DESTINATION:

TEXAS HILL COUNTRY

CESSNA FLYER ASSOCIATION

2450 N LAKE AVE #113
ALTADENA, CA 91001

CHANGE SERVICE REQUESTED

PRSRT STD
US POSTAGE
PAID
PERMIT NO 5377
DENVER, CO

LIFE IN THE FAST PLANE

THE CESSNA 210
SEPT 2013

cessnaflyer.org

VOL 10 ISSUE 09

The complex 210 definitely has its admirers.

Photo: Paul Bowen

The Cessna 210, or

Centurion, was first
created in the late
1950s and entered the
marketplace as a 1960
year model aircraft. A
total of 9,304 C210s
were built according
to Doug Miller, archivist and historian for
Cessna Aircraft Co.
At press time, there
were just under 5,000
Cessna 210s listed in the FAA registration database; many others are still in use
throughout the world.
The aircraft was eventually available
in three different versions: normally aspirated (C210), turbocharged (T210), and
turbocharged and pressurized (P210).

Each aircraft offered

different benefits related
to speed, altitude, loadcarrying capability and
passenger comfort.
All three versions
were certified under
Part 23 and are basically built around the
same airframe; however,
the P210 is structurally
significantly different.
The normally aspirated 210 and the T210 are almost
exactly the same, except for different
enginesand thus some system differences which significantly alter performance and therefore require different
operational procedures.
Many of the basic characteristics

C ES S NA F LYE R

45

SEPTEMBER 2013

Photo: Paul Bowen

All three versions were certified

under Part 23 and are basically
built around the same airframe.

of these aircraft are the same, though,

including preflight and in-flight handling
characteristics.
Models
The original 210 had four seats and a
normally aspirated 260 hp engine. It was
essentially a C182, wing struts included,
with retractable gear.
The first turbocharged Centurion
sold was the 1966 T210F powered by a
Continental TSIO-520C engine. Built-in
oxygen was standard and necessary, as
the specifications claimed a 31,300-foot
service ceiling.
In 1967, the Cessna 210G arrived with
a laminar flow cantilever wing replacing
the strut-braced wing, but it was still a
four-plus-two aircraft.
The introduction of the 210K in 1970
brought to market the full-sized six-seat
C ES S NA F LYE R

46

SEPTEMBER 2013

aircraft and a 400-pound gross weight

increase to 3,800 pounds. One of the
changes that came with the K model was
the tapered tubular steel landing gear legs
with a six-inch wider stance. The gear
legs may look fragile, but they arent.
The 210L arrived in 1972 with a 28
volt electrical system, and in 1975 the
three-bladed propeller became standard. Flap gap seals in 1976 enhanced
climb performance and a key instrument
change occurred: the airspeed indicator
was changed to knots from mph.
The M model of 1977 ushered in the
310 hp TSIO-520R engine for the turbocharged airplanes, which reduced takeoff
distances and provided increased climb
rates. The engine has a five-minute limit on
the 310 hp, which then must be reduced
to 285 hp maximum continuous power.
The pressurized 210 was introduced in

Photo: Paul Bowen

1978 as the P210N. It was powered by a

Continental TSIO-520P putting out 310
hp at takeoff, and like the other turbocharged 210s was limited to 285 hp after
five minutes. Records indicated that a
total of 851 P210s had been built when
production ceased.

The economy was in

a spin during the mid1980s and sales of new
aircraft skidded to a halt.
This gave Cessna time to
redesign the 210 for the
1985 release.

C ES S NA F LYE R

48

SEPTEMBER 2013

Gear doors and other changes

In 1979, the main landing gear doors
were removed from the Centurions. Many
of the earlier Centurions had their main
gear doors removed by owners with a modification called the Uvalde gear door mod.
My own aircraft has the gear door
mod, which I had performed immediately
following an IFR flight where I could
not get a green gear-down light. Because
I didnt have gear mirrors at that time, I
couldnt see the position of my wheels,
which made it a most unpleasant event.
(The value of gear mirrors was instantly
implanted into my brain on that flight.)
In 1982, there was a major change in
the fuel system for 210s. Cessna accomplished this by removing the dual fuel
reservoir tanks and installing a single reservoir tank. This allowed the pilot to select
Left, Right, or Both fuel tanks in flight.
Obviously, being able to select both fuel
tanks reduced the pilots workload.
Other fuel system changes included

