F3001 Service Manual

VHF TRANSCEIVERS
S-14621XZ-C1
Dec. 2009
INTRODUCTION
CAUTION
This service manual describes the latest technical

information for the IC-F3001/F3002/F3003/F3006/F3008
VHF TRANSCEIVERS TRANSCEIVER, at the time of
publication.
NEVER connect the transceiver to an AC outlet or to a DC

power supply that uses more than the specified voltage.
This will ruin the transceiver.
To upgrade quality, any electrical or mechanical parts

and internal circuits are subject to change without notice
or obligation.
MODEL
VERSION
CHANNEL
SPACING
(kHz)
FREQUENCY
RANGE
(MHz)
DO NOT expose the transceiver to rain, snow or any liquids.

DO NOT reverse the polarities of the power supply when
connecting the transceiver.
DO NOT apply an RF signal of more than 20 dBm (100 mW) to
the antenna connector. This could damage the transceivers
front-end.
USA-11
IC-F3001
USA-12
15.0/25.0
USA-13
EUR-21
EUR-22
IC-F3002
EUR-23
UK-01
15.0/20.0/25.0
UK-02
UK-03
EXP-11
EXP-12
EXP-13
136174
EXP-21
EXP-22
IC-F3003
EXP-23
EXP-01
EXP-03
EXP-31
15.0/25.0
AUS-21
AUS-22
AUS-23
RUS-21
IC-F3006
RUS-22
IC-F3008
CHN-31
RUS-23
(IC-F3001)
ORDERING PARTS
REPAIR NOTES
Be sure to include the following four points when ordering

replacement parts:
1. Make sure that the problem is internal before

disassembling the transceiver.
2. DO NOT open the transceiver until the transceiver is
disconnected from its power source.
3. DO NOT force any of the variable components. Turn
them slowly and smoothly.
4. DO NOT short any circuits or electronic parts. An
insulated tuning tool MUST be used for all adjustments.
5. DO NOT keep power ON for a long time when the
transceiver is defective.
6. DO NOT transmit power into a Standard Signal
Generator or a Sweep Generator.
7. ALWAYS connect a 50 dB to 60 dB attenuator between
the transceiver and a Deviation Meter or Spectrum
Analyzer, when using such test equipment.
8. READ the instructions of the test equipment throughly
before connecting it to the transceiver.
1. 10-digit Icom part number

2. Component name
3. Equipment model name and unit name
4. Quantity required
<ORDER EXAMPLE>
1110003491 S.IC
TA31136FNG IC-F3001
8820001210 Screw 2438 screw
IC-F3003
MAIN UNIT
5 pieces
Top cover
10 pieces
Addresses are provided on the inside back cover for your

convenience.
Icom, Icom Inc. and the Icom logo are registered trademarks of Icom Incorporated (Japan) in Japan, the United States, the
United Kingdom, Germany, France, Spain, Russia and/or other countries.
TABLE OF CONTENTS
SECTION
SPECIFICATIONS
SECTION
INSIDE VIEWS
SECTION
DISASSEMBLY INSTRUCTION
SECTION
CIRCUIT DESCRIPITON
SECTION
4-1
RECEIVER CIRCUITS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-1
4-2
TRANSMITTER CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-2
4-3
FREQUENCY SYNTHESIZER CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-3
4-4
VOLTAGE BLOCK DIAGRAM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-3
4-5
PORT ALLOCATIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-4
ADJUSTMENT PROCEDURES
5-1
PREPARATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-1
5-2
FREQUENCY ADJUSTMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-5
5-3
TRANSMIT ADJUSTMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-6
5-4
RECEIVE ADJUSTMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-7
SECTION
PARTS LIST
SECTION
MECHANICAL PARTS
SECTION
BOARD LAYOUTS
SECTION
BLOCK DIAGRAM
SECTION
10 VOLTAGE DIAGRAM
SECTION 1.
SPECIFICATIONS
M GENERAL
Frequency range
Number of conventional channels
Type of emission
Antenna impedance
Operating temperature range
Power supply voltage
Current drain (Approx.)
Dimensions
(Projections not included, approx.)
Weight
: 136174 MHz
: 16 channels
: [EUR]
Wide: 16K0F3E (25.0 kHz)
Middle: 14K0F3E (20.0 kHz)
Narrow: 8K50F3E (12.5 kHz)
Except [EUR] Wide: 16K0F3E (25.0 kHz)
Narrow: 11K0F3E (12.5 kHz)
: 50 (Nominal)
: 30C to +60C; 22F to +140F
Except [EUR], [UK]
25C to +55C
[EUR], [UK]
: Specified Icom's battery packs only (7.2 V DC; negative ground)
: Receiving
75 mA (stand-by)
330 mA (max. audio)
Transmitting 1.3 A (at 5.0 W)
: With BP-264 58.0 (W)111.0 (H)31.0 (D) mm; 2 5/16 (W)4 38 (H)1 732 (D) in.
With BP-265 58.0 (W)111.0 (H)35.5 (D) mm; 2 5/16 (W)4 38 (H)1 1332 (D) in.
: With BP-264 Approx. 330 g; 11 21/32 oz.
With BP-265 Approx. 270 g; 9 17/32 oz.
M TRANSMITTER
Output power
Modulation
Maximum frequency deviation
: 5W
: Variable reactance frequency modulation
: Narrow
2.5 kHz
Middle
4.0 kHz
Wide
5.0 kHz
Frequency stability
: 2.5 ppm
Spurious emissions
: 70 dB min.
0.25 W (1 GHz), 1.0 W (>1 GHz)
Adjacent channel power
: Narrow
60 dB min., 70 dB typ.
Middle
Wide
Audio harmonic distortion
: Wide, Middle 1.0% typ. at AF 1 kHz 40% deviation
Narrow
1.5% typ. at AF 1 kHz 40% Deviation
FM hum and Noise (Except [EUR], [UK]) : Narrow
(Without CCITT FILTER)
Wide
Residual modulation ([EUR], [UK])
: Narrow
40 dB min.
(With CCITT FILTER)
Middle
43 dB min.
Wide
45 dB min.
Limitting charact of modulator
: 60100% of max. deviation
Audio input impedance
: 2.2 k
1-1
Except [EUR], [UK]

[EUR], [UK]
M RECEIVER
Sensitivity
Squelch sensitivity (at threshold)
Intermediate frequency
Intermodulation
Spurious response
Audio output power
Hum and noise (Except [EUR], [UK])
(Without CCITT Filter)
Hum and noise ([EUR], [UK])
(With CCITT Filter)
Adjacent channel selectivity
Audio output impedance
: 0.25 V typ. at 12 dB SINAD

4 dBV (EMF) typ. at 20 dB SINAD
: 0.25 V typ.
4 dBV (EMF) typ.
: 1st 46.35 MHz
2nd 450 kHz
: 70 dB min., 75 dB typ.
65 dB min.
: 70 dB min.
: 0.8 W typ. at 5% distortion with a 12 load (Int. speaker)
0.4 W typ. at 5% distortion with an 8 load (Ext. speaker)
: Narrow
Wide
: Narrow
40 dB min.
Middle
43 dB min.
Wide
45 dB min.
: Narrow
Wide, Middle 70 dB min., 78 dB typ.
:8
Specifications are measured in accordance with TIA/EIA-603B or EN 300 086

All stated specifications are subject to change without notice or obligation.
1-2
Except [EUR], [UK]

[EUR], [UK]
Except [EUR], [UK]
[EUR], [UK]
Except [EUR], [UK]

[EUR], [UK]
SECTION 2.
INSIDE VIEWS
MAIN UNIT
(TOP VIEW)
+5V LINE REGULATOR

(Q75)
+5V LINE REGULATOR

(Q76)
CPU5 LINE REGULATOR

(IC54)
APC AMP
(IC1)
TCXO
(X2)
PLL IC
(IC2)
2ND IF FILTER
(FI2)
2ND IF FILTER
(For narrow mode only)
(FI3)
VCO
LPF
(Q51)
MIC GAIN CONTROLLER

(IC62)
LED DRIVER
(Q82, Q83)
AF LINE SW
(IC61)
LPF
(IC58)
TONE FILTER SW
(Q52)
TONE LPF
(IC59)
MIC/AF LINE SW
(IC56)
2-1
MAIN UNIT
(BOTTOM VIEW)
+5V LINE REGULATOR

(Q74)
AF AMP
(IC55)
POWER AF POWER AMP
CONTROLLER
(Q63)
TUNED BPF
(D24, D26)
AGC LONE DRIVER

(Q21)
RF AMP
(Q22)
TX POWER AMP
(Q1)
1ST IF FILTER
(FI1)
DRIVE AMP
(Q2)
1ST IF MIXER
(Q23)
PRE-DRIVE AMP
(Q3)
IF DEMODULATOR IC
(IC3)
PLL BUFFER
(Q9)
R5 LINE REGULATOR
(Q72)
RIPPLE FILTER
(Q15)
S5 LINE REGULATOR
(Q71)
LPF/BUFFER/VOX AMP
(IC60)
CLONING LINE BUFFER

(Q81, D51)
D/A CONVERTER
(IC57)
CPU
(IC51)
RESET IC
(IC53)
EEPROM
(IC52)
2-2
SECTION 3.
DISASSEMBLY INSTRUCTION
1. REMOVING THE CHASSIS

4) CAREFULLY lift the chassis out of the FRONT PANEL
and turn it over in order to unplug the speaker wire.
1) Remove the ANT connector nut and 2 knobs.

KNOBS
CHASSIS
ANT CONNECTOR NUT
SPEAKER
WIRE
FRONT PANEL
5) Remove the seals and nuts from the CHASSIS.

FRONT PANEL
2) Remove 2 screws from the bottom of the CHASSIS.

3) Lift the bottom of the CHASSIS up in the direction
of the arrow.
TOP SEAL
CHASSIS
BE CAREFUL to not pull out the speaker wire when

separating the CHASSIS and the FRONT PANEL.
SIDE SEAL
NUTS2
SCREWS2
CHASSIS
2. REMOVING THE MAIN UNIT

1) Remove the 9 screws and the side plate from the
MAIN UNIT.
2) Unsolder the 2 points shown, and then remove the
MAIN UNIT.
FRONT PANEL
For easy separation of the CHASSIS

Use a suction lifter to lift the bottom of the CHASSIS up.
UNSOLDER
Solder
remover
MAIN UNIT
Suction lifter
Part name : EA950R-2
Manufacture : ESCO CO.LTD
SIDE PLATE
Suction lifter
SCREWS9
CHASSIS
MAIN UNIT
(Continued to the right above)

3-1
SECTION 4.
CIRCUIT DESCRIPTION
4-1 RECEIVER CIRCUITS
2ND IF CIRCUITS AND DEMODULATOR
RF CIRCUITS
The signal from the 1st IF circuits is applied to the IF

demodulator IC which contains the 2nd IF mixer, 2nd IF
AMP, FM detector, etc. in its package.
The RX signal from the antenna is passed through the LPF

and antenna SW, then filtered by the 2-staged tuned BPF
to eliminate unwanted out-of-band signal. The filtered RX
signal is amplified by the RF AMP, and filtered by another
2-staged tuned BPF to obtain a good image response, then
applied to the 1st IF circuits.
The 1st IF signal is applied to the 2nd IF mixer and mixed

with the 2nd LO signal resulting in the 450 kHz 2nd IF
signal.
The tuned BPFs are tuned to the RX frequency by applying

adequate tuning voltages; T1 and T2 to the variable
capacitors.
The 2nd LO signal is generated by tripling the 15.3 MHz

reference frequency signal oscillated by the reference
frequency oscillator (TCXO).
RF CIRCUITS
The converted 2nd IF signal is filtered by the crystal filter/

filters to eliminate unwanted signal, and amplified by the
2nd IF AMP, then demodulated by the detector circuit which
employs a discriminator as the phase shifter.
ANT
D1,D22
ANT
SW
From the TX circuits
D28
To the 1st IF circuits
Q22
RF
AMP
BPF
LPF
D24,D26
The demodulated AF signal is applied to the RX AF circuits.
BPF
2ND IF CIRCUITS
T1
T2
X2
15.3MHz
TCXO
1ST IF CIRCUITS
Q26
The RX signal from the RF circuits is applied to the 1st IF

mixer and mixed with the 1st LO signal from the RX VCO,
resulting in the 46.35 MHz 1st IF signal. The 1st IF signal is
filtered by the crystal filter, amplified by the 1st IF AMP, then
applied to the 2nd IF circuits.
PLL
IC
X3
IF IC
45.9MHz
BPF
D/A
converter
Q10
BUFF
Q8
BUFF
D31,D32
W/N
SW
D5,D6
LO
SW
IC57
R2A20178
IF
AMP
X1
450kHz
CERAMIC
BPF
Discriminator
W/N
SW
Q27,
D33,D34
NOIS
NWC
FI1
46.35MHz
XTAL
BPF
450kHz
CERAMIC
BPF
FI3
To the TX circuits
ATT
Q24
FI2
SQIN
DISC
To the 2nd IF&demodulator circuits
From the 1st IF

circuits
IC3:NJM2591
1ST IF CIRCUITS
RX VCO
IC2
MB15A02
To the RX AF circuits
Q23
From the RF circuits
1st IF mixer
4-1
RX AF CIRCUITS
4-2 TRANSMITTER CIRCUITS
The demodulated AF signal from the IF demodulator

IC is passed through the LPF, HPF which attenuates
frequencies 300 Hz and below. The filtered AF signal is
passed through the AF line SW, HPF which additionally
attenuates frequencies 300 Hz and below, de-emphasis
circuit which provides 6 dB/oct of frequency response.
The de-emphasized AF signal is passed through the AF
SW, LPF which attenuates frequencies 3 kHz and above, is
adjusted in level by the D/A converter. The level-adjusted AF
signal is then applied to the AF power AMP via the AF line
SW.
TX AF CIRCUITS
The audio signal from the internal or external microphone
(MIC signal) is passed through the MIC gain SW and applied
to the MIC AMP. The amplified MIC signal is passed through
the MIC mute SW, HPF which attenuates frequencies
300 Hz and below. The filtered MIC signal is passed through
the pre-emphasis circuit which provides +6 dB/oct of
frequency response, then they applied to the limiter AMP.
The amplitude-limited MIC signal is passed through the
MIC line SW, and applied to the splatter filter, which
attenuate harmonics in the MIC signal to prevent exceeding
permissible deviation.
The amplified AF signal is applied to the internal or external

speaker.
The filtered MIC signal is applied to the D/A converter which

adjusts its level (=deviation). The level-adjusted MIC signal
is applied to the TX VCO as the modulation signal.
RX AF CIRCUITS
RMUT 1
IC59
the demodulator
circuits
IC58
LPF
HPF
IC62
RX
MUTE
TX AF CIRCUITS
IC58
LPF
IC58
HPF
AF line SW
IC55 TPA0211DGN
AFO
IC57
R2A20178
IC58
D/A
IC57
LPF
J52
Ext.speaker
IC58
Splatter
AF
AM P
IC56
CD4066
D/A
converter
J51
Ext.MIC
IC56
limit
AMP
MIC
line
SW
AF
AM P
AFON
IC62
HPF
MIC
MUTE
IC60
MIC
AMP
IC62
MIC
GAIN
SW
MC51
Int.MIC
MOD
IC12
TA7368F
IC58
To the modulation circuits
J53
1
2
SP1
Int.speaker
MODULATION CIRCUIT
The modulation signal from the TX AF circuits is applied to
D15 of the TX VCO to frequency-modulate it. The frequencymodulated signal from the TX VCO is buffer-amplified by
two buffers, and applied to the TX AMP circuits via the TX/
RX SW (D5).
MODULATION CIRCUITS
TX VCO
Q14,D16
Q10
BUFF
D15
FREQUENCY
MODULATION
From the TX AF circuits
4-2
Q8
BUFF
D5,D6
LO
SW
To the TX AMP circuits
TX AMPLIFIERS
4-3 FREQUENCY SYNTHESIZER CIRCUITS
The buffer amplified signal from the LO SW (D5) is

amplified by the pre-drive AMP, drive AMP, and power AMP
in sequence, to obtain TX power. The amplified TX signal
is passed through the antenna SW and the LPF, which
eliminates harmonics, and then fed to the antenna.
The RX VCO is composed of Q13, D11 and D12. The VCO

output signal is buffer-amplified by two buffers and applied
to the 1st IF mixer, via the LO SW (D6) and the attenuator.
The TX VCO is composed of Q14 and D14D16. The VCO
output signal is buffer-amplified by two buffers and applied
to the 1st IF mixer, via the LO SW (D6) and the LPF.
APC CIRCUITS
D1 and D2 rectify a portion of the TX signal to direct current,
and the APC AMP compares the voltage and the TX power
control reference voltage, T1. The resulting voltage controls
the gain of the power and drive AMPs to keep the TX power
constant.
A portion of oscillated signal from each VCO is fed back to

the PLL IC via the buffer and the LPF.
The applied VCO output signal is divided and phasecompared with a 15.3 MHz reference frequency signal from
the TCXO, which is also divided. The resulting signal is
output from the PLL IC, and DC-converted by the loop filter,
and then applied to the VCO as the lock voltage.
TX AMPLIFIERS AND APC CIRCUIT

