Cat - Dcs.sis - Controller Electrico 962h

101
RD
102
103
Component Location
Wire
Number
Wire
Color
Bat (+)
F766
WH
RD
Head Lmp
G764
PK
Park Brake Lever Sw to Gnd
RD
AIH Breaker
H702
PU
Implement Control Reversing Fan Sw (N.O.)
Description
Power Circuits
Description
Control Circuits Continued
Bucket Position Sw / Fork Position Sw
106
WH
Tilt / Lift Position Sensors
H703
YL
Implement Control Reversing Fan Sw (N.C.)
110
RD
Engine ECM
H704
PK
Implement Control Reversing Fan Sol
112
PU
Main Power Relay Output
H713
PK
Implement Control Lift Proportional Sol
114
RD
Warning Horn (Forward)
H714
OR
Implement Control Lower Proportional Sol
124
GN
A/C
H717
BR
Implement Control Pilot Press Sol
133
OR
LH/RH Dash Indicator Panel
H718
GY
Implement Control Tilt Cylinder Position
136
GN
Supplementary Steering
H746
YL
Fan Control Sol Positive
138
GN
Auto Lube Pump To Payload Monitor
H747
BR
Fan Control Sol Return
141
RD
Beacon / Heated Mirror
H795
PK
Throttle Sensor Common
146
GY
Rotary Tilt Position Sensor
J764
BR
Xmsn Oil Temperature Sensor Ground
147
RD
ECAP/Center Dash Indicator Panel/Autolube
N707
PU
Fuel Pressure Sw
150
OR
Engine ECM/Implement ECM/Transmission ECM
P739
BU
Axle Cooler Clutch
174
RD
Unswitched Fuse Bus Power
P793
BU
Axle Cooler Clutch
175
RD
Hood Actuator Breaker
R746
PK
Boost Pressure Sensor Ground
199
RD
Hood Actuator
Ground Circuits
R747
GY
Atmospheric Press Sensor
T725
WH
Fuel Filter Sw
200
BK
Main Chassis
Y794
OR
Expanded Can Data Link +
201
BK
Operator Monitor Return
Y795
GN
Expanded Can Data Link -
202
BK
Xmsn Ctrl
838
YL
Front Guard Motor
229
BK
Engine ECM
839
BU
Front Guard Motor
C214
BK
Rotary Tilt Position Sensor
G826
BR
Engine ECM Sensor +5v
C216
BK
Implement Return
Basic Machine Circuits
G827
BU
Engine ECM Pressure Sensor Return
G828
WH
Engine ECM Pressure Sensor +5v
304
WH
Start Relay to Starter Motor
G829
GN
Engine ECM Pressure Sensor Common
306
GN
Start Relay to Transmission ECM
G833
PK
Engine ECM Temperature Sensor Common
308
YL
Main Power Relay Coil
G849
BR
Engine Injection Actuation Pressure
321
BR
Backup Alarm Lamp Travel Alarm
G850
BU
Inlet Air Heater
322
GY
Warning Horn (Forward)
G854
PK
Injection Actuation Press Cont Valve
326
RD
Key Sw 'C' Term.
G855
PU
Injection Actuation Press Cont Valve Common
397
OR
Hood Raise Motor
G856
WH
TDC Probe +
398
BU
Hood Raise Motor
G857
YL
TDC Probe -
A300
GN
Hood Raise Relay Coil
J807
BK
Transmission Clutch 4 5 6 Return
A301
WH
Hood Raise Relay Coil
J808
BK
Transmission Clutch 1 3 Return
A307
GY
Throttle Position
Monitoring Circuits
J809
BK
Transmission Clutch 2 Return
J813
BK
Implement Solenoid Control Return
403
GN
Alternator (R) Term.
J814
BK
416
OR
Supplemental Steering Sw
J815
BK
417
GY
Primary Steering Sw
J843
BK
Turbo Inlet Prerssure Sensor Return
419
YL
Parking Brake Sw
J844
GY
Turbo Inlet Prerssure Sensor +5v
426
BR
Power Train Oil Filter
T858
GY
Injector 1&2 Return
430
BU
Air Filter
T859
WH
Injector 3&4 Return
432
PK
Brake Press. (Oil)
T860
OR
Injector 5&6 Return
439
YL
Lamp Indicator
900
PU
Xmsn Shift Sol No. 5
442
GY
Hyd System Temp Gage
901
WH
443
YL
Power Train Temp Gage
944
OR
Cat Data Link +
447
PK
Fuel Level Gage
945
BR
Cat Data Link -
450
YL
Tach Sender (+)
964
BU
Fork Position Select
453
PK
Supplemental Steering Fault Lamp
976
OR
Ride Cont Solenoid 1
484
YL
Primary Steering Lamp
987
WH
Diverter Sol
E455
BR
Hydraulic Oil Filter
994
GY
Oil Pressure (Filtered)
G485
BU
Front Brake Temperature
995
BU
Coolant Temperature
G486
GN
Rear Brake Temperature

Accessory Circuits
A958
WH
Park Brake Sol
A982
BR
Eng Throttle Control
506
PU
Washer - Front
C967
BU
Inlet Air Temperature
507
WH
Washer - Rear
C987
RD
AIH Relay
513
OR
A/C Compressor/Refrigerant Pressure Sw
C991
PK
Fuel Filter Monitor
521
YL
A/C Sw to Refrigerant Sw
E900
WH
Trans Output Spd +

Trans Output Spd -
522
WH
A/C Clutch to Thermostat Sw
E901
GN
C529
GY
Lift Press Sensor
E906
OR
Trans Output Spd Q+
C530
BU
Lift Position Sensor

Lighting Circuits
E907
GY
Trans Output Spd Q-
E908
BR
Trans Input Spd +
OR
Stop Lamp
E909
WH
Trans Input Spd -
605
YL
Turn Lamp - Left
E919
YL
Aux Lower Proportional Sol
606
GY
Turn Lamp - Right
E920
BR
Aux Lift Proportional Sol
611
PU
Head Lamp Hi
E921
PK
Rackback Proportional Sol
614
PU
Park/tail/dash/lamp
E922
GN
Dump Proportional Solenoid
604
Schematic
Location
F-12
C-17
H-12
B-13
L-1
J-9
I-14
L-12
L-13
I-14
I-14
L-14
K-14
J-14
K-14
I-14
J-14
G-14
K-13
B-6
L-14
C-5
A-13
G-15
C-5
J-9
K-11
F-12
J-14
K-10
I-14
E-9
H-16
E-9
E-15
E-15
D-15
K-2
D-16
I-5
D-15
L-3
G-2
D-15
Component
AIH
Alarm - Backup
Alternator
Arc Suppressor - A/C
Arc Suppressor - Quick Coupler
Arc Suppressor - Secondary Steering
Arc Suppressor - Start Relay
Batteries
Block Asm.
Breaker - AIH
Breaker - Alternator
Breaker - Belly Guard Actuator
Breaker - Hood Actuator
Breaker - Main
Breaker - Running Lamp
Breaker - Start
Breaker - Unswitched Bus (Cab)
Control - Engine
Control - Hood Raise/Lower
Motor - Autolube Pump
Motor - Belly Guard
Motor - Front Washer
Motor - Fuel Priming Pump
Motor - Hood Actuator
Motor - Rear Washer
Motor - Secondary Steering
Motor - Starter
Relay - AIH
Relay - Main
Relay - Secondary Steering Intermediate
Relay - Start
Resistor - CAN
Sender - Fuel Level
Sender - T/C Temperature
Sensor - Atmospheric Pressure
Sensor - Boost Pressure
Sensor - Coolant Temperature
Sensor - Front Axle Oil Temperature
Sensor - Fuel Pressure
Sensor - Hydraulic Oil Temperature
Sensor - Intake Manifold Air Temp
Sensor - Lift Cylinder Head End Pressure
Sensor - Lift Position
Sensor - Oil Pressure
Machine
Location
1
2
3
3
4
5
6
7
7
6
6
6
6
6
6
6
6
8
6
9
10
11
1
12
11
5
13
1
6
5
6
8
14
15
16
16
17
18
1
19
16
20
20
17
Component
Sensor - Rail Pressure
Sensor - Rear Axle Oil Temp.
Sensor - Rotary Lift Position
Sensor - Rotary Tilt Position
Sensor - Speed Timing Group
Sensor - Trans. Output Speed (Leading)
Sensor - Trans. Output Speed (Trailing)
Sensor - Transmission Input Speed
Sensor - Transmission Oil Temperature
Sensor - Turbo Inlet Pressure
Solenoid - A/C Clutch
Solenoid - Auto Reversing Fan
Solenoid - Aux Third Function (Forward)
Solenoid - Aux Third Function (Rearward)
Solenoid - Axle Cooler Clutch
Solenoid - Dump Anti-Drift
Solenoid - Dump Prop
Solenoid - Lower Anti-Drift
Solenoid - Lower Prop
Solenoid - Pilot Hydraulic Supply
Solenoid - Quick Coupler
Solenoid - Rack Back Prop
Solenoid - Raise Prop
Solenoid - Start Aid
Solenoid - Variable Speed Fan
Solenoids - Cylinder Head ( 1 - 6)
Solenoids - Ride Control (1-3)
Solenoids - Trans. Clutch
Switch - A/C Refrigerant
Switch - Autolube Pressure
Switch - Belly Guard Actuator
Switch - Brake Oil Pressure
Switch - Bucket Position
Switch - Disconnect
Switch - Fork Position
Switch - Fuel Pressure
Switch - Fuel Priming Pump
Switch - Ground Level Shutdown
Switch - Hood Actuator
Switch - Hydraulic Filter Bypass Pressure
Switch - Park Brake Pressure
Switch - Primary Steering Pressure
Switch - Secondary Steering Pressure
Switch - Trans Filter Bypass
Schematic
Location
E-16
A-11
L-3
L-2
C-15
H-9
I-9
I-9
I-9
G-12
A-13
C-17
E-2, I-2
C-2, H-2
G-12
D-2, I-3
D-2, I-2
D-2, I-3
D-2, H-2
C-2, H-2
L-1
D-2, I-2
D-2, H-2
E-9
G-12
F-17
E-2, H-3
I-10
B-13
B-7
L-13
G-12
G-1
L-12
G-1
D-16
A-13
H-13
H-13
D-5
D-5
J-8
J-8
D-5
Machine
Location
1
21
22
23
17
24
24
25
26
27
3
28
20
20
1
20
20
20
20
20
4
20
20
29
28
30
20
25
3
31
6
3
32
6
32
1
1
6
6
33
34
5
5
33
41
14
35
12
5
29
39
10
13
950H, 962H, and IT62H Wheel Loader

Electrical System
4
43
38
21
37
24
3
27
950H:
N1A1-UP
JAD1-UP
M1G1-UP
J5J1-UP
K5K1-UP
40
36
17
8
1
16
18
32
23
44
26
15
20
31
25
19
30
28
962H:
N4A1-UP
M3G1-UP
J6J1-UP
K6K1-UP
MAL1-UP
IT62H:
M5G1-UP
22
42
34
11
33
Volume 1 of 2: Chassis
2009 Caterpillar, All Rights Reserved
Printed in U.S.A.
Harness And Wire Electrical Schematic Symbols

Symbols
Pressure
Symbol
Temperature
Symbol
Level
Symbol
Circuit Breaker
Symbol
Flow
Symbol
Connector Location
Connector Number
CONN 1
Schematic
Location
Machine
Location
D-16
617
BR
Tail/position Lamp - Left (road Pkg)/width
E963
BK
Engine Speed/Timing A-
CONN 2
D-16
619
GN
Head Lamp Low
E964
WH
Engine Speed/Timing A+
CONN 3
I-17
35
A693
OR
Fuel Priming Pump Sw to Fuel Priming Pump

Control Circuits
E965
BU
Engine Speed/Timing B-
CONN 4
I-17
35
E966
YL
Engine Speed/Timing B+
CONN 5
C-15
16
727
GN
Supplemental Steering Motor Relay
K927
BU
Pilot Hydraulic Supply Solenoid Return
CONN 6
D-15
16
Trans Oil Temp Sensor
CONN 7
F-15
728
BU
Supplemental Steering Control Sw
K977
PK
751
GN
Xmsn Shift Sol No. 1 Or 3
L983
WH
Injector 1&2 Return
CONN 8
L-12
752
YL
L984
OR
Injector 3&4 Return
CONN 9
A-11
36
754
BU
L985
YL
Injector 5&6 Return
CONN 10
E-9
37
755
OR
N939
GN
Ride Control Solenoid 2
CONN 11
F-9
13
762
YL
Bucket Positioner Sol Sw
P945
OR
Anti Drift Sol- Stick
CONN 12
G-9
13
779
WH
Quick Coupler Engage Sol
P946
BR
Anti Drift Sol- Boom
CONN 13
K-8
A701
GY
Injector Solenoid 1
P976
BR
Quick Coupler Sw to Quick Coupler Solenoid
CONN 14
C-7
38
A702
PU
Injector Solenoid 2
P990
BR
Start Relay Control Return
CONN 15
C-7
34
A703
BR
Injector Solenoid 3
T957
PU
Injector Solenoid 1
CONN 16
I-6
39
A704
GN
Injector Solenoid 4
T958
YL
Injector Solenoid 2
CONN 17
H-6
39
A705
BU
Injector Solenoid 5
T959
BR
Injector Solenoid 3
CONN 18
G-6
39
A706
GY
Injector Solenoid 6
T960
BU
Injector Solenoid 4
CONN 19
E-6
39
A751
YL
Not Used
T961
GN
Injector Solenoid 5
CONN 20
J-4
40
E748
BK
Start Aid Solenoid Return
T962
WH
Injector Solenoid 6
CONN 21
J-3
41
F713
OR
Left Turbo Inlet Press
X918
PU
Gnd Level Shutdown (N/O)
CONN 22
J-3
22
F762
GY
Start Aid Solenoid Drive from Engine ECM
X919
WH
Gnd Level Shutdown (N/C)
CONN 23
L-3
42
CONN 24
L-2
20
CONN 25
K-2
20
CONN 26
G-2
43
CONN 47
B-7
44
CONN 48
B-7
Symbols and Definitions

Fuse: A component in an electrical circuit that will open the circuit if too much current flows
through it.
41
9
38
39
Switch (Normally Open): A switch that will close at a specified point (temp, press, etc.). The
circle indicates that the component has screw terminals and a wire can be disconnected from it.
32
22
42
43
27
29
Ground (Wired): This indicates that the component is connected to a grounded wire. The
grounded wire is fastened to the machine.
37
30
1
31
16
19
13
11
15
25
Ground (Case): This indicates that the component does not have a wire connected to ground.
It is grounded by being fastened to the machine.
23
17
44
Reed Switch: A switch whose contacts are controlled by a magnet. A magnet closes the
contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.
20
Sender: A component that is used with a temperature or pressure gauge. The sender
measures the temperature or pressure. Its resistance changes to give an indication to
the gauge of the temperature or pressure.
34
26
35
Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.).
No circle indicates that the wire cannot be disconnected from the component.
28
12
24
33
40
Relay (Magnetic Switch): A relay is an electrical component that is activated by electricity.

It has a coil that makes an electromagnet when current flows through it. The
electromagnet can open or close the switch part of the relay.
14
36
5
Solenoid: A solenoid is an electrical component that is activated by electricity. It has a
coil that makes an electromagnet when current flows through it. The electromagnet
can open or close a valve or move a piece of metal that can do work.
21
10
The connectors shown in this chart are for harness to harness connectors.
Connectors that join a harness to a component are generally located at or near
the component. See the Component Location Chart.
Magnetic Latch Solenoid: A magnetic latch solenoid is an electrical component that is

activated by electricity and held latched by a permanent magnet. It has two coils (latch and unlatch)
that make electromagnet when current flows through them. It also has an internal switch that places
the latch coil circuit open at the time the coil latches.
18
Harness and Wire Symbols

Wire,
Cable,
or
Harness
Assembly Identification: Includes
Harness Identification Letters and
Harness Connector Serialization
Codes (see sample).
Harness Identification Letter(s):

(A, B, C, ..., AA, AB, AC, ...)
L-C12
3E-5179
AG-C4
111-7898
Machine Harness Connector and Component Locations
L-C12
3E-5179
Harness Connector Serialization Code:

The "C" stands for "Connector" and the
number indicates which connector in the
harness (C1, C2, C3, ...).
Part Number: for Connector Plug
Part Number: for Connector Receptacle
2
Plug
Receptacle
Pin or Socket Number
1
2
Deutsch connector: Typical representation

of a Deutsch connector. The plug contains all
sockets and the receptacle contains all pins.
1
2
Sure-Seal connector: Typical representation

of a Sure-Seal connector. The plug and receptacle
contain both pins and sockets.
5A
9X-1123
Fuse (5 Amps)
Component
Part Number
325-AG135 PK-14
Component Identifiers (CID)

Module Identifier (MID)
Engine Control System
(MID No. 036)
CID
0001
0002
0003
0004
0005
0006
0041
0042
0091
0094
0100
0110
0164
0168
0172
0190
0253
0261
0262
0267
0268
0269
0274
0275
0283
0291
0296
0342
0596
1639
1785
Component
Fuel Injector Solenoid #1
ECM 8V DC Supply
Injector Actuation Valve
Throttle Sensor
Fuel Pressure Sensor
Oil Pressure Sensor
Engine Coolant Temperature Sensor
Injector Actuation Pressure Sensor
Electrical Power Supply
Intake Manifold Air Temperature Sensor
Engine Speed Sensor
Personality Module
Engine Speed Sensor
5 Volt Sensor Supply
Engine Shutdown Switch
Check Programmable Parameters
Sensor Power Supply
Atmospheric Pressure Sensor
Right Turbo Inlet Pressure Sensor
Filter Restrict Lamp
Engine Cooling Fan Solenoid
Transmission ECM
Camshaft Position Sensor
Implement Control
Machine Security System
Intake Manifold Pressure Sensor
The CID is a diagnostic code that indicates which circuit is faulty.

The MID is a diagnostic code that indicates which electronic control module
diagnosed the fault.
Event Codes
Engine Control
Failure Mode Identifiers (FMI)

FMI No.
Failure Description
Data valid but above normal operational range.
Data valid but below normal operational range.
Data erratic, intermittent, or incorrect.
Voltage above normal or shorted high.
Voltage below normal or shorted low.
5
6
Event Code
Condition
Resistor, Sender and Solenoid Specifications

Part No.
Component Description
134-2540
Resistor:
CAN Data Link
120
145-7028
Sender:
T/C Temperature
1250
148-2350
Solenoid:
Variable Speed Fan
5.0 0.3
163-0872
Solenoid:
A/C Compressor Clutch
17.60.6
183-7595
Solenoid:
Axle Cooler Clutch
5.0 0.3
E096
High Fuel Pressure
E172
High Air Filter Restriction
E194
High Exhaust Temperature
Current below normal or open circuit.
E198
Low Fuel Pressure
225-0300
Solenoid:
Pilot Hydraulic Supply
Current above normal or grounded circuit.
E360
Low Engine Oil Pressure
241-5895
Solenoid
Auto/Reverse Fan
Mechanical system not responding properly.
E361
High Engine Coolant Temperature
245-4659
Sender
Abnormal frequency, pulse width, or period.
E362
Engine Overspeed
244-3114
Solenoid:
E390
Fuel Filter Restriction
239-1134
Solenoid:
E441
Idle Elevated to Increase Battery Voltage
E539
High Intake Manifold Air Temperature
Abnormal update.
10
Abnormal rate of change.
11
Failure mode not identifiable.
12
Bad device or component.
13
Out of calibration.
14
Parameter failures.
15
Parameter failures.
16
Parameter not available.
17
Module not responding.
18
Sensor supply fault.
19
Condition not met.
20
Parameter failures.
The FMI is a diagnostic code that indicates what type of failure has occurred.
Off Machine Switch Specification

Resistance (Ohms)
Fuel Level
Transmission Clutch
Start Aid
Dump Anti-Drift
262-5265
Solenoid:
Lower Anti-Drift
Ride Control 3
Aux 3rd Function Forward
Aux 3rd Function Rearward
Dump Prop
285-5730
Solenoid:
Racback Prop
Raise Prop
At room temperature unless otherwise noted.
38.12 1.9
35 0.5
Empty: 240 - 250
Full: 28 - 33
8.7 0.4
20.0
33.8
5.0 0.3
Part No.
Function
Actuate
Related Electrical Service Manuals

Deactuate
Contact Position
275 to 1750 kPa

Normally Open
(39.9 to 253.8 psi)
138 28 kPa
89 20 kPa
Normally Closed
117-7773
Hydraulic Filter Bypass Pressure
(20 4 psi)
(12.9 2.9 psi)
A-B, Normally Open
8270 kPa MAX
6890 345 kPa
174-4312
Park Brake Pressure
A-C, Normally Closed
(1200 psi MAX)
(1000 50 psi)
A-B, Normally Open
10700 kPa MAX
8960 537 kPa
175-3244
Brake Oil Pressure
A-C, Normally Closed
(1550 psi MAX)
(1300 79 psi)
Primary Steering Presure
1200 kPa MAX
700 100 kPa
A-B Normally Open
230-5771
Secondary Steering Pressure
(174.0 psi MAX)
(102 14.5 psi)
A-C Normally Closed
110.3 13.8 kPa
69 kPa MIN
Normally Closed
258-0883
Fuel Differential Pressure
(16 2 psi)
(10 psi MIN)
With increasing pressure the closed condition can be maintained up to 2800 kpa (405 psi), with decreasing pressure the closed condition can be maintained
down to 170 kpa (25psi).
Contact postion at the contacts of the harness connector.
114-5333
A/C (High / Low) Pressure
Harness identification code:

This example indicates wire group 325,
wire 135 in harness "AG".
Title
Form Number
Cross Reference for Electrical Connectors:
REHS0970
Alternator: 177-9953
SENR4130
197-8820
Electric Starting Motor: 207-1517
Engine Control:
SENR3581
RENR9319
Wire Gauge
Wire Color
(Dimensions: 48 inches x 35 inches)
Wire
Color
36 Page,
Wire Description
Wire
Number
RENR8882-02 VOL 1 of 2
RENR8882-02
September 2009
16
15
14
13
12
11
10
NORTH AND SOUTH AMERICAN FRONT FRAME

BELLY GUARD ACTUATOR
AH-C2
2Q-4181
1552269
1
838-AH7 YL-16
2
MOTOR
839-AH6 BU-18
101-AJ4 RD-14
15A
839-AH2
141-AH1
838-AH4
838-AH5
200-AH8
839-AH3
141-AH1 RD-14
1
2
3
4
5
6
3
4
ACTUATOR SW
157-1364
200-AH8 BK-16
BELLY GUARD BREAKER

3T-2662
200-AH8 BK-16
WHEN USED CONNECTS TO RUNNING LAMP BREAKER

WHEN USED CONNECTS TO HOOD ACTUATOR BREAKER
WHEN USED CONNECTS TO UNSWITCHED BUSS BREAKER
101-AJ3 RD-14
101-AJ1 RD-14
101-AJ2 RD-12
101-AJ2
101-AJ1
101-AJ3
101-AJ4
AH-C1
1552273
BU-18
RD-14
YL-16
YL-16
BK-16
BU-18
RD-12
RD-14
RD-14
RD-14
POS
CBL-WW1 RD-00
WHEN USED CONNECTS TO ALTERNATOR BREAKER
200-AH8 BK-16
CBL-EE1 RD-00
NEG
POS
12V BATTERY 1
115-2422
BLOCK AS
8C-6358
WASTE GUARD
CBL-GG1 BK-00
NEG
CBL-HH1 BK-00
101-CJ106 RD-4
A
B
C
AG-C11
1552267
106-AG6 WH-18
C216-AG17 BK-18
H718-AG45 GY-18
A
B
C
LH GROUND
2 1
ROTARY LIFT POS SENSOR

169-0417
OR-18
BK-18
WH-18
AG-C18
3E3370
AM-C1
3E3370
+24V
GROUND
SIGNAL
AM-C2
1552267
146-AM2 GY-18
C214-AM7 BK-18
H718-AM8 GY-18
A
B
C
CONN 23
AG-C7
3E3370
A
138-AG4 GN-18
B
C216-AG15 BK-18
C
C529-AG23 GY-18
OR-18
YL-18
GN-18
POWER
GROUND
SIGNAL
ROTARY TILT POSITION SENSOR

169-0417
OR-18
BK-18
WH-18
+V
GROUND
SIGNAL
AG-C39
1552267
A
B
C
AG-C13
3E3364
G485-AG24 BU-18
201-AG44 BK-18
A
B
C
AK-C7
1552267
779-AK23 WH-16
200-AK22 BK-16
HA-C1
1552269
HA-C2
1552269
CBL-CC1 RD-00
MTR BAT
MOTOR
175-CJ95 RD-14
20A
HOOD ACTUATOR BREAKER

6T-3644
101-AF2 RD-12
H704-CJ160 PK-18
103-CJ79 RD-4
X918-CJ116 PU-18
X919-CJ118 WH-18
E748-CJ161 BK-18
102-CJ48 RD-14
112-CJ1 PU-4
174-CJ4 RD-10
199-CJ127 RD-16
306-CJ51 GN-18
308-CJ52 YL-18
H795-CJ117 PK-18
P990-CJ75 BR-18
174-CJ4 RD-10
20A
UNSWITCHED BUSS BREAKER (CAB)

6T-3644
H704-CJ160 PK-18
200-CJ89 BK-14
397-CJ104 OR-14
398-CJ103 BU-14
A300-CJ128 GN-16
A301-CJ126 WH-16
175-CJ95 RD-14
CJ-C3
3E3364
LH STOP TAIL TURN LAMP
145-6929
CONN 4
S
T
RD-18
BK-18
WH-18
TURN
A
B
C
1
2
CJ-C32
1552269
605-CJ67 YL-18
200-CJ54 BK-18
CJ-C31
3E3364
YL-18
WH-18
308-CJ52 YL-18
200-CJ88 BK-18
MAIN BREAKER MAIN RELAY

171-2210
241-8368
CJ-C6
1552269
306-CJ42 GN-18
200-CJ36 BK-18
ARC SUPPRESSOR START RLY
189-3158
CONN 3
BUSS BAR
246-4488
BK-18
BK-18
BUSS BAR
275-9916
LH HOOD TURN SIGNAL
1
2
CJ-C2
1552269
306-CJ71 GN-18
P990-CJ75 BR-18
A
B
C
CE-C1
CE-C4
1552267
3E3370
A
604-CE1 OR-16
B
200-CE2 BK-16
C
617-CE3 BR-16
304-CJ96 WH-8
MATING CONNECTOR
2 PIN CONNECTOR OF 145-6929
1
2
CE-C2
CE-C3
1552269
3E3364
605-CE4 YL-16
200-CE5 BK-16
CJ-C29
3E3364
1
2
LICENSE PLATE LIGHT CONNECTOR
AIH BREAKER
171-2211
CONN 3
MATING CONNECTOR
CJ-C32
1
2
199-CJ127 RD-16
H795-CJ117 PK-18
X918-CJ116 PU-18
X919-CJ118 WH-18
103-CJ79 RD-4
90
101-AF2 RD-12
101-AF4 RD-14
101-AF3 RD-14
FUEL LEVEL SENDER
245-4659
PK-18
BK-18
1
2
CJ-C14
1552269
447-CJ145 PK-18
201-CJ83 BK-18
105A
HOOD ACTUATOR SW
146-0240
BK-18
RD-18
WH-18
A4 E4
262-2879
H704-CJ160 PK-18
E748-CJ161 BK-18
397-CJ104 OR-14
398-CJ103 BU-14
AIH RELAY
CJ-C17
1297164
1
397-CJ104 OR-14
CJ-C20
1297163
398-CJ103 BU-14
RD
IAP CONTROL VALVE
HOOD ACTUATOR MOTOR