separate fuel vapor return lines to return

the vapor to each fuel tank.
A late-season redesign
The economy was in a spin during the
mid-1980s and sales of new aircraft skidded to a halt. This gave Cessna time to
redesign the 210 for the 1985 release of
the R model, which was sold new as the
1985 and 1986 models.
There were many changes in the 85
model; one of the most significant was an
enlarged and strengthened tail for the aircraft. This was accomplished in a variety
of ways, including making the horizontal
stabilizer a full three feet wider.
The wingspan was increased to 38 feet,
10 inches and the gear extension speed
and flap speed were raised. The bottom
line is that the 1985/1986 210R is a
very different airplane than its predecessorsand they are highly prized by their
owners. Cessna delivered its last three
Centurions in 1987 as 1986-year models.
Operating a 210
By any definition, Centurion aircraft
are complex airplanes. Original systems
are in some cases very complex and
perhaps not thoroughly explained in the
owners manual, POH or airplane flight
manual. As time has passed and technol-

The 210 is a checklist airplane. It is very important

to your safety that you
ensure the preflight and
flight operations checklists
you use are representative
of the actual aircraft you
are operating.

Photo: CFA Staff

Photo: CFA Staff

Photo: CFA Staff

ogy has changed, we now see extensively

updated avionics and various other
modifications made to each aircraft that
complicate the situation even more.
The 210 is a checklist airplane. It is
very important to your safety that you
ensure the preflight and flight operations
checklists you use are representative of
the actual aircraft you are operating;
one checklist will not fit all! Seemingly
identical aircraft are probably not, and a
switch in the wrong position or a circuit
breaker located in a different position
can cause harm to the aircraft or you and
your passengers.
In my opinion, the Centurion is a very
safe, comfortable, and easy aircraft to

C ES S NA F LYE R

51

SEPTEMBER 2013

fly if you have been well trained and are

proficient in it. Unfortunately, it is an aircraft that has a less-than-admirable safety record, with over 30 reported in-flight
airframe failures. It should be noted that
this aircraft is capable of staying together
at 5.7 gs150 percent of its 3.8 g rating.
Fuel management has also historically
been a problem and continues to be a
leading cause of Centurion accidents,
despite it being a widely known issue
with the aircraft.
For more information
If you would like to do some interesting research on Centurions, you can
go to the FAA website and pull up the
TCDS on the entire 210 series. The
details are contained in a single 45-page
PDF file.
The TCDS files are a treasure trove of
information for those who want to know
exact details, especially limitations, about
a specific make and model. The information is abundant, right down to the serial
number of the airplane.

This article was excerpted from Flying

the Cessna 210: The Secrets Unlocked
by Chuck McGill.

Cessna T210 G, H and J Turbo Centurion

SPECIFICATIONS

C ES S NA F LYE R

52

SEPTEMBER 2013

Horsepower: 285

TAKEOFF

Top Speed: 203 knots

Ground Roll: 800 feet

Cruise Speed: 194 knots

Over 50-foot obstacle: 1,365 feet

Stall Speed (dirty): 55 knots

Rate of Climb: 1,115 fpm

Gross Weight: 3,400 pounds

Ceiling: 30,200 feet

Empty Weight: 2,050 pounds

LANDING

Fuel Capacity: 89 gallons

Ground Roll: 625 feet

Range: 739 nm

Over 50-foot obstacle: 1,355 feet

Chuck McGill has been teaching for over

30 years and has logged over 12,000
hours in more than different 80 makes
and models of General Aviation aircraft.
He is a six-time Master CFI, and in
2009 was honored as CFI of the Year,
FAA Western Pacific Region. He holds a
Commercial certificate for ASEL, ASES,
MEL, Instrument Airplane, as well as
his CFI and CFII. McGill has bachelors
and masters degrees in business and is a
retired Lieutenant Colonel, United States
Marine Corps.

Resources
FAA Type Certificate Data Sheets
faa.gov
At the home page on the far right side
under Top Requests is a link for Type
Certificate Data Sheets (TCDS).
Flying the Cessna 210:
The Secrets Unlocked
by Chuck McGill
http://safeflightintl.com/
flyingthecessna210.html