A1 Selection Table: Connecting and Control Cables

Application Criteria
LFLEX CLASSIC 100 yellow

Cable and Lead Designation

LFLEX CLASSIC 110 CY black LFLEX CLASSIC 110 orange LFLEX CLASSIC 110 black

LFLEX CLASSIC 110 CH

LFLEX CLASSIC 100 CY

LFLEX CLASSIC 100 SY

LFLEX CLASSIC 110 CY

LFLEX CLASSIC 115 CY

LFLEX CLASSIC 110 SY

For static and occasional flexing use

LFLEX CLASSIC 100

LFLEX CLASSIC 100 H

LFLEX CLASSIC 110 H

LFLEX ROBUST 200

LFLEX CLASSIC 110

LFLEX Tray II CY

Page
For power circuits which cannot be switched off; Warning mark
For intrinsically safe power circuits in explosion endangered areas to/VDE 0165

1.2 1.5 1.6 1.4 1.54 1.8 1.10 1.12 1.15 1.17 1.14 1.19 1.23 1.23 1.27 1.27 1.29 1.29 1.31 1.31 1.33 1.35 1.37 1.39 1.39 1.41 1.43

see EB-cables

Hand tools and lamps on worksites Oil resistant to UL + CSA specification Oil resistant to VDE Bio oil resistant For interlocking power circuits EN 60204 Cables resistant to chemicals Cables resistant to ultra-violet light Cold-flexible cables Servomotors/Motive power engineering Based on VDE/HAR/DIN As per Standard with VDE approval with VDE registration with HAR approval (HAR) with UL approval with CSA approval +90C +80C +70C +60C -5C -10C -15C -25C -30C -40C -50C
Outdoor, only indirectly in the ground (conduit) UV-protected, fu Indoor, on surface, in conduit, in ducting, in partition walls, fu

Application

see separate selection table T1 and T2

LFLEX 120 CH

LFLEX 150 CY

LFLEX 140 CY

LFLEX 191 CY

LFLEX 120 H

LFLEX Tray II

LFLEX 150

LFLEX 140

LFLEX 191

LFLEX SF

** ** **

Temperature range

Standards

Outdoor, protected against UV light, fu Outdoor, unprotected in the open, fu Indoor fu 1) 5XD 10 x D 12,5 x D 15 x D 20 x D 250 V 300/300 V 300/500 V 600 V acc. to UL/CSA 450/750 V 600/1000 V Fine-wire VDE class 5, copper stranded conductors Superfine wire VDE class 6, copper stranded conductors Ultra fine wire VDE class 6, copper stranded conductors Polyurethane core insulation Rubber core insulation PVC/special PVC PE core insulation Halogen free core insulation Number printing Colour code to VDE 0293 LFLEX colour code Screening on the forn of copper braiding Common inner sheath under overall protection/braiding Steel wire braiding PVC sheath PUR sheath, wear resistant, cutting resistant Halogen free outer sheath Bio oil resistant outer sheath P4/11 Outer sheath of synthetic rubber Outer sheath of Neoprene rubber

Bending radius

Laying

Nominal voltage

Make-up

* For use in power chains, under positive guidance over rollers/drums, continually in movement, see Selection Table for FD Cables A2. ** Oil resistance and SEV TP20B/3C. = Principal application = Temperature range for exible laying = Application not customary, butt possible, = Temperature range for static laying or alternative design available in the range = Temperature range for static and flexible laying

14.2

LFLEX ROBUST 210

A1 Selection Table: Connecting and Control Cables

Application Criteria For static and occasional flexing use
LFLEX ROBUST 215C

Cable and Lead Designation

LFLEX CLASSIC 400 CP

LFLEX CLASSIC 400 P

LFLEX SERVO 2YSLCY

LFLEX SERVO 700 CY

LFLEX SERVO 709 CY

LFLEX SERVO 720 CY

LFLEX SERVO 730 CY

LFLEX SERVO 710 CY

LFLEX SERVO 700

LFLEX SERVO 730

Page

1.45 1.47 1.47 1.49 1.51 1.53 1.55 1.56 1.57 1.57 1.59 1.78 1.78 1.80 1.81 1.81 1.82 1.82 1.83 1.75 1.68 1.68 1.68 1.77 1.135 1.130

For power circuits which cannot be switched off; Warning mark

For intrinsically safe power circuits in explosion endangered areas to/VDE 0165

see EB-cables

Hand tools and lamps on worksites Oil resistant to UL + CSA specification Oil resistant to VDE Bio oil resistant For interlocking power circuits EN 60204 Cables resistant to chemicals Cables resistant to ultra-violet light Cold-flexible cables Servomotors/Motive power engineering In Anlehnung an VDE/HAR/DIN Nach Norm mit VDE-Approbation Mit VDE-Registrierung Mit HAR-Approbation Mit UL-Approbation Mit CSA-Approbation +90C +80C +70C +60C -5C -10C -15C -25C -30C -40C -50C
Outdoor, only indirectly in the ground (conduit) UV-protected, fu Indoor, on surface, in conduit, in ducting, in partition walls, fu

Application

see separate selection table T1 and T2

Standards

Temperature range

Outdoor, protected against UV light, fu Outdoor, unprotected in the open, fu Indoor fu 1) 5XD 10 x D 12,5 x D 15 x D 20 x D 250 V 300/300 V 300/500 V 600 V acc. to UL/CSA 450/750 V 600/1000 V Fine-wire VDE class 5, copper stranded conductors Superfine wire VDE class 6, copper stranded conductors Ultra fine wire VDE class 6, copper stranded conductors Polyurethane core insulation Rubber core insulation PVC/special PVC PE core insulation Halogen free core insulation Number printing Colour code to VDE 0293 LFLEX colour code Screening on the forn of copper braiding Common inner sheath under overall protection/braiding Steel wire braiding PVC sheath PUR sheath, wear resistant, cutting resistant Halogen free outer sheath Bio oil resistant outer sheath P4/11 Outer sheath of synthetic rubber Outer sheath of Neoprene rubber

Bending radius

Laying

Nominal voltage

Make-up

* For use in power chains, under positive guidance over rollers/drums, continually in movement, see Selection Table for FD Cables A2. ** Oil resistance and SEV TP20B/3C. = Principal application = Temperature range for exible laying = Application not customary, butt possible, = Temperature range for static laying or alternative design available in the range = Temperature range for static and flexible laying

14.3

LFLEX AQUA BAM

LFLEX 440 P/CP

LFLEX 491 P/CP

LFLEX 540 CP

LFLEX 492 P

LFLEX 450 P

LFLEX 550 P

LFLEX 500 P

LFLEX 540 P

NEOFLEX

H07RN8-F

H05RN-F

NSSHU

H05RR-F

H07RNF

A2 Selection Table: Highly Flexible FD Cables for use in power chains or robot applications
Application criteria
LFLEX SERVO FD 755 CP LFLEX SERVO FD 760 CP LFLEX SERVO FD 750 P LFLEX SERVO FD 755 P

Cable and Lead Designation

SERVO-cable. acc. Indramat Standard INK
SERVO-cable acc. SIEMENS Standard 6FX 5008SERVO-cable acc. SIEMENS Standard 6FX 7008SERVO-cable acc. SIEMENS Standard 6FX 8008green or orange