ANT
From the
TX VCO
Q3
Q2
PRE
DRIVE
DRIVE
AM P
D1,D22
Q1
ANT
SW
PWR
AM P
When the oscillation frequency drifts, its phase changes

from that of the reference frequency, causing a lock voltage
change to compensate for the drift in the VCO oscillating
frequency.
LPF
IC1
APC
AMP
T1
PWR
DET
D1,D2
Q6
To the RX circuits
MUTE
SW
FREQUENCY SYNTHESIZER CIRCUITS
TMUT
D11
LV
ADJ
BAL
REF
LOOP
FILTER
X2
IC60
15.3MHz
TCXO
BUFF
RX VCO
Q13,D12
LV
Q10
BUFF
D14
D5,D6
Q8
BUFF
LO
SW
To the TX AMPs
TX VCO
LVA
Q26
IC2
Q14,D16
PLL
IC
X3
LV
ADJ
ATT
Q9
LPF
BUFF
SO,SCL,PLST
45.9MHz
BPF
Q23
1st IF mixer
IF IC
IC3
4-4 VOLTAGE BLOCK DIAGRAM

Q73
T5C
T5
REG
T5V
To the TX circuits
R5V
To the RX circuits
S5V
To both RX and TX circuits
+5V
To both RX and TX circuits
Q72
Q74-76
R5C
PWON
VCC
R5
REG
+5V
REG
Q71
F51
S5
S5C
S5
REG
IC54
CPU5 CPU5
REG
4-3
To the logical circuits
4-5 PORT ALLOCATIONS

CPU (IC51)
PIN
NO.
LINE
NAME
CDEC
STONE
13
CSFT
14
NWC
15
EPTT
16
ATX
17
BEEP
18
AFON
19
SCK
20
SO
22
KEY2
23
KEY1
24
PLST
25
DAST
26
ESDA
27
ESCL
28
R5C
29
30
T5C
S5C
31
PWON
32
IPTT
33,
34,
36
DESCRIPTION
Tone signal (CTCSS/DTCS)
decoding input.
Tone signal (5/2 TONE, DTMF,
BIIS) decoding/encoding .
Clock frequency shift.
H=Clock frequency is shifted.
RX mode (narrow/wide)
switching.
L=While receiving in the narrow
mode
External PTT input.
H=An external PTT is pushed.
Automatic TX control for VOX
mode.
H=Microphone input is detected.
Beep sounds. (Square waves)
AF power AMP control.
H=A F p owe r A M P ( I C 5 5 ) i s
activated.
Common clock.
Common serial data.
[UPPER] key input.
L=Pushed
[LOWER] key input.
L=Pushed
PLL strobe.
H=Load enable.
D/A converter strobe.
H=Load enable.
EEPROM data.
EEPROM clock.
Power supply switching control.
H=S u p p l y i n g c u r r e n t t o t h e
receiver circuits ("R5"line).
H=S u p p l y i n g c u r r e n t t o t h e
transmitter circuits ("T5"line).
H=Supplying current to the RX/
TX common circuits ("S5"line).
H=The transceiver's power is
ON.
Internal PTT input.
L=PTT pushed.
CENC2,
CENC1, CTCSS/DTCS signal.
CENC0
37
40
CBI0
CBI3
41
DUSE
42
RLED
43
TLED
47
MGC0
Frequency response switching.

H=DTCS encoding
Busy LED (Green) control.
L=LED lights. (Squelch open)
Busy LED (Red) control.
L=LED lights. (Transmit)
MIC gain control.
48
MGC1
MIC gain control.
49
CLI
50
CLO
[ROTARY SELECTOR] input.
Cloning data.
I/O
PIN
NO.
LINE
NAME
51
ADSW
I/O
53
NOIS
54
UNLK
55
RMUT2
56
RMUT1
57
MMUT
58
TMUT
59
MDET
60
LVIN
61
TEMP
Temperature sensing voltage.
62
AFVI
[VOLUME CONTROL] input.
63
VOXV
64
AD5
Microphone input sensing voltage.

Remaining battery voltage.
(or)
RSSI voltage.
(The input signal depends on the
status of pin 51.)
I
O
O
O
O
O
I
I
DESCRIPTION
A/D conversion select.
H=RSSI input, L=BATV input
Noise level detect.
H=Squelch close
PLL unlock detect.
RX AF mute switch control.
L=AF mute.
RX AF mute switch control.
L=AF mute.
MIC mute switch control.
L=MIC mute.
Transmission mute.
L=TX inhibit.
External microphone connection
detect.
Lock voltage input.
I/O
D/A CONVERTER (IC57)
I/O
I/O
PIN
No.
LINE
NAME
I/O
23
T1
BPF tuning voltage
(TXPO) TX power control
24
T2
REF
Reference frequency adjust voltage.

Additional lock voltage adjustment.
O
I
O
I
O
O
O
O
O
I
O
4-4
DESCRIPTION
BPF tuning voltage
LVA
11
SQLC
Squelch threshold setting.
12
TENC
CTCSS deviation adjustment.
19
BAL
20
VRAF
DTCS balance.
Max. deviation/AF volume adjustment.
I/O
O
I
I
O
O
O
O
I
I
SECTION 5.
ADJUSTMENT PROCEDURE
5-1 PREPARATION
REQUIRED EQUIPMENTS
EQUIPMENT
GRADE AND RANGE
EQUIPMENT
GRADE AND RANGE
Cloning software
CS-F3000 CLONING SOFTWARE

(Revision 1.0 or later)
JIG cable
Modified OPC-478/U/UC
(See the illust below)
RF power meter
(50 terminated)
Measuring range
Frequency range
SWR
: 0.110 W
: 100300 MHz
: Less than 1.2 : 1
Frequency counter
Frequency range
: 0.1300 MHz
Frequency accuracy : 1 ppm or better
Input level
: Less than 1 mW
Modulation
Analyzer
Frequency range
Measuring range
: 30300 MHz
: 0 to 10 kHz
AC millivoltmeter
Measuring range
: 10 mV to 10 V
Oscilloscope
Frequency range
Measuring range
: DC20 MHz
: 0.0120 V
Audio generator
(AG)
Frequency range
Output level
: 3003000 Hz
: 1500 mV
Frequency range
Output level
: 0.1300 MHz
: 20 to 90 dB
(127 to 17 dBm)
Attenuator
Power attenuation
Capacity
: 30 dB
: More than 10 W
External speaker
Input impedance
Capacity
:8
: More than 1 W
Standard signal
generator (SSG)
JIG CABLE
AC
MILLIVOLTMETER
AUDIO GENERATOR
(3003000 Hz/1500 mV)
[JIG cable1]
(GND)
PTT
3-conductor 2.5 (d) mm plug
(10 mV to 10 V)
SETTING;
Frequency : 1 kHz
Level
: 150 mV
Waveform : Sine wave
33 k
+
(MIC)
4.7 F
[JIG cable2]
(SP)
EXT. SPEAKER
(1 W/8 )
(GND)
OPC-478/U/UC
3-conductor 3.5(d) mm plug

(CLONE)
5-1
CONNECTION
OPC-478
(RS-232C type)
Standard signal generator

20 to 90 dB
(127 to 17 dBm)
PC
to the antenna connector

to USB port
OPC-478U
(USB type)
CAUTION!
NEVER transmit while
an SSG is connected to
the antenna connector.
Modulation
analyzer
to RS-232C port
to USB port
Attenuator
30 dB
OPC-478UC
(USB type)
RF power meter
0.1 10 W/50
Frequency
counter
To [SP] connector
To [MIC] (JIG cable 1)
To [SP] (JIG cable 2)
5-2
Speaker (8 )
ADJUSTMENT CHANNELS
Before starting the adjustments, use the cloning software to create the same cloning file as shown below, then upload it
into the transceiver.
CONVENIENT: The same cloning file is available.

Right-click
Disk."
below, and select "Save Embeded File to
For [EUR] versions:

When adjusting Deviation in the middle band, change the bandwidth to Middle
as shown below.
Select Middle
5-3
ADJUSTMENT UTILITY
Click
or [Read < TR] in the [Adjust] menu to open the "Adjust Utility" window as shown below.
Click to open the

I/O Check window
ADJ. CHANNEL
TX OUTPUT POWER
MOD. BALANCE
DEVIATION
CTCSS\DTCS
SQUELCH
REF. FREQUENCY
RX SENSITIVITY
LOCK VOLTAGE
(Adjustment)
If the window below appears, the utility is password-protected.

Enter the password to open the "Adjust Utility" window.
5-4
5-2 FREQUENCY ADJUSTMENTS

1) Select an adjustment item using []/[] on the PC's keyboard.
2) Set or modify the adjustment value as specified using []/[] on the PC's keyboard, then push [ENTER].
ADJUSTMENT
PLL LOCK
VOLTAGE
REFERENCE
FREQUENCY
TRANSCEIVERS
CONDITION
1 CH.
Receiving
:1
2 CH.
Transmitting
:1
3 CH.
Receiving
:2
4 CH.
Transmitting
:2
1 CH.
Transmitting
:3
OPERATION
ADJUSTMENT
ITEM
Connect an RF power meter to the

antenna connector.
[RX LVA]
VALUE
3.51 V
[TX LVA]
Click the [Reload (F5)] button to check
on the "I/O Check window" as illustrated
below.
[LVIN]
(On the "I/O
Check window")
Loosely couple a frequency counter to the

antenna connector.
I/O Check window
***
Lock voltage
appears here
(The values shown above are example only.

Each transceiver has own values.)
5-5
[REF]
0.91.5 V
(Verify)
174.0000 MHz
(250 Hz)
5-3 TRANSMIT ADJUSTMENTS

TRANSCEIVERS
CONDITION
ADJUSTMENT
OPERATION
TX OUTPUT
POWER
(Hi power)
1 CH.
Transmitting
:4
(L2 power)
2 CH.
Transmitting
:5
(L1 power)
3 CH.
Transmitting
:6
MODULATION
BALANCE
1) Connect a modulation analyzer with an

1 CH.
:7
oscilloscope to the antenna connector
No audio signals are
through an attenuator.
applied.
2) Set the modulation analyzer as;
Transmitting
HPF
: OFF
LPF
: 20 kHz
De-emphasis : OFF
Detector
: (P-P)/2
FM DEVIATION
(Narrow mode)
1 CH.
Transmitting
:8
(Middle mode)*
2 CH.
Transmitting
:9
(Wide mode)
3 CH.
Transmitting
:9
CTCSS/DTCS
DEVIATION
Connect an RF power meter to the

antenna connector.
1) Connect a modulation analyzer to

the antenna connector through an
attenuator.
HPF
: OFF
LPF
: 20 kHz
De-emphasis : OFF
Detector
: (P-P)/2
3) Connect an audio generator to the MIC
line through the JIG cable. (See the
page 5-1)
ADJUSTMENT
ITEM
VALUE
[Power (Hi)]
5.0 W
[Power (L2)]
2.0 W
[Power (L1)]
1.0 W
Square
waveform
[BAL]
[MOD N]
2.05 to 2.15
kHz
[MOD Ratio]
3.25 to 3.35
kHz
4.05 to 4.15
kHz
[MOD Ratio]
0.65 to 0.75
1) Connect a modulation analyzer to
1 CH.
: 10
kHz
the antenna connector through an
No audio signals are
attenuator.
applied.
Transmitting
[CTCSS/DTCS]
HPF
: OFF
LPF
: 20 kHz
De-emphasis : OFF
Detector
: (P-P)/2
*; [EUR] versions only
5-6
5-4 RECEIVE ADJUSTMENTS

ADJUSTMENT
RX SENSITIVITY
TRANSCEIVERS
CONDITION
1 CH.
: 11
Receiving
SQUELCH
1 CH.
Receiving
: 11
OPERATION
ADJUSTMENT
ITEM
1) C o n n e c t a n S S G t o t h e a n t e n n a
connector and set it as;
Frequency : 136.000 MHz
Level*
: 20 dB (87 dBm)
Modulation : 1 kHz
Deviation : 3.0 kHz
2) Put the cursor on the adjustment item,
then push [ENTER].
1) C o n n e c t a n S S G t o t h e a n t e n n a
connector and set it as;
Frequency : 136.000 MHz
Level*
: 13 dB (120 dBm)
Modulation : 1 kHz
Deviation : 3.0 kHz
2) Once close the squelch by increasing
[SQL] value, then decrease the value to
open the squelch.
3) Push [ENTER] to store the value.
*; The output level of the standard signal generator (SSG) is indicated as the SSGs open circuit.
5-7
VALUE
(A u t o m a t i c
adjustment)
[BPF ALL]
(A u t o m a t i c
adjustment)
[SQL]
SECTION 6.
PARTS LIST
[MAIN UNIT]
REF
NO.
[MAIN UNIT]
PARTS
NO.
REF
NO.
H/V
M. LOCATION
DESCRIPTION
PARTS
NO.
S.DIO
S.DIO
S.DIO
S.DIO
DESCRIPTION
M.
H/V
LOCATION
LRB706F-40T1G <SLVJ>
1SS390 TE61
L1SS400T1G <SLVJ>
L1SS400T1G <SLVJ>
B
B
B
B
67.9/45.8
87/33.7
69.1/3.1
21.9/33.8
IC1
IC2
IC3
IC51
IC52
IC53
IC54
IC55
IC56
IC57
IC58
IC59
IC60
IC61
IC62
1110002751
1140005991
1110007320
1140015230
1130015240
1110007620
1180003600
1110007610
1130011770
1110007550
1110005340
1110006350
1110005340
1140013200
1130011770
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.REG
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
S.IC
TA75S01F(TE85R,F)
MB15A02PFV1-G-BND-ERE1
NJM2591V-TE1-#ZZZB
R4F20102NFA (EMPTY)
R1EX24016ATA00A
NJU7704F3-42A-TE1-#ZZZB
NJM2871BF05-TE1-#ZZZB
TPA0211DGNR
CD4066BPWR
R2A20178NP
NJM12902V-TE1-#ZZZB
LM2902PWR
NJM12902V-TE1-#ZZZB
CD4053BPWR
CD4066BPWR
T
T
B
B
B
B
T
B
T
B
T
T
B
T
T
32.5/8.8
42.9/24.7
45.8/38.9
77.7/38
85/25.2
87.6/44.6
15.6/34.8
13.3/42.1
80.1/18.8
72.5/24.5
80.1/12
80.1/25.9
65.1/7.5
80.1/38.3
66.7/8.1
D51
D52
D53
D55
1750001820
1750001790
1750001810
1750001810
FI1
FI2
FI3
2030000870 S.MON MFT46.3P3 46.350 MHz (FL-442)

