Icom IC-M802 Service Manual

SERVICE
MANUAL
MF/HF MARINE TRANSCEIVER
iM802
INTRODUCTION DANGER
This service manual describes the latest service information NEVER connect the transceiver to an AC outlet or to a DC
for the IC-M802 MF/HF MARINE TRANSCEIVER at the time power supply that uses more than 16 V. This will ruin the
of publication. transceiver.
DO NOT expose the transceiver to rain, snow or any liquids.

To upgrade quality, any electrical or mechanical parts and
DO NOT reverse the polarities of the power supply when
internal circuits are subject to change without notice or connecting the transceiver.
obligation.
DO NOT apply an RF signal of more than 20 dBm (100 mW)
to the antenna connector. This could damage the transceiv-
er’s front end.
ORDERING PARTS REPAIR NOTES

Be sure to include the following four points when ordering 1. Make sure a problem is internal before disassembling the
replacement parts: transceiver.
2. DO NOT open the transceiver until the transceiver is
1. 10-digit order numbers disconnected from its power source.
2. Component part number and name 3. DO NOT force any of the variable components. Turn
3. Equipment model name and unit name them slowly and smoothly.
4. Quantity required 4. DO NOT short any circuits or electronic parts. An insu-
lated tuning tool MUST be used for all adjustments.
<SAMPLE ORDER> 5. DO NOT keep power ON for a long time when the trans-
ceiver is defective.
1110004080 S.IC µPC2709T IC-M802 MAIN UNIT 5 pieces 6. DO NOT transmit power into a signal generator or a
8810005770 Screw BiH M3×8 ZK IC-M802 Top cover 10 pieces sweep generator.
7. ALWAYS connect a 50 dB to 60 dB attenuator between
Addresses are provided on the inside back cover for your the transceiver and a deviation meter or spectrum ana-
convenience. lyzer when using such test equipment.
8. READ the instructions of test equipment thoroughly
before connecting equipment to the transceiver.
TABLE OF CONTENTS
SECTION 1 SPECIFICATIONS
SECTION 2 INSIDE VIEWS
SECTION 3 CIRCUIT DESCRIPTION
SECTION 4 ADJUSTMENT PROCEDURES
SECTION 5 PARTS LIST
SECTION 6 MECHANICAL PARTS AND DISASSEMBLY

6 - 1 RC-25....................................................................................................................................................... 6 - 1
6 - 2 SP-24 ....................................................................................................................................................... 6 - 1
6 - 3 HM-135 .................................................................................................................................................... 6 - 1
6 - 4 IC-M802 ................................................................................................................................................... 6 - 1
SECTION 7 SEMI-CONDUCTOR INFORMATION
SECTION 8 BOARD LAYOUTS

8-1 HM-135
8-1-1 SW BOARD ............................................................................................................................ 8 - 1
8-1-2 MAIN BOARD ......................................................................................................................... 8 - 1
8-2 RC-25
8-2-1 JACK BOARD ......................................................................................................................... 8 - 1
8-2-2 CONNECT BOARD ................................................................................................................ 8 - 1
8-2-3 SENSOR BOARD ................................................................................................................... 8 - 1
8-2-4 VR BOARD ............................................................................................................................. 8 - 2
8-2-5 DISPLAY BOARD ................................................................................................................... 8 - 3
8-3 IC-M802
8-3-1 DSP BOARD ............................................................................................................................8 - 5
8-3-2 MAIN UNIT.............................................................................................................................. 8 - 7
8-3-3 FILTER BOARD ...................................................................................................................... 8 - 9
8-3-4 PLL UNIT............................................................................................................................... 8 - 11
8-3-5 PA UNIT ................................................................................................................................ 8 - 12
8-3-6 DRIVER BOARD................................................................................................................... 8 - 13
8-3-7 VARISTOR-1 BOARD ........................................................................................................... 8 - 13
8-3-8 VARISTOR-2 BOARD ........................................................................................................... 8 - 14
SECTION 9 BLOCK DIAGRAM
SECTION 10 WIRING DIAGRAM
SECTION 11 VOLTAGE DIAGRAMS

11 - 1 RC-21 and HM-135 .................................................................................................................................11 -1
11 - 2 IC-M802
11 - 2 - 1 MAIN UNIT (1) ...................................................................................................................... 11 - 2
11 - 2 - 2 MAIN UNIT (2) ...................................................................................................................... 11 - 3
11 - 2 - 3 MAIN UNIT (3) ...................................................................................................................... 11 - 4
11 - 2 - 4 PA UNIT ................................................................................................................................ 11 - 5
11 - 2 - 5 PLL UNIT (1) ......................................................................................................................... 11 - 6
11 - 2 - 6 PLL UNIT (2) ......................................................................................................................... 11 - 7
11 - 2 - 7 DSP BOARD ......................................................................................................................... 11 - 8
11 - 2 - 8 FILTER BOARD .................................................................................................................... 11 - 9
SECTION 1 SPECIFICATIONS
• IC-M802
‘ GENERAL
• Frequency coverage :
Receive 500 kHz–29.9999 MHz
1.6000–2.9999 MHz 4.0000–4.9999 MHz
6.0000–6.9999 MHz 8.0000–8.9999 MHz
Transmit 12.0000–13.9999 MHz 16.0000–17.9999 MHz
18.0000–19.9999 MHz 22.0000–22.9999 MHz
25.0000–27.5000 MHz
2.1875 MHz, 4.2075 MHz, 6.3120 MHz, 8.4145 MHz,
DSC receive 12.5770 MHz, 16.8045 MHz
• Mode : TX/RX J3E (USB/LSB), J2B (AFSK), F1B (FSK), A1A (CW)
RX H3E
DSC J2B
• Antenna impedance : 50 Ω
• Frequency stability : ±10 Hz
• Power supply requirement : 13.6 V DC ±15% Negative ground
• Current drain (at 13.6 V DC) : RX; 3.0 A at Max. output power
TX; 30 A typical at Max. audio output
• Usable temperature range : –20˚C to +55˚C; –4˚F to +131˚F
• Dimensions (projections not included) : 240(W) × 94(H) × 238.4(D) mm; 2 7⁄16(W) × 3 11⁄16(H) × 9 3⁄8(D) in.
• Weight : 4.7 kg; 10.4 lb; 165.8 oz
‘ TRANSMITTER
• Output power : 150, 60, 20 W PEP
• Spurious emissions : –62 dB
• Carrier suppressions : 40 dB
• Unwanted sideband suppresion : 55 dB
• Microphone impedance : 600 Ω
‘ RECEIVER
• Sensitivity :
(Receiver)
MODE FREQUENCY 20 dB SINAD 10 dB S/N
0.5–1.5999 MHz 30 dBµVe.m.f. 16 dBµV
J3E, A1A 1.6–1.7999 MHz 13 dBµVe.m.f. –1 dBµV
1.8–29.9999 MHz 8 dBµVe.m.f. –6 dBµV
1.6–1.7999 MHz 13 dBµVe.m.f. –1 dBµV
J2B, F1B 1.8–29.9999 MHz 8 dBµVe.m.f. –6 dBµV
1.5–1.5999 MHz 44 dBµVe.m.f. 30 dBµV
H3E 1.6–1.7999 MHz 30 dBµVe.m.f. 16 dBµV
1.8–3.9999 MHz 24 dBµVe.m.f. 10 dBµV
(DSC) : 0 dBµVe.m.f. (J2B; 2.1875, 4.2075, 6.3120, 8.4145, 12.5770, 16.8045 MHz)
• Squelch sensitivity :
MODE Threshold Tight
J3E at 12.230 MHz Less than +20 dBµV Less than +90 dBµV
H3E at 1.000 MHz Less than +30 dBµV Less than +110 dBµV
• Spurious response rejection : More than 70 dB

• Clarity variable range : ±150 Hz
1-1
• RC-25 Remote controller
‘ GENERAL
• Microphone impedance : 600 Ω
• Audio output power : More than 5 mW at 16 Ω headphone with 10 % distortion
• Audio output impedance : 8–16 Ω
• Dimension (projections not included) : 220(W) × 110(H) × 84.4(D) mm; 8 21⁄32(W) ×4 11⁄32(H) × 3 5⁄16(D) in.
• Weight : 570 g; 1.3 lb; 20.1 oz
• SP-24 External speaker

‘ GENERAL
• Impedance :4Ω
• Input power : Rated input; 5W
Maximum input; 7W
• Dimension (projections not included) : 110(W) × 110(H) × 84.4(D) mm; 4 11⁄32(H) ×4 11⁄32(H) × 3 5⁄16(D) in.
• Weight : 370 g; 0.82 lb; 13.1 oz
All stated specifications are subject to change without notice or obligation.
1-2
SECTION 2 INSIDE VIEWS
• RC-25
VR BOARD
Reset IC
S-80942ANMP)
(IC8202: S-80942CNMC)
DISPLAY BOARD CPU
(IC8201: HD64F2134AFA20)
LCD unit
HLC770-018800)
(DS8220: HLC7700-018800)
SENSOR BOARD
Power amplifier
(IC8270: TA7368F)
• IC-M802
DSC 1st mixer

(D2301: HSB88WS)
DSC 2nd mixer
(IC2701: TA4107F)
PA UNIT
MAIN
MAINUNIT
UNIT
DSP
DSPBOARD
BOARD VARISTOR-2 BOARD
CPU
CPU
(IC3303: M30624MGA)
(IC3303: M30624MGA) FAN controller
(IC6501: TS522ID)
2nd
2ndmixer
mixer
(D302: HSB88WS)
(D302: HSB88WS) DRIVER BOARD
1st
1stmixer
mixercircuit
circuit
1st
1stIFIFamplifier
amplifier VARISTOR-1 BOARD
(Q203:
(Q203: 3SK131)
3SK131)
2-1
SECTION 3 CIRCUIT DESCRIPTION
3-1 RECEIVER CIRCUITS The IF amplifier (Q203) and resonator circuits are designed
3-1-1 RF FILTER CIRCUIT (FILTER AND MAIN between the filter pair. The PLL output signal (1LO) enters
the MAIN unit via the J601 and is amplified at the 1st LO
UNITS)
amplifier (Q601). The amplified signal is passed through the
Received signals from the antenna connector are applied to
100 MHz cut-off low-pass filter (L604, L605, C604,
the transmit/receive switching and protection relay (FILTER
C606–C610) to suppress harmonics components, and then
unit; RL7301) which is controlled by the CPU via the “TRXS”
applied to the 1st mixer circuit (Q201, Q202).
line. The signals pass through the 30 MHz cut-off low-pass
filter (FILTER unit; L7321, C7321–C7323, C7325), and then
3-1-3 2ND MIXER AND IF CIRCUITS (MAIN UNIT)
applied to the MAIN unit via the J7321.
The 1st IF signal from the crystal filter (FI301b) is converted
again into a 455 kHz 2nd IF signal at the 2nd mixer circuit
The signals pass through the transmit/receive switch (D53)
(D302, L303, L304). The 2nd LO signal (2LO) from the PLL
and 1.6 MHz cut off high-pass filter (L51–L54, C54, C56,
unit enters the MAIN unit via the J301 to be applied to the
C57, C59, C61–C64), and are then applied to one of the
2nd mixer circuit.
bandpass filters (including one low-pass filter for below 2.0
MHz). These filters are selected by the filter control signals
(B0–B8) as described in the table below.
3-1-4 3RD MIXER AND IF CIRCUITS (MAIN UNIT)
The filtered signals pass through the 33 MHz cut-off low- The 2nd IF signal passes through the low-pass filter (L305,
pass filter (L202, L203, C202–C206), and are then applied L306, C307–C311), and then applied to the IF amplifier
to the 1st mixer circuit (Q201, Q202). (Q401) via the ceramic bandpass filter (FI401). The ampli-
fied signal passes through the ceramic bandpass filter
Frequency (MHz) LPF ctrl signal BPF ctrl signal (FI402), and then applied to the 3rd mixer circuit via the IF
0.5–1.999 L0 B0 amplifier (Q501). The 2nd IF signal is converted into a 12
2–2.999 L1 B1 kHz 3rd IF signal at the 3rd mixer circuit (IC501). The 3rd LO
3–4.999 L2 B2 signal (3LO) from the PLL unit enters the MAIN unit via the
J3601 to be applied to the 3rd mixer circuit.
5–6.999 L3 B3
7–9.999 L4 B4
10–13.999 L5 B5 3-1-5 DSP RECEIVER CIRCUIT (MAIN AND DSP
14–17.999 B6 UNITS)
L6
18–19.999 The DSP (Digital Signal Processor) circuit enables digital IF
20–21.999 B7 filter, digital noise reduction, digital PSN (Pulse Shift
22–23.999 L7 Network), phase demodulation, digital automatic notich, and
24–29.999 B8 etc.
The 3rd IF signal is applied to the IF amplifier (MAIN unit;

IC1002, pin 5) after being passed through the low-pass filter
3-1-2 1ST MIXER AND IF CIRCUITS (MAIN UNIT) (MAIN unit; IC1002, pins 3, 1). The amplified 12 kHz 3rd IF
The 1st mixer circuit converts the received signals into a signal is amplified at the differential amplifiers (IC651a/b),
fixed frequency, 64.445 kHz 1st IF signal using PLL output and is then applied to the A/D convertor section in the
frequency. By changing the PLL frequency, only the desired CODEC IC (IC501) on the DSP board (EX-2432). At the
frequency is picked up at the pair of crystal filters (FI301a, same time, the converted signal is level-shifted 5 V to 3.3 V
FI301b) via the 64.445 kHz bandpass filter (FI201) at the in the IC (IC501).
next stage.
• RECEIVER CONSTRUCTION
Antenna
1st LO 2nd LO
64—94 MHz 64 MHz
0.5—1.9999 MHz
Crystal Crystal IF
LPF LPF BPF BPF amp.
1st mixer FI301A 2nd mixer FI401 Q401
FILTER unit
Q201 FI301B Q201
BPF Q202 Q202
2—30 MHz
3rd LO
443 kHz
DSP IF IF Crystal
to transmit/receiver switch amp. LPF amp. BPF
UNIT IC1002 3rd mixer Q501 FI402
IC501
3-1
The level-shifted signal is applied to the DSP IC (IC301) for When receiving strong signals, the detected voltage increas-
the digital IF filter, demodulator, automatic notch and noise es and the AGC1 voltage decreases. As the AGC1 voltage
reduction, etc. is used for the bias voltage of the IF amplifiers (MAIN unit;
Q203, Q401, Q501), IF amplifier gain is decreased.
The output signal from the DSP IC is applied to the D/A con-
verter section in the CODEC IC (IC501) to convert into the
analog audio signals. Also the signals are level-shifted 3.3 V 3-1-7 AF AMPLIFIER CIRCUIT (DSP AND MAIN
to 5 V at the level converter section in the IC (IC501). UNITS)
The AF amplifier amplifies the audio signals to the suitable
The level-shifted audio signals are passed through the driving level for the speaker.
active filter (IC701a), and then applied to the MAIN unit via
J901 (pin 17) as the DRAF signal. The AF signals from the DSP unit are passed through the
transmit/receive switch (MAIN unit; IC1703, pins 1, 6) via the
3-1-6 AGC CIRCUIT (DSP AND MAIN UNITS) “DSPO1” signal, and then applied to the AF amplifier (MAIN
The AGC (Automatic Gain Control) circuit reduces IF ampli- unit; IC1702, pin 5) after being passed through the low-pass
fier gain and attenuates IF signal to keep the audio output at filter (MAIN unit; IC1702, pins 3, 1). The amplified signal
a constant level. passes through the the SQL gate (MAIN unit; IC1701, pins
7, 1) which is controlled by the CPU (IC3303, pin 49) via the
The receiver gain is determined by the voltage on the AGC1 “SQLC” signal. The signal is applied to the electronic volume
line from the DSP unit. The D/A converter for the AGC IC (MAIN unit; IC1603, pin 2) which can control the volume
(IC102) supplies control voltage to the AGC1 line and sets attenuation by AFG voltage from the CPU (MAIN unit;
the receiver gain with the [RF/SQL] control. IC3303). Beep, tone, side tone, monitor signals are applied
to the the elecronic volume IC too. The signal is applied to
The 3rd IF signal from the CODEC IC (IC501) is detected at the AF mute swtich, and then amplified at the AF power
the AGC detector section in the DSP IC (IC301). The output amplifier (IC1601, pin 1). The amplified signal is applied to
signal from the DSP IC is level-shifted at the level converter the speaker (SP-24) after being passed through the speak-
(IC101) and applied to the D/A converter (IC102). The AGC er jack (J1451) via the “AFO” signal.
voltage is amplified at the buffer amplifier section in the
IC102 and applied to the MAIN unit to control the AGC1 line.
• DSP CIRCUIT
IC301 IC701a
Active DSPO1
IC651b/a DSP IC
filter
AF
3rd IF Differential CODEC IC (IC501) signals
signal converter
A/D Level D/A Level
DSPI1 converter converter converter converter
(12 kHz)
MAIN UNIT DSP UNIT
From the
• AGC CIRCUIT antenna
IC1002 Q501 Q401 Q203

DSPI1 IF IF IF IF
amp. amp. amp. amp.
IC1101
AGC1 2 1
AGC
DSP From the
UNIT DSC antenna
AGC2 6 7
AGC
IF IF RF
AMP. amp. amp. amp.
DSPI2
IC2702 Q2502 Q2401 Q2301
Q2302
3-2
3-2 TRANSMITTER CIRCUITS When the speech compressor function is ON, the level-shift-
3-2-1 MICROPHONE AMPLIFIER CIRCUIT ed signal from the CODEC IC (IC501) is applied to the DSP
IC (IC301) and compressed at the DSP IC to obtain an aver-
(RC-25, MAIN AND DSP UNITS)
age audio level.
The microphone amplifier circuit amplifies microphone audio
signal to a level needed for the DSP circuit.
At the same time, the compressed signals are modulated at
the DSP IC and applied to the D/A converter section in the
Audio signals from the [MIC] connector (J8701, pin 1) are
CODEC IC (IC501).
amplified at the AF amplifier (IC8280, pin 3), and then
applied to the gate modulator IC (MAIN unit; IC2001, pin 3)
via the J2051, pin 1 as “FMOD” signal. The signal is applied
3-2-4 IF AMPLIFIER AND MIXER CIRCUITS
to the DSP unit after being passed through the limitter ampli-
fier and low-pass filter IC (MAIN unit; IC1051, pins 3, 7) as (MAIN UNIT)
“DSPI1” signal. The modulated 3rd IF signal from the DSP unit (“DSPO1”
signal: 12 kHz) passes through the transmit/receive swtich
(IC1703, pins 1, 5), and then applied to the 3rd mixer circuit
3-2-2 DSP TRANSMITTER CIRCUIT (DSP UNIT) (IC901, pin 3). The applied 3rd IF signal is mixed with the
3rd LO signal from the DDS circuit (PLL unit; IC5701) to pro-
The DSP (Digital Signal Processor) circuit enables PSN
duce a 455 kHz 2nd IF signal.
(Phase Shift Network)/Low Power/Phase modulator, trans-
mitter monitor, side tone, and etc.
The 2nd IF signal is output from IC901, pin 5 and passes
through the ceramic bandpass filter (FL402) to suppress the
The microphone audio signals from the MAIN unit via the
unwanted signals via the D404. The filtered 2nd IF signal is
“DISPI1” line are amplified at the differential amplifiers
amplified at the 2nd IF amplifier (Q801), and then applied to
(IC651a/b), and are then applied to the A/D converter sec-
the 2nd mixer circuit after being passed through the D303
tion in the CODEC IC (IC501). at the same time, the con-
and low-pass filter (L304–L306, C304–C311, R306).
verted signals are level-shifted 5 V to 3.3 V in the IC (IC501).
The 2nd IFsignal is mixed with 64 MHz 2nd LO signal, com-
The level shifted signals are applied to the DSP IC (IC301)
ing from the PLL circuit, at the 2nd mixer circuit (D302) to
and modulated at the DSP IC to p[roduce the 12 kHz trans-
obtain 64.455 MHz 1st IF signal. The 1st IF signal is passed
mitter IF signal.
through the crystal bandpass filter (FI301A, FI301B) to cut
off the unwanted signals. The signal is applied to the trans-
The modulated IF signal from the DSP IC is applied to the
mitter mixer circuit (Q702, Q703) to obtain the desired sig-
D/A convertor section in the CODEC IC (IC501) to convert
nal via the transmit/receive switch (D301) and attenuator.
into the analog IF signal. Also the signal is level-shifted 3.3
V to 5 V at the level converter section in the IC (IC501).
The operating (transmitting) frequency is produced at the 1st
IF mixer circuit (Q210, Q202) by mixing the 1st IF and 1st
The level-shifted IF signal is passed through the active filter
LO signals. The mixed signal is then applied to the RF cir-
(IC701a), and then applied to the MAIN unit via J901 (pin
cuit.
17) as the “DSPO1” signal.
3-2-3 SPEECH COMPRESSOR CIRCUIT

(DSP UNIT)
The DSP (Digital Signal Processor) circuit enables PSN
The speech compressor compresses the transmitter audio
input signals to increase the average output level (average
talk power).
• TRANSMIT CONSTRUCTION 3rd LO

(443 kHz)
IC2001 IC1051 7 Q801
1 DSP 455 kHz Ceramic
3 AMP. 1 5 6 AMP.
MIC Controller AMP. VCA 7 DSPI1 UNIT DSPO1 BPF
LPF
IC1001 (12 kHz) FI402
Antenna
2nd mixer 1st mixer PA UNIT FILTER UNIT
D302 FI301b/a Q702, Q703 0.5—1.9999 MHz
64.455 kHz Crystal RF PWR
BPF amp. LPF YGR AMPs LPFs
DET
Bandwidth: Q401 D7271,
2nd LO (64.00 MHz) 1st LO IC1 Q6101, Q6801,
15 kHz BPFs D7272
(64—94 MHz) Q6851, Q6401,
2—30 MHz Q6402
3-3
3-2-5 RF CIRCUIT (MAIN, PA UNITS AND DRIVER • 2–2.9999 MHz signal
BOARD) The signal is applied to the relay (FILTER unit; RL7061)
The RF circuit amplifies operating (transmitting) frequency which is controlled by the band control IC (MAIN unit;
to obtain 150 W of RF output. IC3602) as the “L2M” signal via the buffer amplifier (MAIN
unit; IC1301, pin 12). The signal passes through the low-
The signal from the 1st IF mixer is passed through one of the pass filter (FILTER unit; L7066–L7068, C7063–C7084,
low-pass filter or bandpass filters (Refer to page 4-1 band- C7086, C7087), and then applied to the RL7062.
pass filters used), and then applied to the YGR amplifier
(IC1, pin 1) after being passed through the attenuator • 3–4.9999 MHz signal
(R5–R7). The amplified signal passes through the low-pass The signal is applied to the relay (FILTER unit; RL7091)
filter (L1–L3, C1–C7) and attenuator (R1–R3), and then which is controlled by the band control IC (MAIN unit;
applied to the PA unit via J1. IC3602) as the “L4M” signal via the buffer amplifier (MAIN
unit; IC1301, pin 12). The signal passes through the low-
The signal applied from the MAIN unit is amplified at 2 pass filter (FILTER unit; L7096–L7098, C7094–C7096,
amplifiers (PA unit; Q6101 and Q6801). A part of output sig- C7098–C7101, C7105–C7107), and then applied to the
nal from 2 amplifiers are applied to the amplifiers to improve RL7092.
the frequency characteristic by feedback. The amplified sig-
nal is applied to the drive amplifier (DRIVER board; Q6851) • 5–6.9999 MHz signal
via the J6301 as “DRVI” signal. The signal from the DRIVER The signal is applied to the relay (FILTER unit; RL7121)
board passes through the impedance converter (PA unit; which is controlled by the band control IC (MAIN unit;
L6301), and then applied to push-pull amplifiers (PA unit; IC3602) as the “L6M” signal via the buffer amplifier (MAIN
Q6401, Q6402) to obtain a stable 150 W of RF output unit; IC1301, pin 14). The signal passes through the low-
power. A part of the RF output power returns to the ampli- pass filter (FILTER unit; L7126–L7128, C7124–C7132,
fiers to obtain a stable gain between 1.6 MHz and 27.5 MHz C7136, C7137), and then applied to the RL7122.
bands by using feedback transformer (L6404). The output
power is applied to the filter unit via the J6401 as “FLIN” sig- • 7–9.9999 MHz signal
nal. The signal is applied to the relay (FILTER unit; RL7151)
which is controlled by the band control IC (MAIN unit;
The amplified signal is applied to the one of the 8 low-pass IC3602) as the “L8M” signal via the buffer amplifier (MAIN
filters which are composed chebychev type. unit; IC1301, pin 15). The signal passes through the low-
pass filter (FILTER unit; L7066–L7068, C7063–C7084,
• 1.6–1.9999 MHz signal C7086, C7087), and then applied to the RL7152.
The signal is applied to the relay (FILTER unit; RL7031)
which is controlled by the band control IC (MAIN unit; • 10–13.9999 MHz signal
IC3602) as the “L1M” signal via the buffer amplifier (MAIN The signal is applied to the relay (FILTER unit; RL7181)
unit; IC1301, pin 11). The signal passes through the low- which is controlled by the band control IC (MAIN unit;
pass filter (FILTER unit; L7036–L7038, C7033–C7039, IC3602) as the “L12M” signal via the buffer amplifier (MAIN
C7041–C7045, C7049), and then applied to the RL7032. unit; IC1301, pin 16). The signal passes through the low-
pass filter (FILTER unit; L7182–L7184, C7183–C7188,
C7193), and then applied to the RL7182.
Antenna
• RF FILTER CIRCUIT
power
detector
Transmitter signals Filter: L0
from the PA unit. LPF 1.6—1.9999 MHz
Filter: L1
LPF
2—2.9999 MHz
Filter: L2
LPF
3—4.9999 MHz
Filter: L3
LPF
5—6.9999 MHz
Filter: L4
LPF
7—9.9999 MHz
Filter: L5
LPF
10—13.9999 MHz
Filter: L6
LPF
14—19.9999 MHz
Filter: L7
LPF
20—29.9999 MHz
low-pass filter control signals
from the MAIN unit
(L1M, L2M, L4M, L6M, L8M, L16M, L22M)
3-4
• 14–19.9999 MHz signal • SWR APC CIRCUIT (FILTER AND MAIN UNITS)
The signal is applied to the relay (FILTER unit; RL7211) The reflected wave signal appears and increases on the
which is controlled by the band control IC (MAIN unit; antenna connector. When the antenna is mismatched,
IC3602) as the “L16M” signal via the buffer amplifier (MAIN D7272 of the power detector circuit (D7271, D7272, L7272)
unit; IC1301, pin 17). The signal passes through the low- in the FILTER unit detects the signal and applies it to the
pass filter (FILTER unit; L7216–L7218, C7214, C7216, ALC amplifier (IC1201, pin 9) in the MAIN unit as “REF” sig-
C7217, C7221–C7225), and then applied to the RL7212. nal. The output signal decreases the bias voltage of the RF
APC amplifier to reduce the output power.
• 20–29.9999 MHz signal
The signal is applied to the relay (FILTER unit; RL7241) • CURRENT APC CIRCUIT (FILTER AND MAIN UNITS)
which is controlled by the band control IC (MAIN unit; The power transistor current is detected from the different
IC3602) as the “L22M” signal via the buffer amplifier (MAIN voltage between both terminals of a 0.012 Ω resistor
unit; IC1301, pin 18). The signal passes through the low- (R6651) on the PA board. The detected voltage is applied to
pass filter (FILTER unit; L7245, L7246, L7248, the differential amplifier (IC6501). When the current of the
C7242–C7244, C7247–C7249, C7253, C7254), and then final transistors is more than 30 A, the detected voltage is
applied to the RL7242. applied to the APC amplifier controller (IC1201) in the MAIN
unit to reduce the gate-2 voltage of the IF amplifier (Q801)
The filtered signal is applied to the antenna connector after and thus reduce the output power.
being passed through the RL7301 and J7311.
3-2-8 RF METER CIRCUIT (MAIN UNIT)

3-2-6 ALC CIRCUIT (FILTER AND MAIN UNITS) The output of ALC amplifier (IC1201, pin 12) is applied to the
The ALC (Automatic Level Control) circuit controls the gain CPU (IC3303, pin 97) as “RFML” signal to indicate the trans-
of IF amplifiers in order for the transceiver to output a con- mit power level on the display.
stant RF power set by the [RF PWR] control even when the For antenna current meter indication, the “ANTM” signal
supplied voltage shifts, etc. from the optional AT-130E is applied to the meter amplifier
(IC1201, pin 12) via the J6701 in the PA unit.
The RF power level is detected at the power detector circuit
(Filter unit; D7271) to be converted into DC voltage and
applied to the MAIN unit as the FOR signal. 3-2-9 MONITOR CIRCUIT (DSP AND MAIN UNITS)
The micorphone audio signals can be monitored to check
The FOR signal is applied to the comparator (IC1201, pin 2). voice characteristics.
The “POCV” signal, controlled by the [RF PWR] control via
the I/O expander (IC3606, pin 5), is also applied to the other A portion of the transmit IF signal from the DSP IC (IC301)
input (pin 3) for reference. The compared signal is output is mixed with a 12 kHz LO signal to demodulate into the AF
from pin 1 and applied to the IF amplifier in the MAIN (Q801) signals. The demodulated signals are level-shifted 3.3 V to
unit to control amplifying gain. 5 V at the level converter (IC102) to convert into the analog
AF signals. The AF signals are then applied to the MAIN unit
When the FOR signal exceeds the POCV voltage, ALC bias as “MONI” signal.
voltage from the comparator controls the IF amplifiers. This
adjusts the output power to a specified level from the [RF The “MONI” signal from the DSP unit is amplified at the AF
PWR] control until the FOR and POCV voltages are equal- amplifier (MAIN unit; IC1603, pin 2), and then applied to the
ized. VCA amplifier to control the AF volume (pin 7). The amplified
signal passes through to the AF mute circuit (MAIN unit;
IC1602, pins 1, 7) which is controlled by the CPU via the
3-2-7 APC CIRCUIT (FILTER AND MAIN UNITS) expander IC (MAIN unit; IC3603) as the “AFMS” signal. The
The APC (Automatic Power Control) circuit protects the AF signal is applied to the AF power amplifier circuit (MAIN
power amplifiers on the PA unit from high SWR and exces- unit; IC1601, pin 1) to drive a speaker.
sive current.
• ALC CIRCUIT
Antenna
PA FILTER UNIT
3rd mixer 2nd mixer 1st mixer UNIT
TX Crystal
signals IF BPF
RF LPF YGR PA LPFs
Q801
BPFs
D7271 Power
D7272 detector
ALC amplifier
ALC 1 2
ALC
8 9
ALC
IC1201
3-5
3-3 PLL CIRCUITS The detected signal output from the PLL IC (pin 2) is con-
3-3-1 GENERAL verted into a DC voltage (lock voltage) at the loop filter and
then fed back to one of the VCO circuits (Q5521, D5521,
The PLL circuits generate a reference frequency (32.000
L5523).
MHz); 1st LO frequencies (64.485–94.455 MHz); 2nd LO
frequency (64 MHz), 3rd LO frequency (433.000 kHz).
The oscillated signal from the buffer amplifier (Q5601) is
also applied to the MAIN unit as a 1st LO signal after being
The 1st LO PLL adopts a mixer-less dual loop PLL system.
amplified at LO (Q5602) and buffer (Q5603) amplifiers or
The BFO uses a DDS and a 2nd LO as a fixed frequency
passed through the bandpass filter (L5602–L5604,
double that the crystal oscillator.
C5610–C5616).
3-3-2 1ST LO PLL (PLL UNIT)

3-3-3 2ND LO AND REFERENCE OSCILLATOR
The 1st LO PLL contains a main and reference loop as a
dual loop system. CIRCUITS (PLL UNIT)
The reference oscillator (X5251, CR604) generates a 32.0
The reference loop generates an approximate 10.5 MHz fre- MHz frequency for the 2 DDS circuits as a system clock and
quency using a DDS circuit, and the main loop generates a for the LO output. The oscillated signal is doubled at the
64.485 to 94.455 MHz frequency using the reference loop doubler circuit (Q5202) and the 64.0 MHz frequency is
frequency. picked up at the double tuned filter (L5203, L5204). The 64.0
MHz signal is applied to the RF circuit as a 2nd LO signal.
(1) REFERENCE LOOP PLL
The oscillated signal at the reference VCO (Q5301, D5301)
is amplified at the amplifiers (Q5302, Q5351) and is then 3-3-3 3RD LO CIRCUIT (PLL UNIT)
applied to the DDS IC (IC5101, pin 46). The signal is then The DDS IC (IC5701) generates a 10-bit digital signal using
divided and detected on phase with the DDS generated fre- the 32 MHz system clock. The digital signal is converted into
quency. an analog wave signal at the D/A converter (R5701–R5720).
The converted analog wave is passed through the bandpass
The detected signal output from the DDS IC (pin 56) is con- filter (L5781–L5783, C5781–C5785) and then applied to the
verted into DC voltage (lock voltage) at the loop filter MAIN unit as the 3rd LO signal (433.000 kHz) via the atten-
(R5136, R5146, C5112) and then fed back to the reference uator (R5781–R5783).
VCO circuit (Q5301, D5301).
(2) MAIN LOOP PLL

The oscillated signal at one of the main loop VCOs (Q5521,
D5521, L5523) is amplified at the buffer amplifiers (Q5601,
Q5604) and is then applied to the PLL IC (IC5401, pin 6).
The signal is then divided and detected on phase with the
reference loop output frequency.
• PLL CIRCUIT
PLL IC (IC5401) MAIN loop VCO