LFLEX FD CLASSIC 810 CP

LFLEX FD CLASSIC 810 CY

SERVO-cable acc. to LENZE Standard

LFLEX SERVO FD 795 P

LFLEX SERVO FD 785 P

LFLEX SERVO FD 781 P

LFLEX FD CLASSIC 810

for use in power chains or robot applications

LFLEX FD CLASSIC 810 P

LFLEX SERVO FD 790 CP

LFLEX SERVO FD 795 CP

LFLEX SERVO FD 770 CP

LFLEX SERVO FD 785 CP

LFLEX SERVO FD 781 CP

LFLEX SERVO FD 781 CY

Page

1.85 1.86 1.86 1.88 1.88 1.90 1.91 1.91 1.93 1.93 1.95 1.97 1.97 1.99 1.101 1.102 1.104 1.1081.108 1.110 1.110 1.112 1.112 1.116 1.116 1.105 1.107

For industrial machinery to EN 60204. part 1/VDE 0113 For frequency-converter driven servo drives For servo motor, low capacitance For encoders, feedback systems, sensors For free arm robots/torsion load Restricted guidance over rollers, motor drums For indoor application For outdoor application For field bus systems For video transmission, RGB signal transmission For North America with UL + CSA approvals For use in oily environments, enhanced oil resistance For use in areas with bio oils +105C +90C +80C +70C +60C +5C -5C -10C -20C -30C -40C -50C 5xD 6,5 x D 7,5 x D 10 x D 12,5 x D 15 x D 20 x D For chains with small radii For chains with restricted space For low cable weight in the chain For 24-hour operation at high numbers of cycles For high acceleration values > 10 m/s2 For travel speeds up to 5 m/s, up to 10 m chain length For travel speeds up to 10 m/s, up to 10 m chain length For travel speeds up to 5 m/s, up to 100 m chain length 350 Vss 30/300 V AC 300/500 V AC 600/1000 V AC 600 V acc. to UL/CSA Fine wire VDE class 5, copper stranded conductor Superfine wire VDE class 6, copper stranded conductor Ultra fine wire VDE class 6, copper stranded conductor PVC/special PVC, core insulation Elastomer core insulation PE/cellular PE Polyethylene / Polypropylene TPE core insulation Special TPE (P4/11) core insulation Halogen free compound Number printing VDE colour code DIN 47100 colour code / special colour code Pair screening PiCY/PiMF/STP Total screening Special PVC sheath PUR sheath, wear resistant, cutting resistant Neoprene sheath TPE (P4/11) sheath bio oil resistant Halogen free compound = Principal application = Application not customary, but bussible, or alternative design in the range

Application

Temperature

Bending radius exible use

Movementt parameters

LFLEX FD ROBUST C

LFLEX FD ROBUST

LFLEX FD 820 CH

LFLEX FD 820 H

Laying

= Temperature range for flexible laying = Temperature range for static laying = Temperature range for static and static laying

Make-up

14.4

Special Encoder & Resolver cables

A2 Selection Table: Highly Flexible FD Cables for use in power chains or robot applications
Application criteria for use in power chains or robot applications
LFLEX ROBOT 900 P LFLEX FD 855 CP LFLEX FD 891 CP LFLEX FD 891 CY LFLEX FD 90 CY LFLEX FD 855 P LFLEX FD 891 P

Cable and Lead Designation

UNITRONIC FD P plus UL/CSA
UNITRONIC FD CP (TP) plus UL/CSA

LFLEX ROBOT F1 UL/CSA

UNITRONIC BUS FD P L2/FIP

UNITRONIC BUS FD P-LD

UNITRONIC BUS FD P DeviceNet

UNITRONIC FD CP (TP) plus

UNITRONIC FD CP plus UL/CSA

UNITRONIC BUS FD P IBS

LFLEX ROBOT 900 DP

LFLEX FD 891

UNITRONIC FD

LFLEX FD 90

UNITRONIC FD CY

Page

1.114 1.114 1.118 1.119 1.121 1.121 1.123 1.123 1.125 1.125 1.127 6.27 6.28 6.29 6.30 6.30 6.31 7.3 7.6 7.8 7.22 8.11 2.2 8.17

For industrial machinery to EN 60204. part 1/VDE 0113 For frequency-converter driven servo drives For servo motor, low capacitance For encoders, feedback systems, sensors For free arm robots/torsion load Restricted guidance over rollers, motor drums For indoor application For outdoor application For field bus systems For video transmission, RGB signal transmission For North America with UL + CSA approvals For use in oily environments, enhanced oil resistance For use in areas with bio oils +105C +90C +80C +70C +60C +5C -5C -10C -20C -30C -40C -50C 5xD 6,5 x D 7,5 x D 10 x D 12,5 x D 15 x D 20 x D For chains with small radii For chains with restricted space For low cable weight in the chain For 24-hour operation at high numbers of cycles For high acceleration values > 10 m/s2 For travel speeds up to 5 m/s, up to 10 m chain length For travel speeds up to 10 m/s, up to 10 m chain length For travel speeds up to 5 m/s, up to 100 m chain length 350 Vss 30/300 V AC 300/500 V AC 600/1000 V AC 600 V acc. to UL/CSA Fine wire VDE class 5, copper stranded conductor Superfine wire VDE class 6, copper stranded conductor Ultra fine wire VDE class 6, copper stranded conductor PVC/special PVC, core insulation Elastomer core insulation PE/cellular PE Polyethylene / Polypropylene TPE core insulation Special TPE (P4/11) core insulation Halogen free compound Number printing VDE colour code DIN 47100 colour code / special colour code Pair screening PiCY/PiMF/STP Total screening Special PVC sheath PUR sheath, wear resistant, cutting resistant Neoprene sheath TPE (P4/11) sheath bio oil resistant Halogen free compound = Principal application = Application not customary, but bussible, or alternative design in the range

Application

Temperature

Bending radius exible use

Movementt parameters

Laying

Make-up

= Temperature range for flexible laying = Temperature range for static laying = Temperature range for static and static laying

POF SIMPLEX FD PUR-PE

KOAXIAL-KABEL RGB-FD

KRANFLEX

14.5

A3 Selection Table: Conveyor Cables

Application Criteria Cable and Lead Designation

NEOFLEX flat cable

LFLEX flat cable

Page

2.2 2.3 1.75 2.5 2.4 2.6

2.7 2.8

2.9

Temperature range

+ + + + -

80 C 70 C 60 C 5 C 0 C 5 C 10 C 15 C 20 C 25 C 30 C 40 C

W W W W W

W WW W qq q q K K K W

W W W W

Standards

Based on VDE/HAR/DIN With VDE approbation With VDE registration With HAR approbation Flame retardant acc. to VDE 0472 T. 804 IEC 332.1 For cable trolley guide systems For free arm robots / torsion loading Positive guidance over rollers, motor drums Reeling re-routing under tension For freely suspended application in lift/conveying system For freely suspended application with additional load For indoor application For short travel distances indoors For short travel distances outdoors For use in power chains 5 xD 6,25 x D 7,5 x D 10 x D 12,5 x D 15 x D 20 x D 300/500 V 450/750 V 600/1000 V PVC Rubber Support core: hemp rope / textile rope Support core: steel rope, internal Support core: steel rope, external Support core: Kevlar rope Outer sheath supporting braid PVC sheath PVC sheath cold flexible Neoprene rubber sheath (CR)
= Hauptanwendung/-Ausfhrung = Anwendung nicht blich, jedoch mglich bzw. alternative Ausfhrung im Programm lieferbar