2020002410 CER
LTM450FW <JJE>
2020002570 CER
LTM450HW <JJE>
36.2/34.6
X1
X2
X51
6070000310 S.DIS
6050012050 S.XTA
6050012730 S.XTA
JTBM450CX70 <JJE>
CR-794 TTS14VSB-A6 15.3 MHz
CR-864(SMD-49/12.288 MHz)
<JJE>
T
T
47.6/40.9
41.9/15
86.9/38.5
Q1
Q2
Q3
Q6
Q8
Q9
Q10
Q11
Q12
Q13
Q14
Q15
Q17
Q19
Q21
Q22
Q23
Q24
Q25
Q26
Q27
Q51
Q52
Q58
Q59
Q63
Q64
Q71
Q72
Q73
Q74
Q75
Q76
Q81
Q82
Q83
Q84
Q85
1560001700
1560001241
1530003311
1590004050
1530003311
1530003311
1530003311
1590004070
1590004070
1530002920
1530002920
1530002851
1560000541
1590004070
1560000841
1580000731
1580000731
1530003311
1590004070
1530002851
1590004050
1590001650
1590004070
1590003431
1590004070
1520000460
1590001190
1510001090
1510000771
1510001090
1520000460
1590001190
1590004070
1590003271
1590004050
1590004050
1590004070
1590004070
S.FET
S.FET
S.TRA
S.TRA
S.TRA
S.TRA
S.TRA
S.TRA
S.TRA
S.TRA
S.TRA
S.TRA
S.FET
S.TRA
S.FET
S.FET
S.FET
S.TRA
S.TRA
S.TRA
S.TRA
S.TRA
S.TRA
S.TRA
S.TRA
S.TRA
S.TRA
S.TRA
S.TRA
S.TRA
S.TRA
S.TRA
S.TRA
S.TRA
S.TRA
S.TRA
S.TRA
S.TRA
RD07MUS2B-T112
RD01MUS1-T113
2SC5107-O(TE85R,F)
LDTA144EET1G <SLVJ>
2SC5107-O(TE85R,F)
2SC5107-O(TE85R,F)
2SC5107-O(TE85R,F)
LDTC144EET1G <SLVJ>
LDTC144EET1G <SLVJ>
2SC4226-T1 R25
2SC4226-T1 R25
2SC4116-BL(TE85R,F)
2SK880-Y(T5RICOM,F)
LDTC144EET1G <SLVJ>
2SK1829(TE85R,F)
3SK293(TE85L,F)
3SK293(TE85L,F)
2SC5107-O(TE85R,F)
LDTC144EET1G <SLVJ>
2SC4116-BL(TE85R,F)
LDTA144EET1G <SLVJ>
XP4601(TX)
LDTC144EET1G <SLVJ>
UNR911HG0L
LDTC144EET1G <SLVJ>
2SB1132 T100 R
XP6501-(TX).AB
KTA2015Y-RTK/P
2SA1586-GR(TE85L,F)
KTA2015Y-RTK/P
2SB1132 T100 R
XP6501-(TX).AB
LDTC144EET1G <SLVJ>
UNR9210G0L
LDTA144EET1G <SLVJ>
LDTA144EET1G <SLVJ>
LDTC144EET1G <SLVJ>
LDTC144EET1G <SLVJ>
B
B
B
T
T
B
T
B
B
T
T
B
B
B
B
B
B
B
T
T
B
T
T
B
B
B
B
B
B
B
B
T
T
B
T
T
B
T
28.6/13.5
36.3/14.4
42.2/13.1
33.3/5.9
54.8/18.5
55.9/18.5
60.7/18.5
54.9/23.8
62.5/24.4
57.5/23.6
60/23.6
64.1/18.7
52.6/29.7
63.5/33.5
28.4/30.5
25/27.8
36.4/27.3
38.3/42.6
49.3/35.1
39.6/30.1
56/36.4
65.5/42
75.4/31.4
54.9/7.1
49.1/7.3
15.1/35.5
19.3/36
65.1/36.6
65.6/31.1
78.6/23.8
5.3/34.4
4.5/35.2
6.8/35.2
70.5/45.8
71.6/39.5
71.6/41.6
19.2/43.8
21.1/31.8
L1
L2
L3
L4
L5
L6
L7
L8
L9
L11
L12
L13
L14
L15
L16
L18
L19
L20
L23
L24
L31
L32
L33
L34
L35
L36
L37
L38
L39
L40
L41
L42
L43
L46
6200012780
6200012470
6200012910
6200002861
6200012470
6200012390
6200013010
6200013100
6200007871
6200012470
6200011021
6200008090
6200008090
6200010910
6200010910
6200007901
6200011011
6200004770
6200012170
6200012170
6200011031
6200011031
6200011031
6200007170
6200008090
6200003640
6200007720
6200007170
6200007170
6200007760
6200003640
6200008090
6200007170
6200007881
S.COI
S.COI
S.COI
S.COI
S.COI
S.COI
S.COI
S.COI
S.COI
S.COI
S.COI
S.COI
S.COI
S.COI
S.COI
S.COI
S.COI
S.COI
S.COI
S.COI
S.COI
S.COI
S.COI
S.COI
S.COI
S.COI
S.COI
S.COI
S.COI
S.COI
S.COI
S.COI
S.COI
S.COI
0.30-1.4-6TL 27.2N <COMO>

0.30-1.7-7TL 45.3N <COMO>
0.35-1.6-8TL 45.5N <COMO>
NLV25T-4R7J
0.30-1.7-7TL 45.3N <COMO>
0.30-0.92-3TR 5.8N <COMO>
0.30-0.9-5TL 10.3N <COMO>
0.45-1.5-5TL 18.3N <COMO>
ELJRF 39NJFB
0.30-1.7-7TL 45.3N <COMO>
ELJRF 82NJFB
LQW2BHN68NJ03L
LQW2BHN68NJ03L
LQW18AN56NG00D
LQW18AN56NG00D
ELJRF 22NJFB
ELJRF 68NJFB
ELJNC R56J-F
MLG1608SR18J-T
MLG1608SR18J-T
ELJRF R10JFB
ELJRF R10JFB
ELJRF R10JFB
MLF1608A 3R3K-T
LQW2BHN68NJ03L
MLF1608E 100K-T
LQW2BHN33NJ03L
MLF1608A 3R3K-T
MLF1608A 3R3K-T
LQW2BHN82NJ03L
MLF1608E 100K-T
LQW2BHN68NJ03L
MLF1608A 3R3K-T
ELJRF 33NJFB
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
T
T
T
B
T
B
T
T
T
B
B
T
T
T
B
B
9.4/7.9
9.6/11.7
11.2/15.6
18.4/17.8
18.4/14.1
22/14.1
24.3/15.3
25.2/19
42.2/11.3
14.1/19.6
12.4/23.1
14.9/26.8
20.9/26.8
27.1/27.8
33.3/27.8
32.8/13.4
34.4/25.1
39.4/27.7
39.4/34.6
41.5/31.8
56.6/17.7
56.5/20.4
62.5/17.7
57.4/29.2
55.7/27.7
53/25.6
53.8/22.6
50.6/25.7
59.1/28.5
62.9/27.9
64.6/27.5
64.3/20.6
60/22.7
48.2/19.3
D1
D3
D5
D6
D11
D12
D13
D14
D15
D16
D17
D18
D21
D22
D23
D24
D26
D28
D31
D32
D33
D34
D35
1750001910
1790001790
1750001890
1750001890
1750001880
1750001550
1750001550
1750001880
1750001570
1750001550
1750001550
1750001810
1750001810
1750001910
1750001910
1750001880
1750001880
1750001780
1750001790
1750001790
1750001790
1750001790
1790001241
1790001241
1790001241
1790001241
1790001241
1790001241
1790001241
1790001241
1790001241
1790001241
1790001241
1790001241
1790001241
1790001241
1790001241
1790001241
1790001241
1790001241
1790001241
S.DIO
S.DIO
S.DIO
S.DIO
S.VAR
S.VAR
S.VAR
S.VAR
S.VAR
S.VAR
S.VAR
S.DIO
S.DIO
S.DIO
S.DIO
S.VAR
S.VAR
S.VAR
S.DIO
S.DIO
S.DIO
S.DIO
S.DIO
S.DIO
S.DIO
S.DIO
S.DIO
S.DIO
S.DIO
S.DIO
S.DIO
S.DIO
S.DIO
S.DIO
S.DIO
S.DIO
S.DIO
S.DIO
S.DIO
S.DIO
S.DIO
HVD144AKRF-E
RB876W TL
HVD142AKRF-E
HVD142AKRF-E
HVL375CKRF-E
HVD376BKRF-E
HVD376BKRF-E
HVL375CKRF-E
HVL355CMKRF-E
HVD376BKRF-E
HVD376BKRF-E
L1SS400T1G <SLVJ>
L1SS400T1G <SLVJ>
HVD144AKRF-E
HVD144AKRF-E
HVL375CKRF-E
HVL375CKRF-E
HVB350BYPTL-E
1SS390 TE61
1SS390 TE61
1SS390 TE61
1SS390 TE61
MA2S7280GL
MA2S7280GL
MA2S7280GL
MA2S7280GL
MA2S7280GL
MA2S7280GL
MA2S7280GL
MA2S7280GL
MA2S7280GL
MA2S7280GL
MA2S7280GL
MA2S7280GL
MA2S7280GL
MA2S7280GL
MA2S7280GL
MA2S7280GL
MA2S7280GL
MA2S7280GL
MA2S7280GL
B
B
B
B
T
T
T
T
T
T
T
T
B
B
B
B
B
B
B
B
B
B
[USA-11] T
[USA-12]
[USA-13]
[EXP-11]
[EXP-12]
[EXP-13]
[EXP-21]
[EXP-22]
[EXP-23]
[EXP-01]
[EXP-03]
[EXP-31]
[CHN-31]
[AUS-21]
[AUS-22]
[AUS-23]
[RUS-21]
[RUS-22]
[RUS-23]
16.2/16.3
19.4/9.1
49.6/15.2
49.6/16.6
57.4/29.2
54.1/25.6
55.1/25.6
59.3/27.2
59.3/29.2
63.8/25.1
62.8/23.2
46.3/32.6
30.9/33.2
16.2/20.5
14.1/23.3
17.4/27.7
18.4/27.7
31/27.8
54.1/39.8
51.7/36.8
56.7/39.8
58.1/38.5
37.5/6.3
R1
R2
R6
R7
R8
R9
R10
R11
R12
R13
R14
R15
R16
R17
R18
R21
R22
R23
R24
R25
R26
R31
R32
R33
R35
R36
R37
R38
R41
R42
R44
R45
R47
R48
R51
R52
R53
R54
R55
R56
R57
R61
R62
R65
R66
7030005070
7030008280
7030005290
7030005120
7030005060
7030005050
7030005070
7030005310
7030005110
7030005530
7030004980
7030005030
7030005050
7510001730
7030004980
7030007250
7030005090
7030005040
7030005590
7030005060
7030005040
7030005530
7030005120
7030004980
7030007290
7030005050
7030004980
7030005120
7030005530
7030005240
7030005530
7030005240
7030004980
7030005310
7030008370
7030008370
7030008340
7030011000
7030008340
7030011000
7030009320
7030005040
7030005220
7030005720
7030008300
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.THE
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
ERJ2GEJ 683 X (68K)

ERJ2GEJ 271 X (270)
ERJ2GEJ 682 X (6.8K)
ERJ2GEJ 102 X (1K)
ERJ2GEJ 333 X (33K)
ERJ2GEJ 103 X (10K)
ERJ2GEJ 683 X (68K)
ERJ2GEJ 124 X (120K)
ERJ2GEJ 100 X (10)
ERJ2GEJ 101 X (100)
ERJ2GEJ 103 X (10K)
ERTJOEP 473J
ERJ2GEJ 101 X (100)
ERJ2GEJ 220 X (22)
ERJ2GEJ 680 X (68)
ERJ2GEJ 333 X (33K)
ERJ2GEJ 100 X (10)
ERJ2GEJ 102 X (1K)
ERJ2GEJ 101 X (100)
ERJ2GEJ 103 X (10K)
ERJ2GEJ 101 X (100)
ERJ2GEJ 102 X (1K)
ERJ2GEJ 100 X (10)
ERJ2GEJ 473 X (47K)
ERJ2GEJ 100 X (10)
ERJ2GEJ 473 X (47K)
ERJ2GEJ 101 X (100)
ERJ2GEJ 561 X (560)
ERJ2GEJ 561 X (560)
RR0510P-182-D (1.8K)
RR0510P-392-D (3.9K)
RR0510P-182-D (1.8K)
RR0510P-392-D (3.9K)
ERJ2GEJ 4R7 X (4.7)
ERJ2GEJ 223 X (22K)
ERJ2GEJ 563 X (56K)
B
B
B
B
T
T
T
T
T
T
T
T
T
T
T
B
B
B
B
B
B
B
B
B
B
B
B
B
T
T
B
B
T
T
B
B
T
T
T
T
T
B
B
B
B
9.1/5.7
20.6/19.2
19.4/10.8
17.9/7.9
30.8/5.9
31.7/5.9
32.6/11.3
31.7/11.3
35.7/5.9
35.7/9.6
34.8/7.6
35.7/7.6
29.4/7.1
29.4/8.9
29.4/8
32.3/10.9
33.2/9.2
34.1/9.2
38.4/10.9
39.3/9.2
38.4/9.2
42.2/14.9
44/14.9
44.6/13.1
46.4/14
49.6/13.1
49.6/14
51.8/15.2
53/17.7
56.6/19.4
56.5/21.3
57.7/18.6
63.4/17.7
62.5/19.3
56.5/22.9
60.5/24.4
55.7/23.7
57.9/25.9
61.8/23.7
58.9/25.9
60.7/25.9
60.6/28.9
64.4/27.7
64.4/26.1
65.4/26.1
M.=Mounted side (T: Mounted on the Top side, B: Mounted on the Bottom side)
S.=Surface mount
6-1
[MAIN UNIT]
REF
NO.
R67
R68
R69
R70
R71
R72
R73
R76
R77
R78
R80
R81
R82
R83
R87
R88
R89
R101
R102
R103
R104
R105
R106
R107
R108
R109
R110
R111
R112
R113
R114
R115
R116
R117
R118
R119
R120
R121
R122
R123
R125
R126
R127
R128
R129
R130
R131
R132
R134
R135
R136
R137
R138
R139
R140
R141
R142
R146
R147
R148
R149
R151
R152
R153
R154
R155
R156
R157
R158
R301
R302
R303
R304
R310
R311
R312
R313
R314
R315
R316
R317
[MAIN UNIT]
PARTS
NO.
7030007290
7030005170
7030005060
7030005090
7030005050
7030005120
7030005050
7030005120
7030007570
7030004990
7410001130
7030005100
7030005050
7030004970
7030005090
7510001730
7030010080
7030005230
7030005170
7030009290
7030005040
7030005040
7030005310
7030008290
7030005090
7030005530
7030008280
7030005110
7030004970
7030008370
7030008370
7030008370
7030007280
7030007280
7030007280
7030007280
7030007280
7030007280
7030008370
7030008370
7030008370
7030008370
7030008370
7030008370
7030008370
7030008370
7030008370
7030008370
7030008370
7030008370
7030008370
7030008370
7030008370
7030008370
7030005090
7030005090
7030005080
7030005090
7030005100
7030005310
7030005590
7030007300
7030004970
7030005530
7030008370
7030004980
7030005110
7030005010
7030005000
7030005530
7030005000
7030005050
7030005090
7030007290
7030007290
7030008410
7030005000
7030005310
7030008410
7030005220
7030005090
7030004970
7030005030
7030005120
7030007060
7030005600
7030005210
7030007300
7030005210
7030005600
7030005120
7030005120
7030005120
7030007340
7030008010
7030005720
7030005030
7030005220
7030005220
7030005220
7030007300
7030006610
7030005080
7030005000
7030005290
DESCRIPTION
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.ARR
S.RES
S.RES
S.RES
S.RES
S.THE
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES

ERJ2GEJ 333 X (33K)
ERJ2GEJ 103 X (10K)
ERJ2GEJ 102 X (1K)
ERJ2GEJ 103 X (10K)
ERJ2GEJ 102 X (1K)
ERJ2GEJ 221 X (220)
EXB28V102JX
ERJ2GEJ 103 X (10K)
ERJ2GEJ 470 X (47)
ERTJOEP 473J
ERJ2RHD 104 X (100K)
ERJ2GEJ 183 X (18K)
ERJ2GEJ 100 X (10)
ERJ2GEJ 271 X (270)
ERJ2GEJ 470 X (47)
ERJ2GEJ 561 X (560) [USA-11]
ERJ2GEJ 561 X (560) [USA-12]
ERJ2GEJ 561 X (560) [USA-13]
ERJ2GEJ 331 X (330) [EUR-21]
ERJ2GEJ 331 X (330) [EUR-22]
ERJ2GEJ 331 X (330) [EUR-23]
ERJ2GEJ 331 X (330)
[UK-01]
ERJ2GEJ 331 X (330)
[UK-02]
ERJ2GEJ 331 X (330)
[UK-03]
ERJ2GEJ 561 X (560) [EXP-11]
ERJ2GEJ 561 X (560) [EXP-12]
ERJ2GEJ 561 X (560) [EXP-13]
ERJ2GEJ 561 X (560) [EXP-21]
ERJ2GEJ 561 X (560) [EXP-22]
ERJ2GEJ 561 X (560) [EXP-23]
ERJ2GEJ 561 X (560) [EXP-01]
ERJ2GEJ 561 X (560) [EXP-03]
ERJ2GEJ 561 X (560) [EXP-31]
ERJ2GEJ 561 X (560) [CHN-31]
ERJ2GEJ 561 X (560) [AUS-21]
ERJ2GEJ 561 X (560) [AUS-22]
ERJ2GEJ 561 X (560) [AUS-23]
ERJ2GEJ 561 X (560) [RUS-21]
ERJ2GEJ 561 X (560) [RUS-22]
ERJ2GEJ 561 X (560) [RUS-23]
ERJ2GEJ 823 X (82K)
ERJ2GEJ 680 X (68)
ERJ2GEJ 470 X (47)
ERJ2GEJ 100 X (10)
ERJ2GEJ 561 X (560)
ERJ2GEJ 101 X (100)
ERJ2GEJ 681 X (680)
ERJ2GEJ 471 X (470)
ERJ2GEJ 100 X (10)
ERJ2GEJ 471 X (470)
ERJ2GEJ 103 X (10K)
ERJ2GEJ 471 X (470)
ERJ2GEJ 223 X (22K)
ERJ2GEJ 470 X (47)
ERJ2GEJ 102 X (1K)
ERJ2GEJ 684X (680K)
ERJ2GEJ 273 X (27K)
ERJ2GEJ 273 X (27K)
ERJ2GEJ 102 X (1K)
ERJ2GEJ 102 X (1K)
ERJ2GEJ 102 X (1K)
ERJ2GEJ 153 X (15K)
ERJ2GEJ 123 X (12K)
ERJ2GEJ 563 X (56K)
ERJ2GEJ 223 X (22K)
ERJ2GEJ 223 X (22K)
ERJ2GEJ 223 X (22K)
ERJ2GEJ 823 X (82K)
ERJ2GEJ 471 X (470)
H/V
M. LOCATION
B
B
B
B
B
B
B
T
T
T
T
B
T
T
B
T
T
B
B
B
B
B
B
B
B
B
B
B
B
B
62.3/18
61.5/30.7
61.5/31.6
63.7/30.8
50.3/29.5
50.3/27.9
54.7/28.9
48.3/26.3
46.7/25.4
46.7/24.2
44.4/29.9
62/35.3
40.1/19.4
46.1/19.8
61.5/29.8
58.2/9.6
57.3/12.3
28.7/32.3
28.7/33.2
31/30.7
17.4/25.8
18.4/25.8
22.8/26.9
22.6/30
22.8/28.7
23.5/30
23.5/25.6
24.4/30
27.1/25.6
29.2/27.5
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
T
T
T
B
B
B
B
B
B
B
T
T
B
B
B
B
B
B
B
B
B
B
B
B
T
T
T
T
T
T
T
T
30.1/25.6
31/25.6
35.4/29.3
33.4/25.1
36.4/25.1
36.4/29.3
39.4/25.1
41.2/27.7
42.4/25.1
39.4/29.8
35.6/40.8
39/40.8
37.3/40.8
39.1/44.4
37.4/23.5
36.4/23.5
35.4/23.5
47.4/17.6
40.4/40.3
43/36.7
43/37.6
45.7/36.4
43/35.5
48.3/35.5
46.5/34.6
46.5/33.7
46.5/31.9
45.6/44
47.1/42.2
37.8/31.4
37.8/29.6
51.7/39
53.9/35.1
55.5/38.5
57.5/36.9
58.8/39.8
19.4/24.1
31/23.9
59.4/35.7
68.4/12.4
66.6/12.4
67.5/12.4
69.3/10.7
66.2/36.7
64.6/37.9
64.6/39.6
62.6/39.6
63.7/41.2
63.7/42.8
67.3/42.8
66.4/39.6
REF
NO.
R318
R321
R322
R323
R324
R325
R326
R327
R328
R329
R330
R331
R341
R342
R343
R344
R345
R346
R347
R348
R349
R350
R351
R352
R353
R354
R355
R356
R359
R360
R361
R362
R363
R364
R366
R368
R369
R370
R371
R372
R373
R374
R375
R377
R378
R379
R381
R382
R383
R384
R385
R386
R387
R388
R389
R390
R391
R393
R394
R395
R396
R397
R398
R401
R402
R403
R405
R406
R407
R408
R412
R413
R414
R416
R417
R418
R420
R421
R423
R424
R426
R427
R428
R429
R430
R431
R432
R433
R434
R435
R436
R437
R438
R439
R440
R441
R442
R451
R453
R454
R455
R456
R457
R458
R459
PARTS
NO.
7030005050
7030007340
7030008300
7030005720
7030005220
7030005290
7030005240
7030005240
7030005240
7030005040
7030005090
7030005240
7030005070
7030005070
7030005070
7030005070
7030005070
7030005170
7030005050
7030005160
7030005160
7030005050
7030008290
7030005050
7030005210
7030005160
7030005050
7030010040
7030010040
7030007290
7030005000
7030005060
7030005000
7030005240
7030005100
7030005700
7030005100
7030005170
7030005290
7030009290
7030005080
7030008410
7030005000
7030005060
7030005050
7030005700
7030005700
7030005170
7030008310
7030005090
7030005310
7030005060
7030005030
7030008010
7030005800
7030005810
7030007290
7030005700
7030005310
7030005080
7030008300
7030008310
7030005050
7030005120
7030005000
7030010040
7030011290
7030005090
7030010040
7030004980
7030005040
7030005090
7030005230
7030005120
7030007340
7030005120
7030005090
7210003061
7030005090
7030005090
7030007340
7030005230
7030005120
7030008300
7030005160
7030005050
7030005040
7030005050
7030005050
7030005050
7030005040
7030005050
7030005040
7030007290
7030009280
7030005050
7030007280
7030005530
7030008010
7030005220
7030008010
7030005050
7030005040
7030005120
7030005120
DESCRIPTION
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
VAR
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
S.RES
ERJ2GEJ 103 X (10K)