Q5601 Q5602 Q5603
Phase 1st LO
Loop filter Buff LO Buff
detector (64—94 MHz)
Q5521,
D5521,
Programmable Programmable L5523
divider divider LO Q5202
2nd LO
Doubler
(64 MHz)
Q5801
Q5302 DSC 2nd LO
DDS IC DDS
Loop filter Buff (10.7103 MHz)
(IC5101)
Reference loop VCO
Phase Programmable Q5301, D5301 DSC 1st LO
DDS Buff LO
detector divider AMP. (12.8875—
Q5901 Q5882 Q5881 27.5045 MHz)
Q5351
Programmable
DDS
divider
D/A 3rd LO
DDS convertor (443 kHz)
D/A IC5701
convertor
Reference OSC.
X5251 (32 MHz)
3-6
3-4 DSC CIRCUITS The 1st IF signal from the 1st IF amplifiers is applied to the
3-4-1 DSC BANDPASS FILTER AND RF AMPLIFIER 2nd mixer IC (IC2701, pin 3), and is mixed with the 2nd LO
signal to the converted into a 12 kHz 2nd IF signal.
CIRCUITS (MAIN UNIT)
The RF circuit filters out-of-band signals and amplifiers sig-
The 12 kHz 2nd IF signal from the 2nd mixer (IC2701, pin 5)
nals within the range of frequency coverage.
is applied to the 2nd IF amplifier (IC2702, pin 3), and then
passes through the low-pass filter (IC2702, pins 5, 7). The
(1) 2–7 MHz signals
signal is applied to the DSP unit as the “DSPI2” signal.
The signals from the antenna connector (J2101) pass
The signal is amplified at the differential amplifier (DSP unit;
through the bandpass filter (L2201, L2202, L2207, L2210,
IC601), and is then applied to the A/D converter secition in
L2213, L2216, L2219, L2220, L2225, L2228, L2231, C2201,
the CODEC IC (DSP unit; IC501). At the same time, the con-
C2204, C2207, C2210, C2213, C2216, C2219, C2222,
verted signal is level-shifted 5 V to 3.3 V in the IC (DSP unit;
C2225, C2228, C2234, C2240) to obtain desired 2–6 MHz
IC501).
signals and suppress any undesired signals.
The level-shifted signal is applied to the DSP IC (DSP unit;
(2) 8 MHz signals
IC301) for the digital IF filter, demodulator and noise reduc-
tion, etc.
L2217, L2221, L2222, L2229, L2232, C2202, C2205,
The output signal from the DSP IC is applied to the D/A con-
C2208, C2210, C2211, C2214, C2217, C2220, C2223,
verter section in the CODEC IC (DSP unit; IC501) to convert
C2226, C2236, C2241) to obtain desired 8 MHz signals and
into the analog audio signals. Also the signals are level-shift-
suppress any undesired signals.
ed 3.3 V to 5 V at the level converter section in the IC.
(3) 12 MHz signals
The level-shifted audio signals are passed through the
active filter (IC701b), and then applied to the MAIN unit via
through the bandpass filter (L2235–L2242, L2244, L2245,
the J1102 (pin 21) as the “DSPO2” signal.
C2229, C2235, C2237, C2239, C2243–C2250,
C2252–C2254, C2263, C2264) to obtain desired 12 MHz
3-4-4 DSC AGC CIRCUIT (DSP AND MAIN UNITS)
signals and suppress any undesired signals.
The receiver gain is determined by the voltage on the AGC2
line from the DSP unit. The D/A converter for the AGC
(4) 16 MHz signals
(IC102) supplies control voltage to the AGC2 line and sets
the DSC receiver gain.
L2215, L2218, L2223, L2224, L2230, L2233, C2203, C2206,
The 3rd IF signal from the CODEC IC (IC501) is detected at
C2209, C2212, C2215, C2218, C2221, C2224, C2226,
the AGC detector section in the DSP IC (IC301). The output
C2227, C2238, C2242) to obtain desired 16 MHz signals
signal from the DSP IC is level-shifted at the level converter
and suppress any undesired signals.
(IC101) and applied to the D/A converter (IC102). The AGC
voltage is amplified at the buffer amplifier section in the
The filtered signals are amplified at the RF amplifiers
IC102 and applied to the MAIN unit to control the AGC2 line.
(Q2301, Q2302), and then applied to the 1st mixer circuit
(D2301).
When receiving strong signals, the detected voltage increas-
es and the AGC2 voltage decreases. As the AGC2 voltage
3-4-2 DSC 1ST MIXER AND 1ST IF CIRCUITS
is used for the bias voltage of the IF amplifiers (MAIN unit;
(MAIN UNIT) Q2401, Q2501), IF amplifier gain is decreased.
The 1st mixer circuit converts the received signal into a fixed
frequency of the 1st IF signal with a PLL output frequency.
By changing the PLL frequency, only the desired frequency
will pass through a crystal filter at the next stage of the 1st
mixer.
3-5 FRONT UNIT (RC-25)
3-5-1 LCD CIRCUIT (DISPLAY AND CONNECT
The signals from the RF circuit are mixed at the 1st mixer BOARDS)
(D2301) with a 1st LO signal coming from the PLL circuit to The LCD (CONNECT board; DS8220) is controlled by the
produce a 10.7 MHz 1st IF signal. LCD driver (CONNECT board; IC8240) via the drive signals
(CL1, RES, CS, RS, WR, RD, DB0–DB7) from the display
The 1st IF signal is applied to the crystal bandpass filters board. The LCD’s back light employs 24 LED
(FI231) to suppress out-of-band signals. The filtered 1st IF (DS8300–DS8323). The LED are controlled by dimmer
signal is amplified at the 1st IF amplifiers (Q2401, Q2501), (Q8300, Q8301) and dimmer controller (IC8280) circuits.
then applied to the 2nd mixer circuit (IC2701, pin 3).
3-5-2 MICROPHONE CIRCUIT (DISPLAY BOARD)
3-4-3 DSC 2ND IF AND DSP CIRCUITS The AF signals from the microphone are amplified at the AF
(MAIN AND DSP UNITS) amplifier (IC8280) via the “MIC” signal. The signal is applied
The 2nd mixer circuit converts the 1st signal into a 2nd IF to the IC-M802’s main unit through the J8903 via the “MI”
signal. A double conversion superheterodyne system (which signal.
converts receive signals twice) improves the image rejection
ratio and obtain stable receiver gain.
3-7
3-5-3 GROUP AND CHANNEL DIALS CIRCUIT 3-6-3 PLL UNIT VOLTAGE LINE
(DISPLAY AND SENSOR BOARDS)
LINE DESCRIPTION
• GROUP DIAL
The signals from the group dial (SENSOR board; S8801) is HV13 The voltage from PA and MAIN units via the
applied to the FRONT CPU (IC8201, pins 76, 77) via the J5001.
“GPA” and “GPB” signals.
H5V Common 5 V line from the MAIN unit via the
J5071.
• CHANNEL DIAL
The signals from the channel dial (SENSOR board; S8802) 5V Common 5 V converted from the 13 V line and
is applied to the FRONT CPU (IC8021, pins 74, 75) via the regulated by the +5 regulator circuit (IC5001).
“CHA” and “CHB” signals.
8VL Common 8 V converted from the 13 V line and
regulated by the +8 regulator circuit (IC5031).
3-5-4 KEY’S BACK LIGHTS CIRCUIT (DISPLAY
BOARD)
The key”s back lights compose DS8340–DS8350, and are 3-6-4 MAIN UNIT VOLTAGE LINE
controlled by the dimmer circuit (Q8340–Q8345). The dim-
mer circuit is controlled by the CPU via the “DIMMER” sig- LINE DESCRIPTION
nal from the FRONT CPU. S13V The voltage from the PA unit via the J1901.
3-5-5 RESET CIRCUIT (DISPLAY BOARD) Receive 13 V converted from the S13V line and
R13V
The reset IC (IC8202) resets the FRONT CPU (IC8201) regulated by the R13 regulator circuit (IC1303).
when IC-M802 is power ON or OFF. Common 8 V converted from the 13 V line and
8V
Common –5 V converted from the 13 V line and
–5V regulated by the –5 V DC-DC converter (IC1551,
3-6 POWER SUPPLY CIRCUITS D1551, D1552)
3-6-1 PA UNIT VOLTAGE LINE
Transmit 8 V converted from the S13V line and
T8
LINE DESCRIPTION regulated by the T8 regulator circuit (Q1501).
HV13 The voltage from an external power supply. Receive 8 V converted from the S13V line and
R8
regulated by the R8 regulator circuit (Q1502).
The same voltage as the HV13 line passed
HV
through the fuse (F6701). Common 5 V converted from the 13 V line and
5V
The same voltage as the HV13 line passes
S13V
through the switching relay (RL6701). Common 5 V converted from the 5 V line and
H5V
8 V for transmitter circuits regulated by the +8
PA8V
regulator circuit (IC6601).
8 V for transmitter circuits regulated by the T8
PAT8
regulator circuit (Q6601, Q6602).
3-6-2 DISPLAY BOARD (RC-25) VOLTAGE LINE
LINE DESCRIPTION
The voltage from PA and MAIN units via the
HV13
J8602.
Common 10 V converted from the 13 V line and
10V
Common 5 V converted from the 5 V line and
5V
3-8
3-7 PORT ALLOCATIONS
3-7-1 MAIN CPU (MAIN UNIT; IC3303) MAIN CPU (MAIN UNIT; IC3303)–continued
Pin Port Pin Port
Description Description
number name number name
1 TXS Outputs T8 regulator circuit (MAIN Outputs serial clock signal for the
90 ECK
unit; Q1501) control signal. EEPROM (IC3301, pin 6).
2 RXS Outputs R8 regulator circuit (MAIN Input port for the SEND signal from
92 ASEN
unit; Q1502) control signal. the accessory connector (J1801).
3 PSEL Outputs serial strobe signal to the Input port for the power amplifier tem-
93 TEMP
latch control IC (IC3601, pin 1). perature signal from the PA unit.
4 BEEP Outputs beep audio signals. Input port for the SEND signal from
94 NSEN the AF/MOD connector (PLL unit;
6 PDAT Outputs serial data signal for the PLL
J5051, pin 8) via the J3602.
circuits.
Input port for the RF/ANTC meter’s
7 PCK Outputs serial clock signal for the PLL
97 RFML voltage from the meter amplifier
circuit.
(IC1201, pin 14).
11 UNLK Input port for PLL unlock signal.
19 PWRS Outputs switching relay (PA unit;
RL6701) control signal. 3-7-2 OUTPUT EXPANDER IC FOR THE PLL
23 DRES Outputs the RESET signal. STROBE (IC3601)
Pin Port
24 STBO Outputs strobe signal for the DSP unit. Description
number name
26 RQO Outputs data signal for the DSP unit. Outputs strobe signal for the DDS IC
4 PST1
27 RQI Outputs serial data signal for the DSP (PLL unit; IC5101, pin 91).
unit. Outputs strobe signal for the PLL IC
5 PST2
28 DO Input port for the serial data signal (PLL unit; IC5401, pins 13).
from the DSP unit. Outputs strobe signal for the DDS IC
6 PST3
29 NMEI Input port for the NMEA signal. (PLL unit; IC5701, pin 41).
30 NMEO Outputs NMEA signal for PLL unit. Outputs strobe signal for the DDS IC
7 PST4
(PLL unit; IC5801, pin 41).
32 NMEI2 Input port for the GPS signal from the
PLL unit. Outputs strobe signal for the DDS IC
14 PST5
(PLL unit; IC5901, pin 41).
33 LSTB Outputs serial strobe signal for the
IC3602, IC3603.
34 DSTB Outputs strobe signal for the D/A con-
3-7-3 OUTPUT EXPANDER IC FOR THE FILTER
verter IC (IC3606).
UNIT (IC3602)
Outputs serial clock signal for Pin Port
37 LCK IC3602–IC3605, D/A converter IC Description
number name
(IC3606) and DSP unit.
Outputs 0.5–1.999999 MHz low-pass
Outputs serial data signal for the 4 L0S
filter control signal.
38 LDAT IC3602, IC3603 and D/A converter IC
(IC3606). Outputs 2–2.999999 MHz low-pass fil-
5 L1S
ter control signal.
47 MSTB Outputs serial strobe signal for the
IC3603, IC3605. Outputs 3–4.999999 MHz low-pass fil-
6 L2S
ter control singnal.
48 PSTB Outputs PLL strobe control signal for
the LATCH controller (IC3601). Outputs 5–6.999999 MHz low-pass fil-
7 L3S
ter control signal.
49 SQLC Outputs squelch control signal for the
SQL switching IC (IC1701). Outputs 20–30 MHz low-pass filter
11 L7S
control signal.
Outputs the optional antenna tuner
79 STAT start control signal for the PA unit via Outputs 14–19.999999 MHz low-pass
12 L6S
the J1901. filter control signal.
Input port for the optional antenna Outputs 10–13.999999 MHz low-pass
13 L5S
80 KEYS tuner key control signal via the PA filter control signal.
unit. Outputs 7–9.999999 MHz low-pass fil-
14 L4S
89 EDT I/O port for the serial data signals ter control signal.
from/to the EEPROM (IC3301, pin 5).
3-9
3-7-4 OUTPUT EXPANDER IC FOR BANDPASS FIL- 3-7-7 D/A CONVERTER IC (IC3606)
TERS (IC3604) Pin Port
Description
Pin Port number name
Description
number name
Outputs transmit power control signal.
Outputs 0.5–1.999999 MHz bandpass The signal is applied to the ALC ampli-
4 B0S 5 POCV
filter control signal. fier (IC1201, pin 3) and RF amplifier
(Q701).
Outputs 2–2.999999 MHz bandpass
5 B1S
filter control signal. Outputs the VCA control signal. The
signal is applied to the VCA amplifier
Outputs 3–4.999999 MHz bandpass 6 AFG
6 B2S (IC1603, pin 8) and RC-25 controller
filter control singnal.
via the J2051, pin 5.
7 B3S Outputs the cooling fan control signal.
11 FANS The signal is applied to the fan con-
Outputs 18–23.999999 MHz band- troller (PA unit; IC6501, Q6501).
11 B7S
pass filter control signal.
Outputs the transmitter/receiver
Outputs 14–17.999999 MHz band- switching signal. The signal is applied
12 B6S 13 TRXS
pass filter control signal. to the switching relay circuit (FILTER
unit; RL7301).
Outputs 10–13.999999 MHz band-
13 B5S
pass filter control signal.
14 B4S
3-7-5 OUTPUT EXPANDER IC (IC3603)

Pin Port
Description
number name
Outputs NBDP MOD control signal for
4 NMS
the gate mod IC (IC2001, pin 10).
5 EMS Outputs external MOD control signal
for the gate mode IC (IC2001, pin 11).
Outputs microphone MOD control sig-
6 MMS nal for the gate mode IC (IC2001, pin
9).
Outputs NMEA/RS-232C switching
11 NMRS
singnal.
13 AFMS Outputs AF mute control signal.
Outputs SEND control signal for the
14 CSEN
buffer amplifier (IC1303, pin 6).
3-7-6 OUTPUT EXPANDER IC (IC3605)

Pin Port
Description
number name
Outputs 24–30 MHz bandpass filter
4 B8S
control signal.
Outputs bandpass filter control signal
5 DBP1 for DSC circuit (For 2.1875, 4.2075,
6.3120 MHz).
6 DBP2
for the DSC circuit (8.4145 MHz).
7 DBP3
14 DBP4
3 - 10
3-7-8 FRONT CPU PORT ALLOCATIONS (RC-25,
DISPLAY BOARD; IC8201)
Pin Port
Description
number name
Outputs DISTRESS LED control sig-
17 DSEL
nal.
21 FUNK Input port for the O switch.
22 TXK Input port for the [TX] switch.
23 RXK Input port for the [RX] switch.
24 FCHK Input port for the [FREQ/CH] switch.
25 T0K Input port for the [0] switch.
26 ENTK Input port for the [ENT] switch.
28 PWRK Input port for the [POWER] switch.
Input port for the phone plug insert
31 PMUT
detection signal.
Input port for the [PTT] switch from the
32 FPTT
microphone connector (J8701, pin 5).
33 AFGL Input port for the AF volume control.
Input port for the using microphone
34 M1AD
detection signal.
Input port for the switch signal on the
35 M2AD
microphone.
Input port for the microphone connect-
36 M3AD
ing detection.
CL1
RS
RD
41–46 Output LCD drive signals.
WR
RES
CS
48–55 DB7–DB0 Output LCD drive signals.
58 T8K Input port for the [8] swtich.
59 T7K Input port for the [7] swtich.
Input port for [e-mail]/[DSC]/[TS]
66 EMLK
switches.
67 SETK Input port for the [SET] switch.
68 MODK Input port for the [MODE] switch.
69 TUNK Input port for the [TUNE] switch.
Input port for [CANCEL]/[TELCALL]/
70 DALK
[TXF] switches.
Input port for [DSC]/[CALL]/[CH0]/
71 CSCK
[SELCALL] switches.
Input port for the [DISTRESS]/[CALL]/
72 DSTK
[ALM] switches.
3 - 11
SECTION 4 ADJUSTMENT PROCEDURES
4-1 PREPARATION
When adjusting the contents on page 4-9, a JIG CABLE (see illustration as shown below) is required.
Some adjustments must be performed on the “ADJUSTMENT MODE”. Entering the “ADJUSTMENT MODE”, see the next page.
■ REQUIRED TEST EQUIPMENT

EQUIPMENT GRADE AND RANGE EQUIPMENT GRADE AND RANGE
DC power supply Output voltage : 7.2 V DC Frequency range : 300–3000 Hz

Audio generator
Current capacity : 5 A or more Output level : 1–500 mV
Measuring range : 1–10 W Power attenuation : 40 or 50 dB
RF power meter Frequency range : 300–600 MHz Attenuator
Capacity : 10 W or more
(terminated type) Impedance : 50 Ω
SWR : Less than 1.2 : 1 Frequency range : 120–600 MHz
Standard signal
generator (SSG) Output level : 0.1 µV–32 mV
Frequency range : 0.1–600 MHz (–127 to –17 dBm)
Frequency counter Frequency accuracy : ±1 ppm or better
Sensitivity : 100 mV or better DC voltmeter Input impedance : 50 kΩ/V DC or better
Frequency range : DC–600 MHz Frequency range : DC–20 MHz

FM deviation meter Oscilloscope
Measuring range : 0 to ±5 kHz Measuring range : 0.01–20 V
Digital multimeter Input impedance : 10 MΩ/V DC or better AC millivoltmeter Measuring range : 10 mV–10 V
• CONNECTION
Standard signal Modulation analyzer

generator Attenuator
Spectrum scope
CAUTION!
to antenna connector 1/2
DO NOT transmit while

to antenna connector 1
RF power meter
an SSG is connected to
the antenna connector 1.
DC power supply Ammeter
Distortion meter
Speaker
[MIC] connector
Audio
generator
+ _
1 7
2 8 6
3 5
4
15 k‰
to [CONTROLLER]
PTT to [SP]
4-1
■ ENTERING THE ADJUSTMENT MODE
1 Turn the power OFF.
2 Push and hold the HM-135’s [DOWN] key, [TX] and [RX] buttons, then turn the power ON.
NOTE: Inserting the 15 kΩ resistor between 2 pin and 6 pin of HM-135 works same as pushing and holding HM-135’s [DOWN]
key (See the illustration on page 4-2).
[TX]
[RX]
[DOWN] key
[POWER]
Connect to [MIC] connector.
■ OPERATING ON THE ADJUSTMENT MODE

• Enter the TX adjustment from the MAIN menu : Push the [1] button
• Enter the RX adjustment from the MAIN menu : Push the [2] button
• Enter the DSC adjustment from the MAIN menu : Push the [3] button
• Change the next adjustment item : Push the [0] button
• Return to the pre-adjustment item : Push the [CE] button
[1] [3]
* * * A D J UST M OD E * * *
[2] RX
J3E
Push [1] SET

TX adjustment menu
* * * A D J UST M OD E * * * * * * A D J UST M OD E * * *
RX
[1] TX [CANCEL] J3E
[2] RX BACK TO HERE
[3] DSC Push [2] RX TOTAL GAIN
0 . 80 -0 00
2 . 9 1- 00 0 54(1.647)
0 . 78
TX RX DSC SET
Push [3]
Main menu RX adjustment menu
* * * A D J UST M OD E * * *
RX
J3E
D S C A D J US TM E N T
8 4 1 4 .5
FRQ SET
DSC adjustment menu
TX ADJUSTMENT ITEM CHANGING

[1] [0] [0] [0] [0] [0]
MAIN TX TX TX power TX power TX power TX tune
menu set gain (High) (Middle) (Low) power
[CE] [CE] [CE] [CE] [CE] [CE]
RX ADJUSTMENT ITEM CHANGING

[2] [0] [0]
MAIN RX total S level S level
menu gain zero 8
[CE] [CE] [CE]
DSC ADJUSTMENT ITEM CHANGING *NOTE: DO NOT adjust the “DSC DEMODULATION”.
[3] [0] [0]
DSC *DSC DSC
Thus, after adjusting the “DSC adjustment”,
MAIN
menu adjustment demodulation self check push the [0] button twice to skip it.
[CE] [CE] [CE]
4-2
4-2 PLL UNIT ADJUSTMENT
MEASUREMENT ADJUSTMENT
ADJUSTMENT ADJUSTMENT CONDITIONS VALUE
UNIT LOCATION UNIT ADJUST
LPL LOCK 1 • Operating frequency : 0.5000 MHz PLL Connect a digital multi 1.0 V PLL C5305
VOLTAGE • Mode : J3E meter or oscilloscope
• Receiving to check point
CP5301.
2 • Operating frequency : 0.4999 MHz Less than 4.0 V Verify
• Receiving
HPL LOCK 1 • Operating frequency : 29.9999 MHz PLL Connect a digital multi 4.2 V PLL C5521
VOLTAGE • Mode : J3E meter or oscilloscope
• Receiving to check point
CP5401.
2 • Operating frequency : 0.0300 MHz More than 0.8 V Verify
• Receiving
REFERENCE 1 • Wait for 5 minutes after power ON. PLL Connect an RF volt- Maximum level PLL L5203,
FREQUENCY • Terminate P5201 on the PLL unit to meter to check point L5204
ground with a 50 Ω resister. P5201.
• Receiving
2 Connect a frequency 63.999990 MHz X5251
counter to check point
P5201.
4-3
• IC-M802 BOTTOM VIEW
PLL unit
• PLL UNIT TOP VIEW
X5251
Reference frequency adjustment
L5204
L5203
LPL lock voltage adjustment C5521
HPL lock voltage adjustment
C5305
LPL lock voltage adjustment CP5401
HPL lock voltage check point
P5201
Reference frequency check point
CP5301
LPL lock voltage check point
4-4
4-3 PA AND FILTER UNITS ADJUSTMENT
IDLING 1 • Operating frequency : 12.2350 MHz Rear Connect an ammeter 2.0 A PA R6304
CURRENT • Mode : J3E panel (10 A) between an
(For drive • Apply no audio signal to the [MICRO- external power supply
FETs) PHONE] connector. and the transceiver.
• Disconnect J6702.
• Preset R6304 and R6412 on the PA
unit to max. counter clockwise.
• Connect a dummy load or RF power
meter to the [ANT] connector.
• Transmitting
(For final 2 • Transmitting 0.7 A R6412
transistors)
• After adjustment, connect J6701 to the PA unit.
SWR 1 • Operating frequency : 22.0000 MHz Rear Connect an RF power 140 W Audio Output
DETECTOR • Mode : J3E panel meter to the [ANT] gen- level
• Connect the CP7332 (FOR line) on connector. erator
the FILTER unit to ground.
2 • Connect an audio generator to the FIL- Connect a DC volt- Minimum level FIL- C7275
[MICROPHONE] connector and set TER meter to check point, TER
as: CP7331.
Frequency : 1.5 kHz
• Transmitting
• After adjustment, disconnect CP7332 (FOR line) on the FILTER unit from ground.
4-5
• IC-M802 TOP VIEW
R6412
Idling current adjustment
(For final transistors)
R6304
Idling current adjustment
(For drive FETs)
• FILTER UNIT BOTTOM VIEW
• IC-M802 BOTTOM VIEW
FILTER unit
CP7331 (REF line)

SWR detector check point
CP7332 (FOR line)