262-4914
COOLANT TEMP SNSR
MOTOR
BOOST PRESSURE SNSR
BK
PRESSURE SNSR RETURN

IAP CONTROL VALVE
CX-C2
1539693
A701-CX601 GY-16
L983-CX102 WH-16
CRANKSHAFT SPEED TIMING SNSR +

TDC PROBE +
OIL PRESSURE SNSR
COOLANT TEMP SNSR -
CX-C3
1539693
A702-CX602 PU-16
L983-CX202 WH-16
CRANKSHAFT SPEED TIMING SNSR TDC PROBE -
CX-C4
1539693
A703-CX603 BR-16
L984-CX302 OR-16
A701-CX601
A702-CX602
A703-CX603
A704-CX604
A705-CX605
A706-CX606
L985-CX702
L985-CX502
L984-CX402
L984-CX302
L983-CX202
L983-CX102
CYL HEAD 5
268-1835
CX-C6
1539693
A705-CX605 BU-16
L985-CX502 YL-16
F
CYL HEAD 6
268-1835
CX-C1 K-C9
1552252 3E5179
1
T957-K16 PU-18
GY-16
2
T958-K17 YL-18
PU-16
3
T959-K18 BR-18
BR-16
4
T960-K19 BU-18
GN-16
5
T961-K28 GN-18
BU-16
6
T962-K29 WH-18
GY-16
7
YL-16
T860-K90 OR-18
8
YL-16
T860-K89 OR-18
9
OR-16
T859-K88 WH-18
10
OR-16
T859-K87 WH-18
11
T858-K86 GY-18
WH-16
12
WH-16
T858-K85 GY-18
FUEL PRESSURE SNSR
CAMSHAFT SPEED TIMING SNSR CAMSHAFT SPEED TIMING SNSR +
PRESSURE SENSOR RETURN
CONN 7
INTAKE MANIFOLD AIR TEMP SNSR +

ATM PRESSURE SNSR
CX-C7
1539693
A706-CX606 GY-16
L985-CX702 YL-16
T957-K16 PU-18
T958-K17 YL-18
T959-K18 BR-18
T960-K19 BU-18
T961-K28 GN-18
T962-K29 WH-18
T859-K88 WH-18
T858-K86 GY-18
T860-K90 OR-18
T858-K85 GY-18
T859-K87 WH-18
T860-K89 OR-18
ENGINE INJECTOR HARNESS
IAP CONT
VALVE
1
2
RAIL PRESSURE SNSR

236-6220
K-C6
1552269
1
2
SIGNAL
GROUND
COOLANT TEMP SENSOR

197-8392
995-K12 BU-18
G833-K44 PK-18
K-C7
1552269
C967-K15 BU-18
G833-K45 PK-18
INTAKE MAN AIR TEMP SNSR
197-8391
SIGNAL
GROUND
RH STOP TAIL TURN LAMP

145-6929
RH STOP TAIL LED
135-0426
S
T
RD-18
BK-18
BU-18
S
T
TURN
RD-18
BK-18
WH-18
A
B
C
CJ-C8
1552267
604-CJ115 OR-18
200-CJ113 BK-18
614-CJ86 PU-18
1
2
CJ-C26
1552269
606-CJ68 GY-18
200-CJ112 BK-18
CJ-C27
3E3364
YL-18
WH-18
+V
GROUND
SIGNAL
FUEL PRESSURE SW
258-0883
BK-18
BK-18
FUEL PRESSURE SNSR

194-6725
RH HOOD TURN SIGNAL
MATING CONNECTOR
MATING CONNECTOR
A
B
C
1
2
CF-C2
CF-C3
1552269
3E3364
606-CF4 GY-16
200-CF5 BK-16
BACKUP ALARM
123-6449
CJ-C38
3E3364
BK-18
BK-18
AUTO REV FAN SOL

241-5895
1
2
1
2
CJ-C43
3E3364
1
2
A
B
C
OIL PRESSURE SENSOR

197-8394
CONN 1
CF-C4
CF-C1
3E3370
1552267
A
604-CF1 OR-16
B
200-CF2 BK-16
C
614-CF3 PU-16
1
2
K-C15
1698670
CONN 2
+5V
GROUND
SIGNAL
CONN 2
OR-18
YL-18
GN-18
1
2
X-C2
1552269
X-C1
3E3370
A
B
C
X-C3
3E3388
T725-X1
N707-X2
G828-X3
G829-X4
C991-X5
WH-18
PU-18
PU-18
YL-18
PK-18
1
2
3
4
5
6
7
8
K-C16
1552264
G826-K38 BR-18
G827-K43 BU-18
994-K10 GY-18
FUEL PRESSURE SWITCH
SENSOR +V SUPPLY
AIH RELAY RETURN

SENSOR +V SUPPLY
FUEL PRESSURE SWITCH
RAIL PRESSURE SNSR
INJECTOR 5 &6 RETURN

INJECTOR 6
INJECTOR 3
INJECTOR 5
INJECTOR 4

INJECTOR 1
INJECTOR 2
J2
J1
ANALOG SENSOR POWER
ANALOG SENSOR RETURN
THROTTLE SENSOR POWER
DIGITAL SENSOR/SWITCH RETURN
A751-K13
G833-K46
T725-K32
N707-K31
G826-K35
G827-K36
C991-K33
YL-18
PK-18
WH-18
PU-18
BR-18
BU-18
PK-18
CAT DATA LINK +

CAT DATA LINK REV FAN SOL
PRELUBE/EVAC RELAY
TURBO INLET PRESSURE SENSOR SIG
CONN 6
MATING CONNECTOR
CJ-C8
FUEL JUMPER
K-C3
1552269
G854-K100 PK-18
G855-K91 PU-18
K-C11
1698670
+V
A
G828-K40 WH-18
B
G829-K42 GN-18
GROUND
SIGNAL
C
R747-K6 GY-18
ATMOSPHERIC PRESSURE SENSOR
197-8393
K-C12
1698670
+V
A
G828-K39 WH-18
B
G829-K41 GN-18
GROUND
SIGNAL
C
R746-K20 PK-18
BOOST PRESSURE SNSR
210-1747
K-C13
3E3370
OR-18
A
+V
G828-K95 WH-18
YL-18
B
GROUND
G829-K94 GN-18
GN-18
C
SIGNAL
G849-K96 BR-18
STOP/TAIL
RELAY RTN
CONN 5
CONN 1
MATING CONNECTOR
CJ-C26
TIMING CAL
PROBE
K-C14
3E3364
K-C10
1552269
1
G856-K22 WH-18
2
G857-K30 YL-18
SPEED SENSOR GROUP

236-6221
CJ-C30
1552269
321-CJ55 BR-18
P990-CJ74 BR-18
CV-C6
1552267
202-CV13 BK-18
453-CV14 PK-18
416-CV15 OR-18
A
B
C
PRIM STR PRES SW

230-5771
BK-16
RD-16
BU-16
SEC STR PRES SW

230-5771
BK-16
RD-16
BU-16
J813-CJ80 BK-14
A958-CJ164 GY-18
E919-CJ31 YL-18
E920-CJ32 BR-18
964-CJ148 BU-18
E921-CJ33 PK-18
E922-CJ34 GN-18
J815-CJ45 BK-14
976-CJ27 OR-18
INPUT SPEED SENSOR

193-2550
BK-18
WH-18
AT-C2
1552269
J808-AT25 BK-18
754-AT8 BU-18
J809-AT21 BK-18
752-AT4 YL-18
J808-AT24 BK-18
751-AT3 GN-18
755-AT12 OR-18
J807-AT22 BK-18
900-AT13 PU-18
J807-AT23 BK-18
901-AT14 WH-18
J807-AT26 BK-18
J807-AT26 BK-18
J807-AT23 BK-18
J807-AT22 BK-18
A
C
B
1
2
3
4
CJ-C25
1552267
A301-CJ126 WH-16
A300-CJ128 GN-16
199-CJ127 RD-16
K977-AT16 PK-18
J764-AT1 BR-18
442-CJ9 GY-18
201-CJ26 BK-18
E908-AT7 BR-18
E909-AT11 WH-18
AT-C13
1552269
AT-C8
1552269
CLUTCH 6 1ST
244-3114
OUTPUT SPEED SNSR (LEADING)

193-2550
BK-18
1
E901-AT9 GN-18
WH-18
2
E900-AT5 WH-18
AT-C1
1552269
CJ-C42
1552269
H704-CJ160 PK-18
E748-CJ161 BK-18
SIGNAL
GROUND
1
2
K-C4
1003320
E963-K27 BK-18
E964-K26 WH-18
SIGNAL
GROUND
1
2
K-C5
1112416
E965-K48 BU-18
E966-K49 YL-18
START AID SOLENOID

GROUND LEVEL SHUTDOWN(N/C)
TRANSMISSION LUBE OIL SENSOR
PRELUBE INDICATOR
AIR FILTER RESTRICTED INDICATOR
START AID INDICATOR
CAN DATA LINK -
ENGINE SPEED SIGNAL TO XMSN CONTROL

GROUND LEVEL SHUTDOWN(N/O)
DEMAND FAN SOL +
AUTO REV FAN (NO)
AUTO REV FAN (NC)
+ BATTERY
CAN DATA LINK +
DEMAND FAN SOL + BATTERY
+ BATTERY
EVAC ENABLED
EVAC ON
- BATTERY
- BATTERY
- BATTERY
THROTTLE PEDAL POSITION
KEY SWITCH ON (B+)
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
81
82
83
84
85
86
87
88
89
90
91
92
93
94
95
96
97
98
99
100
101
102
103
104
105
106
107
108
109
110
111
112
113
114
115
116
117
118
119
120
136-CJ124 GN-18
136-CJ53 GN-18
TRANSMISSION
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
ALT
BRAKE OIL PRESS SW CH-C9

1552267
175-3244
A
BK-16
201-CH11 BK-18
RD-16
B
432-CH15 PK-18
BU-16
C
SHOWN WITH
BRAKE OFF
C987-K99 RD-18
G855-K91 PU-18
VARIABLE SPEED FAN SOL

148-2350
995-K12 BU-18
R746-K20 PK-18
G829-K93 GN-18
CH-C15
3E3370
G854-K100 PK-18
OR-18
YL-18
GN-18
+5V
GROUND
SIGNAL
TURBO INLET PRESSURE SENSOR

194-6722
E963-K27 BK-18
G856-K22 WH-18
994-K10 GY-18
AXLE COOLER CLUTCH

183-7595
G833-K47 PK-18
A
B
C
CH-C14
1552269
H746-CH37 YL-18
H747-CH35 BR-18
J844-CH39 GY-18
J843-CH42 BK-18
F713-CH43 OR-18
CH-C11
3E3364
1
2
CH-C10
1552269
P739-CH44 BU-16
200-CH45 BK-16
G850-CH63
H795-CH49
Y794-CH50
Y795-CH51
106-CH40 RD-4
K-C2
1552269
1
C987-K99 RD-18
2
G850-K98 BU-18
E964-K26 WH-18
G857-K30 YL-18
133-EC1 OR-2
AIH
288-3742
AIH RELAY
209-5582
E966-K49 YL-18
E965-K48 BU-18
G827-K2 BU-18
T858-K23 GY-18
T858-K85 GY-18
T858-K86 GY-18
T859-K37 WH-18
T859-K87 WH-18
T859-K88 WH-18
T860-K90 OR-18
T860-K89 OR-18
T860-K34 OR-18
G833-K47 PK-18
C967-K15 BU-18
R747-K6 GY-18
G828-K92 WH-18
A751-K13 YL-18
G829-K93 GN-18
T725-K32 WH-18
G827-K2 BU-18
N707-K31 PU-18
G849-K96 BR-18
150-CJ85 OR-18
200-CJ87 BK-18
201-CJ11 BK-18
E748-CJ161 BK-18
326-CJ44 PU-18
403-CJ50 GN-18
430-CJ59 BU-18
443-CJ90 YL-18
450-CJ93 YL-18
521-CJ94 YL-18
522-CJ97 WH-18
944-CJ98 OR-18
945-CJ100 BR-18
A307-CJ101 GY-18
A982-CJ111 BR-18
G850-CJ108
H795-CJ143
Y794-CJ129
Y795-CJ130
150-CJ85 OR-18
110-CJ99 RD-14
110-CJ163 RD-14
201-CJ82 BK-18
201-CJ11 BK-18
326-CJ44 PU-18
403-CJ50 GN-18
430-CJ59 BU-18
432-CJ8 PK-18
443-CJ90 YL-18
450-CJ93 YL-18
521-CJ94 YL-18
BU-18
PK-18
OR-18
GN-18
Y794-CJ129
Y795-CJ130
P793-CJ158
H703-CJ122
H702-CJ123
CH-C4
1275483
106-CH40 RD-4
G833-K44 PK-18
G833-K46 PK-18
G833-K45 PK-18
G828-K40 WH-18
G828-K39 WH-18
G828-K95 WH-18
G829-K42 GN-18
G829-K94 GN-18
G829-K41 GN-18
CH-C5
1552269
443-CH2 YL-18
201-CH23 BK-18
CH-C6
1552267
Y794-CH52 OR-18
Y795-CH53 GN-18
CH-C16
1552269
F762-CH60 GY-18
E748-CH62 BK-18
1
2
OR-18
GN-18
BU-18
YL-18
PU-18
484-CJ16
416-CJ17
417-CJ43
453-CJ18
727-CJ40
728-CJ39
CJ-C34
1275484
103-CJ79 RD-4
YL-18
OR-18
GY-18
PK-18
GN-18
BU-18
A
B
C
1
2
WH-18
PU-18
484-CJ16 YL-18
987-CJ119 WH-18
H718-CJ19 GY-18
611-CJ2 PU-14
106-CJ20 WH-18
114-CJ21 RD-18
138-CJ22 GN-18
A958-CJ164 GY-18
C216-CJ24 BK-18
322-CJ25 GY-18
J815-CJ45 BK-14
976-CJ27 OR-18
C529-CJ28 GY-18
C530-CJ29 BU-18
K927-CJ62 BU-18
E919-CJ31 YL-18
E920-CJ32 BR-18
E921-CJ33 PK-18
E922-CJ34 GN-18
G485-CJ35 BU-18
G486-CJ23 GN-18
H713-CJ37 PK-18
H714-CJ38 OR-18
P793-CJ158 BU-18
727-CJ40 GN-18
453-CJ18 PK-18
201-CJ41 BK-18
417-CJ43 GY-18
447-CJ145 PK-18
J813-CJ80 BK-14
H717-CJ46 BR-18
N939-CJ47 GN-18
416-CJ17 OR-18
102-CJ48 RD-14
Y794-CJ129 OR-18
Y795-CJ130 GN-18
306-CJ51 GN-18
J814-CJ77 BK-14
P976-CJ10 BR-18
614-CJ60 PU-18
136-CJ125 GN-18
321-CJ55 BR-18
604-CJ56 OR-18
605-CJ57 YL-18
606-CJ58 GY-18
147-CJ151 RD-18
614-CJ60 PU-18
617-CJ61 BR-18
619-CJ3 GN-14
199-CJ127 RD-16
P945-CJ131 OR-18
439-CJ153 YL-18
426-CJ63 BR-18
P946-CJ132 BR-18
CJ-C21
1835784
964-CJ148 BU-18
762-CJ162 YL-18
H795-CJ144 PK-18
H795-CJ117 PK-18
H795-CJ143 PK-18
J813-CJ80 BK-14
J814-CJ77 BK-14
J815-CJ45 BK-14
K927-CJ62 BU-18
N939-CJ47 GN-18
326-CJ44 PU-18
430-CJ59
443-CJ90
450-CJ93
521-CJ94
522-CJ97
P793-CJ158 BU-18
P945-CJ131 OR-18
P946-CJ132 BR-18
110-CJ99 RD-14
110-CJ163 RD-14
150-CJ85 OR-18
201-CJ11 BK-18
201-CJ82 BK-18
326-CJ44 PU-18
403-CJ50 GN-18
430-CJ59 BU-18
432-CJ8 PK-18
443-CJ90 YL-18
450-CJ93 YL-18
521-CJ94 YL-18
522-CJ97 WH-18
ET-C2
1552269
F762-ET1 GY-18
E748-ET2 BK-18
506-CJ12 PU-18
507-CJ13 WH-18
E455-CJ14 BR-18
G764-CJ15 PK-18
762-CJ162 YL-18
944-CJ98 OR-18
945-CJ100 BR-18
964-CJ148 BU-18
976-CJ27 OR-18
987-CJ119 WH-18
A307-CJ101 GY-18
A958-CJ164 GY-18
A982-CJ111 BR-18
C216-CJ24 BK-18
C529-CJ28 GY-18
C530-CJ29 BU-18
E919-CJ31 YL-18
E920-CJ32 BR-18
E921-CJ33 PK-18
E922-CJ34 GN-18
E455-CJ14 BR-18
G485-CJ35 BU-18
G486-CJ23 GN-18
G764-CJ15 PK-18
G850-CJ108 BU-18
H702-CJ123 PU-18
H703-CJ122 YL-18
H713-CJ37 PK-18
H714-CJ38 OR-18
H717-CJ46 BR-18
H718-CJ19 GY-18
102-CJ48 RD-14
112-CJ1 PU-4
174-CJ4 RD-10
199-CJ127 RD-16
201-CJ83 BK-18
306-CJ51 GN-18
308-CJ52 YL-18
321-CJ55 BR-18
447-CJ145 PK-18
604-CJ56 OR-18
605-CJ67 YL-18
606-CJ68 GY-18
614-CJ81 PU-18
614-CJ86 PU-18
617-CJ73 BR-18
P990-CJ75 BR-18
P990-CJ74 BR-18
H795-CJ117 PK-18
SIGNAL
GROUND
1
2
432-CJ8 PK-18
442-CJ9 GY-18
606-CJ58 GY-18
606-CJ68 GY-18
606-CJ69 GY-18
200-CJ141 BK-18
229-CJ155 BK-14
200-CJ87 BK-18
TORQ CONV TEMP SENDER

145-7028
CH-C17 ET-C1
3E3364 3E3364
CJ-C4
1607689
728-CJ39 BU-18
P990-CJ102 BR-18
202-CJ6 BK-18
308-CJ52 YL-18
419-CJ7 YL-18
605-CJ57 YL-18
605-CJ67 YL-18
605-CJ66 YL-18
136-CJ53 GN-18
202-CJ30 BK-18
202-CJ65 BK-18
DC CAN RESISTOR 1
134-2540
1
2
SIGNAL
GROUND
619-AG27 GN-14
A307-CJ101 GY-18
P976-CJ10 BR-18
G850-CJ108 BU-18
A982-CJ111 BR-18
P990-CJ102 BR-18
P990-CJ74 BR-18
P990-CJ75 BR-18
Y794-CJ129 OR-18
H795-CJ144 PK-18
Y795-CJ130 GN-18
403-CJ50 GN-18
944-CJ98 OR-18
945-CJ100 BR-18
944-CJ98 OR-18
945-CJ100 BR-18
A307-CJ101 GY-18
A982-CJ111 BR-18
G850-CJ108 BU-18
H702-CJ123 PU-18
H703-CJ122 YL-18
H795-CJ143 PK-18
P793-CJ158 BU-18
Y794-CJ129 OR-18
Y795-CJ130 GN-18
START AID SOL

239-1134
CONN 10
BU-18
YL-18
YL-18
YL-18
WH-18
H703-CJ122 YL-18
H702-CJ123 PU-18
150-CJ85 OR-18
C216-AG15 BK-18
C216-AG18 BK-18
C216-AG17 BK-18
J813-AG32 BK-14
A958-AG70 WH-18
E919-AG35 YL-18
E920-AG36 BR-18
C529-AG23
E919-AG35
E920-AG36
E921-AG37
E922-AG38
H717-AG53
H713-AG30
H714-AG31
J814-AG61
J814-AG49
J814-AG50
J814-AG60
GY-18
YL-18
BR-18
PK-18
GN-18
BR-18
PK-18
OR-18
BK-18
BK-18
BK-18
BK-18
150-CH6 OR-18
H704-CH59 PK-18
H747-CH35 BR-18
H746-CH37 YL-18
F713-CH43 OR-18
J844-CH39 GY-18
J843-CH42 BK-18
AG-C36
1552269
987-AG67 WH-16
200-AG68 BK-16
J813-AG43 WH-18
J813-AG59 WH-18
J813-AG58 WH-18
J813-AG57 WH-18
CONNECTS TO C-C26
ON THE CAB SCHEMATIC
T958-K17 YL-18
CH-C2
1607689
J844-CH39 GY-18
J843-CH42 BK-18
A982-CH10 BR-18
H795-CH49 PK-18
106-CH40 RD-4
F713-CH43 OR-18
200-CH45 BK-16
J843-CH42 BK-18
J844-CH39 GY-18
P739-CH44 BU-16
Y795-CH53 GN-18
Y794-CH52 OR-18
201-CH23 BK-18
443-CH2 YL-18
F762-CH60 GY-18
E748-CH62 BK-18
106-CH40 RD-4
443-CH2 YL-18
200-CH22 BK-16
201-CH11 BK-18
201-CH23 BK-18
326-CH1 RD-16
403-CH58 GN-18
432-CH15 PK-18
521-CH4 YL-14
522-CH5 WH-14
200-CH45 BK-16
P739-CH44 BU-16
944-CH7 OR-18
945-CH8 BR-18
H704-CH59 PK-18
F713-CH43 OR-18
E748-CH61 BK-18
F762-CH60 GY-18
X919-CH19 WH-18
430-CH13 BU-18
G850-CH63 BU-18
Y795-CH29 GN-18
Y794-CH28 OR-18
Y795-CH29 GN-18
110-CH33 RD-14
110-CH34 RD-14
110-CH36 RD-14
450-CH17 YL-18
X918-CH18 PU-18
H746-CH37 YL-18
229-CH16 BK-14
136-CJ124
200-CJ152
439-CJ153
147-CJ151
150-CH6 OR-18
430-CH13 BU-18
450-CH17 YL-18
944-CH7 OR-18
945-CH8 BR-18
A307-CH9 GY-18
A982-CH10 BR-18
E748-CH48 BK-18
E748-CH62 BK-18
F762-CH60 GY-18
200-CH22 BK-16
326-CH1 RD-16
AC CLUTCH SOL
163-0872
1
2
CH-C3
1552269
513-CH20 OR-14
521-CH4 YL-14
1
2
CH-C7
1552269
513-CH21 OR-14
522-CH27 WH-14
CH-C18
3E3364
GN-18
GN-18
1
2
GN-18
BK-18
YL-18
RD-18
201-CJ120 BK-18
G486-CJ23 GN-18
CJ-C18
1552272
CJ-C19
3E3376
1
2
3
4
1
2
3
4
AW-C2
3E3376
136-AW5 GN-18
200-AW1 BK-18
439-AW4 YL-18
1
2
200-CJ92 BK-14
200-CJ91 BK-14
200-CJ156 BK-14
200-CJ157 BK-14
AG-C20
1552269
A958-AG70 WH-18
J815-AG69 BK-18
1
2
CH-C12
1552269
A693-CH14 OR-16
200-CH22 BK-16
CONN 18
RD-18
BK-18
WH-18
CJ-C40
1552269
G486-CJ23 GN-18
201-CJ120 BK-18
1
2
CY-C1
CY-C2
3E3364
1552269
G486-CY1 GN-18
201-CY2 BK-18
CONN 9
B
C
A
17
16
15
14
LEFT FRONT FLOOD

219-6485
1
2
AJ-C2
1552269
LH TURN SIGNAL
3E-6466
RD-18
BK-18
FR-C2
1552269
GN-14
BK-14
GY-16
BK-16
RIGHT FRONT FLOOD

219-6485
1
2
FR-C3
1552269
1
2
RH TURN SIGNAL
3E-6466
RD-18
BK-18
1
2
3
4
5
6
7
8
9
10
11
12
RH HI LO POS TURN LAMP

105-4850
CM-C1
1552252
619-CM1 GN-14
200-CM2 BK-14
606-CM3 GY-16
CM-C2
1552273
611-CM4
619-CM1
614-CM5
606-CM3
200-CM2
611-CM4 PU-14
614-CM5 PU-16
PU-14
GN-14
PU-16
GY-16
BK-14
5
4
6
3
1
2
BU-18
RD-18
WH-18
YL-18
BK-18
AG-C22
3E3364
E920-AG36 BR-18
J814-AG60 BK-18
H714-AG31 OR-18
J813-AG57 WH-18
RIDE CONTROL SOL3

262-5265
AG-C31
1552269
1
2
RACKBACK PROP SOL

285-5730
1
2
DUMP PROP SOL

285-5730
AG-C32
1552269
AG-C34
1552269
1
2
AG-C30
1552269
1
2
AG-C33
3E3364
AG-C35
3E3364
AG-C16
1552269
AUX 3RD FUNCT FWD SOL

285-5730
AUX 3RD FUN REARWARD SOL

285-5730
1
2
LOWER SOL
285-5730
1
2
RAISE PROP SOL

285-5730
AG-C5
1552269
H
H717-AG53 BR-18
K927-AG54 BU-18
106-AP3 WH-18
619-AP46
200-AP39
605-AP15
200-AP40
611-AP56
617-AP54
606-AP48
106-AP67 WH-18
106-AP35 WH-18
200-AP37 BK-16
200-AP38 BK-14
200-AP34 BK-16
200-AP7 BK-14
200-AP8 BK-14
AG-C2
1552269
1
2
PILOT HYD SUPP SOL

