECTRIC WIRE
IE
To (FF,FH) Clutch pedal stroke switch
18
0.50 B-L
(92LD)
(CL3+)
a609
J/C Common rail 20P
3
20
(&AQ)
0.50 B-L
0.50 L
0.50 GR-L
(U1X)
(U8W)
1
(CL3-)
4
0.50 L
a807
IP-2,6
82560-4180
(&AS)
19 0.50 L
(CLST)
(&AR)
21
To (FF,FH) Common rail ECU
(FF,FH) Common rail circuit

(Fuse 92)
1
(DBZ+)
($2V)
(IND+)
0.50 GR-L
(IND-)
(&4H)
0.50 B
12
0.50 B-L
(PTO+)
3
6
2
2 (E)
b-a 5
6
(#J2)
(PSW-)
0.50 B
6
(&97)
(+)
EG-3,7,10,15,19
82580-7180
0.50 B-L
1
Fr-RH W/H
b31
(PSW+)
b-a 5
5
0.50 GR-L
1 (+)
(#J1)
(#C5)
Fr-LH W/H
0.50 W-B
(&5U)
c-a 1
Rr-W/H
0.50 W-B
e-c 3
2
e28
RR-3
82580-4240
1: RHD
2: LHD
3: HX, MZ transmission
4: ZF transmission
0.50 L-B
0.50 L-B
(%1V)
CHASSIS SIDE WIRING
To (CD,CE) J/C
Earth 14P-G2
c38
EG-3,4,7,9,15,16,19
82580-7180
(#C2)
7
(&3F)
To (CD,CE) J/C
Earth 14P-G2
c-a 1
4 5 6 7 8
(#1E)
INST W/H
(&3H)
OFF
ON
0.50 L-B
1 2
a-f 3
17
IP-6
82580-6870
0.50 L-B
a157
0.50 W-B
(IND-)
(PTO-)
OFF
ON
4 5 6 7 8
13
(&3P)
(PTO-)
(&3N)
0.50 GR-L
1 2
0.50 GR-L
f-a 5
0.50 B
3
($31)
(IND+)
IP-2
82580-6870
0.50 GR-L
(PTO+)
3
14
0.50 GR
f51
6
(&3G)
a606
f-a 5
0.50 GR
J/C ETC 14P
(U1Y)
0.50 GR
(DBZ-)
CAB SIDE WIRING
a43
IP-2,6
82580-6390
To (AD,AF) J/C Earth1 G2-A

Body earth
SHTS12Z160200125
IE.
1.
2.
3.
4.
5.
6.
7.
P.T.O. (POWER TAKE-OFF) CONTROL CIRCUIT

P.T.O. diode
Dump warning buzzer
Transmission P.T.O. switch
Dump up switch
P.T.O. position switch (Models with HX and MZ transmission)
P.T.O. position switch (Models with ZF transmission)
131
ELECTRIC WIRE
16
0.50 GR-L
3
(&F3)
a103
a102
(MPTO)
EL02131
0.50 GR-L
25
(&C3)
(PTO)
0.50 B-L
0.50 GR-L
To (FI) Common rail ECU
0.50 GR-L
Common rail 025

wire to wire
c-sa 2
0.50 GR-L
(%DY)
sa-sb 1
0.50 GR-L
2
4
T/M W/H
(NRV)
EG-4,11,16
82560-1340
c-a 5
3
0.50 B-L
12
(%35)
sb2
(#U3)
c-a 5
CAB MAIN W/H

Fr-LH W/H
(#U2)
0.50 GR-L
P_EL02_001.fm
0.50 B-L
(NRU)
sb-sa 1
0.50 B-L
(%DX)
sa-c 2
11
(%34)
P.T.O. W/H
T/M W/H
7
SHTS12Z160200126
P_EL02_001.fm
132
EL02132
ELECTRIC WIRE
IF
(HGON)
OFF
ON
0.50 L-R
a-f 5
12
($2X)
0.50 L-R
(HGNT)
0.50 W-R
CAB SIDE WIRING
INST W/H
(#2W)
f-a 5
0.50 W-R
(77LD)
To (AB) Fuse 77
(#A5)
sf-c 2
0.50 B
4
(%2A)
0.50 B
(%01)
2 (E)
(RR 1)
Z19
5.00 B
1.25 B
(+)
(&9A)
(%29)
sf-c 2
2
A/S W/H
0.50 L-R
CHASSIS SIDE WIRING
0.50 L-R 38
c-a 1
CAB MAIN W/H

Fr-LH W/H
SHTS12Z160200127
IF. AIR SUSPENSION CIRCUIT (FOR SEMI-TRACTOR)

1. Air suspension switch (Dump control)
2. Air suspension height control magnetic valve
P_EL02_001.fm
133
ELECTRIC WIRE
EL02133
f65
IP-3,7
82560-2900
1 2
3 4
5 6 7 8 9 10
sf5
RR-6
82580-7180
SHTS12Z160200128
P_EL02_001.fm
134
EL02134
ELECTRIC WIRE
IG
(BA) Meter circuit (Fuse 21)
11
0.50 W-R
26
(PGN1)
(PGN2)
0.50 W-B
1
0.50 L-R
2
20
(MHTC)
19
0.50 V-W
a9
a10
(SS )
a9
(EBZ )
a9
(LP1 )
(DCDJ)
5
0.30 L
(DSWJ)
10
To (BA)
1
(HR1)
0.50 BR
0.30 V -W
(+B1)
(HR1G)
25
(HR1V)
0.50 BR
(KSW1)
a9
11
21
11
26
14
(KSW2)
12
(ISOK)
a10
13
(ISOK)
0.85 W-R
0.50 LG
0.50 W-R
2
(77LD)
0.50 L-Y
0.50 W-G
#L5
(A7K)
0.50 L-Y
18
0.50 LG
(&3J)
(BA) Meter circuit (Fuse 46)
CAB SIDE WIRING
To (AA) Fuse 46
To (DK) DIAG OPT
(&2B)
To (DJ) DST-1
($2W)
(DISW)
(PCO3)
(MHC+)
(MHCE)
2A 0.50 W-G
2
(21LD)
(#59)
0.50 W-B
2A 3.00 BR
0.50 G-W
0.50 G
1
(#65)
19
a9
a-c 1
(%B5)
(%B4)
3
d-c 11
0.50 W-B
(#AN)
(#CA)
20
a-c 1
d-c 11
1
(%B2)
2
INT W/H
d36
RR-2
82560-4740
a11
IP-5
82560-1810
IP-5
82580-6890
0.50 W-B
a10
0.50 G-W
26pin
0.50 G
2
2
12pin
(STFL)
16pin
3.00 BR
2
(%C5)
(%A2)
(FLGD)
9 10111213141516
7 8 9 10 1112
1 2 3 4 5 6
3
1 2 3 4 5 6 7 8
(FLSV)
CHASSIS SIDE WIRING
1 2 3 4 5 6 7 8 9 10 11 12 13
14 15 1617181920212223 24 25 26
d-c 11
37
0.50 G
a9
IP-5
82560-1220
(#AB)
0.50 G-W
3
CAB MAIN W/H

Fr-LH W/H
a-c 1
d36
2
SHTS12Z160200129
IG.
1.
2.
3.
4.
5.
AIR SUSPENSION CIRCUIT (FOR TAIWAN FR MODEL)

Air suspension ECU
Height sensor
Air suspension remote control release switch
Air suspension controller (Remote control type)
Height control magnetic valve
P_EL02_001.fm
135
ELECTRIC WIRE
f87
0.50 B-R
a-f 2
0.50 B-R
IP-6
82560-2900
N
PUSH
INST W/H
CAB MAIN W/H
(HGOC)
0.50 W-R
9
(#0Y)
(HGOU)
a-f 2
EL02135
1 2
f87
3 4
5 6 7 8 9 10
($0T)
(M-ON)
(DATA)
(CLK)
a11
a11
a10
a10
(+B )
(DATA)
(GND)
2
(CLK)
3
0.50 Y
f-a 2
10
($0W)
f-a 2
11
($0R)
f63
0.50 BR
0.50 Y
0.50 G
($48)
0.50 BR
2
(TCE)
c-a 1
1
(#CC)
c-a 1
f63
IP-7
82580-6920
d-c 11
0.50 Y-L
0.50 Y-R
(%B8)
sf-d 1
A/S W/H
3 4
(%22)
0.50 Y-L
sf-d 1
(%B6)
1 2
5
0.50 Y-R
(%20)
d-c 11
INT W/H
INST W/H
0.50 R
2
(#CB)
CAB MAIN W/H

Fr-LH W/H
($0S)
f-a 2
0.50 Y-L
0.50 Y-R
0.50 R
0.50 G 16
(U42)
a11
(U52)
(PWR)
a9
0.50 Y-L
0.50 Y-R
1 (SV-A)
2 (SV-B)
sf17
RR-2
82560-1260
d-sf 1
0.50 B
sf17
M/V A
(INTAKE/EXHAUST)
3
M/V B
(OPEN/CLOSE)
0.50 B
1 2
3 4
(INL-)
4
3
(%23)
(EXR-)
SHTS12Z160200130
P_EL02_001.fm
136
EL02136
ELECTRIC WIRE
IH
h11
0.50 B
19
1
31
($5K)
(LVF-)
0.50 L-R
1.25 B
($5X)
3
(SCG)
a-h 1
CAB SIDE WIRING
CA-2,4
82580-6600
(LVF+)
DASH W/H
CAB MAIN W/H

Fr-LH W/H
1
(TBZ+)
CHASSIS SIDE WIRING
24
(#U1)
c-a 1
0.50 L-R
To (IA,IB,IC,ID) Cab tilt buzzer
SHTS12Z160200131
IH. CAB SUSPENSION CIRCUIT

1. Leveling valve
P_EL02_001.fm
137
ELECTRIC WIRE
EL02137
IJ
4
4
0.50 G-O
2
(U7Y)
1
(U7Z)
(BLP+)
To (CJ,CK) Back-up light LH
CAB MAIN W/H

Fr-LH W/H
(#ES)
c-a 2
0.50 G-O
(MCPL)
YOKE SWITCH
(+)
U80
(G)
U7Z
c90
EG-20
82560-4730
1
SHTS12Z160200132
IJ. COUPLER LOCK CIRCUIT

1. Coupler lock switch
P_EL02_001.fm
138
EL02138
ELECTRIC WIRE
IK
(AH,AI) Engine starting circuit
2
1.25 B-Y
(91LD)
(#6K)
f-a 1
0.85 B-Y
To (AB) Fuse 91
(&DY)
OFF
3
(DL-)
1 ON
3
1
0.50 L-O
f-g 1
34
OFF
ON
(DL-)
2
(DL+)
0.85 B-Y
INST SW W/H
(DL+)
CAB SIDE WIRING
32
(&DX)
g-f 1
($0E)
0.85 B-Y 14
0.85 B-Y
7 0.50 L-O
INST W/H
a-f 5
($2S)
0.50 L-O
0.50 L-O
0.50 L-O
1: RHD
2: LHD
3: Semi-tractor
4: Except semi-tractor, Australia
5: Australia
19
0.50 L-O
(&3U)
(MDLK)
7
(&3M)
8
(&3L)
a619
J/C CAN
c-a 1
CAB MAIN W/H
0.50 L-O
0.50 L-O 1
Rr- W/H
(INT-W/H)
2
(E)
e-sg 1
0.50 L-O
1
(+)
5.00 B
B/C W/H
(%1E)
0.85 B
(%A2)
2
(E)
e-c 3
Fr-LH W/H
1
(+)
1
(+)
(%AT)
CHASSIS SIDE WIRING
0.50 L-O
0.50 L-O
(#BQ)
11
2
(E)
6
(%01)

SHTS12Z160200133
IK. INTER-AXLE DIFFERENTIAL LOCK CIRCUIT

1. Differential lock switch
2. Differential lock magnetic valve
139
ELECTRIC WIRE
1
g5
2
f85
IP-2
82560-3010
IP-6
82560-3010
3
c129
4
sg3
EG-5,RR-6
82580-9250
RR-2,3,4,5
82560-1340
EL02139
(AF) Ground
circuit(G2)
(%01)
5.00 B
Z19
0.50 B
(RR 1)
1.25 B
(&9A)
To (BC) Spring brake switch
(PSW-)
0.85 B
To (BA) Spring brake switch
(%1H)
0.50 B
11
P_EL02_001.fm
To (AF) Ground circuit (G2)

SHTS12Z160200134
P_EL02_001.fm
140
EL02140
ELECTRIC WIRE
IL
(G,H) ENGINE STARTING CIRCUIT
AE0
#6K
1.25 B -Y
(91LD)
(5 )
0.85 B -Y
g5
1
1 2
2
0.85 B -Y
1
(DL+)
4
INT
L-R
(L-R-)
(&DK)
(DLB+)
INST W/H
0.50 B
14
(&43)
To (AE)
J/C Earth 14P (G2)
a-f 5
17
($2P)
0.50 G
0.50 G
(DLB-)
0.50 L-O
7
(&3T)
(K )
(A )
0.50 G
4
8
18
0.50 G
(MDL2)
0.50 G
(&3U)
IP-1
82560-3800
0.50 L-O
(&3M)
0.50 L-O
10
9
a823
a-f 5
0.50 L-O
0.50 L-O
a44
IP-2
82560-2990
1
f-g 1
0.50 L-O
34
f-g 1
(INT-)
(&DY)
0.50 G
1
31
($2S)
(MDLK)
17
(MDL3)
19
To (BA)
Combination meter
(DL+)
0.50 L
3 4
1
2
CAB SIDE WIRING
OFF
ON
(DL-)
32
(&DX)
INST SW W/H
g21
IP-2
82580-6920
IP-2
82560-3010
g-f 1
0.85 B -Y 14
INST W/H
($0E)
f-a 1
To (B) Fuse 91
0.50 L-O
To (BA)
Combination meter
(&3L)
Fr-LH W/H
(#CC)
0.50 G 1
c-a 1
CAB MAIN W/H
c138
RR-4
82580-9250
5
1
0.50 B
To (IK)
Differential lock magnetic valve
(Inter-axle)
(E )
(+ )
1
(+ )
0.50 L-O
CHASSIS SIDE WIRING
c-a 1
J/C CAN
2
(%A2)
1.25 B
5
6
(%01)
SHTS12Z160200135
IL.
1.
2.
3.
4.
5.
REAR-REAR AXLE DIFFERENTIAL LOCK CIRCUIT

Differential lock switch
Differential lock change switch
Differential lock buzzer
Differential lock diode
Differential lock magnetic valve (Rear-rear axle)
P_EL02_001.fm
141
ELECTRIC WIRE
EL02141
(9ALD)
To (AB) Fuse 9A
2G 0.50 G-R
CAB SIDE WIRING
IM
(#6X)
Fr-RH W/H
b57
(+)
EG-5,13
82580-9250
1
(-)
CHASSIS SIDE WIRING
2G 0.50 G-R
16
b-a 5
CAB MAIN W/H
2G 0.50 B
2
(&8B)
SHTS12Z160200136
IM. AIR DRYER CIRCUIT

1. Air dryer
P_EL02_001.fm
142
EL02142
ELECTRIC WIRE

EN12Z1602J100005
NOTICE
Drawings may show the terminals that are not mounted on the vehicle according to the vehicle specification.
a-b 1 / b-a 1
Cab main wiring harness to Front RH wiring harness 1
AD, AE, AF, AG
IP-1, 5, EG-6, 9, 14, 18
82560-3640, White, Male
82560-3650, White, Female
1
3
a-b 2 / b-a 2
AD, AE, AF, AG
IP-1, 5, EG-1, 6, 9, 14, 18
82560-2870, Black, Male
1
2
4
a-b 3 / b-a 3
1
4
AA, AC
IP-1, 5, EG-1, 6, 9, 14, 18
82560-3620, White, Male
3
6
2
5
1
4
SHTS12Z160200137
P_EL02_001.fm
143
ELECTRIC WIRE
a-b 4 / b-a 4
AA, AC, AH, AI, AJ, CO, FA, FB, FJ
IP-1, 5, EG-1, 6, 9, 14, 18
82560-4500, White, Male
a-b 5 / b-a 5
EL02143
10
10
15 14 13 12
11
11
12 13 14 15
20 19 18 17
16
16
17 18 19 20
BA, BB, BC, BD, GA, GB, GC, GD, IE, IM
IP-1, 5, EG-1, 6, 9, 14, 18
82560-4540, Blue, Male
82560-4550, Blue, Female
17 16 15 14 13 12 11 10
a-b 6 / b-a 6
10 11 12 13 14 15 16 17
HB
IP-1, 5, EG-6, 9, 14, 18
82560-4540, Green, Male
17 16 15 14 13 12 11 10
82560-4550, Green, Female
10 11 12 13 14 15 16 17
SHTS12Z160200138
P_EL02_001.fm
144
EL02144
ELECTRIC WIRE
a-b 7 / b-a 7
BA, BB, BC, BD, CE
IP-1, 5, EG-1, 6, 9, 14, 18
82560-4560, White, Male
15 14 13 12 11 10 9
a-c 1 / c-a 1
2
9
Cab main wiring harness to Front LH wiring harness 1
AC, AH, AI, AL, CA, CB, CH, CI, CJ, CK, CM, CO, FE, FI, GB, GC, IA, IB, IC, ID, IE, IF, IG, IH, IK, IL
82560-2110, White, Male
7 6
5 4 3
21 20 19 18 17
33 32 31 30 29
43 42 41 40
IP-1, 5, EG-1, 6, 9, 14, 18
16
a-c 2 / c-a 2
10 11 12 13 14 15
15 14 13 12 11 10
28
27 26
25 24 23 22
39
38 37
36 35 34
3 4 5
6 7
16
10 11 12 13 14 15
171819 20 21
22 23 24 25
2627
28
293031 32 33
34 35 36
3738
39
404142 43
AI, AL, BA, BB, BC, BD, CC, CD, CF, DC, FA, FB, FI, IJ
IP-1, 5, EG-1, 6, 9, 14, 18
82560-2130, Gray, Male
13 12 11
10 9 8 7 6 5 4
26 25 24 2322 21 20 19 18 17 16 15
32 31 30
38 37
29
36
35
28
27
34
33
4 5 6 7 8 9 10
11 12 13
15 16 17 18 19 20 21 22 23 24 25 26
14
14
27
33
28
34
29
35
36
30 31 32
37 38
SHTS12Z160200139
P_EL02_001.fm
145
ELECTRIC WIRE
a-c 3 / c-a 3
EL02145
GA, GB, GC
IP-1, 5, EG-1, 6, 9, 14, 18