K K

K K K K

KK K K K K K K K K KK K K K KK KK KK K K K

see selection table A2, Robot cables

Application

k K K K K K K k K k K K K K K K K K K K K

see separate selection table FD-cables A2

Bending radius

K K K K K K K K K K K K K K K K K K KK K K K K K

Make-up

Nominal voltage

KK K K

K K

K K

K KK K K KK K K

K K

K K K K

= Temperaturbereich flexible Verwendung = Temperaturbereich feste Verlegung = Temperaturbereich feste und flexible Anwendung

14.6

LFLEX Trago 2S

KRANFLEX VS

LFLEX Lift S

LFLEX Lift T

LFLEX Lift

KRANFLEX

NEOFLEX

A4 Selection Table: Halogen free Cables and Leads

Application Criteria
LFLEX CLASSIC 110 CH

Cable and Lead Designation

H05Z-K halogen free single core H07Z-K halogen free single core LFLEX SERVO FD 770 CP LFLEX SERVO FD 785 CP LFLEX SERVO FD 755 CP LFLEX SERVO FD 760 CP LFLEX SERVO FD 781 CP LFLEX SERVO FD 785 P LFLEX SERVO FD 755 P LFLEX SERVO FD 781 P
LFLEX TRAFFIC GKWR/flex R/C-flex R

LFLEX CLASSIC 100 H

LFLEX CLASSIC 110 H

SILFLEX-SiF/GL, -SiD, -FZLSi

LAPPTHERM 145 + C Cable

LAPPTHERM 145 Cable

LAPPTHERM 145 EA

LFLEX FD 820 CH

LFLEX FD 855 CP

LFLEX FD 820 H

LFLEX FD 855 P

LFLEX 120 CH

LFLEX 440 CP

LFLEX 540 CP

LFLEX 120 H

LFLEX 440 P

LFLEX 540 P

Page

1.33 1.35 1.37 1.39 1.39 1.49 1.49 1.57 1.57 1.86 1.86 1.88 1.88 1.91 1.91 1.93 1.93 1.112 1.112 1.114 1.114 3.3 3.3 3.3 3.9 3.11 3.12 4.10 4.10 1.37

Application

Machinery and industrial installation: External cabling of machinery Internal cabling in cabinets Other circuits in buildings: Lightning circuits Power circuits Data network cables Halogen free to VDE 0472 T 815 Low smoke density Low toxicity of the smoke Flame retardant to IEC 60 332.1 High ignition temperature to IEC 60 332.3 Based on VDE/HAR/DIN/UL With approval VDE/HAR/DIN/UL + 180 C + 145 C + 120 C + 110 C + 90 C + 80 C + 70 C 0 C 5 C 15 C 25 C 30 C 40 C 50 C 60 C 250 Vss 300/500 V 450/750 V 600/1000 V 1,8/3 KV 3,6/6 KV Solid wire VDE class 1 Multi wire VDE class 1 Fine wire VDE class 5 Superfine wire VDE class 6 Number printing Colour code to VDE 0293, IEC 304 Colour code to DIN 47100 Colour code for indoor telephone cables Special colour code Individual colours

SILFLEX H05SS-F EWKF

SILFLEX-SiHF

Standards

Temperature range

Nominal voltage

Make-up

Further halogen free cables and leads on request. = Principal application = Application not customary, but possible, or alternative design available in the range Halogen free accessories: Productive conduits SILVYN RILL SILVYN HCC SILVYN EDU-AS SILVYN AS SILVYN FPAS SILVYN LCCH-2 SILVYN HFX Screw-type cable glands SKINTOP ST-HF-M = Temperature range for flexible laying = Temperature range for static laying = Temperature range for static and flexible laying Accessories SYMBOL-PACK ALPHA-PACK NUMERO-PACK WM cable marker white Stainless steel FLEXIMARK Mini character holders FLEXILABELS FLEXIMARK FLEXIMARK character holders

FLEXIMARK conf. character holders FLEXIMARK MA/MB/FL-XP/LA/LB/LC Flexiprint Shrinking conduits CMP/PKG/HSB/ PLG transparent FLEXIPART Cable Eater Polyamide cable ties6.6 DYMO label tapes

14.7

A4 Selection Table: Halogen free Cables and Leads

Application criteria
LFLEX TRAFFIC 3GKW/3GKW flex/3GKW C-flex

Cable nad Lead Designation

UNITRONIC FD CP plus UL/CSA UNITRONIC BUS P Combi IBS UNITRONIC FD P plus UL/CSA LAN STP-H CAT 6 halogen free
UNITRONIC FD CP (TP) plus UL/CSA

LAN UTP-H CAT 5+6 halogen free

LAN UTP/S-H CAT 5+6 halogen free

UNITRONIC BUS L2/FiP 7-wire

LAN UTP/BS-H CAT 5+6 halogen free

UNITRONIC BUS AS-INTERFACE

LFLEX TRAFFIC 9GKW-AXplus/C-flex

LFLEX TRAFFIC 4GKW-AXplus/C-flex

SPIREX spiral cables 540 P

UNITRONIC BUS FD P IBS

UNITRONIC BUS FD P-LD

LAPPTHERM SOLAR SR

LAPPTHERM SOLAR XL

Halogen free single core

UNITRONIC LiHCH (TP)

UNITRONIC BUS EiB

UNITRONIC LiHCH

SILFLEX-SiHF/GLS

SILFLEX-EWKF + C

SILFLEX UL/CSA

ETHERLINE H

SILFLEX-EWKF

NSHXAF

Page

1.140 1.145 1.147 3.6 3.7 3.15 3.13 3.16 3.17 1.134 1.62 4.10 7.7 6.11 6.12 7.23 7.3 7.3 7.6 7.18 8.41 8.4 8.5 8.5 8.5 4.16 6.29 6.30 6.31 6.10

Application

Machinery and industrial installation: External cabling of machinery Internal cabling in cabinets Other circuits : Lightning circuits Power circuits Data network cables Halogen free to VDE 0472 T 815 Low smoke density Low toxicity of the smoke Flame retardant to IEC 60332.1 Flame retardant to IEC 60332.3 Based on VDE/HAR/DIN/UL With approval VDE/HAR/DIN/UL + 180 C + 145 C + 120 C + 110 C + 90 C + 80 C + 70 C 0 C 5 C 15 C 25 C 30 C 40 C 50 C 60 C 250 Vss 300/500 V 450/750 V 600/1000 V 1,8/3 KV 3,6/6 KV Solid wire VDE class 1 Multi wire VDE class 1 Fine wire VDE class 5 Superfine wire VDE class 6 Number printing Colour code to VDE 0293, IEC 60304 Colour code to DIN 47100 Colour code for indoor telephone cables Special colour code Individula colours

(N)HXMH

Standards

Make-up

Nominal voltage

Temperature range

Further halogen free cables and leads on request. = Principal application = Application not customary, but possible, or alternative design available in the range Halogen free accessories: Productive conduits SILVYN RILL SILVYN HCC SILVYN EDU-AS SILVYN AS SILVYN FPAS SILVYN LCCH-2 SILVYN HFX Screw-type cable glands SKINTOP ST-HF-M = Temperature range for flexible laying = Temperature range for static laying = Temperature range for static and flexible laying Accessories SYMBOL-PACK ALPHA-PACK NUMERO-PACK WM cable marker white Stainless steel FLEXIMARK Mini character holders FLEXILABELS FLEXIMARK FLEXIMARK character holders

