Wabco Gen Catalogue 2014 LR

WABCO
Automotive South Africa

QUICK CATALOGUE 2014
ABS Components-Truck/Bus
34
Line Filter
23
ABS/EBS - Speed Sensors
38
Load Regulating Valve
12
Adaptor Valves
13
Load Sensing / Levelling Valve Parts
32
Load Sensing Valves -Air Susp
19
Air Dryers
Air Processing Units
10
Load Sensing Valves -Mech Susp
18
Air Reservoirs
13
Low Pressure Switches
12
Air Throttle Valves
29
Non-Return Valves
25
Brake Chambers
29
Nylon Pipes
33
Brake Chambers -Disc Brakes
30
Operating Cylinders
27
Cartridges - Desiccant
Pressure Limiting Valves
12
Charging Valves
11
Proportional Valves
27
Clutch Servos
24
Quick Release Valves
20
Compressors
Raise / Lower Valve
23
Condensor Drain Valves
13
Relay Emergency Valves
21
Couplings (Duomatic)
28
Relay Valves
22
Couplings (F & J)
29
Rubber Hose
33
Couplings (Palm)
28
Safety Valves
25
Cylinder Heads
Servo - Air / Hydraulic
26
Diagnostic Software
40
Shut-Off Cock
21
Diaphragms
32
Silencers
28
Door Control Valve
28
Solenoid Valves
27
Double Check Valves
25
Spiral Binding
33
Double Diaphragm Spring Brakes
31
Spring Boxes
19
Double Diaphragm Spares
31
Spring Brakes
30
Drain Valves
13
Spring Brakes Wedge
30
EBS Components - Trailers
36
Spring Brakes -Disc Brakes
30
EBS Components - Truck
34
Spring Brake Spares
31
EBS Software
40
Stop Light Switches
12
ECAS Truck Components
35
Suzy Pipes
33
Electrical Suzy
33
Test Equipment ABS
40
Empty Load Valves
13
Test Equipment Pneumatic
41
Exhaust Brake Valves
25
Throttled Check choke Valve
25
Foot Brake Valves
14
Trailer Control Valves
20
Four Circuit Protection Valves
11
Trailer Release Valve (PREV)
21
Gearbox / Control / 3/2-way
26
Unloader Valves
Governor Valves
Hand Control Valves
15
FITTINGS CATALOGUE
Levelling Valves
23
Compression Fittings
43
Lift Axle Control Valves
38
Push In Fittings
49
This manual is subject to copyright and should not be copied or otherwise distributed except with WABCOs express written permission
1/53
WABCO
PARTS CATALOGUE 2014
TRUCK COMPONENTS
1 Suction Strainer
14 Brake Chamber
2 Compressor
15 Foot Brake Valve
3 Air Dryer
16 Park Brake Valve
4 Four Circuit Protection Valve
17 Trailer Control Valve
5 Reservoir Circuit 2 (Front Brakes)
18 Relay Load Sensing Valve
6 Reservoir Circuit 1 (Rear Brakes)
19 Spring Brakes
7 Reservoir Circuit 3 (Park Brakes / Trailer)
20 Relay Valve
8 Reservoir (Regeneration)
21 ABS ECU
9 Exhaust Brake Valve
22 ABS Warning Lamps
10 Pressure Gauges
23 ABS Solenoid Valve (Front)
11 Coupling (Red) Emergency Line
24 ABS Solenoid Valve (Relay)
12 Coupling (Yellow) Service Line
25 Power Supply Cable (Trailer)
13 Non Return Valve
26 Stop Light
3/53
WABCO
TRAILER COMPONENTS
27 Coupling (Red) Emergency Line
40 ABS Solenoid Relay Valve (Steering Axle)
28 Coupling (Yellow) Service Line
41 Brake Chamber
29 ABS Power Supply Cable
42 Spring Brake
30 ABS Diagnostic Cable
43 Spring Brake
31 Line Filter
32 Line Filter
33 Park Shunt Valve
34 Relay Emergency Valve
35 ABS ECU
36 Air Reservoir
37 Relay Load Sensing Valve
38 ABS Modulator Relay Valve
39 Quick Release Valve
4/53
WABCO
COMPRESSORS
411 003 000 0
411 003 001 0
411 003 011 0
Single Cylinder Compressor
ASA5272
ASA5273
411 003 340 4
411 141 623 2
ASA6282
411 003 733 2
A97/147
432 600 000 0
Gasket kit including oil seal

Ring Set (75mm Bore)
Con Rod Bearing
Piston Complete
Head Kit for 411 003 011 0 only
Con rod Complete
Pulley 8" Diam
Filter - Wet Suction
411 034 501 0
229cm3. UD (Rotation Forced Oiling.)
150cm3 - Self Lube (75mm Bore)

411 003 000 0 Superceded to 411 003 011 0
MERCEDES 355
AC (Air Cooling). 2800 RPM max.
Vickers. Flange. (90mm Bore)
ASA5280
ASA5281
ASA5410
ASA6501
411 042 340 4
411 042 341 4
411 042 620 2
Head Kit
Ring Set 90mm
Complete Repair Kit
Main Bearing Bush
Con rod Bearing per half
Piston Complete with rings
411 041 845 0

ASA5277
ASA5278
ASA5273
411 042 340 4
411 042 341 4
Head Kit
Ring Set 75mm
Main Bearing Bush
Con rod Bearing per half
411 141 000 0
Single Cylinder (75mm Bore) Mono block

DEUTZ / IVECO / BELL COMPRESSOR
411 042 341 4

411 141 205 4
ASA5273
ASA6312
ASA6313
A97/147
411 141 623 2
Con Rod Bearing per half

Main Bush
Ring Set 75mm
Head Kit
Gasket Kit
Pulley 8" Diam
Piston and Rings
411 143 805 0
293cm3. UD. AC. 3000 RPM max (90mm Bore)

DEUTZ / IVECO COMPRESSOR
ASA 5371
897 316 999 4
897 670 190 4
811 408 040 4
ASA 5410
411 141 205 4
Head Kit ADE 407

Gasket (not in kit above)
O Ring Front
Oil Seal
Ring Set 90mm
Bush
411 142 711 0
229cm3 Single Cylinder UD. 3000 RPM max (90mm Bore)
411 142 623 2

411 142 651 4
ASA 5410
411 142 002 2
MERC 1924
Piston and Rings
Cylinder Head
Ring Set 90mm
Gasket Kit only
5/53
WABCO
COMPRESSORS Continued
411 145 507 0
Water Cooled, UD, 203cm3 (75mm Bore)

3000 PRM Vickers Flange.
MAN
411 041 050 4

411 041 051 4
411 042 341 4
411 141 623 2
411 145 000 2
411 145 653 2
ASA5273
Valve Plate (not in kit)

Leaf Valve (not in kit)
Con Rod Bearing per half
Piston Complete with rings 75mm
Gasket Kit
Cylinder head only (NO GASKET with head)
Ring Set 75mm
412 352 003 0
352cm3 UD, 3000 PRM (85mm Bore)

Watercooled
MAN
412 352 001 2

911 004 202 4
911 501 624 2
911 145 738 2
412 352 924 2
895 073 589 4
ASA6690
Gasket Kit
Main Bearing Bush
Piston With Rings 85mm
Con Rod
Cylinder Head L shape
Sump (welsh) Plug
Ring set Per Piston 85mm
411 151 003 0
411 151 009 0
Single Flange Compressor (85mm Bore)

Flange, Water Cooled 411 151 008 0 supercedes
MERCEDES
Supercedes 411 151 008 0
411 154 002 2

911 501 624 2
411 154 000 2
411 151 052 4
ASA6690
Cylinder Head ( Includes gasket) old no 411 154 800 2

Piston and Rings
Gasket Kit
Gasket Barrel to Valve Plate
412 154 004 0
352cm3. UD. WC. 3000 RPM max.

Flange Compressor (85mm Bore)
ACTROS / ATEGO / BELL
Supercedes: 411 154 000 0 and 411 154 003 0
Mercedes Number: A9061304915
411 154 800 2

911 501 624 2
911 145 738 2
411 154 000 2
411 151 052 4
ASA6690
Cylinder Head & Gasket

Piston and Rings
Con Rod
Gasket Kit
Gasket Barrel to Valve Plate (Incl in gasket kit above)
412 352 027 0
Single Cyl Water Cooled (85mm bore)

352cm3. UD. WC. 3000 RPM max.
Replaces 412 352 016 0 & 412 352 014 0
AXOR
911 501 624 2

ASA6690
412 352 923 2
412 352 922 2
Piston and Rings

Gasket Kit
Cylinder Head
A457 131 01 80
MUST USE Flange Seal ****

**** only from Merc dealers ***
6/53
WABCO
412 704 008 0
412 704 001 0
412 704 004 0
412 704 005 0
Twin Cylinder with PR (Power Reduction) Valve

704cm3. WC. (85mm bore)
VOLVO FH12 (20701801)
412 704 932 2

412 704 920 2
911 501 624 2
911 505 732 2
ASA6690
Cylinder Head c/w metal gasket

Gasket kit
Piston with rings x2
Conrod
412 704 014 0

S/S 412 704 006 0
VOLVO FM9
412 704 933 2

911 501 624 2
ASA6690
Head & Gasket

Piston and Rings
412 704 015 0

704cm3. WC. (85mm bore) 3 Hole Mounting Off Centre
VOLVO (20845313)
412 704 933 2

ASA6690
911 501 624 2
Head & Gasket for 412 704 015 0

Piston and Rings
412 704 018 0

S/S 412 704 015 0
704cm3. WC. (85mm bore) 3 Hole Mounting Off Centre
VOLVO (21172036)
412 704 940 2

ASA6690
911 501 624 2
Head & Gasket for 412 704 018 0

Piston and Rings
911 142 000 0
229cm3 Single Cylinder (90mm bore)
411 142 623 2
Piston and Rings
911 504 506 0
Twin Cylinder WC.

443cm3. UD. WC. (75mm bore) 3000 RPM max.
DAF 95X COMPRESSOR Replaces 911 504 504 0 (1736785)
911 504 920 2

411 141 623 2
A6608
911 504 923 2
Cylinder Head
Piston with Rings x2
Ring Set x2 75mm
Gasket Kit
911 506 505 0
440cm3, UD. WC. 3000RPM. Flange (75mm Bore)

Steering Pump
IVECO Bus
911 506 928 2

411 141 623 2
911 506 924 2
A6608
ASA7073
Gasket Kit
Piston with Rings
Kit (Bottom) Welsh plug and front bearing
Ring Set x2 75mm
Repair kit complete
7/53
WABCO
911 506 054 0
Twin Cylinder 440cm3 (75mm Bore)

Flange Compressor
IVECO
911 506 691 4

911 145 734 2
411 141 623 2
911 506 925 2
A6608
Crankshaft
Con Rod
Piston
Cylinder Head
Ring Set x 2 75mm
M100960
Single Cylinder 160cm3

Air Cooled (65mm Bore)
TATA
M111410
MSP1/226
MSP1/216
Valve Plate
Ring Set
Gasket Kit
412 100 805 2 S/S Water Cooled Head

412 100 806 2
MAN F2000
Note: Excluding Cylinder Head Gasket
412 090 803 2

412 090 801 2
MAN TGA - COMPRESSOR HEAD ONLY

NO GASKET with Head
412 090 921 2
For TGA buy 2 heads

(51 541146081)
411 033 801 2
ADE 400 COMPLETE HEAD (THIN PLATE) - M/BENZ
ASA5371
Head kit
912 551 001 0

912 551 002 0

UD (NISSAN DIESEL) -Compressor exclusive to UD
COMPRESSOR HEAD ONLY
912 551 921 2

ASA6690
Cylinder Head
Ringset Per Piston 85mm
912 510 103 0
912 510 104 0
Twin Cylinder WC.

AXOR
Use 912 510 103 0 Move plug as required
912 510 920 2
Cylinder Head
A457 131 01 80
MUST USE Flange Seal ****

**** only from Merc dealers ***
VARIOUS
411 553 003 0
411 553 921 2
ATEGO BUS S/S 411 553 001 0

repair kit
Universal Cylinder Head

412 704 940 2
Head & Gasket for the following Compressors
911 505 150 0

911 505 001 2
TWIN COMPRESSOR VOLVO FL7

repair kit
911 506 505 0

911 153 525 0
911 154 510 0
911 154 920 2
TWIN 75MM BORE (IVECO)

CUMMINS Only
CUMMINS Only
Head for 911 154 500 0
412 704 018 0

912 512 008 0
912 514 003/4 0
912 551 002 0
VOLVO
VOLVO
Renault
Nissan
911 155 521 0
SINGLE CYLINDER VW
8/53
WABCO
UNLOADER AND GOVERNOR VALVES
975 303 473 0 / 474 0
275508
Part Number
Cut Out Pressure
Repair Kit
975 303 473 0

975 303 474 0
275508
8.1 Bar 2 Port

8.1 Bar 4 Port
7.6 Bar (cut in 5.8bar)
975 303 001 2

975 303 001 2
26723
Service Kit
ASA 5698
ASA 5698
ASA 5699
Description
Port size
General Truck / Bus

General Truck / Bus
ERF, Scania, International
M22 x 1.5
M22 x 1.5
1/8"
GENERAL AIR DRYERS
432 410 083 0
432 410 113 / 117 0 / 202 0
Part Number
432 410 000 0
432 410 200 0
432 410 022 0
432 410 083 0/095 0
432 410 101 0
432 410 111 0
432 410 113 0
432 410 117 0
432 410 202 0
432 410 120 0
432 410 720 0
432 415 029 0
432 415 055 0
432 415 138 0
432 420 002 0
432 421 008 0
432 431 008 0
432 432 279 0
932 400 001 0
932 400 002 0
932 400 005 0
932 400 024 0 Note
432 425 105 0 Note
932 510 004/5 0 /6 0
432 410 552 2
432 420 002 0 / 008 0
Unloader
Repair kits
Dryer
Cartridge
Cut Out
Pressure
432 410 001 2

432 410 001 2
432 410 001 2
432 410 001 2
432 410 002 2

432 410 002 2
432 410 002 2
432 410 002 2
432 410 222 7

432 410 222 7
432 410 222 7
432 410 927 2
8.1 Bar
8.1 Bar
9.5 Bar
9.3 Bar
432 410 001 2

432 410 001 2
432 410 001 2
432 410 002 2

432 410 002 2
432 410 002 2
432 410 222 7

432 410 222 7
432 410 222 7
432 410 001 2

No Repair Kit
432 410 002 2
432 410 222 7

432 410 222 7
12.5 Bar
10 Bar
8.1 bar
12.5 Bar
12.5 Bar
8.3 Bar
10 Bar
10 Bar
13 Bar
13 Bar
432 410 001 2
432 410 001 2

432 410 001 2
432 410 001 2
432 410 001 2
432 410 001 2
NOTE AIR DRYERS: ASA7070

ASA7015
Note: 432 425 920 2
A6645
432 415 921 2

432 410 002 2
432 410 002 2
432 410 002 2
432 431 002 2
432 432 000 2
932 400 000 2
932 400 000 2
932 400 000 2
932 400 000 2
432 410 002 2
932 510 956 2
432 410 222 7

432 410 222 7
432 410 222 7
432 410 222 7
432 420 220 2
432 420 220 2
432 420 220 2
432 420 220 2
432 901 223 2
10 Bar
12 Bar
12 Bar
12 Bar
12 Bar
13 Bar
932 400 024 0
Description / Application
With 24V Heater same as 200 0
With 24V Heater cut out pressure tag
With 24V Heater Port 4 M12 Snap on Exhaust. Nissan
With 24V heater & port 4/23 PR valve line Scania
Superceded to 432 410 202 0
Superceded to 432 410 113 0 port22 M16 not M12
No Heater. Snap on Exhaust. Voss. MAN
No Heater. Snap on Exhaust. Voss. MAN F2000
Snap on Exhaust. Voss. General Use Piston A6645
Superseded to 432 410 720 0
with Unloader, MAN, TGA,TGL,TGS,TGM
With Heater. ERF.
Hino Similar to Rockwell Air dryer
Renault Similar to Rockwell Air dryer
No Heater Pt 4 M12 Ports M22 Merc Volvo
No Heater Unloader Pt 4 M16&M22 Snap on Exh. Voss
With Heater. Pt M22 Twin Cannister. Volvo.
With Heater. Twin Cannister. Volvo.
No Heater. for APU 932 500 001 0/006 0 No port 4
With Heater. for APU 932 500 005 0 No port 4
No Heater.for APU 932 500 013 0 with port 4 Actros
Replaces 010/ 020/ 050 Kit ASA7015 with mods Actros
Replaces 432 425 001 0/ 101 0 ECAD
Volvo FH FM
SCANIA
932 510 958 2 Quad Valve (No PC Board)
Exhaust
Repairs 432 410 to 432 421 . Dryer and Unloader section & include Vers A & B spares
Version B Piston 432 410 622 4 Version A Piston A6645
Repairs 932 400 001 0 / 002 0 / 005 0/ 024 0
Solenoid Kit
Piston (Brass)
9/53
WABCO
AMERICAN VEHICLE AIR DRYERS
432 413 003 0
0.7 Backflow. 12v With heater