82560-2150, White, Male
16
15 14 13 12 11 10
27 26 25 24 23 22
21
1
2
10
15
16
17
20
21
22
23 24 25 26 27
28
29
31
32
33 34 35 36
37
38
1
18
30
17
29
38
a-c 5 / c-a 5
28
37
8
20
32
36 35 34 33
7
19
19
31
11 12 13 14
18
30
BA, BB, BC, BD, BF, HA, IE
IP-1, EG-1, 9, 14
82560-2220, Gray, Male
10 11 12 13 14 15 16 17 18
a-f 1 / f-a 1
18 17 16 15 14 13 12 11 10
Cab main wiring harness to Instrument panel wiring harness 1
AC, AD, AE, AL, BA, BC, BE, BF, CL, DA, DD, DE, DN, HB, IK, IL
82560-4500, White, Male
IP-1, 5
10
10
15 14 13 12
11
11
12 13 14 15
20 19 18 17
16
16
17 18 19 20
SHTS12Z160200140
P_EL02_001.fm
146
EL02146
a-f 2 / f-a 2
ELECTRIC WIRE
IG
IP-5
82560-4540, Blue, Male
17 16 15 14 13 12 11 10
a-f 3 / f-a 3
DI, EA, FE, HB, IA, IB, IC, ID, IE
IP-1, 5
82560-4540, Green, Male
82560-4550, Green, Female
17 16 15 14 13 12 11 10
a-f 4 / f-a 4
10 11 12 13 14 15 16 17
10 11 12 13 14 15 16 17
AD, AE, DF, DM, FA, HA, HB
IP-1, 5
82560-4560, White, Male
15 14 13 12 11 10 9
2
9
10 11 12 13 14 15
SHTS12Z160200141
P_EL02_001.fm
147
ELECTRIC WIRE
a-f 5 / f-a 5
EL02147
CB, CN, CO, DB, FH, FJ, HB, IE, IF, IK, IL
IP-2, 6
82560-2460, White, Male
11 10 9
22 21 20 19 18 17 16 15 14 13 12
a-f 6 / f-a 6
9 10 11
12 13 14 15 16 17 18 19 20 21 22
AD, AG, DM, EA, FJ, GD
IP-1, 5
82580-7340,White, Male
a-h 1 / h-a 1
10
10
Cab main wiring harness to Dash panel wiring harness 1
AE, AG, BC, CC, CE, CG, CL, DA, DB, DF, DG, DH, DL, DM, EA, FA, GD, IH
IP-1, 5, CA-2, 4
82560-2170, Glay, Male
11
10
22
21
32
31
82560-2180, Glay, Female
20 19 18 17 16 15 14
13
12
30 29 28
24
23
27 26 25
10
11
14 15 16 17 18 19 20
21
22
25 26 27
31
32
2
3
12
13
23
24
28 29 30
SHTS12Z160200142
P_EL02_001.fm
148
EL02148
a-i 1 / i-a 1
ELECTRIC WIRE
Cab main wiring harness to Roof wiring harness 1
AE, CG, CL, DI
IP-1, 5, CA-1, 3
82580-7210, Glay, Female
a-j 1 / j-a 1
82580-7340, Glay, Male
10
10
Cab main wiring harness to Door LH wiring harness 1
AE, CC, CE, DA, DG, DM
CA-1
82560-2670, Black, Male
a-j 2 / j-a 2
82560-2680, Black, Female
Cab main wiring harness to Door LH wiring harness 2
DB
CA-1
82580-6030, Gray, Male
SHTS12Z160200143
P_EL02_001.fm
149
ELECTRIC WIRE
a-k 1 / k-a 1
Cab main wiring harness to Door RH wiring harness 1
AE, CC, CE, DH, DM
CA-3
82560-2670, Black, Male
a-ea 1 / ea-a 1
Cab main wiring harness to Engine wiring harness 1
BA, BB, BC, BH, EA, FA, FB, FC, FE
IP-1, 5, EG-1, 6, 9, 14, 18
82560-4520, Black, Male
a-ea 2 / ea-a 2
EL02149
10
15 14 13 12
11
20 19 18 17
16
82560-4530, Black, Male
10
11
12 13 14 15
16
17 18 19 20
FA, FB, FC
IP-1, 5, EG-1, 6, 9, 14, 18
82560-4540, Blue, Male
17 16 15 14 13 12 11 10
10 11 12 13 14 15 16 17
SHTS12Z160200144
P_EL02_001.fm
150
EL02150
a-ea 3 / ea-a 3
ELECTRIC WIRE
FA, FB, FC
IP-1, 5, EG-1, 6, 9, 14, 18
82560-4540, Blue, Male
17 16 15 14 13 12 11 10
a-ea 4 / ea-a 4
10 11 12 13 14 15 16 17
AE, AK, BG, FC
IP-1, 5, EG-1, 6, 9, 14, 18
82560-4560, White, Male
15 14 13 12 11 10 9
a-ea 5 / ea-a 5
2
9
10 11 12 13 14 15
FA, FB
IP-1, 5, EG-1, 6, 9, 14, 18
82560-3720, Dark gray, Male
3
8
13 12 11 10 9
82560-3730, Dark gray, Female
3
6
9 10 11 12 13
SHTS12Z160200145
P_EL02_001.fm
151
ELECTRIC WIRE
b-c 1/ c-b 1
EL02151
Front RH wiring harness to Front LH wiring harness 1
AD, AG, CH, CI, CJ, IC, ID
EG-2, 3, 4, 8, 10, 11, 12, 17, 20
82560-1640, Black, Male
1
1
b-c 2/ c-b 2
AD, AF, AG, AH, BD, IA, IC
EG-2, 3, 4, 8, 10, 11, 12, 17, 20
4
8
b-c 3/ c-b 3
3
7
3
6
4
8
AH
EG-7, 19
82560-1780, Black, Male
1
1
SHTS12Z160200146
P_EL02_001.fm
152
EL02152
b-sc 1/ sc-b 1
ELECTRIC WIRE
Front RH wiring harness to Intake air heater sub wiring harness 1
AJ
EG-1, 9, 14
82560-1780, Black, Male
1
1
c-d 1 / d-c 1
Front LH wiring harness to Intermediate wiring harness 1
AD, AF, BB, CD, CF, CI, GA
EG-5, 8, 13, RR-3
82560-1320, Gray, Male
15 14 13 12 11 10
24 23 22 21 20 19 18
c-d 11 / d-c 11
17 16
8 9
10 11 12 13 14 15
16 17
18 19 20 21 22 23 24
Front LH wiring harness to Intermediate wiring harness 11
IG
EG-8
82580-8480,Black, Male
SHTS12Z160200147
P_EL02_001.fm
153
ELECTRIC WIRE
c-e 1 / e-c 1
Front LH wiring harness to Rear wiring harness 1
BB, CD, CF, CH, GA, GB
EG-5, 8, 13, RR-3, 4
82560-1320, Gray, Male
15 14 13 12 11 10
24 23 22 21 20 19 18
c-e 3 / e-c 3
EL02153
17 16
16 17
8 9
18 19 20 21 22 23 24
IE, IK, IL
EG-5, 8, 13, RR-3, 4
82560-2940, Black, Male
1
1
c-e 9 / e-c 9
10 11 12 13 14 15
CD, GB
EG-5, 13 , RR-4
4
8
2
7
3
6
4
8
SHTS12Z160200148
P_EL02_001.fm
154
EL02154
c-e 10 / c-e 10
ELECTRIC WIRE
GB
EG-5, 13, RR-4
82580-6980, Black, Male
c-sa 2 / sa-c 2
Front LH wiring harness to ZF transmission sub wiring harness 2
AG, AI, BB, BD, BF, CH, CI, CK, HA, IE
EG-4, 11, 16
1
5
9
c-sc 1 / sc-c 1
2
6
10
3
7
11
82580-9030, Gray, Male
12
11
10
4
8
12
Front LH wiring harness to Intake air heater sub wiring harness 1
AJ
82560-1780, Black, Male
1
1
SHTS12Z160200149
P_EL02_001.fm
155
ELECTRIC WIRE
c-sd 1/ sd-c 1
Front LH wiring harness to Headlight sub wiring harness 1
AF, CA, CO
EG-1, 6, 9, 14, 18
82580-6030, Black, Male
c-sd 2/ sd-c 2
Front LH wiring harness to Cab tilt sub wiring harness 1
AF, CA, CB, CD
EG-1, 6, 9, 14, 18
82580-6030, Black, Male
c-se 1 / se-c 1
EL02155
Front LH wiring harness to Cab tilt sub wiring harness 1
AD, AF, IC, ID
EG-1, 9, 14, 18
82560-2780, Black, Male
SHTS12Z160200150
P_EL02_001.fm
156
EL02156
c-sf 2 / sf-c 2
ELECTRIC WIRE
Front LH wiring harness to Air suspension valve box sub wiring harness 2
AF, IF
RR-6
c-sg 1 / sg-c 1
Front LH wiring harness to Brake valve box sub wiring harness 1
BD
EG-17, 20, RR-6
c-sh 1 / sh-c 1
82560-3530, Black, Male
10
11
12
12
11
10
13
14
15
16
16
15
14
13
Front LH wiring harness to Side turn signal sub wiring harness 1
AF, CD
EG-8
82580-8340, Black, Male
SHTS12Z160200151
P_EL02_001.fm
157
ELECTRIC WIRE
d-e 1 / e-d 1
Intermediate wiring harness to Rear wiring harness 1
AD, AF, CD, CF, CI
RR-1, 2, 3, 5
82560-4380, Black, Male
5
6
8
11
d-sf 1 / sf-d 1
10
5
6
8
11
10
Intermediate wiring harness to Air suspension valve box sub wiring harness 1
AF, IG
RR-2
d-sg 1 / sg-d 1
EL02157
82560-3350, Black, Male
Intermediate wiring harness to Brake valve box sub wiring harness 1
BB, GA
RR-1, 2, 3, 5
82560-3530, Black, Male
10
11
12
12
11
10
16
16
15
14
13
13
14
15
SHTS12Z160200152
P_EL02_001.fm
158
EL02158
ELECTRIC WIRE
e-sg 1 / sg-e 1
Rear wiring harness to Side turn signal sub wiring harness 1
BB, IK, IL
RR-3, 4, 5
e-sh 1 / sh-e 1
82560-3530, Black, Male
10
11
12
12
11
10
13
14
15
16
16
15
14
13
Rear wiring harness to Side turn signal wiring harness 1
AF, CD
RR-3
82580-8340, Black, Male
f-g 1 / g-f 1
Instrument panel wiring harness to Instrument panel switch wiring harness 1
DD, FH, FJ, GD, IK, IL
IP-2
82560-2150, White, Male
16
15 14 13 12 11 10
27 26 25 24 23 22
21
1
2
10
15
16
17
20
21
22
27
28
29
31
32
37
38
1
18
17
29
28
30
38
37
36 35 34 33
20
19
32
31
19
11 12 13 14
23 24 25 26
33 34 35 36
18
30
SHTS12Z160200153
P_EL02_001.fm
159
ELECTRIC WIRE
f-m 1 / m-f 1
Instrument panel wiring harness to Floor wiring harness 1
AE, CL, IA, IB, IC, ID
IP-3, 7
82580-8730, White, Male
h-j 1 / j-h 1
12
11
10
10
11
12
Dash panel wiring harness to Door LH wiring harness 1
AE, CC, CE, CL, DH
CA-4
82560-2670, Black, Male
h-j 2 / j-h 2
EL02159
Dash panel wiring harness to Door LH wiring harness 2
DH, DM
CA-4
82580-6030, Gray, Male
SHTS12Z160200154
P_EL02_001.fm
160
EL02160
h-k 1 / k-h 1
ELECTRIC WIRE
Dush panel wiring harness to Door RH wiring harness 1
AE, CC, CE, CL, DA, DF, DG
CA-2
82560-2670, Black, Male
h-k 2 / k-h 2
Dush panel wiring harness to Door RH wiring harness 2
AE, DB, DG, DM
CA-2
82580-6030, Gray, Male
sa-sb 1 / sb-sa 1
ZF transmission sub wiring harness to ZF transmission P.T.O. sub wiring harness 1
IE
EG-4, 11, 16
82580-7170, Black, Male
SHTS12Z160200155
P_EL02_001.fm
161
ELECTRIC WIRE
EL02161
JUNCITON CONNECTOR
EN12Z1602J100006
NOTICE
Drawings may show the terminals that are not mounted on the vehicle according to the vehicle specification.
a606
J/C ETC 14P
FA, IE
IP-2, 6
10
11
12
13
14
82560-3790, White
82550-1170, White
a607
J/C Earth 14P
AD, AE, AG, FG
IP-2, 6
10
11
12
13
14
82560-3790 Orange
82550-1180, Orange
a608
J/C Earth 14P-G2
AD, AE
IP-2, 6
10
11
12
13
14
82560-3790, Yellow
82550-1190, Yellow
SHTS12Z160200156
P_EL02_001.fm
162
EL02162
a609
ELECTRIC WIRE
J/C Common rail 20P
AH, AI, FA, FC, FE, FF, FH, FI, HA, HB, IE
IP-1, 5
10
11
12
13
14
15
16
17
18
19
20
82560-4770, Orange
82550-1300, Orange
a612
J/C Earth G2-a
AD, AE
IP-1, 5
4
9
10 11 12 13
82560-3690, Black
a613
J/C Common rail 13P
FA
IP-1, 5
4
9
10 11 12 13
82560-3690, Blue
82550-1120, Blue
SHTS12Z160200157
P_EL02_001.fm
163
ELECTRIC WIRE
a614
EL02163
J/C ETC 13P-1
BA, BC, CH, CI, CJ, CK ,DJ
IP-1, 5
4
9
10 11 12 13
82560-3690, Blue
82550-1120, Blue
a615
J/C ETC 13P-2
CA, CC, CE, CF, FA, FE
IP-1, 5
4
9
10 11 12 13
82560-3690, Blue
82550-1120, Blue
a619
J/C CAN
BA, BC, FA, IK, IL
IP-1, 5
10
11
12
13
14
15
16
17
18
19
20
82560-4770, Blue
82550-1280, Blue
SHTS12Z160200158
P_EL02_001.fm
164
EL02164
b201
ELECTRIC WIRE
J/C Earth
AD, AF, AG
EG-3, 8, 10, 11, 12, 17, 20
82580-6040, Gray
82550-1230, Gray
b202
J/C Earth G2
AD, AF
EG-3, 8, 10, 11, 12, 17, 20
82560-2680, Gray
82550-1220, Gray
SHTS12Z160200159
P_EL02_001.fm
165
ELECTRIC WIRE
c201
EL02165
J/C Earth G2-a
AD, AF, IC, ID
EG-2, 3, 4, 9, 15, 16, 19, RR-16
82560-2680, Gray
82550-1220, Gray
c202
J/C Earth G2-b
AD, AF
RR-6, 7
82560-2680, Gray
82550-1220, Gray
SHTS12Z160200160
P_EL02_001.fm
166
EL02166
f604
ELECTRIC WIRE
J/C Earth 14P-G2
AC, AD, AE, DF, FH
IP-2, 6
10
11
12
13
14
82560-3790, Yellow
82550-1190, Yellow
ea3
J/C Engine CAN
FC
EG-1, 6, 9, 14, 18
82580-6040, Gray
82550-1230, Gray
SHTS12Z160200161
P_EL02_001.fm
167
ELECTRIC WIRE
EL02167
CONNECTOR LOCATION
EN12Z1602J100007
NOTICE
There is a case that the following figures are different from that for your vehicle in the devices locations due to the
model or specification.
IP-1 [INSTRUMENT PANEL (1 of 4)] (Models: Right-hand drive)
a102
a103
f16
a609
JUNCTION BLOCK
f78
a619
f13
WIRE TO WIRE BOX

a34
f5
a816
f1
a168
a18
a8
a-i 1
f19
a14
f22
a15
f502
f500
o1
f501
o4
a-f 6
f79
a-h 1
a105
a106
n1
n2
a107
a120
a121
1
2
a-f 1
a-f 3
a-f 4
1: Halogen headlight (Blue)
2: Discharge headlight (White)
a169
a25
a167
a32
a19
a24
a23
a20
a21
a22
a-c 5
a-c 3
a33
a-b 2
a-b 3
a-b 1
a-ea 5
a808
a507
a801
a503
a504
a612
a505
a814
a-ea 1
a-ea 2
a100
a-ea 3
a810
a-ea 4
a-c 1
a500
a-b 4
a501
a-b 5
a502
a823
a809
a614
a-b 6
a613
a-c 2
JUNCTION BLOCK
(VEHICLE FRONT VIEW)
a615
a-b 7
WIRE TO WIRE BOX

SHTS12Z160200162
P_EL02_001.fm
168
EL02168
ELECTRIC WIRE

No.
Name
Circuit
No.
Name
Junction block 28P-c
Circuit
CA, CC, CE, EA,
FA, FC
a8
Front speaker (LH)
DI
a505
a14
ES start ECU (26 pin)
GD
a507
Junction block 6P
a15
GD
a609
J/C Common rail 20P
a18
Trailer pick-up controller
CC, CE
a612
J/C Earth 13P G2-a
a19
DC/DC converter
(Common rail)
FC
a613
J/C Common rail 13P
a20
Common rail ECU (31 pin)
FA, FC
a614
J/C ETC 13P-1
BA, BC, CH, CI,

CJ, CK, DJ
a21
Common rail ECU (35 pin-2)
FA, FC, FE, FI,

FJ
a615
J/C ETC 13P-2
CA, CC, CE, CF,

FA, FE
a22
FA, FE, FF, FG,

FI, FJ
a619
J/C CAN
BA, BC, FA, IK,

IL
a23
FA, FC, FD, FE,

FF, FG, FI, FJ
a801
a24
FA, FC, FI
a808
Brake blending stop diode
a25
BA, BC
a809
CA
a32
ABS ECU (14 pin)
GA, GB, GC
a810
EA
a33
ABS ECU (18 pin)
GA, GB, GC
a814
FE
CN
a816
Brake blending resistor
FA
CA, CO
a823
IL
AB
AH, AI, FA, FC,
FE, FF, FI, HA,
HB, IE
AD, AE
FA
CL
CC, CE
a34
a100
a102
Common rail 025 wire to wire

(Male connector)
AH, AI, BA, BC,

FA, FC, FE, GA,
GB, GC, GD,
HA, HB, IE
f1
a103

(Female connector)
AH, AI, BA, BC,

FA, FC, FE, GA,
GB, GC, GD,
HA, HB, IE
f5
Blower motor
EA
a105
Earth AS-1
AD, AE
f13
Lock amp
EA
a106
Earth AS-2
AD, AE
f16
Earth audio
a107
Earth AS-3
AD, AE
f19
EA
a120
Turn signal flasher
CC, CE
f22
DN
a121
Wiper relay
DL
f78
Shift buzzer
HB
a167
Autoleveling ECU
CO
f79
DM
a168
Interface ECU
CO
f500
Junction block 1
AL, CL, DD, DF,

DI, EA
a169
Chill car idle up
FJ
f501
Junction block 2
AL, AM, EA, FJ
a500
Junction block 32P-a
AA, CA, CC, CE,

CG
f502
Junction block 3
AL, AM, DB, DN,

EA
a501
Junction block 32P-b
AA, BA, BC, CL,

DJ, EA
n1
Headlight short circuit connector (Halogen headlight)
CA
AA, AL, BA, BC,

CA, CC, CE, CF,
CN
n2
Headlight short circuit connector (Discharge headlight)
CA

a502
CB, CO
AE, DI
a503
AA, BA, CA, FA
o1
P12V connector
AN
a504
AL, BA, BC DG,

DL, FA
o4
12V socket
AN
P_EL02_001.fm
169
ELECTRIC WIRE
EL02169

No.
Name
No.
Name
a-b 1

Front RH wiring harness 1
a-ea 1

Engine wiring harness 1
a-b 2

a-ea 2

a-b 3

a-ea 3

a-b 4

a-ea 4

a-b 5

a-ea 5

a-b 6

a-f 1

Instrument panel wiring harness 1
a-b 7

a-f 3

a-c 1

Front LH wiring harness 1
a-f 4

a-c 2

a-f 6

a-c 3

a-h 1

Dash panel wiring harness 1
a-c 5

a-i 1

Roof wiring harness 1
P_EL02_001.fm
170
EL02170
ELECTRIC WIRE

LH SIDE
RH SIDE
f39
f34
f38
f35
a66
a51
a49
f48
f36
f37
f33
a122
a45
f32
a71
a44
DETAIL OF
PART
a123
a68
a47
a48
a70
a67
f49
a43
a606
a607
a805
a807
a608
a804
a64
a-f 5
a58
f24
a73
a74
a76
f29
a54
f28
a53
a40
f-g 1
a61
a56
a62
f40
o2
a52
a41
a60
a42
f50
a59
f75
f51
f800
g5
g16
g21
f604
g17
g6
o3
f31
f23
f43
1: Except Australia
2: Australia
f57
1 (Gray)
2 (White)
SHTS12Z160200163
P_EL02_001.fm
171
ELECTRIC WIRE
EL02171