225-0300
AP-C1
3E6286
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
CONN 19
CONNECTS TO C-C35
606-AP16 GY-16
611-AP50 PU-14
619-AP46 GN-14
619-AP45 GN-14
H717-AP21 BR-18
P946-AP59 BR-18
P945-AP58 OR-18
C530-AP14 BU-18
605-AP15 YL-16
606-AP16 GY-16
611-AP50 PU-14
987-AP52 WH-16
617-AP54 BR-16
614-AP53 PU-16
762-AP66 YL-18
P976-AP71 BR-16
964-AP68 BU-18
976-AP29 OR-18
987-AP52 WH-16
A958-AP73 WH-18
C216-AP10 BK-18
EA-C5
7T5957
506-EA8 PU-18
200-EA13 BK-18
1
2
C530-AP14 BU-18
E919-AP23 YL-18
E920-AP24 BR-18
E921-AP26 PK-18
E922-AP27 GN-18
H717-AP21 BR-18
G485-AP6 BU-18
J813-AP31 BK-18
A958-AP73 WH-18
E919-AP23 YL-18
E920-AP24 BR-18
964-AP68 BU-18
E921-AP26 PK-18
E922-AP27 GN-18
J815-AP20 BK-18
976-AP29 OR-18
EA-C6
7T5957
507-EA10 WH-18
200-EA14 BK-18
1
2
H713-AP18 PK-18
H714-AP19 OR-18
J813-AP31 BK-18
J813-AP41
J813-AP25
J813-AP42
J813-AP51
G485-AP6 BU-18
201-AP5 BK-18
BK-18
BK-18
BK-18
BK-18
J815-AP74 BK-18
J815-AP63 BK-18
J815-AP60 BK-18
J814-AP49
J814-AP62
J814-AP61
J814-AP36
BK-18
BK-18
BK-18
BK-18
BU-16
MOTOR
762-AR1 YL-18
964-AR3 BU-18
HYD FILT BYPASS

117-7773
XMSN FILTER BYPASS SW

164-7577
FRONT WASHER PUMP

223-3383
REAR WASHER PUMP

223-3383
AR-C2
3E3370
A
F766-AR5 WH-18
B
762-AR1 YL-18
C
200-AR7 BK-18
AR-C3
3E3370
A
F766-AR6 WH-18
B
964-AR3 BU-18
C
200-AR8 BK-18
BUCKET POS SW
176-5459
OR
BU
BK
+ BATTERY
SOLENOID
GROUND
FORK POS SW
176-5459
OR
BU
BK
+ BATTERY
SOLENOID
GROUND
CONN 21
AP-C46
1552267
WHEN IN USE
CONNECT TO
AK-C7
CONN 24
AP-C3
1552269
LH FORWARD HORN IT
174-7875
1
2
AP-C43
3E5179
1
2
3
4
5
6
7
8
9
10
11
12
CONN 22
WHEN IN USE
CONNECT TO AV-C1,
FR-C1, OR CM-C1
AP-C38
3E3364
1
2
AP-C13
3E3364
1
2
WHEN IN USE
CONNECT TO AW-C1,
AJ-C1, OR CL-C1
A
B
C
AP-C37
1552269
987-AP52 WH-16
200-AP34 BK-16
PARK BRAKE PRESS SW

174-4312
BK-16
SHOWN WITH
RD-16
BRAKE ON
MOTOR
YL-18
WH-18
BU-18
BK-18
200-AR7 BK-18
200-AR8 BK-18
AP-C45
3E3370
C216-AP30 BK-18
C216-AP69 BK-18
K927-AP57 BU-18
J814-AP13 BK-18
619-AP17 GN-14
H713-AP18 PK-18
H714-AP19 OR-18
J814-AP13 BK-18
BK-18
BK-18
F766-AR5 WH-18
F766-AR6 WH-18
200-AR4 BK-18
1
2
3
4
5
6
7
8
9
10
11
12
619-AP45 GN-14
200-AP38 BK-14
606-AP47 GY-16
200-AP37 BK-16
611-AP55 PU-14
614-AP53 PU-16
N939-AP4 GN-18
P945-AP58 OR-18
P946-AP59 BR-18
1
2
GN-14
BK-14
YL-16
BK-16
PU-14
BR-16
GY-16
114-AP1 RD-16
322-AP11 GY-16
617-AP54 BR-16
614-AP53 PU-16
J815-AP20 BK-18
BK-18
BK-18
F766-AR2 WH-18
AP-C41
3E5179
P976-AP71 BR-16
200-AP72 BK-16
611-AP55 PU-14
611-AP56 PU-14
619-AP17 GN-14
C216-AP10 BK-18
322-AP11 GY-16
762-AP66 YL-18
606-AP47 GY-16
606-AP48 GY-16
201-AP5 BK-18
1
2
+24V
GROUND
SIGNAL
AR-C1
1552272
762-AR1
F766-AR2
964-AR3
200-AR4
1
2
3
4
322-AP11 GY-16
605-AP15 YL-16
114-AP1 RD-16
P976-AP71 BR-16
106-AP3 WH-18
N939-AP4 GN-18
201-AP5 BK-18
G485-AP6 BU-18
200-AP7 BK-14
200-AP8 BK-14
CONN 20
A
B
C
LIFT POS SENSOR IT

169-0417
OR-18
BK-18
WH-18
A
B
C
AP-C8
3E3376
200-AP39 BK-14
200-AP40 BK-16
200-AP72 BK-16
136-AW6 GN-18
136-AW7 GN-18
200-AW1 BK-18
439-AW4 YL-18
124-AW3 GN-16
103-AW2 YL-16
200-CJ152 BK-18
200-CJ110 BK-18
200-CJ5 BK-18
200-CJ36 BK-18
200-CJ88 BK-18
200-CJ141 BK-18
200-CJ87 BK-18
200-CJ89 BK-14
200-CJ109 BK-18
200-CJ54 BK-18
200-CJ113 BK-18
200-CJ112 BK-18
1
2
3
4
5
6
7
8
AY-C1
AY-C2
146-4055
3E3388
1
136-AY6 GN-18
2
200-AY1 BK-18
3
136-AY7 GN-18
439-AY4 YL-18
124-AY3 GN-16
103-AY2 YL-16
GN
BK
GN
4
5
6
7
8
YL
GN
YL
200-CJ92 BK-14
200-CJ91 BK-14
200-CJ152 BK-18
200-CJ5 BK-18
AX-C2
AW-C3
AX-C1
155-2269 3E3364
146-4073
1
1 PRESSURE SW.
124-AW3 GN-16
124-AX1 GN-16
2
2 177-3519
103-AW2 YL-16
103-AX2 YL-16
CONN 47
200-CJ110 BK-18
200-CJ36 BK-18
200-CJ88 BK-18
ABBREV
COLOR
RD
WH
OR
YL
PK
BK
GY
PU
BR
GN
BU
RED
WHITE
ORANGE
YELLOW
PINK
BLACK
GRAY
PURPLE
BROWN
GREEN
BLUE
SYMBOL
DESCRIPTION
CIRCUIT CONNECTED
CIRCUIT NOT CONNECTED
ELECTRICAL CONNECTION TO
MACHINE STRUCTURE
INTERNAL ELECTRICAL CONNECTION
TO SURFACE OF COMPONENT
CONNECTOR
H#
CIRCUIT GROUPING DESIGNATION

ATCH WIRE, CABLE, COMPONENT
SPLICE
BLADE, SPADE, RING OR SCREW
TERMINAL
PUMP
AUTOLUBE GROENEVELD PUMP

184-0704
WIRE GROUP COLOR DESCRIPTIONS

GROUND CIRCUIT
GROENEVELD AUTOLUBE
WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS OFF
WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS ON
200-CJ89 BK-14
200-CJ54 BK-18
200-CJ113 BK-18
200-CJ112 BK-18
200-CJ109 BK-18
STARTING CIRCUIT
START AID CIRCUIT
TRANSMISSION CONTROL CIRCUIT
1
2
RH GROUND
SIGNAL
GROUND
HEATER AND AIR CONDITIONER CIRCUIT

200-CJ87 BK-18
200-CJ141 BK-18
229-CJ155 BK-14
FWD DIVERTER SOL
AP-C5
1552269 CONN 25
WHEN IN USE
CONNECT TO
HA-C1
AP-C7
1552269
N939-AP4 GN-18
J815-AP60 BK-18
1
2
AP-C35
3E3364
RIDE CONTROL SOL 2 IT

252-0737
AP-C2
1552269
A958-AP73 WH-18
J815-AP74 BK-18
1
2
AP-C4
3E3364
RIDE CONTROL SOL 3 IT

262-5265
AP-C11
1552269
976-AP29 OR-18
J815-AP63 BK-18
1
2
AP-C36
3E3364
RIDE CONTROL SOL 1

252-0737
AP-C27
1552269
E919-AP23 YL-18
J814-AP49 BK-18
1
2
AP-C32
1552269
E921-AP26 PK-18
J813-AP42 BK-18
1
2
WH-18
PU-18
AP-C31
1552269
E922-AP27 GN-18
J813-AP41 BK-18
1
2
WH-18
PU-18
AP-C34
1552269
P946-AP59 BR-18
J814-AP62 BK-18
1
2
AP-C28
3E3364
AUX 3RD FUNCT FWD SOL IT

285-5730
RACKBACK PROP SOL IT

285-5730
DUMP PROP SOL IT

285-5730
DUMP ANTI-DRIFT SOL IT

262-5265
AP-C26
1552269
H714-AP19 OR-18
J813-AP25 BK-18
1
2
WH-18
PU-18
AP-C20
1552269
H713-AP18 PK-18
J813-AP51 BK-18
1
2
WH-18
PU-18
AP-C33
1552269
P945-AP58 OR-18
J814-AP61 BK-18
1
2
AP-C29
1552269
E920-AP24 BR-18
J814-AP36 BK-18
1
2
AP-C18
1552269
H717-AP21 BR-18
K927-AP57 BU-18
1
2
LOWER PROP SOL IT

285-5730
RAISE PROP SOL IT

285-5730
LOWER ANTI-DRIFT SOL IT

262-5265
AP-C30
3E3364
AUX 3RD FUN REARWARD SOL IT

285-5730
PILOT HYD SUPP SOL IT

225-0300
IMPLEMENT CONTROL CIRCUIT
10
CABLE AND WIRE ASSEMBLIES

AF
246-4489
01
AJ
186-3221
01
CC
246-1698
01
EC
229-8851
01
EE
116-0080
01
GG
246-1697
01
HH
247-9989
01
JJ
246-1715
02
KC
247-4389
01
PP
107-2111
01
RR
8Y-9603
01
UU
248-0072
03
VV
248-0221
02
WW
246-1696
01
LOC
E-13
D-16
K-4
L-15
K-1
L-2
L-3
L-3
F-4
G-1
I-10
C-6
B-6
B-6
J-3
J-3
I-18
C-18
C-14
F-7
K-1
I-1
K-10
F-17
A-12
C-7
E-10
J-1
K-2
NOTE
STD
STD
STD
ATCH
ATCH
ATCH
STD
ATCH
STD
STD
STD
ATCH
ATCH
ATCH
STD
STD
ATCH
ATCH
STD
STD
ATCH
ATCH
ATCH
STD
STD
STD
ATCH
ATCH
STD
I-15
L-15
K-12
G-13
L-13
L-13
L-12
K-12
G-13
J-10
K-12
H-14
K-10
L-14
STD
ATCH
STD
STD
STD
STD
STD
STD
STD
ATCH
STD
STD
ATCH
STD
DESCRIPTION
ENGINE
FUEL JUMPER
FRONT FRAME
WASTE GUARD
LH FRONT ROADING FLOODS
QUICK COUPLER
TILT JUMPER
TILT JUMPER (HIGH LIFT)
FRONT FRAME (IT62H)
BUCKET/FORK JUMPER (IT62H)
TRANSMISSION
GROENEVELD AUTOLUBE
GROENEVELD AUTOLUBE
GROENEVELD AUTOLUBE
RH FRONT FLOODS
LH FRONT FLOODS
LH HOOD TURN SIGNAL
RH HOOD TURN SIGNAL
ENGINE APPLICATION
MAIN CHASSIS
LH FRONT ROADING FLOODS
RH FRONT ROADING FLOODS
SECONDARY STEERING
FUEL INJECTOR
REAR AXLE TEMP MONITORING
HYDRAULIC TANK
ETHER AID JUMPER
RH FRONT ROADING FLOODS
FRONT AXLE TEMP MONITORING
BREAKER POWER
WASTE GUARD
JUNCTION BLOCK TO STARTER
AIR INLET HEATER
BATTERY+ TO BATTERYBATTERY- TO DISCONNECT SWITCH
DISCONNECT SWITCH TO FRAME GROUND
STARTER TO FRAME GROUND
ALTERNATOR GROUND
SECONDARY STEERING TO FRAME GROUND
STARTER TO ENGINE GROUND
ALTERNATOR TO BREAKER
SECONDARY STEERING POWER
BATTERY TO JUNCTION BLOCK
PART NUMBER: 241-0637, CHANGE: 00, VERSION: -
OTHER COLOR DESCRIPTIONS
A693-CH14 OR-16
11
CHG
05
01
04
00
02
03
02
03
02
02
04
00
01
01
02
02
00
00
04
04
02
02
02
05
01
02
00
02
02
THIS SCHEMATIC IS FOR THE 950H, 962H, AND IT62H WHEEL LOADER
VOLUME 1 of 2: CHASSIS
CAN DATA LINK

PAYLOAD CONTROL CIRCUIT
12
PART NUMBER
198-2713
260-4861
241-5688
266-7230
271-4029
271-4027
271-4011
275-0025
265-4407
218-3719
247-4865
281-8742
277-8272
277-8271
271-4017
271-4017
271-4035
271-4036
247-1086
247-4506
271-4038
271-4039
248-0220
222-5917
247-8474
247-7569
263-6668
271-4030
247-8475
CAT DATA LINK
REAR AXLE OIL TEMP SENSOR

130-9811
CH-C13
1552267
326-CH1 RD-16
13
IDENT
K
X
AG
AH
AJ
AK
AM
AM
AP
AR
AT
AW
AX
AY
AV
AW
CE
CF
CH
CJ
CL
CM
CV
CX
CY
EA
ET
FR
HA
TURN SIGNAL / WIPER WASHER CIRCUIT
Components are shown installed on a fully operable machine with the key and engine off, transmission shifter
in neutral and with parking brake set.
Refer to the appropriate Service Manual for Troubleshooting, Specifications and Systems Operations.
HIGHWAYS
18
RIDE CONTROL SOL1

252-0737
114-AP1 RD-16
CONNECTS TO C-C1
229-CJ155 BK-14
FUEL PRIMING PUMP

217-8339
MOM
FR-C1
1552252
619-FR1
200-FR2
606-FR3
200-FR4
H713-AG30 PK-18
J813-AG59 WH-18
ENGINE CONTROL CIRCUIT
FUEL PRIMING PUMP SW

165-5970
1
2
3
4
5
6
7
8
9
10
11
12
E919-AG35 YL-18
J814-AG61 BK-18
WH-18
BR-18
BU-18
WH-18
BK-18
WH-18
OR-18
BR-18
BK-18
GN-18
WH-18
YL-18
PK-18
PK-18
MONITOR CIRCUIT
1
2
AJ-C4
1552269
GN-14
BK-14
YL-16
BK-16
1
2
CONN 26
CONN 48
522-CH5 WH-14
MOTOR
AJ-C1
1552252
619-AJ1
200-AJ2
605-AJ3
200-AJ4
E922-AG38 GN-18
J813-AG43 WH-18
RIDE CONTROL SOL2

252-0737
AG-C25
3E3364
COLOR ABBREVIATIONS
136-AW5 GN-18
439-AW4 YL-18
124-AW3 GN-16
103-AW2 YL-16
200-CJ91 BK-14
200-CJ92 BK-14
200-CJ5 BK-18
200-CJ152 BK-18
CH-C19
1552269
513-CH24 OR-14
522-CH25 WH-14
AG-C10
3E3364
506-EA8 PU-18
507-EA10 WH-18
G764-EA3 PK-18
1
2
3
4
5
6
7
8
9
10
11
12
E921-AG37 PK-18
J813-AG58 WH-18
762-AP66 YL-18
106-AP67 WH-18
964-AP68 BU-18
C216-AP69 BK-18
426-EA7 BR-18
201-EA12 BK-18
BK-18
BK-18
BK-18
BK-18
WHEN USED PLUG

INTO AG-C27
AP-C12
1552267
106-AP35 WH-18
C216-AP30 BK-18
C530-AP14 BU-18
EA-C4
1552269
E455-EA4 BR-18
202-EA1 BK-18
419-EA2 YL-18
426-EA7 BR-18
426-EA7 BR-18
506-EA8 PU-18
200-EA9 BK-18
507-EA10 WH-18
AW-C1
155-2264
136-AW6 GN-18
200-AW1 BK-18
136-AW7 GN-18
PU-18
WH-18
PU-18
YL-18
150-CH6 OR-18
ARC SUPPRESSOR
218-4935
201-EA5 BK-18
CONN 14
521-CH4 YL-14
522-CH5 WH-14
CH-C20
3E3364
200-EA13
200-EA14
201-EA11
201-EA12
200-EA9 BK-18
BU-18
RD-18
WH-18
YL-18
BK-18
IT-62H FRAME
G850-CH63 BU-18
H795-CH49 PK-18
H703-CH65 YL-18
H702-CH64 PU-18
BK-18
BK-18
EA-C1
1552252
202-EA1 BK-18
419-EA2 YL-18
G764-EA3 PK-18
E455-EA4 BR-18
201-EA5 BK-18
5
4
6
3
1
2
PU-14
GN-14
BR-16
YL-16
BK-14
NORTH AND SOUTH AMERICAN FRONT FRAME
110-CH3 RD-14
229-CH30 BK-14
2 3
1
AG-C24
1552269
976-AG42 OR-18
J815-AG40 BK-18
J813-AG58
H717-AG53
K927-AG54
J813-AG59
J814-AG60
J813-AG57
H714-AG31
E920-AG36
J814-AG61
E922-AG38
J813-AG43
E919-AG35
E921-AG37
H713-AG30
EA-C3
1552269
E455-EA4 BR-18
201-EA11 BK-18
1
2
3
4
5
6
7
8
9
10
11
12
611-CL4
619-CL1
617-CL5
605-CL3
200-CL2
IT-62H FRAME
229-CH16 BK-14
229-CH31 BK-14
CH-C8
3E3364
LOWER ANTI-DRIFT SOL

262-5265
1
2
CONNECTS TO C-C2
EA-C2
1552267
202-EA1 BK-18
419-EA2 YL-18
G764-EA3 PK-18
CONN 15
110-CH26 RD-14
E748-CH48 BK-18
X918-CH18
X919-CH19
H702-CH64
H703-CH65
AC PRESS SW
114-5333
1
2
Y795-CH51 GN-18
X918-CH18 PU-18
X919-CH19 WH-18
229-CH32 BK-14
A307-CH9 GY-18
DUMP ANTI-DRIFT SOL

262-5265
Y794-CH50 OR-18
430-CH13 BU-18
450-CH17 YL-18
944-CH7 OR-18
945-CH8 BR-18
A307-CH9 GY-18
A982-CH10 BR-18
G850-CH63 BU-18
H795-CH49 PK-18
Y794-CH28 OR-18
H747-CH35 BR-18
110-CH34 RD-14
110-CH33 RD-14
1
2
AG-C4
1552269
P945-AG55 OR-18
J814-AG50 BK-18
200-CJ92 BK-14
CJ-C9
3E5179
611-CL4 PU-14
617-CL5 BR-16
RH HI/LO POS TURN TOWER
AG-C3
1552269
P946-AG56 BR-18
J814-AG49 BK-18
AG-C8
1552269
N939-AG8 GN-18
J815-AG41 BK-18
CONN 17
CONN 22
AG-C37
3E3364
FWD DIVERTER SOL
200-CJ91 BK-14
426-CJ63 BR-18
506-CJ12 PU-18
200-CJ5 BK-18
507-CJ13 WH-18
H704-CH59 PK-18
200-CH22 BK-16
201-CH11 BK-18
326-CH1 RD-16
403-CH58 GN-18
432-CH15 PK-18
521-CH4 YL-14
522-CH5 WH-14
443-CH2 YL-18
201-CH23 BK-18
106-CH40 RD-4
P739-CH44 BU-16
200-CH45 BK-16
110-CH26 RD-14
110-CH3 RD-14
E748-CH61 BK-18
H703-CH65 YL-18
H702-CH64 PU-18
110-CH36 RD-14
202-CJ64 BK-18
419-CJ7 YL-18
G764-CJ15 PK-18
E455-CJ14 BR-18
201-CJ150 BK-18
201-CH11 BK-18
403-CH58 GN-18
432-CH15 PK-18
H746-CH37 YL-18
H747-CH35 BR-18
106-CH40 RD-4
200-CH22 BK-16
201-CH11 BK-18
201-CH23 BK-18
326-CH1 RD-16
403-CH58 GN-18
432-CH15 PK-18
443-CH2 YL-18
521-CH4 YL-14
522-CH5 WH-14
200-CH45 BK-16
P739-CH44 BU-16
Y794-CH52 OR-18
Y794-CH50 OR-18
Y795-CH53 GN-18
Y795-CH51 GN-18
229-CH32 BK-14
229-CH30 BK-14
229-CH31 BK-14
1
2
200-CJ91 BK-14
136-CJ124 GN-18
147-CJ151 RD-18
201-CJ150 BK-18
202-CJ64 BK-18
419-CJ7 YL-18
426-CJ63 BR-18
439-CJ153 YL-18
506-CJ12 PU-18
507-CJ13 WH-18
E455-CJ14 BR-18
G764-CJ15 PK-18
WHEN USED PLUG

INTO AG-C27
FORWARD HORN HIGH

174-7875
1
2
200-CJ92 BK-14
200-CJ5 BK-18
200-CJ152 BK-18
T859-K37 WH-18
T957-K16 PU-18
AG-C9
1552269
114-AG1 RD-16
322-AG21 GY-16
K927-AP57 BU-18
200-CJ5 BK-18
200-CJ152 BK-18
LH HI LO POS TURN LAMP

105-4849
CL-C2
1552273
RH FLOOD/TURN SIG TOWER
201-CJ120 BK-18
G486-CJ23 GN-18
C987-K99 RD-18
G850-K98 BU-18
CONN 22
RH FRONT FLOOD
219-6485
1
2
N939-AG8 GN-18
P945-AG55 OR-18
P946-AG56 BR-18
J814-AG48 BK-14
CL-C1
1552252
619-CL1 GN-14
200-CL2 BK-14
605-CL3 YL-16
CONN 22
K927-AG54 BU-18
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
WHEN USED PLUG

INTO AG-C26
7
8
9
10
11
12
J815-AG40 BK-18
J815-AG41 BK-18
J815-AG69 BK-18
J815-AG39 BK-14
E921-AG37 PK-18
E922-AG38 GN-18
J815-AG39 BK-14
976-AG42 OR-18
SIGNAL
GROUND
FRONT AXLE OIL TEMP SENSOR

130-9811
LH FLOOD/TURN SIG TOWER
AG-C27 AV-C1
AV-C2
3E5179 1552252
1552269
1
GN-14
619-AV1 GN-14
2
BK-14
200-AV2 BK-14
3
GY-16
4
BK-16
5
PU-14
6
PU-14
619-AG28
200-AG13
606-AG19
200-AG10
611-AG64
614-AG66
200-CJ92 BK-14
200-CJ91 BK-14
GY-18
WH-18
BR-18
GN-18
BU-18
1
2
CONN 21
P976-AG78 BR-16
976-AG42 OR-18
987-AG67 WH-16
A958-AG70 WH-18
C530-AG47 BU-18
G485-AG24 BU-18
H718-AG45 GY-18
201-AG44 BK-18
K927-AG54 BU-18
J814-AG48 BK-14
619-AG27 GN-14
H713-AG30 PK-18
H714-AG31 OR-18
CONN 21
LH FRONT FLOOD
219-6485
1
2
8
9
10
11
12
619-AG28 GN-14
619-AG29 GN-14
C216-AG16 BK-18
201-CJ26 BK-18
442-CJ9 GY-18
HYD OIL TEMP SENSOR