INTERNATIONAL Rockwell Airdryer
Port 4 = 1/4" NPT.
Cut-out Pressure 7.9bar
432 413 925 2

432 420 926 2
432 413 934 2
432 413 929 2
ASA6953
432 410 222 7
Check Valve
Bypass Valve
Turbo Cut-off
Purge Valve
Service Kit
Cartridge
Old No 432 413 928 2
AIR PROCESSING UNITS

932 500 006 0
Combination Air dryer and Four Circuit

MERCEDES ACTROS
932 400 001 0

934 705 005 0
Air Dryer
Quad valve
432 415 055 0

UD Trucks
932 500 007 0

MERCEDES ACTROS
932 500 006 0
932 400 002 0

934 705 005 0
Air Dryer S/S 932 400 024 0

Quad Valve
Repair Kit :
432 410 001 2
932 400 000 2
432 420 220 2
Unloader kit
Dryer kit
Cartridge
934 705 005 0
AIR DRYER INSTALLATION KIT

7186210
4324102020
8114010324
8114010804
8282519086
8930100204
8930402104
8935111104
8938000140
8938000220
AGA179
AIR DRYER SINGLE UNLOADER

WASHER 12MM ALUMINIUM
WASHER 22MM ALUMINIUM
NYLON PIPE 6 X 1MM BLACK
PLUG M22 X 1.5
NYLON INSERT 6 X 1
PIPE CLAMP 6MM
UNION M12 X 1.5 X 6MM
UNION M22 X 1.5 X 6MM
AIR RESERVOIR 5L X 8"
AIR DRYER CARTRIDGES
432 410 226 2
432 420 220 2
Part Number
Port Thread
432 410 226 2

432 420 220 2
432 410 222 7
432 901 223 2
432 410 244 2
G 1 1/4" .
M39 x 1.5 .
M39 x 1.5 .
M39 x 1.5 .
M39 x 1.5 .
432 410 222 7
432 901 223 2
432 410 244 2
Description
Application
Max 13 Bar
Max 20 Bar. Without O Ring
Operating 13 Bar With 'O' Ring
Air System Protector 13 Bar + 'O' Ring
Air System Protector Plus 13 Bar
Scania Superceded by 432 410 927 2

Mercedes Actros
General. Use in place of 432 410 020 2
Extracts oil carry over
Improved ASP for heavy contaminant and oil
10/53
WABCO
MULTI CIRCUIT PROTECTION VALVES
934 702 210 /221/250 0
934 702 100 0/ 300 0/ 350 0
934 714 .
434 700 003 0
934 705 005 0
Application
Repair kit
.040 0
Part Number
Opening pressure Bar

21
22
23
24
934 702 040 0

934 702 210 0
934 702 221 0
934 702 250 0
934 702 100 0
934 702 260 0
934 702 300 0
934 702 320 0
934 705 005 0
934 714 010 0
934 714 003 0
934 714 110 0
934 714 211 0
934 714 137 0
934 714 400 0
934 714 128 0
934 714 140 0
934 714 740 0
934 714 145 0
934 714 151 0
434 700 003 0
932 500 501 1
6.0
7.0
7.0
7.0
7.0
7.0
7.0
7.0
9.0
6.9
6.9
6.9
6.5
6.2
6.9
6.5
6.3
6.3
6.5
6.5
5.2
6.0
7.0
7.0
7.0
7.0
7.0
7.0
7.0
9.0
6.9
6.9
6.9
6.5
6.2
6.9
6.5
6.3
6.3
6.5
6.5
5.2
5.5
7.0
7.0
7.0
6.0
7.0
7.0
7.0
7.5
7.0
6.9
7.0
7.4
6.2
6.9
7.4
5.8
5.8
7.2
7.5
N/A
897 181 531 4

CHARGING VALVES
5.5
7.0
7.0
7.0
6.0
7.0
7.0
7.0
7.5
6.9
6.9
6.9
6.5
6.2
6.9
6.5
5.8
5.8
6.5
6.5
N/A
Description
10 Bar 5 Port
Supp-M22 Del-M16
4 Circuit
10 Bar 7 Port
Supp-M22 Del-M16
General Truck/Bus
20 Bar 7 Port
Supp-M22 Del-M16
General Truck/Bus
20 Bar 5 Port
Supp-M22 Del-M16
General Truck/Bus
10 Bar 5 Port
Supp-M22 Del-M16
Merc, Iveco, DAF, Renault
20 Bar 5 Port
All ports M22
DAF, Powerliner
20 Bar 5 Port
Supp-M22 Del-M16
General Truck/Bus
20 Bar 5 Port
Supp-M22 Del-M16
Truck/Bus Alt ..322 0
13 Bar 23/24 limited 8.5Bar ports M22
Merc Actros 6 port
13 Bar 5 Port
Port1-M22 Del-M16
MAN
13 Bar 5 Port
3/8" NPTF/1/2"NPTF Leyland, Ford, International
13 Bar 5 Port
Port1-M22 Del-M16
Replaces 934 714 128 0
13 Bar 5 Port
Port1-M22 Del-M16
13 Bar 5 Port
934 705 001 2
MAN TGA
13 Bar 5 Port
M22 VOSS
SCANIA Repl 934 714 2110
13 Bar 5 Port
Port1-M22 Del-M16
13 Bar 7 Port
Port1-M22 Del-M16
13 Bar 7 Port
Port1-M22 Del-M16
Volvo
13 Bar 7 Port
Port1-M22 Del-M16
13 Bar 5 Port
Port1-BracketDel-M16 FAW Direct mounting
10 bar 2 Port
All ports M22
Mercedes Benz
Pressure Sensor for 934 705 005 0
Diaphragm only available in kit 935 705 001 2
934 702 000 2

ASA 5735
ASA 5736
ASA 5394
ASA 5393
934 702 004 2
ASA 5391
ASA 5735
934 705 001 2
434 700 003 2
(Single Circuit Protection Valves, Overflow Valves )
Part Number
Opening pressure
Port size
Repair kit
Description
434 100 023 0

434 100 024 0
434 100 034 0
434 100 122 0
434 100 123 0
434 100 124 0
434 100 220 0
434 100 222 0
434 100 224 0
434 100 227 0
434 100 228 0
897 131 741 4
5.5 Bar
6.0 Bar
6.8 Bar
4.5 Bar
5.0 Bar
5.5 Bar
4.5 Bar
6.2 Bar
1.7 Bar
5.5 Bar
6.4 Bar
M22 x 1.5
M22 x 1.5
M22 x 1.5
M22 x 1.5
M22 x 1.5
M22 x 1.5
M22 x 1.5
M22 x 1.5
M22 x 1.5
M22 x 1.5
M22 x 1.5
ASA5699
ASA5699
ASA5699
ASA5699
ASA5699
ASA5699
With return flow

With return flow
With return flow
No return flow
No return flow
No return flow
With Limited return flow
Diaphragm for 434 100 . . . . . . .
11/53
WABCO
PRESSURE LIMITING VALVES (Regulators)
475 009 026 0
475 010 010 0 / 017 0
Part Number
Limiting Pressure
475 009 008 0

475 009 026 0
475 010 010 0
475 010 017 0
475 010 300 0
475 010 301 0
476 010 307 0
475 010 310 0
475 010 400 0
475 015 001 0
475 015 004 0
475 015 009 0
475 020 006 0
475 010 333 0
475 015 061 0
421 355 931 2
475 015 014 0
0.7 Bar
3.0 Bar
4.0 Bar
0.35 Bar
8.5 Bar
10.0 Bar
1.8 Bar
4.0 Bar
8.0 Bar
7.4 Bar
3.5 Bar
5.3 Bar
4.4 Bar
9.3 Bar
7.2 Bar
7.2 Bar
3 Bar
475 010 300 0 / 301 0
Port size
M12 x 1.5
M12 x 1.5
M22 x 1.5
M22 x 1.5
M22 x 1.5Voss
M22 x 1.5
M22 x 1.5
M22 x 1.5
M22 x 1.5 Voss
M16 x 1.5
M16 x 1.5
M16 x 1.5
M22 x 1.5
M22 x 1.5 Voss
M16 x 1.5
M16 x 1.6
M16 x 1.5
475 010 400 0
Repair kit
475 015 001 0 / 004 0
MAN
Merc MAN Scania
Merc Iveco
Merc
MAN
MAN
475 010 000 2

475 010 000 2
475 010 001 2
475 010 001 2
475 010 001 2
475 010 001 2
475 010 002 2
475 015 001 2
475 015 001 2
475 015 001 2
Only available in kit
DAF
Merc MAN
Merc Iveco MAN
Renault
For Actros. With Silencer
MAN TGA, TGM, TGL
kit 421 355 931 2 Excl. to ZF
includes 475 015 061 0
EBS Mech Susp - Old D EBS Trailer only
STOP LIGHT SWITCHES (Normally open, Cut in Switch)
262625
441 014 002 0
441 014 001 0 / 021 0
Part Number
Actuation Pressure
262625
441 014 001 0
441 014 002 0
441 014 021 0
441 014 190 0
0.34 Bar (5 psi)

2 Bar
1 Bar
0.5 Bar
0.15 Bar
Port size
1/2 NPT
M12 x 1.5
M10 x1 tapered
M12 x 1.5
M12 x 1.5
Normally open
Normally open
Normally open
Normally open
Normally open
General Truck / Bus

General Truck / Bus N/S
General Truck / Bus
General Truck / Bus MAN
General Truck / Bus
LOW PRESSURE SWITCHES (normally closed, cut off)
441 014 010 0
AGA987 includes 441 014 101 0
Part Number
Actuation Pressure
AGA987
441 014 101 0
441 014 004 0
441 014 010 0
441 014 013 0
441 014 014 0
441 014 015 0
441 014 025 0
4.5 Bar (65 psi)

4.5 Bar
5.5 bar
0.3 Bar
4.0 Bar
4.5 Bar
5.0 Bar
6.0 Bar
Port size
1/4" NPT
M12 x 1.5 Fem
M12 x 1.5
M12 x 1.5
M12 x 1.5
M12 x 1.5
M12 x 1.5
M12 x 1.5
Normally closed General Truck / Bus. Supercedes: 970 100 031 1
Normally closed General Truck / Bus M12 female Fits 6mm union
Normally closed General Truck / Bus
12/53
WABCO
RESERVOIRS
Part Number
AGA 179 195mm
051 010 004 M
051 015 005 M
051 020 006 M
051 020 011 M
051 030 011 M
451 040 311 M
451 060 311 M
950 405 001 0
A6741
Length
195 mm
355 mm
507 mm
660 mm
411 mm
579 mm
740 mm
1095 mm
185mm
860mm
1675062 M
A6104
451 999 276 2
A6742
Diameter
206mm 8"
206mm 8"
206mm 8"
206mm 8"
276mm 11"
276mm 11"
276mm 11"
276mm 11"
206mm 8"
390mm
Description
5 Litre Reservoir
10 Litre Reservoir
15 Litre Reservoir
20 Litre Reservoir
20 Litre Reservoir
30 Litre Reservoir
40 Litre Reservoir
60 Litre Reservoir
4.5 Litre Reservoir
90 Litre Reservoir 30kg "Fatboy"
11"
8"
11"
Mounting Bracket. Pair for 11"

Mounting Bracket. Single for 8"
Mounting Bracket Strap type
Mounting Bracket Strap 90 litre
4 x M22 Ports
451 999 276 2
1675062 M
DRAIN VALVES
Condensor
Drain (water trap)
934 300 003 0 / 006 0
934 301 000 0
Part Number
Port Thread
934 300 003 0

934 300 006 0
SF1280
934 301 000 0
934 301 003 0
432 511 000 0
434 300 000 0
M22 x 1.5
1/2" NPT
1/4" NPT
M22 x 1.5
M22 x 1.5
M22 x 1.5
M12 x 1.5
432 511 000 0
Description
Manual With Pull Ring
Manual
Manual With Pull Ring
Automatic Repair kit: 934 301 000 2 Filter: 899 380 622 4 Diaphragm: 897 121 400 2
Automatic Repair kit: 934 301 000 2 Filter: 899 380 622 4
Condensor Drain valve Max 10 Bar. Merc. Repair kit: 432 511 000 2 Filter: 432 511 220 4
Automatic. Repair kit: 434 300 000 2
RATIO VALVES / EMPTY LOAD VALVES / ADAPTER VALVES
473 300/ 301 0..
975 001 000 0
Part Number
Port Threads
473 300 001 0

473 300 004 0
473 301 000 0
473 301 001 0
473 301 002 0
473 301 003 0
975 001 000 0
975 002 001 0
975 002 017 0
M22 x 1.5
M16 x 1.5 M22 x 1.5
M22 x 1.5
M22 x 1.5
M22 x 1.5
M22 x 1.5
M22 x 1.5
M22 x 1.5
M16 x 1.5
975 002 001 0
Repair Kit
Description
Empty Load Valve. Reduces front axle braking with empty load
Regulating
Application:
General
Empty Loadratio:1:3.3
Valve. Reduces
front axle
brakingTruck
with empty load.
Regulating
ratio:1.5
: 1 with Contrl
Application:
Renault
Reducing Valve.
Regulating
ratio:2 Port
:1 4Application:
General
Truck
Reducing Valve. Regulating ratio:1.5 :1 Application: General Truck
Reducing Valve. Regulating ratio:1.35 :1Application: General Truck
Reducing Valve. Regulating ratio: 1.15 :1 Application: General Truck
Adapter valve. Adjusting Valve 0.6 to 0.8 Bar.
Application:
Trailer
drawbars,
Benz, Iveco,
Adapter Valve.
Knick
featureDAF,
Appl:Mercedes
DAF, Mercedes
Benz, MAN
MAN
Adapter Valve.
Application: Mercedes Benz.
13/53
WABCO
FOOT VALVES
461 315 008 0 / 004 0 / 042 0
461 319 250 0
461 319 008 0
461 315 180 0
461 319 274 0
Part Number
Port Thread
Repair Kit
461 307 3990
M22 x 1.5
461 307 002 2
461 315 008 0
461 315 005 2

461 315 915 2
461 315 005 2
4x M16 x 1.5
461 315 915 2
2x M12 x 1.5
8x M16 x 1.5
461 315 900 2
2x M12 x 1.5
461 315 917 2
461 315 907 2
461 315 924 2
4x M22 x 1.6
461 315 914 2
461 315 927 2
2x M16/ 2x M22 461 315 914 2
2x M12 x 1.5
461 315 927 2
8x M16 x 1.5
Dual Circuit. Predominance 0.25Bar No Pedal

Elbow Exhaust.
Merc
Dual Circuit. Predominance: 0.3Bar No Pedal
Elbow Exhaust.
Merc, Iveco, Scania
Elbow Exhaust. Merc, Iveco, Scania
Dual Circuit. NO Predominance No Pedal
Elbow Exhaust. Merc, Iveco, Scania
Dual Circuit. NO Predominance No Pedal
Push In fittings, with silencer, Scania
No Pedal Application: Axor. Short Silencer 39.9mm Dia
4 x M8 stud Mounting
No Pedal Application: Axor. Short Silencer 39.9mm Dia
4 x M8 stud Mounting
Dual foot valve with Pedal. No Gauge ports
8x M16 x 1.5
461 315 004 0

461 315 042 0
461 315 180 0
461 315 263 0 NLA
Use 461 315 264 0
461 315 264 0
461 317 021 0
8x
1x
8x
1x
4x
1x
4x
1x
4x
461 319 008 0

461 319 018 0
461 319 250 0
461 319 270 0
461 319 271 0
M16 x 1.5
M12 x 1.5
M16 x 1.5
M12 x 1.5
M22 x 1.5
M16
M22 x 1.5
M16 x 1.5
M22 x 1.5
461 491 102 0
2x M22 x 1.5
3x M16 x 1.5
2x M22 x 1.5
3x M16 x 1.5
M22 x 1.5
461 494 502 0
PI
461 319 273 0/272 0

461 319 274 0
461 317 792 2
Week 20/2001
Week 21/2001
Week 20/2001
Week 21/2001
Week 20/2001
Week 21/2001
Week 20/2001
Week 21/2001
Week 20/2001
Week 21/2001
Week 20/2001
Week 21/2001
461 319 007 2 Week 20/2001

461 319 908 2 Week 21/2001
461 319 007 2 Week 20/2001
461 319 908 2 Week 21/2001
461 319 004 2 Week 20/2001
461 319 905 2 Week 21/2001
461 319 002 2 Week 20/2001
461 319 903 2 Week 21/2001
461 319 006 2 Week 20/2001
461 319 907 2 Week 21/2001
461 319 901 2 Week 20/2001
461 319 912 2 Week 21/2001
461 319 901 2 Week 20/2001
461 319 912 2 Week 21/2001
461 307 002 2
Boot 897 752 670 4

Elbow Exhaust.
Integrated Empty Load function 1,5:1. Merc, DAF
Elbow Exhaust.
Integrated Empty Load function 2:1. Merc, DAF
Dual Circuit. Predominace : 0.4Bar Merc. Powerliner
Elbow Exhaust
Elbow Exh. Integrated Empty Load 2 :1. Merc Econoliner
Exhaust : Pipe Merc.
Long curved silencer. 69mm dia Voss
4 x M8 stud Mounting Application: Axor / Atego
No Pedal Small Silencer 39.9mm Dia
4 x M8 stud Mounting Application: Axor.
Predominance: 0.25Bar
Dual Circuit, Application: Renault
Treadle Assembly
14/53
WABCO
FOOT VALVES Continued ...
470 012 000 0
Part Number
Port Thread
Repair Kit
461 499 005 0
4x
2x
4x
2x
3x
M22 x 1.5
M12 x 1.5
M16 x 1.5
M14 x 1
M14 x 1.5
461 499 000 2
Predominance: 0.25Bar. Dual Circuit.
6x
2x
6x
2x
2x
M16 x 1.5
M12 x 1.5
M16 x 1.5
M10 x 1
M14 x 1.5
470 012 000 0

467 406 102 0
467 406 202 0
467 406 208 0
961 106 000 0
461 307 002 2

470 012 520 2
467 406 004 2
Kit
Slave Cylinder
961 106 000 2
Actros
Dual (Hydraulic / Pneumatic) Brake Valve with slave cylinder. Merc

Hydraulic Brake Foot Valve
Spool Diametre: 14mm Medium: Mineral Oil
Air foot valve. Trailer control for tractors.
ROTARY HAND BRAKE VALVES

961 701 110 0
961 701 115 0
961 701 100 0
Anti-clockwise. M14 x 1.5 Thread. 3 Port.