ERJ2GEJ 153 X (15K)
ERJ2GEJ 563 X (56K)
ERJ2GEJ 223 X (22K)
ERJ2GEJ 473 X (47K)
ERJ2GEJ 473 X (47K)
ERJ2GEJ 473 X (47K)
ERJ2GEJ 473 X (47K)
ERJ2GEJ 683 X (68K)
ERJ2GEJ 683 X (68K)
ERJ2GEJ 683 X (68K)
ERJ2GEJ 683 X (68K)
ERJ2GEJ 683 X (68K)
ERJ2GEJ 103 X (10K)
ERJ2GEJ 105 X (1M)
ERJ2GEJ 105 X (1M)
ERJ2GEJ 103 X (10K)
ERJ2GEJ 183 X (18K)
ERJ2GEJ 103 X (10K)
ERJ2GEJ 105 X (1M)
ERJ2GEJ 103 X (10K)
ERJ2GEJ-JPW
ERJ2GEJ-JPW
ERJ2GEJ 471 X (470)
ERJ2GEJ 333 X (33K)
ERJ2GEJ 471 X (470)
ERJ2GEJ 473 X (47K)
ERJ2GEJ 823 X (82K)
ERJ2GEJ 471 X (470)
ERJ2GEJ 333 X (33K)
ERJ2GEJ 103 X (10K)
ERJ2GEJ 333 X (33K)
ERJ2GEJ 123 X (12K)
RR0510P-102-D (1K)
RR0510P-152-D (1.5K)
ERJ2GEJ 823 X (82K)
ERJ2GEJ 103 X (10K)
ERJ2GEJ 102 X (1K)
ERJ2GEJ 471 X (470)
ERJ2GEJ-JPW
ERJ12YJ1R8U (1.8)
ERJ2GEJ-JPW
ERJ2GEJ 101 X (100)
ERJ2GEJ 102 X (1K)
ERJ2GEJ 153 X (15K)
ERJ2GEJ 102 X (1K)
TP76N00N-15F-A103-2251A
ERJ2GEJ 153 X (15K)
ERJ2GEJ 102 X (1K)
ERJ2GEJ 105 X (1M)
ERJ2GEJ 103 X (10K)
ERJ2GEJ 103 X (10K)
ERJ2GEJ 103 X (10K)
ERJ2GEJ 103 X (10K)
ERJ2GEJ 103 X (10K)
ERJ2GEJ 391 X
ERJ2GEJ 103 X (10K)
ERJ2GEJ 331 X (330)
ERJ2GEJ 100 X (10)
ERJ2GEJ 123 X (12K)
ERJ2GEJ 223 X (22K)
ERJ2GEJ 123 X (12K)
ERJ2GEJ 103 X (10K)
ERJ2GEJ 102 X (1K)
ERJ2GEJ 102 X (1K)
H/V
M. LOCATION
T
T
B
B
B
T
T
T
T
T
T
T
T
T
T
T
T
T
B
T
T
T
T
T
T
T
T
T
B
B
B
B
B
T
B
T
T
B
T
T
T
T
T
T
T
T
T
T
T
T
T
T
T
B
B
B
T
B
B
B
B
B
B
T
B
B
T
B
T
B
B
T
B
B
B
B
T
67.3/39.6
73.7/27.7
69.1/33
70/33
70.9/33
72.8/29.5
73.7/29.5
75.5/29.5
75.5/27.7
77.9/29.5
74.5/32.9
77.4/31.6
84.8/31.1
84.8/29.4
84.8/27.7
86.6/27.7
85.7/26
85.7/24.3
81.3/15.6
82.3/34.6
83.2/34.6
86.6/24.3
75.5/24.3
71.8/12
72.7/10.2
75.4/10.2
73.7/24.3
85.7/23.1
56/10.5
56/9.6
25.1/43.9
51.6/7.5
57.8/8.7
59.5/5.5
57.8/9.6
61.7/8.7
61.7/10.4
61.7/11
74.5/8.4
80.2/8.4
84.7/10.2
86.5/10.2
85.6/12
84.7/13.8
86.5/15.6
84.7/15.6
70.9/15.6
71.8/13.8
70.9/13.8
80.9/15.4
74.5/13.8
73.6/13.8
73.6/15.6
82.8/17.3
83.7/17.3
77.2/15.6
74.5/15.6
61.7/7.8
60.8/6.2
60.8/7.8
61.7/6.2
60.8/4.6
61.7/9.4
66.2/35.8
68.5/22.5
67.5/28.7
33.6/35.3
12.2/45.6
34/37.9
35.6/46.3
15.9/39.5
20.4/33.4
20.2/33.7
21.5/35.8
21.3/37.1
19.8/37.9
79.6/32.3
T
T
B
B
B
B
B
B
B
B
B
B
B
B
T
T
B
T
B
B
B
B
B
B
T
B
B
6.9/37.8
5.2/38.7
69.3/6.3
69.3/4.6
65.1/3.1
66.8/3.1
72.1/3.1
66.6/34.8
70.5/30.9
67.5/30.3
70.5/30
76.8/24.5
75.4/30
8.4/34.7
4.8/33.3
83.2/8.4
17.4/43.5
19.5/32.2
21.5/34.9
85.2/37.3
87.9/35.2
87/32.2
86.1/35.2
87.6/42.7
80.7/35
81.3/30
80.4/30
S.=Surface mount
6-2
[MAIN UNIT]
REF
NO.
[MAIN UNIT]
PARTS
NO.
DESCRIPTION
R460
R461
R462
R463
R464
R466
R467
R468
R469
R470
R471
R472
R473
R474
R475
R476
R477
7410001140
7030005040
7030005040
7030005050
7030005090
7410001140
7410001140
7030008400
7030009280
7030005090
7030007340
7030005090
7410001140
7030007340
7030005090
7030005120
7030005120
S.ARR
S.RES
S.RES
S.RES
S.RES
S.ARR
S.ARR
S.RES
S.RES
S.RES
S.RES
S.RES
S.ARR
S.RES
S.RES
S.RES
S.RES
EXB28V104JX
ERJ2GEJ 103 X (10K)
EXB28V104JX
EXB28V104JX
ERJ2GEJ 391 X
ERJ2GEJ 153 X (15K)
EXB28V104JX
ERJ2GEJ 153 X (15K)
ERJ2GEJ 102 X (1K)
ERJ2GEJ 102 X (1K)
C2
C3
C4
C5
C6
C7
C8
C11
C15
C16
C17
C18
C20
C21
C23
C26
C27
C28
C29
C30
C31
C32
C33
C34
4030009740
4030010080
4030011700
4030009780
4030011650
4030009760
4030019740
4030019740
4030009770
4030009830
4030011630
4030019740
4030019740
4030007070
4030007050
4030019740
4030019740
4030019740
4030019930
4030019950
4030019930
4030019740
4030019740
4030019970
4030019970
4030019970
4030020120
4030020120
4030020120
4030020120
4030020120
4030020120
4030019970
4030019970
4030019970
4030019970
4030019970
4030019970
4030019970
4030019970
4030019970
4030019970
4030019970
4030019970
4030019970
4030019970
4030019970
4030019970
4030011320
4030019740
4030019740
4030017490
4030019740
4030010250
4030019740
4030011320
4030019740
4030019740
4030019740
4030019810
4030017490
4030010250
4030019740
4030011320
4030019740
4030019740
4030009780
4030019810
4030019740
4030009740
4030019740
4030019740
4030009710
4030019740
4030019740
4030019740
4030019740
4030019930
4030019740
4030011680
4030011720
4030019740
4030009790
4030009790
4030009790
4030009830
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
C1005 CH 1H 100C-T
C1005 CH 1H 240J-T
C1005 CH 1H 040B-T
C1005 CH 1H 270J-T
C1005 CH 1H 1R5B-T
C1005 CH 1H 150J-T
C1005 JB 1H 102K-T
C1005 JB 1H 102K-T
C1005 CH 1H 220J-T
C1005 CH 1H 180J-T
C1005 CH 1H 0R5B-T
C1005 JB 1H 102K-T
C1005 JB 1H 102K-T
C1608 CH 1H 330J-T
C1608 CH 1H 220J-T
C1005 JB 1H 102K-T
C1005 JB 1H 102K-T
C1005 JB 1H 102K-T
C1005 JB 1A 104K-T
C1005 JB 0J 224K-T
C1005 JB 1A 104K-T
C1005 JB 1H 102K-T
C1005 JB 1H 102K-T
C1005 JB 0J 105K-T
C1005 JB 0J 105K-T
C1005 JB 0J 105K-T
C1005 JB 0J 225M-T
C1005 JB 0J 225M-T
C1005 JB 0J 225M-T
C1005 JB 0J 225M-T
C1005 JB 0J 225M-T
C1005 JB 0J 225M-T
C1005 JB 0J 105K-T
C1005 JB 0J 105K-T
C1005 JB 0J 105K-T
C1005 JB 0J 105K-T
C1005 JB 0J 105K-T
C1005 JB 0J 105K-T
C1005 JB 0J 105K-T
C1005 JB 0J 105K-T
C1005 JB 0J 105K-T
C1005 JB 0J 105K-T
C1005 JB 0J 105K-T
C1005 JB 0J 105K-T
C1005 JB 0J 105K-T
C1005 JB 0J 105K-T
C1005 JB 0J 105K-T
C1005 JB 0J 105K-T
C1005 CH 1H 470J-T
C1005 JB 1H 102K-T
C1005 JB 1H 102K-T
C1608 JB 1A 105K-T
C1005 JB 1H 102K-T
C1005 CH 1H 101J-T
C1005 JB 1H 102K-T
C1005 CH 1H 470J-T
C1005 JB 1H 102K-T
C1005 JB 1H 102K-T
C1005 JB 1H 102K-T
C1005 JB 1E 103K-T
C1608 JB 1A 105K-T
C1005 CH 1H 101J-T
C1005 JB 1H 102K-T
C1005 CH 1H 470J-T
C1005 JB 1H 102K-T
C1005 JB 1H 102K-T
C1005 CH 1H 270J-T
C1005 JB 1E 103K-T
C1005 JB 1H 102K-T
C1005 CH 1H 100C-T
C1005 JB 1H 102K-T
C1005 JB 1H 102K-T
C1005 CH 1H 070C-T
C1005 JB 1H 102K-T
C1005 JB 1H 102K-T
C1005 JB 1H 102K-T
C1005 JB 1H 102K-T
C1005 JB 1A 104K-T
C1005 JB 1H 102K-T
C1005 CH 1H 030B-T
C1005 CH 1H R75B-T
C1005 JB 1H 102K-T
C1005 CH 1H 330J-T
C1005 CH 1H 330J-T
C1005 CH 1H 330J-T
C1005 CH 1H 180J-T
C35
C36
C41
C43
C44
C46
C48
C49
C51
C52
C53
C54
C55
C56
C57
C58
C59
C60
C63
C64
C65
C71
C72
C73
C74
C75
C76
C77
C78
C79
C80
C81
C83
C85
C86
C87
C88
C89
H/V
M.
LOCATION
B
B
B
T
T
B
B
T
T
B
B
B
B
B
B
B
B
77.7/30
84/30.8
84/29.9
71.8/37.7
73.4/34.8
69.5/40
69.5/37
70/41.6
70/39.5
74.7/46.1
72.6/45.4
72.6/47.2
77.7/46.1
72.6/46.3
79.5/30
75.9/46.1
85.2/34.5
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
T
T
T
T
T
T
T
T
[USA-11] T
[USA-12]
[USA-13]
[EUR-21]
[EUR-22]
[EUR-23]
[UK-01]
[UK-02]
[UK-03]
[EXP-11]
[EXP-12]
[EXP-13]
[EXP-21]
[EXP-22]
[EXP-23]
[EXP-01]
[EXP-03]
[EXP-31]
[CHN-31]
[AUS-21]
[AUS-22]
[AUS-23]
[RUS-21]
[RUS-22]
[RUS-23]
B
B
B
B
T
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
T
T
T
B
T
T
B
B
T
T
T
T
T
T
T
10.3/6.1
7.4/12
11.5/11.4
12.4/11.4
11.5/13
12.4/13
14.5/17.2
20.6/20.1
16.2/14.1
17.9/11.3
19.4/11.7
17.9/9.6
20.4/14.1
21.3/10.4
22.7/10.4
29.9/5.9
39.2/5.9
33.6/11.3
30.8/11.3
34.8/5.9
35.7/11.3
36.6/9.6
36.6/7.6
37.5/7.6
37.5/9.2
44.6/9.5
28/17.6
27.8/20.3
32.7/16.6
32.8/12.4
32.3/9.2
31.4/9.2
23.4/22.7
32.8/14.4
37.5/10.9
39.3/10.9
33.5/16.6
39.9/13.1
40.5/14.9
44.6/11.3
44.6/10.4
44.6/12.2
46.4/14.9
49.6/12.1
51.2/14
51.8/16.6
51.2/17.8
53/19.4
58/18.9
54.1/20.4
58.6/18.6
64.3/17.7
58.9/18.9
64.3/21.2
62.5/25.9
58.5/17.3
58.9/21.2
57.1/21.2
57/25.9
58/21.2
56.1/25.9
57.9/27.5
REF
NO.
C90
C93
C94
C101
C102
C103
C104
C105
C106
C107
C108
C109
C111
C112
C113
C114
C115
C116
C117
C118
C120
C121
C122
C123
C124
C127
C130
C132
C134
C135
C141
C145
C149
C150
C151
C152
C153
C154
C155
C156
C157
C158
C159
C160
C167
C168
C169
C171
C172
C173
C174
C175
C176
C178
C179
C180
C181
C182
C183
C184
C186
C188
C189
C191
C192
C193
C195
C196
C197
C198
C199
C200
C201
C202
C203
C206
C210
C211
C214
C215
C216
C217
C218
C220
C223
C224
C225
C226
C227
C228
C231
C232
C233
C234
C235
C236
C238
C239
C240
C241
C242
C243
C244
C251
C252
PARTS
NO.
4030019740
4030011320
4030009730
4030011630
4030019930
4030019740
4030009830
4030009790
4030011610
4030009770
4030019930
4030019970
4030011640
4030019690
4030011680
4030011680
4030009730
4030019970
4030019750
4030011320
4030019740
4030019560
4030019810
4030019740
4030019740
4030019690
4030011320
4550000560
4550002980
4550000560
4030009740
4030019740
4030019740
4030019930
4030019740
4030019740
4030011320
4030011320
4030011320
4030019930
4030019740
4030009740
4030019930
4030019740
4030009750
4030009750
4030009740
4030019660
4030009760
4030019740
4030009840
4030009840
4030010250
4030011650
4030011690
4030010250
4030011690
4030019740
4030019740
4030019930
4030019930
4030019930
4030019740
4030019810
4030019740
4030019740
4030011700
4030019740
4030011650
4030019740
4030019650
4030009840
4030019740
4030019740
4030019930
4030009740
4030009750
4030019740
4030019740
4030009830
4030019740
4030019810
4030019810
4030009710
4030019740
4030019740
4030019740
4030019810
4030019810
4030011630
4030010250
4030009770
4030019740
4030019810
4030019560
4030019740
4030019740
4030014260
4030019740
4030011300
4030019690
4030019690
4030019930
4030011680
4030010090
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.TAN
S.TAN
S.TAN
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
DESCRIPTION
M.
H/V
LOCATION
C1005 JB 1H 102K-T
C1005 CH 1H 470J-T
C1005 CH 1H 090C-T
C1005 CH 1H 0R5B-T
C1005 JB 1A 104K-T
C1005 JB 1H 102K-T
C1005 CH 1H 180J-T
C1005 CH 1H 330J-T
C1005 CH 1H 680J-T
C1005 CH 1H 220J-T
C1005 JB 1A 104K-T
C1005 JB 0J 105K-T
C1005 CH 1H 010B-T
C1005 CH 1H 221J-T
C1005 CH 1H 030B-T
C1005 CH 1H 030B-T
C1005 CH 1H 090C-T
C1005 JB 0J 105K-T
C1005 JB 1H 122K-T
C1005 CH 1H 470J-T
C1005 JB 1H 102K-T
GRM21BB31C106KE15L
C1005 JB 1E 103K-T
C1005 JB 1H 102K-T
C1005 JB 1H 102K-T
C1005 CH 1H 221J-T
C1005 CH 1H 470J-T
TEESVA 1V 334M8R
TEESVA 1C 225M8R
TEESVA 1V 334M8R
C1005 CH 1H 100C-T
C1005 JB 1H 102K-T
C1005 JB 1H 102K-T
C1005 JB 1A 104K-T
C1005 JB 1H 102K-T
C1005 JB 1H 102K-T
C1005 CH 1H 470J-T
C1005 CH 1H 470J-T
C1005 CH 1H 470J-T
C1005 JB 1A 104K-T
C1005 JB 1H 102K-T
C1005 CH 1H 100C-T
C1005 JB 1A 104K-T
C1005 JB 1H 102K-T
C1005 CH 1H 120J-T
C1005 CH 1H 120J-T
C1005 CH 1H 100C-T
C1005 CH 1H 110J-T
C1005 CH 1H 150J-T
C1005 JB 1H 102K-T
C1005 CH 1H 060C-T
C1005 CH 1H 060C-T
C1005 CH 1H 101J-T
C1005 CH 1H 1R5B-T
C1005 CH 1H 3R5B-T
C1005 CH 1H 101J-T
C1005 CH 1H 3R5B-T
C1005 JB 1H 102K-T
C1005 JB 1H 102K-T
C1005 JB 1A 104K-T
C1005 JB 1A 104K-T
C1005 JB 1A 104K-T
C1005 JB 1H 102K-T
C1005 JB 1E 103K-T
C1005 JB 1H 102K-T
C1005 JB 1H 102K-T
C1005 CH 1H 040B-T
C1005 JB 1H 102K-T
C1005 CH 1H 1R5B-T
C1005 JB 1H 102K-T
C1005 CH 1H 050B-T
C1005 CH 1H 060C-T
C1005 JB 1H 102K-T
C1005 JB 1H 102K-T
C1005 JB 1A 104K-T
C1005 CH 1H 100C-T
C1005 CH 1H 120J-T
C1005 JB 1H 102K-T
C1005 JB 1H 102K-T
C1005 CH 1H 180J-T
C1005 JB 1H 102K-T
C1005 JB 1E 103K-T
C1005 JB 1E 103K-T
C1005 CH 1H 070C-T
C1005 JB 1H 102K-T
C1005 JB 1H 102K-T
C1005 JB 1H 102K-T
C1005 JB 1E 103K-T
C1005 JB 1E 103K-T
C1005 CH 1H 0R5B-T
C1005 CH 1H 101J-T
C1005 CH 1H 220J-T
C1005 JB 1H 102K-T
C1005 JB 1E 103K-T
GRM21BB31C106KE15L
C1005 JB 1H 102K-T
C1005 JB 1H 102K-T
C1005 JB 1H 331K-T
C1005 JB 1H 102K-T
C1005 CH 1H 121J-T
C1005 CH 1H 221J-T
C1005 CH 1H 221J-T
C1005 JB 1A 104K-T
C1005 CH 1H 030B-T
C1005 CH 1H 560J-T
B
T
T
T
T
T
T
T
T
T
B
B
T
T
T
T
T
B
B
B
B
B
B
B
B
B
B
T
T
T
B
B
T
T
T
T
T
T
T
T
T
T
T
T
B
B
B
B
B
B
B
B
B
B
B
B
B
T
B
B
B
B
B
B
B
B
B
B
B
B
B
B
T
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
B
T
B
T
B
B
B
T
B
B
B
B
B
T
T
56.3/30.6
53.2/28.5
53.2/27.5
59.8/21.2
56.2/21.8
61.8/21.8
59.8/25.9
60.7/21.2
61.6/25.9
61.1/27.2
56.3/28.9
61.4/27.7
61.1/29.2
62.8/25.3
64.8/23.7
63.8/23.1
64.8/25.3
65.4/27.7
60.2/31.1
65.9/24.9
61.5/32.5
61.1/19.7
61.1/17.6
48.8/28.4
54.7/30.5
62.8/30.8
59.9/21.6
48.9/29.5
46.7/29.5
47.9/20.5
51.4/19.3
48.3/23.8
46.1/21.4
43.1/20.3
43.1/19.4
43.1/18.5
44.5/32.6
43.6/32.6
42.7/32.6
48.6/32.6
41/19.4
39.2/19.4
40.1/10.9
41.9/10.9
48.8/21.5
47.9/21.5
48.2/20.2
16.2/18.5
13.9/22.2
13.4/24.8
12.4/24.8
13.4/26.5
16.4/25.8
17.9/29.1
19.4/27.7
19.4/25.8
22.8/27.8
19.2/21.7
18.4/24.1
17.4/24.1
21.7/30
25.3/30
27.1/23.9
28.7/28.7
26.2/25.6
25.3/25.6
28.2/27.5
29.2/25.6
31/29.8
31.9/25.6
34.4/26.8
34.4/28.5
31.8/23.2
29.2/23.9
30.1/23.9
47.4/16.6
35.4/25.1
34.4/23.5
37.4/25.1
42.2/27.7
41.4/25.1
40.4/25.1
37.7/29.8
40.4/34.6
42.4/23.5
45.7/17.6
39/39.8
37.3/44.4
35.6/41.8
35.6/39.8
40.9/41.8
43/38.6
40.9/39
47.3/35.5
44.5/42.6
47.1/43.1
41.3/40.3
43/39.6
44.7/35.5
46.5/32.8
48.3/34.6
46.5/35.5
50.2/37
41.5/34.6
39.4/33.4
S.=Surface mount
6-3
[MAIN UNIT]
REF
NO.
C253
C254
C255
C256
C257
C261
C262
C263
C264
C265
C266
C267
C301
C302
C303
C304
C305
C306
C307
C308
C309
C310
C312
C313
C314
C316
C318
C321
C322
C323
C324
C325
C326
C328
C329
C330
C331
C332
C333
C334
C335
C336
C337
C338
C339
C340
C342
C343
C344
C346
C347
C348
C349
C350
C351
C352
C353
C354
C356
C357
C358
C361
C362
C363
C364
C365
C371
C372
C373
C376
C377
C378
C379
C380
C381
C382
C383
C385
C388
C389
C390
C391
C393
C395
C397
C398
C399
C400
C401
C403
C404
C405
C406
C408
C412
C413
C421
C423
C424
C426
C427
C429
C430
C431
C432
[MAIN UNIT]
PARTS
NO.
4030009840
4030010090
4030019810
4030009740
4030019810
4030019930
4030019810
4030019810
4030019810
4030019810
4030019810
4030019930
4030019930
4030019810
4030019690
4030019460
4030019900
4030019890
4030019930
4030019800
4030019860
4030019930
4030019850
4030019930
4030019750
4030019930
4030019810
4030019720
4030019740
4030019710
4030019810
4030011320
4030019810
4030019970
4030013910
4030019810
4030019810
4030013910
4030013910
4030019740
4030019740
4030019970
4030019740
4030019740
4030019740
4030019930
4030019740
4030019560
4030019930
4030019890
4030019810
4030019890
4030019930
4030009800
4030019690
4030019930
4030019810
4030019810
4030019560
4030019810
4030019930
4030019930
4030019930
4030019930
4030013910
4030011320
4030013910
4030019680
4030019900
4030019740
4550007320
4030019740
4550006780
4030011320
4030019850
4030019850
4030009800
4030019930
4030019740
4030019740
4030019740
4030011320
4520000020
4520000020
4030019740
4030019740
4030019930
4550006250
4030019930
4030019930
4030019930
4030019970
4030019740
4030019930
4030019740
4030019740
4030019930
4030019810
4030019740
4030019810
4030019930
4030019810
4030019930
4510009870
4030019740
DESCRIPTION
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.TAN
S.CER
S.TAN
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.NIO
S.NIO
S.CER
S.CER
S.CER
S.TAN
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.ELE
S.CER
C1005 CH 1H 060C-T
C1005 CH 1H 560J-T
C1005 JB 1E 103K-T
C1005 CH 1H 100C-T
C1005 JB 1E 103K-T
C1005 JB 1A 104K-T
C1005 JB 1E 103K-T
C1005 JB 1E 103K-T
C1005 JB 1E 103K-T
C1005 JB 1E 103K-T
C1005 JB 1E 103K-T
C1005 JB 1A 104K-T
C1005 JB 1A 104K-T
C1005 JB 1E 103K-T
C1005 CH 1H 221J-T
C1608 JB 0J 106M-T
C1005 JB 1A 473K-T
C1005 JB 1A 393K-T
C1005 JB 1A 104K-T
C1005 JB 1H 682K-T
C1005 JB 1E 223K-T
C1005 JB 1A 104K-T
C1005 JB 1E 183K-T
C1005 JB 1A 104K-T
C1005 JB 1H 122K-T
C1005 JB 1A 104K-T
C1005 JB 1E 103K-T
C1005 JB 1H 561K-T
C1005 JB 1H 102K-T
C1005 JB 1H 391K-T
C1005 JB 1E 103K-T
C1005 CH 1H 470J-T
C1005 JB 1E 103K-T
C1005 JB 0J 105K-T
C1005 JB 1H 472K-T
C1005 JB 1E 103K-T
C1005 JB 1E 103K-T
C1005 JB 1H 472K-T
C1005 JB 1H 472K-T
C1005 JB 1H 102K-T
C1005 JB 1H 102K-T
C1005 JB 0J 105K-T
C1005 JB 1H 102K-T
C1005 JB 1H 102K-T
C1005 JB 1H 102K-T
C1005 JB 1A 104K-T
C1005 JB 1H 102K-T
GRM21BB31C106KE15L
C1005 JB 1A 104K-T
C1005 JB 1A 393K-T
C1005 JB 1E 103K-T
C1005 JB 1A 393K-T
C1005 JB 1A 104K-T
C1005 JB 1H 471K-T
C1005 CH 1H 221J-T
C1005 JB 1A 104K-T
C1005 JB 1E 103K-T
C1005 JB 1E 103K-T
GRM21BB31C106KE15L
C1005 JB 1E 103K-T
C1005 JB 1A 104K-T
C1005 JB 1A 104K-T
C1005 JB 1A 104K-T
C1005 JB 1A 104K-T
C1005 JB 1H 472K-T
C1005 CH 1H 470J-T
C1005 JB 1H 472K-T
C1005 CH 1H 181J-T
C1005 JB 1A 473K-T
C1005 JB 1H 102K-T
F930J226MAABMA
C1005 JB 1H 102K-T
TEESVB2 0J 476M8R
C1005 CH 1H 470J-T
C1005 JB 1E 183K-T
C1005 JB 1E 183K-T
C1005 JB 1H 471K-T
C1005 JB 1A 104K-T
C1005 JB 1H 102K-T
C1005 JB 1H 102K-T
C1005 JB 1H 102K-T
C1005 CH 1H 470J-T
NOJC227M006
NOJC227M006
C1005 JB 1H 102K-T
C1005 JB 1H 102K-T
C1005 JB 1A 104K-T
TEESVA 1A 106M8R
C1005 JB 1A 104K-T
C1005 JB 1A 104K-T
C1005 JB 1A 104K-T
C1005 JB 0J 105K-T
C1005 JB 1H 102K-T
C1005 JB 1A 104K-T
C1005 JB 1H 102K-T
C1005 JB 1H 102K-T
C1005 JB 1A 104K-T
C1005 JB 1E 103K-T
C1005 JB 1H 102K-T
C1005 JB 1E 103K-T
C1005 JB 1A 104K-T
C1005 JB 1E 103K-T
C1005 JB 1A 104K-T
10 CE 100 LD
C1005 JB 1H 102K-T
H/V
M.
LOCATION
T
T
T
T
T
B
B
B
B
B
B
T
B
B
B
T
T
T
T
T
T
T
T
T
T
T
B
T
T
T
T
T
T
T
T
T
T
T
T
B
B
B
B
B
B
B
B
B
T
T
T
T
T
T
T
T
T
T
B
T
T
B
B
B
B
B
T
T
T
B
B
B
B
B
B
B
B
B
B
B
B
B
B
T
T
B
B
T
B
B
B
B
T
T
T
T
T
B
T
B
T
B
T
T
T
41.5/33.6
39.4/32.5
41.5/29.6
39.2/24.6
36.9/31.4
50.5/38.6
50.2/40.7
57.1/41.5
53.9/36
58.7/36.9
57.4/35.1
50.9/34.6
69.3/12.4
66.6/14.1
68.4/10.7
62.6/42
76.4/32.9
65.5/37.9
63.5/39.6
65.5/39.6
67.3/41.2
62.6/37.9
74.6/29.5
77/29.5
74.6/26
77.4/30.7
70.6/28.7
85.7/29.4
85.7/27.7
84.8/26
86.6/26
87.5/26
71.8/15.6
72.8/24.3
74.6/24.3
72.7/13.8
72.7/12
73.6/10.2
74.5/10.2
15/46.6
26/43.9
56/8.7
52.5/7.5
50.7/7.5
53.4/7.5
57.8/10.5
47.1/6.4
57.6/7.3
59.5/6.4
79.2/8.4
82.2/8.4
81.2/8.4
85.6/10.2
86.5/13.8
85.6/15.6
86.5/12
87.4/23.1
84.1/23.1
76.9/28
83.2/33
82.3/33
76.8/22.2
72.1/19.7
69/28.7
60.8/9.4
61.7/4.6
74.5/12
75.4/13.8
74.5/17.4
77.6/16.9
79.7/17.3
76.7/17.4
84.5/11.6
60.8/11
68.4/8
68.4/6.3
70.2/4.6
72.1/4.1
20.9/3.5
43.6/2.8
53.1/2.8
37.3/46.3
19.8/40.5
21.7/37.1
25.5/37.4
12.2/32
22.2/37.1
12.9/40.8
12.2/37.6
15/39.5
12.2/38.5
19.3/33.7
21.4/34.6
5.2/37.8
6.5/42.8
6.8/44.8
75.4/12
65.2/38.4
63.8/34.4
69/30.3
73.7/26
77.2/25.7
65.9/11.4
14.7/27.1
14.3/31.7
REF
NO.
PARTS
NO.
DESCRIPTION
C1005 JB 1A 104K-T
C1005 JB 1E 103K-T
C1005 JB 1H 102K-T
F930J226MAABMA
C1005 JB 1A 104K-T
C2012 JB 1A 106K-T
C1005 CH 1H 330J-T
C1005 CH 1H 100C-T
C1005 CH 1H 220J-T
C1005 JB 1A 104K-T
C1005 JB 1A 104K-T
C1005 JB 1A 273K-T
C1005 JB 1A 104K-T
C1005 JB 1A 104K-T
C1005 JB 1A 104K-T
C1005 JB 1A 104K-T
C1005 JB 1A 104K-T
C1005 JB 1A 104K-T
C1005 JB 1E 103K-T
C1005 JB 1A 104K-T
C1005 JB 1H 102K-T
C1005 CH 1H 470J-T
H/V
LOCATION
T
T
T
B
T
B
B
B
B
B
B
B
T
B
B
B
B
T
T
B
B
B
16.2/32.2
14.3/32.6
18/32.2
85.2/44.4
17.1/32.2
27.8/46
86.6/38.5
86.1/37.3
87/35.2
86.1/32.2
87.9/32.2
86.8/46.9
84.7/45.5
85.2/40.6
79.5/46.1
80.4/46.1
81.3/46.1
77.4/35
79/35
85.2/32.2
29.1/43.9
28.2/43.9
C433
C434
C435
C436
C437
C448
C451
C452
C453
C454
C456
C457
C458
C459
C460
C461
C462
C465
C466
C467
C469
C470
4030019930
4030019810
4030019740
4550007320
4030019930
4030019490
4030009790
4030009740
4030009770
4030019930
4030019930
4030019870
4030019930
4030019930
4030019930
4030019930
4030019930
4030019930
4030019810
4030019930
4030019740
4030011320
J51
J52
J53
6450000131 CON
HSJ1102-018540
6450002250 CON
HSJ1456-010320
6510021901 S.CON BM02B-ASRS-TF(LF)(SN)
27.8/34.5
F51
5210000970 S.FUS
ERBSE3R00U
10.7/37.6
DS51
5040002670 S.LED
CL-165HR/YG
2.6/37.9
MC51
7700002920 MIC
EM9745P-38-G-01 <HOR>
S51
S52
S53
S54
2260001900
2260002800
2260002800
2250000670
SWI
S.SWI
S.SWI
ENC
SW-149 (SKHLLD)
SW-167 (SKQTLAE010)
SW-167 (SKQTLAE010)
TP70TF5169-15.9F-3285
B
B
39.2/1.8
48.7/1.8
EP2
EP3
EP4
EP5
EP6
EP51
6910018460
6910018460
6910018460
6910018460
6910014730
6910018460
S.BEA
S.BEA
S.BEA
S.BEA
S.BEA
S.BEA
MMZ1005Y102C-T
MMZ1005Y102C-T
MMZ1005Y102C-T
MMZ1005Y102C-T
MPZ2012S331A-T
MMZ1005Y102C-T
B
B
T
T
B
B
32.8/15.5
63.4/21.2
41.9/19.4
41/10.9
25.2/21.4
19.1/46.2
MP3
MP4
MP5
8510016471
6910014760
6910014760
6910014760
6910014760
6910014760
6910014760
6910014760
6910014760
6910014760
6910014760
6910014760
6910014760
6910014760
S.CAS
S.PLA
S.PLA
S.PLA
S.PLA
S.PLA
S.PLA
S.PLA
S.PLA
S.PLA
S.PLA
S.PLA
S.PLA
S.PLA
2775 VCO CASE-1