130-9811
611-AG63 PU-14
611-AG64 PU-14
AG-C26 AW-C1
AW-C2
3E5179 1552252
1552269
619-AW1 GN-14
GN-14 1
BK-14 2
200-AW2 BK-14
YL-16 3
BK-16 4
5
PU-14
BR-16 6
GY-16 7
617-AG65 BR-16
614-AG66 PU-14
CONN 16
1
2
3
4
5
6
7
110-CJ99 RD-14
617-CJ72 BR-18
617-CJ61 BR-18
617-CJ73 BR-18
619-CJ3 GN-14
727-CJ40 GN-18
728-CJ39 BU-18
C991-K33 PK-18
R746-K20 PK-18
R747-K6 GY-18
G849-K96 BR-18
T860-K34 OR-18
611-AG62 PU-14
C529-AG23 GY-18
H718-AG45 GY-18
H717-AG53 BR-18
P946-AG56 BR-18
P945-AG55 OR-18
C530-AG47 BU-18
605-AG25 YL-16
606-AG26 GY-16
611-AG62 PU-14
987-AG67 WH-16
617-AG65 BR-16
614-AG66 PU-14
619-AG29
200-AG14
605-AG25
200-AG11
611-AG63
617-AG65
606-AG20
606-AG19 GY-16
606-AG20 GY-16
606-AG26 GY-16
GN-14
GN-14
LH HI/LO POS TURN TOWER
BK-16
BK-16
BK-14
BK-16
322-AG21 GY-16
605-AG25 YL-16
CJ-C41
1552269
1
2
200-AG12 BK-14
200-AG79
200-AG68
200-AG14
200-AG11
J813-AG32 BK-14
CJ-C11
8N1533
110-CJ163 RD-14
174-CJ4 RD-10
202-CJ6 BK-18
614-CJ86 PU-18
614-CJ70 PU-18
614-CJ81 PU-18
CONN 11
G826-K38 BR-18
G826-K35 BR-18
112-CJ1 PU-4
611-CJ2 PU-14
G850-CJ108 BU-18
H795-CJ143 PK-18
X918-CJ116 PU-18
X919-CJ118 WH-18
201-CJ82 BK-18
432-CJ8 PK-18
229-CJ155 BK-14
P793-CJ158 BU-18
200-CJ141 BK-18
110-CJ99 RD-14
H704-CJ160 PK-18
110-CJ163 RD-14
H703-CJ122 YL-18
H702-CJ123 PU-18
K977-AT16 PK-18
306-CJ51 GN-18
308-CJ52 YL-18
321-CJ55 BR-18
322-CJ25 GY-18
326-CJ44 PU-18
403-CJ50 GN-18
416-CJ17 OR-18
417-CJ43 GY-18
419-CJ7 YL-18
426-CJ63 BR-18
430-CJ59 BU-18
432-CJ8 PK-18
439-CJ153 YL-18
442-CJ9 GY-18
443-CJ90 YL-18
447-CJ145 PK-18
450-CJ93 YL-18
453-CJ18 PK-18
484-CJ16 YL-18
506-CJ12 PU-18
507-CJ13 WH-18
521-CJ94 YL-18
522-CJ97 WH-18
604-CJ56 OR-18
522-CJ97 WH-18
944-CJ98 OR-18
945-CJ100 BR-18
A307-CJ101 GY-18
A982-CJ111 BR-18
CONN 12
994-K10 GY-18
995-K12 BU-18
T957-K16 PU-18
T958-K17 YL-18
T959-K18 BR-18
T960-K19 BU-18
T961-K28 GN-18
C967-K15 BU-18
T962-K29 WH-18
E963-K27 BK-18
E964-K26 WH-18
E965-K48 BU-18
E966-K49 YL-18
N707-K31 PU-18
T725-K32 WH-18
A751-K13 YL-18
G856-K22 WH-18
G857-K30 YL-18
G854-K100 PK-18
G855-K91 PU-18
G850-K98 BU-18
G826-K1 BR-18
CJ-C10
1130580
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
900-AT13 PU-18
901-AT14 WH-18
136-CJ125 GN-18
202-CJ64 BK-18
202-CJ30 BK-18
202-CJ65 BK-18
C530-CJ29 BU-18
E919-CJ31 YL-18
E920-CJ32 BR-18
E921-CJ33 PK-18
E922-CJ34 GN-18
G485-CJ35 BU-18
H713-CJ37 PK-18
H714-CJ38 OR-18
H717-CJ46 BR-18
H718-CJ19 GY-18
J813-CJ80 BK-14
J814-CJ77 BK-14
J815-CJ45 BK-14
K927-CJ62 BU-18
N939-CJ47 GN-18
P945-CJ131 OR-18
P946-CJ132 BR-18
P976-CJ10 BR-18
G827-K43 BU-18
G827-K36 BU-18
G826-K1 BR-18
G828-K92 WH-18
BU-18
PK-18
OR-18
GN-18
X918-CH18 PU-18
X919-CH19 WH-18
201-CH11 BK-18
432-CH15 PK-18
229-CH16 BK-14
P739-CH44 BU-16
200-CH45 BK-16
110-CH26 RD-14
H704-CH59 PK-18
110-CH3 RD-14
H703-CH65 YL-18
H702-CH64 PU-18
BK-18
BK-18
C991-K33 PK-18
T858-K23
T962-K29
T959-K18
T961-K28
T960-K19
1
2
ALT GROUND
CH-C1
3E6286
150-CH6 OR-18
200-CH22 BK-16
201-CH23 BK-18
E748-CH48 BK-18
326-CH1 RD-16
403-CH58 GN-18
430-CH13 BU-18
443-CH2 YL-18
450-CH17 YL-18
521-CH4 YL-14
522-CH5 WH-14
944-CH7 OR-18
945-CH8 BR-18
A307-CH9 GY-18
A982-CH10 BR-18
E907-AT10 GY-18
E909-AT11 WH-18
755-AT12 OR-18
138-CJ22 GN-18
147-CJ151 RD-18
150-CJ85 OR-18
174-CJ4 RD-10
199-CJ127 RD-16
201-CJ11 BK-18
201-CJ83 BK-18
201-CJ82 BK-18
201-CJ120 BK-18
201-CJ26 BK-18
201-CJ150 BK-18
201-CJ78 BK-18
201-CJ41 BK-18
106-CJ20 WH-18
114-CJ21 RD-18
138-CJ22 GN-18
200-CJ91 BK-14
200-CJ92 BK-14
201-CJ26 BK-18
201-CJ78 BK-18
322-CJ25 GY-18
442-CJ9 GY-18
605-CJ66 YL-18
606-CJ69 GY-18
611-CJ2 PU-14
614-CJ70 PU-18
617-CJ72 BR-18
619-CJ3 GN-14
762-CJ162 YL-18
964-CJ148 BU-18
976-CJ27 OR-18
987-CJ119 WH-18
A958-CJ164 GY-18
C216-CJ24 BK-18
C529-CJ28 GY-18
103-CJ79 RD-4
X918-CJ116 PU-18
X919-CJ118 WH-18
E748-CJ161 BK-18
H704-CJ160 PK-18
403-CH58 GN-18
751-AT3 GN-18
752-AT4 YL-18
J809-AT21 BK-18
E900-AT5 WH-18
J808-AT15 BK-18
J807-AT17 BK-18
E906-AT6 OR-18
E908-AT7 BR-18
754-AT8 BU-18
E901-AT9 GN-18
102-CJ48 RD-14
106-CJ20 WH-18
110-CJ99 RD-14
110-CJ163 RD-14
112-CJ1 PU-4
114-CJ21 RD-18
A301-CJ126 WH-16
A300-CJ128 GN-16
CBL-UU1 RD-2
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
J764-AT1 BR-18
J808-AT15 BK-18
J809-AT21 BK-18
751-AT3 GN-18
752-AT4 YL-18
754-AT8 BU-18
755-AT12 OR-18
900-AT13 PU-18
901-AT14 WH-18
ALTERNATOR
177-9953 80A
(197-8820 95A ATCH)
K-C1
2274002
J2
AG-C1
3E6286
114-AG1 RD-16
P976-AG78 BR-16
106-AG5 WH-18
N939-AG8 GN-18
201-AG44 BK-18
G485-AG24 BU-18
200-AG9 BK-14
200-AG12 BK-14
138-AG4 GN-18
C216-AG16 BK-18
322-AG21 GY-16
200-AG9 BK-14
200-AG10 BK-16
200-AG13 BK-14
AT-C10
7X6222
J807-AT17 BK-18
J808-AT24 BK-18
J808-AT25 BK-18
199-CJ127 RD-16
X919-CJ118 WH-18
X918-CJ116 PU-18
H795-CJ117 PK-18
CJ-C36
1552272
X918-CJ116 PU-18
H795-CJ117 PK-18
X919-CJ118 WH-18
1
2
OUTPUT SPEED SENSOR (TRAILING)

193-2550
BK-18
1
E907-AT10 GY-18
WH-18
2
E906-AT6 OR-18
AT-C9
1552269
AT-C7
1552269
CLUTCH 5 2ND
244-3114
1
2
AT-C14
1552269
604-CJ56 OR-18
605-CJ67 YL-18
606-CJ68 GY-18
614-CJ81 PU-18
614-CJ86 PU-18
617-CJ73 BR-18
P990-CJ74 BR-18
H704-CJ160 PK-18
E748-CJ161 BK-18
CX-C5
1539693
A704-CX604 GN-16
L984-CX402 OR-16
BK-18
WH-18
RD-18
200-CJ109 BK-18
200-CJ54 BK-18
200-CJ110 BK-18
200-CJ112 BK-18
200-CJ113 BK-18
321-CJ55 BR-18
200-CJ112 BK-18
200-CJ113 BK-18
321-CJ55 BR-18
604-CJ115 OR-18
606-CJ68 GY-18
614-CJ86 PU-18
P990-CJ74 BR-18
CYL HEAD 4
268-1835
CLUTCH 4 3RD
244-3114
GROUND LVL SHUTDOWN SW

158-6634
604-CJ114 OR-18
604-CJ115 OR-18
CYL HEAD 3
268-1835
XSMN OIL TEMP SENSOR

145-7028
SIGNAL
BK
GROUND
BK
CLUTCH 3 4TH
244-3114
AT-C4
1552269
AT-C6
1552269
1
3
A
B
C
K927-CJ62 BU-18
J814-CJ77 BK-14
619-CJ3 GN-14
H713-CJ37 PK-18
H714-CJ38 OR-18
RELAY PANEL
200-CJ54 BK-18
200-CJ109 BK-18
200-CJ110 BK-18
604-CJ114 OR-18
605-CJ67 YL-18
614-CJ81 PU-18
617-CJ73 BR-18
CYL HEAD 2
268-1835
CLUTCH 2 FWD
244-3114
AT-C5
1552269
ALTERNATOR BREAKER
171-2212
CYL HEAD 1
268-1835
CLUTCH 1 REV
244-3114
CBL-UU1 RD-2
201-CJ83 BK-18
447-CJ145 PK-18
CV-C4
1552267
202-CV8 BK-18
417-CV11 GY-18
484-CV12 YL-18
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
CONN 20
A300-CJ128 GN-16
A301-CJ126 WH-16
CJ-C28
1552269
614-CJ81 PU-18
200-CJ110 BK-18
CJ-C1
1130580
114-CJ21 RD-18
P976-CJ10 BR-18
106-CJ20 WH-18
N939-CJ47 GN-18
201-CJ78 BK-18
G485-CJ35 BU-18
200-CJ92 BK-14
200-CJ91 BK-14
138-CJ22 GN-18
C216-CJ24 BK-18
322-CJ25 GY-18
762-CJ162 YL-18
C529-CJ28 GY-18
H718-CJ19 GY-18
H717-CJ46 BR-18
P946-CJ132 BR-18
P945-CJ131 OR-18
C530-CJ29 BU-18
605-CJ66 YL-18
606-CJ69 GY-18
611-CJ2 PU-14
987-CJ119 WH-18
617-CJ72 BR-18
614-CJ70 PU-18
SECONDARY STEERING ATTACHMENT
605-CJ67 YL-18
447-CJ145 PK-18
200-CJ54 BK-18
200-CJ112 BK-18
200-CJ113 BK-18
200-CJ109 BK-18
200-CJ110 BK-18
201-CJ83 BK-18
321-CJ55 BR-18
604-CJ56 OR-18
606-CJ68 GY-18
614-CJ81 PU-18
614-CJ86 PU-18
617-CJ73 BR-18
P990-CJ74 BR-18
397-CJ104 OR-14
398-CJ103 BU-14
H704-CJ160 PK-18
E748-CJ161 BK-18
306-CJ51 GN-18
START BREAKER START RELAY

171-2206
125-1302
CONN 4
MATING CONNECTOR
CJ-C33
728-CJ39 BU-18
202-CJ65 BK-18
417-CJ43 GY-18
484-CJ16 YL-18
202-CJ30 BK-18
453-CJ18 PK-18
416-CJ17 OR-18
SECONDARY STEERING GROUND
1
2
MATING CONNECTOR
136-CJ53 GN-18
200-CJ88 BK-18
200-CJ89 BK-14
200-CJ36 BK-18
E748-CJ161 BK-18
50A
200-CJ109 BK-18
200-CJ110 BK-18
200-CJ54 BK-18
200-CJ112 BK-18
200-CJ113 BK-18
200-CJ36 BK-18
304-CJ96 WH-8
306-CJ51 GN-18
308-CJ52 YL-18
P990-CJ75 BR-18
1
2
106-AG7 WH-18
106-AG6 WH-18
727-CJ40 GN-18
CBL-PP1 BK-00
175-CJ95 RD-14
103-CJ79 RD-4
102-CJ48 RD-14
112-CJ1 PU-4
174-CJ4 RD-10
200-CJ88 BK-18
112-CJ1 PU-4
80A
1
2
3
4
5
6
7
8
9
10
11
12
106-AG5 WH-18
200-CV6 BK-18
200-CV7 BK-18
MOTOR
1
2
RD-18
BK-18
BU-18
S
T
101-CJ106 RD-4
CJ-C33
1552267
604-CJ114 OR-18
200-CJ109 BK-18
617-CJ73 BR-18
1
2
CJ-C12
1552252
CONN 13
CV-C1
1552269
1
727-CV10 GN-18
2
200-CV7 BK-18
ARC SUPPRESSOR 1
218-4935
200-CV6 BK-18
1
2
LH STOP TAIL LED

135-0426
STOP/TAIL
BK-18
BK-18
BUSS BAR
271-3952
728-CV5 BU-18
202-CV8 BK-18
417-CV11 GY-18
484-CV12 YL-18
202-CV13 BK-18
453-CV14 PK-18
416-CV15 OR-18
727-CV2 GN-18
727-CV10 GN-18
CJ-C13
3E5179
1
2
3
4
5
6
7
8
9
10
11
12
136-CV3 GN-18
CBL-VV RD-00
SECONDARY STEERING PUMP
275-8544
CV-C2
3E5179
727-CV2 GN-18
136-CV3 GN-18
728-CV5 BU-18
727-CV9 GN-18
ENGINE GROUND
201-CJ83 BK-18
321-CJ55 BR-18
447-CJ145 PK-18
604-CJ56 OR-18
605-CJ67 YL-18
606-CJ68 GY-18
614-CJ81 PU-18
614-CJ86 PU-18
617-CJ73 BR-18
P990-CJ74 BR-18
136-CV18 GN-18
136-CV17 GN-18
1
2
101-AF3 RD-14
1
5
2
4
CV-C3
9X1054
136-CV17 GN-18
728-CV5 BU-18
136-CV18 GN-18
727-CV9 GN-18
727-CV1 GN-18
CJ-C16
1552273
1
OR-14
MOTOR LOWER
397-CJ104 OR-14
2
GN-18
LOWER HOOD
A300-CJ128 GN-16
3
BK-14
GROUND
200-CJ89 BK-14
4
BU-14
MOTOR RAISE
398-CJ103 BU-14
5
RD-14
+28V
175-CJ95 RD-14
6
WH-18
RAISE HOOD
A301-CJ126 WH-16
HOOD RAISE/LOWER MOTOR CONTROL
149-2612
RUNNING LAMP BREAKER

3T-2662
87
87a
85
1
2
102-CJ48 RD-14
15A
1
2
101-AF4 RD-14
101-CJ106 RD-4
SEC STEER INTERMEDIATE RELAY

3E-5239
30
86
WHEN USED PLUG

INTO AG-C26
138-AG4 GN-18
114-AG1 RD-16
CBL-RR1 BK-00
101-CJ106 RD-4
STARTER
207-1517
CONN 21
CBL-JJ BK-00
304-CJ96 WH-8
1
2
3
4
5
6
7
8
9
10
11
12
1
2
QUICK COUPLER SOLENOID

180-8585
CONN 25
CBL-CC1 RD-00
QUICK COUPLER ARC SUPPRESSOR

218-4935
1
2
AK-C2
1552269
779-AK20 WH-16
200-AK21 BK-16
G485-HA1 BU-18
201-HA2 BR-18
1
2
CBL-VV RD-00
AK-C1
1552269
779-AK2 WH-16
200-AK3 BK-16
CONN 24
AG-C38
3E3370
CONN 8
KK-C1
1896323
AUXILLARY START RECEPTACLE
A
B
C
LIFT CYL HE PRESS SNSR

221-3416
P976-AG78 BR-16
200-AG79 BK-16
CBL-KK2 BK-00
CBL-KK1 RD-00
AG-C19
3E3370
AG-C12
1552267
106-AG7 WH-18
C216-AG18 BK-18
C530-AG47 BU-18
CBL-JJ BK-00
DISCONNECT SW
7N-0718
12V BATTERY 2
115-2422
CBL-KC1 BK-2
17
36 Page,
18
102
104
105
106
108
110
112
113
114
115
118
120
121
122
124
125
126
127
130
131
133
134
135
136
138
139
141
142
147
148
150
151
164
168
170
174
199
A105
RD
YL
RD
WH
BU
RD
PU
OR
RD
PK
GY
RD
RD
RD
GN
RD
PK
OR
RD
BR
RD
YL
BU
GN
GN
RD
PK
BU
RD
RD
OR
GN
WH
GN
RD
RD
RD
OR
200
201
202
210
250
251
290
291
A272
A273
C216
BK
BK
BK
BK
BK
BK
BK
BK
BK
BK
BK
306
307
308
320
321
322
326
A307
GN
OR
YL
OR
BR
GY
PU
GY
403
410
411
413
416
417
419
426
430
432
436
439
442
443
447
GN
WH
PK
BR
OR
GY
YL
BR
BU
PK
OR
YL
GY
YL
PK
450
453
484
C413
C414
E416
E455
G479
G480
G485
G486
YL
PK
YL
YL
BU
PU
BR
WH
GN
BU
GN
500
501
502
503
504
505
506
507
508
509
511
512
515
516
517
518
521
522
537
538
539
540
550
567
592
A513
A523
A524
A525
A541
C529
C530
C542
C543
C583
F523
F524
F525
BR
GN
OR
BR
YL
BU
PU
WH
PU
WH
BR
GN
GY
GN
BU
OR
YL
WH
GN
BR
BU
WH
GY
WH
BU
RD
PU
BR
GN
PU
GY
BU
GN
GY
GN
PU
BR
GN
603
604
605
606
608
610
611
614
615
617
PK
OR
YL
GY
GN
OR
PU
PU
YL
BR
Description
Power Circuits
Hd Lmp
MSS / Product Link
Key Sw
Tilt/Lift Position Sensors
Air Seat
Engine ECM
Main Power Rly Output
Opr Mon Panel Vmis B+ Switched
Warning Horn (forward)
Voltage Converters / Radio
Front/Rear Wiper/Washer
Voltage Converter Memory
Back Alarm To Lamp
Dome Lamps
AC
Product Link ECM/Radio
Xmsn Ctrl
Front Cab Flood Lamps
Stop Lamps
Flasher / Front/Rear Flood Relays
LH/RH Dash Indicator Panels
Rear Cab Flood Lamps
Converter 12 Volt Switched Out
Supplemental Steering
Auto Lube Pump To PCS
LH Tail / Clearance Lamps
Beacon / Heated Mirrors
Converter 12 Volt Switched Out
ECAP / Center Dash Indicator Panel
Voltage Converter Memory
Bat (+)
Axle Oil Cooler Clutch
Hydro Ctrl Wtl Powertrain Ctrl
Quick Coupler
Transmission ECM
Unswitched Bus Power
Hood Actuator
8 Volt Sensor Supply+
Ground Circuits
Main Chassis
Operator Monitor Return
Xmsn Ctrl
Converter Output (24/12 Volt)
Payload Mon - Customer Gnd
Payload Mon - System Gnd
CMS Service
CMS Clear
Implement Ctrl BTransmission Ctrl BImplement Return
Basic Machine Circuits
Starter Relay Coil to Transmission Control
Key Sw to Transmission Control
Main Power Relay Coil
Horn Relay Coil To Sw
Backup Alarm Lamp Travel Alarm
Warning Horn (forward)
Key Sw 'C' Term.
Throttle Position
Monitoring Circuits
Alternator (R) Term.
Opr Mon Action Alarm
Opr Mon Master
Opr Mon Fuel Press.
Supplemental Steering Sw
Primary Steering Sw
Opr Mon Parking Brake
Opr Mon Power Train Oil Filter
Opr Mon Air Filter
Opr Mon Brake Press. (oil)
Opr Mon Power Train Oil Filter Jumper
Lamp Indicator
Hyd System Temp Gage
Power Train Temp Gage
Fuel Level Gage
Tach Sender (+)
Supplemental Steering Fault Lamp
Primary Steering Lamp
CMS Display Data
CMS Display Load
Lift Cyl Press Sensor
Hydraulic Oil Filter
Prelube Indicator
Fuel Level Low Indicator
Opr Mon Front Brake Temperature
Opr Mon Rear Brake Temperature
Accessory Circuits
Wiper - Front (Park)
Wiper - Front (Low)
Wiper - Front (Hi)
Wiper - Rear (Park)
Wiper - Rear (Low)
Wiper - Rear (Hi)
Washer - Front
Washer - Rear
Radio Speaker - Left
Radio Speaker - Left (Commom)
Radio Speaker - Right
Radio Speaker - Right (Common)
Blower Motor (Hi)
Blower Motor (Medium)
Blower Motor (Low)
Hazard Flasher To Sw
A/C Sw To Refrigerant Sw
A/C Clutch To Thermostat Sw
Turn Signal Sw To Flasher
Hazard Indicator
Turn Signal Indicator Basic/Right
Turn Signal Indicator Left
Aux Hyd Left- Disconnect To Sw
A/C Sw Jumper
DC/DC Converter Power Output
DC/DC Converter Memory Output
Temp Potentiometer Pos 1
Flasher To Indicator Lights
Lift Press Sensor
Heated Mirror Power
Aux Heater Blower
+24v Relay To A/C Control Module
Lighting Circuits
Rotary Beacon
Stop Lamp
Turn Lamp - Left
Turn Lamp - Right
Flood Lamp - Rear
Head Lamp Basic
Head Lamp Hi
Park/Tail/Dash/Lamp
Cab Flood Lamp/Rops
Tail/position Lamp - Left (Road Pkg)/Width
Wire Color
619
633
646
647
651
661
662
663
691
A629
GN
BU
OR
GN
PK
GN
YL
GY
GY
BU
720
727
728
751
752
754
755
762
E701
E707
E708
E735
E746
G746
G750
G755
G760
G761
G762
G763
G764
G766
G767
G768
G787
G788
H702
H703
H708
H709
H710
H711
H713
H714
H717
H718
H722
H728
H729
H730
H795
J764
P739
Y794
Y795
818
819
G848
G850
J807
J808
J809
J813
J814
J815
J887
T852
T853
T854
T855
T856
T857
T858
T859
PU
GN
BU
GN
YL
BU
OR
YL
PK
GN
PK
PU
GN
WH
BU
GY
WH
YL
BR
PU
PK
GN
WH
GN
GN
YL
PU
YL
OR
BU
PK
GN
PK
OR
BR
GY
GN
GN
WH
BR
PK
BR
BU
OR
GN
BR
GY
GN
BU
BK
BK
BK
BK
BK
BK
PU
GY
OR
YL
BU
WH
GN
GY
WH
T860
T861
T862
T863
T864
T866
T869
T870
900
901
910
944
945
961
964
973
976
977
987
A958
A982
E900
E901
E906
E907
E908
E909
E917
E918
E919
E920
E921
E922
E955
K927
K977
N939
N957
N959
N960
N963
N970
N973
N979
N981
P910
P915
P916
P945
P946
P976
P990
T901
T902
T969
T970
X972
X973
X974
X998
OR
YL
BU
PU
BR
YL
WH
BR
PU
WH
YL
OR
BR
BR
BU
BR
OR
YL
WH
WH
BR
WH
GN
OR
GY
BR
WH
WH
GN
YL
BR
PK
GN
OR
BU
PK
GN
PK
PK
OR
OR
YL
BR
GN
GN
BR
PK
OR
OR
BR
BR
BR
YL
PK
YL
GY
GN
BU
BR
BR
Component Identifiers (CID)

Module Identifier (MID)
Caterpillar Monitoring System
(MID No. 030)
Description
Lighting Circuits Continued
Head Lamp Low
Attach Lighting Ckt
Light Sw To Front Flood Relay
Light Sw To Rear Flood Relay
Flood Lamp Rear
Tachometer Lamp
Speedometer Lamp
Gage Lamps
Warning Lights To Breaker
Front Rops Hid Flood Attachment
Control Circuits
Xmsn Brake Sw
Supplemental Steering Motor Relay
Supplemental Steering Cont Sw
Bucket Positioner Sol Sw
Auto Ride Control Sw
CMS Display +v
CMS Display Clock
CMS Tack/Serv Mtr/Odometer Select
Downshift Sw (N.O.)
Xmsn Cont Torque Limit
Xmsn Cont Fwd Sw To Gnd
Xmsn Cont Rev Sw To Gnd
Xmsn Cont Speed 2 Sw To Gnd
Xmsn Cont Neut Sw To Gnd
Xmsn Cont Park Brake Lever Sw To Gnd
Impl Cont Sw To Gnd N.O.
Impl Cont Sw To Gnd N.C.
Xmsn Cont Remote Fwd Sw To Gnd
Xmsn Cont Remote Rev Sw To Gnd
Impl Cont Reversing Fan Sw (N.O.)
Impl Cont Reversing Fan Sw (N.C.)
Impl Cont Kickout Sw 1
Impl Cont Kickout Sw 2
Impl Cont Lift Lever Position
Impl Cont Tilt Lever Position
Impl Cont Lift Proportional Sol
Impl Cont Lower Proportional Sol
Impl Cont Pilot Press Sol
Impl Cont Tilt Cyl Position
Xmsn Cont L. Brake Pedal Position Sens
CCS Auto 3
CCS Auto 2
CCS Auto 1-4
Throttle Sensor Common
Transmission Switch/Sensor Return #1
Axle Cooler Clutch
Expanded Can Data Link +
Expanded Can Data Link Serial Data (transmit)
Serial Data (receive)
Led Driver 2
Inlet Air Heater
Proportional Return (1-3)
Proportional Return (4/Rev)
Proportional Return (Forward)
Implement Proportional Return
Implement Proportional Return
Ride Control Solenoids Proportional Return
Axle Cooler Relay
Auto Dig Mode Sw. Pos #1
Auto Dig Mode Select Sw. Pos #1
Auto Dig Mode Select Sw. Pos #2
Auto Dig Kickout Set Sw. (N.O.)
Auto Dig Kickout Set Sw. (N.C.)
Auto Dig Trigger Sw. (N.O.)
Auto Dig Trigger Sw. (N.C.)
Auto Dig Auto Trigger Indicator
Auto Dig Record Mode Indicator
Auto Dig Operator Trigger Indicator
Dump Detent
Fine Modulation Sw 1
Fine Modulation Sw 2
Xmsn Neutizer Override Indicator
Cat Data Link +
Cat Data Link Selector Sw
Fork Position Select
Autoshift- Auto/Manual Sw 2
Ride Cont Solenoid 1
Autoshift- Auto/Manual Sw 1
Third Function Diverter Sol
Park Brake Sol
Engine Throttle Cont
Trans Output Spd +
Trans Output Spd Trans Output Spd Q+
Trans Output Spd QTrans Input Spd +
Trans Input Spd Implement Lockout Sw To Gnd (N.O.)
Implement Lockout Sw To Gnd (N.C.)
Aux Lower Proportional Sol
Aux Lift Proportional Sol
Rackback Proportional Sol
Dump Proportional Solenoid
PCS Keypad Data
On/Off Pilot Solenoid Return
Trans Oil Temp Sensor
Ride Control Solenoid 2
Rxd - Comm #1
Rxd - Comm #3
Txd - Comm #1
Txd - Comm #3
Dtr - Comm #1
Dcd - Comm #1
Signal Gnd - Comm #1
Signal Gnd - Comm #3
Secondary Steering Test Sw Input
Xmsn Neutral Indicator
Xmsn Neutral Switch
Anti Drift Sol- Stick
Anti Drift Sol- Boom
Quick Coupler Sw To Low Pressure Sol
Start Relay Ctrl Return
MSS Exciter Coil In
MSS Exciter Coil Out
Third Function Control Flow Switch
Third Function Control Flow Switch
Part Throttle Auto Shift Position 1
Digital Sensor Return
CID
0096
0100
0110
0177
0248
0263
0271
0324
0600
0819
0821
0826
0830
Component
Fuel Level Sender
Engine Oil Pressure Sensor
Engine Coolant Temperature Sensor
Torque Converter Oil Temperature Sensor
Data Link
Sensor Power Supply
Action Alarm
Action Lamp
Hydraulic Oil Temperature Sensor
Display Data Link
Display Power Supply
T/C Oil Temperature Sensor
Brake Oil Temperature Sensor
950H, 962H, and IT62H Wheel Loader

Electrical System
CID
0248
0364
0591
0769
1964
46
60
Payload Control System

(MID No. 074)
63
48
61
50
Component
CAT Data Link
Head End Lift Cylinder Pressure Sensor
PCS EEPROM
Rod End Lift Cylinder Pressure Sensor
47
CID
CID
54
51
58
52
53
56
49
62
59
Volume 2 of 2: Cab
2009 Caterpillar, All Rights Reserved
Symbols
62
46
60
Pressure
Symbol
61
Level
Symbol
Circuit Breaker
Symbol
Flow
Symbol
Symbols and Definitions

Fuse: A component in an electrical circuit that will open the circuit if too much current flows
through it.
50
63
Switch (Normally Open): A switch that will close at a specified point (temp, press, etc.). The
circle indicates that the component has screw terminals and a wire can be disconnected from it.
Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.).
No circle indicates that the wire cannot be disconnected from the component.
Ground (Wired): This indicates that the component is connected to a grounded wire. The
grounded wire is fastened to the machine.
52
58
54
Ground (Case): This indicates that the component does not have a wire connected to ground.
It is grounded by being fastened to the machine.
53
Reed Switch: A switch whose contacts are controlled by a magnet. A magnet closes the
contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.
57
Sender: A component that is used with a temperature or pressure gauge. The sender
measures the temperature or pressure. Its resistance changes to give an indication to
the gauge of the temperature or pressure.
51
45
49
56
47
55
Relay (Magnetic Switch): A relay is an electrical component that is activated by electricity.