FLEXIMARK conf. character holders FLEXIMARK MA/MB/FL-XP/LA/LB/LC Flexiprint Shrinking conduits CMP/PKG/HSB/ PLG transparent FLEXIPART Cable Eater Polyamide cable ties6.6 DYMO label tapes

14.8

UNITRONIC LiHH, LiHCH, LiHCH (TP)

A5 Selection Table: Data transmission cables for low frequency analog/digital transmissions
Application Criteria Cable and Lead Designation
UNITRONIC FD CP (TP) plus UL/CSA

UNITRONIC FD P plus UL/CSA

UNITRONIC Li2YCY(TP)-Li2YCYv (TP)

Telephone indoor cable J-YY/J-Y(ST)Y

UNITRONIC FD CP plus UL/CSA

UNITRONIC CY PiDY (TP)

UNITRONIC PUR CP (TP)

UNITRONIC LiFYCY (TP)

Fire alarm cable J-Y(ST)Y red

UNITRONIC Li2YCY PiMF

Page

6.2 6.4 6.6 6.7

6.8 6.9 6.10 6.11 6.12 6.18 6.18 6.20 6.21 6.22 6.23 6.26 6.27 6.28 6.29 6.30 6.31 6.33 6.35 6.39 6.40 6.41 6.43 6.44 6.47

Additional control/time recording systems (ZK/ZE) Operating data acquisition (BDE) Clock systems Forced entry alarm systems (EMA) Fire alarm systems (BMA) Telephone extension systems Interphone/Duplex systems Electroacoustic systems (ELA/PA) Sound studio cable/microphone cable Printer/Plotter Direct current stepping motors Encoder (Weg- oder Winkelmegeber) Industrial sensors, U < 50 Veff Industrial actuators, U < 50 Veff Measurement and control system, analog (MSR) MSR, digital In electronic instruments For cutting/clipping technology (0,34 mm2/AWG 22) + 80 C + 70 C + 60 C - 5 C - 20 C - 30 C - 40 C For static laying outdoors For direct laying underground For static insatllation (indoors) For flexing use (indoors) occasionally For continuous flexing use (indoors/outdoors) Halogen free Flame retardant, self extinguishing

Application

Temperature range

Laying

For electr. symmetrical signal transmission (TP), twisted pair For high end coupling of the pairs, screened For electrical screening effect, total screening For low attenuation transmission, low capacitance With individually screened cores With combined core pairs/individual conductors With colour code DIN 47100 With UNITRONIC colour code With industrial electronics colour code VDE 0815 With star-quad colour code BD to VDE 0815/0816 With pair colour code LG to VDE 0815 With special colour code With numbered cores With PVC/special PVC outer sheath With PUR sheath, wear resistant, cutting resistant With PE outer sheath (not flame-retardant) = Principal application = Application not customary, but possible, or alternative design available in the range Halogen free accessories: Productive conduits SILVYN RILL, SILVYN HCC SILVYN EDU-AS, SILVYN AS SILVYN FPAS, SILVYN LCCH-2 SILVYN AS SILVYN HFX Screw-type cable glands SKINTOP ST-HF-M

Make-up

= Temperature range for flexible laying = Temperature range for static laying = Temperature range for static and flexible laying Accessories SYMBOL-PACK ALPHA-PACK NUMERO-PACK WM cable marker white Stainless steel FLEXIMARK Mini character holders FLEXILABELS FLEXIMARK FLEXIMARK character holders

Further halogen free cables and leads see selction table A4 or on request.

FLEXIMARK conf. character holders FLEXIMARK MA/MB/FL-XP/LA/LB/LC Flexiprint Shrinking conduits CMP/PKG/HSB/ PLG transparent FLEXIPART Cable Eater Polyamide cable ties6.6 DYMO label tapes

14.9

Telephone outdoor cable

UNITRONIC LiHCH (TP)

UNITRONIC LiYCY (TP)

UNITRONIC LiYCY-CY

UNITRONIC LiYY (TP)

UNITRONIC LiYD11Y

UNITRONIC PUR CP

UNITRONIC 100 CY

UNITRONIC LiHCH

UNITRONIC FD CY

UNITRONIC LiYCY

UNITRONIC LiHH

UNITRONIC 100

UNITRONIC FD

UNITRONIC ST

JE-LiYCY (TP)

JE-Y(ST)Y

UNITRONIC J-2Y(ST)Y

UNITRONIC LiYY

A6 Selection Table: UNITRONIC-KOAX-/BUS-/LAN-Cables Interfaces KOAX-/BUS-/LAN-Cables

Application Criteria
COAXIAL CABLE RG 188 A/U COAXIAL CABLE RG 178 B/U COAXIAL CABLE RG 174 A/U COAXIAL CABLE RG 223 /U COAXIAL CABLE RG 213 /U COAXIAL CABLE RG 214 /U COAXIAL CABLE RG 6 A/U

Cable and Lead Designation

UNITRONIC BUS FD P L2/F.I.P.
COAXIAL CABLEL RG 11 A/U outdoor

UNITRONIC BUS Yv COMBI IBS

UNITRONIC BUS P COMBI IBS

UNITRONIC BUS FD P IBS

Page

8.9 8.9 8.9 8.9 8.9 8.9 8.9 8.9 8.9 8.9 8.9 8.9 8.9 8.9 8.10 8.10 8.11 8.11 7.2 7.3 7.4 7.2 7.3 7.4 7.5 7.6 7.7 7.9 7.9 7.7

UNITRONIC BUS LD

UNITRONIC BUS L2/F.I.P

UNITRONIC BUS FD P LD

UNITRONIC BUS Yv IBS

7.7

suitable for netwprk type to: IEEE 802.3 (Ethernet) IEEE 802.4 (MAP) IEEE 802.5 (IBM) ISDN 64 K Bit IBM 3270, 3600, 4300 IBM AS 400, 36, 38 IBM PC Network 10 base 5 Ethernet 10 base 2 Cheapernet 10 base T (UTP) 100 Ohm Token Ring (STP) 150 Ohm Token Bus Radio/TV Video BAS/FBAS Video RGB Monitors EIA RS 232/V24 EIA RS 422 EIA RS 485 EIA RS 232/20 mA (TTY) Service radio, CBRadio, amateur radio PROFIBUS INTERBUS (Phoenix Contact) BITBUS (Intel) For LAN installations (IBM, Ethernet etc.) With IBM reference approval Acc. to DEC specification + 205 C + 90 C + 80 C + 70 C + 60 C 5 C 20 C 30 C 40 C 50 C 190 C 150 Ohm 120 Ohm 100 Ohm 93 Ohm 75 Ohm 60 Ohm 50 Ohm CAT. 5 100 MHz CAT. 6 250 MHz CAT. 7 600 MHz PVC sheath Halogen free sheath PE sheath PUR sheath, wear resistant, PUR sheath, cutting resistant Flourpolymer outer sheath Outdoor laying in air indirectly in the ground Indoor use laid directly directly in the ground Halogen free types see selction table A4.

Application

Standards

Temperature range

Characteristic impedance

Capacity category

Make-up

Laying

= Principal application = Application not customary, but possible, or alternative design in the range

= Temperature range for flexible laying = Temperature range for static laying = Temperature range for static and flexible laying

14.10

UNITRONIC BUS COMBI L2/FIP 7-wire

MULTI-COAXIAL CABLE RG 62 B/U

MULTI-COAXIAL CABLE RG 59 B/U

UNITRONIC BUS L2/FIP 7-wire

UNITRONIC BUS Yv L2/F.I.P.

