Scribd
Upload
209 views1 page

GA Boiler

powerplant boiler,supercritical boiler and its working. It explains all the thermodynamic and mechanical working of supercritical boiler.

Uploaded by

Samridh Sharma
Copyright
© © All Rights Reserved
We take content rights seriously. If you suspect this is your content, claim it here.
Available Formats
Download as PPT, PDF, TXT or read online on Scribd
209 views1 page

GA Boiler

powerplant boiler,supercritical boiler and its working. It explains all the thermodynamic and mechanical working of supercritical boiler.

Uploaded by

Samridh Sharma
Copyright
© © All Rights Reserved
We take content rights seriously. If you suspect this is your content, claim it here.
Available Formats
Download as PPT, PDF, TXT or read online on Scribd
You are on page 1/ 1

MUNDRA

M
UNDRA

Thermal
Power
Plant
ULTRA
MEGA
POWER
PLANT

UNIT 17~&
58
( 800MW
X 5 x) 2)
Units
(500MW
SUPERCRITICAL
COAL
FIRED
STEAM
GENERATOR
Supercritical Coal
Fired
Steam
Generator

BOILER SPEC.

DESCRIPTION OF COMPONENTS
1 FEED WATER PIPE

32 REHEATER REAR FINAL ASSEMBLIES

2 ECONOMIZER INLET HEADER

33 REHEATER OUTLET HEADER

3 ECONOMIZER ASSEMBLIES

34 REHEATER OUTLET PIPES (HRH)

4 ECONOMIZER HANGER TUBES

35 FLASH TANK VENT PIPE

5 ECONOMIZER HANGER TUBE OUTLET HEADER

36 SILENCERS (PSV, ERV, START UP VENT)

BOILER TYPE

Supercritical Once-Thru Boiler


MAIN STEAM

1,672

Ton/Hr

REHEATER

1,325

Ton/Hr

PRESS.
CONDITION

MAIN STEAM

255

Kg/cm2g

REHEATER

53.6

Kg/cm2g

MAIN STEAM

569

REHEATER

596

CAPACITY

6 FURNACE LOWER RING HEADERS

37 F.D. FAN SUCTION W/SILENCERS

TEMP.
CONDITION

7 FURNACE SPIRAL W/W TUBES

38 FORCED DRAFT FANS

FUEL

Hi-Vol. c , Bit. Coal

8 FURNACE VERTICAL W/W TUBES

39 SECONDARY AIR DUCT TO GAS AIR PREHEATERS

FIRING SYSTEM

Low Nox Tangential Burners

9 FURNACE UPP. FRONT HEADER

40 STEAM COIL AIR HEATERS

DRAFT STSTEM

Balanced

FURNACE TYPE

Spiral Wound / Vertical Wall

10 FURNACE UPP. REAR HEADER

41 GAS AIR PREHEATERS

11 WATER SEPARATORS

42 HOT SECONDARY AIR DUCT TO WINDBOX

12 SEPARATOR STORAGE TANK

43 WINDBOX & TILTING TANGETIAL BURNER

13 FLASH TANK

44 SCANNER & COOLING AIR FANS

14 CONDENSATE RECEIVING TANK

45 PRIMARY AIR FANS

15 CONDENSATE DRAIN TRANSFER PUMPS

46 HOT PRIMARY AIR DUCT TO MILLS

16 BOILER WATER RECIRCULATING PUMP

47 COLD PRIMARY AIR DUCT TO MILLS

17 BACKPASS LOWER SIDE HEADERS

48 MIXED HOT AIR DUCT TO MILLS

18 BACKPASS SIDE WALL TUBES

49 COAL TRIPPER CONVEYOR ROOM

19 BACKPASS UPPER SIDE WALL INLET HEADERS

50 COAL SILOS

RETRACTABLE SOOTBLOWER-DOUBLE SIDE

20 BACKPASS LOWER REAR HEADER

51 COAL FEEDERS

HALF TRACT SOOTBLOWER-DOUBLE SIDE

21 L.T.S.H. HORIZONTAL ASSEMBLIES

52 COAL MILLS (PULVERIZER)

FURNACE TEMPERATURE PROBE

22 L.T.S.H. PENDANT ASSEMBLIES

53 COAL PIPNG

FURNACE MONITORING CAMERA (CCTV)

23 L.T.S.H. OUTLET HEADER

54 FURNACE BOTTOM ASH HOPPER

24 SUPERHEATER DIV. PANELETTES

55 ECONOMIZER OUTLET FLUE GAS DUCT

25 SUPERHEATER FINAL INLET HEADER

56 ELECTROSTATIC PRECIPITATOR

26 SUPERHEATER FINAL ASSEMBLIES

57 INDUCED DRAFT FANS

27 SUPERHEATER FINAL OUTLET HEADERS

58 FLUE GAS DUCT TO STACK

28 SUPERHEATER OUTLET PIPES (MS)

59 STACK

29 REHEATER INLET PIPES (CRH)

60 STEAM COIL AIR HEATER DRAIN TANK

30 REHEATER INLET HEADER

61 MILL SEAL AIR FANS

31 REHEATER FRONT PLATTEN ASSEMBLIES

62 PENT HOUSE VENTILATION FANS

LEGEND & ABBREVIATIONS


ACCESS DOOR
ACCESS DOOR IN ROOF EMCLOSURE
OBSERVATION DOORS

TURBINE BUILDING

WALL BLOWER

CLIENT :

ENGINEER :

CONTRACTOR :

You might also like