M-DAC

VERSION HISTORY

M-DAC

Rev

Date

Update Content

V01

July 10, 2012

First Version

CONTENT

1.
2.
3.
4.
5.
6.
7.
8.
9.
10.
M-DAC

Introduction

Specification

2-3

Assembly Sketch

4-5

Schematic Diagram

6-8

Wiring Diagram

Silkscreen of Top/Bottom

10-15

Maintenance Alignment Procedure

16-17

Assembly Parts List

18-19

Electronic Parts List

20-23

Product Version Deviation

24-25

INTRODUCTION

No part of this document may be reproduced or transmitted in any form or by any means,electronic or
mechanical, for any purpose, without the express written permission of International Audio Group
Limited (IAG)
This manual is for the exclusive use of IAG, its approved distributors and approved UK service agents.
No part of this manual shall be transferred to any other party without the express written permission of
IAG.
It is the responsibility of the user to ensure that all the information contained in this manual is current.
Notification for new issues of this manual and minor updates will be given via the IAG web-site or on
request.
This manual has been prepared with the greatest care, it is intended for information only and no liability
shall be accepted for errors or changes to specification.
For further service information, parts lists and updates, please contact our web-site at
www.international audio group.com .
C

2012 International Audio Group Limited. All rights reserved.

1
M-DAC

SPECIFICATION

M-DAC-Specification and Features-P1/2

M-DAC Performance Test

Test condition: AC~253V, COAX: 997Hz Digital Signal,SR: 48kHz
Load: 10 kohms impedance, with Filter NAL setting
Z-out: 20ohms
No.

Test Items

Output Level

THD

S/N

4
5
6
7
8
9
10
12

Gain
Noise Level
DC Offset
Crosstalk
L/R different
Phase
Freq Respond
Idle Current

Condition

Units

997Hz,Digital COAX Input

Vrms
stereo 997Hz output 2V
%
stereo 20kHz output 2V
%
Line output,
dB
Line output, with 22-22kHz BW and A-wtd dB
0dBFS Input (0dBV)
dB
no signal,pre-amp out
dBV
To measure the output DC Voltage
mV
L/R Cross talk,refer to 997Hz
dB
L/R different,un-balance
dB
no reverse
deg
Refer to 997Hz input as 0dBr,+/-0.5dB
Hz
Idle Current,230VAC
mA

XLR
RCA
L
R
L
R
2.21
2.22
4.23
4.22
0.001
0.001
0.001
0.001
0.0002
0.0002
0.0005
0.0005
116
116
108
108
120
120
112
112
7.1
13.2
102.5
102.7
-100.8
-101.4
0.8
0.5
116
116
108
108
0.05
0.01
0
0
20-20k
20-20k
18mA

Digital OUT Test

No.

Test item

Track

1
2
3
4
5
6
7

Output Level
Harmonic Distortion
L/R phase
Digital Output Intensity
Level Linearity
Frequency response
Output impedance

32, 44.1,48,96KHz
(16,24bit)

Sampling Rate

32KHz
44.1KHz
48KHz
96KHz

Units
dBFS
%
deg
Vpp
dBFS
dB
ohm
kHz

Limit
00.05
<0.005
1
>500
0.5dB
751
44.10.01
480.01
960.01

COAX
OPT
L
R
L
R
0
0
0
0
0.00001 0.00001 0.00001 0.00001
0
0
0
0
580
/
-143
-143
-143
-143
0.01
0.01
0.01
0.01
75
44.1KHz
48KHz
96KHz

44.1KHz
48KHz
96KHz

32Bit 84.000MHz 512 Element MultiBit Array DAC

Asynchronous USB supporting 24 Bits / 96kHz with Remote Control of PC / MAC

MediaPlayer via HID support

x2 192KHz 24Bits Coax SPDIF Digital Inputs

x2 96KHz Optical Digital Inputs

High Current, High Linearity RCA Single Ended & XLR True Balanced with fully discrete
JFET CROSS* Class A Output stage's

High Current, High Linearity CROSS* JFET Class A Headphone Amplifier

Triple cascaded Jitter attenuation stages, with triple cascaded Asynchronies Clock
domain isolation all but eliminating the First order effects of Jitter from the external input

2
M-DAC

SPECIFICATION

M-DAC-Specification and Features-P2/2

sources on the Digital to Audio Conversion process
.

Selectable DAC Mode or Digital Pre-Amplifier Mode, allowing direct connection to Power
Amplifiers and Active speakers in Digital only systems

2.7 High contrast OLED display

Bit Perfect Digital Data source analyzer

Intelligent real-time Bit Depth analysis engine Displays the True Bit depth of the Digital
input source

Digital Data Decorrelation Engine Decorrelates the fixed LSB's data pattern within the
Audio data stream when less then 24Bits. Data decorrelation at the DAC substrate level
reduces both Digital and Analogue Second order effects within the DAC at the silicon Die
level

MS Windows LSB Data restoration for Bit Perfect reply corrects Windows' LSB rounding
errors. Allows Bit Perfect Plug and Play with Windows Media Player

ASYNC USB Buffer level display to insure correct functionality and diagnostics of the USB
HOST device in ASYNC Audio streaming mode

Actual or Nominal Sampling Frequency display displays the TRUE input sampling
frequency with 1Hz resolution

Digital level meters in dB with Peak hold

CD / DVD SPDIF subcode embedded Track and Time Display

Advanced De-Jittered Optical and Coax SPDIF Output, with USB to SPDIF output.

Selectable Optical or Coax Clock-Lock interface allowing Jitter Free Clock-Locked

connection with compatible CD transports etc.