It has a coil that makes an electromagnet when current flows through it. The
electromagnet can open or close the switch part of the relay.
Solenoid: A solenoid is an electrical component that is activated by electricity. It has a
coil that makes an electromagnet when current flows through it. The electromagnet
can open or close a valve or move a piece of metal that can do work.
Magnetic Latch Solenoid: A magnetic latch solenoid is an electrical component that is
activated by electricity and held latched by a permanent magnet. It has two coils (latch and unlatch)
that make electromagnet when current flows through them. It also has an internal switch that places
the latch coil circuit open at the time the coil latches.
59
Harness and Wire Symbols
Component
Wire,
Cable,
or
Harness
Assembly Identification: Includes
Harness Identification Letters and
Harness Connector Serialization
Codes (see sample).
Electrical System Voltage

Electronic Control Module
Sensor Power Supply
Remote Communication Module
Alternator "R" Terminal
Harness Identification Letter(s):

(A, B, C, ..., AA, AB, AC, ...)
L-C12
3E-5179
AG-C4
111-7898
Machine Security System

(MID No. 124)
0168
0248
0817
1391
1392
Temperature
Symbol
48
8 Volt DC Supply
Programmed Parameter Fault
Transmission Control
Lift Linkage Position Sensor
Tilt Linkage Position Sensor
Lift Lever Position Sensor
Tilt Lever Position Sensor
Raise Solenoid
Lower Solenoid
Dump Solenoid
Rackback Solenoid
Pilot Pressure Solenoid
Lify Cylinder Head End Oil Pressure Sensor
Kickout Set Switch
3rd Lever Position Sensor
Implement Lockout Switch
3rd Function Forward Solenoid
3rd Function Rearward Solenoid
Caterpillar Monitoring System
Engine Electronic Control Module
Autodig Dig Mode Switch
Machine Application
Continuous Flow Rocker Switch
Autodig Operation Mode Select Switch
Autodig Trigger Switch
ECM Location Code
Autodig Kickout Set Switch
Machine Security System ECM
Fine Modulation Switch
Lower Anti-Drift Solenoid Valve
Dump Anti-Drift Solenoid Valve
CID
Printed in U.S.A.
Harness And Wire Electrical Schematic Symbols
Component
CID
55
45
Product Link Radio

(MID No. 122)
0168
0254
0269
1250
1251
IT62H:
M5G1-UP
Component
8 Volt DC Supply
Transmission Oil Temperature Sensor
Engine Speed Sensor
5 Volt DC Supply
Programmed Parameter Fault
Ride Control Switch
Transmission Auto/Manual Switch
Start Relay
Electronic Monitoring System
Transmission Output Speed Sensor 1
Engine Control Module
Implement Control
Directional Switch
Parking Brake Pressure Sw.
Transmission Input Speed Sensor
Transmission Output Speed Sensor 2
Lever Switch (Transmission Shifting/Direction)
Left Brake Pedal Position Sensor
Primary Steering Pressure Switch
Secondary Steering Pressure Switch
Secondary Steering Relay
Machine Application
ECM Location Code
Rear Axle Oil Cooler Solenoid
Reverse Solenoid
Forward Solenoid
Fourth Speed Clutch
Third Speed Clutch
Second Speed Clutch
First Speed Clutch
Part-Throttle Autoshift Selector Switch
Ignition Key Reader
Ride Control Solenoid (1)
Transmission Direction Switch #2
Electronic Implement Control

(MID No. 082)
0041
0168
0268
0296
0350
0351
0352
0353
0354
0355
0356
0357
0358
0364
0365
0487
0490
0491
0492
0562
0590
0965
0967
1187
1324
1325
1326
1592
1639
1718
2326
2328
962H:
N4A1-UP
M3G1-UP
J6J1-UP
K6K1-UP
MAL1-UP
57
Electronic Transmission Control System

(MID No. 081)
0041
0168
0177
0190
0262
0268
0367
0368
0444
0562
0585
0590
0596
0623
0627
0672
0673
0702
0737
0793
0794
0795
0967
1326
1400
1401
1402
1403
1404
1405
1406
1521
1960
2129
2274
2347
2684
950H:
N1A1-UP
JAD1-UP
M1G1-UP
J5J1-UP
K5K1-UP
L-C12
3E-5179
Part Number: for Connector Plug
Component
Harness Connector Serialization Code:

The "C" stands for "Connector" and the
number indicates which connector in the
harness (C1, C2, C3, ...).
Part Number: for Connector Receptacle

Data Link
ECM Internal Backup Battery
Theft Deterent Output Driver #1
Theft Deterent Output Driver #2
Plug
The CID is a diagnostic code that indicates which circuit is faulty.
Receptacle
Pin or Socket Number
1
2
Deutsch connector: Typical representation

of a Deutsch connector. The plug contains all
sockets and the receptacle contains all pins.
1
2
Sure-Seal connector: Typical representation

of a Sure-Seal connector. The plug and receptacle
contain both pins and sockets.
5A
9X-1123
Fuse (5 Amps)
325-AG135 PK-14
The MID is a diagnostic code that indicates which electronic control module
diagnosed the fault.
Harness identification code:

This example indicates wire group 325,
wire 135 in harness "AG".
Machine Harness Connector and Component Locations
Failure Mode Identifiers (FMI)

FMI No.
Component Location
Failure Description
Component
Schematic
Location
Machine
Location
Connector Location
Component
Schematic
Location
Machine
Location
D-4
46
Off Machine Switch Specification
Schematic
Location
Machine
Location
CONN 16
E-18
54
Connector Number
Data valid but above normal operational range.
Data valid but below normal operational range.
Alarm - Action
E-15
45
Switch - Auto/Manual Gear Select
Data erratic, intermittent, or incorrect.
Alarm - Implement Audible Alert
E-15
45
Switch - Autodig Kickout Set
C-1
46
CONN 17
D-18
59
Voltage above normal or shorted high.
Alarm - Quick Coupler
D-1
46
Switch - Autodig Mode
D-3
46
CONN 18
C-18
54
Voltage below normal or shorted low.
Arc Suppressor - Forward Horn
I-7
47
Switch - Autodig Mode Select
C-1
46
CONN 19
B-18
54
Current below normal or open circuit.
Control - Caterpillar Monitoring System
E-7
48
Switch - Autodig Trigger
G-7
47
CONN 27
F-15
45
Current above normal or grounded circuit.
Control - Dimmer
D-15
45
Switch - Beacon
G-3
52
CONN 28
E-15
45
Mechanical system not responding properly.
Control - Implement Control System
F-14
49
Switch - Blower Fan Speed
D-6
48
CONN 29
L-13
51
Abnormal frequency, pulse width, or period.
Control - Payload Control System
D-7
50
Switch - Bucket/Fork Select
E-2
46
CONN 30
H-12
51
Abnormal update.
Control - Product Link (Gateway)
J-11
51
Switch - Cat Mon Sys Mode Select
C-6
48
CONN 31
H-9
47
10
Abnormal rate of change.
Control - Transmission Control System
L-18
51
Switch - Dimmer
H-1
57
CONN 32
G-9
47
11
Failure mode not identifiable.
Converter - Voltage (10A)
F-15, G-16
51
Switch - Downshift
F-7
47
CONN 33
F-9
45
12
Bad device or component.
Diode - Blower Motor
K-15
51
Switch - Fine Modulation
F-8
47
CONN 34
D-8
48
13
Out of calibration.
Display - Groeneveld Autolube
F-6
48
Switch - Forward Horn
I-3
58
CONN 35
L-7
60
14
Parameter failures.
Flasher - 24V
E-15
45
Switch - Forward Horn 2
G-7
47
CONN 36
L-7
61
15
Parameter failures.
Fuse - Block
B-15
45
Switch - Front Intermittent Wiper/Washer
D-5
48
CONN 37
K-7
60
16
Parameter not available.
Fuse - Thermal Cut Out
K-15
51
Switch - Hazard Lamp
H-3
52
CONN 38
K-7
62
Part No.
3E-5464
Function
A/C Thermostat
Actuate
Deactuate
-1.1 0.8C
2.2 0.8C
(30 1.4F)
(36 1.4F)
Contact Position
Normally Closed
Resistor, Sender and Solenoid Specifications

Part No.
9G-1950
Component Description
Resistor:
Blower Motor Speed
17
Module not responding.
Guage - Quad
J-1
52
Switch - Heated Mirror
E-2
46
CONN 39
D-7
63
18
Sensor supply fault.
Indicator - Center Dash
K-1
52
Switch - HID Lamp
J-3
52
CONN 40
I-3
52
134-2540
19
Condition not met.
Indicator - Left Hand Panel
K-1
52
Switch - HVAC Select
D-6
48
CONN 41
I-3
52
At room temperature unless otherwise noted.
20
Parameter failures.
Indicator - Right Hand Panel
K-1
52
Switch - HVAC Temperature Select
D-5
48
CONN 42
H-3
58
Joystick - Implement Control
I-7
47
Switch - Implement Lockout
G-8
47
CONN 43
F-3
52
Keypad - WLPCS
C-7
50
Switch - Key Start
G-3
52
CONN 44
F-2
52
Motor - Blend Door Actuator
L-15
51
Switch - Lift Tilt Kickout Set
E-1
46
CONN 45
H-1
57
Motor - Blower
L-16
51
Switch - Neutral Override
C-2
46
CONN 46
G-1
55
Motor - Front Wiper
I-1
53
Switch - Quick Coupler
D-1
46
Motor - Rear Wiper
K-14
54
Switch - Rear Wiper/Washer
E-4
46
Radio - Product Link
K-11
51
Switch - Remote FNR
H-7
47
Relay - Axle Cooler
C-15
45
Switch - Reversing Fan
D-1
46
Relay - Forward Cab Floodlamp
C-15
45
Switch - Ride Control
C-2
46
Relay - Forward Horn
C-15
45
Switch - Running Lamp
K-3
52
Relay - Heated Mirrors Timer
D-15
45
Switch - Secoondary Steering Test
D-2
46
Relay - Rear Floodlamp
C-15
45
Switch - Stop Lamp
H-1
55
Resistor A/C (1)
L-14
45
Switch - Third Function Control Flow
K-3
52
Resistor A/C (2)
L-14
45
Switch - Third Function Diverter
G-8
47
Resistor - Blower Motor
K-16
51
Switch - Transmission Gear Selector
I-3
58
Resistor - CAN A
K-6
52
Switch - Transmission Shifter Assembly
H-2
58
Sensor - 3rd Lever Position
F-7
47
Switch - Turn Signal
I-2
58
Sensor - Left Hand Brake Pedal
H-1
55
Switch - Variable Shift Control
D-3
46
Sensor - Lift Lever Position
G-7
47
Tach/Speedometer
J-1
52
Sensor - Throttlle Position
G-1
56
Thermostat
K-15
51
Sensor - Tilt Lever Position
G-7
47
The FMI is a diagnostic code that indicates what type of failure has occurred.
Component
Part Number
Resistor:
CAN
Related Electrical Service Manuals

Resistance (Ohms)
Overall: 2.0 0.1
Tap 1.0 .05
120
Title
Form Number
Cross Reference for Electrical Connectors:
REHS0970
Machine Security System:
RENR2462
Product Link Radio:
RENR7911
Power Train Control:
RENR8846
Implement Control:
RENR8858
Caterpillar Monitoring System:
SENR1394
Payload Control System:
RENR6293
Wire Gauge
Wire Color
Wire Color
Wire
Number
36 Page,
Wire Description
Wire
Number
RENR8882-02
September 2009
STRAP AS.
16
15
14
A272-C35BK-14
13
12
11
10
HVAC UNIT
ECM MOUNT BOLT

J1
J2
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
118-C274GY-18
200-C209BK-14
200-C210BK-18
503-C256BR-18
504-C255YL-18
505-C254BU-18
515-C235GY-14
516-C241GN-14
517-C240BU-14
592-C392BU-16
A523-C236PU-18
A524-C237BR-18
A525-C238GN-18
150-C97OR-16
E900-C207WH-18
E901-C203GN-18
E906-C221OR-18
E907-C246GY-18
TWISTED WIRES
CONN 16
CONNECTS TO
AT-C10 ON THE
CHASSIS AND
ENGINE DGM
FOR PART #'S
SEE THE
TITLE BLOCK
945-C105BR-18
K977-C205PK-18
A273-C409BK-14
202-C27BK-18
170-C70RD-14
202-C19BK-18
977-C197YL-18
973-C195BR-18
H728-C198GN-18
170-C107RD-14
G768-C187GN-18
G760-C191WH-18
G761-C229YL-18
G762-C231BR-18
CONN 17
CONNECTS TO
CJ-C11 ON THE
CHASSIS AND
ENGINE DGM
FOR PART #'S
SEE THE
TITLE BLOCK
CONN 18
CONNECTS TO
CJ-C4 ON THE
CHASSIS AND
ENGINE DGM
FOR PART #'S
SEE THE
TITLE BLOCK
202-C113BK-16
307-C3 OR-18
J887-C490PU-18
A958-C518WH-18
J815-C492BK-14
976-C116OR-18
N939-C112GN-18
306-C109GN-18
P990-C461BR-18
728-C106BU-18
C543-C407GY-18
E701-C405PK-18
G848-C378GN-18
403-C123GN-18
G480-C316GN-18
436-C47OR-18
910-C15YL-18
G763-C185PU-18
450-C263YL-18
G755-C186GY-18
C583-C395GN-18
720-C234PU-18
X974-C200BR-18
X973-C192BU-18
X972-C188GN-18
G746-C13WH-18
P910-C38BR-18
417-C183GY-18
484-C140YL-18
H729-C63WH-18
G787-C418GN-18
P916-C421OR-18
P915-C422PK-18
G788-C423YL-18
H730-C201BR-18
G767-C190WH-18
G766-C189GN-18
106-C18WH-18
110-C472RD-14
110-C66RD-14
112-C1 PU-4
114-C41RD-16
118-C274GY-18
136-C75GN-16
138-C20GN-18
147-C36RD-16
150-C126OR-16
150-C97OR-16
202-C544BK-18
202-C71BK-18
202-C143BK-18
202-C31BK-16
442-C381GY-18
443-C399YL-18
447-C380PK-18
503-C256BR-18
504-C255YL-18
505-C254BU-18
506-C10PU-18
507-C11WH-18
515-C235GY-14
516-C241GN-14
517-C240BU-14
521-C124YL-14
522-C125WH-18
592-C392BU-16
CONN 19
CONNECTS TO
CJ-C21 ON THE
CHASSIS AND
ENGINE DGM
FOR PART #'S
SEE THE
TITLE BLOCK
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
606-C88GY-16
606-C89GY-16
611-C32PU-14
614-C181PU-18
614-C321PU-18
614-C96PU-18
614-C199PU-18
C-C1
2144208
614-C145PU-16
614-C82PU-16
614-C322PU-18
614-C469PU-18
614-C137PU-16
614-C462PU-18
614-C325PU-16
432-C387PK-18
442-C381GY-18
615-C318YL-18
615-C291YL-14
617-C83BR-16
619-C40GN-14
720-C234PU-18
727-C289GN-16
762-C494YL-18
910-C15YL-18
944-C110OR-18
944-C127OR-18
945-C105BR-18
945-C128BR-18
964-C496BU-18
973-C195BR-18
977-C197YL-18
987-C160WH-16
A272-C35BK-14
A273-C408BK-14
A273-C409BK-14
A273-C417BK-14
A307-C129GY-18
A523-C236PU-18
A524-C237BR-18
A525-C238GN-18
A982-C130BR-18
136-C75GN-16
321-C249BR-18
604-C78OR-16
605-C79YL-16
606-C80GY-16
147-C36RD-16
614-C82PU-16
617-C83BR-16
619-C40GN-14
199-C72RD-16
P945-C270OR-18
439-C510YL-18
426-C402BR-18
P946-C303BR-18
C-C35
1835785
964-C496BU-18
762-C494YL-18
326-C287PU-18
430-C313BU-18
443-C399YL-18
450-C263YL-18
521-C124YL-14
522-C125WH-18
A307-C129GY-18
G479-C315WH-18
G850-C29BU-18
A982-C130BR-18
H795-C480PK-18
403-C81GN-18
944-C127OR-18
945-C128BR-18
H703-C478YL-18
H702-C479PU-18
150-C126OR-16
TWISTED
WIRES
J813-C226BK-14
J814-C286BK-14
J815-C491BK-18
J887-C490PU-18
K927-C108BU-18
P739-C493BU-16
P910-C38BR-18
P915-C422PK-18
P916-C421OR-18
P945-C270OR-18
P946-C303BR-18
P976-C77BR-16
X972-C188GN-18
X973-C192BU-18
X974-C200BR-18
Y794-C425OR-18
Y794-C374OR-18
Y794-C431OR-18
Y794-C445OR-18
Y794-C445OR-18
Y795-C426GN-18
Y795-C375GN-18
Y795-C447GN-18
Y795-C447GN-18
403-WA11GN-18
403-WA23GN-18
308-WA22YL-18
308-WA16YL-18
308-WA21YL-18
CAB GROUND 4
N957-WA3PK-18
N960-WA4OR-18
N970-WA5YL-18
N979-WA7GN-18
N973-WA6BR-18
TWISTED WIRES
944-WA1OR-18
945-WA2BR-18
N957-WA3PK-18
Y794-WA9OR-18
125-WA10RD-18
403-WA11GN-18
105-C455RD-16
201-C304BK-16
104-C456YL-16
403-C457GN-18
944-C458OR-18
945-C459BR-18
Y795-C444GN-18
Y794-C435OR-18
TWISTED WIRES
1
2
3
4
5
6
7
8
9
10
11
12
1
2
3
4
5
6
7
8
9
10
11
12
WA-C1
3E5179
125-WA18RD-18
200-WA20BK-18
308-WA22YL-18
403-WA24GN-18
944-WA1OR-18
945-WA2BR-18
Y795-WA8GN-18
Y794-WA9OR-18
TWISTED WIRES
N981-WA14GN-18
N963-WA12OR-18
N959-WA13PK-18
1
2
1
2
N963-WA12OR-18
N959-WA13PK-18
N981-WA14GN-18
200-WA15BK-18
308-WA16YL-18
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
200-WA25BK-16
FUSE PANEL/ELECTRICAL INSTALLATION
142-EG8BU-18
115-EG4PK-18
115-EG9PK-18
142-EG11BU-18
200-EG10BK-18
115-EG9PK-18
115-EG12PK-18
200-EG5BK-18
200-EG6BK-18
200-EG10BK-18
121-EG1RD-18
115-EG4PK-18
200-EG5BK-18
200-EG3BK-18
115-EG2PK-18
121-EG1RD-18
142-EG8BU-18
142 BU IS A 12 VOLT CIRCUIT

115 PK IS A 24 VOLT CIRCUIT
115-EG12PK-18
142-EG7BU-18
200-EG6BK-18
EG-C3 EG-C5
1552272 3E3376
EG-C2
3E3376
1
2
3
4
1
2
3
4
C-C24
1552272
148-C282RD-16
115-C103PK-16
200-C312BK-16
1
2
3
4
1
2
3
4
C-C32
3E3376
200-C509BK-18
439-C512YL-18
439-C511YL-18
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
200-C509BK-18
439-C511YL-18
439-C512YL-18
1
2
3
4
5
6
ACTION ALARM
3E6328
1
2
C529-C59GY-18
C529-C60GY-18
1
2
3
4
CONN 28
SERVICE
MODE
PLUG
H795-C222PK-18
H795-C481PK-18
1
2
3
4
5
6
OUT TO DASH BUCKET IND

GROUND
518-C329OR-16
537-C56GN-16
691-C326GY-16
A541-C327PU-16
633-C328BU-18
200-C213BK-16
1
2
3
4
606-C88GY-16
538-C331BR-16
605-C90YL-16
C-C86 C-C12
3E3364 1552269
691-C326GY-16
131-C266BR-16
1
2
1
2
3
4
5
6
C-C16
1552273
200-C454BK-16
614-C462PU-18
113-C389OR-16
662-C295YL-18
661-C296GN-18
663-C262GY-18
C-C98
2469371
1
5
2
4
1
5
2
4
1
5
2
4
30
FORWARD HORN RELAY

3E5239
87
87a
UNSWITCHED BUS
122-C278RD-16
122-C279RD-16
32
120-C281RD-16
30
130-C5 RD-16
28
139-C277RD-16
121-C228RD-14
121-C361RD-14
110-C66RD-14
110-C472RD-14
10A
DOME LAMPS
10A
VOLTAGE CONVERTOR
MEMORY (STANDARD)
26
10A
15A
15A
118-C463GY-14
18
10A
VOLTAGE CONVERT0RS/24V RADIO

15A
FRONT/REAR WIPER/WASH
108-C271BU-14
16
106-C18WH-18
14
104-C30YL-16
12
141-C470PK-16
10
15A
AIR SEAT
10A
10A
MSS/PRODUCT LINK
10A
BEACON/HEATED MIRRORS
10A
ECM SWITCHED PWR
FUSE PART NUMBERS

10 AMP (9W-1442)
15 AMP (9W-1441)
20 AMP (9W-1446)
10A
25
15A
23
10A
21
10A
19
10A
17
10A
15
10A
13
10A
11
15A
10A
15A
20A
PAYLOAD CONTROL SYSTEM

EMS/(QUAD GAUGE/
SPD TACH BACKLIGHTS)
LH/RH DASH INDICATOR PNL

TS FLASHER/FRNT
REAR FLOOD RELAYS
FRONT CAB FLOODLAMPS

SECONDARY STEERING
(NOT USED ON 980G)
10A
REAR CAB FLOODLAMPS
10A
HVAC
10A
HMU SHIFT HANDLE
C-C30
1886253
27
ECAP/CENTER DASH IND PNL
QUICK COUPLER
10A
LEVER SENSORS/
LH BRAKE PEDAL SENSOR
TILT/LIFT POSITION SENSORS
29
VOL CONV MEM (ATTA)
ENGINE ECM
20
10A
XMSN ECM
IMPL ECM
22
31
HOOD ACTUATOR
LH TAIL/CLEARANCE LAMPS
24
10A
HORN
10A
STOP LAMPS
115-C368PK-16
126-C299PK-16
Y795-C451GN-18
Y795-C114GN-18
85
SWITCHED BUS
1
5
2
4
C-C87
1195094
141-C397PK-16
C543-C407GY-18
141-C14PK-18
C542-C393GN-16
C-C96
1195094
151-C489GN-16
J887-C490PU-18
J815-C491BK-18
P739-C493BU-16
C-C29
9X1054
134-C268YL-14
647-C290GN-18
200-C220BK-18
608-C294GN-14
C-C13
9X1054
322-C39GY-16
114-C42RD-16
320-C390OR-16
200-C211BK-16
10A
AXLE OIL COOLER CLUTCH
147-C514RD-18
147-C36RD-16
147-C177RD-16
147-C73RD-18
147-C65RD-16
136-C517GN-16
136-C75GN-16
136-C310GN-16
136-C515GN-16
105-C455RD-16
105-C259RD-16
112-C1 PU-4
113-C12OR-16
114-C41RD-16
124-C23GN-14
124-C464GN-14
127-C336OR-14
131-C265BR-18
134-C337YL-14
592-C272BU-16
115-C103PK-16
115-C283PK-16
138-C214GN-16
164-C264WH-18
164-C276WH-18
170-C101RD-14
170-C146RD-14
174-C2 RD-10
A513-C339RD-16
151-C159GN-16
199-C72RD-16
200-C454BK-16
200-C529BK-16
320-C390OR-16
J815-C491BK-18
945-C17BR-18
945-C105BR-18
945-C383BR-18
945-C134BR-18
945-C136BR-18
945-C128BR-18
945-C459BR-18
944-C458OR-18
944-C110OR-18
944-C127OR-18
944-C144OR-18
944-C141OR-18
944-C379OR-18
944-C28OR-18
133-C427RD-18
133-C428OR-16
141-C14PK-18
141-C397PK-16
200-C21BK-18
200-C211BK-16
200-C212BK-18
200-C213BK-16
200-C219BK-16
200-C220BK-18
200-C312BK-16
201-C102BK-18
201-C224BK-18
290-C391BK-18
291-C404BK-18
322-C39GY-16
410-C382WH-18
518-C329OR-16
537-C56GN-16
538-C331BR-16
605-C90YL-16
606-C88GY-16
608-C294GN-14
614-C462PU-18
615-C291YL-14
633-C328BU-18
646-C293OR-18
647-C290GN-18
661-C296GN-18
662-C295YL-18
663-C262GY-18
A541-C327PU-16
C542-C393GN-16
C543-C407GY-18
E735-C86PU-18
J887-C490PU-18
P739-C493BU-16
T866-C174YL-18
120-C281RD-16
120-C281RD-16
85
1
5
2
4
C-C5
9X1054
127-C267OR-14
646-C293OR-18
200-C212BK-18
615-C291YL-14
174-C2 RD-10
KEY START SW/PRODUCT LINK
SPARE
Y795-C444GN-18
86
FORWARD CAB FLOODLAMP RELAY