COAXIAL CABLE RG 187 A/U

COAXIAL CABLE RG 62 A/U

COAXIAL CABLE RG 59 B/U

COAXIAL CABLE RG 71 B/U

COAXIAL CABLE RG 11 A/U

COAXIAL CABLE RGB-FD

COAXIAL CABLE RG 58

UNITRONIC BUS IBS

COAXIAL CABLE RGB

UNITRONIC BUS FD P COMBI

A6 Selection Table: UNITRONIC-KOAX-/BUS-/LAN-Cables Interfaces KOAX-/BUS-/LAN-Cables

Application Criteria
UNITRONIC BUS AS-INTERFACE
UNITRONIC BUS Y PROFIBUS HYBRID

Cable and Lead Designation

LAN UTP/S+UTP/BS flex. CAT. 5, 100 MHz LAN UTP/BS DUPLEX CAT. 5, 100 MHz UNITRONIC BUS L2/FIP FESTOON UNITRONIC Li2YCY(TP)-Li2YCYv(TP) LAN PATCH COLOR, CAT.5, 100 MHz

ETHERLINE 2 pair, highly flexible

LAN UTP/BS CAT. 5, 100 MHZ

UNITRONIC BUS L2/FIP PUR

ETHERLINE 2 pair, stationary

LAN UTP/S CAT. 5, 100 MHz

LAN-Cable Transceiver mini

LAN UTP CAT. 5, 100 MHz

Page

7.7 7.7 7.9 7.9

7.9 7.18 7.23 8.2 8.2 8.3 8.3 8.3 8.3 8.4 8.4 8.4 8.4 8.4 8.4 8.5 8.6 8.7 6.33 8.35 8.41 8.43 8.41 8.43 8.41 8.43

suitable for network type to: IEEE 802.3 (Ethernet) IEEE 802.4 (MAP) IEEE 802.5 (IBM) ISDN 64 K Bit IBM 3270, 3600, 4300 IBM AS 400, 36, 38 IBM PC Network 10 base 5 Ethernet 10 base 2 Cheapernet 10 base T 100 Ohm 100 base T 100 Ohm Token Ring (STP) 150 Ohm Token Bus Radio/TV Video BAS/FBAS Video RGB monitors EIA RS 232/V24 EIA RS 422 EIA RS 485 EIA RS 232/20 mA (TTY) Service radio, CBRadio, amateur radio PROFIBUS INTERBUS (Phoenix Contact) BITBUS (Intel) For LAN installations (IBM, Ethernet etc.) With IBM reference approval Acc. to DEC specifications + 205 C + 90 C + 80 C + 70 C + 60 C 5 C 20 C 30 C 40 C 50 C 190 C 150 Ohm 120 Ohm 100 Ohm 93 Ohm 75 Ohm 60 Ohm 50 Ohm CAT. 5 100 MHz CAT. 5e CAT. 6 250 MHz CAT. 7 600 MHz 1,2 GHz PVC sheath Halogen free sheath PE sheath PUR sheath, wear resistant PUR sheath, cutting resistant Flourpolymer outer sheath Outdoor laying in air indirectly in the ground Indoor use laid directly directly in the ground Halogen free types see selction table A4.

Application

Standards

UNITRONIC Li2YCY PiMF

LAN-Cable Transceiver

IBM LAN-Typ 1A (600

LAN-Cable 10b5

LAN-Cable 10b2

MHz)TWINAX

Temperature range

Characteristic impedance

Capacity category

Make-up

Laying

= Principal application = Application not customary, but possible, or alternative design in the range

= Temperature range for flexible laying = Temperature range for static laying = Temperature range for static and flexible laying

14.11

ETHERLINE 4pair, highly flexible

UNITRONIC BUS L2/FIP TORSION

ETHERLINE 4 pair, stationary

LAN STP/S PiMF CAT. 7, 600 MHz

UNITRONIC BUS L2/FIP PE

LAN UTP CAT. 6, 250 MHz

UNITRONIC LAN 1,2 GHz

UNITRONIC BUS EIB

ETHERLINE 4 pair, flexible

ETHERLINE 2 pair, flexible

A7 Selection Table: UNITRONIC BUS Which UNITRONIC BUS cable for which field bus system?
DeviceNet TM (Allen-Bradley/Rockwell Automation) outdoor use/ direct burial/UV-resist. highly fexible (power chains etc.) INTERBUS DIN 19258 EN 50251 Sensor-/Aktor Bus SUCOnet p (Klckner-Mller) INTERBUS (Phoenix Contact) PROFIBUS DIN 19245 EN 50170 VariNet-P (Pepperl + Fuchs) Industrial Ethernet /Fast Ethernet Modulink P (Weidmller)

PROFIBUS-DP, -FMS/FIP FoundationTM Fieldbus

PROFIBUS-PA FoundationTM Fieldbus

UL/CSA approved

CAN ISO 11898

100-120 Ohm

AS-INTERFACE

Application

stationary

UNITRONIC BUS IBS

3 x 2 x 0,22 Part No. 2170206 UNITRONIC BUS IBS UL/CSA 3 x 2 x 0,22 Part No. 2170209 UNITRONIC BUS P COMBI IBS 3 x 2 x 0,22+3 x 1,0 Part No. 2170208 UNITRONIC BUS FD P IBS 3 x 2 x 0,25 Part No. 2170216 UNITRONIC BUS FD P COMBI IBS 3 x 2 x 0,25+3 x 1,0 Part No. 2170218 UNITRONIC BUS Yv IBS 3 x 2 x 0,22 Part No. 2170207 UNITRONIC BUS Yv COMBI IBS 3 x 2 x 0,22+3 x 1,0 Part No. 2170217 UNITRONIC BUS LD 2 x 2 x 0,22 Part No. 2170204 UNITRONIC BUS FD P LD 3 x 2 x 0,25 Part No. 2170214 UNITRONIC BUS L2/FIP 1 x 2 x 0,64 Part No. 2170220 UNITRONIC BUS L2/FIP UL/CSA 1 x 2 x 0,64 Part No. 2170219 UNITRONIC BUS L2/FIP PE 1 x 2 x 0,64 Part No. 2170233 UNITRONIC BUS L2/FIP 7-wire 1 x 2 x 0,64 Part No. 2170224 UNITRONIC BUS L2/FIP 7-wire halogen free 1 x 2 x 0,64 Part No. 2170226 UNITRONIC BUS COMBI L2/FIP 7-wire 1 x 2 x 0,64 + 3 x 1,0 Part No. 2170225 UNITRONIC BUS PA (BU)+(BK) 1 x 2 x 1,0 Part No. 2170234+2170235 UNITRONIC BUS FD P L2/FIP 1 x 2 x 0,64 Part No. 2170222 UNITRONIC FD P COMBI L2/FIP 1 x 2 x 0,64 + 3 x 1,0 Part No. 2170227 UNITRONIC BUS L2/FIP Torsion UL/CSA 1 x 2 x 0,8 Part No. 2170332 UNITRONIC BUS L2/FIP Festoon UL/CSA 1 x 2 x 0,64 Part No. 2170331 UNITRONIC FD P PROFIBUS HYBRID 1 x 2 x 0,64 + 4 x 1,5 Part No. 2170495 UNITRONIC BUS Yv L2/FIP 1 x 2 x 0,64 Part No. 2170223 UNITRONIC BUS YY L2/FIP 1 x 2 x 0,64 Part No. 2170236 UNITRONIC BUS L2/FIP FC 1 x 2 x 0,64 Part No. 2170320 UNITRONIC BUS L2/FIP FC UL/CSA 1 x 2 x 0,64 Part No. 2170820 UNITRONIC BUS L2/FIP-H FC UL/CSA 1 x 2 x 0,64 Part No. 2170326 UNITRONIC BUS L2/FIP PUR FC UL/CSA 1 x 2 x 0,64 Part No. 2170330 UNITRONIC BUS L2/FIP PE FC 1 x 2 x 0,64 Part No. 2170333 UNITRONIC BUS PA FC (BU) UL/CSA 1 x 2 x 1,0 Part No. 2170334 UNITRONIC BUS PA FC (BK) UL/CSA 1 x 2 x 1,0 Part No. 2170335 UNITRONIC BUS FD P L2/FIP FC UL/CSA 1 x 2 x 0,64 Part No. 2170322 UNITRONIC BUS L2/FIP BURIAL FC 1 x 2 x 0,64 Part No. 2170323
= = = = = Remote bus cable for INTERBUS Installation remote bus cable for INTERBUS suitable for power chains Polyurethane outer sheath Wire for outdoor use/direct burial with reinforced PVC outer sheath
is a registered trademark of Phoenix Contact GmbH & Co. is a registered trademark of der Klckner + Moeller GmbH is a registered trademark of Weidmller GmbH & Co. is a registered trademark of Pepperl + Fuchs GmbH