Different Handle - Anti clockwise
Clockwise
Application : DAF, Merc, Iveco
961 702 154 4

899 755 021 4
ASA 5221
Guide Pin
Roller
Service Kit
961 702 014 0
Anti-clockwise M14 x 1.5 Thread. 4 Port.

With Test Position
MERCEDES, MAN
961 702 154 4

899 755 021 4
ASA 5222
Guide Pin
Roller
Service Kit (961 701.)
961 703 001 0
M14 x 1.5 Thread. With Control Port To

Trailer 4 Port
961 703 000 2

ASA 5324
Repair Kit
Service Kit
15/53
WABCO
HAND CONTROL VALVES
961 721 000 0
961 723 017 0
961 721 004 0
961 723 019 0
961 721 045 0
961 721 040 0
961 723 104 0
961 723 100 0
Part Number
Port Thread
961 721 000 0
M14 x 1.5
Repair Kit
961 721 004 / 8 2
961 721 004 0
M14 x 1.5
961 721 004 2
961 721 008 0
1/4" NPT
961 721 004/8 2
961 721 040 0
M14 x 1.5
961 721 004/8 2
961 722 230 0
Slide x 2
961 722 002 2
961 722 232 0
Slide x 3
961 722 252 0
M14 x 1.5
Repair Kit 961 722 003 2

Service Kit ASA 6939
Repair Kit
961 722 003 2
961 722 924 2
Service Kit
ASA 6939
961 722 258 0
M14 x 1.5
Repair Kit
961 722 264 0
M14 x 1.5
961 722 272 0
M14 x 1.5
961 722 284 0
M14 x 1.5
961 722 288 0
M16 x 1.5
961 722 314 0
M14 x 1.5
961 723 017 0
M16 x 1.5
961 723 004 2
961 723 019 0
M16 x 1.5
961 723 000 2
961 723 100 0
M16 x 1.5
961 723 000 2
Service Kit
Repair Kit
Service Kit
961 722 252 0
961 721 004/8 2
961 721 045 0
961 722 232 0
Input Pressure: 8.5 Bar. Output Pressure: 7.5 2 port Side

Bar. Stroke 90o. M14 x 1.5 Thread. Mercedes Benz
Input Pressure: 15 Bar. Output Pressure: 7.5 2 Port Side
Centre Bracket Lock Position. DAF, Iveco, Scania, Volvo
Input Pressure: 8.5 Bar. Output Pressure: 7.5 Side
Bar. 2 Port. Centre Bracket. General Truck / Bus
Input Pressure: 8.5 Bar. Output Pressure: 7.5 Bar. Side
Spring
Return. 2 Port. Merc
Stroke 73 Voss. 2 Port Slide VOSS. (Left Hand Side Bracket). Without
Test Position. Merc
Stroke 73 Voss. 2 Port Slide VOSS. (Left Hand Side Bracket).
Without Test Position. Merc
Stroke 73 Voss. 3 Port Slide VOSS. (Left Hand Side Bracket).
With Test Position. Merc
Stroke 73. Position 85. 3 Port. (Left Hand Side Bracket).
With
Test Position. Merc, DAF Use 961 722 272 0 & Turn bracket
961 722 003 2

961 722 924 2
ASA 6939
Stroke 73 . 3 Port. (Centre Bracket). With Test Position.

Ports Application: Merc
961 722 004 2

961 722 924 2
ASA 6995
Stroke 73. 4 Port. Without Test Position. Side Bracket

Application: Merc
Repair Kit
961 722 003 2
Service Kit
ASA 6939
Repair Kit
961 722 003 2
Service Kit
ASA 6939
Repair Kit 961 722 003 2
Service Kit ASA 6939
Repair Kit 961 722 007 2
Side
Stroke 73. 3 Port. (Right Hand Side Bracket). With Test Position.
Application: International Use 961 722 252 0 & Turn Bracket
Stroke 73. 4 Port (Side) Centre Bracket.
Without Test Position. Merc
Stroke 73 Thread. 3 Port (Side) Right Hand Side Bracket.
With Test Position. Merc Econoliner
Stroke 73 Thread. 3 Port (Side) Side Bracket.
With Test Position. Scania
Stroke 85 2 Port (Side) Centre Bracket.
Without Test Position. DAF
Stroke 73o VOSS Ports. 2 Port (Side) Lock Position. Centre Bracket.
Without Test Position replaces 9617230050 Application: MAN
Stroke 73 VOSS 3 Port (Bottom). Centre
Bracket. With Test Position. Application: MAN
16/53
WABCO
HAND CONTROL VALVES Continued ..
961 723 118 0
961 723 125 0
961 723 203 0
Part Number
Port Thread
961 723 104 0
M16 x 1.5
961 723 000 2
961 723 117 0
M16 x 1.5
961 723 000 2
961 723 118 0
M14 x 1.5
961 723 124 0
M16 x 1.5
961 723 125 0
M16 x 1.5
961 723 203 0
M16 x 1.5
961 724 204/5 0
Repair Kit
961 723 000 2

961 724 926 2
961 723 405 0
Stroke 73 with Parking Position 85 VOSS Push-in Fitting. 3 Port (Side).
Centre Bracket. With Test Position, 5.5Bar . Merc
With Control Port To Trailer. With Electrical Switch. NO Lock Centre
Bracket. Application : Iveco
Stroke 73 VOSS Push-in Fitting. 3 Port (Side). Lock Position. Centre
Bracket. With Test Position. Application: MAN
Stroke 73 VOSS Ports. 3 Port (Side)
Centre Bracket. With Test Position. Application: Merc
Stroke 73 VOSS 3 Port (Side).
Lock Position with Test Position. Application: Merc Actros
3 Ports (Bottom). 5.9 Bar Output.
Centre Bracket. With Test Position. Application: ERF
Volvo Only Kit available to Aftermarket
part numbers: 20367533 and 20367534
961 723 213 0
M16 x 1.5
961 723 217 0
M16 x 1.5
961 723 405 0

(inverted) Normally
open
961 723 201 0
M16 x 1.5
961 723 001 2

961 723 934 2
3 Ports (Bottom).
With Test Position. Application: ERF
3 Ports Stroke 73 (Side Ports).
With Test Position. Application: Scania
Stroke 73. 2 Port (Bottom). Stretch Brake
Centre Bracket. Without Test Position. Application: DAF, MAN
M16 x 1.5
961 723 000 2
3 Ports (Side). 5.5Bar Centre Bracket.
961 723 421 0
M16 x 1.5 Voss
961 723 426 0
M16 x 1.5
Stroke 73. 2 Port (Side).

Without Test Position. Application: ACTROS MPII
Stroke 73. 2 Port (Side). Centre Bracket.
Without Test Position. Application: MAN
TC2 hand Control dashmounted - import on request only
262395M
Part Number
Port Thread
AGA969
1/8"
Repair Kit
Manouevering Valve, Push and hold button
17/53
Volvo
WABCO
LOADSENSING VALVES ( Mechanical )
475 710
Part Number
475 713 501 0
Port 1
Port 2
475 722 / 720 .
Port 4
475 800 301 0
Control
Angle
475 604 011 0
Description
475 701 020 0
M22 x 1.5
M22 x 1.5
30
Loadsensing Valve
Repair kit: 475 701 000 2
475 702 022 0
M22 x 1.5
M22 x 1.5
30
Loadsensing Valve
Repair kit: 475 702 001 2
475 710 000 0
M16 x 1.5
M16 x 1.5
M16 x 1.5
60
Relay Loadsensing
Repair kit 475 710 001 2
475 710 008 0
M22 x 1.5
M16 x 1.5
M16 x 1.5
60
475 710 012 0
M22 x 1.5
M22 x 1.5
M16 x 1.5
60
475 710 016 0
M22 x 1.5
M22 x 1.5
M16 x 1.5
60
475 710 020 0
M16 x 1.5
M16 x 1.5
M16 x 1.5
30
Relay Loadsensing
Repair kit: 475 710 001 2
Service
kit: ASA5381
Roller: 475 710 130 4
Plunger: 475
710 770
4
VOSS, Merc
Relay
Loadsensing
Repair kit: 475 710 001 2
Voss
MAN L2000, M2000
Relay Loadsensing
Repair kit: 475 710 001 2
Service kit: ASA5381 MAN F2000 Anti clockwise
Relay Loadsensing
Repair kit: 475 710 001 2
Service
kit: ASA5381
Roller: 475 710 130 4
Plunger: 475
710 770 4
Merc
475 710 024 0
M22 x 1.5
M16 x 1.5
M16 x 1.5
34.5
475 710 036 0
M22 x 1.5
M22 x 1.5
M16 x 1.5
30
475 710 042 0
M22 x 1.5
M22 x 1.5
M16 x 1.5
20
Relay Loadsensing
Repair kit: 475 710 001 2
Service
kit: ASA5381
Roller: 475 710 130 4
Plunger: 475
710 770 4
General Truck / Trailer / Bus
475 710 128 0
M22 x 1.5
M16 x 1.5
M16 x 1.5
30
475 710 136 0
M22 x 1.5
M22 x 1.5
M16 x 1.5
16
Relay Loadsensing
FH12 & FH16
Relay Loadsensing
Service kit: ASA5381
475 713 501 0
M22 x 1.5
M16 x 1.5
M22 x 1.5
33
475 713 002 0
M22 x 1.5
M16 x 1.5
M16 x 1.5
No Relay. Static Valve with Arm, Cable and Spring

475 713 000 2, 475 713 710 2 Cable& spring
Trailer EBS Mech Susp. Use with 475 015 014 0 limiter
475 713 002 0
M22 x 1.5
M16 x 1.5
M16 x 1.5
Trailer EBS Mech Susp. Use with 475 015 014 0 limiter
475 604 011 0
M22 x 1.5
M22 x 1.5
Manual Load Apportioning Valve
475 800 301 0
M12 x 1.5
M12 x 1.5
Truck Tag Axle Load Regulator Repair Kit 475 800 004 2
475 720 001 0
M22 x 1.5
M22 x 1.5
M16 x 1.5
30
New Gen Relay Loadsensing
475 720 003 0
M22 x 1.5
M22 x 1.5
M16 x 1.5
30
DAF LF 45 & LF 55
475 720 004 0
M22 x 1.5
M22 x 1.5
M16 x 1.5
30
DAF With Silencer
475 720 005 0
M22 x 1.5
M22 x 1.5
NG8 Voss
16
Relay Loadsensing
Repair kit: 475 710 001 2
ASA5381 IVECO
Relay Loadsensing
Repair kit: 475 710 001 2
Service
kit: ASA5381
Roller: 475 710 130 4
Plunger: 475
710 770 4
Repair kit 475 710 002 2
Volvo
Repair kit: 475 710 001 2

VOSS Merc
18/53
Kit:
WABCO
LOADSENSING VALVES ( Air Suspension )
475 721 000 0 / 3 0 / 9 0

475 711
Part Number
475 714 510 0
Port 1
Port 2
Port 4
Control
41/42
Description
475 711 024 0
M22 x 1.5
M22 x 1.5
M16 x 1.5
M16
Relay Loadsensing
Repair kit: 475 711 000 2
Trailers with 30 bags
Control Pressure: 0.6 to 4.3 Bar
475 711 096 0
M22 x 1.5
M22 x 1.5
M16 x 1.5
M16
Relay Loadsensing
Repair kit: 475 711 000 2
VOSS, MAN F2000 / M2000, DAF
475 711 115 0
M22 x 1.5
M22 x 1.5
M16 x 1.5
M16
Relay Loadsensing
Repair kit: 475 711 000 2
Merc,
475 711 118 0
M22 x 1.5
M22 x 1.5
M16 x 1.5
M16
Relay Loadsensing
Repair kit: 475 711 000 2
Actros Control Pressure: 0.5 to 3.0 Bar
Merc,
475 714 510 0
M22 x 1.5
M22 x 1.5
M16 x 1.5
M12
No Relay Function Trailers with 36 or 30 bags

475 721 000 0
M22 x 1.5
M22 x 1.5
M16 x 1.5
M16
Max operating Pressure 13Bar Mini LSV Voss ports

Application: Merc Axor
475 721 003 0
M22 x 1.5
M22 x 1.5
M16 x 1.5
M16
Max operating Pressure 13Bar

Relay Application: DAF
Mini LSV Voss ports No
475 721 008 0
M22 x 1.5
NG8 Voss
NG8 Voss
M16

= 6Bar Application: Merc Axor
Mini LSV Voss ports P4
475 721 009 0
M22 x 1.5
NG8 Voss
NG8 Voss
M16

= 8Bar Application: Merc Axor
Mini LSV Voss ports P4
SPRING BOXES
433 302 .
433 306 .
Part Number
Length
Deflection
433 302 002 0

433 302 014 0
433 302 008 0
433 302 026 0
433 302 025 0
433 306 003 0
260mm
220mm
160mm
220mm
160mm
260mm
100mm
85mm
55mm
85mm
55mm
100mm
Force
20-35N
26-47N
40-110N
49-110N
40-110N
60-130N
With Rubber Connector
No Rubber Connector
With Knuckle Connector (Ball Pivot)
With Connector
No Rubber Connector
Without Knuckle Connector (Ball Pivot)
19/53
Merc,
WABCO
QUICK RELEASE VALVE
973 500 000 0 / 973 500 014 0
973 500 031 0
973 500 051 0
Part Number
Port 1
Port 2
Description
473 501 201 0

473 501 203 0
973 500 000 0
973 500 105 0
973 500 014 0
973 500 031 0
973 500 051 0
M22 x 1.5
M22 x 1.5
M22 x 1.5
1/2"
1/2"
M22 x 1.5
M22 x 1.5 x 2
M22 x 1.5 x 2
M22 x 1.5 x 2
M22 x 1.5 x 2
Oring Seal
3/8" x 2
M22 x 1.5 x 2
M16 x 1.5 x 4
With Silencer
With Silencer
Std Trailer
Diaphragm: 897 130 794 4
Freightliner - Placed between ABS solenoids
Std Trailer
No Kit
Diaphragm: 897 130 794 4
Additional Port 22 - M16 x 1.5 5 port Diaphragm: 897 130 794 4
With Anti compound, double check valve For EBS trailers Diaph: 897 130 794 4
TRAILER CONTROL VALVE
973 002 000 0 / 430 0
973 002 521 0
973 009 001 0
480 204 001 /2 0
Part Number
Port Threads
973 002 000 0
M22 x 1.5
973 002 430 0
M16 x 1.5
ASA5741
973 002 003 2
ASA5741
973 002 521 0
M16 x 1.5
ASA5741
973 009 001 0
M22 x 1.5
973 009 000 2
973 009 006 0
M22 x 1.5
973 009 000 2
973 009 010 0
M16 x 1.5
973 009 000 2
973 009 014 0
M16 x 1.5
973 009 000 2
973 009 015 0
M16 x 1.5
973 009 000 2
Predominance 0.6 Bar. (Adjustable). No Dump.