OG-503040
OG-503040
OG-503040
OG-503040
OG-503040
OG-503040
OG-503040
OG-503040
OG-503040
OG-503040
OG-503040
OG-503040
OG-503040
T
B
[EUR-21] B
[EUR-22]
[EUR-23]
[UK-01]
[UK-02]
[UK-03]
[EUR-21] B
[EUR-22]
[EUR-23]
[UK-01]
[UK-02]
[UK-03]
58.8/23.2
15.1/8.2
29.8/35.6
MP51
S.CER
S.CER
S.CER
S.TAN
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
S.CER
M.
22.2/45.3
S.=Surface mount
6-4
SECTION 7.
MECHANICAL PARTS
[CHASSIS PARTS]
REF
NO.
ORDER
NO.
[ACCESSORIES]
DESCRIPTION
REF
NO.
QTY.
J1
6910021491 ANT CONNECTOR 106-1
SP1
2510001560 045P01202-02
W1
8900009640 OPC-963
EP1
EP2
ORDER
NO.
(Optional)
(Optional)
0910066420 ANT PCB B-7261
MP1
MP2
MP3
MP4
MP5
MP6
MP7
MP8
MP9
MP10
MP11
MP12
MP13
MP14
MP15
MP16
MP17
MP18
MP19
MP20
MP21
MP22
MP23
MP24
MP25
MP26
MP27
MP28
MP31
MP32
MP33
MP34
8010021710
8210026011
8210025830
8930080110
8930080130
8930079890
8210025800
8930080380
8930080180
8930080170
8930080120
8930080620
8930080630
8930042350
8930080410
8930079900
8930080100
8930080400
8930069710
8830003390
8930080091
8930080150
8930080140
8830003440
8610014180
8610007510
8610014190
8610007920
8810008761
8810009511
8810009511
8810009181
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
1
2
1
1
1
1
1
1
1
1
2
9
1
2
3285 CHASSIS
3285 FRONT PANEL-1 (incl. MP39)
3285 PTT PANEL
3285 PTT BUTTON
3285 PTT RUBBER
3285 LOCK PLATE
3285 BOTTOM PANEL
3285 SHAFT
SP NET (F)
3285 NAME SHEET
3285 LENS
O-RING (CF)
3285 SP PLATE
1922 MIC SHEET
3285 MIC SPONGE
3285 TERMINAL HOLDER
3285 PLUS TERMINAL
3285 MINUS TERMINAL
THERMALLY SHEET (BC)
VR NUT (AB)
3285 SIDE PLATE-1
3285 SIDE SEAL
3285 TOP SEAL
3285 ANT NUT
KNOB N-389 (incl. MP26)
KNOB SPRING NO.7800
KNOB N-390 (incl. MP28)
KNOB SPRING NO.1500
SCREW BT B0 2X8 NI-ZC3 (BT)
0TAP 1FLAT WASHER B0 2X5 NI-ZC3 (BT)
EP3
1
1
1
1
MB-124
[USA-11], [USA-12], [USA-13], [EXP-11], [EXP-12],
[EXP-13], [EXP-21], [EXP-22], [EXP-23], [EXP-01],
[EXP-03], [EXP-31], [AUS-21], [AUS-22], [AUS-23],
[RUS-21], [RUS-22], [RUS-23]
8210025840 3285 JACK PANEL
8810004861 SCREW PH M2X6 ZK3
1
1
2
(Optional)
(Optional)
(Optional)
EP4
(Optional)
(Optional)
(Optional)
(Optional)
(Optional)
(Optional)
(Optional)
MP1
MP2
MP3
EP1
EP2
EP4
EP3
ORDER
NO.
DESCRIPTION
QTY.
R421
7210003061 VAR TP76N00N-15F-A103-2251A
J51
J52
J53*
6450000131 HSJ1102-018540
6450002250 HSJ1456-010320
6510021901 BM02B-ASRS-TF (LF) (SN)
1
1
1
DS51*
5040002670 CL-165HR/YG
MC51
7700002920 EM9745P-38-G-01
S51
S52*
S53*
S54
2260001900
2260002800
2260002800
2250000670
SW-149 (SKHLLD)
SW-167 (SKQT)
SW-167 (SKQT)
TP70TF5169-15.9F-3285
1
1
1
1
MP2
MP3*
MP4*
MP5*
MP6
MP51*
8510016461
8510016471
6910014760
6910014760
8930080760
6910014760
2775 VCO COVER-1

2775 VCO CASE-1
OG-503040
OG-503040
SPONGE (KT)
OG-503040
1
1
1
1
1
1
[IC-F3002] only
[IC-F3002] only
MP1
MP2
*: Refer to BOARD LAYOUTS for the location.

Screw abbreviations
A, B0, BT: Self-tapping PH: Pan head ZK: Black NI-ZU: Nickel-Zinc SUS: Stainless
7-1
1
1
1
1
(Optional)
[MAIN UNIT]
REF
NO.
QTY.
FA-SC55V-2
BP-264 EXP
[USA-11], [USA-12], [EXP-11], [EXP-12], [EXP-21],
[EXP-22], [EXP-01], [AUS-21], [AUS-22], [RUS-21],
[RUS-22], [EUR-21], [EUR-22], [UK-01], [UK-02]
BP-265
[USA-13], [EXP-13], [EXP-23], [EXP-03], [AUS-23],
[RUS-23], [EUR-23], [UK-03]
BC-191 EXP
[USA-11], [EXP-11], [EXP-21], [AUS-21], [RUS-21],
[EUR-21], [UK-01]
BC-192 EXP
[EUR-22], [UK-02]
BC-193 EXP
[EUR-23], [UK-03]
BC-123SA (L)
[USA-11], [USA-13], [EXP-11]
BC-147SA
[USA-12], [EXP-12]
BC-123SA
[EXP-13]
BC-123SE (L)
[EXP-21], [EXP-23], [RUS-21], [RUS-23],
[EUR-21], [EUR-23]
BC-147SE
[EXP-22], [RUS-22], [EUR-22]
BC-123SV (L)
[AUS-21], [AUS-23]
BC-147SV
[AUS-22]
(Optional)
EP1
DESCRIPTION
MP3
MP23(C)
J1(C)
MP202(C)
MP1(C)
MP19(C)
EP1(C)
MP312(C)
MP16(C)
MP18(C)
MP22(C)
MP33(C)
MAIN UNIT
MP312(C)
S51(M)
S54(M)
MP17(C)
R421(M)
MP32(C)
MP27(C)
J52(M)
MC51(M) MP2(M)
MP13(C)
J51(M)
MP342(C)
MP25(C)
MP3(C)
MP21(C)
MP24(C)
MP11(C)
MP32(C)
MP12(C)
MP4(C)
MP342(C)
MP5(C)
SP1(C)
W1(C)
MP15(C)
MP9(C)
MP14(C)
MP10(C)
MP2(C)
UNIT ABBREVIATIONS
(C): CHASSIS PARTS
(M): MAIN UNIT
MP6(C)
MP7(C)
MP8(C)
7-2
H0
H5
H10
H15
H20
R9
IPTT
R16
Q6
C31
D35
KEY1KEY2
-TMUT
-T5V
R364
REF
-VCON
C344
MMUT
IC62
R384
C351
R378
R356
R350
R344
C322
C321
R342
R341
X51
R349
C357
X51
IC61
IC56
C353
-TMUT
C44
-EPTT
-ATX
MC51
-VOXV
J54
V50
BATV
RMUT2
-ADSW
-NOIS
-UNLK
-RMUR1
MMUT
LVIN
TLED
CPU5
NC
RLED
OPT2
TLED
RES
OPT1
NC
NMI
DUSE
GND
GND
GND
GND
B7246B
C325
R345
C324
R346
R343
R348
C358
R420
RLED-
R464
R468
Q83
IC61
VHF
C350
C354
C352
C323
IC59
R375
IC58
R379
AFON-
C349
R377
Q52
R331
R374
R373
C316
R439
IC59
R329
C313
R327
C312
R326
R325
C305
R457
C347
Q10
IC56
+5V
BALS5V
MOD-
IC58
R328
R321
R330
C466
C348
C314
R351
C427
R355
C329
C328
IPTTC465
R372
C372
C421
R354
C373
-SO
-SCK
R391
DISC
R385
R463
C371
R310
C333
C111
R387
C330
R5C
R386
C331
R316
-CDEC
R469
C309
R315
C304
R314
Q82
R318
R317
C308
C306
C307
R313
R312
C232
R311
C310
V45
CPU5CL-
C346
R371
R353
DISCVREF
C430
SDEC
C326
C107
L41
PLST
R381
C115
FI3
R382
C113
C424
R401
R383
L42
L40
R137
C332
BAL
Q51
R352
C81
D16
C156
C112
D18
C114
R57
R136
IC62
TEMP
C106
C239
D17
R56
R407
C397
C400
X1
C77
R48
R55
Q14
C103
MP3
C104
C89
R54
C86
D15
D14
C105
Q13
C101
C83
Q8
C78
C75
C87
C267
DS51
V40
C412
R47
C152
D11
L33
C151
L35
R369
C150
C88
C94
C74
R78
R53
R76
C102
R77
L36
C93
C85
IC2
D12
D13
-R5V
R42
L37
C234
Q25
C251
C73
R80
C132
C253
C134
C153
C154
C155
IC54
PWON
R405
C135
L24
V35
R135
L31
R41
-HV
C149
C257
R148
C254
R83
C255
Q26
EP4
IC2
R149
Q85
R441
C435
C437
C433
C252
R368
R88
T1
R89
X2
X2
C157
C256
C431
V30
L23
C160
EP5
R82
C158
-T2
C159
-APCV
C32
R13
C201
V25
R413
C27
C34
C33
R15
R18
R12
C28
R10
V20
-T1
R14
C29
R11
V15
J53
C30
R17
IC1
V10
PDET-
R8
C26
V5
C182
H25
C432
H30
R438
AFON
H35
C434
C406
H40
C395
H45
8-1
FUSE
H50
Q76
F51
AFO
H55
R424
H60
Q75
R423
X1
H65
C408
-VCC
H70
C413
FI2
H75
J51
J52
H80
H85
MAIN UNIT
(TOP VIEW)
H90
SECTION 8.
V0
The combination of top side and bottom side of this
BOARD LAYOUTS
[SPEAKER MICROPHONE JACK]

