Kinetic energy recovery system

Nm (13.3 ftlbs), and the torque at the gearbox connection is correspondingly higher for the change in speed.
The system occupies a volume of 13 litres.[4]
Two minor incidents were reported during testing of various KERS systems in 2008. The rst occurred when
the Red Bull Racing team tested their KERS battery for
the rst time in July: it malfunctioned and caused a re
scare that led to the teams factory being evacuated.[5] The
second was less than a week later when a BMW Sauber
mechanic was given an electric shock when he touched
Christian Klien's KERS-equipped car during a test at the
Jerez circuit.[6]
A Flybrid Systems kinetic energy recovery system.

1.2 FIA

A kinetic energy recovery system (often known simply

as KERS, or kers) is an automotive system for recovering
a moving vehicle's kinetic energy under braking. The
recovered energy is stored in a reservoir (for example a
ywheel or high voltage batteries) for later use under acceleration. Examples include complex high end systems
such as the Zytek, Flybrid,[1] Torotrak[2][3] and Xtrac
used in Formula One racing and simple, easily manufactured and integrated dierential based systems such as the
Cambridge Passenger/Commercial Vehicle Kinetic Energy Recovery System (CPC-KERS).

Formula One has stated that they support responsible solutions to the worlds environmental challenges,[7] and the
FIA allowed the use of 60 kW (82 PS; 80 bhp) KERS
in the regulations for the 2009 Formula One season.[8]
Teams began testing systems in 2008: energy can either
be stored as mechanical energy (as in a ywheel) or as
electrical energy (as in a battery or supercapacitor).[9]

Xtrac and Flybrid are both licensees of Torotraks technologies, which employ a small and sophisticated ancillary gearbox incorporating a continuously variable transmission (CVT). The CPC-KERS is similar as it also
forms part of the driveline assembly. However, the whole
mechanism including the ywheel sits entirely in the vehicles hub (looking like a drum brake). In the CPC-KERS,
a dierential replaces the CVT and transfers torque between the ywheel, drive wheel and road wheel.

1
1.1

Kimi Rikknen took the lead of the 2009 Belgian Grand Prix
with a KERS-aided overtake and subsequently won the race.

With the introduction of KERS in the 2009 season, only

four teams used it at some point in the season: Ferrari,
Renault, BMW and McLaren. Eventually, during the
season, Renault and BMW stopped using the system.
Vodafone McLaren Mercedes became the rst team to
win a F1 GP using a KERS equipped car when Lewis
Hamilton won the Hungarian Grand Prix on July 26,
2009. Their second KERS equipped car nished fth.
At the following race, Lewis Hamilton became the rst
driver to take pole position with a KERS car, his team
mate, Heikki Kovalainen qualifying second. This was
also the rst instance of an all KERS front row. On August 30, 2009, Kimi Rikknen won the Belgian Grand
Prix with his KERS equipped Ferrari. It was the rst
time that KERS contributed directly to a race victory,
with second placed Giancarlo Fisichella claiming Actu-

Use in motor sport

History

The rst of these systems to be revealed was the

Flybrid.[4] This system weighs 24 kg (53 lbs) and has
an energy capacity of 400 kJ after allowing for internal
losses. A maximum power boost of 60 kW (81.6 PS, 80.4
HP) for 6.67 seconds is available. The 240 mm (9.4) diameter ywheel weighs 5.0 kg (11 lbs) and revolves at up
to 64,500 rpm. Maximum torque at the ywheel is 18
1

USE IN MOTOR SPORT

ally, I was quicker than Kimi. He only took me because

of KERS at the beginning.[10]
Although KERS was still legal in F1 in the 2010 season,
all the teams had agreed not to use it.[11] New rules for the
2011 F1 season which raised the minimum weight limit
of the car and driver by 20 kg to 640 kg,[12] along with the
FOTA teams agreeing to the use of KERS devices once
more, meant that KERS returned for the 2011 season.[13]
Use of KERS was still optional as in the 2009 season; and
at the start of the 2011 season three teams elected not to
use it.[14]
WilliamsF1 developed their own ywheel-based KERS
system but decided not to use it in their F1 cars due to
packaging issues, and have instead developed their own
electrical KERS system. However, they set up Williams
Hybrid Power to sell their developments. In 2012 it was
announced that the Audi Le Mans R18 hybrid cars would
use Williams Hybrid Power.[15]
As of 2014, the power capacity of the KERS units will
A KERS ywheel.
increase from 60 kilowatts (80 bhp) to 120 kilowatts (160
bhp). This will be to balance the sports move from 2.4
litre V8 engines to 1.6 litre V6 engines.[16]
the car in the 2009 Le Mans Series season, although it
will not be capable of scoring championship points.[19]