Full Remote Control + External Remote / BUS I/O loop

26 Internal regulated supply rails

10 Ultra Low Noise, Low Impedance Discrete Regulators

7 User Selectable Digital Filters Fully Software upgradeable via the USB Port

Master Clock Jitter less then 3pS Short Term - Measured directly at DAC XOut

Organic Ultra Low ESR capacitors, High Tolerance Polypropylene film / Foil capacitors,
Ultra Stable Very Low VCR 0.1% MELF SMD resistors, 4 Layer PCB

External upgradeable Power supply interface for a future upgrade path

* CROSS Current Regulated Output Stage Solution

3
M-DAC

ASSEMBLY SKETCH

M-DAC-Product Exploded Drawing- P 1/1

4
M-DAC

ASSEMBLY SKETCH

M-DAC-Packing Exploded Drawing- P 1/1

5
M-DAC

SCHEMATIC DIAGRAM

M-DAC-Mainboard-P1/1

6
M-DAC

SCHEMATIC DIAGRAM

M-DAC-Frontboard-P2/2

7
M-DAC

SCHEMATIC DIAGRAM

M-DAC-PSU Board-P1/1

8
M-DAC

WIRING DIAGRAM

M-DAC-Wiring Diagram-P1/1

9
M-DAC

SILKSCREEN OF TOP /BOTTOM

M-DAC-Mainboard-Top-Silkscreeen-P1/1

10
M-DAC

SILKSCREEN OF TOP /BOTTOM

M-DAC-Mainboard-SMD-Silkscreeen-P1/1

11
M-DAC

SILKSCREEN OF TOP /BOTTOM

M-DAC-Front Board-Top-Silkscreeen-P1/1

12
M-DAC

SILKSCREEN OF TOP /BOTTOM

M-DAC-Front Board-SMD-Silkscreeen-P1/1

13
M-DAC

SILKSCREEN OF TOP /BOTTOM

M-DAC-PSU Board-Top-Silkscreeen-P1/1

14
M-DAC

SILKSCREEN OF TOP /BOTTOM

M-DAC-Front Board-SMD-Silkscreeen-P1/1

15
M-DAC

MAINTENANCE ALIGNMENT PROCEDURE

M-DAC-Ageing Test Step-P1/2

MDAC Soak Test procedure Rev 0.1
1.

Insure that Mains input voltage is set to +/- 5% of rated input voltage.

2.

Lock to an External SPDIF source Play Music file / source.

3.

Insure Display, Knob and Buttons function correctly.

4.

Confirm R/C function.

5.

Insure audio is replayed correctly (Headphones can be used).

6.

Soak test for > 8Hours.

7.

Insure Display and Buttons function correctly.

8.

Insure audio is replayed correctly (Headphones can be used).

9.

Inspect internals of Unit for Blown Electrolytic capacitors Blown SMD Components etc.

Post Soak test performance verification

1.

Set to COAX1, (Set Digital Generator on AP to 44.1KHz, 24 Bit, Dither, 997Hz, 0dB).

2.

Check Unit is Locked and indicates 44.1kHz Freq. (As indicated on Display).

3.

Check L & R SE Audio Outputs, Level 2.1V RMS (+/- 0.1dB).

4.

Check L & R SE Audio THD, 0.0025% Max (Norm 0.001%).

5.

Set AP to 997Hz -60dB, check L&R SE, SNR >54dB (=>114dB).

6.

Set AP to -120dB 997Hz, Check L&R SE outputs, DC Level <= +/-5mV.

7.

Set Digital Generator on AP to 44.1KHz, 24 Bit, Dither, 997Hz, 0dB.

8.

Check L & R Balanced Audio Outputs, Level 4.2V RMS (+/- 0.1dB).

9.

Check L & R Balanced Audio Outputs THD, 0.001% Max (Norm 0.0006%).

10. Set AP to 997Hz -60dB, check L&R Balanced, SNR >58dB (=>118dB).
11. Set AP to 44.1KHz, 24 Bit, Dither, 997Hz, 0dB.
12. Confirm COAX2, Optical 1&2 function (Locked indicated on display & Audio Signal
output).
13. Confirm USB function, replay Stereo 997Hz 0dB on PC media player, confirm SE Level
2.1V RMS (+/- 0.1dB), Audio THD, 0.0025% Max (Norm 0.001%).
14. Confirm R/C function.

16
M-DAC

MAINTENANCE ALIGNMENT PROCEDURE

M-DAC-Ageing Test Step-P2/2

15. Test Optical and BNC Digital CD Output function (with AP or external DAC), Digital
Output greater then =>500mV Pk-Pk into 75 Ohms.
16. Completion of Post Soak Test performance verification.
Listening Test
1.

Connect to audio System (via RCA's), Lock to external SPDIF or USB Source,
confirm no undue noise function OK.

2.

Test all Digital inputs (Coax1, 2, Optical 1 & 2) and USB (With PC) repeat listening
test.

3.

Confirm Remote function.

4.

Completion of Listening tests.

Shipping Settings
1.

Restore unit to Factory defaults.

2.

End of Shipping settings.

17
M-DAC

ASSEMBLY PARTS LIST

M-DAC-Product Parts List-P1/1

No.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22

P/N
340-1018420000R
243-1009410000R
206-1018420002R
300-1018420001-1R
263-0074020052R
262-0500005010R
226-0330050331R
308-1018420000R
588-3000066037R
231-2000000052R
309-1018420001-1R
534-3002100906R
300-1018420002-1R
524-2023061001R
524-2923091016R
215-1027420001R
205-1018420000R
231-3007005102R
340-1018420001R
500-3050240300AR
215-1027420000R
262-0200013011R

PART NAME
knob
plastic pad
lens
front panel
EVA
dustproof pad
feet pad
metal block
screw
feet
main chassis
screw
back panel
screw
screw
button cap
button bracket
rubber washer
function button
nut
power button
washer