Connect to ground
C7275
SWR detector adjustment
4-6
4-4 RECEIVER ADJUSTMENTS
”TOTAL GAIN”, “S-METER” and “DSC PEAK” adjustments must be performed at “ADJUSTMENT MODE”.
NOISE NULL 1 • Operating frequency : 0.5 MHz Front Connect an AC milli- Minimum output MAIN L207
POINT • Mode : H3E panel voltmeter to the [SP] level
• Preset L402 and L405 to max. clock- jack with a 4 Ω dummy
wise. load.
• Preset L401, L403, L404 and L801 to
max. counter clockwise.
• Set the standard signal generator to
OFF (no signal output).
• Receiving
RECEIVER 1 • Operating frequency : 12.2310 MHz Front Connect an AC milli- Maximum out- MAIN L208,
GAIN • Mode : J3E panel voltmeter to the [SP] put level L209,
• Connect a standard signal generator jack with a 4 Ω dummy L210,
to the [ANT] connector and set as: load. L301,
Frequency : 12.2310 MHz L302,
Level : 0.5 µV* L307
(–113 dBm)
Modulation : OFF
• Receiving
TOTAL GAIN 1 • While pushing HM-135’s “DOWN” key, • Push the [ENT] switch to write the adjustment value in the mem-
[TX] and [RX] switches, then turn ory.
power ON.
• Push [2] swtich to enter the RX adjust-
ment mode.
• Connect a standard signal generator
to the [ANT] connector and set as:
Frequency : 12.3540 MHz
Level : 320 µV*
(–57 dBm)
Modulation : OFF
• Receiving
S-METER 1 • Set the standard signal generator to • Push the [ENT] switch to write the adjustment value in the mem-
OFF (no signal output). ory.
2 • Set the standard signal generator as: • Push the [ENT] switch to write the adjustment value in the mem-
Frequency : 12.3540 MHz ory.
Level : 10 mV*
(–27 dBm)
• Receiving
DSC PEAK 1 • Push [3] switch to enter the DSC Front Connect an AC milli- Maximum out- MAIN L2306,
adjustment mode. panel voltmeter to the [SP] put level L2307
LCD displayed :“DSC ADJUSTMENT”. jack with a 4 Ω dummy
• DSC frequency : 8.4145 MHz load.
• Connect a standard signal generator
to the [DSC ANT] connector and set
as:
Frequency : 8.4145 MHz
Level : 0.5 µV*
(–113 dBm)
Modulation : OFF
• Receiving
DSC SELF 1 • LCD displayed :”DSC SELF CHECK” • Push the [ENT] switch, and then verify to return to the “Main
CHECK • DSC frequency : 8.4145 MHz menu” on the LCD display.
• Connect an RF power meter to the When this check is failure, displayed “NG” on LCD, and beep
[DSC ANT] connector on the rear sound.
panel.
• Receiving
*The output level of the standard signal generator (SSG) is indicated as the SSG’s open circuit.
4-7
L208
L209
L307
L302
L301
L210
Receiver gain adjustment
L2307
L2306
DSC peak adjustment
L207
Noise null point adjustment
• RC-25 FRONT PANEL
[ENT]
4-8
4-5 TRANSMITTER ADJUSTMENTS
The following adjustments must be performed at “ADJUSTMENT MODE” after “SWR DETECTOR” and “RECEIVER” ADJUST-
MENTS in the SECTION 4-3 and 4-4.
TRANSMIT 1 • While pushing HM-135’s DOWN key, Rear Connect an RF power Maximum out- MAIN L706
PEAK AND [TX] and [RX] switches, turn power panel meter to the [ANT] put power
TOTAL GAIN ON. connector.
(TX PEAK) • Connect an audio generator to the
[MICROPHONE] connector and set
as:
Frequency : 1.5 kHz
Level : 10 mV
• Push [1] swtich to enter the TX adjust-
ment mode (LCD displayed: “TX SET”).
• Push [ENT] switch, then the transceiv-
er is transmitting.
(TOTAL GAIN) 2 • After setting 75 W, push the [ENT] key 75 W RC-25 [CH]
to write the adjustment value in the DIAL
memory.
TX POWER 1 • LCD displayed :“TX POWER HIGH” Rear Connect an RF power 140 W RC-25 [CH]
(HIGH) • Set the audio generator as: panel meter to the [ANT] DIAL
Frequency : 1.5 kHz connector.
Level : 100 mV
2 • After setting 140 W, push the [ENT]
key to write the adjustment value in
the memory.
(MIDDLE) 1 • LCD displayed :“TX POWER MID” Rear Connect an RF power 70 W RC-25 [CH]
• Set the audio generator as: panel meter to the [ANT] DIAL
Level : 100 mV
2 • After setting 70 W, push the [ENT] key
to write the adjustment value in the
memory.
(LOW) 1 • LCD displayed :“TX POWER LOW” Rear Connect an RF power 20 W RC-25 [CH]
• Set the audio generator as: panel meter to the [ANT] DIAL
Level : 100 mV
memory.
TUNE 1 • LCD displayed :“TX POWER TUNE” Rear Connect an RF power 10 W RC-25 [CH]
POWER • Set the audio generator as: panel meter to the [ANT] DIAL
Level : 100 mV
memory.
4-9
L706
Transmit peak and total gain
adjustment
• RC-25 FRONT PANEL
[ENT]
[CH]
4 - 10
SECTION 5 PARTS LIST
5-1 IC-M802
[MAIN UNIT] [MAIN UNIT]
REF ORDER REF ORDER
DESCRIPTION DESCRIPTION
NO. NO. NO. NO.
IC-M802 D104 1790001770 S.DIODE MA80WK-(TX)
MAIN D105 1790000620 S.DIODE MA77 (TX)
IC1 1110004080 S.IC µPC2709T-E3 D106 1790001770 S.DIODE MA80WK-(TX)
IC501 1110005460 S.IC TA4107F (TE12L) D107 1790001770 S.DIODE MA80WK-(TX)
IC901 1110005460 S.IC TA4107F (TE12L) D108 1790001770 S.DIODE MA80WK-(TX)
IC1001 1130006220 S.IC TC4W53FU (TE12L) D109 1790001770 S.DIODE MA80WK-(TX)
IC1002 1110005450 S.IC TS522IDT D110 1790000620 S.DIODE MA77 (TX)
IC1051 1110005450 S.IC TS522IDT D201 1790001770 S.DIODE MA80WK-(TX)
IC1101 1110000960 S.IC NJM4558M-T1 D301 1790001770 S.DIODE MA80WK-(TX)
IC1201 1110005140 S.IC NJM3403AV-TE1 D302 1750000430 S.DIODE HSB88WSTR
IC1301 1160000130 S.IC TD62783AF (TP1) D303 1790001770 S.DIODE MA80WK-(TX)
IC1302 1160000130 S.IC TD62783AF (TP1) D401 1790000620 S.DIODE MA77 (TX)
IC1303 1160000130 S.IC TD62783AF (TP1) D402 1790000620 S.DIODE MA77 (TX)
IC1501 1180000420 S.IC TA78L05F (TE12R) D403 1790000620 S.DIODE MA77 (TX)
IC1502 1180002180 S.IC TA78M08F (TE16L) D404 1790000620 S.DIODE MA77 (TX)
IC1551 1110001400 S.IC µPC1555G2-T1 D601 1730002280 S.ZENER MA8091-M (TX)
IC1601 1110003090 IC LA4425A D602 1790001770 S.DIODE MA80WK-(TX)
IC1602 1130006220 S.IC TC4W53FU (TE12L) D901 1790001770 S.DIODE MA80WK-(TX)
IC1603 1110003300 S.IC M5282FP 70CD D1201 1790001240 S.DIODE MA2S728-(TX)
IC1701 1130006220 S.IC TC4W53FU (TE12L) D1202 1790001250 S.DIODE MA2S111-(TX)
IC1702 1110005450 S.IC TS522IDT D1203 1790001250 S.DIODE MA2S111-(TX)
IC1703 1130006220 S.IC TC4W53FU (TE12L) D1204 1790001250 S.DIODE MA2S111-(TX)
IC2001 1130008230 S.IC BU4053BCFV-E2 D1205 1790001250 S.DIODE MA2S111-(TX)
IC2701 1110005460 S.IC TA4107F (TE12L) D1206 1730002450 S.ZENER MA8043-H (TX)
IC2702 1110005450 S.IC TS522IDT D1207 1790001250 S.DIODE MA2S111-(TX)
IC3101 1180000970 S.IC AN78L05M-(E1) D1501 1790000980 S.DIODE MA742 (TX)
IC3201 1130005720 S.IC TC7W04F (TE12L) D1502 1790000980 S.DIODE MA742 (TX)
IC3301 1140009240 S.IC HN58X24128FPI D1551 1730002320 S.ZENER MA8051-M (TX)
IC3302 1110005770 S.IC S-80942CNMC-G9C-T2 D1552 1790000980 S.DIODE MA742 (TX)
IC3303 1140010480 S.IC M30624FGAFP D1554 1730002280 S.ZENER MA8091-M (TX)
IC3601 1130007700 S.IC BU4094BCF-T1 D1801 1790001250 S.DIODE MA2S111-(TX)
IC3604 1130007700 S.IC BU4094BCF-T1 D2103 1750000810 S.DIODE UM9957F/TR
IC3605 1130007700 S.IC BU4094BCF-T1 D2104 1750000810 S.DIODE UM9957F/TR
IC3606 1110003690 S.IC M62354GP 75EC D2201 1790001770 S.DIODE MA80WK-(TX)
D2202 1790001770 S.DIODE MA80WK-(TX)
D2203 1790001770 S.DIODE MA80WK-(TX)
Q51 1530003090 S.TRANSISTOR 2SC4213-B (TE85R) D2204 1790001770 S.DIODE MA80WK-(TX)
Q201 1560000720 S.FET 2SK2171-4-TD D2301 1750000430 S.DIODE HSB88WSTR
Q202 1560000720 S.FET 2SK2171-4-TD D3001 1790001670 S.DIODE RB706F-40T106
Q203 1580000620 S.FET 3SK131-T2 MAS D3002 1790001670 S.DIODE RB706F-40T106
Q501 1580000620 S.FET 3SK131-T2 MAS D3004 1790001250 S.DIODE MA2S111-(TX)
Q601 1530003150 S.TRANSISTOR 2SC4673D-TD D3006 1790001670 S.DIODE RB706F-40T106
Q1203 1510000770 S.TRANSISTOR 2SA1586-GR (TE85R) D3337 1790001250 S.DIODE MA2S111-(TX)
Q1204 1510000770 S.TRANSISTOR 2SA1586-GR (TE85R)
Q1205 1530003090 S.TRANSISTOR 2SC4213-B (TE85R)
Q1501 1540000440 S.TRANSISTOR 2SD1619-T-TD FI201 2010002600 XTAL FL-345 (64.455 MHz)
Q1502 1540000440 S.TRANSISTOR 2SD1619-T-TD FI231 2010001880 MONOLITH FL-231 (10.700 MHz)
Q1503 1590000680 S.TRANSISTOR DTC114EUA T106 FI301 2010002470 XTAL FL-315 (64.45500 MHz)
Q1504 1590000680 S.TRANSISTOR DTC114EUA T106 FI401 2020001960 CERAMIC CFWLB455KHFA-B0 (CFWM455H)
Q1601 1590000680 S.TRANSISTOR DTC114EUA T106
Q1801 1540000440 S.TRANSISTOR 2SD1619-T-TD FI402 2020001330 CERAMIC CFWLA455KHFA-B0
Q2101 1590000680 S.TRANSISTOR DTC114EUA T106 (CFWS455HT)
Q2102 1530002690 S.TRANSISTOR 2SC4116-GR (TE85R)
Q2301 1560000720 S.FET 2SK2171-4-TD
Q2302 1560000720 S.FET 2SK2171-4-TD X3301 6050010501 S.XTAL CR-636A (14.7456 MHz)
Q2401 1580000620 S.FET 3SK131-T2 MAS
Q2501 1580000620 S.FET 3SK131-T2 MAS
Q3001 1590000680 S.TRANSISTOR DTC114EUA T106 L1 6200002650 S.COIL NL 252018T-R18J
Q3004 1530002690 S.TRANSISTOR 2SC4116-GR (TE85R) L2 6200002910 S.COIL NL 252018T-R27J
L3 6200002860 S.COIL NL 252018T-4R7J
L51 6200002860 S.COIL NL 252018T-4R7J
D51 1750000810 S.DIODE UM9957F/TR L52 6200009880 S.COIL NL 252018T-820J
D52 1750000810 S.DIODE UM9957F/TR L53 6200004670 S.COIL NL 252018T-3R9J
D53 1790001770 S.DIODE MA80WK-(TX) L54 6200002040 S.COIL NL 252018T-101J
D103 1790001770 S.DIODE MA80WK-(TX) L101 6200003940 S.COIL NL 252018T-5R6J
S.=Surface mount
5-1
REF ORDER REF ORDER
NO. NO. NO. NO.
L102 6200002860 S.COIL NL 252018T-4R7J L801 6150004440 COIL LS-495
L103 6200002040 S.COIL NL 252018T-101J L901 6200002040 S.COIL NL 252018T-101J
L104 6200003280 S.COIL NL 252018T-2R2J L902 6200002040 S.COIL NL 252018T-101J
L106 6200009860 S.COIL NL 252018T-1R5J L904 6150005170 COIL ELELN 102KA
L109 6200002040 S.COIL NL 252018T-101J L1551 6180001000 COIL LAL 04NA 102K
L110 6200002850 S.COIL NL 252018T-R82J L1552 6180001000 COIL LAL 04NA 102K
L111 6200002040 S.COIL NL 252018T-101J L1601 6170000140 COIL LW-15
L112 6200003660 S.COIL NL 252018T-R68J L1801 6200003950 S.COIL HF50ACC 322513-T
L113 6200002040 S.COIL NL 252018T-101J L1802 6200003950 S.COIL HF50ACC 322513-T
L114 6200002610 S.COIL NL 252018T-R47J L1803 6200002040 S.COIL NL 252018T-101J
L119 6200002000 S.COIL NL 252018T-3R3J L1904 6200003950 S.COIL HF50ACC 322513-T
L121 6200009860 S.COIL NL 252018T-1R5J L1906 6140002220 COIL LR-270 (TR6X3X2 3A9)
L122 6200001980 S.COIL NL 252018T-1R0J L1907 6200003950 S.COIL HF50ACC 322513-T
L123 6200003660 S.COIL NL 252018T-R68J L1908 6200003950 S.COIL HF50ACC 322513-T
L129 6200003660 S.COIL NL 252018T-R68J L2201 6200003280 S.COIL NL 252018T-2R2J
L132 6200002910 S.COIL NL 252018T-R27J L2205 6180001730 COIL LAL 02NA 1R8K
L134 6200004950 S.COIL NL 252018T-1R8J L2207 6200003710 S.COIL NL 252018T-2R7J
L135 6200001980 S.COIL NL 252018T-1R0J L2208 6200002610 S.COIL NL 252018T-R47J
L136 6200003660 S.COIL NL 252018T-R68J L2209 6200007790 S.COIL LQW2BHNR15J01L (LQN21A R15J04)
L141 6200004950 S.COIL NL 252018T-1R8J L2214 6200002000 S.COIL NL 252018T-3R3J
L142 6200004740 S.COIL NL 252018T-1R2J L2215 6200002850 S.COIL NL 252018T-R82J
L144 6200002040 S.COIL NL 252018T-101J L2217 6200003280 S.COIL NL 252018T-2R2J
L201 6200002040 S.COIL NL 252018T-101J L2218 6180002300 COIL LAL 02NA 1R2K
L204 6140003620 COIL LR-403 L2221 6180001210 COIL LAL 03NA 8R2K
L205 6200002040 S.COIL NL 252018T-101J L2222 6200004960 S.COIL NL 252018T-R33J
L207 6150004270 COIL LS-483A (C-14924) L2224 6200007780 S.COIL LQW2BHNR12J01L (LQN21A R12J04)
L208 6150005110 COIL LS-540 L2225 6200004740 S.COIL NL 252018T-1R2J
L210 6150004270 COIL LS-483A (C-14924) L2229 6200002610 S.COIL NL 252018T-R47J
L301 6150005110 COIL LS-540 L2230 6200007780 S.COIL LQW2BHNR12J01L (LQN21A R12J04)
L302 6150005110 COIL LS-540 L2231 6200002040 S.COIL NL 252018T-101J
L303 6140002810 S.COIL LR-317 L2232 6200002040 S.COIL NL 252018T-101J
L304 6140003530 COIL LR-395 L2233 6200002040 S.COIL NL 252018T-101J
L305 6200005010 S.COIL NL 252018T-100J L2235 6180000680 COIL LAL 02NA 4R7K
L307 6150005110 COIL LS-540 L2237 6200007760 S.COIL LQW2BHN82NJ01L (LQN21A 82NJ04)
L401 6150005140 COIL LS-542 L2238 6180002920 COIL LAL 02NA 5R6K
L402 6150005140 COIL LS-542 L2239 6200003660 S.COIL NL 252018T-R68J
L405 6150005140 COIL LS-542 L2242 6200007760 S.COIL LQW2BHN82NJ01L (LQN21A 82NJ04)
L406 6200003520 S.COIL ELJFB 102K-F L2244 6200007760 S.COIL LQW2BHN82NJ01L (LQN21A 82NJ04)
L502 6200003520 S.COIL ELJFB 102K-F L2245 6200002040 S.COIL NL 252018T-101J
L505 6200002040 S.COIL NL 252018T-101J L2302 6140003660 COIL LR-409
L506 6200003520 S.COIL ELJFB 102K-F L2304 6140003660 COIL LR-409
L601 6200005010 S.COIL NL 252018T-100J L2306 6150005150 COIL LS-543
L602 6200002840 S.COIL NL 252018T-R22J L2307 6150003640 COIL LS-409
L605 6200002840 S.COIL NL 252018T-R22J L2701 6200003520 S.COIL ELJFB 102K-F
L701 6140002810 S.COIL LR-317 L2702 6200003520 S.COIL ELJFB 102K-F
L703 6200003660 S.COIL NL 252018T-R68J L3301 6200000970 S.COIL NL 322522T-100K
L706 6150004270 COIL LS-483A (C-14924)
L707 6140002810 S.COIL LR-317
S.=Surface mount
5-2
REF ORDER REF ORDER
NO. NO. NO. NO.
R1 7030003270 S.RESISTOR ERJ3GEYJ 390 V (39 Ω) R714 7030003370 S.RESISTOR ERJ3GEYJ 271 V (270 Ω)
R5 7030003230 S.RESISTOR ERJ3GEYJ 180 V (18 Ω) R718 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)
R7 7030003370 S.RESISTOR ERJ3GEYJ 271 V (270 Ω) R720 7030003550 S.RESISTOR ERJ3GEYJ 822 V (8.2 kΩ)
R8 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω) R722 7510001460 S.THERMISTOR NTCG16 3NH 471KT
R59 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) R813 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ)
R201 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) R1008 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)
R211 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ) R1051 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)
R212 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ) R1052 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)
R214 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ) R1054 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)
R404 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) R1102 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ)
R409 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω) R1107 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ)
R508 7510001540 S.THERMISTOR NTCG16 4BH 332KT R1205 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
R601 7030006220 S.RESISTOR ERJ12YJ470U (47 Ω) R1207 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)
R707 7510001460 S.THERMISTOR NTCG16 3NH 471KT R1220 7030003840 S.RESISTOR ERJ3GEYJ 225 V (2.2 MΩ)
R708 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) R1221 7030003840 S.RESISTOR ERJ3GEYJ 225 V (2.2 MΩ)
S.=Surface mount
5-3
REF ORDER REF ORDER
NO. NO. NO. NO.
R1232 7030009930 S.RESISTOR ERJ3GEYJ 825 V (8.2 MΩ) R2107 7030003630 S.RESISTOR ERJ3GEYJ 393 V (39 kΩ)
R1308 7030003200 S.RESISTOR ERJ3GEYJ 100 V (10 Ω) R2303 7030004040 S.RESISTOR ERJ3GEYJ 4R7 V (4.7 Ω)
R1309 7030004040 S.RESISTOR ERJ3GEYJ 4R7 V (4.7 Ω) R2402 7030003580 S.RESISTOR ERJ3GEYJ 153 V (15 kΩ)
R1310 7030003500 S.RESISTOR ERJ3GEYJ 332 V (3.3 kΩ) R2403 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ)
R1313 7030003500 S.RESISTOR ERJ3GEYJ 332 V (3.3 kΩ) R2406 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ)
R1318 7030004040 S.RESISTOR ERJ3GEYJ 4R7 V (4.7 Ω) R2505 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)
R1319 7030004040 S.RESISTOR ERJ3GEYJ 4R7 V (4.7 Ω) R2506 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω)
R1553 7030006220 S.RESISTOR ERJ12YJ470U (47 Ω) R2709 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)
R1610 7030003600 S.RESISTOR ERJ3GEYJ 223 V (22 kΩ) R3002 7030003460 S.RESISTOR ERJ3GEYJ 152 V (1.5 kΩ)
R1724 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ) R3050 7030005691 S.RESISTOR ERA3YED 123V
R1801 7030003500 S.RESISTOR ERJ3GEYJ 332 V (3.3 kΩ) R3051 7030009591 S.RESISTOR ERA3YED 472V
R1802 7030003500 S.RESISTOR ERJ3GEYJ 332 V (3.3 kΩ) R3101 7030008190 S.RESISTOR ERJ12YJ330U (33 Ω)
S.=Surface mount
5-4
REF ORDER REF ORDER
NO. NO. NO. NO.
R3308 7030003360 S.RESISTOR ERJ3GEYJ 221 V (220 Ω) C1 4030007110 S.CERAMIC C1608 CH 1H 680J-T
R3312 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) C5 4030007120 S.CERAMIC C1608 CH 1H 820J-T
R3313 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) C6 4030011600 S.CERAMIC C1608 JB 1E 104K-T
R3320 7030003720 S.RESISTOR ERJ3GEYJ 224 V (220 kΩ) C56 4030006870 S.CERAMIC C1608 JB 1H 222K-T
R3333 7030003360 S.RESISTOR ERJ3GEYJ 221 V (220 Ω) C103 4030011600 S.CERAMIC C1608 JB 1E 104K-T
R3339 7030003360 S.RESISTOR ERJ3GEYJ 221 V (220 Ω) C109 4030006870 S.CERAMIC C1608 JB 1H 222K-T
C159 4030006880 S.CERAMIC C1608 JB 1H 472K-T
S.=Surface mount
5-5
REF ORDER REF ORDER
NO. NO. NO. NO.
C160 4030007170 S.CERAMIC C1608 CH 1H 221J-T C603 4030006880 S.CERAMIC C1608 JB 1H 472K-T
C161 4030011600 S.CERAMIC C1608 JB 1E 104K-T C604 4030006860 S.CERAMIC C1608 JB 1H 102K-T
C162 4030007160 S.CERAMIC C1608 CH 1H 181J-T C605 4030010760 S.CERAMIC C1608 CH 1H 331J-T
C163 4030011600 S.CERAMIC C1608 JB 1E 104K-T C606 4030007010 S.CERAMIC C1608 CH 1H 100D-T
C164 4030007150 S.CERAMIC C1608 CH 1H 151J-T C607 4030009510 S.CERAMIC C1608 CH 1H 010B-T
C166 4030007130 S.CERAMIC C1608 CH 1H 101J-T C609 4030006970 S.CERAMIC C1608 CH 1H 060D-T
C167 4030011600 S.CERAMIC C1608 JB 1E 104K-T C610 4030009510 S.CERAMIC C1608 CH 1H 010B-T
C168 4030011600 S.CERAMIC C1608 JB 1E 104K-T C611 4030011600 S.CERAMIC C1608 JB 1E 104K-T
C169 4030006860 S.CERAMIC C1608 JB 1H 102K-T C612 4030007060 S.CERAMIC C1608 CH 1H 270J-T
C171 4030006850 S.CERAMIC C1608 JB 1H 471K-T C702 4030011600 S.CERAMIC C1608 JB 1E 104K-T
C173 4030010760 S.CERAMIC C1608 CH 1H 331J-T C705 4030011600 S.CERAMIC C1608 JB 1E 104K-T
C174 4030011600 S.CERAMIC C1608 JB 1E 104K-T C706 4030007070 S.CERAMIC C1608 CH 1H 330J-T
C205 4030006990 S.CERAMIC C1608 CH 1H 080D-T C714 4030011600 S.CERAMIC C1608 JB 1E 104K-T
C206 4030007130 S.CERAMIC C1608 CH 1H 101J-T C715 4030006960 S.CERAMIC C1608 CH 1H 050C-T
C208 4030006880 S.CERAMIC C1608 JB 1H 472K-T C717 4030006860 S.CERAMIC C1608 JB 1H 102K-T
C213 4030007000 S.CERAMIC C1608 CH 1H 090D-T C804 4030006880 S.CERAMIC C1608 JB 1H 472K-T
C215 4030006990 S.CERAMIC C1608 CH 1H 080D-T C806 4510004640 S.ELECTROLYTIC ECEV1CA470SP
C301 4030006880 S.CERAMIC C1608 JB 1H 472K-T C908 4510004630 S.ELECTROLYTIC ECEV1CA100SR
C303 4030006960 S.CERAMIC C1608 CH 1H 050C-T C910 4030011600 S.CERAMIC C1608 JB 1E 104K-T
C401 4030011600 S.CERAMIC C1608 JB 1E 104K-T C1010 4510004630 S.ELECTROLYTIC ECEV1CA100SR
C507 4030011600 S.CERAMIC C1608 JB 1E 104K-T C1204 4030008680 S.CERAMIC C2012 JF 1C 105Z-T
C510 4510006220 S.ELECTROLYTIC ECEV1CA101UP C1207 4030008680 S.CERAMIC C2012 JF 1C 105Z-T
C520 4510004630 S.ELECTROLYTIC ECEV1CA100SR C1213 4030008680 S.CERAMIC C2012 JF 1C 105Z-T
S.=Surface mount
5-6
REF ORDER REF ORDER
NO. NO. NO. NO.
C1305 4030011600 S.CERAMIC C1608 JB 1E 104K-T C2001 4510006850 S.ELECTROLYTIC ECEV1CA4R7NR (16V 4.7)
C1312 4510004640 S.ELECTROLYTIC ECEV1CA470SP C2008 4030006880 S.CERAMIC C1608 JB 1H 472K-T
C1313 4510006850 S.ELECTROLYTIC ECEV1CA4R7NR (16V 4.7) C2101 4030007010 S.CERAMIC C1608 CH 1H 100D-T
C1314 4510004640 S.ELECTROLYTIC ECEV1CA470SP C2102 4030007030 S.CERAMIC C1608 CH 1H 150J-T
C1504 4510004630 S.ELECTROLYTIC ECEV1CA100SR C2201 4030011600 S.CERAMIC C1608 JB 1E 104K-T
C1508 4510004640 S.ELECTROLYTIC ECEV1CA470SP C2205 4030011600 S.CERAMIC C1608 JB 1E 104K-T
C1509 4030008680 S.CERAMIC C2012 JF 1C 105Z-T C2206 4030007090 S.CERAMIC C1608 CH 1H 470J-T
C1510 4030008680 S.CERAMIC C2012 JF 1C 105Z-T C2207 4030009490 S.CERAMIC C1608 JB 1H 821K-T
C1555 4510004640 S.ELECTROLYTIC ECEV1CA470SP C2210 4030007170 S.CERAMIC C1608 CH 1H 221J-T
C1558 4510004630 S.ELECTROLYTIC ECEV1CA100SR C2212 4030007150 S.CERAMIC C1608 CH 1H 151J-T
C1601 4510006670 S.ELECTROLYTIC ECEV1CA471P C2218 4030009580 S.CERAMIC C1608 JB 1H 681K-T
C1603 4510006670 S.ELECTROLYTIC ECEV1CA471P C2220 4030007160 S.CERAMIC C1608 CH 1H 181J-T
C1604 4510006670 S.ELECTROLYTIC ECEV1CA471P C2221 4030007110 S.CERAMIC C1608 CH 1H 680J-T
C1612 4510004650 S.ELECTROLYTIC ECEV1EA4R7SR C2229 4030007030 S.CERAMIC C1608 CH 1H 150J-T
C1618 4030008680 S.CERAMIC C2012 JF 1C 105Z-T C2241 4030011600 S.CERAMIC C1608 JB 1E 104K-T
C1706 4510006850 S.ELECTROLYTIC ECEV1CA4R7NR (16V 4.7) C2248 4030007060 S.CERAMIC C1608 CH 1H 270J-T
C1714 4510004630 S.ELECTROLYTIC ECEV1CA100SR C2263 4030009510 S.CERAMIC C1608 CH 1H 010B-T
S.=Surface mount
5-7
REF ORDER REF ORDER
NO. NO. NO. NO.
C2504 4030009910 S.CERAMIC C1608 CH 1H 040B-T W2226 7030000010 S.JUMPER MCR10EZHJ JPW (000)
C2701 4030011600 S.CERAMIC C1608 JB 1E 104K-T W2227 7030000010 S.JUMPER MCR10EZHJ JPW (000)
C2702 4030011600 S.CERAMIC C1608 JB 1E 104K-T W2243 7030000010 S.JUMPER MCR10EZHJ JPW (000)
C2703 4030011600 S.CERAMIC C1608 JB 1E 104K-T W2305 7030003860 S.JUMPER ERJ3GE JPW V
C2704 4030011600 S.CERAMIC C1608 JB 1E 104K-T
C2705 4510004630 S.ELECTROLYTIC ECEV1CA100SR
C2706 4030011600 S.CERAMIC C1608 JB 1E 104K-T EP1 0910054674 PCB B 5722D
C2707 4030011600 S.CERAMIC C1608 JB 1E 104K-T EP2 0880000900 UNIT BOARD EX-2432 #02
C2715 4030010040 S.CERAMIC C1608 JB 1H 561K-T [PLL UNIT]
C2716 4030011600 S.CERAMIC C1608 JB 1E 104K-T REF ORDER
C3001 4030008920 S.CERAMIC C1608 JB 1H 473K-T DESCRIPTION
NO. NO.
C3003 4030008920 S.CERAMIC C1608 JB 1H 473K-T IC5001 1180001070 S.IC TA7805F (TE16L)
C3004 4030008920 S.CERAMIC C1608 JB 1H 473K-T IC5031 1180001250 S.IC TA7808F (TE16L)
C3005 4030008920 S.CERAMIC C1608 JB 1H 473K-T IC5081 1120002920 S.IC ADM202EARN
C3006 4030011600 S.CERAMIC C1608 JB 1E 104K-T IC5082 1130006800 S.IC TC7W08F (TE12L)
C3007 4030007130 S.CERAMIC C1608 CH 1H 101J-T IC5083 1130007040 S.IC TC7W32F (TE12L)
C3008 4030011600 S.CERAMIC C1608 JB 1E 104K-T IC5084 1170000290 S.IC PS2701-1-F3
C3009 4030011600 S.CERAMIC C1608 JB 1E 104K-T IC5085 1170000290 S.IC PS2701-1-F3
C3101 4510004640 S.ELECTROLYTIC ECEV1CA470SP IC5101 1140007880 S.IC TC190G08AF-0046-Z/SC-1246A
C3102 4030011600 S.CERAMIC C1608 JB 1E 104K-T IC5102 1130004830 S.IC TC7SU04F (TE85R)
C3104 4510004640 S.ELECTROLYTIC ECEV1CA470SP IC5401 1130009230 S.IC LMX2306TMX
C3201 4030011600 S.CERAMIC C1608 JB 1E 104K-T IC5701 1140004550 S.IC M65343FP/SC1287
C3202 4030006880 S.CERAMIC C1608 JB 1H 472K-T IC5702 1130004830 S.IC TC7SU04F (TE85R)
C3302 4030011600 S.CERAMIC C1608 JB 1E 104K-T IC5801 1140004550 S.IC M65343FP/SC1287
C3304 4030007020 S.CERAMIC C1608 CH 1H 120J-T IC5901 1140004550 S.IC M65343FP/SC1287
C3305 4030007020 S.CERAMIC C1608 CH 1H 120J-T IC5902 1130004830 S.IC TC7SU04F (TE85R)
C3308 4030011600 S.CERAMIC C1608 JB 1E 104K-T Q5081 1530002690 S.TRANSISTOR 2SC4116-GR (TE85R)
C3309 4030006880 S.CERAMIC C1608 JB 1H 472K-T Q5082 1530002690 S.TRANSISTOR 2SC4116-GR (TE85R)
C3310 4030011600 S.CERAMIC C1608 JB 1E 104K-T Q5083 1590000680 S.TRANSISTOR DTC114EUA T106
C3601 4030011600 S.CERAMIC C1608 JB 1E 104K-T Q5085 1590000680 S.TRANSISTOR DTC114EUA T106
C3603 4030011600 S.CERAMIC C1608 JB 1E 104K-T Q5202 1530002600 S.TRANSISTOR 2SC4215-O (TE85R)
C3605 4030011600 S.CERAMIC C1608 JB 1E 104K-T Q5301 1560000330 S.FET 2SK210-GR (TE85R)
Q5401 1590001330 S.TRANSISTOR DTA114EUA T106
Q5521 1560000490 S.FET 2SK508 K52 T2B
RL2101 6330001320 RELAY AHY103 Q5553 1530002690 S.TRANSISTOR 2SC4116-GR (TE85R)
Q5601 1530002600 S.TRANSISTOR 2SC4215-O (TE85R)
Q5602 1530002600 S.TRANSISTOR 2SC4215-O (TE85R)
J1 6510007020 CONNECTOR TMP-J01X-V6 Q5603 1530002600 S.TRANSISTOR 2SC4215-O (TE85R)
J301 6510007020 CONNECTOR TMP-J01X-V6 Q5881 1530003150 S.TRANSISTOR 2SC4673D-TD
J1101 6510021650 CONNECTOR IMSA-9180B-30B
J1102 6510022810 CONNECTOR IMSA-9180B-22B
J1301 6510022610 S.CONNECTOR 16FMN-BMTTR-A-TBT D5051 1790001250 S.DIODE MA2S111-(TX)
J1451 6450000140 CONNECTOR HSJ0807-01-010 D5081 1790001250 S.DIODE MA2S111-(TX)
J1801 6450000170 CONNECTOR TCS4480-01-1111 D5082 1790001250 S.DIODE MA2S111-(TX)
J1901 6510022540 S.CONNECTOR 20FMN-BMTTR-A-TBT D5083 1790001250 S.DIODE MA2S111-(TX)
J2051 6510023180 CONNECTOR TCS7282-01-211 D5084 1790001250 S.DIODE MA2S111-(TX)
J2101 6510007020 CONNECTOR TMP-J01X-V6 D5085 1790001250 S.DIODE MA2S111-(TX)
J2301 6510007020 CONNECTOR TMP-J01X-V6 D5086 1790001250 S.DIODE MA2S111-(TX)
J3001 6510022620 S.CONNECTOR 10FMN-BMTTR-A-TBT D5101 1750000270 S.DIODE 1SS301 (TE85R)
J3601 6510022580 S.CONNECTOR 24FMN-BMTTR-A-TBT D5301 1790000540 S.VARICAP MA338 (TX)
J3602 6510021720 S.CONNECTOR 30FLT-SM1-TB D5302 1790001210 S.DIODE 1SS375-TL
D5303 1790001210 S.DIODE 1SS375-TL
D5402 1750000270 S.DIODE 1SS301 (TE85R)
W501 7030003860 S.JUMPER ERJ3GE JPW V D5521 1720000390 S.VARICAP KV1470TL
W803 7030003860 S.JUMPER ERJ3GE JPW V
W1101 7030003860 S.JUMPER ERJ3GE JPW V FI5101 2020001820 S.CERAMIC SFECV10M5FA00-R0
W1231 7030003860 S.JUMPER ERJ3GE JPW V X5251 6050010320 XTAL CR-604 (32.000 MHz)
S.=Surface mount
5-8
[PLL UNIT] [PLL UNIT]
REF ORDER REF ORDER
NO. NO. NO. NO.
L5005 6200009300 S.COIL ELJPA 100KF 10U R5117 7030007210 S.RESISTOR ERA3YEB 102V
L5021 2040000490 COIL EXC-ELDR25C R5118 7030007230 S.RESISTOR ERA3YED 102V
L5101 6200001830 S.COIL NL 322522T-100J R5119 7030007230 S.RESISTOR ERA3YED 102V
L5203 6150004250 COIL LS-471A (C-14922) R5121 7030007230 S.RESISTOR ERA3YED 102V
L5204 6150004250 COIL LS-471A (C-14922) R5122 7030007230 S.RESISTOR ERA3YED 102V
L5302 6130001850 COIL LB-185 R5124 7030007220 S.RESISTOR ERA3YED 202V
L5303 6200001830 S.COIL NL 322522T-100J R5125 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)
L5304 6200003260 S.COIL NL 322522T-101J R5126 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ)
L5352 6200003100 S.COIL NL 322522T-3R9J-3 R5128 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)
L5521 6170000400 COIL LW-38 R5130 7030003460 S.RESISTOR ERJ3GEYJ 152 V (1.5 kΩ)
L5522 6170000400 COIL LW-38 R5131 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω)
L5523 6190001280 COIL E544GN-110248 R5132 7030003490 S.RESISTOR ERJ3GEYJ 272 V (2.7 kΩ)
L5552 6200003260 S.COIL NL 322522T-101J R5133 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)
L5602 6200003420 S.COIL NL 322522T-R15J-3 R5135 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ)
L5603 6200003430 S.COIL NL 322522T-R10J R5136 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
L5604 6200003430 S.COIL NL 322522T-R10J R5137 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)
L5881 6200001850 S.COIL NL 322522T-5R6J R5144 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)
L5882 6200001850 S.COIL NL 322522T-5R6J R5145 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)
L5883 6200001850 S.COIL NL 322522T-5R6J R5146 7030003430 S.RESISTOR ERJ3GEYJ 821 V (820 Ω)
R5281 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω)
R5021 7070000311 RESISTOR ERG1SJ 100 (10 Ω) R5309 7030003430 S.RESISTOR ERJ3GEYJ 821 V (820 Ω)
R5101 7030007200 S.RESISTOR ERA3YEB 202V R5602 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)
R5102 7030007200 S.RESISTOR ERA3YEB 202V R5603 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)
R5103 7030007200 S.RESISTOR ERA3YEB 202V R5604 7030003650 S.RESISTOR ERJ3GEYJ 563 V (56 kΩ)
R5106 7030007220 S.RESISTOR ERA3YED 202V R5607 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ)
R5107 7030007220 S.RESISTOR ERA3YED 202V R5608 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ)
R5108 7030007220 S.RESISTOR ERA3YED 202V R5609 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)
R5112 7030007220 S.RESISTOR ERA3YED 202V R5613 7030003650 S.RESISTOR ERJ3GEYJ 563 V (56 kΩ)
R5114 7030007210 S.RESISTOR ERA3YEB 102V R5701 7030007220 S.RESISTOR ERA3YED 202V
S.=Surface mount
5-9
REF ORDER REF ORDER
NO. NO. NO. NO.
R5704 7030007230 S.RESISTOR ERA3YED 102V C5021 4510004640 S.ELECTROLYTIC ECEV1CA470SP
R5705 7030007230 S.RESISTOR ERA3YED 102V C5022 4030011600 S.CERAMIC C1608 JB 1E 104K-T
R5707 7030007230 S.RESISTOR ERA3YED 102V C5024 4510007510 S.ELECTOR ECEV1AA470WR
R5708 7030007210 S.RESISTOR ERA3YEB 102V C5031 4510004640 S.ELECTROLYTIC ECEV1CA470SP
R5709 7030007210 S.RESISTOR ERA3YEB 102V C5032 4030011600 S.CERAMIC C1608 JB 1E 104K-T
R5710 7030007210 S.RESISTOR ERA3YEB 102V C5033 4030011600 S.CERAMIC C1608 JB 1E 104K-T
R5711 7030007220 S.RESISTOR ERA3YED 202V C5034 4510007510 S.ELECTOR ECEV1AA470WR
R5716 7030007220 S.RESISTOR ERA3YED 202V C5081 4030006880 S.CERAMIC C1608 JB 1H 472K-T
R5718 7030007200 S.RESISTOR ERA3YEB 202V C5083 4030006900 S.CERAMIC C1608 JB 1H 103K-T
R5720 7030007200 S.RESISTOR ERA3YEB 202V C5085 4030008680 S.CERAMIC C2012 JF 1C 105Z-T
R5721 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ) C5086 4030008680 S.CERAMIC C2012 JF 1C 105Z-T
R5722 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω) C5087 4030008680 S.CERAMIC C2012 JF 1C 105Z-T
R5782 7030007860 S.RESISTOR ERJ3GEYJ 8R2V C5089 4030006900 S.CERAMIC C1608 JB 1H 103K-T
R5802 7030007230 S.RESISTOR ERA3YED 102V C5101 4030007060 S.CERAMIC C1608 CH 1H 270J-T
R5803 7030007230 S.RESISTOR ERA3YED 102V C5102 4030007010 S.CERAMIC C1608 CH 1H 100D-T
R5804 7030007230 S.RESISTOR ERA3YED 102V C5103 4030006960 S.CERAMIC C1608 CH 1H 050C-T
R5810 7030007210 S.RESISTOR ERA3YEB 102V C5110 4510004630 S.ELECTROLYTIC ECEV1CA100SR
R5815 7030007220 S.RESISTOR ERA3YED 202V C5116 4510004640 S.ELECTROLYTIC ECEV1CA470SP
R5821 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ) C5123 4030006880 S.CERAMIC C1608 JB 1H 472K-T
R5881 7030000220 S.RESISTOR MCR10EZHJ 47 Ω (470) C5125 4030011600 S.CERAMIC C1608 JB 1E 104K-T
R5883 7030003450 S.RESISTOR ERJ3GEYJ 122 V (1.2 kΩ) C5201 4030006860 S.CERAMIC C1608 JB 1H 102K-T
R5884 7030000220 S.RESISTOR MCR10EZHJ 47 Ω (470) C5202 4030006860 S.CERAMIC C1608 JB 1H 102K-T
R5887 7030003450 S.RESISTOR ERJ3GEYJ 122 V (1.2 kΩ) C5205 4030007030 S.CERAMIC C1608 CH 1H 150J-T
R5888 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω) C5206 4030006910 S.CERAMIC C1608 CH 1H 0R5C-T
R5901 7030007220 S.RESISTOR ERA3YED 202V C5254 4510004630 S.ELECTROLYTIC ECEV1CA100SR
R5905 7030007230 S.RESISTOR ERA3YED 102V C5301 4550000730 S.TANTALUM TESVA 0J 225M1-8L
R5908 7030007210 S.RESISTOR ERA3YEB 102V C5304 4030011570 S.CERAMIC CM105 CH 101G 50AT
R5909 7030007210 S.RESISTOR ERA3YEB 102V C5305 4610001850 S.TRIMMER TZB4R200AB10R00
R5910 7030007210 S.RESISTOR ERA3YEB 102V (TZBX4R200BA110)
R5915 7030007220 S.RESISTOR ERA3YED 202V C5310 4030007010 S.CERAMIC C1608 CH 1H 100D-T
R5917 7030007220 S.RESISTOR ERA3YED 202V C5312 4510004630 S.ELECTROLYTIC ECEV1CA100SR
R5921 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ) C5351 4030006880 S.CERAMIC C1608 JB 1H 472K-T
C5354 4030010000 S.CERAMIC C1608 CH 1H 510J-T
C5355 4030006960 S.CERAMIC C1608 CH 1H 050C-T
S.=Surface mount
5 - 10
REF ORDER REF ORDER
NO. NO. NO. NO.
C5408 4550005980 S.TANTALUM TEMSVA 1A 475M-8L C5908 4510005600 S.ELECTROLYTIC ECEV1CS100SR
C5521 4610001830 S.TRIMMER TZB4S100AB10R00 (TZBX4N100BA110) C5909 4030006880 S.CERAMIC C1608 JB 1H 472K-T
C5526 4030009510 S.CERAMIC C1608 CH 1H 010B-T C5983 4030009520 S.CERAMIC C1608 CH 1H 020B-T
C5529 4030011340 S.CERAMIC C1608 CH 1H 471J-T C5985 4030009530 S.CERAMIC C1608 CH 1H 030B-T
C5551 4550005980 S.TANTALUM TEMSVA 1A 475M-8L C5986 4030009990 S.CERAMIC C1608 CH 1H 200J-T
C5552 4550003250 S.TANTALUM TEMSVA 1V 474M-8L
C5557 4030011600 S.CERAMIC C1608 JB 1E 104K-T RL5081 6330001640 RELAY ATX209
C5558 4510004590 ELECTROLYTIC 16 MV 470 HC
C5560 4510005430 S.ELECTROLYTIC ECEV0JA220SR
C5561 4030011340 S.CERAMIC C1608 CH 1H 471J-T J5001 6510022580 S.CONNECTOR 24FMN-BMTTR-A-TBT
C5601 4030006880 S.CERAMIC C1608 JB 1H 472K-T J5051 6510023120 CONNECTOR CD6109SA1J0 <CVI>
C5602 4030006860 S.CERAMIC C1608 JB 1H 102K-T J5071 6510021720 S.CONNECTOR 30FLT-SM1-TB
C5603 4030006880 S.CERAMIC C1608 JB 1H 472K-T J5081 6510023120 CONNECTOR CD6109SA1J0 <CVI>
C5604 4030006880 S.CERAMIC C1608 JB 1H 472K-T J5091 6510023040 CONNECTOR 01K1621
C5605 4030006880 S.CERAMIC C1608 JB 1H 472K-T J5201 6510007900 CONNECTOR TBP-P01X-A1 (B1)
C5610 4030011280 S.CERAMIC C1608 CH 1H 271J-T P5201 6510003240 CONNECTOR TMP-P01X-A1
C5615 4030006980 S.CERAMIC C1608 CH 1H 070D-T W5051 7030003860 S.JUMPER ERJ3GE JPW V
C5616 4030007040 S.CERAMIC C1608 CH 1H 180J-T W5052 7030003860 S.JUMPER ERJ3GE JPW V
C5617 4030006860 S.CERAMIC C1608 JB 1H 102K-T W5053 7030003860 S.JUMPER ERJ3GE JPW V
C5619 4030006930 S.CERAMIC C1608 CH 1H 020C-T W5081 7030003860 S.JUMPER ERJ3GE JPW V
C5702 4030006880 S.CERAMIC C1608 JB 1H 472K-T W5201 9009130046 WIRE 62/99/160/C24/C31
C5703 4030006880 S.CERAMIC C1608 JB 1H 472K-T W5202 9086700300 WIRE 08
C5708 4510005600 S.ELECTROLYTIC ECEV1CS100SR W5409 7030003860 S.JUMPER ERJ3GE JPW V
C5711 4030007010 S.CERAMIC C1608 CH 1H 100D-T W5602 9086700300 WIRE 08
C5782 4030009490 S.CERAMIC C1608 JB 1H 821K-T W5802 9086700300 WIRE 08
C5794 4030008920 S.CERAMIC C1608 JB 1H 473K-T WS1 8970024010 CABLE SX2429 1.5D COAXIAL TUBE (3)/PL
C5803 4030006880 S.CERAMIC C1608 JB 1H 472K-T EP5001 0910054683 PCB B 5723C
C5808 4510005600 S.ELECTROLYTIC ECEV1CS100SR
C5811 4030007010 S.CERAMIC C1608 CH 1H 100D-T
C5886 4030009500 S.CERAMIC C1608 CH 1H 0R5B-T
C5888 4030009510 S.CERAMIC C1608 CH 1H 010B-T
C5889 4030011770 S.CERAMIC C1608 CH 1H 060B-T
S.=Surface mount
5 - 11
[PA UNIT] [PA UNIT]
REF ORDER REF ORDER
NO. NO. NO. NO.
IC6501 1110005450 S.IC TS522IDT R6509 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω)
IC6601 1180001250 S.IC TA7808F (TE16L) R6510 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)
R6511 7030006111 S.RESISTOR ERA3YED 752V
R6512 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
Q6101 1560001020 S.FET 2SK2973 (MTS101P) R6513 7030003740 S.RESISTOR ERJ3GEYJ 334 V (330 kΩ)
Q6401 1590003040 TRANSISTOR SD1487 R6514 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ)
Q6402 1590003040 TRANSISTOR SD1487 R6515 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ)
Q6403 1540000500 TRANSISTOR 2SD1585K R6517 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ)
Q6501 1540000550 S.TRANSISTOR 2SD1664 T100Q R6602 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ)
Q6601 1510001040 S.TRANSISTOR 2SA1037AKT146S R6603 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ)
Q6602 1590000680 S.TRANSISTOR DTC114EUA T106 R6604 7030003580 S.RESISTOR ERJ3GEYJ 153 V (15 kΩ)
Q6701 1590000680 S.TRANSISTOR DTC114EUA T106 R6651 7100000810 S.RESISTOR ERX5WQK 12MH
Q6801 1590003050 S.FET PD55003 R6652 7100000810 S.RESISTOR ERX5WQK 12MH
R6704 7030003470 S.RESISTOR ERJ3GEYJ 182 V (1.8 kΩ)
D6601 1710001160 S.DIODE DF40SC4-4072 R6705 7510001550 S.THERMISTOR NTCG16 4LH 333KT
D6701 1160000140 S.DIODE DAP222 TL R6801 7030003410 S.RESISTOR ERJ3GEYJ 561 V (560 Ω)
D6702 1730000480 S.ZENER RD10M-T2B3 R6802 7030004050 S.RESISTOR ERJ3GEYJ 1R0 V (1 Ω)
L6101 6200003840 S.COIL MLF2012D R22K-T C6101 4030007120 S.CERAMIC C1608 CH 1H 820J-T
L6102 6180000990 COIL LAL 04NA 101K C6102 4030007120 S.CERAMIC C1608 CH 1H 820J-T
L6202 6180001240 COIL LAL 04NA 820K C6103 4030011600 S.CERAMIC C1608 JB 1E 104K-T
L6204 2040000490 COIL EXC-ELDR25C C6104 4030011600 S.CERAMIC C1608 JB 1E 104K-T
L6301 6140003720 COIL LR-416 <KN> C6105 4030011600 S.CERAMIC C1608 JB 1E 104K-T
L6404 6140003590 COIL LR-400 C6202 4030011600 S.CERAMIC C1608 JB 1E 104K-T
L6405 6140003350 COIL LR-376 C6203 4030004750 S.CERAMIC C2012 JB 1H 103K-T
L6406 6140002030 COIL LR-230 (SK-10M-15Y 120) C6205 4030008700 S.CERAMIC GRM21BB11H473KA01L (GRM40 B)
L6407 2040000490 COIL EXC-ELDR25C C6206 4030008700 S.CERAMIC GRM21BB11H473KA01L (GRM40 B)
L6501 6200003260 S.COIL NL 322522T-101J C6301 4030008960 S.CERAMIC C2012 JB 1C 104K-T
L6701 6200003590 S.COIL EXCCL3225U1 C6302 4030011600 S.CERAMIC C1608 JB 1E 104K-T
L6702 6200002040 S.COIL NL 252018T-101J C6303 4510004590 ELECTROLYTIC 16 MV 470 HC
L6703 6200003260 S.COIL NL 322522T-101J C6305 4030011600 S.CERAMIC C1608 JB 1E 104K-T
L6705 6200008820 S.COIL HF70ACC 635050-T C6307 4320000811 DIP MICA KD20C 681J5A
L6706 6200008820 S.COIL HF70ACC 635050-T C6308 4030011790 S.CERAMIC GRM55RF52A684ZD01L (GRM44-1 Y5V)
C6401 4030011760 S.CERAMIC GRM55R1X2D682JV01L (GRM44-1 SL)
C6403 4030011760 S.CERAMIC GRM55R1X2D682JV01L (GRM44-1 SL)
R6101 7030003270 S.RESISTOR ERJ3GEYJ 390 V (39 Ω) C6408 4030016740 S.CERAMIC ERE22X6C1H102JD01L (GRH111 CH)
R6102 7030003350 S.RESISTOR ERJ3GEYJ 181 V (180 Ω) C6409 4030016740 S.CERAMIC ERE22X6C1H102JD01L (GRH111 CH)
R6103 7030003350 S.RESISTOR ERJ3GEYJ 181 V (180 Ω) C6410 4030017140 S.CERAMIC GRH111 CH 221J 200PT
R6104 7030003300 S.RESISTOR ERJ3GEYJ 680 V (68 Ω) C6412 4510004600 ELECTROLYTIC 16 MV 1000 HC
R6105 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ) C6413 4510004600 ELECTROLYTIC 16 MV 1000 HC
R6107 7030003420 S.RESISTOR ERJ3GEYJ 681 V (680 Ω) C6415 4030011790 S.CERAMIC GRM55RF52A684ZD01L (GRM44-1 Y5V)
R6110 7030000210 S.RESISTOR MCR10EZHJ 39 Ω (390) C6417 4510004600 ELECTROLYTIC 16 MV 1000 HC
R6201 7030000250 S.RESISTOR MCR10EZHJ 82 Ω (820) C6424 4030016740 S.CERAMIC ERE22X6C1H102JD01L (GRH111 CH)
R6202 7030003510 S.RESISTOR ERJ3GEYJ 392 V (3.9 kΩ) C6425 4320000681 DIP MICA KD19C 681J5A
R6203 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ) C6427 4030011600 S.CERAMIC C1608 JB 1E 104K-T
R6204 7030010800 S.RESISTOR ERJ1TYJ 2R7U (2.7 Ω) C6428 4030011600 S.CERAMIC C1608 JB 1E 104K-T
R6206 7030000340 S.RESISTOR MCR10EZHJ 470 Ω (471) C6429 4030016740 S.CERAMIC ERE22X6C1H102JD01L (GRH111 CH)
R6301 7030000260 S.RESISTOR MCR10EZHJ 100 Ω (101) C6432 4030011740 S.CERAMIC GRM32N2C2H201JV01L (GRM42-2 CH)
R6302 7030003480 S.RESISTOR ERJ3GEYJ 222 V (2.2 kΩ) C6433 4030011740 S.CERAMIC GRM32N2C2H201JV01L (GRM42-2 CH)
R6304 7310004730 TRIMMER EVM-2AGA00 B33 (302) C6503 4030011600 S.CERAMIC C1608 JB 1E 104K-T
R6401 7030010260 S.RESISTOR ERJ1TYJ 3R3 U C6506 4030011600 S.CERAMIC C1608 JB 1E 104K-T
R6402 7030010260 S.RESISTOR ERJ1TYJ 3R3 U C6507 4510004590 ELECTROLYTIC 16 MV 470 HC
R6403 7030010260 S.RESISTOR ERJ1TYJ 3R3 U C6602 4030006880 S.CERAMIC C1608 JB 1H 472K-T
R6404 7030010260 S.RESISTOR ERJ1TYJ 3R3 U C6603 4510004590 ELECTROLYTIC 16 MV 470 HC
R6405 7030010260 S.RESISTOR ERJ1TYJ 3R3 U C6604 4510006230 S.ELECTROLYTIC ECEV1EA470UP
R6406 7030010260 S.RESISTOR ERJ1TYJ 3R3 U C6605 4030011600 S.CERAMIC C1608 JB 1E 104K-T
R6407 7030001010 S.RESISTOR MCR50JZHJ 10 Ω (100) C6606 4030011600 S.CERAMIC C1608 JB 1E 104K-T
R6408 7030001010 S.RESISTOR MCR50JZHJ 10 Ω (100) C6607 4510006230 S.ELECTROLYTIC ECEV1EA470UP
R6409 7070000371 RESISTOR ERX2SJ 2R2 (2.2 Ω) C6608 4030008700 S.CERAMIC GRM21BB11H473KA01L (GRM40 B)
R6410 7070000371 RESISTOR ERX2SJ 2R2 (2.2 Ω) C6609 4510006020 ELECTROLYTIC 16 MV 2200 HC
R6411 7070000521 RESISTOR ERX3SJ 2R7 (2.7 Ω) C6610 4030017320 S.CERAMIC GRM21BB11H104KA11L (GRM40-034)
R6412 7310004710 TRIMMER EVM-2AGA00 B23 (202) C6611 4030004740 S.CERAMIC C2012 JB 1H 472K-T
R6415 7070001030 RESISTOR ERG5SJ 470 C6701 4030008920 S.CERAMIC C1608 JB 1H 473K-T
R6504 7030005971 S.RESISTOR ERA3YKD 683V (68 kΩ) C6704 4030006880 S.CERAMIC C1608 JB 1H 472K-T
R6505 7030005971 S.RESISTOR ERA3YKD 683V (68 kΩ) C6705 4030006880 S.CERAMIC C1608 JB 1H 472K-T
R6507 7030003840 S.RESISTOR ERJ3GEYJ 225 V (2.2 MΩ) C6707 4030006880 S.CERAMIC C1608 JB 1H 472K-T
S.=Surface mount
5 - 12
[PA UNIT] [FILTER UNIT]
REF ORDER REF ORDER
NO. NO. NO. NO.
C6708 4030006880 S.CERAMIC C1608 JB 1H 472K-T L7215 6200005010 S.COIL NL 252018T-100J
C6801 4030011600 S.CERAMIC C1608 JB 1E 104K-T L7216 6140002290 COIL LR-242 (T68-10)
L7217 6140002290 COIL LR-242 (T68-10)
L7218 6140002290 COIL LR-242 (T68-10)
RL6701 6330001470 RELAY AJS1311 L7241 6200005010 S.COIL NL 252018T-100J
L7244 6200005010 S.COIL NL 252018T-100J
L7245 6140002330 COIL LR-262 (T68-6)
J6301 6510021530 CONNECTOR IMSA-9230B-1-04Z024-T L7246 6140002330 COIL LR-262 (T68-6)
J6302 6510021530 CONNECTOR IMSA-9230B-1-04Z024-T L7248 6140002330 COIL LR-262 (T68-6)
J6401 6510007020 CONNECTOR TMP-J01X-V6 L7271 6200002040 S.COIL NL 252018T-101J
J6411 6510021390 CONNECTOR IMSA-9230B-1-03Z024-T L7272 6140003490 COIL LR-391
J6412 6510021390 CONNECTOR IMSA-9230B-1-03Z024-T L7273 6200002040 S.COIL NL 252018T-101J
J6501 6510003390 CONNECTOR B03B-EH-S L7321 6140001460 COIL LR-170
J6701 6510022540 S.CONNECTOR 20FMN-BMTTR-A-TBT L7331 6200002040 S.COIL NL 252018T-101J
J6702 6510007020 CONNECTOR TMP-J01X-V6 L7332 6200002040 S.COIL NL 252018T-101J
J6703 6510003400 CONNECTOR B04B-EH-S