LD L2 FIP PE 7-wire H PROFIBUS-DP = = = = = = =

Lapp Kabel Bus Cables (cross sections in mm2 or diameter in mm or AWG size)

Legend IBS COMBI IBS FD P Yv

INTERBUS SUCOnet P Modulink P VariNet-P

Low attenuation Abbreviation for SINEC L2-DP Factory Instrumentation Protocol Polyethylene outer sheath 7-wire strand Halogen free material Decentralized Periphery
SIMATIC SINEC DeviceNetTM FoundationTM CC-Link = = = = =

PROFIBUS-FMS PROFIBUS-PA AS-I TPE G YE BK

= = = = = = =

Fieldbus Message Specification Process Automation AS-INTERFACE thermoplastic Elastomer rubber outer sheath (EPDM) yellow outer sheath black outer sheath

= = = =

is a registered trademark of SIEMENS AG is a registered trademark of SIEMENS AG is a registered trademark of Open Device Vendors Association (ODVA) is a registered trademark of Foundation Fieldbus is a registered trademark of CLPA, Japan

14.12

CC-Link

flexible

EIB

A7 Selection Table: UNITRONIC BUS Which UNITRONIC BUS cable for which field bus system?
DeviceNet TM (Allen-Bradley/Rockwell Automation)

outdoor use/ direct burial/UV-resist.

highly fexible (power chains etc.)

PROFIBUS DIN 19245 EN 50170

SUCOnet p (Klckner-Mller)

VariNet-P (Pepperl + Fuchs)

PROFIBUS-DP, -FMS/FIP

PROFIBUS-PA FoundationTM Fieldbus

CAN ISO 11898

AS-INTERFACE

100-120 Ohm

UNITRONIC BUS CAN UL/CSA 1 x 2 x 0,22 Part No. 2170260 UNITRONIC-BUS CAN UL/CSA 2 x 2 x 0,22 Part No. 2170261 UNITRONIC BUS CAN UL/CSA 1 x 2 x 0,34 Part No. 2170263 UNITRONIC BUS CAN UL/CSA 2 x 2 x 0,34 Part No. 2170264 UNITRONIC BUS CAN UL/CSA 1 x 2 x 0,5 Part No. 2170266 UNITRONIC BUS CAN UL/CSA 2 x 2 x 0,5 Part No. 2170267 UNITRONIC BUS CAN UL/CSA 1 x 2 x 0,75 Part No. 2170269 UNITRONIC BUS CAN UL/CSA 2 x 2 x 0,75 Part No. 2170270 UNITRONIC BUS FD P CAN UL/CSA 1 x 2 x 0,22 Part No. 2170272 UNITRONIC BUS FD P CAN UL/CSA 2 x 2 x 0,22 Part No. 2170273 UNITRONIC BUS FD P CAN UL/CSA 1 x 2 x 0,34 Part No. 2170275 UNITRONIC BUS FD P CAN UL/CSA 2 x 2 x 0,34 Part No. 2170276 UNITRONIC BUS FD P CAN UL/CSA 1 x 2 x 0,5 Part No. 2170278 UNITRONIC BUS FD P CAN UL/CSA 2 x 2 x 0,5 Part No. 2170279 UNITRONIC BUS ASI (G) YE + BK 2 x 1,5 Part No. 2170228 + 2170229 UNITRONIC BUS ASI (TPE) UL/CSA YE + BK 2 x 1,5 Part No. 2170830 + 2170831 UNITRONIC BUS ASI (PUR) YE + BK 2 x 1,5 Part No. 2170201 + 2170202 UNITRONIC BUS ASI (PUR) MARINE YE + BK 2 x 1,5 Part No. 2170401 + 2170402 UNITRONIC BUS ASI (PVC) UL/CSA CMG YE + BK 2 x 1,5 Part No. 2170842 + 2170843 UNITRONIC DeviceNet THICK (halogen free) AWG 18 + 15 Part No. 2170340 UNITRONIC DeviceNet THIN (halogen free) AWG 24 + 22 Part No. 2170341 UNITRONIC DeviceNet THICK (PVC) AWG 18 + 15 Part No. 2170342 UNITRONIC DeviceNet THIN (PVC) AWG 24 + 22 Part No. 2170343 UNITRONIC FD P DeviceNet THICK (PUR) AWG 18 + 15 Part No. 2170344 UNITRONIC FD P DeviceNet THIN (PUR) AWG 24 + 22 Part No. 2170345 UNITRONIC FD P DeviceNet THICK (PVC) AWG 18 + 15 Part No. 2170346 UNITRONIC FD P DeviceNet THIN (PVC) AWG 24 + 22 Part No. 2170347 UNITRONIC BUS EIB 2 x 2 x 0,8 Part No. 2170240 UNITRONIC-BUS EIB halogen free 2 x 2 x 0,8 Part No. 2170241 UNITRONIC BUS COMBI EIB 2 x 2 x 0,8 + 3 x 1,5 Part No. 2170242 UNITRONIC BUS COMBI EIB halogen free 2 x 2 x 0,8 + 3 x 1,5 Part No. 2170243

Lapp Kabel Bus Cables (cross sections in mm2 or diameter in mm or AWG size)

Legend IBS COMBI IBS FD P Yv

= = = = =

Remote bus cable for INTERBUS Installation remote bus cable for INTERBUS suitable for power chains Polyurethane outer sheath Wire for outdoor use/direct burial with reinforced PVC outer sheath

LD L2 FIP PE 7-wire H PROFIBUS-DP

= = = = = = =

Low attenuation Abbreviation for SINEC L2-DP Factory Instrumentation Protocol Polyethylene outer sheath 7-wire strand Halogen free material Decentralized Periphery

PROFIBUS-FMS PROFIBUS-PA AS-I TPE G YE BK

= = = = = = =

Fieldbus Message Specification Process Automation AS-INTERFACE thermoplastic Elastomer rubber outer sheath (EPDM) yellow outer sheath black outer sheath