Application: Merc, Iveco, MAN
NO Predominance. No Dump.
Application: DAF
With Dump feature. Predominance 0.2 Bar (Adjustable).
Application;
General Truck
With Dump feature. Predominance 0.3. Bar (Adjustable). For VOSS Pushin Fitting. Application: Mercedes Benz, MAN - Powerliner
With Dump feature. Predominance 0.0 Bar (Adjustable) P 41/42 10.5 Bar.
P 11/43 8.5 Bar. For VOSS Push-in Fitting.
Application:
MAN F2000 0.2 Bar. With Silencer
With Dump. Predominance
Application:
With Dump. Predominance 0.4 Bar.
Application: IVECO
With Dump. Predominance 0.1 Bar.
Application: Volvo
471 401 009 2
EBS Trailer Control Valve. Superceded by 480 204 002 0

Application: DAF, Mercedes Benz, Iveco
EBS Trailer Control Valve. Voss Ports. Port 6 (Electrical control).
Application: DAF, Mercedes Benz - Actros, Iveco
Refered to as a "10 S4" valve. Older vehicles
480 204 001 0

480 204 002 0
471 401 010 0
Ports 11,21,22 : M22 x 1.5

Ports 42,43 :
M16 x 1.5
Ports 11,21,22 : M22 x 1.5
Ports 42,43 :
M16 x 1.5
M22 x 1.5
Repair Kit
Description
20/53
WABCO
RELAY EMERGENCY VALVE
281672
471 005 020 0
Port Threads
Part Number
281672
971 002 150 0
Repair Kit
266784
471 005 020 0
Port 1: 1/4, Port 2: 3/8,

Port 4: 1/4, Port1-2: 3/4
M22 x 1.5
971 002 150 0
M22 x 1.5
971 002 003 2
971 002 300 0
Port 4: M16 x 1.5

Port 1, 1-2, 2: M22 x 1.5
971 002 008 2
Part Number
Port Thread
Description
452 002 132 0.
M22 x 1.5
471 005 009 2
971 002 300 0
Description
Re6 Valve. Found on older trucks and trailers
NO Predominance.
Application: Trailer
With Predominance (Adjustable). Alternative: 971 002 300 0 same except

without Flange for manual LSV. Application: Trailer
With Dump feature. Predominance 0.3. Bar (Adjustable). For VOSS Pushin Fitting. Application: Mercedes Benz, MAN
SHUT OFF COCK
452 002 132 0
Park Brake. Engineering Grade Plastic Handle Supercedes: 452 002 107 0
TRAILER PARK RELEASE VALVE / PARK SHUNT VALVE
963 001 051 0
971 002 900 0
Part Number
Port Thread
963 001 051 0

971 002 900 0
A6886
M16 x 1.5
M16 x 1.5
Application:
Description
Std park shunt valve
PREV Valve Park shunt valve with relay emergency function. Application: EBS trailers
PREV Valve Information Plate 971 002 ..
21/53
WABCO
RELAY VALVE
280375
973 011 200 0

973 006 001 0 / 003 0
973 001 010 0 / 020 0 / 220 0
Part Number
280375
Port Threads
473 017 001 0
Port 1: 1/2, Port 2: 3/8,

Port 4: 1/4
Ports: M22 x 1.5
973 001 010 0
Ports: M22 x 1.5
973 001 020 0
Port 1: M22 x 1.5

Port 2, 4: M16 x 1.5
Port 1, 2: M22 x 1.5
Port 4: M16 x 1.5
Port 1: M22 x 1.5
Port 2, 4: M16 x 1.5
Ports: M22 x 1.5
973 001 211 0

973 001 220 0
973 003 007 0
973 006 001 0
973 006 003 0
973 011 001 0
973 011 022 0
973 011 050 0
973 011 200 0
973 011 206 0
973 011 300 0
973 011 000 0
Port 1, 2: M22 x 1.5

Port 4: M16 x 1.5
Port 1, 2: M22 x 1.5
Port 4: M16 x 1.5
Port 1, 2: M22 x 1.5
Port 4: M16 x 1.5
Port 1: 1/2, Port 2: 3/8,
Port 4: 1/4
Port 1: M22 x 1.5
Port 2, 4: M16 x 1.5
Port 1, 2: M22 x 1.5
Port 41, 42: M16 x 1.5
Port 1, 2: M22 x 1.5
Port 4: M16 x 1.5
Port 1, 2: M22 x 1.5
Port 4: M16 x 1.5
Port 1, 2: M22 x 1.5
Port 4: M16 x 1.6
973 011 001 0/ 050 0
Repair Kit
Description
263945
R6 relay. Found on older trucks and trailers

Application: General Truck / Trailer / Bus
Anti Compound Square Relay Valve .
973 001 000 2

ASA5198
973 001 000 2
ASA5198
973 001 006 2
973 003 000 2
Std Square Relay

Std Square Relay
Relay Valve
Application: Volvo
Std Square Relay
Relay Valve Application: MAN TGA
ASA7168
ASA7014
ASA7168
ASA7014
973 011 002 2
ASA7168
973 011 000 2
ASA7168
973 011 006 2
Park Brake Square Relay NO Silencer Max 10 Bar

Application: Mercedes Benz, MAN
Park Brake Square Relay With Silencer , Voss Threads
Application: Mercedes Benz, MAN
Park Brake Square Relay , Voss Threads
Application: Scania, Mercedes Benz, MAN
With Flange For ABS Solenoid (Solenoids 472 195 082 0/30)
Application: Freightliner
Square Relay Built in Non return
Application: Scania
Anti Compound Square Relay , Voss Threads, Control 10Bar
Application: Scania, MAN
Voss Threads. Application: Renault
973 011 005 2

ASA7168
973 011 000 2
ASA7168
Park Brake Square Relay anti compound, Voss Threads, Control 10Bar
Application: Mercedes Actros
Relay valve park brake
Application: Volvo, Scania, Renault, Iveco,
Daf
973 001 002 2
22/53
WABCO
LEVELLING VALVE
464 002 . .
464 006 . .
Part Number
Port Threads
464 002 330 0
M12 x 1.5 (3 port)
464 002 008 2
464 002 332 0
M12 x 1.5 (3 port)
464 002 008 2
464 002 440 0
M12 x 1.5 (3 port)
464 002 008 2
464 006 002 0
M12 x 1.5 (3 port)
464 006 000 2
464 006 100 0
464 006 001 2
464 007 001 0
3x M12 x 1.5 (5 port)

2x M16 x 1.5
M6 Push in (2 port)
464 007 010 0
M10 x 1 (2 port)
464 007 013 0
M6 Push in (2 port)
464 007 001 0 / 010 0
Repair Kit
Description
Two-stage. Nominal Diameter 2 x 1.3. With Arm.
Application: Merc, MAN, Volvo, Trailer Steel Slide
Two-stage. Nominal Diameter 2 x 1.3. Without Arm.
Application: Merc Powerliner, MAN, Volvo Steel Slide
Two-stage. Nominal Diameter 2 x With Arm.
Application: Merc, DAF
Steel Slide
Two-stage. Transversal Throttle. With Linkage.
Application: DAF, MAN, Volvo, Trailer
Plastic Slide
Two-stage. Transversal Throttle. With Height Limitation.
With Linkage. Application DAF, Trailer
Plastic Slide
For suspension of driver cabin. Push-in fittings for plastic tube.
Application DAF, Iveco, Scania, MAN
For suspension of Drivers Cabin.
Application: Scania
For suspension of driver cabin. Push-in fittings for plastic tube.
Application DAF
RAISE / LOWER VALVE (Manual )
463 032 020 0
Part Number
Port Threads
463 032 020 0
Port 1: M16 x 1.5

Port 21,22,23,24: M12 x 1.5
A6887
Repair Kit
463 032 001 2
Description
Two-stage. Nominal Diameter 2 x 1.3. With Arm.
Application:
Information Trailer
Plate
LINE FILTER
432 500 020 0
Part Number
Port Thread
432 500 020 0
M22 x 1.5
Description
Removable filter
Application: Trailer
23/53
WABCO
CLUTCH SERVOS
970 051 111 0 / 114 0 / 126 0 / 127 0
970 051 131 0
970 051 406 0
970 051 439 0
970 051 159 0
970 051 164 0 / 176 0
970 051 414 0 / 424 0
970 150 001 0
Part Number
Port Thread
Repair Kit
970 051 111 0
M16 x 1.5
M14 x 1.5
M16 x 1.5
M14 x 1.5
M16 x 1.5
M14 x 1.5
M16 x 1.5
M14 x 1.5
M16 x 1.5
M14 x 1.5
M16 x 1.5
M14 x 1.5
x2
x1
x2
x1
x2
x1
x2
x1
x2
x1
x1
x1
Repair kit: 970 051 905 2

Dust Boot: 897 754 430 4
Repair Kit : 970 051 904 2
Dust Boot: 897 754 882 4
Repair Kit : 970 051 904 2
Dust Boot: 897 754 882 4
Repair Kit: 970 051 906 2
Dust Boot: 897 754 182 4
Repair Kit : 970 051 906 2
Diameter 80.5mm. Stroke 85mm.

Application MAN
Diameter 75mm. Stroke 67mm.
Application: DAF, Hino, Iveco, Nissan, Renault-V
Diameter 75mm. Stroke 67mm. Force Output 4000 N.
Application: DAF, Hino, Iveco, Nissan, Renault-VI
Diameter 100mm. Stroke 58.5mm. Force Output 6000 N.
Application: Scania
Diameter 108mm. Stroke 58.5mm. Application: Merc
use in place of 970 051 127 0 Only Change pushrod
Diameter 90mm. Stroke 72mm. 970 051 371 4 - guide
Application: Merc
M16 x 1.5
M14 x 1.5
M16 x 1.5
M14 x 1.5
M16 x 1.5
M14 x 1.5
M16 x 1.5
M14 x 1.5
M16 x 1.5
M14 x 1.5
M16 x 1.5
x2
x1
x2
x1
x1
x1
x2
x1
x2
x1
Repair Kit : 970 051 917 2
970 051 114 0

970 051 126 0
970 051 127 0
970 051 128 0
970 051 131 0
970 051 151 0

970 051 157 0
970 051 159 0/158 0
970 051 164 0
970 051 176 0
970 051 405 0
970 051 412 0

970 051 414 0
970 051 424 0 Note
970 051 431 0
970 051 432 0
970 051 435 0
970 051 439 0
M22 x 1.5
M14 x 1.5
M16 x 1.5
M14 x 1.5
M16 x 1.5
x1
x1
x1
x1
M22 x 1.5
M14 x 1.5
M16 x 1.5
M14 x 1.5
M16 x 1.5
x1
x1
x1
x1
x1
970 051 441 0

970 051 438 0
970 150 001 0
Repair Kit : 970 051 911 2

Repair Kit : 970 051 006 2
Repair Kit: 970 051 916 2
Repair Kit : 970 051 945 2
Dust Boot : 897 754 882 4
970 051 950 2
Repair Kit : 970 051 949 2
M22 x 1.5 x 1
M14 x 1.5 x 1
970 051 406 0
Repair Kit: 970 051 903 2

Dust Boot: 897 754 320 4
Rear Housing: 970 051 527 2
M22 x 1.5 x 1
M14 x 1.5 x 1
Repair Kit: 970 051 952 2

Dust Boot: 897 754 430 4
Repair Kit : 970 051 971 2
Sensor Kit: 970 051 986 2
Repair Kit: 970 051 961 2
Dust Boot: 897 754 882 4
Repair Kit: 970 051 961 2
Dust Boot: 897 754 882 4
Repair Kit: 970 051 974 2
Dust Boot: 897 754 882 4
Repair Kit: 970 051 977 2
Sensor:: 970 051 986 2
Repair Kit: 970 051 970 2
Stroke 65mm. Force Output 4000 N.

Application: Merc
Stroke 85mm. Force Output 6000 N.
Can
Dia. 90mm
Dia. 108mm
MAN

Application: Merc Powerliner
Application: Merc
Diameter 108mm. Stroke 85mm. Use 970 051 164 0 Change Pushrod
On Request
Application: Actros
Superceded to 970 051 431 0
Diameter 75mm. Stroke 85mm. Force Output Max 4000 N. Application:

MAN
970 051 987 2 Excl Main Seal

970 051 974 2 Incl Main Seal
Repair Kit: 970 051 984 2
Diam 108mm Stroke 85mm. Force Output Max 6000 N.

Mineral
Oil
Application: MAN / TGA/ TGL/ TGM
Diameter 108mm. Stroke 85mm. Force Output Maxi 6000N Application:
MAN F2000 With wear indicator
Diameter 108mm. Stroke 85mm. Supply the 970 051 414 0 above WITH
an M22-M16 reducer - Hino 700 Brake Fluid
Diameter 108mm. Stroke 85mm. Force Output Max 6000N
App:
Merc Actros with sensor supercedes 970 051 405 0
Diameter 80mm. Stroke 85mm. Force Output Max 4000N
App:
MAN TGA Mineral Oil
Diameter 75mm. Stroke 85mm. Force Output Maximumm 4000N With
wear indicator
Diameter 108mm Stroke 75mm. Force Output Max 6000N Application:
MAN
Diameter: 108mm Stroke 85mm. Force Output Maximumm 6200N
Mineral Oil. Application: Merc Axor
Diameter Stroke 75mm
Application: Renault
Brake Fluid
Repair Kit: 970 150 000 2
Diameter 126mm Stroke 69mm Mineral Oil MPII
Repair Kit: 970 051 984 2
24/53
WABCO
SAFETY VALVES
434 612 004 0
Part Number
Port Thread
434 608 220 0

434 612 004 0
434 612 014 0
M16 x 1.5
M22 x 1.5
M22 x 1.5
Description
Pressure Setting 10 Bar Application: Volvo
Pressure Setting 13 Bar Application: Merc Benz Actros
Pressure Setting 7.5 Bar.
NON RETURN / CHECK VALVE / SHUTTLE VALVES / ONE WAY
434 014 000 0
Part Number
Port Thread
434 014 000 0
M22 x 1.5
Description
Female Ports Application: Trailer, Truck
DOUBLE CHECK VALVE / DIECTIONAL CONTROL / TWO WAY / CUT OFF VALVE
434 208 029 0
Part Number
Port Thread
434 208 029 0
M22 x 1.5
Description
Female Ports With mounting bracket.Application: Trailer, Truck
THROTTLE CHECK VALVE (3/2 Way Valve)
463 013 111 0
Exhaust Brake Valve
463 013 210 0
Part Number
Port Thread
Repair Kit
463 013 111 0

463 013 112 0
463 013 114 0
463 013 116 0
463 013 121 0
463 013 130 0
463 013 200 0
463 013 210 0
463 022 020 0
891 500 464 4
811 401 100 4
M12 x 1.5
M12 x 1.5
M12 x 1.5
M12 x 1.5
M12 x 1.5
M16 x 1.5
M12 /M16 x 1.5
M12 /M16 x 1.5
M10 x 1
M26
M26
ASA 5705
ASA 5705
ASA 5705
ASA 5705
ASA 5705
ASA 5705
ASA 5705
ASA 5705
463 022 020 0
Description
Stroke 5.7mm. Length 39.6mm. Without Lock Nut. General Truck short stem
Stroke 5.7mm. Length 37.9mm. Without Lock Nut. General Truck short stem
Stroke 5.7mm. Length 37.9mm. Without Lock Nut. General Truck long stem
Stroke 5.7mm. Length 46.9mm. With Lock Nut.
DAF, Iveco
short stem
Stroke 5.7mm. Length 75.6mm On Request
Stroke 5.7mm. Length 37.9mm. Without Lock Nut. Merc short stem
Stroke 10mm. Length 41mm.
Without Lock Nut. Merc short stem
Stroke 5.7mm. Length 37.9mm. Without Lock Nut. Merc short stem
Stroke 12.5mm. Length 42mm.
With Lock Nut. DAF, Volvo
Locknut Loose
Washer Loose
25/53
WABCO
GEARBOX CONTROL VALVES (3/2 Way Valve)
463 036 001 0 / 010 0
463 037 001 0
3/2 way
4/2 way
571 003 104 0
Part Number
463 031 102 0
463 036 001 0
ASA5910
463 036 024 0
463 036 010 0
463 036 016 0
463 037 001 0
463 038 009 0
463 039 006 0
463 063 002 0
463 063 003 0
472 260 005 0
472 260 011 0
563 020 000 0
571 003 104 0
571 040 000 0
899 851 810 4
891 500 520 4
A5821
3/2 way
571 040 000 0
5/2 way
463 039 006 0
463 031 102 0
463 063 002 0 / 003 0

5/2 way
472 260 005 0 / 011 0
Port Thread
Repair Kit
463 031 001 2
M10 x 1.5
M10 x 1.5
M10 x 1.5
M16 x 1.5
M16 x 1.5 Voss
M10 x 1.5
463 038 000 2
M10 x 1
463 039 000 2
M10x1/ M12x 1.5 463 063 000 2
M10x1/ M12x 1.5 463 063 000 2
M22 x 1.5
M22 x 1.5 Voss
M10 x 1
M10 x 1
M14 x 1.5
Description
4/2 way, Directional Control Valve.
3/2 way, With Turning Knob. With Retaining Position. Without Lock Nut. Merc
3/2 way - same as 463 036 001 0 but with Washer and Locknut
3/2 way - Push button Type No Washer and Locknut
3/2 way, Without Turning Knob. With Retaining Position. VOSS. Without Lock Nut.
Diff Lock Switch. With switch. Nominal Diameter 4mm. Mounting M28 x 1.5
4/3 way, Nominal Diameter 2.5mm. M10. Without Handle and Lock Nut. Merc
3/2 way, Directional Contol Valve. With Pressure switch
3/2 way, Without switch. Merc
5/2 way, Nominal Diameter 1.5mm. Merc, ZF Box P2= RHS
5/2 way, Nominal Diameter 1.5mm. MAN, ZF Box P2= LHS
Proportional Valve VOITH
Proportional Valve VOITH
3/2 way, NW4 MAN
4/2 way , NW4 Control pressure 2Bar. DAF, Mercedes Benz, Iveco, MAN
3/2 way, Trailer suspension, raise lower & axle lift, General Truck
Handle for 463 037 001 0
Lock nut M28
Washer M28
Pneumatic Assist Hydraulic Servo