F6701 5210000060 FUSE FGB 5A R7272 7030003490 S.RESISTOR ERJ3GEYJ 272 V (2.7 kΩ)
F6702 5220000230 HOLDER S-N5054 R7273 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ)
F6703 5220000230 HOLDER S-N5054 R7274 7030008190 S.RESISTOR ERJ12YJ330U (33 Ω)
W6401 9054500690 WIRE 76/98/020/X98/X98 R7277 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ)
W6402 9054500690 WIRE 76/98/020/X98/X98 R7301 7030003200 S.RESISTOR ERJ3GEYJ 100 V (10 Ω)
W6601 9045201001 WIRE 74/98/040/X98/X98 R7314 7540000230 ABSORBER SA05 401N
W6701 7030008240 S.JUMPER ERJ12YJ0R00U R7315 7030010650 S.RESISTOR ERJ12YJ823U (82 kΩ)
EP6001 0910054694 PCB B 5724D C7031 4510005480 ELECTROLYTIC 50 MV 1 HC

EP6601 6910000630 BEAD FSRH070140RN000B (FSOH070RN) C7032 4030011600 S.CERAMIC C1608 JB 1E 104K-T
EP6602 6510018330 TERMINAL F4053A C7033 4320000651 DIP MICA KD20C 102J5A
EP6603 6510018330 TERMINAL F4053A C7034 4010006410 CERAMIC HM13SJ SL 471J 500V
C7035 4010006410 CERAMIC HM13SJ SL 471J 500V
C7036 4320000981 DIP MICA KD20C 222J5A
C7039 4320000951 DIP MICA KD20C 272J5A
C7041 4030011120 S.CERAMIC GRM31M2C2H100JV01L (GRM42-6 CH)
[FILTER UNIT] C7042 4010005930 CERAMIC HM11SJ SL 391J 500V
REF ORDER C7043 4010005930 CERAMIC HM11SJ SL 391J 500V
DESCRIPTION C7044 4010005930 CERAMIC HM11SJ SL 391J 500V
NO. NO.
Q7301 1590000680 S.TRANSISTOR DTC114EUA T106 C7046 4030011600 S.CERAMIC C1608 JB 1E 104K-T
D7271 1750000190 S.DIODE 1SS322 (TE85R) C7062 4030011600 S.CERAMIC C1608 JB 1E 104K-T
D7272 1750000190 S.DIODE 1SS322 (TE85R) C7063 4030011730 S.CERAMIC GRM31M2C2H101JV01L (GRM42-6 CH)
D7301 1750000550 S.DIODE 1SS355 TE-17 C7064 4010006410 CERAMIC HM13SJ SL 471J 500V
L7031 6200002040 S.COIL NL 252018T-101J C7067 4010005880 CERAMIC HM95SJ SL 271J 500V
L7036 6140002240 COIL LR-236 (T68-2) C7069 4010005880 CERAMIC HM95SJ SL 271J 500V
L7037 6140001990 COIL LR-226 (T68-2) C7070 4030011730 S.CERAMIC GRM31M2C2H101JV01L (GRM42-6 CH)
L7127 6140002340 COIL LR-263 (T68-2) C7085 4030011600 S.CERAMIC C1608 JB 1E 104K-T
L7151 6200005050 S.COIL NL 252018T-330J C7087 4030012480 S.CERAMIC GRM31M2C2H121JV01L (GRM42-6 CH)
L7156 6140002280 COIL LR-241 (T68-6) C7092 4030006880 S.CERAMIC C1608 JB 1H 472K-T
L7211 6200005010 S.COIL NL 252018T-100J C7102 4030006880 S.CERAMIC C1608 JB 1H 472K-T
S.=Surface mount
5 - 13
[FILTER UNIT] [FILTER UNIT]
REF ORDER REF ORDER
NO. NO. NO. NO.
C7105 4010006410 CERAMIC HM13SJ SL 471J 500V RL7092 6330001570 RELAY AJS1315
C7121 4510005480 ELECTROLYTIC 50 MV 1 HC RL7151 6330001570 RELAY AJS1315
C7122 4030006880 S.CERAMIC C1608 JB 1H 472K-T RL7152 6330001570 RELAY AJS1315
C7124 4030012480 S.CERAMIC GRM31M2C2H121JV01L (GRM42-6 CH) RL7181 6330001570 RELAY AJS1315
C7130 4030011510 S.CERAMIC GRM31M2C2H560JV01L (GRM42-6 CH) RL7301 6330000780 RELAY AGP 2013 (DSP1-DC12V)
C7131 4030011070 S.CERAMIC GRM31M2C2H5R0CY21L (GRM42-6 CH)
C7133 4030006880 S.CERAMIC C1608 JB 1H 472K-T CP7331 6910009670 S.CHECK P HK3-S-T
C7136 4010005850 CERAMIC HM95SJ SL 181J 500V CP7332 6910009670 S.CHECK P HK3-S-T
C7153 4030014460 S.CERAMIC GRM31M2C2H820JV01L (GRM42-6 CH) J7311 6510007020 CONNECTOR TMP-J01X-V6
C7154 4010005930 CERAMIC HM11SJ SL 391J 500V J7321 6510007900 CONNECTOR TBP-P01X-A1 (B1)
C7155 4030012480 S.CERAMIC GRM31M2C2H121JV01L (GRM42-6 CH) J7331 6510022560 CONNECTOR 16FMN-BTRK-A
C7158 4030014460 S.CERAMIC GRM31M2C2H820JV01L (GRM42-6 CH) P7001 6510003240 CONNECTOR TMP-P01X-A1
C7160 4030006880 S.CERAMIC C1608 JB 1H 472K-T P7321 6510003240 CONNECTOR TMP-P01X-A1
C7183 4030012480 S.CERAMIC GRM31M2C2H121JV01L (GRM42-6 CH) W7002 9086700300 WIRE 08
C7184 4030012480 S.CERAMIC GRM31M2C2H121JV01L (GRM42-6 CH) W7321 9012961790 WIRE 62/99/280/C31/C24
C7185 4010005880 CERAMIC HM95SJ SL 271J 500V W7322 9086700300 WIRE 08
C7186 4030011510 S.CERAMIC GRM31M2C2H560JV01L (GRM42-6 CH) W7333 7030003860 S.JUMPER ERJ3GE JPW V
C7187 4010005370 CERAMIC HM11SJ SL 331J 500V W7334 7030003860 S.JUMPER ERJ3GE JPW V
C7193 4010005850 CERAMIC HM95SJ SL 181J 500V W7337 7030003860 S.JUMPER ERJ3GE JPW V
C7211 4510005480 ELECTROLYTIC 50 MV 1 HC W7338 7030003860 S.JUMPER ERJ3GE JPW V
C7218 4030006880 S.CERAMIC C1608 JB 1H 472K-T WS1 8970024020 CABLE SX2429 1.5D COAXIAL TUBE (2)/FI
C7223 4030014460 S.CERAMIC GRM31M2C2H820JV01L (GRM42-6 CH) EP7001 0910054704 PCB B 5725D
C7245 4030011070 S.CERAMIC GRM31M2C2H5R0CY21L (GRM42-6 CH) [DRIVER UNIT]
C7247 4030011180 S.CERAMIC GRM31M2C2H220JV01L (GRM42-6 CH) REF ORDER
C7248 4030011210 S.CERAMIC GRM31M2C2H330JV01L (GRM42-6 CH) DESCRIPTION
NO. NO.
C7250 4030006880 S.CERAMIC C1608 JB 1H 472K-T Q6851 1590003060 S.FET PD55015S
C7272 4030006870 S.CERAMIC C1608 JB 1H 222K-T R6851 7030010520 S.RESISTOR ERJ1TYJ 101U (100 Ω)
C7274 4030006870 S.CERAMIC C1608 JB 1H 222K-T R6852 7030000020 S.RESISTOR MCR10EZHJ 1 Ω (010)
C7275 4610002230 TRIMMER TZB4Z100DB10B00 (TZBX4Z100BD110)
C7302 4030006880 S.CERAMIC C1608 JB 1H 472K-T EP6851 0910054751 PCB B 5744A
C7325 4030011790 S.CERAMIC GRM55RF52A684ZD01L (GRM44-1 Y5V)
RL7031 6330001570 RELAY AJS1315

RL7032 6330001570 RELAY AJS1315
RL7061 6330001570 RELAY AJS1315
RL7062 6330001570 RELAY AJS1315
RL7091 6330001570 RELAY AJS1315
S.=Surface mount
5 - 14
EX-2432
[VARISTOR-1 BOARD] [DSP UNIT]
REF ORDER REF ORDER
NO. NO. NO. NO.
D6431 1790001760 S.VARISTOR MA30-(TX) IC1 1130010010 S.IC TC7WHU04FU
IC3 1130010540 S.IC SN74AHC74PWR
IC4 1130010540 S.IC SN74AHC74PWR
C6431 4030008920 S.CERAMIC C1608 JB 1H 473K-T IC51 1130010010 S.IC TC7WHU04FU
IC101 1130010520 S.IC SN74HCT244APWR
IC102 1110004770 S.IC BU9480F-E2
EP6431 0910054761 PCB B 5746A IC152 1180002320 S.REG TK11218CMCL
IC161 1180002020 S.REG BA033FP-E2
IC171 1180002270 S.REG TK11250CMCL
IC201 1130010680 S.IC M29W102BB-70N1
IC202 1130008040 S.IC TC7SH04FU
IC203 1130008810 S.IC TC7SH32FU (TE85L)
IC301 1140010330 S.IC TMS320VC33PGEA120
[VARISTOR-2 BOARD] IC401 1130010550 S.IC SN74AHC595PWR
REF ORDER IC403 1130010530 S.IC SN74AHCT374PWR
DESCRIPTION IC404 1130010530 S.IC SN74AHCT374PWR
NO. NO.
IC405 1130004670 S.IC BU4021BF-T1
D6432 1790001760 S.VARISTOR MA30-(TX) IC406 1130010540 S.IC SN74AHC74PWR
IC501 1190001610 S.IC AK4528-VF
IC601 1110005420 S.IC BA15532F-E2
C6432 4030008920 S.CERAMIC C1608 JB 1H 473K-T IC651 1110005420 S.IC BA15532F-E2
IC701 1110001900 S.IC µPC4570G2-T1
IC801 1130010560 S.IC SN74AHC244PWR
EP6432 0910054771 PCB B 5747A
Q201 1590001660 S.TRANSISTOR XP4312 (TX)

D301 1750000370 S.DIODE DA221 TL

D302 1750000370 S.DIODE DA221 TL
D303 1750000370 S.DIODE DA221 TL
D304 1750000370 S.DIODE DA221 TL
D901 1790000970 S.DIODE MA729 (TX)
X1 6050009860 S.XTAL CR-566 (12.288 MHz)

X51 6050011270 S.XTAL CR-709 (60.000 MHz)
L1 6200003280 S.COIL NL 252018T-2R2J

L2 6200003280 S.COIL NL 252018T-2R2J
L3 6200003280 S.COIL NL 252018T-2R2J
L51 6200003280 S.COIL NL 252018T-2R2J
L52 6200001980 S.COIL NL 252018T-1R0J
L101 6200003280 S.COIL NL 252018T-2R2J
L102 6200003280 S.COIL NL 252018T-2R2J
L301 6200003280 S.COIL NL 252018T-2R2J
L302 6200009840 S.COIL LQH 3C 2R2M 34
L401 6200003280 S.COIL NL 252018T-2R2J
L403 6200003280 S.COIL NL 252018T-2R2J
L404 6200003280 S.COIL NL 252018T-2R2J
L405 6200003280 S.COIL NL 252018T-2R2J
L406 6200003280 S.COIL NL 252018T-2R2J
L501 6200003280 S.COIL NL 252018T-2R2J
L502 6200003280 S.COIL NL 252018T-2R2J
L601 6200002040 S.COIL NL 252018T-101J
L651 6200002040 S.COIL NL 252018T-101J
L701 6200002040 S.COIL NL 252018T-101J
L801 6200003280 S.COIL NL 252018T-2R2J
R1 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ)

R51 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ)
R151 7030007240 S.RESISTOR ERJ12YJ680U (68 Ω)
S.=Surface mount
5 - 15
[DSP UNIT] [DSP UNIT]
REF ORDER REF ORDER
NO. NO. NO. NO.
R310 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) C102 4510004630 S.ELECTROLYTIC ECEV1CA100SR
R320 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ) C157 4510004630 S.ELECTROLYTIC ECEV1CA100SR
R321 7030003520 S.RESISTOR ERJ3GEYJ 472 V (4.7 kΩ) C158 4550006080 S.TANTALUM TEMSVB2 1C 106M-8L
R322 7030003280 S.RESISTOR ERJ3GEYJ 470 V (47 Ω) C161 4550006620 S.TANTALUM ECST0JY226R
R501 7030004040 S.RESISTOR ERJ3GEYJ 4R7 V (4.7 Ω) C203 4030011600 S.CERAMIC C1608 JB 1E 104K-T
R754 7030003540 S.RESISTOR ERJ3GEYJ 682 V (6.8 kΩ) C504 4510005860 S.ELECTROLYTIC ECEV1HA2R2SR
R756 7030003540 S.RESISTOR ERJ3GEYJ 682 V (6.8 kΩ) C506 4550006620 S.TANTALUM ECST0JY226R
R802 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) C510 4550006620 S.TANTALUM ECST0JY226R
R904 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ) C606 4510005830 S.ELECTROLYTIC ECEV1HAN010R
C1 4030006880 S.CERAMIC C1608 JB 1H 472K-T C655 4510005830 S.ELECTROLYTIC ECEV1HAN010R
C6 4030007090 S.CERAMIC C1608 CH 1H 470J-T C704 4510004630 S.ELECTROLYTIC ECEV1CA100SR
C9 4030006960 S.CERAMIC C1608 CH 1H 050C-T C707 4510006220 S.ELECTROLYTIC ECEV1CA101UP
C52 4030009920 S.CERAMIC C1608 CH 1H 050B-T C751 4030011280 S.CERAMIC C1608 CH 1H 271J-T
C53 4030009920 S.CERAMIC C1608 CH 1H 050B-T C752 4030007130 S.CERAMIC C1608 CH 1H 101J-T
S.=Surface mount
5 - 16
RC-25
[DSP UNIT] [FRONT UNIT]
REF ORDER REF ORDER
NO. NO. NO. NO.
C757 4510006220 S.ELECTROLYTIC ECEV1CA101UP W8001 8900009531 CABLE OPC-942A (P=1 N=10 L=170)
C758 4510004630 S.ELECTROLYTIC ECEV1CA100SR W8005 8900008860 CABLE OPC-875 (N:20 L:70)
C901 4030006960 S.CERAMIC C1608 CH 1H 050C-T
J901 6910013900 CONNECTOR IMSA-9180S-22A

J902 6910012460 CONNECTOR IMSA-9180S-30A [DISPLAY UNIT]
REF ORDER DESCRIPTION
NO. NO.
W2 7030008240 S.JUMPER ERJ12YJ0R00U IC8201 1140010240 S.IC HD64F2134AFA20 (EX-2545A)
W3 7030003860 S.JUMPER ERJ3GE JPW V IC8202 1130005770 S.IC S-80942CNMC-G9C
W4 7030008240 S.JUMPER ERJ12YJ0R00U IC8250 1130005720 S.IC TC7W04F (TE12L)
W5 7030003860 S.JUMPER ERJ3GE JPW V IC8260 1130007350 S.IC TC74HC4066AF
W151 7030008240 S.JUMPER ERJ12YJ0R00U IC8270 1110001810 S.IC TA7368F (TP1)
W152 7030003860 S.JUMPER ERJ3GE JPW V IC8280 1110002700 S.IC NJM2904M-T1
W171 7030008240 S.JUMPER ERJ12YJ0R00U IC8290 1180001070 S.IC TA7805F (TE16L)
W201 7030003860 S.JUMPER ERJ3GE JPW V IC8301 1110005580 S.IC AN8010M-(E1)
W202 7030003860 S.JUMPER ERJ3GE JPW V IC8310 1180001250 S.IC TA7808F (TE16L)
W303 7030003860 S.JUMPER ERJ3GE JPW V Q8251 1590001650 S.TRANSISTOR XP4601 (TX)
W308 7030003860 S.JUMPER ERJ3GE JPW V Q8260 1590000680 S.TRANSISTOR DTC114EUA T106
W309 7030003860 S.JUMPER ERJ3GE JPW V Q8280 1530002850 S.TRANSISTOR 2SC4116-BL (TE85R)
W311 7030003860 S.JUMPER ERJ3GE JPW V Q8282 1590000680 S.TRANSISTOR DTC114EUA T106
W312 7030003860 S.JUMPER ERJ3GE JPW V Q8300 1540000440 S.TRANSISTOR 2SD1619-T-TD
W501 7030003860 S.JUMPER ERJ3GE JPW V Q8301 1540000440 S.TRANSISTOR 2SD1619-T-TD
W505 7030008240 S.JUMPER ERJ12YJ0R00U Q8343 1530002850 S.TRANSISTOR 2SC4116-BL (TE85R)
W902 7030008240 S.JUMPER ERJ12YJ0R00U Q8345 1530002850 S.TRANSISTOR 2SC4116-BL (TE85R)
W952 7030003860 S.JUMPER ERJ3GE JPW V D8201 1750000370 S.DIODE DA221 TL
D8203 1750000370 S.DIODE DA221 TL
D8204 1750000550 S.DIODE 1SS355 TE-17
EP1 0910054518 PCB B 5666H D8205 1750000550 S.DIODE 1SS355 TE-17
EP2 6910012350 S.BEAD MMZ1608Y 102BT D8250 1750000550 S.DIODE 1SS355 TE-17
D8280 1750000370 S.DIODE DA221 TL
D8701 1750000550 S.DIODE 1SS355 TE-17
X8211 6050010501 S.XTAL CR-636A (14.7456 MHz)
L8201 6200001830 S.COIL NL 322522T-100J

L8202 6200005010 S.COIL NL 252018T-100J
L8203 6200005010 S.COIL NL 252018T-100J
L8206 6200003950 S.COIL HF50ACC 322513-T
L8270 6200003260 S.COIL NL 322522T-101J
L8286 6200005010 S.COIL NL 252018T-100J
L8290 6200003950 S.COIL HF50ACC 322513-T
L8701 6200001830 S.COIL NL 322522T-100J