Internal speaker
C458
The combination of top side and bottom side of this
V50
V40
C403
C398
V30
C186
C175
L13
V25
C174
C173
C183
C176
R156
C184
C180
R112
C202
C189
L12
C168
L11
V20
C12
D22
C43
C171
L4
C20
L5
C15
V15
D1
L7
C6
C7
Q1
L2
C4
C5
C16
V10
C18
C21
C23
C49
C48
R22
R26
C35
R21
C53
R25
R23
C54
R24
MP4
R7
Q59
C338
C337
R362
C339
V5
R1
R396
R394
C365
R397
C389
C390
8-2
V0
H55
R395
H60
R393
H65
C383
R427
H50
C364
R398
R426
C382
H45
C380
R370
C381
H40
Q3
R302
R303
C303
R304
H35
C167
R45
C76
R67
C302
R301
C301
H30
R131
C211
R130
L19
R118
R129
R120
C217
C216
R122
Q11
Q12
C79
EP3
C362
H70
H75
C376
C378
H25
C196
C203
R65
R402
C361
R347
H20
R114
R157
C192
C193
R110
D24 R104
D26 R105
L14
C179
Q22
L15
R113
C195
R115
R62
R66
C223
C214
C210
R117
C198
C116
IC57
R435
C377
H80
R388
C379
H15
R107
R109
R111
C188
Q21
C199
Q23
L16
C200
R116
R119
L20
R121
C215
C123
R403
C363
C318
C109
L39
L34
C108
R73
Q17
C124
C90
C117
R70
C127
Q72
R433
C426
R436
R475
R459
R458
C8
R389
[PTT SWITCH]
V35
Q74
R437
C405
R414
FI1
R322
R323
R324
C467
H10
R417
C399
C244
D32
R81
R477
H85
IC52
H5
R412
R134
C238
IC3
R151
R153
R154
C265
Q71
R467
IC51
R451
C454
R454
S51
H0
Q84
R361
C335
C470
C469
Q24
R440
IC55
[VOLUME CONTROL]
IC3
C262
C263
R466
C459
R455
C456
PDET
V45
EP51
MP51
D51
Q81
R470
R476
C460
C461
C462
C436
C452
C453
S52
S53
C2
-TMUT
C342
Q63
R453
C36
C336
C334
CPU5-
R472
C457
D53
[LOWER KEY] [UPPER KEY]

MC51
R360
R363
C388
R428
R429
R430
S52
S53
C385
R366
C3
C17
L1
-VCON
Q58
C343
-EPTT
-ATX
D3
C59
-APCV
IC60
R359
MMUT-
R35
R6
C340
SDEC-
C60
C46
R33
C64
L9
C58
L18
C56
R36
TEMP
IC60
R37
C65
DISC-
C55
C206
L6
L3
R38
C52
Q2
C57
R31
R32
C63
D5
EP2
R390
C41
C224
R132
C122
D6
C71
+5V
-VREF
S5V
C72
R2
L46
C11
C169
L32
S54
C172
-T1
EP6
R44
C130
C51
-T5V
R51
L43
D23
R52
L8
Q9
Q15
C141
C121
MOD-
C118
IC52
PWON
C401
R418
[ROTARY SELECTOR]
R106
-REF
C145
Q73
L38
C80
C429
C178
R108
C191
+5V
R61
R103
D55
RSSI
R141
C181
D28
R72
C356
C197
C218
R123
R71
R87
R434
R460
R462
LVA
-SQIN
R68
R432
R461
R101
D21
R142
R69
R102
C241
C120
R442
R140
C220
Q64
R138
C243
C242
C240
R139
C393
R125
R127
R416
MP5
C264
R158
NWC
R152
C266
R431
Q27
C227
C231
R421
C404
C261
C228
C225
R155
PWON
C233
D34
C423
C451
Q19
D52
R146
IC55
C235
R147
R126
D31
D33
-RES
C236
R456
C226
R406
R471
R128
IC53
C448
R408
C391
-CL
R474
R473
J51
J52
MAIN UNIT
(BOTTOM VIEW)
H90
SECTION 9.
BLOCK DIAGRAM
S5V
136-174MHz
Q15
2SC4116
Q17
2SK880
LVIN
Q13 2SC4226
D12,13:HVD376B
RIPPLE
FIL
BUFF
D11
HVL375C
15.3MHz
X2
CR-794
IC60
NJM12902
MAIN UNIT
Q11:LDTC144EE
VCO
SW
R5V
RX VCO
LV
ADJ
Q10
2SC5107
D5:HVD142A
D6:HVD142A
Q8
2SC5107
Q1
RD07MUS2B
Q2
RD01MUS1
Q3
2SC5107
D3
RB876W
D1:HVD144A
D 22:HVD144A
BAL
REF
LOOP
FIL
TCXO
BUFF
LV
LVA
Q26
2SC4116
X3
LPF
BPF
PRE
DRIVE
RSSI
ATT
BUFF
D15
HVL355CM
182.35MHz-220.35MHz
VCO
SW
FI1
FL-442
Q24
2SC5107
Q6
LDTA144EE
APC
AMP
MUTE
SW
BPF
D26
HVL375C
RF
AM P
BPF
TMUT
D24
HVL375C
BPF
BPF
Q22
3SK293
FI2
LTM450FW
CERAMIC
BPF
W/N
SW
X1
SQIN
FI3
LTW450HW
VOL1
R133
LPF
IC1
TA75S01F
GATE
CTRL
D28
HVB350BYPTL
D28
HVB350BYPTL
Q23
3SK293
46.35MHz
XTAL
BPF
IF
AM P
MIXER
RSSI
450kHz
Q25
LDTC144EE
W/N
SW
NOIS
W/N
SW
T1
T1
T2
JTBM450CX
CERAMIC
BPF
DISC
ANT
SW
R5C
IC3:NJM2591V
D/A
PWR
DET
Q12:LDTC144EE
IF IC
D31:D32
1SS390
PWR
AM P
DRIVE
AM P
Q21
2SK1829
Q9
Q14 2SC4226
D16,17:HVD376B 2SC5107
FM
MOD
45.9MHz
TX/RX
SW
BUFF
TX VCO
LV
ADJ
IC2
M B15A02PFV1
PLL
IC
BUFF
D14
HVL375C
D33,D34:1SS390
Q27:LDTA144EE
450kHz
IC59
LM2902PWR
NWC
LVA,T1,T2
R132
IC56
CD4066BPWR
LPF
IC58
NJM12902V
VOL1
IC62
CD4066BPWR
HPF
RX
MUT E
IC58
NJM12902V
IC58
NJM12902V
Q58:UNR911HG0
EPTT
J51
PTT
DET
RMUT 1
S1
S2
LPF
TONE
VOL1
R133
IC58
NJM12902V
IC62
CD4066BPWR
IC60
NJM12902V
MC51
Q59:LDTC144EE
EM9745P
MMUT
ANALOG
SW
AM P
MIC
MUTE
HPF
ATX
AM P
AUTO_TX
CTRL
RMUT 2
S3
S4
AFO
IC60
LM2902
D 53:L1SS400
T5V
IC62
CD4066BPWR
MIC
GAIN
CTRL
M GC0
M GC1
R132
CTCSS/DTCS
VOXV
VOL1
IC55
AMP
DET
MOD
NJM12902V
RBEEP
AF
AM P
TBEEP
IC52
R1EX24016ATA00A
IC59
LM2902PWR
IC57
R2A20178
AFON
IC61:CD4053B
BEEP
SENC
BEEP
SW
T5C
BEEP
SW
Q63:2SB1132
Q64:XP6501
SDEC
AFON
R88
VCC
TEMP
PWR
CTRL
Q73
KTA2015
CPU
AFVI
T5
REG
AF VOL
IC51
IC59
LM2902PWR
R4F20102
CENC0-2
PTT
IPTT
PUSH1
F1
P1
VCC
R5
REG
+5V
REG
S5
REG
S5C
S54
TP70TF5169
S5V
+5V
IC53
N JU7704F3
CH
SELECT
RES
CSFT
D52
1SS390
R5V
Q71
KTA2015
P2
PUSH1
PUSH1
F2
FIL
SW
CLONE
BUFF
R5C
PWON
KEY1
KEY2
DUSE
D51:LRB706F
Q81:UNR9210G0
Q72
2SA1586
Q74:2SB1132
Q75:XP6501
Q76:LDTC144EE
X51
CR-864
IC54
NJM2871BF05
CPU5
Q82:Q83
LDTA144EE
12.288MHz
9-1
F51
S5
YG
VCC
12
SW12
LED
CTRL
SHIFT
SW
CPU5
CPU5
REG
RESET
HR
DS51
CL-165HR
ERBSE3R00U
BT1
LPF
Q52
LDTC144EE
T5V
CDEC
LPF
BATTERY_1
DISC
T5C
R1
CTCSS/DTCS DEC
Q51
XP4601
J53
1
2
AF
AM P
IC61
CD4053B
LPF
J52
IC12
TA7368F
EEPROM
LPF
IC60
NJM12902V
TPA0211
SP1
1.5k
T1
T2
SO
SCK
DAST
LVA
0.0047
C364
VIN6
13
VDAREF1
14
VDAREF2
15
RESET
16
GND
17
VIN7
18
PLST
NJM12902V
1.5k
R390
0.001
C378
MOD
VCON
SQIN
T1
1k
12k
R389
C377
R388
0.001
22
LVA
T2
R387
LVIN
0.047
2.2k
1.5k
C373
RSSI
D ISC
UNLK
SO
SCK
PLST
NW C
TMUT
MOD
VCON
SQIN
LVA
T1
T2
LVIN
R SSI
DISC
NOIS
UNLK
VREF
C379
47 MSVB2
0.01
1M
RBEEP
C357
R348
VREF
10k
R347
AFO
C376
180P
C372
R391
0.0047
C371
33k
0
0.01
C354
0.1
MMUT
T5V
82k
6
5
4
3
2
1
VIN3
DI
CLK
LD
VDD
VIN2
R395
0.1
C362
470k
R346
R356
47P
C325
10k
R350
0.01
0.1
C352
390P
C323
120k
R394
0.1
R403
C361
R402
470
C316
47k
C358
CD4066BPWR
100k
R470
VDD
Y
X
X1
X0
A
B
C
16
15
14
13
12
11
10
9
BEEP
STONE
SDEC
SENC
T5C
BATV
RSSI
TBEEP
RBEEP
0.1
C465
CPU5
D51
LRB706F
CD4053B
0.1
R471
Y1
Y0
Z1
Z
Z0
INH
VEE
VSS
C462
CLO
1
2
3
4
5
6
7
8
0.1
UNR9210G0
Q81
IC61
0.1
C461
1k
R476
C460
CL
TMUT
MMUT
RMUT1
RMUT 2
UNLK
NOIS
VOXV
AFVI
TEMP
LVIN
0.01 10k
C423 R431
R473 100k
15k
R472
R474
15k
100k
0.01 10k
64
63
62
61
60
59
58
57
56
55
54
53
52
51
50
49
PB5/AN5
PB4/AN4
PB0/AN0
PB1/AN1
PB2/AN2
PB3/AN3
PA7
PA6
PA5
PA4
P13/IRQ3
P12/IRQ2
P11/IRQ1
P24/TRDOI_0
P27/TXD_2
P26/RXD_2
Q83
R468
LDTA144EE
1.8k
48
47
46
45
44
43
42
41
40
39
38
37
36
35
34
33
HR
CL-165HR
R466
R467
100k
100k
DUS E
CBI3
CBI2
CBI1
CBI0
CENC0
OPT2
OPT1
NMI
RLED
TLED
CENC1
CENC2
10k
0.1
0.1
C456
IC51
R4F20102NFA
390
MGC1
MGC0
P25/SCK3_2
P23/TRCOI
P22/TXD
P21/RXD
P20/SCK3
P87/TREO
P86/TRBO
P85/TRAIO
P67/FTIOD1
P66/FTIOC1
P65/FTIOB1
P64/FTIOA1
P60/FTIOA0
NMI
P61/FTIOB0
P62/FTIOC0
R463
12k
100k
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
C436
C454
R455
R464
IPTT
R88
CPU5
R460
100k
R89
4.7k
4.7k
R462
R461
ESDA
ESCL
100k
1k
1k
TEMP
ERTJ0EP473 J
IC52
8
7
6
5
VCC
WP
SCL
SDA
1
A0
2
A1
3
A2
4
VSS
R1EX24016ATA00A
R5C
T5C
S5C
PWON
KEY2
KEY1
PLST
DAST
SCK
SO
R458
R459
R475
4.7k
AFON
C466
0.01
BEEP
NWC
EPTT
ATX
0.1
CPU5
C467
CP05S
CP05S
CP05S
CP05S
CP05S
CP05S
CP05S
NMI
DUSE
CP6
CP7
CP8
CP9
CP10
CP12
CP11
R457
16
0.1
R477 1k
15
C459
C437
0.001
J54
1
2
3
4
5
6
7
8
9
10
11
12
13
14
TP70TF5169
LDTC144EE
PB6/AN6/DA0
PB7/AN7/DA1
AVCC
X2
X1
AVSS
RES
TEST
VSS
PJ1/OSC2
PJ0/OSC1
VCC
P37/TXD_3
P36_RXD_3
P35/SCK3_3
P34/FTCI
CPU5
PWON
CBI0
CBI3
CBI2
CBI1
CSFT
22
1SS390
12k
D52
R453
10P
C452
0.01
4
33P
VOUT
NJM2871BF05
C451
VIN
Q76
TP76N00N
C458
0.027
C457
0.1
C433
CTRL
GND
NB
22k
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
P33/FTIOD
P32/FTIOC
P31/FTIOB
P30/FTIOA
P15/IRQ5
P16/IRQ6
P17/IRQ7
P54/SSO
P55/SSCK
P56/SDA/SCS
P57/SCL/SSI
P53/TGIOB
P52/TGIOA
P51/TCLKB
P50/TCLKA
P63/FTIOD0
C429 R435
C432
100
1
2
3
C434
4.7k
C435
0.001
C412
0.001
0.1
C430
1k
ERBSE3R00U
10k
R454
C453
IC54
Q75
HV
0.001
10
CR-864
X51
0.1
XP6501
R438
R421
C413
R456
R451
10k
R437
100k
C408
0.001
R424
BATV
2
R418
0.1
C399
15k
R417
2
C431
100k
Q74 2SB1132
CPU5
0.1
R414
330k
R423
L1SS400
D55
C406
330
C405
C398
0.001
R442
IC53 NJU7704F3
5
1
VDD
CD
2
VSS
3
4
MR
VOUT
LDTA144EE
TLED
DS51
YG
R469
Q82
RLED
RLED
OPT2
TLED
RES
OPT1
SCK
NOIS
CDEC
STONE
RES
VCC
AFVI
C324
0.001
C322
560P
C321
100k
R420
4
V+
GND
11
+5V
F51
1
C1 A1
3
B1
4
C2 A2
6
B2
7
C3 A3
9
B3
VCON
TMUT
NJM12902V
IC60
NJM12902V
AFON
XP6501
0.001
C397
4.7k
+5V
0.1
C400
C401
6
4
3
R416
1
2
S54
14
13
12
11
10
9
8
22P
1k
100k
1.8
R406
Q64
R405
100k
2SB1132
C395
220
0
R407
Q63
R436
T5C
AFO
4.7k
10 MSVA
TPA0211DGN
0.1
220
0.1
C404
*C470
*C469
J52
C403 R412
IC55
1
VOIN
2
GND
SHUTDOWN
3
SE/BTL
VDD
4
VO+
BYPASS
9
47P
100
C391
0.001
R408
S53
C390
8
7
6
5
C393
SO
14
T5V
R5C
ADSW
KEY2
R413
CL
12
R5V
KEY1
CL
CP06S
R5C
NWC
Q73
T5V
CP5
T5V
S5V
KTA2015
IPTT
0.1
C389
0.001
S52
SW-167
10k
KEY2
SW-167
10k
+5V
KEY1
R434
R5C
R441
J53
C363
C318
390
C426 R433
AFON
0.001
LDTC144EE
IPTT
R5V
13
R398
BAL
10k
Q72
C424
Q85
LDTC144EE
Q84
S5V
IC58
2SA1586
R5V
R440
47P
R397
KTA2015
4.7k
CPU5
EPTT
ATX
0.001
C342
C421
0.1
S5C
NJM12902V
4
V+ IC58
GND
11
R432
0.1
S5V
1M
470P
C383
330k
15k
NJM12902V
Q71
LM2902PWR
4
V+ IC59
GND
11
VOXV
L1SS400
CPU5
EPTT
ATX
0.001
C388
10
R427
R426
0.1
SW-149
S51
C382
0.018
D53
C385
10
C344
47k
R364
0.001
C339
UNR911HG0
C381
0.018
VDD
I/O1
O /I1 CONT1
O /I2 CONT4
I/O2
I/O4
O/I4
CONT2
CONT3
O/I3
VSS
I/O3
C365
180k
HV
+5V
NJM12902V
180k
IC60
R430
C343
470
14
12
VREF
R429
1k
Q58
470P
IC58
0.01
0.01 10k
2.2k
R360
33k
0.001
R362
C337
C338
0.001
R363
270k
13
R428
R386
C353
IC56
R379
VREF
Q59
LDTC144EE
R377
33k
C350
470
120k
560k
100k
R375
0.1
C349
NJM12902V
470k
R383
R384
1
2
3
4
5
6
7
R396
270k
VREF
LM2902PWR
RMUT 2
RMUT 1
+5V
10
0.01
3.9k
220P
0.039
68k
R393
560k
IC60
R385
R374
C351
0.039
IC58
NJM12902V
EM9745P
100k
R330
C348
IC59
9
R345 10
68k
10k
C346
R344
LM2902PWR
R378
150k
14
0.1
270k
IC60
1
C427
150k
68k
68k
2.2k
R369
R439
R373
R368
IC59
13
R343 12
82k
470k
R366
R342
C347
R372
R359
R341
SENC
0.01
0.1
MC51
C340
C336
47P
R370
24
23
22
21
20
19
270k
R382
C326
M MUT
5.6k
C335
470
VOUT2
VOUT1
VIN1
VIN8
VOUT8
VOUT7
R381
DUS E
68k
C380
REF
25
+5V
LDTC144EE
CD4066BPWR
R361
0.001
C334
EP51
MMZ1005Y102CT
0.001
10
C448
*MP51
J51
R331
0.0012
LM2902PWR
R2A20178
Q52
IC62
1
VDD
I/O 1
2
CONT1 O /I1
3
CONT4 O /I2
4
I/O4
I/O2
5
O/I4 CONT2
6
O/I3 CONT3
7
I/O3
VSS
14
13
12
11
10
9
8
+5V
10
4.7k
NJM12902V
+5V
RMUT1
C356
0.1
0.1
C313
47k 47k
R329
C314
47k
0.018
22k
VOUT3
VOUT4
VIN4
VIN5
VOUT5
VOUT6
IC59
2
R328
1M
CENC2
R327
R326
R349
7
8
9
10
11
12
TBEEP
0.0047
VREF
IC58
56k
R324
6.8k
C332
CDEC
0.022
10k
180k
R323
CENC1
R318
IC57
15k
R322
CENC0
6.8k
470
C312
R316
1
XP4601
R325
R371
0.0047
82k
R321
S5V
1M
R354
0.01
8.2k
0.01
LM2902PWR
R353
6.8k
C333
C331
10k
10k
C330
R352
22k
R317
0.0047
IC59
6
C328 R355
22k
0.0068
18k
C329
R312
C308
C306
22k
0.039
R351
0.1
C309
R311
R310
10
Q51
3.3k
C307
DISC
C304
R315
0.1
C310
R313 390k
0.01
R314
C TCSS/DTCS FILTER
HV
+5V
0.1
VREF
S5V
+5V
DISC
SDEC
R304
NJM12902V
1k
R401
6
5
0.047
12k
IC60
C305
15k
0.01
0.1
C302
C301
DISC
R302
220P
56k
R303
R301
SQIN
MAIN UNIT (1/2)
MOD
VOLTAGE DIAGRAM
C303
SECTION 10.
100k
*: Refer to the PARTS LIST for the value and name of component.
10 - 1
C234
R158
0.01
Q25
LDTC144EE
C243
10 - 2
R105
4.7k
4.7k
C178
C175
C173
1.5P
6P
0.001
45.3N
Q22
HVD144A
C2
10
270
0.001
R2
HK3-S-T
LPF
L1
10P
MA2S7280G
C30
R101
68k
R1
C4
24P
10
R31
10k
C11
4.7U
0.001
C12
C43
L4
45.3N
11P
L11
C3
27P
C41
18.3N
L8
C44
C72
0.001
C57
0.01
C64
0.001
R41
100
R36
R47
0.001
C77
0.1
C79
EP3
0.001
C51
0.001 M PZ2012S331A
EP6
EP2
47P
0.001
C6
MP 4
OG-503040
C52
22N
C59
0.001
C58
0.001
L18
C55
39N
L9
1k
R32
100
0.001
C65
0.1U
L31
C85
2.2k
0.01
C122
0.001
C78
0.001
C73
0.1U
10
C121
0.001
L33
R37
L2
15P
D22
C171
0.001
C5
22P
R42
45.5N
L3
HVD144A
C172
D23
Q21
6P
100
15P
C7
18P
C15
1.5P
82N
R18
ERTJ0EP473J
C26
RB876W
C17
HVD144A 0.001
C174
10k
R17
C27
1k
R48
47k
6.8k 0.5P
C16
R6
33P
C21
22P
C23
22
R21
C89
18P
120k
C8
L12
HVL375C
R104
100P
C181
D24
3.5P
C176
0.1
R102
18k
470k
10k
D21
R9
0.1
RF AMP
0.001
C18
0.001
R7
D3
0.001
47P
C48
100k
C49
4.7k
R22
68
R24
0.001
33P
C86
D1
L1SS400
R107
5.6k
R16
220k
68N
C186
33k
R8
0.22
L13
R103
R10
220k
R12
68N
APC
3.5P
L14
R111
R5V
0.001
C28
0.1
68k
HVL375C
C179
0.1
100k
120k
IC1
3
45.3N
0.001
C184
HVB350BYPTL
L5
0.001
3SK293
C29
D26
C191
C188
R108
10
TA75S01F 2
R11
R106
0.01
0.001
120k
C197
47
0.1
R109
T5V
0.001
MIX
0.001
C31
R112
R14
0.001
10
2SC5107
LQW18AN56NG00
L15
C189
0.1
270
C193
R110
C192
R13
C32
0.001
R23
0.01
C53
0.001
33k
C54
4.7k
R25
R26
100
C60
R33
2.2k
R35
1k
0.75P
C83
Q2
RD01MUS 1 100P
5.8N
L6 C20
1k
C183
D28
1.5k
R15
C33
0.001
10
0.001
R44
C75
HVD142A
R38
D6
0.1
C101
0.5P
C34
47P
C35
0.001
C36
0.1U
47k
L32
0.001
R45
C76
3P
C81
C103
0.001
C102
33P
C87
HVL375C
D11
10U
L36
L7
Q1
RD07MUS2B 10.3N
C46
C182
1.5P
T1
6P
100
4P
*R113
C200
C195
68N
150k
L19
R118
12P
5P
C210
0.001
C211
C169
R156
Q23
3SK293
L16
470
10
R130
LQW18AN56NG00
C199
100k
R131
470
R129
LDTC144EE
MMZ1005Y102CT
100P
R116
R117
3.3k
18P
R121
0.56U
C215
MMZ1005Y102CT
120k
R119
0.01 10
0.001
10P
C180
FL-442
C218 R123
1
IN
3
GND
0.001
L20
47
C223
C141
100k
0.01 560
FI1
C56
1k
GND
OU T
10P
82k
4
2
10k
C206
0.001
C227 R125
0.01
C216
R122
R132
Q9
R157
IF AMP
C217
0.001
C225
LDTC144EE
100P
2SC5107
0.001
R114
2SC5107
0.01
C226
100
R126
18P
C104
0.001
C90
2SC5107
68
C214
100P
C63
0.001
2.2k
HVD142A 27P
C196
22P
R136
D5
R120
Q24
6
C231
680
R127
C80
0.001
22P
C107
LDTC144EE
7P
C232
R128
JTBM450CX70
R5C
0.001
C145
T5V
22N
L46
C220
16
15
14
13
12
11
10
9
R5C
0.5P
IC3
IF IC
X1
2.2k
100k
R135
1
2
3
4
33P
C105
HVL375C
D14
Q12
Q3
T2
Q27
7P
C201
NJM2591V
R134
4.7k
560
C74
0.001
R141
10
15P
C167
8P
C168
R52
R5V
10P
100k
C198
MIXIN
GND
NOISEREC
N OISEDET
RSSI
IFOUT
QUAD
AFOUT
2SC5107
Q8
0.1
22k
2775
R51
C71
0.001
C203
220P
4.7
220k
C236
47
D12
9P
C94
HVD376B HVD376B
D13
C132
0.33 SVA
1.2k
HV
T5V
S5V
R115
120k
OSCIN
OSCOUT
MIXOUT
V+
IFIN
DEC
FILOUT
FILIN
0.001
C235
C251
Q11
C202
D31
MP 3
Q10
C228
3P
TX VCO
*MP5
R139
2SC4226
0.001
C261
1
2
3
4
5
6
7
8
560
NWC
1SS390
1.5k
R146
C108
MMZ1005Y102C T
3.9k
O
R147
1P
C111
L39
R137
1SS390
D32
68P
C238
2SC4116
1.8k
Q14
R57
C233
0.01
R61
10U
C106
2SC4226
0.001
C264
HVL355CM
D15
100k
R87
L41
HVD376B
3.9k
330P
D33
Q13
NOIS
0.01
0.0012
C117
HVD376B
D16
3P
C113
9P
C115
33N
470
I
0.1
10P
R55
C239
0.01
33P
R138
R56
RX VCO
RSSI
LDTA144EE
FI3
LTM450HW
C262
0.18U
C253
R53
1.8k
0.001
1SS390
3.3U
VCOV
DISC
C265
C240
O
*3 MULTI
R54
3.9k
120P
0.01
6P
C109
Q19
L23
R66
22k
2SC4116
100k
C241
1SS390
D34
FI2
LTM450FW
0.01
R62
56P
IC2
56P
C116
220P
180k
C88
R142
4
D17
3P
C114
47P
C130
220P L40
220P
X2
3.3U
C242
10P
82N
C252
LVA
C127
R68
L34
R140
C256
68N
0.1
Q26
47P
Q15
3.9k
C263
C112
C255
C149
0.01 C257
PLL
0.18U
R5V
470k
L35
C244
MMZ1005Y102C T
EP5
L24
0.001
1k
68N
C93
27k
L37
C254
8
7
6
5
4
3
2
1
R148
R80
680k
WNC
0.001
C120
33k
R77
R67
SQIN
1k
56k
R65
47P
C134
C135
HV
T5V
S5V
R151
OUT
10k
R71
2.2 MSVA
0.33 SVA
HV
8.2k
GND
10k
L43
R152
VCC
CLOCK
FIN
DATA
LD
GND
LE
DO
FC
VCC
NC
VP
FOUT
OSCOUT
P
OSCIN
B
L42
R149
M B15A02PFV1
3.3U
WNC
CR-794
REF
L38
0.01
VCON
1k
9
10
11
12
13
14
15
16
47
L1SS400
R83
EP4
C266
S5V
R70
3.3k
2
R76
0.1
S5V
3.3U
C267
1
Q17
8.2k
R153
UNLK
SCK
SO
PLST
D18
1k
R154
+5V
2SK880
27k
UNLK
0.1
UNLK
R155
NOIS
NWC
DISC
NOIS
100k
R69
S5V
C150
DISC
C118
RSSI
RSSI
220
0.001
LVIN
R78
10P
LVIN
R73
SQIN
0.001
T2
C157
T2
1k
C158
T1
C151
LVIN
C124
LVA
0.001
MOD
10k
T1
MOD
LVA
+5V
R72
R82
SQIN
VCON
0.001
VCON
SCK
47P
MOD
C152
TMUT
TMUT
47P
C153
NWC
0.1
PLST
NWC
C123
PLST
0.001
SCK
SO
CP06S
SO
CP1
R5C
R5C
150k
T5V
C159
R5V
T5V
R81
R5V
47P
C154
S5V
C156
+5V
S5V
0.1
C155
+5V
0.001
HV
C160
MAIN UNIT (2/2)
HV
T5V
ANT
27.2N
4P
D35
LDTA144EEQ 6
T5V
TMUT
T1
C224
0.001
AGC
2SK1829
330k
R SSI
*: Refer to the PARTS LIST for the value and name of component.
1-1-32, Kamiminami, Hirano-ku, Osaka 547-0003, Japan

