MSDS-Suniso3g en Ingles

SONNEBORN, INC.
MATERIAL SAFETY DATA SHEET

Revision: 1.9
06/24/2005
Page: 1 of 8
Product name: SUNISO 3GS Refrigeration Oil
1. PRODUCT AND COMPANY IDENTIFICATION

Product name:
SUNISO 3GS Refrigeration Oil
Chemical name:
Refined Petroleum Oil

Sonneborn, Inc.
771 Old Saw Mill River Road
Tarrytown, NY 10591-6716 06749, USA
Supplier:
Emergency telephone number:
CHEMTREC (24 hours) 800-424-9300

Sonneborn, Inc. Emergency Response (24 hours) 800292-5898
416-284-1661
For MSDS, Product Safety, or regulatory

inquiries, call:
877-948-2688
Customer Service:
Customer Service 877-948-2688
2. COMPOSITION / INFORMATION ON INGREDIENTS

COMPONENT
Distillates, (petroleum), hydrotreated heavy naphthenic
Note(s):
CAS#
CONCENTRATION
64742-52-5
100.0 %
This is not a dangerous substance
3. HAZARDS IDENTIFICATION
EMERGENCY OVERVIEW
THIS PRODUCT IS A REFINED MINERAL OIL AND IT IS NOT EXPECTED TO PRESENT ANY UNUSUAL
HAZARDS, IN PROPER USE.
--- --- CONTENTS MADE IN U.S.A. --- ---
4. FIRST AID MEASURES

Swallowing
Do not induce vomiting. Treat symptomatically. Not expected to be toxic by ingestion.
Skin
No emergency care anticipated. Wash skin with soap and water. Remove contaminated clothing. Wash clothing
before re-use. Obtain medical attention if irritation persists.
SONNEBORN, INC.

Revision: 1.9
06/24/2005
Page: 2 of 8

Inhalation
Obtain medical attention. Oxygen may be given by qualified personnel if breathing is difficult or cyanosis (blue
discoloration of skin) is noted. Give artificial respiration if not breathing. Remove to fresh air if aerosol spray is
inhaled. Aspiration may cause pulmonary edema or aspiration pneumonia. Exposed persons should be kept under
medical observation for at least 48 hours because delayed effects may occur.
Eye contact
Immediately flush eyes with water and continue washing for at least 15 minutes. Obtain medical attention if irritation
persists.
5. FIRE-FIGHTING MEASURES
Flash point:
> 187 C (> 370 F)
NFPA CLASSIFICATION
Health: 1
Flammability: 1
Reactivity: 0
Special provisions: -
Special fire fighting procedures

Use water spray to cool fire-exposed containers and structures. If a rail or tank truck is involved in a fire,
ISOLATE for 800 meters (0.5 mile) in all directions. Shut off fuel to fire if it is possible to do so without
hazard. If this is impossible, withdraw from the area and let the fire burn out under controlled conditions.
Withdraw immediately in case of rising sound from venting safety device or any discoloration of tank due
to fire. Withdraw immediately if rising sound from venting safety device or any discoloration of storage
tanks due to fire.
Special protective equipment for firefighters
Body covering protective clothing, full "turn-out" gear. Self-contained breathing apparatus with full facepiece operated in positive pressure mode.
Extinguishing media
Suitable:
Treat as an oil fire.
Small fires:
- CO2
- dry powder
- foam
Large fires:
- alcohol-type foam or universal-type foams
- water fog
Unsuitable:
Oil will float on water and can spread any fire.
Unusual fire and explosion hazards

This product will float upon water, so water spray is not a suitable extinguishing agent as it may cause any
fire to spread.
6. ACCIDENTAL RELEASE MEASURES
SONNEBORN, INC.

Revision: 1.9
06/24/2005
Page: 3 of 8

Personal precautions
Wear protective clothing when taking up spill. Eliminate sources of ignition.
Environmental precautions
This product is insoluble in water and will float on the surface. Prevent from entering sewers or drains.
Should this product enter sewers or drains, it should be pumped out into an open vessel. Emergency
services may need to be called to assist in this operation.
Methods for cleaning up
Floor may be slippery; use care to avoid falling.
Small spills
Cover remaining spilled product with dry powder, dry sand, or Vermiculite.
Large spills
Large spill: Pump or vacuum transfer spilled product to clean containers for recovery. Absorb
unrecoverable product. Transfer contaminated absorbent, soil and other materials to containers
for disposal.
Stop leak, if without risk.
7. HANDLING AND STORAGE

HANDLING
Handling precautions
Never use pressure to empty drums. Keep drums tightly closed to prevent contamination. Residual vapors
may explode on ignition; do not puncture, drill, grind, or weld near this container. Electrically bond and
ground all containers and equipment before transfer or use of material.
STORAGE
Storage requirements
Normal precautions common to safe manufacturing practice should be followed in handling and storage.
Store in a dry place. Keep out of strong sunlight. Keep away from heat and flame. Keep container tightly
closed.
8. EXPOSURE CONTROLS / PERSONAL PROTECTION

PERSONAL PROTECTION
Respiratory protection
If vapor and/or mist is generated by heating, spraying, etc., wear an organic vapor respirator with a mist
filter. No special respiratory protection is normally required.
Hand protection / protective gloves
Wear oil resistant gloves.
Eye protection
Face shield or chemical splash goggles in case of splashing.
SONNEBORN, INC.