Hydraulic Pressure: 120 Bar.
Pneumatic Pressure: 8 Bar.
60cm3 Cylinder with Air Reservoir.
Application: Iveco
974 010 008 0
3/2 way
3/2 way
SERVO UNIT
921 399 025 0
563 020 000 0
Pneumatic Assist Hydraulic Master Servo

Supercedes 974 010 006 0
Hydraulic Pressure: 45 Bar.
Pneumatic Pressure: 6 - 10 Bar.
Mineral Oil
Application:
MAN TGL
26/53
WABCO
SOLENOID VALVE
472 090 202 0
472 127 140 0
Part Number
Port Thread
472 090 202 0

472 070 639 0
472 072 628 0
472 102 040 0
472 127 140 0
472 132 198 0
472 170 600 0
472 170 637 0
472 172 600 0
472 172 620 0
472 172 626 0
472 172 686 0
472 174 504 0
472 173 700 0
472 176 316 0
472 195 000 0
472 123 706 0
1/4" NPT
M16 x 1.5 Voss
M12 x 1.5
M12 x 1.5
M12 x 1.5
M12 x 1.5
M12 x 1.5
M12 x 1.5
M12 x 1.5
M12 x 1.5
M12 x 1.5
M12 x 1.5
M12 x 1.5
M12 x 1.5
M16 x 1.5
472 170 600 0
472 172 686 0
472 176 3160
472 172 600 0
Description
24V Normally closed. Nominal Diameter 2.8mm. General Truck and Bus
24V Normally closed. Nominal Diam 4mm. DIN Bayonet. Merc
3/2 Way. Nominal Diam. 2,2/3. Type: Normally Closed
12/24V Normally open
12/24V Normally closed. Nominal Diam 2.2mm. Terminals. MAN, General Truck, Trailer
Nominal Diam. 2,2/3. Type: Vented 24V Norm Closed
24V Normally closed. Nominal Diam 4mm. M27x1 Kostal. Merc, ERF
12V Nominal Diam. 2,2/3. normally closed
24V Normally closed. Nominal Diam 2.2mm. M27x1 Kostal. DAF, Iveco, Trailer
Nominal Diam. 2,2/3. Type: Normally closed
24V Nominal Diam. 2,2/3. Type: Normally closed
24V Normally closed DAF
24V Normally closed. 2/2 Type Bayonet
24V Nominal Diam. 4.0. Type: Normally Open
Nominal Diam. 4.0. Type: Normally Open Actros and DAF
Use 472 195 018 0 + cable 894 601 132 2 (adaptor M24 to Bayonet)
Use 472 172 620 0 24V
PROPORTIONAL VALVES
Part Number
Port Thread
472 260 005 0

472 260 011 0
472 250 000 0
M22 Voss
M22 Voss
M12 x 1.5
Description
Truck and Bus
Truck and Bus
24V 8bar max. Speed limiter and ASR controller Closed M27x 1 connector
OPERATING CYLINDERS
421 411 070 0
421 429 003 0
Part Number
Port Thread
421 411 070 0

421 429 003 0
421 411 300 0
421 411 314 0
421 429 002 0
421 444 002 0
421 445 001 0
ASA6620
M12 x 1.5
M12 x 1.5
M12 x 1.5
M12 x 1.5
M10 x 1.0
M12 x 1.5
1/4" NPT
421 429 002 0
422 010 012 0
Description
35mm Diam. Stroke 38mm. With Yoke 8mm. Mercedes Benz, ERF, Iveco, MAN
28mm Diam. Stroke 48mm. Without Yoke. Mercedes Benz, MAN, Toyota, Nissan
35mm Diam. Stroke 85mm.
35mm Diam. Stroke 35mm
28mm Diam. Stroke 70mm.
Cylinder actuator assembly
27/53
421 411 314 0
WABCO
DOOR CONTROL VALVES

472 017 480 0
Conventional Door Control

24 Volt.Normally Open or Closed
8 Bar. M12 Ports.
Application: Mercedes Benz, Iveco, MAN
Repair Kit 472 017 000 2
SILENCERS
432 407 060 0
432 407 070 0
Part Number
Port Thread
432 407 060 0

432 407 070 0
432 407 016 0
M22 x 1.5
Description
Screw On, Max Pressure 13 Bar, Foot Brake
Snap On. Max Pressure 11 Bar, Foot Brake, Loadsensing valves etc
Saw - Tooth Profile
PALM COUPLINGS
952 200 021 0
952 200 022 0
Part Number
Port Thread
952 200 021 0

952 200 022 0
952 200 221 0
952 200 222 0
897 550 020 4
M16 x 1.5
M16 x 1.5
M16 x 1.5
M16 x 1.5
952 200 221 0
952 200 222 0
Description
Red Cap, Trailer Emergency - No Valve
Yellow Cap, Trailer Service - No Valve
Red Cap, Truck Emergency - With Valve
Yellow Cap, Truck Service - With Valve
Replacement seal
DUOMATIC COUPLINGS
452 802 009 0
452 804 012 0
Part Number
Port Thread
452 802 009 0

452 804 012 0
897 550 020 4
M16 x 1.5
M16 x 1.5
Description
Truck Coupling. Maximum 10 Bar Repair kit: 452 802 003 2
Trailer Coupling. Maximum 10 Bar
Replacement seal
28/53
WABCO
F&J COUPLINGS
052 001 002 2 ( 1/2" )

052 002 002 2 ( M22 )
APSA1519 (1/2")
A6722 (M22)
0520000014 (1/2" )
0520000024 (M22)
0520010062 ( 1/2" )
052 003 001 2 ( 1/2" )
1178075
ASA531/2 ( 1/2" )
052 003 006 2
052 001 003 2 (1/2")
520030022
520030052 (1/2")
A6704 (M22)
A1122
052 003 015 2
052 003 014 2
AP11168 ( 1/2" )
( M22 )
A1121
A5776
High Spec
Part Number
Port Thread
0520010022
A6722
APSA1519
0520010062
0520003005
ASA531/2
0520010032
1/2"
M22 x 1.5
1/2"
1/2"
M16 x 1.5
1/2"
1/2"
0520010022D
A6722D
APSA1519D
0520010062D
0520003005D
ASA531/2D
0520010032D
Female std
Female with striker plug assembled
Trailer
Female with striker plug assembled
Trailer
Female F&J with short stem shut off valve
Truck
Truck
Truck
Short stem Shut off valve only
0520000014
0520000024
0520030052
A6704
0520001005
0520030062
0520030012
0520030112
1/2"
M22 x 1.5
1/2"
M22 x 1.5
M16 x 1.5
1/2"
1/2"
0520000014D
0520000024D
0520030052D
A6704D
0520001005D
0520030062D
0520030012D
0520030112D
Male Coupling std Trailer

Male Coupling std Trailer
Male F&J with long stem shut off valve
Long stem Shut off valve only
Long stem Shut off valve only
AP11168
A5776
SF240/4
1/2"
M22 x 1.5
1/2"
AP11168D
A5776D
Striker Plug / Operating Plug

Striker Plug / Operating Plug
Copper Washer
M22 x 1.5
0520030022
0520030142
1178075
A1121
A1122
0520030152
Description
Truck
Truck
Truck
Truck
No dust flap or bracket

No dust flap or bracket
With dust flap and bracket
No dust cap or bracket

No dust cap or bracket
With dust cap and bracket
Dust cover (Female dummy) for male couplings with Chain and bracket
Dust Flap Nylon for Female Couplings
Dust Plug male for female couplings with chain and bracket
Service Tag
Emergency Tag
Plastic Mounting Bracket
AIR THROTTLE VALVES
361 064 050 0
Part Number
3610500002
3610640500
4230200160
8971210304
8965144404
423 020 016 0
Port Thread
M14 x 1.5
M12 x 1.5
NLA
Description
Repair kit
Air Throttle Valves
T3 Throttle Actuator
Type 3 Diaphragm fro T3 chamber
Spring (A6601)
29/53
WABCO
BRAKE CHAMBERS
Part Number
Port Thread
Pic
AGA339
AGA109
AGA448
AGA449
423 107 900 0
423 105 111 0
423 106 292 0
423 106 900 0
423 109 001 0
423 206 700 0
423 206 701 0
425 307 012 0
1/4"
A
A
A
A
B
C
C
B
C
D
D
F
M16 x 1.5
M16 x 1.5
M16 x 1.5
M16 x 1.5
M16 x 1.5
M16 x 1.5
M16 x 1.5
M16 x 1.5
M16 x 1.5
M22 x 1.5
Description
T 12, Short stroke
T 20, Short stroke
T 24, Long stroke old number AGA351
T 30, Long stroke, with nuts, clevis and washers old nummber AGA354
T 30, Long stroke, rod protrusion 85mm long, without clevis, nuts and washers
T20, 37mm Rod Protrusion. With Yoke and Gaiter. Merc
T24, 116mm Rod Protrusion. With Yoke and Gaiter. Merc
T24, 186mm Rod Protrusion. No yoke.
T27 37mm Push Rod
T24. 37mm Piston Rod. Welded Yoke. No Mounting Studs.
T24. 37mm Piston Rod. Welded Yoke. No Mounting Studs.
100mm diam Release 4.5bar M16 push rod kit 425 307 000 2
Stroke 75mm
Stroke 75mm
Stroke 75mm
Stroke 64mm
Stroke 57mm
Stroke 57mm
Stroke 80mm
SPRING BRAKES WEDGE TYPE
Part Number
Port Thread
425 451 052 0

425 451 053 0
3/8"
3/8"
Pic
A
A
Description
T24/24. Wedge Type Right Hand Side
T24/24. Wedge Type Left Hand Side
SPRING BRAKES
Part Number
Port Thread
Pic
925 320 502 0

925 323 125 0
925 324 040 0
925 326 000 0
925 420 902 0
925 421 540 0
925 421 715 0
925 421 751 0
925 424 100 0
925 426 200 0
925 426 201 0
M16 x 1.5
M16 x 1.5
M16 x 1.5
M16 x 1.5
M22 x 1.5
M22 x 1.5
M16 x 1.5
M22 x 1.5
M22 x 1.5
M22 x 1.5
M22 x 1.5
A
E
B
A
A
B
B
D
C
E
E
Description
T20/30. 30mm Piston Rod. With Yoke and Gaiter. Rep Kit 9253200022 (S/S 925 490 755 0)
T36/30. 15mm Push Rod. Without Yoke. Repair Kit 925 320 002 2 (S/S 925 494 0410 0)
T16/24. 60mm Welded Push Rod. Repair Kit 925 320 001 2 (S/S 925 490 902 0)
T14/12 With Yoke and Gaiter
T20/24. 37mm Welded Push Rod. Voss ports. Repair Kit 925 320 001 2 s/s 925 490 902 0
T24/30 G-Type Welded Push Rod Stroke 65mm
T24/24. 200mm Welded Push Rod. Repair Kit 925 321 007 2 NLA (S/S 925 421 752 0)
T24/24. 200mm Welded Push Rod. MAN F2000
(S/S 925 491 755 0)
T16/24. 187mm Rod Length. With Yoke. VOSS Ports. Welded Rod.Merc (S/S 925 494 041 0)
T14/16. 15mm Push Rod. Disc Brake. Repair Kit 925 426 000 2 LHS
T14/16. 15mm Push Rod. Disc Brake. Repair Kit 925 426 000 2 RHS
30/53
WABCO
SPRING BRAKES

Continued .. ..
Part Number
Port Thread
Pic
925 450 001 0

925 451 001 0
925 452 001 0
925 454 001 0
925 424 800 0
925 424 801 0
925 461 470 0
925 480 004 0
925 488 012 0
925 488 021 0
925 492 102 0
925 494 041 0
925 481 012 0
925 481 013 0
925 468 013 0
925 468 020 0
AGA262
AGA445
AGA446
AGA447
AGA430
AGA431
AGA432
M16 x 1.5
M16 x 1.6
M16 x 1.7
M16 x 1.8
M22 x 1.5
M22 x 1.5
M16 x 1.5
M22 x 1.5
M22 x 1.5
M22 x 1.5
M22 x 1.5
M22 x 1.5
M16 x 1.5
M16 x 1.5
M16 x 1.5
M16 x 1.5
3/8"
M16 x 1.5
M16 x 1.5
M16 x 1.5
M16 x 1.5
M16 x 1.5
M22 x 1.5
D
D
D
D
E
E
E
E
E
E
D
D
E
E
E
E
F
F
F
F
Description
DOUBLE DIAPHRAGM SPARES
Description
895 801 513 2

897 750 980 4 ID12
897 751 010 4 ID21
897 753 261 4 ID35
925 321 010 2
925 322 011 2
A5803
ID40
ASA6194
T20/24. 250mm Push Rod. Without Yoke. VOSS Ports. Superceded by 925 490 925 0
T24/24. 250mm. Without Yoke. With Gaiter. M16 x 1.5 Rod. Superceded by 925 491 141 0
T30/30. 250mm.Without Yoke. With Gaiter. M16x1.5 Rod. DAF,Scania,Volvo s/s 925 492 102 0
T16/24. 200mm. Without Yoke. With Gaiter. M16 x 1.5 Rod. Merc, MAN s/s 925 494 041 0
T16/16. 15mm Rod Length. VOSS Ports. Left Hand Side. MAN
T16/16. 15mm Rod Length. VOSS Ports. Right Hand Side MAN
T24/30. 15mm Rod Length. Stroke 65mm
T20/24. 15mm Push Rod. Disc Brake. RHS
T30/30. 250mm Push Rod. Universal Tri-Stop. No Yoke.
T16/24. 250mm Push Rod. Universal Tri-Stop. No Yoke. (S/S 925 494 960 0)
T24/24. 65mm Stroke. VOSS Ports RHS
T24/24. Push Rod 15mm VOSS Ports. Merc Actros. LHS
T14/24. Push Rod 15mm VOSS Ports. Merc Actros. Superseded by 925 488 015 0 LHS
T14/24. Push Rod 15mm VOSS Ports. Merc Actros. Superseded by 925 488 020 0 RHS
T12/12 trailers & mine machinery Pushrod 12mm
T24/30 Long stroke horizontal studs trailers Pushrod M16 1/2" Clevis old number AGA349
T24/30 Long stroke Vertical studs trailers Pushrod M16 1/2" Clevis old number AGA349A
T30/30 Long stroke trailers
Pushrod M16 1/2" Clevis old number AGA350
T24/24 925 491 141 0 with clevis, washers and pushrod lock nut
SPRING BRAKE SPARES
Part Number
M16 x 14mm Clevis and Pin.