DESCRIPTION
black painted
6*9*6.5MM
85.3*39.3*1.5mm, transparent
silkscreened, light grey(BLACK)
74*2*0.5 (thickness)mmEVAblack
5*50*0.25dustproof
33*5*3 (thickness) mmPORONblack
painted
M3*6
RF11-5I SILICONblack
black anodized
M3*10
silkscreened, light grey(BLACK)
M2*6.5
M3*9.5
silver painted,ABS757#
30*40*4mm,ABS
5*7*1mm
black painted
M3 NI
silver painted,ABS757#
20*13*2.6MMblack

QTY
1
1
1
1
3
6
2
1
19
4
1
10
1
1
8
1
1
4
4
2
1
2

UNIT
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS

18
M-DAC

ASSEMBLY PARTS LIST

M-DAC-Packing Parts List-P1/1

No.
P/N
1 401-1018420000R
2 401-1018420001-1R
3

409-1018420000R

PART NAME
Top Foam
Bottom Foam
Outer Carton

DESCRIPTION
EPE white 455*330*35mm ROHS
EPE white 455*330*90mm ROHS
AUDIOLAB MDAC K=Kinner size:
455*330*127MM

QTY UNIT
1
PCS
1
PCS
1

PCS

19
M-DAC

ELECTRONIC PARTS LIST

M-DAC - Electronic Bom -P1/5

No. LEVEL

P/N

PART NAME

022-1000023405R

Power adaptor

2
3

1
1

032-1018420000R
036-1307015000R

Remote
Battery

055-4324260066R

FFC Cable

088-1018420000R

Main board PCBA

006-1014051123-3R

Electrolytic Capacitor

006-1014060833R

Electrolytic Capacitor

006-1014061143-3R

Electrolytic Capacitor

006-1024080803R

Electrolytic Capacitor

10

006-1024081213R

Electrolytic Capacitor

11

006-2214061133-1R

Electrolytic Capacitor

12

006-3314061123-1R

Electrolytic Capacitor

13

006-3914081223R

Electrolytic Capacitor

14

006-4714061113-1R

Electrolytic Capacitor

15

006-4724123533R

Electrolytic Capacitor

16

DESCRIPTION
QTY
INPUT=AC120V
1
OUTPUT=AC13.8V*2,0.5A,USA Mains Cable
AUDIOLAB MDAC black 180*3
1
1.5V SIZE AAA
2
24pin PH=1MM L=280MM C type 0.1mm
1
black
Main board PCBA
1
100uF/10V 20% D5*11MM PH=2.5MM Lelon
11
RXY series 105
100uF16V 6.3*8 20% 105 Lelon OCRZ
4
series
100uF/25V 20% D6.3*11MM PH=5MM Lelon
5
RXY series
1000uF 4V8*8 20% 105 Lelon OCRZ series
1000uF,6.3V,105DegC,8mmDia,12mmH,3.5m
mPitch,Lelon,20%
220uF/16V 20% D6.3*11MM PH=5MM Lelon
RXY series
330uF/10V 20% D6.3*11MM PH=5MM Lelon
RXY series
390uF 10V 8mm Dia 12mm H 3.5mm Pitch
Lelon OCRZ series
470uF/6.3V 20% D6.3*11MM PH=5MM Lelon
RXY series
4700u/16V 20% Lelon RZD 12.5*35mm 105

UNIT

PCS
PCS
PCS
PCS
PCS

C48.C49.C56.C57.C68.C69.C91.C92.C9
6.C99.C101

PCS

C120.C121.C130.C131

PCS

C75.C77.C79.C81.C83

25

C25.C26.C27.C28.C29.C30.C31.C32.C3
PCS 3.C34.C35.C36.C37.C38.C39.C40.C41.C
42.C63.C64.C65.C66.C67.C87.C88

PCS

C43.C45.C51.C53

PCS

C76.C78.C80.C82

11

C58.C59.C61.C70.C71.C74.C84.C94.C9
PCS
7.C100.C103.

PCS

15
24

35

36

37

050-0400000000R

Transistor Clip

10*6MM TR-1

PCS

38

056-4110000000R

Connector

39

059-8400002331R

Crystal

40
41
42
43
44
45
46

2
2
2
2
2
2
2

271-0180000000R
274-2001900168R
277-0130000000R
323-1117000331R
324-0180130100R
538-3001080301R
604-1018420000R

Plastic Post
Washer
Washer
Crystal Base Insulator
Mica
Screw
Heatsink

10PIN 2.54 Box Header

Crystal 84MHz AT5thOT,+/-30PPM HC-49/U
3P(Centre Ground PIN)
Kangyang PDC-5.5D H=5.5 MM
FR4 1.6 17.5*18MM
TW-136
4.4*10.8*1.0 HC-49 QW- 1
TO-220 18*13MM
M3x8
H40mm x W23mm x D15.5mm

17

18

19

20

21
22
23
24
25
26

2
2
2
2
2
2

27

28
29

2
2

30

31
32
33
34

2
2
2
2

Electrolytic Capacitor

C124.C125.C134.C135.

C44.C46.C47.C50.C52.C54.C55.C60.C6
PCS
2.C72.C73.C85.C86.C89.C90
C104.C105.C106.C107.C108.C109.C110
PCS .C111.C112.C113.C114.C115.C116.C11
7.C118.C119.C126.C127.C128.C129.