INTERBUS SUCOnet P Modulink P VariNet-P

= = = =

is a registered trademark of Phoenix Contact GmbH & Co. is a registered trademark of der Klckner + Moeller GmbH is a registered trademark of Weidmller GmbH & Co. is a registered trademark of Pepperl + Fuchs GmbH

SIMATIC SINEC DeviceNetTM FoundationTM CC-Link

= = = = =

is a registered trademark of SIEMENS AG is a registered trademark of SIEMENS AG is a registered trademark of Open Device Vendors Association (ODVA) is a registered trademark of Foundation Fieldbus is a registered trademark of CLPA, Japan

CC-Link

EIB

14.13

Industrial Ethernet /Fast Ethernet

INTERBUS DIN 19258 EN 50251 Sensor-/Aktor Bus

INTERBUS (Phoenix Contact)

UL/CSA approved

Application

stationary

flexible

Modulink P (Weidmller)

A7 Selection Table: UNITRONIC BUS Which UNITRONIC BUS cable for which field bus system?
DeviceNet TM (Allen-Bradley/Rockwell Automation) outdoor use/ direct burial/UV-resist. highly fexible (power chains etc.) INTERBUS DIN 19258 EN 50251 Sensor-/Aktor Bus PROFIBUS DIN 19245 EN 50170 SUCOnet p (Klckner-Mller) INTERBUS (Phoenix Contact) VariNet-P (Pepperl + Fuchs) SIMATIC NET (SIEMENS) Industrial Ethernet /Fast Ethernet Modulink P (Weidmller)

UL/CSA approved

PROFIBUS-PA FoundationTM Fieldbus

CAN ISO 11898

AS-INTERFACE

100-120 Ohm

Application

stationary

Lapp Kabel Bus Cables (cross sections in mm2 or diameter in mm or AWG size)

ETHERLINE-H 2 x 2 x AWG 24/1 Part No. 2170280 4 x 2 x AWG 24/1 Part No. 2170296 ETHERLINE-P 2 x 2 x AWG 24/1 Part No. 2170281 4 x 2 x AWG 24/1 Part No. 2170297 ETHERLINE-H-H 4 x 2 x AWG 24/1 Part No. 2170298 ETHERLINE-H FLEX 2 x 2 x AWG 26/7 Part No. 2170283 4 x 2 x AWG 26/7 Part No. 2170299 ETHERLINE-P FLEX 2 x 2 x AWG 26/7 Part No. 2170284 2 x 2 x AWG 26/7 Part No. 2170300 ETHERLINE-Y UL/CSA CAT.5e 2 x 2 x AWG 22/1 Part No. 2170891 ETHERLINE-Y FC CAT.5e 2 x 2 x AWG 22/1 Part No. 2170893 ETHERLINE-YY CAT.5e 2 x 2 x AWG 22/1 Part No. 2170494 ETHERLINE-FD P CAT.5 2 x 2 x AWG 26/19 Part No. 2170289 ETHERLINE-FD P CAT.5 4 x 2 x AWG 26/19 Part No. 2170489 ETHERLINE-FD P FC UL/CSA CAT.5e 2 x 2 x AWG 22/7 Part No. 2170894 UNITRONIC BUS FF 3 1 x 2 x 1,1 + 1 x 1,1 Part No. 2170350 UNITRONIC BUS FF ARM 1 x 2 x 1,1 + 1 x 1,1 Part No. 2170351 UNITRONIC BUS FF 2 1 x 2 x 1,1 Part No. 2170352 UNITRONIC BUS CCL 3 x 1 x AWG20 Part No. 2170360 ETHERLINE Y FLEX FC UL/CSA (CMG) 2 x 2 x AWG 22/7 Part No. 2170886 ETHERLINE Y2Y ARM Type A CAT.5e 2 x 2 x AWG 22/1 Part No. 2170496 ETHERLINE FRNC HYBRID FLEX FC UL (AWM) Part No. 2170887

Legend IBS COMBI IBS FD P Yv

INTERBUS SUCOnet P Modulink P VariNet-P

= = = = =

Remote bus cable for INTERBUS Installation remote bus cable for INTERBUS suitable for power chains Polyurethane outer sheath Wire for outdoor use/direct burial with reinforced PVC outer sheath
is a registered trademark of Phoenix Contact GmbH & Co. is a registered trademark of der Klckner + Moeller GmbH is a registered trademark of Weidmller GmbH & Co. is a registered trademark of Pepperl + Fuchs GmbH

LD L2 FIP PE 7-wire H PROFIBUS-DP

= = = = = = =

Low attenuation Abbreviation for SINEC L2-DP Factory Instrumentation Protocol Polyethylene outer sheath 7-wire strand Halogen free material Decentralized Periphery
SIMATIC SINEC DeviceNetTM FoundationTM CC-Link = = = = =

PROFIBUS-FMS PROFIBUS-PA AS-I TPE G YE BK

= = = = = = =

Fieldbus Message Specification Process Automation AS-INTERFACE thermoplastic Elastomer rubber outer sheath (EPDM) yellow outer sheath black outer sheath

= = = =

is a registered trademark of SIEMENS AG is a registered trademark of SIEMENS AG is a registered trademark of Open Device Vendors Association (ODVA) is a registered trademark of Foundation Fieldbus is a registered trademark of CLPA, Japan

14.14

CC-Link

flexible

EIB

FIP

A8 Selection Table: Screw Type Cable Glands At a glance

Characteristics

Connection thread metric

Page

SKINTOP ST-M and STR-M SKINTOP ST and STR SKINTOP ST (NPT) and STR (NPT) SKINTOP ST-HF-M SKINTOP BS-M SKINTOP BS SKINTOP BS (NPT) SKINTOP BT and BT-M SKINTOP MS-M and MSR-M SKINTOP MS and MSR SKINTOP MS-IS-M SKINTOP MS-SC-M SKINTOP MS-SC SKINTOP K-M ATEX SKINTOP KR-M ATEX SKINTOP KR1-M ATEX SKINTOP MS-M ATEX SKINTOP MSR-M ATEX SKINDICHT MINI SKINDICHT CN and CN-M SKINDICHT SHV-M SKINDICHT SHV SKINDICHT SHV-M-Viton SKINDICHT SHV-Viton SKINDICHT SHVE-M SKINDICHT SHVE SKINDICHT SR-SV-M SKINDICHT SR-SV SKINDICHT FL SKINDICHT SRE-M SKINDICHT SRE SKINDICHT SR-M SKINDICHT SR SKINDICHT KW-M SKINDICHT KW SKINDICHT SE and SE-M SKINDICHT SE 216/316 and SE-M 220/320 SKINDICHT RWV-M SKINDICHT RWV SKINDICHT SKZ-M SKINDICHT SKZ SKINDICHT SHZ-M SKINDICHT SHZ SKINDICHT SVF and SVF-M SKINDICHT SVFK SKINDICHT SVRE-M SKINDICHT SVRE SKINDICHT SVRN-M SKINDICHT SVRN SKINDICHT SVRX-W SKINDICHT SVRX-Z SKINDICHT SVK SKINDICHT SK SKINDICHT SH

10.7 68 10.78 68 10.75 68 10.9 68 10.10 68 10.80 68 10.75 68 10.81/10.11 68 10.16/10.18 68 10.82/10.83 68 10.19 68 10.24 68 10.84 68 10.12 64 10.12 64 10.13 68 10.20 68 10.20 68 10.42 68 10.111/10.43 68 10.40 68 10.105 68 10.41 68 10.106 68 10.38 65-68 10.102 65-68 10.37 65 10.101 65 10.95 65 10.39 65 10.104 65 10.36 65 10.100 65 10.44 55 10.108 55 10.110/10.47 55 10.111/10.49 55 10.45 55 10.109 55 10.34 55 10.99 55 10.34 55 10.97 55 10.94/10.33 54 10.93 54 10.31 54 10.92 54 10.30 54 10.91 54 10.32 54 10.32 54 10.90 54 10.98 20 10.96 20