1.3

Working diagram for KERS

The operation process of KERS in Formula One

1.4

Autopart makers

Bosch Motorsport Service is developing a KERS for use

in motor racing. These electricity storage systems for
hybrid and engine functions include a lithium-ion battery with scalable capacity or a ywheel, a four to eight
kilogram electric motor (with a maximum power level
of 60 kW (81 hp)), as well as the KERS controller for
power and battery management. Bosch also oers a range
of electric hybrid systems for commercial and light-duty
applications.[17]

Vodafone McLaren Mercedes began testing of their

KERS in September 2008 at the Jerez test track in preparation for the 2009 F1 season, although at that time it
was not yet known if they would be operating an electrical or mechanical system.[20] In November 2008 it was
announced that Freescale Semiconductor would collaborate with McLaren Electronic Systems to further develop
its KERS for McLaren's Formula One car from 2010 onwards. Both parties believed this collaboration would improve McLarens KERS system and help the system lter
down to road car technology.[21]
Toyota has used a supercapacitor for regeneration on
Supra HV-R hybrid race car that won the Tokachi 24Hour endurance race in July 2007. This Supra became
the rst hybrid car in the history of motorsport to win
such a race.[22]
At the NAIAS 2011, Porsche unveiled a RSR variant
of their Porsche 918 concept car which uses a ywheelbased KERS that sits beside the driver in the passenger
compartment and boosts the dual electric motors driving the front wheels and the 565 BHP V8 gasoline engine
driving the rear to a combined power output of 767 BHP.
This system has many problems including the imbalance
caused to the vehicle due to the ywheel. Porsche is currently developing an electrical storage system.[23]

In 2011, Mazda has announced i-ELOOP, a system

which uses a variable-voltage alternator to convert kinetic
energy to electric power during deceleration. The energy,
Several automakers have been testing KERS systems.[18] stored in a double-layer capacitor, is used to supply power
At the 2008 1000 km of Silverstone, Peugeot Sport un- needed by vehicle electrical systems. When used in conveiled the Peugeot 908 HY, a hybrid electric variant of junction with Mazdas start-stop system, i-Stop, the comthe diesel 908, with KERS. Peugeot plans to campaign pany claims fuel savings of up to 10%.[24]

1.5

Carmakers

3
Bosch and PSA Peugeot Citron have developed a hybrid
system that use hydraulics as a way to transfer energy to
and from a compressed nitrogen tank. An up to 45% reduction in fuel consumption is claimed, corresponding to
2.9l/100 km (81 mpg, 69 g CO2/km) on the NEDC cycle for a compact frame like Peugeot 208. The system is
claimed to be much more aordable than competing electric and ywheel systems and is expected on road cars by
2016.[25]

car ever to compete at the event with a hybrid. The system

consisted of high speed slipping clutches which transfer
torque to and from the vehicle, coupled to a 60,000 RPM
ywheel.

Audi and Toyota both developed LMP1 cars with kinetic energy recovery systems for the 2012 and 2013 24
Hours of Le Mans. The Audi R18 e-tron quattro uses
a ywheel-based system while the Toyota TS030 Hybrid
uses a supercapacitor-based system. When Porsche announced its return to Le Mans in 2014, it also unveiled
an LMP1 car with a kinetic energy recovery system. The
1.6 Motorcycles
Porsche 919 Hybrid uses a battery system, in contrast to
KTM racing boss Harald Bartol revealed that the factory the previous Porsche 911 GT3 R Hybrid that used a yraced with a secret kinetic energy recovery system tted wheel system.
to Tommy Koyama's motorcycle during the 2008 seasonending 125cc Valencian Grand Prix.[26] This was illegal,
so they were later banned from using it in the future. The 2 See also
Lit C-1 electric motorcycle will also use a KERS as a regenerative braking system.[27]
Regenerative brake