56uF/16V 20% D5*11mm 105 Lelon RXY

series
100pF/400V 5% PH=2.5MM 2.5*7*4.6MM
016-1017000001R
Capacitor
WIMA FKP02
016-1021132201QR
Capacitor
FKP2 1000PF/100V 2.5% WIMA PCM5
10NF/100V 2.5% EVOX RIFA
016-1031130001R
Capacitor
(PFR5103J100J13L4)
330pF/400V 5% PH=2.5MM 2.5*7*4.6MM
016-3317000001R
Capacitor
WIMA FKP02
017-1240000000R
IC
L7812CV TO-220 ST
017-1377000000R
IC
MC7805CTG TO-220 ON
017-1378000000R
IC
LM337T1.5A TO-220 NS
017-1380000000R
IC
LM317T(1.5A) TO-220ST
017-7510000000R
IC
L7808 +8v TO220 ST
018-9807912111R
IC
L7912CV TO-220 ST
1K 100ppm/ 10% WI3362NOXOX-PA2020-1022120017R
Potentiometer
B1K
024-1120101011R
Relay
HJR1-2C-12VDC
044-4850000000R
Dual 3.5mm Stereo Jack
Dual Vertical PCB Mount 3.5mm
Combined 16Mbps Optical receiver & Gold
044-4860000000R
RCA + Toslink Combo
plated RCA JACK JSR1583
044-5500000000R
RCA Jack Black
PCB Mount 180Deg Black AEC Connectors
044-5510000000R
RCA Jack Black
PCB Mount 180Deg RED AEC Connectors
044-5520000000R
UBSRA-004
USB, Thur Hole, Gold Plated
044-5550000000R
XLR Jack
PCB Mount 90Deg XLR Jack LX-1601H-3
Combined 16Mbps Optical & Gold plated
044-5690000000R
RCA + Toslink Combo
RCA JACK JSR1583
049-1309223000R
6.35mm Stereo Jack
Vertical PCB Mount 6.35mm Stereo Jack
006-5604051130R

LOCATION

PCS

PCS

C93, C95, C98, C102

PCS

C9.C12.C19..C24

PCS

C3.C4.C5.C6.C15.C16.C20.C21

PCS

C1.C2.C7.C10.C13.C14.C17.C22

PCS

C8.C11.C18.C23

2
5
2
3
1
2

PCS
PCS
PCS
PCS
PCS
PCS

U58.U59
U53.U54.U55.U56.U57
U64.U67
U63.U65.U66
U60
U61.U62

PCS

RV1.RV2.RV3.RV4

3
1

PCS
PCS

RLY2.RLY5.RLY7
CN7

PCS

CN3.CN4

1
1
1
2

PCS
PCS
PCS
PCS

CN8
CN12
CN6
CN11.CN9

PCS

CN5

PCS

PCS

CN13
U53 Support.U54 Support.U55
Support.U56Support.U57 Support.
CN1

PCS

X1

1
1
10
1
10
10
10

PCS
PCS
PCS
PCS
PCS
PCS
PCS

X1a

20
M-DAC

ELECTRONIC PARTS LIST

M-DAC - Electronic Bom -P2/5

No. LEVEL

P/N

PART NAME

QTY

UNIT

PCS

Resistor
Resistor
Resistor

DESCRIPTION
Main board PCBA(SMD components
assembled)
0R 0603 1% 50V
OR 1/8W 1%
1206 0R 1/8W 5%

2
8
2

PCS
PCS
PCS

002-1000011010R

Resistor

10K 1% 0603 50V

29

PCS

002-1000032010R

Resistor

10 1/8W 1% 0805

PCS

53

002-1001021010R

Resistor

RES 100 OHM 1/10W 1% 0603

28

PCS

54
55
56
57

3
3
3
3

002-1001032010R
002-1001033010R
002-1002049010R
002-1003032010R

Resistor
Resistor
Resistor
Resistor

100 1/8W 1% 0805

100R 1% SMD 0603
1K MELF 0204 1% 250V 1/4W
10K 1/8W 1% 0805

4
1
8
6

PCS
PCS
PCS
PCS

58

002-1004021010R

Resistor

RES 100K OHM 1/10W 1% 0603

PCS

59
60
61
62
63
64
65

3
3
3
3
3
3
3

002-1005021010R
002-1100021010R
002-1204032010R
002-1301032010R
002-1500021010R
002-1500032010R
002-1502021010R

Resistor
Resistor
Resistor
Resistor
Resistor
Resistor
Resistor

1
1
4
8
3
1
1

PCS
PCS
PCS
PCS
PCS
PCS
PCS

66

002-1503032010HR

Resistor

PCS

R300.R303

67
68
69
70
71
72
73
74

3
3
3
3
3
3
3
3

002-1801032010R
002-1803071010R
002-2200009010R
002-2200021010R
002-2200032010R
002-2201021010R
002-2201032010R
002-2202021010R

Resistor
Resistor
Resistor
Resistor
Resistor
Resistor
Resistor
Resistor

RES 1M OHM 1/10W 1% 0603

110R, 1%, 0603, 1/10W
0805 120K 1/8W 1% ROHS
130R 1/8W 0805 1%
15R, 1%, 0603, 1/10W
150R 1/8W 1% 0805
RES 1.5K OHM 1/10W 1% 0603
15K 1% 100PPM 0805 1/8W VISHAY
CRCW080515K00FKEA
180 1/8W 1% 0805
18K 0603 1% 1/16W
22R MELF 0204 1% 1/2W
22R 0603 1/10W 1%
22 1/8W 1% 0805
220R 0603 1/10W 1%
220 1/8W 1% 0805
RES 2.2K OHM 1/10W 1% 0603

8
1
8
1
1
1
3
6

PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS

75

002-2203032010R

Resistor

22K 1/8W 1% 0805

10

PCS

76

002-2209049010R

Resistor

220R MELF 0204 1% 1/2W

16

PCS

77
78
79
80
81
82
83
84
85
86
87
88
89

3
3
3
3
3
3
3
3
3
3
3
3
3

002-2261032010R
002-2700061010R
002-2702032010R
002-3092061010R
002-3300011010QR
002-3301032010R
002-3901032010R
002-4700021010R
002-4700059010R
002-4701021010R
002-4701032010R
002-4702021010R
002-4703032010R

Resistor
Resistor
Resistor
Resistor
Resistor
Resistor
Resistor
Resistor
Resistor
Resistor
Resistor
Resistor
Resistor

