MSDS and Spec BioGuard Condensate Drain Pan Treatment
Uploaded by
MarymaryBruceMSDS and Spec BioGuard Condensate Drain Pan Treatment
Uploaded by
MarymaryBruceBioGuard
HVAC Condensate Pan Treatment
Continuous controlled chemical release
Lasts 6 - 9 months
EPA registered biocide
Sized for unit tonnage
25 ton block
10 ton strip
5 ton strip
1 ton strip
Prevents drain pan overflow
Non-corrosive
IAQ product
Brought to the market by:
Information phone: 214-682-2333
DISTRIBUTED BY:
MATERIAL
SAFETY
DATA
SHEET
The Green Chemical Store, Inc.
PO Box 2350
Wylie, TX 75098
Product Identity: BioGuard / Product Use: Water Treatment / Product Class:Time Release Solid Core
For Chemical Emergency Call:!
!
!
!
| Product Rating!
!
HMIS Rating
INFOTRAC! !
800-535-5053!!
!
!
|
!
!
!
!
!
!
!
!
| Health!
!
2!
Severe!
! 4
Date Prepared!!
!
!
1/2/2008!
!
| Flammability !
1!
Serious!
3
!
!
!
!
!
!
!
!
| Reactivity ! !
0!
Moderate!
2
Supercedes! !
!
!
10/1/2004!
!
| Protection! !
1!
Slight! !
1
!
!
!
!
!
!
!
!
| !
!
!
!
Minimal!
0
____________________________________________________________________________________________
SECTION I - HAZARDOUS INGREDIENTS
!
!
!
!
!
!
!
!
HAZARDOUS INGREDIENTS!
!
CAS NUMBER ! %!
Didecyl dimethyl ammonium chloride!
7172-51-5!
12!
n-Alkyl (C14 50%, C12 40%, C16 10%)!
!
!
!
Dimethly benzyl ammonium chloride!
8001-54-5!
8!
Inert Ingredients ! !
!
!
!
!
80!
Total ........................................................................................... 100!
!
|!
|!
|
|!
|
|
!
EXPOSURE LIMITS
PEL-OSHA !
!
TLV-ACCIW
N/A ! !
!
N/A
N/A !
N/A
____________________________________________________________________________________________
SECTION II - PHYSICAL & CHEMICAL CHARACTERISTICS
Physical State ................................ Solid!
!
!
Odor / Appearance ......................... Fresh / Yellowish brown!
Solubility in water ........................... Timed release of actives
Percent Volatile .............................. Zero!
!
!
!
!
!!
!
|
|
|
|
Specific Gravity ......... 1!!
Density ...................... 1!!
Evaporation Rate ...... N/A!
(Water = 1)!
!
!
| pH .................................. 6 to 8
| Boiling Point .................. N/A
| Freezing Point ............... 32F
|
____________________________________________________________________________________________
SECTION III - FIRE & EXPLOSION HAZARD DATA
Flash Point ..................................... N/A !
Extinguishing Media ....................... Water!
Special Fire Fighting Procedures ... None!
!
!
!
!
!
!
!
!
!
| Unusual Fire & Explosion Hazards ..... None
| Flammable Limits ................................ LEL = NA UEL = NA
| Product will support combustion
____________________________________________________________________________________________
SECTION IV - REACTIVITY DATA
Is the product stable? ................................................ YES
Conditions to avoid for stability .................................. NA
Incompatibility (Materials to avoid) ............................. NA
Hazardous decomposition products ........................... Carbon Dioxide & Carbon Monoxide may be released under fire conditions
Will hazardous polymerization occur? ........................ NO
Conditions to avoid for polymerization ........................ NONE
____________________________________________________________________________________________
SECTION V - EMERGENCY & FIRST AID DATE
EFFECTS of OVEREXPOSURE
Inhalation ............................... N/A ! !
!
!
!
Eyes ....................................... Can cause irreversible eye damage!
Skin .......................... May irritate or burn sensitive skin
Density ...................... May irritate or burn tissue of gastrointestinal trac
EMERGENCY & FIRST AID PROCEDURES:
INHALATION N/A
EYES:! Hold eye open and rinse slowly and gently with water for 1-20 minutes. Remove contact lenses, if present, after the first 5 minutes,
then continue rinsing eye.
SKIN:! Take off contaminate clothing. Rinse skin immediately with plenty of water for 15-20 minutes.
INGESTION: !
Drink promptly a large quantity of milk, egg whites, gelatin solution or, if these are not available, large quantities of water.
Avoid alcohol Get medical attention.
*NOTE TO PHYSICIAN: Probable mucosal damage may contraindicate the use of gastric lavage.
____________________________________________________________________________________________
SECTION VI - SPILL OR LEAK PROCEDURES
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED:
Contain Spill. Collect for reuse or disposal. Do not contaminate water, food or feed.
WASTE DISPOSAL METHOD:
Store in original container in areas inaccessible to children. Do not store on side. Avoid creasing or impacting of side walls. Do not reuse empty
containers. Discard in trash or recycle. Dispose of pesticide waste according to Federal, State and local regulations.
____________________________________________________________________________________________
SECTION VII - SPECIAL PROTECTION INFROMATION
Respiratory Protection .........................................................
Ventilation ...........................................................................
Protective Gloves ................................................................
Eye Protection ....................................................................
Other Protective Equipment ...............................................
N/A
N/A
Rubber or latex. Recommended to avoid eye contact by transfer
Recommended to avoid eye contact by transfer
None
____________________________________________________________________________________________
SECTION VIII - SPECIAL PRECAUTIONS
PRECAUTIONS TO BE TAKEN IN HANDLING & STORING:
Keep in cool, dry area. Keep under locked storage sufficient to make it inaccessible to children and persons unfamiliar with its proper use. This
is a cationic material, its activity is reduced by soaps and anionics.
PRECAUTIONARY STATEMENTS: DANGER - CORROSIVE to eyes and skin. Read Health Hazard Data.
OTHER PRECAUTIONS: !Wash hands after handling. Read and follow all label and safety directions.
KEEP OUT OF REACH OF CHILDREN
DANGER
DISCLAIMER OF EXPRESS AND IMPLED WARRANTIES
The information in this document is believed to be correct as of the date issued.
HOWEVER, NO WARRANTY OF MERCHANTABILITY, FITNESS FOR USE, OR AN OTHER WARRANTY IS EXPRESSED OR IS TO BE
IMPLIED REGARDING THE ACCURACY OR THE SAFETY OF THIS PRODUCT, OR THE HAZARDS RELATED TO ITS USE.
This information and the product are furnished on the condition that the person receiving them shall make his, or her, own determination as to
the suitability of this product for his, or her, particular purpose and on the condition that he, or she, assume the risk of his, or her, use thereof.