No.
Name
Circuit
No.
Name
Circuit
a40
GA, GB,
GC
a805
Hong Kong diode

(For Hong Kong model)
a41
Diagnosis connector (16P)
DJ
a807
P.T.O. diode
IE
a42
Clutch switch
FE
f23
DM
a43
Dump warning buzzer
IE
f24
Radio/Audio unit
DI
a44
IL
f28
Blower switch
EA
a45
Warning buzzer
BA, BC
f29
EA
a47
Combination meter (18 pin)
BA, BC
f31
Tachograph/ KIENZLE Tachograph
a48
BA, BC
f32
P/BAT
AL
a49
BA, BC
f33
P/M
AL
a51
Front speaker (RH)
DI
f34
P/ACC CAB
AL
a52
Starter switch
AA
f35
P/TAIL CAB
AL
a53
CC, CE,
DL, FE
f36
SERVICE CAB 1
AL
a54
CA, CC,
CE, FG
f37
SERVICE CAB 2
AL
a56
Horn switch
DC
f38
SERVICE CAB 3
AL
a58
GD
f39
SERVICE GROUND
a59
FF
f40
ETC. sub power supply connector
AM
a60
Stop light switch
CC, CE
f43
DF
a61
Accelerator switch
FE
f48
CN
a62
Accelerator sensor
FA
f49
FJ
a64
Diagnosis standard connector
DK
f50
FE
a66
Earth DR-1
AD, AE
f51
IE
a67
Earth DR-2
AD, AE
f57
MZ12 range and splitter change

switch
HB
a68
Earth DR-3
AD, AE
f57
HA
a70
Idle volume
FA
f75
BA, BC
a71
FG
f604
J/C Earth 14P-G2
AD, AE,
DF
a73
CB
f800
CL
a74
CF
g5
IK, IL
a76
CF
g6
Cigarette lighter
DD
a122
Parking light switch
CC, CE
g16
GD
a123
Parking light short circuit connector
CC, CE
g17
FJ
a606
J/C ETC 14P
FA, IE
g21
IL
a607
J/C Earth 14P
AD, AE,
AG, FG
o2
DC/DC converter (12V)
AN
a608
J/C Earth 14P-G2
AD, AE
o3
P24V connector
AN
a804
CC, CE
BE, BF
AD, AE
HB

No.
a-f 5
Name
No.
f-g 1
Name
Instrument panel wiring harness to
Instrument panel switch wiring harness 1
P_EL02_001.fm
172
EL02172
ELECTRIC WIRE
m4
f69
f67
f64
f65
f60
f-m 1
SHTS12Z160200164

No.
Name
Circuit
No.
Name
Circuit
f67
Power mirror switch
DN
f60
CL
f64
DB
f69
DA
f65
Air suspension switch
IF
m4
Courtesy switch RH
CL

No.
f-m 1
Name
Floor wiring harness 1
No.
Name
P_EL02_001.fm
173
ELECTRIC WIRE
EL02173
m1
m7
SHTS12Z160200165

No.
m1
Name
Courtesy switch LH
Circuit
CL
No.
m7
Name
Circuit
IA, IB, IC,
ID
P_EL02_001.fm
174
EL02174
ELECTRIC WIRE
IP-5 [INSTRUMENT PANEL (1 of 4)] (Models: Left-hand drive)

f16
f13
JUNCTION BLOCK
a613
f1
f5
f501
WIRE TO WIRE BOX
f500
a18
f502
a51
a-i 1
a14
a15
f19
a609
a619
a-f 6
a103

a102
a-h 1
a-f 4
a-f 3
a-f 2
a-f 1
a105
a106
a19
a107
n1
a120
a121
a22
a11
a-b 1
a21
a-b 2
a25
a23
a20
a24
a9
a33
a10
a-b 3
a32
a-c 3
a-ea 5
a507
a808
a503
a801
a504
a612
a814
a505
a-b 4
a-b 5
a-b 6
a810
a-b 7
a500
a-c 1
a-ea 1
a-ea 2
a809
a501
a502
a100
a-ea 3
a615
a-c 2
a614
WIRE TO WIRE BOX

a-ea 4
JUNCTION BLOCK
SHTS12Z160200166
P_EL02_001.fm
175
ELECTRIC WIRE
EL02175

No.
Name
Circuit
No.
Name
Circuit
a9
Air suspension ECU (26 pin)
IG
a502
AA, AL, BA,

BC, CA, CC,
CE, CF
a10
IG
a503
AA, BA, CA,

FA
a11
IG
a504
AL, BA, BC,

FA, DH, DL
a14
GD
a505
CA, CC, CE,

EA, FA, FC
a15
GD
a507
Junction block 6P
a18
Pick-up controller
CE
a609
J/C Common rail 20P
a19
DC/DC converter
(Common rail)
FC
a612
J/C Earth 13P G2-a
a20
FA, FC
a613
J/C Common rail 13P
a21
FA, FC, FE, FI,

FJ
a614
J/C ETC 13P-1
BA, BC, CH,

CI, CJ, DJ
a22
FA, FE, FH, FI,

FJ
a615
J/C ETC 13P-2
CA, CC, CE,

FA, FE
a23
FA, FC, FD,

FE, FH, FI, FJ
a619
J/C CAN
a24
FA, FC, FI
a801
a25
BA, BC
a808
CC, CE
a32
ABS ECU (14 pin)
GA, GC
a809
Cornering light diode No.2
CA
a33
ABS ECU (18 pin)
GA, GC
a810
EA
a51
Front speaker (RH)
DI
a814
FE
a100
CA
f1
CB
a102

(Male connector)
AH, BA, BC,

FA, FC, FE,
GA, GC, GD,
HB, IE
f5
Blower motor
EA
a103

(Female connector)
AH, BA, BC,

FA, FC, FE,
GA, GC, GD,
HB, IE
f13
Lock amp
EA
a105
Earth AS-1
AD, AE
f16
Earth audio No.1
a106
Earth AS-2
AD, AE
f19
a107
Earth AS-3
AD, AE
f500
Junction block 1
AL, CL, DI, EA
a120
Turn signal flasher
CC, CE
f501
Junction block 2
AL, AM, EA,

FE, FH
a121
Wiper relay
DL
f502
Junction block 3
AL, AM, EA
a500
AA, CA, CC,

CE, CG
n1
a501
AA, BA, BC,

CL, DJ, EA
Headlight short circuit connector (Halogen headlight)
AB
AH, FA, FC,
FE, FH, FI,
HB, IE
AD, AE
FA
BA, BC, FA, IK

CL
AE, DI
EA
CA
P_EL02_001.fm
176
EL02176
ELECTRIC WIRE

No.
Name
No.
Name
a-b 1

a-f 2

a-b 2

a-f 3

a-b 3

a-f 4

a-b 4

a-f 6

a-b 5

a-h 1

a-b 6

a-i 1

a-b 7

a-ea 1

a-c 1

a-ea 2

a-c 2

a-ea 3

a-c 3

a-ea 4

a-f 1

a-ea 5

P_EL02_001.fm
177
ELECTRIC WIRE
EL02177
P_EL02_001.fm
178
EL02178
ELECTRIC WIRE

RH SIDE
LH SIDE
f34
f35
f38
f39
a66
a8
a49
a607
f33
a45
a157
f32
f87
a68
f37
f36
DETAIL OF
a47
PART
a48
a67
a43
f80
a807
a608
a-f 5
a42
a122
f24
f98
f49
a74
a606
f40
a123
a804
a73
a40
f28
a41
a54
a52
f29
a53
a56
a64
a58
a60
a59
a65
f50
f85
f84
f82
f800
a61
a62
f604
f57
f78
f81
f31
f23
SHTS12Z160200167
P_EL02_001.fm
179
ELECTRIC WIRE
EL02179

No.
Name
Circuit
No.
a8
Front speaker (LH)
a40
a41
Name
Circuit
DI
a608
J/C Earth 14P-G2
GA, GC
a804
HB
DJ
a807
P.T.O. diode
IE
a42
Clutch switch
FE
f23
DM
a43
Dump warning buzzer
IE
f24
Radio/Audio unit
DI
AD, AE
a45
Warning buzzer
BA, BC
f28
Blower switch
EA
a47
BA, BC
f29
EA
a48
BA, BC
f31
Tachograph
a49
BA, BC
f32
P/BAT
AL
a52
Starter switch
AA
f33
P/M
AL
a53
CC, CE, DL,

FE
f34
P/ACC CAB
AL
a54
CA, CC, CE
f35
P/TAIL CAB
AL
a56
Horn switch
DC
f36
SERVICE CAB 1
AL
a58
GD
f37
SERVICE CAB 2
AL
a59
FH
f38
SERVICE CAB 3
AL
a60
Stop light switch
CC, CE
f39
SERVICE GROUND
a61
Accelerator switch
FE
f40
AM
a62
Accelerator sensor
FA
f49
FJ
a64
DK
f50
FE
a65
Diagnosis option connector
DK
f57
MZ12 range and splitter change

switch
HB
a66
Earth DR-1
AD, AE
f78
Shift buzzer
HB
a67
Earth DR-2
AD, AE
f80
Idle volume
FA
a68
Earth DR-3
AD, AE
f81
Cigarette lighter
DE
a73
CB
f82
FH
a74
CF
f84
GD
a122
CC, CE
f85
IK
a123
CC, CE
f87
Air suspension remote control

release switch
IG
a157
IE
f98
AC
a606
J/C ETC 14P
FA, IE
f604
J/C Earth 14P-G2
a607
J/C Earth 14P
AD, AE, AG
f800
BE, BF
AD, AE
AC, AD, AE,

FH

No.
a-f 5
Name
No.
Name
CL
P_EL02_001.fm
180
EL02180
ELECTRIC WIRE
f69
f60
f65
f63
f-m 1
m4
SHTS12Z160200168

No.
Circuit
No.
f60
Name
CL
f69
Name
DA
f63
Air suspension controller

(Remote control type)
IG
m4
Courtesy switch RH
CL
f65
Air suspension switch

(Dump control)
IF

No.
f-m 1
Name
Floor wiring harness 1
No.
Name
Circuit
P_EL02_001.fm
181
ELECTRIC WIRE
EL02181
IP-8 [INSTRUMENT PANEL 4 of 4)] (Models: Left-hand drive)
m1
m7
SHTS12Z160200169

No.
m1
Name
Courtesy switch LH
Circuit
No.
CL
m7
Name
Circuit
IA, IC
P_EL02_001.fm
182
EL02182
ELECTRIC WIRE
CA-1 [CAB (1 of 2)] (Models: Right-hand drive)
i9
i7
i8
i6
i5
i2
a-i 1
j3
j5
j4
a7
j14
a5
a4
j15
a-j 2
a1
a3
a-j 1
a2
SHTS12Z160200170
P_EL02_001.fm
183
ELECTRIC WIRE
EL02183

No.
Name
Circuit
No.
Name
Circuit
a1
Front turn signal light LH
CC, CE
i7
Fluorescent light
CL
a2
CG
i8
CG
a3
Washer pump motor
CN, DL
i9
Dome light RH
CL
a4
EA
j3
Power window motor

(Assistant's side)
DG
a5
Power mirror motor
DN
j4
Power window switch

(Assistant's side)
DG
a7
Mirror heater (Side under)

(Except Ireland model)
DA, DB
j5
Power door lock actuator

(Assistant's side)
DM
i2
CG
j14

(For Ireland model)
DA
i5
Center speaker LH
DI
j15
i6
Center speaker RH
DI

No.
Name
a-i 1

a-j 1

Door LH wiring harness 1
No.
Name
a-j 2

CC, CE
P_EL02_001.fm
184
EL02184
ELECTRIC WIRE
CA-2 [CAB (2 of 2)] (Models: Right-hand drive)
a-h 1
h13
k6
k4
k14
h10
h3
k3
h11
k15
h-k 2
k1
h4
h-k 1
h5
SHTS12Z160200171
P_EL02_001.fm
185
ELECTRIC WIRE
EL02185

No.
Name
Circuit
No.
Name
Circuit
h3
Mirror heater (Back RH)

DA, DB
k1
Step light RH
CL
h4
Front turn signal light RH
CC, CE
k3
DG
h5
CG
k4
DG
h10
Wiper motor
DL
k6
Power door lock switch

(Driver's side)
DF, DM
h11
Leveling valve
IH
k14

(For Ireland model)
DA, DB
h13
EA
k15
Front side turn signal light RH
CC, CE

No.
Name
a-h 1

h-k 1
Dash panel wiring harness to

Door RH wiring harness 1
No.
h-k 2
Name
P_EL02_001.fm
186
EL02186
ELECTRIC WIRE
CA-3 [CAB (1 of 2)] (Models: Left-hand drive)
i2
i10
i7
i5
i6
i8
a-i 1
k11
k12
k10
a7
a4
k2
a1
a3
a2
a-k 1
SHTS12Z160200172
P_EL02_001.fm
187
ELECTRIC WIRE
EL02187

No.
Name
Circuit
No.
Name
Circuit
a1
CC, CE
i7
Fluorescent light
CL
a2
CG
i8
CG
a3
Washer pump motor
DL
i10
Dome light RH
CL
a4
EA
k2
a7
DA
k10
Power window motor

(Assistant's side)
DH
i2
CG
k11
Power window switch

(Assistant's side)
DH
i5
Center speaker LH
DI
k12
Power door lock actuator

(Assistant's side)
DM
i6
Center speaker RH
DI

No.
Name
a-i 1

No.
a-k 1
Name
CC, CE
P_EL02_001.fm
188
EL02188
ELECTRIC WIRE
CA-4 [CAB (2 of 2)] (Models: Left-hand drive)
a-h 1
h13
j13
j10
h10
h3
h17
j9
h11
h8
h9
j2
h-j 2
h15
j1
h14
h-j 1
SHTS12Z160200173
P_EL02_001.fm
189
ELECTRIC WIRE
EL02189

No.
Name
Circuit
No.
Name
Circuit
h3
DA
h15
CG
h8
Brake switch
FA
h17
BC
h9
GD
j1
Step light LH
CL
h10
Wiper motor
DL
j2
h11
Leveling valve
IH
j9
DH
h13
EA
j10
DH
j13
Power door lock switch

(Driver's side)
DM
h14
CC, CE

No.
Name
a-h 1

h-j 1

No.
h-j 2
Name
CC, CE
P_EL02_001.fm
190
EL02190
ELECTRIC WIRE
EG-1 [ENGINE (1 of 3)] (Models: FS for Australia, Hong Kong, Ireland, New Zealand)
1: Manual cab tilt
p1
p2
a-b 7
a-c 1
a-c 2
a-c 3
a-c 5
a-b 1
a-b 2
a-b 3
a-b 4
a-b 5
a-ea 1
a-ea 2
a-ea 3
a-ea 4
a-ea 5
b44
sd4
ea1
sd5
ea19
ea20
c19
c20
ea18
c-sd 1
ea8
ea6
ea3
c17
ea5
sc2
ea2
ea9
ea21
ea17
c6
ea4
c7
ea10
ea13
ea12
ea14
ea11
1
sd1
c10
q1
ea7
ea15
c-sd 2
ea16
sd2
se3
c-se 1
b-sc 1
se2
se4
se5
c18
SHTS12Z160200174
P_EL02_001.fm
191
ELECTRIC WIRE
EL02191

No.
b44
Name
Alternator (Terminal B)
Circuit
No.
Name
Circuit
AK
ea11
FB
c6
IA, IB, IC,

ID
ea12
FB
c7
IA, IB, IC,

ID
ea13
PCV (Pump Control Valve) No.1
FB
c10

(Front LH wiring harness side)
IA, IB
ea14
FB
c17
Cornering light RH
CD
ea15
FB
c18
Cornering light LH
CD
ea16
FB
c19
Horn (Hi)
DC
ea17
BB
c20
Horn (Lo)
DC
ea18
FC
p1
Bonding earth (Cab)
ea19
FB
p2
Bonding earth (Chassis)
ea20
Alternator (Terminal L, R)
AK
q1
IA, IB
ea21
BH
ea1
EGR control
FC
sc2
Intake air heater
AJ
ea2
VNT ECU
sd1
Headlight LH
CA
ea3
J/C Engine CAN
FC
sd2
CB
ea4
VNT control
FC
sd4
Headlight RH
CA
ea5
Earth shield cable
FB
sd5
CB
ea6
FC
se2
Cab tilt relay
IC, ID
ea7
BG
se3
IC, ID
ea8
Air flow sensor
FC
se4
Cab tilt motor
IC, ID
ea9
FB
se5
Cab tilt switch
IC, ID
ea10
EA

No.
Name
No.
Name
a-b 1

a-ea 1

a-b 2

a-ea 2

a-b 3

a-ea 3

a-b 4

a-ea 4

a-b 5

a-ea 5

a-b 7

b-sc 1
Front RH wiring harness to

Intake air heater sub wiring harness 1
a-c 1

c-sd 1
Front LH wiring harness to

Headlight sub wiring harness 1
a-c 2

c-sd 2

a-c 3

c-se 1

Cab tilt sub wiring harness 1
a-c 5

P_EL02_001.fm
192
EL02192
ELECTRIC WIRE
EG-2 [ENGINE (2 of 3)] (Models: FS for Australia, New Zealand)
ia-ib 1
ia2
ia3
ea-ib1
ia4
ia5
b48
ia6
c48
ia7
b49
c47
c8
b47
b52
b35
c37
ba1
c201
c25
c24
b-c 2
b-c 1
b52
b35
b104
b104
MODEL: AUSTRALIA
SHTS12Z160200175
P_EL02_001.fm
193
ELECTRIC WIRE
EL02193

No.
Name
Circuit
No.
Name
Circuit
b35
Speed sensor
BB
c47
BB
b47
GB
c48
FI
b48
GB
c201
J/C Earth G2-a
b49
Starter (Terminal C)
AI
ba1
Starter (Terminal B)
AI
b52
CH
ia2
Fuel injector No.1
FB
b104
Neural switch
AI
ia3
Fuel injector No.2
FB
c8
Cab tilt buzzer
IB, ID
ia4
Fuel injector No.3
FB
c24
GB
ia5
Fuel injector No.4
FB
c25
GB
ia6
Fuel injector No.5
FB
c37
FE
ia7
Fuel injector No.6
FB
AD, AF, ID

No.
Name
No.
Name
b-c 1

ea-ib 1
Engine wiring harness to

Link-up connector 1
b-c 2

ia-ib 1
Injector sub wiring harness to

Link-up connector 1
P_EL02_001.fm
194
EL02194
ELECTRIC WIRE
EG-3 [ENGINE (2 of 3)] (Model: FS for Hong Kong)
ia-ib 1
ia2
ia3
ea-ib1
ia4
ia5
b48
ia6
c48
ia7
b49
c47
c8
c38
b47
c37
ba1
c201
b28
c25
b29
b32
b35
c24
b31
b36
b-c 2
b98
b-c 1
SHTS12Z160200176
P_EL02_001.fm
195
ELECTRIC WIRE
EL02195