226R, 1%, 0805, 1/8W

27R, 1%, 0603, 1/10W
2.7K 1/8W 1% 0805
3.09K, 1%, 0603, 1/10W
33R 1/16W 1%
330 1/8W 1% 0805
390 1/8W 1% 0805
47R 0603 1/10W 1%
47R MELF 0204 1% 1/2W
470R 0603 1/10W 1%
470 1/8W 1% 0805
RES 4.7K OHM 1/10W 1% 0603
47K 1/8W 1% 0805

1
4
4
1
1
1
1
3
8
1
4
6
2

PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS

R15.R16.R47.R48.R81.R82.R111.R112
R380
R27.R29.R59.R61.R91.R93.R123.R125.
R408
R304
R376
R299.R302.R355
R315.R321.R324.R325.R331.R387
R10.R22.R42.R53.R74.R86.R106.R117.
R356.R360
R1.R4.R7.R8.R33.R36.R38.R40.R65.R6
8.R71.R72.R97.R100.R103.R104.
R365
R312.R328.R381.R383
R130.R132.R134.R136.
R384
R335
R301
R366
R336.R337.R375
R3.R6.R35.R39.R67.R70.R99.R102
R385
R129.R131.R133.R135
R399.R402.R403.R405.R412.R418
R358.R362
R30.R31.R32.R62.R63.R64.R94.R95.R9
6.R126.R127..R128
R18.R43.R75.R107
R359.R363
R23.R54.R87.R118
R13.R50.R78.R114.R357.R361
R367.R368.R371.R372
R9.R41.R73.R105
RA2
RA1
C300,C478,C486

47

088-1018420001R

Main board PCBA

48
49
50

3
3
3

002-0000011050R
002-0000032010R
002-0000033050R

51

52

LOCATION

R346.R353.
R14.R24.R46.R56.R79.R88.R110.R120
R287.R290
R309.R313.R314.R316.R320.R322.R323
.R329.R330.R332.R338.R340.R344.R36
4.R369.R379.R386
R20.R51.R84.R115
R11.R12.R21.R44.R45.R52.R76.R77.R8
5.R108.R109.R116.R308.R319.R333.R3
39.R341.R345.R348.R349.R350.R351
R19.R55.R83.R119
R406
R2.R5.R34.R37.R66.R69.R98.R101
R137.R138.R288.R289.R291.R292
R307.R310.R311.R317.R318.R326.R327
.R342.R343.
R398
R377
R25.R57.R89.R121
R26.R28.R58.R60.R90.R92.R122.R124
R306.R334.R370
R305
R382

90

002-4709049010R

Resistor

4R7 MELF 0204 1% 250V 1/4W

12

PCS

91
92
93
94
95
96
97
98
99

3
3
3
3
3
3
3
3
3

002-5101032010R
002-5602032010R
002-6800032010R
002-6802032010R
002-7500021010R
002-8200032010R
003-1000080001R
003-2210000005R
007-1000001060R

Resistor
Resistor
Resistor
Resistor
Resistor
Resistor
Resistor
Resistor
Capacitor

510 1/8W 1% 0805

5.6K 1/8W 1% 0805
68R 1/8W 1%
6.8K 1/8W 1% 0805
75R 1/10W 0603 1%
SMD0805 82R 1%
100R 1/16W 1% 0603 8pin
8P 22R 63MW 1206 5% 3.2*1.6MM
10PF/50V NPO 0603K

4
2
4
6
4
4
1
1
3

PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS

100

007-1000061060R

Capacitor

10NF 50V X7R 0603 1/16W 10%

13

PCS

101

007-1000072060R

Capacitor

PCS

C302,C333,C348,C362,C366,C404,C429,
C434,C444,C448,C450,C452,C501
C503,C504

102

007-1000074010R

Capacitor

PCS

C481.C488.C489.

103

007-1001031061R

Capacitor

10nF, 200V, 0805, X7R, 20%

100uF/6.3V 1210 X5R 20%
GRM32ER60J107M MURATA
0603 100P/50V 5% MURATA

PCS

104

007-1001051060R

Capacitor

100NF 0603 10% Murata 25V

138

PCS

C467.C512.C535
C140C152,C299,C309,C310,C328,C329,C330,
C335-C341,C343,C344,C345,C349C360,C364,C367-C389

21
M-DAC

ELECTRONIC PARTS LIST

M-DAC - Electronic Bom -P3/5

No. LEVEL
P/N
105
3
007-1001052060QR
106
3
007-1002051063R
107

007-1004052060R

Capacitor

100nF 50V 5% 0805

22

PCS

108

007-1005061022R

Capacitor

1U 10V 0306 10% (LWK107B7105KA-T)

17

PCS

109
110
111
112
113

3
3
3
3
3

007-1500001060R
007-2200031061R
007-2206052010R
007-3009061060R
007-4700051060R

Capacitor
Capacitor
Capacitor
Capacitor
Capacitor

15PF/50V NPO 0603K

0603 22P/50V 5% NPO
0805 22U/6.3V X5R 20%
3P 50V 10% 0603 (EZJZ1V500AA)
47PF/50V 0603 5%

1
6
6
3
6

PCS
PCS
PCS
PCS
PCS

114

007-4705051010R

Capacitor

0603 4.7U/6.3V 5% MURATA

33

PCS

115
116
117

3
3
3

007-4708051061R
007-8209051063R
017-0211000000R

Capacitor
Capacitor
IC

2
1
1

PCS
PCS
PCS

118

017-0470000000R

IC

PCS

U22

119
120
121
122

3
3
3
3

017-0480000000R
017-1083000000R
017-1089000000R
017-1091000000R

IC
IC
IC
IC

4.7pF, 50V, 0603, NPO, 5%

8.2pF, 50V, 0603, COG, 5%
74VHC393MTC TSSOP14 Fairchild
WM8805GEDS SSOP-28 Wolfson
Micorelectronics
NC7SZ18P6X SC70-6 Fairchild
TC74VHC595FT TSSOP16 Toshiba
NC7SZ157P6X SC70-6 Fairchild
NE5532D SOIC-8 TI