Revision: 1.9
06/24/2005
Page: 4 of 8

Skin protection
Wear protective clothing, such as long sleeves to minimize skin contact.
Industrial hygiene measures
Remove contaminated clothing and clean it.
Do not eat or drink at work.
ENGINEERING CONTROLS
Ventilation
Local ventilation is needed in the presence of airborne mists.
EXPOSURE LIMITS
Component
Mineral Oil Mist
Type
TWA (mist), ACGIH
Value
5.0 mg/m3
STEL (mist), ACGIH
10.0 mg/m3
Remark
If used in way that generates a "mist"
observe the limits for Mineral Oil Mist.
9. PHYSICAL AND CHEMICAL PROPERTIES

APPEARANCE
Physical state
Liquid
Color
Amber
Odor
Mild petroleum
OTHER PROPERTIES
Boiling point
> 260 C at STP unless specified below.
Specific gravity (H2O=1)
<1
Vapor pressure
< 0.005 hPa
Vapor density (air=1)
> 10
Solubility in water
Insoluble
Solubility in organic solvents
Soluble
Partitioning coefficient
log POW: > 6

This product is soluble in oil.
Flash point
> 187 C (> 370 F)

Method: Cleveland open cup ASTM D 92
Percent volatiles
Nil
(0.00 mmHg)
at 20 C
SONNEBORN, INC.

Revision: 1.9
06/24/2005
Page: 5 of 8

Kinematic viscosity
> 30 mm2/s at 40 C
10. STABILITY AND REACTIVITY

Stability: Stable.
Incompatible materials
Normally unreactive; however avoid contact with:
Strong oxidizing agents.
Sunlight or ultraviolet light.
Heat or high temperature.
Hazardous combustion products
Burning can produce the following combustion products:
Oxides of carbon.
Soot
Hazardous polymerization: Will not occur.
11. TOXICOLOGICAL INFORMATION

SWALLOWING
Acute effects
Ingestion is unlikely to have any toxic effects but the product may act as an intestinal lubricant and result in diarrhea
and frequent loose stools.
If vomiting occurs, aspiration may cause delayed pulmonary edema and chemical pneumonia.
Test results
Acute toxicity:
Remark: No data available.
SKIN ABSORPTION
Acute effects
Harmful effects are not expected from short periods of contact.
Effects of repeated overexposure
Prolonged or repeated contact may lead to skin irritation by dermatitis or oil acne.
INHALATION
Acute effects
Harmful effects are not expected from static vapor at ambient temperature.
Inhalation of mist or spray may be harmful.
Chronic effects
Aspiration may cause pulmonary edema or aspiration pneumonia.
Oil deposits in the lung may lead to fibrosis and reduced pulmonary function.
Prolonged or repeated inhalation of excessive amounts of oil mist or vapors may cause irritation of the respiratory
tract.
SONNEBORN, INC.

Revision: 1.9
06/24/2005
Page: 6 of 8

Test results
Acute toxicity:
Remark: No data available.
SKIN CONTACT
Acute effects
No evidence of harmful effects from available information.
EYE CONTACT
Acute effects
No evidence of harmful effects from available information.
12. ECOLOGICAL INFORMATION

Not expected to be acutely toxic to aquatic organisms. This product is stable in water, and can be
mechanically separated from water. The water may be suitable for disposal in a biological waste water
treatment plant.
13. DISPOSAL CONSIDERATIONS

General:
Incineration is probably the best means of disposal. Dispose of in accordance with appropriate
Federal, State, and local regulations.
14. TRANSPORT INFORMATION

DOT Classification
This product is not regulated by DOT.
65 PETROLEUM OIL, N.O.I.B.N
Freight description road:
IMDG Classification
This product is not regulated by IMDG.
ICAO Classification
This product is not regulated by ICAO.
15. REGULATORY INFORMATION

Superfund Amendments and Reauthorization Act of 1986 (SARA) Title III requires submission of
annual reports of release of toxic chemicals that appear in 40CFR372 (for SARA 313). This
information must be included in MSDS's that are copied and distributed for this material.
Components present in this product at a level which could require reporting under the statute are:
**** NONE ****
New Jersey Worker and Community Right-To-Know Act (Labeling Requirements)
Chemical name
CAS#
New Jersey TS Number
SONNEBORN, INC.