No.
Name
Circuit
No.
Name
Circuit
AH
c37
FE
b28
Neutral switch
b29
IA, IC
c38
IE
b31
P.T.O. position switch
IE
c47
BB
b32
Transmission PCS
(Power cut system) switch No.1
FJ
c48
FI
b35
Speed sensor
BB
c201
J/C Earth G2-a
b36
CI
ba1
AH
b47
GA
ia2
Fuel injector No.1
FB
b48
GA
ia3
Fuel injector No.2
FB
b49
AH
ia4
Fuel injector No.3
FB
b98
Transmission PCS
FJ
ia5
Fuel injector No.4
FB
AC, AF,
IC
c8
Cab tilt buzzer
IA, IC
ia6
Fuel injector No.5
FB
c24
GA
ia7
Fuel injector No.6
FB
c25
GA

No.
Name
No.
Name
b-c 1

ea-ib 1

Link-up connector 1
b-c 2

ia-ib 1

Link-up connector 1
P_EL02_001.fm
196
EL02196
ELECTRIC WIRE
EG-4 [ENGINE (2 of 3)] (Model: FS for Ireland)

ia2
ea-ib 1
ia3
ia-ic 1
ia4
c48
ia5
ba1
ia6
ia7
b48
b49
b47
sa3
c47
sa5
c-sa 2
c8
sa-sb 1
c37
c38
c24
c25
sa4
c201
sa7
c45
b-c 1
c46
b-c 2
sb2
SHTS12Z160200177
P_EL02_001.fm
197
ELECTRIC WIRE
EL02197

No.
Name
Circuit
No.
Name
Circuit
b47
GA
ba1
AI
b48
GA
ia2
Fuel injector No.1
FB
b49
AI
ia3
Fuel injector No.2
FB
IB, ID
ia4
Fuel injector No.3
FB
ia5
Fuel injector No.4
FB
c8
Cab tilt buzzer
c24
GA
c25
GA
ia6
Fuel injector No.5
FB
c37
FE
ia7
Fuel injector No.6
FB
c38
IE
sa3
Neutral switch
AI
c45
ZF clutch magnetic valve
HA
sa4
Speed sensor
BB, BF
c46
HA
sa5
CI
c47
BB
sa7
ZF range Hi switch
HA
c48
FI
sb2
IE
c201
J/C Earth G2-a
AD, AF,
ID

No.
Name
No.
Name
b-c 1

c-sa 2

ZF transmission sub wiring harness 2
b-c 2

ea-ib 1

Link-up connector 1
ia-ic 1
Injector LH wiring harness to

Cab tilt short circuit connector 1
sa-sb 1
ZF transmission sub wiring harness to

ZF transmission P.T.O. sub wiring harness 1
P_EL02_001.fm
198
EL02198
ELECTRIC WIRE
EG-5 [ENGINE (3 of 3)] (Models: FS for Australia, Hong Kong, Ireland, New Zealand)
MODEL: AUSTRALIA
b73
bb1
bc1
b72
bc2
bd1
b76
b71
b75
b79
b78
b81
b74
bd2
b80
b87
b201
b202
b57
b75
b71
bb1
bc1
b201
bc2
b202
bd1
b76
b72
bd2
b73
b81
b91
b79
c129
b78
c138
c-d 1
c-e 1
1
2
b74
b87
c50
c51
b80
1: (Dark gray)
2: (Black)
c67
c68
c69
c65
c66
c-e 3
c-e 9
b67
b66
b64
c-e 10
1: Hong kong, Ireland

2: Australia, New Zealand
ba2
bb2
b70
b68
b69
DETAIL OF
b60
PART
b61
b62
b88
b63
SHTS12Z160200178
P_EL02_001.fm
199
ELECTRIC WIRE
EL02199

No.
Name
Circuit
No.
Name
Circuit
b57
Air dryer
IM
b87
Earth power and light No.4
AD, AF
b60
FL block 1
AA
b88
FL block 5
AA
b61
FL block 2
AA
b91
GD
b62
FL block 3
AA
b201
J/C Earth
AD, AF,
AG
b63
FL block 4
AA
b202
J/C Earth G2
AD, AF
AA
c50

(Hong Kong, Ireland)
AH, AI
c51

(Australia, New Zealand)
BB
AJ
c65
P/TAIL CHASSIS
AL
AH, AI
c66
P/ACC CHASSIS
AL
AJ
c67
AL
c68
AL
c69
AL
c129

(Inter-axle)
IK
BB
c138

(Rear-rear axle)
IL
Low pressure switch No.4
BB
ba2
Battery relay (Terminal LD)
AA
b75
BB
bb1
AA
b76
BB
bb2
Battery relay (Terminal B)
AA
b78
Battery ground (Wiring harness)
AG
bc1
AA
b79
AD, AF
bc2
AA
b80
AD, AF
bd1
AA
b81
AD, AF
bd2
Battery ground (Battery cable)
AA
b64
FL 11
b66
Starter relay (Terminal C)
b67
Intake air heater relay (Terminal F)
b68
Starter relay (Coil)
b69
Intake air heater relay (Coil)
b70
Battery relay (Coil)
AA
b71
BB
b72
BB
b73
b74

No.
Name
No.
Name
c-d 1

c-e 9

Rear wiring harness 9
c-e 1

c-e 10

c-e 3

BB
P_EL02_001.fm
200
EL02200
ELECTRIC WIRE
EG-6 [ENGINE (1 of 3)] (Models: FR, FS for Taiwan)

1: Manual cab tilt
a-b 1
a-b 2
a-b 3
a-b 4
a-b 5
a-b 6
a-b 7
a-c 1
a-c 2
a-c 3
a-ea 1
a-ea 2
a-ea 3
a-ea 4
a-ea 5
ea20
p1
sd5
c6
c7
p2
ea8
c-se 1
b44
sd4
1
c10
q1
ea19
ea6
ea1
se2
se3
ea3
se5
se4
c-sd 1
ea5
c17
ea2
ea17
ea18
ea9
c-sd 2
ea21
ea7
ea10
ea12
ea4
ea13
ea14
ea11
ea15
sd1
sd2
c19
c20
ea16
c18
SHTS12Z160200179
P_EL02_001.fm
201
ELECTRIC WIRE
EL02201

No.
b44
Name
Circuit
No.
Name
Circuit
AK
ea10
EA
c6
IA, IC
ea11
FB
c7
IA, IC
ea12
FB
c10

IA
ea13
FB
c17
Cornering light RH
CD, CE
ea14
FB
c18
Cornering light LH
CD, CE
ea15
FB
c19
Horn (Hi)
DC
ea16
FB
c20
Horn (Lo)
DC
ea17
BB
p1
Bonding earth (Cab)
ea18
FC
p2
ea19
FB
q1
IA
ea20
AK
ea1
EGR control
FC
ea21
BH
ea2
VNT ECU
sd1
Headlight LH
CA
ea3
J/C Engine CAN
FC
sd2
CB
ea4
VNT control
FC
sd4
Headlight RH
CA
ea5
Earth shield cable
FB
sd5
CB
ea6
FC
se2
Cab tilt relay
IC
ea7
BG
se3
IC
ea8
Air flow sensor
FC
se4
Cab tilt motor
IC
ea9
FB
se5
Cab tilt switch
IC

No.
Name
No.
Name
a-b 1

a-c 3

a-b 2

a-ea 1

a-b 3

a-ea 2

a-b 4

a-ea 3

a-b 5

a-ea 4

a-b 6

a-ea 5

a-b 7

c-sd 1

a-c 1

c-sd 2

a-c 2

c-se 1

P_EL02_001.fm
202
EL02202
ELECTRIC WIRE
ia-ib 1
1: MZ12 transmisson
2: HX07 transmission
ia2
ea-ib 1
ia3
ia4
b48
ia5
c48
ia6
b49
ia7
b29
c47
b47
b28
b98
c8
ba1
b37
b35
1 b40
c37
c38
c122
2
1
2
1 b36
c49
1
b41
c25
c24
b31
b42
b32
1
2
b100
b101
1 b43
2 b36
b-c 3
SHTS12Z160200180
P_EL02_001.fm
203
ELECTRIC WIRE
EL02203

No.
Name
Circuit
No.
Name
AH
c8
Cab tilt buzzer
Circuit
b28
Neutral switch
b29
IA, IC
c24
GA
b31
IE
c25
GA
b32
Transmission PCS
FJ
c37
FE
b35
Speed sensor (HX07 transmission)
b36
b37
IA, IC
BB
c38
IE
CH, CI
c47
BB
Speed sensor (MZ12 transmission)
BB
c48
FI
b40
HB
c49
Left turn buzzer (For Dump model)
CD
b41
HB
c122
AC
b42
HB
ba1
AH
b43
HB
ia2
Fuel injector No.1
FB
b47
GA
ia3
Fuel injector No.2
FB
b48
GA
ia4
Fuel injector No.3
FB
b49
AH
ia5
Fuel injector No.4
FB
b98
Transmission PCS
FJ
ia6
Fuel injector No.5
FB
b100
MZ12 splitter magnetic valve
HB
ia7
Fuel injector No.6
FB
b101
HB

No.
Name
b-c 3

ea-ib 1
Engine wiring harness to Link-up connector 1
No.
ia-ib 1
Name
Link-up connector 1
P_EL02_001.fm
204
EL02204
ELECTRIC WIRE

b66
b149
ba2
bb2
b143
b70
b68
b147
b60
b64
b61
b150
b202
DETAIL OF
b75
b201
b62
b88
b63
PART
bb1
b71
bc1
b146
bc2
b148
bd1
b144
b142
sh4
b76
b72
b145
b73
c-sh 1
b141
bd2
b91
b81
b79
b-c 1
c139
b-c 2
c-d 1
c-e 1
1
2
b78
c-e 3
b87
b80
c50
c67
c68
c69
c65
c66
sh3
c-d 11
1: Except Dump, Mixer

2: Dump, Mixer
SHTS12Z160200181
P_EL02_001.fm
205
ELECTRIC WIRE
EL02205

No.
Name
Circuit
No.
Name
Circuit
b60
FL block 1
AA
b145
Battery cut relay (Terminal LD)
AC
b61
FL block 2
AA
b146
Battery cut relay

[Terminal B (2.00 B-Y)]
AC
b62
FL block 3
AA
b147
FL bus bar No.2
AA
b63
FL block 4
AA
b148
Battery cut relay

[Terminal B (15.00 W-B)]
AC
b64
FL block 5
AA
b149
FL 17 (15.00 W-B)
AC
b66
AH
b150
FL 17 (15.00 W)
AC
b68
AH
b201
J/C Earth
AD, AF,
AG
b70
AA
b202
J/C Earth G2
AC, AD,
AF
b71
BB
c50
b72
BB
c65
P/TAIL CHASSIS
AL
b73
BB
c66
P/ACC CHASSIS
AL
b75
BB
c67
AL
b76
BB
c68
AL
b78
AG
c69
AL
b79
AD, AF
c139
Right turn buzzer (For Dump model)
CD
b80
AD, AF
ba2
AA
b81
AD, AF
bb1
AA
b87
AD, AF
bb2

(Battery cable)
AA
b88
FL block 5
AA
bc1
AA
b91
GD
bc2
AA
b141
FL 16
AC
bd1
AA
b142
Battery cut relay (Coil)
AC
bd2
AA
b143

(Wiring harness)
AC
sh3
Side turn signal light LH

(For Dump model)
CD
b144
Battery cut relay

[Terminal B (15.00 B)]
AC
sh4
Side turn signal light RH

(For Dump model)
CD

No.
Name
No.
Name
b-c 1

c-e 1

b-c 2

c-e 3

c-d 1

c-sh 1

Side turn signal wiring harness 1
c-d 11

BB
P_EL02_001.fm
206
EL02206
ELECTRIC WIRE
EG-9 [ENGINE (1 of 3)] (Models: FY for Hong Kong, Ireland, New Zealand)
p1
p2
b44
ea19
a-b 1
a-b 2
a-b 3
a-b 4
a-b 5
a-b 6
a-ea 1
a-ea 2
a-ea 3
a-ea 4
a-ea 5
a-b 7
a-c 1
a-c 2
a-c 3
a-c 5
sd4
sd5
ea20
ea1
ea8
ia-ib1
ea-ib1
sc2
c-sd 1
c19
ea5
ea6
c20
c17
ea3
ea18
ea9
c7
ea2
ia3
c6
ea17
ia4
ia5
ea12
ia2
ea21
ea4
ea13
c48
b-sc 1
ea10
c-sd 2
ia6
ea7
ea15
c47
sd1
ea11
ea14
ia7
ea16
c10
sd2
q1
se3
1
c-se1
se2
c8
se4
se5
c38
c37
c18
c201
1: Manual cab tilt
SHTS12Z160200182

No.
b44
Name
Circuit
No.
AK
ea11
Name
Circuit
FB
c6
IA, IB, IC,

ID
ea12
FB
c7
IA, IB, IC,

ID
ea13
FB
c8
Cab tilt buzzer
IA, IB, IC,

ID
ea14
FB
c10

IA, IB
ea15
FB
c17
Cornering light RH
CD
ea16
FB
c18
Cornering light LH
CD
ea17
BB
c19
Horn (Hi)
DC
ea18
FC
c20
Horn (Lo)
DC
ea19
FB
c37
FE
ea20
AK
c38
IE
ea21
BH
c47
BB
ia2
Fuel injector No.1
FB
c48
FI
ia3
Fuel injector No.2
FB
c201
J/C Earth G2-a
AD, AF,
IC, ID
ia4
Fuel injector No.3
FB
p1
Bonding earth (Cab)
ia5
Fuel injector No.4
FB
p2
ia6
Fuel injector No.5
FB
P_EL02_001.fm
207
ELECTRIC WIRE
No.
Name
EL02207
Circuit
No.
Name
Circuit
IA, IB
ia7
Fuel injector No.6
FB
FC
sc2
Intake air heater
AJ
q1
ea1
EGR control
ea2
VNT ECU
sd1
Headlight LH
CA
ea3
J/C Engine CAN
FC
sd2
CB
ea4
VNT control
FC
sd4
Headlight RH
CA
ea5
Earth shield cable
FB
sd5
CB
ea6
FC
se2
Cab tilt relay
IC, ID
ea7
BG
se3
IC, ID
ea8
Air flow sensor
FC
se4
Cab tilt motor
IC, ID
ea9
FB
se5
Cab tilt switch
IC, ID
ea10
EA

No.
Name
No.
Name
a-b 1

a-ea 1

a-b 2

a-ea 2

a-b 3

a-ea 3

a-b 4

a-ea 4

a-b 5

a-ea 5

a-b 6

b-sc 1

a-b 7

c-sd 1

a-c 1

c-sd 2

a-c 2

c-se 1

a-c 3

ea-ib 1

Link-up connector
a-c 5

ia-ib 1

Link-up connector
P_EL02_001.fm
208
EL02208
ELECTRIC WIRE
EG-10 [ENGINE (2 of 3)] (Model: FY for Hong Kong)

b42
b43
b28
b29
b40
b100
b201
b202
b91
c24
b47
b48
ba1
b49
b31
b41
b36
b101
b37
b-c 1
b-c 2
c25
SHTS12Z160200183
P_EL02_001.fm
209
ELECTRIC WIRE
EL02209

No.
Name
Circuit
No.
Name
Circuit
AH
b48
GA
b28
Neutral switch
b29
IA, IC
b49
AH
b31
IE
b91
GD
b36
CI
b100
HB
b37
Speed sensor
BB
b101
HB
b40
HB
b201
J/C Earth
AD, AF,
AG
b41
HB
b202
J/C Earth G2
AD, AF
b42
HB
ba1
AH
b43
HB
c24
GA
b47
GA
c25
GA
No.
Name

No.
Name
b-c 1

b-c 2

P_EL02_001.fm
210
EL02210
ELECTRIC WIRE
EG-11 [ENGINE (2 of 3)] (Model: FY for Ireland)

sa3
sa5
c-sa 2
b202
b201
c24
sa-sb 1
b47
b48
ba1
b49
sa7
sa4
b-c 1
b-c 2
sb2
c25
SHTS12Z160200184
P_EL02_001.fm
211
ELECTRIC WIRE
EL02211

No.
Name
Circuit
No.
Name
Circuit
b47
GA
c25
GA
b48
GA
sa3
Neutral switch
AI
b49
AI
sa4
Speed sensor
BB, BF
b201
J/C Earth
AD, AF,
AG
sa5
CI
b202
J/C Earth G2
AD, AF
sa7
ZF range Hi switch
HA
ba1
AI
sb2
IE
c24
GA

No.
Name
No.
Name
b-c 1

c-sa 2

b-c 2

sa-sb 1

P_EL02_001.fm
212
EL02212
ELECTRIC WIRE
EG-12 [ENGINE (2 of 3)] (Model: FY for New Zealand)
b52
b35
b201
b202
c24
b47
b48
ba1
b49
b104
b-c 1
b-c 2
c25
SHTS12Z160200185
P_EL02_001.fm
213
ELECTRIC WIRE
EL02213

No.
Name
Circuit
No.
Name
Circuit
b35
Speed sensor
BB
b201
J/C Earth
AD, AF,
AG
b47
GB
b202
J/C Earth G2
AD, AF
b48
GB
ba1
AI
b49
AI
c24
GB
b52
CH
c25
GB
b104
Neutral switch
AI
No.
Name

No.
Name
b-c 1

b-c 2

P_EL02_001.fm
214
EL02214
ELECTRIC WIRE
EG-13 [ENGINE (3 of 3)] (Models: FY for Hong Kong, Ireland, New Zealand)
b75
b57
bb1
b71
bc1
bc2
bd1
b76
b72
b73
bd2
b81
b74
b79
c67
c68
c69
c65
c66
c50
c51
c-e 1
c-d 1
1: (Dark gray)
2: (Black)
b78
1
2
b80
b87
c-e 3
c-e 10
c-e 9
b67
b68
ba2
bb2
2: New Zealand
b66
b70
DETAIL OF
b64
b60
b69
b62
b61
b88
b63
PART
SHTS12Z160200186
P_EL02_001.fm
215
ELECTRIC WIRE
EL02215

No.
Name
Circuit
No.
Name
Circuit
b57
Air dryer
IM
b80
AD, AF
b60
FL block 1
AA
b81
AD, AF
b61
FL block 2
AA
b87
AD, AF
b62
FL block 3
AA
b88
FL block 5
AA
b63
FL block 4
AA
c50

(Hong Kong, Ireland)
BB
b64
FL 11
AA
c51

(New Zealand)
BB
b66
AH, AI
c65
P/TAIL CHASSIS
AL
b67
AJ
c66
P/ACC CHASSIS
AL
b68
AH, AI
c67
AL
b69
AJ
c68
AL
b70
AA
c69
AL
b71
BB
ba2
AA
b72
BB
bb1
AA
b73
BB
bb2
AA
b74
BB
bc1
AA
b75
BB
bc2
AA
b76
BB
bd1
AA
b78
AG
bd2
AA
b79
AD, AF