LOCATION
C297.C298.C532.C533
C306.C307.C511
C284--C296,C390,C391,C394,C395,C396,C454
,C455,C456,C457
C311.C312.C313.C314.C315.C316.C317
.C318.C319.C320.C321.C322.C323.C32
4.C325.C326.C327
C303
C331.C431.C436.C446.C506.C507
C301.C469.C483.C484.C487.C502
ESD1.ESD2.ESD3
C470.C473--C477
C308.C332.C334.C342.C346.C347.C361
.C363.C365.C403.C405.C407.C415.C41
7.C419.C420.C423.C428.C433.
C305.C472
C304
U27

1
1
2
3

PCS
PCS
PCS
PCS

123

017-1092000000R

IC

BC847BS SOT-363 Philips

24

PCS

124

017-1093000000R

IC

BC857BS SOT-363 Philips

20

PCS

125

017-1126000000R

IC

ZHCS400 SOD323 ZETEX

PCS

126
127
128
129
130
131
132
133
134
135
136
137

3
3
3
3
3
3
3
3
3
3
3
3

017-1250000000R
017-1251000000R
017-1252000000R
017-1253000000R
017-1254000000R
017-1264000000R
017-1267000000R
017-1292000000R
017-1295000000R
017-1391000000R
017-8160000000R
018-0002222227QR

IC
IC
IC
IC
IC
IC
IC
IC
IC
IC
IC
Transistor

NC7SZ74K8X US8 fairchild

NC7SZ04P5 SC70-5 FAIRCHILD
NC7SZ86P5X SC70-5 FAIRCHILD
NC7WZ04P6X SC70-6 FAIRCHILD
TAS1020B TQFP48 TI
LM339PWRTSSOP14 TI
AT24C64CN-SH-T SO-8 ATMEL
ES9018 QFP 64 ESS Technlogies
LM1117MPX-ADJ SOT-223 N03A NS
STC809S SOT23 STC Micro
NE5534D SO-8 W=3.9MM TI
MMBT2222A NPN SMD SOT-23

7
4
1
1
1
1
1
1
1
1
4
3

PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS

138

018-1080617227R

Transistor

FMMT617 SOT23 15V 3A 625mW ZETEX

PCS

139
140
141
142
143
144
145
146

3
3
3
3
3
3
3
3

018-1400846227R
018-1400856227R
018-1500520227R
018-4302907227AR
018-4500690224R
018-4500790224R
018-7203422227R
018-9800389236R

Transistor
Transistor
Transistor
Transistor
Transistor
Transistor
MOSFET
JFET

7
6
2
2
4
4
1
4

PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS

147

022-1009044385R

SMD Transformer

PCS

T1 T2

148
149
150

3
3
3

027-3383022000R
027-4793022000R
035-1003062051R

1
1
19

PCS
PCS
PCS

L2
L1
L3-L21

151

053-1048410000R

Inductor
Inductor
Inductor
MDAC/QDAC Main
board PCB Rev0.3

BC846 BLT1 SOT-23 PHILIPS

BC856 BLT1 SOT-23
BFR520 SOT23 PHILIPS
MMBT2907ALT1G SOT-23 ON
FZT690B SOT-223 Zetex
FZT790A SOT-223 Zetex
AO3422 Nch SOT-23 Alpha & Omega
LSK389-C-SOIC-8 SOIC-A Linear Systems
ER-9.5 Screened Digital Isolation
Transformer
330nH Wire Wound 0805 5% Inductor
4.7uH Wire Wound 0805 5% Inductor
1000ohm/100MHz 0805 BLM21BD102SN1D
Class 3 PCB 4 Layer FR4 1.6MM 1oZ 211.7 x
206.9mm

U29
U32
U26.U28.
U4.U5.U6
Q2.Q4.Q6.Q8.Q9.Q12.Q18.Q20.Q22.Q2
4.Q26.Q28.Q34.Q36.Q39.Q40.Q41.Q44.
Q50.Q52.Q55.Q56.Q57.Q60
Q3.Q5.Q7.Q10.Q.11.Q19.Q21.Q23.Q25.
Q27.Q35.Q37.Q38.Q42.Q43.Q51.Q53.Q
54.Q58.Q59
D19.D21.D22.D23.D24.D26.D27.D34.D3
5
U7.U8.U9.U15.U17.U19.U24
U11.U12.U13.U25
U10
U2
U31
U21
U23.
U1
U20
U30
U3.U14.U16.U18
Q140.Q141.Q142
Q133.Q134.Q135.Q136.Q137.Q138.Q13
9
Q14.Q29.Q46.Q61.Q145.Q148.Q152
Q13.Q30.Q45.Q62.Q143.Q144
Q131.Q132
Q149.Q153
Q16.Q31.Q48.Q63
Q15.Q32.Q47.Q64
Q158
Q1.Q17.Q33.Q49

PCS

PCS

152

056-8124551194R

PART NAME
Capacitor
Capacitor

DESCRIPTION
100PF50V 5% NPO 0805
1nF 0603 50v 5% COG

QTY
4
3

UNIT
PCS
PCS

FPC Connector

153

067-7700099112R

Diode

154
155

3
1

067-7700316119R
088-1018424000R

Diode
MDAC Front PCBA

156

006-1014080733R

157

006-1024080803R

158

006-4704080743R

159

020-0002227134R

SMD 24pin PH=1mm Vertical ZIF FFC

Connector
BAV99 DUAL SOT-23 Philips/nxp

BAS316 SOD323 PHILIPS

MDAC Front PCBA
100uF 16V 20% D8*7MM SXJseries Lelon
Electrolytic Capacitor
105
Electrolytic Capacitor 1000uF 4V OCRZ series 8*8 20% 105Lelon
47uF 25V 20% D8*7MM SXJseries Lelon 105
Electrolytic Capacitor