S.=Surface mount
5 - 17
[DISPLAY UNIT] [DISPLAY UNIT]
REF ORDER REF ORDER
NO. NO. NO. NO.
R8231 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) C8220 4030017480 S.CERAMIC C1608 JB 1A 474K-T
R8236 7030003320 S.RESISTOR ERJ3GEYJ 101 V (100 Ω) C8241 4510005310 S.ELECTROLYTIC ECEV1CA220SR
R8239 7030003440 S.RESISTOR ERJ3GEYJ 102 V (1 kΩ) C8243 4510004640 S.ELECTROLYTIC ECEV1CA470SP
R8246 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) C8261 4510007110 S.ELECTROLYTIC ECEV1CA220NP
R8247 7030003240 S.RESISTOR ERJ3GEYJ 220 V (22 Ω) C8270 4510006220 S.ELECTROLYTIC ECEV1CA101UP
R8251 7030003590 S.RESISTOR ERJ3GEYJ 183 V (18 kΩ) C8274 4510007120 S.ELECTROLYTIC ECEV1AA101SP
R8252 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) C8277 4510006220 S.ELECTROLYTIC ECEV1CA101UP
R8253 7030003540 S.RESISTOR ERJ3GEYJ 682 V (6.8 kΩ) C8280 4510005310 S.ELECTROLYTIC ECEV1CA220SR
R8263 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ) C8284 4510005860 S.ELECTROLYTIC ECEV1HA2R2SR
R8270 7030003420 S.RESISTOR ERJ3GEYJ 681 V (680 Ω) C8285 4510004630 S.ELECTROLYTIC ECEV1CA100SR
R8275 7030003500 S.RESISTOR ERJ3GEYJ 332 V (3.3 kΩ) C8287 4510004650 S.ELECTROLYTIC ECEV1EA4R7SR
R8290 7030006060 S.RESISTOR ERJ12YJ100U (10 Ω) C8301 4510004640 S.ELECTROLYTIC ECEV1CA470SP
R8301 7030006220 S.RESISTOR ERJ12YJ470U (47 Ω) C8304 4510004640 S.ELECTROLYTIC ECEV1CA470SP
R8302 7030003510 S.RESISTOR ERJ3GEYJ 392 V (3.9 kΩ) C8310 4510004640 S.ELECTROLYTIC ECEV1CA470SP
R8303 7030006220 S.RESISTOR ERJ12YJ470U (47 Ω) C8311 4030006880 S.CERAMIC C1608 JB 1H 472K-T
R8341 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω) C8313 4510004640 S.ELECTROLYTIC ECEV1CA470SP
R8345 7030003400 S.RESISTOR ERJ3GEYJ 471 V (470 Ω) J8205 6510022540 S.CONNECTOR 20FMN-BMTTR-A-TBT
R8346 7030003650 S.RESISTOR ERJ3GEYJ 563 V (56 kΩ) J8701 6510022440 CONNECTOR LTW-8MP-C
R8347 7030003390 S.RESISTOR ERJ3GEYJ 391 V (390 Ω) J8702 6450001630 CONNECTOR HSJ1406-01-050
R8348 7030003660 S.RESISTOR ERJ3GEYJ 683 V (68 kΩ) J8902 6510022620 S.CONNECTOR 10FMN-BMTTR-A-TBT
R8349 7030003380 S.RESISTOR ERJ3GEYJ 331 V (330 Ω) J8903 6510022620 S.CONNECTOR 10FMN-BMTTR-A-TBT
R8352 7030003680 S.RESISTOR ERJ3GEYJ 104 V (100 kΩ) DS8300 5040002600 LED TLYU1002
R8373 7030003420 S.RESISTOR ERJ3GEYJ 681 V (680 Ω) DS8301 5040002600 LED TLYU1002
R8705 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ) DS8306 5040002600 LED TLYU1002
R8708 7510001560 S.THERMISTOR NTCG16 4BH 102KT DS8309 5040002600 LED TLYU1002
DS8310 5040002600 LED TLYU1002
DS8311 5040002600 LED TLYU1002
C8201 4030011600 S.CERAMIC C1608 JB 1E 104K-T DS8312 5040002600 LED TLYU1002
C8202 4510006220 S.ELECTROLYTIC ECEV1CA101UP DS8313 5040002600 LED TLYU1002
C8205 4030006900 S.CERAMIC C1608 JB 1H 103K-T DS8316 5040002600 LED TLYU1002
C8206 4030007020 S.CERAMIC C1608 CH 1H 120J-T DS8317 5040002600 LED TLYU1002
C8207 4030007020 S.CERAMIC C1608 CH 1H 120J-T DS8318 5040002600 LED TLYU1002
C8209 4030006900 S.CERAMIC C1608 JB 1H 103K-T DS8320 5040002600 LED TLYU1002
S.=Surface mount
5 - 18
[DISPLAY UNIT] [VR UNIT]
REF ORDER REF ORDER
NO. NO. NO. NO.
DS8321 5040002600 LED TLYU1002 R8901 7210002360 VARIABLE TP96N97-15F-10KB-1301
DS8322 5040002600 LED TLYU1002
DS8323 5040002600 LED TLYU1002
DS8340 5040002310 S.LED SML-311YTT86 EP8901 0910054742 PCB B 5730B
DS8341 5040002310 S.LED SML-311YTT86
DS8342 5040002310 S.LED SML-311YTT86
DS8343 5040002310 S.LED SML-311YTT86
DS8344 5040002310 S.LED SML-311YTT86
DS8345 5040002310 S.LED SML-311YTT86
DS8346 5040002310 S.LED SML-311YTT86
DS8347 5040002310 S.LED SML-311YTT86 [CONNECT UNIT]
DS8348 5040002310 S.LED SML-311YTT86 REF ORDER
DS8349 5040002310 S.LED SML-311YTT86 DESCRIPTION
NO. NO.
DS8350 5040002310 S.LED SML-311YTT86
IC8240 1140010010 S.IC HD66421TBOL
W8201 7030000010 S.JUMPER MCR10EZHJ JPW (000)

W8202 7030000010 S.JUMPER MCR10EZHJ JPW (000) L8220 6200001830 S.COIL NL 322522T-100J
W8238 7030003860 S.JUMPER ERJ3GE JPW V L8221 6200001830 S.COIL NL 322522T-100J
W8271 7030003860 S.JUMPER ERJ3GE JPW V R8241 7030003830 S.RESISTOR ERJ3GEYJ 185 V (1.8 MΩ)
W8280 7030003860 S.JUMPER ERJ3GE JPW V R8242 7030003840 S.RESISTOR ERJ3GEYJ 225 V (2.2 MΩ)
W8281 7030003860 S.JUMPER ERJ3GE JPW V R8243 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)
R8246 7030003830 S.RESISTOR ERJ3GEYJ 185 V (1.8 MΩ)
EP8201 0910054714 PCB B 5727D

EP8205 6910012350 S.BEAD MMZ1608Y 102BT C8230 4030011600 S.CERAMIC C1608 JB 1E 104K-T
EP8292 6910012350 S.BEAD MMZ1608Y 102BT C8231 4030011600 S.CERAMIC C1608 JB 1E 104K-T
EP8293 6910012350 S.BEAD MMZ1608Y 102BT C8232 4550006450 S.TANTALUM ECST1EY105R
C8236 4550006450 S.TANTALUM ECST1EY105R
J8220 6510022540 S.CONNECTOR 20FMN-BMTTR-A-TBT
[JACK UNIT]
REF ORDER DS8220 5030002280 LCD HLC7700-018800
DESCRIPTION
NO. NO.
EP8220 0910054783 PCB B 5751C
J8601 6510022620 S.CONNECTOR 10FMN-BMTTR-A-TBT
J8602 6510023060 CONNECTOR TCS7186-01-201
EP8601 0910054961 PCB B 5812A
[SENSOR UNIT]
NO. NO.
S8801 2250000220 ENCODER TP90N937E20-15F-1540
S8802 2250000220 ENCODER TP90N937E20-15F-1540
EP8801 0910054732 PCB B 5729B
S.=Surface mount
5 - 19
HM-135 SP-24
[MAIN UNIT] [CHASSIS UNIT]
REF ORDER REF ORDER
NO. NO. NO. NO.
R1 7010006890 RESISTOR R20J 12 kΩ SP1 2510001170 SPEAKER 077P0401 <KS>
R2 7010006910 RESISTOR R20J 33 kΩ
R3 7010006880 RESISTOR R20J 6.8 kΩ
R4 7010006900 RESISTOR R20J 15 kΩ W1 8900011090 CABLE OPC-1104
C1 4010008030 CERAMIC DD104 B 471K 50V EP1 8930006760 M.OTHER SR-2P-4
MC1 7700002120 MICROPHONE KUC2123-030245
S1 2260002340 SWITCH SKHHAM024A

W1 9018490010 WIRE 71/98/010/X98/X98 <KN>

W2 9018490010 WIRE 71/98/010/X98/X98 <KN>
EP1 0910051480 PCB B 5324

EP2 9018230010 TUBE IRRAX 0.7(d) L=5mm
[SW BOARD]
NO. NO.
S1 2260002330 SWITCH SKHHLP014A
EP1 0910051490 PCB B 5325
S.=Surface mount
5 - 20
SECTION 6 MECHANICAL PARTS AND DISASSEMBLY
6-1 RC-25 6-3 HM-135

[FRONT PARTS] [CHASSIS PARTS]
REF. ORDER REF. ORDER
DESCRIPTION QTY. DESCRIPTION QTY.
NO. NO. NO. NO.
W8001 8900009531 Cable OPC-942A 1 W1 8900011080 Cable OPC-1108 1
W8005 8900008860 Cable OPC-875 1
MP1 8210015570 1823 front panel (B) 1
MP8001 8210018720 2545 front panel assembly 1 MP2 8210013620 1823 rear panel 1
MP8002 8210018730 2545 rear panel assembly 1 MP4 8930039780 1823 seal 1
MP8004 8210018620 2545 reflector 1 MP5 8930039750 1823 PTT holder 1
MP8005 8930057170 2545 20-key 1 MP6 8930039760 1823 PTT rubber 1
MP8006 8930057160 2545 3-key 1 MP7 8930039730 1823 key board 1
MP8007 8930057480 2545 LCD holder Y618 1 MP8 8930039720 1823 hanger knob 1
MP8008 8930057490 2545 LCD filter 1 MP9 8930039740 1823 M-sheet 2
MP8009 8830001630 VR nut (P) 1 MP11 8810009250 Screw PH B0 2.6 × 16 SUS 5
MP8016 8610010851 Knob N279-1 1 MP12 8810009260 Screw PH BT 2 × 6 NI 5
MP8017 8610010861 Knob N280-1 2 MP13 8810009240 Screw BiH M4 × 10 ZK 1
MP8020 8810004430 Screw PH M3 × 6 ZK 8 MP14 8850001610 Spring washer M4 SUS 1
MP8022 8810008660 Screw PH BT M3 × 8 NI-ZU 9
MP8023 8930057110 2545 phone cap 1
[MAIN BOARD]
[DISPLAY BOARD]
REF. ORDER DESCRIPTION QTY.
REF. ORDER NO. NO.
DESCRIPTION QTY.
NO. NO. MC1 7700002120 Microphone KUC2123-030245 1
J8701 6510022440 Connector LTW-8MP-C 1
J8702 6450001630 Connector HSJ1406-01-050 1
6-4 IC-M802
MP8201 8510014560 2545 shield case 1 [CHASSIS PARTS]
[JACK BOARD] REF. ORDER DESCRIPTION QTY.
NO. NO.
REF. ORDER J4501 6510000370 Connector MR-DS 1
DESCRIPTION QTY.
NO. NO. J4503 6510000370 Connector MR-DS 1
J8602 6510023060 Connector TCS7186-01-201 1
W4501 8900011050 Cable OPC-1109 1
[SENSOR BOARD] W4502 8900011060 Cable OPC-1141 1
W4505 8900011220 Cable OPC-1143 1
REF. ORDER W4506 8900008880 Cable OPC-877 1
DESCRIPTION QTY.
NO. NO. W4507 8900011230 Cable OPC-1142 1
S8801 2250000220 TP90N937E20-15F-1540 1 W4528 8900011030 Cable OPC-1130 1
S8802 2250000220 TP90N937E20-15F-1540 1
MF4501 2710000520 Fan SB0812H-ICOM-00 1
[VR BOARD]
MP4501 8010018820 2429 chassis 1
REF. ORDER DESCRIPTION QTY. MP4502 8110007700 2429 T-cover 1
NO. NO.
MP4503 8110007710 2429 U-cover 1
R8901 7210002360 TP96N97-15F-10KB-1301 1
MP4504 8110007690 2429 PA-cover 1
MP4505 8930057190 2429 earth plate Y620 2
[CONNECT BOARD] MP4506 8930057980 Rubber foot (N) SJ-5023K 4
MP4508 8930035230 1546 TR-A clip 1
REF. ORDER DESCRIPTION QTY. MP4509 8820000530 Flange bolt M4 × 8 NI 1
NO. NO.
DS8220 5030002320 M802 LCD assembly C 1 MP4511 8820000550 Cap bolt M4 × 8 ZK 2
MP4512 8810008660 Screw PH BT M3 × 8 NI-ZU 42
Screw BiH M3 × 8 ZK
6-2 SP-24 MP4513
MP4514
8810005770
8810003170 Setscrew A M3 × 8
14
9
[CHASSIS PARTS] MP4515 8930057870 2429 earth spring 1
MP4516 8930058100 2429 DC plate 1
REF. ORDER DESCRIPTION QTY. MP4517 8930050320 Thermally sheet (M) TC-500TK 1
NO. NO.
MP4518 8930050330 Thermally sheet (N) TC-400TKC 2
W1 8900011090 Cable OPC-1104 1
MP4519 8930055990 Shield tape (H) 1
MP4520 8930057870 2429 earth spring 1
EP1 8930006760 SR-2P-4 1
SP1 2510001170 Speaker 077P0401 1
MP1 8210018780 2431 front panel assembly 1

MP2 8210018790 2431 rear panel assembly 1
MP7 8810004430 Screw PH M3 × 6 ZK 4
MP8 8930057640 Insulate plate (GW) 1
6-1
[MAIN UNIT] [ACCESSORIES]
REF. ORDER
• IC-M802
DESCRIPTION QTY.
NO. NO. REF. ORDER DESCRIPTION QTY.
J1451 6450000140 Connector HSJ0807-01-010 1 NO. NO.
J1801 6450000170 Connector TCS4480-01-1111 1 J4002 6450001280 Connector TCP0587-71-5401 1
J2051 6510023180 Connector TCS7282-01-211 1
P4001 5610000290 Connector XMP-06V 1
EP2 0880000900 DSP board 1 P4002 5610000300 Terminal BXA-001T-P0.6 4
MP201 8510014610 2429 MIX case 1 F4001 5210000090 Fuse FGB 30A 1
MP301 8510000180 117 shield plate 1 F4002 5210000060 Fuse FGB 5A 2
MP302 8930054530 2355 earth spring 1
MP701 8510011970 2177 OSC case 1 W4001 8900011041 Cable OPC-1107A 1
MP702 8510014600 2429 OSC cover 1
MP1501 8510013140 2241 DC-A case 1 EP4002 0880000960 RC-25 1
MP2051 8930057990 2429 control plate Y630 1 EP4003 0880001000 SP-24 1
[PLL UNIT] MP4001 8010018980 2429 bracket 1

MP4002 8810001490 Screw A0 5 × 20 SUS 4
REF. ORDER MP4003 8850000500 Spring washer SUS 4
DESCRIPTION QTY.
NO. NO. MP4004 8850000180 Flat washer SUS 4
J5051 6510023120 Connector CD6109SA1J0 1 MP4005 8810009300 Setscrew (J) 4
J5081 6510023120 Connector CD6109SA1J0 1 MP4006 8950005720 Tie mount (CL8) 1
J5091 6510023040 Connector 01K1621 1 MP4007 8950005710 Release tie (RELK2R) 1
MP5801 8510006941 DTMF shield case-1 1 • RC-25

MP5901 8510006941 DTMF shield case-1 1
NO. NO.
MC8101 0800006490 HM-135 1
ACCESSORIES
MC8101 (R) MP4001 (M) EP4002 (M) W8101 8900011070 Cable OPC-1106 1
MP8101 8010018860 2455 bracket 1

MP8102 8810001490 Screw A0 5 × 20 SUS 4
MP8103 8850000500 Spring washer SUS 4
MP8104 8850000180 Flat washer SUS 4
MP8105 8610010561 2040 knob bolt-1 2
MP8101 (R) MP4002 (M)
MP8106 8950005110 2289 mic hanger 1
EP4003 (M) MP1 (S) MP8107 8810004700 Screw A0 3 × 16 SUS 2
MP4004 (M)
• SP-24
MP4003 (M)
MP8105 (R) NO. NO.
MP4005 (M) MP1 8010018870 2456 bracket 1
MP2 (S) MP5 (S)
MP2 8810001490 Screw A0 5 × 20 SUS 2
MP8102 (R) W4001 (M) MP3 8850000500 Spring washer SUS 2
MP4 (S)
MP4 8850000180 Flat washer SUS 2
MP8104 (R) MP3 (S) MP5 8610010561 2040 knob bolt-1 2
MP8103 (R) F4001 (M)

MP4006 (M) Screw abbreviations PH: Pan head
MP8106 (R) BiH: Binding head
F4002 (M)
MP4007 (M) BT, B0: Selt-tapping
SUS: Stainless
P4001 (M)
MP8107 (R) J4002 (M) NI: Nickel
NI-ZU: Nickel-Zinc
W8101 (R) P4002 (M)
(R): RC-25 ZK: Black
(S): SP-24
(M): IC-M802
6-2
MP8020 (F)
J8602 (J)
J8061 (J)
JACK BOARD
MP8022 (F) MP8022 (F) MP8002 (F)

MP8004 (F) W8001 (F)
W8001 (F)
W8005 (F)
MP8008 (F)
DS8220 (C) MP8201 (D)

J8702 (D)
MP8007 (F)
J8701 (D)
SENSOR
MP8006 (F) BOARD
DISPLAY
BOARD
VR
S8801 (S) BOARD
W8005 (F)
S8802 (S)
R8901 (V)
MP8005 (F)
MP8023 (F)
MP8009 (F)
MP8001 (F)
S8801 (S)
Unit abbreviations (F): FRONT PARTS
S8802 (S) (D): DISPLAY BOARD
(J): JACK BOARD
R8901 (V) (S): SENSOR BOARD
(V): VR BOARD
RC-25 MP8017 (F) MP8016 (F) (C): CONNECT BOARD
6-3
MP7 (C)
MP8 (C)
MF4501 (C)
MP4512 (C)
SP1 (C)
MP2 (C)
PA unit
1 MP4512 (C)
MP4504 (C)
2 MP4514 (C)
EP1 (C)
W4506 (C)
MP4511 (C)
2
EP2 (M) 2 1
2 VARISTOR-2 BOARD
W1 (C) 2 2
2
VARISTOR-1 BOARD
MP1 (C) MP2051 (M) DRIVER BOARD
W4505 (C) W4507 (C)
MP4508 (C) 1 MP4502 (C)
W4506 (C)
1
MP5 (A) MP4512 (C)
PA UNIT
2
MP1501 (M) 2
MP4515 (C) MP4513 (C)
2
MP4516 (C) 1 J4503 (C)
W4501 (C)
MP1 (A) MP4520 (C) MP4512 (C)
MP5 (A)
SP-24 J1451 (M)
Unit abbreviations (C): CHASSIS PARTS J2051 (M)
W4528 (C) MP4509 (C) J4501 (C)
(A): ACCESSORY PARTS
MAIN UNIT MP702 (M) MP4505 (C) W4507 (C)
MP12 (C)
MP701 (M)
J1801 (M) W4502 (C) to J4501 (C)
MP6 (C)
MP201 (M)
SW BOARD
MP5 (C) MP301 (M) MP302 (M)
MP4501 (C)
MP8 (C) MP4519 (C)
W4505 (C)
MAIN BOARD W4528 (C)
MC1 (M) MP4518 (C) MP5901 (P)
MP7 (C) MP4517 (C)
MP9 (C) MP14 (C) MP5801 (P) FILTER BOARD
MP13 (C) MP4518 (C) MP4503 (C)
MP1 (C)
MP4512 (C)
MP11 (C) J5091 (P)
J5081 (P)
MP9 (C)
MP2 (C)
PLL UNIT
MP4 (C)
J5051 (P)
W1 (C) MP4512 (C)
Unit abbreviations (C): CHASSIS PARTS

Unit abbreviations (C): CHASSIS PARTS MP4513 (C) (M): MAIN UNIT
HM-135 IC-M802
(M): MAIN BOARD MP4506 (C) (P): PLL UNIT
6-4
SECTION 7 SEMI-CONDUCTOR INFORMATION
• TRANSISTOR AND FET’S • DIODES
2SA1037AK S 2SA1213 Y 2SA1586 GR 2SC2873 Y 2SC4116 BL 1SS301 1SS322 1SS355 1SS375-TL DA221 TL
(Symbol: FS) (Symbol: NY) (Symbol: SG) (Symbol: M) (Symbol: LL) (Symbol: B3) (Symbol: A9) (Symbol: A) (Symbol: FH) (Symbol: K)
B B
B B B A1 A
A C
C C C C C C C
E E E A2
E E
2SC4116 GR 2SC4213 B 2SC4215 O 2SC4673 D TD 2SD1585 K DAP222 TL DF40SC4 HSB88WSTR KV1470 TL MA2S111
(Symbol: LG) (Symbol: AB) (Symbol: QO) (Symbol: CO) (Symbol: None) (Symbol: P) (Symbol: Silver line) (Symbol: F7) (Symbol: A)
C
B C1
B B B B A1
A C
C C C C A C
E
E E E C2 A2
E E
BC
2SD1619 T TD 2SD1664 T100Q 2SK210 GR 2SK508 K52 T2B 2SK2171 4 TD MA2S728 MA30-(TX) MA77 MA80WK MA338
(Symbol: DB) (Symbol: DAQ) (Symbol: YG) (Symbol: K52) (Symbol: KM) (Symbol: B) (Symbol: 3B) (Symbol: 4B) (Symbol: M1Y) (Symbol: 6H)
B B S
D S A1
A C A C A C A C
C C S G G G C
G D A2
E E D
2SK2973 3SK131 T2 MAS DTA114EUA T106 DTC114EUA T106 PD55003 MA729 MA742 MA8043 H MA8051 M MA8091 M
(Symbol: K1) (Symbol: V11) (Symbol: 14) (Symbol: 24) (Symbol: PD55003) (Symbol: 2B) (Symbol: M1U) (Symbol: 4^3) (Symbol: 5-1) (Symbol: 9-1)
S
D D
G G1 S B B A
G
A C A C A C
S S C C C
G2 D S
D E E G S
PD55015S SD1487 XP4312 XP4601 RB706F-40 T106 RD10M B3 TLYU1002 UM9957F/TR

(Symbol: PD55015) (Symbol: SD1487) (Symbol: 7T) (Symbol: 5C) (Symbol: 3J) (Symbol: 103)
S
D yellow dot
D
C E1 C1 E1 C1 A
E C
G B A C A C
B1 B2 B1 B2 C
S E C2 E2 C2 E2
G S B E
7-1
SECTION 8 BOARD LAYOUTS
8-1 HM-135
8-1-1 SW BOARD 8-1-2 MAIN BOARD 8-2-2 CONNECT BOARD
• TOP VIEW • TOP VIEW • TOP VIEW
SW MOD
PTT
UP
P
GND PTT DN
8-2 RC-25 J8602

8-2-1 JACK BOARD RXD TXD H13V
• TOP VIEW 8-2-3 SENSOR BOARD
to IC-M802 MAIN • TOP VIEW
unit J2051
FAFG FAF GND GRP CH
FMODG FMOD
to DISPLAY board
8-1
VOL
8-2-4 VR BOARD
• BOTTOM VIEW (CONNECT BOARD)
19 1
J8220
GND
GND
RES
DB1
DB3
DB5
DB7
RD
RS
5V
to DISPLAY board
9 1
GND
GND
DB0
DB2
DB4
DB6
CL1
WR
CS
9V
J8601
FMODG
H13V
GND
RXD
FAF
20 2 • BOTTOM VIEW (JACK BOARD)
to DISPLAY board J8205 to DISPLAY
board J8903
FMOD
FAFG
GND
GND
TXD
10 2
• BOTTOM VIEW (SENSOR BOARD)
H13V TXD RXD
GND FAF FAFG
FMOD FMODG
8-2
8-2-5 DISPLAY BOARD
• TOP VIEW
1/NB 2/SQL 3/SCAN
THRU/TUNE
DISTRESS
4/SP 5/AGC 6/RF-G
SET/MODE
DSC 7/Lo 8/Mid 9/Hi
CE 0/DIM ENT
CANSEL
/CALL
e-mail
CLAR/RX TXF/TX FREQ/CH

HEAD
PHONE
MIC
J8701
MIC PTTE
MISW MICE
AFE
AF1 PTT
AF2
8-3
• BOTTOM VIEW (DISPLAY BOARD)
2 10 9 1 19 1
J8902 J8903 J8205
FMOD
FAFG
FZTX
FZ5V
GND
GND
GND
GND
GND
TXD
DB6
DB4
DB2
DB0
CL1
WR
NC
NC
CS
9V
to JACK to CONNECT
board J8601 board J8220
FMODG
FZMD
FZRS
FZRX
H13V
GND
GND
GND
GND
GND
RXD
RES
DB7
DB5
DB3
DB1
FAF
RD
RS
5V
1 9 10 2 20 2
8 5
1 4
5 4
80 61
1 60
8 1
1 10 1 14
20 41 5 6
21 40
7 8
PHD PMUT
PHE
PMUT PHD
to SENSOR board
MICE MIC
PTTE AFE MISW
PTT AF1
AF2
to VR board
8-4
8-3 IC-M802
8-3-1 DSP BOARD
• TOP VIEW
3 1
4 6
72 37
73 36
9 8
16 1
14 1
11 10
108 1
109 144 15 28
20 1
1 8
1 8 4 5
8 7 4 5
14 1
3 1
4 6
8-5
• BOTTOM VIEW (DSP BOARD)
20 11
5 4
21 20
8 1
1 10
20 11
5 4 40 1
8 1
1 10
8 1
8 7
14 1
8 5 9 16
1 14 10 1
1 4
7 8
1 8 11 20
4 5
MAIN unit J1102 J901 J902 MAIN unit J1101

2 DSPI1 GND 1 1 DSPI1 GND 2 30 29 29 30
DRES GND1 DRES GND1
GND GND GND GND
KEYIN UNLK KEYIN UNLK
GND DSPI2 GND DSPI2
GND1 GND1 GND1 GND1
GND GND GND GND
OUT7 OUT8 OUT7 OUT8
8V 8V 8V 8V
OUT5 OUT6 OUT5 OUT6
GND GND GND GND
OUT3 OUT4 OUT3 OUT4
AGC2 AGC1 AGC2 AGC1
OUT1 OUT2 OUT1 OUT2
GND GND GND GND
GND1 GND1 GND1 GND1
DSPO1 GND DSPO1 GND
OBSY STBO OBSY STBO
GND GND GND GND
RQO DO RQO DO
22 GND DSPO2 21 21 GND DSPO2 22
GND1 GND1 GND1 GND1
to MAIN unit J1102 CK DI CK DI
RQI IBSY RQI IBSY
GND1 GND1 GND1 GND1
2 GND1 192K 1 1 GND1 192K 2
to MAIN unit J1101
8-6
unit J6702
8-3-2 MAIN UNIT
from PA
• TOP VIEW to FILTER
board J7331 to PA unit J6701 20
2 16 2
J1301 J1901
THRM
L16M
S13L
STAT
GND
GND
GND
GND
GND
PON
L8M
L4M
L1M
S13
S13
S13
ICV
HV
P6702
P501
DSC ANT P7321
from CHASSIS J4503 MRX from FILTER board J7321
ANTC
TRXS
KEYS
FANC
L22M
L12M
GND
GND
GND
GND
FOR
REF
L6M
L2M
T8V
S13
S13
HV
YGR
1 15 1 19
from PLL unit J5601

from PLL unit J5801
3 4
1 6
8 5
P5601
18 10
P5801
1 4
8 7
M1LO
D1LO
10 9 1 9 14 1
9 8
8 1
18 1 16 1 9 16
18 10
1 16
8 9
8 5 1 9
16 9
8 5
5 4
1 4 8 1
1 4
1 8 J1101
1 8 2
1 GND1 192K
J1102 GND1 GND1
30 GND DSPO2 29 4 5 RQI IBSY
100 81
GND GND 1 80 CK DI
DSPO1 GND GND1 GND1
GND GND 8 5 RQO DO
AGC2 AGC1 OBSY STBO
GND GND 4 1 GND1 GND1
8V 8V 4 1 1 4 OUT1 OUT2
GND GND OUT3 OUT4
GND DSPI2 8 5 1 8 OUT5 OUT6
GND GND 5 8 5 8 OUT7 OUT8
2 DSPI1 GND 1 4 5 1 8 GND1 GND1
to DSP board 1 4 UNLK
4 5 KEYIN
30 51 29 DRES GND1 30
8 1 31 50
to DSP board
8 5
8 5
9 8 5 16
1 4
6 5 1 4
9 8
1 4 13.6V FALC SCAN
10 1 16 1 AAF AMOD
SEND AGND CWK
1 16
SPE
5 4
SPO
8 1
8 9
ACC
CONTROLLER
SP
to SP-24 8 7 4 6 23 1 30 2 9 1
J2051 J3601 J3602 J3001
CNVSS
NMEI2
NMEO
DSMD
DTRM
FZCLK
PCO2
UNLK
DSAF
PST2
PST5
S13P
S13P
GND
GND
GND
GND
GND
GND
H13V
PCK
H5V
GND
VCC
RXD
A16
TXD
FAF
NC
NC
NC
D0
D2
D4
D6
CE
P5201
to RC-25 M2LO
to FLASH from PLL unit J5201
JACK board
writer
FZBUSY
DSMDE
FMODG
DSAFE
RESET
RSSW
NMRS
FZTXD
DRES
NSEN
RXPC
NMEI2
M3LO
REFS
D2LO
FMOD
J8602
PDAT
H13P
PST1
PST3
PST4
NMEI
S13P
S13P
FAFG
GND
GND
GND
EPM
NC
NC
NC
D1
D3
D5
D7
5 2 1 3 24 to PLL unit J5001 2 29 to PLL unit J5071 1 10 2
8-7
• BOTTOM VIEW (MAIN UNIT)
8-8
8-3-3 FILTER BOARD P7321
to MAIN unit J51 MRX
• TOP VIEW
ANT
from CHASSIS J4501
15 1
J7331
L16M
S13V
GND
GND
GND
L8M
L4M
L1M
FLIN P7001
to PA unit J6401
to MAIN
unit J1301
TRXS
L22M
L12M
GND
FOR
REF
L6M
L2M
16 2
8-9
• BOTTOM VIEW (FILTER BOARD)
8 - 10
8-3-4 PLL UNIT
P5801 P5601 M1LO

D1LO
to MAIN unit J2301 to MAIN unit J601
44 34
1 33
11 1
12 34
11 23
12 22
22 34
23 33
1 16
100 76 8 9
1 75
11 1
12 34
22 34 25 51
23 33 26 50
6 5
16 9
8 5
1 4
1 8
1 4
GPS
P5201
M2LO
REMOTE to MAIN unit J301 AF/MOD
5 1 2 24 1 29 5 1
J5081 J5001 J5071 J5051
PXRXD
NKME0
PCTXD
NMEI2
MOD-
DSMD
MOD+
DTRM
PTMP
DSAF
PCO2
UNLK
REFV
PST2
PST5
S13V
S13V
GND
GND
GND
GND
GND
GND
GND
GND
DTR
PCK
AF-
H5V
AF+
A16
NC
D0
D2
D4
D6
DSMDE
NSEND
DSAFE
RSSW
NMRS
MSEN
RXPC
ENAB
AACK
DRES
M3LO
REFS
D2LO
NMEI
PDAT
H13V
PST1
PST3
PST4
S13V
S13V
GND
GND
GND
GND
DTR
NC
NC
NC
D1
D3
D5
D7
9 6 1 to MAIN unit J3601 23 2 to MAIN unit J3602 30 9 6
8 - 11
8-3-5 PA UNIT
to CHASSIS W4501
1 3 3 1 J6301 J6703
J6501 J6412 4 GND 1 KEY
to
VARO
HV13V
FAN+
GND
GND
GND
GND to DRIVER START to CHASSIS
NC
GND
to FAN VARISTOR-2 DRVI board 13.6 W4502

board 1 DRVI 4 ANTC/GND
5 4
8 1
19 1 J6302
P7001 FLIN J6701 1 DRVO YGR
THRM
S13V
S13V
S13V
from MAIN unit J1

STAT
GND
GND
PON
from FILTER board J7001 DRVO

ICV
HV
GND
4 GND 3 1
to DRIVER J6411
to
ANTC
KEYS
FANC
S13V
S13V
VARO
GND
GND
GND
VARI
GND
T8V
HV
board VARISTOR-1
board
20 to MAIN unit J1901 2
8 - 12
8-3-6 DRIVER BOARD
• TOP VIEW
8-3-7 VARISTOR-1 BOARD
VARI
to PA unit J6411
VARO
GND
8 - 13
• BOTTOM VIEW (DRIVER BOARD)
to PA unit J6301
DARI
DARI
DARI
DARI
DRVO
DRVO
GND
GND
to PA unit J6302
8-3-8 VARISTOR-2 BOARD
VARO
to PA unit J6412
GND
GND
8 - 14
SECTION 9 BLOCK DIAGRAM
IC152 IC-161 IC171

TK11218CM BA033FP TK11250CM IC1002 Q501
455 kHz 64.455 MHz 64.455 MHz
MAIN UNIT FILTER BOARD D7271
TS522ID IC501 3SK131 D302 Q201,Q202 1SS322
1.8V 3.3V +5 8V BW=6 kHz BW=6 kHz BW=15 kHz BW=15 kHz 30 MHz D7272
TA4107F HSB88WS 2SK2171
REG REG REG RX IF IF CERAMIC IF CERAMIC XTAL XTAL IF RX 1SS322
AMP LPF AMP BPF AMP BPF LPF BPF BPF AMP BPF LPF LPF HPF LPF
PWR
1.8V 3.3V 5V FI402 Q401 FI401 FI301B FI301A Q203 FI201 33 MHz 0.5-2 MHz IC1 DET
IC651 CFWS455HT 3SK131 CFWM455H 3SK131 FL-345 µPC2709T 1.6 MHz
BA15532F IC1051 AGC1 TX TRXS FOR
TS522ID FI-315 BPF REF
DSPI1 Q801 2LO Q701 YGR
DIFF 3SK131 3SK131 2-3 MHz ATT LPF ATT
CONV IC901 Q702,Q703 AMP
IC651 TX LIMIT TA4107F 3SK131
BA15532F LPF AMP ATT
IC601 IF RF LPF L0
BA15532F AMP ATT LPF AMP LPF BPF
DIFF 0.5-2 MHz
CONV DSPI2 Q601 3-5 MHz
DIFF 2SC4673 Q6401,
IC501 CONV 100MHz PA UNIT Q6101 Q6801 Q6851 Q6402 LPF L1
AK4528VF BPF 2SK2973 PD55003 PD55015 SD1487
LO 1LO
AMP LPF 2-3 MHz
TRX DSC IC601 5-7 MHz
BA15532F ATT LPF AMP AMP AMP AMP
LPF L2
BPF
A/D A/D DIFF BIASPP BIASP BIASD BIASE Q6403 3-5 MHz
CONV 7-10 MHz
60 MHz 3LO IC1201 2SD1585K
Q1204 2SA1586 NJM3403AV LPF L3
BUFF IC1303 Q1501 Q1205 2SC4213 BPF TEMP BIAS BIAS BIAS BIAS
TD62783AF 2SD1619 DET PP P P F 5-7 MHz
IC201 AJLC ADJ ALC ICA 10-14 MHz
R13V R13V T8 T8
M29W102BB-70N1 TXS SW AMP Q6501 2SD1664 PAT8 LPF L4
REG REG BPF IC6501 TS522ID
ROM Q1203 IC1201 7-10 MHz
Q1502 14-18 MHz
IC1502 2SA1586 NJM3403AV FUN IC6501
2SD1619 13.6 LPF L5
TA78M08F EXT BPF CTRL TS522ID
R8 R8 FALC ALC REF
8V +8 RXS ALC ICA APC IC 10-14 MHz
IC406 REG AMP 18-24 MHz
REG I/F CTRL DET
SN74AHC74PW LPF L6
DSP IC1501 IC1201 BPF Q6601 2SA1037AK IC6601 D6601
OUT1-8 IC1551 µPC1555G2 TA78L05F NJM3403AV Q6602 DTC114EU TAZ808F DF40SC4 14-20 MHz
LATCH 24-30 MHz
D1552 MA742 5V +5 S13V T8 PA8V +8
D1551 MA8051 ALC FOR REG REG LPF L7
REG AMP
IC401 -5V IC1201 20-30 MHz
SN74AHC595PW -5 NJM3403AV
IC301 DC-DC RL6701
TMS320VC33PGE120 IC1302 AJS1311
SERI RFML METER TD62783AF BUFF
-PARA AMP S13V HV13 HV
SW +
IC1301 BUFF
GND TD62783AF
IC3604 BCD -
IC405 POCV BU4094BCF TO
IC404 BU4021BF
SN74AHCT374PW DECI IC3602 BCD TO
PARA BU4094BCF DECI
LATCH -SERI
IC102 FANS
BU9480F
IC1101
NJM4558M IC3606
IC1 M62354GP
TC7WHU04FU AGC1 AGC
D/A BUFF AMP PWRS IC3605 IC1303
D/A BU4094BCF TD62783AF
D/A D/A TIMING TEMP
IC1101
NJM4558M BCD TO BUFF
DECI
DSC TRX X1 AGC2 AGC
D/A BUFF AMP IC2702 Q2501 Q2401 Q2301,Q2302
CR-628 TS522ID 3SK131 3SK131 FI231B FI231A 2SK2171
12 kHz
12.288 MHz IC2701 BW=15 kHz BW=15 kHz D2301 2,4,6M

