Scribd
Upload
442 views

Volvo Problem Solver Advanced Edition-1 PDF

Uploaded by

luis262
Copyright
© Attribution Non-Commercial (BY-NC)
We take content rights seriously. If you suspect this is your content, claim it here.
Available Formats
Download as PDF or read online on Scribd
442 views

Volvo Problem Solver Advanced Edition-1 PDF

Uploaded by

luis262
Copyright
© Attribution Non-Commercial (BY-NC)
We take content rights seriously. If you suspect this is your content, claim it here.
Available Formats
Download as PDF or read online on Scribd
You are on page 1/ 242
VOLVO PROBLEM SOLVER ADVANCED EDITION THE ULTIMATE VOLVO REPAIR GUIDE! moe LET:.RNG BE YOUR INSIDE SOURCE FOR VOLVO INFORMATION! ROBERT N. GERHARDT & ASSOCIATES, INC. P.0. BOX 6073 BLOOMINGDALE, ILLINOIS 60108 VOLVO PROBLEM SOLVER Cc ‘QUICK CHECK’ - USE FOR PARTIAL TESTING REFER TO 'BASIC CHECK' FOR MORE COMPREHENSIVE TESTS. 0S 011 SET BASE IDLE SPEED __ 1962-ON _ CONSTANT IDLE SYSTEM 05 201 ‘BOSCH POINTLESS IGNITION _ QUICK CHECK 05 501 MPG IGNITION _ COMPUTER CONTROL IGNITION __ QUICK CHECK 05 701 «EZ IGNITION _ COMPUTER CONTROL IGNITION _ QUICK CHECK "VITAL SIGNS' - USE FOR POOR RUNNING CONDITION TESTING REFER TO COMPLETE SYSTEM & COMPONENT INFORMATION IN THE AFFECTED GROUPS IN MANUAL FOR MORE COMPREHENSIVE TESTS. 7 201 "VITAL SIGNS’ __ INTRODUCTION TO ALL MODELS 7 251 76-85 K-JETRONIC INJECTION __ POOR RUNNING 7 261 ‘89-84. _LEEJETRONIC INJECTION _ POOR RUNNING 7 271 ‘85-88 LH-JETRONIC INJECTION _ POOR RUNNING "BASIC CHECK' THIS SHOULD BE THE FIRST CHECK YOU MAKE — WHEN A 'NO START! CONDITION EXISTS. IT WILL HELP PINPOINT IF THE FAULT IS IN EITHER THE FUEL INJECTION SYSTEM OR THE IGNITION SYSTEM. 1l- 001 ENGINE WON'T START _ 1979-ON _ BASIC CHECK OTHER 'BASIC CHECK’ TOPICS - USE FOR NO START CONDITION MORE COMPREHENSIVE THAN 'QUICK CHECK’. 11 021 FUEL INJ RELAYS _ TESTING __ 1974-77 __ K-JETRONIC 11 031 FUEL INJ RELAY _ TESTING __ 1978-ON __ K-JETRONIC ll 041 FUEL INJ RELAYS _ TESTING __ 1983-84 _ LH-JETRONIC 11 (052 FUEL INJ RELAY _ TESTING __ 1985-ON __ LH-JETRONIC 11-201 BOSCH POINTLESS IGN _ FAULT TRACING 11-502 MPG IGN __ COMPUTER CONTROL IGNITION __ FAULT TRACING 11-701 EZK IGN __ COMPUTER CONTROL IGNITION __ FAULT TRACING —* Copyright 1990, 1992, 1994 © by Robert N. Gerhardt And Associates, Inc. GROUP 20 20- 11 20- 31 GROUP 21 21- 241 21- s1L 21- 400 21- 501 21- 51L 21- 531 21- 71 GROUP 22 22- 001 22- 003 22- 111 22- 121 22- 131 22- 133 22- 200 22- 321 22- 331 22- 711 22- 721 GROUP 23 23- ail 23- 211 GENERAL INFORMATION TEST POINT TERMINALS [C-O, STARTER BYPASS, IDLE DISABLE] SERVICE REMINDER LITES [EGR, LAMBDA] ENGINE MECHANICAL SIZED CAMSHAFT REPAIR [B-21, 23, 230] CAMSHAFT REPLACEMENT TIME SAVER [B-18, 20, 30] ENGINE 'KNOCKING NOISE’ [B-18, 20, 30], TIMING GEARS REAR CRANKSHAFT SEAL LEAKS [B-18, 20] ENGINE OIL LEAKS DIAGNOSIS ENGINE FLAME ARRESTOR, NOTES, LOCATION & REPLACEMENT ENGINE TIMING BELT _ TIPS & REPLACEMENT OXYGEN SENSOR, LAMBDA SOND, FUEL PUMP (02 SENSORS __ LAMBDA SOND COMPONENTS K-JETRONIC LH-INJECTION (02 SENSOR THEORY OF OPERATION CO CHECKING AT 02 SENSOR [VOLTAGE TESTING] TEST POINT _ LAMBDA SOND DUTY CYCLES [CHECKING CO] COLD ENG, ACCELERATION & TURBO ENRICHMENT K-JETRONIC _ SEVERE IDLE HUNTING [COLD ENG] K-JETRONIC LAMBDA SOND _ PROBLEM CHECK ITEMS "WHAT IS NEEDED TO TURN THE FUEL PUMP ON' HARD HOT START __ LONG CRANKING [F/P CHECK VALVE] FUEL PUMP & FILTER LOCATION __ Ground{-] circuit NOTES SURGING __ LOSS OF POWER [PRE PUMP & PRE PUMP HOSE] PRE PUMP QUICK CHECK CARB & D-JETRONIC EFI SU CARB PROBLEMS __ ADJUSTMENTS _ CHECK POINTS ZENITH/STROM CARB PROBLEMS _DIAPHRAMS _ ADJUSTMENTS TEMP COMPENSATOR, BYPASS VALVE _ CHECK POINTS

You might also like