EC162101E1B-HA1-016 L=20MM 6mm

Encoder + Push Switch
R/T200450gf

20
2
1

CN2

D1--PCS
D12,D20.D25.D28.D29.D30.D31.D32.D33
PCS
D36.D37
PCS

PCS

C5

PCS

C1.C2.C3

PCS

C4

PCS

SW5

21
M-DAC

ELECTRONIC PARTS LIST

M-DAC E- Electronic Bom -P4/5

No. LEVEL
P/N
160
2
026-0000003000R

PART NAME
Light Sensor

168

088-1018424001R

MDAC Front PCBA

169

002-0000011050R

Resistor

DESCRIPTION
AT405-ALS-T2 PH=5MM GOODTAKE
VG-2864ASWDT09 128x64Dot 2.7 WISE
CHIP
TC-17XA 7.8*7.8*5
6PIN sh-56-01 PH=2.54MM 13.2*18MM
11*10*9.6 RCEB-8
KS1838
LEDK-8KangYangNYLON66UL
94V-2
RCEB-7KangYang NYLON66UL94V2
MDAC Front PCBA(SMD components
assembled)
0R 0603 5% 50V

170

002-1000011010R

Resistor

10K 1% 0603 50V

10

PCS

171
172
173
174
175
176
177
178
179
180
181

3
3
3
3
3
3
3
3
3
3
3

002-1001021010R
002-1002021010R
002-1004021010R
002-1203021010R
002-1500021010R
002-9103021010R
003-1000080001R
007-1000001060R
007-1000061060R
007-1000072060R
007-1001031061R

Resistor
Resistor
Resistor
Resistor
Resistor
Resistor
Resistor
Capacitor
Capacitor
Capacitor
Capacitor

RES 100 OHM 1/10W 1% 0603

RES 1K OHM 1/10W 1% 0603
RES 100K OHM 1/10W 1% 0603
RES 12K OHM 1/10W 1% 0603
15R, 1%, 0603, 1/10W
910K 0603 1/10W 1%
100R 1/16W 1% 0603 8pin
10PF/50V NPO 0603K
10NF 50V X7R 0603 1/16W 10%
10nF, 200V, 0805, X7R, 20%
0603 100P/50V 5% MURATA

4
1
2
1
1
1
7
1
3
8
1

PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS

182

007-1001051060R

Capacitor

100NF 0603 10% Murata 25V(20100830

21

PCS

183
184
185
186
187
188

3
3
3
3
3
3

007-1002051063R
007-1006072034R
007-2200031061R
007-2206052010R
007-3001001060R
017-0170000000-1R

Capacitor
Capacitor
Capacitor
Capacitor
Capacitor
IC

5
2
8
5
1
1

PCS
PCS
PCS
PCS
PCS
PCS

189

017-0211300000R

190
191
192
193

3
3
3
3

017-0480000000R
017-1089000000R
017-1405000000R
035-1003062051R

194

053-1048410048R

195

056-0230552190R

196

056-8124551194R

197
198
199
200
201
202

3
1
2
2
2
2

067-7700316119R
088-1018420400R
349-1006000011R
044-6550000000R
041-1376000000QR
006-4724183503R

203

088-1018420401R

204
205
206
207
208
209
210

3
3
3
3
3
3
3

055-0310030100R
002-1000011010R
002-1001032010R
002-1002021010R
002-1503011010R
002-2203021010R
002-4703021010R

161

030-7324000000R

OLED

162
163
164
165

2
2
2
2

039-3000000000R
044-6570000000R
044-6590000000R
052-2200000000R

Tact Switch
Connector
IR PAD
IR receiver

166

223-0500120803R

Plastic Post

167

277-0120000001R

Plastic Post

211

007-1000072060R

212
213
214
215
216
217
218

3
3
3
3
3
3
3

007-1001052060QR
007-1004052060R
018-1400846227R
018-1400856227R
018-5600070227R
018-7203404227R
018-7203407227R

219

053-1048410004R

220

067-2200002103R

1nF 0603 50v 5% COG

10uF 16V 20% X5R 0805
0603 22P/50V 5% NPO
0805 22U/6.3V X5R 20%
33PF/50V NPO 0603K
PIC24FJ64GB106-I/PT TQFP64 Microchip
LP2951 SO8 ADJ 100mA ON(CDR2G)
IC
Fairchild(CM)
IC
NC7SZ18P6X SC70-6 Fairchild
IC
NC7SZ157P6X SC70-6 Fairchild
IC
WM8804GEDS SSOP-20 Wolfson
Inductor
1000ohm/100MHz 0805 BLM21BD102SN1D
MDAC/QDAC Front PCB Class 3 PCB 4 Layer FR4 1.6MM 1oZ 216.5
Rev0.2
x 40mm
SMD 30pin PH=0.5mm Parallel ZIF FFC
FPC Connector
Connector 1226-30-02
SMD 24pin PH=1mm Vertical ZIF FFC
FPC Connector
Connector
Diode
BAS316 SOD323 PHILIPS
MDAC PSU PCBA
MDAC PSU PCBA
Glounding piece
PCB-2
S-video
9pin DIN-912A chunsheng
SWITCH
SWITCH MAINSP SDDSA 3289A
Electrolytic Capacitor
4700u/25V 20% Lelon RXY 18*35mm 105
MDAC PSU PCBA(SMD components
MDAC PSU PCBA
assembled)
10P Cable
2.54MM L=250MM 1007 24AWG
Resistor
10K 1% 0603 50V
Resistor
100 1/8W 1% 0805
Resistor
RES 1K OHM 1/10W 1% 0603
Resistor
RC03K153JT
Resistor
RES 22K OHM 1/10W 1% 0603
Resistor
0603 47K1/8W1%