1.7

Bicycles

KERS is also possible on a bicycle. The EPA, working with students from the University of Michigan, developed the hydraulic Regenerative Brake Launch Assist
(RBLA)[28]
This has also been demonstrated by mounting a ywheel
on a bike frame and connecting it with a CVT to the back
wheel. By shifting the gear, 20% of the kinetic energy
can be stored in the ywheel, ready to give an acceleration
boost by reshifting the gear.[29]
Experimental Machinist Douglas Goncz connected three
ultracapacitor packs on an electric hub equipped recumbent bicycle in series/parallel with a 4PDT toggle switch
in 2007 and described the resulting MObile Experimental
Physics Educational Demonstrator (MOEPED) and its 19
kJ electric ywheel in a newsgroup posting to the moderated newsgroup sci.physics.research dated 11/9 of that
year titled MOEPED Update and in other newsgroup
threads under the keyword MOEPED. In parallel, the
packs were a regenerative brake; in series, they were a
boost source. The vehicle remained in use so equipped
until 2010. It was surplus disposed in 2013.

1.8

Races

Make Cars Green

3 References
[1] Flybrid Systems LLP (2010-09-10). Flybrid Systems.
Flybrid Systems. Retrieved 2010-09-17.
[2] Torotrak
[3] Torotrak, Xtrac & CVT pdf (PDF). Retrieved 2010-0917.
[4] F1 KERS: Flybrid. Racecar Engineering. 2008-11-18.
Retrieved 2014-06-15.
[5] KERS failure caused Red Bull re scare.
tosport.com. 17 July 2008. Retrieved 2008-07-22.

au-

[6] BMW mechanic escapes KERS scare. autosport.com.

22 July 2008. Retrieved 2008-07-22.
[7] Teams Comment on F1s Environmental Future. FIA.
October 8, 2008. Retrieved 2009-01-14.
[8] 2009 Formula One Technical Regulations (PDF). FIA.
December 22, 2006. Retrieved 2006-12-22.
[9] FIA management (December 22, 2006). 2009 FORMULA ONE TECHNICAL REGULATIONS (PDF).
FIA. Retrieved 2008-07-08.

Automobile Club de l'Ouest, the organizer behind the an- [10] Whyatt, Chris (August 30, 2009). Raikkonen wins exciting Spa duel. BBC. Retrieved 2009-08-30.
nual 24 Hours of Le Mans event and the Le Mans Series
is currently studying specic rules for LMP1 that will [11] Formula 1 - The Ocial F1 Website. Forbe equipped with a kinetic energy recovery system. "[30]
mula1.com. Retrieved 2010-08-14.
Peugeot was the rst manufacturer to unveil a fully functioning LMP1 car in the form of the 908 HY at the 2008 [12] "http://www.formula1.com/news/headlines/2010/12/
11603.html". bbc.co.uk. Retrieved 2010-12-04.
Autosport 1000 km race at Silverstone.[31]
The 2011 24 Hours of Le Mans saw Hope Racing enter [13] Benson, Andrew (23 June 2010). Changes made to F1l.
with a Flybrid Systems mechanical KERS, to be the rst
BBC. Retrieved 23 June 2010.

[14] Team Lotus, Virgin, HRT F1 to Start 2011 Without

KERS. Autoevolution. 2011-01-28. Retrieved 201106-01.
[15] "http://www.autosport.com/news/report.php/id/97739".
autosport.com. Retrieved 2012-02-29.
[16] Formula 1 delays introduction of green engines until
2014. bbc.co.uk. 2011-06-29. Retrieved 2011-06-27.
[17] Bosch Developing Modular KERS Systems for Range of
Motorsport Applications. Green Car Congress. 200811-18. Retrieved 2010-04-27.
[18] http://www.carmondo.de/blog/2008/07/03/
honda-und-bmw-mit-formel-1-hybriden/ (German)
[19] Peugeot Sport Hybrid. Racecar Engineering.
September 2008. Retrieved 2008-09-13.