Phone : +81 (06) 6793 5302
Fax
: +81 (06) 6793 0013
URL : http://www.icom.co.jp/world/index.html
<Corporate Headquarters>
2380 116th Avenue N.E., Bellevue, WA 98004, U.S.A.
Phone : +1 (425) 454-8155
Fax : +1 (425) 454-1509
URL : http://www.icomamerica.com
E-mail : [email protected]
<Customer Service>
Phone : +1 (425) 454-7619
Glenwood Centre #150-6165

Highway 17 Delta, B.C., V4K 5B8, Canada
Phone : +1 (604) 952-4266
Fax : +1 (604) 952-0090
URL : http://www.icomcanada.com
Unit 1 / 103 Garden Road, Clayton VIC 3168 Australia

Phone : +61 (03) 9549-7500
Fax : +61 (03) 9549-7505
URL : http://www.icom.net.au
146A Harris Road, East Tamaki,

Auckland, New Zealand
Phone : +64 (09) 274 4062
URL : http://www.icom.co.nz
Fax : +64 (09) 274 4708
10C07, Long silver Mansion, No.88, Yong Ding

Road, Haidian District, Beijing, 100039, China
Phone : +86 (010) 5889 5391/5392/5393
Fax
: +86 (010) 5889 5395
URL : http://www.bjicom.com
Communication Equipment
Auf der Krautweide 24
65812 Bad Soden am Taunus, Germany
Fax : +49 (6196) 76685-50
Phone : +49 (6196) 76685-0
URL : http://www.icomeurope.com
Ctra. Rubi, No. 88 Bajos A 08174, Sant Cugat del Valles, Barcelona, Spain
Phone : +34 (93) 590 26 70
Fax : +34 (93) 589 04 46
URL : http://www.icomspain.com
Blacksole House, Altira Park, Herne Bay, Kent CT6 6GZ, UK

Phone : +44 (01227) 741741
Fax : +44 (01227) 741742
URL : http://www.icomuk.co.uk
Zac de la Plaine
1 Rue Brindejonc des Moulinais BP 5804
31505 Toulouse Cedex, France
Phone : +33 (5) 61 36 03 03
Fax : +33 (5) 61 36 03 00
URL : http://www.icom-france.com
6F No.68, Sec. 1 Cheng-Teh Road, Taipei, Taiwan, R.O.C.

Phone : +886 (02) 2559 1899
Fax : +886 (02) 2559 1874
URL : http://www.asia-icom.com
81-850 Sopot, ul. 3 Maja 54, Poland

Phone : +48 (58) 550 7135
Fax : +48 (58) 551 0484
1-1-32, Kamiminami, Hirano-ku, Osaka 547-0003, Japan
S-14621XZ-C1
2009 Icom Inc.

F3001 Service Manual

Uploaded by

Copyright:

Available Formats

F3001 Service Manual

Uploaded by

Document Information

Copyright

Available Formats

Share this document

Share or Embed Document

Sharing Options

Did you find this document useful?

Is this content inappropriate?

Copyright:

Available Formats

F3001 Service Manual

Uploaded by

Copyright:

Available Formats

VHF TRANSCEIVERS

This service manual describes the latest technical

NEVER connect the transceiver to an AC outlet or to a DC

To upgrade quality, any electrical or mechanical parts

DO NOT expose the transceiver to rain, snow or any liquids.

Be sure to include the following four points when ordering

1. Make sure that the problem is internal before

1. 10-digit Icom part number

8820001210 Screw 2438 screw

Addresses are provided on the inside back cover for your

RECEIVER CIRCUITS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-1

TRANSMITTER CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-2

FREQUENCY SYNTHESIZER CIRCUITS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-3

VOLTAGE BLOCK DIAGRAM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-3

PORT ALLOCATIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-4

FREQUENCY ADJUSTMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-5

TRANSMIT ADJUSTMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-6

RECEIVE ADJUSTMENT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-7

Except [EUR], [UK]

: 0.25 V typ. at 12 dB SINAD

Specifications are measured in accordance with TIA/EIA-603B or EN 300 086

Except [EUR], [UK]

Except [EUR], [UK]

+5V LINE REGULATOR

+5V LINE REGULATOR

CPU5 LINE REGULATOR

MIC GAIN CONTROLLER

+5V LINE REGULATOR

AGC LONE DRIVER

CLONING LINE BUFFER

1. REMOVING THE CHASSIS

1) Remove the ANT connector nut and 2 knobs.

ANT CONNECTOR NUT

5) Remove the seals and nuts from the CHASSIS.

2) Remove 2 screws from the bottom of the CHASSIS.

BE CAREFUL to not pull out the speaker wire when

2. REMOVING THE MAIN UNIT

For easy separation of the CHASSIS

(Continued to the right above)

4-1 RECEIVER CIRCUITS

2ND IF CIRCUITS AND DEMODULATOR

The signal from the 1st IF circuits is applied to the IF

The RX signal from the antenna is passed through the LPF

The 1st IF signal is applied to the 2nd IF mixer and mixed

The tuned BPFs are tuned to the RX frequency by applying

The 2nd LO signal is generated by tripling the 15.3 MHz

The converted 2nd IF signal is filtered by the crystal filter/

From the TX circuits

The demodulated AF signal is applied to the RX AF circuits.

The RX signal from the RF circuits is applied to the 1st IF

To the 2nd IF&demodulator circuits

From the 1st IF

4-2 TRANSMITTER CIRCUITS

The demodulated AF signal from the IF demodulator

The amplified AF signal is applied to the internal or external

The filtered MIC signal is applied to the D/A converter which

To the modulation circuits

From the TX AF circuits

To the TX AMP circuits

4-3 FREQUENCY SYNTHESIZER CIRCUITS