Dust Boot. 1 Hole (Small) L=100mm W=45mm
Dust Boot. 1 Hole (Large) L=100mm W=45mm
Dust Boot. 2 Hole L=85mm W=45mm
Type 24 Rear Housing (Steel).
Type 30 Rear Housing (Steel).
Dust Boot Maxi
Maxi Booster Kit
Part Number
A 5948
ASA 1779
ASA 1780
ASA 5267
ASA6868
ASA 6294
Description
Centre Seal Kit.
T24 Push Rod Not for AGA349
T30 Push Rod.
5/8" Clevis x 1/2" Pin.
5/8" Clevis x 1/2" Pin (Long)
Clevis M16 x 1.5mm x 1/2" Pin.
31/53
WABCO
DIAPHRAGMS
Part Number
897 121 030 4
234433M
234226M
897 121 610 4
A6447
897 120 510 4
A6448
897 120 520 4
A2400
897 120 530 4
897 120 536 4
897 121 925 4
A3000
897 120 540 4
897 120 546 4
234362M
897 120 516 4
Description
Wabco Type 3. OD:78.6mm Depth 22mm
Type 9.
OD: 130mm
Type 12.
Wabco Type 14. OD: 147mm Depth 33mm
Type 16.
Type 20.
OD: 169.7mm Depth 28.7mm
Type 24.
OD: 180mm Depth 29mm
Wabco Type 24. Deep dish
Wabco Type 27.
Type 30.
OD: 203mm Depth 32mm
Type 36.
Type 16 Deep Dish
LOADSENSING & LEVELLING VALVE COMPONENTS
433 300 381 4 (STR)

A 5349 LSU
ASA 5080/5081
433 300 383 4 (L)
464 002 730 2 (Levelling Valve)

475 701 712 2 (L.S.V.)
Part Number
A 5349 LSU
A 5426
A 5427
A 6356
ASA 5080
ASA 5081
433 300 381 4
433 300 383 4
433 300 384 4
433 300 385 4
433 401 003 0
433 401 004 0
433 401 380 4
464 002 730 2
475 701 712 2
475 710 130 4
475 710 770 4
441 050 718 2
475 713 710 2
898 011 350 4
899 144 631 4
A6434
A5347
Description
Coiled Spring Arm for loadsensing
Bracket (Springbox Mounting / Single Axle).
Bracket (Springbox Mounting / Tandem Axle).
Data Plate - Air Suspension Valve / Mechanical
Linkage Kit Tandem Axle.
Linkage Kit Single Axle.
Axle Linkage Connection 8mm (Rubber Straight). Loadsensing Valve
Axle Linkage Connection 8mm (Rubber L Shape). Loadsensing Valve
Link Connection 6mm (Rubber L Shape). Levelling Valve
Link Connection 6mm (Rubber L Shape) Levelling Valve
Axle Linkage Kit. Levelling Valve. Clamp 893 510 470 2
Double Axle Linkage Kit Buffer Kit
Link Connection 6mm (Rubber Straight). Levelling Valve No Clamp
Metal Arm (464 002...0) Levelling Valve. Includes straight rubber
Straight Load Sensing Arm with Rubber Link.
Roller (475 710...0). Load Sensing Valve.
Plastic Plunger (475 710...0). Load Sensing Valve.
Flat Bar Levelling Valve arm for 464 002 532 0
Arm and Cable with spring for 475 713 .. Loadsensing Valve
Dust Cover / Cap (475 710...0). Load Sensing Valve.
Data Plate - Air Suspension Valve.
Single Rubber Buffer with steel threaded rod
Bottom Linkage Elbow and mounting nuts
32/53
WABCO
SUZY COILS
Air Suzy
7 & 15 pin Suzy
Part Number
7 & 15 pin Plug
7 & 15 pin Socket
A6699 & A6701
A6698 & A6700
Description
ASA 5477
ASA 5478
AGA347
AGA348
A6700
A6701
A6698
A6699
A6624
Red with Springs and 1/2" NPT Fittings. DIN Specification 73378.
Yellow with Springs and 1/2" NPT Fittings. DIN Specification 73378.
Electrical Male to Male 7 pin ISO 7638 ABS/EBS suzi
Electrical Male to Male 15 pin ISO 12098 suzi
Lighting 15 PIN ISO SOCKET
Female Easy connector type
Lighting 15 PIN ISO PLUG
Male Easy connector type
ABS/EBS 7 PIN ISO Socket
Female Easy connector type
ABS/EBS 7 PIN ISO Plug
Male Easy connector type
ABS/EBS 7 Core ADR Cable
NYLON PIPE
Part Number
Description
A 5766
A 6115
A 6232
A 6114
A 6119
828 251 908 6
A 6038
A 6041
A 6245
A 6241
828 251 907 6
A 5914
A6244
A 5912
A 6599
A 3005/N/10SB
828 251 906 6
A 3005/N/10R
04 Black.
04 Blue.
04 Green.
04 Red.
06 Blue.
06 Black.
06 Red.
06 Yellow
06 Green
08 Blue
08 Black.
08 Red
08 Yellow
08 Green
09 Black.
010 Blue.
010 Black
010 Red.
RUBBER HOSE
A3626
DIN Specification 73378 or 74324.

Part Number
Description
A 3005/N/10SY
A 5405
A 5606
A 5635
A 5633
A 5608
A 5782
A 5632
A 5634
A 5607
828 251 904 6
010 Yellow.
010 Green.
011 Black (Push on).
012 Blue.
012 Green.
016 Black (Push on ).
012 Black.
012 Red.
012 Yellow.
013 Black (Push on).
015 Black
1/2" Bore Rubber Hose Working pressure 15.5 Bar

DIN: SAE J1402.
INSTALLATION ACCESSORIES
AGA 322
A 900
899 700 001 4
899 700 002 4
899 700 003 4
899 700 012 4
899 700 014 4
899 700 015 4
Nylon Pipe Cutter

Spiral Binding 25m lengths
8mm Nylon Pipe Extraction tool plastic
12mm Nylon Pipe Release tool plastic
8mm Nylon Pipe Release tool stainless steel
Plastic Release Tool

Stainless Steel release tool
33/53
WABCO
TRUCK EBS COMPONENTS
446 130 014 0 / 015 0
480 001 000 0
480 001 011 0
480 103 011 0
480 202 005 0
480 204 001/ 2 0
Part Number
Port Thread
446 130 014 0
EBS ECU (Electronic Control Unit) 4x2, 1999, with EPS/EAS.

Application: Merc Actros
Diagnostic Software: 246 301 547 0
EBS ECU (Electronic Control Unit) 4x2, 6x2, 6x4, 8x4. Not 4x2 tractors. 1999, with EPS/EAS.
EBS ECU (Electronic Control Unit)
All ports: M22 x 1.5 Port Brake Signal Transmitter Without Silencer. With port 4 VOSS
4 M16 x1.5
M22 x 1.5 Voss
Brake Signal Transmitter With Silencer.
With Port 4VOSS
Application: Actros
All ports: M22 x 1.5
Brake Signal Transmitter With Silencer. 2003. Without port 4 VOSS.
Application:
Merc Actros
M22 x 1.5 Voss
Brake Signal Transmitter Without Silencer. Without port 4
Application:
Nissan UD 440
M22 x 1.5 Voss
Brake Signal Transmitter With Silencer. Without port 4
Application:
DAF
All ports: M22 x 1.5 Port Brake Signal Transmitter With Silencer. Without port 4
Application:
4 M16 x1.5
Axor
M22 x 1.5
EBS Axle Modulator. 4x2. 1999.
Application: Merc Actros / Axor
M22 x 1.5
EBS Axle Modulator. 6x2, 6x4, 8x4. 1999
EBS Axle Modulator. 4x2. 2004
446 130 015 0

446 130 053 0
480 001 000 0
480 001 010 0
480 001 011 0
480 001 400 0
480 001 500 0
480 003 000 0
480 103 011 0
480 103 012 0
480 103 015 0
EBS Axle Modulator. 6x2. 2004.

Application: All vehicles except 4x2
EBS Axle Modulator 6x2
EBS Axle Modulator. DAF
480 103 016 0

480 103 055 0
480 104 003 0
All ports: M22 x 1.5 Port Proportional Relay Valve. Front Axle. All vehicles except 8x4
4: M16 x1.5
All ports: M22 x 1.5 Port Proportional Relay Valve. Front Axle. For 8x4 vehicles. Replaces 8840135030
4: M16 x1.5
Application: DAF 85
M22 x 1.5
EBS Trailer Control valve. Reworked 7 pin Bayonet fitting plugged from below,
by: 480 204 002 0 Application: DAF, Merc Actros, Nissan Not Available
EBS Trailer Control valve. Reworked 7 pin Bayonet fitting plugged from below,
by: 480 204 002 0 Application: DAF, Merc Actros, Nissan
All ports: M22 x 1.5 Port EBS Axle Modulator. DAF
4: M12 x1.5
EBS Axle Modulator. Nissan
480 202 004 0

480 202 005 0
480 204 001 0
480 204 002 0
480 103 042 0
480 103 033 0
480 104 002 0
All ports: M22 x 1.5 Port EBS Axle Modulator. Nissan (4760-001207)
4: M16 x1.5
EBS Axle Modulator MAN 2005
480 104 106 0

446 135 003 0
446 210 001 0
446 210 006 0
Description
EBS ECU Nissan UD (4789.01273

Use
CVC Central Vehicle Controller MAN
34/53
Superceded
Superceded
WABCO
TRUCK ABS COMPONENTS
446 004 064 0
446 004 313 0 / 416 0
Part Number
446 004 064 0
446 004 416 0
446 004 335 0
472 195 006 0
472 195 016 0
472 195 018 0
472 195 052 0
472 195 082 0
472 195 083 0
446 044 200 0
446 056 127 0
449 423 060 0
449 423 080 0
449 423 120 0
449 715 120 0
449 715 080 0
894 601 133 2
446 004 335 0
472 195
Description
ABS/ASR - C3 4S/4M. 24v. Engine Interface, EDC/EMS. Application: DAF, Dennis, Nissan
4S/4M. 24V. D Engine Interface.
Application: MAN F2000 / Bus Diagnostics Software: 246 301 628 0
E Generation ECU. Basic ABS with ASR. Application: UD Nissan, Hino 700/500 Diagnostics Software: 246 301 628 0
24V ABS Solenoid Valve. Connector Kostal M24 x 1, 1/2" ports
Application: Older Trucks with ABS
24V ABS Solenoid Valve. Electric Connector Bayonet. M22 x 1.5 VOSS Port.
12V ABS Solenoid Valve. Electric Connector: Bayonet. 1/2"-14 NPTF dry seal
12V ABS Solenoid Valve. Electric Connector Kostal M24 x 1, 1/2"BSP ports Left Hand Side
Flange Mounted Application: Freightliner
12V ABS Solenoid Valve. Electric Connector Kostal M24 x 1, 1/2"BSP ports Right Hand Side
Flange Mounted Application: Freightliner
ABS ECU
24V ECAS Remote Control Unit
Solenoid Cable 6m
Solenoid Cable 8m
Solenoid Cable 12m
Truck Sensor cable 12M
Truck Sensor cable 8M
Adapter Cable Din to Bayonet
TRUCK ECAS (Electronically Controlled Air Suspension)
472 900 060 0
Part Number
472 900 053 0
472 900 060 0
472 905 111 0
473 905 114 0
472 880 001 0
446 056 116 0
446 056 202 0
446 056 010 4
446 170 208 0
441 050 011 0
441 050 012 0
441 050 100 0
472 880 000 0
441 040 007 0
441 040 015 0
441 043 504 1
441 050 123 0
441 100 531 2
463 084 010 0
446 056 116 0
441 050 011 0 /012 0
441 040 007 0 / 015 0
472 880 001 0
Description
For Rear Axle with 2 Height Sensor. 3 Solenoids. 1 Electrical Connection. Bayonet. M22 x 1.5 VOSS Push-in Fitting. With
Silencer. Application: DAF, MAN, Repair Kit : 472 900 009 2 Same as 472 900 060 0 but with Plug
For Rear Axle with 2 Height Sensor. 3 Solenoids. 1 Electrical Connection. Bayonet. M22 x 1.5 VOSS Push-in Fitting. With
Silencer. Repair Kit : 472 900 009 2.
NO Plug but Same as 472 900 053 0
ECAS Solenoid valve drive and lift axle M22 Kit 472 905 004 2 DAF MAN TGA AXOR
ECAS Solenoid valve drive and lift axle M22 2x silencers Bayonet connector
ECAS Solenoid replaces 472 900 053 0
ECAS Remote control Hand held Truck only
ECAS Remote control Hand held Universal
Mounting bracket for remote control
ECAS ECU Unit
ECAS Height Sensor. Bayonet without Lever. Height Sensor. Application Mercedes Benz, DAF, MAN
ECAS Height Sensor. Bayonet without Lever. Without Temperature Compensation. Application: Merc, MAN
ECAS Height Sensor. Bayonet with Lever. Without Temperature Compensation.
ECAS Solenoid Valve use 472 880 030 0 AXOR RA, DAF Iveco
ECAS Pressure Sensor M16 x1.5 Bayonet 400 mV/Bar (16 Counts/Bar) Appl: Mercedes, DAF, Iveco, MAN, Scania, Trailer
ECAS Pressure Sensor. M16 x 1.5 Bayonet. 400 mV/Bar (16 Counts / Bar). With O ring
Application:
Mercedes Benz, DAF, Iveco, MAN, Scania, Trailer
Pressure Sensor
ECAS Height Sensor
Distance Sensor Module
35/53
WABCO
EBS & TCE TRAILER COMPONENTS
480 102 014 0 / 015 0
Part Number
480 207 001 0
446 122 001 0
Description
C Version EBS
971 002 802 0
971 002 805 0
449 472 080 0
EBS Relay Emergency Valve C Version EBS OLD system. Use 9710028050 below with kit
EBS Relay Emergency Valve rep. 9710028020 C Version. Use with 9710029212 or 9710029222 see date of valve
EBS CABLE to REV C Version EBS OLD system Use with 9710029212 or 9710029222 see date of valve
D Version EBS
480 102 015 0
480 102 010 0
480 102 014 0
480 207 001 0
EBS D ECU VALVE WITH RSS WITH TCE replaces 4801020020 4S3M
EBS D ECU VALVE NO RSS NO TCE Basic EBS
4S2M
EBS D ECU VALVE WITH RSS NOT FOR TCE 4S3M
EBS 3rd Modulator Relay Valve for trailers
441 040 015 0

449 752 030 0
449 752 100 0
449 823 020 0
Pressure Transducer used with ECAS and TCE replaces 4410400070 24V 10 Bar max
Pressure Transducer Cable 3m to EBS from transducer 4410400150 for drawbars D -Ver EBS and old EBS
Pressure Transducer Cable 10m to EBS from transducer 4410400150 for drawbars D -Ver EBS and old EBS
Pressure Transducer Cable to TCE x44 from 4410400150 for ECAS
449 372 130 0

449 672 030 0
449 172 120 0
449 272 100 0
449 684 313 0
449 172 150 0
ASA7118
449 377 030 0
446 192 110 0
EBS 3rd Modulator Cable

DIAGNOSTIC PLUG CABLE 3m
ELECTRICAL SUPPLY CABLE with ISO6738 7pin Female socket 12m
ELECTRICAL SUPPLY CABLE with ISO6738 7pin Male socket 10m
ELEC SUPPLY (stoplight) & diagnostic cable 12m (replaces normal diag cable) NOT ISO7638
ELECTRICAL SUPPLY CABLE with ISO6738 7pin Female socket 15m
15 EXTENDED POWER CABLE WITH MALE FOR DRAWBARS
Smartboard cable to D gen EBS
Smartboard EBS with battery (Not ADR Compliant)
TCE Components
446 122 001 0
449 113 120 0
446 122 400 0
449 704 253 0
449 672 040 0
449 399 020 0
449 655 050 0
446 156 010 0
449 392 075 0
TCE computer UNIT Supercedes 446 122 000 0

POWER SUPPLY CABLE x13 on TCE 15PIN
PARK Distance Controller sensor TCE
TCE To Park Dist Control sensor Cable 6m 2 split x31
TCE Diagnostic Cable x14
TCE To EBS Cable x22
ECAS/ELM fixed keypad cable to TCE board X41 use fixed mount box 4461560100
Fixed control keypad Box Mounted on vehicle
Cable for rear lighting with 15 pin ISO Socket
TCE ECAS Air Susp Control Parts

472 900 055 0
ECAS Air Susp Control Valve NO axle lift
449 483 015 0
TCE To ECAS Cable x43
446 056 202 0
Remote control keypad Hand held TRAILER
449 635 050 0
TCE to IRCU Unit Cable x41
441 050 012 0
Height Sensor Unit Without Arm
449 814 228 0
Height Sensor Cable to TCE 3m x42
Additional EBS Trailer Parts (non electronic parts)
971 002 900 0
PREV Valve - Trailer Park Release Valve with relay emergency feature
973 500 051 0
Quick Release Valve M22 & M16 del Anti compound valve. Port 12 to Prev valve
434 500 003 0
Select Low valve for Steering Axle control instead of using a solenoid
ASA6960
EBS data plate Calculation Information for EBS software
36/53
WABCO
EBS E GENERATION TRAILER COMPONENTS
480 102 063 0
441 050 100 0
446 192 110 0 or 446 192 100 0
472 905 111 0/114 0
480 102 030 0

480 102 060 0
480 102 063 0
481 102 080 0
2S/2M
4S/3M
4S/3M
4S/2M
449 173 120 0

449 273 120 0
449 349 150 0
449 723 030 0
449 723 100 0
480 207 001 0
472 195 031 0
449 429 080 0
449 436 030 0
449 611 030 0
441 050 100 0
449 811 000 0
Power Cable ISO 7638 Semi - Female 12m

Power Cable ISO 7638 Drawbar - male 12m
Stoplight Power cable 15m
Sensor extension cable 3m
Sensor extension cable 10m
EBS 3rd Modulator Relay Valve 24V
EBS 3rd Modulator Relay Valve Multivoltage Same as VCSII Valve
3rd modulator cable to EBS E
3rd modulator cable to EBS E
Diagnostic cable E-EBS 3m
Distance Sensor Unit Without Arm for height control and on Mechanical suspension
Distance sensor Connecting cable for EBS E
472 880 001 0

472 905 111 0
472 905 114 0
449 443 040 0
894 601 135 2
ECAS Air Susp Control Valve NO axle lift

ECAS Air Susp Control Valve with Axle Lift and Optiturn - 1 point control
ECAS Air Susp Control Valve with Axle Lift and Optiturn - 2 point control
Single Circ Axle lift Cable 4m
Dual Circuit Axle Lift Cable
446 192 110 0

446 192 100 0
449 911 040 0
Smartboard EBS with battery (Not ADR Compliant)

Smartboard EBS without battery (ADR Compliant)
Smartboard Cable to EBS E
472 880 001 0
Premium 4 GIOs - Mech Susp & Int Air susp Without PEM
Premium 7 GIOs - Mech Susp & Int Air susp
Premium 7 GIOs - Mech Susp & Int Air susp & PEM & Fittings
Premium 7 GIOs - MultiVoltage ABS/EBS with RSS Without PEM
446 122 080 0