TA4107F HSB88WS
12 kHz IF IF 10. 7 MHz RF
LPF AMP AMP AMP BPF BPF AMP BPF
TX
8M
fc=98 kHz DAGC FL-231
DSP01 ACML S13V BPF
LPF BUFF
RX AF
LPF AMP 12M DET
IC3302 IC3101 MUTE
IC701A S-80942CNMC-G9C AN78L05M BPF
µPC4570G2 IC1702 Q2102
TS522ID RESET H5V +5 HV13 16M 2SC4116
fc=98 kHz CTRL REG
DSP02 MONI/SIDETONE IC1701 TC4W53FU BPF
LPF BUFF
SQL
D2LO
D1LO
GATE NBDP
SENB NSEN
IC701B MATRIX
DSP BOARD µPC4570G2 SQLC
CPU Q5882 Q5881
IC2001
SLFP IC5901 IC5801 2SC4215 2SC4673 PLL UNIT
BEEP SC-1287 SC-1287
BU4053BCFV LPF IC3303
EMOD M30624FGAFP LO
EXT EXT MOD LPF D/A DDS DDS D/A LPF BUFF AMP
MOD EMS GATE Q1801 UNLK
IC2001 2SD1619
IC2001 BU4053BCFV ACC SEND ASEN
BU4053BCFV MMOD SW RAM BACK
MMOD GATE UP
NBDP NMS EXT MOD MMS MOD
MOD GATE IC3601 IC5401
AFG IC1303 IC3603 BU4094BCF LMX2306TM PLL IC
IC1603 TD62783AF BU4094BCF
M5282FP Q5603 Q5602 Q5601 Q5521 2SK508
IC1601 LATCH 2SC4215 2SC4215 2SC4215 D5521 KV1470
LA4425A IC1602 CSEND BCD X3301 CTRL 64.455-94.455 MHz
TC4W53FU BUFF TO CR-636A L5523 E544GN-110248
DECI 14.7456 MHz M1LO LO LOOP
AFO PWR AF AF BPF BUFF AMP BUFF FIL PD 1/M
AMP MUTE VCA AMP
Q5604
64MHz
VC1S
SPEAKER ABWS VSQL Q5202 2SC4215
EX-2431 EEPROM 2SC4215
13V AFMS LO
AMP 1/N
M2LO 64MHz
EXT.AF BPF X2
DSC AF BUFF Q5281

2SC4215
UNLK
HV13
BUFF
DTRM RXPC Q5302
NBDP.AF NBDP BUFF Q5301 2SK210 2SC4116
I/F M3AD D5301 MA338
POWER SW
FAF PWR IC8260 PWRK LOOP
AMP TC74HC4066AF FIL BUFF
IC5081
PLL UNIT ADM202EARN PLUG GATE PHSM
IC8270 AF 1 X5251
DET CTRL CR-604
TA7368F 32.000 MHz
J8701 IC8250
RS-232C 232C TC7W04F VOL DDS IC
IC5103 Q5351
IC8280 PHONE 1 PLUG CLONE TC7SU04F 2SC4215
NMRS NJM2904M /CLONE DET I/F IC5001
IC5082 2 DIAL1 TA7805F AMP DDS PD LPF AMP
I/F TC7W08F MMOD AF MIC J8702
AMP MIC +5 S13V
PHOTO NMEA PMUT 5V REG IC5101
CPL I/F IC8280 SC-1246A
NMEA IC5084 PS2701-1 M1AD NJM2904M CPU DIAL2 IC5031
DIM TA7808F
IC5082 IC8301 CTRL
TC7W08F AN8010M 8VL +8
X8211 REG
GPS NMEA2 +10 CR-636A IC8201 IC5702 IC5102
NMEA I/F 10V REG 14.7456 MHz HD64F2134AFA20 DSEL IC5701 TC7SU04F SFECV10.5MA5S TC7SU04F
SC-1287 10.5 MHz
IC8290 DS8220 IC8240 M3LO
STRT TA7805F HLC7700-018800 HD66421TBO ATT LPF D/A DDS AMP D/A BPF AMP TX
KEY +5 H13V RX
5V REG LCD DRIVER BW=230 kHz
GND FI5101
ANT 13.6 FPTT COMMON
TUNER M1AD
Q3004 M2AD RESET TENKEY SELECT
2SC4116 SMUT CTRL SW SW Bus line
CWKYIN CWKEY IC8202
I/F RC-25(Controller) S-80942CNMC-G9C
9-1
SECTION 10 WIRING DIAGRAM
IC-M802
J6301
J6401
J7001 J7321 J51 FLIN DRVI
P7321
FLIN MRX DRVI
MRX
J3001 GND
GND
VCC
FZBUSY J6302
FZCLK
J7331 J1301 DRVO DRVO DRVI
NMEI2
CHASSIS W4507 DRVO DRVO DRVI
TRXS TRXS CE
S13V S13L EPM
to FLASH WRITER GND GND DRIVER BOARD GND
CHASSIS GND GND GND
L22M L22M GND
J4501 J7311 L16M L16M RESET
ANT ANT L12M L12M CNVSS J6411
L8M L8M FZTXD
L6M L6M VARI VARI
L4M L4M VARO VARO VARISTOR-1 BOARD
L2M L2M GND GND
L1M L1M J1 J6702
GND GND J6412
GND GND YGR YGR
REF VARO VARO
REF
GND GND GND GND VARISTOR-2 BOARD
FOR FOR GND GND
GND GND
FILTER BOARD J1901
CHASSIS W4506
J6701 EP6603
PON PON HV13V
HV HV HV13V CHASSIS W4501
HV HV HV13V
FANC FANC HV13V
S13 S13V
S13 S13V EP6602 POWER
J5001 J3601 S13 S13V
S13 S13V GND
CHASSIS W4505
HV13
S13V
H13P
S13P
S13
KEYS
S13V
KEYS
GND
GND
HM-135
S13V S13P STAT STAT GND
S13V S13P ANTC ANTC
S13V S13P ICV ICV (BLACK)
J6703 CHASSIS W4502 PTTE
J5051 UNLK UNLK GND GND
5 PDAT PDAT GND KEY (RED)
GND
AF- PCK START PTT
9
GND
PCK
PST1 PST1
J1101 J902 GND GND
13.6
SW BOARD
4 GND1 192K GND GND TUNER
AF+ PST2 PST2 GND1 192K ANTC/GND
8 J901 J1102 GND GND
NSEND PST3 PST3 GND1 GND1 GND1 GND1 MICE(SHIELD)
3 RQI IBSY THRM THRM
AF/MOD GND PCO2 PCO2 RQI IBSY DSPI1 GND DSPI1 GND
7 CK DI T8V T8V MC1
NC PST4 PST4 CK DI GND GND GND GND
2 GND1 GND1 GND1 GND1 GND DSPI2 GND DSPI2 (YELLOW)
MOD- PST5 PST5 7 1 MOD
6 RQO DO RQO DO GND GND GND GND J6501
GND DRES DRES
1 OBSY STBO OBSY STBO 8V 8V 8V 8V + FAN (GREEN)
MOD+ REFV NC FAN+ 6 8 2 SW
REFS REFS GND1 GND1 GND1 GND1 GND GND GND GND MAIN UNIT
PTMP NC OUT1 OUT2 OUT1 OUT2 AGC2 AGC1 AGC2 AGC1 PA UNIT GND
M
5 3
GND GND OUT3 OUT4 OUT3 OUT4 GND GND GND GND - 4
GND GND OUT5 OUT6 OUT5 OUT6 DSPO1 GND DSPO1 GND CHASSIS
OUT7 OUT8 OUT7 OUT8 CHASSIS MF4501 CHASSIS UNIT W1
M3LO M3LO GND GND GND GND J2101 J4503
J5081 GND GND GND1 GND1 GND1 GND1 GND DSPO2 GND DSPO2
DSC ANT DSC ANT
5 D2LO D2LO KEYIN UNLK KEYIN UNLK
GND GND GND DRES GND1 DRES GND1
9
8
4 NC
DTR DSP BOARD MIC
7
MICE
1
MIC RC-25
6 8 2
3 J8701 PTTE AFE MISW
REMOTE 7 PXRXD J5601 J601
P5601 J8902 5 3
2 M1LO J1451 SP PTT 4 AF1
PCTXD M1LO FZ5V
6 SPO AF2
1
SPE
SP-24 FZRX
FZTX
FZRS
J5201 J301 NC
P5201
M2LO FZMD
M2LO
NC
GND
GND
GND
J5801 P5801 J2301
D1LO
D1LO
J5091
GPS J8601 J8903
CHASSIS W8001
J2051 CONTROLLER J8602 FMOD FMOD J8702
J5071 J3602 PHE
FMODG FMODG
CHASSIS W4528 HEADPHONE
GND GND GND GND PMUT
8 7 6 8 7 6 /CLONE
MSEN NSEN FAF FAF PMUT
RXD TXD H13V OPC-1106 RXD TXD H13V FAFG FAFG
DSAF DSAF PHO
5 4 3 5 4 3 H13V H13V
DSAFE DSAFE
FAFG FAF GND FAFG FAF GND TXD TXD
DSMD DSMD
2 1 2 1 RXD RXD
DSMDE DSMDE
FMODG FMOD FMODG FMOD GND GND
GND GND
GND GND
ENAB NC
D0 D0
D1
JACK BOARD GPB GPB
D1
D2 GPA GPA
D2
GND GND
D3 D3
J8220 J8205
D4 D4 CHASSIS W8005
D5 9V 9V CHB CHB
D5 J1801
5V 5V CHA CHA
D6 D6
D7 D7 13.6V
GND GND GND GND
SENSOR BOARD
A16 7 SCAN 6 GND GND
A16 CL1
NC SEND EALC CWK CL1
AACK RES RES
NC 3 8 1 ACC
NC CS CS
NC NC AAF AMOD
5 AGND 4 RS RS
H5V H5V WR WR
RXPC 2
RXPC RD RD
DTRM DTRM GND GND VR5V VR5V
NMRS NMRS GND GND
NKME0 NMEO DB0 DB0 VOL VOL
RSSW RSSW DB1 DB1
NMEI2 DB2 DB2 GND GND
NMEI2
NMEI NMEI DB3 DB3 VR BOARD
GND DB4 DB4
GND
DB5 DB5
GND GND
DB6 DB6
DB7 DB7
PLL UNIT MAIN UNIT CONNECT BOARD DISPLYA BOARD
10 - 1
SECTION 11 VOLTAGE DIAGRAMS
11-1 RC-21 and HM-135
CHASSIS UNIT W1
MICE(SHIELD)
5V 5V 5V
R8236 100
7 1 D8250 R8253 IC8290 12.9V
R8254
R8252 100k
R8250 100k
R8226 1.8k
R8235 3.3k
R8224 47k
R8225 18k
C8250 0.01
TA7805F
C8244 10
C8241 22
1SS355 33k 6.8k J8902
6 8 2
C8242 0.0047
AFE FZ5V FZ5V
R8223 47k
R8237 68k
C8243 47
R8222 1k
C8223 0.0047
L8270 O I
5 3 G FZRX FZRX
0.0047
C8221
4 100µ IC8270
C8218
C8292 0.1
C8291 0.1
FZTX FZTX
C8293 47
C8290 47
R8290 10
C8271 0.0047
MIC Q8251 TA7368F
C8270 100
FZRS FZRS
10
J8701 R8247 XP4601 1 10
22 C8216 10 NC POUT NC
SW UNIT MOD(YELLOW) IC8250 2 9
TC7W04F VCC PWGND FZMD FZMD
MICE MIC 3 8
SW(GREEN)
7 1 NC PREGND NC
R8227
AF
S1
C8277 100
PTT(RED)
4 7
(BLACK)
10k
SKHHAMG24A PTTE MISW 1 8 VIN PHASE GND
3
D8204
M1
6 8 2 5 6
W8201 1SS355 RIPPLE NF GND
CLONE
AF1 FP
R8373 680
R8270 680
R8255 47k
5 3 2 7 GND
C8373 0.1
C8274
4 10.11V IC8301
L8203 10µ
R8251 18k
100
MCE AN8010M
AF2 3 6
J8903 J8601 J8602
O I
PTT G MI EP8293 FMOD FMOD FMOD
4 5
W8271
W8270
C8303 0.1
C8302 0.1
C8304 47
C8301 47
MAIN UNIT MC FE1 EP8292 FMODG FMODG FMODG
0.0047
C8222
C8295
100p
L8202 10µ R8291 GND GND GND
P 1k
S1 M2 AFIN FAF FAF FAF
SKHHAMG24A R2 EP8296 FAFG FAFG FAFG
W8202
0.0047
C8226
to IC-M802
33k D8205
MAIN unit
AFIN
H13V H13V H13V
PHE
FE1
1SS355
AF
J2051
LRXD EP8294 TXD TXD TXD
UP
S2 LTXD EP8295 RXD RXD RXD
R3
MC
MCE
SKHHAMG24A GND GND GND
FE1
MI
W8296
6.8k C8283 R8283 R8284 R8275
R8285 GND GND GND
W8281 10 1k 56k 470 3.3k
DN
S3 JACK BOARD
C8294
1000p
SKHHAMG24A R4 IC8260
0.0047
C8297
15k TC74HC4066AF IC8310
0.0047
C8288
7.83V
1 14 R8276 IC8280 L8286 TA7808F L8290
I/O1 VDD R8281 2 NJM2904M 10µ HF50ACC322513-B
2 13 100k - 1 1k
MC1 O/I1 CONT1 3 O I
W1 3 12 + 8 G
0.0047
C8312 0.0047
C8311 0.0047
O/I2 CONT4 C8286
0.0047
C8298
IC8280
47k
4 11 V+
C8282
C8313 47
C8310 47
0.0047
C8284
C8289
I/O2 I/O4 R8280 47
5 10 2.2 NJM2904M GND
CP8241
CP8240
CP8239
CP8236
CP8235
CP8234
CP8233
CP8232
CP8231
10k
470p
10
D8280
W8280
12k
CONT2 O/I4
R1
C1
W2 6 9 DA221 4
R8263
C8260
CONT3 O/I3 R8287
R8289 1.5k
7 8 R8282 120k
R8288
VSS I/O3 10k
1.8k
C8261
R8706 J8205 J8220
0.0047
R8274
C8280 22
R8278
C8281
22
HM-135 12k 68k Q8282 100 9V 9V
Q8281 DTC114EU
C8285 10
PHO Q8280 2SC4116 5V 5V
R8279
R8229
J8702 PHE 2SC4116 GND GND
R8707
22k
10k
R8701 33 1k GND GND
D8701 C8287
HEADPHONE L8701 R8704 4.7 CL1 CL1 CL1 LCL1
10µ 100 1SS355
/CLONE PMUT RES RES RES LRES
R8702 33 FZTX R8708 CS CS CS LCS
R8703
C8219
R8705
FZRX RS LRS
R8260
100k
FZMD
NTCG16 RS RS
FZRS
FZ5V
R8216
10
10k
1M
WR WR WR LWR
47k
R8202
R8203
RD RD RD LRD
5V
HF50ACC322513-B
47k
47k
GROUP DIAL LRXD R8204 GND GND
LTXD 47k GND GND
R8232
R8231
S8801
R8230
R8233
C8299
TP90N937E20-15F-1540
47k
47k
47k
47k
Q8260 DB0 DB0 DB0 LDB0
47p
C8300
3 GPB CP8201 CP8201 GPB GPB DTC114EU DB1 DB1 DB1 LDB1
R8208
C8202
C8201
47p
B
L8206
L8201
100
56k
2 GPA CP8202 CP8202 GPA GPA DB2 DB2 DB2 LDB2
0.1
A 10µ
1 GND CP8203 CP8203 GND 5V DB3 DB3 DB3 LDB3
COM
DB4 DB4 DB4 LDB4
DB5 DB5 DB5 LDB5
3 CHB CP8204 CP8204 CHB CHB DB6 DB6 DB6 LDB6
B
GPB
GPA
CHB
CHA
DSTK
CSCK
DALK
TUNK
MODK
SETK
EMLK
T1K
T2K
T3K
T4K
T5K
2 CHA CP8205 CP8205 CHA CHA DB7 DB7 DB7 LDB7
A
1 GND CP8206 CP8206 GND
COM C8207 12p
C8205
R8206
R8207
R8239
R8240
DS8340
0.01
47k
47k
S8802 POWER
1k
1k
CP8221
CP8222
CP8223
CP8224
CP8225
CP8226
CP8227
CP8228
CP8229
TP90N937E20-15F-1540 LED Q8340 X8211
2SC4116 CR-636A
CHANNEL DIAL
R8340 22k
SENSOR BOARD C8206 12p
80
79
78
77
76
75
74
73
72
71
70
69
68
67
66
65
64
63
62
61
W8340
DA221
DA221
D8201
D8203
10k
SCK1/IRQ5/P86
RXD1/IRQ4/P85
TXD1/IRQ3/P84
P83
P82
P81
P80
VSS
D7/P37
D6/P36
D5/P35
D4/P34
D3/P33
D2/P32
D1/P31
D0/P30
A0/P10
A1/P11
A2/P12
A3/P13
R8341 470
POWER DISTRESS Q8341 MESUREMENT CONDITIONS
LED 2SC4116 frequency: 12.29 MHz
DSTK DS8341 L8220 10µ
R8205
DISTRESS
/CALL/ALM mode: J3E(USB)
R8342 22k *ANT(RX): no input L8221 10µ
DSC/CALL CSCK (TX): no modulation
R8352 100k
/CHO/SELCALL 4.95V
R8343 470 Digital tester
CANCEL DALK unit: V
/TELCAL/TXF 1 60 T6K IC8240
Q8342 RES P14/A4 range: 20V
IC8202 2 59 T7K HD66421TBO
TUNE TUNK DS8342 2SC4116 XTAL P15/A5 input impedance: 10MΩ
6.42V S-80942CNMC-G9C 3 58 T8K no specification: voltage at RX 1 306
(THRU/METER) EXTAL P16/A6 GND1 COM100
R8344 22k 1 5 4 57 T9K C8230 0.1 2 305
MODK OUT CD MD1 P17/A17 VLCD1 COM99
MODE(DIM) 2 5 56 C8231 0.1 3 304
VDD MD0 VSS VCC1 COM98
C8209 0.01
R8345 470 3 4 6 55 DB0 DS3800-DS8311 C8232 1 4
R8209 100k
SETK DS8343 VSS NC NMI P20/A8 V5O

C8208 0.1
SET 7 54 DB1 TLYU1002 C8233 1 5

STBY P21/A9 V4O
8 53 DB2 C8234 1 6
e-mail EMLK VCC2(VCL) P22/A10 V3O
/DSC/TS(ALE) C8220 9 52 DB3 C8235 1 7
SCK0/P52 P23/A11 V2O
DS8300
DS8303
DS8306
DS8309
Q8343 IC8201
2SC4116 0.47 10 51 DB4 C8236 1 8 257
T1K DS8344 RXD0/P51 HD64F2134AFA20 P24/A12 V1O COM51
1(NB) 11 50 DB5 9 256
TXD0/P50 P25/A13 GREF SEG160
R8346 56k 12 49 DB6 10 255
T2K R8210 VSS P26/A14 IREFM SEG159
2(SQL) 13 48 DB7 R8241 R8246 11 254
WAIT/P97 P27/A15 IREFP SEG158
DS8301
DS8304
DS8307
DS8310
47k 14 47 1.8M 1.8M 12
T3K DS8345 R8347 390 EXCL/P96 VCC1 VLCD2
3(SCAN) 15 46 CS 13
IOS/AS/P95 P47/PWX1 VLCD3
16 45 RES C8237 14
T4K HWR/P94 P46/PWX0 VCC2
4(SP) 17 44 WR 0.1 15
RD/P93 P45/TMRI1 GND2
DS8302
DS8305
DS8308
DS8311
R8211 47k 18 43 RD 16
T5K IRQ0/P92 P44/TMO1 GND3
5(AGC) DS8346 R8212 47k 19 42 RS 17
IRQ1/P91 P43/TMCI1 VCC3
R8213 47k 20 41 CL1 R8242 18
P66/FTOB/CIN6/KIN6/IRQ6
T6K ADTRG/IRQ2/P90 P42/TMRI0/SCK2 2.2M OSC1
P62/FTIA/CIN2/KIN2/TMIY
6(RF-G) 19
P41/TMO0/RXD2/IRRXD
P40/TMCI0/TXD2/IRTXD
R8300
0.1
1.98V OSC2
Q8344 20
P61/FTOA/CIN1/KIN1
3.9k
P67/CIN7/KIN7/IRQ7
P60/FTCI/CIN0/KIN0
P64/FTIC/CIN4/KIN4
P65/FTID/CIN5/KIN5
P63/FTIB/CIN3/KIN3
T7K 2SC4116 Q8300 OSC
7(LO) DS8347 2SD1619 21
HLC7700-018800
CO
C8203
22
P76/AN6/DA0
P77/AN7/DA1
T8K R8348 68k DCON
8(MID) 1.92V LCL1 23 LCD
CL1
R8301 47
P70/AN0
P71/AN1
P72/AN2
P73/AN3
P74/AN4
P75/AN5
24
DS8220
T9K FLM
AVCC
AVSS
9(HI) DS8348 R8349 330 25
R8244
DS8312-DS8323 M
26
47k
ENTK TLYU1002 M/S
ENT LRES 27
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
RES
LCS 28
T0K CS
0 LRS 29
DS8312
DS8315
DS8318
DS8321
DS8349 RS
C8204
LWR 30
FCHK W8242 WR
0.1
FREQ/CH LRD 31
RD
32
RXK Q8345 VCC4
RX(CLAR) 33
DS8313
DS8316
DS8319
DS8322
2SC4116
R8243 100k
DS8350 GND4
R8215 LDB0 34 99
TXK 4.73V DB0 SEG3
FUNK
FCHK
ENTK
TX(TXF) 47k LDB1 35 98

RXK
TOK
TXK
R8350 68k DB1 SEG2

DS8340-DS8350 FP R8221 1k R8241 6 LDB2 36 97
FUNK 100k - 7 W8238 DB2 SEG1
FUNC SML-311YT 4.73V M1 R8218 1k 5 + LDB3 37 96
DS8314
DS8317
DS8320
DS8323
R8351 330 DB3 COM50
M2 R8219 1k LDB4 38 95
DB4 COM49
R8214 47k
IC8280 LDB5 39
NJM2904M DB5
EP8205 LDB6 40
R8302 DB6
VR5V CP8209 CP8209 VR5V R8201 47k 1.97V LDB7 41
3.9k DB7
DIMMER Q8301 42
R8243
VOLUME VCC5
R8245
VOL CP8208 CP8208 VOL 2SD1619 43
47k
47k
R8901 GND5
TP96N97 R8234 44 49
1.91V VCC6 COM3
GND CP8207 CP8207 GND 45 48
R8246 47k
1k
0.0047
0.0047
0.0047
0.0047
C8214
C8211
C8212
C8210
R8303 47
VLCD4 COM2
46 47
GND6 COM1
VR BOARD DISPLAY BOARD CONNECT BOARD
11 - 1
11-2 IC-M802
11-2-1 MAIN UNIT (1)
MAIN UNIT(1)
BUS LINE1
M1LO
J301 R4
68 2.77V
from PLL M2LO 8V 8V
unit J5201 5.63V
D101 D106 D104 D109 R204 470 Q201
L101 L118 C127 L112 L124 C138 C162
4.7µ
0.1
0.1
C6
C8
5.69V MA80WK MA80WK MA80WK MA80WK D201 2SK2171
L3
5.6µ 4.7µ 0.047 0.68µ 0.47µ 270p 180p L202 L203 L204 a
J601 C201 MA80WK
L1 L2 C7 C9 R5 C10 0.27µ 0.27µ LR-403 C209 0.1 L206
from PLL M1LO 6 0.1
0.18µ 0.27µ 0.1 0.1 18 0.1 11.88V 0.1µ
100µ
L140
100µ
C119 R109 C124
L113
0.47µ
0.56µ
unit J5601
L130
L137
4 1
270p 220 47p C203 C205 C210 0.1
B0
R110
R201
22p 8p
470
270
270
R1 C2 C4 R207
R6
R7
1k
J1 IC1
0.0022
0.0018
39 82p 22p 5 3 2 470
C106
C175
C115
C139
C163
R106
C168
0.0015
µPC2709T
220p
220p
C109
C128
YGR
18p
220
C152
from PA
0.1
0.1
0.1
W2002
C202
C204
C206
C207
150p
100p
unit J6702
82p
100µ
100µ
L144
L201
0.1
R205 470
150p
150
150
68p
82p
R2
R3
C1
C5
B6
C3
R8 L102 L119 C129 C155 b
470 4.7µ 3.3µ 0.0027 0.0015 L114 L125 C140 C164 L205 R203 Q202
0.47µ 0.39µ 180p 150p 100µ 22 2SK2171
R13V
c
100µ
L103
L127
L133
C11
L52 R54 C120
3.3µ
5.6µ
0.1
0.0047
0.0047
82µ 560 200p
0.001
C214
C212
C211
C208
100µ
C125
L115
0.39µ
0.39µ
L131
L138
R202
D53
0.1
470
22p
MA80WK C65
0.0015
C156
R101
C101
0.012
C147
C54 C56 C59 C62
C110
220
J51 0.1 R8
0.0015
0.1
0.1
C130
0.1 0.0022 0.0012 0.0022 R8
C107
C116
C141
C165
R107
0.0015
200p
180p
MRX
220
C153
from FILTER
0.1
0.1
L601 R601 L603 C612 R607 d
board J7321 B1
UM9957
UM9957
R57
R58
470
470
0.015
0.015
10µ 47 2.2µ 27p 1k e
C66
C67
0.01
C57
R56
470
0.1
0.1
C61
C63
D102 D107 B7
D51
D52
R61 MA80WK L104 L120 C131 C169 MA80WK
MA8091
0.0047
10k 2.2µ 2.2µ 0.0015 0.001 POCV
R603
C611
C601
D105 L116 L126 C142 C166 D110
0.0047
5.6k
D601
100µ
100µ
0.1
C603
L55
L56
MA77 0.33µ 0.27µ 150p 100p MA77
100µ
4.7µ
3.9µ
C604 L604 L605
L51
L53
L54
0.001 0.33µ 0.22µ
100µ
L105
L128
L141
R59 C132
2.2µ
1.8µ
R13V
S13V
1k 120p
100µ
C126 C602
L117
R8
0.27µ
0.33µ
L132
Q51 R8
2SC4213 18p 0.0047 D602
0.0047
0.0022
MA80WK
R60
C68
C102
C111
C118
C133
C170
C148
C157
C607 C609
C64
560p
270p
560p
0.1
0.1
1k
Q601
0.1
0.1
0.22µ
1p 6p
C108
C117
C143
C167
R108
R602
R604
L602
R102
150p
100p
0.001
C154
2SC4673
1.5k
220
0.1
0.1
56
220
TX: 4.96V B2
R605
C605
C606
C608
C610
R606
330p
S13V B8
10p
10p
10
1p
1k
L106 L121 C144 C171
1.5µ 1.5µ 120p 470p
J1301 R8
R1309
TRXS TRXS IC1301 R13V
4.7
L134
L142
unselected
100µ
C121 C145
L107
1.8µ
1.2µ
S13L TD62783AF S13V
band 10.7V
R718
100p 560p
L22M R1301 10 18 1 L7S TX: 7.44V
1k
01 IN1
L16M R1302 10 17 2 L6S
0.0015
0.0018
C172
R103
02 IN2
C103
C112
C134
C158
560p
470p
C149
220
L12M R1303 10 16 3 L5S POCV
0.1
0.1
03 IN3
S13V
L8M R1304 10 15 4 L4S MAIN
R8
C702
R703
R720
04 IN4
8.2k
L6M R1305 10 14 5 L3S B3
0.1
1k
L4M R1306 10 13
05 IN5
6 L2S D103 D108
L704
100µ
L705
100µ
UNIT
to FILTER 06 IN6
board J7331
L2M R1307 10 12 7 L1S MA80WK L108 L122 C146 C173 MA80WK (2)
R704
C312
R309
07 IN7 1.0µ 1.0µ 470p 330p L701
47k
L1M R1308 10 11 8 L0S TX: 0.44V
0.1
1k
C712
08 IN8 LR-317 Q701 R710
GND 10 9
0.1
GND VS 3SK131 220
100µ
C122 R719 R706 L702 L703 C705
L109
L135
0.82µ
C1301 0.1
C1302 0.1
C1303 0.1
C1304 0.1
C1305 0.1
C1306 0.1
C1307 0.1
C1308 0.1
1.0µ
L143
GND
R701
C1309
56p 100 100 1.0µ 0.68µ 0.1
220
REF unselected band
0.1
Q702 L706
R13V
S13V
GND 4.92V
NTCG16
0.0022
0.0047
3SK131
220
R705
LS-483A
C104
C113
C135
C174
C150
C159
R8
C707 C710 R715 C717
470p
330p
8V
220
FOR FOR
NTCG16
R707
IC1302
0.1
0.1
C701
R702
C703
TD62783AF R104 6p 18p 18 0.001
560
GND
R722
0.1
0.1
R1318 220
10 9 4.7 B4
C706
C709
C711
R708
R711
C715
R712
R716
C720
GND VS
33p
39p
22p
470
270
270
39p
B7 11 8 B7S
5p
1k
08 IN8 L110 L123 C136 C160
B6 12 7 B6S TX: 6.66V
07 IN7 0.82µ 0.68µ 270p 220p
B5 13 6 B5S
06 IN6 MESUREMENT CONDITIONS
B4 14 5 B4S frequency: 12.29 MHz
0.68µ
0.68µ
05 IN5
100µ
L111
L129
L136
B3 15 4 B3S C123 R713 C718
mode: J3E(USB)
04 IN4 39p
* ANT(RX): no input
18 0.001
B2 16 3 B2S
03 IN3 (TX): no modulation Q703
B1 17 2 B1S
0.0022
3SK131
R714
R717
02 IN2 Digital tester
0.001
L707
C716
C105
C114
C137
C161
R105
C714
C151
390p
300p
270
270
B0 18 1 B0S
220
0.1
0.1
0.1
01 IN1 unit: V LR-317
R709
B8
range: 20V
1k
REF
R1310 3.3k
R1311 3.3k
R1312 3.3k
R1313 3.3k
R1314 3.3k
R1315 3.3k
R1316 3.3k
R1317 3.3k
B5 input impedance: 10MΩ

no specification: voltage at RX S13V
C1310
C1312
-5V
unselected R8 R8
0.1
47
5V
band 11.76V
8V
REF REF
T8
S13V S13V S13V
L1907 RXS
J1451 -5V -5V
HF50ACC322513-B
L1302
R1319
SPO AFO 5V 5V
330µ
L1301
4.7
8V
C1451
SP 330µ
SPE 13.36V R13V TX: 12.88V T8
0.1
RX: 13.29V RXS

R1320
C1313
C1315
R1502 Q1501 TX: 7.89V
3.3k
C1311
C1314
4.7
0.1
4.7 2SD1619
ABWS
J1901
AFMS
IC1303 e-mail H3E
0.1
47
PON L1901 100µ PWRS TD62783AF C1604 selected 4.96V
S13V
R1504
470
HV 10 9
GND VS
1k
HV 11 8 B8S IC1502 D1501 Q1601
LW-15
L1601
R1607
08 IN8 TX: 0.05V C1619 DTC114EU IC1602
FANC L1902 100µ FANS 12 7 TA78M08F MA742
470
07 IN7 RX: 4.86V 0.047 TC4W53FU
S13 L1906 LR-270 13 6
06 IN6 O I f
S13 CSEND 14 5 CSEN G TXS 5 4
C1901
C1903
C1906
C1508
C1507
C1506
C1505
C1602
C1603
C1605
05 IN5
S13 DBPN 15 4 DBP4
470
470
0.1
0.1
0.1
0.1
0.1
0.1
C1509
13.41V 04 IN4 Q1503
47
10
S13 DBPM 16 3 DBP3 DTC114EU 6 3
R1606
03 IN3 TX: 13.13V C1607 R1602
1
S13 DBPH 17 2 DBP2 C1601
470
02 IN2 RX: 13.00V 5 10 1k
KEYS R1903 1k KEYC DBPL 18 1 DBP1 IC1501 470 1 7 2
to PA 01 IN1 TA78L05F R1501 R1503 Q1502 7.88V AFO 4 C1609
STAT R1901 4.7 STAS 2
C1606
unit J6701
R1603
22 4.7 2SD1619 1
R1601
0.01
ANTC 3 8 1
4.7k
T8
O I
470
ICV R1902 1k ICA G
C1501
C1502
C1503
C1504
C1608
R1505
C1610
IC1601
GND -5V LA4425A
0.1
0.1
0.1
0.0047
0.0047
C1910
C1904
C1907
0.1
47
10
1k
GND D1502 C1611
0.1
MA742 W1601 1
GND TX: 13.20V FAF
R3608
GND RX: 13.35V