13

[20] Lawrence Butcher (2008-09-18). F1 KERS; McLaren

on track with KERS | People. Racecar Engineering. Retrieved 2010-08-14.
[21] McLaren to work with Freescale on KERS November 12,
2008
[22] Toyota Hybrid Race Car Wins Tokachi 24-Hour Race;
In-Wheel Motors and Supercapacitors. Green Car
Congress. 2007-07-17. Retrieved 2010-09-17.
[23] 918 RSR: Have Flywheel, Will Race January 10, 2011,
[24] Kurt Ernst. Mazdas regenerative braking system switches
batteries for capacitors. 2011
[25] http://www.greencarcongress.com/2013/01/
psabosch-20130122.html
[26] KTM beats F1 with secret KERS debut! | MotoGP News
| Feb 2009. Crash.Net. 2009-02-04. Retrieved 2010-0814.
[27] C-1. Lit Motors. Retrieved 31 October 2013.
[28] http://www.epa.gov/otaq/technology/research/
research-hhb.htm
[29] Boost Your Bike, Science Friday, 2011-08-12, retrieved
2012-11-23
[30] ACO Technical Regulations 2008 for Prototype LM"P1
and LM"P2 classes, page 3 (PDF). Automobile Club de
l'Ouest (ACO). 20 December 2007. Archived from the
original (PDF) on 2008-06-25. Retrieved 2008-01-20.
[31] Sam Collins (2008-09-13). Peugeot Sport Hybrid | People. Racecar Engineering. Retrieved 2010-08-14.

REFERENCES

Text and image sources, contributors, and licenses

4.1

Text

Kinetic energy recovery system Source: https://en.wikipedia.org/wiki/Kinetic_energy_recovery_system?oldid=663006001 Contributors:

Michael Zimmermann, DGoncz, Bdoserror, Giraedata, Hooperbloob, Anthony Appleyard, BD2412, Rjwilmsi, Musser, Mark83, Chobot,
Grafen, Closedmouth, Back ache, Jdoniach, Chris the speller, Decltype, Twaelti, NaBUru38, Pyrope, Marokwitz, Dougher, JAnDbot,
Harryzilber, Aheyfromhome, Mwarren us, Midgrid, Rod57, Conceptuweasel, DH85868993, Geanixx, Truthanado, Jojalozzo, Latics,
F1fans, Sun Creator, Dthomsen8, Addbot, FstrthnU, AnomieBOT, InfoManiac, Bihco, Hughreid, Junkcops, Billydevil, Fiddle and herman, Cnwilliams, Green Yoshi, Robertiki, RjwilmsiBot, EmausBot, BillyPreset, 67, SporkBot, ClueBot NG, Wasoxygen, Snotbot, Lukeno94, HMSSolent, Bigdon128, Louisrix12, Ksmith9146, BattyBot, Googol30, JamesHaigh, Humanjukeboxmusic, Rainbowben,
Pippara679, TychoDodo and Anonymous: 55

4.2

Images

File:Flybrid_Systems_Kinetic_Energy_Recovery_System.jpg Source:
https://upload.wikimedia.org/wikipedia/commons/8/8e/
Flybrid_Systems_Kinetic_Energy_Recovery_System.jpg License: GFDL Contributors: Photo by user:geni Original artist: Geni
File:KERS_flywheel.jpg Source: https://upload.wikimedia.org/wikipedia/commons/e/e4/KERS_flywheel.jpg License: GFDL Contributors: Photo by User:geni Original artist: Geni
File:Kimi_Raikkonen_2009_Belgium_3.jpg Source: https://upload.wikimedia.org/wikipedia/commons/5/54/Kimi_Raikkonen_2009_
Belgium_3.jpg License: CC BY 2.0 Contributors: Belgian Grand Prix Friday Practice Original artist: Jane Belinda Smith from Peterborough,
Cambridgeshire, England
File:Kinetic_Energy_Recovery_System.gif Source:
https://upload.wikimedia.org/wikipedia/commons/4/45/Kinetic_Energy_
Recovery_System.gif License: CC BY-SA 4.0 Contributors: Own work Original artist: This image has been created during DensityDesign
Integrated Course Final Synthesis Studio at Polytechnic University of Milan, organized by DensityDesign Research Lab. Image is released
under CC-BY-SA licence. Attribution goes to Rodolfo Riva, DensityDesign Research Lab.

4.3

Content license

Creative Commons Attribution-Share Alike 3.0