463 090 023 0
TASC Valve
446 122 070 0

ELEX
446 122 401 0/402 0

Park Distance Sensor
TASC ELEX & Park Distance Control Components

463 090 023 0
449 623 253 0
450 443 060 0
446 122 070 0
449 303 020 0
449 908 060 0
446 122 401 0
446 122 402 0
449 806 060 0
894 600 024 0
446 122 080 0
TASC Valve
Cable from ABS to TASC Valve with diagnostic plug 6m/6m
Cable from EBS E to TASC Valve 6m
ELEX ECU
Cable from ELEX to EBS Valve Subsystems plug
ELEX-Cable to ISO 12098
Park Distance ultrasonic sensor 0 degrees
Park Distance ultrasonic sensor 15 degrees
Sensor Cable to ELEX
Splitter cable for Sensors
Truck Remote control for trailer ELEX system
General Components
899 200 922 4
Sticky Silver Foil Data Label
893 129 467 4
Push in to 1/2" Hose barb
37/53
Remote Control
WABCO
SENSORS & ABS ACCESSORIES
441 032 808 0
441 032 921 0
Part Number
899 760 510 4
Description
449 712 023 0

449 712 038 0
449 712 051 0
449 032 905 0
441 032 808 0
441 032 823 0
441 032 851 0
441 032 082 0
441 032 920 0
441 032 921 0
441 100 110 0
2,3m Sensor Ext Cable

Std Truck or Trailer
3,81m Sensor Ext Cable Std Truck or Trailer
5.1m Sensor Ext Cable
Std Truck or Trailer
ABS Sensor BPW Disc Caliper
Sensor and cable 0.4m tail 90
Application: DAF, Merc, Trailer
Sensor Type S Plus. 2m tail 90
Sensor Type S Plus. 1.5m tail 90
Sensor S - Type Truck 3.5m 90
Sensor S - Type Truck Straight 2.5m
Sensor S - Type Truck Straight 3.0m
EDS Distance Sensor - Exclusive to FTE Automotive
A6609
895 905 155 4 NLA
899 760 510 4
ASA 6241
Warning Light Green round 12/24V LED

Pole Wheel ( For Henred and Go Axles Only) Not Available from WABCO
Sensor Bush
Mounting Block
TRAILER PNEUMATIC SUSPENSION & ECAS (Electronically Controlled Air Suspension)
4741000010
Part Number
463 084 010 0
463 084 020 0
463 084 041 0
446 056 202 0
Description
463 084 020 0
Full Pneumatic Automatic Axle Lift Valve. Valve factory set at Air bag pressure: 1.5Bar lift Axle 4.2Bar lower
449 664 190 0

449 664 253 0
449 443 040 0
894 601 135 2
463 084 030 0
463 084 041 0
EBS D Axle lift valve cable for Single Axle lift Valve 4630840300 4m / 4m diag
EBS D Axle lift valve cable for Single Axle lift Valve 4630840300 6m / 6m diag
EBS E Single Circ Axle lift Cable 4m
EBS E Dual Circuit Axle Lift Cable
Single circuit Axle lift Valve
Single circuit Axle lift Valve NEW with push in fittings 8mm
463 084 010 0

449 624 113 0
449 554 113 0
EBS D Dual axle lift valve. Split left and right of trailer M16 x 1.5 / M22 x 1.5
EBS D Axle lift valve cable for dual axle lift 4630840100
EBS D Diag / ELM / Single circuit Axle lift Cable 6m/2m/2m
474 100 001 0

449 344 253 0
449 340 153 0
ELM (Electronic Leveling Module) M16 x 1.5

Power cable from EBS ECU to ELM with EBS diagnostic plug
Power cable from ABS ECU to ELM + diagnostics
446 056 202 0

446 156 010 0
449 633 060 0
446 056 010 4
449 638 060 0
441 050 718 2
Remote control keypad Hand held TRAILER

Fixed control keypad Box Mounted on vehicle
Remote control Cable to remote control hand held
Mounting bracket for remote control
Remote control Cable from ELM to remote control Box Mounted on Vehicle
Flat arm for ELM and ECAS height valve
38/53
WABCO
TRAILER ABS COMPONENTS
VCSI
VCSII
400 500 035 0 / 050 0
Part Number
400 500 081 0 / 083 0
472 195 031 0
434 500 003 0
Description
TRAILER PARTS VCS I

400 500 035 0 NLA
24V ECU 4S/3M mixed Power supply stoplight power required with permanent power for diagnostics
400 500 050 0 NLA
12V ECU 4S/3M Permanent Power supply required for ABS to function, stoplight power optional
449 411 140 0 NLA
3rd modulator cable 14m
472 195 041 0
24V Bayonet. Boxer Valve. Double-ABS-Relay Valve. M22 x 1.5
449 314 257 0
Stoplight Power/Diagnostic cable 12/6 VCSI ABS
449 332 120 0
Constant Power Cable 12m No socket or plug VCSI ABS
449 332 140 0
Constant Power Cable 14m No socket or plug VCSI ABS
449 612 030 0
Diagnostic plug only
TRAILER PARTS VCS II
399 500 070 0
24V ECU 2S/2M Only ABS VCS II Mixed Power Supply
400 500 081 0
24V ECU 2S/2M or 4S/2M or 4S/3M ABS VCS II Mixed Power Supply
400 500 083 0
12V ECU 2S/2M or 4S/2M or 4S/3M ABS VCS II Mixed Power Supply
449 616 158 0
VCSII 3rd Modulator 15m Cable AND DIAGNOSTIC CABLE 3m
449 616 153 0
VCSII 3rd Modulator 6m Cable AND DIAGNOSTIC CABLE 3m
449 134 337 0
12m 7 Pin Y-Supply Cable ISO 7638 & ISO 1185 WITH FEMALE SOCKET - Semi Trailers (Stoplight and constant power)
449 234 337 0
12m 7Pin Y-Supply Cable ISO 7638 & ISO 1185 WITH MALE SOCKET -Drawbar Trailers (Stoplight and constant power)
449 615 030 0
Diagnostic Cable 3m prefered usage
449 615 060 0
Diagnostic Cable 6m
446 008 310 4
ISO 7638 Socket Pins 1,5
446 008 311 4
ISO 7638 Socket Pins 6,0
449 374 323 0
5 Pin Y cable - Semi and Drawbar Trailers (Stoplight supply only) 12m
Lengthening cables
449 384 333 0
449 384 328 0
449 133 120 0
449 233 100 0
ASA7075
ASA7080
6m Y-Supply Cable ISO 7638 & 12m ISO 1185 lengthen ISO cable with either 4491331200 or 4492331000 below
3m Y-Supply Cable ISO 7638 & 12m ISO 1185 lengthen ISO cable with either 4491331200 or 4492331000 below
12m 7 Pin ISO 7638 WITH FEMALE SOCKET join to 4493843330 above - Semi Trailers
10m 7 Pin ISO 7638 WITH MALE PLUG join to 4493843330 above - Drawbar Trailers
Superceded 14m 7 pin Extended Power Cable ISO 7638 & ISO1185 with Female socket - LONG SEMI TRAILERS
Superceded 14m 7 pin Extended Power Cable ISO 7638 & ISO1185 with Male socket - DRAWBAR TRAILERS
COMMON ABS PARTS FOR VCSI AND VCSII

472 195 031 0
24V 3rd Modulator Valve, Electrical Connector: Bayonnet
472 195 033 0
12V 3rd Modulator Valve, Electrical Connector: Bayonnet
434 500 003 0
Ports: M22 x 1.5 (Old No. 472 195 020 0)

Ports: 3/4" supply, 3/8" delivery, signal
Select Low valve for Steering Axle control instead of using a solenoid
ABS and General Plates and Labels

Sticky label "WABCO ABS"
A6259
Aluminium label "WABCO ABS" same text as A6259
A6602
A6389
Welding warning plate (This old plate now replaced by plate below A6621)
A6621
Diagnostics instruction data Plate replaces A6389
A6622
24V connector Plate
A6623
12V connector Plate
A6274
Diagnostics plate, next to diagnostic plug
A6627
A4 "Do not Weld Sticker ABS on Vehicle"
A6607
Torque to 210Nm plate for spring brakes
A6356
LSV Data Plate
39/53
WABCO
DIAGNOSTIC EQUIPMENT
GENERAL EQUIPMENT
AGA658
4463010300
A
4463004300
B
4463004000
B
Laptop, Diagnostic Interface II & Carry Case

Diagnostic Interface 2 & PC USB cable S/S 4463010220
Truck and Trailer ABS Handheld Tester & Hydraulic ABS
Trailer Handheld ABS Tester C, VCS I and VCSII
G
TRAILER DIAGNOSTIC CABLES

4463003292
C
K line Cable Trailer VCSI VCSII TCE EBS - Blue Diag plugs
4463003480
5V CAN Cable - Yellow Diagnostic trailer plug (IVTM)
4463003600
F
Inter Adapter ISO7638 CAN Cable use with 446 300 361 0
4463003610
E
24V CAN Cable CAN use with 446 300 360 0
4460562020
G
ELM Keypad
TRAILER SOFTWARE
4463015100
4463015420
4463015890
4463016920
Trailer VCSII Software

USB Stick
Trailer EBS D Software USB Stick
Trailer EBS E Software
USB Stick
ODR - Operating Data Recorder Software USB Stick
TRUCK DIAGNOSTICS CABLES

4463004040
H
ABS/ASR D vers. Inter-Adapter Cable MAN A63 bus
4463004080
I
ABS/ASR E vers. Inter-Adapter Cable Hino Toyota
4463004530
DAF EBS Cable
4463004540
J
OBD - EBS (EPB) Cable MPII Actros, Axor, defender
4463004560
ECAS Diagnostic Cable
4463004600
OBD - 15 pin Cable for DAF, Scania, MAN
4463003270
ABS, ECAS Inter Adaptor 35Pin Old version Truck
4463003170
ECAS / ATC Inter adapter 25pin
4463003440
EBS Euro/ Asia Vehicles OLD Nissan UD
4463003400
K
EBS / ECAS (EPB) Cable (Actros Axor) old cable
4463003450
ZBR II MAN cable (TGA MAN ECAS etc)
4463003490
IVECO EBS Cable
TRUCK DIAGNOSTICS SOFTWARE
4463016280
D+ ABS E Gen Software Hino Toyota
4463016240
ABS SAE D Gen Software Freightliner
4463018980
EBS 1C Asia Software UD trucks
4463015470
EBS EPB Software for Mercedes (Actros)
4463016820
Diagnostic Software for Trailer TCE
4463015450
Diagnostic Software for Truck EBS (Europe)
4463015560
Diagnostic Software for Truck EBS (Asia)
4463015720
Diagnostic Software HPB BAE software
4463018740
Diagnostic Software ENR Actros/Merc ECAS
4463006570
ZBR II MAN Software TGA MAN
Pipe Extractor Tools
899 700 001 4
899 700 002 4
899 700 003 4
899 700 012 4
899 700 014 4
899 700 015 4
8mm
12mm
15mm
8mm
12mm
15mm
Nylon Pipe Extraction tool plastic

Nylon Pipe Release tool plastic
Nylon Pipe Release tool plastic
Nylon Pipe Release tool stainless steel
40/53
WABCO
TEST EQUIPMENT PNEUMATIC
453 004 007 0
Part Number
453 004 007 0
AGA 211
ASA 5896*
118 938 6
A6918
AGA 211
Description
Pressure Gauge. 16 Bar. M16 x 1.5. Diameter (100mm).
Pressure Gauge. 10 Bar. Dash Mount. Diameter (60mm).
Test Hose 6m Long with Wing Nuts.
Test Gauge kit: 2x gauges, 2x hoses 6m , fittings and couplings and test pts
Wing Nut for Test Gauge Hose
41/53
WABCO
FITTINGS CATALOGUE
42/53
WABCO
GENERAL/ COMPRESSION FITTINGS

1
UNIONS
16
SOCKETS
ELBOW UNIONS
17
STEEL WASHERS
TEE UNIONS
18
ADAPTERS
BULKHEADS STRAIGHT
19
TEST CONNECTORS
O - RINGS
20
REDUCERS
THRUST RINGS
21
COPPER WASHERS
ALUMINIUM WASHERS
22
STRAPS
KORS (UNION SWIVEL ADAPTERS)
23
PIPE NUTS
NIPPLES
24
CUTTING RINGS
10
LINE CONNECTORS
25
STEEL PIPES
11
HOSE TAILS
26
PIPE CLAMPS
12
NYLON INSERTS
13
PLUGS
14
LOCKNUTS
15
BOLTS
43/53
WABCO
1
893 800 294 0
893 800 304 0
ASA6794
893 800 014 0
893 800 234 2
893 800 044 0
893 800 984 0
893 800 064 0
893 800 244 0
893 800 073 0
1677039
893 809 010 0
893 809 020 0
893 801 994 0
893 800 974 0
893 800 022 0
893 800 224 0
893 800 109 0
893 800 964 0
ASA1250
893 800 033 0
ASA5223
ASA555
893 800 264 0
ASA7077
893 800 254 0
ASA6223
893 800 008 2
893 800 033 0
2
8938300140
8938301040
ASA6503
893 830 214 0
8938307700
8938302040
8938300420
8938300910
8938900630
ASA5225
ASA1261
ASA1476
ASA1342
ASA1258
8938400340
ASA1263
ASA1262
8938401040

UNIONS
M10 -06
M10 -08
M10 -12
M12 -06
M12 -08
M12 -010
M12 -012
M14 -06
M14 -08
M14 -010
M14 -012
M16-06
M16-08
M16-010
M16-012
M22 -06
M22 -08
M22 -010
M22 -012
M22 -016
M22-015 Long nut and body
M22-015 Short nut and body
M22 -1/2"
M26-015 Long Nut and Body
M26-015 Short Nut and Body
M26-018 Long Nut Stoss
M12X1-08
M22-012
M22-015 Long nut and body
ASA6548
893 800 354 0
893 800 371 0
893 800 904 0
893 801 314 0
ASA1790
ASA5208
ASA5530
ASA5182
ASA930
ASA5315
ASA5366
ASA959A
ASA1025
ASA1009
ASA931
ASA5128
ASA952
ASA5806
ASA6729
893 800 134 0
A6196
ASA6766
1/8"BSP-08LL
1/4"BSP-010
1/4"BSPT-06
1/4"NPT-08
1/4"NPT-012
3/8"NPT-010 (S)
3/8"NPT-012
1/2"NPT-010
1/2"NPT-012
1/2"NPT-012 (BR)
1/2"NPT-015
1/2"BSP-012B/H
1/4"BSP-06
3/8"NPT-015
1/2"-012 B/H Brass
1/2"NPT-012
1/2"BSP-012
1/4"NPT-06
1/8"NPT-06
1/8"NPT-1/4"PIPE
3/8"NPT-010
3/8"BSP-08
1/4"NPT-1/4"PIPE
ASA5313
ASA2013
ASA2014
ASA963
ASA1235
ASA6728
ASA1435
ASA965
ASA5312
ASA6579
ASA964
ASA1237
ASA1374
1/4"NPT-012
3/8"BSP-010
3/8"BSP-012
1/4"NPT-012
1/4"NPT-06
1/2"NPT-010
3/8"NPT-012
1/2"NPT-012 Brass
1/2"NPT-012 Steel
1/4"NPT-08
3/8"NPT-012
1/8"NPT-06
1/8"NPT-08
ELBOWS
M12-06
M12-08
M16-08
M16-012 B/H
M22-08 B/H
M22-012 B/H
M22-015
M26-015 LONG NUT B/H
M22(male)-M22(Female)
M22-015 SHORT NUT
06SW-06
08SW-08
010SW-010
012SW-012
06-06 B/H
08-08 B/H
010-010 B/H
012-012 B/H
44/53
WABCO
3
8938600140
8938601440
8938600530
8938603740
8938600940
8938601940
8938603940
8938503240
8938503940
ASA969
ASA5956
A844
A636
A637
ASA5414
8938506600
A1012
4
8938213900
ASA5255
8938201600
8938205740
8938900140
8938900400
5
8970711104
8977700704
8977702504
8970804004
8977705304
7
8114010084
8114011724
8114010324
8114010454
8114010574
8114010664
8114010804
8114011004
9
8931000354
8931001644
8931800344

TEE
06-06-06
08-08-08
010-010-010
012-012-012
015-015-015
08-06-08
012-06-012
M22-012-012
M22-M22-012
012-1/4"(F)-012
012-08-012
1/4"(F)-1/4"(F)-1/4"(F)
1/4"(M)-1/4"(F)-1/4"(F)
3/8"(M)-3/8"(F)-3/8"(F)
1/8"(M)-1/8"(F)-1/8"(F)
M16-012-012
1/2" HOSE TEE Steel
ASA1336
ASA1345
ASA5443
ASA5242
ASA1504
ASA1348
ASA1260
ASA1259
ASA5258
ASA5207
893 850 314 0
ASA6279
893 500 044 4
221979
06SW-06-06
06-06SW-06
08SW-08-08
08-08SW-08
010SW-010-010
010-010SW-010
012SW-012-012
012-012SW-012
012SW-06-012
012SW-TEST-012
012-M22-012
Hyd Test M12x1
M22-M22-M22
1/4"-1/4"-1/4"
8938212340
8938212240
8938212440
8931039004
M16-012
M22-012
M22-015
M16-M22
BULKHEAD STRAIGHT
06-06
08-08
010-010
012-012
M22-M22
M22-1/2"BSP
O-RINGS
M12
M14
M16
M22
M26
6
893 030 070 4
893 030 080 4
893 030 170 4
893 030 040 4
893 030 090 4
893 030 014 4
ALUMINIUM WASHERS
M6
M10
M12
M14
M16
M18
M22
M26
THRUST RINGS
M12
M14
M16
M22
M26
M15
KORS (SWIVEL)
ASA5252
ASA5259
ASA1267
ASA1351
ASA1350
ASA5398
ASA5490
08-06
010-06
012-06
012-08
012-010
016-06
016-012
A60
A6217
1/4"NPT - 1/4"NPT
1/2"NPT - 1/2"NPT
NIPPLES
M22-M22 Hex
M22-1/2"BSP
M16 (Male)-M22 (Female)
45/53
WABCO
10
8938200120
8938201340
8938200240
8938205640
ASA5231
8938205740
8938200700
ASA5261
8938200840
ASA5237
205514
ASA6188
12