47k
IC2001
GND BU4053BCFV 11.22V
C2001 4.7 C2107 C2104 g
THRM L1905 100µ TEMP DSMD 1 16
C1510
Y1 VDD Q1504 0.1 0.1
T8V L1903 100µ 2 15 DTC114EU
C2003
C2002 4.7 Y0 Y
1
3 14 A TX: 4.86V
C1902
C1903
0.1
UM9957
UM9957
Z1 X
L2101
R2103
RX: 0.05V
D2103
D2104
4 13
100µ
RL2101
0.1
0.1
Z X1
100
L2054 5 12 L1552 R1553 AHY103
100µ W2001 Z0 X0 1m 47
FAFG DSMDE 6 11 EMS
INH A
MA2S111
MA8091
RXD 7 10 NMS
C1557
C1558
C1559
R1555
R2104
0.0047
D1554
C2103
VEE B
D2102
R2105
J2051 8 9 MMS
10k
33k
0.1
0.1
VSS C
10
470
L1908
HF50ACC322513-B
10k
10k
0.0047
0.0047
0.0047
0.1
8 7 6
47k
47k
47k
TXD IC1551
R2106
C2004 µPC1555G2
C2007
R2001
R2002
Q2101
HF50ACC322513-B
39k
4.7
C2106
5 4 3 L2051 100µ D1552
FAF 1 8 DTC114EU
R3610
R3609
R3611
C2005
C2006
C2008
L1551 R1551
R1556
CONTROLLER MA742 C1555 GND VCC

220k
1
1m 47 2 7
R2107
2 1 L2053 R2003 47 TRG DISCHARGE
3 6
39k
100µ 5.6k OUT VTH
MA8051
C2101 R2101
C1552
C1551
FMOD 4 5
L1904
D1551
C1562
C1563
C1561
RESET VCONT 10p 22k
220p
220p
47
Q2102
C1560
0.1
1
L2052 2SC4116
MA2S728
C1905
C2105
R2102
0.1
100µ
C2102
0.047
D2101
FMODG
10k
0.1
15p
AMOD
J4503 J2101
TXS
DSC ANT DSC ANT

HV13 HV13 HV13
HV13
T8 T8 T8
DSC ANT
BUS LINE2
11 - 2
MAIN UNIT(2)
BUS LINE1 BUS LINE1
FOR
POCV
REF
M2LO
MAGC
1.39V
0.0047
a L210
C224
0.001
C314
LS-483A L401
D302 D303 FI401
R209 C217 D301 L301 L302 L304 R307 L305 L306 LS-542 CFWM455H
HSB88WS MA80WK
22 0.001 MA80WK LS-540 LS-540 LR-395 1k 10µ 12µ
R212
C213 9p
0.0047
L303
C219
1M
LR-317 I O
R214
FI301a FI301b
2.2k
0.0047
0.0039
FL-315 FL-315
C307
C305
270p
C310
L207 L208 C309
470p
C311
LS-483A LS-540 L209 Q203 0.1
0.0047
LS-540 3SK131
R210
R211
C302
C303
C401
FI201 L307
C220
2.2k
10k
0.1
LS-540
6p
5p
b FL-345 6.14V
R306
C308
680p
47
R208
100
0.0047
0.0047
0.0047
0.0047
R215
C218
C215
R213
R301
R401
C223
C301
C221
100
100
8p
1k
1k
c
TX: 7.2V
RXS
R8 R8 R8
R8
d
T8
e
FOR L904
C501
C503
C403
R911
W501
POCV
R507
0.1
0.1
POCV 0.1 1m
100
1k
REF
7.46V
L801 MAGC MAGC
R404
LS-495 C402
47k
R1219 0.0047
R804
R406
C404
R415
0.0047
L406 R414 D402
470k
2.2k
220k 4.76V 6.13V
470
C805
0.1
1000µ 1k MA77
R801
R802
1000µ
R506
C507
C510
2.2k
L502
470
100
0.1
22
0.0047
Q801
R504
D1204 L402 L403 L404
C504
3SK131 D1205 R1212 R1211 L405
MA77
1k
2 MA2S111 LS-542 1.42V LS-450 LS-542
D403
C411
C414
D401
180p
MA2S111 330k 100k - 1 LS-542
0.1
0.0047
3 MA77
C802
R813
R408
R409
C508
C804
470
100
22k
0.1
W803
R1222 0.1
R502
Q401
0.0047
C1010 R1008
C1204
120k
0.0047
C1201
R1207
C1214
R1217
D1207
C502
22 3SK131
220k
IC1201 D404 10 100
C801
C806
MA2S111 C407
10k
0.1
Q501
1
0.1
NJM3403AV MA77
47
R1232 0.0047 1.46V 3SK131 8
0.0047
8.2M I O
R405
R407
C406
C405
8V R1220 7.2V V+ IC1002
100
10k
0.1
R1230
C412
C413
C1011
120p
GND TS522ID
470k
2.2M 0.0047
R1215
R1208
0.23V 10
R503
0.46V R1216 4
NTCG16
27k
R1206
47k
10k
0.0047
47k
C408
C409
R410
C410
R413
C506
R505
FI402
C505
470k ICA 6
560
R508
0.1
0.1
0.1
0.1
- CFWS455HT
1k
1k
7 R1009
MAIN R1202 R1203 13
D1201
MA2S728
5
+
D1202
100 MAIN
UNIT UNIT
R1209
470k 470k - 14 IC1201 MA2S111
12 0.24V M3LOK T8 T8
47k
+ NJM3403AV
(1) R1221 (3)
R1233
R1205
IC1201 7.2V
R902
C901
IC1001
470k
100k
2.2M
C518
IC501 IC901
0.1
NJM3403AV
C1210
C1211
C1208
1k
R1213 C521 C906 C909 TC4W53FU
0.1
D1203 TA4107F TA4107F
100k 0.1 0.1 0.1
C910
1
REF 9 MA2S111 1 8 1 8 1 8
0.1
- 8 L01 L02 L01 L02 R1017
8V 10 2 7 2 7
Q1204 R1228 + VCC GND VCC GND 1k
3 6 3 6 2 7
R1210
R1218
2SA1586 1k R1214 IC1201 RF2 IF2 D901 RF2 IF2
4 5 4 5
47k
47k
560k NJM3403AV
R1226
C1206 RF1 IF1 MA80WK RF1 IF1
3 6
220
1000µ
R514
C1209
R1234
100µ
L505
Q1205 0.001
C517
R903
C905
R904
R910
L506
100µ
100µ
L903
L902
1k
10k
0.1
0.1
2SC4213
W1231
0.1
47
1k
1k
R1004
R1005
C1202 R1018
4 5 100
0.1 Q1203
1k
1k
R1223
2SA1586
R1235
W1227 2.2k
C519
C520
C907
C908
100µ
100µ
C904
L504
L901
4
10k
0.1
0.1
10
10
C1012
0.1
C509
C511
C902
R901
0.0047
MA8043H
V+
C903
IC1201
0.1
0.1
0.1
C1212
C1213
1k
C1001
R1002
R1003
C1002
0.1
M3LO
NJM3403AV GND C1203
D1206
470
470
0.1
0.1
0.1
DSPI1
C516
1
-5V
11
0.1
C1205
RFML
AJLC
MAGC
R1224
R1225
10
8V
EALC
ICA
100
100
5V
AFG
REF
S13V S13V
S13V S13V
-5V -5V
-5V
5V 5V
5V 5V
8V 8V
8V 8V
T8 T8
T8
RXS RXS
RXS
BEEP
DSAF
DSAFE
R1609
R1052
R1051
R1712
R1711
R1720
R1721
-5V
C1051 C1713
5V
2.2k
100
100
100
100
470
470
10 10
R1011 1k
8 8
W1701
R1610 V+ V+ C1101 R1109

IC1051 IC1702
RXS
C1003
0.0047
C1007
C1615
C1705
22k C1618 R1612 10 100
0.0047
GND C1052 GND C1714 R1006 R1010
C1006
TS522ID TS522ID 0.1 6
1 1k 10 10 7 - 1k 1k W1011 2 R1015
10
IC1703 -
1
IC1603 4 4 5 1 56k 8
C1612 IC1701 TC4W53FU + 3
M5282FP IC1002 + V+ IC1001
R1703
R1611
R1614
R1704
R1707
C1005
4.7 TC4W53FU R1007 IC1002
0.0018
C1102
C1004
TS522ID GND NJM4558M
0.0047
560p
C1008
6 5 5 4
470
100
R1014
R1016
470
560
1k TS522ID
C1709
C1710
NC GND IC1702 R1715 8.2k 0.1

1k
0.056
0.056
7 4 1 8 4
10k
TS522ID
1k
VCAIN OUT C1617 R1702 R1705 C1706
8 3 R1709 R1713 6 3
CTL IN- 10 10k 12k 4.7 6 R1717 C1715 R1110
9 2 2 7 7 - 1k 1k 2 100
f VCAOUT IN+ 5 1 - 1k 0.1
C1057
S13V
+
C1056
10 1 3 7 2
0.022
-5V
R1053 R1055
C1062
C1063
0.022
0.0047
+
R1701
C1703
R1706
C1701
VCC VCC2 6
0.022
0.022
8V
R1615 - R1059 R1057
C1707
C1711
3 6 R1710 7 1k 1k 2
2.7k
0.012
0.056
15k
C1613
C1614
R1613
-
0.1
10k 0V IC1702 5 1 1k 1k
R1716
R1718
1k 8 1 + 3
470
TS522ID
C1702
0.1
2.2k
+
10k
1k
IC1051
C1058
C1054
C1055
4 5 R1054 IC1051
0.022
0.001
0.1
TS522ID
C1616
C1704
R1724
C1716
R1719
C1717
R1722
C1059
C1061
R1060
R1723 R1058
C1064
0.01
0.001
1k TSS522ID
0.022
0.01
4.7k
DSPO2
DSPO1
1k 1k
10k
0.1
0.1
0.1
0V
10
SQLC
1k
AAF
DSPO2
D2201 D2203 D2202 D2204 S13V S13V
MA80WK L2201 C2204 L2210 C2213 L2216 C2222 L2225 C2234 MA80WK MA80WK L2235 C2239 L2238 C2245 L2240 C2248 C2252 MA80WK
D1LO
2.2µ 0.001 1.8µ 0.0012 2.2µ 0.0012 1.2µ 0.1 4.7µ 27p 5.6µ 27p 5.6µ 27p W2243 0.1 L2307
R2303
1.14V 13.09V
L2306 LS-409
4.7
D2301
L2202
C2263
C2264
L2213 18µ L2219 22µ LS-543

L2236
C2235 L2239 L2241 L2245 C2301 L2302 Q2301 L2304 FI231a FI231b C2710 R2709
100µ
100µ
HSB88WS
L2231
0.1 0.68µ 1.0µ 100µ 0.1 LR-409 2SK2171 LR-409 FL-231 FL-231 10 100
1p
1p
100µ
C2228 8V
g C2210 220p C2219 100p 47p
8
R2205
C2201
C2309
C2307
C2229 C2244 220p C2247 150p
L2301
R2207
100µ
V+ IC2702
3.3k
15p
22p
0.1
3.3k
4p
C2711 GND TS522ID
0.0012
C2225
C2207
C2216
C2240
C2303
10
L2207
L2220
L2228
0.001
820p
4
2.7µ
2.7µ
3.3µ
C2243
C2237
C2250
C2246
C2249
C2253
C2254
R2301
C2302
R2302
0.1
0.1
L2237
L2242
L2244
R2201
0.001
0.001
0.001
0.001
0.001
0.001
82n
82n
82n
ICA
0.1
0.1
100 R2710
22
0.0047
R2204 1k
C2402
DBPL Q2302 100
100
DBPN 2SK2171
C2205 L2211 C2214 L2217 C2223 C2236
0.1 2.2µ 220p 2.2µ 180p W2226 0.1 L2205 C2206 L2212 C2215 L2218 C2224 C2238 8V 8V
1.8µ 47p 1.8µ 47p 1.2µ 68p W2227 0.1
DAGC
L2214 3.3µ L2221 8.2µ DAGC
R2501
R2503
R2505
L2232
L2204
R2405
C2266
100µ
L2215 L2223 C2409

100µ
470k
6.8k
100
100
10p
R2401
R2403
C2211 220p C2220 180p 0.82µ 1.2µ 0.0047

L2206
L2233
68k
100µ
100µ
1M
R2506
C2504
L2501
R2406
C2405
C2212 150p C2221 68p MESUREMENT CONDITIONS
L2401
Q2401 Q2501
56µ
470
2.2k
56µ
frequency: 12.29 MHz
0.0015
0.0015
R2206
C2202
C2241
3SK131 3SK131
C2208
4p
C2226
L2208
L2222
L2229
0.0022
C2217
4p
0.47µ
0.33µ
0.47µ
1.50V
3.3k
mode: J3E(USB)
0.1
0.1
R2202 *ANT(RX): no input

0.0047
0.0047
0.0047
0.0047
R2208
C2203
C2209
C2218
C2227
C2242
R2402
R2404
C2406
R2502
R2504
C2503
C2403
C2404
C2501
C2502
100
L2209
L2224
L2230
(TX): no modulation
0.15µ
0.12µ
0.12µ
560p
680p
680p
DBPM
3.3k
1.5k
100
100
15k
0.1
0.1
0.1
0.1
R2203 Digital tester
6.72V 6.70V unit: V
100
DBPH range: 20V
1.48V
input impedance: 10MΩ
no specification: voltage at RX
A
HV13
HV13 HV13
BUS LINE2 BUS LINE2
11 - 3
MAIN UNIT(3)
BUS LINE1
RSS
NSEN
REF
L3602 HF50ACC322513-B J3601
L3601 HF50ACC322513-B H13P
S13P
IC3101 S13P
R3101 AN78L05M IC3601 S13P
33 BU4094BCF
HV13 S13P
I O
G PSEL 1 16 UNLK UNLK
C3101
C3102
C3103
C3104
C3201
L3301
STR VDD
R3306
PWRS R3017 220 PWRSR PDAT 2 15 PDAT PDAT
10µ
0.1
0.1
0.1
47
47
D QE
PCK 3 14 PCK PCK
1k
IC3201
TC7W04F CLK Q5
PST1 4 13 PST1 PST1
UNLK
C3601
Q1 Q6
PST2 5 12 PST2 PST2
C3307
0.1
Q2 Q7
0.047
IC3301 1 8 PST3 6 11 PST3 PST3
HN58X24128FPI Q3 Q8
DRES PST4 7 10 PCO2 PCO2
RB706F-40
RB706F-40
R3001 1.5k
R3002 1.5k
R3050 12k
R3013 10k
R3015 10k
R3018 47k
Q4 QS to PLL
R3201
1 8 2 7 8 9 PST4 PST4
C3302
R3301
R3302
unit J5001
D3007
D3006
A0 VCC VSS QS
47k
2 7 PST5 PST5
10k
10k
0.1
A1 WP
PSTB
3 6 3 6 DRES DRES
A2 SCL
R3003 220 RXS1 4 5
RXS VSS SDA
TXS R3004 220 TXS1 4 5 REFS
SQLC R3006 1k SQLC1 IC3602
R3202
0.0047
R3204
C3202
47k
47k
47k
47k
47k
47k
R3203
100k
RFML R3007 1k RFML1 BU4094BCF GND
47k
1k
R3008 1k ACML1 1 16 GND
STR VDD
R3601
R3602
R3603
R3604
R3605
R3606
NSEN R3009 1k NSEN1 2 15 M3LO
D QE
TEMP R3010 1k TEMP1 3 14 L4S GND
CLK Q5
ASEN R3011 1k ASEN1 H5V L0S 4 13 L5S D2LO
Q1 Q6
BEEP R3012 1k BEEP1 L1S 5 12 L6S GND
PSTB
Q2 Q7
L2S 6 11 L7S
RFML1
ACML1
NSEN1
TEMP1
ASEN1
PTMP1
D0
D1
D2
D3
D4
D5
D6
D7
C3311
Q3 Q8
L3S 7 10
C3310
C3308
C3602
0.1
Q4 QS
0.0047
C3001 0.047
C3002 0.047
C3003 0.047
C3004 0.047
C3005 0.047
C3309
R3051 4.7k
R3036 47k
8 9
R3014 1M
C3009 0.1
C3006.0.1
C3008.0.1
0.1
0.1
0.1
VSS QS
100
99
98
97
96
95
94
93
92
91
90
89
88
87
86
85
84
83
82
81
NMR
220k
220k
220k
220k
P97
AVCC
VREF
P100/AN0
AVSS
P101/AN1
P102/AN2
P103/AN3
P104/AN4/KI0
P105/AN5/KI1
P106/AN6/KI2
P107/AN7/KI3
P00/D0
P01/D1
P02/D2
P03/D3
P04/D4
P05/D5
P06/D6
P07/D7
R3020 47k IC3603
KEYC R3019 1k BU4094BCF
R3317
R3318
R3319
R3320
TXS1 1 80 1 16
P96 P10 STR VDD
RB706F-40
RXS1 2 79 2 15
P95 P11 D QE
PSEL R3308 220 3 78 OUT5R 3 14 CSEN
D3001
P94 P12 CLK Q5

Q3001 BEEP1 4 77 OUT2R NMS 4 13 AFMS
P93/DA0 P13/D11 Q1 Q6
MAIN STAS
DTC114EU PC02
PDAT
R3309
R3310
220
220
5
6
P92/DA1 P14/D12
76
75
OUT3R
OUT4R
EMS
MMS
5
6
Q2 Q7
12
11 M3LO
UNIT PCK R3311 220 7
P91 P15/D13/INT3
74 OUT7R 7
Q3 Q8
10 D2LO J3602
C3603
P90 P16/D14/INT4 Q4 QS
(2) 8 73 OUT1R 8 9 GND
R3612
0.1
BYTE P17/D15/INT5 VSS QS
CNVSS 9 72 R3316 220k NSEN NSEN
47k
R3034 CNVSS P20/A0
10 71 A1 DSAF DSAF
22k P87/XCIN P21/A1
UNLK R3312 1k 11 70 A2 DSAFE DSAFE
P86/XCOUT P22/A2
RESET 12 69 A3 DSMD DSMD
R3027
R3030
RESET P23/A3
4.7k
C3304 12p 13 68 A4 IC3604 DSMDE DSMDE

22k
XOUT P24/A4 BU4094BCF

14 67 A5 GND
C3305 X3301 VSS P25/A5
15 66 R3322 220k LSTB 1 16
R3028 12p CR-636A XIN IC3303 P26/A6 STR VDD
16 65 A7 2 15 D0 D0
ASEN
47k VCC M30624FGAFP P27/A7 D QE

CWK Q3004 17 64 3 14 B4S D1 D1
P85/NMI VSS CLK Q5
2SC4116 18 63 R3324 220k B0S 4 13 B5S D2 D2
R3029
R3305
D3004 P84/INT2 P30/A8 Q1 Q6

IC3302 PWRSR 19 62 B1S 5 12 B6S D3 D3
15k
MA2S111
10k
P83/INT1 VCC Q2 Q7
S-80942CNMC-G9C RPC 20 61 R3325 220k B2S 6 11 B7S D4 D4
P82/INT0 P31/A9 Q3 Q8
1 5 DTR 21 60 R3326 220k B3S 7 10 D5 D5
C3604
OUT CD P81/TA4IN/U P32/A10 Q4 QS
2 22 59 A11 8 9 D6 D6
0.1
VDD P80/T4OUT/U P33/A11 VSS QS to PLL
3 4 23 58 R3328 220k D7 D7
R3304
C3303
unit J5071
C3306
R3303 VSS NC P77/TA3IN P34/A12

0.027
STBOR 24 57 R3329 220k A16 A16

56k
56k
0.1
P76/TA3OUT P35/A13
KEYINR 25 56 R3330 220k IC3605
P75/TA2IN P36/A14 BU4094BCF
S13V RQOR 26 55 R3331 220k
S13V P74/TA2OUT P37/A15
RQIR 27 54 A16 MSTB 1 16
P73 P40/A16 STR VDD
5V DOR 28 53 2 15 H5V
5V P72 P41/A17 D QE
8V NMEI1 29 52 3 14 DBP4 RPC R3915 220 RXPC
220k
220k
220k
8V P71 P42/A18 CLK Q5
H5V NMEO1 30 51 B8S 4 13 DTR R3916 220 DTRM
P51/WRH/BHE
P50/WRL/WR
C3901
P70 P43/A19 Q1 Q6
DBP1 5 12 R3917 220 NMRS
P62/RXDO
R3025
R3026
P63/TXDO
P55/HOLD
P54/HLDA
P53/BCLK
0.1
P61/CLK0
Q2 Q7
P57/RDY
P47/CS3
P46/CS2
P56/ALE
R3327
R3323
R3321
DBP2 6 11 AJLC NMEO1 R3918 220 NMEO
47k
47k
P52/RD
Q3 Q8
RXD R3023 1k DBP3 7 10 RSS R3919 220 RSSW
P67
P66
P65
P64
P60
P45
P44
C3605
Q4 QS
TXD R3024 1k 8 9 NMEI3 R3920 220 NMEI2
0.1
VSS QS
NMEI1 R3921 220 NMEI
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
SQLC1 GND
RB706F-40
RB706F-40
FZTXD R3307 220 POCV GND

D3002
D3003
NMEI3 INITIAL IC3606
R3903
M62354GP
47k
1 16
A1
A2
A3
A4
A5
A7
J3001
A11
DO VCC
1.61V DSTB 2 15 VCC
R1101 R1107 R1103 R1108 LD VDD
2.80V 4.13V R3333 220 D3301 MA2S111 LCK 3 14 ABWS FZBUSY FZBUSY
47k
47k
47k
47k
10k
10k
10k
10k
10k
10k
10k
100k 1M 100k 1M CLK A06
AGC1 R3335 220 D3302 MA2S111 LDAT 4 13 TRXS FZCLK FZCLK
R3336
R3337
DI A05
R1113 R1114 5 12 NMEI2
MA2S111
220
220
R1102 R1104 A01 A04
R3909
R3908
R3907
R3906
R3402
R3403
R3404
R3405
R3406
R3408
R3412
2 100 6 100 6 11 FANS CE
1M - 1 1M - 7 A02 A03
100k
100k
220
220
3 5 7 10 EPM EPM to FLASH WRITER

+ + NC NC
MA2S111
IC1101 IC1101 R3340 8 9 GND

D3336
C3606
GND VSS
R1111
R1105
R1112
R1106
1.49V NJM4558M NJM4558M 220

270k
270k
RESET RESET
10k
10k
D3337
R3339
R3314
R3313
0.1
R3338
FZBUSY
PODN
GENE
STMD
FNCO
USAS
CNVSS CNVSS
TRVS
TXVS
R3334
R3332
1.69V 1.69V
FZCLK
DSTB
MSTB
LSTB
LDAT
AGC2 AFG
EPM
FZTXD FZTXD
LCK
47k
47k
MAGC 5V
R3315
C3007
H5V H5V
100p
10k
L2703 100µ S13V
8V
R2701
1000µ
1000µ
L2701
L2702
IC2701
1k
TA4107F
C2703 0.1
1 8 4.17V
L01 L02
2 7
C2701 0.1 VCC GND MESUREMENT CONDITIONS
3 6
RF2 IF2 frequency: 12.29 MHz L1804
4 5
47k
R2715 RF1 IF1 mode: J3E(USB) J1101 100µ

*ANT(RX): no input J902 CWK
W1101
C2706
18 GND1 192K J901 J1102

D2LO (TX): no modulation GND1 192K
R3613
DRES
0.1
Digital tester GND1 GND1 DSPI1 GND

R2706
R2716
C2702
C2704
C2705
W1102 GND1 GND1 DSPI1 GND
C1805 0.1
C1807
unit: V RQIR R3616 220 RQI IBSY GND GND C1806
ACC
270
270
0.1
0.1
range: 20V RQI IBSY GND GND 0.1

10
0.1
input impedance: 10MΩ CK DI GND DSPI2 J1801
CK DI GND DSPI2 L1801
no specification: voltage at RX GND1 GND1 GND GND
DAGC GND1 GND1 GND GND HF50ACC322513-B
DO R3614 220 DOR RQOR R3617 220 RQO DO 8V 8V
R2705 RQO DO 8V 8V 7 6
0.05V 0.05V STBO R3615 220 STBOR OBSY STBO GND GND EALC
1M OBSY STBO GND GND
GND1 GND1 AGC2 AGC1 ASEN
h IC2702 GND1 GND1 AGC2 AGC1 3 8 1
OUT2 R3620 220 OUT2R OUT1R R3619 220 OUT1 OUT2 GND GND
0.0047
0.0047
IC2702
C2712
C2713
OUT1 OUT2 GND GND 100µ
C1801
C1803
C1804
TS522ID C2716 OUT4 R3622 220 OUT4R OUT3R R3621 220 OUT3 OUT4 DSPO1 GND D1801 L1803
TS522ID R2708 OUT3 OUT4 DSPO1 GND MA2S111
0.1
0.1
0.1
C2707 R2702 6 0.1 OUT5R R3623 220 OUT5 OUT6 GND GND 5 4
2 1k - 7
0.1 56k - 1 5 OUT5 OUT6 GND GND 2
3 + OUT7R R3624 220 OUT7 OUT8 GND DSPO2
+ OUT7 OUT8 GND DSPO2 R1801 3.3k L1802 HF50ACC322513-B
R2711 R2712 GND1 GND1 CSEND
0.0047
R2714
C2708
R2703
R2704
0.0018
GND1 GND1
C2714
C2715
1k 1k KEYINR R3618 220 KEYIN UNLK

560p
10k
56k
KEYIN UNLK
1k
C1802
DRES GND1 R1802 3.3k
47k
47k
47k
to DSP
47k
47k
47k
DRES GND1
0.1
board J901 C2304 J2301
R2713
R1803 3.3k Q1801

DSP BOARD 2SD1619 0.1
to DSP
R3629
R3627
R3625
AMOD
HV13 D1LO from PLL
DSPI2
R3626
R3628
R3630
1k
board J902 TX: 11.7V
AAF
W2305 unit J5801
RX: 0V D1LO
BUS LINE2
11 - 4
11-2-4 PA UNIT
J6302 L6401
C6851 0.01 TX: 0.69V EXC-ELDR25C R6409 2.2
DRVO
DRVO
R6401 3.3
R6851
GND
100
GND
R6402 3.3
Q6851
PD55015
C6432
200p
R6852 R6403 3.3
1 Q6401
SD1487
C6401 0.0068
DRIVER BOARD
R6407 10
J6301
DRVI
DRVI L6301 L6405 J6401
LR-416 LR-376
GND FLIN
C6429 0.001
C6424 0.001
from FILTER
C6425 680p
C6408 0.001
C6409 0.001
C6410 220p
C6307 680p
R6415 47
GND L6404 board J7001
LR-400
R6408 10
R6801 C6301
EXC-ELDR25C
L6402
C6801
Q6801
R6206 470
560 0.1
L6202 82µ
R6301 100
C6105 R6107 C6201 PD55003 EXC-ELDR25C
0.1
0.1 680 0.1 TX: 4.03V
L6407
R6404 3.3
R6802 Q6402
TX: 6.30V SD1487
R6109
L6102
Q6101 1 TX: 0.47V
100µ
R6101 L6101 C6103 RX: 8.03V R6405 3.3
470
J6702 2SK2973
39 0.22µ 0.1
EXC-ELDR25C
from MAIN YGR
R6302 2.2k
R6303 1.2k
C6302 0.1
unit J1 R6406 3.3
R6201
R6204
C6203
0.01
R6104
C6433
2.7
82
L6403
R6102 180
R6103 180
C6101 82p
C6102 82p
R6110 39
R6111 39
R6112 39
200p
C6403 0.0068 R6410 2.2
L6406 LR-230
68
R6411 2.7
C6109
0.047
TX: 3.59V L6204
EXC-ELDR25C
C6104
R6105
R6106
2.2k
4.7k
C6418 0.0047
0.1
C6416 0.047
C6417 1000
C6202
R6202
R6203
C6205
C6206
R6304
0.047
0.047
3.9k
4.7k
TX: 2.54V
0.1
3k
D6431 MA30PXB
C6419 TX: 1.36V J6411
0.0047 C6431 0.047
VARI
C6106 0.1
C6108 0.1
F6702
1
L6303 VARO
TX: 7.97V EXC-ELDR25C GND
C6308 0.68
C6303 470
F6701 Q6602 TX: 7.30V
DTC114EU RX: 8.03V
R6412
J6703 Q6403
L6703 100µ 2SD1585K
KEY Q6601
2k
START L6704 100µ 2AS1037AK
2
F6703 R6602 VARISTOR-1 BOARD

C6708 0.0047
C6427 0.1
to TUNER 13.6 4.7k
L6701
C6707 0.0047
ANTC/GND
EXCCL3225U R6413
HF70ACC635050-T
220
R6603 D6432 MA30PXB
C6602 0.0047
C6701
HF70ACC635050-T
C6306 1000
0.047
R6604 15k
4.7k
C6305 0.1
J6412
C6432 0.047
D6701 DAP222
VARO
L6705
C6705 0.0047
RL6701 GND
C6428 0.1
AJS1311 GND
L6706
IC6601
C6706 0.0047
TA7808F
O I
G
W6701 VARISTOR-2 BOARD
C6604
C6603
C6605
C6606
C6607
RX: 4.86V
470
0.1
0.1
Q6701
47
47
J6701 DTC114EU
PON
R6507 2.2M
HV
HV R6502
33k
FANC
S13V R6509
100 2
C6414 0.0047
-
C6501
R6652
R6651
S13V 1
C6413 1000
C6412 1000
C6415 0.68
0.012
0.012
100p
3 R6503
S13V TX: 2.02V +
33k
S13V IC6501
S13V TS522ID
RX: 0.15V
R6505
R6504
KEYS
to MAIN
68k
68k
RX: 10.43V
C6702
STAT
0.047
unit J1901
R6702
ANTC
680
ICV D6702
RD10M
R6506
R6511
GND
L6501
2.2k
7.5k
R6515
GND 100µ
4.7k
NTCG16
GND EP6603
R6705
GND HV13V
GND HV13V
THRM 8 HV13V
T8V HV13V
L6702
0.0047
C6704
C6703
R6704
0.047
100µ
C6503 0.1
EP6601
1.8k
C6611 0.0047
V+ IC6501
C6608 0.047
C6612 0.001
C6609 2200
C6610 0.1
GND TS522ID D6601
to CHASSIS W4501
4 DF40SC4-4072
TX: 7.48V
RX: 2.29V
MESUREMENT CONDLTIONS
Q6501
R6514
J6501 mode: J3E(USB)

100k
2SD1664 *ANT(RX): no input

FAN+ EP6602
(TX): no modulation GND
to FAN R6513 Digital tester
GND GND
C6507 470
unit: V
C6506 0.1
330k
range: 20V GND
input impedance: 10MΩ GND
R6510
1k 6
7 -
5
+
R6517
R6512
IC6501
100k
TS522ID
1k
PA UNIT
11 - 5
11-2-5 PLL UNIT (1)
PLL UNIT(1)
R5901
IC5902
TC7SU04F
2k
J5051 4 3 R5922 C5910
R5911 2 100 0.001 M2LO
R5902
CP5002
CP5023
CP5021
CP5701
CP5703
CP5018
CP5017
CP5016
CP5014
CP5015
CP5024
CP5019
CP5020
CP5902
CP5904
5 AF- W5051 2k
5 1
1k
9 GND
R5921
W5052
C5911
4 AF+
1M
R5912
R5903
10p
8 NSEND J5071 J5001 2k
L5901
1k
3 GND GND GND
AF/MOD 7 D5051 10µ
MA2S111 MSEN D2LO R5913
W5053
R5904
2 MOD- DSAF GND 2k
0.0047
0.0047
C5903
C5909
1k
0.0047
6
C5901
GND DSAFE M3LO
1 W5054
MOD+ DSMD GND R5914
R5905
DSMDE GND 2k
11
10
1k
R5051
C5051
C5052
C5053
C5055
GND PTMP
9
8
7
6
5
4
3
2
1
820
0.1
0.1
0.1
0.1
VDD
NUM2
NUM1
NUM0
SYS CLK
VDD
ETC1
ETC0
FSK0
FSK1
VSS
ENAB REFS R5915
R5906
D0 REFV 2k 12 44
VSS VDD
1k
D1 DRES R5002 470 DRES 13 43 PCK
R5098 DA0 CON CLK
D2 PST5 R5008 470 PST5 R5916 14 42 PDAT
DA1 DATA
R5907
47k H5V D3 PST4 R5003 470 PST4 2k 15 41 PST5
to MAIN DA2 STRB
1k
D4 unit J3601 PCO2 R5009 470 PCO2 16 40
DA3 VSS
R5088
D5 PST3 R5004 470 PST3 R5917 17 IC5901 39
to MAIN DA4 VDD
R5908
47k
D6 unit PST2 R5010 470 PST2 2k 18 SC-1287 38
VSS P2
1k
Q5081 D7 J3602 PST1 R5005 470 PST1 19 37
2SC4116 DA5 TREE
A16 PCK R5011 470 (PCO0) PCK R5918 20 36
DA6 P1
R5909
AACK PDAT R5006 470 (PCO1) PDAT 2k 21 35
0.0047
R5081
C5092
DA7 UL
1k
R5086 UNLK UNLK 22 34
47k
10k DA8 VSS
ROMCE
Q5082 S13V R5919
RESET
PDM0
PDM1
PDM2
2SC4116 H5V S13V 2k
VDD
VDD
VSS
DA9
R5910
Q
RXPC S13V
I
C5084
1k
0.01
DTRM S13V
23
24
25
26
27
28
29
30
31
32
33
NMRS HV13
NKME0 R5920 DRES
C5088 1
5V RSSW 2k
NMEI2
J5081
0.0047
0.0047
0.0047
0.0047
C5905
C5907
C5908
0.0047
C5902
C5904
C5906
NMEI
5
C5090
GND GND
10
IC5081
CP5001
CP5006
CP5007
CP5008
CP5009
CP5010
CP5011
CP5012
CP5013
9 ADM202EARN GND
1
4 DTR C5085 1 1 16
8 C1+ VCC
2 15
3 V+ GND
PXRXD 3 14
REMOTE 7 C1- T1O
C5086 1 4 13
2 C2+ R1I
PCTXD 5 12
6 C2- R1O
W5082 6 11 R5096
1 V- T1I 47k
W5081 7 10
T2O T2I
8 9
R2I R2O
C5981 L5981 L5982 L5983
W5981 0.1 18µ 22µ 15µ
R5093
R5094
C5087
C5091
47k
47k
0.01 C5983 C5985