No.
Name
No.
Name
c-d 1

c-e 9

rear wiring harness 9
c-e 1

c-e 10

c-e 3

P_EL02_001.fm
216
EL02216
ELECTRIC WIRE
EG-14 [ENGINE (1 of 3)] (Models: SH, SS for Hong Kong, Ireland)

a-b 1
a-b 2
a-b 3
a-b 4
a-b 5
a-b 6
a-b 7
a-c 1
a-c 2
a-c 3
a-c 5
a-ea 1
a-ea 2
a-ea 3
a-ea 4
a-ea 5
p1
p2
ea19
ea1
b44
ea5
1: Manual cab tilt
c-sd 1
sd4
sc2
ea20
c7
sd5
ea6
c6
ea8
ea3
c17
ea17
b-sc 1
ea2
ea18
ea12
ea4
c19
ea14
b-sc 1
c-sd 2
c20
ea7
ea9
sd1
ea11
ea21
sd1
ea10
c10
c-se 1
1
ea16
q1
ea13
se3
ea15
se2
se5
se4
c18
SHTS12Z160200187
P_EL02_001.fm
217
ELECTRIC WIRE
EL02217

No.
b44
Name
Circuit
No.
Name
Circuit
AK
ea11
FB
c6
IA, IB, IC,

ID
ea12
FB
c7
IA, IB, IC,

ID
ea13
FB
c10

IA, IB
ea14
FB
c17
Cornering light RH
CE
ea15
FB
c18
Cornering light LH
CE
ea16
FB
c19
Horn (Hi)
DC
ea17
BC
c20
Horn (Lo)
DC
ea18
FC
p1
Bonding earth (Cab)
ea19
FB
p2
ea20
AK
q1
IA, IB
ea21
BH
ea1
EGR control
FC
sc2
Intake air heater
AJ
ea2
VNT ECU
sd1
Headlight LH
CA
ea3
J/C Engine CAN
FC
sd2
ea4
VNT control
FC
sd4
Headlight RH
ea5
Earth shield cable
FB
sd5
ea6
FC
se2
Cab tilt relay
IC, ID
ea7
BG
se3
IC, ID
ea8
Air flow sensor
FC
se4
Cab tilt motor
IC, ID
ea9
FB
se5
Cab tilt switch
IC, ID
ea10
EA
CA

No.
Name
No.
CB, CO
Name
a-b 1

a-c 5

a-b 2

a-ea 1

a-b 3

a-ea 2

a-b 4

a-ea 3

a-b 5

a-ea 4

a-b 6

a-ea 5

a-b 7

b-sc 1

a-c 1

c-sd 1

a-c 2

c-sd 2

a-c 3

c-se 1

CB, CO
P_EL02_001.fm
218
EL02218
ELECTRIC WIRE
EG-15 [ENGINE (2 of 3)] (Models: SH, SS for Hong Kong)

c48
ia3
ea-ib 1
c31
ia4
ia-ib 1
c30
ia5
ia2
c32
ia6
c33
ia7
b140
b48
ba1
b49
b47
c47
b42
b28
c8
c37
b29
c38
b100
b101
b37
b35
c201
c25
c24
c600
b74
b43
b31
1: MZ12 transmission
2: HX07 transmission
3: Model : SS
b40
b36
b41
c78
SHTS12Z160200188
2
1
P_EL02_001.fm
219
ELECTRIC WIRE
EL02219

No.
Name
Circuit
No.
Name
Circuit
AH
c25
GC
b28
Neutral switch
b29
IA, IC
c30
Spot light switch
CM
b31
IE
c31
Spot light
CM
b35
Speed sensor (HX07 transmission)
BB
c32
ABS trailer socket
GC
b36
CJ
c33
Trailer socket
GC
b37
Speed sensor (MZ12 transmission)
BD
c37
FE
b40
HB
c38
IE
b41
HB
c47
BD
b42
HB
c48
FI
b43
HB
c78
BD
b47
GC
c201
J/C Earth G2-a
b48
GC
c600
Trailer fuse
GC
b49
AH
ba1
AH
b74

(Model: SS)
BD
ia2
Fuel injector No.1
FB
b100
HB
ia3
Fuel injector No.2
FB
b101
HB
ia4
Fuel injector No.3
FB
b140
CO
ia5
Fuel injector No.4
FB
IA, IC
ia6
Fuel injector No.5
FB
GC
ia7
Fuel injector No.6
FB
c8
Cab tilt buzzer
c24
AD, AF, IC

No.
ea-ib 1
Name
Link-up connector 1
No.
ia-ib 1
Name
Injector wiring harness to
Link-up connector 1
P_EL02_001.fm
220
EL02220
ELECTRIC WIRE
EG-16 [ENGINE (2 of 3)] (Model: SH for Ireland)

ia-ib 1
ia2
ia3
ea-ib 1
ia4
ia5
ia6
ia7
c48
c31
c30
c32
c33
c47
b48
c8
b47
c37
sa-sb 1
b49
ba1
sa5
c38
sa3
c-sa 2
c201
c25
c24
c600
c45
c46
c50
sa7
sb2
sa4
SHTS12Z160200189
P_EL02_001.fm
221
ELECTRIC WIRE
EL02221

No.
Name
Circuit
No.
Name
Circuit
b47
GC
c50
BD
b48
GC
c201
J/C Earth G2-a
b49
AI
c600
Trailer fuse
GC
IB, ID
ba1
AI
GC
ia2
Fuel injector No.1
FB
AD, AF, ID
c8
Cab tilt buzzer
c24
c25
GC
ia3
Fuel injector No.2
FB
c30
Spot light switch
CM
ia4
Fuel injector No.3
FB
c31
Spot light
CM
ia5
Fuel injector No.4
FB
c32
ABS trailer socket
GC
ia6
Fuel injector No.5
FB
c33
Trailer socket
CE
ia7
Fuel injector No.6
FB
c37
FE
sa3
Neutral switch
AI
c38
IE
sa4
Speed sensor
BD, BF
c45
HA
sa5
CK
c46
HA
sa7
ZF range Hi switch
HA
c47
BD
sb2
IE
c48
FI

No.
Name
No.
Name
c-sa 2

ia-ib 1
Injector wiring harness to Link-up connector 1
ea-ib 1
Engine wiring harness to Link-up connector 1
sa-sb 1

P_EL02_001.fm
222
EL02222
ELECTRIC WIRE
EG-17 [ENGINE (3 of 3)] (Models: SH, SS for Hong Kong, Ireland)

b64
b66
b67
b57
b88
b90
b73
ba2
bb2
b70
b68
b60
b69
b61
b62
b63
bb1
bc1
DETAIL OF
PART
b72
bc2
bd1
b76
b71
b75
b79
b78
b74
b81
bd2
b80
b201
b87
b202
b-c 2
b-c 1
c67
c68
c69
c65
c66
sg13
1: Model : SH
sg14
c-sg 1
SHTS12Z160200190
P_EL02_001.fm
223
ELECTRIC WIRE
EL02223

No.
Name
Circuit
No.
Name
Circuit
b57
Air dryer
IM
b87
Earth Power and light No.4
AD, AF
b60
FL block 1
AA
b88
FL block 5
AA
b61
FL block 2
AA
b90
CE
b62
FL block 3
AA
b201
J/C Earth
AD, AF,
AG
J/C Earth G2
AD, AF
b63
FL block 4
AA
b202
b64
FL 11
AA
c65
P/TAIL CHASSIS
AL
b66
AH
c66
P/ACC CHASSIS
AL
b67
AJ
c67
AL
b68
AH
c68
AL
b69
AJ
c69
AL
b70
AA
c78
BD
b71
BD
ba2
AA
b72
BD
bb1
AA
b73
BD
bb2
AA
b74

(Model: SH)
BD
bc1
AA
b75
BD
bc2
AA
b76
BD
bd1
AA
b78
AG
bd2
AA
b79
AD, AF
sg13
Spring brake switch
BD
b80
AD, AF
sg14
Buzzer cancel switch
BD
b81
AD, AF

No.
Name
b-c 1

b-c 2

No.
c-sg 1
Name
Brake valve box sub wiring harness 1
P_EL02_001.fm
224
EL02224
ELECTRIC WIRE
EG-18 [ENGINE (1 of 3)] (Models: SH, SR for Taiwan)
1: Manual cab tilt
a-b 1
a-b 2
a-b 3
a-b 4
a-b 5
a-b 6
a-b 7
a-c 1
a-c 2
a-c 3
a-ea 1
a-ea 2
a-ea 3
a-ea 4
a-ea 5
sd5
c6
c7
1
c10
p1
1
q1
c-se 1
p2
se2
b44
ea19
se3
sd4
ea1
se5
ea8
se4
c17
ea5
ea2
c-sd 1
ea6
ea3
ea17
ea4
ea14
ea9
ea21
ea12
ea18
ea20
ea10
ea11
ea7
c-sd 2
ea15
sd1
ea13
sd2
c19
ea16
c20
c18
SHTS12Z160200191
P_EL02_001.fm
225
ELECTRIC WIRE
EL02225

No.
b44
Name
Circuit
No.
Name
Circuit
AK
ea10
EA
c6
IA, IC
ea11
FB
c7
IA, IC
ea12
FB
c10

IA
ea13
FB
c17
Cornering light RH
CE
ea14
FB
c18
Cornering light LH
CE
ea15
FB
c19
Horn (Hi)
DC
ea16
FB
c20
Horn (Lo)
DC
ea17
BC
p1
Bonding earth (Cab)
ea18
FC
p2
ea19
FB
q1
IA
ea20
AK
ea1
EGR control
FC
ea21
BH
ea2
VNT ECU
sd1
Headlight LH
CA
ea3
J/C Engine CAN
FC
sd2
CB
ea4
VNT control
FC
sd4
Headlight RH
CA
ea5
Earth shield cable
FB
sd5
CB
ea6
FC
se2
Cab tilt relay
IC
ea7
BG
se3
IC
ea8
Air flow sensor
FC
se4
Cab tilt motor
IC
ea9
FB
se5
Cab tilt switch
IC

No.
Name
No.
Name
a-b 1

a-c 3

a-b 2

a-ea 1

a-b 3

a-ea 2

a-b 4

a-ea 3

a-b 5

a-ea 4

a-b 6

a-ea 5

a-b 7

c-sd 1

a-c 1

c-sd 2

a-c 2

c-se 1

P_EL02_001.fm
226
EL02226
ELECTRIC WIRE
c31
ia-ib 1
c30
ea-ib 1
ia2
c33
c32
ia3
ia4
ia5
b48
ia6
b47
ia7
c47
c201
c8
c48
c38
c122
ba1
b49
c25
c600
b28
b100
b43
b42
b29
c24
b31
b36
b101
b37
b40
b41
b-c 3
c50
SHTS12Z160200192
P_EL02_001.fm
227
ELECTRIC WIRE
EL02227

No.
Name
Circuit
No.
Name
Circuit
AH
c31
Spot light
CM
b28
Neutral switch
b29
IA, IC
c32
ABS trailer socket
GC
b31
IE
c33
Trailer socket
CE
b36
CJ
c38
IE
b37
Speed sensor
BD
c47
BD
b40
HB
c48
FI
b41
HB
c50
BD
b42
HB
c122
AC
b43
HB
c201
J/C Earth G2-a
b47
GC
c600
Trailer fuse
GC
b48
GC
ba1
AH
b49
AH
ia2
Fuel injector No.1
FB
b100
HB
ia3
Fuel injector No.2
FB
b101
AD, AF, IC
HB
ia4
Fuel injector No.3
FB
IA, IC
ia5
Fuel injector No.4
FB
GC
ia6
Fuel injector No.5
FB
c25
GC
ia7
Fuel injector No.6
FB
c30
Spot light switch
CM
c8
Cab tilt buzzer
c24

No.
Name
b-c 3

ea-ib 1

Link-up connector 1
No.
ia-ib 1
Name
Link-up connector 1
P_EL02_001.fm
228
EL02228
ELECTRIC WIRE

b66
ba2
bb2
b143
b68
b70
b147
b60
DETAIL OF
b64
b61
b62
b88
b63
PART
b144
b148
b146
b142
b150
b149
bb1
bc1
b141
b90
b145
bc2
bd1
DETAIL OF RELAY BOX

FOR EXPLOSION-PROOF
b76
b79
b73
b81
b78
b75
b72
b71
bd2
b80
b202
b87
b201
b-c 1
b74
RELAY BOX
b-c 2
c90
c67
c68
c69
c65
c66
sg14
c-sg 1
sg13
SHTS12Z160200193
P_EL02_001.fm
229
ELECTRIC WIRE
EL02229

No.
Name
Circuit
No.
Name
Circuit
b60
FL block 1
AA
b144
Battery cut relay

[Terminal B (15.00 B)]
AC
b61
FL block 2
AA
b145
AC
b62
FL block 3
AA
b146
Battery cut relay

[Terminal B (2.00 B-Y)]
AC
b63
FL block 4
AA
b147
FL bus bar No.2
AA
AC
b64
FL 11
AA
b148
Battery cut relay

[Terminal B (15.00 W-B)]
b66
AH
b149
FL 17 (15.00 W-B)
AC
b68
AH
b150
FL 17 (15.00 W)
AC
b70
AA
b201
J/C Earth
AD, AF,
AG
b71
BD
b202
J/C Earth G2
AC, AD,
AF
b72
BD
c65
P/TAIL CHASSIS
AL
b73
BD
c66
P/ACC CHASSIS
AL
b74
BD
c67
AL
b75
BD
c68
AL
b76
BD
c69
AL
b78
AG
c90
Coupler lock switch
IJ
b79
AD, AF
ba2
AA
b80
AD, AF
bb1
AA
b81
AD, AF
bb2
AA
b87
AD, AF
bc1
AA
b88
FL block 5
AA
bc2
AA
b90
CE
bd1
AA
b141
FL 16
AC
bd2
AA
b142
AC
sg13
Spring brake switch
BD
b143

(Wiring harness)
AC
sg14
BD

No.
Name
b-c 1

b-c 2

No.
c-sg 1
Name
P_EL02_001.fm
230
EL02230
ELECTRIC WIRE
RR-1 (REAR) (Model: FR with leaf suspension)

BRAKE VALVE BOX
d-sg 1
sg5
sg7
sg3
DETAIL OF BRAKE VALVE BOX
e8
e10
e9
d-e 1
e2
e7
e6
e12
SHTS12Z160200194

No.
Name
Circuit
No.
Name
Circuit
e2
CD
e10
Back-up light RH
CI
e6
CI
e12
Back-up light LH
CI
e7
Back buzzer
CI
sg3
IK
e8
Rear combination light RH
CD
sg5
Spring brake switch
BB
e9
Earth power and light rear
AD
sg7
BB

No.
d-e 1
Name
Intermediate wiring harness to
No.
d-sg 1
Name
P_EL02_001.fm
231
ELECTRIC WIRE
EL02231
RR-2 (REAR) (Model: FR with air suspension)

d-sg 1
AIR SUSPENSION
VALVE BOX
sg5
sg7
BRAKE VALVE BOX
d21
d36
sg3
sg8
sg4

e8
e10
e9
d16
d-sf 1
sf17
e2
d-e 1
e7
e6
e12
DETAIL OF AIR SUSPENSION VALVE BOX

SHTS12Z160200195

No.
Circuit
No.
GA
e10
d21
GA
e12
Back-up light LH
CI
d36
Height sensor
IG
sf17
IG
e2
CD
sg3
IK
e6
CI
sg4
GA
e7
Back buzzer
CI
sg5
Spring brake switch
BB
e8
CD
sg7
BB
e9
AD
sg8
GA
d16
Name
Name
Back-up light RH
CI

No.
Name
d-e 1

d-sf 1

Air suspension valve box sub wiring harness 1
No.
d-sg 1
Circuit
Name
P_EL02_001.fm
232
EL02232
ELECTRIC WIRE
RR-3 (REAR) (Model: FS except full-tractor)

sg7
sg5
1: Except Cargo truck, Taiwan Dump, Mixer

2: Taiwan Dump, Mixer
3: Ireland
4: Taiwan
5: Cargo truck
sg8
sg4
5
d-sg 1
sg8
sg4
BRAKE VALVE BOX

(CARGO TRUCK)
sg7
sg3
c-d 1
c-e 1

(CARGO TRUCK)
1
2
d21
sg5
sg3
d67

(DUMP, MIXER)
d68
d-sg 1
e-sg 1
1
2
sh3
c-e 3
BRAKE VALVE BOX

(DUMP, MIXER)
e8
e9
e-sh 1
d16
d-e 1
1
e5
e7
e2
e28
MODELS:
TAIWAN CARGO TRUCK,
IRELAND
e6
e12
sh4
e8
e8
MODEL:
HONG KONG
e9
e2
e6
e7
e9
e10
3
e10
e7
e2
e11
e6
e12
e11
SHTS12Z160200196
P_EL02_001.fm
233
ELECTRIC WIRE
EL02233

No.
Name
Circuit
No.
Name
Circuit
d16
GA
e11
CH, CI
d21
GA
e12
Back-up light LH
CH, CI
d67

(For Ireland model)
GA
e28
Dump up switch
IE
d68

(For Ireland model)
GA
sg3
IK
e2
CD
sg4

GA
e5
Rear fog light
CF
sg5
Spring brake switch
BB
e6
CH, CI
sg7
BB
e7
Back buzzer
CH, CI
sg8

GA
e8
CD
sh3
CD
e9
AD
sh4
CD
e10
Back-up light RH
CI

No.
Name
No.
Name
c-d 1

d-sg 1

c-e 1

e-sg 1

c-e 3

e-sh 1
Rear wiring harness to

Side turn signal sub wiring harness 1
d-e 1

P_EL02_001.fm
234
EL02234
ELECTRIC WIRE
RR-4 (REAR) (Model: FS full-tractor)

d-sg 1
sg7
sg5
c-e 1
c-e 3
e-sg 1
e21
c-e 9
c-e 10
e63
e7
e68
BRAKE VALVE BOX
e8
e9
e67
e10
e16
e59
e2
e6
e40
e11
MODEL : NEW ZEALAND

e7
BRAKE VALVE BOX
e8
e9
e63
sg4
sg8
sg7
sg5
sg3
e-sg 1
e10
e59
e2
e6
e40
SHTS12Z160200197
P_EL02_001.fm
235
ELECTRIC WIRE
EL02235

No.
Name
Circuit
No.
Name
Circuit
e2
CD
e59
ABS trailer socket
GB
e6
CH
e63
CD
e7
Back buzzer
CH
e67

(For Australia model)
GB
e8
CD
e68

GB
e9
AD
sg3
IK
e10
Back-up light RH
CH
sg4

(For New Zealand model)
GB
e11
CH
sg5
Spring brake switch
BB
e16

GB
sg7
BB
e21

GB
sg8

GB
e40
Trailer socket
CD

No.
Name
No.
Name
c-e 1

c-e 10

c-e 3

e-sg 1

c-e 9

P_EL02_001.fm
236
EL02236
ELECTRIC WIRE
RR-5 (REAR) (Model: FY)

sg7
sg7

2: New Zealand
sg3
sg5
d-sg 1
e-sg 1
1
2

(HONG KONG, NEW ZEALAND)
sg3
sg5
sg4
BRAKE VALVE BOX
d21
e21
sg8

(IRELAND)
1
2
d68
d67
e7
d16
e16
e8
e9
e63
1
2
d-e 1
e10
e59
e2
e6
e40
e8
e8
e9
MODEL :
IRELAND
MODEL :
HONG KONG
e9
e10
e5
e10
e2
e6
e7
e2
e7
e11
e6
e11
e12
SHTS12Z160200198
P_EL02_001.fm
237
ELECTRIC WIRE
EL02237