Revision: 1.9
06/24/2005
Page: 7 of 8

Distillates, (petroleum), hydrotreated heavy naphthenic
EPA Hazard Categories (SARA 311, 312):
64742-52-5
None
CHEMICAL INVENTORY
Canada:
The ingredients of this product are on the DSL.
Europe:
The ingredients of this product are on the EINECS inventory.
United States:
The ingredients of this product are on the TSCA inventory.
Australia:
The ingredients of this product are on the AICS inventory.
China:
This product is on the IECSC Inventory.
Japan:
The ingredients of this product are on the ENCS inventory.
Korea:
The ingredients of this product are on the ECL.
Philippines:
The ingredients of this product are on the PICCS.
16. OTHER INFORMATION

FURTHER INFORMATION
MAY BE ON THE INVENTORY LIST BUT NOT NECESSARILY REGISTERED, (Korea, China, New
Zealand) CONSULT REGULATORY SPECIALIST.
HMIS RATING
Health: 1
Flammability: 1
Reactivity: 0
PPI: -
LEGEND
STP
W/W
0 (HMIS)
1 (HMIS)
2 (HMIS)
3 (HMIS)
4 (HMIS)
X (HMIS)
Standard temperature and pressure

Weight/Weight
Minimal hazard
Slight hazard
Moderate hazard
Serious hazard
Severe hazard
Personal protection rating to be supplied by user depending on use conditions
Copyright 2005 Sonneborn, Inc.
The opinions expressed herein are those of qualified experts within Sonneborn, Inc. We believe that the
information contained herein is current as of the date of this Safety Data Sheet. Since the use of this
information and of these opinions and the conditions of use of this product are not within the control of
Sonneborn, Inc., it is the user's obligation to determine the conditions of safe use of the products.
SONNEBORN, INC.

Revision: 1.9
06/24/2005
Page: 8 of 8

MSDS-Suniso3g en Ingles

Uploaded by

Copyright:

Available Formats

MSDS-Suniso3g en Ingles

Uploaded by

Document Information

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

MSDS-Suniso3g en Ingles

Uploaded by

Copyright:

Available Formats

SONNEBORN, INC.

MATERIAL SAFETY DATA SHEET

Product name: SUNISO 3GS Refrigeration Oil

1. PRODUCT AND COMPANY IDENTIFICATION

SUNISO 3GS Refrigeration Oil

Refined Petroleum Oil

Emergency telephone number:

CHEMTREC (24 hours) 800-424-9300

For MSDS, Product Safety, or regulatory

Customer Service 877-948-2688

2. COMPOSITION / INFORMATION ON INGREDIENTS

This is not a dangerous substance

4. FIRST AID MEASURES

MATERIAL SAFETY DATA SHEET

Product name: SUNISO 3GS Refrigeration Oil

> 187 C (> 370 F)

Special fire fighting procedures

Oil will float on water and can spread any fire.

Unusual fire and explosion hazards

6. ACCIDENTAL RELEASE MEASURES

MATERIAL SAFETY DATA SHEET

Product name: SUNISO 3GS Refrigeration Oil

7. HANDLING AND STORAGE

8. EXPOSURE CONTROLS / PERSONAL PROTECTION

MATERIAL SAFETY DATA SHEET

Product name: SUNISO 3GS Refrigeration Oil

STEL (mist), ACGIH

9. PHYSICAL AND CHEMICAL PROPERTIES

> 260 C at STP unless specified below.

Specific gravity (H2O=1)

< 0.005 hPa

Vapor density (air=1)

Solubility in organic solvents

log POW: > 6

> 187 C (> 370 F)

MATERIAL SAFETY DATA SHEET

Product name: SUNISO 3GS Refrigeration Oil

10. STABILITY AND REACTIVITY

11. TOXICOLOGICAL INFORMATION

Remark: No data available.

MATERIAL SAFETY DATA SHEET

Product name: SUNISO 3GS Refrigeration Oil

Remark: No data available.

12. ECOLOGICAL INFORMATION

13. DISPOSAL CONSIDERATIONS

14. TRANSPORT INFORMATION

15. REGULATORY INFORMATION

New Jersey TS Number

MATERIAL SAFETY DATA SHEET

Product name: SUNISO 3GS Refrigeration Oil

The ingredients of this product are on the EINECS inventory.

The ingredients of this product are on the TSCA inventory.

The ingredients of this product are on the AICS inventory.

This product is on the IECSC Inventory.

The ingredients of this product are on the ENCS inventory.

The ingredients of this product are on the ECL.

The ingredients of this product are on the PICCS.

16. OTHER INFORMATION

Standard temperature and pressure

MATERIAL SAFETY DATA SHEET