3E5239
30
86
168-C68GN-16
Y795-C434GN-18
290-C391BK-18
291-C404BK-18
E735-C86PU-18
201-C102BK-18
C-C58 C-C34
3E3376 1552272
Y794-C450OR-18
Y794-C25OR-18
410-C382WH-18
201-C224BK-18
C-C17 C-C28
3E3382 1552273
HAZ SW INPUT
OUT TO CHASSIS LIGHTS
KEY SW INPUT
150-C471OR-16
Y794-C435OR-18
120-C281RD-16
115-C283PK-16
200-C219BK-16
A513-C339RD-16
592-C272BU-16
200-C529BK-16
200-C21BK-18
T866-C174YL-18
87
87a
104-C30YL-16
105-C455RD-16
106-C18WH-18
110-C66RD-14
110-C472RD-14
112-C1 PU-4
114-C41RD-16
136-C75GN-16
147-C36RD-16
170-C101RD-14
170-C146RD-14
174-C2 RD-10
199-C72RD-16
320-C390OR-16
322-C39GY-16
439-C511YL-18
439-C512YL-18
592-C272BU-16
605-C90YL-16
606-C88GY-16
614-C462PU-18
615-C291YL-14
944-C110OR-18
944-C127OR-18
944-C458OR-18
945-C105BR-18
945-C128BR-18
945-C459BR-18
A273-C408BK-14
A273-C409BK-14
A273-C417BK-14
C543-C407GY-18
J815-C491BK-18
J887-C490PU-18
P739-C493BU-16
C-C9
1552269
C-C4 C-C11
1552272 1965330
118-C274GY-18
138-C20GN-18
150-C97OR-16
150-C126OR-16
200-C209BK-14
200-C210BK-18
201-C135BK-18
201-C304BK-16
A272-C35BK-14
C216-C148BK-18
C216-C149BK-18
C216-C26BK-16
C529-C60GY-18
C530-C62BU-18
E919-C51YL-18
E920-C52BR-18
E921-C53PK-18
E922-C54GN-18
H713-C57PK-18
H714-C58OR-18
H717-C67BR-18
H718-C225GY-18
J813-C226BK-14
J814-C286BK-14
K927-C108BU-18
P945-C270OR-18
P946-C303BR-18
Y794-C25OR-18
Y795-C114GN-18
C216-C26BK-16
C216-C148BK-18
C216-C149BK-18
C216-C508BK-18
C216-C545BK-18
C216-C217BK-18
C216-C314BK-18
C216-C24BK-18
C-C22
1552273
105-C455RD-16
105-C259RD-16
104-C30YL-16
106-C18WH-18
108-C271BU-14
110-C66RD-14
115-C368PK-16
118-C463GY-14
110-C472RD-14
121-C228RD-14
121-C361RD-14
122-C279RD-16
122-C278RD-16
126-C299PK-16
130-C5 RD-16
139-C277RD-16
141-C470PK-16
150-C471OR-16
168-C68GN-16
114-C42RD-16
114-C41RD-16
199-C72RD-16
147-C65RD-16
170-C101RD-14
170-C146RD-14
148-C282RD-16
138-C214GN-16
113-C12OR-16
113-C389OR-16
104-C30YL-16
105-C455RD-16
106-C18WH-18
110-C66RD-14
110-C472RD-14
112-C1 PU-4
114-C41RD-16
136-C75GN-16
147-C36RD-16
439-C511YL-18
439-C512YL-18
592-C272BU-16
170-C101RD-14
170-C146RD-14
174-C2 RD-10
199-C72RD-16
A273-C409BK-14
A273-C408BK-14
A273-C417BK-14
320-C390OR-16
322-C39GY-16
605-C90YL-16
606-C88GY-16
614-C462PU-18
615-C291YL-14
944-C110OR-18
944-C127OR-18
944-C458OR-18
945-C128BR-18
945-C105BR-18
945-C459BR-18
C543-C407GY-18
J887-C490PU-18
P739-C493BU-16
J815-C491BK-18
121-C228RD-14
121-C361RD-14
150-C471OR-16
C-C7
1471445
J1
115-C283PK-16
115-C103PK-16
115-C368PK-16
115-C280PK-16
105-C259RD-16
108-C271BU-14
113-C12OR-16
118-C463GY-14
122-C278RD-16
122-C279RD-16
124-C23GN-14
124-C464GN-14
127-C336OR-14
130-C5 RD-16
131-C265BR-18
126-C299PK-16
134-C337YL-14
136-C310GN-16
138-C214GN-16
139-C277RD-16
200-C509BK-18
A273-C417BK-14
133-C428OR-16
141-C285PK-16
141-C470PK-16
141-C14PK-18
141-C397PK-16
133-C427RD-18
136-C515GN-16
147-C73RD-18
147-C177RD-16
151-C159GN-16
164-C264WH-18
164-C276WH-18
168-C68GN-16
200-C21BK-18
200-C211BK-16
200-C212BK-18
200-C213BK-16
200-C219BK-16
200-C220BK-18
200-C312BK-16
200-C454BK-16
200-C529BK-16
201-C102BK-18
201-C224BK-18
290-C391BK-18
291-C404BK-18
410-C382WH-18
518-C329OR-16
537-C56GN-16
538-C331BR-16
608-C294GN-14
633-C328BU-18
646-C293OR-18
647-C290GN-18
661-C296GN-18
662-C295YL-18
663-C262GY-18
944-C28OR-18
944-C144OR-18
944-C379OR-18
945-C17BR-18
945-C136BR-18
945-C383BR-18
A273-C408BK-14
A273-C409BK-14
A513-C339RD-16
A541-C327PU-16
C542-C393GN-16
E735-C86PU-18
150-C471OR-16
150-C126OR-16
150-C97OR-16
944-C141OR-18
H717-C67BR-18
210-C178BK-14
944-C141OR-18
945-C134BR-18
961-C495BR-18
A105-C151OR-18
A272-C233BK-14
C216-C26BK-16
C216-C148BK-18
C216-C149BK-18
C529-C60GY-18
C530-C62BU-18
E917-C152WH-18
E918-C153GN-18
E919-C51YL-18
E920-C52BR-18
E921-C53PK-18
E922-C54GN-18
H708-C157OR-18
H709-C158BU-18
H710-C171PK-18
H711-C172GN-18
H713-C57PK-18
H714-C58OR-18
H717-C67BR-18
H718-C225GY-18
H722-C301GN-18
J813-C226BK-14
J814-C286BK-14
K927-C108BU-18
P945-C270OR-18
P946-C303BR-18
T852-C163GY-18
T853-C164OR-18
T854-C165YL-18
T855-C166BU-18
T856-C155WH-18
T857-C156GN-18
T858-C175GY-18
T859-C176WH-18
T860-C161OR-18
T861-C162YL-18
T862-C182BU-18
T863-C179PU-18
T864-C180BR-18
T866-C174YL-18
T869-C168WH-18
T870-C167BR-18
T969-C307YL-18
T970-C308GY-18
X998-C154BR-18
Y794-C25OR-18
Y795-C114GN-18
210-C532BK-14
210-C533BK-14
945-C134BR-18
210-C173BK-14
961-C495BR-18
C216-C149BK-18
121-C133RD-14
C216-C148BK-18
E917-C152WH-18
E918-C153GN-18
H708-C157OR-18
121-C150RD-14
H709-C158BU-18
T869-C168WH-18
A105-C151OR-18
X998-C154BR-18
121-C170RD-14
H713-C57PK-18
H714-C58OR-18
J813-C226BK-14
E921-C53PK-18
E922-C54GN-18
210-C269BK-14
E919-C51YL-18
E920-C52BR-18
J814-C286BK-14
P945-C270OR-18
P946-C303BR-18
T870-C167BR-18
210-C173BK-14
210-C269BK-14
210-C178BK-14
C216-C26BK-16
511-C306BR-18
512-C223GN-18
A272-C35BK-14
K927-C108BU-18
105-C259RD-16
108-C271BU-14
113-C12OR-16
115-C280PK-16
122-C278RD-16
122-C279RD-16
T864-C180BR-18
T862-C182BU-18
T863-C179PU-18
T866-C174YL-18
118-C463GY-14
H710-C171PK-18
H711-C172GN-18
H722-C301GN-18
T857-C156GN-18
T856-C155WH-18
T858-C175GY-18
T859-C176WH-18
C530-C62BU-18
H718-C225GY-18
138-C37GN-18
138-C43GN-18
138-C20GN-18
138-C214GN-16
T852-C163GY-18
T853-C164OR-18
T854-C165YL-18
T855-C166BU-18
T860-C161OR-18
T861-C162YL-18
C529-C60GY-18
T970-C308GY-18
T969-C307YL-18
C542-C393GN-16
139-C277RD-16
141-C285PK-16
147-C73RD-18
147-C177RD-16
151-C159GN-16
164-C264WH-18
164-C276WH-18
168-C68GN-16
290-C391BK-18
291-C404BK-18
410-C382WH-18
518-C329OR-16
537-C56GN-16
538-C331BR-16
608-C294GN-14
633-C328BU-18
646-C293OR-18
647-C290GN-18
661-C296GN-18
662-C295YL-18
663-C262GY-18
944-C379OR-18
944-C28OR-18
944-C144OR-18
945-C17BR-18
945-C136BR-18
945-C383BR-18
A541-C327PU-16
C542-C323GN-18
C542-C506GN-16
200-C534BK-12
200-C230BK-12
200-C206BK-16
Y794-C25OR-18
Y795-C114GN-18
200-C535BK-12
200-C208BK-16
200-C260BK-12
TWISTED
WIRES
201-C524BK-16
201-C304BK-16
201-C347BK-18
201-C525BK-16
201-C348BK-16
201-C135BK-18
201-C224BK-18
201-C102BK-18
A272-C233BK-14
A273-C409BK-14
A273-C417BK-14
A273-C408BK-14
ECM MOUNT BOLT
133-C428OR-16
133-C427RD-18
A273-C475BK-14
A273-C476BK-14
200-C547BK-12
131-C266BR-16
131-C265BR-18
200-C468BK-18
200-C311BK-18
200-C369BK-18
200-C370BK-18
200-C320BK-18
200-C519BK-14
127-C267OR-14
127-C336OR-14
C-C100 C-C101
3E3376 1552272
136-C517GN-16
439-C511YL-18
1
439-C512YL-18
2
200-C509BK-18
3
147-C514RD-18
4
AUTOLUBE CONNECTION
134-C268YL-14
134-C337YL-14
124-C464GN-14
124-C23GN-14
200-C546BK-16
200-C209BK-14
200-C520BK-14
200-C204BK-14
200-C309BK-16
200-C210BK-18
151-C489GN-16
151-C159GN-16
200-C528BK-14
200-C454BK-16
200-C213BK-16
200-C220BK-18
200-C212BK-18
200-C21BK-18
200-C509BK-18
200-C211BK-16
200-C219BK-16
200-C529BK-16
200-C312BK-16
121-C228RD-14
121-C361RD-14
150-C471OR-16
944-C141OR-18
945-C134BR-18
T866-C174YL-18
15
14
13
12
608-M1 GN-14
200-M2 BK-14
608-M5 GN-14
200-M6 BK-14
M-C3
1552269
1
2
608-Y3 GN-14
200-Y4 BK-14
Y-C5 K-C1
1552269 3E3364
1
2
651-Y6 PK-14
200-Y10BK-14
CONN 37
200-K3 BK-14
615-K5 YL-14
615-K4 YL-14
200-K1 BK-14
K-C2
1552269
615-K6 YL-14
200-K2 BK-14
200-C335BK-16
200-C341BK-16
200-C547BK-12
C-C88
1552267
A
B
C
200-K2 BK-14
615-K6 YL-14
200-C546BK-16
200-C548BK-16
Y794-C452OR-18
Y795-C453GN-18
200-C415BK-16
200-C412BK-18
200-C410BK-18
200-C414BK-16
200-C261BK-18
200-C332BK-18
200-C413BK-16
200-C406BK-18
200-C411BK-18
200-C416BK-18
200-C504BK-18
200-C288BK-18
TWISTED WIRES
1
2
Y794-C449OR-18
Y794-C95OR-18
Y794-C452OR-18
CAB LIGHT HARNESS
G-C2
1552252
200-G27BK-18
200-G23BK-18
200-G25BK-16
200-G17BK-16
202-G31BK-18
202-G16BK-18
202-G26BK-18
200-G4 BK-16
H710-G13PK-18
H711-G10GN-18
A105-G1OR-18
X998-G5BR-18
202-G30BK-18
E746-G6GN-18
G787-G15GN-18
H722-G3GN-18
202-G30BK-18
P916-G20OR-18
P915-G21PK-18
G788-G22YL-18
320-G7 OR-16
A105-G1OR-18
X998-G5BR-18
H722-G3GN-18
614-G28PU-18
A105-G1OR-18
G-C3
1552264
C216-G9BK-18
C216-G14BK-18
164-G8 WH-18
C216-G9BK-18
H711-G10GN-18
E746-G6GN-18
G787-G15GN-18
G788-G22YL-18
H710-G13PK-18
H711-G10GN-18
H722-G3GN-18
P915-G21PK-18
P916-G20OR-18
T860-G12OR-18
T861-G11YL-18
X998-G5BR-18
164-G8 WH-18
200-G4 BK-16
C216-G2BK-18
320-G7 OR-16
614-G28PU-18
T861-G11YL-18
T860-G12OR-18
CONN 32
1
2
3
4
5
6
7
8
9
10
11
12
E746-G6GN-18
614-G29PU-18
614-G24PU-18
G-C4
1552273
H710-G13PK-18
T861-G11YL-18
T860-G12OR-18
C216-G14BK-18
1
2
3
4
5
6
7
8
9
10
G-C1
1552252
200-G17BK-16
320-G18OR-16
202-G26BK-18
320-G18OR-16
320-G19OR-16
C216-G2BK-18
1
2
3
4
5
6
7
8
G-C5
1552267
1
2
3
4
5
6
A
B
C
AUTODIG TRIGGER SW
1
2
IMPLEMENT POD (JOYSTICK)
122-C278RD-16
200-C208BK-16
200-C230BK-12
200-C260BK-12
508-C302PU-18
509-C340WH-18
603-C297PK-16
608-C294GN-14
651-C239PK-14
A629-C300BU-14
C542-C506GN-16
H710-C171PK-18
H711-C172GN-18
A105-C151OR-18
X998-C154BR-18
164-C276WH-18
200-C309BK-16
C216-C314BK-18
320-C317OR-16
614-C181PU-18
T861-C162YL-18
T860-C161OR-18
IMPLEMENT POD
C-C20 E-C2
3E5179 1552252
1
2
3
4
5
6
7
8
9
10
11
12
H710-E1PK-18
H711-E2GN-18
E746-E23GN-18
G787-E5GN-18
H722-E9GN-18
202-E27BK-18
P916-E10OR-18
P915-E13PK-18
G788-E14YL-18
202-E27BK-18
614-E30PU-18
614-E29PU-18
614-E4 PU-18
200-E31BK-18
200-E22BK-16
200-E18BK-18
200-E8 BK-16
C-C19 E-C3
3E3388 1552264
G787-E5GN-18
202-E6 BK-18
P916-E10OR-18
P915-E13PK-18
202-E28BK-18
G788-E14YL-18
614-E29PU-18
200-E31BK-18
200-E18BK-18
614-E4 PU-18
164-E19WH-18
164-E20WH-18
164-E21WH-18
202-E6 BK-18
202-E3 BK-18
202-E28BK-18
164-E7 WH-18
CONN 31
C-C39
2234778
E918-C153GN-18
C216-C217BK-18
E917-C152WH-18
320-E12OR-16
E746-E23GN-18
G787-E5GN-18
G788-E14YL-18
H710-E1PK-18
H711-E2GN-18
H722-E9GN-18
P915-E13PK-18
P916-E10OR-18
T860-E25OR-18
T861-E24YL-18
164-E7 WH-18
200-E8 BK-16
C216-E11BK-18
320-E12OR-16
614-E30PU-18
T861-E24YL-18
T860-E25OR-18
1
2
3
4
5
6
7
8
C216-E26BK-18
C216-E16BK-18
C216-E17BK-18
C216-E15BK-18
C216-E11BK-18
CONN 32
614-C322PU-18
200-C468BK-18
200-C320BK-18
614-C469PU-18
C-C46
2234778
151-C159GN-16
200-C311BK-18
200-C320BK-18
200-C369BK-18
200-C370BK-18
200-C468BK-18
614-C96PU-18
614-C199PU-18
614-C321PU-18
614-C322PU-18
614-C469PU-18
987-C160WH-16
C216-C24BK-18
C216-C217BK-18
E917-C152WH-18
E918-C153GN-18
T869-C168WH-18
T870-C167BR-18
108-C271BU-14
200-C204BK-14
151-C159GN-16
987-C160WH-16
614-C321PU-18
200-C370BK-18
200-C369BK-18
614-C199PU-18
320-E12OR-16
200-E22BK-16
1
2
3
4
5
6
7
8
9
10
T861-E24YL-18
T860-E25OR-18
C216-E26BK-18
C-C23 C-C36
1552269 3E3364
1
2
1
2
1
2
3
4
5
6
7
8
9
10
614-C96PU-18
AT-C1
3E3364
200-C311BK-18
108-AT1BU-14
200-AT2BK-14
1
2
3
4
5
6
7
8
9
10
Y795-C448GN-18
Y795-C139GN-18
Y795-C453GN-18
Y795-C503GN-18
614-C325PU-16
102-C69RD-14
104-C46YL-16
202-C31BK-16
202-C143BK-18
307-C3 OR-18
308-C87YL-18
320-C319OR-16
326-C287PU-18
430-C313BU-18
436-C47OR-18
592-C8 BU-16
592-C122BU-16
592-C202BU-16
604-C78OR-16
605-C91YL-16
606-C89GY-16
611-C32PU-14
614-C325PU-16
615-C318YL-18
617-C83BR-16
619-C40GN-14
910-C15YL-18
A307-C129GY-18
A982-C130BR-18
C216-C508BK-18
E701-C405PK-18
G479-C315WH-18
G480-C316GN-18
G746-C13WH-18
G750-C196BU-18
G755-C186GY-18
G760-C191WH-18
G761-C229YL-18
G762-C231BR-18
G763-C185PU-18
G768-C187GN-18
G848-C378GN-18
G850-C29BU-18
H795-C222PK-18
Y794-C450OR-18
Y795-C451GN-18
102-C69RD-14
614-C232PU-18
614-C6 PU-18
614-C93PU-18
614-C330PU-16
614-C505PU-18
538-C446BR-18
538-C465BR-16
538-C331BR-16
102-C248RD-14
102-C131RD-16
611-C32PU-14
611-C100PU-14
611-C424PU-18
537-C56GN-16
537-C16GN-16
537-C305GN-16
663-C433GY-18
663-C432GY-18
663-C262GY-18
E708-C442PK-18
E708-C443PK-18
C413-C251YL-18
C413-C436YL-18
C413-C437YL-18
C414-C244BU-18
C414-C438BU-18
C414-C439BU-18
E707-C250GN-18
E707-C440GN-18
E707-C441GN-18
T969-C307YL-18
C216-C508BK-18
T970-C308GY-18
200-C504BK-18
C-C66
2234778
127-C336OR-14
A629-C300BU-14
134-C337YL-14
651-C239PK-14
614-C93PU-18
200-C288BK-18
201-C420BK-18
201-C419BK-18
201-C292BK-18
201-C9 BK-16
1
2
A
B
C
1
2
3
4
C-C93 C-C47
1552273 3E3382
1
2
3
4
5
6
T864-C180BR-18
T862-C182BU-18
T863-C179PU-18
1
2
3
4
5
6
7
8
9
10
C-C14
1552273
E707-C440GN-18
201-C419BK-18
E708-C443PK-18
C413-C436YL-18
C414-C438BU-18
1
2
3
4
5
6
7
8
C-C42
7T5957
1
2
3
4
5
6
7
8
9
10
11
12
633-C328BU-18
411-C243PK-18
539-C429BU-18
G848-C378GN-18
E701-C405PK-18
G850-C29BU-18
G479-C315WH-18
611-C424PU-18
436-C47OR-18
1
2
3
4
5
6
7
8
9
10
C-C44
1552252
133-C427RD-18
200-C414BK-16
1
2
3
4
5
6
C-C15
1552273
E707-C441GN-18
201-C420BK-18
E708-C442PK-18
C413-C437YL-18
C414-C439BU-18
1
2
537-C16GN-16
539-C429BU-18
540-C430WH-18
605-C91YL-16
606-C89GY-16
A541-C327PU-16
202-C31BK-16
320-C319OR-16
126-C299PK-16
1
2
3
4
5
6
C-C85
1552252
1
2
3
4
5
6
606-AY5GY-14
CONN 40
G762-C231BR-18
G763-C185PU-18
C-C71
3T3158
539-AY2BU-18
540-AY3WH-18
1
2
3
4
5
6
7
8
9
10
11
12
G750-C196BU-18
G755-C186GY-18
G768-C187GN-18
G760-C191WH-18
G761-C229YL-18
C-C70
3T3158
663-C433GY-18
200-C406BK-18
663-C432GY-18
200-C410BK-18
605-AY4YL-14
C-C69
3T3158
537-AY1GN-14
539-AY2BU-18
540-AY3WH-18
605-AY4YL-14
606-AY5GY-14
A541-AY6PU-18
1
2
3
4
5
6
STEERING GROUP
AY-C1
3E3381
C-C68
3T3158
661-C296GN-18
200-C411BK-18
662-C295YL-18
200-C412BK-18
A541-AY6PU-18
537-AY1GN-14
FORWARD HORN SW
2T-3360
C-C10
1552273
501-C257GN-18
320-OR
200-C416BK-18
118-C275GY-18
500-C252BR-18
502-C253OR-18
4
1
2
6
3
5
CONN 41
CONN 41
1
2
3
4
5
6
7
8
9
10
11
12
CR-C1
3E5179
A
B
C
322-CR2GY-16
CR-C3 CA-C2
1552264 3E3388
202-CR1BK-16
322-CR2GY-16
G750-CR3BU-16
G755-CR4GY-16
G768-CR5GN-16
G760-CR6WH-16
G761-CR7YL-16
G762-CR8BR-16
G763-CR9PU-16
CA-C1
1711653
G763-CA1 PU 20
202-CA2BK-20
G750-CA3 BU 20
G755-CA4 GY 20
G768-CA5GN-20
G760-CA6 WH 20
G761-CA7 YL 20
G762-CA8 BR 18
1
2
3
4
5
6
7
8
G763-CR9PU-16
202-CR1BK-16
G750-CR3BU-16
G755-CR4GY-16
G768-CR5GN-16
G760-CR6WH-16
G761-CR7YL-16
G762-CR8BR-16
XMSN SHIFTER SW AS
151-7007
C-C79
2234778
537-C305GN-16
538-C465BR-16
102-C131RD-16
518-C329OR-16
614-C6 PU-18
200-C332BK-18
C-C80
2234778
614-C232PU-18
200-C261BK-18
308-C87YL-18
326-C287PU-18
307-C3 OR-18
105-C259RD-16
539-C429BU-18
540-C430WH-18
610-C333OR-14
104-C46YL-16
201-C9 BK-16
Y794-C466OR-18
Y795-C503GN-18
T902-C488PK-18
T901-C487YL-18
TWISTED WIRES
C-C90
1552272
W-C1
3E3370
610-W2 OR-14
619-W3 GN-14
611-W1 PU-14
DIMMER SW
NOTE:FOR JAPAN ROADING
2H-1855
CONN 45
NEUTRAL SW
GROUND
FORWARD SW
REVERSE SW
UPSHIFT (NC)
UPSHIFT (NO)
DOWNSHIFT (NC)
DOWNSHIFT (NO)
G763-PU-18
202-BK-18
G750-BU-18
G755-GY-18
G768-GN-18
G760-WH-18
G761-YL-18
G762-BR-18
1
2
3
4
5
6
7
8
NOTE: JUMPER 610-OR TO 619-GN