No.
Name
Circuit
No.
Name
Circuit
d16

(For Hong Kong, Ireland models)
GA
e12
Back-up light LH
CH
d21

GA
e16

GB
d67

(For Ireland model)
GA
e21

GB
d68

(For Ireland model)
GA
e40
Trailer socket
CD
e2
CD
e59
ABS trailer socket
GB
e5
Rear fog light
CF
e63
CD
e6
CH, CI
sg3
IK
e7
Back buzzer
CH, CI
sg4

GA, GB
e8
CD
sg5
Spring brake switch
BB
e9
AD
sg7
BB
e10
Back-up light RH
CH, CI
sg8

e11
CI

No.
Name
d-e 1

d-sg 1

No.
e-sg 1
Name
Rear wiring harness to
GA, GB
P_EL02_001.fm
238
EL02238
ELECTRIC WIRE
RR-6 (REAR) (Model: SH)

c135
c136
c-sf 2
sf5
c150
c94
c111
c108
c114
c116
c201
c106
c202
c99
c110
c95
c105
c109
c107
c98
SHTS12Z160200199

No.
Name
Circuit
No.
Name
Circuit
c94
Rear endout marker light RH

(For Ireland model)
CG
c111
c95
Rear endout marker light LH

(For Ireland model)
CG
c114
Back buzzer
CJ, CK
c98
GC
c116
AD, AF
c99
GC
c135
GC
c105
CE
c136
GC
c106
Back-up light RH
CJ, CK
c150
CO
c107
CJ, CK
c201
J/C Earth G2-a
AD, AF,
IC, ID
c108
Rear fog light
CF
c202
J/C Earth G2-b
AD, AF
c109
CJ, CK
sf5
c110
Back-up light LH
(For Taiwan model)
CJ

No.
c-sf 2
Name
Air suspension valve box sub wiring harness 2
No.
Name
CE
IF
P_EL02_001.fm
239
ELECTRIC WIRE
EL02239
RR-7 (REAR) (Models: SR, SS)

c129
c136
c135
c202
c98
c99
c114
c111
c116
c106
c110
c107
c109
c105
SHTS12Z160200200

Circuit
No.
c98
No.
Name
GC
c111
Name
Circuit
CE
c99
GC
c114
Back buzzer
CJ
c105
CE
c116
c106
Back-up light RH
CJ
c129
IK
c107
CJ
c135
GC
c109
CJ
c136
GC
c110
Back-up light LH
(For Taiwan model)
CJ
c202
J/C Earth G2-b
AD, AF
AD, AF
P_EL02_001.fm
240
EL02240
ELECTRIC WIRE
RELAY LOCATION
EN12Z1602J100008
NOTICE
There is a case that the following figures are different from that for your vehicle in the devices locations due to the
model or specification.
RIGHT-HAND DRIVE MODEL
TURN SIGNAL
ES START ECU
FLASHER

WIPER RELAY
JUNCTION BLOCK
PULSE ADJUST COMPUTER
INTERFACE ECU
AUTOLEVELING
ECU
HEADLIGHT WASHER CONTROLLER

LOCK AMP
DC/DC
CONVERTER
POWER MIRROR CONTROLLER

DOOR LOCK CONTROLLER
OR KEYLESS ENTRY
CONTROLLER
ABS ECU
WARNING BUZZER
ZF INTARDER
ECU
COMMON RAIL
ECU
WIRE TO WIRE BOX
KEYLESS ENTRY
DIAGNOSIS CONNECTOR (16 pin)
DIAGNOSIS CONNECTOR
(OPTION)
DIAGNOSIS CONNECTOR
(STANDARD)
SHTS12Z160200201
P_EL02_001.fm
241
ELECTRIC WIRE
EL02241
LEFT-HAND DRIVE MODEL

JUNCTION BLOCK
WIPER RELAY
ES START ECU
PULSE ADJUST COMPUTER

TURN SIGNAL
FLASHER
HEADLIGHT WASHER CONTROLLER

LOCK AMP
DC/DC
CONVERTER
ABS ECU
WARNING BUZZER
ZF INTARDER
ECU
COMMON RAIL
ECU
WIRE TO WIRE BOX

DIAGNOSIS CONNECTOR (16 pin)
DIAGNOSIS CONNECTOR
(OPTION)
DIAGNOSIS CONNECTOR
(STANDARD)
SHTS12Z160200202
P_EL02_001.fm
242
EL02242
ELECTRIC WIRE

EN12Z1602J100009
NOTICE
There is a case that the following figures are different from that for your vehicle due to the model or specification.
Stop light relay

85920-2570
CC, CE
RELAY ALIGNMENT
Light
check relay
85920-2660
BA, BC
Rear fog
light relay
85920-2660
CF
Horn relay
85920-2660
DC
Cornering light
relay LH
85920-2650
CC, CE
Cornering light
relay RH
85920-2650
CC, CE
RELAY BLOCK TERMINAL ALIGNMENT
SHTS12Z160200203
P_EL02_001.fm
243
ELECTRIC WIRE
EL02243
RELAY ALIGNMENT
MZ12
Over-run relay
82560-2680
HB
ZF
Range relay
85920-2770
HA
MZ12
Power shift
relay
85920-2770
HB
MZ12
Range relay
85920-2770
HB
1: Ireland
2: Hong Kong
SHTS12Z160200204
P_EL02_001.fm
244
EL02244
ELECTRIC WIRE
RELAY ALIGNMENT
Brake
blending
relay
85920-2650
FE
1
2
SHTS12Z160200205
P_EL02_001.fm
245
ELECTRIC WIRE
EL02245
FUSE ALIGNMENT
Power window
Turn signal light
Horn
Wiper
Alternator
Spare power sauce

(Trailer tail)
ABS
ES Start
Height control
FUSE BLOCK TERMINAL ALIGNMENT
Fuse 62
(20A)
Fuse 7C
2
(10A)
2
Fuse 71
(10A)
Fuse 39 1
(10A)
Fuse 61
2
(15A)
2
Fuse 76
(10A)
1
Fuse 7F
2
(5A)
Fuse 65
1
(15A)
1
Fuse 77
2
(5A)
SHTS12Z160200206
P_EL02_001.fm
246
EL02246
ELECTRIC WIRE
FUSE ALIGNMENT
Battery relay
Air dryer
ABS trailer 1
Chassis main
ES Start
Working light
ABS trailer 2
P.T.O.
Spare power
source (P-M)
Starter switch
ABS
Parking light
Mirror heater
Starter relay
Fuse 14
(5A)
Fuse 47
(10A)
Fuse 94
(10A)
Fuse 93
(15A)
Fuse 9A
(10A)
Fuse 97
2
(10A)
Fuse 96
(20A)
Fuse 95
(5A)
Fuse 49
(15A)
Fuse 91
(15A)
Fuse 92
2
(10A)
Fuse 10
(10A)
Fuse 4B
1
(10A)
1
Fuse 11
2
(10A)
SHTS12Z160200207
P_EL02_001.fm
247
ELECTRIC WIRE
EL02247
RELAY ALIGNMENT
Air
conditioner
condenser
relay
85920-2650
EA
ABS
sub brake
cut relay
85920-2770
FE, GA,
GB, GC
Trailer tail light

relay
85920-2650
AA
Mirror heater
relay
85920-2660
DA
Front fog light

relay
85920-2660
CF
SHTS12Z160200208
P_EL02_001.fm
248
EL02248
ELECTRIC WIRE
Stop light relay

85920-2570
CC, CE
RELAY ALIGNMENT
Horn relay
85920-2660
DC
Cornering light
relay LH
85920-2650
CC, CE
Cornering light
relay RH
85920-2650
CC, CE
Blake blending
relay
85920-2650
FE
SHTS12Z160200209
P_EL02_001.fm
249
ELECTRIC WIRE
EL02249
RELAY ALIGNMENT
MZ12
Power shift
relay
85920-2770
HB
MZ12
Range relay
85920-2770
HB
MZ12
Over-run
relay
85920-2680
HB
SHTS12Z160200210
P_EL02_001.fm
250
EL02250
ELECTRIC WIRE
RELAY ALIGNMENT
SHTS12Z160200211
P_EL02_001.fm
251
ELECTRIC WIRE
EL02251
FUSE ALIGNMENT
Power window
Turn signal light
Horn
Alternator
Wiper
Spare power source

(Trailer tail)
ABS
Height control
ES Start
Fuse 62
(20A)
Fuse 7C
2
(10A)
2
Fuse 71
(10A)
Fuse 39 1
(10A)
Fuse 61
2
(15A)
2
Fuse 76
(10A)
1
Fuse 7F
2
(5A)
Fuse 65
1
(15A)
1
Fuse 77
2
(5A)
SHTS12Z160200212
P_EL02_001.fm
252
EL02252
ELECTRIC WIRE
FUSE ALIGNMENT
Battery relay
Air dryer
ABS trailer 1
Chassis main
ES Start
Working light
ABS trailer 2
P.T.O.
Spare power
source (P-M)
Starter switch
ABS
Parking light
Mirror heater
Starter relay
Transmission
Fuse 14
(5A)
Fuse 47
(10A)
Fuse 94
(10A)
Fuse 93
(15A)
Fuse 9A
(10A)
Fuse 97
2
(10A)
Fuse 96
(20A)
Fuse 95
(5A)
Fuse 49
(15A)
Fuse 91
(15A)
Fuse 92
2
(10A)
Fuse 10
(10A)
Fuse 4B
1
(10A)
Fuse 99
(5A)
1
Fuse 11
2
(10A)
SHTS12Z160200213
P_EL02_001.fm
253
ELECTRIC WIRE
EL02253
RELAY ALIGNMENT
Air
conditioner
condenser
relay
85920-2650
EA
ABS
Mirror
heater
subrelay
brake
cut
relay
(3-76)
85920-2770
85920-2660
FE, GA, GC
Trailer
Trailer
tail
tail
light
relay
relay
(3-11)
85920-2650
85920-2650
AA
Mirror
heater
ABS
subrelay
brake
85920-2660
cut relay
DA
(3-122,
142,145)
85920-2770
Front fog light

relay
85920-2660
CF
SHTS12Z160200214
P_EL02_001.fm
254
EL02254
ELECTRIC WIRE
JUNCTION BLOCK
EN12Z1602J100010
NOTICE
FUSE AND RELAY ALIGNMENT
Spare
Spare
(P-BAT)
Engine ECU
(PCV2)
Engine ECU
(Main)
Spare
Heater
Engine ECU
(PCV1)
Engine ECU
(Actuator)
Meter
Headlight
(Main)
Headlight
(Dimmer)
Tail light
Spare
Spare
Spare
Spare
Engine ECU
Headlight
(Main) RH
Fog light
Spare
(P-Tail)
Stop light
Headlight
(Main) LH
Head light
Cleaner
Cab main
Headlight
(Dimmer) LH
Spare
(ACC)
Headlight
(Dimmer) RH
ACC
Air
conditioner
Actuator
power relay
85920-2660
FA
PCV relay
85920-2660
AA, FA
Tail light
relay No.2
85920-2650
AA, CA
Power
accessery
relay
85920-2650
AA
Headlight
relay
(Dimmer)
85920-2650
AA, CA
Headlight
relay
(Main)
85920-2650
AA, CA
Tail light
Room light
Radio
Tail light
relay No.1
85920-2650
AA, CA
Heater
relay
85920-2650
EA
ECU
Main relay
85920-2660
FA
PCV Diode
Air
conditioner
relay
85920-2650
EA
SHTS12Z160200215
P_EL02_001.fm
255
ELECTRIC WIRE
EL02255

TERMINAL ALIGNMENT
Fuse 75
(5A)
Fuse 52
(15A)
Fuse 74
(5A)
Fuse 51
(20A)
Fuse 72
(10A)
Fuse 19
2
(10A)
1
20A
Fuse 16
2
(15A)
1
Fuse 17
2
(10A)
Fuse 13
(5A)
15A
Fuse 12
1
(5A)
Fuse 15
2
(15A)
1
10A
Fuse 7E
(10A)
Fuse 7H
(15A)
Fuse 7K
(10A)
Fuse 31
(10A)
2
1
Fuse 32
(10A)
1
2
Fuse 34
2
(10A)
1
Fuse 44
(10A)
Fuse 22
2
(10A)
Fuse 21
2
(15A)
Fuse 42
2
(15A)
1
Fuse 41
2
(10A)
2
2
1
Fuse 33
2
(10A)
Fuse 1A
2
(5A)
5A
Fuse 43
(15A)
5
Fuse 73
2
(5A)
Fuse 45
(15A)
1
Fuse 46
(15A)
1
5
3
1 2
2
1
5
3
SHTS12Z160200216
P_EL02_001.fm
256
EL02256
ELECTRIC WIRE
CONNECTOR ALIGNMENT
f501
f500
f502
J/B 2
82560-3750
J/B 1
82560-3740
J/B 3
82560-3690
3
8
9 10 11 12 13
9 10 11 12 13
SHTS12Z160200217
P_EL02_001.fm
257
ELECTRIC WIRE
EL02257
CONNECTOR ALIGNMENT
a503
a504
a505
J/B 28P-A
82560-4640
J/B 28P-B
82560-4630
J/B 28P-C
82560-4620
1
7
a507
9 10
1
5
2
6
3
7
9 10 11 12
J/B 1
82560-3760
1
3
2
4
a612
J/C Earth 13P G2-a
82560-3690
1 2 3
4 5
6 7 8 9 10 11 12 13
a500
a501
a502
J/B 32P-C
82560-4650
J/B 32P-B
82560-4630
J/B 32P-A
82560-4620
9 10 11 12
9 10 11 12
SHTS12Z160200218
P_EL02_001.fm
258
EL02258
ELECTRIC WIRE
WIRE TO WIRE BOX

EN12Z1602J100011
NOTICE
a-b 2
a-ea 5
a-c 3
a-c 5
a-b 1
a-b 3
a808
a814
a801
a810
A7
a-ea 1
a-b 4
a-ea 2
a-c 1
a-b 5
a-b 6
a-ea 3
a-b 7
a-ea 4
a-c 2
a615
a614
a613
a823
a809
SHTS12Z160200219
P_EL02_001.fm
259
ELECTRIC WIRE
EL02259
a-b 1
a-b 2
a-c 3
a-b 3
a-ea 5
a808
a814
a801
a810
A7
a-ea 1
a-b 4
a-b 5
a-c 1
a-ea 2
a-ea 3
a-b 6
a-ea 4
a-b 7
a-c 2
a615
a614
a809
SHTS12Z160200220
P_EL02_001.fm
260
EL02260
ELECTRIC WIRE
ELECTRICAL EQUIPMENT BOX

EN12Z1602J100012
NOTICE
There is a case that this figure is different from that for your vehicle due to the model or specification.
BATTERY RELAY
HEATER RELAY
STARTER RELAY
FUSEBLE LINK BLOCK

FL7
60A
FL1
50A
FL9
60A
FL5
50A
FL6
60A
FL3
50A
FL4
60A
FL12
100A
FL2
50A
FL11
100A
FL10
100A
FL14
30A
SHTS12Z160200221
P_EL02_001.fm
261
ELECTRIC WIRE
EL02261
CONNECTOR INDEX
EN12Z1602J100013
ELECTRICAL EQUIPMENT CONNECTOR

CONNECTOR
No.
PART No.
(COLOR)
a40
82560-4100
ABS ECU (14 pin)
a32
82580-9490
ABS ECU (18 pin)
a33
82580-9480
c24
82560-1340
b47
82560-1340
c25
82560-4720
NAME
CIRCUIT OR AREA
GA, GB, GC
IP-2, 6
GA, GB, GC
IP-1, 5
GA, GB, GC
IP-1, 5
GA, GB, GC
EG-2, 3, 4, 7, 10, 11, 12, 15,
16, 19
GA, GB, GC
EG-2, 3, 4, 7, 10, 11, 12, 15,
16, 19
GA, GB, GC
EG-2, 3, 4, 7, 10, 11, 12, 15,
16, 19
GA, GB, GC
b48
82560-4720
ABS rear modulator LH (Semi-tractor)
c135
82560-1340
ABS rear modulator LH (For Ireland model)
d67
82560-1340
ABS rear modulator LH (For Australia model)
e67
82560-1340
ABS rear modulator LH (For Hong Kong, Taiwan

models) (Except semi-tractor)
sg8
82560-1340
ABS rear modulator RH (Except semi-tractor)
c136
82560-1340
ABS rear modulator RH (For Ireland model)
d68
82560-1340
ABS rear modulator RH (For Australia model)
e68
82560-1340
ABS rear modulator RH (For Hong Kong, Taiwan

models) (Except semi-tractor)
sg4
82560-1340
ABS rear wheel sensor LH (Semi-tractor)
c99
82560-4720
ABS rear wheel sensor LH (Semi-tractor)
d16
82560-4720
ABS rear wheel sensor LH (For Australia, New

Zealand models)
e16
82560-4720
ABS rear wheel sensor RH (Semi-tractor)
c98
82560-4720
EG-2, 3, 4, 7, 10, 11, 12, 15,

16, 19
GC
RR-6, 7
GA
RR-3, 5
GB
RR-4
GA, GB
RR-2, 3, 4, 5
GC
RR-6, 7
GA
RR-3, 5
GB
RR-4
GA
RR-2, 3, 4, 5
GC
RR-6, 7
GA
RR-2, 3, 5
GA
RR-4, 5
GC
RR-6, 7
P_EL02_001.fm
262
EL02262
ELECTRIC WIRE
CONNECTOR
No.
PART No.
(COLOR)
ABS rear wheel sensor RH (Except semi-tractor)
d21
82560-4720
ABS rear wheel sensor RH (For Australia, New

Zealand) (Except semi-tractor)
e21
82560-4720
ABS trailer socket (Semi-tractor)
c32
82580-7550
ABS trailer socket (Full-tractor)
e59
82580-7550
Accelerator sensor
a62
82580-9450
Accelerator switch
a61
82580-8110
ea10
825680-6970
a4
82580-7780
Air conditioner condenser relay
a810
Air conditioner relay
f29
82560-2400
f19
82580-6870
Air dryer
b57
82580-9250
Air flow sensor
ea8
82828-1630
Air suspension controller (Remote control type)
f63
82580-6920
a11
82580-6890
a10
82560-1810
a9
82560-1220
Air suspension height control magnetic valve
sf5
82580-7180
NAME
Actuator power relay
CIRCUIT OR AREA
GA
RR-2, 3, 5
GB
RR-4, 5
FE, GA, GB, GC
GC
EG-15, 16, 19
GB
RR-4, 5
FA
IP-2, 6
FE
IP-2, 6
FA
EA
EG-1, 6, 9, 14, 18
EA
CA-1, 3
EA
EA
IP-1, 5
EA
EA
IP-2, 6
EA
IP-1, 5
IM
EG- 5, 13, 17
FC
EG-1, 6, 9, 14, 18
IG
IP-7
IG
IP-5
IG
IP-5
IG
IP-5
IF
RR-6
P_EL02_001.fm
263
ELECTRIC WIRE
EL02263
CONNECTOR
No.
PART No.
(COLOR)
Air suspension remote control release switch
f87
82560-2900
Air suspension switch (Dump control)
f65
82560-2900
b44
9806-06150
ea20
82580-8640
a71
82560-4080
Autoleveling ECU
a167
82560-2470
Back buzzer (Semi-tractor)
c114
82580-6820
Back buzzer (Except semi-tractor)
e7
82580-6820
Back-up light LH
e12
82580-7660
Back-up light LH
(For left-hand drive model) (Semi-tractor)
c110
82580-7660
Back-up light RH
e10
82580-7660