LINE CONNECTORS
06-06
08-08
010-010
012-012
015-015 short nut replaces 8938200610
012-012 B/H
015-015 short nut B/H
016-016 Short Nut
018-018 Long Nut
018-018 Short Nut
1/4"-1/4"
1/4"-1/4"B/H
06 X 1.5
08 X 1.5
10 X 1.5
12 X 1.5
15 X 1.5
18 X 1.5
13
PLUGS
14
5000110
5000484
A6001
5000112
5000113
8103150024
8103150034
8103150044
8103040314
8103150054
8915004544
8915004644
8915005204
16
8932402244
8933000124
8933000114
HOSE TAILS
A24
A6735
A646
A588
A25
A23
8931294462
8931204144
8931294452
A588
A6199
3/8"NPT - 1/2" HOSE - short Fir tree

3/8"NPT - 1/2" HOSE Steel Replaces A24
M22 -1/2" HOSE
Adapter hose stem pipe 12mm- 1/2"
1/4"BSPT - 1/2" HOSE
1/2"BSPT - 1/2" HOSE
M22 - 1/2" Hose Tail with Oring
M16 - 1/2" Hose Tail
Standpipe 12mm - 1/2"Hose Tail
Standpipe 12mm - 1/2"Hose Tail
246088
246089
246090
1/4"
3/8"
1/2"
ASA5974
04mm
A6113
A174
A31
A30
A29
A27
A28
1/8"BSP
1/8"NPT
1/4"NPT
3/8"NPT Brass
1/2"NPT Brass
1/2"BSP
3/4"NPT
NYLON INSERTS
8930402104
8930402204
8930402304
8930402404
8930402504
8930402604
8109030084
8930100304
8930100104
8930100114
8930117104
8930117114
8109040044
8930100204
8930102304
8930220144
8930220154
11
M10
M12
M14
M14
M16
M16
M16
M22
M26
M16
M22
Fine Thread
With O ring
With O ring
LOCKNUTS
M5
M6 NYLOC
M8 NYLOC
M8
M10
M12
M14
M16
M16 BOOSTERS
M18
M22
M26
M28
15
BOLTS
5000186
5000240
5000242
5005520
5000253
5000250
5000141
A5668
A5669
A5999
A6000
M5x25mm
M6x18mm
M6x20mm
M6x45mm
M8x1.25x35mm
M8x20mm
M10x20mm
M12x1,5mm Air Dryer
M12x1,75mm Reservoir
M8x60mm
M8x25mm
W103/8
ASA5595
A6056
1/2"NPT BRASS
1/4"
M22 -1/2"NPT
SOCKETS
M12
M22 SHORT
M22 LONG
46/53
WABCO
17
5000222
5000131
5000122
A5872
8951049304
5000582
5000583
5000584
5000585
5000587
8104200104
A5821
19
4637051020
4637031060
ASA5254
4637031140
4637031070
ASA5867
8937839404
ASA6279
ASA7096
463 703 116 0
21
A5764
A5371
A5530
A5531
SF240/4

STEEL WASHERS
M6 FLAT
M8 FLAT
M10 FLAT
M18 FLAT
M26 FLAT
M5 SPRING
M6 SPRING
M8 SPRING
M10 SPRING
M14 SPRING
M16 SPRING
M28 FLAT
18
A6112
ASA6251
ASA5405
893 180 184 4
893 180 274 4
893 180 034 4
TEST CONNECTOR
1/4"NPT MALE
M14 FEMALE
M16 FEMALE
M16 MALE
M18 FEMALE
VOSS TEST POINT
RUBBER DUST BOOT COVER
HYD TEST TEE
08-TP-08 TEE
M12 MALE
20
A5379
A5414
A5414
A5379
893 104 066 4
893 104 051 4
893 104 052 4
A499
A498
A673
893 180 880 4
A34
A35
A36
A39
A672
A6181
COPPER WASHERS
M12
M14
M16
M18
1/2"
23
PIPE NUTS
8930700544
8930701044
8930700744
8930708344
8930701744
8930700654
8930700844
06
08
010
012
015 SHORT
015 LONG
018 LONG
22
A900
A900/B
A1134
A6153
ADAPTERS
1/2"(M)-3/8"(F)
06L TAIL ONLY
08L TAIL ONLY
M22 (M)-1/2" (F)
M16 (M)-1/2" (F)
M16(M) - M22(F)
M16-M22
REDUCERS
M16 - 3/8"NPT
M16 (M) - 1/4" (F)
M16 (M) - 1/4" (F)
M16 (M) - 3/8" (F)
M16 (M) - M12 (F)
M22 (M) - M12 (F)
M22 (M) - M16 (F)
M22 (M) - 3/8"NPT (F)
M22 (M) - 1/4"NPT (F)
M22 (M) - 1/2"NPT (F)
M26 (M)-M22 (F)
3/4"NPT (M) - 1/2"NPT (F)
1/2"-3/8"
3/8"NPT (M) - 1/4"NPT (F)
1/2" (M) - 1/4" (F)
1/2"NPT (M) - M22 (F)
1/4"NPT (M) - 1/8" (F)
With O ring
With O ring
With O ring
STRAPS
Clear Spiral Binding
Black Spiral Binding
Plastic Straps 200mm (100Qty)
Plastic Straps Heavy Duty 395mm (50Qty)
24
893 050 014 4
893 050 054 4
893 050 024 4
893 050 144 4
894 050 034 4
A5554
893 050 040 4
A488
CUTTING RINGS
06
08
010
012
015
016
018
012 Brass
47/53
WABCO
25
8201205016
8201205046
8201105046
8201105036
A3005/BU/6MM
8201205726
8201205816
8201205736
A3005/S/16MM
A5851
A3005/BU/12MM

STEEL PIPES
08
010
012 (PHOS.)
012 (GALV.)
06 BUNDY TUBE
015 (PHOS.)
015 (GALV.)
018 (GALV.)
016
016 STAINLESS
012 BUNDY TUBE
26
893 511 110 4
893 511 030 4
893 510 990 4
893 511 000 4
893 511 010 4
893 511 020 4
A5370
A3626
A6720
A6183
PIPE CLAMPS
06
08
010
012
015
018
1/2" Hose Clamp
1/2" Hose Clamp
20-22mm Bolt clamp Best
1/2" Hose Clamp
48/53
WABCO
PUSH IN FITTINGS
1
STRAIGHT UNIONS
11
BULKHEAD UNIONS
MALE BULKHEAD BARREL TEE BLOCK
12
BULKHEAD ELBOWS
MALE BULKHEAD STUD BLOCK
13
TEES
MALE BULKHEAD ELBOW BLOCK
14
BRANCH TEES (ASSEMBLED)
FEMALE TEE BLOCK
15
BARREL TEES (ASSEMBLED)
MALE BULKHEAD TEE BRANCH BLOCK
16
TEST POINT TEES (ASSEMBLED)
SCREW THREAD WITH SWIVEL PLUG
17
LINE CONNECTORS
SWIVEL PLUG ELBOW
18
VEE NUTS
SWIVEL PLUG BARREL TEE
19
O-RINGS
10
SWIVEL PLUG BRANCH TEE
20
THRUST RINGS
21
VARIOUS
49/53
WABCO
1
893 803 035 0
893 803 022 0
893 803 023 0
893 803 024 0
893 803 025 0
893 800 007 2
893 800 001 2
893 800 005 2
893 800 002 2
893 800 008 2
893 800 004 2
893 803 420 0
893 803 410 0
893 803 990 0
893 800 005 2
899 700 001 4
899 700 002 4
899 700 003 4
899 700 012 4
899 700 014 4
899 700 015 4
2
893 851 400 0
893 851 390 0
4101083M

STRAIGHT UNIONS
(M10x1
thread)
M10 - 6mm
(M10x1
thread)
M12 - 6mm (alternative 4100916M)
M16 - 6mm
M22 - 6mm
M10 - 8x1 mm (M10x1 thread)
M12 - 8x1 mm (8938034900, 4100888M) **
M16 - 8x1 mm (8938035400, 4100911M) **
M22 - 8x1 mm (8938034000, 4100913M) **
M16 - 12x1.5 mm (8938034300, 4100915M) **
M22 - 12x1.5 mm (8938034400, 4100914M) **
M22 - 15x1.5 mm (8938037800, 4101056M) **
M22 - 10x1 mm
M16 - 10x1 mm
M26 - 15x1.5 mm
M16 - 16 x 1
**
** This type of fitting has pipe removable using a tool below
8mm Nylon Pipe Extraction tool plastic
Plastic Tool
MALE BULKHEAD BARREL TEE BLOCK

M22-M16F-M16F * (alternative 4101087M)
M16-M16F-M16F * (alternative 4101086M)
M12-M12F-M12F
* WITH Lock nut, Thrust ring and O ring
3
4101005M
4101017M
MALE BULKHEAD STUD BLOCK

M22 / M22 - M16F B/H stud * (alternative 8931042962)
M16 / M22 - M16F B/H stud * (alternative 8931042972)
4
893 401 008 4
893 401 292 4
893 401 770 4
893 890 450 0
4101105M
4101098M
4101102M
5
4100994M
893 501 191 4
893 501 197 4
6
890 159 586 4
4101096M
4101095M
4101091M
A6605
A6606
MALE BULKHEAD ELBOW BLOCK

M12 - M12F B/H Elbow stud *
M22-M16F B/H Elbow stud
* WITHOUT Lock nut, Thrust ring and O ring
FEMALE TEE BLOCK
M12F - M12F - M12F TEE Block (alternative 8935010054)
M16F-M16F-M16F TEE BLOCK (alternative 4100993M)
M22-M22F-M22F TEE BLOCK (alternative 4101198M)
MALE BULKHEAD TEE BRANCH BLOCK

M16F -M22 - M16F TEE Branch *
M16F-M22-M16F TEE BRANCH (alternative 8901595864 *)
M16F -M16 - M16F TEE Branch (alternative 8935010014 * )
M12F -M12 - M12F TEE Branch (alternative 893 501 006 4 * )
3/8M - 1/4F - 3/8F TEE Branch (replaces A36 & A637)
M16M -1/4F - 3/8F TEE Branch
* WITHOUT Lock nut, Thrust ring and O ring
50/53
Stainless Steel
WABCO
7
893 920 342 4
893 129 191 2
893 129 192 2
893 129 193 2
8
893 401 827 2
893 401 015 2
9
893 501 193 4
893 501 194 4
10
893 501 195 4
893 501 196 4
11
ASA7098
ASA7169
ASA7099
ASA7123
ASA7124

SCREW THREAD WITH SWIVEL PLUG
M 10x1 Swivel Plug P5 (893 920 827 2)
M 12x1.5 Swivel Plug P5
SWIVEL PLUG ELBOW

M12x1.5 Elbow for P5 plug
M 16x1.5 Elbow for P5 plug
SWIVEL PLUG BARREL TEE

M12x1.5 Barrel Tee for P5 plug
M 16x1.5 Barrel Tee for P5 plug
SWIVEL PLUG BRANCH TEE

M12x1.5 Branch Tee for P5 plug
M 16x1.5 Branch Tee for P5 plug
BULKHEAD UNIONS
M16 - 12mm *
(Alternative:ASA7100)
ASA7169)
M22 - 12mm * (Alternative:
M22 - 08mm *
M18body
body
M22 - 12mm * M18
M18body
body
M22 - 08mm * M18
12
ASA7101
ASA7102
ASA7103
ASA7187
BULKHEAD ELBOWS
M22 - 12mm Swivel Type Short P5 plug (alternative: ASA7170)
(Alternative:
8930 831
M12 - 08mm * (Alternative:
893 831 291
* ) 291 0)
M16 - 08mm Swivel Type Short P5 plug (Alternative: 893 831 293 0 *)
M22 - 15mm *
`
13
ASA7105
ASA7182
ASA7106
ASA7177
ASA7203
TEES
08-08-08
12-12-12 (Alternative: ASA7104)
15-15-15 (Alternative: ASA7183)
012-08-012
012-08-08
51/53
WABCO
14
ASA7107
ASA7109
ASA7164

BRANCH TEES (ASSEMBLED)
012-M22-08 * (replaces: 8938510200)
012-M22-012 * (replaces 8938509700 and ASA7202)
08-M22-08 *
15
ASA7108
ASA7110
ASA7115
BARREL TEES (ASSEMBLED)

M22-012-08 * (replaces 8938510500)
M22-012-012 *
M12-08-08 * (replaces 8938510600)
16
ASA7111
ASA7112
ASA7113
ASA7114
ASA7097
TEST POINT TEES (ASSEMBLED)

M22 - TP - 08 *
M22 - TP - 012 *
M16 - TP - 012 *
M16 - TP - 08 *
M12 - TP - 08 *
17
893 803 034 0
893 803 037 0
893 803 039 0
893 803 041 0
18
893 771 236 4
893 771 234 4
893 771 235 4
19
897 071 110 4
897 770 250 4
897 080 400 4
20
893 030 070 4
893 030 170 4
893 030 040 4
LINE CONNECTORS
6mm-6mm
08mm - 08mm (replaces 4101064M)
12mm - 12mm (replaces 4101066M)
15mm - 15mm
VEE NUTS
VEE Nut 6x1 Pipe M12
VEE Nut 8x1 Pipe M14
VEE Nut 12x1.5 Pipe M18
O-RINGS
M12
M16
M22
THRUST RINGS
M12
M16
M22
52/53
WABCO
21

VARIOUS
891 503 076 2

891 500 454 4
Locknut with O ring M22

Locknut withOUT O ring M22
4101058M
4101057M
M16 M Test point

M12 M Test point
893 022 014 4

893 022 015 4
M16 M Plug with Oring

M22 M Plug with Oring
A6735
4087055F
4087063F
ASA7127
3/8" - 1/2" Hose Tail

M16M - 1/2"hose - 1/2" hose
893 104 058 4
M22 Bulkhead Stud ID M16 (alternative 4100992M)

(No Locknut)
899 360 210 4

899 360 260 4
899 360 140 4
Thread Filter M 12x1.5

4101163M
A6717
M18 - M16 Socket

M16 - 1/2" Socket
(alternative 4637031140)
(replaces 4637020030)
(alternative 4101061F)
(alternative 4087057F)
(alternative 8931294452 )
(alternative 8931294462)
53/53

Wabco Gen Catalogue 2014 LR

Uploaded by

Copyright:

Available Formats

Wabco Gen Catalogue 2014 LR

Uploaded by

Document Information

Original Description:

Original Title

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

Wabco Gen Catalogue 2014 LR

Uploaded by

Copyright:

Available Formats

What components are covered in the catalogue?

What components are covered in the catalogue?

What page numbers are covered in the document?

What page numbers are covered in the document?

WABCO

Automotive South Africa

ABS/EBS - Speed Sensors

Load Regulating Valve

Load Sensing / Levelling Valve Parts

Load Sensing Valves -Air Susp

Air Processing Units

Load Sensing Valves -Mech Susp

Low Pressure Switches

Air Throttle Valves

Brake Chambers -Disc Brakes

Pressure Limiting Valves

Quick Release Valves

Raise / Lower Valve

Condensor Drain Valves

Relay Emergency Valves

Servo - Air / Hydraulic

Door Control Valve

Double Check Valves

Double Diaphragm Spring Brakes

Double Diaphragm Spares

Spring Brakes Wedge

EBS Components - Trailers

Spring Brakes -Disc Brakes

EBS Components - Truck

Spring Brake Spares

Stop Light Switches

ECAS Truck Components

Test Equipment ABS

Empty Load Valves

Test Equipment Pneumatic

Exhaust Brake Valves

Throttled Check choke Valve

Foot Brake Valves

Trailer Control Valves

Four Circuit Protection Valves

Trailer Release Valve (PREV)

Gearbox / Control / 3/2-way

Hand Control Valves

Lift Axle Control Valves

PARTS CATALOGUE 2014

15 Foot Brake Valve

16 Park Brake Valve

4 Four Circuit Protection Valve

17 Trailer Control Valve

5 Reservoir Circuit 2 (Front Brakes)

18 Relay Load Sensing Valve

6 Reservoir Circuit 1 (Rear Brakes)

7 Reservoir Circuit 3 (Park Brakes / Trailer)

9 Exhaust Brake Valve

22 ABS Warning Lamps

23 ABS Solenoid Valve (Front)

11 Coupling (Red) Emergency Line

24 ABS Solenoid Valve (Relay)

WABCO