1
2p 3p
R5982 1k
C5982
C5984
C5986
12p
22p
20p
IC5083
TC7W32F
R5089 Q5084 1 8
12 2SC4116
2 7
R5701
IC5702
R5087
3 6 TC7SU04F
100k
2k
RL5081 R5092 4 5
ATX209 4.7k 4 3 R5722 C5710
R5711 2 100 0.001
R5702
D5084 D5085 2k
5 1
1k
R5721
MA2S111 MA2S111
C5711
1M
Q5085 R5712
R5703
10p
DTC114EU 2k
L5701
1k
10µ
R5713
R5704
Q5083 2k
0.0047
0.0047
C5703
C5709
0.0047
C5701
DTC114EU
1k
R5084 C5083
220 0.01
R5714
R5705
2k
11
10
1k
R5085 D5083
9
8
7
6
5
4
3
2
1
220 MA2S111
VDD
NUM2
NUM1
NUM0
SYS CLK
VDD
ETC1
ETC0
FSK0
FSK1
VSS
R5715
R5706
1k 12 44
VSS VDD
1k
13 43 PCK
DA0 CON CLK
R5716 14 42 PDAT
DA1 DATA
R5707
8VL 2k 15 41 PST3
DA2 STRB
1k
16 40
DA3 VSS
R5717 17 IC5701 39
CP5004 DA4 VDD
R5708
IC5031 2k SC-1287 38
TA7808F 18
VSS P2
1k
R5082 IC5084 R5090 L5005 19 37
470 PS2701-1 4.7k 10µ DA5 TREE
R5718 20 36
I O DA6 P1
R5709
2k 21 35
G DA7 UL
1k
C5032
C5031
22 34
EXC-ELDR25C
MA2S111
DA8 VSS
0.0047
C5081
0.1
ROMCE
47
R5719
D5081
RESET
PDM0
PDM1
PDM2
2k
VDD
VDD
VSS
DA9
R5710
Q
L5021
I
C5089 R5095
1k
C5034
0.01
C5033
23
24
25
26
27
28
29
30
31
32
33
47k
CP5091
0.1
47
R5720 DRES
2k
R5021
IC5082
10
0.0047
0.0047
TC7W08F
0.0047
0.0047
C5705
C5707
C5708
0.0047
C5702
C5704
CP5003
C5706
J5091 R5083 IC5085 IC5001
TA7805F
10
470 PS2701-1 1 8 D5086
GPS MA2S111
2 7
CP5092 I O
MA2S111
G
0.0047
C5082
R5097
3 6
C5022
C5021
D5082
MESUREMENT CONDITIONS L5781 L5782 L5783

47k
4 5 R5782 C5794
0.1
47
8.2 0.047 22µ 22µ 18µ

mode: J3E(USB) M3LO
*ANT(RX): no input 11.22V
(TX): no modulation C5782 C5784
C5024
C5023
R5781 560
R5783 560
R5799 1k
Digital tester 820p 0.0015
0.1
47
unit: V
range: 20V
0.0056
C5783
C5785
C5781
input impedance: 10MΩ
0.01
0.01
no specification : voltage at RX a
M2LO
BUS LINE
8VL
8VL
5V 5V
5V
R5091 HV13V
HV13V
4.7k
PLL UNIT(2)
11 - 6
11-2-6 PLL UNIT (2)
PLL UNIT(2) 8VL 8VL 8VL
L5601
100µ
CP5601
CP5603
L5605
100µ
R5801
CP5401
CP5402
IC5802 CP5602
C5602
R5605
0.0047
0.0047
C5604
C5607
TC7SU04F
0.001
R5602
R5609
2k
100
100
R5822 C5810
100
4 3
R5811 2 100 0.001 M2LO C5618 R5601 C5611 L5603 L5604 J5601
R5802
R5403
C5617
2k 0.0047 4.7k 47p 0.1µ 0.1µ P5601
0.001
5 1 1.2k W5409 M1LO to MAIN
1k
R5821
unit J601
C5811
1M
R5812
0.0047
0.0047
C5601
C5605
R5607
R5803
10p
R5606
0.0047
C5608
W5402
R5612
2k
4.7k
0.0047
C5404
C5610
330
CP5403
L5801
1k
330
270p
10µ R5613 C5613 C5615
R5813 5V 56k Q5601 12p 7p
R5804
2k 2SC4215 Q5603
0.0047
0.0047
C5803
C5809
0.0047
C5801
1k
C5606 2SC4215
R5604
0.001
56k
R5814 C5619 R5614 C5603
R5805
2k L5401 2p 180 0.0047

Q5604
11
10
R5611
1k
10µ C5609
9
8
7
6
5
4
3
2
1
5V 2SC4215 27 47p
C5614
C5616
VDD
NUM2
NUM1
NUM0
SYS CLK
VDD
ETC1
ETC0
FSK0
FSK1
VSS
C5612
R5608
R5610
L5602
R5815
0.15µ
Q5602
R5603
R5806
4.7k
27p
18p
27p
220
2k 12 44 W5401 2SC4215
VSS VDD
1k
1k
13 43 PCK
DA0 CON CLK
R5816 14 42 PDAT
DA1 DATA
R5807
R5406
2k 15 41 PST4
100k
DA2 STRB IC5401
1k
16 40 LMX2306TM 2.77V
DA3 VSS
R5817 17 IC5801 39 4.85V 3.6V 3.82V L5552 R5524
DA4 VDD 1 16
R5808
2k 18 SC-1287 38 FLO VP Q5401 100µ 100

VSS P2 2 15 R5407 DTA114EU 8VL
1k
19 37 CPO VCC2 1k
DA5 TREE 3 14
R5818 20 36 GND PO/LD Q5553
R5556
C5556
C5557
C5558
DA6 P1 4 13
R5809
2SC4116
0.001
C5526
2k 21 35 GND LE
C5529
470
LW-38
10k
L5522
DA7 UL 5 12
0.1
C5408
470p
1k
22 34 FIN DATA
1p
DA8 VSS 6 11 L5523
4.7
ROMCE
R5819 FIN CLOCK C5524

RESET
7 10 C5528 E544GN-110248
PDM0
PDM1
PDM2
2k VCC1 CE 0.0047
VDD
VDD
0.001
VSS
DA9
C5561
C5560
R5557
8 9
R5810
470p
Q
OSCIN GND D5402
I
10k
22
1k
1SS301 L5521
23
24
25
26
27
28
29
30
31
32
33
C5522
C5401
C5403
C5402
0.001
LW-38 100p
R5404 1k
R5408 1k
R5410 1k
0.01
0.1
R5820 DRES
2k Q5521
R5551
2SK508
C5521
C5523
100
R5522
0.0047
0.0047
0.0047
0.0047
C5805
C5807
C5808
0.0047
C5802
C5804
C5806
PDAT
PST2
10p
12p
0.0V
C5552
PCK
330 W5502
0.47
10
UNLK
C5551
C5525
4.7
D1LO D5521 0.0047 CP5201 CP5203
KV1470 J5201
C5890 7.65V P5201
M2LO M2LO to MAIN
R5884 47 0.0047 L5884 10µ
R5128 4.21V unit J301
100 CP5202
5V
R5888 47
C5892
L5101 R5130 C5108

0.1
0.0047
C5106
8VL 10µ R5126 1.5k 0.0047
R5125
C5110
0.0047
C5111
D5101 1M
C5883
100
R5886
1SS301
10
7.0V 7.71V
0.1
R5882
L5304
0.0047
C5315
100µ
L5882 L5883
1k
R5891 C5884 L5881 R5304 R5306 IC5103 IC5102 Q5101

1k
470 0.0047 5.6µ 5.6µ 5.6µ 100k 100

Q5881 Q5882 TC7SU04F TC7SU04F FI5101 2SC4116
2SC4673 2SC4215 1 5 4 3 C5105 SFECV10.5MA5S
R5137
0.001
0.0047
0.0047
R5308
C5309
C5311
Q5301 7.20V
C5312
2 2
R5312
C5888
100
1k
C5886 2SK210 3 4 5 1
470
10
0.5p 1p R5129 C5107
C5882 C5891 330 0.0047
R5132
R5131
R5133 R5134
0.0047
R5127
C5104
C5881 0.047
C5307
12p 0.1 R5307

R5887 1.2k
R5881 47
C5313
150p
2.7k
R5889 1k
47k 47k
470
330
0.0047
120k
C5113
0.0047
R5883
R5885
R5890
C5885
C5887
C5889
R5310
R5135
1.2k
270
560 1M
820
Q5302
7p
7p
6p
C5310 C5314
C5308
L5303
10p 2SC4116
150p
10µ 0.0047
R5101
2k
8VL
R5306
7.76V R5203 7.20V
R5309
C5101
R5311
L5202
150
R5113
820
0.0047
27p
0.0047
C5122
C5123
0.0047
0.0047
820
C5121
C5120
100µ 100 C5206 R5102
1k
0.5p C5126 2k
0.1
C5201
L5351
R5204
0.001
C5102
100µ
22k
C5357 0.0047
R5114
10p
R5103
1k
C5115
50
49
48
47
46
45
44
43
42
41
40
39
38
37
36
35
34
33
32
31
30
29
28
27
26
Q5202 2k
0.0047
VDD
DIVOUT
VSS
REFIN
PDIN
VSS
OSCO
VSS
VDD
OSCF
VSS
OSCI
VDD
VSS
SYSRESET
VDD
VDD
TEOUTH4
TEOUTH3
TEOUTH2
TEOUTH1
TEOUTH0
VDD
VSS
VSS
2SC4215 L5203 L5204
0.0047
C5353
C5103
0.0047
R5352
C5351
R5351
C5207 15p
D5303
C5205 15p
LS-471A LS-471A
R5115
470
1SS375
12k
5p
51 25 R5104
1k
W5203 C5202 PD2 VDD 2k
0.001 52 24
PD1 TE3
53 23
C5352 L5352 VDD TE2
R5116
54 22
0.0047 3.9µ PD0 TE1
R5206
R5205
0.0047
0.0047
C5203
C5204
55 21 R5105
1k
220
VSS VDD
10k
2k
56 20
PDTRI DA11
C5355 57 19
D5302 VDD DA10
5p
R5117
1SS375 58 18
REFOSC DA9
0.0047
R5106
C5283
R5282
59 17
1k
RC DA8 2k
100
Q5351 60 16
FCK VSS
R5354
6.91V
R5353
C5356
C5354
2SC4215 61 15
X5251 VSS VSS
470
51p
51p
R5118
62 14
1k
CR-604 Q16MA DA7

5
63 IC5101 13 R5107
1k
GND
OUT
Q4MA SC-1246A DA6 2k

64 12
VDD DA5
0.0047
C5281
6 7 65 11
R5283
CP5251
W5251
CP5041
MESUREMENT CONDITIONS VSS DA4

2.2k
R5119
66 10
TEMP
frequency: 12.29 MHz ETCO7 VSS

VCC
mode: J3E(USB) 67 9 R5108

5V
1k
*ANT(RX): no input ETCO6 DA3 2k
68 8
ETCO5 DA2
1
2
3
CP5301
CP5302
CP5303
(TX): no modulation 69 7
Q5281 Digital tester VSS DA1
2SC4215
R5120
unit: V DULS 70 6
R5251
C5282 ETCO4 DA0 R5109

range: 20V 71 5
470
1k
0.001 ETCO3 VSS 2k
input impedance: 10MΩ C5116 72 4
no specification: voltage at RX 47 VSS VDD
73 3
C5306 C5303 L5301 ETCO2 VDD
R5121
CP5223
CP5222
CP5221
74 2
R5284
150p
R5281
C5251
24p 100µ ETCO1 SYSCLK0 R5110

100p
4.7k
5V 75 1
1k
470
ETCO0 VSS 2k
CONTCLK
SYS-CLK
R5146 C5117 C5125
BUM2O
BUN2O
BUN2O
BUM2I
820 0.0047
BUN2I
BUN2I
CON2
CON1
CON0
BUSY
STRB
DATA
0.1
C5301
VDD
VDD
VDD
VDD
VSS
VSS
VSS
VSS
VSS
VSS
VSS
R5122
2.2
R5111
C5254
0.0047
C5253
L5302
1k
C5118 2k
76
77
78
79
80
81
82
83
84
85
86
87
88
89
90
91
92
93
94
95
96
97
98
99
LB-185
100
MA338
R5136
C5112
0.0047
C5305
C5304
D5301
C5302
10
0.0047
R5303
C5124
100k
100p
100k
47p
20p
0.0047
R5302
R5123
150
R5112
DRES
1k
2k
PST1 R5143 47k
PCO2 R5140 47k
a
R5124
M2LO PDAT R5144 47k
M2LO
CP5803
CP5801
PCK R5141 47k
2k
BUS LINE
8VL R5138 1k R5145 47k
8VL
5V R5139 1k R5142 47k
5V
J5801 P5801
HV13V
D1LO D1LO to MAIN
unit J2301
CP5802
PLL UNIT(1)
11 - 7
11-2-7 DSP BOARD
DSP BOARD 3.36V

5.01V
L2 L3
#01:80ns 2.2µ 2.2µ
1.82V
33
27
15
#02:160ns
IC3 IC4 R151
2.6V 68
14 SN74AHC74PW 14 SN74AHC74PW 4.07V 6.84V
R161
R162
R171
#01:40ns C4 V+ C7 V+
#02:80ns 0.0047 GND 0.1 GND #01:10.4µs L101 L102 7.61V
0.4V 2.2µ 2.2µ IC152 IC161 IC171
0V 7 7 #02:20.8µs
2.3V IC101 TK11218CM BA033FP TK11250CM
SN74HCT244APW C101 IC102 1 6
0.1 CONT VIN 1 CONT 6
3.3V BU9480F VIN
0.9V 1 20 2 GND GND 5 2 5
O GND GND
0V 2 ENA VCC 19 8 1 3 N.BYPASS VOUT 4 I 3 4
L1 C1 VCC OUTR N.BYPASS VOUT
IC3 0V 3 A1 ENB 18 7 2 G
EP2 2.2µ 0.0047 BCLK REF
1 13 SN74AHC74PW 1 13 4 YB4 YA1
0.1
0.1
0.1
0.1
0.1
0.1
0.1
0.1
17 6 3
10
10
22
10
10
10
SDATA GND
IC1 5 A2 B4 16 5 4
LRCLK OUTL
6 YB3 YA2
CLK
CLK
CLK
CLK
TC7WHU04FU 2 5 12 9 2 5 12 9 15
C154
C155
C158
C156
C157
C161
C162
C163
C164
C171
C172
C175
C173
C174
CP1 D Q D Q D Q D Q
C.P8S 8 1 W1 7 A3 B3 14
7 2 3 6 11 8 3 6 11 8 8 YB2 YA3 13
6 3 CK Q CK Q CK Q CK Q 9 A4 B2 12 C102 C103 C104
PR
PR
PR
PR
5 4 IC3 10 YB1 YA4 11 10 0.1 10
GND B1
C6 R3 C8 C9 SN74AHC74PW 4 10 4 10
47p 47k 10p 5p
R2 IC4 IC4
470 SN74AHC74PW SN74AHC74PW
X1
CR-628 #01:5.2µs
#02:10.4µs
3.3V
OBSY
W2
IBSY
OBS
IBS
R1 0V
C2 C3
33p 1M 33p
W151 W3
L801 IC201 DSP02 DSP02 DSP02
W203
W202
IC801 2.2µ M29W102BB W902 W171 W152
SN74AHC244PW C802 A09 1 40
0.001 A9 VSS B
1 VCC 20 A10 2 39 A08
ENA A10 A8
2 ENB 19 A11 3 38 A07 AGC1 DSP02 AGC1 DSP02 AGC1 DSP02 L501 L502
A1 A11 A7
3 8V CP801 A12 4 37 A06
YB4 YA1 18 A12 A6 C202
2.2µ 2.2µ
4 B4 17 FBSY CP811 A13 5 36 A05
A2 CP812
A13 A5 0.1 C
5 YA2 16 FOK A14 6 35 A04
YB3 A14 A4
6 B3 15 GND1 CP802 A15 7 34 A03
1.7V A3 A15 A3
1.5V 7 YA3 14 FSTB CP803 8 33 A02
YB2 NC A2 L601
8 FCK CP804 9 32 A01 5 1
A4 B2 13 W201 W A1 R601 100µ
0V 9 CP805 10 31 A00 2
YB1 YA4 12 FDAT VCC A0 1.2k IC601
10 DRES CP806 11 30 4 3
GND B1 11 RP G 2.83V 8 BA15532F
0.1
FINT CP807 12 29 D00
10
L51 C51 E DQ0
FENA CP808 D15 13 28 D01 IC202 V+
2.2µ 0.0047 DQ15 DQ1
CP301 FDIS CP809 D14 14 27 D02 TC7SH04FU GND
C604
C603
DQ14 DQ2
IC51 GND1 CP810 D13 15 26 D03 R501 4
100k
DQ13 DQ3 4.7
100k
100k
TC7WHU04FU R602 C601
100k
D12 16 25 D04
100k
0.0047
DQ12 DQ4
8 1 D11 17 24 D05 IC501 4.7k 10
DQ11 DQ5 R607 R609
7 2 D10 18 23 D06 AK4528VF
DQ10 DQ6 2.83V 4.7k 4.7k
R802
6 3 D09 19 22 D07 1 28
DQ9 DQ7 VCOM AOUTR+
R803
R804
R805
R801
C801
5 4 Q201 D08 20
DQ8 VSS
21 C203 0.1 2
AINR+ AOUTR-
27
XP4312 3
AINR- AOUTL+
26
R608 R610 C606
W303 4 25 IC601a IC601b
C201 5 1 AINL+ AOUTL- R603 BA15532F 4.7k BA15532F 4.7k 1
R52 X51 5 24 2 6
0.1 2 AINL- DGND 390
100 CR-709 6 23 1 7
R201
4 3 VREF VD
1k
1k
1k
1k
4
47k
3 7 22 3 5
AGND VT
8 21 R611 C602
VA DEM1
L301 L302 L52 5 2 IC203 9 20 5.6k 0.0015
R329
R330
R331
R332
TC7SH32FU P/S DEM0
2.2µ 2.2µ 1.0µ 10 19
MCLK PDN
6 1 11 18
LRCK DFS R604
12 17
C53 R51 C52 C54 BICK CSN 390
13 16
5p 1M 5p 0.01 SDTO CCLK
14 15 R605 R606 C605
SDTI CDTI 0.1
W302
C511 22p
C504 2.2
C505 0.1
C507 0.1
C508 0.1
C509 0.1
1k 1k
C506 22
C510 22
L651
W501 100µ
A B C
R322 IC651
47 8 BA15532F
0.1
10
3.93V V+
GND
C653
C652
4
W311
W312 R655 R657

4.7k 4.7k
2.83V
Q301 R656 R658 C655

DTC144EU KEYIN 4.7k 1
R651 4.7k
UNLK 2 6
390
D302 DA221 1 7
0.0047
0.0047
D301 3 5
W308
W309
R323 R324 DA221 IC651a IC651b

0.1
0.1
0.1
10k 10k R659 C651

L401 2.2µ 5.6k 0.0015 BA15532F BA15532F
D00
C307
C308
C309
C311
C312
Q302 R652
DTC144EU D01 1 16
D303 DA221 QB VCC 390
D02 2 15
QC QA 2.83V R653 R654 C654
D03 3 14 DI
D04 4 QD SI 13 1k 1k 0.1
D05 5 QE G 12
2.2k
2.2k
10k
10k
10k
10k
10k
10k
10k
10k
10k
D06 6 QF RCK 11 CK
CP300
D07 7 QG SCK 10
QH SCLR L701
D304 DA221 8 9 100µ
GND QH’
R306
R305
R308
R309
R310
R303
R304
R311
R312
R313
R307
C401 L406
IC401 IC701
W310
0.0047 2.2µ
8 µPC4570G2
0.1
SN74AHC595PW
C704 10
V+
GND
C703
4 J901
C406 14 DSPI1 1 2 GND
0.0047 IC406 2.5V GND GND
V+
SN74AHC74PW 1 R701 R703 GND DSPI2
GND 4.7k 3.3k
144
143
142
141
140
139
138
137
136
135
134
133
132
131
130
129
128
127
126
125
124
123
122
121
120
119
118
117
116
115
114
113
112
111
110
109
GND GND
7
CLK
5 2 8V 8V
Q D C702 GND GND
A21
DVDD
A22
A23
VSS
RSV0
RSV1
CVDD
CLKMD0
CLKMD1
PLLVSS
XIN
XOUT
PLLVDD
EXTCLK
DVDD
SHZ
RESET
VSS
MCBL/MP
EDGEMODE
CVDD
INT0
INT1
INT2
INT3
VSS
XF0
XF1
DVDD
TCLK0
TCLK1
VSS
DX0
FSX0
CLKX0
C701 R704 IC701b

6 3 RQI 100p µPC4570G2 AGC2 AGC1
IC406 Q CK 270p 6.8k C708
2.5V 6 GND GND
PR
C320 SN74AHC74PW R702 10
7 DSPO1 GND
0.1 4.7k
1 108 MEASUREMENT CONDITIONS 4 5 GND GND
2 A20 DVDD 107 GND 21 22 DSPO2
VSS CLKR0 frequency : 14.1MHz USB R707 R706
3 106 IBS R705
A19 FER0 SG input : off 1k 3.3k 6.8k
4 105 Digital tester OBS C705 C901
C301 5 A18 VSS 100p to MAIN
104 Oxilloscope(20MHz) 0.001
0.0047 A17 DR0 unit J1102
6 103 Voltage at rx 3.84V
7 DVDD TRST 102 C321 13 R708 C707 C706
A16 TMS 0.1
A15 8 101 1k 100 0.1
A15 CVDD C407 L403
CLK
9 100 9 12
VSS TDI 0.001 2.2µ Q D
A14 10 99
A13 11 A14 TDO 98 8 11 ROO
IC403 2.49V
C302 0.0047 12 A13 TCK 97 SN74AHCT374PW Q CK R751 R753
PR
CVDD VSS 4.7k 3.3k
A12
A11
13
14 A12
A11
EMU0
EMU1
96
95
R320
R321
4.7k
4.7k
C322
0.0047
20
19 VCC O-CTRL 2
8Q 1Q 3
1
OUT1 IC406
10
MAIN UNIT (3)
C303 0.1 15 94 D15 18 SN74AHC74PW C752 IC701a
DVDD DVDD 8D 1D 4 R754
A10 16 93 D00 D14 17 C751
6.8k
100p µPC4570G2 C758 J1102
A09 17 A10 D0 92 16 7D 2D 5 OUT2 DRES 270p
D01 2.49V 2 10 2 1
18 A9 D1 91 15 7Q 2Q 6 OUT3 R752 1 DSPI1 GND
IC301 D02
19 VSS D2 6Q 3Q 7 4.7k GND GND
A08 TMS320VC33PGE120 90 D03 D13 14 3
A07 20 A8 D3 89 D12 13 6D 3D 8 GND DSPI2
A06 21 A7 VSS 88 12 5D 4D 9 OUT4 R757 R755 R756 GND GND
D04 3.3k
22 A6 D4 5Q 4Q 10 1k 6.8k 8V 8V
A05 87 D05 11 C755
C304 0.0047 23 A5 D5 86 C323 0.1 CLK GND 100p GND GND
A04 24 DVDD DVDD AGC2 AGC1
85 D06 C403 3.84V
25 A4 D6 0.0047 C757 GND GND
84 D07 R758 C756
VSS D7 DSPO1 GND
A03 26 83 C324 0.0047 1k 100 0.1
A3 CVDD GND GND
A02 27 82 D08 OUT5 GND 22 DSPO2
C305 0.1 28 A2 D8 81 OUT6 21
D09
A01 29 CVDD D9 80 OUT7
A00 30 A1 VSS 79 OUT8
D10
C306 0.1 31 A0 D10 78 D11
D11
32 DVDD D11 77 D10
C325 0.0047
CP302 33 PAGE3 DVDD 76 D09
D12
CP305 34 PAGE2 D12 75 D08
D13
35 VSS D13 74 W903
D14
CP304 36 PAGE1 D14 L404 2.2µ
73 D15 R904
CP303 PAGE0 D15 10k
IC404 L405
SN74AHCT374PW C408 2.2µ
HOLDA
10k
10k
10k
10k
W904
DVDD
DVDD
CVDD
DVDD
DVDD
CVDD
DVDD
J902
HOLD
STRB
20 1 0.001
IACK
VCC O-CTRL J1101

RDY
VSS
VSS
VSS
VSS
VSS
R/W
D31
D30
D29
D28
D27
D26
D25
D24
D23
D22
D21
D20
D19
D18
D17
D16
D0H 19 2 D0A GND1 2 1 192K

H1
H3
8Q 1Q IC405
D07 18 8D 1D 3 BU4021BF GND1 GND1 GND1 1 2 192K
R325
R326
R327
R328
D06 17 4 D0H 1 16 RQI IBSY GND1 GND1

7D 2D H VDD
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
D0G 16 5 D0B 2 15 D0G [#02]only CK DI RQI IBSY

7Q 2Q QF G CK DI
D0F 15 6Q 3Q 6 D0C 3 QH F 14 D0F GND1 GND1
CP306 CP360 GND1 GND1
PD D05 14 6D 3D 7 D0D 4 D E 13 D0E RQO DO
CP307 CP359 RQO DO
EMU1 D04 13 8 D0C 5 12 OBSY STBO
10k
10k
CP308 CP358 5D 4D C QG OBSY STBO

TDI D0E 12 5Q 4Q 9 D0D D0B 6 B SER 11 GND1 GND1
CP357 GND1 GND1
TDO 11 CLK GND 10 D0A 7 A CLK 10 OUT1 OUT2
CP356 OUT1 OUT2
TMS 8 VSS P/S 9 STBO OUT3 OUT4 OUT3 OUT4
CP355
R317
R318
EMU0 C404 OUT5 OUT6 OUT5 OUT6

TCK CP354 0.0047 C405 OUT7 OUT8 OUT7 OUT8
TRST CP353 0.0047 W951 GND1 GND1
CP352 GND1 GND1
KEYIN UNLK KEYIN UNLK
CP351 DRES 30 29 GND1 DRES 29 GND1
30
0.0047
0.0047
0.0047
0.0047
D03 DO
D02 D901
0.1
0.1
0.1
to MAIN
10k
10k
10k
D01 MA729
W901
unit J1101
D00 R905 R906
C313
C314
C315
C316
C317
C318
C319
W952 10k 10k
R901
R902
R903
11 - 8
11-2-8 FILTER BOARD
RL7031 RL7032
AJS1315 AJS1315
L7036 LR-236 L7037 LR-226 L7038 LR-227
1.6-1.9999 MHz
L7035 C7034 470p C7037 300p C7041 10p
100µ L7031 100µ
L1M
C7035 470p C7038 270p C7049 180p
C7031 1
C7032
C7046
C7036 0.0022
C7039 0.0027
0.1
0.1
C7033 0.001
C7042 390p
C7043 390p
C7044 390p
C7045 330p
RL7061 RL7062
AJS1315 AJS1315
L7066 LR-263 L7067 LR-235 L7068 LR-236
2-2.9999 MHz
L7065 C7066 330p C7074 270p C7080 120p
100µ L7061 100µ
L2M
C7067 270p C7075 330p C7081 120p
C7061 1
C7062
C7085
C7068 270p
0.1
0.1
C7069 270p
J7001
to PA P7001
FLIN
unit
C7063 100p
C7064 470p
C7065 470p
C7087 120p
C7070 100p
C7071 470p
C7072 470p
C7076 330p
C7073 470p
C7077 330p
C7078 390p
C7079 470p
C7082 390p
C7083 390p
J6401
C7086 10p
C7084 68p
RL7091 RL7092
AJS1315 AJS1315
L7096 LR-238 L7097 LR-235 L7098 LR-235
3-4.9999 MHz
L7095 C7094 330p C7106 150p C7100 100p
100µ L7091 100µ
L4M
C7091 1
0.0047
0.0047
C7092
C7102
C7105 470p
C7095 390p
C7096 390p
C7098 330p
C7099 470p
C7101 300p
C7107 82p
RL7121 RL7122
AJS1315 AJS1315
L7126 LR-237 L7127 LR-263 L7128 LR-263
5-6.9999 MHz
L7125 C7124 120p C7126 10p C7130 56p
100µ L7121 100µ
L6M
C7127 120p C7131 5p
C7121 1
0.0047
0.0047
C7122
C7133
C7136 180p
C7137 100p
C7125 390p
C7128 270p
C7129 300p
C7132 300p
RL7151 RL7152
AJS1315 AJS1315
L7156 LR-241 L7157 LR-237 L7158 LR-237
7-9.9999 MHz
L7155 C7153 82p C7155 120p
33µ L7151 33µ
L8M
C7156 10p C7158 82p
C7151 1
0.0047
0.0047
C7152
C7160
C7154 390p
C7157 390p
C7163 180p
RL7181 RL7182
AJS1315 AJS1315
L7182 LR-243 L7183 LR-242 L7184 LR-242
10-13.9999 MHz
L7185
33µ L7181 33µ
L12M
C7184 120p C7186 56p C7188 22p
C7181 1
0.0047
0.0047
C7182
C7190
C7183 120p
C7185 270p
C7187 330p
C7193 180p
RL7211 RL7212
AJS1315 AJS1315
L7216 LR-242 L7217 LR-242 L7218 LR-242
14-19.9999 MHz
L7215 C7214 47p C7216 27p
10µ L7211 10µ
L16M
C7211 1
0.0047
0.0047
C7212
C7218
C7222 200p
C7217 120p
C7221 82p
C7223 82p
C7225 10p
C7224 33p
RL7241 RL7242
AJS1315 AJS1315
L7248 LR-262 L7245 LR-262 L7246 LR-262
20-29.9999 MHz
L7244 C7244 22p
10µ L7241 10µ
L22M
C7254 22p C7247 22p
0.0047
0.0047
C7241
C7250
C7242 100p
C7253 150p
C7243 56p
C7248 33p
C7249 39p
CP7332
J7331
GND L7271 R7272 R7273 C7272 L7272
100µ 2.7k 4.7k 0.0022 LR-391 ANT
FOR
GND J7311 J4501
C7275
1SS322
0.0047
C7345
R7271
C7278
REF ANT
D7271
10p
R7274 33
47p
10k
GND Q7301 RL7301

GND DTC114EU AGP2013
C7277
L7273 R7276 R7277 C7274 2

180p
L1M W7340
100µ 2.7k 4.7k 0.0022
to MAIN L2M W7339
1
C7302 0.0047
C7303 0.0047
unit J1301 L4M W7338

R7314 SA05
D7301 1SS355
1SS322
R7315 82k
4
R7275
C7279
C7301 0.0047
L6M W7337
D7272
47p
10k
L8M W7336
CP7331 3
L12M W7335
L16M W7334 L7321 J7321
LR-170 P7321 to
L22M W7333 6 MRX MAIN
L7332 100µ R7301 10 unit
S13V
5 C7325 J51
TRXS 0.68
0.0047
0.0047
C7332
C7304
L7331 100µ C7322

C7321
C7323
18p
100p
100p
FILTER BOARD
11 - 9
1-1-32, Kamiminami, Hirano-ku, Osaka 547-0003, Japan S-13901HZ-C1
C 2002 Icom Inc.

Icom IC-M802 Service Manual

Uploaded by

Document Informationclick to expand document information

Copyright:

Available Formats

Icom IC-M802 Service Manual

Uploaded by

Document Information

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

Icom IC-M802 Service Manual

Uploaded by

Copyright:

Available Formats

SERVICE

MF/HF MARINE TRANSCEIVER

DO NOT expose the transceiver to rain, snow or any liquids.

ORDERING PARTS REPAIR NOTES

SECTION 2 INSIDE VIEWS

SECTION 3 CIRCUIT DESCRIPTION

SECTION 4 ADJUSTMENT PROCEDURES

SECTION 5 PARTS LIST

SECTION 6 MECHANICAL PARTS AND DISASSEMBLY

SECTION 7 SEMI-CONDUCTOR INFORMATION

SECTION 8 BOARD LAYOUTS

SECTION 9 BLOCK DIAGRAM

SECTION 10 WIRING DIAGRAM

SECTION 11 VOLTAGE DIAGRAMS

• Spurious response rejection : More than 70 dB

• SP-24 External speaker

All stated specifications are subject to change without notice or obligation.

DSC 1st mixer

The 3rd IF signal is applied to the IF amplifier (MAIN unit;

MAIN UNIT DSP UNIT

IC1002 Q501 Q401 Q203

3-2-3 SPEECH COMPRESSOR CIRCUIT

• TRANSMIT CONSTRUCTION 3rd LO

3-2-8 RF METER CIRCUIT (MAIN UNIT)

3-3-2 1ST LO PLL (PLL UNIT)

(2) MAIN LOOP PLL

PLL IC (IC5401) MAIN loop VCO

3-6-2 DISPLAY BOARD (RC-25) VOLTAGE LINE

3-7-5 OUTPUT EXPANDER IC (IC3603)

3-7-6 OUTPUT EXPANDER IC (IC3605)

■ REQUIRED TEST EQUIPMENT

DC power supply Output voltage : 7.2 V DC Frequency range : 300–3000 Hz

Frequency range : DC–600 MHz Frequency range : DC–20 MHz

Standard signal Modulation analyzer

DO NOT transmit while

DC power supply Ammeter

■ OPERATING ON THE ADJUSTMENT MODE

Push [1] SET

TX ADJUSTMENT ITEM CHANGING

RX ADJUSTMENT ITEM CHANGING

• PLL UNIT TOP VIEW

• FILTER UNIT BOTTOM VIEW

• IC-M802 BOTTOM VIEW

CP7331 (REF line)

CP7332 (FOR line)

• RC-25 FRONT PANEL

• RC-25 FRONT PANEL

R7271 7030003560 S.RESISTOR ERJ3GEYJ 103 V (10 kΩ)

EP6001 0910054694 PCB B 5724D C7031 4510005480 ELECTROLYTIC 50 MV 1 HC

RL7031 6330001570 RELAY AJS1315

Q201 1590001660 S.TRANSISTOR XP4312 (TX)

D301 1750000370 S.DIODE DA221 TL

X1 6050009860 S.XTAL CR-566 (12.288 MHz)

L1 6200003280 S.COIL NL 252018T-2R2J

R1 7030003800 S.RESISTOR ERJ3GEYJ 105 V (1 MΩ)

J901 6910013900 CONNECTOR IMSA-9180S-22A

X8211 6050010501 S.XTAL CR-636A (14.7456 MHz)

L8201 6200001830 S.COIL NL 322522T-100J

R8201 7030003640 S.RESISTOR ERJ3GEYJ 473 V (47 kΩ)