ON MACHINES NOT EQUIPPED WITH
ROADING LIGHTS.
CONN 42
C-C74 X-C1
1552267 3E3370
164-C264WH-18
202-C143BK-18
G746-C13WH-18
1
2
3
4
5
6
7
8
9
10
130-C5 RD-16
604-C78OR-16
C-C75
2304013
200-X1 BK-14
A
B
C
610-C333OR-14
619-C40GN-14
611-C100PU-14
COMMAND CONTROL STEERING WHEEL
141-C285PK-16
603-C297PK-16
1
2
3
4
CONN 45
1
2
3
C-C76 T-C1
3E3364 1552269
1
2
STOP LAMP SW
105-6117
102-T2 RD-16
604-T1 OR-16
CONN 46
LH BRAKE PEDAL (178-3186)
1
2
3
4
5
6
7
8
9
10
C-C77
1552267
A982-C130BR-18
H795-C222PK-18
A307-C129GY-18
A
B
C
1
2
3
4
C-C25 C-C27
1552264 3E3388
1
2
3
4
5
6
7
8
C-C89
C-C91 3E3364
1552269
E-C4
3E3370
A
B
C
E746-E23GN-18
202-E3 BK-18
910-C15YL-18
G480-C316GN-18
430-C313BU-18
615-C318YL-18
413-C33BR-18
C-C83 C-C84
1552273 3E3382
539-C429BU-18
540-C430WH-18
610-C333OR-14
1
2
3
4
1
2
3
4
5
6
7
8
9
10
11
12
540-C430WH-18
538-C446BR-18
1
2
3
4
5
6
7
8
C-C81 C-C82
1552264 3E3388
509-C340WH-18
508-C302PU-18
200-C341BK-16
115-C280PK-16
A513-C339RD-16
592-C122BU-16
512-C223GN-18
511-C306BR-18
102-C131RD-16
102-C248RD-14
104-C46YL-16
105-C259RD-16
115-C280PK-16
126-C299PK-16
127-C336OR-14
131-C265BR-18
134-C337YL-14
139-C277RD-16
141-C285PK-16
147-C73RD-18
200-C261BK-18
200-C288BK-18
200-C332BK-18
200-C334BK-16
200-C335BK-16
200-C341BK-16
200-C504BK-18
201-C9 BK-16
201-C292BK-18
202-C31BK-16
307-C3 OR-18
308-C87YL-18
320-C319OR-16
326-C287PU-18
508-C302PU-18
509-C340WH-18
511-C306BR-18
512-C223GN-18
518-C329OR-16
537-C16GN-16
537-C305GN-16
538-C465BR-16
539-C429BU-18
540-C430WH-18
592-C8 BU-16
592-C122BU-16
592-C202BU-16
603-C297PK-16
605-C91YL-16
606-C89GY-16
610-C333OR-14
614-C6 PU-18
614-C93PU-18
614-C232PU-18
614-C330PU-16
614-C505PU-18
617-C83BR-16
646-C293OR-18
647-C290GN-18
651-C239PK-14
944-C28OR-18
945-C17BR-18
A513-C339RD-16
A541-C327PU-16
A629-C300BU-14
C216-C508BK-18
G750-C196BU-18
G755-C186GY-18
G760-C191WH-18
G761-C229YL-18
G762-C231BR-18
G763-C185PU-18
G768-C187GN-18
T969-C307YL-18
T970-C308GY-18
Y794-C466OR-18
Y794-C449OR-18
Y795-C448GN-18
Y795-C503GN-18
308-C87YL-18
320-C319OR-16
326-C287PU-18
411-C243PK-18
413-C33BR-18
430-C313BU-18
436-C47OR-18
500-C252BR-18
501-C257GN-18
502-C253OR-18
508-C302PU-18
509-C340WH-18
511-C306BR-18
512-C223GN-18
518-C329OR-16
592-C8 BU-16
592-C202BU-16
592-C122BU-16
603-C297PK-16
604-C78OR-16
605-C91YL-16
606-C89GY-16
615-C318YL-18
617-C83BR-16
619-C40GN-14
633-C328BU-18
646-C293OR-18
647-C290GN-18
651-C239PK-14
661-C296GN-18
662-C295YL-18
910-C15YL-18
944-C28OR-18
945-C17BR-18
A307-C129GY-18
A513-C339RD-16
A541-C327PU-16
A629-C300BU-14
A982-C130BR-18
C216-C508BK-18
E701-C405PK-18
G479-C315WH-18
G480-C316GN-18
G746-C13WH-18
G750-C196BU-18
G755-C186GY-18
G760-C191WH-18
G761-C229YL-18
G762-C231BR-18
G763-C185PU-18
G768-C187GN-18
G848-C378GN-18
G850-C29BU-18
H795-C222PK-18
T970-C308GY-18
T862-C182BU-18
T863-C179PU-18
T864-C180BR-18
T969-C307YL-18
411-C243PK-18
500-C252BR-18
501-C257GN-18
502-C253OR-18
C413-C251YL-18
C414-C244BU-18
E707-C250GN-18
E708-C247PK-18
C-C102
2234778
614-C505PU-18
E-C10 E-C5
1552272 3E3376
164-E20WH-18
C216-E16BK-18
H722-E9GN-18
CONN 33
ANTENNA 1
(AM/FM RADIO)
9U-2331
C-C73
1552252
133-C428OR-16
200-C415BK-16
147-C177RD-16
200-C413BK-16
592-C202BU-16
200-C334BK-16
104-C46YL-16
105-C259RD-16
115-C280PK-16
118-C275GY-18
126-C299PK-16
127-C336OR-14
130-C5 RD-16
131-C265BR-18
134-C337YL-14
139-C277RD-16
141-C285PK-16
147-C73RD-18
147-C177RD-16
133-C427RD-18
133-C428OR-16
164-C264WH-18
202-C31BK-16
202-C143BK-18
307-C3 OR-18
201-C524BK-16
C-C78
1552264
131-C265BR-18
102-C248RD-14
139-C277RD-16
646-C293OR-18
617-C83BR-16
610-C333OR-14
647-C290GN-18
614-C330PU-16
E708-C247PK-18
E-C13 E-C1
1552267 3E3370
E-C9
1552272
164-E19WH-18
C216-E15BK-18
H711-E2GN-18
FINE MODULATION SW
C-C94 2364622
2234778
T870-C167BR-18
C216-C24BK-18
T869-C168WH-18
E-C11
1552269
E-C7
1552272
164-E21WH-18
C216-E17BK-18
H710-E1PK-18
1
2
3
4
5
6
7
8
9
10
E-C6
2234778
Y794-C466OR-18
Y795-C451GN-18
508-C302PU-18
509-C340WH-18
603-C297PK-16
651-C239PK-14
A629-C300BU-14
105-C259RD-16
115-C280PK-16
118-C275GY-18
126-C299PK-16
127-C336OR-14
130-C5 RD-16
131-C265BR-18
133-C427RD-18
133-C428OR-16
134-C337YL-14
139-C277RD-16
141-C285PK-16
147-C73RD-18
147-C177RD-16
164-C264WH-18
200-C546BK-16
200-C547BK-12
201-C524BK-16
413-C33BR-18
511-C306BR-18
512-C223GN-18
518-C329OR-16
537-C56GN-16
538-C331BR-16
633-C328BU-18
646-C293OR-18
647-C290GN-18
661-C296GN-18
662-C295YL-18
663-C262GY-18
944-C28OR-18
945-C17BR-18
A513-C339RD-16
A541-C327PU-16
T862-C182BU-18
T863-C179PU-18
T864-C180BR-18
T970-C308GY-18
T969-C307YL-18
G-C6
1552269
320-G19OR-16
200-G25BK-16
202-C71BK-18
320-C317OR-16
614-C96PU-18
614-C181PU-18
614-C199PU-18
614-C321PU-18
614-C322PU-18
614-C469PU-18
987-C160WH-16
C216-C24BK-18
C216-C217BK-18
C216-C314BK-18
E746-C44GN-18
G787-C418GN-18
G788-C423YL-18
P915-C422PK-18
P916-C421OR-18
118-C275GY-18
130-C5 RD-16
133-C427RD-18
133-C428OR-16
147-C177RD-16
164-C264WH-18
200-C406BK-18
200-C410BK-18
200-C411BK-18
200-C412BK-18
200-C413BK-16
200-C414BK-16
200-C415BK-16
200-C416BK-18
201-C419BK-18
201-C420BK-18
202-C143BK-18
411-C243PK-18
413-C33BR-18
430-C313BU-18
436-C47OR-18
500-C252BR-18
501-C257GN-18
502-C253OR-18
538-C446BR-18
539-C429BU-18
540-C430WH-18
604-C78OR-16
610-C333OR-14
611-C100PU-14
611-C424PU-18
615-C318YL-18
619-C40GN-14
633-C328BU-18
661-C296GN-18
662-C295YL-18
663-C432GY-18
663-C433GY-18
910-C15YL-18
A307-C129GY-18
A982-C130BR-18
C413-C436YL-18
C413-C437YL-18
C414-C438BU-18
C414-C439BU-18
E701-C405PK-18
E707-C440GN-18
E707-C441GN-18
E708-C442PK-18
E708-C443PK-18
G479-C315WH-18
G480-C316GN-18
G746-C13WH-18
G848-C378GN-18
G850-C29BU-18
H795-C222PK-18
T862-C182BU-18
T863-C179PU-18
T864-C180BR-18
1
2
200-K3 BK-14
200-K2 BK-14
ELECTRICAL STUDS PASS

THROUGH THE CAB ROOF
CONNECT TO TERMINALS
PART NUMBERS:
PILOT/HMU 186-0696
EH/CCS
186-0623
G-C7
2234778
ANTENNA
(C.B. RADIO)
9U-2332
CABLE AS. 124-4883
CABLE AS. 124-4884
ONE STUD FOR EACH CIRCUIT

200,615,608(ATTACH),603(ATTACH)
1
2
IMPLEMENT POD
147-C73RD-18
201-C292BK-18
944-C28OR-18
945-C17BR-18
Y795-C448GN-18
Y794-C449OR-18
TWISTED WIRES
E735-C132PU-18
E735-C55PU-18
118-C258GY-16
411-C243PK-18
500-C252BR-18
501-C257GN-18
502-C253OR-18
C413-C251YL-18
C414-C244BU-18
E707-C250GN-18
E708-C247PK-18
403-C401GN-18
426-C402BR-18
432-C387PK-18
442-C381GY-18
443-C399YL-18
447-C380PK-18
503-C256BR-18
504-C255YL-18
505-C254BU-18
506-C10PU-18
507-C11WH-18
515-C235GY-14
516-C241GN-14
517-C240BU-14
521-C124YL-14
567-C360WH-14
567-C364WH-14
567-C372WH-14
614-C137PU-16
108-C271BU-14
122-C278RD-16
151-C159GN-16
164-C276WH-18
200-C204BK-14
200-C208BK-16
200-C230BK-12
200-C260BK-12
200-C309BK-16
200-C311BK-18
200-C320BK-18
200-C369BK-18
200-C370BK-18
200-C468BK-18
608-C294GN-14
C542-C506GN-16
H722-C301GN-18
202-C544BK-18
567-C473WH-14
720-C234PU-18
727-C289GN-16
964-C496BU-18
973-C195BR-18
977-C197YL-18
A523-C236PU-18
A524-C237BR-18
A525-C238GN-18
C216-C545BK-18
C529-C59GY-18
C530-C61BU-18
C583-C395GN-18
105-C259RD-16
115-C280PK-16
118-C275GY-18
126-C299PK-16
127-C336OR-14
130-C5 RD-16
131-C265BR-18
133-C427RD-18
133-C428OR-16
134-C337YL-14
139-C277RD-16
141-C285PK-16
147-C73RD-18
147-C177RD-16
164-C264WH-18
200-C546BK-16
200-C547BK-12
201-C524BK-16
413-C33BR-18
511-C306BR-18
512-C223GN-18
518-C329OR-16
537-C56GN-16
538-C331BR-16
633-C328BU-18
646-C293OR-18
647-C290GN-18
661-C296GN-18
662-C295YL-18
663-C262GY-18
944-C28OR-18
945-C17BR-18
A513-C339RD-16
A541-C327PU-16
T862-C182BU-18
T863-C179PU-18
T864-C180BR-18
T969-C307YL-18
T970-C308GY-18
113-C12OR-16
124-C23GN-14
124-C464GN-14
136-C310GN-16
138-C37GN-18
138-C43GN-18
168-C68GN-16
H702-C479PU-18
H703-C478YL-18
H795-C481PK-18
200-C483BK-18
200-C45BK-18
200-C342BK-18
200-C527BK-18
200-C539BK-18
200-C499BK-18
200-C498BK-18
200-C138BK-18
200-C384BK-18
200-C356BK-18
200-C538BK-18
200-C537BK-18
200-C536BK-16
201-C347BK-18
201-C348BK-16
964-C496BU-18
202-C396BK-18
202-C350BK-18
202-C366BK-18
202-C358BK-18
202-C85BK-18
202-C351BK-18
202-C284BK-18
202-C544BK-18
290-C391BK-18
291-C404BK-18
403-C401GN-18
410-C382WH-18
411-C243PK-18
426-C402BR-18
432-C387PK-18
439-C513YL-18
442-C381GY-18
443-C399YL-18
447-C380PK-18
500-C252BR-18
501-C257GN-18
502-C253OR-18
503-C256BR-18
504-C255YL-18
505-C254BU-18
506-C10PU-18
507-C11WH-18
515-C235GY-14
516-C241GN-14
517-C240BU-14
521-C124YL-14
567-C360WH-14
567-C364WH-14
567-C372WH-14
567-C473WH-14
439-C513YL-18
762-C494YL-18
H702-C479PU-18
H703-C478YL-18
H795-C481PK-18
P910-C38BR-18
P976-C77BR-16
X972-C188GN-18
X973-C192BU-18
X974-C200BR-18
614-C542PU-16
113-C12OR-16
118-C258GY-16
122-C279RD-16
124-C23GN-14
124-C464GN-14
136-C310GN-16
136-C515GN-16
138-C37GN-18
138-C43GN-18
168-C68GN-16
200-C206BK-16
201-C348BK-16
201-C347BK-18
290-C391BK-18
291-C404BK-18
410-C382WH-18
511-C306BR-18
512-C223GN-18
944-C144OR-18
944-C379OR-18
945-C136BR-18
945-C383BR-18
961-C495BR-18
C542-C323GN-18
E735-C86PU-18
H708-C157OR-18
H709-C158BU-18
T852-C163GY-18
T853-C164OR-18
T854-C165YL-18
T855-C166BU-18
T856-C155WH-18
T857-C156GN-18
T858-C175GY-18
T859-C176WH-18
200-C536BK-16
200-C537BK-18
200-C538BK-18
200-C539BK-18
200-C540BK-18
200-C357BK-18
200-C474BK-18
200-C338BK-18
200-C104BK-18
200-C359BK-18
200-C467BK-18
200-C516BK-16
200-C345BK-18
200-C344BK-18
200-C346BK-18
200-C484BK-16
200-C343BK-18
E455-C403BR-18
G485-C385BU-18
G486-C388GN-18
G766-C189GN-18
G767-C190WH-18
H728-C198GN-18
H729-C63WH-18
H730-C201BR-18
113-C12OR-16
118-C258GY-16
124-C23GN-14
124-C464GN-14
136-C310GN-16
136-C515GN-16
138-C37GN-18
138-C43GN-18
168-C68GN-16
201-C347BK-18
201-C348BK-16
290-C391BK-18
291-C404BK-18
410-C382WH-18
944-C379OR-18
944-C144OR-18
945-C136BR-18
945-C383BR-18
961-C495BR-18
C542-C323GN-18
E735-C86PU-18
H708-C157OR-18
H709-C158BU-18
T852-C163GY-18
T853-C164OR-18
T854-C165YL-18
T855-C166BU-18
T856-C155WH-18
T857-C156GN-18
T858-C175GY-18
T859-C176WH-18
118-C355GY-18
118-C352GY-18
118-C353GY-18
118-C354GY-18
200-C502BK-18
200-C362BK-18
200-C324BK-18
200-C363BK-18
200-C540BK-18
614-C543PU-16
614-C137PU-16
614-C477PU-18
614-C169PU-18
614-C74PU-18
614-C216PU-18
614-C371PU-18
614-C541PU-18
614-C215PU-18
614-C242PU-18
614-C245PU-18
614-C526PU-18
614-C64PU-18
614-C482PU-18
614-C94PU-18
614-C501PU-18
614-C7 PU-18
614-C497PU-18
614-C500PU-18
614-C92PU-18
614-C76PU-18
720-C234PU-18
727-C289GN-16
762-C494YL-18
944-C144OR-18
944-C379OR-18
945-C136BR-18
945-C383BR-18
961-C495BR-18
973-C195BR-18
977-C197YL-18
A523-C236PU-18
A524-C237BR-18
A525-C238GN-18
C216-C365BK-18
C216-C349BK-18
C216-C367BK-18
C216-C376BK-18
C216-C386BK-18
C216-C545BK-18
C413-C251YL-18
C414-C244BU-18
C529-C59GY-18
C530-C61BU-18
C542-C323GN-18
C583-C395GN-18
210-C533BK-14
210-C532BK-14
E455-C403BR-18
E707-C250GN-18
E708-C247PK-18
A272-C35BK-14
A272-C233BK-14
G485-C385BU-18
G486-C388GN-18
G766-C189GN-18
G767-C190WH-18
H708-C157OR-18
H709-C158BU-18
H728-C198GN-18
H729-C63WH-18
H730-C201BR-18
A273-C475BK-14
A273-C476BK-14
201-C525BK-16
201-C524BK-16
P910-C38BR-18
P976-C77BR-16
200-C534BK-12
200-C535BK-12
200-C519BK-14
200-C546BK-16
200-C536BK-16
200-C537BK-18
200-C538BK-18
200-C539BK-18
200-C540BK-18
200-C521BK-12
200-C547BK-12
200-C521BK-12
P976-C485BR-16
P976-C486BR-16
T852-C163GY-18
T853-C164OR-18
T854-C165YL-18
T855-C166BU-18
T856-C155WH-18
T857-C156GN-18
T858-C175GY-18
T859-C176WH-18
X972-C188GN-18
X973-C192BU-18
X974-C200BR-18
113-C12OR-16
136-C515GN-16
200-C516BK-16
201-C348BK-16
290-C391BK-18
291-C404BK-18
403-C401GN-18
410-C382WH-18
411-C243PK-18
426-C402BR-18
432-C387PK-18
439-C513YL-18
442-C381GY-18
C-C103 C-C104
1552267 3E3370
147-A1 RD-18
200-A2 BK-18
944-A3 OR-18
945-A4 BR-18
Y795-A5GN-18
Y794-A6OR-18
C-C3
8T9834
113-C12OR-16
201-C348BK-16
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
410-C382WH-18
944-C379OR-18
443-C399YL-18
447-C380PK-18
944-C379OR-18
945-C383BR-18
C413-C251YL-18
C414-C244BU-18
E455-C403BR-18
E707-C250GN-18
E708-C247PK-18
E735-C132PU-18
G485-C385BU-18
G486-C388GN-18
G485-C385BU-18
447-C380PK-18
442-C381GY-18
TWISTED WIRES
411-C243PK-18
945-C383BR-18
C414-C244BU-18
E735-C132PU-18
432-C387PK-18
138-C37GN-18
138-C43GN-18
200-C345BK-18
200-C346BK-18
614-C541PU-18
944-C144OR-18
945-C136BR-18
C529-C59GY-18
C530-C61BU-18
124-C23GN-14
124-C464GN-14
200-C104BK-18
200-C138BK-18
200-C338BK-18
201-C347BK-18
200-C359BK-18
200-C384BK-18
515-C235GY-14
516-C241GN-14
517-C240BU-14
521-C124YL-14
567-C360WH-14
567-C364WH-14
567-C372WH-14
567-C473WH-14
614-C215PU-18
614-C216PU-18
614-C242PU-18
614-C245PU-18
614-C371PU-18
E735-C55PU-18
290-C391BK-18
E708-C247PK-18
443-C399YL-18
138-C43GN-18
200-C345BK-18
200-C346BK-18
138-C37GN-18
C529-C59GY-18
C530-C61BU-18
614-C541PU-18
944-C144OR-18
945-C136BR-18
TWISTED
WIRES
C-C40
1552252
1
2
3
4
5
6
7
8
9
10
11
12
1
2
3
4
5
6
7
8
9
10
11
12
N-C4
3E5178
C-C41
3E5179
CONN 34
403-C401GN-18
138-N5 GN-18
200-N4 BK-18
251-N6 BK-18
138-N11GN-18
C529-N8GY-18
C530-N9BU-18
614-N3 PU-18
944-N1 OR-18
945-N2 BR-18
E416-N7PU-18
TWISTED
WIRES
426-C402BR-18
291-C404BK-18
E707-C250GN-18
C413-C251YL-18
G486-C388GN-18
E455-C403BR-18
N-C3
3E5136
118-C353GY-18
118-C354GY-18
200-C344BK-18
500-C252BR-18
501-C257GN-18
E
D
A
C
B
818-N12BR-18
819-N13GY-18
250-N14BK-18
CUSTOMER
DATA
CONNECTION
502-C253OR-18
506-C10PU-18
A523-C236PU-18
A524-C237BR-18
A525-C238GN-18
CONN 39
251-N15BK-18
188-N16WH-18
E955-N10OR-18
118-C352GY-18
118-C355GY-18
200-C343BK-18
202-C350BK-18
503-C256BR-18
504-C255YL-18
505-C254BU-18
507-C11WH-18
N-C2
1698669
188-N16WH-18
251-N15BK-18
E955-N10OR-18
973-C195BR-18
977-C197YL-18
H728-C198GN-18
H729-C63WH-18
H730-C201BR-18
A
B
C
D
E
F
G
H
J
944-A3 OR-18
945-A4 BR-18
Y795-A5GN-18
Y794-A6OR-18
TWISTED
PAIR
TWISTED
PAIR
CAP PART NUMBER

8C-6354
1
2
C-C67
2234778
C-C38
2234778
202-C396BK-18
C583-C395GN-18
C-C53
1552264
118-C355GY-18
118-C352GY-18
200-C343BK-18
505-C254BU-18
504-C255YL-18
503-C256BR-18
507-C11WH-18
567-C360WH-14
124-C23GN-14
567-C473WH-14
C-C43
2234778
124-C464GN-14
521-C124YL-14
614-C245PU-18
200-C338BK-18
200-C359BK-18
614-C242PU-18
20
13
2
19
15
16
1
24
18
12
5
9
3
4
8
10
11
22
6
23
17
21
7
14
517-C240BU-14
567-C364WH-14
516-C241GN-14
C-C49
2234778
567-C372WH-14
515-C235GY-14
614-C216PU-18
200-C104BK-18
200-C138BK-18
614-C215PU-18
C-C50
2234778
201-C347BK-18
E735-C55PU-18
614-C371PU-18
A
B
C
200-C384BK-18
1
2
3
4
5
6
7
8
9
10
1
2
3
4
5
6
7
8
9
10
A523-C236PU-18
A524-C237BR-18
A525-C238GN-18
118-C354GY-18
118-C353GY-18
200-C344BK-18
502-C253OR-18
501-C257GN-18
500-C252BR-18
506-C10PU-18
614-C7 PU-18
200-C362BK-18
200-C363BK-18
C542-C323GN-18
1
2
3
4
5
6
7
8
AUOTDIG NOT
AVAILABLE ON
IT-62
C-C55 C-C56
1552273 3E3382
HVAC TEMP SELECT POTENT

C-C51 127-4540
1552267
A
B
C
C-C52
1552264
1
2
3
4
5
6
7
8
C216-C386BK-18
T852-C163GY-18
T853-C164OR-18
T854-C165YL-18
T855-C166BU-18
RD-14
BK-14
BR-14
RD-16
RD-16
BK-16
WH-16
YL-16
BU-16
BR-16
WIPER B+
WASHER B+
GROUND
HIGH
LOW
PARK
WASH
202-C350BK-18
973-C195BR-18
977-C197YL-18
H728-C198GN-18
H729-C63WH-18
H730-C201BR-18
C-C54
1552273
762-C494YL-18
961-C495BR-18
964-C496BU-18
C-C57
1552273
1
2
3
4
5
6
202-C351BK-18
X972-C188GN-18
X973-C192BU-18
X974-C200BR-18
1
2
3
4
5
6
C-C97
2234778
614-C497PU-18
200-C498BK-18
200-C499BK-18
614-C500PU-18
200-N4 BK-18
614-N3 PU-18
1
2
3
4
5
6
C-C64
2234778
202-C366BK-18
P910-C38BR-18
136-C310GN-16
727-C289GN-16
614-C501PU-18
FRONT INTER WIPER WASHER SW

110-7886
200-C502BK-18
C-C62
2234778
202-C284BK-18
720-C234PU-18
1
2
3
4
5
6
7
8
9
10
614-C169PU-18
200-C467BK-18
202-C358BK-18
G766-C189GN-18
G767-C190WH-18
202-C85BK-18
N-C5
3T3158
614-C74PU-18
200-C474BK-18
200-C357BK-18
614-C477PU-18
COLOR ABBREVIATIONS
WIRE GROUP COLOR DESCRIPTIONS

GROUND CIRCUIT
WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS OFF
WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS ON
VOLTAGE CONVERTER OUTPUT CIRCUIT
STARTING CIRCUIT
TRANSMISSION CONTROL CIRCUIT
MONITOR CIRCUIT
ENGINE CONTROL CIRCUIT
200-C536BK-16
HEATER AND AIR CONDITIONER CIRCUIT
200-C537BK-18
200-C538BK-18
TURN SIGNAL / WIPER WASHER CIRCUIT

CAT DATA LINK
200-C539BK-18
200-C540BK-18
ABBREV
COLOR
RD
WH
OR
YL
PK
BK
GY
PU
BR
GN
BU
RED
WHITE
ORANGE
YELLOW
PINK
BLACK
GRAY
PURPLE
BROWN
GREEN
BLUE
SYMBOL
CIRCUIT NOT CONNECTED

ELECTRICAL CONNECTION TO
MACHINE STRUCTURE
INTERNAL ELECTRICAL CONNECTION
TO SURFACE OF COMPONENT
CONNECTOR
H#
CIRCUIT GROUPING DESIGNATION

ATCH WIRE, CABLE, COMPONENT
SPLICE
BLADE, SPADE, RING OR SCREW
TERMINAL
C-C65
2234778
IT-62 ONLY
168-C68GN-16
P976-C485BR-16
614-C64PU-18
P976-C486BR-16
200-C484BK-16
1
2
3
4
5
6
7
8
9
10
C-C92
1552269
H703-C478YL-18
H795-C481PK-18
H702-C479PU-18
614-C482PU-18
1
2
3
4
5
6
7
8
9
10
T858-C175GY-18
C216-C376BK-18
T859-C176WH-18
1
2
3
4
5
6
7
8
9
10
1
2
C-C95
2234778
D
1
2
3
4
5
6
7
8
9
10
C-C61
2234778
614-C76PU-18
200-C324BK-18
C-C59
2234778
1
2
3
4
5
6
7
8
9
10
C216-C349BK-18
T856-C155WH-18
C216-C367BK-18
T857-C156GN-18
614-C92PU-18
200-C356BK-18
1
2
3
4
5
6
7
8
9
10
1
2
3
4
5
6
7
8
9
10
HARNESS ASSEMBLIES
IDENT
PART NUMBER
A
260-9602
C
273-0274
E
246-0578
F
192-2823
G
245-8335
H
280-1436
J
236-7775
K
280-1436
L
280-1437
M
280-1437
N
188-1421
T
146-1892
W
121-8039
Y
235-5506
AT
192-7805
AY
154-4563
CA
152-6432
CE
236-7773
CF
236-6207
CR
118-2943
EG
236-7772
WA
276-0031
CHG
01
00
03
01
04
00
01
00
00
00
02
01
01
03
00
01
06
01
01
04
01
01
LOC
F-3
G-18
G-9
L-15
L-15
L-6
L-10
K-6
L-8
K-8
B-9
H-1
H-1
K-7
F-10
H-3
H-3
K-9
L-10
H-3
G-15
I-10
NOTE
SERVICE TOOL
MAIN CAB
IMPLEMENT POD
HVAC
IMPLEMENT POD JOYSTICK (ATTACHMENT)
CAB FLOOD LAMPS (ATTACHMENT)
BEACON (ATTACHMENT)
PAYLOAD CONTROL SYSTEM (ATTACHMENT)
LH PEDAL STOP LAMP SWITCH
DIMMER SWITCH (JAPAN ATTACHMENT)
CAB FLOOD LAMPS (STANDARD)
AIR SEAT
TURN SIGNAL SWITCH (ATTACHMENT)
COMMAND CONTROL STEERING (ATTACHMENT)
CAB HID LIGHTING (ATTACHMENT)
HEATED OUTSIDE MIRRORS (ATTACHMENT)
HORN SWITCH/COMAND CONTROL STEERING
10A VOLT CONVERTER (ATTACHMENT)
GATEWAY PRODUCT LINK (ATTACHMENT))
WIRE ASSEMBLIES
X
121-8038
02
F-2
DIMMER SWITCH JUMPER
PAYLOAD CONTROL CIRCUIT
A
C
B
PART NUMBER: 237-5752, CHANGE: 01, VERSION: -
OTHER COLOR DESCRIPTIONS
RH DOME LAMP
3E-6389
Components are shown installed on a fully operable machine with the key and engine off, transmission shifter
in neutral and with parking brake set.
Refer to the appropriate Service Manual for Troubleshooting, Specifications and Systems Operations.
HIGHWAYS
RD-16
WH-16
BK-16
THIS SCHEMATIC IS FOR THE 950H, 962H, AND IT62H WHEEL LOADER
VOLUME 2 of 2: CAB
IMPLEMENT CONTROL CIRCUIT
200-C206BK-16
1
2
3
4
5
6
7
8
9
10
614-C94PU-18
200-C527BK-18
200-C342BK-18
614-C526PU-18
1
2
3
4
5
6
7
8
9
10
CAN DATA LINK
511-C306BR-18
512-C223GN-18
122-C279RD-16
DESCRIPTION
CIRCUIT CONNECTED
PRODUCT LINK
C-C18
1552267
1
2
3
4
5
6
7
8
9
10
200-C483BK-18
136-C310GN-16
200-C357BK-18
200-C362BK-18
200-C363BK-18
200-C467BK-18
200-C474BK-18
200-C498BK-18
200-C499BK-18
200-C502BK-18
202-C85BK-18
202-C284BK-18
202-C358BK-18
202-C366BK-18
202-C396BK-18
614-C7 PU-18
614-C74PU-18
614-C169PU-18
614-C477PU-18
614-C497PU-18
614-C500PU-18
614-C501PU-18
720-C234PU-18
727-C289GN-16
762-C494YL-18
961-C495BR-18
964-C496BU-18
C542-C323GN-18
C583-C395GN-18
G766-C189GN-18
G767-C190WH-18
P910-C38BR-18
168-C68GN-16
200-C45BK-18
200-C324BK-18
200-C342BK-18
200-C356BK-18
200-C483BK-18
200-C484BK-16
200-C527BK-18
614-C64PU-18
614-C76PU-18
614-C92PU-18
614-C94PU-18
614-C482PU-18
614-C526PU-18
C216-C349BK-18
C216-C365BK-18
C216-C367BK-18
C216-C376BK-18
H702-C479PU-18
H703-C478YL-18
H708-C157OR-18
H709-C158BU-18
H795-C481PK-18
P976-C485BR-16
P976-C486BR-16
T856-C155WH-18
T857-C156GN-18
T858-C175GY-18
T859-C176WH-18
H709-C158BU-18
C216-C365BK-18
H708-C157OR-18
200-C45BK-18
C-C60
2234778
202-C351BK-18
C216-C386BK-18
T852-C163GY-18
T853-C164OR-18
T854-C165YL-18
T855-C166BU-18
X972-C188GN-18
X973-C192BU-18
X974-C200BR-18
CONN 44
SERVICE
TOOL CONNECTOR
DASH
N-C1
7X6222
C530-N9BU-18
C529-N8GY-18
251-N6 BK-18
944-N1 OR-18
945-N2 BR-18
E416-N7PU-18
138-N5 GN-18
138-N11GN-18
A-C1
9W1951
147-A1 RD-18
200-A2 BK-18
C-C72
7T5957
PANEL B
1
2
3
4
5
6
592-C8 BU-16
200-C335BK-16
A
B
C
136-C515GN-16
200-C516BK-16
439-C513YL-18
122-C279RD-16
200-C206BK-16
511-C306BR-18
512-C223GN-18
10
C-C48 A-C2
1552273 3E3382
CONN 43
136-C515GN-16
E735-C86PU-18
A105-C151OR-18
E917-C152WH-18
E918-C153GN-18
H710-C171PK-18
H711-C172GN-18
T860-C161OR-18
T861-C162YL-18
T869-C168WH-18
T870-C167BR-18
X998-C154BR-18
11
608-C294GN-14
1
2
615-K5 YL-14
615-K6 YL-14
CONN 38
200-M4 BK-14
200-M6 BK-14
608-M5 GN-14
200-M6 BK-14
603-C297PK-16
PANEL B
CAB GROUND 2
16
200-C230BK-12
TWISTED WIRES
118-C274GY-18
138-C20GN-18
150-C97OR-16
150-C126OR-16
200-C209BK-14
200-C210BK-18
201-C135BK-18
201-C304BK-16
A272-C35BK-14
C216-C26BK-16
C216-C148BK-18
C216-C149BK-18
C529-C60GY-18
C530-C62BU-18
E919-C51YL-18
E920-C52BR-18
E921-C53PK-18
E922-C54GN-18
H713-C57PK-18
H714-C58OR-18
H717-C67BR-18
H718-C225GY-18
J813-C226BK-14
J814-C286BK-14
K927-C108BU-18
P945-C270OR-18
P946-C303BR-18
Y794-C25OR-18
Y795-C114GN-18
FUSE PANEL/ELECTRICAL INSTALLATION
17
1
2
CONN 31
200-C520BK-14
200-C528BK-14
E735-C86PU-18
615-K5 YL-14
200-K3 BK-14
200-Y2 BK-14
M-C1 Y-C6
3E3364 1552269
164-G8 WH-18
A513-C339RD-16
112-C1 PU-4
105-C455RD-16
944-C458OR-18
945-C459BR-18
201-C304BK-16
118-C275GY-18
118-C258GY-16
118-C274GY-18
124-C23GN-14
124-C464GN-14
126-C299PK-16
127-C336OR-14
130-C5 RD-16
131-C265BR-18
133-C427RD-18
133-C428OR-16
134-C337YL-14
136-C310GN-16
136-C515GN-16
413-C33BR-18
C-C8
1471446
J2
164-C264WH-18
164-C276WH-18
121-C228RD-14
121-C361RD-14
150-C98OR-16
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
944-C141OR-18
945-C134BR-18
T866-C174YL-18
121-C150RD-14
121-C133RD-14
121-C170RD-14
608-M3 GN-14
200-M4 BK-14
1
2
1
2
3
4
5
6
7
8
9
10
11
12
200-C260BK-12
200-C334BK-16
G787-G15GN-18
202-G16BK-18
P916-G20OR-18
P915-G21PK-18
202-G31BK-18
G788-G22YL-18
614-G29PU-18
200-G27BK-18
200-G23BK-18
614-G24PU-18
508-C302PU-18
509-C340WH-18
603-C297PK-16
651-C239PK-14
A629-C300BU-14
413-C33BR-18
150-C98OR-16
K-C3
1552269
200-Y4 BK-14
608-Y1 GN-14
608-Y3 GN-14
608-M5 GN-14
608-M3 GN-14
ELECTRICAL STUDS PASS