Capacitor

10nF, 200V, 0805, X7R, 20%

Capacitor
100PF50V 5% NPO 0805
Capacitor
100nF 50V 5% 0805
Transistor
BC846 BLT1 SOT-23 PHILIPS
Transistor
BC856 BLT1 SOT-23
Transistor
BAV70LT1G SOT-23 ON
MOSFET
AO3404A Nch SOT-23 Alpha & Omega
MOSFET
AO3407A Pch SOT-23 Alpha & Omega
MDAC/QDAC PUS PCB Class 3 PCB 2Layer FR4 1.6MM 2oZ 198.4x
Rev0.3
47mm
S2J Silicon Rectifier Diode 2A 600VSMA
Doide
(D0-214)

QTY
1

UNIT
PCS

LOCATION
U10

PCS

4
1
1
1

PCS
PCS
PCS
PCS

SW1.SW2.SW3.SW4
CN3

PCS

Light Sensor+FRONT PCB

PCS

IR+FRONT PCB

PCS

PCS

U11

R17
R3.R7.R14.R15.R16.R26.R31.R32.R33.
R34.
R1.R11.R20.R21
R4
R2 R5
R6
R12
R13
RA1.RA2.RA3.RA4.RA5.RA6.RA7
C7.
C24.C25.C30
C67.C68.C69.C70.C71.C72.C73.C74
C6
C15.C16.C17.C18.C19.C20.C21.C27.C3
3.C34.C35.C36.C37.C39.C40.C41.C42.C
43.C48.C54.C55
C53.C56.C57.C58.C59
C28.C29
C9.C10.C11.C12.C13.C44.C45.C46.
C14.C23.C26.C31.C32
C22
U1

PCS

U6

1
1
1
5

PCS
PCS
PCS
PCS

U4
U5
U2
L1.L2.L3.L4.L5

PCS

PCS

CN2

PCS

CN1

1
1
2
1
1
5

PCS
PCS
PCS
PCS
PCS
PCS

D1

PCS

1
7
12
3
2
4
2

PCS
PCS
PCS
PCS
PCS
PCS
PCS

22

PCS

1
6
1
2
2
2
2

PCS
PCS
PCS
PCS
PCS
PCS
PCS

PCS

11

PCS

MH1MH2
CN1
SW1
C1.C2.C3.C4.C5

R12.R14.R21.R23.R24.R25.R26
R1--R8R27.R28.R37.R38
R11.R16.R22
R15.R19
R9.R13.R17.R20
R10.R18
C15.C16.C17.C18.C20.C21.C23.C24.C2
5.C27.C28.C29.C31.C32.C33.C34.C36.C
38.C39.C40.C71.C72
C19
C22.C26.C30.C35.C37.C41
Q7
Q2.Q5
D9.D10
Q1.Q4
Q3.Q6

D1.D2.D3.D4.D5.D6.D7.D8.D11.D12.D13
.

23
M-DAC

PRODUCT VERSION DEVIATION

M-DAC-Color Deviation-P1/1

No.

P/N
340-1018420000R
1
340-1018420002R
300-1018410000-2R
2
300-1018420001-1R
309-1018410000-2R
3
309-1018420001-1R
534-3002100606R
4
534-3002100906R
301-1084100000-2R
5
300-1018420002-1R
524-2025050601R
6
524-2023061001R
524-2923090616R
7
524-2923091016R
215-1027420001R
8
215-1027410001R
309-1018410000R
9
309-1018420001R
215-1027410000R
10
215-1027420000R

PART NAME
knob
front panel
main chassis
screw
back panel
screw
screw
button cap
function button
power button

DESCRIPTION
black painted
silver painted
silkscreened, light greysilver
silkscreened, light greyblack
silver painted
black anodized
M3*10NI
M3*10Black
silkscreened, light greysilver
silkscreened, light greyblack
M2*5NI
M2*6.5Black
ST2.9*9.5NI
ST2.9*9.5Black
silver painted,ABS757#
black painted,ABS757#
silver painted
black painted
silver painted,ABS757#
black painted,ABS757#

QTY
1
1
1
1
1
1
10
10
1
1
1
1
8
8
1
1
4
4
1
1

UNIT
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS
PCS

24
M-DAC

PRODUCT VERSION DEVIATION

M-DAC-Country Deviation-P1/1
No.
1
2
3
4
5
6
7

UNIT CODE
AH-001841-01A
AH-001842-01A
AH-001841-02A
AH-001842-02A
AH-001841-03A
AH-001842-03A
AH-001841-05A
AH-001842-05A
AH-001841-06A
AH-001842-06A
AH-001841-07A
AH-001842-07A
AH-001841-12A
AH-001842-12A

COLOR COUNTRY
silver
CH
black
silver
USA
black
silver
UK
black
silver
AU
black
silver
TW
black
silver
FG
black
silver
JP
black

P/N

PART NAME

022-1000013405R

Power adaptor

022-1001023405R

Power adaptor

022-1000033405R

Power adaptor

022-1000073405R

Power adaptor

022-1004023405R

Power adaptor

022-1000063405R

Power adaptor

022-1000603405R

Power adaptor

DESCRIPTION
EI TYPE INPUT=AC220V
OUTPUT=AC14.2V*[email protected],CH
EI TYPE INPUT=AC110-120V
OUTPUT=AC13.8V*[email protected],USA
EI TYPE INPUT=AC230V
OUTPUT=AC13.8V*[email protected],UK
EI TYPE INPUT=AC230V
OUTPUT=AC13.8V*[email protected],AU
EI TYPE INPUT=AC110V
OUTPUT=AC13.8V*[email protected],TW
EI TYPE INPUT=AC230V
OUTPUT=AC13.8V*[email protected],FG
EI TYPE INPUT=AC100V
OUTPUT=AC15V*[email protected],JP

25
M-DAC