(Semi-tractor)
c106
82580-7660

(Models with HX and MZ transmission)
b36
82580-6820

(Models with EATON transmission)
b52
82580-7180

(Models with ZF transmission)
sa5
82580-1340
bc1
9008-56107
bd1
9008-56107
bb1
82583-1730
bc2
9008-55112
b142
82580-8100
b145
9806-08150
Battery cut relay [Terminal B (15.00 B)]
b144
9806-08150
NAME
CIRCUIT OR AREA
IG
IP-6
IF
IP-3, 7
AK
EG-1, 6, 9, 14, 18
AK
EG-1, 6, 9, 14, 18
FG
IP-2
CO
IP-1
CJ, CK
RR-6, 7
CH, CI
RR-1, 2, 3, 4, 5
CH
RR-3, 5, 6
CI, CJ
RR-1, 2, 3, 6, 7
CI
RR-1, 2, 3, 5
CJ, CK
RR-6, 7
CH, CI, CJ
EG-3, 7, 10, 15, 19
CH
EG-2, 12
CH, CI, CK
EG-4, 11, 16
AA
EG-5, 8, 13, 17, 20
AA
EG-5, 8, 13, 17, 20
AA
EG-5, 8, 13, 17, 20
AA
EG-5, 8, 13, 17, 20
AC
EG-8, 20
AC
EG-8, 20
AC
EG-8, 20
P_EL02_001.fm
264
EL02264
ELECTRIC WIRE
CONNECTOR
No.
PART No.
(COLOR)
Battery cut relay [Terminal B (15.00 W-B)]
b148
9806-08150
Battery cut relay [Terminal B (2.00 B-Y)]
b146
9806-08020
f98
82560-3010
c122
82580-7580
bd2
82583-1100
b78
9806-08150
b70
82580-8100
Battery relay (Terminal B) (Battery cable)
bb2
82583-1730
Battery relay (Terminal B) (Wiring harness)
b143
9806-08150
ba2
82583-1730
Blower motor
f5
82560-2990
Blower switch
f28
82560-4480
ea9
82580-8980
a814
82560-3800
Brake blending relay
Brake blending resistor
a816
82560-2990
a808
82560-3800
Brake switch
h8
82580-6820
sg7
82580-6820
Buzzer cancel switch (Semi-tractor)
sg14
82580-6820
Cab tilt buzzer
c8
82580-6820
m7
82580-7140
NAME
CIRCUIT OR AREA
AC
EG-8, 20
AC
EG-8, 20
AC
IP-6
AC
EG-7, 19
AA, AG
EG-5, 8, 13, 17, 20
AD, AG
EG-5, 8, 13, 17, 20
AA
EG-5, 8, 13, 17, 20
AA
EG-5, 8, 13, 17, 20
AA
EG-8, 20
AA
EG-5, 8, 13, 17, 20
EA
IP-1, 5
EA
IP-2, 6
FB
EG-1, 6, 9, 14, 18
FE
IP-1, 5
FE
FA
IP-1
CC, CE
IP-1, 5
FA
CA-4
BB
RR-1, 2, 3, 4, 5
BD
EG-17, 20
IA, IB, IC, ID
EG-2, 3, 4, 7, 9, 15, 16, 19
IA, IB, IC, ID
IP-4, 8
P_EL02_001.fm
265
ELECTRIC WIRE
CONNECTOR
No.
PART No.
(COLOR)
Cab tilt motor
se4
82580-7290
b29
82580-7180
se3
82580-7140
Cab tilt relay
se2
82580-9770
q1
82560-2790

c10
82560-2780
c7
82580-6600
c6
82580-6600
Cab tilt switch
se5
82580-7180
Center speaker LH
i5
82580-8610
Center speaker RH
i6
82580-8610
a169
82580-6170
Cigarette lighter (For right-hand drive model)
g6
82580-4610
Cigarette lighter (For left-hand drive model)
f81
82580-4610
h9
82580-6600
a58
82580-7140
a59
82560-3030
Clutch switch
a42
82560-3030
Combination meter (18 pin-L)
a47
82560-2230
Combination meter (22 pin-L)
a48
82560-2470
Combination meter (22 pin-R)
a49
82560-2470
NAME
EL02265
Chill car idle up
CIRCUIT OR AREA
IC, ID
EG-1, 6, 9, 14, 18
IA, IC
EG-3, 7, 10, 15, 19
IC, ID
EG-1, 6, 9, 14, 18
IC, ID
EG-1, 6, 9, 14, 18
IA, IB
EG-1, 6, 9, 14, 18
IA, IB
EG-1, 6, 9, 14, 18
IA,IB,IC,ID
EG-1, 6, 9, 14, 18
IA, IB, IC, ID
EG-1, 6, 9, 14, 18
IC, ID
EG-1, 6, 9, 14, 18
DI
CA-1, 3
DI
CA-1, 3
FJ
IP-1
DD
IP-2
DE
IP-6
GD
CA-4
GD
IP-2, 6
FF, FH
IP-2, 6
FE
IP-2, 6
BA, BC
IP-2, 6
BA, BC
IP-2, 6
BA, BC
IP-2, 6
P_EL02_001.fm
266
EL02266
ELECTRIC WIRE
NAME
Common rail 025 wire to wire (Female)
CONNECTOR
No.
a103
PART No.
(COLOR)
82560-2100
CIRCUIT OR AREA
AH, AI, BA, BC, FA, FC, FE,
GA, GB, GC, GD, HA, HB, IE
IP-2, 6
Common rail 025 wire to wire (Male)
a102
82560-2100
AH, AI, BA, BC, FA, FC, FE,

GA, GB, GC, GD, HA, HB, IE
IP-2, 6
a20
82560-4410
a22
82560-4420
a24
82580-4430
a23
82560-4440
FA, FC
IP-1, 5
FA, FE, FF, FG, FH, FI, FJ
IP-1, 5
FA, FC, FI
IP-1, 5
FA, FC, FD, FE, FF, FG, FH,
FI, FJ
IP-1, 5
a21
82560-4450
ea12
82580-6630
c47
82580-7180
ea19
82580-8760
a809
82560-3800
c18
82560-3340
Cornering light relay LH
a514
82660-1120
Cornering light relay RH
a514
82660-1120
Cornering light RH
c17
82560-3340
Coupler lock switch
c90
82560-4730
Courtesy switch LH
m1
82580-6170
Courtesy switch RH
m4
82580-6170
DC/DC converter (12V)
o2
82580-8380
DC/DC converter (Common rail)
a19
82560-3290
FA, FC, FE, FI, FJ

IP-1, 5
FB
EG-1, 6, 9, 14, 18
BB, BD
Cornering light LH
EG-2, 5, 8, 10, 13, 17, 19, 20,

23
FB
EG-1, 6, 9, 14, 18
CA
IP-1, 5
CD, CE
EG-1, 6, 9, 14, 18
CC, CE
CC, CE
CD, CE
EG-1, 6, 9, 14, 18
IJ
EG-20
CL
IP-4, 8
CL
IP-3, 7
AN
IP-2
FC
IP-1, 5
P_EL02_001.fm
267
ELECTRIC WIRE
EL02267
CONNECTOR
No.
PART No.
(COLOR)
f1
82560-3290
a41
82560-4320
Diagnosis option connector
a65
82560-2620
a64
82560-2620
a44
82560-2990
g21
82580-6920
a823
82560-3800
Differential lock magnetic valve (Inter-axle)

(Semi-tractor SS, FS for Australia, New Zealand)
c129
82580-9250
Differential lock magnetic valve (Inter-axle)

(FR, FS, FY for except Australia, New Zealand)
sg3
82560-1340
Differential lock magnetic valve (Rear-rear axle)
c138
82580-9250

g5
82560-3010

f85
82560-3010
Dome light LH (For left-hand drive model)
i10
82580-3360
Dome light RH (For right-hand drive model)
i9
82580-3360
Dump up switch
e28
82580-4240
Dump warning buzzer
a43
82580-6390
Earth AS-1
a105
82583-1680
Earth AS-2
a106
82583-1650
Earth AS-3
a107
82583-1660
Earth audio
f16
82583-1650
Earth DR-1
a66
82583-1680
Earth DR-2
a67
82583-1650
NAME
CIRCUIT OR AREA
CB, CO
IP-1, 5
DJ
IP-2, 6
DK
IP-6
DK
IP-2, 6
IL
IP-2
IL
IP-2
IL
IP-1
IK
EG-5, RR-7
IK
RR-1, 2, 3, 4, 5
IL
EG-5
IK, IL
IP-2
IK
IP-2
CL
CA-3
CL
CA-1
IE
RR-3
IE
IP-2, 6
AD, AE
IP-1, 5
AD, AE
IP-1, 5
AD, AE
IP-1, 5
AE, DI
IP-1, 5
AD, AE
IP-2, 6
AD, AE
IP-2, 6
P_EL02_001.fm
268
EL02268
ELECTRIC WIRE
CONNECTOR
No.
PART No.
(COLOR)
Earth DR-3
a68
82583-1660
b79
9806-08150
b80
9806-08150
b81
9806-08150
b87
9806-08020
e9
9806-08020
Earth power and light rear (Semi-tractor)
c116
9806-06050
Earth shield cable
ea5
9806-08010
f49
82560-4120
ECU main relay
EGR control
ea1
82580-8490
ea18
82580-8760
ea16
82560-1230
ea15
82580-9960
b91
82580-9250
a15
82580-6890
a14
82560-1220
ES start main switch (For right-hand drive model)
g16
82560-1100
ES start main switch (For left-hand drive model)
f84
82560-1100
f40
82580-6920
f50
82580-5600
NAME
Engine stop switch
CIRCUIT OR AREA
AD, AE
IP-2, 6
AD, AF
EG-5, 8, 13, 17, 20
AD, AF
EG-5, 8, 13, 17, 20
AD, AF
EG-5, 8, 13, 17, 20
AD, AF
EG-5, 8, 13, 17, 20
AD
RR-1, 2, 3, 4, 5
AD, AF
RR-6, 7
FB
EG-1, 6, 9, 14, 18
FJ
IP-2, 6
FA
FC
EG-1, 6, 9, 14, 18
FC
EG-1, 6, 9, 14, 18
FB
EG-1, 6, 9, 14, 18
FB
EG-1, 6, 9, 14, 18
FB, FI
GD
EG-5, 8, 10
GD
IP-1, 5
GD
IP-1, 5
GD
IP-2
GD
IP-6
AM
IP-2, 6
FE
IP-2, 6
P_EL02_001.fm
269
ELECTRIC WIRE
CONNECTOR
No.
PART No.
(COLOR)
c37
82580-7180
i7
82580-7330
f60
82560-3010
b75
82560-3190
Front fog light relay
a511
82660-1120
a74
82580-8060

a2
82560-1670

h15
82560-1670

a2
82560-1670

h5
82560-1670

j2
82580-7580

j15
82580-7660

k2
82580-7580

k15
82580-7660
Front speaker (LH)
a8
82580-8610
Front speaker (RH)
a51
82580-8610

h14
82580-7660

a1
82580-7660

a1
82580-7660

h4
82580-7660
ea7
82580-9420

(Except Hong Kong semi tractor, Australia, New
Zealand)
c50
82560-4350
NAME
E
Fluorescent light
EL02269
CIRCUIT OR AREA
FE
EG-2, 3, 4, 7, 9, 15, 16
CL
CA-1, 3
CL
IP-3, 7
BB, BD
EG-5, 8, 13, 17, 20
CF
CF
IP-2, 6
CG
CA-1
CG
CA-4
CG
CA-3
CG
CA-2
CC, CE
CA-4
CC, CE
CA-1
CC, CE
CA-3
CC, CE
CA-2
DI
IP-1, 6
DI
IP-1, 6
CC, CE
CA-4
CC, CE
CA-1
CC, CE
CA-3
CC, CE
CA-2
BG
EG-1, 6, 9, 14, 18
BB, BD
EG-6, 8, 13, 16, 19
P_EL02_001.fm
270
EL02270
ELECTRIC WIRE
CONNECTOR
No.
PART No.
(COLOR)

(Australia, New Zealand)
c51
82560-4350

(Hong Kong semi-tractor)
c78
82560-3340
Fuel injector No.1
ia2
82580-9600
Fuel injector No.2
ia3
82580-9600
Fuel injector No.3
ia4
82580-9600
Fuel injector No.4
ia5
82580-9600
Fuel injector No.5
ia6
82580-9600
Fuel injector No.6
ia7
82580-9600
ea11
82580-7210
sd2
82580-6970
sd5
82580-6970
a73
82560-2290
Headlight LH
sd1
82580-6970
sd4
82580-6970
a100
82560-2540
Headlight short circuit connector (Discharge)
n2
82560-2550
Headlight short circuit connector (Halogen)
n1
82560-2550
a34
80560-2790
sf17
82560-1260
NAME
Headlight RH
Heater relay
CIRCUIT OR AREA
BB, BD
EG-5, 13
BD
EG-15
FB
EG-2, 3, 4, 7, 9, 15, 16, 19
FB
EG-2, 3, 4, 7, 9, 15, 16, 19
FB
EG-2, 3, 4, 7, 9, 15, 16, 19
FB
EG-2, 3, 4, 7, 9, 15, 16, 19
FB
EG-2, 3, 4, 7, 9, 15, 16, 19
FB
EG-2, 3, 4, 7, 9, 15, 16, 19
FB
EG-1, 6, 9, 14, 18
CB, CO
EG-1, 6, 9, 14, 18
CB, CO
EG-1, 6, 9, 14, 18
CB
IP-2, 6
CA
EG-1, 6, 9, 14, 18
AA, CA
AA, CA
CA
EG-1, 6, 9, 14, 18
CA, CO
IP-1, 5
CA
IP-1
CA
IP-1, 5
CN
IP-1
EA
IG
RR-2
P_EL02_001.fm
271
ELECTRIC WIRE
EL02271
CONNECTOR
No.
PART No.
(COLOR)
Height sensor
d36
82560-4740
Hong Kong diode
a805
82560-3800
Horn (Hi)
c19
82580-5680
Horn (Lo)
c20
82580-5680
Horn relay
a514
82660-1120
Horn switch
a56
82580-8110
Idle volume (For right-hand drive model)
a70
82580-8660
Idle volume (For left-hand drive model)
f80
82580-8660
Intake air heater
sc2
98060-6150
b67
98060-6150
b69
82560-2810
Interface ECU
a168
82560-2470
JAKE EGR (Solenoid valve)
82828-1080
JAKE retarder (Solenoid valve)
82828-1080
f43
82580-7210
f79
82580-6870
Left turn buzzer
c49
82580-7140
Leveling valve
h11
82580-6600
e11
82580-6600
License plate light LH (Semi-tractor)
c109
82580-6600
e6
82580-6600
c107
82580-6600
NAME
License plate light RH (Semi-tractor)
CIRCUIT OR AREA
IG
RR-2
CC, CE
IP-2
DC
EG-1, 6, 9, 14, 18
DC
EG-1, 6, 9, 14, 18
DC
DC
IP-2, 6
FA
IP-2
FA
IP-6
AJ
EG-1, 9, 14
AJ
EG-5, 13, 17
AJ
EG-5, 13, 17
CO
IP-1
FC
FE
DF
IP-2
DM
IP-1
CD
EG-7
IH
CA-2, 4
CH, CI
RR-3, 4, 5
CJ, CK
RR-3, 5, 6, 7
CH, CI
RR-1, 2, 3, 4, 5
CJ, CK
RR-6, 7
P_EL02_001.fm
272
EL02272
ELECTRIC WIRE
CONNECTOR
No.
PART No.
(COLOR)
a54
82580-9310
Lock amp
f13
82580-7210
b71
82560-3590
b72
82560-3590
b73
82560-3590
b74
82560-3590
Mirror heater (Back LH) (Except Ireland model)
a7
82560-2650
Mirror heater (Back LH) (For Ireland model)
j14
82560-2660
Mirror heater (Back RH) (Except Ireland model)
h3
82560-2640
Mirror heater (Back RH) (For Ireland model)
k14
82560-2660

a7
82560-2650
Mirror heater (Side under) (For Ireland model)
j14
82560-2660
a511
82660-1120
f69
82580-6060
g17
82580-7210
MZ12 over run relay
a523
82660-1120
b101
82580-8490
MZ12 power shift relay
a523
82660-1120
MZ12 range and splitter change switch
f57
82580-6060
b43
82580-6820
b42
82560-2950
MZ12 range relay
a518
82660-1120
NAME
Mirror heater relay
CIRCUIT OR AREA
CA, CC, CE, FG
IP-2, 6
EA
IP-1, 5
BB, BD
EG-5, 8, 13, 17, 20
BB, BD
EG-5, 8, 13, 17, 20
BB, BD
EG-5, 8, 13, 17, 20
BB, BD
EG-5, 13, 15, 17, 20
DA
CA-1, 3
CI, DA
DA, DB
CA-2, 4
DA, DB
CA-2
DA, DB
CA-1, 3
DA
CA-1
DA
DA
IP-3, 7
FJ
IP-2
HB
HB
EG-7, 10, 15, 19
HB
HB
IP-2, 6
HB
EG-7, 10, 15, 19
HB
EG-7, 10, 15, 19
HB
P_EL02_001.fm
273
ELECTRIC WIRE
CONNECTOR
No.
PART No.
(COLOR)
b40
82560-2950
b100
82580-8350
b41
82580-7180
MZ12 splitter relay
a518
82660-1120
a804
82560-4180
Neutral switch (EATON)
b104
82580-7180
Neutral switch (HX, MZ)
b28
82580-7180
Neutral switch (ZF)
sa3
82560-1340
ea21
82580-6570
ea17
82580-6830
c48
82560-1260
a807
82560-4180
c38
82580-7180
P.T.O. position switch (HX, MZ)
b31
82580-7180
P.T.O. position switch (ZF)
sb2
82560-1340
P/ACC CAB
f34
97840-4050
P/ACC CHASSIS
c66
82580-4240
P/BAT
f32
97840-4050
P/M
f33
97840-4050
P/TAIL CAB
f35
97840-4050
P/TAIL CHASSIS
c65
82580-4240
P12V connector
o1
82580-6920
NAME
EL02273
P.T.O. diode
CIRCUIT OR AREA
HB
EG-7, 10, 15, 19
HB
EG-7, 10, 15, 19
HB
EG-7, 10, 15, 19
HB
HB
IP-2, 6
AI
EG-2, 12
AH
EG-3, 7, 10, 15, 19
AI
EG-4, 11, 16
BH
EG-1, 6, 9, 14, 18
BB, BC
EG-1, 6, 9, 14, 18
FI, HA
EG-2, 3, 4, 7, 9, 15, 16, 19
IE
IP-2, 6
IE
EG-3, 4, 7, 9, 15, 16, 19
IE
EG-2, 7, 10, 15, 19
IE
EG-4, 11, 16
AL
IP-2, 6
AL
EG-5, 8, 13, 17, 20
AL
IP-2, 6
AL
IP-2, 6
AL
IP-2, 6
AL
EG-5, 8, 13, 17, 20
AN
IP-1
P_EL02_001.fm
274
EL02274
ELECTRIC WIRE
CONNECTOR
No.
PART No.
(COLOR)
o3
82580-7210
a122
82560-2900
a123
82560-2890
ea13
82580-8260
ea14
82580-8260
PCV diode
PCV relay
a18
82580-7210
Power accessory relay

j5
82580-7660

k12
82580-7660
f23
82580-6870

k6
82560-3300

j13
82560-3300
f22
82580-6870
Power mirror motor
a5
82580-9420
Power mirror switch
f67
82560-2840

j3
82580-9420

k10
82560-4400

k3
82560-4400

j9
82580-9420

j4
82580-6250
NAME
P24V connector
Pick-up controller
CIRCUIT OR AREA
AN
IP-2
CC, CE
IP-2, 6
CC, CE
IP-2, 6
FB
EG-1, 6, 9, 14, 18
FB
EG-1, 6, 9, 14, 18
FA
AA, FA
CE
IP-1, 5
AA
DM
CA-1
DM
CA-3
DM
IP-2, 6
DF, DM
CA-2
DM
CA-4
DN
IP-1
DN
CA-1
DN
IP-3
DG
CA-1
DH
CA-3
DG
CA-2
DH
CA-4
DG
CA-1
P_EL02_001.fm
275
ELECTRIC WIRE
CONNECTOR
No.
PART No.
(COLOR)

k11
82580-6250

k4
825800-7210

j10
82580-7210
h13
82560-4270
a25
82580-7960
Radio/Audio unit
f24
82580-8810
b76
82560-3190
e2
80580-8350