THROUGH THE CAB ROOF
CONNECTING TO TERMINALS
ON THE CHASSIS
AND ENGINE DIAGRAMS
FOR PART NUMBERS SEE THE
TITLE BLOCK
651-C239PK-14
CABLE AS. 124-4885
608-CE13GN-14
200-CE14BK-14
108-C271BU-14
122-C278RD-16
151-C159GN-16
164-C276WH-18
200-C204BK-14
200-C208BK-16
200-C230BK-12
200-C260BK-12
200-C309BK-16
200-C311BK-18
200-C320BK-18
200-C369BK-18
200-C370BK-18
200-C468BK-18
608-C294GN-14
C542-C506GN-16
H722-C301GN-18
EG-C4 EG-C6
1552272 3E3376
A273-C409BK-14
A273-C408BK-14
A273-C417BK-14
1
2
C542-C506GN-16
A629-C300BU-14
DASH
CE-C8
1552269
T860-C161OR-18
T861-C162YL-18
T869-C168WH-18
T870-C167BR-18
X998-C154BR-18
CONNECTIONS FOR COMMUNICATIONS RADIO
121-EG1RD-18
115-EG2PK-18
200-EG3BK-18
608-M3 GN-14
200-M4 BK-14
651-CE7PK-14
200-CE8BK-14
A105-C151OR-18
E917-C152WH-18
E918-C153GN-18
H710-C171PK-18
H711-C172GN-18
142-EG11BU-18
142-EG7BU-18
1
2
H-C3
1552269
615-H5 YL-14
200-H3 BK-14
651-Y9 PK-14
651-Y6 PK-14
M-C2
1552269
608-Y3 GN-14
200-Y10BK-14
200-Y7 BK-14
608-L5 GN-14
200-L6 BK-14
C-C6
1552267
LH DOME LAMP
3E-6389
RD-16
WH-16
BK-16
200-H3 BK-14
615-H5 YL-14
WA-C3
1607690
TWISTED WIRES
CONN 30
1
2
200-H2 BK-14
200-H3 BK-14
608-Y1 GN-14
L-C3
1552269
200-H2 BK-14
615-H6 YL-14
615-H4 YL-14
200-H1 BK-14
CONN 36
200-L4 BK-14
200-L6 BK-14
CE-C3
1552269
E746-C44GN-18
G787-C418GN-18
H722-C301GN-18
202-C71BK-18
P916-C421OR-18
P915-C422PK-18
G788-C423YL-18
24V FLASHE
A629-CE6BU-14
200-CE4BK-14
1
2
651-Y9 PK-14
200-Y7 BK-14
615-H5 YL-14
615-H6 YL-14
200-C230BK-12
200-C260BK-12
603-C297PK-16
608-C294GN-14
651-C239PK-14
A629-C300BU-14
C542-C506GN-16
A
C
B
LH REAR SPEAKER
168-8772
+
-
122-C278RD-16
IMPLEMENT POD (JOYSTICK)
Y795-WA8GN-18
C-C63
C-C37 3E5179
1552252
1
2
CAB HID LIGHT HARNESS (ATTACHMENT)
N973-WA6BR-18
N979-WA7GN-18
104-C456YL-16
105-C455RD-16
201-C304BK-16
403-C457GN-18
944-C458OR-18
945-C459BR-18
Y794-C435OR-18
Y795-C444GN-18
508-C302PU-18
509-C340WH-18
Y794-C450OR-18
1
2
3
4
5
6
7
8
9
10
11
12
N960-WA4OR-18
N979-WA7GN-18
N970-WA5YL-18
N973-WA6BR-18
944-WA1OR-18
945-WA2BR-18
Y794-WA9OR-18
Y795-WA8GN-18
118-C274GY-18
200-C209BK-14
200-C210BK-18
503-C256BR-18
504-C255YL-18
505-C254BU-18
515-C235GY-14
516-C241GN-14
517-C240BU-14
522-C125WH-18
592-C392BU-16
A523-C236PU-18
A524-C237BR-18
A525-C238GN-18
105-C455RD-16
201-C304BK-16
944-C458OR-18
945-C459BR-18
18
125-WA17RD-18
200-WA19BK-18
308-WA21YL-18
403-WA23GN-18
N957-WA3PK-18
125-WA10RD-18
200-WA25BK-16
200-WA15BK-18
308-WA16YL-18
403-WA11GN-18
N957-WA3PK-18
N960-WA4OR-18
N970-WA5YL-18
N973-WA6BR-18
N979-WA7GN-18
104-C456YL-16
105-C455RD-16
201-C304BK-16
403-C457GN-18
522-C125WH-18
944-C458OR-18
945-C459BR-18
Y794-C435OR-18
Y795-C444GN-18
1
2
3
4
5
6
A629-CE5BU-14
200-CE3BK-14
1
2
200-CE12BK-14
200-WA15BK-18
200-WA25BK-16
200-WA19BK-18
125-WA17RD-18
125-WA10RD-18
200-WA20BK-18
608-L5 GN-14
200-L6 BK-14
WA-C2
1552252
N960-WA4OR-18
N970-WA5YL-18
C-C99
2469371
C530-C62BU-18
C530-C61BU-18
H795-C480PK-18
200-C210BK-18
118-C274GY-18
503-C256BR-18
505-C254BU-18
403-WA24GN-18
N981-WA14GN-18
N963-WA12OR-18
N959-WA13PK-18
950/962 ONLY
C543-C407GY-18
C583-C395GN-18
E455-C403BR-18
E701-C405PK-18
E746-C44GN-18
E919-C51YL-18
E920-C52BR-18
E921-C53PK-18
E922-C54GN-18
G479-C315WH-18
G480-C316GN-18
G485-C385BU-18
G486-C388GN-18
G746-C13WH-18
G750-C196BU-18
G755-C186GY-18
G760-C191WH-18
G761-C229YL-18
G762-C231BR-18
G763-C185PU-18
G766-C189GN-18
G767-C190WH-18
G768-C187GN-18
G787-C418GN-18
G788-C423YL-18
G848-C378GN-18
G850-C29BU-18
H702-C479PU-18
H703-C478YL-18
H713-C57PK-18
H714-C58OR-18
H717-C67BR-18
H718-C225GY-18
H728-C198GN-18
H729-C63WH-18
H730-C201BR-18
TWISTED
WIRES
605-C90YL-16
C530-C49BU-18
BK-16
GY-16
BR-16
OR-16
504-C255YL-18
TO INSURE PROPER GROUND

REMOVE PAINT AND
CORROSION BEFORE
CONNECTING GROUND STRAP
ENG END FRAME GND
202-C544BK-18
403-C401GN-18
426-C402BR-18
432-C387PK-18
439-C513YL-18
442-C381GY-18
443-C399YL-18
447-C380PK-18
503-C256BR-18
504-C255YL-18
505-C254BU-18
506-C10PU-18
507-C11WH-18
515-C235GY-14
516-C241GN-14
517-C240BU-14
521-C124YL-14
567-C360WH-14
567-C364WH-14
567-C372WH-14
567-C473WH-14
614-C137PU-16
720-C234PU-18
727-C289GN-16
762-C494YL-18
964-C496BU-18
973-C195BR-18
977-C197YL-18
A523-C236PU-18
A524-C237BR-18
A525-C238GN-18
C216-C545BK-18
C529-C59GY-18
C530-C61BU-18
C583-C395GN-18
E455-C403BR-18
G485-C385BU-18
G486-C388GN-18
G766-C189GN-18
G767-C190WH-18
H702-C479PU-18
H703-C478YL-18
H728-C198GN-18
H729-C63WH-18
H730-C201BR-18
H795-C481PK-18
P910-C38BR-18
P976-C77BR-16
X972-C188GN-18
X973-C192BU-18
X974-C200BR-18
604-C78OR-16
C529-C48GY-18
B+
4
1
2
6
3
5
C-C45
1552273
608-Y1 GN-14
200-Y2 BK-14
1
2
Y-C2 H-C1
1552269 3E3364
CONN 35
1
2
200-CE10BK-14
125-WA10RD-18
200-WA25BK-16
200-WA15BK-18
308-WA16YL-18
403-WA11GN-18
PK-18
BK-18
592-C272BU-16
592-C8 BU-16
592-C122BU-16
592-C202BU-16
C216-C373BK-18
200-CE4BK-14
1
2
CE-C2
1552269
125-WA18RD-18
202-C71BK-18
320-C317OR-16
614-C96PU-18
614-C181PU-18
614-C199PU-18
614-C321PU-18
614-C322PU-18
614-C469PU-18
987-C160WH-16
C216-C314BK-18
C216-C24BK-18
C216-C217BK-18
E746-C44GN-18
G787-C418GN-18
G788-C423YL-18
P915-C422PK-18
P916-C421OR-18
567-C372WH-14
567-C360WH-14
567-C473WH-14
567-C364WH-14
C216-C22BK-16
GN-16
REAR WIPER MOTOR

1555789
EG-C1
1552273
CE-C1
1552269
HEATED OUTSIDE MIRRORS HARNESS (ATTACHMENT)
A273-C408BK-14
A273-C409BK-14
A273-C417BK-14
439-C511YL-18
439-C512YL-18
439-C513YL-18
606-C80GY-16
484-C140YL-18
987-C160WH-16
H718-C225GY-18
611-C32PU-14
106-C18WH-18
114-C41RD-16
138-C20GN-18
A958-C518WH-18
C216-C22BK-16
322-C39GY-16
J815-C84BK-14
976-C116OR-18
C529-C48GY-18
C530-C49BU-18
K927-C108BU-18
E919-C51YL-18
E920-C52BR-18
E921-C53PK-18
E922-C54GN-18
G485-C385BU-18
G486-C388GN-18
H713-C57PK-18
H714-C58OR-18
P739-C493BU-16
727-C289GN-16
453-C119PK-18
201-C135BK-18
417-C183GY-18
447-C380PK-18
J813-C226BK-14
H717-C67BR-18
N939-C112GN-18
416-C184OR-18
102-C69RD-14
Y794-C425OR-18
Y795-C426GN-18
306-C109GN-18
J814-C286BK-14
P976-C77BR-16
GND
T
320-C319OR-16
320-C390OR-16
320-C317OR-16
426-C402BR-18
430-C313BU-18
432-C387PK-18
436-C47OR-18
506-C10PU-18
507-C11WH-18
E455-C403BR-18
G764-C117PK-18
CF-C2
1552269
200-CE3BK-14
CE-C6
1552269
CONN 27
403-C401GN-18
403-C457GN-18
110-C66RD-14
174-C2 RD-10
C542-CF3GN-14
200-CF4BK-14
608-L1 GN-14
200-L2 BK-14
L-C1 Y-C1
3E3364 1552269
200-Y2 BK-14
200-Y4 BK-14
615-CE11YL-14
200-CE12BK-14
H MOTOR
102-C69RD-14
104-C46YL-16
202-C31BK-16
202-C143BK-18
307-C3 OR-18
308-C87YL-18
320-C319OR-16
326-C287PU-18
430-C313BU-18
436-C47OR-18
592-C8 BU-16
592-C122BU-16
592-C202BU-16
604-C78OR-16
605-C91YL-16
606-C89GY-16
611-C32PU-14
614-C325PU-16
615-C318YL-18
617-C83BR-16
619-C40GN-14
910-C15YL-18
A307-C129GY-18
A982-C130BR-18
C216-C508BK-18
E701-C405PK-18
G479-C315WH-18
G480-C316GN-18
G746-C13WH-18
G750-C196BU-18
G755-C186GY-18
G760-C191WH-18
G761-C229YL-18
G762-C231BR-18
G763-C185PU-18
G768-C187GN-18
G848-C378GN-18
G850-C29BU-18
H795-C222PK-18
Y794-C450OR-18
Y795-C451GN-18
170-C101RD-14
170-C146RD-14
322-C39GY-16
326-C287PU-18
403-C123GN-18
403-C81GN-18
200-CF2BK-14
200-CF4BK-14
1
2
HVAC UNIT
GND STRAP
8X-5802
608-L5 GN-14
608-L3 GN-14
615-CE9YL-14
615-CE11YL-14
104-C456YL-16
105-C455RD-16
201-C304BK-16
403-C457GN-18
522-C125WH-18
944-C458OR-18
945-C459BR-18
Y794-C435OR-18
Y795-C444GN-18
104-C456YL-16
104-C46YL-16
104-C30YL-16
202-C4 BK-18
202-C27BK-18
202-C113BK-16
202-C19BK-18
307-C3 OR-18
308-C87YL-18
C542-CF1GN-14
200-CF2BK-14
CF-C1
1552269
PRODUCT LINK ATTACHMENT
TWISTED
WIRES
102-C69RD-14
174-C2 RD-10
199-C72RD-16
200-C210BK-18
200-C209BK-14
201-C135BK-18
C542-CF3GN-14
C542-CF1GN-14
592-C392BU-16
A525-C238GN-18
A524-C237BR-18
A523-C236PU-18
517-C240BU-14
516-C241GN-14
515-C235GY-14
200-C209BK-14
522-C125WH-18
200-F4 BK-14
Y794-C374OR-18
Y795-C375GN-18
170-C107RD-14
170-C99RD-14
170-C70RD-14
1
2
3
4
5
6
7
8
9
10
11
12
A629-CE5BU-14
A629-CE6BU-14
453-C119PK-18
416-C184OR-18
J764-C273BR-18
608-L3 GN-14
200-L4 BK-14
651-CE1YL-14
200-CE2BK-14
516-F9 GN-14
517-F10BU-14
522-F12WH-14
F524-F14BR-18
522-F12WH-14
G764-C117PK-18
419-C118YL-18
C-C33
1471446
CE-C4
1552269
CONN 29
515-F7 GY-14
515-F8 GY-14
517-F10BU-14
F-C1 C-C21
3E5179 1552252
200-C208BK-16
135-F16BU-18
515-F6 GY-14
118-C274GY-18
200-C209BK-14
200-C210BK-18
503-C256BR-18
504-C255YL-18
505-C254BU-18
515-C235GY-14
516-C241GN-14
517-C240BU-14
592-C392BU-16
A523-C236PU-18
A524-C237BR-18
A525-C238GN-18
605-C91YL-16
728-C106BU-18
P990-C461BR-18
202-C4 BK-18
308-C87YL-18
419-C118YL-18
135-F18BU-18
135-A17BU-16
515-F8 GY-14
615-H6 YL-14
200-H2 BK-14
608-L3 GN-14
200-L4 BK-14
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
515-F7 GY-14
G750-C196BU-18
605-C79YL-16
110-C472RD-14
F525-F15GN-18
200-F1 BK-14
200-F2 BK-18
200-F3 BK-14
200-F4 BK-14
200-F5 BK-18
150-C97OR-16
170-C99RD-14
170-C70RD-14
170-C107RD-14
202-C19BK-18
202-C27BK-18
202-C113BK-16
307-C3 OR-18
403-C123GN-18
436-C47OR-18
720-C234PU-18
910-C15YL-18
944-C110OR-18
945-C105BR-18
973-C195BR-18
977-C197YL-18
A272-C35BK-14
A273-C408BK-14
A273-C409BK-14
A273-C417BK-14
C543-C407GY-18
C583-C395GN-18
E701-C405PK-18
E746-C44GN-18
G480-C316GN-18
G746-C13WH-18
G750-C196BU-18
G755-C186GY-18
G760-C191WH-18
G761-C229YL-18
G762-C231BR-18
G763-C185PU-18
G766-C189GN-18
G767-C190WH-18
G768-C187GN-18
G787-C418GN-18
G788-C423YL-18
G848-C378GN-18
H728-C198GN-18
H729-C63WH-18
H730-C201BR-18
J764-C273BR-18
J887-C490PU-18
P910-C38BR-18
P915-C422PK-18
P916-C421OR-18
X972-C188GN-18
X973-C192BU-18
X974-C200BR-18
Y794-C374OR-18
Y795-C375GN-18
751-C115GN-18
754-C142BU-18
K977-C205PK-18
112-C1 PU-4
200-F3 BK-14
515-F7XXGY-14
516-F9 GN-14
H-C2
1552269
1
2
3
4
5
6
7
135-F16BU-18
F525-F15GN-18
F524-F14BR-18
F523-F13PU-18
517-F10BU-14
516-F9 GN-14
515-F6 GY-14
200-F1 BK-14
522-F12WH-14
J815-C491BK-18
752-C111YL-18
E746-C44GN-18
751-C115GN-18
752-C111YL-18
J809-C460BK-18
E900-C207WH-18
J808-C194BK-18
J807-C193BK-18
E906-C221OR-18
E908-C227BR-18
754-C142BU-18
E901-C203GN-18
C-C2
8N1532
F-C4
1698668
L-C2
1552269
608-CE15GN-14
200-CE16BK-14
615-CE9YL-14
200-CE10BK-14
J815-C84BK-14
J809-C460BK-18
1
2
CE-C7
1552269
CE-C5
1552269
200-F2 BK-18
550-F11GY-14
1
2
1
2
BEACON ATTACHMENT HARNESS
F523-F13PU-18
200-F5 BK-18
F524-F14BR-18
135-A17BU-16
1
2
1
2
200-J2 BK-14
135-F18BU-18
J815-C492BK-14
J808-C194BK-18
J764-C273BR-18
A273-C417BK-14
J764-C273BR-18
900-C147PU-18
901-C121WH-18
F-C3
522-F12WH-14
170-C99RD-14
901-C121WH-18
755-C120OR-18
J807-C193BK-18
900-C147PU-18
C-C26
9X0145
E907-C246GY-18
E909-C218WH-18
755-C120OR-18
306-C109GN-18
321-C249BR-18
416-C184OR-18
417-C183GY-18
419-C118YL-18
450-C263YL-18
453-C119PK-18
484-C140YL-18
728-C106BU-18
751-C115GN-18
752-C111YL-18
754-C142BU-18
755-C120OR-18
900-C147PU-18
901-C121WH-18
976-C116OR-18
A958-C518WH-18
E900-C207WH-18
E901-C203GN-18
E906-C221OR-18
E907-C246GY-18
E908-C227BR-18
E909-C218WH-18
G764-C117PK-18
J807-C193BK-18
J808-C194BK-18
J809-C460BK-18
K977-C205PK-18
N939-C112GN-18
P990-C461BR-18
E908-C227BR-18
E909-C218WH-18
439-C510YL-18
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
1
2
3
4
5
6
944-C110OR-18
321-C249BR-18
A273-C408BK-14
J-C1
1552269
603-J1 PK-14
200-J2 BK-14
603-J1 PK-14
TWISTED WIRES
306-C109GN-18
321-C249BR-18
416-C184OR-18
417-C183GY-18
419-C118YL-18
450-C263YL-18
453-C119PK-18
484-C140YL-18
728-C106BU-18
751-C115GN-18
752-C111YL-18
754-C142BU-18
755-C120OR-18
900-C147PU-18
901-C121WH-18
976-C116OR-18
A958-C518WH-18
E900-C207WH-18
E901-C203GN-18
E906-C221OR-18
E907-C246GY-18
E908-C227BR-18
E909-C218WH-18
G764-C117PK-18
J807-C193BK-18
J808-C194BK-18
J809-C460BK-18
J815-C84BK-14
K977-C205PK-18
N939-C112GN-18
P990-C461BR-18
150-C97OR-16
170-C70RD-14
170-C107RD-14
170-C99RD-14
202-C19BK-18
202-C27BK-18
202-C113BK-16
307-C3 OR-18
403-C123GN-18
436-C47OR-18
720-C234PU-18
910-C15YL-18
944-C110OR-18
945-C105BR-18
973-C195BR-18
977-C197YL-18
A272-C35BK-14
A273-C408BK-14
A273-C409BK-14
A273-C417BK-14
C543-C407GY-18
C583-C395GN-18
E701-C405PK-18
E746-C44GN-18
G480-C316GN-18
G746-C13WH-18
G750-C196BU-18
G755-C186GY-18
G760-C191WH-18
G761-C229YL-18
G762-C231BR-18
G763-C185PU-18
G766-C189GN-18
G768-C187GN-18
G767-C190WH-18
G787-C418GN-18
G788-C423YL-18
G848-C378GN-18
H728-C198GN-18
H729-C63WH-18
H730-C201BR-18
J764-C273BR-18
J815-C491BK-18
J887-C490PU-18
P910-C38BR-18
P915-C422PK-18
P916-C421OR-18
X972-C188GN-18
X973-C192BU-18
X974-C200BR-18
Y794-C374OR-18
Y795-C375GN-18
C-C31
1471445
STRAP AS.
17
36 Page,
18

Cat - Dcs.sis - Controller Electrico 962h

Uploaded by

Copyright:

Available Formats

Cat - Dcs.sis - Controller Electrico 962h

Uploaded by

Document Information

Original Description:

Original Title

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

Cat - Dcs.sis - Controller Electrico 962h

Uploaded by

Copyright:

Available Formats

101

Park Brake Lever Sw to Gnd

Implement Control Reversing Fan Sw (N.O.)

Tilt / Lift Position Sensors

Implement Control Reversing Fan Sw (N.C.)

Implement Control Reversing Fan Sol

Main Power Relay Output

Implement Control Lift Proportional Sol

Warning Horn (Forward)

Implement Control Lower Proportional Sol

Implement Control Pilot Press Sol

LH/RH Dash Indicator Panel

Implement Control Tilt Cylinder Position

Fan Control Sol Positive

Auto Lube Pump To Payload Monitor

Fan Control Sol Return

Beacon / Heated Mirror

Throttle Sensor Common

Rotary Tilt Position Sensor

Xmsn Oil Temperature Sensor Ground

ECAP/Center Dash Indicator Panel/Autolube

Engine ECM/Implement ECM/Transmission ECM

Axle Cooler Clutch

Unswitched Fuse Bus Power

Axle Cooler Clutch

Hood Actuator Breaker

Boost Pressure Sensor Ground

Atmospheric Press Sensor

Expanded Can Data Link +

Operator Monitor Return

Expanded Can Data Link -

Front Guard Motor

Front Guard Motor

Rotary Tilt Position Sensor

Engine ECM Sensor +5v

Engine ECM Pressure Sensor Return

Engine ECM Pressure Sensor +5v

Start Relay to Starter Motor

Engine ECM Pressure Sensor Common

Start Relay to Transmission ECM

Engine ECM Temperature Sensor Common

Main Power Relay Coil

Engine Injection Actuation Pressure

Backup Alarm Lamp Travel Alarm

Inlet Air Heater

Warning Horn (Forward)

Injection Actuation Press Cont Valve

Key Sw 'C' Term.

Injection Actuation Press Cont Valve Common

Hood Raise Motor

Hood Raise Motor

Hood Raise Relay Coil

Transmission Clutch 4 5 6 Return

Hood Raise Relay Coil

Transmission Clutch 1 3 Return

Transmission Clutch 2 Return

Implement Solenoid Control Return

Alternator (R) Term.