Kabelverschraubungen

14.15

Use for hazardous areas

Connection thread NPT

Connection thread PG

Vibration protection

Antikink protection

Screen connection

Protection class IP

for round cables

for flat cables

Strain relief

Plastic

Metal

Angle

A9 Selection Table: DESINA conform cables

Rationalisation by standardisation and decentralisation

With DESINA (DEcentralised and Standardised INstAllation Technology); the Verein Deutscher Werkzeugmaschinenfabriken e.V. (Federation of German Machine Tool Manufacturers) has developed a comprehensive overall concept for standardising the electrical installation of plant and machinery. Using the latest technologies, installation becomes simpler, assembly and maintenance are speeded up and the quality improved. Decentralisation means that control components and their functions can be removed from the central switchgear cabinet and transferred to field level.

Lapp Kabel and DESINA conform products

On the basis of existing field BUS systems, the VDW in cooperation with the machine tool, automotive and component supply industries has developed new standards in the area of connectors and for more rational cabling. As a leading supplier to the machine tool industry, Lapp Kabel declares its wholehearted support for the DESINA concept. We develop DESINA conform solutions for you with a minimum of delay: from the components to the ready-to-install, custom-built solution.

Application criteria
SERVO-Ltg. acc. to SIEMENS-Standard 6FX 7008 LFLEX SERVO FD 770 CP 4 x 2 x 0,25 mm2 SERVO cable. to SIEMENS-Standard 6FX 8008 SERVO-Ltg. acc. to SIEMENS-Standard 6FX 5008 K

Screened single cable SC CY DESINA

LFLEX SERVO-FD 795 CP UL + CSA

LFLEX SERVO FD 790 CP UL + CSA

Screened single cable SC CP DESINA

SERVO-Ltg. acc. to INDRAMAT-Standard

LFLEX SERVO-FD 795 P UL + CSA

LFLEX FD 891 / 891CY UL + CSA

HITRONIC HYBRID FD P DESINA

LFLEX SERVO 709 CY UL + CSA

UNITRONIC SENSOR P DESINA

LFLEX 150 UL + CSA + HAR

LFLEX SERVO FD 785 CP

LFLEX SERVO FD 755 CP

LFLEX SERVO FD 781 CY

LFLEX SERVO FD 785 CP

LFLEX CLASSIC 400 P

LFLEX 191 UL + CSA

LFLEX CLASSIC FD 810 P

LFLEX SERVO FD 770 CP

Outer sheath colour

LFLEX FD 855 P

LFLEX FD 891 P UL + CSA

LFLEX 100 H

LFLEX 440 P

Page

1.80 1.86 1.93 1.95 1.88 1.88 1.47 1.23 1.51 1.49 1.27 1.29 1.33 1.35 1.90 1.93 1.110 1.114 1.121 1.123 6.29 8.21 6.49 1.102 1.31 1.97 1.97 4.12 4.12 1.104 1.105 1.107 1.101 1.99

Servo cable, screened: Outer sheath colour: orange RAL 2003 Cable for measuring systems, screened: Outer sheath colour: green RAL 6018 Power cable, unscreened: Outer sheath colour: black RAL 9005 24 Volt control cable, unscreened: Outer sheath colour: grey RAL 7040 (similar to 7001)
Field bus hybrid cable, Cu and LWL: Outer sheath colour: violet RAL 4001

K K K K

LFLEX 110 H

LFLEX 491 P

LFLEX 140

K K

UNITRONIC FD P

LFLEX Tray II UL + CSA + NOM

K K K K K

SERVO-Ltg. acc. to FANUC-Standard

SERVO-Ltg. acc. to LENZE-Standard

K K

K K

K K K K

k
K K

K K

k K k K K K K K

K K

Sensor-/actuator cable, unscreened: Outer sheath colour: yellow RAL 1021 DESINA-printing on sheath K K K K K K K

K K

K K

Use in power chains

K K K K K

K K K K K K K K

K K

K K K K K

Sheath compound material of improved oil resistance UL and / or CSA approvals

K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K

Need a DESINA conform cable? Call us under: Phone ++49-(0)711/7838-4990, Fax ++49-(0)711/7838-4900 We can supply you with DESINA conform cables ready-to-install, custom-made, on request! Ask us: our experts can help you with advice and practical assistance: Phone: ++49-(0)711/7838-9320, Fax: ++49-(0)711/78 38-4870 For informations on DESINA conform connectors, call CONTACT, Phone: ++49-(0)711/78 38-6000, Fax: ++49-(0)711/78 38-3660 * DESINA = registered trademark of the VDW

14.16

A11 Selection Table: Applications of HITRONIC POF components At a glance

Application
Energy and data transmission Bidirectional data transmission systems Unidirectional data transmission systems K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K K

temperature resistant

limited UV-resistant

HITRONIC POF SIMPLEX PE-PUR POF 980/1000, Part No. 2185 030 HITRONIC POF SIMPLEX PVC UL POF 980/1000, Part No. 2185 201 HITRONIC POF SIMPLEX S PE-PUR POF 980/1000, Part No. 2185 205 HITRONIC POF SIMPLEX S PA-PUR POF 980/1000, Part No. 2185 204 HITRONIC POF SIMPLEX PE POF 980/1000, Part No. 2185 001 HITRONIC POF SIMPLEX FD PE-PUR POF 980/1000, Part No. 2185 207 HITRONIC POF DUPLEX FD PE-PUR POF 980/1000, Part No. 2185 213 HITRONIC POF SIMPLEX 115C XPE POF 980/1000, Part No. 2185 202

8.14 8.18 8.15 8.15 8.13 8.17 8.17 8.16 8.19 8.19 8.19 8.19 8.20 8.21
K

Page

Lapp Kabel-HITRONIC-LWL (POF) program bre type, part number

HITRONIC POF DUPLEX PE POF 980/1000, Part No. 2185 010 HITRONIC POF DUPLEX HEAVY PE-PUR POF 980/1000, Part No. 2185 211 HITRONIC POF DUPLEX PE-PVC POF 980/1000, Part No. 2185 209 HITRONIC POF DUPLEX PVC-PVC POF 980/1000, Part No. 2185 210 HITRONIC POF DUPLEX PE-PUR POF 980/1000, Part No. 2185 040 HITRONIC FD P DESINA 4x1,5 + 2xPOF 980/1000, Part No. 2186 001 Lapp Kabel PCF LWL HITRONIC BUS PCF DUPLEX indoor Part No. 2185 311 HITRONIC BUS PCF DUPLEX outdoor Part No. 2185 302 LWL connectors SMA-type ST-type HFBR-type SERCOS-type CIRCON HYBRID LWL converter ERbic PROFIBUS ERbic INTERBUS

8.22 8.22

K K

K K

K K

K K K K

8.23 to 8.27
K

K K

K K

o.d. o.d.
K

Note: Standard lengths without surplus for sectioning: 100 m and 500 m. o.d. = on demand

SERCOS interface

highly flexible

UL approved

halogen free

heavy duty

PROFIBUS

INTERBUS

14.17