(Semi-tractor)
c105
80580-8350
e8
80580-8350

(Semi-tractor)
c111
80580-8350
Rear endout marker light LH
c95
82580-7180
Rear endout marker light RH
c94
82580-7180
Rear fog light (Semi-tractor)
c108
82580-6600
Rear fog light (Except semi-tractor)
e5
82580-6600
Rear fog light LH (In case of with 2 pieces)
e13
82580-6600
Rear fog light relay
a514
82660-1120
a76
82560-2560
Remote control mirror LH
h3
82560-2640
Remote control mirror LH (For Ireland model)
j14
82560-2660
Remote control mirror RH
a7
82560-2650
Remote control mirror RH (For Ireland model)
k14
82560-2660
NAME
EL02275
CIRCUIT OR AREA
DH
CA-3
DG
CA-2
DH
CA-4
EA
CA-2, 4
BA, BC
IP-1, 5
DI
IP-2, 6
BB, BD
EG-5, 8, 13, 17, 20
CD
RR-1, 2, 3, 4, 5
CE
RR-6, 7
CD
RR-1, 2, 3, 4, 5
CE
RR-6, 7
CG
RR-6
CG
RR-6
CF
RR-6
CF
RR-3, 5
CF
CF
CF
IP-2
DB
CA-2
DB
CA-1
DB
CA-1
DB
CA-2
P_EL02_001.fm
276
EL02276
ELECTRIC WIRE
CONNECTOR
No.
PART No.
(COLOR)
f64
82580-3870
c139
82580-7140
i2
8280-8100
i8
82580-8100
f800
82560-2030
a801
82560-2030
SERVICE CAB 1
f36
97840-4050
SERVICE CAB 2
f37
97840-4050
SERVICE CAB 3
f38
97840-4050
c67
82580-4240
c68
82580-4240
c69
82580-4240
Shift buzzer
f78
82560-2990

(For Taiwan dump truck)
sh3
82580-6600

(For Taiwan dump truck)
sh4
82580-6600
sa4
82560-1340
b35
82560-3570

(Semi-tractor)
b37
82560-1340
Spot light
c31
82580-6600
Spot light switch
c30
82580-7140
Spring brake switch
sg5
82580-6770
Spring brake switch (Semi-tractor)
sg13
82580-6770
NAME
Right turn buzzer (For Taiwan dump truck)
CIRCUIT OR AREA
DB
IP-3
CD
EG-8
CG
CA-1, 3
CG
CA-1, 3
CL
IP-2, 6
CH, CL
IP-1, 5
AL
IP-2, 6
AL
IP-2, 6
AL
IP-2, 6
AL
EG-5, 8, 13, 17, 20
AL
EG-5, 8, 13, 17, 20
AL
EG-5, 8, 13, 17, 20
HB
IP-1, 6
CD
EG-8
CD
EG-8
BB, BD, BF
EG-4, 11, 16
BB
EG-2, 3, 7, 12, 15
BB, BD
EG-7, 10, 15, 19
CM
EG-15, 16, 19
CM
EG-15, 16, 19
BB
RR-1, 2, 3, 4, 5
BD
EG-17, 20
P_EL02_001.fm
277
ELECTRIC WIRE
NAME
CONNECTOR
No.
EL02277
PART No.
(COLOR)
CIRCUIT OR AREA
AH, AI
ba1
82580-6730
b49
82580-6730
b68
82580-7320
b66
9806-06050
Starter switch
a52
82580-6060
f82
82560-4120
Step light LH (For left-hand drive model)
j1
82580-6600
Step light RH (For right-hand drive model)
k1
82580-6600
Stop light relay
Stop light switch
a60
82560-3030
Tachograph/KIENZLE Tachograph
f31
92580-7000
a511
82660-1120

f75
82580-6820

h17
82580-6820
Trailer pick-up controller
a18
82580-7210
Trailer socket (Full-tractor)
e40
82580-6040
Trailer socket (Semi-tractor)
c33
82580-6040
Trailer stop light switch (Full-tractor)
e63
82560-3610
Trailer stop light switch (Semi-tractor)
b90
82580-7550
Tailer tail light relay (For Tractor)
EG-2, 3, 4, 7, 10, 12, 15, 16,

19
AH, AI
EG-2, 4, 12, 16
AH, AI
EG-5, 8, 13, 17, 20
AH, AI
EG-5, 8, 13, 17, 20
AA
IP-2, 6
FH
IP-6
CL
CA-4
CL
CA-2
CC, CE
CC, CE
IP-2, 6
BE, BF
IP-2, 6
AA, CA
AA, CA
AA
BA, BC
IP-2
BC
CA-4
CC
IP-1
CD
RR-4, 5
CE
EG-15, 16, 19
CD
RR-4
CE
EG-17, 20
P_EL02_001.fm
278
EL02278
ELECTRIC WIRE
CONNECTOR
No.
PART No.
(COLOR)
a157
82580-6870

f51
82580-6870
Transmission PCS (Power cut system) switch

No.1
b32
82560-2950
Transmission PCS (Power cut system) switch

No.2
b98
82560-2950
ea6
82828-1100
Turn signal flasher
a120
82580-6060
b140
82560-4750
c150
82580-9960
VNT control
ea4
82560-3560
Warning buzzer
a45
82580-6390
Washer pump motor
a3
82580-8350
a53
82580-9320
f48
82580-3250
Wiper motor
h10
82580-8350
Wiper relay
a121
82580-5820
c45
82580-9250
c46
82580-9250
ZF range Hi switch
sa7
82560-1340
a513
82660-1120
f57
82580-6060
NAME
ZF range relay
CIRCUIT OR AREA
IE
IP-6
IE
IP-2
FJ
EG-3, 7
FJ
EG-3, 7
FC
EG-1, 6, 9, 14, 18
CC, CE
IP-1, 5
CO
EG-15
CO
RR-6
FC, KA, KB, KC
EG-1, 6, 9, 14, 18
BA, BC
IP-2, 6
CN, DL
CA-1, 3
CC, CE, DL, FE
IP-2, 6
CN
IP-2
DL
CA-2, 4
DL
IP-1, 5
HA
EG-4, 16
HA
EG-4, 16
HA
EG-4, 11, 16
HA
HA
IP-2
P_EL02_001.fm
279
ELECTRIC WIRE
EL02279

CONNECTOR
No.
NAME
PART No.
MALE
FEMALE
CIRCUIT OR AREA
a-b 1

825603640
825603650
AD, AE, AF, AG
a-b 2

825602870
825603670
AD, AE, AF, AG
a-b 3

825603620
825603630
AA, AC
a-b 4

825604500
825604510
AA, AC, AH, AI, AJ, CO, FA, FB, FJ
a-b 5

825604540
825604550
BA, BB, BC,BD, GA, GB, GC, GD, IE, IM
a-b 6

825604540
825604550
HB
a-b 7

825604560
825604570
BA, BB, BC, BD, CE
a-c 1

825602110
825602120
IP-1, 5, EG-1, 6, 9, 14, 18
IP-1, 5, EG-1, 6, 9, 14, 18
IP-1, 5, EG-1, 6, 9, 14, 18
IP-1, 5, EG-1, 6, 9, 14, 18
IP-1, 5, EG-1, 6, 9, 14, 18
IP-1, 5, EG-6, 9, 14, 18
IP-1, 5, EG-1, 6, 9, 14, 18

AC, AH, AI, AL, CA, CB, CH, CI, CJ, CK,
CM, CO, FE, FI, GB, GC, IA, IB, IC, ID, IE,
IF, IG, IH, IK, IL
IP-1, 5, EG-1, 6, 9, 14, 18
AI, AL, BA, BB, BC, BD, CC, CD, CE, CF,
DC, FA, FB, FI, IJ

825602130
825602140
a-c 3

825602150
825602160
GA, GB, GC
a-c 5

825602220
825602230
BA, BB, BC, BD, BF, HA, IE
a-f 1

825604500
825604510
a-f 2

825604540
825604550
a-f 3

825604540
825604550
a-f 4

825604560
825604570
a-f 5

825602460
825602470
a-f 6

825807340
825807210
a-h 1

825602170
825602180
a-c 2
IP-1, 5, EG-1, 6, 9, 14, 18
IP-1, 5, EG-1, 6, 9, 14, 18
IP-1, EG-1, 9, 14
AC, AD, AE, AL, BA, BC, BE, BF, CL, DA,
DD, DE, DN, HB, IK, IL
IP-1, 5
IG
IP-5
DI, EA, FE, HB, IA, IB, IC, ID, IE
IP-1, 5
AD, AE, DF, DM, FA, HA, HB
IP-1, 5
CB, CN, CO, DB, FH, FJ, HB, IE, IF, IK, IL
IP-2, 6
AD, AG, DM, EA, FJ, GD
IP-1, 5
AE, AG, BC, CC, CE, CG, CL, DA, DB, DF,
DG, DH, DL, DM, EA, FA, GD, IH
IP-1, 5, CA-2, 4
P_EL02_001.fm
280
EL02280
CONNECTOR
No.
ELECTRIC WIRE
NAME
PART No.
MALE
FEMALE
CIRCUIT OR AREA
a-i 1

825807340
825807210
AE, CG, CL, DI
a-j 1

825602670
825602680
AE, CC, CE, DA, DG, DM
a-j 2

825606030
825806040
DB
a-k 1

825602670
825602680
AE, CC, CE, DH, DM
a-ea 1

825604520
825604530
BA, BB, BC, BH, EA, FA, FB, FC, FE
a-ea 2

825604540
825604550
FA, FB, FC
a-ea 3

825604540
825604550
FA, FB, FC
a-ea 4

825604560
825604570
AE, AK, BG, FC
a-ea 5

825603270
825603730
FA, FB
b-c 1

825601640
825601650
AD, AG, CH, CI, CJ, IC, ID
b-c 2

825807540
825807550
AD, AF, AG, AH, BD, IA, IC
b-c 3

825601780
825601790
AJ
b-sc 1

825601780
825601790
c-d 1

825601320
825601330
AD, AF, BB, CD, CF, CI, GA
c-d 11

825808480
825808490
IG
c-e 1
Front LH wiring harness to Rear

wiring harness 1
825601320
825601330
BB, CD, CF, CH, GA, GB
c-e 3

wiring harness 3
825602940
825602950
IE, IK, IL
c-e 9

wiring harness 9
825807540
825607550
CD, GB
c-e 10

wiring harness 10
825806980
825606990
GB
c-sa 2
Front LH wiring harness to ZF

transmission sub wiring harness 2
825809030
825809040
c-sc 1

825601780
825601790
IP-1, 5, CA-1, 3
CA-1
CA-1
CA-3
IP-1, 5, EG-1, 6, 9, 14, 18
IP-1, 5, EG-1, 6, 9, 14, 18
IP-1, 5, EG-1, 6, 9, 14, 18
IP-1, 5, EG-1, 6, 9, 14, 18
IP-1, 5, EG-1, 6, 9, 14, 18
EG-2, 3, 4, 8, 10, 11, 12, 17, 20
EG-2, 3, 4, 8, 10, 11, 12, 17, 20
EG-7, 19
AJ
EG-1, 9, 14
EG-5, 8, 13, RR-3
EG-8
EG-5, 8, 13, RR-3, 4
EG-5, 8, 13, RR-3, 4
EG-5, 13, RR-4
EG-5, 13, RR-4

AG, AI, BB, BD, BF, CH, CI, CK, HA, IE
EG-4, 11, 16
AJ
P_EL02_001.fm
281
ELECTRIC WIRE
CONNECTOR
No.
NAME
c-sd 1
EL02281
PART No.
CIRCUIT OR AREA
MALE
FEMALE

825806030
825806040
AF, CA, CO
c-sd 2

825806030
825806040
AF, CA, CB, CO
c-se 1
Front LH wiring harness to Cab

tilt sub wiring harness 1
825602780
825602790
AD, AF, IC, ID
c-sf 2
Front LH wiring harness to Air

suspension valve box sub wiring harness 2
825601250
825601260
c-sg 1

825603530
825603540
c-sh 1
Front LH wiring harness to Side

turn signal wiring harness 1
825808340
825808350
AF, CD
d-e 1

825604380
825604390
AD, AF, CD, CF, CI
d-sf 1

Air suspension valve box sub
wiring harness 1
825603350
825604750
d-sg 1

825603530
825603540
e-sg 1
Rear wiring harness to Brake

valve box sub wiring harness 1
825603530
825603540
BB, IK, IL
e-sh 1
Rear wiring harness to Side

turn signal wiring harness 1
825808340
825808350
AF, CD
f-g 1
Instrument panel wiring harness to Instrument panel switch

wiring harness 1
825602150
825602160
f-m 1
Instrument panel wiring harness to Floor wiring harness 1
825808730
825808740
AE, CL, IA, IB, IC, ID
h-j 1

825602670
825602680
AE, CC, CE, CL, DH
h-j 2

825806030
825806040
DH,DM
h-k 1

825602670
825602680
AE, CC, CE, CL, DA, DF, DG
h-k 2

825806030
825806040
AE, DB, DG, DM
ZF transmission sub wiring harness to ZF transmission P.T.O.

sub wiring harness 1
825807170
825807180
sa-sb 1
EG-1, 6, 9, 14, 18
EG-1, 6, 9, 14, 18
EG-1, 9, 14, 18
AF, IF
RR-6
AF, BD
EG-17, 20, RR-6
EG-8
RR-1, 2, 3, 5
AF, IG
RR-2
BB, GA
RR-1, 2, 3, 5
RR-3, 4, 5
RR-3
DD, FH, FJ, GD, IK
IP-2
IP-3, 7,
CA-4
CA-4
CA-2
CA-2
IE
EG-4, 11, 16
P_EL02_001.fm
282
EL02282
ELECTRIC WIRE
JUNCTION CONNECTOR
CONNECTOR
No.
NAME
PART No.
CIRCUIT OR AREA
a606
J/C ETC 14P
82560-3790
82550-1170
FA, IE
a607
J/C Earth 14P
82560-3790
82550-1180
AD, AE, AG, FG, FH
a608
J/C Earth 14P-G2
82560-3790
82550-1190
AD, AE
a609
J/C Common rail 20P
82560-4770
82550-1300
AH, AI, FA, FC, FE, FF, FH, FI, HA, HB, IE
a612
J/C Earth 13P G2-a
82560-3690
a613
J/C Common rail 13P
82560-3690
82550-1120
FA
a614
J/C ETC 13P-1
82560-3690
82550-1120
BA, BC, CH, CI, CJ, CK, DJ
a615
J/C ETC 13P-2
82560-3690
82550-1120
CA, CC, CE, CF, FA, FE
a619
J/C CAN
82560-4770
82550-1280
BA, BC, FA, IK, IL
b201
J/C Earth
82580-6040
82550-1230
AD, AF, AG
b202
J/C Earth G2
82560-2680
82550-1220
AC, AD, AF
c201
J/C Earth G2-a
82560-2680
82550-1220
AC, AD, AF, IC, ID
c202
J/C Earth G2-b
82560-2680
82550-1220
AD, AF
f604
J/C Earth 14P-G2
82560-3790
82550-1190
AC, AD, AE, DF, FH
ea3
J/C Engine CAN
82580-6040
82550-1230
FC
IP-2, 6
IP-2, 6
IP-2, 6
IP-1, 5
AD, AE
IP-2, 5
IP-1, 5
IP-1, 5
IP-1, 5
IP-1, 5
EG-3, 8, 10, 11, 12, 17, 20
EG-3, 8, 10, 11, 12, 17, 20
EG-2, 3, 4, 9, 15, 16, 19, RR-6
RR-6, 7
IP-2, 6
EG-1, 6, 9, 14, 18
COLOPHON(EWD).fm
Pub. No. S1-YFSE17A EWD 07-3

S1-YFSE17B EWD 07-6
S1-YFSE17C EWD 07-9
COLOPHON(EWD).fm

Hino 700 Series

Uploaded by

Copyright:

Available Formats

Hino 700 Series

Uploaded by

Document Information

Original Description:

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

Hino 700 Series

Uploaded by

Copyright:

Available Formats

FOREWORD(EWD).

INDEX: CHASSIS GROUP

All rights reserved. This manual may not be

Serial number in the circuit diagram

Code of the wire to wire connector

Code for the connector

"a" wiring harness side

Code of the area specifying this connecor

Wiring color code

Second letter: Stripe color

Second letter: Stripe color

Serial number in the circuit diagram

WIRE TO WIRE CONNECTOR

Cab main wiring harness to Front wiring harness 3

IP-1, EG-5, EG-10

Code of the circuit diagram specifying this connecor

Code of the area specifying this connecor

82560-2170, Gray, Male

82560-2180, Gray, Female

Code of the area

EG-26 [ENGINE (3 of 3)] (Model: FM8J for Chile)

Code of the wire to wire connector

ELECTRICAL EQUIPMENT CONNECTOR AND JUNCTION CONNECTOR

Low pressure switch 1

Battery (+) terminal (Battery 2)

Low pressure switch 2

Battery (+) terminal (Battery 1)

Low pressure switch 3

Battery (-) terminal (Battery 2)

Air gauge sensor (Front)

Battery (-) terminal (Battery 1)

Air gauge sensor (Rear)

Exhaust brake magnetic valve

P.T.O. magnetic valve

P.T.O. accelerator sensor

Service power (Tail)

WIRE TO WIRE CONNECTOR

Front wiring harness to

Code of the area specifying this connecor

Internal wire connection

FUSE AND RELAY BLOCK

FUSE AND RELAY BLOCK

Code of the circuit diagram specifying this connecor

ELECTRICAL EQUIPMENT CONNECTOR

ABS diagnosis switch

WIRE TO WIRE CONNECTOR

Cab main wiring harness to

AA, AB, AD, AG, BA, BG, BH, CA, CB,

Code of the area specifying this connecor

POWER SUPPLY CIRCUIT (CONTINUOUS POWER SOURCE)

POWER SUPPLY CIRCUIT (STARTER SWITCH "ON")

BATTERY CUT SWITCH CIRCUIT (FOR TAIWAN EXPLOSION-PROOF MODEL)

EARTH SYSTEM (G2) (CAB SIDE)

EARTH SYSTEM (G2) (CHASSIS)

EARTH SYSTEM (G4-C AND G4-P)

ENGINE STARTING CIRCUIT (MODELS WITH MZ AND HX TRANSMISSION)

ENGINE STARTING CIRCUIT (MODELS WITH ZF AND EATON TRANSMISSION)

ENGINE STARTING ASSIST CIRCUIT

SPARE POWER SOURCE CIRCUIT